Engine - Repair Instructions (N62)

00 Engine, General
- 00 Danger Of Poisoning If Oil Is Ingested/Absorbed Through The Skin
- 00 Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- 00 Safety Instructions For Handling Oil
- 00 00 610 Engine Oil Service (N62/N62TU)
- 11 00 045 Checking Absolute Compression Of All Cylinders
  - Diagnosis and Information System (DIS)
- 11 00 050 Removing And Installing Engine (N62 / N62TU)
  - Notes
  - Engine identification
12 Cylinder Head And Cylinder Head Cover
- 11 12 005 Removing And Installing/Sealing Left Cylinder Head Cover (N62/N62TU)
- 11 12 006 Removing And Installing/Sealing Right Cylinder Head Cover (N62/N62TU)
- 11 12 105 Removing And Installing Left Cylinder Head (N62 From 9/03 And N62TU)
- 11 12 105 Removing And Installing Left Cylinder Head (N62 To 9/03)
- 11 12 106 Removing And Installing Right Cylinder Head (N62 From 9/03 And N62TU)
- 11 12 106 Removing And Installing Right Cylinder Head (N62 To 9/03)
- 11 12 110 Replacing Left Cylinder Head Gasket (M62 / S62 / N62)
- 11 12 111 Replacing Right Cylinder Head Gasket (M62 / S62 / N62)
- 11 12 503 Disassembling And Assembling Cylinder Head (N62/N62TU)
- 11 12 527 REMACHINING A Valve Seat - Cylinder Head Disassembled (N62)
- 11 12 595 Checking A Valve Guide For Wear (N62)
- 11 12 719 Milling Cylinder Head Sealing Face (N62/N62TU)
- 11 12 729 Checking Cylinder Head For Water Leaks (N62/N62TU)
13 Oil Sump
- 11 13 010 Removing And Installing/Replacing Oil Sump Top Section (N62/N62TU)
- 11 13 020 Removing And Installing/Replacing Oil Sump Bottom Section (N62/N62TU)
14 Housing Cover
- 11 14... Removing And Installing/Replacing Support Block For Radial Compressor (BMW ALPINA B7)
- 11 14 080 Removing And Installing Top Left Timing Case Cover (N62/N62TU)
- 11 14 085 Removing And Installing Top Right Timing Case Cover (N62 / N62TU)
- 11 14 110 Removing And Installing Bottom Timing Case Cover (N62 / N62TU)
- 11 14 141 Replacing Radial Shaft Seal In Timing Case Cover At Bottom (N62/N62TU)
- 11 14 151 Replacing Crankshaft Radial Shaft Seal (N62 / N62TU)
21 Crankshaft With Bearing
- 11 21 500 Replacing Crankshaft (N62 / N62TU)
- 11 21 531 Replacing All Main Crankshaft Bearing Shells (N62/N62TU)
22 Flywheel
- 11 22 000 Removing And Installing/Replacing Flywheel (N62/N62TU)
23 Vibration Damper
- 11 23 010 Removing And Installing/Replacing Vibration Damper (N62/N62TU)
- 11 23 031 Removing And Installing/Replacing Vibration Damper Hub (N62/N62TU)
24 Connecting Rod With Bearing
- 11 24 571 Replacing All CONROD Bearings (N62/N62TU)
25 Piston With Rings And
- 11 25 530 Removing And Installing/Replacing All Pistons (N62)
- 11 25 671 Replacing Piston Rings On All Pistons (N62)
28 V-Ribbed Belt W.TENSIONER
- 11 28... Removing And Installing/Replacing Radial Compressor Belt TENSIONER (BMW ALPINA B7)
- 11 28... Removing And Installing/Replacing Radial Compressor Deflection Pulley (BMW ALPINA B7)
- 11 28... Removing And Installing/Replacing Radial Compressor Drive Belt (BMW ALPINA B7)
- 11 28 010 Replacing Alternator Drive Belt (N62/N62TU)
- 11 28 050 Replacing A/C Compressor Drive Belt (N62)
- 11 28 050 Replacing A/C Compressor Drive Belt With Belt TENSIONER (N62/N62TU)
31 Camshaft
- 11 31 032 Removing And Installing/Replacing Left Inlet Camshaft (N62 From 9/03 And N62TU)
- 11 31 032 Removing And Installing/Replacing Left Inlet Camshaft (N62 To 9/03)
- 11 31 034 Removing And Installing/Replacing Right Inlet Camshaft (N62 From 9/03 And N62TU)
  - Notes
  - Installation
- 11 31 034 Removing And Installing/Replacing Right Inlet Camshaft (N62 To 9/03)
- 11 31 036 Removing And Installing/Replacing Left Exhaust Camshaft (N62/N62TU)
- 11 31 038 Removing And Installing/Replacing Right Exhaust Camshaft (N62/N62TU)
- 11 31 052 Replacing Both Timing Chains (N62/N62TU)
- 11 31 070 Checking Camshaft Timing On Left Side (N62/N62TU)
- 11 31 071 Checking Camshaft Timing On Right Side (N62/N62TU)
- 11 31 573 Adjusting Camshaft Timing On Left Side (N62 / N62TU)
- 11 31 574 Adjusting Camshaft Timing On Right Side (N62 / N62TU)
- 11 33 516 Removing And Installing/Replacing Rocker Arms On Left Inlet Side (N62 From 9/03 And N62TU)
- 11 33 516 Removing And Installing/Replacing Rocker Arms On Left Inlet Side (N62 To 9/03)
  - Notes
  - Installation
- 11 33 517 Removing And Installing/Replacing Rocker Arms On Right Inlet Side (N62 From 9/03 And N62TU)
- 11 33 517 Removing And Installing/Replacing Rocker Arms On Right Inlet Side (N62 To 9/03)
- 11 37 012 Removing And Installing/Replacing Left Intermediate Lever (N62 To 9/03)
- 11 37 012 Removing And Installing/Replacing Left Intermediate Levers (N62 From 9/03 And N62TU)
- 11 37 014 Removing And Installing/Replacing Right Intermediate Lever (N62 To 9/03)
- 11 37 014 Removing And Installing/Replacing Right Intermediate Levers (N62 From 9/03 And N62TU)
  - Notes
  - Installation
33 Rocker Arm With Bearing
- 11 33 516 Removing And Installing/Replacing Rocker Arms On Left Inlet Side (N62 From 9/03 And N62TU)
- 11 33 516 Removing And Installing/Replacing Rocker Arms On Left Inlet Side (N62 To 9/03)
  - Notes
  - Removal
- 11 33 517 Removing And Installing/Replacing Rocker Arms On Right Inlet Side (N62 From 9/03 And N62TU)
- 11 33 517 Removing And Installing/Replacing Rocker Arms On Right Inlet Side (N62 To 9/03)
34 Valves With Springs
- 11 34 552 Removing And Installing/Replacing All Valves (N62)
- 11 34 560 Replacing All Valve Stem Seals (N62)
- 11 34 715 Replacing All Valve Springs (N62)
36 Variable Camshaft Timing
- 11 31 070 Checking Camshaft Timing On Left Side (N62/N62TU)
- 11 31 071 Checking Camshaft Timing On Right Side (N62/N62TU)
- 11 31 573 Adjusting Camshaft Timing On Left Side (N62 / N62TU)
- 11 31 574 Adjusting Camshaft Timing On Right Side (N62 / N62TU)
- 11 36 047 Removing And Installing/Replacing Inlet And Exhaust Adjustment Units On Left Side (N62/N62TU)
- 11 36 048 Removing And Installing/Replacing Inlet And Exhaust Adjustment Units On Right Side (N62/N62TU)
- 11 36 715 Removing And Installing/Replacing Both Left Solenoid Valves (N62/N62TU)
- 11 36 720 Removing And Installing/Replacing Both Right Solenoid Valves (N62/N62TU)
37 Variable Valve Gear
- 11 37 006 Removing And Installing/Replacing Left Eccentric Shaft (N62 From 9/03 And N62TU)
  - Notes
  - Installation
- 11 37 006 Removing And Installing/Replacing Left Eccentric Shaft (N62 To 9/03)
- 11 37 008 Removing And Installing/Replacing Right Eccentric Shaft (N62 From 9/03 And N62TU)
- 11 37 008 Removing And Installing/Replacing Right Eccentric Shaft (N62 To 9/03)
- 11 37 012 Removing And Installing/Replacing Left Intermediate Lever (N62 To 9/03)
- 11 37 012 Removing And Installing/Replacing Left Intermediate Levers (N62 From 9/03 And N62TU)
- 11 37 014 Removing And Installing/Replacing Right Intermediate Lever (N62 To 9/03)
- 11 37 014 Removing And Installing/Replacing Right Intermediate Levers (N62 From 9/03 And N62TU)
- 11 37 022 Removing And Installing/Replacing Servomotor For Left Eccentric Shaft (N62/N62TU)
- 11 37 024 Removing And Installing/Replacing Servomotor For Right Eccentric Shaft (N62/N62TU)
- 11 37 035 Removing And Installing/Replacing Left Eccentric Shaft Sensor (N62/N62TU)
- 11 37 040 Removing And Installing/Replacing Right Eccentric Shaft Sensor (N62/N62TU)
- 11 37 700 Replacing Control Unit (VALVETRONIC)
40 Oil Supply
- 11 40 000 Checking Engine Oil Pressure
41 Oil Pump With Filter A
- 11 41 000 Removing And Installing/Replacing Oil Pump (N62)
43 Oil Filling, Dipstick
- 11 43 000 Removing And Installing/Sealing Guide Tube For Oil Dipstick (N62)
51 Water Pump With Drive
- 11 51 000 Removing And Installing/Replacing Water Pump (N62/N62TU)
52 Fan
- 11 52 020 Removing And Installing Or Replacing Fan Clutch (N62)
53 Thermostat And Connect
- 11 53 000 Removing And Installing/Replacing Coolant Thermostat (N62)
61 Intake Manifold
- 11 61 050 Removing And Installing Intake Air Manifold (N62)
- 11 61 095 Removing And Installing/Replacing DISADJUSTMENT Unit
62 Exhaust Manifold
- 11 65 ... Removing And Installing/Replacing Radial Compressor Centrifugal Clutch (BMW ALPINA B7)
- 11 65 035 Removing And Installing/Replacing Charger (BMW ALPINA B7 Radial Compressor)
65 Supercharger With Cont
- 11 65 ... Removing And Installing/Replacing Radial Compressor Centrifugal Clutch (BMW ALPINA B7)
- 11 65 035 Removing And Installing/Replacing Charger (BMW ALPINA B7 Radial Compressor)
66 Vacuum Pump
- 11 65 ... Removing And Installing/Replacing Radial Compressor Centrifugal Clutch (BMW ALPINA B7)
- 11 65 035 Removing And Installing/Replacing Charger (BMW ALPINA B7 Radial Compressor)
72 Air Pump, Lines And Co
- 11 72 000 Removing And Installing/Replacing Air Pump (N62)
78 Emission Control, Oxygen Control Sensor
- 11 78 ... Removing And Installing/Replacing Exhaust Temperature Sensor (BMW ALPINA B7)
- 11 78 530 Replacing Left Oxygen Control Sensor (N62/N62TU)
- 11 78 533 Replacing Right Oxygen Control Sensor (N62/N62TU)
- 11 78 540 Replacing Left Oxygen Monitor Sensor (N62 / N62TU)
- 11 78 543 Replacing Right Oxygen Monitor Sensor (N62/N62TU)