Port Fuel Injection - Scan Data Specifications
NOTE:
Information contained in the following table is typical of readings taken on vehicle with engine idling, upper radiator hose hot, closed throttle, transmission in Park or Neutral, "closed loop" status achieved and all accessories off (except as noted in tables). Data parameters are updated every 1 1/4 seconds. On systems using P-4 computers, parameter updates are virtually instantaneous. Not all devices & systems are used on all models.
PORT FUEL INJECTION
| Tester Position | Units Measured | Nominal Data Value |
|---|---|---|
| A/C Clutch | On/Off | Off (On with A/C). |
| A/C Request | Yes/No | No/Yes (with request). |
| AIR Divert Sol. | On/Off | On (air to switching sol.). |
| AIR Divert Sol. | On/Off | Off (air to atmosphere). |
| AIR Switching Sol. | On/Off | On (to exhaust manifold). |
| AIR Switching Sol. | On/Off | Off (to catalytic converter). |
| Air Flow | Gr/Sec. | Same as MAF or ECM Default |
| BARO | Volts | 3-4.5. |
| Battery Voltage | Volts | 13.5-14.5. |
| Block Learn | Counts | . 118-138 (128 normal). |
| Brake Switch | On/Off | On when engaged. |
| Canister Purge Sol. | On/Off | On/engine cold (idle some). |
| Clear Flood | On/Off | ***See tester manual***. |
| Coolant Fan | On/Off | Off below 216°F (102°C). |
| Coolant Temp. | °C | 85-105° (norm. temperature). |
| Crank RPM | RPM | 100-900. |
| Cross Counts | Counts | 0-255. |
| EGR Solenoid | On/Off | On when energized. |
| EGR Duty Cycle | 0-1 00% | 0/closed-100/fully open. |
| Fan Relay | On/Off | On when energized. |
| Fan Request | On/Off | On with request. |
| Fuel Backup | Yes/No | Yes when engaged. |
| IAC | Counts | 0-50. |
| Ignition/Crank | On/Off | On with ignition/crank. |
| Injector Pulse Width | Mil./Sec | .8-3.0. |
| INT (Integrator) | Counts | 110-145 (128 normal). |
| Knock Retard (ESC) | Counts | 0-255. |
| Knock Signal | Yes/No | Yes when knock exists. |
| MAT | °C | 10-90°. |
| MAP | Volts | 1 (idle) to 4.5 (WOT). |
| Open/Closed Loop Status | Ol/Cl | Closed/Open during extended idle. |
| O2 Sensor | Millivolts | 100 (lean) to 999 (rich). |
| P/N Switch | P/N/RDL | Park/Neutral. |
| P/S Switch | Norm/Hi | Normal. |
| PROM I.D. | PROM # | Original factory number. |
| RPM | RPM | Spec. +/-25 RPM Drive (Auto.). |
| RPM | RPM | Spec. +/-50 RPM Neut. (man.). |
| Spark Advance | # of Deg. | Varies. |
| TCC | On/Off | Off (On with command). |
| TPS | Volts | 1.25 (idle) to 5.0 (WOT). |
| Throttle Angle | 0-100% | 0 (idle) to 110 (WOT). |
| Trouble Codes | Code # | No codes. |
| Turbo Boost | On/Off | On when activated. |
| Upshift Light (M/T) | On/Off | Off. |
| VSS or MPH | MPH | 0-actual. |
| Wastegate By-Pass | On/Off | On when by-pass. |
| Water Injection | On/Off | On when injecting. |
| 1st Gear Switch | On/Off | On/1st gear only. |
| 3rd Gear Switch | On/Off | On/3rd & 4th gear. |
| 4th Gear Switch | On/Off | On/4th gear. |
NOTE:
If ECM displays data but engine fails to start, proceed to chart A-3 in the TESTS W/ CODES article in this section.
NOTE:
Condensed, general SYMPTOM DIAGNOSIS and INTERMITTENTS testing articles are located in the TROUBLE SHOOTING section. Also refer to the CEC TESTS W/O CODES article in this section.