Technical Service Bulletins

A/C Compressor
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Ac Blows Warm Or Poor Performance (PIT5099H)
- Diagnostic Information to Accurately Diagnose A/C Low Pressure Switch Using Kent Moore Special Tool GE-47742 (04-01-38-010A)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
- Information on GM ACR2000 (J-43600) and New Refrigerant Recovery Recharging Equipment Standard SAE J2788 (07-01-38-004)
- A/C System Refrigerant Hiss Noise (06-01-38-002)
- ASI Resolution - High-Pitched Tone Heard Inside Vehicle When A/C Compressor Is Engaged (04-01-38-014A)
- New PAG Oil Released (02-01-39-004B)
- Diagnostic Information for Moan, Groan or Boom Noise at Idle, Vibration in Steering Wheel or Felt Through Floor When A/C Compressor Engages - Do Not Replace A/C Compressor (04-01-38-015)
- HVAC Not Cold Enough, A/C Compressor Does Not Engage (Repair Engine Compartment Wiring Harness Near Idler Arm) (04-01-38-013)
- Contaminated R-134a A/C Systems - Air Conditioning System Flushing Procedures and Universal In-Line A/C Filter Installation (83-12-21)
- Underhood Rattle Noise Heard On Acceleration (Check A/C System Performance and Compressor Operation) (03-01-38-019A)
- J-43600 ACR 2000 Essential Refrigerant Recovery/Recharge Equipment (99-01-38-006B)
- Revised Air Conditioning (A/C) System Performance Test (04-01-37-004)
- J 44551 A/C Suction Screen Kit Repair Recommendations And Procedures After Catastrophic Compressor Failures (01-01-39-003A)
- A/C Refrigerant System Sealer And A/C System Leak Detection Guidelines (03-01-38-001)
- Refrigerant Dye Added To A/C System At Assembly Plant (00-01-38-009B)
- Diagnostic Information To Consider Before Air Conditioning Compressor Replacement (01-01-38-013A)
Accessories & Equipment
- Concerns Or Questions Regarding Installation Of Dealer Installed Accessories (PIT3099U)
- Information On Module Harvesting (22-NA-205)
- Requesting A New Key Code For Customer With Lost Or Stolen Keys (12-00-89-002E)
- New Labor Operation Codes for Dealer-Installed GM Accessories Replaced During Warranty Coverage Period (02-20-89-014)
- Announcement of Price Increase for MDI (EL-47955) (08-00-89-018A)
- Processing GM Accessories - Initial Quality Issues (04-00-89-018C)
- Part and Accessory Replacement Policy (04-00-89-011)
Accessories Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Speedometer Needle Accuracy Information (PIT5195H)
- Information On Communication With ONSTAR Module After CANADIAN Cellular Upgrade (15-08-73-001A)
- Diagnostic Tip: Unable To Connect To ONSTAR Or Connects Failed To Voice (PIT5389F)
- Requirements For ONSTAR Over The Air Programming And Updates (PIC6107A)
- ONSTAR- Unwanted Or Phantom Phone Calls (PIC3278G)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Cargo Lamp Indictor Turns On Briefly When Dome/Glove Box Lamp Is Activated (PIT3553A)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- Caller Id Unavailable After ONSTAR Upgrade (PIT5464)
- Unable To Receive Incoming ONSTAR Or HFC (Hands Free Calling) Calls (PIC6101)
- Diagnostic Tip: Unable To Connect Or Use Hands Free Calling Or No Data On The Call (Failed To Voice) (PIC4310L)
- Fuel Gauge Fluctuation In Park Or Neutral (PIT3046G)
- Diagnostic Tip: CANADIAN ONSTAR Subscriber Unable To Receive Turn-By-Turn Directions While Traveling In The United States (PIT5264C)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
- Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
- Programming OnStar(R) Module for Canadian French Voice Recognition (OnStar(R) Generation 5 or Generation 6) (02-08-46-010G)
- No Communication with Any Modules, Memory Seat May Not Recall, Multiple U-DTCs Set or Instrument Panel Cluster (IPC) Warning Indicators, Crank No Start (Inspect/Repair Affected Wiring Harness) (03-08-50-014A)
- Rear Seat Audio (RSA) and/or Rear HVAC Inoperative (Replace RSA Module) (03-08-44-018C)
- Malfunction Indicator Lamp (MIL) On, Transmission Stuck in Second or Third Gear, Instrument Cluster Inoperative (Verify and Repair Source of Voltage Loss In Transmission Solenoid Power Supply Circuit) (01-07-30-002E)
- Intermittent Heated Seats Inoperative, DTC B3941 Set (Reprogram Driver Seat Module) (05-08-50-008)
- Memory Seat May Not Return to Requested Position (Reprogram Driver Seat Module) (04-08-50-016C)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- 2003, 2004, 2005 Silverado and Sierra, Tahoe, Yukon, Avalanche, Suburban, Yukon XL, Escalade, Escalade EXT and ESV, and HUMMER H2 Power Seat Will Not Retain Preset Memory Position (VSS20050521)
- Power Seat Switch Works In The Opposite Direction - Keywords An3 Driver Electrical Intermittent Memory Module Move Operation Recall Reverse RKE (PIT3598)
- Trailer Brakes Applied When Headlights/Park Lamps Are On, Brake Controller Illumination (Modify Brake Controller Wiring Harness) (02-05-22-004C)
- Parts Restriction Program For Vehicle Stability Enhancement System (Stabilitrak(R)) (02-05-25-007A)
- Enabling Memory Seat Feature via DIC If Feature Appears Inoperative (04-08-50-003)
- GMT 800 IP Clusters for 2003-2004 Full Size Pickups and Utilities (VSS20050398)
- Supplemental Inflatable Restraint (SIR) Light ON, Diagnostic Trouble Codes (DTC) B0026 and/or B0044 (Inspect and/or Replace IP Harness to Inflatable Restraint Steering Wheel Module Yellow 4-Way Connector C221) (05-09-41-001)
- OnStar(R) Proactive Parts Shipment Process (02-08-46-013A)
- Cranks But No Start, Stall, Inaccurate/Incorrect Fuel Gauge Reading, No Fuel, Vehicle is Out of Fuel and Fuel Gauge Reads Above Empty (Replace Fuel Level Sensor) (04-08-49-018E)
- Instrument Panel Cluster (IPC) Gauges Inoperative (Reprogram IPC) (03-08-49-020)
- 2003, 2004, 2005 Full Size Pickup and Sport Utility Vehicles Power Seat Will Not Retain Preset Memory Position (VSS20040205)
- Proper Use of Labor Operation Code When Diagnosis Leads to SIR Passenger Presence System Replacement (04-09-41-003)
- Service Information for Front Heated Seat Inoperative/Cold (04-08-50-007)
- Diagnostic Information For Replacement Remote Keyless Entry (RKE) Transmitter Inoperative - Unable To Synchronize (03-08-52-005)
- Intermittent No Start, Service Stability Message, Abs Light Illuminated, Multiple DTCS, DIC Shows Unknown Driver, Various Electrical Related Conditions (Repair And/Or Reroute Seat Wiring Harness) (03-08-50-014)
- Chime Volume Level Too Loud (Adjust Chime Level Using Tech 2) (03-08-49-013)
- HOMELINK Transceiver/Garage Door Opener Transmitter Test Kit (01-08-97-001B)
- SMU - Revised Engine Oil Pressure Gage Inaccurate Or Inoperative Diagnostic Information (03-08-49-009)
- Info - Changes In A/C Compressor On/Off Instrument Panel Display Symbol From 2003 To 2004 Model Year And Synchronizing The Driver And Passenger Set Temperatures (03-01-39-008)
- IP Cluster High Beam Indicator Too Bright (Reprogram IPC) (03-08-49-006)
- Seat Heater And/Or Memory Power Seat Inoperative (Replace Memory Seat Control Module) (03-08-50-003)
- Diagnostic Information For No Audio Out Of Speakers On One Or More Channels (02-08-44-018)
- Info - Cycling Power Folding Exterior Mirror To Remain In Locked Position After Transport (02-08-64-022)
- Selecting Radio Source Using Steering Wheel Controls (02-08-44-017)
- DTCS B1001, B1271 Or B1780 Set When Replacing/Reprogramming Other Modules (99-06-03-010A)
Accessory Drive Belts
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
Air Bag, SRS
- Supplemental Inflatable Restraint (SIR) Light ON, Diagnostic Trouble Codes (DTC) B0013, B0014, B0017, B0018, B0024, B0026, B0043, B0044 (Inspect and/or Replace IP Harness to Inflatable Restraint Module (Air Bag) Yellow 4-Way Connector C221 and/or C222) (05-09-41-001B)
- General Motors Position Statement on Installation of Used, Salvaged, or Imitation Air Bag System Components (08-09-41-003)
- New SIR System Disabling and Enabling Procedure (05-09-41-010)
- Proper Use of Labor Operation Code When Diagnosis Leads to SIR Passenger Presence System Replacement (04-09-41-003)
- Air Bag Lamp On, Passenger Air Bag Indicator Always Reads OFF, DTC B0092 Set (Repair Passenger Presence System (PPS) Sensor Harness) (02-09-41-002A)
Anti-Lock Brakes
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Pre-Formed And Pre-Flared Hydraulic Brake Pipe Kits Now Available For Service (13-05-22-001D)
- GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
- Antilock Brake (ABS) Activation At Low Speeds (Clean Wheel Speed Sensor Mounting Surface) (03-05-25-007D)
- ABS Light On, DTCs C0265, C0201, U1041 Set and/or Loss of Communication with Brake Module (Reground EBCM Ground) (04-05-25-002E)
- Service Stability Message and DTC C0550 Set (VSS20040070)
- Intermittent No Start, Service Stability Message, Abs Light Illuminated, Multiple DTCS, DIC Shows Unknown Driver, Various Electrical Related Conditions (Repair And/Or Reroute Seat Wiring Harness) (03-08-50-014)
- Service Stability Message And DTCS C0455 Or C0550 Set (Update Vehicle Stability Enhancement System (VSES) Module Software) (03-05-25-005)
Anti-Theft Systems
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (U.S. Only) (10-00-89-009F)
- Requesting A New Key Code For Customer With Lost Or Stolen Keys (12-00-89-002E)
- Information On Poor, Limited, Reduced Remote Keyless Entry (RKE) Or Remote Vehicle Start (RVS) Range (PI1018A)
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (CANADA Only) (10-00-89-010C)
- Key Code Information (99-00-89-011E)
- Remote Keyless Entry Operational Characteristics (99-08-52-005C)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- No Communication with Any Modules, Memory Seat May Not Recall, Multiple U-DTCs Set or Instrument Panel Cluster (IPC) Warning Indicators, Crank No Start (Inspect/Repair Affected Wiring Harness) (03-08-50-014A)
- SMU - Addition of Pickup Box End Gate Latch Handle Bezel Procedure (05-08-66-005)
- Remote Keyless Entry (RKE) System Inoperative (03-08-52-001C)
- Diagnostic Information For Replacement Remote Keyless Entry (RKE) Transmitter Inoperative - Unable To Synchronize (03-08-52-005)
- Chime Volume Level Too Loud (Adjust Chime Level Using Tech 2) (03-08-49-013)
- DTCS B1001, B1271 Or B1780 Set When Replacing/Reprogramming Other Modules (99-06-03-010A)
Automatic Trans
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Ethylene Glycol In Transmission Fluid (08-07-30-035I)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Driveline Clunk Noise (99-04-20-002O)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Diagnostic Tip On Avoiding Torque Converter Or Crankshaft Damage While Diagnosing Noise Concerns (PIP5640A)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Prior To Any Circuit Testing (PIP5094A)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Automatic Transmission Oil Cooler Flow Test Essential Tool J-45096 TRANSFLOW® (03-07-30-002B)
- Information On 2-3 Upshift Or 3-2 Downshift Clunk Noise (01-07-30-042H)
- Vibration Analysis Worksheet (03-00-91-001I)
- Information On Normal Maintenance Or Warranty Service For 4T40, 4T45, 4T65, 4L60 Automatic Transmission Oil Pan Magnet Upgrade (08-07-30-040C)
- Release Of DEXRON®-VI Automatic Transmission Fluid (ATF) (04-07-30-037E)
- Warranty Administration- Change in Automatic Transmission Add Condition Documentation and Claim Submission (09-07-30-018A)
- Current Model Year Goodwrench Transmission Replacement Assembly Program (00-07-30-009D)
- GM Training - June 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-026)
- Diagnostic Tips for Automatic Transmission DTC P0756, Second, Third, Fourth Gear Start (01-07-30-036H)
- Information on 4T65-E MN7, M15, M76, MN3 Automatic Transmission Case, Cooler Fitting and Torque Converter Drain Back Check Ball Change (04-07-30-017B)
- Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032E)
- No Reverse, Second Gear or Fourth Gear (Replace Reaction Sun Shell with More Robust Heat Treated Parts) (00-07-30-022D)
- No Movement When Transmission is Shifted to Drive or Third - Normal Operation When Shifted to Second, First or Reverse (Replace Forward Sprag Assembly) (08-07-30-027)
- Diagnostic Information on Diagnostic Trouble Code (DTC) P0894 and P1870 (08-07-30-008B)
- Automatic Transmission/Transaxle Torque Converter Replacement (01-07-30-010C)
- 4L60-E, 4L65-E, 4L70-E HYDRA-MATIC® Automatic Transmission RPOs M30, M70, M32, M33, MK2, MD6 Oil Cooler Fitting Change (08-07-30-004)
- Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
- Information Regarding Automatic Transmission Shift Lock Control Function (03-07-30-043A)
- Instructions To Be Followed To Aid in Obtaining Root Cause Analysis on Both OEM and Goodwrench(R) Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
- 4L60-E/4L65-E Automatic Transmission Diagnostic Information on Harsh 1-2 Upshift (01-07-30-030B)
- Transmission Fluid Leak Diagnosis (01-07-30-041B)
- Diagnosis of Cracked or Broken Transmission Case (02-07-30-024B)
- Info - Oil Pump Assembly Seal And Transmission Case Change (04-07-30-023)
- 1-2, 2-3, 3-4, 4-5 Shift and Torque Converter Clutch (TCC) Characteristics During Cold Weather Operation on 4L60-E, 4L80-E or Allison Transmissions (01-07-30-031A)
- 4L65-E, 4L60-E, 4L60 And 200-4R Automatic Transmission Oil Pump Spring First And Second Design Identification (04-07-30-006)
- 4L60-E A/T Oil Pump First & Second Design Identification (03-07-30-056)
- Driveline Clunk When Stopping (Reprogram Powertrain Control Module (Pcm)) (03-07-30-028)
- Most Frequently Asked Questions And Answers For J 45096 TRANSFLOW Transmission Oil Cooling System Flushing Machine (03-07-30-027)
- Diagnostic Information For Intermittent Transmission Downshift, Slip, Busy/Cycling TCC Or Noisy Cooling Fan (99-07-30-016B)
- Automatic Transmission Serial Number & Site Code Locations (02-07-30-028)
Auxiliary Emission Control Systems
- Catalytic Converter Break-In Information To Prevent DTCS P0420 And/Or P0430 (PIP3119P)
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- I/M Readiness as Part of Emission Inspection and Maintenance Program for OBD II Vehicles (00-06-04-033B)
- LR4, Lm4, Lm7, L59, LQ9, LQ4, L18 DTC P0446 (Restricted/Blocked EVAP Vent Path) Set, Service Engine Soon (SES) Lamp Illuminated (Replace Vent Solenoid And Bracket) (04-06-04-055A)
- New Add Time For Labor Operation L2300 - Converter, Oxidation Catalytic-Replace (02-00-89-006C)
- Oil Leak Under Extreme Cold Temperatures (-34°C (-30°F) or Colder) (Install Vented Oil Fill Cap) (05-06-01-014)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- Check Engine Light On With No DRIVEABILITY Concerns, DTC P0120, P0220, P1516, P1518 (Clear Code) (03-06-04-032)
- ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
Axle Shafts
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Information on Difficult to Remove 8.25 and 9.25 Left Front Axle Shaft - Center C-Clip (08-04-19-006)
- Revised Wheel Drive Shaft Nut Torque Specification (04-04-95-001)
- Advance Service Info - Fluid Leak From Front Of Vehicle (Add TEFLON Tape To Front Axle Vent/Plug Threads) (03-04-19-003)
- SMU - Revised Wheel Drive Shaft Inner Joint And Seal Replacement (03-04-18-003)
Body Electrical
- Information For Electrical Ground Repair - Use New Replacement Fasteners With Conductive Finish (10-08-45-001F)
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Information on Engine Misfire MIL/SES Light Illuminated or Flashing DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308, P0420 or P0430 (06-06-04-046)
- Replacement of Connector When Replacing Fuel Tank Module/Fuel Pump Module (04-06-04-088C)
- Updated Transfer Case Connector Service Kit Now Available For Transfer Case Speed Sensor Wire Harness Connector that Comes Loose Or Connector Retainer Clip Breaks (06-04-21-001)
- Instrument Panel (I/P), Body and General Wiring Harness Repair (06-08-45-004)
- UPFITTER Bulletin - Modified Brake Controller Wiring Harness (UI 57)
Body Interior
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- OnStar® Labor Operation Codes (05-08-46-005C)
- Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
- No Communication with Any Modules, Memory Seat May Not Recall, Multiple U-DTCs Set or Instrument Panel Cluster (IPC) Warning Indicators, Crank No Start (Inspect/Repair Affected Wiring Harness) (03-08-50-014A)
- Rear Seat Audio (RSA) and/or Rear HVAC Inoperative (Replace RSA Module) (03-08-44-018C)
- Intermittent Heated Seats Inoperative, DTC B3941 Set (Reprogram Driver Seat Module) (05-08-50-008)
- Memory Seat May Not Return to Requested Position (Reprogram Driver Seat Module) (04-08-50-016C)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Trailer Brakes Applied When Headlights/Park Lamps Are On, Brake Controller Illumination (Modify Brake Controller Wiring Harness) (02-05-22-004C)
- GMT 800 IP Clusters for 2003-2004 Full Size Pickups and Utilities (VSS20050398)
- Supplemental Inflatable Restraint (SIR) Light ON, Diagnostic Trouble Codes (DTC) B0026 and/or B0044 (Inspect and/or Replace IP Harness to Inflatable Restraint Steering Wheel Module Yellow 4-Way Connector C221) (05-09-41-001)
- OnStar(R) Proactive Parts Shipment Process (02-08-46-013A)
- Cranks But No Start, Stall, Inaccurate/Incorrect Fuel Gauge Reading, No Fuel, Vehicle is Out of Fuel and Fuel Gauge Reads Above Empty (Replace Fuel Level Sensor) (04-08-49-018E)
- Instrument Panel Cluster (IPC) Gauges Inoperative (Reprogram IPC) (03-08-49-020)
- 2003, 2004, 2005 Full Size Pickup and Sport Utility Vehicles Power Seat Will Not Retain Preset Memory Position (VSS20040205)
- Proper Use of Labor Operation Code When Diagnosis Leads to SIR Passenger Presence System Replacement (04-09-41-003)
- Service Information for Front Heated Seat Inoperative/Cold (04-08-50-007)
- Chime Volume Level Too Loud (Adjust Chime Level Using Tech 2) (03-08-49-013)
- HOMELINK Transceiver/Garage Door Opener Transmitter Test Kit (01-08-97-001B)
- IP Cluster High Beam Indicator Too Bright (Reprogram IPC) (03-08-49-006)
- Seat Heater And/Or Memory Power Seat Inoperative (Replace Memory Seat Control Module) (03-08-50-003)
- Adm Msg VSS20020149 - Vehicle Will Not Start (VSS20020149)
- Diagnostic Information For No Audio Out Of Speakers On One Or More Channels (02-08-44-018)
- Info - Cycling Power Folding Exterior Mirror To Remain In Locked Position After Transport (02-08-64-022)
- Selecting Radio Source Using Steering Wheel Controls (02-08-44-017)
Brakes Control Systems
- Prior To Any Circuit Testing (PIP5094A)
- Antilock Brake (ABS) Activation At Low Speeds (Clean Wheel Speed Sensor Mounting Surface) (03-05-25-007D)
- ABS Light On, DTCs C0265, C0201, U1041 Set and/or Loss of Communication with Brake Module (Reground EBCM Ground) (04-05-25-002E)
- Intermittent No Start, Service Stability Message, Abs Light Illuminated, Multiple DTCS, DIC Shows Unknown Driver, Various Electrical Related Conditions (Repair And/Or Reroute Seat Wiring Harness) (03-08-50-014)
- Service Stability Message And DTCS C0455 Or C0550 Set (Update Vehicle Stability Enhancement System (VSES) Module Software) (03-05-25-005)
- UPFITTER Bulletin - Modified Brake Controller Wiring Harness (UI 57)
Charging Systems
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- Battery and Charging System Electrical Diagnostics (99-06-03-012)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Incorrect Amp Code On Generator (04-06-03-001)
- Proper Diagnostic Procedures For No Start, No Crank, Battery, Batteries, Generator, Gauges, SES, Sir, Brake, Security, Theft, Abs, Hot, DIC Messages, Lamp, Light, Battery And Generator Diag. Testing (02-06-03-012)
Collision/Avoidance
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
Communication Devices
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Information On Communication With ONSTAR Module After CANADIAN Cellular Upgrade (15-08-73-001A)
- Diagnostic Tip: Unable To Connect To ONSTAR Or Connects Failed To Voice (PIT5389F)
- Requirements For ONSTAR Over The Air Programming And Updates (PIC6107A)
- Diagnostic Tips: XM Audio Traffic And Travel Link Availability And Operation (PIT5353C)
- ONSTAR Will Not Power Up (PIC5491K)
- Normal Characteristic - ONSTAR Power Consumption (PIC4935F)
- Diagnostic Tip - ONSTAR Turn By Turn /TBT Feature Inoperative (PIC4801H)
- ONSTAR- Unwanted Or Phantom Phone Calls (PIC3278G)
- Programming And Activation Of Replacement ONSTAR Modules (VCIM) (PIC5588C)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- Unable Place An ONSTAR Call With Ignition In On Position After 15-08-44-001 CANADA Upgrade (PIT5485B)
- No Connect With Disabled Vehicle Or Dropped Calls With 1234567890 Min (PIC5050A)
- 118 Error When Attempting To Configure ONSTAR, Use TBT, Or Other Data Services After 15-08-44-001 Upgrade (PIT5484A)
- Behavior Of Non-Upgraded ONSTAR® Equipped Vehicles Operating In CANADA After Decommissioning Of 2G CDMA Cellular Networks (16-NA-025)
- ONSTAR® Voice Fallback Number Update (15-NA-079)
- Caller Id Unavailable After ONSTAR Upgrade (PIT5464)
- Unable To Receive Incoming ONSTAR Or HFC (Hands Free Calling) Calls (PIC6101)
- Diagnostic Tip: Unable To Connect Or Use Hands Free Calling Or No Data On The Call (Failed To Voice) (PIC4310L)
- Information On Upgrading Certain ONSTAR® Analog/Digital-Ready Systems To ONSTAR® Generation 6 Digital-Capable System (05-48-46-006G)
- Diagnostic Tip: CANADIAN ONSTAR Subscriber Unable To Receive Turn-By-Turn Directions While Traveling In The United States (PIT5264C)
- UPFITTER Bulletin - Info - Radio Telephone/Mobile Radio (Transceiver) Installation And Troubleshooting Guidelines (UI 119)
- Information On Requests To Add ONSTAR BLUETOOTH Option (PIT4864F)
- ONSTAR Voice Recognition Operation Issues (PIC3011H)
- Information On Aftermarket Device Interference With ONSTAR® Diagnostic Services (08-08-46-004A)
- OnStar® Phone Number Concerns (Phone Number Incorrect/Assigned to Another Vehicle/Phone) That Occur During Diagnosis of OnStar® System (05-08-46-004C)
- GM Training - July 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-031)
- Information Required Before Contacting GM Technical Assistance or When Ordering Replacement OnStar® VCIM (09-08-46-003)
- OnStar® Labor Operation Codes (05-08-46-005C)
- Servicing Vehicles Upgraded To ONSTAR® Generation 6 Digital-Capable System (Follow Information Below) (09-08-46-001)
- Information on OnStar® Dual-Mode (Analog/Digital) Systems (06-08-46-008C)
- OnStar® Generation 5 or 6 (Digital) System Inoperative/Has No Power, LED Light Not On (Remove/Reinstall OnStar® Fuse and Replace VCIM or Follow SI Diagnostics) (05-08-46-001D)
- Re-establishing Communications with OnStar® Center After Battery Disconnect (00-08-46-004C)
- OnStar® System Inoperative, OnStar® System Status Light is Red, Radio Locked in Phone Mode or DTC B1000 (Update Early Release Generation 5 OnStar® System Software) (04-08-46-004B)
- Availability of GM OnStar® Vehicle Diagnostics and GM Goodwrench® Remote Diagnostic Services (06-08-46-002B)
- Cataloging of Electronic Service Center Parts (06-00-89-016A)
- Incorrect OnStar® Global Positioning System (GPS) Location Reported During OnStar® Call (02-08-46-006C)
- Information on OnStar® Dual-Mode (Analog/Digital) Systems (06-08-46-008A)
- Information On ONSTAR System - Possible Loss Of GPS Signal, Hands-Free Calling Minutes Expire Prematurely And/Or Inability To Add Hands-Free Calling Minutes (02-08-46-007D)
- Programming OnStar(R) Module for Canadian French Voice Recognition (OnStar(R) Generation 5 or Generation 6) (02-08-46-010G)
- Unable to Connect to OnStar(R) or OnStar(R) Personal Calling Inoperative (04-08-46-003B)
- Parts Restriction on Ordering OnStar(R) Generation 5 and 6 Vehicle Communication Interface Modules (VCIM) (03-08-46-004A)
- Programming of Replacement OnStar(R) Vehicle Communication and Interface Modules (VCIM) (01-08-46-002D)
- OnStar(R) System Cellular Antenna Replacement Parts Availability (00-08-46-002A)
- OnStar(R) Proactive Parts Shipment Process (02-08-46-013A)
- Radio Telephone/Mobile Radio (Transceiver) Installation and Troubleshooting Guidelines (04-08-46-002)
Cooling Fan
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- High Temperature Gauge Readings at an Extended Idle with the AC On (A001773B)
Cooling System (Mechanical)
- Information On Flushing Oil Contamination From Cooling System (25-NA-052)
- Information On Ethylene Glycol In Transmission Fluid (08-07-30-035I)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- All Chain Driven Water Pumps (TT003-13)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Information On Aluminum Heater Core and/or Radiator Replacement (73-62-13A)
- DEX-COOL® Coolant - New Leak Detection Dye J 46366 - Replaces J 29545-6 (05-06-02-002B)
- Information on Gradual Coolant Loss Over Time With No Evidence of Leak Found (06-06-01-019B)
- Engine Coolant Recycling and Warranty Information (00-06-02-006D)
- Information on Contacting Technical Assistance for Poor Engine Cooling and/or A/C Blowing Warm Air When Vehicle is Idling or Moving at Low Speeds (06-06-02-005)
- Instructions for Using GE-47716 Vac-N-Fill Coolant Refill Tool (05-06-02-006)
- DEX-COOL(R) Engine Coolant Information (736214)
Cruise Control Systems
- Downhill Cruise Control Surge (PIT3073A)
Differentials & Drive Axles
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Whine or Click Type Noises from Front Axle/New Design Front Axle Side Bearing Adjusters (Inspect/Replace with New Lock Rings) (09-04-19-001)
- Diagnostic Information for Front Wheel Drive Transaxle/Transmission Final Drive and/or Front Hub Bearing Hum and/or Grind Noise (06-07-30-006)
- Revised Front Drive Axle Carrier Lubricant Information (05-00-90-010)
- Clunk, Bump or Squawk when Vehicle Comes to Complete Stop or Accelerating from Complete Stop (Replace Rear Drive Shaft Nickel-Plated Slip Yoke) (01-04-17-004B)
- Revised Wheel Drive Shaft Nut Torque Specification (04-04-95-001)
- Advance Service Info - Fluid Leak From Front Of Vehicle (Add TEFLON Tape To Front Axle Vent/Plug Threads) (03-04-19-003)
- SMU - Revised Wheel Drive Shaft Inner Joint And Seal Replacement (03-04-18-003)
- Whine Noise From Front Axle (03-04-17-005)
Driveshaft & Universal Joints
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Whine Noise from Rear Axle (Diagnose and Replace Rear Shaft With Tuned Torsional Damper Rear Propeller Shaft) (03-04-17-001E)
- Advance Service Info - Fluid Leak From Front Of Vehicle (Add TEFLON Tape To Front Axle Vent/Plug Threads) (03-04-19-003)
- Driveline Clunk When Stopping (Reprogram Powertrain Control Module (Pcm)) (03-07-30-028)
- Whine Noise From Front Axle (03-04-17-005)
Electronic Suspension
- GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
- Parts Restriction Program For Vehicle Stability Enhancement System (Stabilitrak(R)) (02-05-25-007A)
- Service Stability Message and DTC C0550 Set (VSS20040070)
Engine Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Diagnostic Aids For Gas Engine Misfire/Rough Running With DTC P0300-P0308 And/Or DTC P050D (PIP5628G)
- Diagnostic Tip For Malfunction Indicator Lamp (Mil) Illuminated - DTC P0442 And/Or P0455 Set (21-NA-124)
- Sir Mil With DTC B1001 After BCM Or SDM Replacement (PIT4093B)
- Catalytic Converter Break-In Information To Prevent DTCS P0420 And/Or P0430 (PIP3119P)
- SES Light With Fuel Trim And Or Oxygen Sensor Codes (PIP4925B)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Information On Rough Idle, Crank No Start, Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves, Malfunction Indicator Light (Mil) Illuminated - DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308 Set (16-NA-383)
- Prior To Any Circuit Testing (PIP5094A)
- Slight Roughness At Idle With No DTCS - Possible Characteristic (PIP4404F)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- DTC P0300 Setting After Engine Repairs (PIP5169)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- Replacement of Connector When Replacing Fuel Tank Module/Fuel Pump Module (04-06-04-088C)
- Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Revised DTC P1172 and DTC P2636 (05-06-04-024)
- Revised Inspection/Maintenance (I/M) Evaporative Emission (EVAP) System Set Procedure (05-06-04-021)
- High Temperature Gauge Readings at an Extended Idle with the AC On (A001773B)
- Idle Instability, Low or Rough Idle with Electronic Throttle Control (Clean Throttle Body) (04-06-04-040)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- SMU - Revised DTC P0336 (03-06-04-033A)
- SMU - Revised DTC P2135 (03-06-04-062)
- UPFITTER Bulletin - PTO Vs Fast Idle (UI 64)
- Intermittent No Start, Service Stability Message, Abs Light Illuminated, Multiple DTCS, DIC Shows Unknown Driver, Various Electrical Related Conditions (Repair And/Or Reroute Seat Wiring Harness) (03-08-50-014)
- SMU - Revised Engine Oil Pressure Gage Inaccurate Or Inoperative Diagnostic Information (03-08-49-009)
- Check Engine Light On With No DRIVEABILITY Concerns, DTC P0120, P0220, P1516, P1518 (Clear Code) (03-06-04-032)
- SMU - Revised DTC P1125 (03-06-04-031)
- ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
Entertainment Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Diagnostic Tips: XM Audio Traffic And Travel Link Availability And Operation (PIT5353C)
- Programming And Activation Of Replacement ONSTAR Modules (VCIM) (PIC5588C)
- Information On Inappropriate Warranty Claims Submitted For Damaged Radios And Instrument Panel Clusters (IPCS) (08-08-44-015H)
- XM Band Not Receiving All Channels (Preview Mode) (PIC5088F)
- Return Or Reimbursement Of Customer Owned CDS, DVDS Or Navigation Discs (05-08-44-024E)
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- Changes to XM Network of Terrestrial Repeaters (08-08-46-006)
- Information on Refurbish Instead of Replace Out of Warranty Radios with Worn Graphics on Faceplate, Knobs or Buttons (08-08-44-026)
- Parts Restriction on Ordering XM Digital Radio Receiver (04-08-44-009A)
- Utilizing Tech 2® To Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) (04-08-44-005C)
- Cataloging of Electronic Service Center Parts (06-00-89-016A)
- GM Accessories Headrest DVD System Display Monitor Inoperative (Install Cable Connector Clamps) (07-08-44-016A)
- Information on Rear Seat Headphone Foam Ear Pad Replacement if Worn or Damaged (05-08-44-005A)
- Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
- Radio Knobs Available for Service (05-08-44-029A)
- No Communication with Any Modules, Memory Seat May Not Recall, Multiple U-DTCs Set or Instrument Panel Cluster (IPC) Warning Indicators, Crank No Start (Inspect/Repair Affected Wiring Harness) (03-08-50-014A)
- Rear Seat Audio (RSA) and/or Rear HVAC Inoperative (Replace RSA Module) (03-08-44-018C)
- XM Radio Labor Operation Codes (03-08-44-001A)
- Global Position Sensor (GPS) Performance Degradation (00-08-46-003B)
- Compact Disc (Cd) Or DVD Player Skipping, Inoperative, Sluggish And/Or Long Search Times (05-08-44-001)
- Radio Noise Heard In One Or More Speakers (03-08-44-009)
- Diagnostic Information For No Audio Out Of Speakers On One Or More Channels (02-08-44-018)
- Selecting Radio Source Using Steering Wheel Controls (02-08-44-017)
- DTCS B1001, B1271 Or B1780 Set When Replacing/Reprogramming Other Modules (99-06-03-010A)
- Parts Restriction On Ordering XM Digital Radio Receiver (02-08-44-009)
- No Audio Out Of Speakers At Times (Reprogram Radio And/Or Replace Amplifier) (02-08-44-020B)
Exhaust
- Catalytic Converter Break-In Information To Prevent DTCS P0420 And/Or P0430 (PIP3119P)
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Exhaust Popping/Snapping Noise When Vehicle is Hot, at Idle, or Immediately After Vehicle is Shut Off (Replace Muffler Heat Shield) (03-06-05-008D)
- L59, LR4, LM4, LM7, LQ4, LQ9, LS1, LS6 New Exhaust Manifold Bolts and Torque Specifications for GEN III Vortec(tm) Engine (06-06-01-026)
- New Add Time For Labor Operation L2300 - Converter, Oxidation Catalytic-Replace (02-00-89-006C)
- Exhaust/Muffler Heat Shield Rattle, Popping Noise Under Vehicle (Install Heat Shield Retaining Straps on Muffler) (02-06-05-005C)
Exterior Body Panels
- Underbody Component Corrosion (PI0281L)
- PAINTLESS Dent Repair Process (99-08-51-001F)
- Normal Characteristic - Tailgate Cable Slack (PIT3227S)
- Non-Approval Of "Clipping" (Sectioning Of Two Vehicles) For Collision Repair (07-08-98-001B)
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Information On Hem Flange Sealer For Corrosion Protection (06-08-51-005C)
- Squeeze Type Resistance Spot Welding/Equipment (03-08-98-002B)
- Metal Panel Bonding (02-08-98-001C)
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- Rear Floor Carpet Wet with Dirty Water (Apply Sealer) (03-08-57-001B)
- SMU - Addition of Pickup Box End Gate Latch Handle Bezel Procedure (05-08-66-005)
- Usage of E85 Fuels in GM Vehicles (05-06-04-035)
- Revised Crossmember/Body Mount Bolt Installation Information (05-08-61-005)
- Revised Inspection/Maintenance (I/M) Evaporative Emission (EVAP) System Set Procedure (05-06-04-021)
- 2002, 2003, 2004, 2005 Avalanche, Escalade EXT Midgate Cross Bar Seal - Service Part (VSS20040237)
- Repair Procedure for Service Sheet Metal - Craters in ELPO Surface (04-08-98-002)
- Stowage Box Lid Strap Breaking (Install Strap Kit) (04-08-66-009)
- Additional Material and Source for Metal Panel Bonding Adhesives (04-08-98-001)
- 2002/2003/2004 Avalanche, Cadillac EXT Cargo Covers/Cladding Stained or Discolored (VSS20040071)
- Expandable Acoustic Foam (Two Component Sound Dampener) Usage With Collision Damage Repairs (02-08-98-003)
Exterior Lights
- Exterior Lighting Components "Tinted Or Smoked" By An Outside Vendor (15-08-42-001A)
- Headlamp, Tail Lamp, License Lamp Or Fog/Driving Lamp Damage (02-08-42-001J)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- Information on Damaged Fog Lamp Housings Caused By Incorrect Replacement Bulb (05-08-42-008)
- Chime Volume Level Too Loud (Adjust Chime Level Using Tech 2) (03-08-49-013)
- Service Stability Message And DTCS C0455 Or C0550 Set (Update Vehicle Stability Enhancement System (VSES) Module Software) (03-05-25-005)
- Daytime Running Lamp (DRL) Bulb Replacement (00-08-42-010A)
- Outside Rearview Mirror Courtesy Lamp Falls Out, Bulb Burns Out (Replace Lamp Or Bulb) (03-08-64-018)
Frames, Subframes & Crossmembers
- Underbody Component Corrosion (PI0281L)
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Non-approval of "Clipping" (Sectioning of Two Vehicles) For Collision Repair (07-08-98-001A)
- Information on Repair of Polypropylene Energy Absorbers (63-20-02)
- Rear Floor Carpet Wet with Dirty Water (Apply Sealer) (03-08-57-001B)
- Revised Crossmember/Body Mount Bolt Installation Information (05-08-61-005)
- Expandable Acoustic Foam (Two Component Sound Dampener) Usage With Collision Damage Repairs (02-08-98-003)
Front Suspension
- Information On Diagnosis And Replacement Of Shock Absorber And Strut Due To Fluid Leak (72-05-12)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Vibration Analysis Worksheet (03-00-91-001I)
- SMU - Revised Upper Control Arm Replacement (06-03-08-002)
- Rattle/Squeak from Front of Vehicle (Replace Lower Portion of Upper Insulator Assembly) (03-03-08-002B)
- Revised Stabilizer Shaft Link Replacement Procedure and Fastener Tightening Specifications (05-03-08-006)
Fuel System
- Top Tier™ Detergent Gasoline And Top Tier™ Diesel Fuel Information And Licensed Brands (05-06-04-022Q)
- Rough Idle Crank No Start Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves (PIP5029H)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Usage Of E85 Fuel In Gm Vehicles (05-06-04-035E)
- DTC P0300 Setting After Engine Repairs (PIP5169)
- Fuel And Oil Additives - Facts And Myths - Maximizing Gasoline Fuel Economy (05-00-89-072F)
- Top Tier Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047L)
- Gm Fuel System Treatment Plus, Fuel Sending Unit Corrosion And Fuel System Deposits (05-00-89-078C)
- Use of E85 Fuels in Vehicles Not Certified by GM as being FlexFuel Compatible / Aftermarket Conversion of Vehicles to Operate on E85 Fuels (06-06-04-035A)
- Replacement of Connector When Replacing Fuel Tank Module/Fuel Pump Module (04-06-04-088C)
- LR4, Lm4, Lm7, L59, LQ9, LQ4, L18 DTC P0446 (Restricted/Blocked EVAP Vent Path) Set, Service Engine Soon (SES) Lamp Illuminated (Replace Vent Solenoid And Bracket) (04-06-04-055A)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Usage of E85 Fuels in GM Vehicles (05-06-04-035)
- Revised DTC P1172 and DTC P2636 (05-06-04-024)
- Revised Inspection/Maintenance (I/M) Evaporative Emission (EVAP) System Set Procedure (05-06-04-021)
- Cranks But No Start, Stall, Inaccurate/Incorrect Fuel Gauge Reading, No Fuel, Vehicle is Out of Fuel and Fuel Gauge Reads Above Empty (Replace Fuel Level Sensor) (04-08-49-018E)
- Idle Instability, Low or Rough Idle with Electronic Throttle Control (Clean Throttle Body) (04-06-04-040)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- SMU - Revised DTC P2135 (03-06-04-062)
- Check Engine Light On With No DRIVEABILITY Concerns, DTC P0120, P0220, P1516, P1518 (Clear Code) (03-06-04-032)
- SMU - Revised DTC P1125 (03-06-04-031)
- ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
Fuses & Circuit Breakers
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Service Alert: Concerns With Aftermarket Fuses in GM Vehicles (07-08-45-002)
- Information on Changes to the SI Table of Contents, Electrical Connectors, Terminal Testing/Repair, and the Importance of J-38125 Electrical Terminal Repair Kit Maintenance (06-08-45-001)
- Diagnostic Information For No Audio Out Of Speakers On One Or More Channels (02-08-44-018)
Gauges & Instrument Panels
- Interior Cleaning - Instrument Panel (IP), Hard Or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability (06-00-89-029W)
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Speedometer Needle Accuracy Information (PIT5195H)
- Verifying Odometer Accuracy (PIC3100G)
- IPC Odometer Programming Method Quick Reference Guide (07-08-49-020O)
- Information On Inappropriate Warranty Claims Submitted For Damaged Radios And Instrument Panel Clusters (IPCS) (08-08-44-015H)
- Cargo Lamp Indictor Turns On Briefly When Dome/Glove Box Lamp Is Activated (PIT3553A)
- Fuel Gauge Fluctuation In Park Or Neutral (PIT3046G)
- Information on Instrument Panel Cluster (IPC) Odometer and Engine Hour Meter Set Up at Dealership After IPC Replacement (07-08-49-015D)
- Utilizing Tech 2® To Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) (04-08-44-005C)
- Cataloging of Electronic Service Center Parts (06-00-89-016A)
- PRNDL Display Reduced Visibility For Approximately One Minute (02-08-72-004A)
- Noise Coming From Instrument Panel Cluster (Replace Instrument Panel Cluster (IPC)) (04-08-49-015A)
- Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
- Instrument Panel (I/P), Body and General Wiring Harness Repair (06-08-45-004)
- Malfunction Indicator Lamp (MIL) On, Transmission Stuck in Second or Third Gear, Instrument Cluster Inoperative (Verify and Repair Source of Voltage Loss In Transmission Solenoid Power Supply Circuit) (01-07-30-002E)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- GMT 800 IP Clusters for 2003-2004 Full Size Pickups and Utilities (VSS20050398)
- Supplemental Inflatable Restraint (SIR) Light ON, Diagnostic Trouble Codes (DTC) B0026 and/or B0044 (Inspect and/or Replace IP Harness to Inflatable Restraint Steering Wheel Module Yellow 4-Way Connector C221) (05-09-41-001)
- Cranks But No Start, Stall, Inaccurate/Incorrect Fuel Gauge Reading, No Fuel, Vehicle is Out of Fuel and Fuel Gauge Reads Above Empty (Replace Fuel Level Sensor) (04-08-49-018E)
- Instrument Panel Cluster (IPC) Gauges Inoperative (Reprogram IPC) (03-08-49-020)
- SMU - Revised Engine Oil Pressure Gage Inaccurate Or Inoperative Diagnostic Information (03-08-49-009)
- IP Cluster High Beam Indicator Too Bright (Reprogram IPC) (03-08-49-006)
General Servicing
- Information On Refrigerant (R1234YF) For A/C Service (12-01-37-001G)
- Passenger Compartment Air Filter - Aftermarket Dirt Dust HVAC Information Interior Part (PI01348)
- Diagnostic Information To Consider Before Air Conditioning Compressor Replacement (01-01-38-013A)
Headlights
- Exterior Lighting Components "Tinted Or Smoked" By An Outside Vendor (15-08-42-001A)
- Headlamp, Tail Lamp, License Lamp Or Fog/Driving Lamp Damage (02-08-42-001J)
- Replacement of Headlamp Assemblies Under Warranty and Use of GM vs. Non-GM Headlamp Assemblies (08-08-42-005B)
- Chime Volume Level Too Loud (Adjust Chime Level Using Tech 2) (03-08-49-013)
- Daytime Running Lamp (DRL) Bulb Replacement (00-08-42-010A)
Heated Glass/Defoggers
- Rear And Side Tempered Glass Spots (Quench Marks) (PI0754G)
- Repair Information For Reconnection Of Rear Window (Defroster) Contact Or Tab (03-08-48-006J)
HVAC Control Systems
- Ac Blows Warm Or Poor Performance (PIT5099H)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Air Conditioning Odor (Install Evaporator Core Dryer Kit And Apply Cooling Coil Coating) (99-01-39-004I)
- Diagnostic Tips For Odor Emanating From HVAC System (PI1440)
- Information On Aluminum Heater Core and/or Radiator Replacement (73-62-13A)
- Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
- 18 Digit "Snapshot/Charge Summary" Code No Longer Required For A/C Refrigerant System Repairs Submitted For Warranty Reimbursement (05-01-38-008B)
- Blower Motor Inoperative or May Not Shut Off in Extremely Low Ambient Temperature Conditions (Replace Blower Motor Control Module) (06-01-39-002C)
- HVAC Blower Motor Inoperative or Stays Running (Replace Blower Motor Control Module) (04-01-39-009C)
- Unable To Control Rear HVAC Temperature Or Modes, Intermittent Ticking Noise From Rear HVAC Actuators Or Rear HVAC DTCs B0434 Or B3764 (Replace Auxiliary HVAC Control Module) (06-01-39-015A)
- Contaminated R134a Refrigerant Found on Market for Automotive Air-Conditioning Systems (06-01-39-007)
- Information on Contacting Technical Assistance for Poor Engine Cooling and/or A/C Blowing Warm Air When Vehicle is Idling or Moving at Low Speeds (06-06-02-005)
- Intermittent Heated Seats Inoperative, DTC B3941 Set (Reprogram Driver Seat Module) (05-08-50-008)
- HVAC Module External Seal Kit Now Available For Service Use (04-01-38-018)
- Diagnostic Information for Moan, Groan or Boom Noise at Idle, Vibration in Steering Wheel or Felt Through Floor When A/C Compressor Engages - Do Not Replace A/C Compressor (04-01-38-015)
- HVAC Not Cold Enough, A/C Compressor Does Not Engage (Repair Engine Compartment Wiring Harness Near Idler Arm) (04-01-38-013)
- Contaminated R-134a A/C Systems - Air Conditioning System Flushing Procedures and Universal In-Line A/C Filter Installation (83-12-21)
- J-43600 ACR 2000 Essential Refrigerant Recovery/Recharge Equipment (99-01-38-006B)
- HVAC System Cannot be Controlled or Defaults to Defrost Mode (Repair HVAC Actuator Harness) (04-01-38-008)
- Revised Air Conditioning (A/C) System Performance Test (04-01-37-004)
- Service Information for Front Heated Seat Inoperative/Cold (04-08-50-007)
- HVAC Control Knob Replacement (04-01-37-001)
- Passenger Compartment Air Filter - Aftermarket Dirt Dust HVAC Information Interior Part (PI01348)
- J 44551 A/C Suction Screen Kit Repair Recommendations And Procedures After Catastrophic Compressor Failures (01-01-39-003A)
- A/C Refrigerant System Sealer And A/C System Leak Detection Guidelines (03-01-38-001)
- Automatic Air Conditioning Control Operation (99-01-39-007B)
- Diagnostic Information To Consider Before Air Conditioning Compressor Replacement (01-01-38-013A)
Identification
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Battery Specification Label (04-06-03-016)
- Incorrect Amp Code On Generator (04-06-03-001)
Ignition Switch/Steering Lock
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (U.S. Only) (10-00-89-009F)
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (CANADA Only) (10-00-89-010C)
- Key Code Information (99-00-89-011E)
- Diagnostic Information for Intermittent Vehicle No Crank/Dead Battery (04-06-03-002)
Ignition System
- Information on New Spark Plugs and Gapping (03-06-04-060B)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
Infotainment
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- ONSTAR Module 2G Sunset Information (23-NA-001)
- DVD Navigation Update Program, Navigation Disc Diagnostic Aid, AVN Software Update Discs And Ordering Information (06-08-44-012G)
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Information On Navigation Radio Not Displaying Accurate Vehicle Location After Radio Replacement, Power Loss Or Battery Replacement (08-08-44-023A)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- Navigation Radio Diagnostic Tips (08-08-44-010F)
- Re-establishing Communications with OnStar® Center After Battery Disconnect (00-08-46-004C)
- Cataloging of Electronic Service Center Parts (06-00-89-016A)
- Incorrect OnStar® Global Positioning System (GPS) Location Reported During OnStar® Call (02-08-46-006C)
- Information On ONSTAR System - Possible Loss Of GPS Signal, Hands-Free Calling Minutes Expire Prematurely And/Or Inability To Add Hands-Free Calling Minutes (02-08-46-007D)
- Information on Obtaining Replacement Navigation Discs When Radios are Exchanged - Order Replacement Navigation Disc Through Navigation Disc Center (07-08-44-007)
- Unable to Connect to OnStar(R) or OnStar(R) Personal Calling Inoperative (04-08-46-003B)
- OnStar(R) System Cellular Antenna Replacement Parts Availability (00-08-46-002A)
- Global Position Sensor (GPS) Performance Degradation (00-08-46-003B)
Interior/Exterior Trim
- Information On Proper Use Of Floor Mats (10-08-110-001L)
- Diagnostic Tip - Headliner Sagging Reattach Hook And Loop Patch (PIT3946C)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Normal Characteristic - Passenger Compartment Air Filter (PIT3330G)
- Tonneau Cover, Cargo To MIDGATE Water Leak (Adjust Strikers) (07-08-57-005B)
- Cargo Covers and/or Body Cladding Discolored (Chalky) (Apply Coating) (04-08-111-001F)
- Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including Chevy Bowtie (Bulletin Cancelled) (06-08-111-004B)
- Information on Maintaining Exterior Weatherstrip Appearance (99-08-64-016C)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- Cadillac Escalade EXT and Chevrolet Avalanche Cargo Area (01-08-66-006D)
- Revised Weatherstrip Replacement - MIDGATE - Upper (06-08-66-006)
- Radio Knobs Available for Service (05-08-44-029A)
- Rear Floor Carpet Wet with Dirty Water (Apply Sealer) (03-08-57-001B)
- 2002, 2003, 2004, 2005 Avalanche, Escalade EXT Midgate Cross Bar Seal - Service Part (VSS20040237)
- Center Console CUPHOLDER And Ashtray Cover Won't Close (Replace Latch Assembly) (03-08-49-017A)
- 2002/2003/2004 Avalanche, Cadillac EXT Cargo Covers/Cladding Stained or Discolored (VSS20040071)
- MIDGATE Rear Glass Storage Retainers Now Available For Service (03-08-66-012)
- Removing Front Door Trim Panel To Avoid Breakage (03-08-64-029)
- Intermittent No Start, Service Stability Message, Abs Light Illuminated, Multiple DTCS, DIC Shows Unknown Driver, Various Electrical Related Conditions (Repair And/Or Reroute Seat Wiring Harness) (03-08-50-014)
- Information On Removing Front Door Trim Panel During Switch Removal To Avoid Breakage (03-08-64-022)
- HOMELINK Transceiver/Garage Door Opener Transmitter Test Kit (01-08-97-001B)
- Outside Rearview Mirror Courtesy Lamp Falls Out, Bulb Burns Out (Replace Lamp Or Bulb) (03-08-64-018)
- IP Cluster High Beam Indicator Too Bright (Reprogram IPC) (03-08-49-006)
- Second Row Seat Center Armrest Panel Warping (Replace Panel) (03-08-50-001)
- Rattle In Floor Console CUPHOLDER Door (Add Felt Washer) (03-08-49-001)
- Adm Msg VSS20020152- Door Lock Bezel Retention (VSS20020152)
Interior/Illumination Lights
- Cargo Lamp Indictor Turns On Briefly When Dome/Glove Box Lamp Is Activated (PIT3553A)
- Service Stability Message And DTCS C0455 Or C0550 Set (Update Vehicle Stability Enhancement System (VSES) Module Software) (03-05-25-005)
Lubrication System
- Information On Flushing Oil Contamination From Cooling System (25-NA-052)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Engine Oil Consumption Guidelines (01-06-01-011Q)
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Information On Gasoline Engine Replacement Guidelines After Connecting Rod Or Crankshaft Main Bearing Damage - Replace Oil Cooler, Oil Cooler Lines, Oil Tank And Turbocharger (22-NA-074)
- Information For Engine Concerns Resulting From Lack Of Scheduled Maintenance, Improper Service Or Aftermarket Calibrations (16-NA-222)
- Information On New Torque Specification And Installation Procedure For ACDELCO Spin-On Oil Filters (22-NA-009)
- Fuel And Oil Additives - Facts And Myths - Maximizing Gasoline Fuel Economy (05-00-89-072F)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- 60 Degree V6 Engine Oil Leak at Crankshaft Front Oil Seal (Use New Crankshaft Front Oil Seal Installer Tool EN-48869) (07-06-01-023)
- Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019F)
- Oil Leak Under Extreme Cold Temperatures (-34°C (-30°F) or Colder) (Install Vented Oil Fill Cap) (05-06-01-014)
- SMU - Revised Engine Oil Pressure Gage Inaccurate Or Inoperative Diagnostic Information (03-08-49-009)
- Engine Knock Or Lifter Noise (Replace O-Ring) (02-06-01-038)
- Engine Crankcase Flush (02-06-01-028)
Manual Steering
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Power Steering Noise Or Fluid Leak From Power Steering Pump, Gear Or High Pressure Hose During Extreme Low Temperature Operation (Replace Power Steering Fluid) (12-02-32-002B)
- Diagnosing Power Steering Concerns (05-02-32-008F)
- Vibration Analysis Worksheet (03-00-91-001I)
- Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013B)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
Manual Trans
- Information On Driveline Clunk Noise (99-04-20-002O)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Vibration Analysis Worksheet (03-00-91-001I)
- Instructions To Be Followed To Aid in Obtaining Root Cause Analysis on Both OEM and Goodwrench(R) Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
Mechanical
- Engine Replacement After Severe Internal Engine Damage - Replace Intake Manifold (00-06-01-026R)
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Use Of Surface Conditioning Disks When Cleaning Gasket Sealing Surfaces And/Or Reused Parts (00-06-01-012N)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Engine Repair Tip For Installation Of Pistons (PI1394B)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Information On Engine Block Cracked At Head Bolt Hole Locations (23-NA-141)
- Information On Gasoline Engine Replacement Guidelines After Connecting Rod Or Crankshaft Main Bearing Damage - Replace Oil Cooler, Oil Cooler Lines, Oil Tank And Turbocharger (22-NA-074)
- Information For Engine Concerns Resulting From Lack Of Scheduled Maintenance, Improper Service Or Aftermarket Calibrations (16-NA-222)
- Diagnostic Tip On Avoiding Torque Converter Or Crankshaft Damage While Diagnosing Noise Concerns (PIP5640A)
- Needle Bearings Found In The Oil Pan During An Oil Change (PIP5226D)
- Alleged Cylinders Out Of Round (PIP5163E)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Rough Idle Crank No Start Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves (PIP5029H)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Engine Knock On Cold Start (01-06-01-028C)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- Vibration Analysis Worksheet (03-00-91-001I)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019F)
- GM Performance Parts Engine Warranty Q & A (04-06-01-019A)
- Information on Revised Connecting Rod Bolt Torque for Small Block GEN III and GEN IV Vortec(tm) V8 Engines (07-06-01-002)
- Revised Mass Air Flow Core Return Requirements (06-06-04-057)
- Instructions To Be Followed To Aid in Obtaining Root Cause Analysis on Both OEM and Goodwrench(R) Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
- Oil Leak Under Extreme Cold Temperatures (-34°C (-30°F) or Colder) (Install Vented Oil Fill Cap) (05-06-01-014)
- High Temperature Gauge Readings at an Extended Idle with the AC On (A001773B)
- Idle Instability, Low or Rough Idle with Electronic Throttle Control (Clean Throttle Body) (04-06-04-040)
- Powertrain Quality Center For Performance Parts Engine Replacements (03-06-01-006)
- Flywheel/FLEXPLATE Replacement (03-06-01-003)
- Engine Knock Or Lifter Noise (Replace O-Ring) (02-06-01-038)
- Engine Crankcase Flush (02-06-01-028)
- Engine Identification Information (02-06-01-026)
Mechanical - Hydraulic
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Brake Pedal Moves Or Self Applies At Full Turns (PIT3665M)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Brake Lathe Calibration Procedure (VSS20040074)
- Pre-Formed And Pre-Flared Hydraulic Brake Pipe Kits Now Available For Service (13-05-22-001D)
- Vibration Analysis Worksheet (03-00-91-001I)
- Information On Resurfacing Park Brake Portion Of Rear Brake Rotor (12-05-26-001)
- On-Car Brake Lathe Specifications and Maintenance Requirements (05-05-22-001)
Memory Modules
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- HOMELINK Transceiver/Garage Door Opener Transmitter Test Kit (01-08-97-001B)
Mirrors
- Information On Curb Park Assist And Memory Related Issues On Outside Rearview Mirrors (07-08-64-022B)
- Outside Rearview Mirrors May Blow In At Highway Speeds or Power Folding Feature Appears Inoperative (Synchronize Mirrors) (03-08-64-010C)
- Outside Rearview Mirror Courtesy Lamp Falls Out, Bulb Burns Out (Replace Lamp Or Bulb) (03-08-64-018)
- Info - Cycling Power Folding Exterior Mirror To Remain In Locked Position After Transport (02-08-64-022)
Paint & Coatings
- Information On Paint Stain Under Protective Shipping Film (05-08-51-001L)
- PAINTLESS Dent Repair Process (99-08-51-001F)
- Refinishing Aluminum And Chrome Wheels (99-08-51-007G)
- Application Of Anti-Corrosion Materials (01-08-51-003E)
- Information On Hem Flange Sealer For Corrosion Protection (06-08-51-005C)
- Pre-Painting/Cleaning Process For TPO Plastic Fascias (08-08-51-002A)
- Warranty Information-Fascia Refinish Labor Operations (10-08-62-003)
- Cargo Covers and/or Body Cladding Discolored (Chalky) (Apply Coating) (04-08-111-001F)
- Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) (43-17-01B)
- Repair Procedure for Service Sheet Metal - Craters in ELPO Surface (04-08-98-002)
- Additional Material and Source for Metal Panel Bonding Adhesives (04-08-98-001)
- 2002/2003/2004 Avalanche, Cadillac EXT Cargo Covers/Cladding Stained or Discolored (VSS20040071)
Parking Brake System
- Information On Resurfacing Park Brake Portion Of Rear Brake Rotor (12-05-26-001)
- Low Effort Parking Brake Apply System (01-05-26-001A)
- Scraping Noise From Rear Of Vehicle (02-05-26-002A)
Passive Restraints
- Seat Belt Extender Availability (99-09-40-005H)
- Seat Belt Buckle Latching Issues And/Or Seat Belt Warning Lights Illuminated (09-09-40-001C)
- Availability Of Rear Seat Shoulder Belt Comfort Guides (02-09-40-005A)
Power Takeoff
- UPFITTER Bulletin - PTO Vs Fast Idle (UI 64)
Procedures
- Vehicle Noise Diagnosis And TAC Requests For Assistance With Noise Related Complaints (PIP5358D)
- Website For AFIT, TPM, Gr8, MIT And PICO Scope Updates (PIP4723H)
Rear Suspension
- Information On Diagnosis And Replacement Of Shock Absorber And Strut Due To Fluid Leak (72-05-12)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Suspension DTCS C0696 Or C0711 - Incorrect Trim Height - Compressor Inlet Hose Loose Or Compressor Self Test Inoperative (PIT4954D)
- Vibration Analysis Worksheet (03-00-91-001I)
Restraints Control Systems
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Prior To Any Circuit Testing (PIP5094A)
- Seat Belt Buckle Latching Issues And/Or Seat Belt Warning Lights Illuminated (09-09-40-001C)
- Supplemental Inflatable Restraint (SIR) Light ON, Diagnostic Trouble Codes (DTC) B0013, B0014, B0017, B0018, B0024, B0026, B0043, B0044 (Inspect and/or Replace IP Harness to Inflatable Restraint Module (Air Bag) Yellow 4-Way Connector C221 and/or C222) (05-09-41-001B)
- New SIR System Disabling and Enabling Procedure (05-09-41-010)
- Supplemental Inflatable Restraint (SIR) Light ON, Diagnostic Trouble Codes (DTC) B0026 and/or B0044 (Inspect and/or Replace IP Harness to Inflatable Restraint Steering Wheel Module Yellow 4-Way Connector C221) (05-09-41-001)
- Proper Use of Labor Operation Code When Diagnosis Leads to SIR Passenger Presence System Replacement (04-09-41-003)
- Air Bag Lamp On, Passenger Air Bag Indicator Always Reads OFF, DTC B0092 Set (Repair Passenger Presence System (PPS) Sensor Harness) (02-09-41-002A)
- Chime Volume Level Too Loud (Adjust Chime Level Using Tech 2) (03-08-49-013)
- DTCS B1001, B1271 Or B1780 Set When Replacing/Reprogramming Other Modules (99-06-03-010A)
Seats
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Seat Belt Extender Availability (99-09-40-005H)
- Information On Driver Or Passenger Seat Head Restraint Concerns With Comfort, Custom Upholstery Or Other Comfort Enhancing Devices (10-08-50-003A)
- Minor Wrinkles/Creases, Discoloration, Cigarette Burns and Customer Induced Cuts and Stains on Front and Rear Driver and Passenger Seats with Leather, Vinyl or Cloth Seat Covers (04-08-50-006D)
- Unwanted/Loose Seat Movement (Apply Adhesive and Install New Bolts in Seat Mounting Rails) (05-08-50-012A)
- No Communication with Any Modules, Memory Seat May Not Recall, Multiple U-DTCs Set or Instrument Panel Cluster (IPC) Warning Indicators, Crank No Start (Inspect/Repair Affected Wiring Harness) (03-08-50-014A)
- Power Front Seat (RPO AN3) Switch Knobs Loose or Missing (Replace Switch Knobs) (05-08-50-017)
- Intermittent Heated Seats Inoperative, DTC B3941 Set (Reprogram Driver Seat Module) (05-08-50-008)
- Memory Seat May Not Return to Requested Position (Reprogram Driver Seat Module) (04-08-50-016C)
- 2003, 2004, 2005 Silverado and Sierra, Tahoe, Yukon, Avalanche, Suburban, Yukon XL, Escalade, Escalade EXT and ESV, and HUMMER H2 Power Seat Will Not Retain Preset Memory Position (VSS20050521)
- Power Seat Switch Works In The Opposite Direction - Keywords An3 Driver Electrical Intermittent Memory Module Move Operation Recall Reverse RKE (PIT3598)
- Enabling Memory Seat Feature via DIC If Feature Appears Inoperative (04-08-50-003)
- 2003, 2004, 2005 Full Size Pickup and Sport Utility Vehicles Power Seat Will Not Retain Preset Memory Position (VSS20040205)
- Service Information for Front Heated Seat Inoperative/Cold (04-08-50-007)
- Intermittent No Start, Service Stability Message, Abs Light Illuminated, Multiple DTCS, DIC Shows Unknown Driver, Various Electrical Related Conditions (Repair And/Or Reroute Seat Wiring Harness) (03-08-50-014)
- Seat Heater And/Or Memory Power Seat Inoperative (Replace Memory Seat Control Module) (03-08-50-003)
Starter
- Cold Weather And Long Stand Time Battery Maintenance And Testing Tips (15-06-03-001F)
- Warranty Administration - Battery Testing And Warranty Replacement Requirements (North AMERICA Only) (03-06-03-004Z)
- ACDELCO® Replacement Battery Warranty Procedures (03-06-03-003D)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- GM Dealer Visits: Proper Management of Batteries in Dealer Parts Stock / Vehicle Inventory (08-06-03-005)
- Battery and Charging System Electrical Diagnostics (99-06-03-012)
- Battery Charging Tips (Includes Information References for HP2 Hybrid Truck [PHT] 42-volt System) (02-06-03-009C)
- Automatic Dual Zone HVAC Battery Draw (02-01-39-007B)
- Starter Cranks After Key Is Released (Normal Condition) (03-06-03-001D)
- Intermittent No Crank, No Start (03-06-03-006A)
- Diagnostic Information for Intermittent Vehicle No Crank/Dead Battery (04-06-03-002)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Battery Specification Label (04-06-03-016)
- Battery Parasitic Drain (02-06-03-010A)
- Flywheel/FLEXPLATE Replacement (03-06-01-003)
- Adm Msg VSS20020149 - Vehicle Will Not Start (VSS20020149)
- Proper Diagnostic Procedures For No Start, No Crank, Battery, Batteries, Generator, Gauges, SES, Sir, Brake, Security, Theft, Abs, Hot, DIC Messages, Lamp, Light, Battery And Generator Diag. Testing (02-06-03-012)
Steering Column
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Clunking Noise Under Hood and Can Be Felt in Steering Wheel and/or Steering Column (Replace Upper Intermediate Steering Shaft [I-Shaft] Assembly) (00-02-35-003N)
- Selecting Radio Source Using Steering Wheel Controls (02-08-44-017)
Steering Control Systems
- Prior To Any Circuit Testing (PIP5094A)
- Adm Msg VSS20020149 - Vehicle Will Not Start (VSS20020149)
Steering Gear
- Power Steering Noise Or Fluid Leak From Power Steering Pump, Gear Or High Pressure Hose During Extreme Low Temperature Operation (Replace Power Steering Fluid) (12-02-32-002B)
- Information on Pitman Arm Shaft Seal Service Kit (10-02-33-001A)
- Inner Tie Rod Released For Service (03-02-34-001A)
Steering Linkage
- Inner Tie Rod Released For Service (03-02-34-001A)
Sun Roof/T-Top/Convertible Top
- Rear And Side Tempered Glass Spots (Quench Marks) (PI0754G)
- GM Training - GM Moveable Roof Systems Hands-On (#12040.30H) (U.S. Dealers) (This is not a Saturn STS Requirement) (08-00-89-027)
- Sunroof Jams When Closing (Install Guides) (02-08-67-009A)
Suspension Control Systems
- Suspension DTCS C0696 Or C0711 - Incorrect Trim Height - Compressor Inlet Hose Loose Or Compressor Self Test Inoperative (PIT4954D)
- Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
- Parts Restriction Program For Vehicle Stability Enhancement System (Stabilitrak(R)) (02-05-25-007A)
- Service Stability Message and DTC C0550 Set (VSS20040070)
System
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- SES Light With Fuel Trim And Or Oxygen Sensor Codes (PIP4925B)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Information On Rough Idle, Crank No Start, Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves, Malfunction Indicator Light (Mil) Illuminated - DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308 Set (16-NA-383)
- Prior To Any Circuit Testing (PIP5094A)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Slight Roughness At Idle With No DTCS - Possible Characteristic (PIP4404F)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Usage Of E85 Fuel In Gm Vehicles (05-06-04-035E)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Diagnostic Trouble Codes (DTCs) Required On Repair Orders (06-00-89-050B)
- Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
- Information on Engine Misfire MIL/SES Light Illuminated or Flashing DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308, P0420 or P0430 (06-06-04-046)
- Normal Characteristics of Malfunction Indicator Lamp (MIL) During On-Board Diagnostic (OBD) Inspection/Maintenance (I/M) Testing (06-06-04-037)
- Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Diagnostic Information for Intermittent Vehicle No Crank/Dead Battery (04-06-03-002)
- Oil Leak Under Extreme Cold Temperatures (-34°C (-30°F) or Colder) (Install Vented Oil Fill Cap) (05-06-01-014)
- Revised DTC P1172 and DTC P2636 (05-06-04-024)
- Revised Inspection/Maintenance (I/M) Evaporative Emission (EVAP) System Set Procedure (05-06-04-021)
- Idle Instability, Low or Rough Idle with Electronic Throttle Control (Clean Throttle Body) (04-06-04-040)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- SMU - Revised DTC P0336 (03-06-04-033A)
- SMU - Revised DTC P2135 (03-06-04-062)
- UPFITTER Bulletin - PTO Vs Fast Idle (UI 64)
- Intermittent No Start, Service Stability Message, Abs Light Illuminated, Multiple DTCS, DIC Shows Unknown Driver, Various Electrical Related Conditions (Repair And/Or Reroute Seat Wiring Harness) (03-08-50-014)
- Check Engine Light On With No DRIVEABILITY Concerns, DTC P0120, P0220, P1516, P1518 (Clear Code) (03-06-04-032)
- SMU - Revised DTC P1125 (03-06-04-031)
- ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
Towing
- Recreational (Dinghy) Towing (00-00-89-008F)
- Trailer Brakes Applied When Headlights/Park Lamps Are On, Brake Controller Illumination (Modify Brake Controller Wiring Harness) (02-05-22-004C)
- Shift Stabilization And Tow/Haul Mode Feature For Hydra-MATIC 4L60-E/4L65-E And 4L80-E/4L85-E Transmissions (99-07-30-022A)
Transfer Case
- Driveline Characteristics For All-Wheel Drive (AWD) and Four-Wheel Drive (4WD) Systems (01-04-18-001F)
- Instructions To Be Followed To Aid in Obtaining Root Cause Analysis on Both OEM and Goodwrench(R) Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
- Updated Transfer Case Connector Service Kit Now Available For Transfer Case Speed Sensor Wire Harness Connector that Comes Loose Or Connector Retainer Clip Breaks (06-04-21-001)
- Guidelines for Replacement of Transfer Case Control Module (TCCM) (05-04-21-002)
- Information on Excessive Use of RTV Silicone Sealant on New Venture Gear (NVG) and Borg Warner Transfer Cases During Service (05-04-21-001)
- Release Of New Tool J 45380 - Rear Output Shaft Bushing Remover And Installer (02-04-21-007)
Transmission Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Prior To Any Circuit Testing (PIP5094A)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Information On 2-3 Upshift Or 3-2 Downshift Clunk Noise (01-07-30-042H)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- Diagnostic Information on Diagnostic Trouble Code (DTC) P0894 and P1870 (08-07-30-008A)
- Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
- Information Regarding Automatic Transmission Shift Lock Control Function (03-07-30-043A)
- Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
- Malfunction Indicator Lamp (MIL) On, Transmission Stuck in Second or Third Gear, Instrument Cluster Inoperative (Verify and Repair Source of Voltage Loss In Transmission Solenoid Power Supply Circuit) (01-07-30-002E)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Guidelines for Replacement of Transfer Case Control Module (TCCM) (05-04-21-002)
- 1-2, 2-3, 3-4, 4-5 Shift and Torque Converter Clutch (TCC) Characteristics During Cold Weather Operation on 4L60-E, 4L80-E or Allison Transmissions (01-07-30-031A)
- Driveline Clunk When Stopping (Reprogram Powertrain Control Module (Pcm)) (03-07-30-028)
- Shift Stabilization And Tow/Haul Mode Feature For Hydra-MATIC 4L60-E/4L65-E And 4L80-E/4L85-E Transmissions (99-07-30-022A)
- ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
- Diagnostic Information For Intermittent Transmission Downshift, Slip, Busy/Cycling TCC Or Noisy Cooling Fan (99-07-30-016B)
Warning Systems
- No Communication with Any Modules, Memory Seat May Not Recall, Multiple U-DTCs Set or Instrument Panel Cluster (IPC) Warning Indicators, Crank No Start (Inspect/Repair Affected Wiring Harness) (03-08-50-014A)
- Chime Volume Level Too Loud (Adjust Chime Level Using Tech 2) (03-08-49-013)
Wheel Alignment
- Refinishing Aluminum And Chrome Wheels (99-08-51-007G)
- Wheel Alignment Specifications, Requirements And Recommendations For Gm Vehicles (05-03-07-009H)
- Missing Alignment Dowel Pin (PI02003D)
- Revised Front Caster and Camber Adjustment Procedure (02-03-07-002A)
- New Alignment Procedure For Labor Operation Numbers E2020 and E2000 (04-03-07-002A)
- SMU - Revised Front Caster And Camber Adjustment Procedure (02-03-07-002)
Wheel Hubs
- Wheel Hub Changes - Gen III vs. Gen II (08-03-08-003A)
Wheels & Tire System
- Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean And Resurface Wheel Bead Seat) (08-03-10-006I)
- Guidelines When Changing Tire And Wheel Size (PIT3271P)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Vibration Shortly After Tires Are Mounted/Preventing Vibration From Wheel Slip (Tire Sliding On Wheel) (12-03-10-001E)
- Information On Proper Tire Pressure (00-00-90-002M)
- Information On Tire Radial Force Variation (RFV) (00-03-10-006P)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5338B)
- Information On Hunter Road Force Balancer (17-NA-170)
- Non-Design Intent Wheel Lock Nuts And Lug Nuts (17-NA-126)
- Information On Tire/Wheel Characteristics (Vibration, Balance, Shake, Flat Spotting) Of Gm Original Equipment Tires (03-03-10-007J)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Use Of Nitrogen Gas In Tires (05-03-10-020F)
- Statement On Tire Sealant Included In Gm Inflator Kits (Supplied With New Vehicles Or As Gm Accessory) (09-03-10-013B)
- Wheel Balancing Machine Finish Damage To Chrome Clad Or CHROMETECH® Wheels (09-03-10-016A)
- General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015B)
- Guidelines for Using Labor Operations E0200, E0201, E0203, E0204 - Wheel Balance (72-05-03)
- Information on Proper Wheel Changing Procedures and Cautions (06-03-10-010A)
- Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (93-U-57)
- Tire Puncture Repair Procedures For All Cars and Light Duty Trucks (04-03-10-001F)
- Information on Replacement Wheel Weights (09-03-10-017)
- Mounting, Balancing And Installation Of Accessory Wheels And Tires Available Through Gm Accessories (08-03-10-004A)
- Use of Chrome or Chrome Plated Steel Valve Caps on Aluminum Valve Stems (08-03-10-005A)
- Spare Tire is a Different Size than Other Tires (02-03-10-001D)
- Performance Characteristics of Vehicles with Accessory Wheel/Tire Assemblies Installed as "Upsized" to Original Equipment (05-03-10-005D)
- Minimizing Damage to Tire Pressure Monitor (TPM) Sensors During Tire Mounting/Dismounting (08-03-10-007)
- Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
- Driveline Characteristics For All-Wheel Drive (AWD) and Four-Wheel Drive (4WD) Systems (01-04-18-001F)
- Pitting and Brake Dust on Chrome Wheels (04-03-10-012B)
- Spare Tire is a Different Size than Other Tires (02-03-10-001C)
- Proper Use of OEM Service Wheel Weights, Marring and/or Damage Due to Use of Non-OEM and/or Incorrect Wheel Weight Installation (06-03-10-004)
- 20" Wheels and Tires Available Through GM Accessories (04-03-10-007E)
- Use Recommended Tire Mounting Lubricant To Prevent Tires From Slipping on Chrome Wheels (T-93-93)
- Recommended Wheel Nut/Bolt Torque Specifications (02-03-10-008)
- Wheel Balance Weight Usage (99-03-10-009A)
Window Motors & Regulators
- Information On Side Door Window Glass Chipping Caused By Hanging Vehicle Key Lock Box (06-08-64-001D)
- Repair Information For Reconnection Of Rear Window (Defroster) Contact Or Tab (03-08-48-006J)
- Distortion in Outer Surface of Vehicle Glass (00-08-48-005D)
- Marks/Stains on Windshield When Wet (Clean Windshield) (09-08-48-002A)
- Labor Time Revision for C0182 and C0183 Labor Operations (07-08-64-001)
- Availability of A New Design Back Glass (06-08-48-002)
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- Power Window Regulator Now Available Separately From Motor (05-08-64-029B)
- Rubbing or Scratching Noise When Front Driver or Front Passenger Power Windows Are Activated (Install New Anti-Noise Sleeve on Window Regulator Support) (05-08-64-038)
- Diagnostic Information For Front Power Window Noisy Or Inoperative (03-08-64-037B)
- Power Window Motor Now Available Separately From The Power Window Regulator Assembly (04-08-64-003A)
Wiper/Washer Systems
- Windshield Wiper Performance, Cleaning Instructions And Maintenance (06-08-43-003E)
- Replacement of Windshield Wiper Inserts (04-08-43-003)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Prior To Any Circuit Testing (PIP5094A)
- Information on Changes to the SI Table of Contents, Electrical Connectors, Terminal Testing/Repair, and the Importance of J-38125 Electrical Terminal Repair Kit Maintenance (06-08-45-001)
- No Communication with Any Modules, Memory Seat May Not Recall, Multiple U-DTCs Set or Instrument Panel Cluster (IPC) Warning Indicators, Crank No Start (Inspect/Repair Affected Wiring Harness) (03-08-50-014A)
- Diagnostic Information for Intermittent Vehicle No Crank/Dead Battery (04-06-03-002)
- Trailer Brakes Applied When Headlights/Park Lamps Are On, Brake Controller Illumination (Modify Brake Controller Wiring Harness) (02-05-22-004C)
- Intermittent No Start, Service Stability Message, Abs Light Illuminated, Multiple DTCS, DIC Shows Unknown Driver, Various Electrical Related Conditions (Repair And/Or Reroute Seat Wiring Harness) (03-08-50-014)
- UPFITTER Bulletin - Modified Brake Controller Wiring Harness (UI 57)