Fastener Specifications
Single Use Non-Threaded Fasteners/Components
|
NOTE:
All fasteners/components listed in this table MUST BE DISCARDED and replaced with NEW after removal. |
|---|
| Application |
| Power Steering Assist Motor Seal |
| Power Steering Gear Inlet Hose Connector Seal |
| Power Steering Gear Inlet Hose Seal |
| Power Steering Gear Outlet Hose Seal |
| Steering Gear Belt |
| Steering Gear Boot Inner Clamp |
| Steering Gear Bushing |
| Steering Gear Pipe Seal |
Single Use Threaded Fastener/Component Tightening Specifications
|
NOTE:
All fasteners/components listed in this table MUST BE DISCARDED and replaced with NEW after removal. |
|
|---|---|
| Application | Specification |
| Metric (English) | |
| Power Steering Assist Motor Pivot Bolt | 22 N.m (16 lb ft) |
| Steering Gear Bolt | |
|
110 N.m (81 lb ft) |
|
150-165 degrees |
| Steering Gear Housing Cover Bolt - M6 | 10 N.m (89 lb in) |
| Steering Gear Housing Cover Bolt - M8 | 22 N.m (16 lb ft) |
Reusable Threaded Fastener Tightening Specifications
|
NOTE:
All fasteners listed in this table can be reused after removal. |
|
|---|---|
| Application | Specification |
| Metric (English) | |
| Power Steering Fluid Cooler Bracket Bolt | 9 N.m (80 lb in) |
| Power Steering Fluid Reservoir Bracket Bolt | 9 N.m (80 lb in) |
| Power Steering Fluid Reservoir Inlet Hose | 34 N.m (25 lb ft) |
| Power Steering Gear Inlet and Outlet Hose Bolt | 9 N.m (80 lb in) |
| Power Steering Gear Inlet Hose | 9 N.m (80 lb in) |
| Power Steering Gear Inlet Hose and Outlet Pipe Bracket Nut | 9 N.m (80 lb in) |
| Power Steering Gear Inlet Hose Bolt | 50 N.m (37 lb ft) |
| Power Steering Gear Inlet Hose Bracket Bolt-Bracket@Engine | 58 N.m (43 lb ft) |
| Power Steering Gear Inlet Hose Bracket Bolt-Hose@Bracket | 9 N.m (80 lb in) |
| Power Steering Gear Inlet Hose Connector | 34 N.m (25 lb ft) |
| Power Steering Gear Outlet Hose | 34 N.m (25 lb ft) |
| Power Steering Pump Bolt | 22 N.m (16 lb ft) |
| Power Steering Pump Bracket Bolt-Long | 58 N.m (43 lb ft) |
| Power Steering Pump Bracket Bolt-Short | 22 N.m (16 lb ft) |
| Steering Gear Heat Shield Bolt | 9 N.m (80 lb in) |
| Steering Gear Pipe | 19 N.m (14 lb ft) |
| Steering Gear Pipe Retainer Bolt | 12 N.m (106 lb in) |
| Steering Gear Wiring Harness Bracket Bolt | 9 N.m (80 lb in) |
| Steering Linkage Inner Tie Rod | 100 N.m (74 lb ft) |
| Steering Linkage Outer Tie Rod Nut | |
|
35 N.m (26 lb ft) |
|
30 - 45 degrees |