Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups- Accessories & Equipment
- Cruise Control Systems
- Cruise Control System - Vacuum Servo (3.8L)
- Description & Operation
- Adjustments
- Testing
- Notes
- Cruise Control System Check
- Code 24, Vehicle Speed Sensor (VSS)
- Code 38, Brake Switch Circuit
- Code 61, Cruise Vent Solenoid
- Code 62, Cruise Vacuum Solenoid
- Code 63, Cruise Servo Position Sensor (SPS) Indicates Low
- Code 65, Cruise Servo Position Sensor (SPS)
- Code 67, Cruise Engage Switches
- Code 68, Cruise System Problem
- Cruise Control System - Vacuum Servo (Except 3.8L)
- Cruise Control System - Vacuum Servo (3.8L)
- Gauges & Instrument Panels
- Heated Glass/Defoggers
- Steering Column Switches
- Window Motors & Regulators
- Wiper/Washer Systems
- Description & Operation
- Trouble Shooting
- System Testing
- Front Wipers Inoperative In All Modes
- Front Wipers Operate In High Speed Only
- Front Wipers Operate In Low Speed Only
- Front Wipers Run Continuously
- Front Wiper Pulse Delay Inoperative Or Operates Incorrectly
- Front Washer Inoperative
- Rear Wiper Inoperative In All Modes
- Rear Wiper Delay Operates Incorrectly Or Not At All
- Rear Washer Inoperative
- Rear Wiper Runs Continuously
- Removal & Installation
- Torque Specifications
- Wiring Diagrams
- Cruise Control Systems
- Body & Frame
- Brakes
- Anti-Lock Brakes
- Anti-Lock Brake System - 4-Wheel
- Description
- Operation
- Bleeding Brake System
- Diagnosis & Testing
- Diagnostic Charts
- Notes
- Chart A: Abs Warning Light On Continuously, No Codes Stored
- Chart B: Abs Warning Light On Intermittently, No Codes Stored
- Chart C: Abs Warning Light Constantly Off, No Codes Stored
- Chart D - Tech 1 Displays Undefined Codes
- Code A011 - Abs Warning Light Circuit Open Or Shorted To Ground
- Code A013 - Abs Warning Light Circuit Shorted To Battery
- Code A014 - Enable Relay Contacts Or Fuse Open
- Code A015 - Enable Relay Contacts Shorted To Battery
- Code A016 - Enable Relay Coil Circuit Open
- Code A017 - Enable Relay Coil Circuit Shorted To Ground
- Code A018 - Enable Relay Coil Circuit Shorted To Battery
- Code A021 - Left Front Wheel Speed Is Zero
- Code A022 - Right Front Wheel Speed Is Zero
- Code A023 - Left Rear Wheel Speed Is Zero
- Code A024 - Right Rear Wheel Speed Is Zero
- Code A025 - Excessive Left Front Wheel Speed Variation
- Code A026 - Excessive Right Front Wheel Speed Variation
- Code A027 - Excessive Left Rear Wheel Speed Variation
- Code A028 - Excessive Right Rear Wheel Speed Variation
- Code A032 - Left Front Wheel Sensor Shorted To Battery Or Ground
- Code A033 - Right Front Wheel Sensor Shorted To Battery Or Ground
- Code A034 - Left Rear Wheel Sensor Shorted To Battery Or Ground
- Code A035 - Right Rear Wheel Sensor Shorted To Battery Or Ground
- Code A036 - System Voltage Low
- Code A037 - System Voltage High
- Code A038 - Left Front ESB Will Not Hold Motor
- Code A041 - Right Front ESB Will Not Hold Motor
- Code A042 - Rear Axle ESB Will Not Hold Motor
- Code A044 - Left Front Channel Will Not Move
- Code A045 - Right Front Channel Will Not Move
- Code A046 - Rear Axle Channel Will Not Move
- Code A047 - Left Front Motor Spins Freely
- Code A048 - Right Front Motor Spins Freely
- Code A051 - Rear Axle Motor Spins Freely
- Code A052 - Left Front Channel In Release Too Long
- Code A053 - Right Front Channel In Release Too Long
- Code A054 - Rear Axle Channel In Release Too Long
- Code A055 - EBCM Failure
- Code A056 - Left Front Motor Circuit Open
- Code A057 - Left Front Motor Circuit Shorted To Ground
- Code A058 - Left Front Motor Circuit Shorted To Battery Or Motor Shorted
- Code A061 - Right Front Motor Circuit Open
- Code A062 - Right Front Motor Circuit Shorted To Ground
- Code A063 - Right Front Motor Circuit Shorted To Battery Or Motor Shorted
- Code A064 - Rear Axle Motor Circuit Open
- Code A065 - Rear Axle Motor Circuit Shorted To Ground
- Code A066 - Rear Axle Motor Circuit Shorted To Battery Or Motor Shorted
- Code A076 - Left Front Solenoid Circuit OPENOR Shorted To Battery
- Code A077 - Left Front Solenoid Circuit Shorted To Ground Or Driver Circuit Open
- Code A078 - Right Front Solenoid Circuit Open Or Shorted To Battery
- Code A081 - Right Front Solenoid Circuit Shorted To Ground Or Driver Circuit Open
- Code A082 - Calibration Memory Failure
- Code A086 - Red Brake Warning Light Activated By Abs
- Code A087 - Red Brake Warning Light Circuit Open
- Code A088 - Red Brake Warning Light Circuit Shorted To Battery
- Code A091 - Open Brake Switch Contacts (During Deceleration)
- Code A092 - Open Brake Switch Contacts (When Abs Required)
- Code A093 - Code A091 Or A092 Failed In Last Or Current Ignition Cycle
- Code A094 - Brake Switch Contacts Always Closed
- Code A095 - Open Brake Switch Circuit
- Code A096 - BRAKELIGHT Circuit Open
- Removal & Installation
- Torque Specifications
- Wiring Diagram
- Anti-Lock Brake System - 4-Wheel
- Mechanical - Hydraulic
- Disc & Drum Brake System
- Model Identification
- Description & Operation
- Bleeding Brake System
- Adjustments
- Height-Sensing Proportioning Valve
- Parking Brake
- Notes
- Astro & Safari
- Lumina APV, Silhouette & Trans Sport
- "C" & "K" Series With Leading/Trailing Brakes
- "C" Series with Transmission-Mounted Parking Brake
- "C" & "K" Series With Dual-Servo Brakes, "G" Series & "P" Series With Foot Pedal
- "P" Series With Hand Lever
- "P" Series With Transmission-Mounted Parking Brake
- "S" & "T" Series
- Parking Brake Control Rod
- Rear Brake Shoes
- Stoplight Switch
- Testing
- Removal & Installation
- Automatic Parking Brake - ("P" Series MOTORHOME)
- Front Brake Caliper
- Front Brake Rotor
- Removal (All 2WD Vehicles Except Lumina APV, Silhouette & Trans Sport)
- Installation (All 2WD Vehicles Except Lumina APV, Silhouette & Trans Sport)
- Removal & Installation (AWD Astro & Safari, Bravada, Lumina APV, Silhouette, Trans Sport & All Light Duty 4WD Vehicles)
- Removal & Installation (K3500 & C3500HD)
- Rear Brake Caliper
- Rear Brake Rotor
- Rear Brake Drum
- Rear Brake Shoes
- Wheel Cylinder
- Master Cylinder
- Power Brake Booster
- Height-Sensing Proportioning Valve
- Combination Valve
- Rear Axle Bearing & Oil Seal (Semi-Floating Axle)
- Rear Axle Hub Bearings & Oil Seal (Full-Floating Axle)
- Overhaul
- Torque Specifications
- Drum Brake Specifications
- Disc Brake Specifications
- Disc & Drum Brake System
- Traction Control
- Anti-Lock Brake System - 4-Wheel
- Description
- Operation
- Bleeding Brake System
- Diagnosis & Testing
- Diagnostic Charts
- Notes
- Chart A: Abs Warning Light On Continuously, No Codes Stored
- Chart B: Abs Warning Light On Intermittently, No Codes Stored
- Chart C: Abs Warning Light Constantly Off, No Codes Stored
- Chart D - Tech 1 Displays Undefined Codes
- Code A011 - Abs Warning Light Circuit Open Or Shorted To Ground
- Code A013 - Abs Warning Light Circuit Shorted To Battery
- Code A014 - Enable Relay Contacts Or Fuse Open
- Code A015 - Enable Relay Contacts Shorted To Battery
- Code A016 - Enable Relay Coil Circuit Open
- Code A017 - Enable Relay Coil Circuit Shorted To Ground
- Code A018 - Enable Relay Coil Circuit Shorted To Battery
- Code A021 - Left Front Wheel Speed Is Zero
- Code A022 - Right Front Wheel Speed Is Zero
- Code A023 - Left Rear Wheel Speed Is Zero
- Code A024 - Right Rear Wheel Speed Is Zero
- Code A025 - Excessive Left Front Wheel Speed Variation
- Code A026 - Excessive Right Front Wheel Speed Variation
- Code A027 - Excessive Left Rear Wheel Speed Variation
- Code A028 - Excessive Right Rear Wheel Speed Variation
- Code A032 - Left Front Wheel Sensor Shorted To Battery Or Ground
- Code A033 - Right Front Wheel Sensor Shorted To Battery Or Ground
- Code A034 - Left Rear Wheel Sensor Shorted To Battery Or Ground
- Code A035 - Right Rear Wheel Sensor Shorted To Battery Or Ground
- Code A036 - System Voltage Low
- Code A037 - System Voltage High
- Code A038 - Left Front ESB Will Not Hold Motor
- Code A041 - Right Front ESB Will Not Hold Motor
- Code A042 - Rear Axle ESB Will Not Hold Motor
- Code A044 - Left Front Channel Will Not Move
- Code A045 - Right Front Channel Will Not Move
- Code A046 - Rear Axle Channel Will Not Move
- Code A047 - Left Front Motor Spins Freely
- Code A048 - Right Front Motor Spins Freely
- Code A051 - Rear Axle Motor Spins Freely
- Code A052 - Left Front Channel In Release Too Long
- Code A053 - Right Front Channel In Release Too Long
- Code A054 - Rear Axle Channel In Release Too Long
- Code A055 - EBCM Failure
- Code A056 - Left Front Motor Circuit Open
- Code A057 - Left Front Motor Circuit Shorted To Ground
- Code A058 - Left Front Motor Circuit Shorted To Battery Or Motor Shorted
- Code A061 - Right Front Motor Circuit Open
- Code A062 - Right Front Motor Circuit Shorted To Ground
- Code A063 - Right Front Motor Circuit Shorted To Battery Or Motor Shorted
- Code A064 - Rear Axle Motor Circuit Open
- Code A065 - Rear Axle Motor Circuit Shorted To Ground
- Code A066 - Rear Axle Motor Circuit Shorted To Battery Or Motor Shorted
- Code A076 - Left Front Solenoid Circuit OPENOR Shorted To Battery
- Code A077 - Left Front Solenoid Circuit Shorted To Ground Or Driver Circuit Open
- Code A078 - Right Front Solenoid Circuit Open Or Shorted To Battery
- Code A081 - Right Front Solenoid Circuit Shorted To Ground Or Driver Circuit Open
- Code A082 - Calibration Memory Failure
- Code A086 - Red Brake Warning Light Activated By Abs
- Code A087 - Red Brake Warning Light Circuit Open
- Code A088 - Red Brake Warning Light Circuit Shorted To Battery
- Code A091 - Open Brake Switch Contacts (During Deceleration)
- Code A092 - Open Brake Switch Contacts (When Abs Required)
- Code A093 - Code A091 Or A092 Failed In Last Or Current Ignition Cycle
- Code A094 - Brake Switch Contacts Always Closed
- Code A095 - Open Brake Switch Circuit
- Code A096 - BRAKELIGHT Circuit Open
- Removal & Installation
- Torque Specifications
- Wiring Diagram
- Anti-Lock Brake System - 4-Wheel
- Anti-Lock Brakes
- Drivelines & Axles
- Electrical
- Charging Systems
- Alternator & Regulator
- Description (Alternator & Regulator)
- Operation (Alternator & Regulator)
- Adjustments (Alternator & Regulator)
- Trouble Shooting (Alternator & Regulator)
- On-Vehicle Testing (Alternator & Regulator)
- Bench Testing (Alternator & Regulator)
- Removal & Installation (Alternator & Regulator)
- Overhaul (Alternator & Regulator)
- Specifications (Alternator & Regulator)
- Alternator & Regulator
- Component Locations
- Fuses & Circuit Breakers
- Fuses & Circuit Breakers
- Fuse Panel Location
- Circuit Breaker/Relay Panel
- Fuse Panel Identification (1990 Trans Sport)
- Fuse Panel Identification (1990 Lumina APV & Silhouette)
- Fuse Panel Identification (1991 Models)
- Fuse Panel Identification (1992-95 Models With 3.1L Engine)
- Fuse Panel Identification (1992-95 Models With 3.8L Engine)
- Fuses & Circuit Breakers
- Gauges
- Starter
- Wiring Diagrams
- Charging Systems
- Engine Mechanical
- Accessory Drive Belts
- Drive Belt Routing
- Adjustments & Inspection
- Serpentine Belt Routing
- Notes
- Serpentine Belt Routing (2.5L)
- Serpentine Belt Routing (2.8L)
- Serpentine Belt Routing (3.1L)
- Serpentine Belt Routing (3.8L)
- Serpentine Belt Routing (4.3L, 5.0L & 5.7L)
- Serpentine Belt Routing ("C" 15, C/K 25 & 35 With 7.4L)
- Serpentine Belt Routing (6.2L & 6.5L - Diesel)
- Serpentine Belt Routing ("G" Series With 4.3L, 5.0L & 5.7L)
- Serpentine Belt Routing ("G" Series With 7.4L)
- Drive Belt Routing
- Auxiliary Emission Control Systems
- EGR Function Testing
- Emission Control System Visual Inspection Procedures - General Information
- * Please Read This First *
- Emission Control Labels
- Emission Control Visual Inspection
- Notes
- Positive Crankcase Ventilation (PCV)
- Thermostatic Air Cleaner (TAC)
- Fuel Evaporative System (EVAP)
- Catalytic Converters
- Fill Pipe RESTRICTOR (Fr)
- Exhaust Gas RECIRCULATION (EGR) System
- Spark Controls (SPK)
- Air Injection System (AIS)
- Oxygen Sensor (O2)
- Computerized Engine Controls (CEC)
- Early Fuel Evaporation (EFE)
- Emission Maintenance Reminder Light (EMR) (If Equipped)
- Malfunction Indicator Light (Mil)
- Engine Cooling Fan
- Description
- Operation
- Trouble Shooting
- Scan Tester
- Cooling Fan Charts
- Chart C-12, Cooling Fan Diagnosis 3.1L - VIN D (1 Of 2)
- Chart C-12, Cooling Fan Diagnosis 3.1L - VIN D (2 Of 2)
- Chart C-12A, Cooling Fan Diagnosis 3.8L - VIN L (1 Of 4)
- Chart C-12B, Fan On At All Times 3.8L - VIN L (2 Of 4)
- Chart C-12C, No Puller Fan 3.8L - VIN L (3 Of 4)
- Chart C-12D, No Pusher Fan 3.8L - VIN L (4 Of 4)
- Wiring Diagrams
- Cooling System (Mechanical)
- Cooling System Specifications
- Drive Belt Routing
- Adjustments & Inspection
- Serpentine Belt Routing
- Notes
- Serpentine Belt Routing (2.5L)
- Serpentine Belt Routing (2.8L)
- Serpentine Belt Routing (3.1L)
- Serpentine Belt Routing (3.8L)
- Serpentine Belt Routing (4.3L, 5.0L & 5.7L)
- Serpentine Belt Routing ("C" 15, C/K 25 & 35 With 7.4L)
- Serpentine Belt Routing (6.2L & 6.5L - Diesel)
- Serpentine Belt Routing ("G" Series With 4.3L, 5.0L & 5.7L)
- Serpentine Belt Routing ("G" Series With 7.4L)
- Mechanical
- 3.1L V6 - VIN [D]
- Engine Identification
- Adjustments
- Trouble Shooting
- Removal & Installation
- Overhaul
- Lubrication
- Torque Specifications
- Engine Specifications
- 3.8L V6 - VIN [L]
- Engine Identification
- Adjustments
- Trouble Shooting
- Removal & Installation
- Overhaul
- Lubrication
- Torque Specifications
- Engine Specifications
- 3.1L V6 - VIN [D]
- Starter
- Accessory Drive Belts
- Engine Performance
- Engine Controls - Adjustments
- Application
- Emissions
- EGR Function Testing - General Motors Trucks
- Emission Applications
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Engine Controls - Pin Voltage Charts
- Introduction
- Pin Voltage Charts
- "S" Series - 2.5L
- "S" Series - 2.8L
- "U" Series - 3.1L
- "U" Series - 3.8L
- "M" & "L" Series - 4.3L
- "S" & "T" Series - 4.3L (A/T)
- "S" & "T" Series - 4.3L (Utility, M/T)
- "S" & "T" Series - 4.3L (Pickup, M/T)
- Typhoon - 4.3L Turbo
- "C" & "K" Series - 4.3L, 5.0L & 5.7L (4L60-E A/T)
- "C" & "K" Series - 4.3L, 5.0L, 5.7L & 7.4L (M/T)
- "G" Series - 4.3L, 5.0L & 5.7L
- "P" Series - 4.3L & 5.7L (M/T)
- All 4.3L, 5.7L & 7.4L With 4L80-E A/T
- "C" & "K" Series - 6.2L Diesel (A/T)
- "C" & "K" Series - 6.2L Diesel (M/T)
- Remove, Overhaul & Install
- Engine Controls - Remove/Install/Overhaul
- Introduction
- On-Vehicle Adjustments
- Electronic Control Module (ECM)
- Electronic Spark Control (ESC) Module
- Fuel System (Gasoline)
- Fuel System (Diesel)
- Ignition System
- Throttle Position (TP) Sensor
- Oxygen Sensor
- Turbocharger
- Torque Specifications
- Engine Controls - Remove/Install/Overhaul
- Sensor Range Charts
- Engine Controls - Specifications
- System
- Engine Controls - Basic Testing
- Model Identification
- Introduction
- Preliminary Inspection & Adjustments
- A-3, No-Start Diagnosis
- A-7, Basic Fuel System Checks (Gasoline)
- Basic Fuel System Checks (Diesel)
- C-4, Basic Ignition System Checks (Gasoline)
- Idle Speed & Ignition Timing (Gasoline)
- Diagnostic Circuit Check (Gasoline)
- Diagnostic Circuit Check (Diesel)
- Summary
- Engine Controls - System/Component Tests
- Model Identification
- Introduction
- Air Induction Systems
- Computerized Engine Controls
- Engine Sensors & Switches
- A/C On Switch/System Test
- Brake Switch
- Coolant Temperature Sensor (Cts)
- Knock Sensor
- Manifold Absolute Pressure (Map) Sensor
- Intake Air Temperature (IAT) Sensor
- Oxygen Sensor
- Oxygen Sensor Heating Element (4.3L)
- Park/Neutral (P/N) Switch
- Power Steering Pressure Switch (2.5L)
- Throttle Position (TP) Sensor
- Vehicle Speed Sensor (Pm Generator)
- Relays, Solenoids, Motors & Modules
- Fuel System (Gasoline)
- Fuel System (Diesel)
- Ignition System
- Emission Systems & Sub-Systems (Gasoline)
- Emission Systems & Sub-Systems (Diesel)
- Miscellaneous ECM Controls
- Notes
- Transmission (C-8)
- A/C Clutch (C-10) & Electric Cooling Fan (C-12)
- A/C Clutch (C-10)
- Cooling Fan (C-12)
- Chart C-10, A/C Clutch Control Circuit Diagnosis 2.5L & 2.8L
- C-10, A/C Clutch CNTRL CKT Diagnosis - 3.1L (Front A/C Only)
- C-10, A/C Clutch CNTRL CKT Diagnosis - 3.1L (Rear A/C Only)
- C-10, A/C Clutch Control Circuit Diagnosis - 3.8L
- Chart C-10, A/C Control Diagnosis (A/T) 4.3L Turbo PFI
- Chart C-12, Cooling Fan Circuit Diagnosis 3.1L
- Chart C-12A, Cooling Fan Circuit Diagnosis 3.8L
- Intake Manifold Tuning Valve Assembly
- Component Locations
- Engine Controls - Tests W/Codes - V6
- Introduction
- Self-Diagnostic System
- Summary
- Self-Diagnostic Tests
- Notes
- Code 13, Open Oxygen Sensor Circuit
- Code 14, Coolant Sensor Signal Voltage Low
- Code 15, Coolant Sensor Signal Voltage High
- Code 16, System Voltage High/Low 3.8L
- Code 16, Transmission Output Speed 4.3L "S" & "T" Series Utility Vehicles With M/T & 4.3L With 4L60E Transmission
- Code 17, Rpm Signal Problem 3.8L
- Code 18, Cam/Crank Error 3.8L
- Code 21, TPS Signal Voltage High
- Code 22, TPS Signal Voltage Low
- Code 23, Mat Sensor Temp. Low - 3.8L & 4.3L CPI
- Code 23, Mat Sensor Temp. Low - 4.3L Turbo
- Code 24, Vehicle Speed Sensor - 4.3L Turbo & 4.3L ("C", "K" & "P" Series) With Manual Transmission
- Code 24, Vehicle Speed Sensor (VSS) 3.1L
- Code 24, Vehicle Speed Sensor (VSS) 3.8L
- Code 24, Vehicle Speed Sensor 4.3L "S" & "T" Series Pickup With Man. Trans. (Except Turbo) & All 4WD With 4L80-E Transmission
- Code 24, Vehicle Speed Sensor 4.3L "S" & "T" Series Utility Vehicles With Manual Transmission, 4.3L, 5.0L & 5.7L With 4L60E Transmission & All 2WD With 4L80-E Transmission
- Code 25, Mat Sensor Temp. High - 3.8L & 4.3L CPI
- Code 25, Mat Sensor Temp. Low - 4.3L Turbo
- Code 26, Quad-Driver Circuit 3.8L
- Code 26, Quad-Driver No. 1 Circuit - 4.3L "S" & "T" Series Pickup With Manual Transmission
- Code 27, Quad-Driver No. 2 Circuit - 4.3L "S" & "T" Series Pickup With Manual Transmission
- Code 31, Park/Neutral Switch Circuit - 3.8L
- Code 31, Turbo OVERBOOST - 4.3L Turbo
- Code 32, EGR System Error - 3.1L
- Code 32, EGR System Error - 4.3L "G" Series, 4.3L "C", "K" & "M" Series (Non-CALIFORNIA) With 4L60E Transmission & 4.3L "C", "G", "K" & "P" Series With 4L80-E Transmission
- Code 32, EGR System Error 4.3L "S" & "T" Series Utility Vehicles With Manual Transmission (Except CPI)
- Code 32, EGR System Error - 4.3L "C", "K" & "P" Series) & 4.3L "S" & "T" Series Pickup (Except Turbo) With Manual Transmission
- Code 32, EGR System Error - 4.3L Turbo
- Code 32, EGR System Error - 4.3L With Linear EGR
- Code 33, Map Sensor Signal Voltage High
- Code 34, Map Sensor Signal Voltage Low
- Code 34, MAF Sensor Signal Voltage Low - 3.8L
- Code 35, Idle Speed Error
- IAC Valve Reset Procedure
- Code 36, Shift Control Problem - 3.8L
- Code 38, Brake Switch Circuit - 3.8L
- Code 38, Knock Sensor Circuit Open - 4.3L "S" & "T" Series Pickup With Manual Transmission
- Code 39, TCC Circuit - 3.8L
- Code 39, Knock Sensor Circuit Shorted - 4.3L "S" & "T" Series Pickup With Manual Transmission
- Code 41, Cam Sensor Circuit - 3.8L
- Code 42, Electronic Spark Timing (Except 3.8L)
- Code 42, Electronic Spark Timing - 3.8L
- Code 43, Electronic Spark Control With Spark Control Module
- Code 43, Electronic Spark Control Without ESC Module (Single Sensor) - Except 4.3L "S" & "T" Series Pickup With M/T & 4.3L CPI
- Code 43, Electronic Spark Control 4.3L "S" & "T" Series With M/T & "L" & "M" Series With 4.3L CPI
- Code 44, Lean Exhaust Indication (Except 4.3L Turbo)
- Code 44, Lean Exhaust Indication - 4.3L Turbo
- Code 45, Rich Exhaust Indication (Except 4.3L Turbo)
- Code 45, Rich Exhaust Indication - 4.3L Turbo
- Code 51, Faulty Prom/Mem-Cal
- Code 52, Faulty CALPAK
- Code 53, System OVERVOLTAGE (Except 3.8L)
- Code 55, ECM/Pcm Error
- Codes 53, 54 & 55, EGR Fault - 3.8L
- Code 54, Fuel Pump Circuit
- Code 56, Quad-Driver "B" Fault 3.8L
- Quad-Driver Related Symptoms
- Code 61, Cruise Vent Solenoid - 3.8L
- Code 62, Cruise Vacuum Solenoid - 3.8L
- Code 63, Cruise System Problem - 3.8L
- Code 65, Cruise Servo Position - 3.8L
- Code 66, Low A/C Refrigerant Charge - 3.8L
- Code 67, Cruise Engage Switches - 3.8L
- Code 68, Cruise System Problem Using Tech 1 - 3.8L
- Code 69, A/C Head Pressure Switch - 3.8L
- Engine Controls - Tests W/O Codes
- Introduction
- Symptoms (Gasoline)
- Notes
- How To Use This Section
- Hard Start
- Stalls After Starting
- Hesitation, Sag Or Stumble
- Vehicle Surges
- Lack Of Power Or Sluggish
- Engine Backfires
- Cuts Out, Misses
- Rough, Unstable Or Incorrect Idle
- Engine Will Not Idle
- Poor Fuel Economy
- Engine Dieseling/Run-On
- Detonation/Spark Knock
- Excessive Exhaust Emission (Odors)
- Symptoms (Diesel)
- Engine Will Not Start
- Engine Stalls At Idle
- Engine Starts, Idles Rough Without Unusual Noise Or Smoke
- Engine Starts And Idles With Excessive Noise And/Or Smoke
- Engine Idles But Misfires Above Idle
- Engine Will Not Idle
- Fuel Leaks With No Other Engine Malfunction
- Low Engine Power
- "Rapping" Noise From Cylinders
- Excessive Noise With Black Smoke
- Engine Will Not Shut Off With Key
- Turbocharger Trouble Shooting
- INTERMITTENTS
- Engine Controls - Basic Testing
- Testing & Diagnosis
- Engine Controls - Basic Testing
- Model Identification
- Introduction
- Preliminary Inspection & Adjustments
- A-3, No-Start Diagnosis
- A-7, Basic Fuel System Checks (Gasoline)
- Basic Fuel System Checks (Diesel)
- C-4, Basic Ignition System Checks (Gasoline)
- Idle Speed & Ignition Timing (Gasoline)
- Diagnostic Circuit Check (Gasoline)
- Diagnostic Circuit Check (Diesel)
- Summary
- Engine Controls - System/Component Tests
- Model Identification
- Introduction
- Air Induction Systems
- Computerized Engine Controls
- Engine Sensors & Switches
- A/C On Switch/System Test
- Brake Switch
- Coolant Temperature Sensor (Cts)
- Knock Sensor
- Manifold Absolute Pressure (Map) Sensor
- Intake Air Temperature (IAT) Sensor
- Oxygen Sensor
- Oxygen Sensor Heating Element (4.3L)
- Park/Neutral (P/N) Switch
- Power Steering Pressure Switch (2.5L)
- Throttle Position (TP) Sensor
- Vehicle Speed Sensor (Pm Generator)
- Relays, Solenoids, Motors & Modules
- Fuel System (Gasoline)
- Fuel System (Diesel)
- Ignition System
- Emission Systems & Sub-Systems (Gasoline)
- Emission Systems & Sub-Systems (Diesel)
- Miscellaneous ECM Controls
- Notes
- Transmission (C-8)
- A/C Clutch (C-10) & Electric Cooling Fan (C-12)
- A/C Clutch (C-10)
- Cooling Fan (C-12)
- Chart C-10, A/C Clutch Control Circuit Diagnosis 2.5L & 2.8L
- C-10, A/C Clutch CNTRL CKT Diagnosis - 3.1L (Front A/C Only)
- C-10, A/C Clutch CNTRL CKT Diagnosis - 3.1L (Rear A/C Only)
- C-10, A/C Clutch Control Circuit Diagnosis - 3.8L
- Chart C-10, A/C Control Diagnosis (A/T) 4.3L Turbo PFI
- Chart C-12, Cooling Fan Circuit Diagnosis 3.1L
- Chart C-12A, Cooling Fan Circuit Diagnosis 3.8L
- Intake Manifold Tuning Valve Assembly
- Component Locations
- Engine Controls - Tests W/Codes - V6
- Introduction
- Self-Diagnostic System
- Summary
- Self-Diagnostic Tests
- Notes
- Code 13, Open Oxygen Sensor Circuit
- Code 14, Coolant Sensor Signal Voltage Low
- Code 15, Coolant Sensor Signal Voltage High
- Code 16, System Voltage High/Low 3.8L
- Code 16, Transmission Output Speed 4.3L "S" & "T" Series Utility Vehicles With M/T & 4.3L With 4L60E Transmission
- Code 17, Rpm Signal Problem 3.8L
- Code 18, Cam/Crank Error 3.8L
- Code 21, TPS Signal Voltage High
- Code 22, TPS Signal Voltage Low
- Code 23, Mat Sensor Temp. Low - 3.8L & 4.3L CPI
- Code 23, Mat Sensor Temp. Low - 4.3L Turbo
- Code 24, Vehicle Speed Sensor - 4.3L Turbo & 4.3L ("C", "K" & "P" Series) With Manual Transmission
- Code 24, Vehicle Speed Sensor (VSS) 3.1L
- Code 24, Vehicle Speed Sensor (VSS) 3.8L
- Code 24, Vehicle Speed Sensor 4.3L "S" & "T" Series Pickup With Man. Trans. (Except Turbo) & All 4WD With 4L80-E Transmission
- Code 24, Vehicle Speed Sensor 4.3L "S" & "T" Series Utility Vehicles With Manual Transmission, 4.3L, 5.0L & 5.7L With 4L60E Transmission & All 2WD With 4L80-E Transmission
- Code 25, Mat Sensor Temp. High - 3.8L & 4.3L CPI
- Code 25, Mat Sensor Temp. Low - 4.3L Turbo
- Code 26, Quad-Driver Circuit 3.8L
- Code 26, Quad-Driver No. 1 Circuit - 4.3L "S" & "T" Series Pickup With Manual Transmission
- Code 27, Quad-Driver No. 2 Circuit - 4.3L "S" & "T" Series Pickup With Manual Transmission
- Code 31, Park/Neutral Switch Circuit - 3.8L
- Code 31, Turbo OVERBOOST - 4.3L Turbo
- Code 32, EGR System Error - 3.1L
- Code 32, EGR System Error - 4.3L "G" Series, 4.3L "C", "K" & "M" Series (Non-CALIFORNIA) With 4L60E Transmission & 4.3L "C", "G", "K" & "P" Series With 4L80-E Transmission
- Code 32, EGR System Error 4.3L "S" & "T" Series Utility Vehicles With Manual Transmission (Except CPI)
- Code 32, EGR System Error - 4.3L "C", "K" & "P" Series) & 4.3L "S" & "T" Series Pickup (Except Turbo) With Manual Transmission
- Code 32, EGR System Error - 4.3L Turbo
- Code 32, EGR System Error - 4.3L With Linear EGR
- Code 33, Map Sensor Signal Voltage High
- Code 34, Map Sensor Signal Voltage Low
- Code 34, MAF Sensor Signal Voltage Low - 3.8L
- Code 35, Idle Speed Error
- IAC Valve Reset Procedure
- Code 36, Shift Control Problem - 3.8L
- Code 38, Brake Switch Circuit - 3.8L
- Code 38, Knock Sensor Circuit Open - 4.3L "S" & "T" Series Pickup With Manual Transmission
- Code 39, TCC Circuit - 3.8L
- Code 39, Knock Sensor Circuit Shorted - 4.3L "S" & "T" Series Pickup With Manual Transmission
- Code 41, Cam Sensor Circuit - 3.8L
- Code 42, Electronic Spark Timing (Except 3.8L)
- Code 42, Electronic Spark Timing - 3.8L
- Code 43, Electronic Spark Control With Spark Control Module
- Code 43, Electronic Spark Control Without ESC Module (Single Sensor) - Except 4.3L "S" & "T" Series Pickup With M/T & 4.3L CPI
- Code 43, Electronic Spark Control 4.3L "S" & "T" Series With M/T & "L" & "M" Series With 4.3L CPI
- Code 44, Lean Exhaust Indication (Except 4.3L Turbo)
- Code 44, Lean Exhaust Indication - 4.3L Turbo
- Code 45, Rich Exhaust Indication (Except 4.3L Turbo)
- Code 45, Rich Exhaust Indication - 4.3L Turbo
- Code 51, Faulty Prom/Mem-Cal
- Code 52, Faulty CALPAK
- Code 53, System OVERVOLTAGE (Except 3.8L)
- Code 55, ECM/Pcm Error
- Codes 53, 54 & 55, EGR Fault - 3.8L
- Code 54, Fuel Pump Circuit
- Code 56, Quad-Driver "B" Fault 3.8L
- Quad-Driver Related Symptoms
- Code 61, Cruise Vent Solenoid - 3.8L
- Code 62, Cruise Vacuum Solenoid - 3.8L
- Code 63, Cruise System Problem - 3.8L
- Code 65, Cruise Servo Position - 3.8L
- Code 66, Low A/C Refrigerant Charge - 3.8L
- Code 67, Cruise Engage Switches - 3.8L
- Code 68, Cruise System Problem Using Tech 1 - 3.8L
- Code 69, A/C Head Pressure Switch - 3.8L
- Engine Controls - Tests W/O Codes
- Introduction
- Symptoms (Gasoline)
- Notes
- How To Use This Section
- Hard Start
- Stalls After Starting
- Hesitation, Sag Or Stumble
- Vehicle Surges
- Lack Of Power Or Sluggish
- Engine Backfires
- Cuts Out, Misses
- Rough, Unstable Or Incorrect Idle
- Engine Will Not Idle
- Poor Fuel Economy
- Engine Dieseling/Run-On
- Detonation/Spark Knock
- Excessive Exhaust Emission (Odors)
- Symptoms (Diesel)
- Engine Will Not Start
- Engine Stalls At Idle
- Engine Starts, Idles Rough Without Unusual Noise Or Smoke
- Engine Starts And Idles With Excessive Noise And/Or Smoke
- Engine Idles But Misfires Above Idle
- Engine Will Not Idle
- Fuel Leaks With No Other Engine Malfunction
- Low Engine Power
- "Rapping" Noise From Cylinders
- Excessive Noise With Black Smoke
- Engine Will Not Shut Off With Key
- Turbocharger Trouble Shooting
- INTERMITTENTS
- Engine Controls - Basic Testing
- Theory and Operation
- Engine Controls - Theory & Operation
- Introduction
- Air Induction System
- Computerized Engine Controls (Gasoline)
- Notes
- Electronic Control Module (ECM)
- Input Devices
- Notes
- A/C On (A/C Request) Signal
- Battery Voltage
- Brake Switch Feedback
- Coolant Temperature Sensor (CTS)
- Crankshaft Position Sensor
- Cranking Signal
- Digital Ratio Adapter Controller (DRAC)
- Fuel Pump Feedback
- Gear Switches
- Knock Sensor
- Manifold Absolute Pressure (MAP) Sensor (Except 3.8L)
- Manifold Air Temperature (MAT) Sensor (2.5L & 4.3L Turbo)
- Mass Airflow (MAF) Sensor (3.8L)
- Oxygen (O2) Sensor
- Park/Neutral (P/N) Switch
- Power Steering (P/S) Pressure Switch (2.5L)
- Pressure Switch Manifold (PSM) (4L60-E & 4L80-E Transmission)
- RPM Reference Signal
- Throttle Position (TP) Sensor
- Transmission Temperature Sensor (TTS) (4L60-E & 4L80-E Transmission)
- Vehicle Speed Sensor (VSS)
- Output Signals
- Notes
- A/C Clutch Relay
- Air Injection Control Solenoid
- Charge Air Cooler Pump Relay (4.3L Turbo)
- Computer Controlled Coil Ignition (C(3)I)
- Cooling Fan Relay (3.1L & 3.8L)
- SERVICE ENGINE SOON Light
- EGR Control Solenoid Valve
- ESC Timing Retard
- EVRV Solenoid
- Fuel Injectors
- Fuel Module
- Fuel Pump & Fuel Pump Relay
- HEI-EST Ignition
- Idle Air Control (IAC) Valve
- Self-Diagnostics
- Serial Data
- Shift Solenoids (4L60-E & 4L80-E Transmission)
- Torque Converter Clutch
- Transmission Shift Light (Manual Transmission)
- Turbo Boost Relay (4.3L Turbo)
- Wastegate Solenoid (4.3L Turbo)
- Computerized Engine Controls (Diesel)
- Fuel System (Gasoline)
- Fuel System (Diesel)
- Ignition System (Gasoline)
- Ignition Timing Control Systems (Gasoline)
- Emission Systems (Gasoline)
- Emission Systems (Diesel)
- Self-Diagnostic System
- Miscellaneous ECM Controls
- Engine Controls - Theory & Operation
- Vacuum Diagrams
- Wiring Diagrams
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- Computer Relearn Procedures
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Hoist/Jack
- Identification
- Metric Conversions
- Maintenance Reminder Light (Reset Procedures)
- Engine Oil Replacement Reminder
- Notes
- Engine Oil Replacement Reminder Reset - Procedure 01
- Engine Oil Replacement Reminder Reset - Procedure 02
- Engine Oil Replacement Reminder Reset - Procedure 03
- Engine Oil Replacement Reminder Reset - Procedure 04
- Engine Oil Replacement Reminder Reset - Procedure 05
- Engine Oil Replacement Reminder Reset - Procedure 06
- Engine Oil Replacement Reminder Reset - Procedure 07
- Engine Oil Replacement Reminder Reset - Procedure 08
- Engine Oil Replacement Reminder Reset - Procedure 09
- Engine Oil Replacement Reminder Reset - Procedure 10
- Engine Oil Replacement Reminder Reset - Procedure 11
- Engine Oil Replacement Reminder Reset - Procedure 12
- Engine Oil Replacement Reminder Reset - Procedure 13
- Engine Oil Replacement Reminder Reset - Procedure 14
- Engine Oil Replacement Reminder Reset - Procedure 15
- Engine Oil Replacement Reminder Reset - Procedure 16
- Engine Oil Replacement Reminder Reset - Procedure 17
- Engine Oil Replacement Reminder Reset - Procedure 18
- Engine Oil Replacement Reminder Reset - Procedure 19
- Engine Oil Replacement Reminder Reset - Procedure 20
- Engine Oil Replacement Reminder Reset - Procedure 21
- Engine Oil Replacement Reminder Reset - Procedure 22
- Engine Oil Replacement Reminder Reset - Procedure 23
- Engine Oil Replacement Reminder Reset - Procedure 24
- Engine Oil Replacement Reminder Reset - Procedure 25
- Engine Oil Replacement Reminder Reset - Procedure 26
- Engine Oil Replacement Reminder Reset - Procedure 27
- Engine Oil Replacement Reminder Reset - Procedure 28
- Engine Oil Replacement Reminder Reset - Procedure 29
- Engine Oil Replacement Reminder Reset - Procedure 30
- Engine Oil Replacement Reminder Reset - Procedure 31
- Engine Oil Replacement Reminder Reset - Procedure 32
- Engine Oil Replacement Reminder Reset - Procedure 33
- Engine Oil Replacement Reminder Reset - Procedure 34
- Engine Oil Replacement Reminder Reset - Procedure 35
- Engine Oil Replacement Reminder Reset - Procedure 36
- Engine Oil Replacement Reminder Reset - Procedure 37
- Emissions Maintenance Reminder (Reminder Flag)
- Emissions Maintenance Reminder (Warning Light)
- Emissions Maintenance Reminder (Check Engine Light)
- Diesel Fuel Filter Replacement Reminder
- Maintenance Service Reminder
- Timing Belt Replacement Reminder
- Transmission Fluid Replacement Reminder
- Tire Pressure Monitor System Reminder
- Notes
- TPMS Reminder Reset - Procedure 01
- TPMS Reminder Reset - Procedure 02
- TPMS Reminder Reset - Procedure 03
- TPMS Reminder Reset - Procedure 04
- TPMS Reminder Reset - Procedure 05
- TPMS Reminder Reset - Procedure 06
- TPMS Reminder Reset - Procedure 07
- TPMS Reminder Reset - Procedure 08
- TPMS Reminder Reset - Procedure 09
- TPMS Reminder Reset - Procedure 10
- TPMS Reminder Reset - Procedure 11
- TPMS Reminder Reset - Procedure 12
- TPMS Reminder Reset - Procedure 13
- TPMS Reminder Reset - Procedure 14
- TPMS Reminder Reset - Procedure 15
- TPMS Reminder Reset - Procedure 16
- TPMS Reminder Reset - Procedure 17
- TPMS Reminder Reset - Procedure 18
- TPMS Reminder Reset - Procedure 19
- TPMS Reminder Reset - Procedure 20
- TPMS Reminder Reset - Procedure 21
- TPMS Reminder Reset - Procedure 22
- TPMS Reminder Reset - Procedure 23
- TPMS Reminder Reset - Procedure 24
- TPMS Reminder Reset - Procedure 25
- TPMS Reminder Reset - Procedure 26
- TPMS Reminder Reset - Procedure 27
- TPMS Reminder Reset - Procedure 28
- TPMS Reminder Reset - Procedure 29
- TPMS Reminder Reset - Procedure 30
- TPMS Reminder Reset - Procedure 31
- TPMS Reminder Reset - Procedure 32
- TPMS Reminder Reset - Procedure 33
- TPMS Reminder Reset - Procedure 34
- TPMS Reminder Reset - Procedure 35
- TPMS Reminder Reset - Procedure 36
- TPMS Reminder Reset - Procedure 37
- Engine Oil Replacement Reminder
- RPO Codes
- RPO Code Description (Codes 001-19F)
- RPO Code Description (Codes 19H-2EL)
- RPO Code Description (Codes 2F1-44I)
- RPO Code Description (Codes 44L-5J9)
- RPO Code Description (Codes 5K0-6FF)
- RPO Code Description (Codes 6FG-76A)
- RPO Code Description (Codes 76D-7XD)
- RPO Code Description (Codes 7XF-8M0)
- RPO Code Description (Codes 8M1-9C0)
- RPO Code Description (Codes 9C1-A0F)
- RPO Code Description (Codes A0G-Ar4)
- RPO Code Description (Codes Ar5-BCP)
- RPO Code Description (Codes BCQ-C12)
- RPO Code Description (Codes C13-Cur)
- RPO Code Description (Codes Cut-Dir)
- RPO Code Description (Codes Dr7-EHE)
- RPO Code Description (Codes EHF-F5P)
- RPO Code Description (Codes F5Q-G1V)
- RPO Code Description (Codes G1W-HFN)
- RPO Code Description (Codes HFO-JRG)
- RPO Code Description (Codes JRH-KLY)
- RPO Code Description (Codes KLZ-LQX)
- RPO Code Description (Codes LQY-MW9)
- RPO Code Description (Codes MWE-ODK)
- RPO Code Description (Codes ODL-Ora)
- RPO Code Description (Codes Orb-PDE)
- RPO Code Description (Codes PDF-QH6)
- RPO Code Description (Codes QH7-R8D)
- RPO Code Description (Codes R8E-T07)
- RPO Code Description (Codes T08-TJ0)
- RPO Code Description (Codes TJ1-U10)
- RPO Code Description (Codes U11-Us9)
- RPO Code Description (Codes USB-VG9)
- RPO Code Description (Codes VGA-W5Y)
- RPO Code Description (Codes W5Z-XE3)
- RPO Code Description (Codes XE4-Y9Z)
- RPO Code Description (Codes Ya2-ZD9)
- RPO Code Description (Codes ZDE-ZZZ)
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- A/C Compressor Clutch Controls
- Model Identification
- Description & Operation
- Trouble Shooting
- Scan Tester
- A/C Compressor Clutch Charts
- General Servicing
- A/C Compressor Overhaul
- A/C Compressor Refrigerant Oil Checking
- A/C System General Servicing
- USING R-12 & R-134a REFRIGERANT
- Sight Glass Indicator
- System Service Valves
- Manifold Gauge Set
- Pressure Gauge Indications
- Trouble Shooting
- Excessive Moisture Gauge Readings
- Defective Thermostatic Switch Gauge Readings
- MISADJUSTED Thermostatic Switch Gauge Readings
- Defective Clutch Cycling Switch Pressure Gauge Readings
- Low R-12 Charge Gauge Readings
- Very Low R-12 Charge Gauge Readings
- Expansion Or "H" Valve Stuck Closed Gauge Readings
- Orifice Tube Plugged Gauge Readings
- Expansion Or "H" Valve Stuck Open Gauge Readings
- Compressor Malfunction Gauge Readings
- Condenser Malfunction Or R-12 Overcharge Gauge Readings
- Orifice Tube Replacement
- Refrigerant Recovery/Recycling
- Discharging A/C System
- Flushing A/C System
- Evacuating A/C System
- Charging A/C System
- Leak Testing
- Refrigerant Oil & Refrigerant Specifications
- Compressor Applications & Body Designations
- A/C System Specifications
- HVAC Control Systems
- A/C-Heater System - Manual
- A/C System Specifications
- Description
- Operation
- Adjustments
- Trouble Shooting
- Testing
- A/C Compressor Clutch Control
- Airflow From Outlets Is Incorrect
- Auxiliary Blower Motor Inoperative At One Or More Speeds
- Blower Motor & Auxiliary Blower Motor Inoperative
- Blower Motor Goes To High Speed When A/C-Heater Control Panel Is Activated
- Blower Motor Inoperative Or Will Not Operate At Low Speed
- Blower Motor Operates At Low & Medium Speeds, But Not At High Speed
- Blower Motor Operates At Low, But Not At Medium Speeds
- Rear A/C Is Not Cold
- Rear Auxiliary Blower Switch Inoperative At One Or More Speeds (Front Switch Fully Operative)
- Temperature Lever Causes No Change In Airflow At Outlets
- Removal & Installation
- Torque Specifications
- Vacuum Hose Diagram(S)
- Wiring Diagrams
- A/C-Heater System Trouble Shooting - Manual
- Refrigerant System Diagnosis
- Trouble Shooting Charts
- CCOT System, Insufficient Cooling Chart "A"
- CCOT System, Insufficient Cooling Chart "B"
- CCOT System, Insufficient Cooling Chart "C"
- CCOT System, Insufficient Cooling Chart "E"
- V5 System, Preliminary Checks - Step 1
- V5 System, Checking Refrigerant Charge - Step 2
- V5 System, Checking Compressor Clutch Engagement - Step 3
- V5 System, Checking System Performance - Step 4
- V5 System, Gray Area Diagnosis & Service - Step 5
- V5 System, Striped Area Diagnosis & Service - Step 6
- V5 System, Control Valve Diagnosis - Step 7
- Operational Testing
- Electrical Trouble Shooting
- Heater System
- Description
- Operation
- Adjustments
- Trouble Shooting
- Notes
- Blower Motor Inoperative Or No Operation At Low Speed
- Blower Motor Runs At High Speed When Control Is Activated
- Blower Motor Operates At Low, But Not Medium Speed
- Blower Motor Operates At Low & Medium Speeds, But Not High Speed
- Auxiliary Blower Motor Does Not Operate In One, Two Or All Speeds
- Blower Motor & Auxiliary Blower Motor Inoperative
- Temperature Control Inoperative
- Airflow From Incorrect Outlets
- Removal & Installation
- Vacuum Hose Diagram(S)
- Wiring Diagram
- Heater System Trouble Shooting
- A/C-Heater System - Manual
- A/C Compressor Clutch Controls
- Maintenance
- Procedures
- Maintenance Information
- Model Identification
- Maintenance Service Information
- Service Point Locations
- Service Labor Times
- Wheel & Tire Specifications
- Battery Specifications
- Cautions & Warnings
- Supplemental Restraint System (Air Bag)
- Air Conditioning Servicing
- Anti-Lock Brake System
- Replacing Blown Fuses
- Battery Warning
- Brake Pad Wear Indicator
- Catalytic Converter
- Coolant (DEX-Cool 1995-96 Models)
- Coolant (Propylene-Glycol Formulations)
- Electrostatic Discharge Sensitive (ESD) Parts
- Fuel System Service
- Halogen Bulbs
- Methanol Gasoline
- Radiator Cap
- Radiator Fan
- Spark Plugs
- Warranty Information
- Fuses & Circuit Breakers
- Circuit Breaker/Relay Fuse Panel Location - 1990-95
- Circuit Breaker/Relay Panel
- Circuit Breaker/Relay Panel - 1990-95
- Fuse Panel Identification - 1990 Trans Sport
- Fuse Panel Identification - 1990 Lumina APV & Silhouette
- Fuse Panel Identification - 1991 Models
- Instrument Panel Fuse Identification - 92-96 With 3.1L V6
- Fuse Panel Identification (1992-96 Models With 3.8L V6)
- Maintenance Information
- Procedures
- Steering
- Manual Steering
- Power Steering
- Steering Column
- Suspension
- Electronic Suspension
- Suspension - Rear Electronic Level Control
- Description
- Operation
- Adjustments
- Testing
- System Operational Test
- System Leak Test
- Compressor Performance Test
- Compressor/Drier Leak Test
- Height Sensor Operation Test
- Sensor Actuator Arm Test
- Inflator Switch Does Not Activate Compressor Motor
- Inflator Switch Activates Compressor Motor, But High Pressure Air Is Not Available At Air Hose
- Inflator Switch Activates Compressor Motor, But Will Not Turn Compressor Motor "Off"
- Compressor Motor Does Not Turn On To Raise Rear Of Vehicle, But Inflator Switch Operates Normally
- Compressor Motor Does Not Turn "On" To Raise Rear Of Vehicle
- Electronic Level Control System Does Not Vent To Lower Rear Of Vehicle
- Compressor Motor Runs Continuously Or For Maximum Run Time, Then Stops
- Trouble Shooting
- Removal & Installation
- Torque Specifications
- Wiring Diagrams
- Suspension - Rear Electronic Level Control
- Front Suspension
- Rear Suspension
- Wheel Alignment
- Electronic Suspension
- Transmission
- Automatic Trans
- Diagnosis - 4T60-E
- Application
- Description
- Operation
- Self-Diagnostic System
- Self Diagnostic Charts
- Charts
- Code 14/P0118, Coolant Temp. Sensor Signal Voltage Low
- Code 15/P0117, Coolant Temp. Sensor Signal Voltage High
- Code 21/P0123, Throttle Position Sensor Signal Voltage High
- Code 22/P0122, Throttle Position Sensor Signal Voltage Low
- Code 24, Vehicle Speed Sensor (VSS) 3.1L, 3.4L & 3.8L "W" Body
- Code 24, Vehicle Speed Sensor (VSS) 3.8L "C", "E", "H" & "U" Bodies
- Code 26, Quad-Driver Circuit 3.8L "E" Body
- Code 26, Quad-Driver Circuit 3.8L "C", "H" & "U" Body
- Code 26, Quad-Driver Circuit 3.8L "W" Body
- Code 31, Park/Neutral Switch Circuit
- Code 36, Shift Problem 3.8L "C" & "H" Bodies
- Code 36, Shift Problem 3.8L "E" & "W" Bodies
- Code 36, Shift Problem 3.8L "U" Body
- Code 38, Brake Switch Circuit
- Code 39, TCC Circuit Without Tech 1 3.8L "C", "H" & "W" Bodies
- Code 39, TCC Circuit With Tech 1 3.8L "C", "H" & "W" Bodies
- Code 39, TCC Circuit 3.8L "U" Body
- Code 56, Quad-Driver Circuit 3.8L "C", "H" & "W" Bodies
- Code 56, Quad-Driver Circuit 3.8L "U" Body
- Code 62, Gear Switch Error 3.1L "W" (Exc. CALIF.) & 3.4L "W" Bodies
- Code 79, VSS Signal Voltage High 3.1 CALIF. "W" Body
- Code 80, VSS Signal Voltage Low 3.1L CALIF. "W" Body
- Electronic Testing
- Wiring Diagrams
- Overhaul - 3T40
- Application & Labor Times
- Identification
- Description
- Lubrication & Adjustments
- On-Vehicle Service
- Trouble Shooting
- Notes
- Symptoms
- Chatters Or Slips In 1st Gear
- Inoperative Or Slips In 1st Gear
- Inoperative Or Slips In Reverse
- Delayed Or No Upshifts
- Slipping Or Rough 1-2 Shift
- Delayed Or Rough 2-3 Shift
- Slipping, Soft Or Early 2-3 Shift
- Delayed Or No 2-3 Shift
- Delayed Neutral-To-Drive Shift
- Delays In Drive & Reverse
- No 2nd Gear In "D"
- All Gears Inoperative
- Inoperative In "D"
- Forward Gears Inoperative
- Transaxle Starts In 2nd Gear
- Transaxle Skips 2nd Gear
- Shifts From 3rd To 1st At High Speeds
- No Full Throttle Detent Downshift
- No Overrun Braking In "1", Reverse Okay
- Binds In 3rd Gear
- Inoperative In "2"
- Engine Stalls In "R" Or "D"
- Noise In All Gears
- High Pitched Whine or Popping
- Buzzing Or High Pitched Rattle
- Whine Or Growl Under Light Accessories
- Noise In 1st Or Reverse Gear
- Noise In 2nd Gear
- Hum During Light Acceleration (All Gears)
- Light Rattle In 2nd Or 3rd At 25-40 MPH
- Testing
- Clutch & Band Application Chart
- Torque Converter
- Torque Converter Clutch
- Removal & Installation
- Transaxle Disassembly
- Component Disassembly & Reassembly
- Notes
- Transaxle Case
- Differential & Final Drive
- Reaction Internal Gear
- Low Roller Clutch & Reaction Carrier Assembly
- Low-Reverse Clutch Housing
- Reaction Sun Gear & Input Drum End Play
- Input Carrier, Input Sun Gear & Internal Gear
- Forward Clutch Assembly
- Direct Clutch Assembly
- Intermediate Band
- Driven Sprocket Support
- Manual Shaft
- Drive Link Assembly (Chain, Sprockets & Turbine Shaft)
- Case Cover
- Control Valve Body & Oil Pump Assemblies
- Auxiliary Valve Body
- Intermediate Servo
- Governor/Speedometer Gear Or Governor/Speed Sensor Assembly
- Transaxle Disassembly
- Transaxle Reassembly
- Transaxle Specifications
- Torque Specifications
- Wiring Diagrams
- Overhaul - 4T60-E
- Application
- Identification
- Description
- Lubrication & Adjustments
- On-Vehicle Service
- Trouble Shooting
- Notes
- Quick Check
- Symptom Diagnosis
- Notes
- Oil Out Of Vent Or Foaming
- High Or Low Line Pressure
- Delayed Engagement
- No Drive in "D"
- Slips in "D"
- No 1-2 Shift (1st Gear)
- Harsh or Soft 1-2 Shift
- 1-2 Shift Shudder
- No 2-3 Shift (1st & 2nd Gears)
- 1-4 Shift (Misses 2nd & 3rd Gears)
- 2-3 Shift Only
- 1-2-4 Shift (No 2-3 Shift)
- Harsh or Soft 2-3 Shift
- Early or Late 2-3 Shift
- 3-4 Shift (Misses 1st & 2nd Gears)
- No 3-4 Shift
- Harsh or Soft 3-4 Shift
- Early Or Late 3-4 Shift
- No Reverse
- Locked In Reverse
- Slips in Reverse
- Vehicle Moves in Park
- Harsh Neutral-To-Drive Engagement
- Vehicle Starts in 2nd Gear
- Harsh Reverse
- No Engine Breaking In Manual 2nd or Low
- Harsh 4-3 Downshift
- Harsh 3-2 Downshift
- Harsh 2-1 Downshift
- No Converter Clutch Apply
- Converter Clutch Does Not Release
- Converter Clutch Stuck On in 3rd & 4th
- Converter Applied with Maximum Pressure (with PWM)
- Converter Clutch Apply Rough, Slips or Shudders
- No TCC
- Clutch & Band Application Chart
- Testing - Electronic Self-Diagnostics
- Testing - Non-Electronic
- Removal & Installation
- Transaxle Disassembly
- Component Disassembly & Reassembly
- Transaxle Case
- Final Drive Assembly Overhaul
- Sun Gear Shaft
- 1-2 & Forward Bands
- Reaction Carrier & Drum
- Input Carrier Assembly
- Reverse Reaction Drum & Reverse Band
- 3RD Roller Clutch, Input Sprag & Input Sun Gear
- Input Clutch Assembly
- 2ND Clutch Assembly
- Driven Sprocket Support
- Output Shaft
- Drive Link Assembly & Sprockets
- Valve Body
- Oil Pump Assembly
- 1-2 & Reverse Servos
- Transaxle Reassembly
- Torque Specifications
- Wiring Diagrams
- Removal & Installation - A/T
- Servicing - A/T
- Transmission Oil Pan Gasket Id
- Diagnosis - 4T60-E
- Automatic Transaxle Hydraulic Diagrams - 125C/3T40
- Automatic Trans
- External Pages
