Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups
Electrical Component Locations- Engine Control System - 2.5L (LBK) Engine Controls Component Views
- Lighting Systems
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Lighting Systems
- Symptoms - Lighting Systems
- Automatic Transaxle Gear Position Illumination Lamp Inoperative, All Other Instrument Lamps OK
- Fog Lamps Inoperative - Front
- Instrument Panel Illumination Lamps Inoperative
- Backup Lamps Inoperative
- Courtesy Lamps Inoperative
- Courtesy Lamps Inoperative - Ashtray
- Courtesy Lamps Inoperative - Door Step
- Daytime Running Lamps (DRL) Inoperative (2.0 Liter)
- Daytime Running Lamps (DRL) Inoperative (2.5 Liter)
- Fog Lamps Inoperative - Rear
- Hazard Lamps Inoperative
- Headlamps Inoperative - High Beams
- Headlamps Inoperative - Low Beams
- Headlamps Inoperative - Low and High Beams
- Headlight Leveling Inoperative
- Ignition Lock Cylinder Lamp Inoperative
- Instrument Panel (I/P) Compartment Lamp Inoperative
- Park, Tail and Side Marker Lamps Inoperative
- Rear Compartment Lamp(s) Inoperative
- Stop Lamps Always On
- Stop Lamps Inoperative
- Turn Signal Lamps and/or Indicators Inoperative
- Vanity Mirror Lamp(s) Inoperative
- Repair Instructions
- Dome and Reading Lamp Replacement
- Stop Lamp Switch Adjustment
- Stop Lamp Switch Replacement
- Daytime Running Lights (DRL) Control Module Replacement
- Ashtray Lamp Bulb Replacement
- Ignition Lock Cylinder Lamp Replacement
- Door Lamp Replacement
- Instrument Panel (I/P) Compartment Lamp Replacement
- Instrument Cluster Dimmer/Headlamp Leveling Switch Replacement
- Vanity Mirror Lamp Replacement
- Headlamp Replacement
- Headlamp Aiming
- Fog Lamp Replacement - Front (2.5L)
- Fog Lamp Replacement - Front (2.0L)
- Repeater Lamp Replacement
- Marker Lamp Replacement - Front Side
- Park/Turn Signal Lamp Replacement
- High Mounted Stop Lamp Replacement
- License Lamp Replacement
- Tail Lamp Replacement
- Rear Compartment Lamp Replacement
- Description and Operation
- Wiring Systems - Component Locator - Electrical Center Identification Views
- Wiring Systems - Component Locator - Master Electrical Component List
Fluids
Technical Bulletins
Wiring Diagrams- Automatic Transmission - ZF 4HP 16 - Schematic And Routing Diagrams
- Engine Control System - 2.0L (L34 GMDAT) - ECM Connector End Views
- Engine Control System - 2.0L (L34 GMDAT) - Engine Controls Connector End Views
- Engine Control System - 2.0L (L34 GMDAT) - Schematic And Routing Diagrams
- Engine Control System - 2.5L (LBK) - ECM Connector End Views
- Engine Control System - 2.5L (LBK) - Engine Controls Connector End Views
- Engine Control System - 2.5L (LBK) - Schematic And Routing Diagrams
- Lighting Systems
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Lighting Systems
- Symptoms - Lighting Systems
- Automatic Transaxle Gear Position Illumination Lamp Inoperative, All Other Instrument Lamps OK
- Fog Lamps Inoperative - Front
- Instrument Panel Illumination Lamps Inoperative
- Backup Lamps Inoperative
- Courtesy Lamps Inoperative
- Courtesy Lamps Inoperative - Ashtray
- Courtesy Lamps Inoperative - Door Step
- Daytime Running Lamps (DRL) Inoperative (2.0 Liter)
- Daytime Running Lamps (DRL) Inoperative (2.5 Liter)
- Fog Lamps Inoperative - Rear
- Hazard Lamps Inoperative
- Headlamps Inoperative - High Beams
- Headlamps Inoperative - Low Beams
- Headlamps Inoperative - Low and High Beams
- Headlight Leveling Inoperative
- Ignition Lock Cylinder Lamp Inoperative
- Instrument Panel (I/P) Compartment Lamp Inoperative
- Park, Tail and Side Marker Lamps Inoperative
- Rear Compartment Lamp(s) Inoperative
- Stop Lamps Always On
- Stop Lamps Inoperative
- Turn Signal Lamps and/or Indicators Inoperative
- Vanity Mirror Lamp(s) Inoperative
- Repair Instructions
- Dome and Reading Lamp Replacement
- Stop Lamp Switch Adjustment
- Stop Lamp Switch Replacement
- Daytime Running Lights (DRL) Control Module Replacement
- Ashtray Lamp Bulb Replacement
- Ignition Lock Cylinder Lamp Replacement
- Door Lamp Replacement
- Instrument Panel (I/P) Compartment Lamp Replacement
- Instrument Cluster Dimmer/Headlamp Leveling Switch Replacement
- Vanity Mirror Lamp Replacement
- Headlamp Replacement
- Headlamp Aiming
- Fog Lamp Replacement - Front (2.5L)
- Fog Lamp Replacement - Front (2.0L)
- Repeater Lamp Replacement
- Marker Lamp Replacement - Front Side
- Park/Turn Signal Lamp Replacement
- High Mounted Stop Lamp Replacement
- License Lamp Replacement
- Tail Lamp Replacement
- Rear Compartment Lamp Replacement
- Description and Operation
- System Wiring Diagrams
- Using lemon2025'S System Wiring Diagrams
- Wiring Systems - Component Locator - Master Electrical Component List
- Wiring Systems - In-Line Harness Connector End Views
- Wiring Systems - Power And Grounding Connector End Views
- Wiring Systems - Schematic And Routing Diagrams
- Wiring Systems - Splice Pack Connector End Views
- Accessories & Equipment
- Anti-Theft Systems
- Door System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Doors
- Diagnostic System Check - Door Systems
- Scan Tool Data List
- Scan Tool Data Definitions
- Diagnostic Trouble Code (DTC) List
- DTC 025-026
- DTC 027-028
- DTC 029
- Symptoms - Doors
- Power Windows Inoperative - All
- Power Door Locks Inoperative
- Power Mirrors Inoperative
- Heated Mirrors Inoperative
- Repair Instructions
- Door Replacement
- Hinge Replacement - Door
- Door Check Link Replacement
- Door Handle Replacement - Outside
- Door Handle Replacement - Inside
- Locking Rod Replacement - Front Door
- Lock Replacement - Front Door
- Lock Replacement - Rear Door
- Lock Cylinder Replacement - Door
- Striker Replacement - Door
- Lock Striker Adjustment - Door
- Window Regulator Replacement
- Window Replacement - Front Door
- Window Replacement - Rear Door
- Window Channel Replacement - Door
- Window Run Channel Replacement - Rear Door
- Window Run Channel Replacement - Front Door
- Window Replacement - Rear Door Stationary
- Sealing Strip Replacement - Front Door Window Belt Outer
- Sealing Strip Replacement - Rear Door Window Belt Outer
- Sealing Strip Replacement - Door Bottom
- Weatherstrip Replacement - Door
- Weatherstrip Replacement - Front Door Opening
- Weatherstrip Replacement - Rear Door Opening
- Mirror Replacement - Power
- Description and Operation
- Keyless Entry System
- Diagnostic Information and Procedures
- Repair Instructions
- Description and Operation
- Special Tools and Equipment
- Theft Deterrent System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Theft Deterrent
- Diagnostic System Check - Theft Deterrent
- Scan Tool Data List
- Scan Tool Data Definitions
- Diagnostic Trouble Code (DTC) List
- DTC 032
- DTC 033
- DTC 034
- DTC 035
- DTC 036
- Symptoms - Theft Deterrent
- Content Theft Deterrent (CTD) Alarm Mode Always On
- Content Theft Deterrent (CTD) Alarm Mode Inoperative
- Content Theft Deterrent (CTD) Does Not Disarm with Key Lock
- Lights Inoperative in Content Theft Deterrent (CTD) Alarm Mode
- Security Indicator Always On or Flashing
- Security Indicator Inoperative
- Theft Deterrent Alarm Inoperative
- Theft Deterrent System Inoperative
- Repair Instructions
- Deck Lid Switch Replacement
- Door Contact Switches Replacement
- Hood Ajar Switch Replacement
- Theft Deterrent Control Module Replacement
- LED Indicator Replacement - Vehicle Security System
- Theft Deterrent Alarm Replacement
- Programming Additional Keys
- Programming Theft Deterrent System Components (Scan 100)
- Programming Theft Deterrent System Components (Tech 2)
- Description and Operation
- Door System
- Communication Devices
- Body Control System
- Communications Systems
- Cruise Control Systems
- Entertainment Systems
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Entertainment
- Symptoms - Entertainment
- Radio Poor Reception (FM)
- Radio Poor Reception (AM)
- Audio Distortion - One or More Speakers (Front)
- Audio Distortion - One or More Speakers (Rear)
- Compact Disc Inoperative
- Radio Display Inoperative, No Sound from Speakers
- Tape Player Inoperative
- Repair Instructions
- Description and Operation
- Exterior Lights
- Lighting Systems
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Lighting Systems
- Symptoms - Lighting Systems
- Automatic Transaxle Gear Position Illumination Lamp Inoperative, All Other Instrument Lamps OK
- Fog Lamps Inoperative - Front
- Instrument Panel Illumination Lamps Inoperative
- Backup Lamps Inoperative
- Courtesy Lamps Inoperative
- Courtesy Lamps Inoperative - Ashtray
- Courtesy Lamps Inoperative - Door Step
- Daytime Running Lamps (DRL) Inoperative (2.0 Liter)
- Daytime Running Lamps (DRL) Inoperative (2.5 Liter)
- Fog Lamps Inoperative - Rear
- Hazard Lamps Inoperative
- Headlamps Inoperative - High Beams
- Headlamps Inoperative - Low Beams
- Headlamps Inoperative - Low and High Beams
- Headlight Leveling Inoperative
- Ignition Lock Cylinder Lamp Inoperative
- Instrument Panel (I/P) Compartment Lamp Inoperative
- Park, Tail and Side Marker Lamps Inoperative
- Rear Compartment Lamp(s) Inoperative
- Stop Lamps Always On
- Stop Lamps Inoperative
- Turn Signal Lamps and/or Indicators Inoperative
- Vanity Mirror Lamp(s) Inoperative
- Repair Instructions
- Dome and Reading Lamp Replacement
- Stop Lamp Switch Adjustment
- Stop Lamp Switch Replacement
- Daytime Running Lights (DRL) Control Module Replacement
- Ashtray Lamp Bulb Replacement
- Ignition Lock Cylinder Lamp Replacement
- Door Lamp Replacement
- Instrument Panel (I/P) Compartment Lamp Replacement
- Instrument Cluster Dimmer/Headlamp Leveling Switch Replacement
- Vanity Mirror Lamp Replacement
- Headlamp Replacement
- Headlamp Aiming
- Fog Lamp Replacement - Front (2.5L)
- Fog Lamp Replacement - Front (2.0L)
- Repeater Lamp Replacement
- Marker Lamp Replacement - Front Side
- Park/Turn Signal Lamp Replacement
- High Mounted Stop Lamp Replacement
- License Lamp Replacement
- Tail Lamp Replacement
- Rear Compartment Lamp Replacement
- Description and Operation
- Lighting Systems
- Gauges & Instrument Panels
- Instrument Panel, Gages, And Console
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Code Index
- Diagnostic Starting Point - Instrument Panel, Gages and Console
- Diagnostic System Check - Instrument Cluster
- Diagnostic Trouble Code (DTC) List
- DTC P0461 (2.0L - L34 GMDAT)
- DTC P0461 (2.5L - LBK)
- DTC P0462 (2.0L - L34 GMDAT)
- DTC P0462 (2.5L - LBK)
- DTC P0463 (2.0L - L34 GMDAT)
- DTC P0463 (2.5L - LBK)
- DTC P0654
- DTC P0656
- Symptoms - Instrument Panel, Gages and Console
- Door Open Warning Chime Inoperative
- Cigar Lighter Inoperative
- Clock Malfunction
- Engine Coolant Temperature Gage Inaccurate or Inoperative
- Fuel Gage Inaccurate or Inoperative
- Speedometer and/or Odometer Inaccurate or Inoperative
- Chime Inoperative
- Repair Instructions
- Cigar Lighter Housing Replacement
- Knee Bolster Replacement
- Trim Panel Replacement - Instrument Panel (I/P) Cluster
- Storage Compartment Replacement - Instrument Panel (I/P)
- Instrument Panel Cluster (IPC) Replacement
- Speedometer Replacement
- Tachometer Replacement
- Instrument Cluster Lamp Replacement
- Ashtray Replacement
- Cupholder Replacement
- Instrument Panel (I/P) Assembly Replacement
- Clock Replacement
- Extension Replacement - Floor Console - Side
- Console Replacement - Front Floor
- Description and Operation
- Instrument Panel, Gages, And Console
- Headlights
- Lighting Systems
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Lighting Systems
- Symptoms - Lighting Systems
- Automatic Transaxle Gear Position Illumination Lamp Inoperative, All Other Instrument Lamps OK
- Fog Lamps Inoperative - Front
- Instrument Panel Illumination Lamps Inoperative
- Backup Lamps Inoperative
- Courtesy Lamps Inoperative
- Courtesy Lamps Inoperative - Ashtray
- Courtesy Lamps Inoperative - Door Step
- Daytime Running Lamps (DRL) Inoperative (2.0 Liter)
- Daytime Running Lamps (DRL) Inoperative (2.5 Liter)
- Fog Lamps Inoperative - Rear
- Hazard Lamps Inoperative
- Headlamps Inoperative - High Beams
- Headlamps Inoperative - Low Beams
- Headlamps Inoperative - Low and High Beams
- Headlight Leveling Inoperative
- Ignition Lock Cylinder Lamp Inoperative
- Instrument Panel (I/P) Compartment Lamp Inoperative
- Park, Tail and Side Marker Lamps Inoperative
- Rear Compartment Lamp(s) Inoperative
- Stop Lamps Always On
- Stop Lamps Inoperative
- Turn Signal Lamps and/or Indicators Inoperative
- Vanity Mirror Lamp(s) Inoperative
- Repair Instructions
- Dome and Reading Lamp Replacement
- Stop Lamp Switch Adjustment
- Stop Lamp Switch Replacement
- Daytime Running Lights (DRL) Control Module Replacement
- Ashtray Lamp Bulb Replacement
- Ignition Lock Cylinder Lamp Replacement
- Door Lamp Replacement
- Instrument Panel (I/P) Compartment Lamp Replacement
- Instrument Cluster Dimmer/Headlamp Leveling Switch Replacement
- Vanity Mirror Lamp Replacement
- Headlamp Replacement
- Headlamp Aiming
- Fog Lamp Replacement - Front (2.5L)
- Fog Lamp Replacement - Front (2.0L)
- Repeater Lamp Replacement
- Marker Lamp Replacement - Front Side
- Park/Turn Signal Lamp Replacement
- High Mounted Stop Lamp Replacement
- License Lamp Replacement
- Tail Lamp Replacement
- Rear Compartment Lamp Replacement
- Description and Operation
- Lighting Systems
- Heated Glass/Defoggers
- Body Glass System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Stationary Windows
- Diagnostic System Check - Defogger
- Scan Tool Data List
- Scan Tool Data Definitions
- Diagnostic Trouble Code (DTC) List
- DTC 021
- Symptoms - Stationary Windows
- Defogger Inoperative - Rear Window
- Defogger Indicator Always On
- Defogger Grid Lines Diagnosis
- Mirrors - Automatic Day-Night Inoperative
- Repair Instructions
- Description and Operation
- Special Tools and Equipment
- Body Glass System
- Horns
- Ignition Switch/Steering Lock
- Steering Wheel & Steering Column
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Steering Column
- Symptoms - Steering Wheel and Column
- Loose Steering Wheel
- Noise When Lifting the Column
- Turn Signal Switch Does Not Stay in Turn Position
- Turn Signal Switch Does Not Cancel
- Turn Signal Switch Difficult to Operate
- Turn Signal Does Not Indicate Lane Change
- Ignition Switch Electrical System Does Not Operate
- Ignition Switch Does Not Turn
- High Steering Shaft Effort
- Lock System Does Not Unlock
- Lock System Does Not Lock
- Key Cannot Be Removed in the Off Lock Position
- High Lock Effort
- Noise in Steering Column
- Looseness in Steering Column
- Repair Instructions
- Description and Operation
- Special Tools and Equipment
- Steering Wheel & Steering Column
- Infotainment
- Entertainment Systems
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Entertainment
- Symptoms - Entertainment
- Radio Poor Reception (FM)
- Radio Poor Reception (AM)
- Audio Distortion - One or More Speakers (Front)
- Audio Distortion - One or More Speakers (Rear)
- Compact Disc Inoperative
- Radio Display Inoperative, No Sound from Speakers
- Tape Player Inoperative
- Repair Instructions
- Description and Operation
- Entertainment Systems
- Interior/Exterior Trim
- Door System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Doors
- Diagnostic System Check - Door Systems
- Scan Tool Data List
- Scan Tool Data Definitions
- Diagnostic Trouble Code (DTC) List
- DTC 025-026
- DTC 027-028
- DTC 029
- Symptoms - Doors
- Power Windows Inoperative - All
- Power Door Locks Inoperative
- Power Mirrors Inoperative
- Heated Mirrors Inoperative
- Repair Instructions
- Door Replacement
- Hinge Replacement - Door
- Door Check Link Replacement
- Door Handle Replacement - Outside
- Door Handle Replacement - Inside
- Locking Rod Replacement - Front Door
- Lock Replacement - Front Door
- Lock Replacement - Rear Door
- Lock Cylinder Replacement - Door
- Striker Replacement - Door
- Lock Striker Adjustment - Door
- Window Regulator Replacement
- Window Replacement - Front Door
- Window Replacement - Rear Door
- Window Channel Replacement - Door
- Window Run Channel Replacement - Rear Door
- Window Run Channel Replacement - Front Door
- Window Replacement - Rear Door Stationary
- Sealing Strip Replacement - Front Door Window Belt Outer
- Sealing Strip Replacement - Rear Door Window Belt Outer
- Sealing Strip Replacement - Door Bottom
- Weatherstrip Replacement - Door
- Weatherstrip Replacement - Front Door Opening
- Weatherstrip Replacement - Rear Door Opening
- Mirror Replacement - Power
- Description and Operation
- Exterior Trim
- Instrument Panel, Gages, And Console
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Code Index
- Diagnostic Starting Point - Instrument Panel, Gages and Console
- Diagnostic System Check - Instrument Cluster
- Diagnostic Trouble Code (DTC) List
- DTC P0461 (2.0L - L34 GMDAT)
- DTC P0461 (2.5L - LBK)
- DTC P0462 (2.0L - L34 GMDAT)
- DTC P0462 (2.5L - LBK)
- DTC P0463 (2.0L - L34 GMDAT)
- DTC P0463 (2.5L - LBK)
- DTC P0654
- DTC P0656
- Symptoms - Instrument Panel, Gages and Console
- Door Open Warning Chime Inoperative
- Cigar Lighter Inoperative
- Clock Malfunction
- Engine Coolant Temperature Gage Inaccurate or Inoperative
- Fuel Gage Inaccurate or Inoperative
- Speedometer and/or Odometer Inaccurate or Inoperative
- Chime Inoperative
- Repair Instructions
- Cigar Lighter Housing Replacement
- Knee Bolster Replacement
- Trim Panel Replacement - Instrument Panel (I/P) Cluster
- Storage Compartment Replacement - Instrument Panel (I/P)
- Instrument Panel Cluster (IPC) Replacement
- Speedometer Replacement
- Tachometer Replacement
- Instrument Cluster Lamp Replacement
- Ashtray Replacement
- Cupholder Replacement
- Instrument Panel (I/P) Assembly Replacement
- Clock Replacement
- Extension Replacement - Floor Console - Side
- Console Replacement - Front Floor
- Description and Operation
- Interior Trim
- Specifications
- Repair Instructions
- Trim Panel Replacement - Front Door
- Trim Panel Replacement - Rear Door
- Compartment Trim Panel Replacement - Rear
- Trim Panel Replacement - Cargo Area Rear
- Door Sill Plate Replacement - Front
- Door Sill Plate Replacement - Rear
- Carpet Replacement
- Headliner Replacement
- Assist Handle Replacement
- Sunshade Replacement
- Garnish Molding Replacement - Windshield Pillar
- Trim Panel Replacement - Upper Center Pillar
- Trim Panel Replacement - Lower Center Pillar
- Trim Panel Replacement - Hinge Pillar
- Trim Panel Replacement - Rear Quarter Upper
- Trim Panel Replacement - Rear Window Shelf
- Description and Operation
- Special Tools and Equipment
- Door System
- Interior/Illumination Lights
- Lighting Systems
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Lighting Systems
- Symptoms - Lighting Systems
- Automatic Transaxle Gear Position Illumination Lamp Inoperative, All Other Instrument Lamps OK
- Fog Lamps Inoperative - Front
- Instrument Panel Illumination Lamps Inoperative
- Backup Lamps Inoperative
- Courtesy Lamps Inoperative
- Courtesy Lamps Inoperative - Ashtray
- Courtesy Lamps Inoperative - Door Step
- Daytime Running Lamps (DRL) Inoperative (2.0 Liter)
- Daytime Running Lamps (DRL) Inoperative (2.5 Liter)
- Fog Lamps Inoperative - Rear
- Hazard Lamps Inoperative
- Headlamps Inoperative - High Beams
- Headlamps Inoperative - Low Beams
- Headlamps Inoperative - Low and High Beams
- Headlight Leveling Inoperative
- Ignition Lock Cylinder Lamp Inoperative
- Instrument Panel (I/P) Compartment Lamp Inoperative
- Park, Tail and Side Marker Lamps Inoperative
- Rear Compartment Lamp(s) Inoperative
- Stop Lamps Always On
- Stop Lamps Inoperative
- Turn Signal Lamps and/or Indicators Inoperative
- Vanity Mirror Lamp(s) Inoperative
- Repair Instructions
- Dome and Reading Lamp Replacement
- Stop Lamp Switch Adjustment
- Stop Lamp Switch Replacement
- Daytime Running Lights (DRL) Control Module Replacement
- Ashtray Lamp Bulb Replacement
- Ignition Lock Cylinder Lamp Replacement
- Door Lamp Replacement
- Instrument Panel (I/P) Compartment Lamp Replacement
- Instrument Cluster Dimmer/Headlamp Leveling Switch Replacement
- Vanity Mirror Lamp Replacement
- Headlamp Replacement
- Headlamp Aiming
- Fog Lamp Replacement - Front (2.5L)
- Fog Lamp Replacement - Front (2.0L)
- Repeater Lamp Replacement
- Marker Lamp Replacement - Front Side
- Park/Turn Signal Lamp Replacement
- High Mounted Stop Lamp Replacement
- License Lamp Replacement
- Tail Lamp Replacement
- Rear Compartment Lamp Replacement
- Description and Operation
- Lighting Systems
- Mirrors
- Door System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Doors
- Diagnostic System Check - Door Systems
- Scan Tool Data List
- Scan Tool Data Definitions
- Diagnostic Trouble Code (DTC) List
- DTC 025-026
- DTC 027-028
- DTC 029
- Symptoms - Doors
- Power Windows Inoperative - All
- Power Door Locks Inoperative
- Power Mirrors Inoperative
- Heated Mirrors Inoperative
- Repair Instructions
- Door Replacement
- Hinge Replacement - Door
- Door Check Link Replacement
- Door Handle Replacement - Outside
- Door Handle Replacement - Inside
- Locking Rod Replacement - Front Door
- Lock Replacement - Front Door
- Lock Replacement - Rear Door
- Lock Cylinder Replacement - Door
- Striker Replacement - Door
- Lock Striker Adjustment - Door
- Window Regulator Replacement
- Window Replacement - Front Door
- Window Replacement - Rear Door
- Window Channel Replacement - Door
- Window Run Channel Replacement - Rear Door
- Window Run Channel Replacement - Front Door
- Window Replacement - Rear Door Stationary
- Sealing Strip Replacement - Front Door Window Belt Outer
- Sealing Strip Replacement - Rear Door Window Belt Outer
- Sealing Strip Replacement - Door Bottom
- Weatherstrip Replacement - Door
- Weatherstrip Replacement - Front Door Opening
- Weatherstrip Replacement - Rear Door Opening
- Mirror Replacement - Power
- Description and Operation
- Door System
- Seats
- Seat System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Height Adjustment Knobs Replacement
- Seat Replacement - Front Bucket
- Seat Cushion Replacement - Front
- Seat Back Replacement - Front
- Seat Back Recliner Handle Replacement - Front
- Seat Back Cushion-Side Bolster Panel Replacement
- Lumbar Support Knob Replacement
- Seat Adjuster Replacement - Front
- Seat Adjuster Replacement - Driver Side
- Heated Seat Switch Replacement - Front
- Seat Heater Element Replacement - Front
- Head Restraint Replacement
- Trim Panel Replacement - Front Seat
- Seat Cushion Replacement - Rear
- Seat Cushion Cover Replacement - Rear
- Seat Back Replacement - Rear Split Folding
- Seat Back Hinge Replacement - Rear
- Armrest Replacement - Rear Seat
- Seat Back Latch Striker Replacement - Rear Folding
- Description and Operation
- Seat System
- Steering Column Switches
- Steering Wheel & Steering Column
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Steering Column
- Symptoms - Steering Wheel and Column
- Loose Steering Wheel
- Noise When Lifting the Column
- Turn Signal Switch Does Not Stay in Turn Position
- Turn Signal Switch Does Not Cancel
- Turn Signal Switch Difficult to Operate
- Turn Signal Does Not Indicate Lane Change
- Ignition Switch Electrical System Does Not Operate
- Ignition Switch Does Not Turn
- High Steering Shaft Effort
- Lock System Does Not Unlock
- Lock System Does Not Lock
- Key Cannot Be Removed in the Off Lock Position
- High Lock Effort
- Noise in Steering Column
- Looseness in Steering Column
- Repair Instructions
- Description and Operation
- Special Tools and Equipment
- Steering Wheel & Steering Column
- Window Motors & Regulators
- Body Glass System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Stationary Windows
- Diagnostic System Check - Defogger
- Scan Tool Data List
- Scan Tool Data Definitions
- Diagnostic Trouble Code (DTC) List
- DTC 021
- Symptoms - Stationary Windows
- Defogger Inoperative - Rear Window
- Defogger Indicator Always On
- Defogger Grid Lines Diagnosis
- Mirrors - Automatic Day-Night Inoperative
- Repair Instructions
- Description and Operation
- Special Tools and Equipment
- Door System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Doors
- Diagnostic System Check - Door Systems
- Scan Tool Data List
- Scan Tool Data Definitions
- Diagnostic Trouble Code (DTC) List
- DTC 025-026
- DTC 027-028
- DTC 029
- Symptoms - Doors
- Power Windows Inoperative - All
- Power Door Locks Inoperative
- Power Mirrors Inoperative
- Heated Mirrors Inoperative
- Repair Instructions
- Door Replacement
- Hinge Replacement - Door
- Door Check Link Replacement
- Door Handle Replacement - Outside
- Door Handle Replacement - Inside
- Locking Rod Replacement - Front Door
- Lock Replacement - Front Door
- Lock Replacement - Rear Door
- Lock Cylinder Replacement - Door
- Striker Replacement - Door
- Lock Striker Adjustment - Door
- Window Regulator Replacement
- Window Replacement - Front Door
- Window Replacement - Rear Door
- Window Channel Replacement - Door
- Window Run Channel Replacement - Rear Door
- Window Run Channel Replacement - Front Door
- Window Replacement - Rear Door Stationary
- Sealing Strip Replacement - Front Door Window Belt Outer
- Sealing Strip Replacement - Rear Door Window Belt Outer
- Sealing Strip Replacement - Door Bottom
- Weatherstrip Replacement - Door
- Weatherstrip Replacement - Front Door Opening
- Weatherstrip Replacement - Rear Door Opening
- Mirror Replacement - Power
- Description and Operation
- Body Glass System
- Wiper/Washer Systems
- Wiper System & Washer System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Wiper/Washer Systems
- Diagnostic System Check - Wiper/Washer
- Scan Tool Data List
- Scan Tool Data Definitions
- Diagnostic Trouble Code (DTC) List
- DTC 022
- Symptoms - Wiper/Washer Systems
- Wipers Do Not Work on HI Speed
- Wipers Do Not Work on LO Speed
- Wipers Do Not Work on Intermittent
- Washers Inoperative
- Wipers Inoperative - All Modes
- Wipers Blades Do Not Park
- Repair Instructions
- Description and Operation
- Wiper System & Washer System
- Anti-Theft Systems
- Body & Frame
- Door Locks
- Door System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Doors
- Diagnostic System Check - Door Systems
- Scan Tool Data List
- Scan Tool Data Definitions
- Diagnostic Trouble Code (DTC) List
- DTC 025-026
- DTC 027-028
- DTC 029
- Symptoms - Doors
- Power Windows Inoperative - All
- Power Door Locks Inoperative
- Power Mirrors Inoperative
- Heated Mirrors Inoperative
- Repair Instructions
- Door Replacement
- Hinge Replacement - Door
- Door Check Link Replacement
- Door Handle Replacement - Outside
- Door Handle Replacement - Inside
- Locking Rod Replacement - Front Door
- Lock Replacement - Front Door
- Lock Replacement - Rear Door
- Lock Cylinder Replacement - Door
- Striker Replacement - Door
- Lock Striker Adjustment - Door
- Window Regulator Replacement
- Window Replacement - Front Door
- Window Replacement - Rear Door
- Window Channel Replacement - Door
- Window Run Channel Replacement - Rear Door
- Window Run Channel Replacement - Front Door
- Window Replacement - Rear Door Stationary
- Sealing Strip Replacement - Front Door Window Belt Outer
- Sealing Strip Replacement - Rear Door Window Belt Outer
- Sealing Strip Replacement - Door Bottom
- Weatherstrip Replacement - Door
- Weatherstrip Replacement - Front Door Opening
- Weatherstrip Replacement - Rear Door Opening
- Mirror Replacement - Power
- Description and Operation
- Keyless Entry System
- Diagnostic Information and Procedures
- Repair Instructions
- Description and Operation
- Special Tools and Equipment
- Theft Deterrent System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Theft Deterrent
- Diagnostic System Check - Theft Deterrent
- Scan Tool Data List
- Scan Tool Data Definitions
- Diagnostic Trouble Code (DTC) List
- DTC 032
- DTC 033
- DTC 034
- DTC 035
- DTC 036
- Symptoms - Theft Deterrent
- Content Theft Deterrent (CTD) Alarm Mode Always On
- Content Theft Deterrent (CTD) Alarm Mode Inoperative
- Content Theft Deterrent (CTD) Does Not Disarm with Key Lock
- Lights Inoperative in Content Theft Deterrent (CTD) Alarm Mode
- Security Indicator Always On or Flashing
- Security Indicator Inoperative
- Theft Deterrent Alarm Inoperative
- Theft Deterrent System Inoperative
- Repair Instructions
- Deck Lid Switch Replacement
- Door Contact Switches Replacement
- Hood Ajar Switch Replacement
- Theft Deterrent Control Module Replacement
- LED Indicator Replacement - Vehicle Security System
- Theft Deterrent Alarm Replacement
- Programming Additional Keys
- Programming Theft Deterrent System Components (Scan 100)
- Programming Theft Deterrent System Components (Tech 2)
- Description and Operation
- Door System
- Exterior Body Panels
- Air/Wind Noise
- Body Front End
- Specifications
- Repair Instructions
- Description and Operation
- Special Tools and Equipment
- Body Rear End
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Bracket Replacement - Cargo Tie Down Loop
- Fuel Filler Door Replacement
- Fuel Filler Door Release Cable Replacement
- Compartment Lid Replacement - Rear
- Torque Rod Replacement - Rear Compartment Lid
- Lock Cylinder Replacement - Rear Compartment Lid
- Latch Replacement - Rear Compartment Lid
- Lock Striker Replacement - Rear Compartment Lid
- Weatherstrip Replacement - Rear Compartment Opening
- Description and Operation
- Bumper System
- Squeaks And Rattles
- Water Leaks
- Exterior/Interior Trim
- Door System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Doors
- Diagnostic System Check - Door Systems
- Scan Tool Data List
- Scan Tool Data Definitions
- Diagnostic Trouble Code (DTC) List
- DTC 025-026
- DTC 027-028
- DTC 029
- Symptoms - Doors
- Power Windows Inoperative - All
- Power Door Locks Inoperative
- Power Mirrors Inoperative
- Heated Mirrors Inoperative
- Repair Instructions
- Door Replacement
- Hinge Replacement - Door
- Door Check Link Replacement
- Door Handle Replacement - Outside
- Door Handle Replacement - Inside
- Locking Rod Replacement - Front Door
- Lock Replacement - Front Door
- Lock Replacement - Rear Door
- Lock Cylinder Replacement - Door
- Striker Replacement - Door
- Lock Striker Adjustment - Door
- Window Regulator Replacement
- Window Replacement - Front Door
- Window Replacement - Rear Door
- Window Channel Replacement - Door
- Window Run Channel Replacement - Rear Door
- Window Run Channel Replacement - Front Door
- Window Replacement - Rear Door Stationary
- Sealing Strip Replacement - Front Door Window Belt Outer
- Sealing Strip Replacement - Rear Door Window Belt Outer
- Sealing Strip Replacement - Door Bottom
- Weatherstrip Replacement - Door
- Weatherstrip Replacement - Front Door Opening
- Weatherstrip Replacement - Rear Door Opening
- Mirror Replacement - Power
- Description and Operation
- Exterior Trim
- Instrument Panel, Gages, And Console
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Code Index
- Diagnostic Starting Point - Instrument Panel, Gages and Console
- Diagnostic System Check - Instrument Cluster
- Diagnostic Trouble Code (DTC) List
- DTC P0461 (2.0L - L34 GMDAT)
- DTC P0461 (2.5L - LBK)
- DTC P0462 (2.0L - L34 GMDAT)
- DTC P0462 (2.5L - LBK)
- DTC P0463 (2.0L - L34 GMDAT)
- DTC P0463 (2.5L - LBK)
- DTC P0654
- DTC P0656
- Symptoms - Instrument Panel, Gages and Console
- Door Open Warning Chime Inoperative
- Cigar Lighter Inoperative
- Clock Malfunction
- Engine Coolant Temperature Gage Inaccurate or Inoperative
- Fuel Gage Inaccurate or Inoperative
- Speedometer and/or Odometer Inaccurate or Inoperative
- Chime Inoperative
- Repair Instructions
- Cigar Lighter Housing Replacement
- Knee Bolster Replacement
- Trim Panel Replacement - Instrument Panel (I/P) Cluster
- Storage Compartment Replacement - Instrument Panel (I/P)
- Instrument Panel Cluster (IPC) Replacement
- Speedometer Replacement
- Tachometer Replacement
- Instrument Cluster Lamp Replacement
- Ashtray Replacement
- Cupholder Replacement
- Instrument Panel (I/P) Assembly Replacement
- Clock Replacement
- Extension Replacement - Floor Console - Side
- Console Replacement - Front Floor
- Description and Operation
- Interior Trim
- Specifications
- Repair Instructions
- Trim Panel Replacement - Front Door
- Trim Panel Replacement - Rear Door
- Compartment Trim Panel Replacement - Rear
- Trim Panel Replacement - Cargo Area Rear
- Door Sill Plate Replacement - Front
- Door Sill Plate Replacement - Rear
- Carpet Replacement
- Headliner Replacement
- Assist Handle Replacement
- Sunshade Replacement
- Garnish Molding Replacement - Windshield Pillar
- Trim Panel Replacement - Upper Center Pillar
- Trim Panel Replacement - Lower Center Pillar
- Trim Panel Replacement - Hinge Pillar
- Trim Panel Replacement - Rear Quarter Upper
- Trim Panel Replacement - Rear Window Shelf
- Description and Operation
- Special Tools and Equipment
- Door System
- Frames, Subframes & Crossmembers
- Ignition Switch/Steering Lock
- Steering Wheel & Steering Column
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Steering Column
- Symptoms - Steering Wheel and Column
- Loose Steering Wheel
- Noise When Lifting the Column
- Turn Signal Switch Does Not Stay in Turn Position
- Turn Signal Switch Does Not Cancel
- Turn Signal Switch Difficult to Operate
- Turn Signal Does Not Indicate Lane Change
- Ignition Switch Electrical System Does Not Operate
- Ignition Switch Does Not Turn
- High Steering Shaft Effort
- Lock System Does Not Unlock
- Lock System Does Not Lock
- Key Cannot Be Removed in the Off Lock Position
- High Lock Effort
- Noise in Steering Column
- Looseness in Steering Column
- Repair Instructions
- Description and Operation
- Special Tools and Equipment
- Steering Wheel & Steering Column
- Mirrors
- Door System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Doors
- Diagnostic System Check - Door Systems
- Scan Tool Data List
- Scan Tool Data Definitions
- Diagnostic Trouble Code (DTC) List
- DTC 025-026
- DTC 027-028
- DTC 029
- Symptoms - Doors
- Power Windows Inoperative - All
- Power Door Locks Inoperative
- Power Mirrors Inoperative
- Heated Mirrors Inoperative
- Repair Instructions
- Door Replacement
- Hinge Replacement - Door
- Door Check Link Replacement
- Door Handle Replacement - Outside
- Door Handle Replacement - Inside
- Locking Rod Replacement - Front Door
- Lock Replacement - Front Door
- Lock Replacement - Rear Door
- Lock Cylinder Replacement - Door
- Striker Replacement - Door
- Lock Striker Adjustment - Door
- Window Regulator Replacement
- Window Replacement - Front Door
- Window Replacement - Rear Door
- Window Channel Replacement - Door
- Window Run Channel Replacement - Rear Door
- Window Run Channel Replacement - Front Door
- Window Replacement - Rear Door Stationary
- Sealing Strip Replacement - Front Door Window Belt Outer
- Sealing Strip Replacement - Rear Door Window Belt Outer
- Sealing Strip Replacement - Door Bottom
- Weatherstrip Replacement - Door
- Weatherstrip Replacement - Front Door Opening
- Weatherstrip Replacement - Rear Door Opening
- Mirror Replacement - Power
- Description and Operation
- Door System
- Seats
- Seat System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Height Adjustment Knobs Replacement
- Seat Replacement - Front Bucket
- Seat Cushion Replacement - Front
- Seat Back Replacement - Front
- Seat Back Recliner Handle Replacement - Front
- Seat Back Cushion-Side Bolster Panel Replacement
- Lumbar Support Knob Replacement
- Seat Adjuster Replacement - Front
- Seat Adjuster Replacement - Driver Side
- Heated Seat Switch Replacement - Front
- Seat Heater Element Replacement - Front
- Head Restraint Replacement
- Trim Panel Replacement - Front Seat
- Seat Cushion Replacement - Rear
- Seat Cushion Cover Replacement - Rear
- Seat Back Replacement - Rear Split Folding
- Seat Back Hinge Replacement - Rear
- Armrest Replacement - Rear Seat
- Seat Back Latch Striker Replacement - Rear Folding
- Description and Operation
- Seat System
- Sun Roof/T-Top/Convertible Top
- Windows
- Body Glass System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Stationary Windows
- Diagnostic System Check - Defogger
- Scan Tool Data List
- Scan Tool Data Definitions
- Diagnostic Trouble Code (DTC) List
- DTC 021
- Symptoms - Stationary Windows
- Defogger Inoperative - Rear Window
- Defogger Indicator Always On
- Defogger Grid Lines Diagnosis
- Mirrors - Automatic Day-Night Inoperative
- Repair Instructions
- Description and Operation
- Special Tools and Equipment
- Door System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Doors
- Diagnostic System Check - Door Systems
- Scan Tool Data List
- Scan Tool Data Definitions
- Diagnostic Trouble Code (DTC) List
- DTC 025-026
- DTC 027-028
- DTC 029
- Symptoms - Doors
- Power Windows Inoperative - All
- Power Door Locks Inoperative
- Power Mirrors Inoperative
- Heated Mirrors Inoperative
- Repair Instructions
- Door Replacement
- Hinge Replacement - Door
- Door Check Link Replacement
- Door Handle Replacement - Outside
- Door Handle Replacement - Inside
- Locking Rod Replacement - Front Door
- Lock Replacement - Front Door
- Lock Replacement - Rear Door
- Lock Cylinder Replacement - Door
- Striker Replacement - Door
- Lock Striker Adjustment - Door
- Window Regulator Replacement
- Window Replacement - Front Door
- Window Replacement - Rear Door
- Window Channel Replacement - Door
- Window Run Channel Replacement - Rear Door
- Window Run Channel Replacement - Front Door
- Window Replacement - Rear Door Stationary
- Sealing Strip Replacement - Front Door Window Belt Outer
- Sealing Strip Replacement - Rear Door Window Belt Outer
- Sealing Strip Replacement - Door Bottom
- Weatherstrip Replacement - Door
- Weatherstrip Replacement - Front Door Opening
- Weatherstrip Replacement - Rear Door Opening
- Mirror Replacement - Power
- Description and Operation
- Body Glass System
- Door Locks
- Brakes
- Anti-Lock Brakes
- Antilock Brake System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Code Index
- Diagnostic Starting Point - Antilock Brake System
- Diagnostic System Check - ABS
- Diagnostic Trouble Code (DTC) List
- DTC C1101
- DTC C1102
- DTC C1200
- DTC C1201
- DTC C1202
- DTC C1203
- DTC C1204
- DTC C1205
- DTC C1206
- DTC C1207
- DTC C1208
- DTC C1209
- DTC C1210
- DTC C1211
- DTC C1503
- DTC C1605, C1611, C1612 or C1616
- DTC C1604
- DTC C2112 or C2380
- DTC C2402
- No Communication with EBCM
- ABS Indicator Always On
- ABS Indicator Inoperative
- Traction Active Indicator Always On
- Traction Active Indicator Inoperative
- Traction Control Indicator Always On
- Traction Control Indicator Inoperative
- Repair Instructions
- Description and Operation
- ABS Description and Operation
- Notes
- Basic Knowledge Required
- Antilock Brake System (ABS) System Components
- Base Braking Mode
- Antilock Braking Mode - Apply
- Antilock Braking Mode - Hold
- Antilock Braking Mode - Release
- De-Coupled Dynamic Rear Proportioning (DDRP)
- Electronic Brake Control Module (EBCM)
- Solenoid Relay
- Wheel Speed Sensors and Rings
- Antilock Brake System (ABS) Warning Lamp
- Brake Warning Lamp
- Traction Control System (TCS)
- Traction Control System Indicators
- ABS Description and Operation
- Antilock Brake System
- Mechanical - Hydraulic
- Disc Brakes
- Specifications
- Diagnostic Information and Procedures
- Repair Instructions
- Brake Pads Replacement - Front
- Brake Pads Replacement - Rear
- Brake Caliper Replacement - Front
- Brake Caliper Replacement - Rear
- Brake Caliper Overhaul - Front
- Brake Caliper Overhaul - Rear
- Brake Rotor Replacement - Front
- Brake Rotor Replacement - Rear
- Disc Brake Splash Shield Replacement - Front
- Disc Brake Backing Plate Replacement - Rear
- Description and Operation
- Hydraulic Brake System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Master Cylinder Reservoir Replacement
- Master Cylinder Replacement
- Master Cylinder Overhaul
- Brake Pedal Assembly Replacement
- Proportioning Valve Replacement
- Brake Hose Replacement - Front
- Brake Hose Replacement - Rear
- Hydraulic Brake System Bleeding
- Vacuum Brake Booster Replacement
- Vacuum Brake Booster Check Valve and/or Hose Replacement
- Stop Lamp Switch Replacement
- Description and Operation
- Disc Brakes
- Parking Brake System
- Traction Control
- Antilock Brake System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Code Index
- Diagnostic Starting Point - Antilock Brake System
- Diagnostic System Check - ABS
- Diagnostic Trouble Code (DTC) List
- DTC C1101
- DTC C1102
- DTC C1200
- DTC C1201
- DTC C1202
- DTC C1203
- DTC C1204
- DTC C1205
- DTC C1206
- DTC C1207
- DTC C1208
- DTC C1209
- DTC C1210
- DTC C1211
- DTC C1503
- DTC C1605, C1611, C1612 or C1616
- DTC C1604
- DTC C2112 or C2380
- DTC C2402
- No Communication with EBCM
- ABS Indicator Always On
- ABS Indicator Inoperative
- Traction Active Indicator Always On
- Traction Active Indicator Inoperative
- Traction Control Indicator Always On
- Traction Control Indicator Inoperative
- Repair Instructions
- Description and Operation
- ABS Description and Operation
- Notes
- Basic Knowledge Required
- Antilock Brake System (ABS) System Components
- Base Braking Mode
- Antilock Braking Mode - Apply
- Antilock Braking Mode - Hold
- Antilock Braking Mode - Release
- De-Coupled Dynamic Rear Proportioning (DDRP)
- Electronic Brake Control Module (EBCM)
- Solenoid Relay
- Wheel Speed Sensors and Rings
- Antilock Brake System (ABS) Warning Lamp
- Brake Warning Lamp
- Traction Control System (TCS)
- Traction Control System Indicators
- ABS Description and Operation
- Antilock Brake System
- Anti-Lock Brakes
- Drivelines & Axles
- Electrical
- Body Electrical
- Accessory Power Socket
- Lighting Systems
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Lighting Systems
- Symptoms - Lighting Systems
- Automatic Transaxle Gear Position Illumination Lamp Inoperative, All Other Instrument Lamps OK
- Fog Lamps Inoperative - Front
- Instrument Panel Illumination Lamps Inoperative
- Backup Lamps Inoperative
- Courtesy Lamps Inoperative
- Courtesy Lamps Inoperative - Ashtray
- Courtesy Lamps Inoperative - Door Step
- Daytime Running Lamps (DRL) Inoperative (2.0 Liter)
- Daytime Running Lamps (DRL) Inoperative (2.5 Liter)
- Fog Lamps Inoperative - Rear
- Hazard Lamps Inoperative
- Headlamps Inoperative - High Beams
- Headlamps Inoperative - Low Beams
- Headlamps Inoperative - Low and High Beams
- Headlight Leveling Inoperative
- Ignition Lock Cylinder Lamp Inoperative
- Instrument Panel (I/P) Compartment Lamp Inoperative
- Park, Tail and Side Marker Lamps Inoperative
- Rear Compartment Lamp(s) Inoperative
- Stop Lamps Always On
- Stop Lamps Inoperative
- Turn Signal Lamps and/or Indicators Inoperative
- Vanity Mirror Lamp(s) Inoperative
- Repair Instructions
- Dome and Reading Lamp Replacement
- Stop Lamp Switch Adjustment
- Stop Lamp Switch Replacement
- Daytime Running Lights (DRL) Control Module Replacement
- Ashtray Lamp Bulb Replacement
- Ignition Lock Cylinder Lamp Replacement
- Door Lamp Replacement
- Instrument Panel (I/P) Compartment Lamp Replacement
- Instrument Cluster Dimmer/Headlamp Leveling Switch Replacement
- Vanity Mirror Lamp Replacement
- Headlamp Replacement
- Headlamp Aiming
- Fog Lamp Replacement - Front (2.5L)
- Fog Lamp Replacement - Front (2.0L)
- Repeater Lamp Replacement
- Marker Lamp Replacement - Front Side
- Park/Turn Signal Lamp Replacement
- High Mounted Stop Lamp Replacement
- License Lamp Replacement
- Tail Lamp Replacement
- Rear Compartment Lamp Replacement
- Description and Operation
- Wiring Systems - Component Locator - Electrical Center Identification Views
- Wiring Systems - Component Locator - Master Electrical Component List
- Wiring Systems - Diagnostic Information And Procedures
- Diagnostic Information and Procedures
- Electrical Symbols
- General Electrical Diagnosis Procedures
- Checking Aftermarket Accessories
- Circuit Testing
- Using Connector Test Adapters
- Probing Electrical Connectors
- Troubleshooting with a Digital Multimeter
- Troubleshooting with a Test Lamp
- Using Fused Jumper Wires
- Measuring Voltage
- Measuring Voltage Drop
- Measuring Frequency
- Testing for Continuity
- Testing for Short to Ground
- Testing for a Short to Voltage
- Testing for Intermittent Conditions and Poor Connections
- Inducing Intermittent Fault Conditions
- Testing for Electrical Intermittents
- Scan Tool Snapshot Procedure
- Circuit Protection - Fuses
- Circuit Protection - Circuit Breakers
- Circuit Protection - Fusible Links
- Wiring Repairs
- Repairing Damaged Wire Insulation
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- SIR/SRS Wiring Repairs
- Connector Repairs
- Connector Position Assurance Locks
- Terminal Position Assurance Locks
- Push to Seat Connectors
- Pull to Seat Connectors
- Weather Pack Connectors
- Micro-Pack 100W Connectors
- Micro .64 Connectors
- Repairing Connector Terminals
- Diagnostic Information and Procedures
- Wiring Systems - In-Line Harness Connector End Views
- Wiring Systems - Power And Grounding Connector End Views
- Wiring Systems - Repair Instructions
- Wiring Systems - Schematic And Routing Diagrams
- Wiring Systems - Special Tools And Equipment
- Wiring Systems - Splice Pack Connector End Views
- Charging Systems
- Engine Electrical System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Code Index
- Diagnostic Starting Point - Engine Electrical
- Diagnostic System Check - Engine Electrical
- Diagnostic Trouble Code (DTC) List
- DTC P0562 (w/2.0L L34 GMDAT)
- DTC P0562 (w/2.5L LBK)
- DTC P0563 (w/2.0L (L34 GMDAT))
- DTC P0563 (w/2.5L (LBK))
- Symptoms - Engine Electrical
- Battery Inspection/Test
- Battery Charging
- Battery Electrical Drain/Parasitic Load Test
- Battery Common Causes of Failure
- Jump Starting in Case of Emergency
- Charging System Test
- Charge Indicator Always On
- Charge Indicator Inoperative
- Generator Noise Diagnosis
- Starter Solenoid Does Not Click
- Starter Solenoid Clicks, Engine Does Not Crank
- Engine Cranks Slowly
- Starter Motor Noise Diagnosis
- Repair Instructions
- Battery and Battery Tray Replacement
- Battery Negative Cable Disconnect/Connect Procedure
- Starter Motor Replacement (2.0L)
- Starter Motor Replacement (2.5L)
- Generator Replacement (2.0L)
- Generator Replacement (2.5L)
- Starter Motor Overhaul (2.0L)
- Starter Motor Overhaul (2.5L)
- Generator Overhaul (2.0L)
- Generator Overhaul (2.5L)
- Description and Operation
- Special Tools and Equipment
- Engine Electrical System
- Component Locations
- Engine Control System - 2.5L (LBK) Engine Controls Component Views
- Lighting Systems
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Lighting Systems
- Symptoms - Lighting Systems
- Automatic Transaxle Gear Position Illumination Lamp Inoperative, All Other Instrument Lamps OK
- Fog Lamps Inoperative - Front
- Instrument Panel Illumination Lamps Inoperative
- Backup Lamps Inoperative
- Courtesy Lamps Inoperative
- Courtesy Lamps Inoperative - Ashtray
- Courtesy Lamps Inoperative - Door Step
- Daytime Running Lamps (DRL) Inoperative (2.0 Liter)
- Daytime Running Lamps (DRL) Inoperative (2.5 Liter)
- Fog Lamps Inoperative - Rear
- Hazard Lamps Inoperative
- Headlamps Inoperative - High Beams
- Headlamps Inoperative - Low Beams
- Headlamps Inoperative - Low and High Beams
- Headlight Leveling Inoperative
- Ignition Lock Cylinder Lamp Inoperative
- Instrument Panel (I/P) Compartment Lamp Inoperative
- Park, Tail and Side Marker Lamps Inoperative
- Rear Compartment Lamp(s) Inoperative
- Stop Lamps Always On
- Stop Lamps Inoperative
- Turn Signal Lamps and/or Indicators Inoperative
- Vanity Mirror Lamp(s) Inoperative
- Repair Instructions
- Dome and Reading Lamp Replacement
- Stop Lamp Switch Adjustment
- Stop Lamp Switch Replacement
- Daytime Running Lights (DRL) Control Module Replacement
- Ashtray Lamp Bulb Replacement
- Ignition Lock Cylinder Lamp Replacement
- Door Lamp Replacement
- Instrument Panel (I/P) Compartment Lamp Replacement
- Instrument Cluster Dimmer/Headlamp Leveling Switch Replacement
- Vanity Mirror Lamp Replacement
- Headlamp Replacement
- Headlamp Aiming
- Fog Lamp Replacement - Front (2.5L)
- Fog Lamp Replacement - Front (2.0L)
- Repeater Lamp Replacement
- Marker Lamp Replacement - Front Side
- Park/Turn Signal Lamp Replacement
- High Mounted Stop Lamp Replacement
- License Lamp Replacement
- Tail Lamp Replacement
- Rear Compartment Lamp Replacement
- Description and Operation
- Wiring Systems - Component Locator - Electrical Center Identification Views
- Wiring Systems - Component Locator - Master Electrical Component List
- Gauges
- Instrument Panel, Gages, And Console
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Code Index
- Diagnostic Starting Point - Instrument Panel, Gages and Console
- Diagnostic System Check - Instrument Cluster
- Diagnostic Trouble Code (DTC) List
- DTC P0461 (2.0L - L34 GMDAT)
- DTC P0461 (2.5L - LBK)
- DTC P0462 (2.0L - L34 GMDAT)
- DTC P0462 (2.5L - LBK)
- DTC P0463 (2.0L - L34 GMDAT)
- DTC P0463 (2.5L - LBK)
- DTC P0654
- DTC P0656
- Symptoms - Instrument Panel, Gages and Console
- Door Open Warning Chime Inoperative
- Cigar Lighter Inoperative
- Clock Malfunction
- Engine Coolant Temperature Gage Inaccurate or Inoperative
- Fuel Gage Inaccurate or Inoperative
- Speedometer and/or Odometer Inaccurate or Inoperative
- Chime Inoperative
- Repair Instructions
- Cigar Lighter Housing Replacement
- Knee Bolster Replacement
- Trim Panel Replacement - Instrument Panel (I/P) Cluster
- Storage Compartment Replacement - Instrument Panel (I/P)
- Instrument Panel Cluster (IPC) Replacement
- Speedometer Replacement
- Tachometer Replacement
- Instrument Cluster Lamp Replacement
- Ashtray Replacement
- Cupholder Replacement
- Instrument Panel (I/P) Assembly Replacement
- Clock Replacement
- Extension Replacement - Floor Console - Side
- Console Replacement - Front Floor
- Description and Operation
- Instrument Panel, Gages, And Console
- Horns
- Motors, Switches, Relays
- Accessory Power Socket
- Lighting Systems
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Lighting Systems
- Symptoms - Lighting Systems
- Automatic Transaxle Gear Position Illumination Lamp Inoperative, All Other Instrument Lamps OK
- Fog Lamps Inoperative - Front
- Instrument Panel Illumination Lamps Inoperative
- Backup Lamps Inoperative
- Courtesy Lamps Inoperative
- Courtesy Lamps Inoperative - Ashtray
- Courtesy Lamps Inoperative - Door Step
- Daytime Running Lamps (DRL) Inoperative (2.0 Liter)
- Daytime Running Lamps (DRL) Inoperative (2.5 Liter)
- Fog Lamps Inoperative - Rear
- Hazard Lamps Inoperative
- Headlamps Inoperative - High Beams
- Headlamps Inoperative - Low Beams
- Headlamps Inoperative - Low and High Beams
- Headlight Leveling Inoperative
- Ignition Lock Cylinder Lamp Inoperative
- Instrument Panel (I/P) Compartment Lamp Inoperative
- Park, Tail and Side Marker Lamps Inoperative
- Rear Compartment Lamp(s) Inoperative
- Stop Lamps Always On
- Stop Lamps Inoperative
- Turn Signal Lamps and/or Indicators Inoperative
- Vanity Mirror Lamp(s) Inoperative
- Repair Instructions
- Dome and Reading Lamp Replacement
- Stop Lamp Switch Adjustment
- Stop Lamp Switch Replacement
- Daytime Running Lights (DRL) Control Module Replacement
- Ashtray Lamp Bulb Replacement
- Ignition Lock Cylinder Lamp Replacement
- Door Lamp Replacement
- Instrument Panel (I/P) Compartment Lamp Replacement
- Instrument Cluster Dimmer/Headlamp Leveling Switch Replacement
- Vanity Mirror Lamp Replacement
- Headlamp Replacement
- Headlamp Aiming
- Fog Lamp Replacement - Front (2.5L)
- Fog Lamp Replacement - Front (2.0L)
- Repeater Lamp Replacement
- Marker Lamp Replacement - Front Side
- Park/Turn Signal Lamp Replacement
- High Mounted Stop Lamp Replacement
- License Lamp Replacement
- Tail Lamp Replacement
- Rear Compartment Lamp Replacement
- Description and Operation
- Wiring Systems - Component Locator - Electrical Center Identification Views
- Wiring Systems - Component Locator - Master Electrical Component List
- Wiring Systems - Diagnostic Information And Procedures
- Diagnostic Information and Procedures
- Electrical Symbols
- General Electrical Diagnosis Procedures
- Checking Aftermarket Accessories
- Circuit Testing
- Using Connector Test Adapters
- Probing Electrical Connectors
- Troubleshooting with a Digital Multimeter
- Troubleshooting with a Test Lamp
- Using Fused Jumper Wires
- Measuring Voltage
- Measuring Voltage Drop
- Measuring Frequency
- Testing for Continuity
- Testing for Short to Ground
- Testing for a Short to Voltage
- Testing for Intermittent Conditions and Poor Connections
- Inducing Intermittent Fault Conditions
- Testing for Electrical Intermittents
- Scan Tool Snapshot Procedure
- Circuit Protection - Fuses
- Circuit Protection - Circuit Breakers
- Circuit Protection - Fusible Links
- Wiring Repairs
- Repairing Damaged Wire Insulation
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- SIR/SRS Wiring Repairs
- Connector Repairs
- Connector Position Assurance Locks
- Terminal Position Assurance Locks
- Push to Seat Connectors
- Pull to Seat Connectors
- Weather Pack Connectors
- Micro-Pack 100W Connectors
- Micro .64 Connectors
- Repairing Connector Terminals
- Diagnostic Information and Procedures
- Wiring Systems - In-Line Harness Connector End Views
- Wiring Systems - Power And Grounding Connector End Views
- Wiring Systems - Repair Instructions
- Wiring Systems - Schematic And Routing Diagrams
- Wiring Systems - Special Tools And Equipment
- Wiring Systems - Splice Pack Connector End Views
- Starter
- Engine Electrical System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Code Index
- Diagnostic Starting Point - Engine Electrical
- Diagnostic System Check - Engine Electrical
- Diagnostic Trouble Code (DTC) List
- DTC P0562 (w/2.0L L34 GMDAT)
- DTC P0562 (w/2.5L LBK)
- DTC P0563 (w/2.0L (L34 GMDAT))
- DTC P0563 (w/2.5L (LBK))
- Symptoms - Engine Electrical
- Battery Inspection/Test
- Battery Charging
- Battery Electrical Drain/Parasitic Load Test
- Battery Common Causes of Failure
- Jump Starting in Case of Emergency
- Charging System Test
- Charge Indicator Always On
- Charge Indicator Inoperative
- Generator Noise Diagnosis
- Starter Solenoid Does Not Click
- Starter Solenoid Clicks, Engine Does Not Crank
- Engine Cranks Slowly
- Starter Motor Noise Diagnosis
- Repair Instructions
- Battery and Battery Tray Replacement
- Battery Negative Cable Disconnect/Connect Procedure
- Starter Motor Replacement (2.0L)
- Starter Motor Replacement (2.5L)
- Generator Replacement (2.0L)
- Generator Replacement (2.5L)
- Starter Motor Overhaul (2.0L)
- Starter Motor Overhaul (2.5L)
- Generator Overhaul (2.0L)
- Generator Overhaul (2.5L)
- Description and Operation
- Special Tools and Equipment
- Engine Electrical System
- Wiring Diagrams
- Automatic Transmission - ZF 4HP 16 - Schematic And Routing Diagrams
- Engine Control System - 2.0L (L34 GMDAT) - ECM Connector End Views
- Engine Control System - 2.0L (L34 GMDAT) - Engine Controls Connector End Views
- Engine Control System - 2.0L (L34 GMDAT) - Schematic And Routing Diagrams
- Engine Control System - 2.5L (LBK) - ECM Connector End Views
- Engine Control System - 2.5L (LBK) - Engine Controls Connector End Views
- Engine Control System - 2.5L (LBK) - Schematic And Routing Diagrams
- Lighting Systems
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Lighting Systems
- Symptoms - Lighting Systems
- Automatic Transaxle Gear Position Illumination Lamp Inoperative, All Other Instrument Lamps OK
- Fog Lamps Inoperative - Front
- Instrument Panel Illumination Lamps Inoperative
- Backup Lamps Inoperative
- Courtesy Lamps Inoperative
- Courtesy Lamps Inoperative - Ashtray
- Courtesy Lamps Inoperative - Door Step
- Daytime Running Lamps (DRL) Inoperative (2.0 Liter)
- Daytime Running Lamps (DRL) Inoperative (2.5 Liter)
- Fog Lamps Inoperative - Rear
- Hazard Lamps Inoperative
- Headlamps Inoperative - High Beams
- Headlamps Inoperative - Low Beams
- Headlamps Inoperative - Low and High Beams
- Headlight Leveling Inoperative
- Ignition Lock Cylinder Lamp Inoperative
- Instrument Panel (I/P) Compartment Lamp Inoperative
- Park, Tail and Side Marker Lamps Inoperative
- Rear Compartment Lamp(s) Inoperative
- Stop Lamps Always On
- Stop Lamps Inoperative
- Turn Signal Lamps and/or Indicators Inoperative
- Vanity Mirror Lamp(s) Inoperative
- Repair Instructions
- Dome and Reading Lamp Replacement
- Stop Lamp Switch Adjustment
- Stop Lamp Switch Replacement
- Daytime Running Lights (DRL) Control Module Replacement
- Ashtray Lamp Bulb Replacement
- Ignition Lock Cylinder Lamp Replacement
- Door Lamp Replacement
- Instrument Panel (I/P) Compartment Lamp Replacement
- Instrument Cluster Dimmer/Headlamp Leveling Switch Replacement
- Vanity Mirror Lamp Replacement
- Headlamp Replacement
- Headlamp Aiming
- Fog Lamp Replacement - Front (2.5L)
- Fog Lamp Replacement - Front (2.0L)
- Repeater Lamp Replacement
- Marker Lamp Replacement - Front Side
- Park/Turn Signal Lamp Replacement
- High Mounted Stop Lamp Replacement
- License Lamp Replacement
- Tail Lamp Replacement
- Rear Compartment Lamp Replacement
- Description and Operation
- System Wiring Diagrams
- Using lemon2025'S System Wiring Diagrams
- Wiring Systems - Component Locator - Master Electrical Component List
- Wiring Systems - In-Line Harness Connector End Views
- Wiring Systems - Power And Grounding Connector End Views
- Wiring Systems - Schematic And Routing Diagrams
- Wiring Systems - Splice Pack Connector End Views
- Body Electrical
- Engine Mechanical
- Cooling System (Mechanical)
- Engine Cooling System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Code Index
- DTC P0480 or P0481
- Symptoms - Engine Cooling
- Cooling Fan Circuit Diagnosis (Non European Emissions)
- Cooling Fan Circuit Diagnosis (European Emissions)
- Cooling Fan Circuit Diagnosis (North American Emissions)
- Engine Overheating
- Loss of Coolant
- Thermostat Diagnosis
- Coolant Heater Inoperative
- Engine Fails To Reach Normal Operating Temperature
- Pressure Cap Testing
- Repair Instructions
- Draining and Filling Cooling System (2.0L)
- Draining and Filling Cooling System (2.5L)
- Surge Tank Replacement (2.0L)
- Surge Tank Replacement (2.5L)
- Cooling Fan Replacement - Electric (2.0L)
- Cooling Fan Replacement - Electric (2.5L)
- Thermostat Replacement (2.0L)
- Thermostat Replacement (2.5L)
- Engine Coolant Temperature Sensor Replacement
- Radiator Replacement (2.0L)
- Radiator Replacement (2.5L)
- Coolant Heater Replacement
- Coolant Heater Cord Replacement
- Description and Operation
- Special Tools and Equipment
- Engine Cooling System
- Engine Exhaust
- Specifications
- Visual Identification
- Diagnostic Information and Procedures
- Repair Instructions
- Description and Operation
- Lubrication System
- Maintenance And Lubrication
- Specifications
- Maintenance
- Maintenance Schedule (European Emissions)
- Normal Vehicle Use
- Footnotes
- 1 000 km (600 mi)
- 15 000 km (9,000 mi) or every 12 months, whichever comes first
- 30 000 km (18,000 mi) or every 24 months, whichever comes first
- 45 000 km (27,000 mi) or every 36 months, whichever comes first
- 60 000 km (36,000 mi) or every 48 months, whichever comes first
- 75 000 km (45,000 mi) or every 60 months, whichever comes first
- 90 000 km (54,000 mi) or every 72 months, whichever comes first
- 105 000 km (63,000 mi) or every 84 months, whichever comes first
- 120 000 km (72,000 mi) or every 96 months, whichever comes first
- Maintenance Schedule (North American Emissions)
- Notes
- Short Trip/City Definition
- Short Trip/City Intervals
- Long Trip/Highway Definition
- Long Trip/Highway Intervals
- Normal Vehicle Use
- Short Trip Footnotes
- 3,000 Miles (5 000 km)
- 6,000 Miles (10 000 km)
- 9,000 Miles (15 000 km)
- 12,000 Miles (20 000 km)
- 15,000 Miles (25 000 km)
- 18,000 Miles (30 000 km)
- 21,000 Miles (35 000 km)
- 24,000 Miles (40 000 km)
- 27,000 Miles (45 000 km)
- 30,000 Miles (50 000 km)
- 33,000 Miles (55 000 km)
- 36,000 Miles (60 000 km)
- 39,000 Miles (65 000 km)
- 42,000 Miles (70 000 km)
- 45,000 Miles (75 000 km)
- 48,000 Miles (80 000 km)
- 50,000 Miles (83 000 km)
- 51,000 Miles (85 000 km)
- 54,000 Miles (90 000 km)
- 57,000 Miles (95 000 km)
- 60,000 Miles (100 000 km)
- 63,000 Miles (105 000 km)
- 66,000 Miles (110 000 km)
- 69,000 Miles (115 000 km)
- 72,000 Miles (120 000 km)
- 75,000 Miles (125 000 km)
- 78,000 Miles (130 000 km)
- 81,000 Miles (135 000 km)
- 84,000 Miles (140 000 km)
- 87,000 Miles (145 000 km)
- 90,000 Miles (150 000 km)
- 93,000 Miles (155 000 km)
- 96,000 Miles (160 000 km)
- 99,000 Miles (165 000 km)
- 100,000 Miles (166 000 km)
- Long Trip Footnotes
- 7,500 Miles (12 500 km)
- 22,500 Miles (37 500 km)
- 37,500 Miles (62 500 km)
- 52,500 Miles (87 500 km)
- 67,500 Miles (112 500 km)
- 82,500 Miles (137 500 km)
- 97,500 Miles (162 500 km)
- Maintenance Schedule (not European or North American)
- Normal Vehicle Use
- Footnotes
- 1 000 km (600 mi)
- 10 000 km (6,000 mi) or every 6 months, whichever comes first
- 20 000 km (12,000 mi) or every 12 months, whichever comes first
- 30, 000 km (18,000 mi) or every 18 months, whichever comes first
- 40, 000 km (24,000 mi) or every 24 months, whichever comes first
- 50, 000 km (30,000 mi) or every 30 months, whichever comes first
- 60, 000 km (36,000 mi) or every 36 months, whichever comes first
- 70, 000 km (42,000 mi) or every 42 months, whichever comes first
- 80, 000 km (48,000 mi) or every 48 months, whichever comes first
- 90, 000 km (54,000 Mi) or every 54 months, whichever comes first
- 100, 000 km (60,000 mi) or every 60 months, whichever comes first
- Explanation of Scheduled Services
- Normal Vehicle Use
- Explanation of Scheduled Maintenance Services
- Drive Belt Inspection
- Engine Oil and Oil Filter Change
- Engine Oil Viscosity
- Cooling System Service
- Fuel Micro-Filter Replacement - North American Emissions
- Fuel Micro-Filter Replacement - European Emissions
- Fuel Micro-Filter Replacement - Non-European Emissions
- Air Cleaner Element Replacement - North American Emissions
- Air Cleaner Element Replacement - European Emissions
- Air Cleaner Element Replacement - Non European Emissions
- Throttle Body Mounting Bolt Torque
- Spark Plug Replacement
- Spark Plug Wire Replacement
- Brake System Service - European Emission
- Brake System Service - North American Emissions
- Brake System Service - Non European Emissions
- Transaxle Service
- Owner Checks and Services
- Maintenance Schedule (European Emissions)
- Maintenance And Lubrication
- Mechanical
- Engine Mechanical - 2.0L (L34 GMDAT) - Component Locator
- Engine Mechanical - 2.0L (L34 GMDAT) - Description And Operation
- Engine Mechanical - 2.0L (L34 GMDAT) - Diagnostic Information And Procedures
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Engine Mechanical
- Symptoms - Engine Mechanical
- Oil Pressure Diagnosis and Testing
- Oil Leak Diagnosis
- Engine Noise Diagnosis
- Engine Knocks Cold and Continues for Two-Three Minutes and/or Knock Increases with Engine Torque
- Engine Noise Under Load
- Light Knock Hot
- Engine Noise on Start-Up, but Only Lasting a Few Seconds
- Knocks at Idle Hot
- Main Bearing Noise
- Connecting Rod Bearing Noise Symptom
- Piston Noises
- Base Engine Misfire with Abnormal Valve Train Noise
- Engine Compression Test
- Diagnostic Information and Procedures
- Engine Mechanical - 2.0L (L34 GMDAT) - Repair Instructions
- Repair Instructions
- Intake Manifold Replacement
- Timing Belt Replacement
- Timing Belt Inspection
- Timing Belt Cover Replacement
- Valve Rocker Arm Cover Replacement
- Cylinder Head Replacement
- Oil Pan Replacement
- Oil Pan Cleaning and Inspection
- Oil Pump Replacement
- Oil Pump Cleaning and Inspection
- Engine Mount Replacement (Right Side)
- Engine Mount Replacement (Forward)
- Engine Replacement
- Exhaust Manifold Removal
- Crankshaft and Bearings Cleaning and Inspection
- Piston, Connecting Rod, and Bearing Replacement
- Piston, Connecting Rod, and Bearings Cleaning and Inspection
- Camshaft Gear Replacement
- Camshaft Replacement
- Valve Rocker Arm and Shaft Cleaning and Inspection
- Valve Guide Reaming/Valve and Seat Grinding
- Cylinder Head Disassemble
- Cylinder Head Cleaning and Inspection
- Cylinder Head Assemble
- Crankshaft Replacement
- Exhaust Manifold Installation
- Repair Instructions
- Engine Mechanical - 2.0L (L34 GMDAT) - Special Tools And Equipment
- Engine Mechanical - 2.0L (L34 GMDAT) - Specifications
- Engine Mechanical - 2.5L (LBK) - Component Locator
- Engine Mechanical - 2.5L (LBK) - Description And Operation
- Engine Mechanical - 2.5L (LBK) - Diagnostic Information And Procedures
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Engine Mechanical
- Symptoms - Engine Mechanical
- Oil Pressure Diagnosis and Testing
- Oil Leak Diagnosis
- Engine Noise Diagnosis
- Engine Knocks Cold and Continues for Two-Three Minutes and/or Knock Increases with Engine Torque
- Engine Noise Under Load
- Light Knock Hot
- Engine Noise on Start-Up, but Only Lasting a Few Seconds
- Knocks at Idle Hot
- Main Bearing Noise
- Connecting Rod Bearing Noise Symptom
- Piston Noises
- Engine Compression Test
- Base Engine Misfire with Abnormal Valve Train Noise
- Diagnostic Information and Procedures
- Engine Mechanical - 2.5L (LBK) - Repair Instructions
- Repair Instructions
- Intake Manifold Replacement
- Valve Rocker Arm and Shaft Replacement
- Cylinder Head Cover Replacement
- Cylinder Head Replacement
- Oil Filter Adapter Replacement
- Oil Pan Replacement
- Oil Pump Replacement
- Engine Mount Replacement (Right Side)
- Engine Mount Replacement (Left Side)
- Engine Replacement
- Timing Chain and Sprockets Replacement
- Exhaust Manifold Removal
- Lower Crankcase Replacement
- Cylinder Head Disassemble
- Cylinder Head Assemble
- Crankshaft Replacement
- Exhaust Manifold Installation
- Repair Instructions
- Engine Mechanical - 2.5L (LBK) - Special Tools And Equipment
- Engine Mechanical - 2.5L (LBK) - Specifications
- Starter
- Engine Electrical System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Code Index
- Diagnostic Starting Point - Engine Electrical
- Diagnostic System Check - Engine Electrical
- Diagnostic Trouble Code (DTC) List
- DTC P0562 (w/2.0L L34 GMDAT)
- DTC P0562 (w/2.5L LBK)
- DTC P0563 (w/2.0L (L34 GMDAT))
- DTC P0563 (w/2.5L (LBK))
- Symptoms - Engine Electrical
- Battery Inspection/Test
- Battery Charging
- Battery Electrical Drain/Parasitic Load Test
- Battery Common Causes of Failure
- Jump Starting in Case of Emergency
- Charging System Test
- Charge Indicator Always On
- Charge Indicator Inoperative
- Generator Noise Diagnosis
- Starter Solenoid Does Not Click
- Starter Solenoid Clicks, Engine Does Not Crank
- Engine Cranks Slowly
- Starter Motor Noise Diagnosis
- Repair Instructions
- Battery and Battery Tray Replacement
- Battery Negative Cable Disconnect/Connect Procedure
- Starter Motor Replacement (2.0L)
- Starter Motor Replacement (2.5L)
- Generator Replacement (2.0L)
- Generator Replacement (2.5L)
- Starter Motor Overhaul (2.0L)
- Starter Motor Overhaul (2.5L)
- Generator Overhaul (2.0L)
- Generator Overhaul (2.5L)
- Description and Operation
- Special Tools and Equipment
- Engine Electrical System
- Cooling System (Mechanical)
- Engine Performance
- Emissions
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Specifications
- System
- Engine Control System - 2.0L (L34 GMDAT) - Description And Operation
- Description and Operation
- Engine Control Module (ECM) Description
- Notes
- Comprehensive Component Monitor Diagnostic Operation
- Input Components
- Output Components
- Passive and Active Diagnostic Tests
- Warm-Up Cycle
- Freeze Frame
- Failure Records
- Common OBD Terms
- Primary System-Based Diagnostics
- Oxygen Sensor Diagnosis
- Misfire Monitor Diagnostic Operation
- Misfire Counters
- Fuel Trim System Monitor Diagnostic Operation
- Fuel Trim Cell Diagnostic Weights
- Engine Control Component Description
- Crankshaft Position Sensor
- Camshaft Position Sensor
- Idle Air System Operation
- Engine Coolant Temperature (ECT) Sensor
- Throttle Position (TP) Sensor
- Catalyst Monitor Oxygen Sensors
- Exhaust Gas Recirculation (EGR) Valve
- Intake Air Temperature (IAT) Sensor
- Idle Air Control (IAC) Valve
- G Sensor
- Manifold Absolute Pressure (MAP) Sensor
- Fuel System Description
- Fuel System Overview
- Fuel Tank
- Fuel Fill Pipe
- Fuel Filler Cap
- Fuel Sender Assembly
- Fuel Level Sensor
- Fuel Pump
- Fuel Strainer - Typical
- Fuel Filter - Typical
- Fuel Feed and Return Pipes
- Nylon Fuel Pipes
- Quick-Connect Fittings
- Fuel Pipe O-Rings
- Fuel Rail Assembly
- Fuel Injectors
- Fuel Pressure Regulator Assembly - Typical
- Fuel Metering Modes of Operation
- Starting Mode
- Clear Flood Mode
- Run Mode
- Acceleration Mode
- Deceleration Mode
- Battery Voltage Correction Mode
- Fuel Cutoff Mode
- Fuel Trim
- Evaporative Emission (EVAP) Control System Description
- Electronic Ignition (EI) System Description
- Knock Sensor (KS) System Description
- Exhaust Gas Recirculation (EGR) System Description
- Crankcase Ventilation System Description
- Air Intake System Description
- Engine Control Module (ECM) Description
- Description and Operation
- Engine Control System - 2.0L (L34 GMDAT) - Diagnostic Information And Procedures
- Diagnostic Code Index
- Diagnostic Starting Point - Engine Controls
- Diagnostic System Check - Engine Controls (Non European Emissions)
- Diagnostic System Check - Engine Controls (European Emissions)
- Scan Tool Data List (Non European Emissions)
- Scan Tool Data List (European and North America Emissions)
- Scan Tool Data Definitions
- Scan Tool Output Controls
- Diagnostic Trouble Code (DTC) List
- Engine Control System - 2.0L (L34 GMDAT) - DTC P0141 To DTC P0700
- DTC P0141
- DTC P0171
- DTC P0172
- DTC P0201-P0204
- DTC P0300-P0304
- DTC P0313
- DTC P0317
- DTC P0325
- DTC P0327
- DTC P0336
- DTC P0337
- DTC P0341
- DTC P0342
- DTC P0351 or P0352
- DTC P0401
- DTC P0402
- DTC P0404
- DTC P0405
- DTC P0406
- DTC P0420
- DTC P0443
- DTC P0502
- DTC P0506 or P0507
- DTC P0601-P0607, P1600, P1621, P1627, P1680, P1681, P1683, or P2610
- DTC P0700
- Engine Control System - 2.0L (L34 GMDAT) - DTC P1106 To DTC P1655
- Engine Control System - 2.0L (L34 GMDAT) - ECM Connector End Views
- Engine Control System - 2.0L (L34 GMDAT) - Engine Controls Component Views
- Engine Control System - 2.0L (L34 GMDAT) - Engine Controls Connector End Views
- Engine Control System - 2.0L (L34 GMDAT) - Flash Codes DTC 002 To DTC 044
- Engine Control System - 2.0L (L34 GMDAT) - Repair Instructions
- Repair Instructions
- Engine Control Module (ECM) Replacement (Non European Emissions)
- Engine Control Module (ECM) Replacement (European Emissions)
- CKP System Variation Learn Procedure
- Idle Learn Procedure
- Engine Coolant Temperature (ECT) Sensor Replacement
- Intake Air Temperature (IAT) Sensor Replacement
- Manifold Absolute Pressure (MAP) Sensor Replacement
- Oxygen Sensor (O2S) Replacement
- Heated Oxygen Sensor (HO2S) Replacement Bank 1 Sensor 2
- Throttle Position (TP) Sensor Replacement
- Idle Air Control (IAC) Valve Replacement
- Throttle Body Assembly Replacement
- Throttle Body Service
- Fuel Pressure Relief Procedure
- Fuel Pressure Gage Installation and Removal
- Fuel Filter Replacement
- Fuel Tank Draining Procedure
- Fuel Tank Replacement
- Fuel Sender Assembly Replacement
- Fuel Pump Replacement
- Fuel System Cleaning
- Fuel Rail Assembly Replacement
- Fuel Pressure Regulator Replacement
- Acceleration Sensor Replacement
- Evaporative Emission (EVAP) Canister Replacement
- Evaporative Emission (EVAP) Canister Purge Solenoid Valve Replacement
- Ignition Coil(s) Replacement
- Spark Plug Wire Inspection
- Spark Plug Wire Replacement
- Spark Plug Inspection
- Spark Plug Replacement
- Crankshaft Position (CKP) Sensor Replacement
- Camshaft Position (CMP) Sensor Replacement
- Knock Sensor (KS) Replacement
- Exhaust Gas Recirculation (EGR) Valve Replacement
- Repair Instructions
- Engine Control System - 2.0L (L34 GMDAT) - Schematic And Routing Diagrams
- Engine Control System - 2.0L (L34 GMDAT) - Special Tools And Equipment
- Engine Control System - 2.0L (L34 GMDAT) - Specifications
- Engine Control System - 2.0L (L34 GMDAT) - Symptom Troubleshooting And Diagnosis
- Symptoms - Engine Controls
- Intermittent Conditions
- Hard Start
- Surges/Chuggles
- Lack of Power, Sluggishness, or Sponginess
- Detonation/Spark Knock
- Hesitation, Sag, Stumble
- Cuts Out, Misses
- Poor Fuel Economy
- Rough, Unstable, or Incorrect Idle and Stalling
- Dieseling, Run-On
- Backfire
- Malfunction Indicator Lamp (MIL) Inoperative
- Malfunction Indicator Lamp (MIL) Will Not Flash
- Malfunction Indicator Lamp (MIL) Always On
- Engine Cranks but Does Not Run (Non European Emissions)
- Engine Cranks but Does Not Run (European Emissions)
- Engine Control Module (ECM) Outputs Diagnosis
- Multiple Engine Control Module (ECM) Information Sensor DTCs Set (Non European Emissions)
- Multiple Engine Control Module (ECM) Information Sensor DTCs Set (European Emissions)
- Main Relay Circuit Diagnosis (Non European Emissions)
- Main Relay Circuit Diagnosis (European Emissions)
- Fuel System Diagnosis
- Fuel Pump Electrical Circuit Diagnosis
- Fuel Injector Coil Test
- Fuel Injector Circuit Diagnosis
- Fuel Injector Balance Test with Special Tool
- Fuel Tank Leak Test
- Alcohol/Contaminants-in-Fuel Diagnosis (w/o Special Tool)
- Manifold Absolute Pressure (MAP) Sensor Diagnosis
- Idle Air Control (IAC) System Diagnosis
- Electronic Ignition (EI) System Diagnosis
- Crankcase Ventilation System Inspection/Diagnosis
- Engine Control System - 2.0L (L34 GMDAT) Flash Codes DTC 049 To OBDII DTC P0140
- Engine Control System - 2.5L (LBK) - Description And Operation
- Description and Operation
- Engine Control Module (ECM) Description
- Engine Control Component Description
- Crankshaft Position (CKP) Sensor
- Camshaft Position (CMP) Sensor
- Idle Air System Operation
- Engine Coolant Temperature (ECT) Sensor
- Throttle Position (TP) Sensor
- Catalyst Monitor Oxygen Sensors
- Exhaust Gas Recirculation (EGR) Valve
- Intake Air Temperature (IAT) Sensor
- Manifold Absolute Pressure (MAP) Sensor
- Main Throttle Idle Actuator (MTIA)
- Fuel System Description
- Fuel System Overview
- Fuel Tank
- Fuel Fill Pipe
- Fuel Filler Cap
- Fuel Sender Assembly
- Fuel Level Sensor
- Fuel Pump
- Fuel Strainer - Typical
- Fuel Filter - Typical
- Fuel Feed and Return Pipes
- Nylon Fuel Pipes
- Quick-Connect Fittings
- Fuel Pipe O-Rings
- Fuel Rail Assembly
- Fuel Injectors
- Fuel Pressure Regulator Assembly - Typical
- Fuel Metering Modes of Operation
- Starting Mode
- Clear Flood Mode
- Run Mode
- Acceleration Mode
- Deceleration Mode
- Battery Voltage Correction Mode
- Fuel Cutoff Mode
- Fuel Trim
- Evaporative Emission (EVAP) Control System Description
- Electronic Ignition (EI) System Description
- Knock Sensor (KS) System Description
- Exhaust Gas Recirculation (EGR) System Description
- Crankcase Ventilation System Description
- Air Intake System Description
- Description and Operation
- Engine Control System - 2.5L (LBK) - Diagnostic Information And Procedures
- Engine Control System - 2.5L (LBK) - DTC P0030 To DTC P0154
- DTC P0030, P0036, P0050, or P0056
- DTC P0031, P0037, P0051, or P0057
- DTC P0032, P0038, P0052, or P0058
- DTC P0101
- DTC P0102
- DTC P0103
- DTC P0106
- DTC P0107
- DTC P0108
- DTC P0111
- DTC P0112
- DTC P0113
- DTC P0116
- DTC P0117
- DTC P0118
- DTC P0119
- DTC P0121
- DTC P0122
- DTC P0123
- DTC P0125
- DTC P0128
- DTC P0131 or P0151
- DTC P0132 or P0152
- DTC P0133 or P0153
- DTC P0134 or P0154
- Engine Control System - 2.5L (LBK) - DTC P0137 To DTC P0403
- DTC P0137 or P0157
- DTC P0138 or P0158
- DTC P0139 or P0159
- DTC P0140 or P0160
- DTC P0171 or P0174
- DTC P0172 or P0175
- DTC P0222
- DTC P0223
- DTC P0230
- DTC P0261, P0264, P0267, P0270, P0273, or P0276
- DTC P0262, P0265, P0268, P0271, P0274, or P0277
- DTC P0300
- DTC P0301-P0306
- DTC P0329
- DTC P0334
- DTC P0335
- DTC P0336
- DTC P0337
- DTC P0341
- DTC P0342
- DTC P0351-P0356
- DTC P0400
- DTC P0401
- DTC P0402
- DTC P0403
- Engine Control System - 2.5L (LBK) - DTC P0404 To DTC P0662
- Engine Control System - 2.5L (LBK) - DTC P0700 To DTC P2422
- Engine Control System - 2.5L (LBK) - ECM Connector End Views
- Engine Control System - 2.5L (LBK) - Engine Controls Connector End Views
- Engine Control System - 2.5L (LBK) - Repair Instructions
- Repair Instructions
- Engine Control Module (ECM) Replacement
- Idle Learn Procedure
- Engine Coolant Temperature (ECT) Sensor Replacement
- Intake Air Temperature (IAT) Sensor Replacement
- Manifold Absolute Pressure (MAP) Sensor Replacement
- Heated Oxygen Sensor (HO2S) Replacement Bank 1 Sensor 2
- Knock Sensor (KS) Replacement
- Throttle Body Assembly Replacement
- Throttle Body Service
- Fuel Pressure Relief Procedure
- Fuel Pressure Gage Installation and Removal
- Fuel Filter Replacement
- Fuel Tank Draining Procedure
- Fuel Sender Assembly Replacement
- Fuel Rail Assembly Replacement
- Fuel Pressure Regulator Replacement
- Evaporative Emission (EVAP) Canister Purge Solenoid Valve Replacement
- Ignition Coil(s) Replacement
- Spark Plug Inspection
- Spark Plug Replacement
- Crankshaft Position (CKP) Sensor Replacement
- Camshaft Position (CMP) Sensor Replacement
- Exhaust Gas Recirculation (EGR) Valve Replacement
- Exhaust Gas Recirculation (EGR) Valve Pipe Replacement (Intake)
- Exhaust Gas Recirculation (EGR) Valve Pipe Replacement (Exhaust)
- Intake Manifold Tuning (IMT) Valve Actuator Solenoid Replacement
- Intake Manifold Tuning (IMT) Valve Actuator Replacement
- Intake Manifold Tuning (IMT) Valve Vacuum Reservoir Replacement
- Air Cleaner Element Replacement
- Air Cleaner Assembly Replacement
- Repair Instructions
- Engine Control System - 2.5L (LBK) - Schematic And Routing Diagrams
- Engine Control System - 2.5L (LBK) - Special Tools And Equipment
- Engine Control System - 2.5L (LBK) - Specifications
- Engine Control System - 2.5L (LBK) - Symptom Troubleshooting And Diagnosis
- Symptoms - Engine Controls
- Intermittent Conditions
- Hard Start
- Surges/Chuggles
- Lack of Power, Sluggishness, or Sponginess
- Detonation/Spark Knock
- Hesitation, Sag, Stumble
- Cuts Out, Misses
- Poor Fuel Economy
- Rough, Unstable, or Incorrect Idle and Stalling
- Dieseling, Run-On
- Backfire
- Malfunction Indicator Lamp (MIL) Inoperative
- Malfunction Indicator Lamp (MIL) Always On
- Engine Cranks but Does Not Run
- Fuel System Diagnosis
- Fuel Pump Electrical Circuit Diagnosis
- Fuel Injector Coil Test
- Fuel Injector Balance Test with Special Tool
- Fuel Tank Leak Test
- Alcohol/Contaminants-in-Fuel Diagnosis (WO/Special Tool)
- Alcohol/Contaminants-in-Fuel Diagnosis (W/Special Tool)
- Crankcase Ventilation System Inspection/Diagnosis
- Intake Manifold Tuning (IMT) Valve Diagnosis
- Electronic Ignition (EI) System Diagnosis
- Engine Control System - 2.5L (LBK) Engine Controls Component Views
- Engine Control System - 2.0L (L34 GMDAT) - Description And Operation
- Testing & Diagnosis
- Engine Control System - 2.0L (L34 GMDAT) - Description And Operation
- Description and Operation
- Engine Control Module (ECM) Description
- Notes
- Comprehensive Component Monitor Diagnostic Operation
- Input Components
- Output Components
- Passive and Active Diagnostic Tests
- Warm-Up Cycle
- Freeze Frame
- Failure Records
- Common OBD Terms
- Primary System-Based Diagnostics
- Oxygen Sensor Diagnosis
- Misfire Monitor Diagnostic Operation
- Misfire Counters
- Fuel Trim System Monitor Diagnostic Operation
- Fuel Trim Cell Diagnostic Weights
- Engine Control Component Description
- Crankshaft Position Sensor
- Camshaft Position Sensor
- Idle Air System Operation
- Engine Coolant Temperature (ECT) Sensor
- Throttle Position (TP) Sensor
- Catalyst Monitor Oxygen Sensors
- Exhaust Gas Recirculation (EGR) Valve
- Intake Air Temperature (IAT) Sensor
- Idle Air Control (IAC) Valve
- G Sensor
- Manifold Absolute Pressure (MAP) Sensor
- Fuel System Description
- Fuel System Overview
- Fuel Tank
- Fuel Fill Pipe
- Fuel Filler Cap
- Fuel Sender Assembly
- Fuel Level Sensor
- Fuel Pump
- Fuel Strainer - Typical
- Fuel Filter - Typical
- Fuel Feed and Return Pipes
- Nylon Fuel Pipes
- Quick-Connect Fittings
- Fuel Pipe O-Rings
- Fuel Rail Assembly
- Fuel Injectors
- Fuel Pressure Regulator Assembly - Typical
- Fuel Metering Modes of Operation
- Starting Mode
- Clear Flood Mode
- Run Mode
- Acceleration Mode
- Deceleration Mode
- Battery Voltage Correction Mode
- Fuel Cutoff Mode
- Fuel Trim
- Evaporative Emission (EVAP) Control System Description
- Electronic Ignition (EI) System Description
- Knock Sensor (KS) System Description
- Exhaust Gas Recirculation (EGR) System Description
- Crankcase Ventilation System Description
- Air Intake System Description
- Engine Control Module (ECM) Description
- Description and Operation
- Engine Control System - 2.0L (L34 GMDAT) - Diagnostic Information And Procedures
- Diagnostic Code Index
- Diagnostic Starting Point - Engine Controls
- Diagnostic System Check - Engine Controls (Non European Emissions)
- Diagnostic System Check - Engine Controls (European Emissions)
- Scan Tool Data List (Non European Emissions)
- Scan Tool Data List (European and North America Emissions)
- Scan Tool Data Definitions
- Scan Tool Output Controls
- Diagnostic Trouble Code (DTC) List
- Engine Control System - 2.0L (L34 GMDAT) - DTC P0141 To DTC P0700
- DTC P0141
- DTC P0171
- DTC P0172
- DTC P0201-P0204
- DTC P0300-P0304
- DTC P0313
- DTC P0317
- DTC P0325
- DTC P0327
- DTC P0336
- DTC P0337
- DTC P0341
- DTC P0342
- DTC P0351 or P0352
- DTC P0401
- DTC P0402
- DTC P0404
- DTC P0405
- DTC P0406
- DTC P0420
- DTC P0443
- DTC P0502
- DTC P0506 or P0507
- DTC P0601-P0607, P1600, P1621, P1627, P1680, P1681, P1683, or P2610
- DTC P0700
- Engine Control System - 2.0L (L34 GMDAT) - DTC P1106 To DTC P1655
- Engine Control System - 2.0L (L34 GMDAT) - ECM Connector End Views
- Engine Control System - 2.0L (L34 GMDAT) - Engine Controls Component Views
- Engine Control System - 2.0L (L34 GMDAT) - Engine Controls Connector End Views
- Engine Control System - 2.0L (L34 GMDAT) - Flash Codes DTC 002 To DTC 044
- Engine Control System - 2.0L (L34 GMDAT) - Repair Instructions
- Repair Instructions
- Engine Control Module (ECM) Replacement (Non European Emissions)
- Engine Control Module (ECM) Replacement (European Emissions)
- CKP System Variation Learn Procedure
- Idle Learn Procedure
- Engine Coolant Temperature (ECT) Sensor Replacement
- Intake Air Temperature (IAT) Sensor Replacement
- Manifold Absolute Pressure (MAP) Sensor Replacement
- Oxygen Sensor (O2S) Replacement
- Heated Oxygen Sensor (HO2S) Replacement Bank 1 Sensor 2
- Throttle Position (TP) Sensor Replacement
- Idle Air Control (IAC) Valve Replacement
- Throttle Body Assembly Replacement
- Throttle Body Service
- Fuel Pressure Relief Procedure
- Fuel Pressure Gage Installation and Removal
- Fuel Filter Replacement
- Fuel Tank Draining Procedure
- Fuel Tank Replacement
- Fuel Sender Assembly Replacement
- Fuel Pump Replacement
- Fuel System Cleaning
- Fuel Rail Assembly Replacement
- Fuel Pressure Regulator Replacement
- Acceleration Sensor Replacement
- Evaporative Emission (EVAP) Canister Replacement
- Evaporative Emission (EVAP) Canister Purge Solenoid Valve Replacement
- Ignition Coil(s) Replacement
- Spark Plug Wire Inspection
- Spark Plug Wire Replacement
- Spark Plug Inspection
- Spark Plug Replacement
- Crankshaft Position (CKP) Sensor Replacement
- Camshaft Position (CMP) Sensor Replacement
- Knock Sensor (KS) Replacement
- Exhaust Gas Recirculation (EGR) Valve Replacement
- Repair Instructions
- Engine Control System - 2.0L (L34 GMDAT) - Schematic And Routing Diagrams
- Engine Control System - 2.0L (L34 GMDAT) - Special Tools And Equipment
- Engine Control System - 2.0L (L34 GMDAT) - Specifications
- Engine Control System - 2.0L (L34 GMDAT) - Symptom Troubleshooting And Diagnosis
- Symptoms - Engine Controls
- Intermittent Conditions
- Hard Start
- Surges/Chuggles
- Lack of Power, Sluggishness, or Sponginess
- Detonation/Spark Knock
- Hesitation, Sag, Stumble
- Cuts Out, Misses
- Poor Fuel Economy
- Rough, Unstable, or Incorrect Idle and Stalling
- Dieseling, Run-On
- Backfire
- Malfunction Indicator Lamp (MIL) Inoperative
- Malfunction Indicator Lamp (MIL) Will Not Flash
- Malfunction Indicator Lamp (MIL) Always On
- Engine Cranks but Does Not Run (Non European Emissions)
- Engine Cranks but Does Not Run (European Emissions)
- Engine Control Module (ECM) Outputs Diagnosis
- Multiple Engine Control Module (ECM) Information Sensor DTCs Set (Non European Emissions)
- Multiple Engine Control Module (ECM) Information Sensor DTCs Set (European Emissions)
- Main Relay Circuit Diagnosis (Non European Emissions)
- Main Relay Circuit Diagnosis (European Emissions)
- Fuel System Diagnosis
- Fuel Pump Electrical Circuit Diagnosis
- Fuel Injector Coil Test
- Fuel Injector Circuit Diagnosis
- Fuel Injector Balance Test with Special Tool
- Fuel Tank Leak Test
- Alcohol/Contaminants-in-Fuel Diagnosis (w/o Special Tool)
- Manifold Absolute Pressure (MAP) Sensor Diagnosis
- Idle Air Control (IAC) System Diagnosis
- Electronic Ignition (EI) System Diagnosis
- Crankcase Ventilation System Inspection/Diagnosis
- Engine Control System - 2.0L (L34 GMDAT) Flash Codes DTC 049 To OBDII DTC P0140
- Engine Control System - 2.5L (LBK) - Description And Operation
- Description and Operation
- Engine Control Module (ECM) Description
- Engine Control Component Description
- Crankshaft Position (CKP) Sensor
- Camshaft Position (CMP) Sensor
- Idle Air System Operation
- Engine Coolant Temperature (ECT) Sensor
- Throttle Position (TP) Sensor
- Catalyst Monitor Oxygen Sensors
- Exhaust Gas Recirculation (EGR) Valve
- Intake Air Temperature (IAT) Sensor
- Manifold Absolute Pressure (MAP) Sensor
- Main Throttle Idle Actuator (MTIA)
- Fuel System Description
- Fuel System Overview
- Fuel Tank
- Fuel Fill Pipe
- Fuel Filler Cap
- Fuel Sender Assembly
- Fuel Level Sensor
- Fuel Pump
- Fuel Strainer - Typical
- Fuel Filter - Typical
- Fuel Feed and Return Pipes
- Nylon Fuel Pipes
- Quick-Connect Fittings
- Fuel Pipe O-Rings
- Fuel Rail Assembly
- Fuel Injectors
- Fuel Pressure Regulator Assembly - Typical
- Fuel Metering Modes of Operation
- Starting Mode
- Clear Flood Mode
- Run Mode
- Acceleration Mode
- Deceleration Mode
- Battery Voltage Correction Mode
- Fuel Cutoff Mode
- Fuel Trim
- Evaporative Emission (EVAP) Control System Description
- Electronic Ignition (EI) System Description
- Knock Sensor (KS) System Description
- Exhaust Gas Recirculation (EGR) System Description
- Crankcase Ventilation System Description
- Air Intake System Description
- Description and Operation
- Engine Control System - 2.5L (LBK) - Diagnostic Information And Procedures
- Engine Control System - 2.5L (LBK) - DTC P0030 To DTC P0154
- DTC P0030, P0036, P0050, or P0056
- DTC P0031, P0037, P0051, or P0057
- DTC P0032, P0038, P0052, or P0058
- DTC P0101
- DTC P0102
- DTC P0103
- DTC P0106
- DTC P0107
- DTC P0108
- DTC P0111
- DTC P0112
- DTC P0113
- DTC P0116
- DTC P0117
- DTC P0118
- DTC P0119
- DTC P0121
- DTC P0122
- DTC P0123
- DTC P0125
- DTC P0128
- DTC P0131 or P0151
- DTC P0132 or P0152
- DTC P0133 or P0153
- DTC P0134 or P0154
- Engine Control System - 2.5L (LBK) - DTC P0137 To DTC P0403
- DTC P0137 or P0157
- DTC P0138 or P0158
- DTC P0139 or P0159
- DTC P0140 or P0160
- DTC P0171 or P0174
- DTC P0172 or P0175
- DTC P0222
- DTC P0223
- DTC P0230
- DTC P0261, P0264, P0267, P0270, P0273, or P0276
- DTC P0262, P0265, P0268, P0271, P0274, or P0277
- DTC P0300
- DTC P0301-P0306
- DTC P0329
- DTC P0334
- DTC P0335
- DTC P0336
- DTC P0337
- DTC P0341
- DTC P0342
- DTC P0351-P0356
- DTC P0400
- DTC P0401
- DTC P0402
- DTC P0403
- Engine Control System - 2.5L (LBK) - DTC P0404 To DTC P0662
- Engine Control System - 2.5L (LBK) - DTC P0700 To DTC P2422
- Engine Control System - 2.5L (LBK) - ECM Connector End Views
- Engine Control System - 2.5L (LBK) - Engine Controls Connector End Views
- Engine Control System - 2.5L (LBK) - Repair Instructions
- Repair Instructions
- Engine Control Module (ECM) Replacement
- Idle Learn Procedure
- Engine Coolant Temperature (ECT) Sensor Replacement
- Intake Air Temperature (IAT) Sensor Replacement
- Manifold Absolute Pressure (MAP) Sensor Replacement
- Heated Oxygen Sensor (HO2S) Replacement Bank 1 Sensor 2
- Knock Sensor (KS) Replacement
- Throttle Body Assembly Replacement
- Throttle Body Service
- Fuel Pressure Relief Procedure
- Fuel Pressure Gage Installation and Removal
- Fuel Filter Replacement
- Fuel Tank Draining Procedure
- Fuel Sender Assembly Replacement
- Fuel Rail Assembly Replacement
- Fuel Pressure Regulator Replacement
- Evaporative Emission (EVAP) Canister Purge Solenoid Valve Replacement
- Ignition Coil(s) Replacement
- Spark Plug Inspection
- Spark Plug Replacement
- Crankshaft Position (CKP) Sensor Replacement
- Camshaft Position (CMP) Sensor Replacement
- Exhaust Gas Recirculation (EGR) Valve Replacement
- Exhaust Gas Recirculation (EGR) Valve Pipe Replacement (Intake)
- Exhaust Gas Recirculation (EGR) Valve Pipe Replacement (Exhaust)
- Intake Manifold Tuning (IMT) Valve Actuator Solenoid Replacement
- Intake Manifold Tuning (IMT) Valve Actuator Replacement
- Intake Manifold Tuning (IMT) Valve Vacuum Reservoir Replacement
- Air Cleaner Element Replacement
- Air Cleaner Assembly Replacement
- Repair Instructions
- Engine Control System - 2.5L (LBK) - Schematic And Routing Diagrams
- Engine Control System - 2.5L (LBK) - Special Tools And Equipment
- Engine Control System - 2.5L (LBK) - Specifications
- Engine Control System - 2.5L (LBK) - Symptom Troubleshooting And Diagnosis
- Symptoms - Engine Controls
- Intermittent Conditions
- Hard Start
- Surges/Chuggles
- Lack of Power, Sluggishness, or Sponginess
- Detonation/Spark Knock
- Hesitation, Sag, Stumble
- Cuts Out, Misses
- Poor Fuel Economy
- Rough, Unstable, or Incorrect Idle and Stalling
- Dieseling, Run-On
- Backfire
- Malfunction Indicator Lamp (MIL) Inoperative
- Malfunction Indicator Lamp (MIL) Always On
- Engine Cranks but Does Not Run
- Fuel System Diagnosis
- Fuel Pump Electrical Circuit Diagnosis
- Fuel Injector Coil Test
- Fuel Injector Balance Test with Special Tool
- Fuel Tank Leak Test
- Alcohol/Contaminants-in-Fuel Diagnosis (WO/Special Tool)
- Alcohol/Contaminants-in-Fuel Diagnosis (W/Special Tool)
- Crankcase Ventilation System Inspection/Diagnosis
- Intake Manifold Tuning (IMT) Valve Diagnosis
- Electronic Ignition (EI) System Diagnosis
- Engine Control System - 2.5L (LBK) Engine Controls Component Views
- Engine Control System - 2.0L (L34 GMDAT) - Description And Operation
- Emissions
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Hoist/Jack
- General Information
- Introduction
- Vehicle Identification
- VIN Derivative (Except North America)
- VIN Derivative (North America)
- Label - Vehicle Certification
- Engine ID and VIN Derivative Location (2.0L)
- Engine ID and VIN Derivative Location (2.5L)
- Transmission ID and VIN Derivative Location (Manual Transmission D20)
- Transmission ID and VIN Derivative Location (Automatic Transmission ZF 4HP 16)
- Label - Service Parts ID
- Fasteners
- Lifting and Jacking the Vehicle
- Diagnostic Information and Procedures
- Introduction
- General Information
- Identification
- Metric Conversions
- OEM General Information
- Cautions And Notices
- Introduction
- Definition of Caution, Notice, and Important
- ABS Component Handling Caution
- Approved Equipment for Collision Repair Caution
- Assistant Driving Caution
- Batteries Produce Explosive Gases Caution
- Battery Disconnect Caution
- Brake Dust Caution
- Brake Fluid Caution
- Brake Fluid Irritant Caution
- Breathing R-134a Caution
- Checking Hot Transmission Fluid through Drain Plug Hole Caution
- Clutch Dust Caution
- Compressed Valve Spring Caution
- Cracked Window Caution
- Damaged Fan Blade Caution
- Defroster Outlet Caution
- Electric Coolant Fan Caution
- Exhaust Gas Recirculation (EGR) Caution
- Exhaust Service Caution
- Eye Protection Caution
- Fuel and EVAP Pipe Caution
- Fuel Vapors in Evaporative Emission (EVAP) Components Caution
- Gasoline/Gasoline Vapors Caution
- Hood Hold-Open Device Caution
- Hot Exhaust System Caution
- Knock Sensor Service Caution
- Moving Parts and Hot Surfaces Caution
- Protective Goggles and Glove Caution
- Radiator Cap Removal Caution
- Relieving Fuel Pressure Caution
- Repair Material Curing Caution
- Replacement Carpet Caution
- Road Test Caution
- Safety Glasses Caution
- Safety Glasses and Compressed Air Caution
- Safety Goggles and Fuel Caution
- Seat Belt Replacement Caution
- Servicing the SIR System Caution
- SDM Voltage After Ignition Is Turned OFF Caution
- Sensing and Diagnostic Module Handling Caution
- SIR Seatbelt Pretensioner Handling Caution
- SIR Caution
- SRS Caution
- SRS Sensing and Diagnostic Module Handling Caution
- SRS Handling Caution
- SIR Inflatable Module Deployment Outside Vehicle Caution
- SIR Inflator Module Disposal Caution
- SIR Inflator Module Handling and Storage Caution
- SRS Inflator Module Handling and Storage Caution
- SIR Special Tool Caution
- SRS Special Tool Caution
- Suspension Spring Caution
- Vehicle Lifting Caution
- Work Stall Test Caution
- Adding Fluid to the Brake System Notice
- Air Cleaner Notice
- Air in the Power Steering System Notice
- Avoid Damage to Grid Lines Notice
- Belt Dressing Notice
- Brake Caliper Notice
- Brake Fluid Damage to Electrical Connections Notice
- Brake Fluid Effects on Paint and Electrical Components Notice
- Catalytic Converter Movement Notice
- Clutch Hydraulic System Lubricant Notice
- Defective Scan Tool Notice
- Drive Axle Notice
- Emission Modification Notice
- Engine Emission Notice
- Engine Lifting Notice
- Engine Mounting Notice
- Fastener Notice
- Filling the Master Cylinder Notice
- Flex Decoupler Notice
- Fuel Injector Balance Test Notice
- Fuel Pressure Notice
- Fuel Tank Strap Fastener Notice
- Handling ESD Sensitive Parts Notice
- Heated Oxygen and Oxygen Sensor Notice
- Heated Oxygen Sensor (HO2S) Wire Repair Notice
- Ignition OFF When Disconnecting Battery Notice
- Installing Hoses without Twists or Bends Notice
- Liftgate Assist Rod Notice
- Methanol Fuel Notice
- Nylon Fuel Lines Notice
- OBDII Symbol Description Notice
- Oxygen Sensor Notice
- Power Steering Hose Disconnected Notice
- Power Steering Required Fluid Notice
- Steering Column in Lock Position Notice
- Steering Gear Preload Adjustment Notice
- Steering Wheel in the Full Turn Position Notice
- Steering Wheel Straight and Column Locked Notice
- Transaxle Case Damage Notice
- Using Proper Power Steering Fluid Notice
- Vehicle Lifting and Jacking Notice
- Windshield Installation Notice
- Introduction
- General Information
- Introduction
- Vehicle Identification
- VIN Derivative (Except North America)
- VIN Derivative (North America)
- Label - Vehicle Certification
- Engine ID and VIN Derivative Location (2.0L)
- Engine ID and VIN Derivative Location (2.5L)
- Transmission ID and VIN Derivative Location (Manual Transmission D20)
- Transmission ID and VIN Derivative Location (Automatic Transmission ZF 4HP 16)
- Label - Service Parts ID
- Fasteners
- Lifting and Jacking the Vehicle
- Diagnostic Information and Procedures
- Introduction
- Vibration Symptoms Diagnosis And Correction
- Cautions And Notices
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- HVAC Control Systems
- HVAC Systems
- Specifications
- Diagnostic Information and Procedures
- Repair Instructions
- Compressor Shaft Seal Replacement
- Rear Head, Gasket, Valve Plate and O-Ring Replacement
- Cylinder to Front Head O-Ring Replacement
- Refrigerant Tubes Replacement
- Refrigerant Recovery and Recharging
- Compressor Replacement
- Compressor Control Valve Assembly Removal
- Compressor Control Valve Assembly Install
- Compressor Leak Testing
- Compressor Clutch Plate/Hub Assembly Replacement
- Clutch Rotor and/or Bearing Replacement
- Compressor Clutch Coil Replacement
- O-Ring Replacement
- Discharge Hose Replacement
- Suction Hose Replacement
- Compressor Relay Replacement
- Thermal Expansion Valve Replacement
- Air Conditioning (A/C) Refrigerant Pressure Sensor Replacement
- Condenser Replacement
- Accumulator Replacement
- HVAC Module Assembly Replacement
- Evaporator Core Replacement
- Heater Hose Assembly Replacement
- Passenger Compartment Air Filter Replacement
- Blower Motor Relay Replacement
- Blower Motor Resistor Replacement
- Blower Motor Replacement
- Deflector Replacement - Instrument Panel Air
- Heater Core Replacement
- Special Tools and Equipment
- HVAC Systems - Automatic
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic System Check - HVAC Systems - Automatic
- Diagnostic Trouble Code (DTC) List
- DTC 1
- DTC 2
- DTC 3
- DTC 4
- DTC 5
- DTC 6
- DTC 7
- HVAC Compressor Clutch Does Not Engage
- Blower Motor Inoperative
- Too Hot in Vehicle
- Too Cold in Vehicle
- Air Delivery Improper
- Air Recirculation Malfunction
- Control Head Inoperative
- Control Head Illumination/Display Does Not Operate Properly
- Motor Control Table
- Intake Control Table
- Repair Instructions
- HVAC Control Assembly Replacement
- Recirculation Actuator Replacement
- Mode Actuator Replacement
- Air Temperature Actuator Replacement
- Ambient Air Temperature Sensor Replacement
- Inside Air Temperature Sensor Replacement
- Sun Load Sensor Replacement
- Coolant Temperature Sensor Replacement
- Blower Control Module Replacement
- Description and Operation
- HVAC Systems - Manual
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Introduction
- Description and Operation
- HVAC Systems
- HVAC Control Systems
- Maintenance
- Procedures
- Maintenance And Lubrication
- Specifications
- Maintenance
- Maintenance Schedule (European Emissions)
- Normal Vehicle Use
- Footnotes
- 1 000 km (600 mi)
- 15 000 km (9,000 mi) or every 12 months, whichever comes first
- 30 000 km (18,000 mi) or every 24 months, whichever comes first
- 45 000 km (27,000 mi) or every 36 months, whichever comes first
- 60 000 km (36,000 mi) or every 48 months, whichever comes first
- 75 000 km (45,000 mi) or every 60 months, whichever comes first
- 90 000 km (54,000 mi) or every 72 months, whichever comes first
- 105 000 km (63,000 mi) or every 84 months, whichever comes first
- 120 000 km (72,000 mi) or every 96 months, whichever comes first
- Maintenance Schedule (North American Emissions)
- Notes
- Short Trip/City Definition
- Short Trip/City Intervals
- Long Trip/Highway Definition
- Long Trip/Highway Intervals
- Normal Vehicle Use
- Short Trip Footnotes
- 3,000 Miles (5 000 km)
- 6,000 Miles (10 000 km)
- 9,000 Miles (15 000 km)
- 12,000 Miles (20 000 km)
- 15,000 Miles (25 000 km)
- 18,000 Miles (30 000 km)
- 21,000 Miles (35 000 km)
- 24,000 Miles (40 000 km)
- 27,000 Miles (45 000 km)
- 30,000 Miles (50 000 km)
- 33,000 Miles (55 000 km)
- 36,000 Miles (60 000 km)
- 39,000 Miles (65 000 km)
- 42,000 Miles (70 000 km)
- 45,000 Miles (75 000 km)
- 48,000 Miles (80 000 km)
- 50,000 Miles (83 000 km)
- 51,000 Miles (85 000 km)
- 54,000 Miles (90 000 km)
- 57,000 Miles (95 000 km)
- 60,000 Miles (100 000 km)
- 63,000 Miles (105 000 km)
- 66,000 Miles (110 000 km)
- 69,000 Miles (115 000 km)
- 72,000 Miles (120 000 km)
- 75,000 Miles (125 000 km)
- 78,000 Miles (130 000 km)
- 81,000 Miles (135 000 km)
- 84,000 Miles (140 000 km)
- 87,000 Miles (145 000 km)
- 90,000 Miles (150 000 km)
- 93,000 Miles (155 000 km)
- 96,000 Miles (160 000 km)
- 99,000 Miles (165 000 km)
- 100,000 Miles (166 000 km)
- Long Trip Footnotes
- 7,500 Miles (12 500 km)
- 22,500 Miles (37 500 km)
- 37,500 Miles (62 500 km)
- 52,500 Miles (87 500 km)
- 67,500 Miles (112 500 km)
- 82,500 Miles (137 500 km)
- 97,500 Miles (162 500 km)
- Maintenance Schedule (not European or North American)
- Normal Vehicle Use
- Footnotes
- 1 000 km (600 mi)
- 10 000 km (6,000 mi) or every 6 months, whichever comes first
- 20 000 km (12,000 mi) or every 12 months, whichever comes first
- 30, 000 km (18,000 mi) or every 18 months, whichever comes first
- 40, 000 km (24,000 mi) or every 24 months, whichever comes first
- 50, 000 km (30,000 mi) or every 30 months, whichever comes first
- 60, 000 km (36,000 mi) or every 36 months, whichever comes first
- 70, 000 km (42,000 mi) or every 42 months, whichever comes first
- 80, 000 km (48,000 mi) or every 48 months, whichever comes first
- 90, 000 km (54,000 Mi) or every 54 months, whichever comes first
- 100, 000 km (60,000 mi) or every 60 months, whichever comes first
- Explanation of Scheduled Services
- Normal Vehicle Use
- Explanation of Scheduled Maintenance Services
- Drive Belt Inspection
- Engine Oil and Oil Filter Change
- Engine Oil Viscosity
- Cooling System Service
- Fuel Micro-Filter Replacement - North American Emissions
- Fuel Micro-Filter Replacement - European Emissions
- Fuel Micro-Filter Replacement - Non-European Emissions
- Air Cleaner Element Replacement - North American Emissions
- Air Cleaner Element Replacement - European Emissions
- Air Cleaner Element Replacement - Non European Emissions
- Throttle Body Mounting Bolt Torque
- Spark Plug Replacement
- Spark Plug Wire Replacement
- Brake System Service - European Emission
- Brake System Service - North American Emissions
- Brake System Service - Non European Emissions
- Transaxle Service
- Owner Checks and Services
- Maintenance Schedule (European Emissions)
- Maintenance And Lubrication
- Procedures
- Restraints
- Air Bag, SRS
- Supplemental Inflatable Restraint System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Code Index
- Diagnostic Starting Point - SIR
- Diagnostic System Check - SIR
- Diagnostic Trouble Code (DTC) List
- DTC 001
- DTC 002
- DTC 003
- DTC 004
- DTC 005
- DTC 006
- DTC 007
- DTC 008
- DTC 009
- DTC 010
- DTC 011
- DTC 012
- DTC 013
- DTC 014
- DTC 015
- DTC 016
- DTC 023
- DTC 024
- DTC 025
- DTC 031
- DTC 032
- DTC 033
- DTC 034
- DTC 035
- DTC 038
- DTC 052
- DTC 053
- DTC 054
- DTC 055
- DTC 056
- DTC 057
- DTC 058
- DTC 059
- DTC 080
- DTC 081
- DTC 082
- DTC 083
- DTC 084
- DTC 085
- DTC 086
- DTC 087
- DTC B1101
- DTC B1102
- DTC B1103
- DTC B1104
- DTC B1326
- DTC B1327
- DTC B1328
- DTC B1329
- DTC B1330
- DTC B1331
- DTC B1332
- DTC B1333
- DTC B1334
- DTC B1335
- DTC B1346
- DTC B1347
- DTC B1348
- DTC B1349
- DTC B1352
- DTC B1353
- DTC B1354
- DTC B1355
- DTC B1361
- DTC B1362
- DTC B1363
- DTC B1364
- DTC B1367
- DTC B1368
- DTC B1369
- DTC B1370
- DTC B1378
- DTC B1379
- DTC B1380
- DTC B1381
- DTC B1382
- DTC B1383
- DTC B1384
- DTC B1385
- DTC B1395
- DTC B1400
- DTC B1401
- DTC B1402
- DTC B1403
- DTC B1404
- DTC B1405
- DTC B1409
- DTC B1410
- DTC B1414
- DTC B1415
- DTC B1440
- DTC B1446
- DTC B1447
- DTC B1448
- DTC B1449
- DTC B1450
- DTC B1481
- DTC B1482
- DTC B1483
- DTC B1484
- DTC B1485
- DTC B1486
- DTC B1487
- DTC B1488
- DTC B1620
- DTC B1650
- DTC B1651
- DTC B1652
- DTC B1657
- DTC B1670
- DTC B2500
- DTC B2502
- SDM Integrity Check
- Symptoms - SIR
- Air Bag Indicator Always On
- Air Bag Indicator Does Not Come ON
- SIR Disabling and Enabling Zones
- Repair Instructions
- SIR Service Precautions
- Disabling the SIR System
- SIR Disabling and Enabling Zone 2
- SIR Disabling and Enabling Zone 3
- SIR Disabling and Enabling Zone 5
- SIR Disabling and Enabling Zone 6
- SIR Disabling and Enabling Zone 7
- SIR Disabling and Enabling Zone 8
- SIR Disabling and Enabling Zone 9
- Enabling the SIR System
- Inflatable Restraint Side Impact Sensor Replacement
- Inflatable Restraint Sensing and Diagnostic Module Replacement
- Inflatable Restraint Steering Wheel Module Replacement
- Inflatable Restraint Steering Wheel Module Coil Replacement
- Inflatable Restraint Instrument Panel Module Replacement
- Repairs and Inspections Required After a Collision
- Inflator Module Handling and Scrapping
- Description and Operation
- Supplemental Inflatable Restraint System
- Restraints Control Systems
- Seat Belt System
- Seat Belts
- Seat Belt System
- Air Bag, SRS
- Steering
- Electronic Steering
- Variable Effort Steering System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Code Index
- Diagnostic Starting Point - Variable Effort Steering
- Diagnostic System Check - Variable Effort Steering
- Scan Tool Data List
- Scan Tool Data Definitions
- Diagnostic Trouble Code (DTC) List
- DTC C1104
- DTC C1105
- DTC C1212
- DTC C1604
- DTC C2203
- Symptoms - Variable Effort Steering
- SSPS Warning Lamp Always On
- SSPS Warning Lamp Inoperative
- Variable Effort Steering Operating with Full Assist at all Times
- Variable Effort Steering Operating with Decreased Assist at all Times
- Repair Instructions
- Description and Operation
- Variable Effort Steering System
- Manual Steering
- Power Steering System
- Specifications
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Power Steering System
- Symptoms - Power Steering System
- Power Steering System Test Procedure
- Power Steering Fluid Leaks
- Rattle in Rack and Pinion Steering Gear
- Objectionable Hiss in the Power Steering System
- Rattle or Chuckle Noise in Steering Gear
- Groan Noise in Steering Pump
- Steering Vibrates During Low Speed or Static Steering
- Power Rack and Pinion Steering Gear Bench Testing
- Hard Steering
- Wander or Poor Steering Stability
- Erratic Steering When Braking
- Foaming, Milky-Appearing Power Steering Fluid
- Increase in Effort While Turning Steering Wheel
- Poor Return of Steering Wheel
- Steering Wheel Surges/Jerks While Turning
- Steering Wheel Kickback
- Steering Effort Hard in One or Both Directions
- Too Much Play in Steering
- Repair Instructions
- Power Steering Pump Hoses and Pipes Replacement
- Steering Gear Cylinder Pipe Assemblies/O-Ring Seals Replacement - On Vehicle
- Bleeding the Power Steering System
- Checking and Adding Power Steering Fluid
- Power Steering Fluid Reservoir Replacement
- Power Steering Pulley Replacement
- Power Steering Pump Replacement
- Power Steering Pump Drive Belt Replacement (2.0L)
- Power Steering Pump Drive Belt Replacement (2.5L)
- Rack and Pinion Outer Tie Rod End Replacement
- Rack and Pinion Boot Replacement
- Power Steering Reservoir Outlet Pipe/Hose Replacement
- Power Steering Gear Replacement
- Rack and Pinion Gear Rack Bearing Preload Adjustment - Off Vehicle
- Rack and Pinion Steering Gear Overhaul
- Description and Operation
- Special Tools and Equipment
- Power Steering System
- Power Steering System
- Specifications
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Power Steering System
- Symptoms - Power Steering System
- Power Steering System Test Procedure
- Power Steering Fluid Leaks
- Rattle in Rack and Pinion Steering Gear
- Objectionable Hiss in the Power Steering System
- Rattle or Chuckle Noise in Steering Gear
- Groan Noise in Steering Pump
- Steering Vibrates During Low Speed or Static Steering
- Power Rack and Pinion Steering Gear Bench Testing
- Hard Steering
- Wander or Poor Steering Stability
- Erratic Steering When Braking
- Foaming, Milky-Appearing Power Steering Fluid
- Increase in Effort While Turning Steering Wheel
- Poor Return of Steering Wheel
- Steering Wheel Surges/Jerks While Turning
- Steering Wheel Kickback
- Steering Effort Hard in One or Both Directions
- Too Much Play in Steering
- Repair Instructions
- Power Steering Pump Hoses and Pipes Replacement
- Steering Gear Cylinder Pipe Assemblies/O-Ring Seals Replacement - On Vehicle
- Bleeding the Power Steering System
- Checking and Adding Power Steering Fluid
- Power Steering Fluid Reservoir Replacement
- Power Steering Pulley Replacement
- Power Steering Pump Replacement
- Power Steering Pump Drive Belt Replacement (2.0L)
- Power Steering Pump Drive Belt Replacement (2.5L)
- Rack and Pinion Outer Tie Rod End Replacement
- Rack and Pinion Boot Replacement
- Power Steering Reservoir Outlet Pipe/Hose Replacement
- Power Steering Gear Replacement
- Rack and Pinion Gear Rack Bearing Preload Adjustment - Off Vehicle
- Rack and Pinion Steering Gear Overhaul
- Description and Operation
- Special Tools and Equipment
- Steering Wheel & Steering Column
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Steering Column
- Symptoms - Steering Wheel and Column
- Loose Steering Wheel
- Noise When Lifting the Column
- Turn Signal Switch Does Not Stay in Turn Position
- Turn Signal Switch Does Not Cancel
- Turn Signal Switch Difficult to Operate
- Turn Signal Does Not Indicate Lane Change
- Ignition Switch Electrical System Does Not Operate
- Ignition Switch Does Not Turn
- High Steering Shaft Effort
- Lock System Does Not Unlock
- Lock System Does Not Lock
- Key Cannot Be Removed in the Off Lock Position
- High Lock Effort
- Noise in Steering Column
- Looseness in Steering Column
- Repair Instructions
- Description and Operation
- Special Tools and Equipment
- Manual Steering Gear
- Electronic Steering
- Suspension
- Front Suspension
- Front Suspension
- Specifications
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Control Arm Bushing Replacement
- Strut, Strut Component and/or Spring Replacement
- Front Suspension Support Brace Replacement
- Crossmember Replacement - Front Suspension
- Stabilizer Shaft Replacement
- Stabilizer Shaft Link Replacement
- I-Beam Suspension Replacement
- Lower Ball Joint Replacement
- Steering Knuckle Replacement
- Control Arm Replacement
- Strut Assembly Replacement
- Description and Operation
- Special Tools and Equipment
- Suspension General Diagnosis
- Specifications
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Suspension General Diagnosis
- Symptoms - Suspension General Diagnosis
- Ride Diagnosis - Too Soft
- Ride Diagnosis - Too Hard
- Vehicle Leads/Pulls
- Body Leans or Sways in Corners
- Suspension Bottoms
- Torque Steer
- Noise Diagnosis - Front Suspension
- Wheel Bearings Diagnosis
- Low or Uneven Trim Height
- Trim Height Inspection Procedure
- Front Suspension
- Rear Suspension
- Rear Suspension
- Specifications
- Visual Identification
- Diagnostic Information and Procedures
- Repair Instructions
- Crossmember Replacement
- Wheel Bearing/Hub Replacement - Rear
- Knuckle Replacement
- Rear Axle Upper Control Arm Replacement
- Stabilizer Shaft Replacement
- Stabilizer Shaft Link Replacement
- Shock Absorber Replacement
- Trailing Arm Replacement
- Strut Assembly Replacement
- Lateral Link Replacement (Front)
- Lateral Link Replacement (Rear)
- Description and Operation
- Special Tools and Equipment
- Suspension General Diagnosis
- Specifications
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Suspension General Diagnosis
- Symptoms - Suspension General Diagnosis
- Ride Diagnosis - Too Soft
- Ride Diagnosis - Too Hard
- Vehicle Leads/Pulls
- Body Leans or Sways in Corners
- Suspension Bottoms
- Torque Steer
- Noise Diagnosis - Front Suspension
- Wheel Bearings Diagnosis
- Low or Uneven Trim Height
- Trim Height Inspection Procedure
- Rear Suspension
- Wheel Alignment
- Wheels & Tire System
- Front Suspension
- Transmission
- Automatic Trans
- Automatic Transmission - ZF 4HP 16 - Automatic Transmission Internal Wiring Harness Check
- Automatic Transmission - ZF 4HP 16 - Component Locator
- Automatic Transmission - ZF 4HP 16 - Description And Operation
- Description and Operation
- Park or Neutral - Engine Running
- Drive Range, First Gear
- Drive Range, Second Gear
- Drive Range, Third Gear
- Drive Range - Third Gear, Emergency/Substitute Mode
- Drive Range - Fourth Gear, Emergency/Substitute Mode
- Drive Range - Fourth Gear
- Reverse
- Transmission Identification Information
- Transmission General Description
- Mechanical Component Description
- Electronic Component Description
- Selector Lever/Program Switch
- Park/Neutral Position Switch
- Automatic Transaxle Output Speed Sensor (A/T OSS)
- Automatic Transaxle Input Speed Sensor (A/T ISS)
- Shift Solenoid Valve: Solenoid 1,2
- Pressure Control Solenoid Valve (PCS VALVE 3,4,5,6)
- Transaxle Fluid Temperature (TFT) Sensor
- Transaxle Electrical Connector
- Transaxle Control Module (TCM)
- Data Link Connector (DLC)
- TCM Inputs That Affect The 4HP 16 Transaxle
- TCM Initialization
- Throttle Position Sensor
- Automatic Transaxle Output (Shaft) Speed Sensor
- Automatic Transaxle Input (Shaft) Speed Sensor
- Engine Coolant Temperature Sensor
- Engine Speed
- Stop Lamp Switch
- Transmission Adaptive Functions
- Clearing Transmission Adaptive Pressure (TAP)
- Description and Operation
- Automatic Transmission - ZF 4HP 16 - Diagnostic Information And Procedures
- Automatic Transmission - ZF 4HP 16 - DTC P0218 To DTC P0722
- DTC P0218
- DTC P0562 (Non Europe or N American Emissions)
- DTC P0562 (European and N American Emission)
- DTC P0563 (Non Europe or N American Emissions)
- DTC P0563 (European and N American Emissions)
- DTC P0601 (Non Europe or N American Emissions)
- DTC P0601 (European and N American Emissions)
- DTC P0603 (Non Europe or N American Emissions)
- DTC P0603 (European and N American Emissions)
- DTC P0606 (Non Europe or N American Emissions)
- DTC P0606 (Europe and N American Emissions)
- DTC P0604 (Non Europe or N American Emissions)
- DTC P0604 (European and N American Emissions)
- DTC P0703
- DTC P0705 (Non Europe or N American Emissions)
- DTC P0705 (European and N American Emissions)
- DTC P0706
- DTC P0710
- DTC P0711
- DTC P0715
- DTC P0716 (European and N American Emissions)
- DTC P0716 (Non Europe or N American Emissions)
- DTC P0717
- DTC P0720
- DTC P0722
- Automatic Transmission - ZF 4HP 16 - DTC P0721 To DTC P1606
- DTC P0721 (European and N American Emissions)
- DTC P0721 (Non Europe or N American Emissions)
- DTC P0725 (Europe Emissions)
- DTC P0725 (N American Emissions)
- DTC P0726 (Non Eurpoean or N Amer Emissions)
- DTC P0726 (Eurpoean and North American Emissions)
- DTC P0727
- DTC P0731 (Non-Europe Emissions)
- DTC P0731 (European Emissions)
- DTC P0732 (Non Europe Emissions)
- DTC P0732 (European Emissions)
- DTC P0733 (European Emissions)
- DTC P0733 (Non European Emissions)
- DTC P0734 (European Emissions)
- DTC P0734 (Non European Emissions)
- DTC P0741
- DTC P0742
- DTC P0781 (Non Europe or N American Emissions)
- DTC P0781 (European and N America Emissions)
- DTC P0782 (Non Europe or N American Emissions)
- DTC P0782 (European and N American Emissions)
- DTC P0783 (Non Europe or N American Emissions)
- DTC P0783 (European and N American Emissions)
- DTC P1604
- DTC P1606 (Europe and N American Emissions)
- Automatic Transmission - ZF 4HP 16 - DTC P1606 To DTC P1861
- DTC P1606 (Non European or N American Emissions)
- DTC P1671
- DTC P1672
- DTC P1673
- DTC P1779 (Non Europe or N American Emissions)
- DTC P1779 (North American Emissions)
- DTC P1780
- DTC P1791 (Non Europe or N American Emissions)
- DTC P1791 (North American Emissions)
- DTC P1839 (Non Europe or N American Emissions)
- DTC P1839 (European and N American Emissions)
- DTC P1840 (Non Europe or N American Emissions)
- DTC P1840 (European and N American Emissions)
- DTC P1841 (Non Europe or N American Emissions)
- DTC P1841 (European and N American Emissions)
- DTC P1850
- DTC P1851
- DTC P1852
- DTC P1853 (European and N American Emissions)
- DTC P1853 (Non Europe or N American Emissions)
- DTC P1854 (European and N American Emissions)
- DTC P1854 (Non Europe or N American Emissions)
- DTC P1855 (European and N American Emissions)
- DTC P1855 (Non Europe or N American Emissions)
- DTC P1861 (European and N American Emissions)
- Automatic Transmission - ZF 4HP 16 - DTC P1861 To DTC P1884
- DTC P1861 (Non European or N American Emissions)
- DTC P1862 (European and N American Emissions)
- DTC P1862 (Non European or N American Emissions)
- DTC P1863 (European and N American Emissions)
- DTC P1864 (European and N American Emissions)
- DTC P1864 (Non European or N American Emissions)
- DTC P1865 (European and N American Emissions)
- DTC P1865 (Non European or N American Emissions)
- DTC P1866 (European and N American Emissions)
- DTC P1866 (Non European or N American Emissions)
- DTC P1867 (Non European or N American Emissions)
- DTC P1867 (European and N American Emissions)
- DTC P1868 (Non European or N American Emissions)
- DTC P1868 (Eurpoean and N American Emissions)
- DTC P1869 (Non European or N American Emissions)
- DTC P1869 (European and N American Emissions)
- DTC P1871 (Non European or N American Emissions)
- DTC P1871 (European and N American Emission)
- DTC P1874 (Non European or N American Emissions)
- DTC P1874 (European and N American Emission)
- DTC P1881 (European and N American Emissions)
- DTC P1881 (Non European or N American Emissions)
- DTC P1883 (European and N American Emissions)
- DTC P1883 (Non European or N American Emissions)
- DTC P1884 (European and N American Emissions)
- Automatic Transmission - ZF 4HP 16 - DTC P1884 To DTC P1886
- Automatic Transmission - ZF 4HP 16 - Repair Instructions
- Repair Instructions
- Transmission Holding Fixture Assemble
- Automatic Transmission Range Selector Cable Replacement
- Automatic Transmission Range Selector Cable Adjustment
- Park/Neutral Position Switch Replacement
- Transmission Fluid Level Inspection
- Draining Transmission Fluid
- Shift Mechanism Removal
- Shift Mechanism Installation
- Parking Lock Removal
- Parking Lock Installation
- Bearing Plate Assembly Removal
- Bearing Plate Assembly Installation
- Differential/Side Shaft Outer Race, Bearing Shim Removal
- Differential/Side Shaft Outer Race, Bearing Shim Installation
- Transmission Fluid Cooler Hose/Pipe Replacement
- Gearshift Control Lever Replacement
- Transmission Control Module (TCM) Replacement
- Drive Axle Shaft Seal Replacement
- Oil Pan and Gasket Removal
- Oil Pan and Gasket Installation
- Control Valve Body Replacement
- Transmission Mount Bracket Replacement (2.0L DOHC)
- Transmission Mount Bracket Replacement (2.5L DOHC)
- Transmission Replacement (2.0L DOHC)
- Transmission Replacement (2.5L DOHC)
- Torque Converter Assembly Removal
- Converter Housing Removal
- Oil Pump Disassemble
- Oil Pump Assemble
- Differential Assembly Disassemble
- Differential Assembly Assemble
- Converter Housing Installation
- Control Valve Body Disassemble
- Control Valve Body Assemble
- Rear Cover Replacement
- Clutch B/E Disassemble
- Clutch B/E Measurement Procedure
- Clutch B/E Assemble
- Planetary Gear Set Disassemble
- Planetary Gear Set Assemble
- Brake C/D Disassemble
- Brake C/D Assemble
- Side Shaft Removal
- Side Shaft Installation
- Brake F, Slotted Nut Removal
- Brake F, Slotted Nut Installation
- Torque Converter End Play Inspection
- Torque Converter Installation
- Repair Instructions
- Automatic Transmission - ZF 4HP 16 - Schematic And Routing Diagrams
- Automatic Transmission - ZF 4HP 16 - Special Tools And Equipment
- Automatic Transmission - ZF 4HP 16 - Specifications
- Automatic Transmission - ZF 4HP 16 - Symptom Troubleshooting And Diagnosis
- Symptoms - Automatic Transmission
- Line Pressure Check Procedure
- Road Test Procedure
- Functional Test Procedure
- Torque Converter Diagnosis Procedure
- Clutch Plate Diagnosis
- Fluid Leak Diagnosis
- Case Porosity Repair
- Automatic Transmission Oil Cooler Flushing and Flow Test
- Automatic Transmission Fluid Leaks
- Harsh Garage Shift
- Torque Converter Clutch (TCC) Shudder
- TCM Inputs that Affect the 4HP16 Transaxle
- Shift Interlock System
- Clutch System
- Specifications
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Clutch Pedal Replacement
- Clutch Master Cylinder Replacement
- Clutch Master Cylinder Assembly Overhaul
- Hydraulic Clutch Bleeding
- Clutch Pedal Free Travel Adjustment
- Clutch Pedal Position Switch Replacement
- Hydraulic Clutch Release Point Adjustment
- Clutch Assembly Replacement
- Clutch Release Cylinder Assembly
- Clutch Release Assembly Overhaul
- Description and Operation
- Special Tools and Equipment
- Hydraulic Diagrams
- Automatic Transmission - ZF 4HP 16 - Description And Operation
- Description and Operation
- Park or Neutral - Engine Running
- Drive Range, First Gear
- Drive Range, Second Gear
- Drive Range, Third Gear
- Drive Range - Third Gear, Emergency/Substitute Mode
- Drive Range - Fourth Gear, Emergency/Substitute Mode
- Drive Range - Fourth Gear
- Reverse
- Transmission Identification Information
- Transmission General Description
- Mechanical Component Description
- Electronic Component Description
- Selector Lever/Program Switch
- Park/Neutral Position Switch
- Automatic Transaxle Output Speed Sensor (A/T OSS)
- Automatic Transaxle Input Speed Sensor (A/T ISS)
- Shift Solenoid Valve: Solenoid 1,2
- Pressure Control Solenoid Valve (PCS VALVE 3,4,5,6)
- Transaxle Fluid Temperature (TFT) Sensor
- Transaxle Electrical Connector
- Transaxle Control Module (TCM)
- Data Link Connector (DLC)
- TCM Inputs That Affect The 4HP 16 Transaxle
- TCM Initialization
- Throttle Position Sensor
- Automatic Transaxle Output (Shaft) Speed Sensor
- Automatic Transaxle Input (Shaft) Speed Sensor
- Engine Coolant Temperature Sensor
- Engine Speed
- Stop Lamp Switch
- Transmission Adaptive Functions
- Clearing Transmission Adaptive Pressure (TAP)
- Description and Operation
- Automatic Transmission - ZF 4HP 16 - Description And Operation
- Manual Transmission - D20
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Transmission Fluid Level Inspection
- Shift Linkage Adjustment
- Shift Rod Replacement
- Gearshift Tube, Boot, Bushing and/or Bearing Ring Replacement
- Gearshift Control Lever Replacement
- Speedometer Driven Gear Replacement
- Shift Control Linkage Replacement
- Shift Lever Cover Replacement
- Drive Axle Seal Replacement
- Transmission Replacement
- Transmission Disassemble
- Input Shaft Disassemble
- Input Shaft Assemble
- Mainshaft Disassemble
- Mainshaft Assemble
- Transaxle Case Disassemble
- Transaxle Case Assembly
- Differential Case Disassemble
- Differential Case Assemble
- Transmission Assemble
- Description and Operation
- Special Tools and Equipment
- Automatic Trans