Technical Service Bulletins
- A/C Compressor
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Ac Blows Warm Or Poor Performance (PIT5099H)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
- Information on GM ACR2000 (J-43600) and New Refrigerant Recovery Recharging Equipment Standard SAE J2788 (07-01-38-004)
- New PAG Oil Released (02-01-39-004B)
- Serpentine Drive Belt Assembly Squeals at Higher RPM and May Emit an Odor (Replace Serpentine Drive Belt Assembly) (05-06-01-009)
- Contaminated R-134a A/C Systems - Air Conditioning System Flushing Procedures and Universal In-Line A/C Filter Installation (83-12-21)
- J-43600 ACR 2000 Essential Refrigerant Recovery/Recharge Equipment (99-01-38-006B)
- Accessories & Equipment
- Concerns Or Questions Regarding Installation Of Dealer Installed Accessories (PIT3099U)
- General Motors Dealership Critical Equipment Requirements And Recommendations (05-00-89-029F)
- Information On Module Harvesting (22-NA-205)
- Requesting A New Key Code For Customer With Lost Or Stolen Keys (12-00-89-002E)
- Information - Non-Gm Parts And Accessories (Aftermarket) (04-06-04-054D)
- New Labor Operation Codes for Dealer-Installed GM Accessories Replaced During Warranty Coverage Period (02-20-89-014)
- Announcement of Price Increase for MDI (EL-47955) (08-00-89-018A)
- Processing GM Accessories - Initial Quality Issues (04-00-89-018C)
- Accessories Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Communication With ONSTAR Module After CANADIAN Cellular Upgrade (15-08-73-001A)
- Diagnostic Tip: Unable To Connect To ONSTAR Or Connects Failed To Voice (PIT5389F)
- Requirements For ONSTAR Over The Air Programming And Updates (PIC6107A)
- Incorrect Odometer Reading After BCM Replacement (PIC3843E)
- ONSTAR- Unwanted Or Phantom Phone Calls (PIC3278G)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- Caller Id Unavailable After ONSTAR Upgrade (PIT5464)
- Various Electrical Concerns (15-08-45-001)
- Unable To Receive Incoming ONSTAR Or HFC (Hands Free Calling) Calls (PIC6101)
- Diagnostic Tip: Unable To Connect Or Use Hands Free Calling Or No Data On The Call (Failed To Voice) (PIC4310L)
- Diagnostic Tip: CANADIAN ONSTAR Subscriber Unable To Receive Turn-By-Turn Directions While Traveling In The United States (PIT5264C)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Servicing and Required Return of Complete Body Control Module (BCM) with Integrated Electrical Centers (05-08-47-001A)
- Required Return Criteria of Complete Electrical Center (EC) and Body Control Module (BCM) with Integrated Electrical Center to Warranty Parts Center (WPC) (05-08-45-002E)
- GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
- Programming OnStar(R) Module for Canadian French Voice Recognition (OnStar(R) Generation 5 or Generation 6) (02-08-46-010G)
- Revised Remote Control Door Lock Receiver Replacement (Sedan) (05-08-52-004)
- Malfunction Indicator Lamp (MIL) On, Transmission Stuck in Second or Third Gear, Instrument Cluster Inoperative (Verify and Repair Source of Voltage Loss In Transmission Solenoid Power Supply Circuit) (01-07-30-002E)
- Addition of Instrument Cluster Bulb Replacement Procedure (05-08-49-023)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Driver Information Center (DIC) Messages Missing (Reprogram BCM) (05-08-49-011A)
- Information On False DTC B0595 Set In History (05-09-41-006)
- Cruise Control Operation - Increasing Set Speed (04-08-68-002)
- Accessory Drive Belts
- Aerodynamic Devices
- Air Bag, SRS
- General Motors Position Statement on Installation of Used, Salvaged, or Imitation Air Bag System Components (08-09-41-003)
- New SIR System Disabling and Enabling Procedure (05-09-41-010)
- Driver Information Center (DIC) Messages Missing (Reprogram BCM) (05-08-49-011A)
- Information On False DTC B0595 Set In History (05-09-41-006)
- Anti-Lock Brakes
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Various Electrical Concerns (15-08-45-001)
- GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
- Anti-Theft Systems
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (U.S. Only) (10-00-89-009F)
- Requesting A New Key Code For Customer With Lost Or Stolen Keys (12-00-89-002E)
- Information On Poor, Limited, Reduced Remote Keyless Entry (RKE) Or Remote Vehicle Start (RVS) Range (PI1018A)
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (CANADA Only) (10-00-89-010C)
- Key Code Information (99-00-89-011E)
- Diagnostic Information for Inoperative Remote Vehicle Start (08-08-52-002)
- Remote Keyless Entry Operational Characteristics (99-08-52-005C)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Revised Remote Control Door Lock Receiver Replacement (Sedan) (05-08-52-004)
- Door Latch Freezing In Cold Temperatures (05-08-64-002B)
- Automatic Trans
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Ethylene Glycol In Transmission Fluid (08-07-30-035I)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Driveline Clunk Noise (99-04-20-002O)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Information On Automatic Transmission Oil Cooler Flush And Flow Test (17-NA-066)
- Diagnostic Tip On Avoiding Torque Converter Or Crankshaft Damage While Diagnosing Noise Concerns (PIP5640A)
- Information On Shifter Sticking And/Or Difficulty Selecting Desired Gear (19-NA-134)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Prior To Any Circuit Testing (PIP5094A)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Automatic Transmission Oil Cooler Flow Test Essential Tool J-45096 TRANSFLOW® (03-07-30-002B)
- Dealer Reimbursement Procedures For CAC Tier 1 And Tier 2 Empowerment Tools: Diagnostic Fee, Short Term Rental, And Up-Front Towing (U.S. Only) (15-00-89-003)
- Vibration Analysis Worksheet (03-00-91-001I)
- Information On Normal Maintenance Or Warranty Service For 4T40, 4T45, 4T65, 4L60 Automatic Transmission Oil Pan Magnet Upgrade (08-07-30-040C)
- Release Of DEXRON®-VI Automatic Transmission Fluid (ATF) (04-07-30-037E)
- Warranty Administration- Change in Automatic Transmission Add Condition Documentation and Claim Submission (09-07-30-018A)
- Current Model Year Goodwrench Transmission Replacement Assembly Program (00-07-30-009D)
- GM Training - June 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-026)
- Information on 4T65-E MN7, M15, M76, MN3 Automatic Transmission Case, Cooler Fitting and Torque Converter Drain Back Check Ball Change (04-07-30-017B)
- Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032E)
- No Reverse, Second Gear or Fourth Gear (Replace Reaction Sun Shell with More Robust Heat Treated Parts) (00-07-30-022D)
- No Movement When Transmission is Shifted to Drive or Third - Normal Operation When Shifted to Second, First or Reverse (Replace Forward Sprag Assembly) (08-07-30-027)
- Diagnostic Information on Diagnostic Trouble Code (DTC) P0894 and P1870 (08-07-30-008B)
- Automatic Transmission/Transaxle Torque Converter Replacement (01-07-30-010C)
- Grinding and/or Growling Noise in Park on Incline (99-07-30-030F)
- Information On 4T40-E (MN4) and 4T45-E (MN5) Front Wheel Drive Automatic Transmission Valve Body Reconditioning, DTC P0741, P0742, P0751, P0752, P0756, P0757, P1811, Harsh Shifts, Slips, No Drive, No Reverse (07-07-30-025)
- 4L60-E/4L65-E/4L70-E Automatic Transmission Product Update (07-07-30-008)
- Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
- Information Regarding Automatic Transmission Shift Lock Control Function (03-07-30-043A)
- Instructions To Be Followed To Aid in Obtaining Root Cause Analysis on Both OEM and Goodwrench(R) Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
- 4L60-E / 4L65-E / 4L70-E Automatic Transmission Product Update (05-07-30-028A)
- Transmission Fluid Leak Diagnosis (01-07-30-041B)
- Revised Essential Tool J 35944-200-A Adapter For 9.525 mm (0.375 in) Automatic Transmission Oil Cooler Lines (05-07-30-009A)
- Auxiliary Emission Control Systems
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Difficulty Filling Fuel Tank, MIL/SES Light Illuminated DTC P0446 - Evaporative Emissions (EVAP) Vent System Performance (Inspect/Clean EVAP Canister Vent Valve Solenoid and Install Screen) (07-06-04-023A)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- I/M Readiness as Part of Emission Inspection and Maintenance Program for OBD II Vehicles (00-06-04-033B)
- New Add Time For Labor Operation L2300 - Converter, Oxidation Catalytic-Replace (02-00-89-006C)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- Axle Shafts
- Body Electrical
- J-35616-64B Or El-35616-58 Terminal Test Probe Information/Repair (PIT5074R)
- Information For Electrical Ground Repair - Use New Replacement Fasteners With Conductive Finish (10-08-45-001F)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Information on Importance of Using GM-Approved Terminal Probe Test Kit (J 35616) to Diagnose Electrical Concerns (07-00-89-060)
- Instrument Panel (I/P), Body and General Wiring Harness Repair (06-08-45-004)
- Body Interior
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Servicing and Required Return of Complete Body Control Module (BCM) with Integrated Electrical Centers (05-08-47-001A)
- Required Return Criteria of Complete Electrical Center (EC) and Body Control Module (BCM) with Integrated Electrical Center to Warranty Parts Center (WPC) (05-08-45-002E)
- Information on Body Control Module (BCM) Functionality Across Vehicle Lines (09-08-47-002)
- OnStar® Labor Operation Codes (05-08-46-005C)
- Revised Remote Control Door Lock Receiver Replacement (Sedan) (05-08-52-004)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Information On False DTC B0595 Set In History (05-09-41-006)
- Brakes Control Systems
- Charging Systems
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- Battery and Charging System Electrical Diagnostics (99-06-03-012)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Serpentine Drive Belt Assembly Squeals at Higher RPM and May Emit an Odor (Replace Serpentine Drive Belt Assembly) (05-06-01-009)
- Collision/Avoidance
- Communication Devices
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Information On Communication With ONSTAR Module After CANADIAN Cellular Upgrade (15-08-73-001A)
- Diagnostic Tip: Unable To Connect To ONSTAR Or Connects Failed To Voice (PIT5389F)
- Requirements For ONSTAR Over The Air Programming And Updates (PIC6107A)
- Diagnostic Tips: XM Audio Traffic And Travel Link Availability And Operation (PIT5353C)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- ONSTAR Will Not Power Up (PIC5491K)
- Normal Characteristic - ONSTAR Power Consumption (PIC4935F)
- Diagnostic Tip - ONSTAR Turn By Turn /TBT Feature Inoperative (PIC4801H)
- ONSTAR- Unwanted Or Phantom Phone Calls (PIC3278G)
- Programming And Activation Of Replacement ONSTAR Modules (VCIM) (PIC5588C)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- No Connect With Disabled Vehicle Or Dropped Calls With 1234567890 Min (PIC5050A)
- 118 Error When Attempting To Configure ONSTAR, Use TBT, Or Other Data Services After 15-08-44-001 Upgrade (PIT5484A)
- Behavior Of Non-Upgraded ONSTAR® Equipped Vehicles Operating In CANADA After Decommissioning Of 2G CDMA Cellular Networks (16-NA-025)
- ONSTAR® Voice Fallback Number Update (15-NA-079)
- Diagnostic Tip: BLUETOOTH Connectivity Issues After Software Update (PIT5468)
- Caller Id Unavailable After ONSTAR Upgrade (PIT5464)
- Various Electrical Concerns (15-08-45-001)
- Unable To Receive Incoming ONSTAR Or HFC (Hands Free Calling) Calls (PIC6101)
- Diagnostic Tip: Unable To Connect Or Use Hands Free Calling Or No Data On The Call (Failed To Voice) (PIC4310L)
- Information On Upgrading Certain ONSTAR® Analog/Digital-Ready Systems To ONSTAR® Generation 6 Digital-Capable System (05-48-46-006G)
- Diagnostic Tip: CANADIAN ONSTAR Subscriber Unable To Receive Turn-By-Turn Directions While Traveling In The United States (PIT5264C)
- UPFITTER Bulletin - Info - Radio Telephone/Mobile Radio (Transceiver) Installation And Troubleshooting Guidelines (UI 119)
- Information On Requests To Add ONSTAR BLUETOOTH Option (PIT4864F)
- ONSTAR Voice Recognition Operation Issues (PIC3011H)
- Information On Aftermarket Device Interference With ONSTAR® Diagnostic Services (08-08-46-004A)
- OnStar® Phone Number Concerns (Phone Number Incorrect/Assigned to Another Vehicle/Phone) That Occur During Diagnosis of OnStar® System (05-08-46-004C)
- GM Training - July 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-031)
- Information Required Before Contacting GM Technical Assistance or When Ordering Replacement OnStar® VCIM (09-08-46-003)
- OnStar® Labor Operation Codes (05-08-46-005C)
- Servicing Vehicles Upgraded To ONSTAR® Generation 6 Digital-Capable System (Follow Information Below) (09-08-46-001)
- Information on OnStar® Dual-Mode (Analog/Digital) Systems (06-08-46-008C)
- Re-establishing Communications with OnStar® Center After Battery Disconnect (00-08-46-004C)
- Availability of GM OnStar® Vehicle Diagnostics and GM Goodwrench® Remote Diagnostic Services (06-08-46-002B)
- Cataloging of Electronic Service Center Parts (06-00-89-016A)
- Incorrect OnStar® Global Positioning System (GPS) Location Reported During OnStar® Call (02-08-46-006C)
- Information on OnStar® Dual-Mode (Analog/Digital) Systems (06-08-46-008A)
- Information On ONSTAR System - Possible Loss Of GPS Signal, Hands-Free Calling Minutes Expire Prematurely And/Or Inability To Add Hands-Free Calling Minutes (02-08-46-007D)
- Programming OnStar(R) Module for Canadian French Voice Recognition (OnStar(R) Generation 5 or Generation 6) (02-08-46-010G)
- Revised OnStar(R) Microphone Replacement (06-08-46-001)
- Unable to Connect to OnStar(R) or OnStar(R) Personal Calling Inoperative (04-08-46-003B)
- Parts Restriction on Ordering OnStar(R) Generation 5 and 6 Vehicle Communication Interface Modules (VCIM) (03-08-46-004A)
- OnStar(R) System Cellular Antenna Replacement Parts Availability (00-08-46-002A)
- Radio Telephone/Mobile Radio (Transceiver) Installation and Troubleshooting Guidelines (04-08-46-002)
- Cooling Fan
- Cooling System (Mechanical)
- Information On Flushing Oil Contamination From Cooling System (25-NA-052)
- Information On Ethylene Glycol In Transmission Fluid (08-07-30-035I)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Information On Aluminum Heater Core and/or Radiator Replacement (73-62-13A)
- DEX-COOL® Coolant - New Leak Detection Dye J 46366 - Replaces J 29545-6 (05-06-02-002B)
- Engine Coolant Recycling and Warranty Information (00-06-02-006D)
- Instructions for Using GE-47716 Vac-N-Fill Coolant Refill Tool (05-06-02-006)
- Serpentine Drive Belt Assembly Squeals at Higher RPM and May Emit an Odor (Replace Serpentine Drive Belt Assembly) (05-06-01-009)
- Cruise Control Systems
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Diagnostic Aids For Gas Engine Misfire/Rough Running With DTC P0300-P0308 And/Or DTC P050D (PIP5628G)
- Diagnostic Tip For Malfunction Indicator Lamp (Mil) Illuminated - DTC P0442 And/Or P0455 Set (21-NA-124)
- SES Light With Fuel Trim And Or Oxygen Sensor Codes (PIP4925B)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Information On Rough Idle, Crank No Start, Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves, Malfunction Indicator Light (Mil) Illuminated - DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308 Set (16-NA-383)
- Procedure To Take Snapshot Data With A Tech 2 And Upload Data To A Computer Using TIS Software (07-07-30-010D)
- Prior To Any Circuit Testing (PIP5094A)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Various Electrical Concerns (15-08-45-001)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Information - Non-Gm Parts And Accessories (Aftermarket) (04-06-04-054D)
- Information to Avoid Damaging EVAP Canister and Setting DTCs P0442/P0455 When Hoisting Vehicle (05-06-04-004E)
- Fuel Gauge Does Not Read Correctly, Fuel Gauge Stuck, Check Engine Light On, DTC P0455, P0461 Set (Reposition Fuel Vapor Line) (09-06-04-007A)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- Intermittent Loss of Power, Rough Running Engine at Start Up (Reprogram PCM) (07-06-04-031)
- Intermittent No Crank, No Start, Starter Solenoid Clicks Engine Does Not Crank (Reprogram PCM) (07-06-04-030)
- LSJ, L61, LK5, L52, LL8 Engine - Reduced Engine Power, MIL/SES Light, DTC P1516, P2135, P2138 (Replace PCM) (07-06-04-003)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Severe Hesitation, Drop of Engine RPM or Idle Stall (Install Jumper Harness) (04-06-03-010A)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- Entertainment Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Diagnostic Tips: XM Audio Traffic And Travel Link Availability And Operation (PIT5353C)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- Programming And Activation Of Replacement ONSTAR Modules (VCIM) (PIC5588C)
- Information On Inappropriate Warranty Claims Submitted For Damaged Radios And Instrument Panel Clusters (IPCS) (08-08-44-015H)
- XM Band Not Receiving All Channels (Preview Mode) (PIC5088F)
- Return Or Reimbursement Of Customer Owned CDS, DVDS Or Navigation Discs (05-08-44-024E)
- Various Electrical Concerns (15-08-45-001)
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Poor Radio Reception Or Radio Static/Increased Interference With Rear Window Defogger On Or Some Rear Window Defogger Grids May Be Inoperative (03-08-44-005L)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Information On Eliminating Noise In Audio System When Using Portable Playback Device (06-08-44-015C)
- Information on Availability of Service Parts for GM Accessory DVD Headrest Systems (09-08-44-016)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- Changes to XM Network of Terrestrial Repeaters (08-08-46-006)
- Information on Refurbish Instead of Replace Out of Warranty Radios with Worn Graphics on Faceplate, Knobs or Buttons (08-08-44-026)
- Parts Restriction on Ordering XM Digital Radio Receiver (04-08-44-009A)
- Utilizing Tech 2® To Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) (04-08-44-005C)
- Cataloging of Electronic Service Center Parts (06-00-89-016A)
- Information on Rear Seat Headphone Foam Ear Pad Replacement if Worn or Damaged (05-08-44-005A)
- Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
- Radio Static Noise on AM Stations When Using Rear Defogger (Install Capacitor) (05-08-44-017)
- XM Radio Labor Operation Codes (03-08-44-001A)
- Global Position Sensor (GPS) Performance Degradation (00-08-46-003B)
- Compact Disc (Cd) Or DVD Player Skipping, Inoperative, Sluggish And/Or Long Search Times (05-08-44-001)
- Exhaust
- Exterior Body Panels
- Underbody Component Corrosion (PI0281L)
- PAINTLESS Dent Repair Process (99-08-51-001F)
- Hem Flange Rust Repair (02-08-98-002H)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Non-Approval Of "Clipping" (Sectioning Of Two Vehicles) For Collision Repair (07-08-98-001B)
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Information On Hem Flange Sealer For Corrosion Protection (06-08-51-005C)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- Squeeze Type Resistance Spot Welding/Equipment (03-08-98-002B)
- Difficulty Filling Fuel Tank, MIL/SES Light Illuminated DTC P0446 - Evaporative Emissions (EVAP) Vent System Performance (Inspect/Clean EVAP Canister Vent Valve Solenoid and Install Screen) (07-06-04-023A)
- Metal Panel Bonding (02-08-98-001C)
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- Laminated Steels - General Information and Specific Repair Procedures for Front Lower Rail Replacement, Front Wheelhouse Replacement and Hinge Pillar Body Replacement (05-08-98-004)
- Usage of E85 Fuels in GM Vehicles (05-06-04-035)
- Revised Trim Height Specifications and Wheel Alignment Specifications (05-03-07-005)
- Hood Will Not Latch in Primary Latch Position (Apply Lubricant) (05-08-63-001)
- Repair Procedure for Service Sheet Metal - Craters in ELPO Surface (04-08-98-002)
- Exterior Lights
- Exterior Lighting Components "Tinted Or Smoked" By An Outside Vendor (15-08-42-001A)
- Various Electrical Concerns (15-08-45-001)
- Intermittently Brake Lights (Stop Lamps) Do Not Function Correctly, Extended Travel To Shift Out Of Park, Cruise Control Inoperative, DTCS C0131, C0161 Or C0277 Set (Bulletin Canceled) (08-05-22-009D)
- Headlamp, Tail Lamp, License Lamp Or Fog/Driving Lamp Damage (02-08-42-001J)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- Front Park/Turn/DRL or Rear Stop/Turn/Tail Lamp Inoperative (Replace Bulb and Inspect Socket) (06-08-42-004C)
- Frames, Subframes & Crossmembers
- Underbody Component Corrosion (PI0281L)
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Non-approval of "Clipping" (Sectioning of Two Vehicles) For Collision Repair (07-08-98-001A)
- Information on Repair of Polypropylene Energy Absorbers (63-20-02)
- Laminated Steels - General Information and Specific Repair Procedures for Front Lower Rail Replacement, Front Wheelhouse Replacement and Hinge Pillar Body Replacement (05-08-98-004)
- Front Suspension
- Information On Diagnosis And Replacement Of Shock Absorber And Strut Due To Fluid Leak (72-05-12)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Vibration Analysis Worksheet (03-00-91-001I)
- Revised Trim Height Specifications and Wheel Alignment Specifications (05-03-07-005)
- Fuel System
- Top Tier™ Detergent Gasoline And Top Tier™ Diesel Fuel Information And Licensed Brands (05-06-04-022Q)
- Rough Idle Crank No Start Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves (PIP5029H)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Usage Of E85 Fuel In Gm Vehicles (05-06-04-035E)
- Fuel And Oil Additives - Facts And Myths - Maximizing Gasoline Fuel Economy (05-00-89-072F)
- Top Tier Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047L)
- Gm Fuel System Treatment Plus, Fuel Sending Unit Corrosion And Fuel System Deposits (05-00-89-078C)
- Information to Avoid Damaging EVAP Canister and Setting DTCs P0442/P0455 When Hoisting Vehicle (05-06-04-004E)
- Use of E85 Fuels in Vehicles Not Certified by GM as being FlexFuel Compatible / Aftermarket Conversion of Vehicles to Operate on E85 Fuels (06-06-04-035A)
- L61 Engine Malfunction Indicator Lamp (MIL)/Service Engine Soon (SES) Lamp Illuminated with DTC P0171 "Fuel Trim System Lean" Set (Reprogram ECM) (06-06-04-033)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Usage of E85 Fuels in GM Vehicles (05-06-04-035)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- Fuses & Circuit Breakers
- J-35616-64B Or El-35616-58 Terminal Test Probe Information/Repair (PIT5074R)
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Servicing and Required Return of Complete Body Control Module (BCM) with Integrated Electrical Centers (05-08-47-001A)
- Information on Importance of Using GM-Approved Terminal Probe Test Kit (J 35616) to Diagnose Electrical Concerns (07-00-89-060)
- Service Alert: Concerns With Aftermarket Fuses in GM Vehicles (07-08-45-002)
- Information on Changes to the SI Table of Contents, Electrical Connectors, Terminal Testing/Repair, and the Importance of J-38125 Electrical Terminal Repair Kit Maintenance (06-08-45-001)
- Gauges & Instrument Panels
- Interior Cleaning - Instrument Panel (IP), Hard Or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability (06-00-89-029W)
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Verifying Odometer Accuracy (PIC3100G)
- IPC Odometer Programming Method Quick Reference Guide (07-08-49-020O)
- Incorrect Odometer Reading After BCM Replacement (PIC3843E)
- Information On Inappropriate Warranty Claims Submitted For Damaged Radios And Instrument Panel Clusters (IPCS) (08-08-44-015H)
- Various Electrical Concerns (15-08-45-001)
- Fuel Gauge Does Not Read Correctly, Fuel Gauge Stuck, Check Engine Light On, DTC P0455, P0461 Set (Reposition Fuel Vapor Line) (09-06-04-007A)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Utilizing Tech 2® To Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) (04-08-44-005C)
- Cataloging of Electronic Service Center Parts (06-00-89-016A)
- PRNDL Display Reduced Visibility For Approximately One Minute (02-08-72-004A)
- Instrument Panel Cluster (IPC) Backlighting Inoperative During Daylight Hours (Reprogram BCM) (06-08-49-016B)
- Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
- Instrument Panel (I/P), Body and General Wiring Harness Repair (06-08-45-004)
- Malfunction Indicator Lamp (MIL) On, Transmission Stuck in Second or Third Gear, Instrument Cluster Inoperative (Verify and Repair Source of Voltage Loss In Transmission Solenoid Power Supply Circuit) (01-07-30-002E)
- Addition of Instrument Cluster Bulb Replacement Procedure (05-08-49-023)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Driver Information Center (DIC) Messages Missing (Reprogram BCM) (05-08-49-011A)
- General Servicing
- Headlights
- Heated Glass/Defoggers
- Hoist/Jack
- HVAC Control Systems
- Ac Blows Warm Or Poor Performance (PIT5099H)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Air Conditioning Odor (Install Evaporator Core Dryer Kit And Apply Cooling Coil Coating) (99-01-39-004I)
- Diagnostic Tips For Odor Emanating From HVAC System (PI1440)
- Information On Aluminum Heater Core and/or Radiator Replacement (73-62-13A)
- Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
- 18 Digit "Snapshot/Charge Summary" Code No Longer Required For A/C Refrigerant System Repairs Submitted For Warranty Reimbursement (05-01-38-008B)
- Contaminated R134a Refrigerant Found on Market for Automotive Air-Conditioning Systems (06-01-39-007)
- Contaminated R-134a A/C Systems - Air Conditioning System Flushing Procedures and Universal In-Line A/C Filter Installation (83-12-21)
- J-43600 ACR 2000 Essential Refrigerant Recovery/Recharge Equipment (99-01-38-006B)
- Identification
- Ignition Switch/Steering Lock
- Ignition System
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Infotainment
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- ONSTAR Module 2G Sunset Information (23-NA-001)
- DVD Navigation Update Program, Navigation Disc Diagnostic Aid, AVN Software Update Discs And Ordering Information (06-08-44-012G)
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Information On Navigation Radio Not Displaying Accurate Vehicle Location After Radio Replacement, Power Loss Or Battery Replacement (08-08-44-023A)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- Navigation Radio Diagnostic Tips (08-08-44-010F)
- Re-establishing Communications with OnStar® Center After Battery Disconnect (00-08-46-004C)
- Cataloging of Electronic Service Center Parts (06-00-89-016A)
- Incorrect OnStar® Global Positioning System (GPS) Location Reported During OnStar® Call (02-08-46-006C)
- Information On ONSTAR System - Possible Loss Of GPS Signal, Hands-Free Calling Minutes Expire Prematurely And/Or Inability To Add Hands-Free Calling Minutes (02-08-46-007D)
- Compass Zone Adjustment and Calibration Procedure During Pre-Delivery Inspection (03-08-48-005C)
- Information on Obtaining Replacement Navigation Discs When Radios are Exchanged - Order Replacement Navigation Disc Through Navigation Disc Center (07-08-44-007)
- Unable to Connect to OnStar(R) or OnStar(R) Personal Calling Inoperative (04-08-46-003B)
- OnStar(R) System Cellular Antenna Replacement Parts Availability (00-08-46-002A)
- Global Position Sensor (GPS) Performance Degradation (00-08-46-003B)
- Interior/Exterior Trim
- Information On Proper Use Of Floor Mats (10-08-110-001L)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including Chevy Bowtie (Bulletin Cancelled) (06-08-111-004B)
- Sun Visor Mirror Cover Comes Off Sunshade or Cover Will Not Fully Open (Bulletin Canceled) (05-08-110-005H)
- Information on Maintaining Exterior Weatherstrip Appearance (99-08-64-016C)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- Front Seat Back Trim Panel "Falling Off"/Loose/Detached from Seat Frame (Install New Retainer) (05-08-50-001)
- 2005 Malibu, Malibu Maxx May Have Loose Seat Back Panels (CHS20040044)
- Plastic Wheel Nut Covers Missing and/or Loose (Replace Missing Covers and Add Sealant to All Covers) (01-03-10-009A)
- Interior/Illumination Lights
- Lubrication System
- Information On Flushing Oil Contamination From Cooling System (25-NA-052)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Engine Oil Consumption Guidelines (01-06-01-011Q)
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Information On Gasoline Engine Replacement Guidelines After Connecting Rod Or Crankshaft Main Bearing Damage - Replace Oil Cooler, Oil Cooler Lines, Oil Tank And Turbocharger (22-NA-074)
- Information For Engine Concerns Resulting From Lack Of Scheduled Maintenance, Improper Service Or Aftermarket Calibrations (16-NA-222)
- Information On New Torque Specification And Installation Procedure For ACDELCO Spin-On Oil Filters (22-NA-009)
- Fuel And Oil Additives - Facts And Myths - Maximizing Gasoline Fuel Economy (05-00-89-072F)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- 60 Degree V6 Engine Oil Leak at Crankshaft Front Oil Seal (Use New Crankshaft Front Oil Seal Installer Tool EN-48869) (07-06-01-023)
- Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019F)
- Manual Steering
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Power Steering Noise Or Fluid Leak From Power Steering Pump, Gear Or High Pressure Hose During Extreme Low Temperature Operation (Replace Power Steering Fluid) (12-02-32-002B)
- Vibration Analysis Worksheet (03-00-91-001I)
- Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013B)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Noise in Steering Column, Lack of Power Steering Assist, DTCs C0460 and C0545, Steering Wheel Moves Slightly By Itself (Replace Steering Column) (04-02-35-009A)
- Serpentine Drive Belt Assembly Squeals at Higher RPM and May Emit an Odor (Replace Serpentine Drive Belt Assembly) (05-06-01-009)
- Manual Trans
- Information On Driveline Clunk Noise (99-04-20-002O)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Vibration Analysis Worksheet (03-00-91-001I)
- Instructions To Be Followed To Aid in Obtaining Root Cause Analysis on Both OEM and Goodwrench(R) Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
- Mechanical
- Engine Replacement After Severe Internal Engine Damage - Replace Intake Manifold (00-06-01-026R)
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Use Of Surface Conditioning Disks When Cleaning Gasket Sealing Surfaces And/Or Reused Parts (00-06-01-012N)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Engine Repair Tip For Installation Of Pistons (PI1394B)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Information On Engine Block Cracked At Head Bolt Hole Locations (23-NA-141)
- Information On Gasoline Engine Replacement Guidelines After Connecting Rod Or Crankshaft Main Bearing Damage - Replace Oil Cooler, Oil Cooler Lines, Oil Tank And Turbocharger (22-NA-074)
- Information For Engine Concerns Resulting From Lack Of Scheduled Maintenance, Improper Service Or Aftermarket Calibrations (16-NA-222)
- Diagnostic Tip On Avoiding Torque Converter Or Crankshaft Damage While Diagnosing Noise Concerns (PIP5640A)
- Alleged Cylinders Out Of Round (PIP5163E)
- Whine Noise From Timing Chain Area (PIP3535D)
- Cylinder Head Tick Noise And Or Damage - Possible Plugged Oil Feed Orifice (PIP4495F)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Rough Idle Crank No Start Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves (PIP5029H)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Dealer Reimbursement Procedures For CAC Tier 1 And Tier 2 Empowerment Tools: Diagnostic Fee, Short Term Rental, And Up-Front Towing (U.S. Only) (15-00-89-003)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- Vibration Analysis Worksheet (03-00-91-001I)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019F)
- GM Performance Parts Engine Warranty Q & A (04-06-01-019A)
- L61 Engine Front End Wobble or Vibration On Acceleration (Refer to SI Procedure for Powertrain Mount Balance - Lower Mount) (06-06-01-025)
- Revised Mass Air Flow Core Return Requirements (06-06-04-057)
- Instructions To Be Followed To Aid in Obtaining Root Cause Analysis on Both OEM and Goodwrench(R) Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
- SMU - New Cylinder Bore Piston Sleeve Replacement Procedure (03-06-01-018D)
- Revised Oil Pan Replacement Procedure (06-06-01-002)
- Oil Leak from Engine Front Cover Crankshaft Oil Seal During Extremely Cold Weather (Replace Crankshaft Front Oil Seal) (04-06-01-009A)
- Serpentine Drive Belt Assembly Squeals at Higher RPM and May Emit an Odor (Replace Serpentine Drive Belt Assembly) (05-06-01-009)
- Mechanical - Hydraulic
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Brake Lathe Calibration Procedure (VSS20040074)
- Vibration Analysis Worksheet (03-00-91-001I)
- Information On Resurfacing Park Brake Portion Of Rear Brake Rotor (12-05-26-001)
- Brake Align® System for Brake Rotor Lateral Runout Correction (01-05-23-001B)
- Brake Rotor/Drum Refinishing Labor Operations (06-05-22-007)
- On-Car Brake Lathe Specifications and Maintenance Requirements (05-05-22-001)
- Service Information Regarding Rear Brake Drum Wheel Cylinder Inspections (03-05-24-001A)
- Memory Modules
- Mirrors
- Paint & Coatings
- Information On Paint Stain Under Protective Shipping Film (05-08-51-001L)
- PAINTLESS Dent Repair Process (99-08-51-001F)
- Hem Flange Rust Repair (02-08-98-002H)
- Refinishing Aluminum And Chrome Wheels (99-08-51-007G)
- Application Of Anti-Corrosion Materials (01-08-51-003E)
- Information On Hem Flange Sealer For Corrosion Protection (06-08-51-005C)
- Pre-Painting/Cleaning Process For TPO Plastic Fascias (08-08-51-002A)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) (43-17-01B)
- Cloudy Spot in Paint After Protective Covering is Removed (Heat Area) (05-08-51-005)
- Repair Procedure for Service Sheet Metal - Craters in ELPO Surface (04-08-98-002)
- Parking Brake System
- Passive Restraints
- Procedures
- Rear Suspension
- Information On Diagnosis And Replacement Of Shock Absorber And Strut Due To Fluid Leak (72-05-12)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Vibration Analysis Worksheet (03-00-91-001I)
- Revised Rear Shock Absorber Replacement and Fastener Tightening Specifications (05-03-09-009)
- Revised and New Rear Suspension Tightening Specifications (05-03-09-006)
- Revised Trim Height Specifications and Wheel Alignment Specifications (05-03-07-005)
- Restraints Control Systems
- Information On Passenger Presence Sensing System (PPS Or PSS) Concerns With Custom Upholstery, Accessory Seat Heaters Or Other Comfort Enhancing Devices (06-08-50-009J)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Prior To Any Circuit Testing (PIP5094A)
- Seat Belt Buckle Latching Issues And/Or Seat Belt Warning Lights Illuminated (09-09-40-001C)
- New SIR System Disabling and Enabling Procedure (05-09-41-010)
- Driver Information Center (DIC) Messages Missing (Reprogram BCM) (05-08-49-011A)
- Information On False DTC B0595 Set In History (05-09-41-006)
- Seats
- Information On Passenger Presence Sensing System (PPS Or PSS) Concerns With Custom Upholstery, Accessory Seat Heaters Or Other Comfort Enhancing Devices (06-08-50-009J)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Seat Belt Extender Availability (99-09-40-005H)
- Various Electrical Concerns (15-08-45-001)
- Information On Driver Or Passenger Seat Head Restraint Concerns With Comfort, Custom Upholstery Or Other Comfort Enhancing Devices (10-08-50-003A)
- Warranty Admin - Front Seat Cushion Frame Replacement and Front Seat Back Frame Replacement Labor Operations C6060 and C6068 (07-08-50-006)
- Front Seat Rear Trim Panels Falling Off (Refer to Corporate Bulletin Number 05-08-50-001) (05-08-53-001A)
- Addition of Front Seat Track Synchronization Procedure (05-08-50-014)
- Front Seat Back Trim Panel "Falling Off"/Loose/Detached from Seat Frame (Install New Retainer) (05-08-50-001)
- Information On False DTC B0595 Set In History (05-09-41-006)
- Front Seat Head Restraint Uncomfortable, Positioned Too Far Forward (Replace Head Restraints) (05-08-50-002)
- 2005 Malibu, Malibu Maxx May Have Loose Seat Back Panels (CHS20040044)
- Starter
- Cold Weather And Long Stand Time Battery Maintenance And Testing Tips (15-06-03-001F)
- Warranty Administration - Battery Testing And Warranty Replacement Requirements (North AMERICA Only) (03-06-03-004Z)
- ACDELCO® Replacement Battery Warranty Procedures (03-06-03-003D)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- GM Dealer Visits: Proper Management of Batteries in Dealer Parts Stock / Vehicle Inventory (08-06-03-005)
- Battery and Charging System Electrical Diagnostics (99-06-03-012)
- Battery Charging Tips (Includes Information References for HP2 Hybrid Truck [PHT] 42-volt System) (02-06-03-009C)
- Intermittent No Crank, No Start, Starter Solenoid Clicks Engine Does Not Crank (Reprogram PCM) (07-06-04-030)
- Starter Cranks After Key Is Released (Normal Condition) (03-06-03-001D)
- Intermittent No Crank, No Start (03-06-03-006A)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Battery Specification Label (04-06-03-016)
- Battery Parasitic Drain (02-06-03-010A)
- Steering Column
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Clunk, Knock or Rattle Noise From Front of Vehicle While Driving or Turning Over Bumps at Low Speeds (Diagnose Noise and Perform Outlined Repair) (06-02-32-007G)
- Steering Column Tilt Wheel Release Lever Inoperative/Broken (Replace Tilt Wheel Release Lever Kit and/or Release Lever Retainer (Tilt Teeth)) (09-02-35-006)
- Noise in Steering Column, Lack of Power Steering Assist, DTCs C0460 and C0545, Steering Wheel Moves Slightly By Itself (Replace Steering Column) (04-02-35-009A)
- Increased Steering Effort on Cold Start-up (Replace Lower Control Arms) (05-02-32-001C)
- Revised Tilt Lever Replacement (06-02-35-012)
- Snap/Pop Type Noise During Steering Wheel Rotation (Replace Inner Tie Rod Boot) (06-02-32-005)
- Steering Column Tilt/Telescope Wheel Lever Available for Service Use (05-02-35-001)
- Steering Control Systems
- Prior To Any Circuit Testing (PIP5094A)
- Information for Normal Operating Characteristics of Electric Power Steering (EPS) System During Extended Lock-to-Lock Turns or When Held at Maximum Steering Wheel Rotation and/or DTCs C0176 and C0476 Set (06-02-32-002D)
- Noise in Steering Column, Lack of Power Steering Assist, DTCs C0460 and C0545, Steering Wheel Moves Slightly By Itself (Replace Steering Column) (04-02-35-009A)
- Vehicle Leads/Pulls Characteristics and Diagnosis (04-03-06-001)
- Steering Gear
- Power Steering Noise Or Fluid Leak From Power Steering Pump, Gear Or High Pressure Hose During Extreme Low Temperature Operation (Replace Power Steering Fluid) (12-02-32-002B)
- Hydraulic Power Steering System Leak - Required Diagnostic Actions (07-02-32-002M)
- Release of Steering Gear Stub Shaft Bearing Kit for Service (04-02-32-001F)
- Increased Steering Effort on Cold Start-up (Replace Lower Control Arms) (05-02-32-001C)
- Steering Column Tilt/Telescope Wheel Lever Available for Service Use (05-02-35-001)
- Steering Linkage
- Clunk, Knock or Rattle Noise From Front of Vehicle While Driving or Turning Over Bumps at Low Speeds (Diagnose Noise and Perform Outlined Repair) (06-02-32-007G)
- Servicing Intermediate Steering Shafts - Do Not Grease Painted I-Shafts (08-02-34-001A)
- Snap/Pop Type Noise During Steering Wheel Rotation (Replace Inner Tie Rod Boot) (06-02-32-005)
- Sun Roof/T-Top/Convertible Top
- Rear And Side Tempered Glass Spots (Quench Marks) (PI0754G)
- Intermittent Sunroof Operation, Bind, Noise, Auto-Reverse, And/Or Water Leaks (PIC5260F)
- Various Electrical Concerns (15-08-45-001)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- GM Training - GM Moveable Roof Systems Hands-On (#12040.30H) (U.S. Dealers) (This is not a Saturn STS Requirement) (08-00-89-027)
- Wind Noise From Sunroof (Install Air Deflector) (04-08-67-009)
- Suspension Control Systems
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
- Revised Trim Height Inspection Procedure and Trim Height Specifications (06-03-03-004)
- System
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- SES Light With Fuel Trim And Or Oxygen Sensor Codes (PIP4925B)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Information On Rough Idle, Crank No Start, Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves, Malfunction Indicator Light (Mil) Illuminated - DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308 Set (16-NA-383)
- Procedure To Take Snapshot Data With A Tech 2 And Upload Data To A Computer Using TIS Software (07-07-30-010D)
- Prior To Any Circuit Testing (PIP5094A)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Usage Of E85 Fuel In Gm Vehicles (05-06-04-035E)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Difficulty Filling Fuel Tank, MIL/SES Light Illuminated DTC P0446 - Evaporative Emissions (EVAP) Vent System Performance (Inspect/Clean EVAP Canister Vent Valve Solenoid and Install Screen) (07-06-04-023A)
- Fuel Gauge Does Not Read Correctly, Fuel Gauge Stuck, Check Engine Light On, DTC P0455, P0461 Set (Reposition Fuel Vapor Line) (09-06-04-007A)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Diagnostic Trouble Codes (DTCs) Required On Repair Orders (06-00-89-050B)
- Information On 4T40-E (MN4) and 4T45-E (MN5) Front Wheel Drive Automatic Transmission Valve Body Reconditioning, DTC P0741, P0742, P0751, P0752, P0756, P0757, P1811, Harsh Shifts, Slips, No Drive, No Reverse (07-07-30-025)
- LSJ, L61, LK5, L52, LL8 Engine - Reduced Engine Power, MIL/SES Light, DTC P1516, P2135, P2138 (Replace PCM) (07-06-04-003)
- Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
- Normal Characteristics of Malfunction Indicator Lamp (MIL) During On-Board Diagnostic (OBD) Inspection/Maintenance (I/M) Testing (06-06-04-037)
- L61 Intermittent MIL/SES, DTC P0171 Fuel Trim System Lean During Low Speed Driving Event After Hot Soak (Reprogram Powertrain Control Module (PCM)) (06-06-04-019A)
- L61 Engine Malfunction Indicator Lamp (MIL)/Service Engine Soon (SES) Lamp Illuminated with DTC P0171 "Fuel Trim System Lean" Set (Reprogram ECM) (06-06-04-033)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- Towing
- Transfer Case
- Transmission Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Procedure To Take Snapshot Data With A Tech 2 And Upload Data To A Computer Using TIS Software (07-07-30-010D)
- Prior To Any Circuit Testing (PIP5094A)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- Diagnostic Information on Diagnostic Trouble Code (DTC) P0894 and P1870 (08-07-30-008A)
- Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
- Information Regarding Automatic Transmission Shift Lock Control Function (03-07-30-043A)
- 4L60-E / 4L65-E / 4L70-E Automatic Transmission Product Update (05-07-30-028A)
- Malfunction Indicator Lamp (MIL) On, Transmission Stuck in Second or Third Gear, Instrument Cluster Inoperative (Verify and Repair Source of Voltage Loss In Transmission Solenoid Power Supply Circuit) (01-07-30-002E)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Wheel Alignment
- Refinishing Aluminum And Chrome Wheels (99-08-51-007G)
- Wheel Alignment Specifications, Requirements And Recommendations For Gm Vehicles (05-03-07-009H)
- Revised Trim Height Inspection Procedure and Trim Height Specifications (06-03-03-004)
- Revised Trim Height Specifications and Wheel Alignment Specifications (05-03-07-005)
- New Alignment Procedure For Labor Operation Numbers E2020 and E2000 (04-03-07-002A)
- Vehicle Leads/Pulls Characteristics and Diagnosis (04-03-06-001)
- Wheels & Tire System
- Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean And Resurface Wheel Bead Seat) (08-03-10-006I)
- Guidelines When Changing Tire And Wheel Size (PIT3271P)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Vibration Shortly After Tires Are Mounted/Preventing Vibration From Wheel Slip (Tire Sliding On Wheel) (12-03-10-001E)
- Information On Proper Tire Pressure (00-00-90-002M)
- Information On Tire Radial Force Variation (RFV) (00-03-10-006P)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5338B)
- Information On Hunter Road Force Balancer (17-NA-170)
- Non-Design Intent Wheel Lock Nuts And Lug Nuts (17-NA-126)
- Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean And Resurface Wheel Bead Seat) (08-03-10-006H)
- Information On Tire/Wheel Characteristics (Vibration, Balance, Shake, Flat Spotting) Of Gm Original Equipment Tires (03-03-10-007J)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Various Electrical Concerns (15-08-45-001)
- Use Of Nitrogen Gas In Tires (05-03-10-020F)
- Statement On Tire Sealant Included In Gm Inflator Kits (Supplied With New Vehicles Or As Gm Accessory) (09-03-10-013B)
- Wheel Balancing Machine Finish Damage To Chrome Clad Or CHROMETECH® Wheels (09-03-10-016A)
- Gm Tire Warranty Program Goodwill Guidelines (U.S. Only) (08-03-10-012B)
- General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015B)
- Guidelines for Using Labor Operations E0200, E0201, E0203, E0204 - Wheel Balance (72-05-03)
- Information on Proper Wheel Changing Procedures and Cautions (06-03-10-010A)
- Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (93-U-57)
- Tire Puncture Repair Procedures For All Cars and Light Duty Trucks (04-03-10-001F)
- Information on Replacement Wheel Weights (09-03-10-017)
- Mounting, Balancing And Installation Of Accessory Wheels And Tires Available Through Gm Accessories (08-03-10-004A)
- Use of Chrome or Chrome Plated Steel Valve Caps on Aluminum Valve Stems (08-03-10-005A)
- Performance Characteristics of Vehicles with Accessory Wheel/Tire Assemblies Installed as "Upsized" to Original Equipment (05-03-10-005D)
- Minimizing Damage to Tire Pressure Monitor (TPM) Sensors During Tire Mounting/Dismounting (08-03-10-007)
- Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
- Pitting and Brake Dust on Chrome Wheels (04-03-10-012B)
- Proper Use of OEM Service Wheel Weights, Marring and/or Damage Due to Use of Non-OEM and/or Incorrect Wheel Weight Installation (06-03-10-004)
- Use Recommended Tire Mounting Lubricant To Prevent Tires From Slipping on Chrome Wheels (T-93-93)
- Window Motors & Regulators
- Information On Side Door Window Glass Chipping Caused By Hanging Vehicle Key Lock Box (06-08-64-001D)
- Repair Information For Reconnection Of Rear Window (Defroster) Contact Or Tab (03-08-48-006J)
- Distortion in Outer Surface of Vehicle Glass (00-08-48-005D)
- Marks/Stains on Windshield When Wet (Clean Windshield) (09-08-48-002A)
- Warranty Admin - Guidelines for Claiming C0034 - Windshield Replacement (72-05-04)
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- Wiper/Washer Systems
- Wiring Diagrams
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- J-35616-64B Or El-35616-58 Terminal Test Probe Information/Repair (PIT5074R)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Prior To Any Circuit Testing (PIP5094A)
- Information on Changes to the SI Table of Contents, Electrical Connectors, Terminal Testing/Repair, and the Importance of J-38125 Electrical Terminal Repair Kit Maintenance (06-08-45-001)