LEMON Manuals: Even more car manuals for everyone: 1960-2025
Home >> Chevrolet >> 2011 >> Volt >> Repair and Diagnosis >> Engine Mechanical >> Engine Exhaust System >> Repair Instructions >> Catalytic Converter Replacement
April 5, 2026: LEMON Manuals is launched! Read the announcement.

Catalytic Converter Replacement

Fig 1: Catalytic Converter
GM2398026Courtesy of GENERAL MOTORS CORP.
Callout Component Name
WARNING: Do not use a service jack to lift this vehicle. Lifting the vehicle with a jack could cause the vehicle to slip off the jack and roll; this could cause injury or death.
WARNING: Refer to Hot Exhaust System Warning .

Preliminary Procedures

  1. Raise and support the vehicle. Refer to Lifting and Jacking the Vehicle .
  2. Disconnect the heated oxygen sensor. Refer to Heated Oxygen Sensor Replacement - Sensor 2 .
  3. Remove the exhaust muffler clamp. Refer to Exhaust System Replacement .
1 Catalytic Converter Nut (Qty: 3)
CAUTION: Refer to Fastener Caution .

Tighten:  22 N.m (16 lb ft)

2 Exhaust Gasket
Tip:  Replace the gasket with a NEW one.
3 Exhaust Clamp

Tighten:  55 N.m (41 lb ft)

4 Exhaust Isolator
5 Catalytic Converter
Tip:  If replacing the catalytic converter, transfer the heated oxygen sensor over to the new catalytic converter.