Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups- Accessories & Equipment
- Anti-Theft Systems
- Cruise Control Systems
- Description
- Operation
- Adjustments
- Testing
- Trouble Shooting
- No Cruise Control When Speed Set Button Is Pressed
- No Resume When Slide Switch Is Moved
- Cruise Control Does Not Disengage With Pedal Depressed
- Cruise Control Engages Without Actuating Speed Set Button
- Engine Does Not Return To Normal Idle
- Speedometer Noise, Excessive Needle Flutter Or Erratic Servo Lock-In Performance
- Erratic Speed Or Engine Shuts Off
- Speed Setting After Lock-In Is Too High Or Too Low
- Unit Disengages On Rough Road
- Resume Speed Possible Below 25 Mph
- Cruise Control Engages When Engine Is Started
- Removal & Installation
- Wiring Diagrams
- Gauges & Instrument Panels
- Instrument Panel - Electronic
- Description
- Operation
- Adjustments
- Testing
- Self-Diagnostic Tests
- Electronic Instrument Cluster Diagnosis
- Displays Not Illuminated After Vehicle Starts
- Speedometer & Odometer Inoperative Or Intermittent Operation
- Oil, Fuel, Temperature Or Voltage Gauge Inoperative (Dynasty & New Yorker)
- Cluster Display Will Not Dim
- Tachometer Inoperative
- Washer, Door/Deck Or "CHECK ENGINE" Light Inoperative (Dynasty & New York)
- Odometer Is Blank (Dynasty & New Yorker)
- US/MET Mode Inoperable & Trip Odometer Will Not Reset (Dynasty & New Yorker)
- Electronic Navigator
- Navigator Diagnostic Functions
- Removal & Installation
- Wiring Diagrams
- Instrument Panel - Electronic
- Headlights
- Heated Glass/Defoggers
- Infotainment
- Mirrors - Power
- Description
- Operation
- Testing
- Removal & Installation
- Mirror Switch Replacement
- Removal & Installation (Acclaim & Spirit)
- Removal & Installation (Aries, Daytona, Reliant, Shadow & Sundance)
- Removal & Installation (Diplomat, Fifth Avenue & Gran Fury)
- Removal & Installation (Dynasty & New Yorker)
- Removal & Installation (LeBaron 2-Door & LeBaron Convertible)
- Removal & Installation (Lancer & LeBaron 4-Door)
- Power Mirror Assembly
- Mirror Switch Replacement
- Wiring Diagrams
- Seats
- Seats - Power
- Seats - Power W/Memory
- Description
- Operation
- Testing
- Removal & Installation
- Wiring Diagrams
- Trouble Shooting
- No System Operation
- No Recliner Motion Forward (Relay Clicks)
- No Recliner Motion Rearward (Relay Clicks)
- No Seat Front Up Motion (Relay Clicks)
- No Seat Front Down Motion (Relay Clicks)
- No Seat Rear Up Motion (Relay Clicks)
- No Seat Rear Down Motion (Relay Clicks)
- No Seat Forward Motion (Relay Clicks)
- No Seat Rearward Motion (Relay Clicks)
- No Recliner Motion
- No Manual Recliner Motion (Moves In Recall Mode Only)
- No Manual Recliner Motion Forward (Moves In Recall Mode Only)
- No Recliner Movement Rearward (Moves In Recall Mode Only)
- No Recliner Movement In Recall (Recliner Moves Manually Without Stall Detection)
- No Movement In Recall (Seat Moves Manually Without Stall Detection)
- No Forward, Rearward, Front Vertical Or Rear Vertical Seat Track Motion (In Recall Mode)
- No Seat Track/Recliner Motion In Recall Mode (Will Move Manually Without Stall Detention)
- No Front Vertical Motion (In Recall Mode)
- No Forward/Rearward Motion (In Recall Mode)
- No Rear Upward/Downward Motion (In Recall Mode)
- No Forward Seat Motion (Moves Forward In Recall Mode Only)
- No Rearward Seat Motion (Moves Rearward In Recall Mode Only)
- No Front Downward Seat Motion (Moves Downward In Recall Mode Only)
- No Front Upward/Downward Motion (Moves Upward In Recall Mode Only)
- No Rear Downward Motion (Moves Downward In Recall Mode Only)
- No Rear Upward Motion (Moves Upward In Recall Mode Only)
- No Memory Recall/Set In "1" Set (Cannot Enter Self-Test)
- No Memory Recall/Set In "2" Set (Cannot Enter Self-Test)
- No "Set" In Either Memory Position (Only Previous Memory Recalled)
- Memory Recall/Set Can Be Set With Vehicle Moving & Belt Unbuckled
- No Memory Positions Recalled (Self-Test System Will Not Work)
- Steering Column Switches
- Window Motors & Regulators
- Wiper/Washer Systems
- Description
- Operation
- Adjustments
- Testing
- Notes
- Intermittent Wiper Motor Test
- Wipers Do Not Stop With Switch In Delay Position
- Wipers Do Not Work With Switch In "DELAY" Position
- Wipers Start, But Stop Before One Complete Cycle (Do Not Return To "PARK" Position)
- Excessive Delay (More Than 30 Seconds) Or Inadequate Variation In Delay
- Wipers Do Not Run Continually When Wash Control Is Operated During "DELAY" Mode
- In "Delay" Mode, Wipers Run Continually When Wash Is Operated, But Do Not Provide Extra Wipe When Wash Control Is Released
- Wipers Start Erratically During "DELAY" Mode
- Intermittent Wiper Switch Test
- Removal & Installation
- Wiring Diagrams
- Body & Frame
- Door Locks
- Headlight Doors - Automatic
- Mirrors - Power
- Description
- Operation
- Testing
- Removal & Installation
- Mirror Switch Replacement
- Removal & Installation (Acclaim & Spirit)
- Removal & Installation (Aries, Daytona, Reliant, Shadow & Sundance)
- Removal & Installation (Diplomat, Fifth Avenue & Gran Fury)
- Removal & Installation (Dynasty & New Yorker)
- Removal & Installation (LeBaron 2-Door & LeBaron Convertible)
- Removal & Installation (Lancer & LeBaron 4-Door)
- Power Mirror Assembly
- Mirror Switch Replacement
- Wiring Diagrams
- Seats
- Seats - Power
- Seats - Power W/Memory
- Description
- Operation
- Testing
- Removal & Installation
- Wiring Diagrams
- Trouble Shooting
- No System Operation
- No Recliner Motion Forward (Relay Clicks)
- No Recliner Motion Rearward (Relay Clicks)
- No Seat Front Up Motion (Relay Clicks)
- No Seat Front Down Motion (Relay Clicks)
- No Seat Rear Up Motion (Relay Clicks)
- No Seat Rear Down Motion (Relay Clicks)
- No Seat Forward Motion (Relay Clicks)
- No Seat Rearward Motion (Relay Clicks)
- No Recliner Motion
- No Manual Recliner Motion (Moves In Recall Mode Only)
- No Manual Recliner Motion Forward (Moves In Recall Mode Only)
- No Recliner Movement Rearward (Moves In Recall Mode Only)
- No Recliner Movement In Recall (Recliner Moves Manually Without Stall Detection)
- No Movement In Recall (Seat Moves Manually Without Stall Detection)
- No Forward, Rearward, Front Vertical Or Rear Vertical Seat Track Motion (In Recall Mode)
- No Seat Track/Recliner Motion In Recall Mode (Will Move Manually Without Stall Detention)
- No Front Vertical Motion (In Recall Mode)
- No Forward/Rearward Motion (In Recall Mode)
- No Rear Upward/Downward Motion (In Recall Mode)
- No Forward Seat Motion (Moves Forward In Recall Mode Only)
- No Rearward Seat Motion (Moves Rearward In Recall Mode Only)
- No Front Downward Seat Motion (Moves Downward In Recall Mode Only)
- No Front Upward/Downward Motion (Moves Upward In Recall Mode Only)
- No Rear Downward Motion (Moves Downward In Recall Mode Only)
- No Rear Upward Motion (Moves Upward In Recall Mode Only)
- No Memory Recall/Set In "1" Set (Cannot Enter Self-Test)
- No Memory Recall/Set In "2" Set (Cannot Enter Self-Test)
- No "Set" In Either Memory Position (Only Previous Memory Recalled)
- Memory Recall/Set Can Be Set With Vehicle Moving & Belt Unbuckled
- No Memory Positions Recalled (Self-Test System Will Not Work)
- Sun Roof/T-Top/Convertible Top
- Power Windows
- Brakes
- Anti-Lock Brakes
- Anti-Lock Brake System - BOSCH Abs-3
- Description
- Operation
- Bleeding Brake System
- Testing
- Fault Codes
- Trouble Shooting Charts
- Notes
- Codes 1-4 Wheel Circuit Valve
- Codes 5-10 Wheel Speed Sensor Circuits
- Code 11 Replenishing Valve
- Code 12 Valve Relay
- Codes 13: Excessive Displacement Or Circuit Failure; Codes 14: Piston Travel Switches; Codes 15: Brake Light Switch
- Code 16 ABCM Error
- Charts C, C-1, C-2, C-3 & C-4 Pump/Motor Circuit
- Charts D, E & F Red Brake Light Circuit
- Charts G, H & J System Power Circuit
- Symptom Diagnosis Chart
- Diagnosis & Testing
- Removal & Installation
- Wiring Diagrams
- Anti-Lock Brake System - BOSCH Abs-3
- Mechanical - Hydraulic
- Brake System Bleeding
- Disc & Drum
- Description
- Brake System Bleeding
- Adjustments
- Rotor Servicing
- Cleaning & Inspection
- Removal & Installation
- Brake Booster - Fwd Models
- Brake Booster - RWD Models
- Disc Brake Caliper & Pads - Front (Fwd Models)
- Disc Brake Caliper & Pads - Rear (DAYTONA & LEBARON)
- Disc Brake Caliper & Pads - Rear (Dynasty & New YORKER)
- Disc Brake Caliper & Pads - RWD Models
- Disc Brake Rotor - Front (Fwd Models)
- Disc Brake Rotor - RWD Models
- Drum Brake Shoe & Lining - Fwd Models
- Drum Brake Shoe & Lining - RWD Models
- Master Cylinder
- Rear Axle Seal & Bearings - RWD Models
- Overhaul
- Torque Specifications
- Brake System Specifications
- Traction Control
- Anti-Lock Brake System - BOSCH Abs-3
- Description
- Operation
- Bleeding Brake System
- Testing
- Fault Codes
- Trouble Shooting Charts
- Notes
- Codes 1-4 Wheel Circuit Valve
- Codes 5-10 Wheel Speed Sensor Circuits
- Code 11 Replenishing Valve
- Code 12 Valve Relay
- Codes 13: Excessive Displacement Or Circuit Failure; Codes 14: Piston Travel Switches; Codes 15: Brake Light Switch
- Code 16 ABCM Error
- Charts C, C-1, C-2, C-3 & C-4 Pump/Motor Circuit
- Charts D, E & F Red Brake Light Circuit
- Charts G, H & J System Power Circuit
- Symptom Diagnosis Chart
- Diagnosis & Testing
- Removal & Installation
- Wiring Diagrams
- Anti-Lock Brake System - BOSCH Abs-3
- Anti-Lock Brakes
- Drivelines & Axles
- Electrical
- Charging Systems
- Alternator - CHRYSLER & NIPPONDENSO
- Description
- Operation
- Trouble Shooting
- Testing & Diagnosis
- System Diagnosis
- On-Vehicle Tests
- Entering On-Board Diagnostics
- Diagnostic Testing
- Notes
- Charging Circuit Check For Fault Codes
- Check For Intermittent Failures
- Battery Temperature Sensor Calibration Check
- Checking for Fault Code 16
- Checking For Fault Codes 41-46 Or 46
- Checking Alternator Field Control To SMEC For Short Circuit
- Alternator Field Control From 14-Pin To 60-Pin Connector Check
- Checking For Fault Codes 41 Or 41-47
- Checking Alternator Field Control Circuit Of SMEC
- Checking Charging System Field Control Circuit
- Alternator Field Ckt Between Check 60-Pin & 14-Pin Connectors
- Checking For Voltage To Alternator Field Circuit
- Bench Tests
- Alternator & Regulator - BOSCH 90-Amp
- Alternator - CHRYSLER & NIPPONDENSO
- Component Locations
- Fuses & Circuit Breakers ("C" Body)
- Identification
- Fuse Panel Identification (1988-89 Models)
- Fuse & Circuit Breaker Identification (1988-89)
- 1 - 20 Amp (Yellow)
- 2 - 20 Amp (Yellow)
- 3 - 10 Amp (Red)
- 4 - 10 Amp (Red)
- 5 - 4 Amp (Pink)
- 6 - 20 Amp (Yellow)
- 7 - 20 Amp (Yellow)
- 8 - 5 Amp (Tan)
- 9 - 30 Amp (Circuit Breaker Silver Can)
- 10 - 30 Amp (Light Green)
- 11 - 20 Amp (Yellow)
- 12 - 20 Amp (Yellow)
- 13 - 20 Amp (Yellow)
- 14 - 20 Amp (Yellow)
- 15 - 30 Amp (Circuit Breaker)
- 16 - 20 Amp (Yellow)
- 17 - 10 Amp (Red)
- 18 - 20 Amp (Yellow)
- 19 - 20 Amp (Yellow)
- 20 - 10 Amp (Red)
- 21 - Relay(s)
- 22 - Relay
- Fuse Panel Identification (1990-93 Models)
- Fuse & Circuit Breaker Identification (1990-93)
- 1 - 20 Amp (Yellow)
- 2 - 20 Amp (Yellow)
- 3 - 10 Amp (Red)
- 4 - 10 Amp (Red)
- 5 - 4 Amp (Pink)
- 6 - 20 Amp (White)
- 7 - Empty (1993); 20 Amp (Yellow)
- 8 - 5 Amp (Tan)
- 9 - 10 Amp (Red)
- 10 - 30 Amp (Green)
- 11 - 10 Amp (Red)
- 12 - 20 Amp (Yellow - Except 1990); Empty (1990)
- 13 - 20 Amp (Yellow)
- 14 - 20 Amp (Yellow)
- 15 - 30 Amp (Circuit Breaker)
- 16 - 15 Amp (Lt. Blue) (1991-93); 20 Amp (Yellow) (1988-90)
- 17 - 10 Amp (Red)
- 18 - 20 Amp (Yellow)
- 19 - 20 Amp (Yellow)
- 20 - 10 Amp (Red)
- 21 - Relay
- 22 - Relay
- 23 - Relay
- 24 - Relay
- 25 - Circuit Breaker
- 26 - Hazard Warning Flasher
- 27 - Turn Signal Flasher
- Power Distribution Center (1990-93)
- Cautions & Warnings
- Identification
- Gauges
- Instrument Panel - Electronic
- Description
- Operation
- Adjustments
- Testing
- Self-Diagnostic Tests
- Electronic Instrument Cluster Diagnosis
- Displays Not Illuminated After Vehicle Starts
- Speedometer & Odometer Inoperative Or Intermittent Operation
- Oil, Fuel, Temperature Or Voltage Gauge Inoperative (Dynasty & New Yorker)
- Cluster Display Will Not Dim
- Tachometer Inoperative
- Washer, Door/Deck Or "CHECK ENGINE" Light Inoperative (Dynasty & New York)
- Odometer Is Blank (Dynasty & New Yorker)
- US/MET Mode Inoperable & Trip Odometer Will Not Reset (Dynasty & New Yorker)
- Electronic Navigator
- Navigator Diagnostic Functions
- Removal & Installation
- Wiring Diagrams
- Instrument Panel - Electronic
- Starter
- Wiring Diagrams
- Charging Systems
- Engine Mechanical
- Accessory Drive Belts
- Auxiliary Emission Control Systems
- Emission Control System Visual Inspection Procedures - General Information
- * Please Read This First *
- Emission Control Labels
- Emission Control Visual Inspection
- Notes
- Positive Crankcase Ventilation (PCV)
- Thermostatic Air Cleaner (TAC)
- Fuel Evaporative System (EVAP)
- Catalytic Converters
- Fill Pipe RESTRICTOR (Fr)
- Exhaust Gas RECIRCULATION (EGR) System
- Spark Controls (SPK)
- Air Injection System (AIS)
- Oxygen Sensor (O2)
- Computerized Engine Controls (CEC)
- Early Fuel Evaporation (EFE)
- Emission Maintenance Reminder Light (EMR) (If Equipped)
- Malfunction Indicator Light (Mil)
- Emission Control System Visual Inspection Procedures - General Information
- Engine Cooling Fan
- Cooling System (Mechanical)
- Mechanical
- 3.0L V6 - VIN [3]
- Engine Identification
- Adjustments
- Removal & Installation
- Overhaul
- Engine Oiling
- Engine Cooling
- Torque Specifications
- Engine Specifications
- Engine Oil Pan Removal
- Engine Removal - V6
- 3.0L V6 - VIN [3]
- Starter
- Timing Belt Replacement - 3.0L - SOHC
- Engine Performance
- Adjustment
- Application
- Emissions
- EGR Function Testing - CHRYSLER Cars
- Emission Applications - Domestic Cars
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Ignition System
- System
- 2.2L/2.5L SPFI Tests/Code
- Description
- Operation
- Air Conditioning Clutch Relay
- Auto Shutdown (ASD) Relay
- Automatic Idle Speed (AIS) Motor
- Canister Purge Solenoid
- Check Engine Light
- Coolant Temperature Sensor
- Schematic Of Computer, Input Sensors & Output Devices (SPFI)
- Distance (Speed) Sensor
- Limp-In Mode
- Location Of Diagnostic Connector
- Manifold Absolute Pressure (Map) Sensor
- Oxygen Sensor
- Single Module Engine Controller (SMEC)
- Throttle Body Temperature Sensor
- Throttle Position Sensor (TPS)
- Solenoid & Map Sensor Location
- Removal & Installation
- Testing & Diagnosis
- Diagnostic Trouble Code (DTC) Identification
- No Start Tests
- NS-1, Checking Spark & Fuel At Throttle Body
- NS-2, Checking Injector Flow & Fuel Control Faults
- NS-3, Checking SMEC, Wet Plugs & Timing
- NS-4, Checking IGN. Coil Driver, Open Circuits & SMEC
- NS-5, Checking Coil Primary & Coil
- NS-6, Checking Fuel Pressure, TPS & Circuits
- NS-7, Checking Injector Driver Circuits & Injectors
- NS-8, Checking INJ. Interface Fault & Control Circuit
- NS-9, Flooding Injector Check, CTRL. CKT. & Press. Regulator
- NS-10, Checking System Faults
- NS-11, SYS. Power, Ground, Map, SMEC & Distributor Pick-Up Check
- NS-12, Checking Distributor Pick-Up & Circuits
- NS-13, Checking ASD Relay & Pull In Coil Circuits
- NS-14, Power CKT. To Pull In Coil & ASD Relay Check
- NS-15, Power Feed CKTS. To ASD Relay & Relay Check
- NS-VER, Verification Of No Start
- DRIVEABILITY Tests
- Dr-1, Checking System For Faults
- Dr-2, Checking Output Circuits Of SMEC
- Dr-3, Intermittent Test For Solenoids & Relays
- Dr-4, Intermittent Test For Map Sensor Signal
- Dr-5, Intermittent Test For Sensor Voltages
- Dr-6, Intermittent Test For Injectors & AIS Motor
- Dr-7, Checking For Fault Message "Map Pneumatic Signal"
- Dr-8, Checking For Fault Message "Map Pneumatic Change"
- Dr-9, Checking For Fault Message "Map Voltage Low"
- Dr-10, Checking For Fault Message "Map Voltage Too High"
- Dr-11, Checking For Fault Message "Vehicle Speed Signal"
- Dr-12, Checking For Fault Message "Oxygen Sensor Signal"
- Dr-13, Checking For Fault Message "Coolant Voltage Low"
- Dr-14, Checking For Fault Message "Coolant Voltage High"
- Dr-15, Checking For Fault Message "T/B Temp. Voltage Low"
- Dr-16, Checking For Fault Message "T/B Temp. Voltage High"
- Dr-17, Checking For Fault Message "TPS Voltage Low"
- Dr-18, Checking For Fault Message "TPS Voltage High"
- Dr-19, For Fault Message "AIS Motor Circuits" Check
- Dr-20, Checking For Fault Message "Purge Solenoid Circuits"
- Dr-21, Checking For Fault Message "EGR Solenoid Circuit
- Dr-22, Fault Message "EGR System Failure" Check
- Dr-23, Checking For Fault Message "A/C Clutch Relay Circuit"
- Dr-24, Checking Radiator & A/C Fan Relays
- Dr-25, Checking For Fault Message "Radiator Fan Relay"
- Dr-26, Checking For Fault Message "PTU Solenoid Circuit"
- Dr-27, Checking For Fault Message "FJ2 Voltage Sense"
- Dr-28, Fault Message "EMR Mileage ACCUM & Ee Prom Write Denied" Check
- Dr-29, Checking Sensor Calibrations With Engine Cold
- Dr-30, Sensor Calibrations With Engine Warm (1 Of 3) Check
- Dr-31, EGR Valve With Engine Warm Check
- Dr-32, Checking Secondary Ignition System
- Dr-33, Checking Basic Timing & Fuel System
- Dr-34, Checking Oxygen Sensor
- Dr-35, Checking Throttle Body Minimum Airflow
- Dr-36 - Other Possible Causes Of DRIVEABILITY Related Problems
- DRIVEABILITY Verification Tests
- Speed Control System Tests
- Charging System Tests
- Wiring Diagrams
- 3.0L MPFI Tests W/Codes
- Description
- Operation
- Air Conditioning (A/C) Clutch Relay
- Auto Shutdown (ASD) Relay
- Automatic Idle Speed (AIS) Motor
- Canister Purge Solenoid
- Check Engine Light
- Coolant Temperature Sensor
- Distance (Speed) Sensor
- Limp-In Mode
- Manifold Absolute Pressure (Map) Sensor
- Oxygen Sensor
- Single Board Engine Controller (SBEC)
- Throttle Position Sensor (TPS)
- Removal & Installation
- Testing & Diagnosis
- Preliminary Checks
- System Diagnosis
- Diagnostic Procedure
- Entering On-Board Diagnostics
- Check Engine Light Diagnostic Mode
- DRB-II Diagnostic Mode
- DRB-II Switch Test Mode
- DRB-II Read Input States
- DRB-II Read Output States
- DRB-II Actuate Solenoids & Relays
- DRB-II Actuate Outputs
- DRB-II Read Sensor Voltages
- DRB-II Read Sensor Values
- DRB-II Set Engine RPM
- DRB-II Minimum Airflow Speed
- DRB-II Emissions EMR Tests
- DRB-II Read Module Information
- DRB-II Problems & Error Messages
- Clearing Codes
- Vehicle Security System Diagnosis
- Diagnostic Trouble Codes (DTC) Identification
- No Start Test
- NS-1 - Checking For Ignition Spark & Z1 Power
- NS-2 - Checking Fuel Pressure, Throttle Position Sensor & Power Supply To Injectors
- NS-3 - Checking For Wet Plugs, Valve & Ignition Timing
- NS-4 - Checking DRB-II, Z1 Power & Fuel Filter
- NS-5 - Checking For Defective Coil Or Control Circuitry
- NS-6 - Checking Injector Control Circuit & Controller
- NS-7 Checking DRB-II & System Faults
- NS-8 - Checking Power Supply, Map Sensor, Ground Circuit & Engine Controller
- NS-9 - Checking Control Circuits To Distributor Pick-Up, Distributor Pick-Up & Engine Controller
- NS-10 - Checking ASD Relay & Circuitry
- NS-11 - Checking ASD Relay & Z1 Circuitry
- NS-VER - No Start Verification
- DRIVEABILITY Test
- Dr-1 - Checking System For Faults
- Dr-2 - Checking Output Circuits Of SBEC
- Dr-2 - Checking Brake Switch Input Circuit To SBEC
- Dr-2 - Checking Switch Inputs To SBEC
- Dr-2 - Checking A/C Push Button Switch Input
- Dr-2 - Checking AIS Motor Operation
- Dr-2 - Checking For Defective Injectors
- Dr-2 - Checking SBEC Ground Circuits
- Dr-3 - Intermittent Test For Solenoids & Relays
- Dr-4 - Intermittent Test For Map Sensor Signal
- Dr-5 - Intermittent Test For Sensor Voltages
- Dr-6 - Intermittent Test For Injectors & AIS Motor
- Dr-7 - Intermittent Test For Distributor Sync Pick-Up
- Dr-8 - Checking For Fault Message "Map Pneumatic Signal" (DTC 13)
- Dr-9 - Checking For Fault Message "Map Pneumatic Change" (DTC 13)
- Dr-10 - Checking For Fault Message "Map Voltage Too Low" (DTC 14)
- Dr-11 - Checking For Fault Message "Map Voltage Too High" (DTC 14)
- Dr-12 - Checking For Fault Message "Vehicle Speed Signal" (DTC 15)
- Dr-13 - Checking For Fault Message "Oxygen Sensor Signal" (DTC 21)
- Dr-14 - Checking For Fault Message "Coolant Voltage Low" (DTC 22)
- Dr-15 - Checking For Fault Message "Coolant Voltage High" (DTC 22)
- Dr-16 - Checking For Fault Message "TPS Voltage Low" (DTC 24)
- Dr-17 - Checking For Fault Message "TPS Voltage High" (DTC 24)
- Dr-18 - Checking For Fault Message "AIS Motor Circuits" (DTC 25)
- DR-19 - CHECKING INJECTOR CONTROL CIRCUIT & INJECTOR PEAK CURRENT FAULTS (DTCs 26 & 27)
- DR-20 - CHECKING INJECTOR CONTROL CIRCUIT & INJECTOR PEAK CURRENT FAULTS (DTCs 26 & 27)
- DR-21 - CHECKING INJECTOR CONTROL CIRCUIT & INJECTOR PEAK CURRENT FAULTS (DTCs 26 & 27)
- Dr-22 - Checking For Fault Message "Purge Solenoid CKT" (DTC 31)
- Dr-23 - Checking For Fault Message "EGR Solenoid Circuit" (DTC 32)
- Dr-24 - Checking For Fault Message "EGR System Failure" (DTC 32)
- Dr-25 - Checking For Fault Message "A/C Clutch Relay CKT" (DTC 33)
- Dr-26 - Checking For Fault Message "A/C Clutch Relay CKT - A Body" (DTC 33)
- Dr-27 - Checking For Fault Message "Radiator Fan Relay" (DTC 35)
- Dr-28 - Checking For Fault Message "Sync Pick-Up Signal" (DTC 54)
- Dr-29 - Checking Sensor Calibrations (Cold Engine)
- Dr-29 - Checking Spark Plugs (Cold Engine)
- Dr-30 - Checking Sensor Calibrations (Warm Engine)
- Dr-31 - Checking EGR Valve Operation (Warm Engine)
- Dr-32 - Checking Secondary Ignition System
- Dr-33 - Checking Basic Timing & Fuel System
- Dr-34 - Checking O2 Sensor Operation
- Dr-35 - Checking Throttle Body Minimum Airflow
- Dr-36 - Other Possible Causes Of DRIVEABILITY Related Problems
- Verification Test
- Speed Control Test
- SP-1 - Checking Speed Control System For Fault Messages
- SP-2 - Checking For Fault Message "S/C Servo Solenoids" (DTC 34)
- SP-3 - Testing Speed Control Switch
- SP-4 - Testing Brake Switch Circuit
- SP-4 - Testing Park/Neutral Input
- SP-4 - Testing Servo Ground
- SP-4 - Servo Actuator Test
- SP-5 - Check On/Off Switch & Stalk Feed
- SP-6 - Testing "Resume" Switch
- Charging System Test
- Air Cleaner - Thermostatic
- Air Injection System
- BCC Tests W/O Codes
- Diagnosis & Testing
- Notes
- Diagnostic Test Procedure
- CCD Bus Testing
- Test 1: Id Vehicle Equip & SYS Problems
- Test 2: Repair Blank Message Screen On EVIC Head
- Test 3: Warning Messages
- Test 4: Brake Light Out
- Test 5: Right Upper Brake Light Out
- Test 6: Right Lower Brake Light Out
- Test 7: Left Upper Brake Light Out
- Test 8: Left Lower Brake Light Out
- Test 9: Coolant Level Low
- Test 10: Left Front Door Ajar
- Test 11: Engine Oil Level Low
- Test 12: Eng Temp Hi Or Eng Temp Critical
- Test 13: Exterior Lights On
- Test 14: Fasten Seat Belts
- Test 15: Right Headlight Out
- Test 16: Key In Ignition
- Test 17: Left Rear Door Ajar
- Test 18: Low Brake Fluid
- Test 19: Low Fuel Level
- Test 20: Low Oil Pressure
- Test 21: Headlight Out Message With No Headlights Out
- Test 22: Parking Brake Engaged
- Test 23: Passenger Door Ajar
- Test 24: Right Rear Door Ajar
- Test 25: Service Reminder
- Test 26: Taillight Out
- Test 27: Right Taillight Out
- Test 28: Left Taillight Out
- Test 29: Trunk Ajar
- Test 30: Voltage Improper
- Test 31: Washer Fluid Low
- Test 32: Turn Signal On
- Test 33: No Message On EVIC Head Monitor
- Test 34: Headlights Out With No Message
- Test 35: All Brake Lights Out
- Test 36: Right Or Left Side Brake Light Out
- Test 37: All Taillights Out
- Test 38: Check Air Suspension
- Test 39: EVIC Head Monitor Switch Test
- Test 40: Electronic Cluster Diagnosis
- Test 41: Fault Messages
- Test 42: Electronic Instrument Cluster Problems Not Covered By Fault Code
- Test 43: Identifying Faulty Gauge
- Test 44: Fuel Gauge Not Operating Correctly
- Test 45: Coolant Gauge Not Operating Correctly
- Test 46: Oil Pressure Gauge Not Operating Correctly
- Test 47: Voltage Gauge Not Operating Correctly
- Test 48: Determining Which Cluster Light Is Not Operating Correctly
- Test 49: Washer Fluid Low Light Operating Incorrectly
- Test 50: Door/Deck Light Operating Incorrectly
- Test 51: Check Engine Light Not Operating Properly
- Test 52: Brake Light Not Operating Correctly
- Test 53: Gauges Light Not Operating Correctly
- Test 54: Electronic Cluster Illumination Problem
- Test 55: Diagnosing Vehicle Theft Alarm Module
- Test 56: Diagnosing Vehicle Theft Alarm Module
- Test 57: Diagnosing Vehicle Theft Alarm Module
- Test 58: Theft Alarm Indicator Light
- Test 59: Diagnosing Vehicle Theft Alarm Ignition Input
- Test 60A: Diagnosing Trunk Key Cylinder Switch
- Test 60B: Diagnosing Horn Output Circuit
- Test 61: Vehicle Theft Alarm Module Driver's Door Ajar Switch Test
- Test 62: Vehicle Theft Alarm Module Passenger's Door Ajar Switch Test
- Test 63: Vehicle Theft Alarm Module Right Rear Door Ajar Switch Test
- Test 64: Vehicle Theft Alarm Module Left Rear Door Ajar Switch Test
- Test 65: Diagnosing Short To Ground On Door Ajar Circuit
- Test 66: Vehicle Theft Alarm Module Hood Ajar Switch
- Test 67: Vehicle Theft Alarm Module Power Door Lock
- Test 68: Vehicle Theft Alarm Module Power Door Unlock
- Test 69: Vehicle Theft Alarm Module Driver's Key Cylinder Switch Test
- Test 70: Vehicle Theft Alarm Module Passenger's Key Cylinder Switch Test
- Test 71: Vehicle Theft Alarm Module Ignition Sense Test
- Test 72: Diagnosing Short To Ground On Driver's Door Ajar Circuit
- Test 73: Diagnosing Short To Ground On Passenger's Door Ajar Circuit
- Test 74: Diagnosing Short To Ground On Right Rear Door Ajar Circuit
- Test 75: Diagnosing Short To Ground On Left Rear Door
- Test 76: Theft Alarm Driver's Door Ajar Switch Test With Incandescent Message Center
- Test 77: Theft Alarm Passenger's Door Ajar Switch Test With Incandescent Message Center
- Test 78: Theft Alarm Right Rear Door Ajar Switch Test With Incandescent Message Center
- Test 79: Theft Alarm Left Rear Door Ajar Switch Test With Incandescent Message Center
- Test 80: Theft Alarm Module Short To GND. SW. Test For Incandescent Message Center
- Test 81: Theft Alarm Module Door Key Cylinder Switch Shorted To Ground Test
- Test 82: Diagnosing Headlight Door System
- Test 83: Headlight Doors Will Not Open
- Test 84: Headlight Doors Will Not Close
- Test 85: Headlight Doors Do Not Open For Flash To Pass
- Test 86: Headlight Doors Do Not Operate By Headlight Switch
- Test 87: Diagnosing Automatic Door Lock System
- Test 88: Diagnosing Automatic Door Lock System
- Test 89: Diag Driver's Door Ajar Switch For Short To GRN
- Test 90: Diagnosing Passenger's Door Ajar Switch For Short To Ground
- Test 91: Diagnosing Left Rear Door Ajar Switch For Short To Ground
- Test 92: Diagnosing Right Rear Door Ajar Switch For Short To Ground
- Test 93: Diagnosing Faulty Door Ajar Message W/Incandescent Message Center
- Test 94: Diagnosing Driver's Door Ajar SW. For Short CKT. W/Incandescent Message Center
- Test 95: Diagnosing Passenger's Door Ajar SW. For Short CKT. W/Incandescent Message Center
- Test 96: Diagnosing Right Rear Door Ajar SW. For Short CKT. W/Incandescent Message Center
- Test 97: Diagnosing Left Rear Door Ajar SW. For Short CKT. W/Incandescent Message Center
- Test 98: Checking Intermittent Wiper Circuits In Body Controller & Power Feed
- Test 99: Checking Stalk Switch, Body Controller & Related Wiring
- Test 100: Checking Wiper Motor & Ground
- Test 101: Testing Illuminated Entry System
- Test 102: Testing Passenger's Door Illuminated Entry Switch For Open Circuit
- Test 103: Testing Courtesy Light & Door Jamb Switches
- Test 104: Testing Driver's Door Jamb Switch
- Test 105: Testing Left Rear Door Jamb Switch
- Test 106: Testing Right Rear Door Jamb Switch
- Test 107: Testing Passenger's Door Jamb Switch
- Test 108: Testing DRB-II For Proper Operation
- Test 109: Repairing DRB-II Failures
- Test 110: Checking CCD Bus Failure Messages Using DRB-II
- Test 111: Repair Bus System For Short To Battery
- Test 112: Repair Bus System For Short To 5 Volts
- Test 113: Repair Bus System For Short To Ground
- Test 114: Repair Bus System For Bus (+) & Bus (-) Shorted Together
- Test 115: Repair Bus System For No Response Message
- Test 116: Check For No Response At Body Controller
- Test 117: Check For No Response From Elect Cluster
- Test 118: Check For No Response From Engine Node
- Test 119: Check For No Response From EVIC Head
- Test 120: Check For No Response From Theft Alarm
- Test 121: Check For No Response From Eng Controller
- Test 122: Repair Bus SYS For Not Receiving Bus Messages
- Test 123: Check Eng Controller For Open Bus Message
- Test 124: Repairing Bus System For No Termination Messages
- Test 125: Repairing Bus System For Bias Level Too High Or Too Low Message
- Test 126: Repairing Bus System For Bias Level Too High Or Too Low Message
- Test 127: Headlights Will Not Turn Off
- Diagnosis & Testing
- Catalytic Converter
- EGR Function Testing
- EGR System
- Fuel Evaporation System
- Fuel Injection System - 2.5L Turbo
- Description
- Operation
- Trouble Shooting
- Testing & Diagnosis
- Removal & Installation
- Wiring Diagrams
- Fuel Injection System - 3.0L V6
- Description
- Operation
- Trouble Shooting
- Testing & Diagnosis
- Removal & Installation
- Wiring Diagrams
- PCV System
- Waveform (Injector) - 3.0L MFI VIN [3]
- 2.2L/2.5L SPFI Tests/Code
- Testing & Diagnosis
- 2.2L/2.5L SPFI Tests/Code
- Description
- Operation
- Air Conditioning Clutch Relay
- Auto Shutdown (ASD) Relay
- Automatic Idle Speed (AIS) Motor
- Canister Purge Solenoid
- Check Engine Light
- Coolant Temperature Sensor
- Schematic Of Computer, Input Sensors & Output Devices (SPFI)
- Distance (Speed) Sensor
- Limp-In Mode
- Location Of Diagnostic Connector
- Manifold Absolute Pressure (Map) Sensor
- Oxygen Sensor
- Single Module Engine Controller (SMEC)
- Throttle Body Temperature Sensor
- Throttle Position Sensor (TPS)
- Solenoid & Map Sensor Location
- Removal & Installation
- Testing & Diagnosis
- Diagnostic Trouble Code (DTC) Identification
- No Start Tests
- NS-1, Checking Spark & Fuel At Throttle Body
- NS-2, Checking Injector Flow & Fuel Control Faults
- NS-3, Checking SMEC, Wet Plugs & Timing
- NS-4, Checking IGN. Coil Driver, Open Circuits & SMEC
- NS-5, Checking Coil Primary & Coil
- NS-6, Checking Fuel Pressure, TPS & Circuits
- NS-7, Checking Injector Driver Circuits & Injectors
- NS-8, Checking INJ. Interface Fault & Control Circuit
- NS-9, Flooding Injector Check, CTRL. CKT. & Press. Regulator
- NS-10, Checking System Faults
- NS-11, SYS. Power, Ground, Map, SMEC & Distributor Pick-Up Check
- NS-12, Checking Distributor Pick-Up & Circuits
- NS-13, Checking ASD Relay & Pull In Coil Circuits
- NS-14, Power CKT. To Pull In Coil & ASD Relay Check
- NS-15, Power Feed CKTS. To ASD Relay & Relay Check
- NS-VER, Verification Of No Start
- DRIVEABILITY Tests
- Dr-1, Checking System For Faults
- Dr-2, Checking Output Circuits Of SMEC
- Dr-3, Intermittent Test For Solenoids & Relays
- Dr-4, Intermittent Test For Map Sensor Signal
- Dr-5, Intermittent Test For Sensor Voltages
- Dr-6, Intermittent Test For Injectors & AIS Motor
- Dr-7, Checking For Fault Message "Map Pneumatic Signal"
- Dr-8, Checking For Fault Message "Map Pneumatic Change"
- Dr-9, Checking For Fault Message "Map Voltage Low"
- Dr-10, Checking For Fault Message "Map Voltage Too High"
- Dr-11, Checking For Fault Message "Vehicle Speed Signal"
- Dr-12, Checking For Fault Message "Oxygen Sensor Signal"
- Dr-13, Checking For Fault Message "Coolant Voltage Low"
- Dr-14, Checking For Fault Message "Coolant Voltage High"
- Dr-15, Checking For Fault Message "T/B Temp. Voltage Low"
- Dr-16, Checking For Fault Message "T/B Temp. Voltage High"
- Dr-17, Checking For Fault Message "TPS Voltage Low"
- Dr-18, Checking For Fault Message "TPS Voltage High"
- Dr-19, For Fault Message "AIS Motor Circuits" Check
- Dr-20, Checking For Fault Message "Purge Solenoid Circuits"
- Dr-21, Checking For Fault Message "EGR Solenoid Circuit
- Dr-22, Fault Message "EGR System Failure" Check
- Dr-23, Checking For Fault Message "A/C Clutch Relay Circuit"
- Dr-24, Checking Radiator & A/C Fan Relays
- Dr-25, Checking For Fault Message "Radiator Fan Relay"
- Dr-26, Checking For Fault Message "PTU Solenoid Circuit"
- Dr-27, Checking For Fault Message "FJ2 Voltage Sense"
- Dr-28, Fault Message "EMR Mileage ACCUM & Ee Prom Write Denied" Check
- Dr-29, Checking Sensor Calibrations With Engine Cold
- Dr-30, Sensor Calibrations With Engine Warm (1 Of 3) Check
- Dr-31, EGR Valve With Engine Warm Check
- Dr-32, Checking Secondary Ignition System
- Dr-33, Checking Basic Timing & Fuel System
- Dr-34, Checking Oxygen Sensor
- Dr-35, Checking Throttle Body Minimum Airflow
- Dr-36 - Other Possible Causes Of DRIVEABILITY Related Problems
- DRIVEABILITY Verification Tests
- Speed Control System Tests
- Charging System Tests
- Wiring Diagrams
- 3.0L MPFI Tests W/Codes
- Description
- Operation
- Air Conditioning (A/C) Clutch Relay
- Auto Shutdown (ASD) Relay
- Automatic Idle Speed (AIS) Motor
- Canister Purge Solenoid
- Check Engine Light
- Coolant Temperature Sensor
- Distance (Speed) Sensor
- Limp-In Mode
- Manifold Absolute Pressure (Map) Sensor
- Oxygen Sensor
- Single Board Engine Controller (SBEC)
- Throttle Position Sensor (TPS)
- Removal & Installation
- Testing & Diagnosis
- Preliminary Checks
- System Diagnosis
- Diagnostic Procedure
- Entering On-Board Diagnostics
- Check Engine Light Diagnostic Mode
- DRB-II Diagnostic Mode
- DRB-II Switch Test Mode
- DRB-II Read Input States
- DRB-II Read Output States
- DRB-II Actuate Solenoids & Relays
- DRB-II Actuate Outputs
- DRB-II Read Sensor Voltages
- DRB-II Read Sensor Values
- DRB-II Set Engine RPM
- DRB-II Minimum Airflow Speed
- DRB-II Emissions EMR Tests
- DRB-II Read Module Information
- DRB-II Problems & Error Messages
- Clearing Codes
- Vehicle Security System Diagnosis
- Diagnostic Trouble Codes (DTC) Identification
- No Start Test
- NS-1 - Checking For Ignition Spark & Z1 Power
- NS-2 - Checking Fuel Pressure, Throttle Position Sensor & Power Supply To Injectors
- NS-3 - Checking For Wet Plugs, Valve & Ignition Timing
- NS-4 - Checking DRB-II, Z1 Power & Fuel Filter
- NS-5 - Checking For Defective Coil Or Control Circuitry
- NS-6 - Checking Injector Control Circuit & Controller
- NS-7 Checking DRB-II & System Faults
- NS-8 - Checking Power Supply, Map Sensor, Ground Circuit & Engine Controller
- NS-9 - Checking Control Circuits To Distributor Pick-Up, Distributor Pick-Up & Engine Controller
- NS-10 - Checking ASD Relay & Circuitry
- NS-11 - Checking ASD Relay & Z1 Circuitry
- NS-VER - No Start Verification
- DRIVEABILITY Test
- Dr-1 - Checking System For Faults
- Dr-2 - Checking Output Circuits Of SBEC
- Dr-2 - Checking Brake Switch Input Circuit To SBEC
- Dr-2 - Checking Switch Inputs To SBEC
- Dr-2 - Checking A/C Push Button Switch Input
- Dr-2 - Checking AIS Motor Operation
- Dr-2 - Checking For Defective Injectors
- Dr-2 - Checking SBEC Ground Circuits
- Dr-3 - Intermittent Test For Solenoids & Relays
- Dr-4 - Intermittent Test For Map Sensor Signal
- Dr-5 - Intermittent Test For Sensor Voltages
- Dr-6 - Intermittent Test For Injectors & AIS Motor
- Dr-7 - Intermittent Test For Distributor Sync Pick-Up
- Dr-8 - Checking For Fault Message "Map Pneumatic Signal" (DTC 13)
- Dr-9 - Checking For Fault Message "Map Pneumatic Change" (DTC 13)
- Dr-10 - Checking For Fault Message "Map Voltage Too Low" (DTC 14)
- Dr-11 - Checking For Fault Message "Map Voltage Too High" (DTC 14)
- Dr-12 - Checking For Fault Message "Vehicle Speed Signal" (DTC 15)
- Dr-13 - Checking For Fault Message "Oxygen Sensor Signal" (DTC 21)
- Dr-14 - Checking For Fault Message "Coolant Voltage Low" (DTC 22)
- Dr-15 - Checking For Fault Message "Coolant Voltage High" (DTC 22)
- Dr-16 - Checking For Fault Message "TPS Voltage Low" (DTC 24)
- Dr-17 - Checking For Fault Message "TPS Voltage High" (DTC 24)
- Dr-18 - Checking For Fault Message "AIS Motor Circuits" (DTC 25)
- DR-19 - CHECKING INJECTOR CONTROL CIRCUIT & INJECTOR PEAK CURRENT FAULTS (DTCs 26 & 27)
- DR-20 - CHECKING INJECTOR CONTROL CIRCUIT & INJECTOR PEAK CURRENT FAULTS (DTCs 26 & 27)
- DR-21 - CHECKING INJECTOR CONTROL CIRCUIT & INJECTOR PEAK CURRENT FAULTS (DTCs 26 & 27)
- Dr-22 - Checking For Fault Message "Purge Solenoid CKT" (DTC 31)
- Dr-23 - Checking For Fault Message "EGR Solenoid Circuit" (DTC 32)
- Dr-24 - Checking For Fault Message "EGR System Failure" (DTC 32)
- Dr-25 - Checking For Fault Message "A/C Clutch Relay CKT" (DTC 33)
- Dr-26 - Checking For Fault Message "A/C Clutch Relay CKT - A Body" (DTC 33)
- Dr-27 - Checking For Fault Message "Radiator Fan Relay" (DTC 35)
- Dr-28 - Checking For Fault Message "Sync Pick-Up Signal" (DTC 54)
- Dr-29 - Checking Sensor Calibrations (Cold Engine)
- Dr-29 - Checking Spark Plugs (Cold Engine)
- Dr-30 - Checking Sensor Calibrations (Warm Engine)
- Dr-31 - Checking EGR Valve Operation (Warm Engine)
- Dr-32 - Checking Secondary Ignition System
- Dr-33 - Checking Basic Timing & Fuel System
- Dr-34 - Checking O2 Sensor Operation
- Dr-35 - Checking Throttle Body Minimum Airflow
- Dr-36 - Other Possible Causes Of DRIVEABILITY Related Problems
- Verification Test
- Speed Control Test
- SP-1 - Checking Speed Control System For Fault Messages
- SP-2 - Checking For Fault Message "S/C Servo Solenoids" (DTC 34)
- SP-3 - Testing Speed Control Switch
- SP-4 - Testing Brake Switch Circuit
- SP-4 - Testing Park/Neutral Input
- SP-4 - Testing Servo Ground
- SP-4 - Servo Actuator Test
- SP-5 - Check On/Off Switch & Stalk Feed
- SP-6 - Testing "Resume" Switch
- Charging System Test
- Air Cleaner - Thermostatic
- Air Injection System
- BCC Tests W/O Codes
- Diagnosis & Testing
- Notes
- Diagnostic Test Procedure
- CCD Bus Testing
- Test 1: Id Vehicle Equip & SYS Problems
- Test 2: Repair Blank Message Screen On EVIC Head
- Test 3: Warning Messages
- Test 4: Brake Light Out
- Test 5: Right Upper Brake Light Out
- Test 6: Right Lower Brake Light Out
- Test 7: Left Upper Brake Light Out
- Test 8: Left Lower Brake Light Out
- Test 9: Coolant Level Low
- Test 10: Left Front Door Ajar
- Test 11: Engine Oil Level Low
- Test 12: Eng Temp Hi Or Eng Temp Critical
- Test 13: Exterior Lights On
- Test 14: Fasten Seat Belts
- Test 15: Right Headlight Out
- Test 16: Key In Ignition
- Test 17: Left Rear Door Ajar
- Test 18: Low Brake Fluid
- Test 19: Low Fuel Level
- Test 20: Low Oil Pressure
- Test 21: Headlight Out Message With No Headlights Out
- Test 22: Parking Brake Engaged
- Test 23: Passenger Door Ajar
- Test 24: Right Rear Door Ajar
- Test 25: Service Reminder
- Test 26: Taillight Out
- Test 27: Right Taillight Out
- Test 28: Left Taillight Out
- Test 29: Trunk Ajar
- Test 30: Voltage Improper
- Test 31: Washer Fluid Low
- Test 32: Turn Signal On
- Test 33: No Message On EVIC Head Monitor
- Test 34: Headlights Out With No Message
- Test 35: All Brake Lights Out
- Test 36: Right Or Left Side Brake Light Out
- Test 37: All Taillights Out
- Test 38: Check Air Suspension
- Test 39: EVIC Head Monitor Switch Test
- Test 40: Electronic Cluster Diagnosis
- Test 41: Fault Messages
- Test 42: Electronic Instrument Cluster Problems Not Covered By Fault Code
- Test 43: Identifying Faulty Gauge
- Test 44: Fuel Gauge Not Operating Correctly
- Test 45: Coolant Gauge Not Operating Correctly
- Test 46: Oil Pressure Gauge Not Operating Correctly
- Test 47: Voltage Gauge Not Operating Correctly
- Test 48: Determining Which Cluster Light Is Not Operating Correctly
- Test 49: Washer Fluid Low Light Operating Incorrectly
- Test 50: Door/Deck Light Operating Incorrectly
- Test 51: Check Engine Light Not Operating Properly
- Test 52: Brake Light Not Operating Correctly
- Test 53: Gauges Light Not Operating Correctly
- Test 54: Electronic Cluster Illumination Problem
- Test 55: Diagnosing Vehicle Theft Alarm Module
- Test 56: Diagnosing Vehicle Theft Alarm Module
- Test 57: Diagnosing Vehicle Theft Alarm Module
- Test 58: Theft Alarm Indicator Light
- Test 59: Diagnosing Vehicle Theft Alarm Ignition Input
- Test 60A: Diagnosing Trunk Key Cylinder Switch
- Test 60B: Diagnosing Horn Output Circuit
- Test 61: Vehicle Theft Alarm Module Driver's Door Ajar Switch Test
- Test 62: Vehicle Theft Alarm Module Passenger's Door Ajar Switch Test
- Test 63: Vehicle Theft Alarm Module Right Rear Door Ajar Switch Test
- Test 64: Vehicle Theft Alarm Module Left Rear Door Ajar Switch Test
- Test 65: Diagnosing Short To Ground On Door Ajar Circuit
- Test 66: Vehicle Theft Alarm Module Hood Ajar Switch
- Test 67: Vehicle Theft Alarm Module Power Door Lock
- Test 68: Vehicle Theft Alarm Module Power Door Unlock
- Test 69: Vehicle Theft Alarm Module Driver's Key Cylinder Switch Test
- Test 70: Vehicle Theft Alarm Module Passenger's Key Cylinder Switch Test
- Test 71: Vehicle Theft Alarm Module Ignition Sense Test
- Test 72: Diagnosing Short To Ground On Driver's Door Ajar Circuit
- Test 73: Diagnosing Short To Ground On Passenger's Door Ajar Circuit
- Test 74: Diagnosing Short To Ground On Right Rear Door Ajar Circuit
- Test 75: Diagnosing Short To Ground On Left Rear Door
- Test 76: Theft Alarm Driver's Door Ajar Switch Test With Incandescent Message Center
- Test 77: Theft Alarm Passenger's Door Ajar Switch Test With Incandescent Message Center
- Test 78: Theft Alarm Right Rear Door Ajar Switch Test With Incandescent Message Center
- Test 79: Theft Alarm Left Rear Door Ajar Switch Test With Incandescent Message Center
- Test 80: Theft Alarm Module Short To GND. SW. Test For Incandescent Message Center
- Test 81: Theft Alarm Module Door Key Cylinder Switch Shorted To Ground Test
- Test 82: Diagnosing Headlight Door System
- Test 83: Headlight Doors Will Not Open
- Test 84: Headlight Doors Will Not Close
- Test 85: Headlight Doors Do Not Open For Flash To Pass
- Test 86: Headlight Doors Do Not Operate By Headlight Switch
- Test 87: Diagnosing Automatic Door Lock System
- Test 88: Diagnosing Automatic Door Lock System
- Test 89: Diag Driver's Door Ajar Switch For Short To GRN
- Test 90: Diagnosing Passenger's Door Ajar Switch For Short To Ground
- Test 91: Diagnosing Left Rear Door Ajar Switch For Short To Ground
- Test 92: Diagnosing Right Rear Door Ajar Switch For Short To Ground
- Test 93: Diagnosing Faulty Door Ajar Message W/Incandescent Message Center
- Test 94: Diagnosing Driver's Door Ajar SW. For Short CKT. W/Incandescent Message Center
- Test 95: Diagnosing Passenger's Door Ajar SW. For Short CKT. W/Incandescent Message Center
- Test 96: Diagnosing Right Rear Door Ajar SW. For Short CKT. W/Incandescent Message Center
- Test 97: Diagnosing Left Rear Door Ajar SW. For Short CKT. W/Incandescent Message Center
- Test 98: Checking Intermittent Wiper Circuits In Body Controller & Power Feed
- Test 99: Checking Stalk Switch, Body Controller & Related Wiring
- Test 100: Checking Wiper Motor & Ground
- Test 101: Testing Illuminated Entry System
- Test 102: Testing Passenger's Door Illuminated Entry Switch For Open Circuit
- Test 103: Testing Courtesy Light & Door Jamb Switches
- Test 104: Testing Driver's Door Jamb Switch
- Test 105: Testing Left Rear Door Jamb Switch
- Test 106: Testing Right Rear Door Jamb Switch
- Test 107: Testing Passenger's Door Jamb Switch
- Test 108: Testing DRB-II For Proper Operation
- Test 109: Repairing DRB-II Failures
- Test 110: Checking CCD Bus Failure Messages Using DRB-II
- Test 111: Repair Bus System For Short To Battery
- Test 112: Repair Bus System For Short To 5 Volts
- Test 113: Repair Bus System For Short To Ground
- Test 114: Repair Bus System For Bus (+) & Bus (-) Shorted Together
- Test 115: Repair Bus System For No Response Message
- Test 116: Check For No Response At Body Controller
- Test 117: Check For No Response From Elect Cluster
- Test 118: Check For No Response From Engine Node
- Test 119: Check For No Response From EVIC Head
- Test 120: Check For No Response From Theft Alarm
- Test 121: Check For No Response From Eng Controller
- Test 122: Repair Bus SYS For Not Receiving Bus Messages
- Test 123: Check Eng Controller For Open Bus Message
- Test 124: Repairing Bus System For No Termination Messages
- Test 125: Repairing Bus System For Bias Level Too High Or Too Low Message
- Test 126: Repairing Bus System For Bias Level Too High Or Too Low Message
- Test 127: Headlights Will Not Turn Off
- Diagnosis & Testing
- Catalytic Converter
- EGR Function Testing
- EGR System
- Fuel Evaporation System
- Fuel Injection System - 2.5L Turbo
- Description
- Operation
- Trouble Shooting
- Testing & Diagnosis
- Removal & Installation
- Wiring Diagrams
- Fuel Injection System - 3.0L V6
- Description
- Operation
- Trouble Shooting
- Testing & Diagnosis
- Removal & Installation
- Wiring Diagrams
- PCV System
- Waveform (Injector) - 3.0L MFI VIN [3]
- 2.2L/2.5L SPFI Tests/Code
- Theory and Operation
- Tune-Up
- Vacuum Diagrams
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- Computer Relearn Procedures
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Identification
- Metric Conversions
- Maintenance Reminder Light (Reset Procedures)
- Emissions Maintenance Reminder (EGR)
- Emissions Maintenance Reminder (EMR Mileage)
- Emissions Maintenance Reminder (MAINT REQD Or Check EGR)
- Emissions Maintenance Reminder (Sri)
- Engine Oil Replacement Reminder
- Maintenance Service Reminder (ASSYST Maintenance Computer)
- Maintenance Service Reminder (Perform Service)
- Maintenance Service Reminder (Service Reminder Indicator)
- Maintenance Service Reminder (Service Reminder Message)
- Tire Pressure Monitor System Reminder
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- General Servicing
- A/C Compressor Oil Checking
- Isolating Compressor
- Refrigerant Oil
- Discharging System
- Disconnecting Lines & Fittings
- Connecting Lines And Fittings
- Placing System In Operation
- CHRYSLER C-171 & A-590 Oil Checking Information
- CHRYSLER C-171 & A-590 Compressor Oil Checking
- NIPPONDENSO/CHRYSLER 6C-17 Compressor Oil Checking
- Oil Checking During System Discharging
- Oil Checking During Compressor Replacement
- Oil Checking During Component Replacement
- If Leak Is Suspected Or Components Are Removed From System
- Compressor Failure & System Contaminated
- A/C Compressor Servicing
- A/C System General Servicing
- Using R-12 Refrigerant
- Sight Glass Indicators
- System Service Valves
- Use Manifold Gauge Set
- Pressure Gauge Indications
- Notes
- Excessive Moisture
- Defective Thermostatic Switch
- MISADJUSTED Thermostatic Switch Or Defective Clutch Cycling Switch
- Low R-12 Charge
- Very Low R-12 Charge
- Orifice Tube Plugged
- Expansion Or "H" Valve Stuck Closed
- Expansion Or "H" Valve Stuck Open
- Compressor Malfunction
- Condenser Malfunction Or R-12 Overcharge
- Discharging A/C System
- Flushing A/C System
- Evacuating A/C System
- Charging A/C System
- Leak Testing
- R-12 & Oil Capacity Table
- A/C System Precautions
- Before Opening The System
- Discharging A/C System
- Disconnecting Lines & Fittings
- Component Replacement
- Using R-12 Refrigerant - Safety Precautions
- Using Individual R-12 Cans
- Multi-Can Dispensing Valves
- Can Tap Installation Flat Type Seal Cans
- Screw Type Seal Cans
- Connecting Lines & Fittings
- Placing System In Operation
- Compressor Removal Information - Isolation Method
- Compressor Removal Information - Discharge Method
- A/C Compressor Oil Checking
- HVAC Control Systems
- A/C-Heater System - Automatic
- Description
- Operation
- Testing
- Entering Self-Test & Diagnostic Mode
- Non-Computer Aided Diagnostics
- Computer Display Does Not Dim With Headlights On
- Computer Does Not Return To Set Temperature After Vehicle Is Shut Off And Restarted, Computer Repeatedly Displays A Test Complete Display
- Push Buttons Stick, Do Not Function Properly, Or Panel Display Figures Are Partly Illuminated
- Insufficient Cooling Or Heating With No Failure Code
- Blower Motor Operates At High Speed Only And Cannot Be Controlled With Blower Speed Selector Switch, No Failure Code Displayed
- Pre-Computer Aided Diagnostics
- Computer Aided Diagnostics
- Preliminary Test Steps & Failure Code Information
- Failure Codes Involving PVM
- Failure Codes No. 1, 2 Or 3 Test
- Failure Code No. 4 Test
- Failure Code No. 5 Test
- Failure Code No. 6 Test
- Failure Code No. 7 Test
- Failure Code No. 8 Test
- Failure Code No. 9 Test
- Failure Code No. 10 Test
- Failure Code No. 11 Test
- Failure Codes No. 12 & 13 Test
- Failure Code No. 14 Test
- Failure Code No. 15 Test
- Failure Codes No. 16, 17 & 18 Test
- Removal & Installation
- Vacuum Hose Diagram(S)
- Wiring Diagrams
- A/C-Heater System - Manual
- * Please Read This First*
- CHRYSLER Body Code Designations
- Description
- Operation
- Adjustments
- Trouble Shooting
- Testing
- Removal & Installation
- Vacuum Hose Diagram(S)
- Wiring Diagrams
- A/C-Heater System Trouble Shooting - Manual
- Heater System
- Heater System Trouble Shooting
- A/C-Heater System - Automatic
- General Servicing
- Maintenance
- Procedures
- Interference Verification Check For OHC Engine
- Maintenance Information ("C" Body)
- Maintenance Reminder Light (Reset Procedures)
- Emissions Maintenance Reminder (EGR)
- Emissions Maintenance Reminder (EMR Mileage)
- Emissions Maintenance Reminder (MAINT REQD Or Check EGR)
- Emissions Maintenance Reminder (Sri)
- Engine Oil Replacement Reminder
- Maintenance Service Reminder (ASSYST Maintenance Computer)
- Maintenance Service Reminder (Perform Service)
- Maintenance Service Reminder (Service Reminder Indicator)
- Maintenance Service Reminder (Service Reminder Message)
- Tire Pressure Monitor System Reminder
- Service Indicator & Warning Lights ("C" Body)
- Procedures
- Steering
- Manual Steering
- Power Steering
- Steering Column
- Steering Linkage
- Suspension
- Electronic Suspension
- Front Suspension
- Rear Suspension
- Wheel Alignment
- Transmission
- Automatic Trans
- Diagnosis - A-604
- Description
- Operation
- System Testing
- Trouble Code Charts
- Notes
- Test 1
- Test 2
- Test 3
- Hard Fault Code Directory
- Test 5
- Test 6
- Test 7
- Test 8
- Test 9
- Test 10
- Test 11
- Test 12
- Test 13
- Test 14
- Test 15
- Test 16
- Test 17
- Test 18
- Test 19
- Test 20
- Test 21
- Test 22
- Test 23
- Test 24
- Test 25
- Test 26
- Test 27
- Test 28
- Test 29
- Test 30
- Test 31
- Test 32
- Test 33
- Test 34
- Test 35
- Test 36
- Test 37
- Test 38
- Test 39
- Test 40
- Test 41
- Test 42
- Test 43
- Test 44
- Test 46
- Test 47
- Test 48
- Test 49
- Test 50
- Repair Verification Test Procedure
- Wiring Diagrams
- Overhaul - A-604/41TE & 41AE
- Application
- Identification
- Description
- Operation
- Shift Quality Quick-Learn Procedure
- Pinion Factor Procedure
- Lubrication & Adjustments
- On-Vehicle Service
- Trouble Shooting
- Notes
- Buzzing Noise
- Buzzing Noise During Transaxle Shifts
- Delayed Engagement From Neutral To Drive
- Delayed Engagement From Neutral To Reverse
- Grating, Scraping Or Growling Noise
- Hard To Fill With Fluid Or Fluid Blows Out Filler Tube
- Harsh Downshifts
- Harsh Engagement From Neutral To Drive
- Harsh Engagement From Neutral To Reverse
- Harsh Torque Converter Lock-Up
- Harsh Upshift
- High Shift Efforts
- No Torque Converter Lock-Up
- No Upshift Into Overdrive
- Poor Shift Quality
- Shifts Erratically
- Transaxle Overheats
- Vehicle Drags Or Locks
- Vehicle Moves In Neutral
- Testing - Non-Electronic
- Removal & Installation
- Torque Converter
- Transaxle Disassembly
- Component Disassembly & Reassembly
- Bearing Adjustments
- Transaxle Reassembly
- Torque Specifications
- Transaxle Specifications
- Wiring Diagrams
- Removal & Installation - A/T
- Servicing - A/T
- Transmission Oil Pan Gasket Id
- Diagnosis - A-604
- Clutches
- Hydraulic Diagrams - A604
- Automatic Trans
- External Pages
