Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups
Electrical Component Locations
Fluids
Technical Bulletins
Tire Fitment
Wiring Diagrams
- Accessories & Equipment
- Anti-Theft Systems
- Cruise Control Systems
- Description
- Operation
- Adjustments
- Testing
- Trouble Shooting
- No Cruise Control When Set/DECEL Button Is Pressed
- No Resume When Resume/ACCEL Button Is Pressed
- Cruise Control Does Not Disengage With Pedal Depressed
- Cruise Control Engages Without Actuating Speed Set Button
- Engine Does Not Return To Normal Idle
- Erratic Speed Or Engine Shuts Off
- Speed Setting After Lock-In Is Too High Or Too Low
- Unit Disengages On Rough Road
- Cruise Control Engages When Engine Is Started
- Removal & Installation
- Diagnostic Charts
- Notes
- SP-1: Checking DRB II Operation & Reading Faults
- SP-2: Repairing Fault "S/C Servo Solenoids"
- SP-3: Repairing Fault "Vehicle Speed Signal"
- SP-4: Checking Switch Input
- SP-5: Testing On/Off Switch
- SP-6: Testing On/Off Switch Minivan & Truck
- SP-7: Testing Resume Switch
- SP-8: Testing Resume Switch Minivan & Truck
- SP-9: Testing Set Switch
- SP-10: Testing Set Switch Minivan & Truck
- SP-11: Testing Brake Switch Input
- SP-12: Testing Park/Neutral Switch Input
- SP-13: Checking Servo Electrical Circuits
- SP-14: Speed Control Performance Check
- SP-VER: Speed Control Verification Check
- Wiring Diagrams
- Gauges & Instrument Panels
- Instrument Panel - Electronic
- Description
- Operation
- Diagnosis
- Notes
- Instrument Panel - Electronic
- Displays Not Illuminated After Vehicle Starts
- Instrument Cluster Asterisk (*) Flashes & Incorrect Data Display Exists
- Speedometer & Odometer Inoperative Or Operates Intermittently
- Oil, Fuel, Temperature Or Volt Gauge Inoperative
- Instrument Cluster Will Not Dim With Headlights On And Rheostat Rotated
- Seat Belt Warning Light Inoperative
- Low Washer Fluid, Door/Deck Or Check Engine Warning Light Inoperative
- Odometer Display Is Blank
- US/MET Modes Will Not Change Or Trip Odometer Will Not Reset
- Testing
- Removal & Installation
- Wiring Diagrams
- Instrument Panel - Standard
- Description & Operation
- Trouble Shooting
- Testing
- Notes
- Air Bag Warning System
- "Check Engine" Warning System
- Brake System Warning Light
- Fuel Gauge Circuit Test
- Low Oil Pressure Warning Light
- Combination Oil Sending Unit
- Oil Pressure Gauge Circuit Test
- Distance Sensor
- Speedometer Circuit Test
- Temperature Gauge Circuit Test
- Voltmeter Circuit Test
- Sending Units (Fuel Tank, Temperature & Oil Pressure)
- Removal & Installation
- Wiring Diagrams
- Instrument Panel - Electronic
- Headlights
- Heated Glass/Defoggers
- Infotainment
- Mirrors - Power
- Seats - Power
- Steering Column Switches
- Identification
- Description & Operation
- Trouble Shooting
- System Tests
- Component Tests
- Removal & Installation
- Notes
- Cruise Control Switch
- Dual-Function Switch
- Ignition Switch & Key Cylinder
- Notes
- Removal (AA, AP, & AL Models With Non-Tilt Column)
- Installation (AA, AP, & AL Models With Non-Tilt Column)
- Removal (AC, AG, AJ, & AY Models With Non-Tilt Or Tilt Column, AA & AP Models With Tilt Column)
- Installation (AC, AG, AJ, & AY Models With Non-Tilt Or Tilt Column, AA & AP Models With Tilt Column)
- Multi-Function Switch
- Remote Turn Signal Switch
- Turn Signal/Hazard Warning Switch
- Torque Specifications
- Wiring Diagrams
- Window Motors & Regulators
- Wiper/Washer Systems
- Body & Frame
- Door Locks
- Headlight Doors - Automatic
- Mirrors - Power
- Seats - Power
- Sun Roof/T-Top/Convertible Top
- Power Windows
- Brakes
- Anti-Lock Brakes
- Anti-Lock Brake System
- Description
- Operation
- Bleeding Brake System
- System Precautions
- Diagnosis & Testing
- Code Charts
- Notes
- Test 1A: Reading Fault Messages
- Test 2A: Cab Fault
- Test 3A: Modulator Fault
- Test 3B: Modulator Fault
- Test 3C: Modulator Fault
- Test 3D: Modulator Fault
- Test 3E: Modulator Fault
- Test 3F: Modulator Fault
- Test 3G: Modulator Fault
- Test 3H: Modulator Fault
- Test 3J: Modulator Fault
- Test 3K: Modulator Fault
- Test 3L: Modulator Fault
- Test 4A: Solenoid UNDERVOLTAGE Fault
- Test 4B: Solenoid UNDERVOLTAGE Fault
- Test 5A: Low Fluid/Parking Brake Fault
- Test 5B: Low Fluid/Parking Brake Fault
- Test 5C: Low Fluid/Parking Brake Fault
- Test 5D: Low Fluid/Parking Brake Fault
- Test 5E: Low Fluid/Parking Brake Fault
- Test 5F: Low Fluid/Parking Brake Fault
- Test 6A: System Relay Fault
- Test 7A: Low Accumulator Fault
- Test 8A: Boost Pressure Fault
- Test 8B: Boost Pressure Fault
- Test 8C: Boost Pressure Fault
- Test 8D: Boost Pressure Fault
- Test 9A: RR Wheel Speed Sensor Fault
- Test 9B: RR Wheel Speed Sensor Fault
- Test 9C: RR Wheel Speed Sensor Fault
- Test 9D: RR Wheel Speed Sensor Fault
- Test 9E: RR Wheel Speed Sensor Fault
- Test 9F: RR Wheel Speed Sensor Fault
- Test 9G: RR Wheel Speed Sensor Fault
- Test 9H: RR Wheel Speed Sensor Fault
- Test 9J: RR Wheel Speed Sensor Fault
- Test 9K: RR Wheel Speed Sensor Fault
- Test 9L: RR Wheel Speed Sensor Fault
- Test 9M: RR Wheel Speed Sensor Fault
- Test 9N: RR Wheel Speed Sensor Fault
- Test 10A: LR Wheel Speed Sensor Fault
- Test 10B: LR Wheel Speed Sensor Fault
- Test 10C: LR Wheel Speed Sensor Fault
- Test 10D: LR Wheel Speed Sensor Fault
- Test 10E: LR Wheel Speed Sensor Fault
- Test 10F: LR Wheel Speed Sensor Fault
- Test 10G: LR Wheel Speed Sensor Fault
- Test 10H: LR Wheel Speed Sensor Fault
- Test 10J: LR Wheel Speed Sensor Fault
- Test 10K: LR Wheel Speed Sensor Fault
- Test 10L: LR Wheel Speed Sensor Fault
- Test 10M: LR Wheel Speed Sensor Fault
- Test 10N: LR Wheel Speed Sensor Fault
- Test 11A: RF Wheel Speed Sensor Fault
- Test 12A: LF Wheel Speed Sensor Fault
- Test 13A: RR Wheel Speed Sensor Fault
- Test 14A: LR Wheel Speed Sensor Fault
- Test 15A: RF Wheel Speed Sensor Fault
- Test 16A: LF Wheel Speed Sensor Fault
- Test 17A: Primary Pressure/Delta Pressure Fault
- Test 17B: Primary Pressure/Delta Pressure Fault
- Test 17C: Primary Pressure/Delta Pressure Fault
- Test 17D: Primary Pressure/Delta Pressure Fault
- Test 17E: Primary Pressure/Delta Pressure Fault
- Test 18A: Anti-Lock Light Fault
- Test 18B: Anti-Lock Light Fault
- Test 19A: Anti-Lock Light Relay Fault
- Test 19B: Anti-Lock Light Relay Fault
- Test 20A: Excess Decay Fault
- Test 21A: Hydraulic Pump/Motor Circuit Test
- Test 21B: Hydraulic Pump/Motor Circuit Test
- Test 21C: Hydraulic Pump/Motor Circuit Test
- Test 21D: Hydraulic Pump/Motor Circuit Test
- Test 21E: Hydraulic Pump/Motor Circuit Test
- Test 21F: Hydraulic Pump/Motor Circuit Test
- Test 22A: Hydraulic Pressure Performance Test
- Test 22B: Hydraulic Pressure Performance Test
- Test 23A: Stoplight Switch Input Test
- Test VER-1: System Verification Test
- Removal & Installation
- Adjustments
- Torque Specifications
- Wiring Diagrams
- Anti-Lock Brake System - BOSCH Abs-3
- Description
- Operation
- Bleeding Brake System
- Testing
- Fault Codes
- Trouble Shooting Charts
- Notes
- Codes 1-4 Wheel Circuit Valve
- Codes 5-10 Wheel Speed Sensor Circuits
- Code 11 Replenishing Valve
- Code 12 Valve Relay
- Codes 13: Excessive Displacement Or Circuit Failure; Codes 14: Piston Travel Switches; Codes 15: Brake Light Switch
- Code 16 ABCM Error
- Charts C, C-1, C-2, C-3 & C-4 Pump/Motor Circuit
- Charts D, E & F Red Brake Light Circuit
- Charts G, H & J System Power Circuit
- Symptom Diagnosis Chart
- Diagnosis & Testing
- Removal & Installation
- Wiring Diagrams
- Anti-Lock Brake System
- Mechanical - Hydraulic
- Brake System Bleeding
- Disc & Drum
- Description
- Brake System Bleeding
- Adjustments
- Brake Booster Push Rod
- Disc Brakes
- Drum Brake Shoes - MONACO & Premier
- Drum Brake Shoes - Except MONACO & Premier
- Parking Brake - W/Rear Disc Brakes
- Parking Brake - W/Drum Brakes (MONACO & Premier)
- Parking Brake - W/Drum Brakes (Except MONACO & Premier)
- Stoplight Switch - Horizon & Omni
- Stoplight Switch - All Other Models
- Rear Wheel Bearings
- Rotor Servicing
- Cleaning & Inspection
- Removal & Installation
- Brake Booster
- Disc Brake Caliper & Pads - Front
- Disc Brake Caliper & Pads - Rear (Dynasty, Fifth Avenue, Imperial & New YORKER)
- Disc Brake Caliper & Pads - Rear (DAYTONA & LEBARON)
- Disc Brake Caliper & Pads - Rear (MONACO & Premier)
- Disc Brake Rotor - Front
- Drum Brake Shoes - Except MONACO & Premier
- Drum Brake Shoes - MONACO & Premier
- Master Cylinder
- Overhaul
- Torque Specifications
- Brake System Specifications
- Traction Control
- Anti-Lock Brake System
- Description
- Operation
- Bleeding Brake System
- System Precautions
- Diagnosis & Testing
- Code Charts
- Notes
- Test 1A: Reading Fault Messages
- Test 2A: Cab Fault
- Test 3A: Modulator Fault
- Test 3B: Modulator Fault
- Test 3C: Modulator Fault
- Test 3D: Modulator Fault
- Test 3E: Modulator Fault
- Test 3F: Modulator Fault
- Test 3G: Modulator Fault
- Test 3H: Modulator Fault
- Test 3J: Modulator Fault
- Test 3K: Modulator Fault
- Test 3L: Modulator Fault
- Test 4A: Solenoid UNDERVOLTAGE Fault
- Test 4B: Solenoid UNDERVOLTAGE Fault
- Test 5A: Low Fluid/Parking Brake Fault
- Test 5B: Low Fluid/Parking Brake Fault
- Test 5C: Low Fluid/Parking Brake Fault
- Test 5D: Low Fluid/Parking Brake Fault
- Test 5E: Low Fluid/Parking Brake Fault
- Test 5F: Low Fluid/Parking Brake Fault
- Test 6A: System Relay Fault
- Test 7A: Low Accumulator Fault
- Test 8A: Boost Pressure Fault
- Test 8B: Boost Pressure Fault
- Test 8C: Boost Pressure Fault
- Test 8D: Boost Pressure Fault
- Test 9A: RR Wheel Speed Sensor Fault
- Test 9B: RR Wheel Speed Sensor Fault
- Test 9C: RR Wheel Speed Sensor Fault
- Test 9D: RR Wheel Speed Sensor Fault
- Test 9E: RR Wheel Speed Sensor Fault
- Test 9F: RR Wheel Speed Sensor Fault
- Test 9G: RR Wheel Speed Sensor Fault
- Test 9H: RR Wheel Speed Sensor Fault
- Test 9J: RR Wheel Speed Sensor Fault
- Test 9K: RR Wheel Speed Sensor Fault
- Test 9L: RR Wheel Speed Sensor Fault
- Test 9M: RR Wheel Speed Sensor Fault
- Test 9N: RR Wheel Speed Sensor Fault
- Test 10A: LR Wheel Speed Sensor Fault
- Test 10B: LR Wheel Speed Sensor Fault
- Test 10C: LR Wheel Speed Sensor Fault
- Test 10D: LR Wheel Speed Sensor Fault
- Test 10E: LR Wheel Speed Sensor Fault
- Test 10F: LR Wheel Speed Sensor Fault
- Test 10G: LR Wheel Speed Sensor Fault
- Test 10H: LR Wheel Speed Sensor Fault
- Test 10J: LR Wheel Speed Sensor Fault
- Test 10K: LR Wheel Speed Sensor Fault
- Test 10L: LR Wheel Speed Sensor Fault
- Test 10M: LR Wheel Speed Sensor Fault
- Test 10N: LR Wheel Speed Sensor Fault
- Test 11A: RF Wheel Speed Sensor Fault
- Test 12A: LF Wheel Speed Sensor Fault
- Test 13A: RR Wheel Speed Sensor Fault
- Test 14A: LR Wheel Speed Sensor Fault
- Test 15A: RF Wheel Speed Sensor Fault
- Test 16A: LF Wheel Speed Sensor Fault
- Test 17A: Primary Pressure/Delta Pressure Fault
- Test 17B: Primary Pressure/Delta Pressure Fault
- Test 17C: Primary Pressure/Delta Pressure Fault
- Test 17D: Primary Pressure/Delta Pressure Fault
- Test 17E: Primary Pressure/Delta Pressure Fault
- Test 18A: Anti-Lock Light Fault
- Test 18B: Anti-Lock Light Fault
- Test 19A: Anti-Lock Light Relay Fault
- Test 19B: Anti-Lock Light Relay Fault
- Test 20A: Excess Decay Fault
- Test 21A: Hydraulic Pump/Motor Circuit Test
- Test 21B: Hydraulic Pump/Motor Circuit Test
- Test 21C: Hydraulic Pump/Motor Circuit Test
- Test 21D: Hydraulic Pump/Motor Circuit Test
- Test 21E: Hydraulic Pump/Motor Circuit Test
- Test 21F: Hydraulic Pump/Motor Circuit Test
- Test 22A: Hydraulic Pressure Performance Test
- Test 22B: Hydraulic Pressure Performance Test
- Test 23A: Stoplight Switch Input Test
- Test VER-1: System Verification Test
- Removal & Installation
- Adjustments
- Torque Specifications
- Wiring Diagrams
- Anti-Lock Brake System - BOSCH Abs-3
- Description
- Operation
- Bleeding Brake System
- Testing
- Fault Codes
- Trouble Shooting Charts
- Notes
- Codes 1-4 Wheel Circuit Valve
- Codes 5-10 Wheel Speed Sensor Circuits
- Code 11 Replenishing Valve
- Code 12 Valve Relay
- Codes 13: Excessive Displacement Or Circuit Failure; Codes 14: Piston Travel Switches; Codes 15: Brake Light Switch
- Code 16 ABCM Error
- Charts C, C-1, C-2, C-3 & C-4 Pump/Motor Circuit
- Charts D, E & F Red Brake Light Circuit
- Charts G, H & J System Power Circuit
- Symptom Diagnosis Chart
- Diagnosis & Testing
- Removal & Installation
- Wiring Diagrams
- Anti-Lock Brake System
- Anti-Lock Brakes
- Drivelines & Axles
- Axle Shafts - Front
- Description & Identification
- Lubrication
- Hub Bearings Service (In-Vehicle)
- Axle Shafts Service (In-Vehicle)
- Inner CV Joint Overhaul
- Outer CV Joint Overhaul
- Intermediate Shaft Assembly Overhaul
- CV Joint Boots Overhaul
- Axle Shaft Damper Weights Overhaul
- Axle Shaft Positioning Overhaul
- Axle Shaft Positioning Specifications
- Torque Specifications
- Axle Shafts - Front
- Electrical
- Charging Systems
- Component Locations
- Fuses & Circuit Breakers
- Identification
- Notes
- Fuse & Circuit Breaker Identification
- 1 - 20 Amp
- 2 - 20 Amp (1990-91)
- 20 Amp (1992-93)
- 3 - 10 Amp
- 4 - 10 Amp
- 5 - 4 Amp
- 6 - 20 Amp
- 7 - 20 Amp (1990-92); (Blank) (1993)
- 8 - 5 Amp
- 9 - 10 Amp
- 10 - 30 Amp
- 11 - 10 Amp
- 12 - (Blank) (1990-91); 20 Amp (1992-93)
- 13 - 20 Amp
- 14 - 20 Amp
- 15 - 30 Amp (Circuit Breaker)
- 16 - 20 Amp (1990-91)
- 15 Amp (1992-93)
- 17 - 10 Amp
- 18 - 20 Amp
- 19 - 20 Amp
- 20 - 10 Amp (1990-91)
- 10 Amp (1992-93)
- Cautions & Warnings
- Identification
- Gauges
- Instrument Panel - Electronic
- Description
- Operation
- Diagnosis
- Notes
- Instrument Panel - Electronic
- Displays Not Illuminated After Vehicle Starts
- Instrument Cluster Asterisk (*) Flashes & Incorrect Data Display Exists
- Speedometer & Odometer Inoperative Or Operates Intermittently
- Oil, Fuel, Temperature Or Volt Gauge Inoperative
- Instrument Cluster Will Not Dim With Headlights On And Rheostat Rotated
- Seat Belt Warning Light Inoperative
- Low Washer Fluid, Door/Deck Or Check Engine Warning Light Inoperative
- Odometer Display Is Blank
- US/MET Modes Will Not Change Or Trip Odometer Will Not Reset
- Testing
- Removal & Installation
- Wiring Diagrams
- Instrument Panel - Standard
- Description & Operation
- Trouble Shooting
- Testing
- Notes
- Air Bag Warning System
- "Check Engine" Warning System
- Brake System Warning Light
- Fuel Gauge Circuit Test
- Low Oil Pressure Warning Light
- Combination Oil Sending Unit
- Oil Pressure Gauge Circuit Test
- Distance Sensor
- Speedometer Circuit Test
- Temperature Gauge Circuit Test
- Voltmeter Circuit Test
- Sending Units (Fuel Tank, Temperature & Oil Pressure)
- Removal & Installation
- Wiring Diagrams
- Instrument Panel - Electronic
- Starter
- Wiring Diagrams
- Engine Mechanical
- Accessory Drive Belts
- Auxiliary Emission Control Systems
- Emission Control System Visual Inspection Procedures - General Information
- * Please Read This First *
- Emission Control Labels
- Emission Control Visual Inspection
- Notes
- Positive Crankcase Ventilation (PCV)
- Thermostatic Air Cleaner (TAC)
- Fuel Evaporative System (EVAP)
- Catalytic Converters
- Fill Pipe RESTRICTOR (Fr)
- Exhaust Gas RECIRCULATION (EGR) System
- Spark Controls (SPK)
- Air Injection System (AIS)
- Oxygen Sensor (O2)
- Computerized Engine Controls (CEC)
- Early Fuel Evaporation (EFE)
- Emission Maintenance Reminder Light (EMR) (If Equipped)
- Malfunction Indicator Light (Mil)
- Emission Control System Visual Inspection Procedures - General Information
- Engine Cooling Fan
- Cooling System (Mechanical)
- Mechanical
- 3.3L V6 - VIN [R]
- Engine Identification
- Adjustments
- Trouble Shooting
- Removal & Installation
- Overhaul
- Engine Oiling
- Torque Specifications
- Engine Specifications
- Engine Oil Pan Removal - 4-CYL & V6
- Engine Removal
- 3.3L V6 - VIN [R]
- Starter
- Engine Performance
- Engine Controls - Adjustments
- Application
- Emissions
- EGR Function Testing - CHRYSLER Cars
- Emission Applications - Domestic Cars
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Remove, Overhaul & Install
- Engine Controls - Remove/Install/Overhaul
- Introduction
- Camshaft Angle Sensor 3.3L & 3.8L
- Crank Angle Sensor 3.3L & 3.8L
- Distributor 2.2L & 2.5L
- Distributor 3.0L
- Fuel System Pressure Release
- Fuel Rails & Injectors (PFI) (4-CYL)
- Fuel Rails & Injectors (PFI) (3.0L)
- Fuel Rails & Injectors (PFI) (3.3L)
- Injectors (TBI)
- Oxygen Sensor
- TBI
- PFI (4-CYL)
- PFI (3.0L)
- PFI (3.3L)
- Throttle Position Sensor
- Turbocharger
- Torque Specifications
- Engine Controls - Remove/Install/Overhaul
- Sensor Range Charts
- Engine Controls - Specifications
- System
- EGR Function Testing
- Engine Controls - Basic Testing
- Introduction
- Visual Inspection
- Mechanical Inspection
- Fuel Pressure
- Fuel Pressure Release
- TBI Fuel Pump Test
- 4-Cylinder PFI Fuel Pump Test
- 3.0L Fuel Pump Test
- 3.3L Fuel Pump Test
- Fuel Pump Pressure Specifications
- Auto Shutdown (ASD) Relay
- Testing Spark At Coil 2.2L, 2.5L & 3.0L
- Testing Spark At Coil 3.3L
- Failure To Start Test 2.2L, 2.5L & 3.0L
- Failure To Start Test 3.3L
- Idle Speed & Ignition Timing
- Summary
- Engine Controls - System/Component Tests
- Engine Controls - Tests W/Codes - 3.3L
- Introduction
- Model Identification
- System Diagnosis
- Hard Failures
- Intermittent Failures
- Diagnostic Procedure
- Entering On-Board Diagnostics
- Check Engine Light Diagnostic Mode
- DRB-II Diagnostic Mode
- Start Counter
- Fault Counter
- DRB-II Switch Test Mode
- DRB-II Read Input States
- DRB-II Read Output States
- DRB-II Actuates Solenoids & Relays
- DRB-II Actuates Outputs
- DRB-II Read Sensor Voltages
- DRB-II Read Sensor Values
- DRB-II Engine Parameters
- DRB-II Set Engine Rpm
- DRB-II Emissions EMR Tests
- DRB-II Read Module Information
- DRB-II System Monitors
- DRB-II Special Functions
- DRB-II Problems & Error Messages
- Diagnostic Trouble Codes (DTC) Identification
- Emission Maintenance Reminder (EMR) Mileage Transfer
- Emission Maintenance Reminder (EMR) Light Reset Procedure
- Clearing Codes
- Vehicle Security System Diagnosis
- Summary
- SBEC 60-Pin Connector Terminal Identification
- Code Charts
- No Start Tests
- NS1: IGN Spark, Fault Message & Dis Signal Status
- NS2: Check Fault Messages & Theft Alarm Status
- NS3: Check TPS, Fuel Pressure, Power To Coil, Plugs & Engine Timing
- NS4: Check Fuel Filter & Pump, Fuel Pressure Regulator & Power To Fuel Pump
- NS5: Check For High Pressure At Regulator & Fuel Tank
- NS6: Check Dis Signal Status Crank Sensor
- NS7: Check Dis Camshaft Sensor
- NS8: Check Dis Camshaft & Crankshaft Sensor Circuit
- NS9: Fault "IGN Coil CKT" - Check Power Feed To Injectors & Dis
- NS10: System Power & Ground, Map Sensor & Controller
- NS11: Code 42 "ASD Relay Circuit"
- NS12: Code 42 "Z1 Voltage Sense"
- DRIVEABILITY Tests
- Dr1: Checking System For Faults
- Dr2: Code 13 "Map Pneumatic Change"
- Dr3: Code 14 "Map Voltage Too Low"
- Dr4: Code 14 "Map Voltage Too High"
- Dr5: Code 15 "Vehicle Speed Signal"
- Dr6: Code 21 "Oxygen Sensor Signal"
- Dr7: Code 21 "Oxygen Sensor Shorted Hi"
- Dr8: Code 22 "Coolant Voltage Low"
- Dr9: Code 22 "Coolant Voltage High"
- Dr10: Code 23 "Charge Temp Volt Low"
- Dr11: Code 23 "Charge Temp Volt Hi"
- Dr12: Code 24 "TPS Voltage Low"
- Dr13: Code 24 "TPS Voltage Hi"
- Dr14: Code 25 "AIS Motor Circuit
- Dr15: Fault "INJ 1 Peak Current"
- Dr16: Code 27 "INJ 1 Control CKT"
- Dr17: Fault "INJ 2 Peak Current"
- Dr18: Code 27 "INJ 2 Control CKT"
- Dr19: Fault "INJ 3 Peak Current"
- Dr20: Code 27 "INJ 3 Control CKT"
- Dr21: Code 31 "Purge Solenoid CKT"
- Dr22: Code 32 "EGR Solenoid CKT" (CALIF.)
- Dr23: Code 32 "EGR System Failure" (CALIF)
- Dr24: Code 33 "A/C Clutch Relay CKT" (S Body)
- Dr25: Code 33 "A/C Clutch Relay CKT" (C & Y Body)
- Dr26: Code 35 "Radiator Fan Relay" (S Body)
- Dr27: Code 35 "Radiator Fan Relay" (C & Y Body)
- Dr28: Code 42: "Z1 Voltage Sense"
- Dr29: Fault "IGN Coil #1 CKT"
- Dr30: Fault "IGN Coil #2 CKT"
- Dr31: Fault "IGN Coil #3 CKT"
- Dr32: Repairing EMR Faults
- Dr33: Check Eng Controller GND & PWR CKTS
- Dr34: Checking Secondary Coil Output
- Dr35: Check Fuel Pressure
- Dr36: Check Fuel Mixture
- Dr37: Code 51: "Lean F/A Condition"
- Dr38: Check Heated O2 Sensor
- Dr39: Check Minimum Airflow
- Dr40: Other Possible Causes Of Dr Problems
- Dr41: Intermittent Tests For Solenoids & Relays
- Dr42: Intermittent Faults "Map Pneumatic Change"
- Dr43: Intermittent Tests For Volt Sensors
- Dr44: Intermittent Tests For Idle Motor CKTS
- Dr45: Intermittent Tests For Injector Faults
- Dr46: Intermittent Tests For IGN Coil Faults
- Verification Tests
- Engine Controls - Tests W/O Codes - BCC
- Diagnostic Test Procedure
- CCD Bus Testing
- Test 1: Id Vehicle Equip & SYS Problems
- Test 2: Repair Blank Message Screen On EVIC Head
- Test 3: Warning Messages
- Test 4, 5, 6, 7 & 8: Brake Lights
- Test 9: Coolant Level Low
- Test 10: Left Front Door Ajar
- Test 11: Engine Oil Level Low
- Test 12: Eng Temp Hi Or Eng Temp Critical
- Test 13: Exterior Lights On
- Test 14: Fasten Seat Belts
- Test 15: Right Headlight Out
- Test 16: Key In Ignition
- Test 17: Left Rear Door Ajar
- Test 18: Low Brake Fluid
- Test 19: Low Fuel Level
- Test 20: Low Oil Pressure
- Test 21: Headlight Out Message With No Headlights Out
- Test 22: Parking Brake Engaged
- Test 23: Passenger Door Ajar
- Test 24: Right Rear Door Ajar
- Test 25: Service Reminder
- Test 26, 27 & 28: Taillight Out
- Test 29: Trunk Ajar
- Test 30: Voltage Improper
- Test 31: Washer Fluid Low
- Test 32: Turn Signal On
- Test 33: No Message On EVIC Head Monitor
- Test 34: Headlights Out With No Message
- Test 35: All Brake Lights Out
- Test 36: Right Or Left Side Brake Light Out
- Test 37: All Taillights Out
- Test 38: Check Air Suspension
- Test 39: EVIC Head Monitor Switch Test
- Test 40: Electronic Cluster Diagnosis
- Test 41: Fault Messages
- Test 42: Electronic Instrument Cluster Problems Not Covered By Fault Code
- Test 43: Identifying Faulty Gauge
- Test 44, 45, 46 & 47: Gauges INOP
- Test 48: Determining Which Cluster Light Is Not Operating Correctly
- Test 49: Washer Fluid Low Light Operating Incorrectly
- Test 50: Door/Deck Light Operating Incorrectly
- Test 51: Check Engine Light Not Operating Properly
- Test 52: Brake Light Not Operating Correctly
- Test 53: Gauges Light Not Operating Correctly
- Test 54: Electronic Cluster Illumination Problem
- Test 55, 56, 57: Diag Theft Alarm Module
- Test 58: Theft Alarm Indicator Light
- Test 59: Diagnosing Vehicle Theft Alarm Ignition Input
- Test 60A: Diagnosing Trunk Key Cylinder Switch
- Test 60B: Diagnosing Horn Output Circuit
- Test 61 Thru 66: Theft Alarm Module Door Ajar Switch
- Test 61: Vehicle Theft Alarm Module Driver's Door Ajar Switch Test
- Test 62: Vehicle Theft Alarm Module Passenger's Door Ajar Switch Test
- Test 63: Vehicle Theft Alarm Module Right Rear Door Ajar Switch Test
- Test 64: Vehicle Theft Alarm Module Left Rear Door Ajar Switch Test
- Test 65: Diagnosing Short To Ground On Door Ajar Circuit
- Test 66: Vehicle Theft Alarm Module Hood Ajar Switch
- Test 67: Vehicle Theft Alarm Module Power Door Lock
- Test 68: Vehicle Theft Alarm Module Power Door Unlock
- Test 69: Vehicle Theft Alarm Module Driver's Key Cylinder Switch Test
- Test 70: Vehicle Theft Alarm Module Passenger's Key Cylinder Switch Test
- Test 71: Vehicle Theft Alarm Module Ignition Sense Test
- Test 72 Thru 75: Diag Short To GRN On Door Ajar Circuit
- Test 76: Theft Alarm Driver's Door Ajar Switch Test With Incandescent Message Center
- Test 77: Theft Alarm Passenger's Door Ajar Switch Test With Incandescent Message Center
- Test 78: Theft Alarm Right Rear Door Ajar Switch Test With Incandescent Message Center
- Test 79: Theft Alarm Left Rear Door Ajar Switch Test With Incandescent Message Center
- Test 80: Theft Alarm Module Short To GND. SW. Test For Incandescent Message Center
- Test 81: Theft Alarm Module Door Key Cylinder Switch Shorted To Ground Test
- Test 82 Thru 86: Diag Headlight Doors
- Test 87 & 88: Diag Automatic Door Lock System
- Test 89: Diag Driver's Door Ajar Switch For Short To GRN
- Test 90: Diagnosing Passenger's Door Ajar Switch For Short To Ground
- Test 91: Diagnosing Left Rear Door Ajar Switch For Short To Ground
- Test 92: Diagnosing Right Rear Door Ajar Switch For Short To Ground
- Test 93: Diagnosing Faulty Door Ajar Message W/Incandescent Message Center
- Test 94: Diagnosing Driver's Door Ajar SW. For Short CKT. W/Incandescent Message Center
- Test 95: Diagnosing Passenger's Door Ajar SW. For Short CKT. W/Incandescent Message Center
- Test 96: Diagnosing Right Rear Door Ajar SW. For Short CKT. W/Incandescent Message Center
- Test 97: Diagnosing Left Rear Door Ajar SW. For Short CKT. W/Incandescent Message Center
- Test 98: Checking Intermittent Wiper Circuits In Body Controller & Power Feed
- Test 99: Checking Stalk Switch, Body Controller & Related Wiring
- Test 100: Checking Wiper Motor & Ground
- Test 101: Testing Illuminated Entry System
- Test 102: Testing Passenger's Door Illuminated Entry Switch For Open Circuit
- Test 103 Thru 107: Courtesy Light & Door Jamb Switches
- Test 108: Testing DRB-II For Proper Operation
- Test 109: Repairing DRB-II Failures
- Test 110: Checking CCD Bus Failure Messages Using DRB-II
- Test 111: Repair Bus System For Short To Battery
- Test 112 Thru 115: Repairing Bus System
- Test 116: Check For No Response At Body Controller
- Test 117: Check For No Response From Elect Cluster
- Test 118: Check For No Response From Engine Node
- Test 119: Check For No Response From EVIC Head
- Test 120: Check For No Response From Theft Alarm
- Test 121: Check For No Response From Eng Controller
- Test 122: Repair Bus SYS For Not Receiving Bus Messages
- Test 123: Check Eng Controller For Open Bus Message
- Test 124: Repairing Bus System For No Termination Messages
- Test 125: Repairing Bus System For Bias Level Too High Or Too Low Message
- Test 126: Repairing Bus System For Bias Level Too High Or Too Low Message
- Test 127: Headlights Will Not Turn Off
- Engine Controls - Tests W/O Codes - SBEC
- Introduction
- Symptom Diagnosis
- No Start - Cold Engine
- No Start - Warm Engine
- Starts But Stalls
- Hard To Start - Cold Engine
- Erratic Idle - Warm-Up
- Backfiring
- Incorrect Idle Speed
- Hesitation - Acceleration
- Hesitation - Coasting
- Knocking
- Engine Misfire - All Conditions
- Insufficient Engine Power
- Poor Fuel Economy
- EXCESSIVE HC AND NOx
- Intermittent Problem Diagnosis
- Test Procedures
- Waveform (Injector) - 3.3L MFI VIN [R]
- Testing & Diagnosis
- EGR Function Testing
- Engine Controls - Basic Testing
- Introduction
- Visual Inspection
- Mechanical Inspection
- Fuel Pressure
- Fuel Pressure Release
- TBI Fuel Pump Test
- 4-Cylinder PFI Fuel Pump Test
- 3.0L Fuel Pump Test
- 3.3L Fuel Pump Test
- Fuel Pump Pressure Specifications
- Auto Shutdown (ASD) Relay
- Testing Spark At Coil 2.2L, 2.5L & 3.0L
- Testing Spark At Coil 3.3L
- Failure To Start Test 2.2L, 2.5L & 3.0L
- Failure To Start Test 3.3L
- Idle Speed & Ignition Timing
- Summary
- Engine Controls - System/Component Tests
- Engine Controls - Tests W/Codes - 3.3L
- Introduction
- Model Identification
- System Diagnosis
- Hard Failures
- Intermittent Failures
- Diagnostic Procedure
- Entering On-Board Diagnostics
- Check Engine Light Diagnostic Mode
- DRB-II Diagnostic Mode
- Start Counter
- Fault Counter
- DRB-II Switch Test Mode
- DRB-II Read Input States
- DRB-II Read Output States
- DRB-II Actuates Solenoids & Relays
- DRB-II Actuates Outputs
- DRB-II Read Sensor Voltages
- DRB-II Read Sensor Values
- DRB-II Engine Parameters
- DRB-II Set Engine Rpm
- DRB-II Emissions EMR Tests
- DRB-II Read Module Information
- DRB-II System Monitors
- DRB-II Special Functions
- DRB-II Problems & Error Messages
- Diagnostic Trouble Codes (DTC) Identification
- Emission Maintenance Reminder (EMR) Mileage Transfer
- Emission Maintenance Reminder (EMR) Light Reset Procedure
- Clearing Codes
- Vehicle Security System Diagnosis
- Summary
- SBEC 60-Pin Connector Terminal Identification
- Code Charts
- No Start Tests
- NS1: IGN Spark, Fault Message & Dis Signal Status
- NS2: Check Fault Messages & Theft Alarm Status
- NS3: Check TPS, Fuel Pressure, Power To Coil, Plugs & Engine Timing
- NS4: Check Fuel Filter & Pump, Fuel Pressure Regulator & Power To Fuel Pump
- NS5: Check For High Pressure At Regulator & Fuel Tank
- NS6: Check Dis Signal Status Crank Sensor
- NS7: Check Dis Camshaft Sensor
- NS8: Check Dis Camshaft & Crankshaft Sensor Circuit
- NS9: Fault "IGN Coil CKT" - Check Power Feed To Injectors & Dis
- NS10: System Power & Ground, Map Sensor & Controller
- NS11: Code 42 "ASD Relay Circuit"
- NS12: Code 42 "Z1 Voltage Sense"
- DRIVEABILITY Tests
- Dr1: Checking System For Faults
- Dr2: Code 13 "Map Pneumatic Change"
- Dr3: Code 14 "Map Voltage Too Low"
- Dr4: Code 14 "Map Voltage Too High"
- Dr5: Code 15 "Vehicle Speed Signal"
- Dr6: Code 21 "Oxygen Sensor Signal"
- Dr7: Code 21 "Oxygen Sensor Shorted Hi"
- Dr8: Code 22 "Coolant Voltage Low"
- Dr9: Code 22 "Coolant Voltage High"
- Dr10: Code 23 "Charge Temp Volt Low"
- Dr11: Code 23 "Charge Temp Volt Hi"
- Dr12: Code 24 "TPS Voltage Low"
- Dr13: Code 24 "TPS Voltage Hi"
- Dr14: Code 25 "AIS Motor Circuit
- Dr15: Fault "INJ 1 Peak Current"
- Dr16: Code 27 "INJ 1 Control CKT"
- Dr17: Fault "INJ 2 Peak Current"
- Dr18: Code 27 "INJ 2 Control CKT"
- Dr19: Fault "INJ 3 Peak Current"
- Dr20: Code 27 "INJ 3 Control CKT"
- Dr21: Code 31 "Purge Solenoid CKT"
- Dr22: Code 32 "EGR Solenoid CKT" (CALIF.)
- Dr23: Code 32 "EGR System Failure" (CALIF)
- Dr24: Code 33 "A/C Clutch Relay CKT" (S Body)
- Dr25: Code 33 "A/C Clutch Relay CKT" (C & Y Body)
- Dr26: Code 35 "Radiator Fan Relay" (S Body)
- Dr27: Code 35 "Radiator Fan Relay" (C & Y Body)
- Dr28: Code 42: "Z1 Voltage Sense"
- Dr29: Fault "IGN Coil #1 CKT"
- Dr30: Fault "IGN Coil #2 CKT"
- Dr31: Fault "IGN Coil #3 CKT"
- Dr32: Repairing EMR Faults
- Dr33: Check Eng Controller GND & PWR CKTS
- Dr34: Checking Secondary Coil Output
- Dr35: Check Fuel Pressure
- Dr36: Check Fuel Mixture
- Dr37: Code 51: "Lean F/A Condition"
- Dr38: Check Heated O2 Sensor
- Dr39: Check Minimum Airflow
- Dr40: Other Possible Causes Of Dr Problems
- Dr41: Intermittent Tests For Solenoids & Relays
- Dr42: Intermittent Faults "Map Pneumatic Change"
- Dr43: Intermittent Tests For Volt Sensors
- Dr44: Intermittent Tests For Idle Motor CKTS
- Dr45: Intermittent Tests For Injector Faults
- Dr46: Intermittent Tests For IGN Coil Faults
- Verification Tests
- Engine Controls - Tests W/O Codes - BCC
- Diagnostic Test Procedure
- CCD Bus Testing
- Test 1: Id Vehicle Equip & SYS Problems
- Test 2: Repair Blank Message Screen On EVIC Head
- Test 3: Warning Messages
- Test 4, 5, 6, 7 & 8: Brake Lights
- Test 9: Coolant Level Low
- Test 10: Left Front Door Ajar
- Test 11: Engine Oil Level Low
- Test 12: Eng Temp Hi Or Eng Temp Critical
- Test 13: Exterior Lights On
- Test 14: Fasten Seat Belts
- Test 15: Right Headlight Out
- Test 16: Key In Ignition
- Test 17: Left Rear Door Ajar
- Test 18: Low Brake Fluid
- Test 19: Low Fuel Level
- Test 20: Low Oil Pressure
- Test 21: Headlight Out Message With No Headlights Out
- Test 22: Parking Brake Engaged
- Test 23: Passenger Door Ajar
- Test 24: Right Rear Door Ajar
- Test 25: Service Reminder
- Test 26, 27 & 28: Taillight Out
- Test 29: Trunk Ajar
- Test 30: Voltage Improper
- Test 31: Washer Fluid Low
- Test 32: Turn Signal On
- Test 33: No Message On EVIC Head Monitor
- Test 34: Headlights Out With No Message
- Test 35: All Brake Lights Out
- Test 36: Right Or Left Side Brake Light Out
- Test 37: All Taillights Out
- Test 38: Check Air Suspension
- Test 39: EVIC Head Monitor Switch Test
- Test 40: Electronic Cluster Diagnosis
- Test 41: Fault Messages
- Test 42: Electronic Instrument Cluster Problems Not Covered By Fault Code
- Test 43: Identifying Faulty Gauge
- Test 44, 45, 46 & 47: Gauges INOP
- Test 48: Determining Which Cluster Light Is Not Operating Correctly
- Test 49: Washer Fluid Low Light Operating Incorrectly
- Test 50: Door/Deck Light Operating Incorrectly
- Test 51: Check Engine Light Not Operating Properly
- Test 52: Brake Light Not Operating Correctly
- Test 53: Gauges Light Not Operating Correctly
- Test 54: Electronic Cluster Illumination Problem
- Test 55, 56, 57: Diag Theft Alarm Module
- Test 58: Theft Alarm Indicator Light
- Test 59: Diagnosing Vehicle Theft Alarm Ignition Input
- Test 60A: Diagnosing Trunk Key Cylinder Switch
- Test 60B: Diagnosing Horn Output Circuit
- Test 61 Thru 66: Theft Alarm Module Door Ajar Switch
- Test 61: Vehicle Theft Alarm Module Driver's Door Ajar Switch Test
- Test 62: Vehicle Theft Alarm Module Passenger's Door Ajar Switch Test
- Test 63: Vehicle Theft Alarm Module Right Rear Door Ajar Switch Test
- Test 64: Vehicle Theft Alarm Module Left Rear Door Ajar Switch Test
- Test 65: Diagnosing Short To Ground On Door Ajar Circuit
- Test 66: Vehicle Theft Alarm Module Hood Ajar Switch
- Test 67: Vehicle Theft Alarm Module Power Door Lock
- Test 68: Vehicle Theft Alarm Module Power Door Unlock
- Test 69: Vehicle Theft Alarm Module Driver's Key Cylinder Switch Test
- Test 70: Vehicle Theft Alarm Module Passenger's Key Cylinder Switch Test
- Test 71: Vehicle Theft Alarm Module Ignition Sense Test
- Test 72 Thru 75: Diag Short To GRN On Door Ajar Circuit
- Test 76: Theft Alarm Driver's Door Ajar Switch Test With Incandescent Message Center
- Test 77: Theft Alarm Passenger's Door Ajar Switch Test With Incandescent Message Center
- Test 78: Theft Alarm Right Rear Door Ajar Switch Test With Incandescent Message Center
- Test 79: Theft Alarm Left Rear Door Ajar Switch Test With Incandescent Message Center
- Test 80: Theft Alarm Module Short To GND. SW. Test For Incandescent Message Center
- Test 81: Theft Alarm Module Door Key Cylinder Switch Shorted To Ground Test
- Test 82 Thru 86: Diag Headlight Doors
- Test 87 & 88: Diag Automatic Door Lock System
- Test 89: Diag Driver's Door Ajar Switch For Short To GRN
- Test 90: Diagnosing Passenger's Door Ajar Switch For Short To Ground
- Test 91: Diagnosing Left Rear Door Ajar Switch For Short To Ground
- Test 92: Diagnosing Right Rear Door Ajar Switch For Short To Ground
- Test 93: Diagnosing Faulty Door Ajar Message W/Incandescent Message Center
- Test 94: Diagnosing Driver's Door Ajar SW. For Short CKT. W/Incandescent Message Center
- Test 95: Diagnosing Passenger's Door Ajar SW. For Short CKT. W/Incandescent Message Center
- Test 96: Diagnosing Right Rear Door Ajar SW. For Short CKT. W/Incandescent Message Center
- Test 97: Diagnosing Left Rear Door Ajar SW. For Short CKT. W/Incandescent Message Center
- Test 98: Checking Intermittent Wiper Circuits In Body Controller & Power Feed
- Test 99: Checking Stalk Switch, Body Controller & Related Wiring
- Test 100: Checking Wiper Motor & Ground
- Test 101: Testing Illuminated Entry System
- Test 102: Testing Passenger's Door Illuminated Entry Switch For Open Circuit
- Test 103 Thru 107: Courtesy Light & Door Jamb Switches
- Test 108: Testing DRB-II For Proper Operation
- Test 109: Repairing DRB-II Failures
- Test 110: Checking CCD Bus Failure Messages Using DRB-II
- Test 111: Repair Bus System For Short To Battery
- Test 112 Thru 115: Repairing Bus System
- Test 116: Check For No Response At Body Controller
- Test 117: Check For No Response From Elect Cluster
- Test 118: Check For No Response From Engine Node
- Test 119: Check For No Response From EVIC Head
- Test 120: Check For No Response From Theft Alarm
- Test 121: Check For No Response From Eng Controller
- Test 122: Repair Bus SYS For Not Receiving Bus Messages
- Test 123: Check Eng Controller For Open Bus Message
- Test 124: Repairing Bus System For No Termination Messages
- Test 125: Repairing Bus System For Bias Level Too High Or Too Low Message
- Test 126: Repairing Bus System For Bias Level Too High Or Too Low Message
- Test 127: Headlights Will Not Turn Off
- Engine Controls - Tests W/O Codes - SBEC
- Introduction
- Symptom Diagnosis
- No Start - Cold Engine
- No Start - Warm Engine
- Starts But Stalls
- Hard To Start - Cold Engine
- Erratic Idle - Warm-Up
- Backfiring
- Incorrect Idle Speed
- Hesitation - Acceleration
- Hesitation - Coasting
- Knocking
- Engine Misfire - All Conditions
- Insufficient Engine Power
- Poor Fuel Economy
- EXCESSIVE HC AND NOx
- Intermittent Problem Diagnosis
- Test Procedures
- Waveform (Injector) - 3.3L MFI VIN [R]
- Theory and Operation
- Engine Controls - Theory & Operation
- Introduction
- Air Induction System
- Turbocharger I
- Turbocharger IV
- Control Unit
- Input Devices
- Notes
- Brake Switch
- Camshaft Angle Sensor
- Charge Temperature Sensor
- Clutch Switch
- Coolant Temperature Sensor
- Crankshaft Angle Sensor
- Denotation Sensor
- Hall Effect Switch
- Manifold Absolute Pressure Sensor
- Optical Distributor
- Oxygen Sensor
- P/N Switch
- Throttle Body Temperature Sensor
- Throttle Position Sensor
- Vehicle Speed Sensor
- Output Signals
- Fuel Delivery
- Throttle Body Injection (TBI)
- Port Fuel Injection (PFI)
- Idle Speed
- Direct Ignition System (Dis)
- Optical Ignition System (3.0L)
- Ignition Timing Control System
- Emission Systems
- Exhaust Gas RECIRCULATION (EGR) System
- Self-Diagnostic System
- Check Engine Light
- Miscellaneous Controls
- A/C Clutch Relay
- Alternator
- Auto Shutdown (ASD) Relay
- Radiator Fan Relay
- Speed Control Servo
- Engine Controls - Theory & Operation
- Vacuum Diagrams
- Wiring Diagrams
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- Computer Relearn Procedures
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Identification
- Metric Conversions
- OEM General Information
- How To Use The Engine Performance Section
- Maintenance Reminder Light (Reset Procedures)
- Emissions Maintenance Reminder (EGR)
- Emissions Maintenance Reminder (EMR Mileage)
- Emissions Maintenance Reminder (MAINT REQD Or Check EGR)
- Emissions Maintenance Reminder (Sri)
- Engine Oil Replacement Reminder
- Maintenance Service Reminder (ASSYST Maintenance Computer)
- Maintenance Service Reminder (Perform Service)
- Maintenance Service Reminder (Service Reminder Indicator)
- Maintenance Service Reminder (Service Reminder Message)
- Tire Pressure Monitor System Reminder
- Air Bag Restraints & SRS Components - Inspection & Replacement Tables
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- General Servicing
- A/C Compressor Servicing
- CHRYSLER C-171 6-CYL Clutch R & I
- CHRYSLER C-171 6-CYL Shaft Seal R & I
- NIPPONDENSO & CHRYSLER 6C-17 6-CYL Clutch R & I
- NIPPONDENSO & CHRYSLER 6C-17 6-CYL Shaft Seal R & I
- NIPPONDENSO 10PA17 & 10PA17A 10-CYL Clutch R & I
- NIPPONDENSO 10PA17 & 10PA17A 10-CYL Shaft Seal R & I
- SANDEN SD-508 5-CYL & SD-709 7-CYL Clutch R & I
- SANDEN SD-508 5-CYL & SD-709 7-CYL Shaft Seal R & I
- A/C Refrigerant Oil & R-12 Capacities
- A/C System General Servicing
- Using R-12 Refrigerant - Safety Precautions
- Using Individual R-12 Cans
- Multi-Can Dispensing Valves
- Can Tap Installation
- Sight Glass Indicators
- 1990 Service Valve Location Table
- 1991 System Service Valve Locations
- Stem-Type Valve Operation
- SCHRADER-Type Valve Operation
- Manifold Gauge Set
- Connecting Gauge Set
- Purging Test Hoses
- Stabilizing A/C System
- Pressure Gauge Indications
- Excessive Moisture Gauge Readings
- Defective Thermostatic Switch Gauge Readings
- MISADJUSTED Thermostatic Switch Gauge Readings
- Defective Clutch Cycling Switch Pressure Gauge Readings
- Low R-12 Charge Gauge Readings
- Very Low R-12 Charge Gauge Readings
- Orifice Tube Plugged Gauge Readings
- Expansion Or "H" Valve Stuck Closed
- Expansion Or "H" Valve Stuck Open Gauge Readings
- Compressor Malfunction Gauge Readings
- Condenser Malfunction Or R-12 Overcharge Gauge Readings
- Orifice Tube R & I - 1990 MONACO
- Orifice Tube R & I - 1991 MONACO
- Refrigerant Recovery
- Discharging A/C System
- Flushing A/C System
- Evacuating A/C System
- Charging A/C System - MONACO
- Charging A/C System All Others
- Leak Testing All Manufacturers
- A/C System Precautions
- Before Opening The System
- Discharging A/C System
- Disconnecting Lines & Fittings
- Component Replacement
- Using R-12 Refrigerant - Safety Precautions
- Using Individual R-12 Cans
- Multi-Can Dispensing Valves
- Can Tap Installation Flat Type Seal Cans
- Screw Type Seal Cans
- Connecting Lines & Fittings
- Placing System In Operation
- Compressor Removal Information - Isolation Method
- Compressor Removal Information - Discharge Method
- A/C Compressor Servicing
- HVAC Control Systems
- A/C-Heater System - Automatic
- A/C System Specifications
- Description
- Operation
- Testing
- Pre-Test Preparation
- Non-Computer Aided Diagnostics
- Computer Display Does Not Dim With Headlights On
- Computer Does Not Return To Set Temperature After Vehicle Is Shut Off And Restarted
- Push Buttons Stick, Do Not Function Properly, Or Panel Display Figures Are Partly Illuminated
- Insufficient Cooling Or Heating With No Failure Code
- Blower Motor Operates At High Speed Only And Cannot Be Controlled With Blower Speed Selector Switch, No Failure Code Displayed
- Entering Self-Test & Diagnostic Mode
- Pre-Computer Aided Diagnostics
- Computer Aided Diagnostics
- Preliminary Test Steps & Failure Code Information
- Failure Codes Involving PVM
- Failure Codes No. 1, 2 Or 3 Test
- Failure Code No. 4 Test
- Failure Code No. 5 Test
- Failure Code No. 6 Test
- Failure Code No. 7 Test
- Failure Code No. 8 Test
- Failure Code No. 9 Test
- Failure Code No. 10 Test
- Failure Code No. 11 Test
- Failure Codes No. 12 & 13 Test
- Failure Code No. 14 Test
- Failure Code No. 15 Test
- Failure Codes No. 16, 17 & 18 Test
- Removal & Installation
- Vacuum Hose Diagram(S)
- Wiring Diagrams
- A/C-Heater System - Manual
- *Please Read This First*
- A/C System Specifications Table
- Body Code Designations Table
- Description
- System Control Operation
- Adjustments
- Testing
- Removal & Installation
- Expansion Valve R & I
- Evaporator & Heater Core R & I (C Body)
- Evaporator & Heater Core R & I (P Body)
- Evaporator & Heater Core R & I (Y Body)
- Evaporator & Heater Core R & I (A Body)
- Evaporator & Heater Core R & I (G & L Body)
- Evaporator & Heater Core R & I
- Blower Motor R & I
- Control Panel R & I
- Temperature Control Cable R & I
- Vacuum Hose Diagram(S)
- Wiring Diagrams
- A/C-Heater System Trouble Shooting - Manual
- Vacuum Control System Diagnosis
- Diagnosis
- Compressor Noisy/Won't Turn Properly, Clutch Slips/Smokes
- Clutch Won't Engage, Compressor Leaks
- Blower Motor & Control System
- Refrigerant System Diagnosis
- Heater A/C Vacuum Control System Diagnosis
- Blower Motor Noise/Vibration
- Variable Displacement Compressor Diagnosis
- A/C Refrigerant System Diagnosis W/Variable Displacement Compressor
- Heater System
- Heater System Trouble Shooting
- A/C-Heater System - Automatic
- General Servicing
- Maintenance
- Procedures
- Maintenance Information
- Model Identification
- Maintenance Service Information
- Service Point Locations
- Service Labor Times
- Wheel & Tire Specifications
- Battery Specifications
- Cautions & Warnings
- Warranty Information
- Fuses & Circuit Breakers
- Maintenance Reminder Light (Reset Procedures)
- Emissions Maintenance Reminder (EGR)
- Emissions Maintenance Reminder (EMR Mileage)
- Emissions Maintenance Reminder (MAINT REQD Or Check EGR)
- Emissions Maintenance Reminder (Sri)
- Engine Oil Replacement Reminder
- Maintenance Service Reminder (ASSYST Maintenance Computer)
- Maintenance Service Reminder (Perform Service)
- Maintenance Service Reminder (Service Reminder Indicator)
- Maintenance Service Reminder (Service Reminder Message)
- Tire Pressure Monitor System Reminder
- Service Indicator & Warning Lights
- Maintenance Information
- Procedures
- Restraints
- Air Bag, SRS
- Air Bag Restraint System
- Post-Collision Air Bag Safety Inspection
- Air Bag, SRS
- Steering
- Manual Steering
- Power Steering Pump - SAGINAW & ZF
- Steering Gear - Power
- Steering System - Power
- Power Steering
- Power Steering Pump - SAGINAW & ZF
- Steering Gear - Power
- Steering System - Power
- Steering Column
- Description
- Trouble Shooting
- Removal & Installation
- Overhaul
- Manual Steering
- Suspension
- Electronic Suspension
- Automatic Air System
- Description
- Operation
- Test 8: Test For Disabling CCD Bus Messages
- Test 9: Compressor Fails To Run
- Test 10: Compressor Runs But Right Front Will Not Raise
- Test 11: Right Front Wheel Will Not Lower
- Test 12: Compressor Runs But Left Front Will Not Raise
- Test 13: Rear Will Not Raise
- Test 14: Test For No Response Message
- Test 15: DRB-II Error Message Test
- Test 16: Blank Message Screen Test
- Wiring Diagram
- Testing & Diagnosis
- Test 1: DRB-II Hook-Up & CCD Bus Testing
- Test 2: Verification Test
- Test 3: Testing Right Front Height Sensor Circuit
- Test 4: Testing Left Front Height Sensor Circuit
- Test 5: Testing Rear Height Sensor Circuit
- Test 6: Test For No Messages Received Message
- Test 7: Test For Compressor Overrun Message
- Air Drier R & I
- Air Lines R & I
- Air Spring (Rear) R & I
- Height Control Solenoid R & I
- Compressor R & I
- Compressor Relay R & I
- Air Suspension Control Module (ASCM) R & I
- Air Strut Assembly R & I
- Torque Specifications
- Automatic Air System
- Front Suspension
- Rear Suspension
- Wheel Alignment
- Electronic Suspension
- Transmission
- Automatic Trans
- Diagnosis - A-604
- Description
- Operation
- System Testing
- Trouble Code Charts
- Notes
- Test 1
- Test 2
- Test 3
- Hard Fault Code Directory
- Test 5
- Test 6
- Test 7
- Test 8
- Test 9
- Test 10
- Test 11
- Test 12
- Test 13
- Test 14
- Test 15
- Test 16
- Test 17
- Test 18
- Test 19
- Test 20
- Test 21
- Test 22
- Test 23
- Test 24
- Test 25
- Test 26
- Test 27
- Test 28
- Test 29
- Test 30
- Test 31
- Test 32
- Test 33
- Test 34
- Test 35
- Test 36
- Test 37
- Test 38
- Test 39
- Test 40
- Test 41
- Test 42
- Test 43
- Test 44
- Test 46
- Test 47
- Test 48
- Test 49
- Test 50
- Repair Verification Test Procedure
- Wiring Diagrams
- Overhaul - A-604/41TE & 41AE
- Application
- Identification
- Description
- Operation
- Shift Quality Quick-Learn Procedure
- Pinion Factor Procedure
- Lubrication & Adjustments
- On-Vehicle Service
- Trouble Shooting
- Notes
- Buzzing Noise
- Buzzing Noise During Transaxle Shifts
- Delayed Engagement From Neutral To Drive
- Delayed Engagement From Neutral To Reverse
- Grating, Scraping Or Growling Noise
- Hard To Fill With Fluid Or Fluid Blows Out Filler Tube
- Harsh Downshifts
- Harsh Engagement From Neutral To Drive
- Harsh Engagement From Neutral To Reverse
- Harsh Torque Converter Lock-Up
- Harsh Upshift
- High Shift Efforts
- No Torque Converter Lock-Up
- No Upshift Into Overdrive
- Poor Shift Quality
- Shifts Erratically
- Transaxle Overheats
- Vehicle Drags Or Locks
- Vehicle Moves In Neutral
- Testing - Non-Electronic
- Removal & Installation
- Torque Converter
- Transaxle Disassembly
- Component Disassembly & Reassembly
- Bearing Adjustments
- Transaxle Reassembly
- Torque Specifications
- Transaxle Specifications
- Wiring Diagrams
- Removal & Installation - A/T
- Servicing - A/T
- Identification
- Lubrication - Service Intervals
- Checking Fluid Levels
- Recommended Fluid
- Fluid Capacity
- Draining & Refilling
- Adjustments - KICKDOWN Band (Front)
- Adjustments - Low-Reverse Band (Rear)
- Transmission Throttle Cable
- Shift Linkage
- Console Or Column Shift
- Neutral Safety Switch
- Throttle Valve Cable
- Oil Pan Gasket Identification
- Diagnosis - A-604
- Hydraulic Diagrams - A604
- Automatic Trans
- External Pages