Engine Controls - Tests W/Codes - 3.0L
- Model Identification
- Introduction
- Self-Diagnostic System
- Inactive Trouble Code Condition
- Fuel Pressure Release
- Trouble Codes/Messages
- Notes
- CODES/MESSAGES (Note: For DTC table, see TEST TC-1A under "Self-Diagnostics.")
- Code 11
- Code 12
- Code 13
- Code 14
- Code 15 (3.0L Only)
- Code 17
- Code 21 (3.0L Only)
- Code 22
- Code 24
- Code 25
- Code 27 (3.0L Only)
- Code 31
- Code 33
- Code 34
- Code 35 (3.0L Only)
- Code 37 (3.0L Only)
- Code 41
- Code 42
- Code 42 (3.0L Only)
- Code 44
- Code 46
- Code 47
- Code 51 (3.0L Only)
- Code 52 (3.0L Only)
- Code 53
- Code 54
- Code 55
- Code 62 (3.0L Only)
- Code 63
- Self-Diagnostic Tests
- Notes
- Test TC-1A - Checking System For Trouble Codes
- Test TC-2A - No Crank Reference Signal At Pcm (DTC 11)
- Test TC-2B - No Crank Reference Signal At Pcm
- Test TC-3A - No Cam Sync Signal At Pcm (DTC 54)
- Test TC-4A - No Change In Map From Start To Run (DTC 13)
- Test TC-5A - Map Sensor Voltage Too Low (DTC 14)
- Test TC-6A - Map Sensor Voltage Too High (DTC 14)
- Test TC-7A - No Vehicle Speed Sensor Signal (DTC 15)
- Test TC-7B - No Vehicle Speed Sensor Signal
- Test TC-7C - No Vehicle Speed Sensor Signal
- Test TC-7D - No Vehicle Speed Sensor Signal
- Test TC-8A - O2S Stays At Center (DTC 21)
- Test TC-9A - O2S Stays Above Center (Rich) (DTC 52)
- Test TC-10A - O2S Stays Below Center (Lean) (DTC 51)
- Test TC-11A - O2S Shorted To Voltage (DTC 21)
- Test TC-12A - ECT Sensor Voltage Too Low (DTC 22)
- Test TC-13A - ECT Sensor Voltage Too High (DTC 22)
- Test TC-14A - Throttle Position Sensor Voltage Low (DTC 24)
- Test TC-15A - Throttle Position Sensor Voltage High (DTC 24)
- Test TC-16A - Idle Air Control Motor Circuits (DTC 25)
- Test TC-16B - Idle Air Control Motor Circuits
- Test TC-16C - Idle Air Control Motor Circuits
- Test TC-16D - Idle Air Control Motor Circuits
- Test TC-16E - Idle Air Control Motor Circuits
- Test TC-17A - Injector Control Circuit (DTC 27)
- Test TC-17B - Injector #1 Control Circuit
- Test TC-17C - Injector #1 Control Circuit
- Test TC-18A - Injector #2 Control Circuit (DTC 27)
- Test TC-18B - Injector #2 Control Circuit
- Test TC-19A - Injector #3 Control Circuit (DTC 27)
- Test TC-19B - Injector #3 Control Circuit
- Test TC-20A - Injector #4 Control Circuit (DTC 27)
- Test TC-20B - Injector #4 Control Circuit
- Test TC-21A - Injector #5 Control Circuit (DTC 27)
- Test TC-21B - Injector #5 Control Circuit
- Test TC-22A - Injector #6 Control Circuit (DTC 27)
- Test TC-22B - Injector #6 Control Circuit
- TEST TC-23A - PCM FAILURE SRI MILE NOT STORED OR PCM FAILURE EEPROM WRITE DENIED (DTC 62 or 63)
- Test TC-24A - EGR System Failure (DTC 32)
- Test TC-25A - EGR Solenoid Circuit (DTC 32)
- Test TC-26A - EVAP Solenoid Circuit (DTC 31)
- Test TC-27A - Torque Converter Clutch Solenoid Circuit (DTC 37)
- Test TC-28A - No ASD Relay Volt Sensed At Pcm (DTC 42)
- Test TC-29A - Auto Shutdown Relay Control Circuit (DTC 42)
- Test TC-30A - A/C Clutch Relay Circuit (DTC 33)
- Test TC-31A - Radiator Fan Relay Circuit (DTC 35)
- Test TC-32A - Low Speed Fan CTRL Relay Circuit (DTC 35)
- Test TC-33A - High Speed Fan CTRL Relay Circuit (DTC 35)
- Test TC-38A - Battery Temp Sensor Volts Out Of Limit (DTC 44)
- Test NTC-1A - No Trouble Code Test Menu
- Test NTC-2A - Checking Secondary Ignition & Timing
- Test NTC-3A - Checking Fuel Pressure
- Test NTC-3B - Checking Fuel Pressure
- Test NTC-4A - Checking Coolant Sensor Calibration & Radiator Fan Operation
- Test NTC-5A - Checking TPS Calibration
- Test NTC-6A - Checking Manifold Absolute Pressure (Map) Sensor Calibration
- Test NTC-7A - Checking Oxygen Sensor (O2S) Switching
- Test NTC-7B - Checking Oxygen Sensor (O2S) Switching
- Test NTC-8A - Checking Oxygen Sensor Heater
- Test NTC-9A - Checking Idle Air Control Motor
- Test NTC-9B - Checking Idle Air Control Motor
- Test NTC-10A - Checking Solenoid Operations
- Test NTC-11A - Checking Park/Neutral Switch
- Test NTC-12A - Checking Pcm Ground & Power Circuits
- Test NTC-13A - Checking Engine Vacuum
- Test NTC-14A - Checking Minimum Idle Airflow
- Test NTC-15A - No Trouble Code Mechanical Test
- No-Start Tests
- Test NS-1A - Qualifying No-Start Condition
- Test NS-2A - Inspecting Fuel System
- Test NS-3A - Inspecting Mechanical System
- Test NS-4A - Correcting Fuel Delivery
- Test NS-4B - Correcting Fuel Delivery
- Test NS-5A - Inspecting Fuel Pump
- Test NS-5B - Inspecting Fuel Pump
- Test NS-6A - Correcting No Response Condition
- Test NS-6B - Correcting No Response Condition
- Test NS-6C - Correcting No Response Condition
- Test NS-6D - Correcting No Response Condition
- Test NS-7A - Inspecting Idle Air Control Motor Operation
- Test NS-7B - Inspecting Idle Air Control Motor Operation
- Test NS-7C - Inspecting Idle Air Control Motor Operation
- Test NS-7D - Inspecting Idle Air Control Motor Operation
- Test NS-7E - Inspecting Idle Air Control Motor Operation
- Test NS-8A - Correcting Start & Stall Condition
- Test NS-9A - Repairing No Crank Condition
- Test NS-9B - Repairing No Crank Condition
- Test NS-9C - Repairing No Crank Condition
- Verification Tests