Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups- Accessories & Equipment
- Anti-Theft Systems
- Anti-Theft Systems
- Power Door Lock System & Trunk Release System
- Remote Keyless Entry System
- Shift Interlock System
- Body Interior
- Body Control Modules
- Description
- Operation
- Component Locations
- Programming
- Trouble Shooting
- Self-Diagnostic System
- System Tests
- Chime Systems
- Communications
- Notes
- ATC Messages Not Received
- Battery Voltage To Module Disconnected
- EATX Bus Communication Failure
- EEPROM Constant Checksum Failure
- Internal Base/Premium Select Failure
- MHSMM Messages Not Received
- MIC Message Not Received
- No PCI Messages From CD Changer
- OTIS Messages Not Received
- Post Failure
- SBEC Bus Communication Failure
- SKIM Messages Not Received
- Bus +/- Signal Open From SKIM
- Bus +/- Signals Open From Or Blank Screen On OTIS
- Diagnostic Readout Box (DRBIII(R)) Displays A Blank Screen
- Fused Ignition Switch Output To BCM
- No Response From Body Control Module (Bus +/- Signal Open)
- No Response From CAB
- No Response From ORC
- No Response From Powertrain Control Module (PCI Bus)
- No Response From Radio
- No Response From Transmission Control Module (TCM)
- Odometer Displays NO BUS
- PCI Bus Communication Failure
- Electrically Heated Systems
- Notes
- Driver Heated Seat Switch Open/Shorted To Ground
- Driver Heated Seat Switch Stuck In High/Low State
- Driver Seat Heat Output Open
- Driver Seat Heat Output Short To Gnd
- Driver Thermistor Out Of Range High
- Driver Thermistor Out Of Range Low
- Passenger Heated Seat Switch Open/Shorted To Ground
- Passenger Heated Seat Switch Stuck In High/Low State
- Passenger Seat Heat Output Open
- Passenger Seat Heat Output Short To Gnd
- Passenger Thermistor Out Of Range High
- Passenger Thermistor Out Of Range Low
- Rear Window Defogger Inoperative (Manual A/C)
- Rear Window Defogger Inoperative W/ATC
- Exterior Lighting Systems
- Notes
- Headlight Switch Input Failure
- Auto Lamps And/Or Fog Lights Not Operating Properly
- Fog Lights Will Not Turn Off
- Fog Lights Will Not Turn On
- Headlight Time Delay Inoperative
- High Beam Headlights Will Not Turn Off
- High Beam Headlights Will Not Turn On
- Low Beam Headlights Will Not Turn Off
- Low Beam Headlights Will Not Turn On
- Parking Lights Will Not Turn Off
- Parking Lights Will Not Turn On
- Instrument Cluster Systems
- Notes
- Dimming Level Switch Failure
- Fuel Level Sending Unit Failure
- No Messages From ABS
- No Messages From AECM
- No Messages From BCM
- No Messages From EATX
- No Messages From SBEC
- ABS Warning Indicator Not Operating Properly
- Air Bag Warning Indicator Not Operating Properly
- All Gauges Not Operating Correctly
- Brake Indicator Not Operating Properly
- Charging Indicator Not Operating Properly
- Check Engine Indicator Not Operating Properly
- Cluster & Panel Illumination Problems
- Cruise On Indicator Not Operating Properly
- Decklid Ajar Indicator Not Operating
- Door Ajar Indicator Not Operating Properly
- Engine Coolant Temperature Indicator Not Operating Properly
- Fuel Gauge Not Operating Properly
- Low Fuel Indicator Not Operating Properly
- Low Washer Fluid Indicator Not Operating Properly
- Odometer Not Operating Properly
- Oil Pressure Warning Indicator Not Operating Properly
- PRND3L Indicator Malfunctions
- Seat Belt Indicator Not Operating Properly
- Speedometer Gauge Not Operating Properly
- Tachometer Not Operating Properly
- Temperature Gauge Not Operating Properly
- Traction Off Indicator Not Operating Properly
- Traction On Indicator Not Operating Properly
- Interior Lighting Systems
- Notes
- Courtesy Light Output Short To Battery
- Courtesy Lights Inoperative With Door Open (All Lights)
- Courtesy Lights Inoperative With Door Open (Door Lights Only)
- Courtesy Lights Inoperative With Door Open (Overhead Console Lights Only)
- Courtesy Lights Inoperative From Headlight Switch
- Courtesy Lights Inoperative With Driver's Door Open
- Courtesy Lights Inoperative With Left Rear Door Open
- Courtesy Lights Inoperative With Passenger's Door Open
- Courtesy Lights Inoperative With Right Rear Door Open
- Courtesy Lights Stay On At All Times
- Memory Systems
- Notes
- Driver Mirror Horizontal Sensor Out Of Range High
- Driver Mirror Horizontal Sensor Out Of Range Low
- Driver Mirror Vertical Sensor Out Of Range High
- Driver Mirror Vertical Sensor Out Of Range Low
- Front Riser Down Position Stuck
- Front Riser Sensor Out Of Range High
- Front Riser Sensor Out Of Range Low
- Front Riser Up Position Stuck
- Horizontal Forward Position Stuck
- Horizontal Rearward Position Stuck
- Horizontal Sensor Out Of Range High
- Horizontal Sensor Out Of Range Low
- Memory Position No. 1 Stuck
- Memory Position No. 2 Stuck
- Memory Set "S" Position Stuck
- Passenger Mirror Horizontal Sensor Out Of Range High
- Passenger Mirror Horizontal Sensor Out Of Range Low
- Passenger Mirror Vertical Sensor Out Of Range High
- Passenger Mirror Vertical Sensor Out Of Range Low
- Rear Riser Down Position Stuck
- Rear Riser Sensor Out Of Range High
- Rear Riser Sensor Out Of Range Low
- Rear Riser Up Position Stuck
- Recliner Down Position Stuck
- Recliner Sensor Out Of Range High
- Recliner Sensor Out Of Range Low
- Recliner Up Position Stuck
- Driver Mirror Inoperative From Memory
- Memory Switch Inoperative
- Passenger Mirror Inoperative From Memory
- OTIS
- Notes
- Ambient Temperature Sensor Failure (Otis Displaying "SC" Or "OC")
- Distance To Empty Inoperative Or Wrong
- Elapsed Time Inoperative Or Wrong
- Incorrect Ambient Temperature Sensor Reading
- OTIS Mileage & Distance Function Malfunction
- OTIS Screen Displays FAIL
- OTIS Screen Displays No Values
- OTIS Segments Fail To Light Up
- OTIS Switch Test
- Power Door Locks/RKE System
- Notes
- Decklid Release Solenoid Output Failure
- Decklid Release Switch Failure
- Driver Door Central Lock (Arm)/Unlock (Disarm) Switch Failure
- Passenger Door Central Lock (Arm)/Unlock (Disarm) Switch Failure
- RKE Program Mode Entered Without Program Request
- RKE Unable To Enter Program Mode
- All Doors Failing To Lock & Unlock From Any Switch
- All Doors Failing To Lock & Unlock One Any Switch
- All Doors Failing To Lock From Any Switch
- All Doors Failing To Lock From One Switch
- All Doors Failing To Unlock From Any Switch
- All Doors Failing To Unlock From One Switch
- Automatic (Rolling) Door Locks
- Door Lock Inhibit Malfunction
- Driver Front Door Failing To Lock From Any Switch
- Driver Front Door Failing To Unlock From Any Switch
- Inoperative Decklid Release
- One Door Failing To Lock & Unlock From Any Switch
- Remote Keyless Entry (RKE) Problem
- RKE Horn Chirp Inoperative
- Speed Proportional Steering System
- VTSS
- Windshield Wiper System
- Notes
- Wiper Park Switch Failure/Wipers Run Continuously
- Washer Inoperative
- Washer Runs At All Times With Ignition On
- Wiper Not Working In Low Speed
- Wiper Erratic Operation In Intermittent Speeds
- Wiper No Wiper After Wash
- Wiper Not Working At All
- Wiper Not Working In High Speed
- Wiper Runs All The Time With Ignition On
- Verification Tests
- Removal & Installation
- Wiring Diagrams
- Body Control Modules
- Communication Devices
- Body Control Modules
- Description
- Operation
- Component Locations
- Programming
- Trouble Shooting
- Self-Diagnostic System
- System Tests
- Chime Systems
- Communications
- Notes
- ATC Messages Not Received
- Battery Voltage To Module Disconnected
- EATX Bus Communication Failure
- EEPROM Constant Checksum Failure
- Internal Base/Premium Select Failure
- MHSMM Messages Not Received
- MIC Message Not Received
- No PCI Messages From CD Changer
- OTIS Messages Not Received
- Post Failure
- SBEC Bus Communication Failure
- SKIM Messages Not Received
- Bus +/- Signal Open From SKIM
- Bus +/- Signals Open From Or Blank Screen On OTIS
- Diagnostic Readout Box (DRBIII(R)) Displays A Blank Screen
- Fused Ignition Switch Output To BCM
- No Response From Body Control Module (Bus +/- Signal Open)
- No Response From CAB
- No Response From ORC
- No Response From Powertrain Control Module (PCI Bus)
- No Response From Radio
- No Response From Transmission Control Module (TCM)
- Odometer Displays NO BUS
- PCI Bus Communication Failure
- Electrically Heated Systems
- Notes
- Driver Heated Seat Switch Open/Shorted To Ground
- Driver Heated Seat Switch Stuck In High/Low State
- Driver Seat Heat Output Open
- Driver Seat Heat Output Short To Gnd
- Driver Thermistor Out Of Range High
- Driver Thermistor Out Of Range Low
- Passenger Heated Seat Switch Open/Shorted To Ground
- Passenger Heated Seat Switch Stuck In High/Low State
- Passenger Seat Heat Output Open
- Passenger Seat Heat Output Short To Gnd
- Passenger Thermistor Out Of Range High
- Passenger Thermistor Out Of Range Low
- Rear Window Defogger Inoperative (Manual A/C)
- Rear Window Defogger Inoperative W/ATC
- Exterior Lighting Systems
- Notes
- Headlight Switch Input Failure
- Auto Lamps And/Or Fog Lights Not Operating Properly
- Fog Lights Will Not Turn Off
- Fog Lights Will Not Turn On
- Headlight Time Delay Inoperative
- High Beam Headlights Will Not Turn Off
- High Beam Headlights Will Not Turn On
- Low Beam Headlights Will Not Turn Off
- Low Beam Headlights Will Not Turn On
- Parking Lights Will Not Turn Off
- Parking Lights Will Not Turn On
- Instrument Cluster Systems
- Notes
- Dimming Level Switch Failure
- Fuel Level Sending Unit Failure
- No Messages From ABS
- No Messages From AECM
- No Messages From BCM
- No Messages From EATX
- No Messages From SBEC
- ABS Warning Indicator Not Operating Properly
- Air Bag Warning Indicator Not Operating Properly
- All Gauges Not Operating Correctly
- Brake Indicator Not Operating Properly
- Charging Indicator Not Operating Properly
- Check Engine Indicator Not Operating Properly
- Cluster & Panel Illumination Problems
- Cruise On Indicator Not Operating Properly
- Decklid Ajar Indicator Not Operating
- Door Ajar Indicator Not Operating Properly
- Engine Coolant Temperature Indicator Not Operating Properly
- Fuel Gauge Not Operating Properly
- Low Fuel Indicator Not Operating Properly
- Low Washer Fluid Indicator Not Operating Properly
- Odometer Not Operating Properly
- Oil Pressure Warning Indicator Not Operating Properly
- PRND3L Indicator Malfunctions
- Seat Belt Indicator Not Operating Properly
- Speedometer Gauge Not Operating Properly
- Tachometer Not Operating Properly
- Temperature Gauge Not Operating Properly
- Traction Off Indicator Not Operating Properly
- Traction On Indicator Not Operating Properly
- Interior Lighting Systems
- Notes
- Courtesy Light Output Short To Battery
- Courtesy Lights Inoperative With Door Open (All Lights)
- Courtesy Lights Inoperative With Door Open (Door Lights Only)
- Courtesy Lights Inoperative With Door Open (Overhead Console Lights Only)
- Courtesy Lights Inoperative From Headlight Switch
- Courtesy Lights Inoperative With Driver's Door Open
- Courtesy Lights Inoperative With Left Rear Door Open
- Courtesy Lights Inoperative With Passenger's Door Open
- Courtesy Lights Inoperative With Right Rear Door Open
- Courtesy Lights Stay On At All Times
- Memory Systems
- Notes
- Driver Mirror Horizontal Sensor Out Of Range High
- Driver Mirror Horizontal Sensor Out Of Range Low
- Driver Mirror Vertical Sensor Out Of Range High
- Driver Mirror Vertical Sensor Out Of Range Low
- Front Riser Down Position Stuck
- Front Riser Sensor Out Of Range High
- Front Riser Sensor Out Of Range Low
- Front Riser Up Position Stuck
- Horizontal Forward Position Stuck
- Horizontal Rearward Position Stuck
- Horizontal Sensor Out Of Range High
- Horizontal Sensor Out Of Range Low
- Memory Position No. 1 Stuck
- Memory Position No. 2 Stuck
- Memory Set "S" Position Stuck
- Passenger Mirror Horizontal Sensor Out Of Range High
- Passenger Mirror Horizontal Sensor Out Of Range Low
- Passenger Mirror Vertical Sensor Out Of Range High
- Passenger Mirror Vertical Sensor Out Of Range Low
- Rear Riser Down Position Stuck
- Rear Riser Sensor Out Of Range High
- Rear Riser Sensor Out Of Range Low
- Rear Riser Up Position Stuck
- Recliner Down Position Stuck
- Recliner Sensor Out Of Range High
- Recliner Sensor Out Of Range Low
- Recliner Up Position Stuck
- Driver Mirror Inoperative From Memory
- Memory Switch Inoperative
- Passenger Mirror Inoperative From Memory
- OTIS
- Notes
- Ambient Temperature Sensor Failure (Otis Displaying "SC" Or "OC")
- Distance To Empty Inoperative Or Wrong
- Elapsed Time Inoperative Or Wrong
- Incorrect Ambient Temperature Sensor Reading
- OTIS Mileage & Distance Function Malfunction
- OTIS Screen Displays FAIL
- OTIS Screen Displays No Values
- OTIS Segments Fail To Light Up
- OTIS Switch Test
- Power Door Locks/RKE System
- Notes
- Decklid Release Solenoid Output Failure
- Decklid Release Switch Failure
- Driver Door Central Lock (Arm)/Unlock (Disarm) Switch Failure
- Passenger Door Central Lock (Arm)/Unlock (Disarm) Switch Failure
- RKE Program Mode Entered Without Program Request
- RKE Unable To Enter Program Mode
- All Doors Failing To Lock & Unlock From Any Switch
- All Doors Failing To Lock & Unlock One Any Switch
- All Doors Failing To Lock From Any Switch
- All Doors Failing To Lock From One Switch
- All Doors Failing To Unlock From Any Switch
- All Doors Failing To Unlock From One Switch
- Automatic (Rolling) Door Locks
- Door Lock Inhibit Malfunction
- Driver Front Door Failing To Lock From Any Switch
- Driver Front Door Failing To Unlock From Any Switch
- Inoperative Decklid Release
- One Door Failing To Lock & Unlock From Any Switch
- Remote Keyless Entry (RKE) Problem
- RKE Horn Chirp Inoperative
- Speed Proportional Steering System
- VTSS
- Windshield Wiper System
- Notes
- Wiper Park Switch Failure/Wipers Run Continuously
- Washer Inoperative
- Washer Runs At All Times With Ignition On
- Wiper Not Working In Low Speed
- Wiper Erratic Operation In Intermittent Speeds
- Wiper No Wiper After Wash
- Wiper Not Working At All
- Wiper Not Working In High Speed
- Wiper Runs All The Time With Ignition On
- Verification Tests
- Removal & Installation
- Wiring Diagrams
- Body Control Modules
- Cruise Control Systems
- Exterior Lights
- Gauges & Instrument Panels
- Analog Instrument Panels
- Overhead Console
- Headlights
- Heated Glass/Defoggers
- Interior/Illumination Lights
- Mirrors
- Seats
- Steering Column Switches
- Description
- Component Locations
- Adjustments
- Trouble Shooting
- Horn System
- Turn Signal And Hazard Flasher System
- System Does Not Flash On One Side & Indicator Light Flashes At Twice Normal Rate
- Indicator Light Flashes At Twice Normal Rate (External Light Flashes Rapidly Or No Flash)
- Hazard Flashers Inoperative
- Indicator Light Flashes At Twice Normal Rate (External Light Inoperative)
- System Does Not Flash On Either Side
- Turn Signals Do Not Cancel After Turn
- Indicator Light Inoperative (External Lights Okay)
- System Tests
- Component Tests
- Removal & Installation
- Torque Specifications
- Wiring Diagrams
- Warning Systems
- Window Motors & Regulators
- Wiper/Washer Systems
- Wiper System & Washer System
- Description & Operation
- Component Locations
- Adjustments
- Trouble Shooting
- Notes
- Washers
- Washer Power Feed Fuse Open
- Washer System Will Not Flow Fluid
- Washer Nozzle Does Not Flow Fluid
- Washer Fluid Output Is Low
- Washer Nozzle Overshoots Windshield
- Wiper Does Not Cycle When Washer Button Is Depressed
- Washer System Operates Intermittently
- Washer Fluid Level Indicator Inoperative
- Washer Fluid Leaking
- Wipers
- Wiper Motor Will Not Operate
- Wiper Motor Inoperative In High Position
- Wiper Motor Operates In Intermittent Position Only
- Wiper Motor Operates In High Position Only
- Wiper Motor Switches Between Low & High Speed Operation
- Wipers Do Not Park When Wiper Switch Is Turned Off
- Wipers Do Not Park When Ignition Switch Is Turned Off
- Wiper Motor Runs Past Park Position
- Wiper System Makes Knocking Noise
- Wiper Blade Chatter
- Wiper Arms Do Not Move With Motor Running
- System Tests
- Notes
- Washer Inoperative
- Fuse Blows When Washer Switch Is Depressed
- Wipers Do Not Run When Washer Is Engaged
- Washer Fluid Level Indicator Inoperative
- Wipers Inoperative
- Wipers Run Slowly At All Speeds
- Wiper Motor Inoperative In High Position
- Wiper Motor Operates In High Position Only
- Wipers Run At One Speed Only
- Wipers Operate At High Speed With Switch In Any Position
- Wipers Run At Low Speed With Switch In High Speed Position
- Wiper Motor Runs When Ignition Switch Is On & Wiper Switch Is Turned Off
- Wipers Run Continuously With Switch In Intermittent Position & Wipers Do Not Park
- Wipers Do Not Park
- Component Tests
- Removal & Installation
- Wiring Diagrams
- Wiper System & Washer System
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Data Link Connector Wiring Diagrams
- Data Link Connectors Wiring Diagram (Avenger & SEBRING Coupe)
- Data Link Connectors Wiring Diagram (Breeze, Cirrus & Stratus)
- Data Link Connectors Wiring Diagram (Caravan, Town & Country, & Voyager)
- Data Link Connectors Wiring Diagram (CONCORDE, Intrepid, LHS & 300M)
- Data Link Connectors Wiring Diagram (DAKOTA)
- Data Link Connectors Wiring Diagram (DURANGO)
- Data Link Connectors Wiring Diagram (Neon)
- Data Link Connectors Wiring Diagram (Ram Van & Ram Wagon)
- Data Link Connectors Wiring Diagram (Ram Pickup)
- Ground Distribution - Wiring Diagrams
- Avenger & SEBRING Ground Distribution Wiring Diagram
- Breeze, Cirrus & Stratus Ground Distribution Wiring Diagram
- Caravan, Town & Country, & Voyager Ground Distribution Wiring Diagram
- CONCORDE, Intrepid, LHS & 300M Ground Distribution Wiring Diagram
- DAKOTA Ground Distribution Wiring Diagram
- DURANGO Ground Distribution Wiring Diagram
- Neon Ground Distribution Wiring Diagram
- Ram Pickup Ground Distribution Wiring Diagram
- Ram Van & Ram Wagon Ground Distribution Wiring Diagram
- Power Distribution - Wiring Diagrams
- Avenger & SEBRING Coupe Power Distribution Wiring Diagram
- Breeze, Cirrus & Stratus Power Distribution Wiring Diagram
- Caravan, Town & Country, & Voyager Power Distribution Wiring Diagram
- CONCORDE, Intrepid, LHS & 300M Power Distribution Wiring Diagram
- DAKOTA Power Distribution Wiring Diagram
- DURANGO Power Distribution Wiring Diagram
- Neon Power Distribution Wiring Diagram
- Ram Pickup Power Distribution Wiring Diagram
- Ram Van & Ram Wagon Power Distribution Wiring Diagram
- SEBRING Convertible Power Distribution Wiring Diagram
- Data Link Connector Wiring Diagrams
- Anti-Theft Systems
- Body & Frame
- Body, Cab Control Systems
- Body Control Modules
- Description
- Operation
- Component Locations
- Programming
- Trouble Shooting
- Self-Diagnostic System
- System Tests
- Chime Systems
- Communications
- Notes
- ATC Messages Not Received
- Battery Voltage To Module Disconnected
- EATX Bus Communication Failure
- EEPROM Constant Checksum Failure
- Internal Base/Premium Select Failure
- MHSMM Messages Not Received
- MIC Message Not Received
- No PCI Messages From CD Changer
- OTIS Messages Not Received
- Post Failure
- SBEC Bus Communication Failure
- SKIM Messages Not Received
- Bus +/- Signal Open From SKIM
- Bus +/- Signals Open From Or Blank Screen On OTIS
- Diagnostic Readout Box (DRBIII(R)) Displays A Blank Screen
- Fused Ignition Switch Output To BCM
- No Response From Body Control Module (Bus +/- Signal Open)
- No Response From CAB
- No Response From ORC
- No Response From Powertrain Control Module (PCI Bus)
- No Response From Radio
- No Response From Transmission Control Module (TCM)
- Odometer Displays NO BUS
- PCI Bus Communication Failure
- Electrically Heated Systems
- Notes
- Driver Heated Seat Switch Open/Shorted To Ground
- Driver Heated Seat Switch Stuck In High/Low State
- Driver Seat Heat Output Open
- Driver Seat Heat Output Short To Gnd
- Driver Thermistor Out Of Range High
- Driver Thermistor Out Of Range Low
- Passenger Heated Seat Switch Open/Shorted To Ground
- Passenger Heated Seat Switch Stuck In High/Low State
- Passenger Seat Heat Output Open
- Passenger Seat Heat Output Short To Gnd
- Passenger Thermistor Out Of Range High
- Passenger Thermistor Out Of Range Low
- Rear Window Defogger Inoperative (Manual A/C)
- Rear Window Defogger Inoperative W/ATC
- Exterior Lighting Systems
- Notes
- Headlight Switch Input Failure
- Auto Lamps And/Or Fog Lights Not Operating Properly
- Fog Lights Will Not Turn Off
- Fog Lights Will Not Turn On
- Headlight Time Delay Inoperative
- High Beam Headlights Will Not Turn Off
- High Beam Headlights Will Not Turn On
- Low Beam Headlights Will Not Turn Off
- Low Beam Headlights Will Not Turn On
- Parking Lights Will Not Turn Off
- Parking Lights Will Not Turn On
- Instrument Cluster Systems
- Notes
- Dimming Level Switch Failure
- Fuel Level Sending Unit Failure
- No Messages From ABS
- No Messages From AECM
- No Messages From BCM
- No Messages From EATX
- No Messages From SBEC
- ABS Warning Indicator Not Operating Properly
- Air Bag Warning Indicator Not Operating Properly
- All Gauges Not Operating Correctly
- Brake Indicator Not Operating Properly
- Charging Indicator Not Operating Properly
- Check Engine Indicator Not Operating Properly
- Cluster & Panel Illumination Problems
- Cruise On Indicator Not Operating Properly
- Decklid Ajar Indicator Not Operating
- Door Ajar Indicator Not Operating Properly
- Engine Coolant Temperature Indicator Not Operating Properly
- Fuel Gauge Not Operating Properly
- Low Fuel Indicator Not Operating Properly
- Low Washer Fluid Indicator Not Operating Properly
- Odometer Not Operating Properly
- Oil Pressure Warning Indicator Not Operating Properly
- PRND3L Indicator Malfunctions
- Seat Belt Indicator Not Operating Properly
- Speedometer Gauge Not Operating Properly
- Tachometer Not Operating Properly
- Temperature Gauge Not Operating Properly
- Traction Off Indicator Not Operating Properly
- Traction On Indicator Not Operating Properly
- Interior Lighting Systems
- Notes
- Courtesy Light Output Short To Battery
- Courtesy Lights Inoperative With Door Open (All Lights)
- Courtesy Lights Inoperative With Door Open (Door Lights Only)
- Courtesy Lights Inoperative With Door Open (Overhead Console Lights Only)
- Courtesy Lights Inoperative From Headlight Switch
- Courtesy Lights Inoperative With Driver's Door Open
- Courtesy Lights Inoperative With Left Rear Door Open
- Courtesy Lights Inoperative With Passenger's Door Open
- Courtesy Lights Inoperative With Right Rear Door Open
- Courtesy Lights Stay On At All Times
- Memory Systems
- Notes
- Driver Mirror Horizontal Sensor Out Of Range High
- Driver Mirror Horizontal Sensor Out Of Range Low
- Driver Mirror Vertical Sensor Out Of Range High
- Driver Mirror Vertical Sensor Out Of Range Low
- Front Riser Down Position Stuck
- Front Riser Sensor Out Of Range High
- Front Riser Sensor Out Of Range Low
- Front Riser Up Position Stuck
- Horizontal Forward Position Stuck
- Horizontal Rearward Position Stuck
- Horizontal Sensor Out Of Range High
- Horizontal Sensor Out Of Range Low
- Memory Position No. 1 Stuck
- Memory Position No. 2 Stuck
- Memory Set "S" Position Stuck
- Passenger Mirror Horizontal Sensor Out Of Range High
- Passenger Mirror Horizontal Sensor Out Of Range Low
- Passenger Mirror Vertical Sensor Out Of Range High
- Passenger Mirror Vertical Sensor Out Of Range Low
- Rear Riser Down Position Stuck
- Rear Riser Sensor Out Of Range High
- Rear Riser Sensor Out Of Range Low
- Rear Riser Up Position Stuck
- Recliner Down Position Stuck
- Recliner Sensor Out Of Range High
- Recliner Sensor Out Of Range Low
- Recliner Up Position Stuck
- Driver Mirror Inoperative From Memory
- Memory Switch Inoperative
- Passenger Mirror Inoperative From Memory
- OTIS
- Notes
- Ambient Temperature Sensor Failure (Otis Displaying "SC" Or "OC")
- Distance To Empty Inoperative Or Wrong
- Elapsed Time Inoperative Or Wrong
- Incorrect Ambient Temperature Sensor Reading
- OTIS Mileage & Distance Function Malfunction
- OTIS Screen Displays FAIL
- OTIS Screen Displays No Values
- OTIS Segments Fail To Light Up
- OTIS Switch Test
- Power Door Locks/RKE System
- Notes
- Decklid Release Solenoid Output Failure
- Decklid Release Switch Failure
- Driver Door Central Lock (Arm)/Unlock (Disarm) Switch Failure
- Passenger Door Central Lock (Arm)/Unlock (Disarm) Switch Failure
- RKE Program Mode Entered Without Program Request
- RKE Unable To Enter Program Mode
- All Doors Failing To Lock & Unlock From Any Switch
- All Doors Failing To Lock & Unlock One Any Switch
- All Doors Failing To Lock From Any Switch
- All Doors Failing To Lock From One Switch
- All Doors Failing To Unlock From Any Switch
- All Doors Failing To Unlock From One Switch
- Automatic (Rolling) Door Locks
- Door Lock Inhibit Malfunction
- Driver Front Door Failing To Lock From Any Switch
- Driver Front Door Failing To Unlock From Any Switch
- Inoperative Decklid Release
- One Door Failing To Lock & Unlock From Any Switch
- Remote Keyless Entry (RKE) Problem
- RKE Horn Chirp Inoperative
- Speed Proportional Steering System
- VTSS
- Windshield Wiper System
- Notes
- Wiper Park Switch Failure/Wipers Run Continuously
- Washer Inoperative
- Washer Runs At All Times With Ignition On
- Wiper Not Working In Low Speed
- Wiper Erratic Operation In Intermittent Speeds
- Wiper No Wiper After Wash
- Wiper Not Working At All
- Wiper Not Working In High Speed
- Wiper Runs All The Time With Ignition On
- Verification Tests
- Removal & Installation
- Wiring Diagrams
- Body Control Modules
- Door Locks
- Anti-Theft Systems
- Power Door Lock System & Trunk Release System
- Remote Keyless Entry System
- Shift Interlock System
- Mirrors
- Seats
- Sun Roof/T-Top/Convertible Top
- Power Roof System
- Description & Operation
- Adjustments
- Trouble Shooting
- Notes
- Sun Roof Motor Inoperative
- Audible Whine When Switch Is Depressed, Sun Roof Does Not Operate
- Audible Clicking Or Ratcheting When Switch Is Depressed, Sun Roof Does Not Operate
- Sun Roof Vents & Opens, But Does Not Close
- Sun Roof Vents, But Does Not Open
- Sun Roof Does Not Vent
- Sun Roof Water Leak
- Wind Noise From Sun Roof
- Sun Roof Rattles In Open Or Closed Position While Driving
- Removal & Installation
- Wiring Diagrams
- Power Roof System
- Power Windows
- Body, Cab Control Systems
- Brakes
- Anti-Lock Brakes
- Anti-Lock Brake System - TEVES Mark 20
- Description
- Operation
- Bleeding Brake System
- Diagnosis & Testing
- Connector Identification
- Diagnostic Tests
- Notes
- Test 1A: Abs Warning Light
- Test 2A: Cab Power Feed Circuit
- Test 3A: Controller Failure
- Test 4A: Left Front Sensor Circuit Failure
- Test 5A: Left Front Sensor Signal Failure
- Test 6A: Left Rear Sensor Circuit Failure
- Test 7A: Left Rear Sensor Signal Failure
- Test 8A: PCI Bus Communication
- Test 9A: Pump Motor Not Working Properly
- Test 10A: Right Front Sensor Circuit Failure
- Test 11A: Right Front Sensor Signal Failure
- Test 12A: Right Rear Sensor Circuit Failure
- Test 13A: Right Rear Sensor Signal Failure
- Test 14A: System OVERVOLTAGE
- Test 15A: System UNDERVOLTAGE
- Test 16A: BRAKELIGHT Switch
- Test 17A: TRAC Off Indicator Always/Never On
- Test 18A: TRAC On Indicator Always/Never On
- Test VER-1A: Verification Test
- Component Tests
- Removal & Installation
- Adjustments
- Torque Specifications
- Wiring Diagrams
- Anti-Lock Brake System - Wiring
- Anti-Lock Brake System - TEVES Mark 20
- Mechanical - Hydraulic
- Disc Brakes
- Description & Operation
- Bleeding Brake System
- Adjustments
- System Tests
- Component Tests
- Removal & Installation
- Overhaul
- Disc Brake Specifications
- Torque Specifications
- Disc Brakes
- Parking Brake System
- Disc Brakes
- Description & Operation
- Bleeding Brake System
- Adjustments
- System Tests
- Component Tests
- Removal & Installation
- Overhaul
- Disc Brake Specifications
- Torque Specifications
- Disc Brakes
- Traction Control
- Anti-Lock Brake System - TEVES Mark 20
- Description
- Operation
- Bleeding Brake System
- Diagnosis & Testing
- Connector Identification
- Diagnostic Tests
- Notes
- Test 1A: Abs Warning Light
- Test 2A: Cab Power Feed Circuit
- Test 3A: Controller Failure
- Test 4A: Left Front Sensor Circuit Failure
- Test 5A: Left Front Sensor Signal Failure
- Test 6A: Left Rear Sensor Circuit Failure
- Test 7A: Left Rear Sensor Signal Failure
- Test 8A: PCI Bus Communication
- Test 9A: Pump Motor Not Working Properly
- Test 10A: Right Front Sensor Circuit Failure
- Test 11A: Right Front Sensor Signal Failure
- Test 12A: Right Rear Sensor Circuit Failure
- Test 13A: Right Rear Sensor Signal Failure
- Test 14A: System OVERVOLTAGE
- Test 15A: System UNDERVOLTAGE
- Test 16A: BRAKELIGHT Switch
- Test 17A: TRAC Off Indicator Always/Never On
- Test 18A: TRAC On Indicator Always/Never On
- Test VER-1A: Verification Test
- Component Tests
- Removal & Installation
- Adjustments
- Torque Specifications
- Wiring Diagrams
- Anti-Lock Brake System - Wiring
- Anti-Lock Brake System - TEVES Mark 20
- Anti-Lock Brakes
- Drivelines & Axles
- Electrical
- Charging Systems
- Charging System - Generators & Regulators
- Description
- Operation
- Adjustments
- Trouble Shooting
- Self-Diagnostic System
- Self-Diagnostic Tests
- Notes
- DTC Test: Checking System For Diagnostic Trouble Codes
- DTC P0622: Generator Field Not Switching Properly
- DTC P1492/P1493: Battery Temp Sensor Voltage Too High/Battery Temp Sensor Voltage Too Low (Breeze, Cirrus, SEBRING Convertible & Stratus)
- DTC P1492/P1493: Battery Temp Sensor Voltage Too High/Battery Temp Sensor Voltage Too Low (CONCORDE, Intrepid, LHS & 300M)
- DTC P1594: Charging System Voltage Too High
- DTC P1682: Charging System Voltage Too Low
- Test Ch-1A: Charging System No Code Test
- Ambient Temperature Sensor Test (CONCORDE, Intrepid, LHS & 300M)
- Test VER-3A: Charging Verification
- Test VER-5A: Road Test Verification
- On-Vehicle Testing
- Removal & Installation
- Notes
- Generator
- Removal & Installation (2.0L Sebring Coupe)
- Removal & Installation (2.0L Breeze & Stratus)
- Removal & Installation (2.0L Neon)
- Removal & Installation (2.4L)
- Removal & Installation (2.5L Avenger)
- Removal & Installation (2.5L Cirrus, Sebring Convertible & Stratus)
- Removal & Installation (2.7L)
- Removal & Installation (3.2L & 3.5L)
- Overhaul
- Torque Specifications
- Wiring Diagrams
- Charging System - Generators & Regulators
- Component Locations
- Fuses & Circuit Breakers
- Gauges
- Analog Instrument Panels
- Overhead Console
- Starter
- Starting System - Except Coupe
- Description
- Trouble Shooting
- On-Vehicle Testing
- Bench Testing
- Overhaul
- Starter Motor
- Starter Specifications
- Torque Specifications
- Wiring Diagrams
- Starting System - Except Coupe
- Using lemon2025'S System Wiring Diagrams
- Charging Systems
- Engine Mechanical
- Accessory Drive Belts
- Engine Cooling System Specifications & Drive Belt Routing
- Cooling System Bleeding
- Belt Adjustment
- Drive Belt Routing
- Drive Belt (2.0L & 2.4L Neon & Pt Cruiser)
- Drive Belt (2.0L, 2.4L, 2.5L, 2.7L & 3.0L V6 Breeze, Caravan, Cirrus, SEBRING Convertible, Stratus Sedan - 2000 & Voyager)
- Drive Belt (2.4L SEBRING Coupe & Stratus Coupe)
- Drive Belt (2.4L SEBRING Sedan & Stratus Sedan - 2001)
- Drive Belt (2.5L Avenger, SEBRING Coupe & Stratus Coupe)
- DRIVE BELT (2.5L Dakota With A/C)
- DRIVE BELT (2.5L Dakota Without A/C)
- Drive Belt (2.7L CONCORDE, Intrepid, LHS & 300M)
- Drive Belt (3.0L Caravan & Voyager)
- Drive Belt (3.0L SEBRING Coupe & Stratus Coupe)
- Drive Belt (3.2L & 3.5L CONCORDE, Intrepid, LHS, Prowler & 300M)
- Drive Belt (3.3L & 3.8L Caravan, Town & Country, & Voyager) (2000)
- Drive Belt (3.3L & 3.8L Caravan, Town & Country, & Voyager) (2001)
- Drive Belt (3.9L, 5.2L & 5.9L Gasoline - DAKOTA, DURANGO, Ram Pickup & Ram Van/Wagon)
- Drive Belt (4.7L DAKOTA & DURANGO)
- Drive Belt (5.9L Diesel - Ram Pickup)
- Drive Belt (5.9L & 8.0L Gasoline - Ram Pickup)
- Specifications
- Engine Cooling System Specifications & Drive Belt Routing
- Electric Cooling Fans
- Cooling System (Mechanical)
- Engine Cooling System Specifications & Drive Belt Routing
- Cooling System Bleeding
- Belt Adjustment
- Drive Belt Routing
- Drive Belt (2.0L & 2.4L Neon & Pt Cruiser)
- Drive Belt (2.0L, 2.4L, 2.5L, 2.7L & 3.0L V6 Breeze, Caravan, Cirrus, SEBRING Convertible, Stratus Sedan - 2000 & Voyager)
- Drive Belt (2.4L SEBRING Coupe & Stratus Coupe)
- Drive Belt (2.4L SEBRING Sedan & Stratus Sedan - 2001)
- Drive Belt (2.5L Avenger, SEBRING Coupe & Stratus Coupe)
- DRIVE BELT (2.5L Dakota With A/C)
- DRIVE BELT (2.5L Dakota Without A/C)
- Drive Belt (2.7L CONCORDE, Intrepid, LHS & 300M)
- Drive Belt (3.0L Caravan & Voyager)
- Drive Belt (3.0L SEBRING Coupe & Stratus Coupe)
- Drive Belt (3.2L & 3.5L CONCORDE, Intrepid, LHS, Prowler & 300M)
- Drive Belt (3.3L & 3.8L Caravan, Town & Country, & Voyager) (2000)
- Drive Belt (3.3L & 3.8L Caravan, Town & Country, & Voyager) (2001)
- Drive Belt (3.9L, 5.2L & 5.9L Gasoline - DAKOTA, DURANGO, Ram Pickup & Ram Van/Wagon)
- Drive Belt (4.7L DAKOTA & DURANGO)
- Drive Belt (5.9L Diesel - Ram Pickup)
- Drive Belt (5.9L & 8.0L Gasoline - Ram Pickup)
- Specifications
- Engine Cooling System Specifications & Drive Belt Routing
- Mechanical
- 2.7L V6 Engine
- Engine Identification
- Adjustments
- Trouble Shooting
- Removal & Installation
- Notes
- Fuel Pressure Release
- Fuel Line Quick-Connect Fitting
- Cooling System Bleeding
- Radiator
- Engine
- Intake Manifold
- Exhaust Manifold
- Cylinder Head
- Crankshaft Oil Seal (Front)
- Crankshaft Oil Seal (Rear)
- Rear Crankshaft Oil Seal Retainer
- Primary Timing Chain & Sprockets
- Rocker Arm & Valve Lash Adjuster
- Camshafts
- Water Pump
- Thermostat
- Oil Pan
- Overhaul
- Engine Oiling
- Torque Specifications
- Engine Specifications
- 2.7L V6 Engine
- Starter
- Starting System - Except Coupe
- Description
- Trouble Shooting
- On-Vehicle Testing
- Bench Testing
- Overhaul
- Starter Motor
- Starter Specifications
- Torque Specifications
- Wiring Diagrams
- Starting System - Except Coupe
- Timing Belt Replacement - 3.2L & 3.5L
- Accessory Drive Belts
- Engine Performance
- Engine Controls - On-Vehicle Adjustments
- Application
- Emissions
- Emission Applications
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Remove, Overhaul & Install
- Engine Controls - Removal, Overhaul & Installation
- Introduction
- Air Induction Systems
- Cooling System
- Computerized Engine Controls
- Engine Sensors & Switches
- A/C Pressure Sensor
- A/C Temperature Sensor
- Ambient Temperature Sensor
- Battery Temperature Sensor
- Brake Switch
- Camshaft Position Sensor
- Crankshaft Position Sensor
- Downstream Oxygen Sensor
- EGR Position Sensor
- Engine Coolant Temperature Sensor
- Input/Output Speed Sensors
- Intake Air Temperature (IAT) Sensor
- Knock Sensor
- Manifold Absolute Pressure (Map) Sensor
- Manifold Absolute Pressure (Map)/Intake Air Temperature (IAT) Sensor
- Park/Neutral Switch
- Power Steering Pressure Switch
- Throttle Position (TP) Sensor
- Transmission Range Sensor
- Transmission Temperature Sensor
- Upstream Oxygen Sensor
- Removal (Avenger & Sebring Coupe)
- Installation (Avenger & Sebring Coupe)
- Removal (Breeze, Cirrus & Stratus - 2.0L & 2.4L & Neon)
- Installation (Breeze, Cirrus & Stratus - 2.0L & 2.4L & Neon)
- Removal (Cirrus, Sebring Convertible & Stratus - 2.5L)
- Installation (Cirrus, Sebring Convertible & Stratus - 2.5L)
- Removal (Concorde, Intrepid, LHS & 300M)
- Installation (Concorde, Intrepid, LHS & 300M)
- Vehicle Speed Sensor
- Motors, Relays & Solenoids
- Ignition System
- Camshaft Position Sensor
- Removal & Installation (Avenger, Cirrus, Sebring Convertible, Sebring Coupe & Stratus - 2.5L)
- Removal & Installation (Breeze, Cirrus, Stratus - 2.0L & Neon)
- Removal & Installation (Breeze, Cirrus & Stratus - 2.4L)
- Removal (Concorde & Intrepid - 2.7L)
- Installation (Concorde & Intrepid - 2.7L)
- Removal (Concorde, Intrepid, LHS & 300M - 3.2L & 3.5L)
- Installation (Concorde, Intrepid, LHS & 300M - 3.2L & 3.5L)
- Crankshaft Position Sensor
- Removal & Installation (Avenger & Sebring Coupe)
- Removal & Installation (Breeze, Cirrus & Stratus - 2.0L & 2.4L & Neon)
- Removal (Cirrus, Sebring Convertible & Stratus - 2.5L)
- Installation (Cirrus, Sebring Convertible & Stratus - 2.5L)
- Removal (Concorde, Intrepid, LHS & 300M)
- Installation (Concorde, Intrepid, LHS & 300M)
- Distributor
- Ignition Coil
- Knock Sensor
- Camshaft Position Sensor
- Fuel Systems
- Fuel System Pressure Release
- Fuel Line Disconnect Fittings
- Fuel Filter
- Fuel Filter/Fuel Pressure Regulator
- Fuel Level Sensor
- Fuel Pressure Regulator
- Fuel Pump
- Fuel Pump Inlet Strainer
- Fuel Pump Module
- Fuel Tank
- Removal (Avenger & Sebring Coupe)
- Installation (Avenger & Sebring Coupe)
- Removal (Breeze, Cirrus & Stratus)
- Installation (Breeze, Cirrus & Stratus)
- Removal (Sebring Convertible)
- Installation (Sebring Convertible)
- Removal (Concorde, Intrepid, LHS & 300M)
- Installation (Concorde, Intrepid, LHS & 300M)
- Removal (Neon)
- Installation (Neon)
- Fuel Rail & Injectors
- Removal (Avenger & Sebring Coupe)
- Installation (Avenger & Sebring Coupe)
- Removal (Breeze, Cirrus & Stratus - 2.0L & 2.4L & Neon)
- Installation (Breeze, Cirrus & Stratus - 2.0L & 2.4L & Neon)
- Removal (Cirrus, Sebring Convertible & Stratus - 2.5L)
- Installation (Cirrus, Sebring Convertible & Stratus - 2.5L)
- Removal (Concorde, Intrepid, LHS & 300M)
- Installation (Concorde, Intrepid, LHS & 300M)
- Throttle Body
- Removal & Installation (Avenger & Sebring Coupe)
- Removal (Breeze, Cirrus & Stratus - 2.0L & 2.4L)
- Installation (Breeze, Cirrus & Stratus - 2.0L & 2.4L)
- Removal & Installation (Cirrus, Sebring Convertible & Stratus - 2.5L)
- Removal & Installation (Concorde & Intrepid - 2.7L)
- Removal (Concorde, Intrepid, LHS & 300M - 3.2L & 3.5L)
- Installation (Concorde, Intrepid, LHS & 300M - 3.2L & 3.5L)
- Removal (Neon)
- Emission Systems
- EGR Position Sensor
- EGR Solenoid
- EGR Valve Assembly
- Removal & Installation (Avenger & Sebring Coupe)
- Removal & Installation (Breeze, Cirrus & Stratus - 2.0L & 2.4L)
- Removal & Installation (Cirrus, Sebring Convertible & Stratus - 2.5L)
- Removal (Concorde & Intrepid - 2.7L)
- Installation (Concorde & Intrepid - 2.7L)
- Removal (Concorde, Intrepid, LHS & 300M - 3.2L & 3.5L)
- Installation (Concorde, Intrepid, LHS & 300M - 3.2L & 3.5L)
- EVAP Canister
- EVAP Purge Solenoid
- EVAP Leak Detection Pump
- Miscellaneous Controls
- Torque Specifications
- Engine Controls - Removal, Overhaul & Installation
- Engine Controls - Service & Adjustment Specifications
- Introduction
- Capacities
- Quick-Service
- Mechanical Checks
- Ignition System
- Fuel System
- System
- Engine Controls - Basic Engine Testing
- Engine Controls - Self-Diagnostics
- Introduction
- Self-Diagnostic System
- Powertrain Control Module Location
- Programming
- Fuel System Pressure Release
- Diagnostic Trouble Code Definitions
- Diagnostic Tests
- Notes
- DTC P0106: Barometric Pressure Out Of Range
- DTC P0107: Map Sensor Voltage Too Low
- DTC P0108: Map Sensor Voltage Too High
- DTC P0112: Intake Air Temp Sensor Voltage Low
- DTC P0113: Intake Air Temp Sensor Voltage High
- DTC P0117: ECT Sensor Voltage Too Low
- DTC P0118: ECT Sensor Voltage Too High
- DTC P0121: TPS Voltage Does Not Agree With Map
- DTC P0122: Throttle Position Sensor Voltage Low
- DTC P0123: Throttle Position Sensor Voltage High
- DTC P0125: Closed Loop Temp Not Reached Or DTC P1281: Engine Is Cold Too Long
- DTC P0131: 1/1 O2 Sensor Shorted To Ground
- DTC P0132: 1/1 O2 Sensor Shorted To Voltage
- DTC P0133: 1/1 O2 Sensor Slow Response
- DTC P0134: 1/1 O2 Sensor Stays At Center
- DTC P0135: 1/1 O2 Sensor Heater Failure
- DTC P0137: 1/2 O2 Sensor Shorted To Ground
- DTC P0138: 1/2 O2 Sensor Shorted To Voltage
- DTC P0139: 1/2 O2 Sensor Slow Response
- DTC P0140: 1/2 O2 Sensor Stays At Center
- DTC P0141: 1/2 O2 Sensor Heater Failure
- DTC P0151: 2/1 O2 Sensor Shorted To Ground
- DTC P0152: 2/1 O2 Sensor Shorted To Voltage
- DTC P0153: 2/1 O2 Sensor Slow Response
- DTC P0154: 2/1 O2 Sensor Stays At Center
- DTC P0155: 2/1 O2 Sensor Heater Failure
- DTC P0157: 2/2 O2 Sensor Shorted To Ground
- DTC P0158: 2/2 O2 Sensor Shorted To Voltage
- DTC P0160: 2/2 O2 Sensor Stays At Center
- DTC P0161: 2/2 O2 Sensor Heater Failure
- DTC P0171: 1/1 Fuel System Lean Or DTC P0174: 2/1 Fuel System Lean
- DTC P0172: 1/1 Fuel System Rich Or DTC P0175: 2/1 Fuel System Rich
- DTC P0201: Injector #1 Control Circuit
- DTC P0202: Injector #2 Control Circuit
- DTC P0203: Injector #3 Control Circuit
- DTC P0204: Injector #4 Control Circuit
- DTC P0205: Injector #5 Control Circuit
- DTC P0206 Injector #6 Control Circuit
- DTC P0300: Multiple Cylinder Misfire
- DTC P0301-P0306: Cylinder Misfire
- DTC P0320: No Crank Reference Signal At Pcm
- DTC P0325: Knock Sensor #1 Circuit
- DTC P0340: No Cam Signal At Pcm
- DTC P0351: Ignition Coil #1 Primary Circuit
- DTC P0352: Ignition Coil #2 Primary Circuit
- DTC P0353: Ignition Coil #3 Primary Circuit
- DTC P0354: Ignition Coil #4 Primary Circuit
- DTC P0355: Ignition Coil #5 Primary Circuit
- DTC P0356: Ignition Coil #6 Primary Circuit
- DTC P0401: EGR System Failure
- DTC P0403: EGR Solenoid Circuit
- DTC P0404: EGR Position Sensor Rationality
- DTC P0405: EGR Position Sensor Voltage Too Low
- DTC P0406: EGR Position Sensor Voltage Too High
- DTC P0420: 1/1 Catalytic Converter Efficiency
- DTC P0432: 2/1 Catalytic Converter Efficiency
- DTC P0441: EVAP Purge Flow Monitor
- DTC P0442: EVAP Leak Monitor Medium (.040") Leak Detected Or DTC P0455: EVAP Leak Monitor Large Leak Detected
- DTC P0443: EVAP Purge Solenoid Circuit
- DTC P0460: Fuel Level Unit No Change Over Miles
- DTC P0462: Fuel Level Sending Unit Volts Too Low Or DTC P0463: Fuel Level Sending Unit Volts Too High
- DTC P0500: No Vehicle Speed Signal
- DTC P0505: Idle Air Control Motor Circuits
- DTC P0551: Power Steering Switch Failure
- DTC P0600: Pcm Failure SPI Communications
- DTC P0601: Internal Controller Failure
- DTC P0622: Generator Field Not Switching Properly
- DTC P0645: A/C Clutch Relay Circuit
- DTC P0700: EATX Controller DTC Present
- DTC P0703: Brake Switch Sense Circuit
- DTC P1195: 1/1 O2 Sensor Slow During Catalyst Monitor
- DTC P1196: 2/1 O2 Sensor Slow During Catalyst Monitor
- DTC P1282: Fuel Pump Relay Control Circuit
- DTC P1288: Short Runner Solenoid Circuit
- DTC P1289: Manifold Tune Valve Solenoid Circuit
- DTC P1294: Target Idle Not Reached
- DTC P1297: No Change In Map Sensor From Start To Run
- DTC P1299: Vacuum Leak Found (IAC Fully Seated)
- DTC P1388: Auto Shutdown Relay Control Circuit
- DTC P1389: No ASD Relay Output Voltage At Pcm
- DTC P1391: Intermittent Loss Of CMP Or CKP
- DTC P1398: Misfire Adaptive Numerator At Limit
- DTC P1478: Battery Temp Sensor Volts Out Of Limit
- DTC P1486: EVAP Leak Monitor Pinched Hose
- DTC P1489: High Speed Fan Control Relay Circuit
- DTC P1490: Low Speed Fan Control Relay Circuit
- DTC P1492: Ambient/Batt Temp Sen Volts Too High Or DTC P1493: Ambient/Batt Temp Sen Volts Too Low
- DTC P1494: Leak Detect Pump SW Or Mechanical Fault
- DTC P1495: Leak Detection Pump Solenoid Circuit
- DTC P1496: 5-Volt Supply Output Too Low
- DTC P1594: Charging System Voltage Too High
- DTC P1598: A/C Pressure Sensor Volts Too High
- DTC P1599: A/C Pressure Sensor Volts Too Low
- DTC P1682: Charging System Voltage Too Low
- DTC P1685: Invalid Skim Key
- DTC P1686: No Skim Bus Message Received
- DTC P1687: No Cluster Bus Message
- DTC P1695: No CCD/J1850 Message From Body Control Module
- DTC P1696: Pcm Failure EEPROM Write Denied
- DTC P1697: Pcm Failure Sri Mile Not Stored
- DTC P1698: No Bus Message From Trans Control Module
- DTC P1899: P/N Switch Stuck In Park Or In Gear
- Test NTC-1: No Trouble Codes Test Menu
- Test NTC-2: No Response From Pcm (Sci Only)
- Test NTC-3: Checking Brake Switch
- Test NTC-4: Checking Engine Mechanical Systems
- Test NTC-5: Checking Engine Vacuum
- Test NTC-6: Checking Evaporative Emissions System
- Test NTC-7: Checking Fuel Delivery
- Test NTC-8: Checking Idle Air Control Motor Operation
- Test NTC-9: Checking Map Sensor Operation
- Test NTC-10: Checking Minimum Idle Airflow
- Test NTC-11: Checking Radiator Fan Operation
- Test NTC-12: Checking Engine Coolant Temperature Sensor
- Test NTC-13: Checking Intake Air Temperature Sensor
- Test NTC-14: Checking Pcm Power & Grounds
- Test NTC-15: Checking Throttle Position Sensor Operation
- Test NTC-16: Checking A/C System Operation
- Test NTC-17: Checking Ambient/Battery Temperature Sensor
- Test NTC-18: Checking Charging System
- Test NTC-19: Checking Park/Neutral Position Switch
- Test NS-SEL: No Start Test Selection
- Test NS-1: Engine Cranks But Does Not Start
- Test NS-2: No Crank Condition
- Test NS-3: No Response From Pcm With A No Start Condition
- Test NS-4: Start & Stall Condition
- Test VER-1
- Test VER-2
- Test VER-3
- Test VER-5
- Test VER-6
- Skis Verification Test
- Transmission Verification Test
- Engine Controls - System & Component Testing - (Except Avenger & SEBRING Coupe)
- Introduction
- Computerized Engine Controls
- Engine Sensors & Switches
- Barometric Pressure Sensor
- Camshaft Position (CMP) Sensor
- Crankshaft Position (CKP) Sensor
- Engine Coolant Temperature (ECT) Sensor
- Heated Oxygen Sensor (Ho2S)
- Intake Air Temperature (IAT) Sensor
- Knock Sensor
- Manifold Absolute Pressure (Map) Sensor
- Throttle Position (TP) Sensor
- Vehicle Speed Sensor (VSS)
- Brake Switch
- Leak Detection Pump (LDP) Switch
- Park/Neutral (P/N) Switch
- Power Steering Switch (Except Neon)
- Speed Control Switch
- Motors, Relays & Solenoids
- A/C Clutch Relay
- Auto Shutdown (ASD) Relay
- Exhaust Gas RECIRCULATION (EGR) Solenoid
- Evaporative (EVAP) Purge Solenoid
- Fuel Pump Relay
- Leak Detection Pump (LDP) Solenoid
- Radiator Fan Control Relay
- Torque Converter Clutch (TCC) Relay (Neon Only)
- Vehicle Speed Control Relay
- Torque Converter Clutch (TCC) Solenoid (Neon Only)
- Fuel Systems
- Idle Control Systems
- Ignition Systems
- Emission Systems & Sub-Systems
- Miscellaneous Controls
- Engine Controls - Tests W/O Codes - Except Diesel
- Testing & Diagnosis
- Engine Controls - Basic Engine Testing
- Engine Controls - Self-Diagnostics
- Introduction
- Self-Diagnostic System
- Powertrain Control Module Location
- Programming
- Fuel System Pressure Release
- Diagnostic Trouble Code Definitions
- Diagnostic Tests
- Notes
- DTC P0106: Barometric Pressure Out Of Range
- DTC P0107: Map Sensor Voltage Too Low
- DTC P0108: Map Sensor Voltage Too High
- DTC P0112: Intake Air Temp Sensor Voltage Low
- DTC P0113: Intake Air Temp Sensor Voltage High
- DTC P0117: ECT Sensor Voltage Too Low
- DTC P0118: ECT Sensor Voltage Too High
- DTC P0121: TPS Voltage Does Not Agree With Map
- DTC P0122: Throttle Position Sensor Voltage Low
- DTC P0123: Throttle Position Sensor Voltage High
- DTC P0125: Closed Loop Temp Not Reached Or DTC P1281: Engine Is Cold Too Long
- DTC P0131: 1/1 O2 Sensor Shorted To Ground
- DTC P0132: 1/1 O2 Sensor Shorted To Voltage
- DTC P0133: 1/1 O2 Sensor Slow Response
- DTC P0134: 1/1 O2 Sensor Stays At Center
- DTC P0135: 1/1 O2 Sensor Heater Failure
- DTC P0137: 1/2 O2 Sensor Shorted To Ground
- DTC P0138: 1/2 O2 Sensor Shorted To Voltage
- DTC P0139: 1/2 O2 Sensor Slow Response
- DTC P0140: 1/2 O2 Sensor Stays At Center
- DTC P0141: 1/2 O2 Sensor Heater Failure
- DTC P0151: 2/1 O2 Sensor Shorted To Ground
- DTC P0152: 2/1 O2 Sensor Shorted To Voltage
- DTC P0153: 2/1 O2 Sensor Slow Response
- DTC P0154: 2/1 O2 Sensor Stays At Center
- DTC P0155: 2/1 O2 Sensor Heater Failure
- DTC P0157: 2/2 O2 Sensor Shorted To Ground
- DTC P0158: 2/2 O2 Sensor Shorted To Voltage
- DTC P0160: 2/2 O2 Sensor Stays At Center
- DTC P0161: 2/2 O2 Sensor Heater Failure
- DTC P0171: 1/1 Fuel System Lean Or DTC P0174: 2/1 Fuel System Lean
- DTC P0172: 1/1 Fuel System Rich Or DTC P0175: 2/1 Fuel System Rich
- DTC P0201: Injector #1 Control Circuit
- DTC P0202: Injector #2 Control Circuit
- DTC P0203: Injector #3 Control Circuit
- DTC P0204: Injector #4 Control Circuit
- DTC P0205: Injector #5 Control Circuit
- DTC P0206 Injector #6 Control Circuit
- DTC P0300: Multiple Cylinder Misfire
- DTC P0301-P0306: Cylinder Misfire
- DTC P0320: No Crank Reference Signal At Pcm
- DTC P0325: Knock Sensor #1 Circuit
- DTC P0340: No Cam Signal At Pcm
- DTC P0351: Ignition Coil #1 Primary Circuit
- DTC P0352: Ignition Coil #2 Primary Circuit
- DTC P0353: Ignition Coil #3 Primary Circuit
- DTC P0354: Ignition Coil #4 Primary Circuit
- DTC P0355: Ignition Coil #5 Primary Circuit
- DTC P0356: Ignition Coil #6 Primary Circuit
- DTC P0401: EGR System Failure
- DTC P0403: EGR Solenoid Circuit
- DTC P0404: EGR Position Sensor Rationality
- DTC P0405: EGR Position Sensor Voltage Too Low
- DTC P0406: EGR Position Sensor Voltage Too High
- DTC P0420: 1/1 Catalytic Converter Efficiency
- DTC P0432: 2/1 Catalytic Converter Efficiency
- DTC P0441: EVAP Purge Flow Monitor
- DTC P0442: EVAP Leak Monitor Medium (.040") Leak Detected Or DTC P0455: EVAP Leak Monitor Large Leak Detected
- DTC P0443: EVAP Purge Solenoid Circuit
- DTC P0460: Fuel Level Unit No Change Over Miles
- DTC P0462: Fuel Level Sending Unit Volts Too Low Or DTC P0463: Fuel Level Sending Unit Volts Too High
- DTC P0500: No Vehicle Speed Signal
- DTC P0505: Idle Air Control Motor Circuits
- DTC P0551: Power Steering Switch Failure
- DTC P0600: Pcm Failure SPI Communications
- DTC P0601: Internal Controller Failure
- DTC P0622: Generator Field Not Switching Properly
- DTC P0645: A/C Clutch Relay Circuit
- DTC P0700: EATX Controller DTC Present
- DTC P0703: Brake Switch Sense Circuit
- DTC P1195: 1/1 O2 Sensor Slow During Catalyst Monitor
- DTC P1196: 2/1 O2 Sensor Slow During Catalyst Monitor
- DTC P1282: Fuel Pump Relay Control Circuit
- DTC P1288: Short Runner Solenoid Circuit
- DTC P1289: Manifold Tune Valve Solenoid Circuit
- DTC P1294: Target Idle Not Reached
- DTC P1297: No Change In Map Sensor From Start To Run
- DTC P1299: Vacuum Leak Found (IAC Fully Seated)
- DTC P1388: Auto Shutdown Relay Control Circuit
- DTC P1389: No ASD Relay Output Voltage At Pcm
- DTC P1391: Intermittent Loss Of CMP Or CKP
- DTC P1398: Misfire Adaptive Numerator At Limit
- DTC P1478: Battery Temp Sensor Volts Out Of Limit
- DTC P1486: EVAP Leak Monitor Pinched Hose
- DTC P1489: High Speed Fan Control Relay Circuit
- DTC P1490: Low Speed Fan Control Relay Circuit
- DTC P1492: Ambient/Batt Temp Sen Volts Too High Or DTC P1493: Ambient/Batt Temp Sen Volts Too Low
- DTC P1494: Leak Detect Pump SW Or Mechanical Fault
- DTC P1495: Leak Detection Pump Solenoid Circuit
- DTC P1496: 5-Volt Supply Output Too Low
- DTC P1594: Charging System Voltage Too High
- DTC P1598: A/C Pressure Sensor Volts Too High
- DTC P1599: A/C Pressure Sensor Volts Too Low
- DTC P1682: Charging System Voltage Too Low
- DTC P1685: Invalid Skim Key
- DTC P1686: No Skim Bus Message Received
- DTC P1687: No Cluster Bus Message
- DTC P1695: No CCD/J1850 Message From Body Control Module
- DTC P1696: Pcm Failure EEPROM Write Denied
- DTC P1697: Pcm Failure Sri Mile Not Stored
- DTC P1698: No Bus Message From Trans Control Module
- DTC P1899: P/N Switch Stuck In Park Or In Gear
- Test NTC-1: No Trouble Codes Test Menu
- Test NTC-2: No Response From Pcm (Sci Only)
- Test NTC-3: Checking Brake Switch
- Test NTC-4: Checking Engine Mechanical Systems
- Test NTC-5: Checking Engine Vacuum
- Test NTC-6: Checking Evaporative Emissions System
- Test NTC-7: Checking Fuel Delivery
- Test NTC-8: Checking Idle Air Control Motor Operation
- Test NTC-9: Checking Map Sensor Operation
- Test NTC-10: Checking Minimum Idle Airflow
- Test NTC-11: Checking Radiator Fan Operation
- Test NTC-12: Checking Engine Coolant Temperature Sensor
- Test NTC-13: Checking Intake Air Temperature Sensor
- Test NTC-14: Checking Pcm Power & Grounds
- Test NTC-15: Checking Throttle Position Sensor Operation
- Test NTC-16: Checking A/C System Operation
- Test NTC-17: Checking Ambient/Battery Temperature Sensor
- Test NTC-18: Checking Charging System
- Test NTC-19: Checking Park/Neutral Position Switch
- Test NS-SEL: No Start Test Selection
- Test NS-1: Engine Cranks But Does Not Start
- Test NS-2: No Crank Condition
- Test NS-3: No Response From Pcm With A No Start Condition
- Test NS-4: Start & Stall Condition
- Test VER-1
- Test VER-2
- Test VER-3
- Test VER-5
- Test VER-6
- Skis Verification Test
- Transmission Verification Test
- Engine Controls - System & Component Testing - (Except Avenger & SEBRING Coupe)
- Introduction
- Computerized Engine Controls
- Engine Sensors & Switches
- Barometric Pressure Sensor
- Camshaft Position (CMP) Sensor
- Crankshaft Position (CKP) Sensor
- Engine Coolant Temperature (ECT) Sensor
- Heated Oxygen Sensor (Ho2S)
- Intake Air Temperature (IAT) Sensor
- Knock Sensor
- Manifold Absolute Pressure (Map) Sensor
- Throttle Position (TP) Sensor
- Vehicle Speed Sensor (VSS)
- Brake Switch
- Leak Detection Pump (LDP) Switch
- Park/Neutral (P/N) Switch
- Power Steering Switch (Except Neon)
- Speed Control Switch
- Motors, Relays & Solenoids
- A/C Clutch Relay
- Auto Shutdown (ASD) Relay
- Exhaust Gas RECIRCULATION (EGR) Solenoid
- Evaporative (EVAP) Purge Solenoid
- Fuel Pump Relay
- Leak Detection Pump (LDP) Solenoid
- Radiator Fan Control Relay
- Torque Converter Clutch (TCC) Relay (Neon Only)
- Vehicle Speed Control Relay
- Torque Converter Clutch (TCC) Solenoid (Neon Only)
- Fuel Systems
- Idle Control Systems
- Ignition Systems
- Emission Systems & Sub-Systems
- Miscellaneous Controls
- Engine Controls - Tests W/O Codes - Except Diesel
- Theory and Operation
- Engine Controls - Theory & Operation
- Introduction
- Computerized Engine Controls
- Powertrain Control Module (Pcm)
- Input Devices
- Notes
- A/C Pressure Sensor (All Models)
- A/C Switch
- Ambient/Battery Temperature Sensor (2.5L Sebring Convertible)
- Battery Voltage
- Brake Switch
- Camshaft Position (CMP) Sensor (All Models)
- Crankshaft Position (CKP) Sensor (All Models)
- Cruise Control Switches
- Engine Coolant Temperature (ECT) Sensor (All Models)
- Fuel Level Sensor
- Heated Oxygen Sensor (HO2S)
- Ignition Switch
- Intake Air Temperature (IAT) Sensor (All Models)
- Knock Sensor (Except 2.5L)
- Manifold Absolute Pressure (MAP) Sensor (All Models)
- Output Speed Sensor (Except 2.0L)
- Park/Neutral (P/N) Switch
- Power Steering Pressure (PSP) Switch (All Models)
- Sensor Return
- Serial Communication Interface (SCI) Receive
- Throttle Position (TP) Sensor
- Torque Management Input Signal
- Vehicle Speed Sensor (Breeze, Cirrus, Neon & Stratus M/T Models)
- Output Signals
- Notes
- A/C Clutch Relay
- Auto Shutdown (ASD) Relay
- Data Link Connector (DLC)
- Distributorless Ignition System (DIS)
- Electric EGR Transducer (EET)
- Evaporative Canister Purge Control Solenoid (EVAP-CPCS)
- Exhaust Gas Recirculation (EGR) Solenoid
- Fuel Injectors
- Fuel Pump Relay
- Generator
- Idle Air Control (IAC) Motor
- In-Tank Fuel Pump
- Leak Detection Pump (LDP)
- Limp-In Mode
- Malfunction Indicator Light (MIL)
- Manifold Tuning Valve (MTV)
- Proportional Purge Solenoid
- Radiator Fan Relay
- Serial Communications Interface (SCI) Transmit
- Short Runner Valve (SRV)
- Speed Control Servo
- Tachometer
- Torque Converter Clutch (TCC) Solenoid
- Fuel System
- Ignition System
- Emission Systems
- Self-Diagnostic System
- Miscellaneous Controls
- Engine Controls - Theory & Operation
- Vacuum Diagrams
- Engine Performance Wiring Diagrams
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- Computer Relearn Procedures
- Introduction
- Relearn Procedures
- Notes
- Control Module (DAKOTA, DURANGO & Ram Pickup)
- Engine Control Module Programming (Diesel)
- Powertrain Control Module Programming
- Electronic Time Alarm Control System Electronic Control Unit (ETACS-Ecu) (Avenger & SEBRING Coupe)
- Pinion Factor Procedure (All Fwd Cars Except Avenger & SEBRING Coupe, & All Fwd Vans)
- Pinion Factor Procedure (Avenger & SEBRING Coupe)
- Programming Pcm & Clearing DTCS From Abs & SRS Modules
- Sentry Key Immobilizer System (Skis) Initialization Procedure
- Transmission Control Module (TCM) Resetting Procedure (Avenger & SEBRING Coupe)
- Transaxle Shift Quality Quick Learn Procedure (Avenger & SEBRING Coupe)
- Transaxle/Transmission Shift Quality Quick Learn Procedure (All Fwd Cars Except Avenger & SEBRING Coupe, All Fwd Vans & DAKOTA 4.7L, DURANGO 4.7L & Grand CHEROKEE 4.7L)
- Vehicle DRIVEABILITY Computer Relearn Procedure
- Vehicle Theft Security System (Caravan, Town & Country, & Voyager)
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- DTC Index
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Identification
- Metric Conversions
- Specifications Index
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- General Servicing
- HVAC System - Compressor Applications & Body Designations
- HVAC System - Compressor Refrigerant Oil Checking
- Refrigerant Oils
- Servicing Precautions
- Checking Compressor Oil
- DELPHI-Thermal (HARRISON) Hd6/Ht6/HU6 & Hd6/Hr-6HE 6-CYL., V5 5-CYL. & V7 7-CYL.
- Ford FS-10 10-Cylinder
- Ford SC90V Variable Scroll
- Ford SC115 Fixed Scroll
- NIPPONDENSO 10-Cylinder
- NIPPONDENSO 10S15/10S17/10S20
- NIPPONDENSO 10PA17/10PA17C 10-CYL.
- SANDEN Scroll
- SANDEN MSC90-C Scroll
- SANDEN SD-7H15 7-Cylinder
- SANDEN TRS-90 & Tr-105 Scroll
- ZEXEL Rotary Vane
- HVAC System - Compressor Servicing
- DELPHI-Thermal (HARRISON) Hd6/Ht6/HU6 & Hd6/Hr-6HE 6-CYL., V5 5-CYL. & V7 7-CYL.
- Ford FS-10 10-Cylinder
- Ford SC90V Scroll
- Ford SC115 Scroll
- NIPPONDENSO 10-Cylinder
- NIPPONDENSO 10S15/10S17/10S20
- NIPPONDENSO 10PA17/10PA17C 10-Cylinder
- SANDEN Scroll
- SANDEN MSC90-C Scroll
- SANDEN SD-7H15 7-Cylinder
- SANDEN TRS-90 Scroll
- SANDEN TRS-105 Scroll
- ZEXEL Rotary Vane
- HVAC System - General Servicing Procedures
- USING R-134a REFRIGERANT
- System Service Valves
- Service Equipment
- Manifold Gauge Set
- Pressure-Temperature Relationship
- Pressure Gauge Readings
- Orifice Tube Replacement
- Refrigerant Recovery/Recycling
- Flushing A/C System
- Evacuating A/C System
- Charging A/C System
- Leak Testing
- HVAC System - Refrigerant Oil & Refrigerant Specifications
- HVAC Control Systems
- HVAC System - Automatic
- Specifications
- Description
- Operation
- Adjustments
- Self-Diagnostics
- Diagnostic Tests
- Notes
- Test A: DTC P0645 - A/C Clutch Relay Circuit
- Test B: DTC P1598 - A/C Pressure Sensor Volts Too High
- Test C: DTC P1599 - A/C Pressure Sensor Volts Too Low
- Test D: ATC Blower Motor Inoperative
- Test E: ATC Blower Motor Speeds Incorrect
- Test F: ATC Control Panel Illumination
- Test G: ATC Switch Failure Or Inoperative
- Test H: ATC System Check
- Test I: ATC Temperature Control Incorrect In Sun Or Shade
- Test J: Blend Door Feedback Failure Blend Door Stall Test Failure
- Test K: Blend Door Output Shorted To Ground
- Test L: Door Actuator Output Shorted To Battery Voltage
- Test M: Common Door Output Shorted To Ground
- Test N: Evaporator Temperature Sensor Failure
- Test P: In-Car Temp Sensor/Aspirator Failure
- Test Q: Mode Door Feedback Failure Mode Door Stall Test Failure
- Test R: Mode Door Output Shorted To Ground
- Test S: RECIRCULATION Door Output Shorted To Ground
- Test T: RECIRCULATION Door Test Failure
- Test U: Sun Load Sensor Failure
- Verification Test
- System Tests
- Component Tests
- Removal & Installation
- Notes
- A/C Pressure Transducer
- Blower Motor Resistor
- Blower Motor Power Module
- Compressor
- Expansion Valve
- Sun Sensor
- Compressor Clutch/Coil Assembly
- Condenser
- Evaporator
- Filter/Dryer
- Mode Door Motor/Actuator
- RECIRCULATION Door Motor/Actuator
- Temperature Door Motor/Actuator
- Unit Housing
- Instrument Panel
- A/C Ambient Temperature Sensor
- Automatic Temperature Control Module
- Evaporator Temperature Sensor
- Blower Motor
- ATC In Car Temperature Sensor
- In-Car Temperature Sensor
- Sun Load Sensor
- Wiring Diagrams
- HVAC System - Manual
- Specifications
- Description
- Operation
- Adjustments
- Self-Diagnostics
- Diagnostic Tests
- Visual Inspection
- Test A: Identifying A/C-Heater System Problems
- Test B: Identifying A/C-Heater System BCM DTCS
- Test C: A/C Switch Failure
- Test D: Rear Defogger Switch Failure
- Test E: Blend Door Input Open Or Shorted To Ground
- Test F: Blend Door Input Shorted To Battery Voltage
- Test G: Mode Door Input Open Or Shorted To Battery Voltage
- Test H: Mode Door Input Shorted To Ground
- Test I: Inoperative Blower Motor
- Test J: Shorted Blower Motor Circuit
- Test K: Incorrect Blower Motor Speeds
- Test L: Control Head Illumination
- Test M: Inoperative Control Head Switch
- Verification Test
- System Tests
- Removal & Installation
- Notes
- A/C-Heater Assembly
- A/C-Heater Control Head
- A/C Pressure Transducer
- Blower Motor
- Blower Motor Resistor
- Compressor
- Compressor High Pressure Relief Valve
- Condenser
- Evaporator
- Evaporator Temperature Sensor
- Expansion Valve
- Heater Core
- Instrument Panel
- Mode Door Actuator
- Outside/Recirculated Air Door Actuator
- Receiver-Drier
- Temperature Door Actuator
- Torque Specifications
- Wiring Diagrams
- HVAC System - Manual - Trouble Shooting
- A/C System Diagnosis
- Rapid Compressor Clutch Cycling
- Compressor Will Not Engage
- Temperature Is Too High With A/C On
- Low Side Pressure Is Low-To-Normal & High Side Pressure Is Low
- Low Side Pressure Is High-To-Normal & High Side Pressure Is High
- Low Side Pressure Is High & High Side Pressure Is Low
- Low Side Pressure Is Low & High Side Pressure Is High
- Blower Motor Diagnosis
- Vacuum Control System Diagnosis
- Trouble Shooting
- A/C System Diagnosis
- Manual HVAC Systems - Wiring
- HVAC System - Automatic
- General Servicing
- Restraints
- Air Bag, SRS
- Air Bag Restraint Systems
- Description & Operation
- Air Bag Restraint Systems
- Component Locations
- System Operation Check
- Air Bag Safety Precautions
- Adjustments
- Disabling & Activating Air Bag System
- Disposal Procedures
- Post-Collision Inspection
- Removal & Installation
- Diagnostics
- Diagnostic Tests
- Test 1A: Identifying System Problems
- Test 1B: Repairing Stored Codes
- Test 2A: Calibration Message Mismatch (Active Code)
- Test 3A: Cluster Message Mismatch (Active Code)
- Test 4A: Driver Squib #1 Circuit Open (Active Code)
- Test 5A: Driver Squib #1 Circuit Shorted (Active Code)
- Test 6A: Driver Squib #1 Circuit Shorted To Battery (Active Code)
- Test 7A: Driver Squib #1 Circuit Shorted To Ground (Active Code)
- Test 8A: Loss Of Ignition Run Only (Active Code)
- Test 9A: Loss Of Ignition Run/Start (Active Code)
- Test 10A: No Cluster Messages (Active Code)
- Test 11A: No Odometer Message (Active Code)
- Test 12A: Passenger Squib #1 Circuit Open (Active Code)
- Test 13A: Passenger Squib #1 Circuit Shorted (Active Code)
- Test 14A: Passenger Squib #1 Circuit Shorted To Battery (Active Code)
- Test 15A: Passenger Squib #1 Circuit Shorted To Ground (Active Code)
- Test 16A: Vehicle Body Style Unknown (Active Code)
- Test 17A: Warning Lamp Open (Active Code)
- Test 18A: Warning Lamp Shorted (Active Code)
- Test VER-1A: Verification Test
- Test VER-2A: Verification Test
- Vehicle Communications
- Torque Specifications
- Wiring Diagrams
- Air Bag Restraint Systems
- Air Bag, SRS
- Steering
- Electronic Steering
- Manual Steering
- Power Steering
- Steering Wheel & Steering Column
- Steering Gear
- Steering System - Electronic - Variable Power Assist
- Description & Operation
- Adjustments
- Self-Diagnostic System
- Diagnostic Tests
- Test 2A: Speed Proportional Steering Circuit Open Or Shorted To Ground
- Test 3A: Speed Proportional Steering Circuit Shorted To Voltage
- Test 4A: Speed Proportional Steering Solenoid High Temperature
- Test 5A: Speed Proportional Steering System Functional Test
- Speed Proportional Steering System Verification Test
- Removal & Installation
- Overhaul
- Wiring Diagrams
- Steering System - Electronic - Variable Power Assist
- Suspension
- Front Suspension
- Rear Suspension
- Wheel Alignment Specifications & Adjustment Procedures
- Transmission
- Automatic Trans
- 42LE Automatic Transmission (Service Information)
- Automatic Transmission Diagnosis - 42LE Automatic Transmission
- Application
- Description & Operation
- Trouble Shooting
- Diagnosis & Testing
- Notes
- Test Equipment Hook-Up
- Retrieving Diagnostic Trouble Codes
- No Response From TCM (Prowler)
- No Response From TCM (Except Prowler)
- Clearing Diagnostic Trouble Codes
- Pinion Factor Procedure
- Shift Quality Quick-Learn Procedure
- Checking Transmission Fan Relay Output
- Component Locations
- Connector Identification
- Diagnostic Tests
- Notes
- DTC P0120: Throttle Position Sensor Signal Circuit
- DTC P0600: Serial Communication Link
- DTC P0604, P0605 & P0700: Internal Trans Controller
- DTC P0705: Check Shifter Signal
- DTC P0715: Input Speed Sensor Error
- DTC P0720: Output Speed Sensor Error
- DTC P0725: Engine Speed Sensor Circuit
- DTC P0731: Gear Ratio Error In 1ST
- DTC P0732: Gear Ratio Error In 2ND
- DTC P0733: Gear Ratio Error In 3RD
- DTC P0734: Gear Ratio Error In 4TH
- DTC P0736: Gear Ratio Error In Reverse
- DTC P0740: Torque Converter Clutch Control Circuit
- DTC P0750: L-R Solenoid Circuit
- DTC P0755: 2-4 Solenoid Circuit
- DTC P0760: Od Solenoid Circuit
- DTC P0765: UD Solenoid Circuit
- DTC P1479: Transmission Fan Relay Control Circuit
- DTC P1714: Low Battery Voltage
- DTC P1716: Bus Communication With Engine Module
- DTC P1717: No Communication With Mic
- DTC P1738: High Temperature Operation Activated
- DTC P1739: Power-Up At Speed
- DTC P1765: Switched Battery
- DTC P1767: Relay Output Always On
- DTC P1768: Relay Output Always Off
- DTC P1775: Solenoid Switch Latched In TCC Position
- DTC P1776: Solenoid Switch Valve Latched In L-R Position
- DTC P1781: Od Pressure Switch Sense Circuit
- DTC P1782: 2-4 Pressure Switch Sense Circuit
- DTC P1784: L-R Pressure Switch Sense Circuit
- DTC P1787: Od Hydraulic Pressure Switch Circuit
- DTC P1788: 2-4 Hydraulic Pressure Switch Circuit
- DTC P1789: 2-4/Od Hydraulic Pressure Switch Circuit
- DTC P1790: Fault Immediately After Shift
- DTC P1791: Loss Of Prime
- DTC P1792: Battery Was Disconnected
- DTC P1793: TRD Link Communication Error
- DTC P1794: Sensor Ground Error
- P1795: Internal Trans Controller
- DTC P1796: AUTOSTICK Switch Circuit
- DTC P1797: Manual Shift Overheat
- DTC P1798: Worn Out/Burnt Transmission Fluid
- DTC P1799: Calculated Oil Temperature In Use
- DTC P1899: P/N Switch Stuck In Park Or In Gear
- Transmission Verification Test VER-1A
- Powertrain Verification Test VER-2
- Powertrain Verification Test VER-5
- Symptom Tests
- Notes
- No Manual AUTOSTICK Operation
- Back-Up Lights Illuminate While Gearshift Lever Is Not In "R" Position
- Back-Up Lights Inoperative
- Checking Park/Neutral Position Switch Operation
- Transmission Noisy With No DTC Present
- Transmission Shifts Early With No DTC Present
- Transmission Simulator Will Not Power Up
- Wiring Diagrams
- Overhaul - 42LE Automatic Transmission
- Application
- Identification
- Description
- Operation
- Lubrication
- On-Vehicle Service
- Trouble Shooting
- Preliminary Inspection
- Symptom Diagnosis
- Buzzing Noise
- Buzzing Noise During Shifts Only
- Delayed Engagement From Neutral To Drive
- Delayed Engagement From Neutral To Reverse
- Grating, Scraping Or Growling Noise
- Hard To Fill With Fluid Or Fluid Blows Out Filler Tube
- Harsh Downshifts
- Harsh Engagement From Neutral To Drive
- Harsh Engagement From Neutral To Reverse
- Harsh Lock-Up Shift Or Shudder
- Harsh Upshift
- High Shift Efforts
- No Torque Converter Lock-Up
- No Upshift Into Overdrive
- Poor Shift Quality
- Shifts Erratically
- Transaxle Overheats
- Vehicle Drags Or Locks
- Vehicle Moves In Neutral
- Operation Characteristics At Various Fluid Temperatures
- Performance Tests
- Components Tests
- Removal & Installation
- Transaxle Disassembly
- Component Disassembly & Reassembly
- Transaxle Reassembly
- Torque Specifications
- Transaxle Specifications
- Shift Interlock Systems
- Transmission Removal & Installation - Automatic (Cars)
- Automatic Trans
- External Pages
