Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups- Accessories & Equipment
- Anti-Theft Systems
- Anti-Theft Systems
- Description & Operation
- Component Locations
- Diagnosis
- Symptom Tests
- Notes
- Test A: Left Door Key Cylinder Switch Failure
- Test B: Right Door Cylinder Switch Failure
- Test C: Disarming VTSS
- Test D: Horn Fails To Sound With Alarm Tripped (If Enabled)
- Test E: Inoperative VTSS Indicator Lamp
- Test F: Theft Alarm Will Not Arm
- Test G: VTSS Does Not Arm/Disarm From Door Cylinder Lock Switch
- Test H: VTSS Does Not Trip From DECKLID
- Test I: VTSS Does Not Trip From Driver Door
- Test J: VTSS Does Not Trip From Hood
- Test K: VTSS Does Not Trip From Passenger Door
- Test L: VTSS Indicator Lamp Comes On While Driving
- Test M: VTSS Verification Test VER-1
- Removal & Installation
- Connector Identification
- Wiring Diagrams
- Power Door Locks & Remote Keyless Entry System
- Description & Operation
- Component Locations
- Programming
- Trouble Shooting
- System Tests
- Notes
- Test A: Door Lock Switch Failure
- Test B: Door Unlock Switch Failure
- Test C: Automatic Door Locks Inoperative
- Test D: Both Doors Fail To Lock/Unlock From One Switch
- Test E: DECKLID Release Inoperative
- Test F: Door Lock Inhibit Inoperative
- Test G: Doors Fail To Lock From Either Switch
- Test H: Doors Fail To Lock From One Switch
- Test I: Doors Fail To Lock/Unlock From Either Switch
- Test J: Doors Fail To Unlock From Either Switch
- Test K: Doors Fail To Unlock From One Switch
- Test L: One Door Fails To Lock/Unlock From Either Switch
- Test M: One Door Fails To Unlock From Either Switch
- Test N: Remote Keyless Entry Inoperative
- Test O: Body Verification Test VER-1
- Component Tests
- Removal & Installation
- Connector Identification
- Wiring Diagrams
- Anti-Theft Systems
- Communication Devices
- Identification
- Description & Operation
- Component Locations
- Trouble Shooting
- Bulb Check
- Bus Failure Messages
- Airbag Message Not Received
- Battery Power To Module Disconnected
- Bus Bias Level Too High Or Too Low
- Bus (+) Or Bus (-) Open
- CCD Bus (+) & CCD Bus (-) Shorted Together
- CCD Bus Short To 5-Volts
- CCD Bus Short To Battery
- CCD Bus Short To Ground
- EATX PRNDL Message Not Received
- No Bus Bias
- No Response From The Airbag Control Module
- No Response From The Body Control Module
- No Response From The Compass Mini-Trip Computer
- No Response From The Instrument Cluster
- No Response From The Low Tire Pressure Warning Module
- No Response From Pcm (Sci Only)
- No Response From The Radio CCD
- No Response From The Transmission Control Module
- No Termination
- SBEC Message Not Received
- Body Verification Test - VER 1
- Low Tire Pressure Warning System Verification Test
- Powertrain Verification Test VER-1
- Diagnostic Testing
- Component Testing
- Removal & Installation
- Wiring Diagrams
- Cruise Control Systems
- Lighting Systems - Exterior Lights
- Description & Operation
- Headlamp Adjustment
- Diagnosis & Testing
- Removal & Installation
- Backup Lamp Unit
- Brake Lamp Switch
- Backup Lamp Bulb
- Center High Mounted Stop Lamp
- Combination Flasher
- Headlamp Bulb
- Headlamp Switch
- Headlamp Unit
- License Plate Lamp Bulb
- License Plate Lamp Lens
- Rear Side Marker Lamp Bulb
- Multi-Function Switch
- Park & Turn Signal Lamp Bulb
- Tail/Stop/Turn Signal Lamp Bulb
- Tail/Stop/Side Marker/ Turn Signal Lamp Unit
- Side Turn Signal Lamp Bulb
- Side Turn Signal Lamp Unit
- Bulb Specifications
- Gauges & Instrument Panels
- Description & Operation
- Diagnosis & Testing
- Removal & Installation
- Antenna Amplifier Module
- Body Control Module (BCM)
- Center Bezel
- Cluster Gauges (Temperature, Fuel, Oil & Voltmeter)
- Speedometer & Tachometer
- Speedometer/Odometer
- Cluster Lamps (1997)
- Cluster Lamp (1999)
- Instrument Cluster Pc Board
- Speedometer Pc Board
- Oil Gauge Pc Board
- Voltmeter Pc Board
- Headlamp Switch
- HVAC Control Panel
- Instrument Cluster
- Instrument Panel
- Instrument Panel ENDCAPS (1997)
- Instrument Panel ENDCAPS (1999)
- Instrument Panel Speakers
- Instrument Panel Top Cover
- Mask/Lens
- Power Outlet
- Wiring Diagrams
- Power Mirrors
- Steering Column Switches
- Warning Systems
- Window Motors & Regulators
- Wiper/Washer Systems
- Wiper System & Washer System
- Description & Operation
- Component Locations
- Adjustments
- Trouble Shooting
- Diagnostic Tests
- Symptom Tests - Intermittent & Washer Fluid Indicator
- Component Tests
- Removal & Installation
- Torque Specifications
- Connector Identification
- Wiring Diagrams
- Wiper System & Washer System
- Anti-Theft Systems
- Body & Frame
- Door Locks
- Anti-Theft Systems
- Description & Operation
- Component Locations
- Diagnosis
- Symptom Tests
- Notes
- Test A: Left Door Key Cylinder Switch Failure
- Test B: Right Door Cylinder Switch Failure
- Test C: Disarming VTSS
- Test D: Horn Fails To Sound With Alarm Tripped (If Enabled)
- Test E: Inoperative VTSS Indicator Lamp
- Test F: Theft Alarm Will Not Arm
- Test G: VTSS Does Not Arm/Disarm From Door Cylinder Lock Switch
- Test H: VTSS Does Not Trip From DECKLID
- Test I: VTSS Does Not Trip From Driver Door
- Test J: VTSS Does Not Trip From Hood
- Test K: VTSS Does Not Trip From Passenger Door
- Test L: VTSS Indicator Lamp Comes On While Driving
- Test M: VTSS Verification Test VER-1
- Removal & Installation
- Connector Identification
- Wiring Diagrams
- Power Door Locks & Remote Keyless Entry System
- Description & Operation
- Component Locations
- Programming
- Trouble Shooting
- System Tests
- Notes
- Test A: Door Lock Switch Failure
- Test B: Door Unlock Switch Failure
- Test C: Automatic Door Locks Inoperative
- Test D: Both Doors Fail To Lock/Unlock From One Switch
- Test E: DECKLID Release Inoperative
- Test F: Door Lock Inhibit Inoperative
- Test G: Doors Fail To Lock From Either Switch
- Test H: Doors Fail To Lock From One Switch
- Test I: Doors Fail To Lock/Unlock From Either Switch
- Test J: Doors Fail To Unlock From Either Switch
- Test K: Doors Fail To Unlock From One Switch
- Test L: One Door Fails To Lock/Unlock From Either Switch
- Test M: One Door Fails To Unlock From Either Switch
- Test N: Remote Keyless Entry Inoperative
- Test O: Body Verification Test VER-1
- Component Tests
- Removal & Installation
- Connector Identification
- Wiring Diagrams
- Anti-Theft Systems
- Power Mirrors
- Power Windows
- Door Locks
- Brakes
- Mechanical - Hydraulic
- Disc Brakes
- Description & Operation
- Bleeding
- Servicing
- Adjustments
- Brake System Diagnostics
- Component Tests
- Removal & Installation
- Overhaul
- Torque Specifications
- Disc Brake Specifications
- Special Tools
- Disc Brakes
- Mechanical - Hydraulic
- Drivelines & Axles
- Axle Shafts
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Electrical
- Charging Systems
- Component Locations
- Gauges
- Instrument Panel
- Description & Operation
- Diagnosis & Testing
- Removal & Installation
- Antenna Amplifier Module
- Body Control Module (BCM)
- Center Bezel
- Cluster Gauges (Temperature, Fuel, Oil & Voltmeter)
- Speedometer & Tachometer
- Speedometer/Odometer
- Cluster Lamps (1997)
- Cluster Lamp (1999)
- Instrument Cluster Pc Board
- Speedometer Pc Board
- Oil Gauge Pc Board
- Voltmeter Pc Board
- Headlamp Switch
- HVAC Control Panel
- Instrument Cluster
- Instrument Panel
- Instrument Panel ENDCAPS (1997)
- Instrument Panel ENDCAPS (1999)
- Instrument Panel Speakers
- Instrument Panel Top Cover
- Mask/Lens
- Power Outlet
- Wiring Diagrams
- Instrument Panel
- Starter
- Wiring Diagrams
- Engine Mechanical
- Accessory Drive Belts
- Engine Cooling System & Automatic Transmission Cooling System
- Description & Operation
- Bleeding Cooling System
- Adjustments
- Accessory Drive Belt Routing
- Cleaning & Inspection
- Diagnosis & Testing
- Removal & Installation
- Torque Specifications
- Engine Cooling System & Automatic Transmission Cooling System
- Auxiliary Emission Control Systems
- Emission Control System Visual Inspection Procedures - General Information
- * Please Read This First *
- Emission Control Labels
- Emission Control Visual Inspection
- Notes
- Positive Crankcase Ventilation (PCV)
- Thermostatic Air Cleaner (TAC)
- Fuel Evaporative System (EVAP)
- Catalytic Converters
- Fill Pipe RESTRICTOR (Fr)
- Exhaust Gas RECIRCULATION (EGR) System
- Spark Controls (SPK)
- Air Injection System (AIS)
- Oxygen Sensor (O2)
- Computerized Engine Controls (CEC)
- Early Fuel Evaporation (EFE)
- Emission Maintenance Reminder Light (EMR) (If Equipped)
- Malfunction Indicator Light (Mil)
- Evaporative Emission System
- Emission Control System Visual Inspection Procedures - General Information
- Electric Cooling Fans
- Cooling System (Mechanical)
- Engine Cooling System & Automatic Transmission Cooling System
- Description & Operation
- Bleeding Cooling System
- Adjustments
- Accessory Drive Belt Routing
- Cleaning & Inspection
- Diagnosis & Testing
- Removal & Installation
- Torque Specifications
- Engine Cooling System & Automatic Transmission Cooling System
- Mechanical
- 3.5L V6 Engine
- Identification
- Description & Operation
- On-Vehicle Service
- Diagnosis & Testing
- Removal & Installation
- Front & Rear Engine Mounts
- Engine Assembly
- Crankshaft Damper
- Cylinder Head Covers
- Spark Plug Tubes
- Intake Manifold
- Exhaust Manifold
- Cylinder Head
- Crankshaft
- Camshaft
- Camshaft Sprockets & Timing Procedure
- Hydraulic Lash Adjuster
- Rocker Arm & Shaft Assembly
- Valve & Valve Springs
- Timing Belt Covers (Front)
- Timing Belt
- Oil Pan
- Camshaft Oil Seal
- Crankshaft Oil Seal (Front)
- Crankshaft Oil Seal (Rear)
- Crankshaft Oil Seal Retainer (Rear)
- Thermostat
- Water Pump
- Overhaul (Service Procedures)
- Disassembly & Assembly
- Cleaning & Inspection
- Engine Specifications
- Torque Specifications
- 3.5L V6 Engine
- Starter
- Timing Belt Replacement - 3.2L & 3.5L
- Accessory Drive Belts
- Engine Performance
- Application
- Emissions
- EGR Function Testing - CHRYSLER Cars
- Emission Applications
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Ignition System
- Mode 6 - CHRYSLER
- Introduction
- 1996
- 1997-1998
- 1999
- 2000
- 2001
- 2002
- 2003-2004
- 2005
- 2006
- 2007
- 2007-09 Diesel Engines
- 2008
- 2008-10 Viper
- 2009-10 Pt Cruiser
- 2009 - All Vehicles With V6 Or V8 Engines
- 2009 Vehicles With The "World I4" 4 Cylinder Engine
- 2010 Vehicles
- 2011 Vehicles
- 2012 Vehicles
- Remove, Overhaul & Install
- Theory and Operation
- Emissions Control System
- Emissions Control
- Description - Monitored Component
- Description - Monitored Systems
- Operation - Non-Monitored Circuits
- Description - Trip Definition
- Description - Vehicle Emission Control Information Label
- Description - High And Low Limits
- Operation - System
- DRBIII(R) State Display Test Mode
- Operation - DRBIII(R) Circuit Actuation Test Mode
- Specifications
- Emissions Control
- Exhaust Gas RECIRCULATION System
- On-Board Diagnostics
- Emissions Control System
- Tune-Up
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- OBD-II Drive Cycles
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- DTC Index
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Identification
- Metric Conversions
- OEM General Information
- How To Use The Engine Performance Section
- Maintenance Reminder Light (Reset Procedures)
- Emissions Maintenance Reminder (EGR)
- Emissions Maintenance Reminder (EMR Mileage)
- Emissions Maintenance Reminder (MAINT REQD Or Check EGR)
- Emissions Maintenance Reminder (Sri)
- Engine Oil Replacement Reminder
- Maintenance Service Reminder (ASSYST Maintenance Computer)
- Maintenance Service Reminder (Perform Service)
- Maintenance Service Reminder (Service Reminder Indicator)
- Maintenance Service Reminder (Service Reminder Message)
- Tire Pressure Monitor System Reminder
- Specifications Index
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- General Servicing
- Cabin Air Filter (Special Applications) - General Information
- HVAC System - Compressor Applications & Body Designations
- HVAC System - Compressor Refrigerant Oil Checking
- Refrigerant Oils
- Servicing Precautions
- Checking Compressor Oil
- DELPHI-Thermal (HARRISON) Hd6/Ht6/HU6 & Hd6/Hr-6HE 6-CYL., V5 5-CYL. & V7 7-CYL.
- Ford FS-10 10-Cylinder
- Ford SC90V Variable Scroll
- Ford SC115 Fixed Scroll
- NIPPONDENSO 10-Cylinder
- NIPPONDENSO 10S15/10S17/10S20
- NIPPONDENSO 10PA17/10PA17C 10-CYL.
- SANDEN Scroll
- SANDEN MSC90-C Scroll
- SANDEN SD-7H15 7-Cylinder
- SANDEN TRS-90 & Tr-105 Scroll
- ZEXEL Rotary Vane
- HVAC System - Compressor Servicing
- DELPHI-Thermal (HARRISON) Hd6/Ht6/HU6 & Hd6/Hr-6HE 6-CYL., V5 5-CYL. & V7 7-CYL.
- Ford FS-10 10-Cylinder
- Ford SC90V Scroll
- Ford SC115 Scroll
- NIPPONDENSO 10-Cylinder
- NIPPONDENSO 10S15/10S17/10S20
- NIPPONDENSO 10PA17/10PA17C 10-Cylinder
- SANDEN Scroll
- SANDEN MSC90-C Scroll
- SANDEN SD-7H15 7-Cylinder
- SANDEN TRS-90 Scroll
- SANDEN TRS-105 Scroll
- ZEXEL Rotary Vane
- HVAC System - General Servicing Procedures
- USING R-134a REFRIGERANT
- System Service Valves
- Service Equipment
- Manifold Gauge Set
- Pressure-Temperature Relationship
- Pressure Gauge Readings
- Orifice Tube Replacement
- Refrigerant Recovery/Recycling
- Flushing A/C System
- Evacuating A/C System
- Charging A/C System
- Leak Testing
- HVAC System - Refrigerant Oil & Refrigerant Specifications
- General Servicing
- Maintenance
- Maintenance Reminder Light (Reset Procedures)
- Emissions Maintenance Reminder (EGR)
- Emissions Maintenance Reminder (EMR Mileage)
- Emissions Maintenance Reminder (MAINT REQD Or Check EGR)
- Emissions Maintenance Reminder (Sri)
- Engine Oil Replacement Reminder
- Maintenance Service Reminder (ASSYST Maintenance Computer)
- Maintenance Service Reminder (Perform Service)
- Maintenance Service Reminder (Service Reminder Indicator)
- Maintenance Service Reminder (Service Reminder Message)
- Tire Pressure Monitor System Reminder
- Maintenance Reminder Light (Reset Procedures)
- Restraints
- Steering
- Manual Steering
- Rack & Pinion Power Steering System
- Steering Wheel & Steering Column
- Suspension
- Front Suspension
- Cautions & Warnings
- Description & Operation
- Diagnosis & Testing
- Removal & Installation
- Disassembly & Assembly
- System Specifications
- Torque Specifications
- Rear Suspension
- Front Suspension
- Transmission
- Automatic Trans
- Diagnosis - 42LE Automatic Transmission
- Application
- Identification
- Description & Operation
- Component Locations
- Programming
- Trouble Shooting
- Notes
- Preliminary Inspection
- Symptom Diagnosis
- Notes
- Buzzing Noise
- Buzzing Noise During Shifts Only
- Delayed Engagement From Neutral To Drive
- Delayed Engagement From Neutral To Reverse
- Grating, Scraping Or Growling Noise
- Hard To Fill With Fluid Or Fluid Blows Out Filler Tube
- Harsh Downshifts
- Harsh Engagement From Neutral To Drive
- Harsh Engagement From Neutral To Reverse
- Harsh Lock-Up Shift Or Shudder
- Harsh Upshift
- High Shift Efforts
- No Torque Converter Lock-Up
- No Upshift Into Overdrive
- Poor Shift Quality
- Shifts Erratically
- Transaxle Overheats
- Vehicle Drags Or Locks
- Vehicle Moves In Neutral
- Operation Characteristics At Various Fluid Temperatures
- Clutch Applications
- Performance Tests
- Self-Diagnostic System
- Diagnostic Tests
- Notes
- Pre-Diagnostic Check
- DTC P0120: Throttle Position Sensor Signal Circuit
- DTC P0600: Serial Communication Link Malfunction
- DTC P0604, P0605 & P0700: Internal TCM
- DTC P0705: Check Shifter Signal
- DTC P0715: Input Speed Sensor Error
- DTC P0720: Output Speed Sensor Error
- DTC P0725: Engine Speed Sensor Circuit
- DTC P0731: Gear Ratio Error In 1ST
- DTC P0732: Gear Ratio Error In 2ND
- DTC P0733: Gear Ratio Error In 3RD
- DTC P0734: Gear Ratio Error In 4TH
- DTC P0736: Gear Ratio Error In Reverse
- DTC P0740: Torque Converter Clutch Control Circuit
- DTC P0750: L-R Solenoid Circuit
- DTC P0755: 2-4 Solenoid Circuit
- DTC P0760: Od Solenoid Circuit
- DTC P0765: UD Solenoid Circuit
- DTC P1479: Transmission Fan Relay Control Circuit (Prowler)
- DTC P1714: Low Battery Voltage
- DTC P1716: Bus Communication With Pcm
- DTC P1717: No Communication With Mic
- DTC P1738: High Temperature Operation Activated
- DTC P1739: Power-Up At Speed
- DTC P1765: Switched Battery
- DTC P1767: Relay Output Always On
- DTC P1768: Relay Output Always Off
- DTC P1775: Solenoid Switch Latched In TCC Position
- DTC P1776: Solenoid Switch Valve Latched In L-R Position
- DTC P1781: Od Pressure Switch Sense Circuit
- DTC P1782: 2-4 Pressure Switch Sense Circuit
- DTC P1784: L-R Pressure Switch Sense Circuit
- DTC P1787: Od Hydraulic Pressure Switch Circuit
- DTC P1788: 2-4 Hydraulic Pressure Switch Circuit
- DTC P1789: 2-4/Od Hydraulic Pressure Switch Circuit
- DTC P1790: Fault Immediately After Shift
- DTC P1791: Loss Of Prime
- DTC P1792: Battery Was Disconnected
- DTC P1793: TRD Link Communication Error
- DTC P1794: Speed Sensor Ground Error
- P1795: Internal TCM
- DTC P1796: AUTOSTICK Switch Circuit
- DTC P1797: Manual Shift Overheat
- DTC P1798: Worn Out/Burnt Transmission Fluid
- DTC P1799: Calculated Oil Temperature In Use
- DTC P1899: P/N Switch Stuck In Park Or In Gear (Prowler)
- Transmission Verification Test VER-1A
- Powertrain Verification Test VER-2
- Powertrain Verification Test VER-5
- Symptom Tests
- Notes
- No Manual AUTOSTICK Operation
- Back-Up Lights Illuminate While Gearshift Lever Is Not In "R" Position
- Back-Up Lights Inoperative
- Checking Park/Neutral Position Switch Operation
- Transmission Noisy With No DTC Present
- Transmission Shifts Early With No DTC Present
- Transmission Simulator Will Not Power Up
- Removal & Installation
- Connector Identification
- Wiring Diagrams
- Removal & Overhaul & Installation - Automatic Transmission
- 42LE Automatic Transaxle
- Description
- Operation
- Diagnosis And Testing
- 42LE General Diagnosis
- Diagnosis And Testing - Road Test
- Diagnosis And Testing - Hydraulic Pressure Tests
- Notes
- TEST ONE-SELECTOR IN L (1st Gear)
- TEST TWO-SELECTOR IN DRIVE (Second Gear)
- TEST TWO A-SELECTOR IN OD (Fourth Gear)
- TEST THREE-SELECTOR IN OVERDRIVE (Third and Second Gear)
- TEST FOUR-SELECTOR IN OD (Fourth Gear)
- TEST FIVE-SELECTOR IN OVERDRIVE (Fourth Gear, CC on)
- Test Six-Selector In Reverse
- Test Result Indications
- Diagnosis And Testing - Clutch Air Pressure Tests
- Diagnosis And Testing - Fluid Leakage
- Fluid Leakage-Differential Housing Area
- Diagnosis And Testing - AUTOSTICK
- Standard Procedure
- Removal
- Disassembly
- Assembly
- Installation
- Schematics And Diagrams
- Specifications
- Special Tools
- Accumulator
- AUTOSTICK Switch
- Bearings
- Final Drive
- Fluid
- Gear Shift Cable
- Oil Pump
- Planetary GEARTRAIN
- Seal - Stub Shaft (Long)
- Seal - Stub Shaft (Short)
- Seal - Transfer Shaft
- Seal - Oil Pump
- Shift Interlock Cable
- Shift Interlock System
- Shift Mechanism
- Solenoid/Pressure Switch Assembly
- Speed Sensor - Input
- Speed Sensor - Output
- Torque Converter
- Transfer System
- Transmission Control Relay
- Transmission Range Sensor
- TRD Link
- Valve Body
- 42LE Automatic Transaxle
- Shift Interlock Systems
- Diagnosis - 42LE Automatic Transmission
- Automatic Trans
- External Pages
