Technical Service Bulletins

A/C Compressor
- Fluid Flushing Requirements (26-003-07)
Accessories Control Systems
- Scan Tool Support Before And After Collision Repair (31-002-16)
- Drivers And/Or Passenger Front Power Door Locks And Windows Inoperative U0200 Lost Communication With Passengers Door Module U0199 Lost Communication With Drivers Door Module (08-061-12)
- STARSCAN(R)/STARMOBILE(tm) ABORT RECOVERY PROCEDURES (18-001-06 REV.A)
- Co-Pilot Support And Correct Cable Usage (18-029-05)
- MOPAR Accessory Remote Starter Inoperative Due To Hood Switch (08-014-05)
- Flash: Headlights Fluctuation And/Or Interior Lamps Fluctuation (18-003-05)
- RECALIBRATION Procedures Required After Battery Disconnect (08-013-04 REV. A)
- Loss Of Communication DTC'S Set In Multiple Modules During New Vehicle Prep/Service (08-012-04)
Air Bag, SRS
- Replacement Seat Covers And Seat Cover Repairs (31-004-11)
- Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
- Safety Systems - Vehicle Modifications/Repair (08-027-04)
- Loss Of Communication DTC'S Set In Multiple Modules During New Vehicle Prep/Service (08-012-04)
- Front Passenger Airbag Safety Precautions (08-001-04)
Anti-Lock Brakes
- Loss Of Communication DTC'S Set In Multiple Modules During New Vehicle Prep/Service (08-012-04)
Anti-Theft Systems
- Drivers And/Or Passenger Front Power Door Locks And Windows Inoperative U0200 Lost Communication With Passengers Door Module U0199 Lost Communication With Drivers Door Module (08-061-12)
- Powertrain Control Module Initialization (08-030-06 REV.A)
- Flash: Illuminated Approach, Fog Lamps And/Or Rear Wiper Operation (08-015-06)
Automatic Trans
- Fluid Flushing Requirements (26-004-12)
- Fluid Flushing Requirements (26-003-07)
- Automatic Transmission Diagnostic Tear Down Procedure (21-021-08)
- Automatic Transmission Fluid Usage ATF+4 (Type Ms9602) (21-014-07)
- Flash: 1 - 2 Upshift Shudder Or Rough Shift (21-012-06 REV.B)
- Dipstick Tube Seal May Leak Causing ATF Contamination Or Transmission Shudder/Buzz (21-011-05 REV. A)
- Automatic Transmission Fluid (ATF) WEEPAGE (21-002-05 REV. A)
- Shudder During Shifts (21-006-04 REV. A)
- Automatic Transmission Diagnostic TEARDOWN Procedure (21-009-03)
Auxiliary Emission Control Systems
- Evaporative Systems Service (25-001-04)
Body Electrical
- Flash: DRIVEABILITY Improvements Mil Illumination Diagnostic Trouble Codes P0116, P0139, P0159, P0197, U110B Or U1402 (18-031-04 REV. A)
Body Interior
- Scan Tool Support Before And After Collision Repair (31-002-16)
- Flash: Headlights Fluctuation And/Or Interior Lamps Fluctuation (18-003-05)
- RECALIBRATION Procedures Required After Battery Disconnect (08-013-04 REV. A)
- Loss Of Communication DTC'S Set In Multiple Modules During New Vehicle Prep/Service (08-012-04)
Brakes Control Systems
- Flash Delayed Engine Crank Or Mil Illumination With DTC P0573 (18-031-06)
- STARSCAN(R)/STARMOBILE(tm) ABORT RECOVERY PROCEDURES (18-001-06 REV.A)
- Safety Systems - Vehicle Modifications/Repair (08-027-04)
- Loss Of Communication DTC'S Set In Multiple Modules During New Vehicle Prep/Service (08-012-04)
Collision/Avoidance
- Customer Would Prefer A Louder Warning Tone From The Park Assist System (08-020-05)
Communication Devices
- UCONNECT Hands Free Module Fails To Respond Due To Module Lock Up (08-069-14)
- Radio Communication Equipment Installation Recommendations (08-024-05)
- UCONNECT Hands Free Phone Inoperative (08-013-05)
Cooling System (Mechanical)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Cold Start Idle Cycling Or Radiator Steaming At Idle (18-044-04)
- Flash: DRIVEABILITY Improvements Mil Illumination Diagnostic Trouble Codes P0116, P0139, P0159, P0197, U110B Or U1402 (18-031-04 REV. A)
Driveshaft & Universal Joints
- Ringing Sound Coming From Propeller Shaft When Transmission Is Shifted From Drive To Reverse Or Reverse To Drive (03-004-07)
Engine Control Systems
- Engine Stall Immediately Following Fuel Tank Fill-Up (X53 Lifetime Warranty Extension) (14-002-14)
- Flash: Mil Illumination Due To Diagnostic Trouble Code P0340 Or P0344 (18-015-09)
- Flash Malfunction Indicator Lamp (Mil) On For P0573 (18-035-06)
- Powertrain Control Module Initialization (08-030-06 REV.A)
- STARSCAN(R)/STARMOBILE(tm) ABORT RECOVERY PROCEDURES (18-001-06 REV.A)
- Generic Powertrain Control Module (Pcm) Procedure (18-007-06 REV. A)
- Co-Pilot Support And Correct Cable Usage (18-029-05)
- Powertrain Control Module Initialization (08-015-05)
- Flash - Engine Roughness Or Idle Fluctuation (18-001-05)
- Flash: DRIVEABILITY Improvements Mil Illumination Diagnostic Trouble Codes P0116, P0139, P0159, P0197, U110B Or U1402 (18-031-04 REV. A)
- Generic Powertrain Control Module (Pcm) Procedure (18-033-03)
- Safety Systems - Vehicle Modifications/Repair (08-027-04)
- Flash: Rough Idle Or High Rpm On Start Or Spark Knock (18-027-04)
Entertainment Systems
- Poor Radio Reception (08-032-04)
- Rear Shelf Speaker Buzz/Rattle Sound (23-046-04)
- Erroneous Radio Diagnostic Trouble Code (DTC) (08-021-04)
- Premium Audio System Intermittent Output (08-016-04)
Exterior Body Panels
- Scan Tool Support Before And After Collision Repair (31-002-16)
- Blending CLEARCOAT During The Refinish Process (31-002-13)
- OVERSPRAY Removal (31-001-13)
- Welded Sheet Metal Repairs And Replacements (31-007-12)
- Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
- Repair Parts Used For Structural Repairs (31-002-11)
- Use Of Heat To Straighten Damaged Components (31-001-11)
- Hard To Fill With Fuel Or Fuel Nozzle Shuts Off Repeatedly (14-001-09 REV. A)
- Hood Secondary Catch Binding (23-020-04)
Exterior Lights
- Exterior Lamp Condensation And Fogging (08-091-14)
- Flash: Illuminated Approach, Fog Lamps And/Or Rear Wiper Operation (08-015-06)
Frames, Subframes & Crossmembers
- Rear Cradle Clunk Noise (13-001-16)
- Repair Parts Used For Structural Repairs (31-002-11)
Front Suspension
- Shock Strut Weeping Condition Identification (02-001-15)
- Suspension/Towing/Lifting Damage (02-004-04)
Fuel System
- Engine Stall Immediately Following Fuel Tank Fill-Up (X53 Lifetime Warranty Extension) (14-002-14)
- Hard To Fill With Fuel Or Fuel Nozzle Shuts Off Repeatedly (14-001-09 REV. A)
Gauges & Instrument Panels
- Compass Display Does Not Update (08-018-05)
- Pop/Snap Sound On Right Side Of Instrument Panel (23-018-05)
- Instrument Cluster Language (Non-English) **And/Or Metric Display** Selection Is Not Saved (08-031-04 REV A)
- Real Wood Trim Scratch Repair (23-033-02)
Headlights
- Exterior Lamp Condensation And Fogging (08-091-14)
- Color And/Or Brightness Difference On Hid Replacement Headlamp Bulbs (08-029-07)
- Flash: Headlights Fluctuation And/Or Interior Lamps Fluctuation (18-003-05)
Hoist/Jack
- Suspension/Towing/Lifting Damage (02-004-04)
HVAC Control Systems
- A/C Cooling Coil Odor (24-013-05)
- Flash: Poor Or Intermittent A/C Performance (24-004-05)
- Loss Of Communication DTC'S Set In Multiple Modules During New Vehicle Prep/Service (08-012-04)
- Flash: Poor Or Intermittent A/C Performance (24-005-04)
Identification
- Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
Ignition System
- Flash: Rough Idle Or High Rpm On Start Or Spark Knock (18-027-04)
Interior/Exterior Trim
- Replacement Seat Covers And Seat Cover Repairs (31-004-11)
- Low Gloss Interior Trim (23-036-07)
- Adhesive Residue From The Protective Covering On Carpeting (23-019-06)
- Sill Cladding Replacement (23-001-06)
- Rattle Sound From The Headliner, Rear Shelf Or C- Pillar (23-012-05)
- Rear Grab-Handle Bezel Broken At Screw Boss (23-011-05)
- Ash Tray Will Not Open, Will Not Stay Closed, And/Or Opens/Closes With Inconsistent Speed (23-006-05)
- A-Pillar Molding Fit/Wind Noise (23-048-04)
- Puncture In Carpet At Drivers Footrest (23-044-04)
- "A" Pillar Interior Trim Molding Color (23-031-04)
- Gap Between Carpet And Front Door Scuff Plate (23-021-04)
- Real Wood Trim Scratch Repair (23-033-02)
Interior/Illumination Lights
- Flash: Headlights Fluctuation And/Or Interior Lamps Fluctuation (18-003-05)
Lubrication System
- Fluid Flushing Requirements (26-004-12)
- Fluid Flushing Requirements (26-003-07)
- Gasoline Engine Oil Quality And Viscosity Grades (09-013-04)
Manual Steering
- Fluid Flushing Requirements (26-004-12)
- Revised Power Steering System Bleeding Procedures (19-008-05 REV. A)
- Power Steering Fluid Contamination (19-010-04)
Manual Trans
- Real Wood Trim Scratch Repair (23-033-02)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Fluid Flushing Requirements (26-003-07)
- Engine Whine Sound At Idle (09-011-06)
Mechanical - Hydraulic
- Fluid Flushing Requirements (26-004-12)
- Fluid Flushing Requirements (26-003-07)
Paint & Coatings
- Blending CLEARCOAT During The Refinish Process (31-002-13)
- OVERSPRAY Removal (31-001-13)
- Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
Parking Brake System
- Add Parking Brake Adjustment To The 30 Month, 30 K Miles Or 50 KKM Service Interval (26-002-08)
Passive Restraints
- Safety Systems - Vehicle Modifications/Repair (08-027-04)
- Front Passenger Airbag Safety Precautions (08-001-04)
Rear Suspension
- Rear Cradle Clunk Noise (13-001-16)
- Shock Strut Weeping Condition Identification (02-001-15)
- Suspension/Towing/Lifting Damage (02-004-04)
Restraints Control Systems
- Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
- STARSCAN(R)/STARMOBILE(tm) ABORT RECOVERY PROCEDURES (18-001-06 REV.A)
- Loss Of Communication DTC'S Set In Multiple Modules During New Vehicle Prep/Service (08-012-04)
Schedule
- Fluid Flushing Requirements (26-004-12)
Seats
- Replacement Seat Covers And Seat Cover Repairs (31-004-11)
- Flash: Memory Seat/Memory Steering Column (08-027-05)
- Front Passenger Airbag Safety Precautions (08-001-04)
Starter
- Flash Delayed Engine Crank Or Mil Illumination With DTC P0573 (18-031-06)
- MOPAR Accessory Remote Starter Inoperative Due To Hood Switch (08-014-05)
Steering Column
- Steering Wheel Not Centered (02-002-15)
- Flash: Memory Seat/Memory Steering Column (08-027-05)
- Variable Steering Effort In Cold Temperatures (19-002-05)
- Real Wood Trim Scratch Repair (23-033-02)
Steering Control Systems
- STARSCAN(R)/STARMOBILE(tm) ABORT RECOVERY PROCEDURES (18-001-06 REV.A)
- Flash: Memory Seat/Memory Steering Column (08-027-05)
- RECALIBRATION Procedures Required After Battery Disconnect (08-013-04 REV. A)
Steering Linkage
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
Sun Roof/T-Top/Convertible Top
- Rattle Sound In Sunroof Area (23-009-08)
- Ratcheting Sound During Sunroof Operation (23-004-08)
- Ratcheting Sound During Sunroof Operation (23-045-06)
- Flash Rear Of Sunroof Glass Is Not Flush To Roof/Sunroof Will Not Close (23-040-06)
- Sunroof Rattle Sound (23-002-06)
- Rear Of Sunroof Glass Is Not Flush To Roof (23-028-05)
Suspension Control Systems
- STARSCAN(R)/STARMOBILE(tm) ABORT RECOVERY PROCEDURES (18-001-06 REV.A)
System
- Engine Stall Immediately Following Fuel Tank Fill-Up (X53 Lifetime Warranty Extension) (14-002-14)
- Drivers And/Or Passenger Front Power Door Locks And Windows Inoperative U0200 Lost Communication With Passengers Door Module U0199 Lost Communication With Drivers Door Module (08-061-12)
- Flash: Mil Illumination Due To Diagnostic Trouble Code P0340 Or P0344 (18-015-09)
- Flash Malfunction Indicator Lamp (Mil) On For P0573 (18-035-06)
- Flash Delayed Engine Crank Or Mil Illumination With DTC P0573 (18-031-06)
- Co-Pilot Support And Correct Cable Usage (18-029-05)
- Mil Illumination, DTC'S P0037, P0058, P0131, P0132, P0133, P0138, P0151, P0153, P0159 (08-034-05)
- Flash: Headlights Fluctuation And/Or Interior Lamps Fluctuation (18-003-05)
- Flash: DRIVEABILITY Improvements Mil Illumination Diagnostic Trouble Codes P0116, P0139, P0159, P0197, U110B Or U1402 (18-031-04 REV. A)
- Generic Powertrain Control Module (Pcm) Procedure (18-033-03)
- Flash: Rough Idle Or High Rpm On Start Or Spark Knock (18-027-04)
Towing
- Suspension/Towing/Lifting Damage (02-004-04)
Transfer Case
- Transfer Case Shudder (21-019-05 REV. A)
Transmission Control Systems
- STARSCAN(R)/STARMOBILE(tm) ABORT RECOVERY PROCEDURES (18-001-06 REV.A)
- Flash: Shift Hesitation During Wide Open Throttle (18-031-05)
- Co-Pilot Support And Correct Cable Usage (18-029-05)
- MIL ILLUMINATION FOR DTC's P0750, P0755, P0760, P0765, P0846, P0871 OR P0841 (21-009-05)
- Flash: DRIVEABILITY Improvements Mil Illumination Diagnostic Trouble Codes P0116, P0139, P0159, P0197, U110B Or U1402 (18-031-04 REV. A)
- Generic Powertrain Control Module (Pcm) Procedure (18-033-03)
- Loss Of Communication DTC'S Set In Multiple Modules During New Vehicle Prep/Service (08-012-04)
Wheel Alignment
- Steering Wheel Not Centered (02-002-15)
- Vehicle Pulls Or Leads Right Or Left (02-003-15)
- Right/** Left** Lead Revised Alignment Specifications (02-004-07)
Wheel Hubs
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
Wheels & Tire System
- Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
- Steering Wheel Vibration Diagnostic Procedure (22-001-14 REV. A)
- Chrome Clad Wheel Adapters For Proper Balancing (22-001-12)
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
- Reconditioned Wheel Usage (31-005-11)
- Chrome Clad Wheel Adapters For Proper Balancing (22-002-09)
- Wheel Lug Nuts (22-003-07)
- Chrome Wheel Care (22-01-99)
Window Motors & Regulators
- Drivers And/Or Passenger Front Power Door Locks And Windows Inoperative U0200 Lost Communication With Passengers Door Module U0199 Lost Communication With Drivers Door Module (08-061-12)
- Inoperative Power Window Express Up Feature (08-011-07 REV. A)
- Windshield Header Buzz Or Humming Sound (23-031-06)
- Circular/Ring Marks On Glass (23-035-05)
- Rear Door Glass Binds (23-038-04)
- Left Front Door Glass Run Distortion (23-018-04)
- RECALIBRATION Procedures Required After Battery Disconnect (08-013-04 REV. A)
Wiper/Washer Systems
- Windshield Wiper Blade/Element Maintenance (23-037-15)
- Flash: Illuminated Approach, Fog Lamps And/Or Rear Wiper Operation (08-015-06)