Technical Service Bulletins

A/C Compressor
- Fluid Flushing Requirements (26-003-07)
Accessories Control Systems
- Scan Tool Support Before And After Collision Repair (31-002-16)
Air Bag, SRS
- Replacement Seat Covers And Seat Cover Repairs (31-004-11)
- Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
Automatic Trans
- Fluid Flushing Requirements (26-004-12)
- Fluid Flushing Requirements (26-003-07)
- Automatic Transmission Diagnostic Tear Down Procedure (21-021-08)
Auxiliary Emission Control Systems
- Flash: Mil Illumination For Diagnostic Trouble Code P0139 Or P0571 Is Set (18-018-09)
- Flash: DRIVEABILITY Improvements Or Mil Illumination Diagnostic Trouble Code P0452 - EVAP Pressure Switch Stuck Closed (18-003-09 REV. C)
Body Interior
- Scan Tool Support Before And After Collision Repair (31-002-16)
Clutch
- Vehicle Exhibits Vibration From The Transmission During Vehicle Launch **(X43 Warranty Extension 5 Years\160,000 KMS)** (21-006-12 REV A)
Collision/Avoidance
- Adaptive Cruise Control (Acc) Module Sensor And Bracket Guidelines During Collision Repair And Damage Estimating (31-003-12)
Communication Devices
- Flash: REW Or REX Radio Software Enhancements (08-026-12)
- RER, REW, Rep Radio Software Enhancements (08-001-11 REV. A)
Cooling System (Mechanical)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Flash: Mil Illumination For P2181 - Cooling System Performance (18-032-11)
Cruise Control Systems
- Adaptive Cruise Control (Acc) Module Sensor And Bracket Guidelines During Collision Repair And Damage Estimating (31-003-12)
Engine Control Systems
- Flash: Mil Illumination For P2181 - Cooling System Performance (18-032-11)
- Flash: Mil Illumination P2270 - O2 Sensor 1/2 Signal Biased Lean (18-021-10)
- Flash: Engine Over Rev Condition (18-019-10)
- Flash: Mil Illumination For Diagnostic Trouble Code P0139 Or P0571 Is Set (18-018-09)
- Flash: DRIVEABILITY Improvements Or Mil Illumination Diagnostic Trouble Code P0452 - EVAP Pressure Switch Stuck Closed (18-003-09 REV. C)
- Flash: Mil Illumination Diagnostic Trouble Code P0452 - EVAP Pressure Switch Stuck Closed Or P0841 - LR Pressure Switch Rationality (18-034-08 REV. D)
Entertainment Systems
- Flash: REW Or REX Radio Software Enhancements (08-026-12)
- RER, REW, Rep Radio Software Enhancements (08-001-11 REV. A)
- Radio Locks Up (08-014-10)
- Radio Video Disable Update (08-004-10)
- MYGIG REN Or REZ Radio Inoperative After Battery Disconnect (08-003-09)
- Flash: Audio System Mutes On Start-Up, Amplifier Settings After Exiting Hands Free Mode And Navigational Volume Corrections (08-036-08)
Exterior Body Panels
- Scan Tool Support Before And After Collision Repair (31-002-16)
- Blending CLEARCOAT During The Refinish Process (31-002-13)
- OVERSPRAY Removal (31-001-13)
- Welded Sheet Metal Repairs And Replacements (31-007-12)
- Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
- Repair Parts Used For Structural Repairs (31-002-11)
- Use Of Heat To Straighten Damaged Components (31-001-11)
- Lower Door Hinges Make Popping Or Groan When Opened Or Closed (23-018-10)
- Hard To Fill With Fuel Or Fuel Nozzle Shuts Off Repeatedly (14-001-09 REV. A)
Exterior Lights
- Exterior Lamp Condensation And Fogging (08-091-14)
Frames, Subframes & Crossmembers
- Repair Parts Used For Structural Repairs (31-002-11)
Front Suspension
- Shock Strut Weeping Condition Identification (02-001-15)
Fuel System
- Hard To Fill With Fuel Or Fuel Nozzle Shuts Off Repeatedly (14-001-09 REV. A)
- Flash: Mil Illumination Diagnostic Trouble Code P0452 - EVAP Pressure Switch Stuck Closed Or P0841 - LR Pressure Switch Rationality (18-034-08 REV. D)
Fuses & Circuit Breakers
- MYGIG REN Or REZ Radio Inoperative After Battery Disconnect (08-003-09)
Headlights
- Exterior Lamp Condensation And Fogging (08-091-14)
HVAC Control Systems
- Water In HVAC Housing Or Wet Carpet Under HVAC Housing (24-003-10)
Identification
- Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
Infotainment
- Radio Video Disable Update (08-004-10)
Interior/Exterior Trim
- Replacement Seat Covers And Seat Cover Repairs (31-004-11)
- Water In HVAC Housing Or Wet Carpet Under HVAC Housing (24-003-10)
- "Replacement" Seat Back Latch Handle Looseness (23-009-09)
Lubrication System
- Fluid Flushing Requirements (26-004-12)
- Gasoline Engine Diagnostic Inspection Procedure (09-001-13)
- Fluid Flushing Requirements (26-003-07)
Manual Steering
- Fluid Flushing Requirements (26-004-12)
- Power Steering Honk, Moan Or Grinding Sound On Left Turns (19-001-09)
Manual Trans
- Vehicle Exhibits Vibration From The Transmission During Vehicle Launch **(X43 Warranty Extension 5 Years\160,000 KMS)** (21-006-12 REV A)
Mechanical
- Gasoline Engine Diagnostic Inspection Procedure (09-001-13)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Fluid Flushing Requirements (26-003-07)
Mechanical - Hydraulic
- Fluid Flushing Requirements (26-004-12)
- Fluid Flushing Requirements (26-003-07)
- Pre Delivery - Front Brake Rotor Corrosion Inspection & Procedure (05-002-09 REV. B)
- Pre Delivery Brake Inspection Procedure (05-002-08 REV. A)
Paint & Coatings
- Blending CLEARCOAT During The Refinish Process (31-002-13)
- OVERSPRAY Removal (31-001-13)
- Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
- Light To Moderate Paint Surface Imperfections On Factory Applied Paint Finish (23-003-12)
Rear Suspension
- Shock Strut Weeping Condition Identification (02-001-15)
Restraints Control Systems
- Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
Schedule
- Fluid Flushing Requirements (26-004-12)
Seats
- Replacement Seat Covers And Seat Cover Repairs (31-004-11)
- "Replacement" Seat Back Latch Handle Looseness (23-009-09)
Starter
- RER, REW, Rep Radio Software Enhancements (08-001-11 REV. A)
- MYGIG REN Or REZ Radio Inoperative After Battery Disconnect (08-003-09)
Steering Column
- Steering Wheel Not Centered (02-002-15)
Steering Linkage
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
System
- Flash: Mil Illumination For P2181 - Cooling System Performance (18-032-11)
- Flash: Mil Illumination P2270 - O2 Sensor 1/2 Signal Biased Lean (18-021-10)
- Flash: Engine Over Rev Condition (18-019-10)
- Flash: Mil Illumination For Diagnostic Trouble Code P0139 Or P0571 Is Set (18-018-09)
- Flash: DRIVEABILITY Improvements Or Mil Illumination Diagnostic Trouble Code P0452 - EVAP Pressure Switch Stuck Closed (18-003-09 REV. C)
- Flash: Mil Illumination Diagnostic Trouble Code P0452 - EVAP Pressure Switch Stuck Closed Or P0841 - LR Pressure Switch Rationality (18-034-08 REV. D)
Transmission Control Systems
- Flash: DECEL Hunting/Bump/Oscillation Feeling And Automatic Transmission Shift Improvements (21-003-09)
Wheel Alignment
- Steering Wheel Not Centered (02-002-15)
- Vehicle Pulls Or Leads Right Or Left (02-003-15)
Wheel Hubs
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
Wheels & Tire System
- Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
- Steering Wheel Vibration Diagnostic Procedure (22-001-14 REV. A)
- Chrome Clad Wheel Adapters For Proper Balancing (22-001-12)
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
- Reconditioned Wheel Usage (31-005-11)
- Chrome Clad Wheel Adapters For Proper Balancing (22-002-09)
Wiper/Washer Systems
- Windshield Wiper Blade/Element Maintenance (23-037-15)