Technical Service Bulletins

Accessories Control Systems
- Scan Tool Support Before And After Collision Repair (31-002-16)
- Driver And Passenger HVAC Blower Air Temperatures Are Not The Same When "Sync" Setting Mode Is Selected And Headlamps Always Stay On. (24-002-14)
- Flash: No Audio From The Radio Caused By The Amplifier Not Communicating (08-032-13)
- RHA And REB Radio Software Enhancements (08-030-12 REV. B)
- Flash: No Start, Battery Drain, B1606-95, B16AF-15, B16B3-15, B1632-15, B1636-15, Passive Entry Slow Response, Trunk Lamps Shut Off Too Quick, Trunk Release Button Inoperable (08-016-11 REV. C)
- DECKLID Will Not Open When Pressing The Passive Entry Switch (08-028-11)
- Flash: Ghost Chime From Blind Spot Detection System (08-022-11)
Accessory Drive Belts
- Idler Pulley Noise During Cold Start (07-002-15 REV. A)
Air Bag, SRS
- Customer Satisfaction Notification W50 Driver Air Bag (W50)
- Replacement Seat Covers And Seat Cover Repairs (31-004-11)
- Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
Anti-Theft Systems
- Flash: No Start, Battery Drain, B1606-95, B16AF-15, B16B3-15, B1632-15, B1636-15, Passive Entry Slow Response, Trunk Lamps Shut Off Too Quick, Trunk Release Button Inoperable (08-016-11 REV. C)
- DECKLID Opens Unintentionally (08-084-13 REV. A)
Automatic Trans
- Fluid Flushing Requirements (26-004-12)
- Failure Code Change (04-001-17)
- Flash: Shudder And/Or Performance And/Or Transmission Shift Issues (21-001-12)
Axle Shafts
- Rear Axle Gear Whine (03-001-12)
Body Electrical
- Fuel Pump Connector Replacement (08-152-23)
- POWERNET Architecture - Ship To Customer Mode And Tool Cable Requirements (08-004-11)
Body Interior
- Scan Tool Support Before And After Collision Repair (31-002-16)
- Flash: U1411, Instrument Cluster Chime Locks Up (08-032-11)
Collision/Avoidance
- Adaptive Cruise Control (Acc) Module Sensor And Bracket Guidelines During Collision Repair And Damage Estimating (31-003-12)
Cooling System (Mechanical)
- Flash: Powertrain Diagnostic And System Improvements (18-113-16)
- Coolant WEEPAGE At EGR Hose (07-002-14)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
Cruise Control Systems
- Adaptive Cruise Control (Acc) Module Sensor And Bracket Guidelines During Collision Repair And Damage Estimating (31-003-12)
Differentials & Drive Axles
- Rear Axle Gear Whine (03-001-12)
Engine Control Systems
- Fuel Pump Connector Replacement (08-152-23)
- Failure Code Change (04-001-17)
- Flash: Powertrain Diagnostic And System Improvements (18-113-16)
- Mil Illumination: P0300, P0302, P0304 Or P0306 (X56 Warranty Extension) (09-009/12)
Entertainment Systems
- Re2 Re3 Re6 RB4 RB5 RB6 Radio Enhancements (08-055-15 REV-A)
- Flash: No Audio From The Radio Caused By The Amplifier Not Communicating (08-032-13)
- RHA And REB Radio Software Enhancements (08-030-12 REV. B)
- Flash: No Sound From Radio (08-052-11)
- Clock Loses Time, Audio Makes Popping Noise (08-044-11)
Exterior Body Panels
- Scan Tool Support Before And After Collision Repair (31-002-16)
- Blending CLEARCOAT During The Refinish Process (31-002-13)
- Right And/Or Left Rear Door Contacts Inner Quarter Panel (23-004-13)
- OVERSPRAY Removal (31-001-13)
- Welded Sheet Metal Repairs And Replacements (31-007-12)
- Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
- Repair Parts Used For Structural Repairs (31-002-11)
- Use Of Heat To Straighten Damaged Components (31-001-11)
- Trunk Ajar Lamp Illumination (23-036-11)
- Flash: No Start, Battery Drain, B1606-95, B16AF-15, B16B3-15, B1632-15, B1636-15, Passive Entry Slow Response, Trunk Lamps Shut Off Too Quick, Trunk Release Button Inoperable (08-016-11 REV. C)
- Bowing In Front Fascia And/Or Gap Above Headlamp (23-022-11)
- DECKLID Will Not Open When Pressing The Passive Entry Switch (08-028-11)
- DECKLID Opens Unintentionally (08-084-13 REV. A)
Exterior Lights
- High Beam Headlamps Flicker (08-054-21)
- Exterior Lamp Condensation And Fogging (08-091-14)
- Driver And Passenger HVAC Blower Air Temperatures Are Not The Same When "Sync" Setting Mode Is Selected And Headlamps Always Stay On. (24-002-14)
- Exterior Mirror Turn Signal Lamp Water Intrusion (23-004-12)
- Bowing In Front Fascia And/Or Gap Above Headlamp (23-022-11)
Frames, Subframes & Crossmembers
- Approved Use Of Weld Through Primers (31-001-22)
- Rear Cradle Clunk Noise (13-001-16)
- Repair Parts Used For Structural Repairs (31-002-11)
Front Suspension
- Servicing Lower Control Arm Inner Pivot Bushings (02-008-17)
- Shock Strut Weeping Condition Identification (02-001-15)
Fuel System
- Fuel Pump Connector Replacement (08-152-23)
- Possible DRIVEABILITY Issues Due To The Winter-Blend Fuel Into The Warmer Season (18-039-20)
- Mil Illumination: P0300, P0302, P0304 Or P0306 (X56 Warranty Extension) (09-009/12)
Fuses & Circuit Breakers
- POWERNET Architecture - Ship To Customer Mode And Tool Cable Requirements (08-004-11)
Gauges & Instrument Panels
- Trunk Ajar Lamp Illumination (23-036-11)
- Clock Loses Time, Audio Makes Popping Noise (08-044-11)
- Flash: U1411, Instrument Cluster Chime Locks Up (08-032-11)
- Flash: Ghost Chime From Blind Spot Detection System (08-022-11)
Headlights
- High Beam Headlamps Flicker (08-054-21)
- Headlamp Condensation And Fogging (23-042-20)
- Exterior Lamp Condensation And Fogging (08-091-14)
- Driver And Passenger HVAC Blower Air Temperatures Are Not The Same When "Sync" Setting Mode Is Selected And Headlamps Always Stay On. (24-002-14)
HVAC Control Systems
- Flash: HVAC System Enhancement (24-014-16)
Identification
- Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
- Alternative Fuel Label Missing From Windshield (14-003-11)
Infotainment
- Re2 Re3 Re6 RB4 RB5 RB6 Radio Enhancements (08-055-15 REV-A)
Interior/Exterior Trim
- Replacement Seat Covers And Seat Cover Repairs (31-004-11)
- Rattle Or Buzzing Noise In Rear Shelf Area With Radio On Or While Driving On Bumpy Roads (23-018-15)
- Sagging And/Or Gap Between Rear Shelf Silencer And Shelf Panel (23-008-12)
- WINDNOISE At Left And/Or Right Front Door At A-Pillar (23-044-11)
- Bowing In Front Fascia And/Or Gap Above Headlamp (23-022-11)
Interior/Illumination Lights
- Flash: No Start, Battery Drain, B1606-95, B16AF-15, B16B3-15, B1632-15, B1636-15, Passive Entry Slow Response, Trunk Lamps Shut Off Too Quick, Trunk Release Button Inoperable (08-016-11 REV. C)
Lubrication System
- Fluid Flushing Requirements (26-004-12)
- Oil Filter Adapter (OFA) - Pressure Relief Valve Replacement (09-009-18)
- Flash: Powertrain Diagnostic And System Improvements (18-113-16)
- PENTASTAR Engine Oil Filter Application Reference (09-003-13)
- Gasoline Engine Diagnostic Inspection Procedure (09-001-13)
Manual Steering
- Fluid Flushing Requirements (26-004-12)
Mechanical
- Oil Filter Adapter (OFA) - Pressure Relief Valve Replacement (09-009-18)
- Idler Pulley Noise During Cold Start (07-002-15 REV. A)
- Coolant WEEPAGE At EGR Hose (07-002-14)
- Gasoline Engine Diagnostic Inspection Procedure (09-001-13)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
Mechanical - Hydraulic
- Fluid Flushing Requirements (26-004-12)
Mirrors
- Exterior Mirror Turn Signal Lamp Water Intrusion (23-004-12)
Paint & Coatings
- Blending CLEARCOAT During The Refinish Process (31-002-13)
- OVERSPRAY Removal (31-001-13)
- Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
- Light To Moderate Paint Surface Imperfections On Factory Applied Paint Finish (23-003-12)
- Chrome Wheel Delamination (22-005-11 REV.A)
Rear Suspension
- Rear Cradle Clunk Noise (13-001-16)
- Shock Strut Weeping Condition Identification (02-001-15)
- Rear Axle Gear Whine (03-001-12)
Restraints Control Systems
- Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
Schedule
- Fluid Flushing Requirements (26-004-12)
Seats
- Replacement Seat Covers And Seat Cover Repairs (31-004-11)
- Driver And/Or Passenger Seat Fore/Aft Movement During Acceleration And/Or Braking (23-016-13)
- Sagging And/Or Gap Between Rear Shelf Silencer And Shelf Panel (23-008-12)
Starter
- Flash: No Start, Battery Drain, B1606-95, B16AF-15, B16B3-15, B1632-15, B1636-15, Passive Entry Slow Response, Trunk Lamps Shut Off Too Quick, Trunk Release Button Inoperable (08-016-11 REV. C)
Steering Column
- Steering Wheel Not Centered (02-002-15)
Steering Linkage
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
Sun Roof/T-Top/Convertible Top
- Rattle Or Squeak At Front Or Rear Of Sunroof (23-028-11)
System
- Fuel Pump Connector Replacement (08-152-23)
- Failure Code Change (04-001-17)
- Flash: Powertrain Diagnostic And System Improvements (18-113-16)
- Mil Illumination: P0300, P0302, P0304 Or P0306 (X56 Warranty Extension) (09-009/12)
- RHA And REB Radio Software Enhancements (08-030-12 REV. B)
Transmission Control Systems
- Failure Code Change (04-001-17)
- Flash: Shudder And/Or Performance And/Or Transmission Shift Issues (21-001-12)
Wheel Alignment
- Steering Wheel Not Centered (02-002-15)
- Vehicle Pulls Or Leads Right Or Left (02-003-15)
Wheel Hubs
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
Wheels & Tire System
- Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
- Steering Wheel Vibration Diagnostic Procedure (22-001-14 REV. A)
- Chrome Clad Wheel Adapters For Proper Balancing (22-001-12)
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
- Reconditioned Wheel Usage (31-005-11)
- Chrome Wheel Delamination (22-005-11 REV.A)
Window Motors & Regulators
- Driver's And Front Passenger's Window Have Auto Up Down Function But Only The Front Passenger Switch Has Auto Printed On It. (08-014-11)
Wiper/Washer Systems
- Windshield Wiper Blade/Element Maintenance (23-037-15)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Fuel Pump Connector Replacement (08-152-23)