Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups
Common Specs & Procedures
DTC Index
Electrical Component Locations
Fluids
Technical Bulletins
Tire Fitment
Wiring Diagrams- Connector End Views
- Connector Pin-Outs
- A/C Compressor Clutch Connector End View
- A/C Low Pressure Switch Connector End View
- A/C Pressure Transducer Connector End View
- A/C Heater Control Connector End View (C1)
- A/C Heater Control Connector End View (C2)
- Adjustable Pedals Motor Connector End View
- Adjustable Pedals Switch Connector End View
- Airbag Control Module (Occupant Restraint Control) Connector End View (C1)
- Airbag Control Module (Occupant Restraint Control) Connector End View (C2)
- Passenger Airbag On Off Switch Connector End View
- Driver Airbag Squib 1 Connector End View
- Driver Airbag Squib 2 Connector End View
- Passenger Airbag Squib Connector End View
- Decklid Ajar Switch Connector End View
- Driver Door Ajar Switch Connector End View
- Hood Ajar Switch Connector End View
- Passenger Door Ajar Switch Connector End View
- Amplifier Antenna Connector End View
- Backup Lamp Switch Connector End View
- Left Backup Lamp Connector End View
- Right Backup Lamp Connector End View
- Battery Temperature Sensor Connector End View
- Negative Battery Connector End View
- Positive Battery Connector End View
- Blend Door Actuator Connector End View
- Blower Motor Connector End View
- Blower Motor Resistor Block Connector End View
- Body Control Module Connector End View (C1)
- Body Control Module Connector End View (C2)
- Body Control Module Connector End View (C3)
- Body Control Module Connector End View (C4)
- Brake Fluid Level Switch Connector End View
- Brake Lamp Switch Connector End View
- Headlamp And Dash Side Inline Connector End View (C100)
- Instrument Panel Side Inline Connector End View (C100)
- Inline (Instrument Panel Side) Connector End View (C101)
- Inline (Headlamp And Dash Side) Connector End View (C101)
- Inline (Headlamp And Dash Side) Connector End View (C102)
- Body Side Inline Connector End View (C102)
- Inline (Headlamp And Dash Side) Connector End View (C103)
- Body Side Inline Connector End View (C103)
- Inline (Headlamp And Dash Side) Connector End View (C104)
- Engine Side Inline Connector End View (C104)
- Inline (Headlamp And Dash Side) Connector End View (C106)
- Inline (Left Headlamp Jumper Side) Connector End View (C106)
- Inline (Right Headlamp Jumper Side) Connector End View (C107)
- Inline (Headlamp And Dash Side) Connector End View (C107)
- Instrument Panel Side Inline Connector End View (C200)
- Body Side Inline Connector End View (C200)
- Body Side Inline Connector End View (C201)
- Instrument Panel Side Inline Connector End View (C201)
- Instrument Panel Side Inline Connector End View (C202)
- Driver Door Side Inline Connector End View (C202)
- Inline (Passenger Door Side) Connector End View (C203)
- Inline (Instrument Panel Side) Connector End View (C203)
- Inline (HVAC Jumper Side) Connector End View (C204)
- Inline (Instrument Panel Side) Connector End View (C204)
- Inline (Mirror Jumper Side) Connector End View (C205)
- Inline (Instrument Panel Side) Connector End View (C205)
- Inline (Instrument Panel Side) Connector End View (C206)
- Console Jumper Side Inline Connector End View (C206)
- Inline (Instrument Panel Side) Connector End View (C207)
- Inline (Passenger Door Side) Connector End View (C207)
- Driver Door Side Inline Connector End View (C208)
- Inline (Instrument Panel Side) Connector End View (C208)
- Transmission Side Inline Connector End View (C300)
- Body Side Inline Connector End View (C300)
- Body Side Inline Connector End View (C301)
- Inline (Left Tail Lamp Side) Connector End View (C301)
- Inline (Right Tail Lamp Side) Connector End View (C302)
- Body Side Inline Connector End View (C302)
- Decklid Jumper Side Inline Connector End View (C303)
- Body Side Inline Connector End View (C303)
- Camshaft Position Sensor Connector End View
- Center High Mounted Stop Lamp Connector End View
- Cigar Lighter Outlet Connector End View
- Clockspring Connector End View
- Clutch Interlock Switch Connector End View
- Antilock Brake Controller Connector End View
- Crankshaft Position Sensor Connector End View
- Driver Cylinder Unlock Switch Connector End View
- Data Link Connector, Connector End View
- Decklid Release Motor Connector End View
- Driver Door Latch Motor Connector End View
- Passenger Door Latch Motor Connector End View
- Driver Door Lock Switch Connector End View
- Passenger Door Lock Switch Connector End View
- Engine Coolant Temperature Sensor Connector End View
- Engine Oil Pressure Sensor Connector End View
- Engine Oil Temperature Sensor Connector End View
- EVAP Purge Solenoid Connector End View
- Driver Exterior Door Handle Switch Connector End View
- Passenger Exterior Door Handle Switch Connector End View
- Left Fog Lamp Connector End View
- Right Fog Lamp Connector End View
- Left Footwell Lamp Connector End View
- Right Footwell Lamp Connector End View
- Fuel Injector 1 Connector End View
- Fuel Injector 2 Connector End View
- Fuel Injector 3 Connector End View
- Fuel Injector 4 Connector End View
- Fuel Injector 5 Connector End View
- Fuel Injector 6 Connector End View
- Fuel Injector 7 Connector End View
- Fuel Injector 8 Connector End View
- Fuel Injector 9 Connector End View
- Fuel Injector 10 Connector End View
- Fuel Tank Module Connector End View
- Gauge Cluster Connector End View (C1)
- Gauge Cluster Connector End View (C2)
- Generator Connector End View
- Glove Box Lamp Connector End View
- Left HID Lamp Connector End View
- Right HID Lamp Connector End View
- Left High Beam Headlamp Connector End View
- Right High Beam Headlamp Connector End View
- Switch Horn Connector End View
- High Note Horn Connector End View
- Low Note Horn Connector End View
- Hydraulic Cooling Module Connector End View
- Idle Air Control Motor Connector End View
- Left Ignition Coil Pack Connector End View
- Right Ignition Coil Pack Connector End View
- Ignition Switch Connector End View
- Illuminated Rearview Mirror Connector End View
- Instrument Cluster Connector End View (C1)
- Instrument Cluster Connector End View (C2)
- Intake Air Temperature Sensor Connector End View
- Driver Interior Door Handle Switch Connector End View
- Passenger Interior Door Handle Switch Connector End View
- Key In Switch Halo Lamp Connector End View
- Knock Sensor 1 Connector End View
- Knock Sensor 2 Connector End View
- Leak Detection Pump Connector End View
- Left License Lamp Connector End View
- Right License Lamp Connector End View
- Manifold Absolute Pressure Sensor Connector End View
- Left Front Marker Lamp Connector End View
- Left Rear Marker Lamp Connector End View
- Right Front Marker Lamp Connector End View
- Right Rear Marker Lamp Connector End View
- Mode Door Defrost To Floor Actuator 1 Connector End View
- Mode Door Actuator 2 (Panel To Floor) Connector End View
- Multifunction Switch Connector End View
- Left Bank Up Oxygen Sensor 1/1 Connector End View
- Left Bank Down Oxygen Sensor 1/2 Connector End View
- Right Bank Up Oxygen Sensor 2/1 Connector End View
- Right Bank Down Oxygen Sensor 2/2 Connector End View
- Park Brake Switch Connector End View
- Left Park Turn Lamp Connector End View
- Right Park Turn Lamp Connector End View
- Power Amplifier Connector End View (C1)
- Power Amplifier Connector End View (C2)
- Power Distribution Center Eyelet Connector End View
- Power Mirror Switch Connector End View
- Driver Power Mirror Connector End View
- Passenger Power Mirror Connector End View
- Power Outlet Connector End View
- Driver Power Window Motor Connector End View
- Passenger Power Window Motor Connector End View
- Driver Power Window Switch Connector End View
- Passenger Power Window Switch Connector End View
- Powertrain Control Module Connector End View (C1)
- Powertrain Control Module Connector End View (C2)
- Powertrain Control Module Connector End View (C3)
- Push Button Starter Switch Connector End View
- Radio Connector End View
- Rear Window Defogger Feed Connector End View
- Rear Window Defogger Ground Connector End View
- Recirculation Door Actuator Connector End View
- Remote Keyless Entry Module Connector End View
- Left Remote Radio Provision Switch Connector End View
- Right Remote Radio Provision Switch Connector End View
- Reverse Lock Out Solenoid Connector End View
- Driver Seat Belt Switch Connector End View
- Passenger Seat Belt Switch Connector End View
- Driver Seat Belt Tensioner Connector End View
- Passenger Seat Belt Tensioner Connector End View
- Left Shutter Motor Connector End View
- Right Shutter Motor Connector End View
- Skip Shift Solenoid Connector End View
- Left Door Speaker Connector End View
- Left Instrument Panel Speaker Connector End View
- Left Rear Speaker Connector End View
- Rear Woofer Speaker Connector End View
- Right Door Speaker Connector End View
- Right Instrument Panel Speaker Connector End View
- Right Rear Speaker Connector End View
- Starter Motor Connector End View
- Starter Motor Battery Eyelet Connector End View
- Starter Motor Generator Connector End View
- Left Tail Lamp Connector End View
- Right Tail Lamp Connector End View
- Left Tail Stop Lamp Connector End View
- Right Tail Stop Lamp Connector End View
- Throttle Position Sensor Connector End View
- Tire Pressure Monitor Module Connector End View
- Left Rear Turn Signal Lamp Connector End View
- Right Rear Turn Signal Lamp Connector End View
- Vehicle Theft Security System LED Connector End View
- Washer Pump Motor Connector End View
- Left Front Wheel Speed Sensor Connector End View
- Left Rear Wheel Speed Sensor Connector End View
- Right Front Wheel Speed Sensor Connector End View
- Right Rear Wheel Speed Sensor Connector End View
- Passenger Window Down Relay Connector End View
- Passenger Window Up Relay Connector End View
- Wiper Control Module Connector End View
- Wiper Motor Connector End View
- Connector Pin-Outs
- Using lemon2025'S System Wiring Diagrams
- Wiring Diagram Information
- Wiring Diagram Information
- Description
- Warning
- Diagnosis And Testing
- Standard Procedure
- Standard Procedure - Electrostatic Discharge (ESD) Sensitive Devices
- Standard Procedure - Testing Of Voltage Potential
- Standard Procedure - Testing For Continuity
- Standard Procedure - Testing For A Short To Ground
- Standard Procedure - Testing For A Short To Ground On Fuses Powering Several Loads
- Standard Procedure - Testing For A Voltage Drop
- Special Tools
- Connector
- Diode
- Terminal
- Wire
- Wiring Diagram Information
- Connector End Views
- Accessories & Equipment
- Anti-Theft Systems
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Body Control Module
- Chime Warning System
- Communication
- Door Ajar System
- Exterior Lighting System
- Relays Controlled By The BCM
- Heating & A/C System
- Instrument Cluster / Gauge Cluster
- Interior Lighting
- Tire Pressure Monitoring System (TPMS)
- Power Door Entry System
- Power Windows
- Electrically Heated Systems
- Vehicle Theft Security System
- Using The DRBIII®
- DRBIII® Error Messages
- DRBIII® Does Not Power Up (Blank Screen)
- Display Is Not Visible
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; ACCELEROMETER 2; INTERNAL 1; OUTPUT DRIVER 1; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: DRIVER SQUIB 2 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 2 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 2 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 2 SHORT TO GROUND
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH OPEN
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO BATTERY
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO GROUND
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO BATTERY
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: PASSENGER SQUIB 2 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 2 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 2 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 2 SHORT TO GROUND
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom List: CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH BCM
- Chime
- Communication
- Symptom: ACM MESSAGES NOT RECEIVED
- Symptom: AUDIO MESSAGES NOT RECEIVED
- Symptom: COUNTRY CODE NOT PROGRAMMED
- Symptom: INTERNAL BCM FAILURE
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom List: PCI BUS SHORTED TO BATTERY; PCI BUS SHORTED TO GROUND
- Symptom: PCI INTERNAL FAULT
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM BODY CONTROL MODULE
- Symptom: *NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE
- Symptom: *NO RESPONSE FROM HVAC
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM PCM (PCI BUS)
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY)
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM TIRE PRESSURE MONITOR MODULE
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Door Ajar
- Symptom: *DECKLID AJAR CIRCUIT OPEN
- Symptom: *DECKLID AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *DRIVER DOOR AJAR CIRCUIT OPEN
- Symptom: *DRIVER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *HOOD AJAR CIRCUIT OPEN
- Symptom: *HOOD AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *PASSENGER DOOR AJAR CIRCUIT OPEN
- Symptom: *PASSENGER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Electrically Heated Systems
- Exterior Lighting
- Symptom: LEFT FOG LAMP OUTPUT OPEN
- Symptom: LEFT FOG LAMP OUTPUT SHORTED
- Symptom: LEFT HIGH BEAM OUTPUT OPEN
- Symptom: LEFT HIGH BEAM OUTPUT SHORT
- Symptom: LOW BEAM RELAY COIL OUTPUT OPEN/SHORT TO GROUND
- Symptom: LOW BEAM RELAY COIL SHORT TO VOLTAGE
- Symptom: PARK LAMP OUTPUT SHORT
- Symptom: RIGHT FOG LAMP OUTPUT OPEN
- Symptom: RIGHT FOG LAMP OUTPUT SHORTED
- Symptom: RIGHT HIGH BEAM OUTPUT OPEN
- Symptom: RIGHT HIGH BEAM OUTPUT SHORT
- Heating & A/C
- Symptom List: A/C SWITCH FAULT (ACTIVE); CHECKSUM FAILURE (ACTIVE); DEFOG SWITCH FAULT (ACTIVE)
- Symptom List: A/C SWITCH FAULT (STORED); BACKLIGHT DIMMING RX FAILURE (STORED); BLEND OVERCURRENT (STORED); CHECKSUM FAILURE (STORED); DEFOG SWITCH FAULT (STORED); LOOPBACK TEST FAILURE (STORED); MODE 1 OVERCURRENT (STORED); MODE 2 OVERCURRENT (STORED); RECIRC OVERCURRENT (STORED); REFRIGERANT PRESS RX FAILURE (STORED); TX FAILURE (STORED); VIN RX FAILURE (STORED)
- Notes
- When Monitored and Set Condition:
- A/C Switch Fault (Stored)
- Backlight Dimming RX Failure (Stored)
- Blend OVERCURRENT (Stored)
- Checksum Failure (Stored)
- Defog Switch Fault (Stored)
- LOOPBACK Test Failure (Stored)
- Mode 1 OVERCURRENT (Stored)
- Mode 2 OVERCURRENT (Stored)
- RECIRC OVERCURRENT (Stored)
- Refrigerant Press RX Failure (Stored)
- TX Failure (Stored)
- VIN RX Failure (Stored)
- Possible Causes
- Diagnostic Procedure
- Symptom List: ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE; BLEND CIRCUIT SHORTED TO GROUND; BLEND CIRCUIT SHORTED TO IGN OR BATT; COMMON DRIVER SHORTED TO GROUND; COMMON DRIVER SHORTED TO IGN OR BATT; MODE 1 CIRCUIT SHORTED TO GROUND; MODE 1 CIRCUIT SHORTED TO IGN OR BATT; MODE 2 CIRCUIT SHORTED TO GROUND; MODE 2 CIRCUIT SHORTED TO IGN OR BATT; RECIRC CIRCUIT SHORTED TO GROUND; RECIRC CIRCUIT SHORTED TO IGN OR BATT; SHORT TOO COMPLEX
- Notes
- When Monitored and Set Condition:
- Act CKT Test Passed, OVERCURRENT DTCS Active
- Blend Circuit Shorted To Ground
- Blend Circuit Shorted To IGN Or Batt
- Common Driver Shorted To Ground
- Common Driver Shorted To IGN Or Batt
- Mode 1 Circuit Shorted To Ground
- Mode 1 Circuit Shorted To IGN Or Batt
- Mode 2 Circuit Shorted To Ground
- Mode 2 Circuit Shorted To IGN Or Batt
- RECIRC Circuit Shorted To Ground
- RECIRC Circuit Shorted To IGN Or Batt
- Short Too Complex
- Possible Causes
- Diagnostic Procedure
- Symptom: BACKLIGHT DIMMING RX FAILURE (ACTIVE)
- Symptom List: BLEND CALIBRATION FAULT; MODE 1 CALIBRATION FAULT; MODE 2 CALIBRATION FAULT; RECIRCULATION CALIBRATION FAULT
- Symptom List: BLEND OVERCURRENT (ACTIVE); MODE 1 OVERCURRENT (ACTIVE); MODE 2 OVERCURRENT (ACTIVE); RECIRC OVERCURRENT (ACTIVE)
- Symptom: DEFOG RELAY CONTROL CKT SHORTED TO BATT
- Symptom: LOOPBACK TEST FAILURE (ACTIVE)
- Symptom List: REFRIGERANT PRESSURE RX FAILURE (ACTIVE); VIN RX FAILURE (ACTIVE)
- Symptom: TX FAILURE (ACTIVE)
- Symptom: *A/C - HEATER CONTROL ILLUMINATION INOPERATIVE
- Symptom: *BLEND/MODE/RECIRC DOOR OPERATION IMPROPER
- Symptom: *BLOWER MOTOR INOPERATIVE
- Symptom: *BLOWER MOTOR SPEEDS INCORRECT
- Symptom: *EBL STATUS INDICATOR FLASHING
- Symptom: *HVAC SYSTEM TEST
- Ignition, Power, Accessory
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT OPEN
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT SHORT TO GROUND
- Symptom: BCM - IGNITION MUX SWITCH INPUT MISMATCH
- Symptom: BCM - IGNITION MUX SWITCH INPUT OPEN
- Symptom: BCM - IGNITION MUX SWITCH INPUT SHORT
- Symptom: BCM - IGNITION RUN 1 SHORT
- Symptom: BCM - IGNITION RUN 2 SHORT
- Symptom: BCM - IOD OUTPUT CIRCUIT SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT OPEN / SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT SHORT TO VOLTAGE
- Symptom: BCM - RUN/START HARDWIRE INPUT MISMATCH
- Symptom: HORN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: HORN RELAY COIL SHORT TO BATTERY
- Symptom: HORN SWITCH STUCK
- Symptom: *HORNS INOPERATIVE
- Instrument Cluster
- Symptom List: ABS LAMP CIRCUIT OPEN; ABS LAMP CIRCUIT SHORTED; AIRBAG LAMP CIRCUIT OPEN; AIRBAG LAMP CIRCUIT SHORTED
- Symptom: ABS MESSAGES NOT RECEIVED
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT OPEN / SHORTED TO VOLTAGE
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT SHORT TO GROUND
- Symptom: BCM - PWM DIMMING OUTPUT SHORT
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: ORC MESSAGES NOT RECEIVED
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *GAUGE CLUSTER DIAGNOSTIC TEST
- Symptom: *INSTRUMENT CLUSTER DIAGNOSTIC TEST
- Interior Lighting
- Power Door Locks/RKE
- Symptom: DECKLID RELEASE OUTPUT OPEN
- Symptom: DECKLID RELEASE OUTPUT SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH OPEN OR SHORT TO VOLTAGE
- Symptom: DRIVER CYLINDER UNLOCK SWITCH SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH STUCK
- Symptom: DRIVER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: DRIVER DOOR LOCK SWITCH STUCK
- Symptom: DRIVER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: DRIVER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: DRIVER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER DOOR LOCK SWITCH STUCK
- Symptom: PASSENGER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER/DRIVER DOOR UNLATCH RETURN SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT OPEN/SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT SHORT TO BATTERY
- Symptom: *ALL DOOR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR UNLATCH INOPERATIVE
- Symptom: *PASSENGER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *PASSENGER DOOR UNLATCH INOPERATIVE
- Symptom: *REMOTE KEYLESS ENTRY PROBLEM
- Power Windows
- Symptom: DRIVER WINDOW DOWN OUTPUT SHORT TO GROUND
- Symptom: DRIVER WINDOW HALL EFFECT FAILURE
- Symptom: DRIVER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: DRIVER WINDOW SWITCH SHORT TO GROUND
- Symptom: DRIVER WINDOW SWITCH STUCK DOWN
- Symptom: DRIVER WINDOW SWITCH STUCK UP
- Symptom: DRIVER WINDOW UP OUTPUT SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL SHORT TO BATTERY
- Symptom: PASSENGER WINDOW HALL EFFECT FAILURE
- Symptom: PASSENGER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: PASSENGER WINDOW SWITCH SHORT TO GROUND
- Symptom: PASSENGER WINDOW SWITCH STUCK DOWN
- Symptom: PASSENGER WINDOW SWITCH STUCK UP
- Symptom: PASSENGER WINDOW UP SHORT TO GROUND
- Symptom: *DRIVER WINDOW INOPERATIVE
- Symptom: *PASSENGER WINDOW INOPERATIVE
- Tire Pressure Monitoring
- Symptom: CRITICAL TIRE PRESSURE - BCM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM
- Symptom: TIRE PRESSURE LOW - BCM
- Symptom: TIRE PRESSURE MONITOR MODULE FAILURE - TPM
- Symptom: TPM DIAGNOSTIC - BCM
- Symptom: TPM MODULE INITIALIZED - BCM
- Symptom: *LO TIRE LCD MESSAGE FLASHING
- Vehicle Theft/Security
- Symptom: VTSS INDICATOR OUTPUT OPEN
- Symptom: VTSS INDICATOR OUTPUT SHORT
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *DECKLID DOES NOT TRIP VTSS
- Symptom: *DRIVER DOOR DOES NOT TRIP VTSS
- Symptom: *EXTERIOR LAMPS FAIL TO FLASH WHEN ALARM IS TRIPPED
- Symptom: *HOOD DOES NOT TRIP VTSS
- Symptom: *HORN FAILS TO SOUND WHEN ALARM IS TRIPPED
- Symptom: *PASSENGER DOOR DOES NOT TRIP VTSS
- Symptom: *VTSS LAMP ON STEADY DURING ARMING
- Symptom: *VTSS WILL NOT ARM
- Verification Tests
- Airbag
- Component Locations
- Connector PINOUTS
- A/C-Heater Control C1 - Black 10 Way
- A/C-Heater Control C2 - Black 16 Way
- Airbag Control Module C1 (Orc) - Yellow 32 Way
- Airbag Control Module C2 (Orc) - Yellow 32 Way
- Airbag On/Off Switch-Passenger - Yellow 6 Way
- Airbag Squib 1-Driver - Yellow/Black 2 Way
- Airbag Squib 2-Driver - Yellow/Gray 2 Way
- Airbag Squib-Passenger - Yellow 4 Way
- Ajar Switch-DECKLID - Black 3 Way
- Ajar Switch-Driver Door - Black 4 Way
- Ajar Switch-Hood - Natural 3 Way
- Ajar Switch-Passenger Door - Black 4 Way
- Blend Door Actuator - Gray 2 Way
- Blower Motor - Orange 2 Way
- Blower Motor Resistor Block - Black 4 Way
- Body Control Module C1 - Black 6 Way
- Body Control Module C2 - Black/Green 34 Way
- Body Control Module C3 - Black/White 34 Way
- Body Control Module C4 - Black/Gray 34 Way
- Brake Fluid Level Switch - Black 2 Way
- C200 - Black (Body Side)
- C200 - Black (Instrument Panel Side)
- C201 - Yellow (Body Side)
- C201 - Yellow (Instrument Panel Side)
- C202 - Natural (Driver Door Side)
- C202 - Natural (Instrument Panel Side)
- C203 - Natural (Instrument Panel Side)
- C203 - Natural (Passenger Door Side)
- C204 - LT. Gray (HVAC Jumper Side)
- C204 - LT. Gray (Instrument Panel Side)
- C206 - Red (Console Jumper Side)
- C206 - Red (Instrument Panel Side)
- C207 - Green (Instrument Panel Side)
- C207 - Natural (Passenger Door Side)
- C208 - Green (Instrument Panel Side)
- C208 - Natural (Driver Door Side)
- C303 - Black (Body Side)
- C303 - Black (DECKLID Jumper Side)
- CLOCKSPRING - White 8 Way
- Controller Antilock Brake - Black 24 Way
- Cylinder Unlock Switch-Driver - Black 2 Way
- Data Link Connector - Black 16 Way
- DECKLID Release Motor - Black 2 Way
- Door Latch Motor-Driver - 2 Way
- Door Latch Motor-Passenger - 2 Way
- Door Lock Switch-Driver - Black 3 Way
- Door Lock Switch-Passenger - Black 3 Way
- Exterior Door Handle Switch-Driver - Black 2 Way
- Exterior Door Handle Switch-Passenger - Black 2 Way
- Fog Lamp-Left - Black 2 Way
- Gauge Cluster C1 - White 3 Way
- Gauge Cluster C2 - Black 20 Way
- Hid Lamp-Left - Gray 2 Way
- High Beam Headlamp-Left - Black 2 Way
- Horn Switch - Black 1 Way
- Horn-High Note - Black 2 Way
- Horn-Low Note - Black 2 Way
- Ignition Switch - Black 5 Way
- Instrument Cluster C1 - Black 16 Way
- Instrument Cluster C2 - Black 20 Way
- Interior Door Handle Switch-Driver - Black 2 Way
- Interior Door Handle Switch-Passenger - Black 2 Way
- Marker Lamp-Left Front - DK. Gray 2 Way
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way
- Multi-Function Switch - Gray 20 Way
- Power Distribution Center
- Power Window Motor-Driver - Black 6 Way
- Power Window Motor-Passenger - Black 6 Way
- Power Window Switch-Driver - Gray 3 Way
- Power Window Switch-Passenger - Gray 3 Way
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Radio - Gray 22 Way
- RECIRCULATION Door Actuator - Gray 2 Way
- Remote Keyless Entry Module - Black 6 Way
- Seat Belt Switch-Driver - White 2 Way
- Seat Belt Switch-Passenger - White 2 Way
- Seat Belt TENSIONER-Driver - Yellow 2 Way
- Seat Belt TENSIONER-Passenger - Yellow 2 Way
- Speaker-Left Door - Black 2 Way
- Speaker-Left Instrument Panel - White 2 Way
- Speaker-Left Rear - White 3 Way
- Speaker-Rear Woofer - Gray 4 Way
- Speaker-Right Door - Black 2 Way
- Speaker-Right Instrument Panel - White 2 Way
- Speaker-Right Rear - White 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Window Down Relay-Passenger - Black 5 Way
- Window Up Relay-Passenger - Black 5 Way
- Schematic Diagrams
- Airbag System
- Audio System
- Chime System
- Communication
- Door Ajar System
- Electrically Heated Systems
- Exterior Lighting
- Heating & A/C System
- Ignition, Power, Accessory
- Instrument Cluster/Gauge Cluster
- Interior Lighting
- Power Door Locks/RKE
- Power Window System
- Tire Pressure Monitor Module (TPM)
- Vehicle Theft Security System
- Power Door Locks (Service Information)
- Power Locks
- Door Cylinder Unlock Switch
- Exterior Door Handle Switch
- Interior Door Handle Switch
- Power Lock Switch
- Remote Keyless Entry Module
- Remote Keyless Entry Transmitter
- Powertrain Diagnostic Procedures
- DTC Index
- Introduction
- Identification Of System
- System Description And Functional Operation
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Acronyms
- Diagnostic Information And Procedures
- Communication - Symptoms
- DRIVEABILITY - Gas - Symptoms
- Symptom: INTERMITTENT CONDITION
- Symptom: *BRAKE SWITCH SENSE STATUS DOES NOT CHANGE ON DRBIII®
- Symptom: *CANNOT SHIFT INTO 2ND AND 3RD GEARS
- Symptom: *CANNOT SHIFT INTO REVERSE
- Symptom: *CHECKING A/C SYSTEM OPERATION WITH NO DTCS
- Symptom: *CHECKING CHARGING SYSTEM OPERATION WITH NO DTCS
- Symptom: *CHECKING RADIATOR FAN OPERATION
- Symptom: *CHECKING THE PCM POWER AND GROUNDS
- DRIVEABILITY - Gas - Diagnostic Tests
- P0031-O2 Sensor 1/1 Heater Circuit Low; P0032-O2 Sensor 1/1 Heater Circuit High; P0051-O2 Sensor 2/1 Heater Circuit Low; P0052-O2 Sensor 2/1 Heater Circuit High
- P0071-Ambient/Battery Temp Sensor Performance
- P0107-Map Sensor Voltage Too Low
- P0108-Map Sensor Voltage Too High
- P0111-Intake Air Temp Performance
- P0112-Intake Air Temp Sensor Voltage Too Low
- P0113-Intake Air Temp Sensor Voltage Too High
- P0117-Engine Coolant Temp Sensor Voltage Too Low
- P0118-Engine Coolant Temp Sensor Voltage Too High
- P0121-TP Sensor Voltage Does Not Agree With Map
- P0122-Throttle Position Sensor #1 Voltage Too Low
- P0123-Throttle Position Sensor #1 Voltage Too High
- P0125-Closed Loop Temp Not Reached
- P0131-O2 Sensor 1/1 Circuit Voltage Too Low; P0137-O2 Sensor 1/2 Circuit Voltage Too Low; P0151-O2 Sensor 2/1 Circuit Voltage Too Low; P0157-O2 Sensor 2/2 Circuit Voltage Too Low
- P0132-O2 Sensor 1/1 Circuit Voltage Too High; P0138-O2 Sensor 1/2 Circuit Voltage Too High; P0152-O2 Sensor 2/1 Circuit Voltage Too High; P0158-O2 Sensor 2/2 Circuit Voltage Too High
- P0133-O2 Sensor 1/1 Slow Response; P0139-O2 Sensor 1/2 Slow Response; P0153-O2 Sensor 2/1 Slow Response; P0159-O2 Sensor 2/2 Slow Response
- P0135-O2 Sensor 1/1 Heater Failure; P0141-O2 Sensor 1/2 Heater Failure; P0155-O2 Sensor 2/1 Heater Failure; P0161-O2 Sensor 2/2 Heater Failure
- P0136-O2 Sensor 1/2 Heater Circuit Malfunction
- P0171-1/1 Fuel System Lean; P0174-2/1 Fuel System Lean
- P0172-1/1 Fuel System Rich; P0175-2/1 Fuel System Rich
- P0197-Engine Oil Temperature Sensor Voltage Too Low
- P0198-Engine Oil Temperature Sensor Voltage Too High
- P0201-Injector #1 Control Circuit; P0202-Injector #2 Control Circuit; P0203-Injector #3 Control Circuit; P0204-Injector #4 Control Circuit; P0205-Injector #5 Control Circuit; P0206-Injector #6 Control Circuit; P0207-Injector #7 Control Circuit; P0208-Injector #8 Control Circuit; P0209-Injector #9 Control Circuit; P0210-Injector #10 Control Circuit
- Notes
- When Monitored and Set Condition:
- P0201-Injector #1 Control Circuit
- P0202-Injector #2 Control Circuit
- P0203-Injector #3 Control Circuit
- P0204-Injector #4 Control Circuit
- P0205-Injector #5 Control Circuit
- P0206-Injector #6 Control Circuit
- P0207-Injector #7 Control Circuit
- P0208-Injector #8 Control Circuit
- P0209-Injector #9 Control Circuit
- P0210-Injector #10 Control Circuit
- Possible Causes
- Diagnostic Procedure
- P0300-Multiple Cylinder Mis-Fire; P0301-Cylinder #1 Misfire; P0302-Cylinder #2 Misfire; P0303-Cylinder #3 Misfire; P0304-Cylinder #4 Misfire; P0305-Cylinder #5 Misfire; P0306-Cylinder #6 Misfire; P0307-Cylinder #7 Misfire; P0308-Cylinder #8 Misfire; P0309-Cylinder #9 Misfire; P0310-Cylinder #10 Misfire
- P0320-No Crank Reference Signal At Pcm
- P0340-No Cam Reference Signal At Pcm
- P0351-Ignition Coil #1 Primary Circuit; P0352-Ignition Coil #2 Primary Circuit; P0353-Ignition Coil #3 Primary Circuit; P0354-Ignition Coil #4 Primary Circuit; P0355-Ignition Coil #5 Primary Circuit
- P0420-1/1 Catalytic Converter Efficiency; P0432-2/1 Catalytic Converter Efficiency
- P0441-EVAP Purge Flow Monitor
- P0442-EVAP Leak Monitor Medium (0.040) Leak Detected P0455-EVAP Leak Monitor Large Leak Detected
- P0443-EVAP Purge Solenoid Circuit
- P0460-Fuel Level Sending Unit No Change Over Miles
- P0462-Fuel Level Sending Unit Volts Too Low
- P0463-Fuel Level Sending Unit Volts Too High
- P0500-No Vehicle Speed Signal
- P0505-Idle Air Control Motor Circuits
- P0522-Oil Pressure Circuit Low
- P0523-Oil Pressure Circuit High
- P0601-Pcm Internal Controller Failure
- P0622-Generator Field Not Switching Properly
- P0645-A/C Clutch Relay Circuit
- P0801-Reverse Gear Lockout Circuit Open Or Shorted
- P1195-O2 Sensor 1/1 Slow During Catalyst Monitor P1196-O2 Sensor 2/1 Slow During Catalyst Monitor
- P1281-Engine Is Cold Too Long
- P1282-Fuel Pump/System Relay Control Circuit
- P1294-Target Idle Not Reached
- P1296-No 5-Volts To Map Sensor
- P1297-No Change In Map From Start To Run
- P1388-Auto Shutdown Relay Control Circuit
- P1389-No ASD Relay Output Voltage At Pcm
- P1391-Intermittent Loss Of CMP Or CKP
- P1398-Mis-Fire Adaptive Numerator At Limit
- P1486-EVAP Leak Monitor Pinched Hose Found
- P1492-Ambient/Battery Temperature Sensor Voltage Too High
- P1493-Ambient/Battery Temperature Sensor Voltage Too Low
- P1494-Leak Detection Pump Switch Or Mechanical Fault
- P1495-Leak Detection Pump Solenoid Circuit
- P1499-Hydraulic Fan Solenoid Circuit
- P1594-Charging System Voltage Too High
- P1598-A/C Pressure Sensor Voltage Too High
- P1599-A/C Pressure Sensor Voltage Too Low
- P1682-Charging System Voltage Too Low
- P1687-No Cluster Bus Message
- P1695-Bus Message From Body Control Module
- P1696-Pcm Failure EEPROM Write Denied
- P1719-Skip Shift Solenoid Circuit Open Or Shorted
- Starting - Symptoms
- Verification Tests
- Component Locations
- Control Modules And PDC
- Data Link Connector
- Sensors And Solenoids
- Battery Temp. Sensor Location
- Cam Position Sensor Location
- Crank Position Sensor Location
- MAP, ECT And Fuel Injector Locations
- IAT Sensor Location
- Engine Oil Pressure Sensor And Engine Oil Temp. Sensor Locations
- O2 Sensor Locations
- IAC Motor And TPS Locations
- Ignition Coil Locations
- Skip Shift Solenoid And Vehicle Speed Sensor Locations
- Fuel System
- Connector PINOUTS
- A/C Compressor Clutch - Black 2 Way
- A/C Low Pressure Switch - DK. Green 2 Way
- A/C Pressure Transducer - Black 4 Way
- Battery Temperature Sensor - 2 Way
- Brake Lamp Switch - Black 6 Way
- Camshaft Position Sensor - Gray 3 Way
- CLOCKSPRING - White 8 Way
- Clutch Interlock Switch - DK.Green 2 Way
- Crankshaft Position Sensor - Black 3 Way
- Data Link Connector - Black 16 Way
- Engine Coolant Temperature Sensor - Black 2 Way
- Engine Oil Pressure Sensor - Black 3 Way
- Engine Oil Temperature Sensor - Black 2 Way
- EVAP/Purge Solenoid - Black 2 Way
- Fuel Injector No. 1 - Black 2 Way
- Fuel Injector No. 2 - Black 2 Way
- Fuel Injector No. 3 - Black 2 Way
- Fuel Injector No. 4 - Black 2 Way
- Fuel Injector No. 5 - Black 2 Way
- Fuel Injector No. 6 - Black 2 Way
- Fuel Injector No. 7 - Black 2 Way
- Fuel Injector No. 8 - Black 2 Way
- Fuel Injector No. 9 - Black 2 Way
- Fuel Injector No. 10 - Black 2 Way
- Fuel Tank Module - Gray 4 Way
- Generator - Gray 2 Way
- Hydraulic Cooling Module - Black 3 Way
- Idle Air Control Motor - Black 4 Way
- Ignition Coil Pack-Left - Black 4 Way
- Ignition Coil Pack-Right - Black 3 Way
- Ignition Switch - Black 5 Way
- Intake Air Temperature Sensor - Black 2 Way
- Leak Detection Pump - Black 4 Way
- Manifold Absolute Pressure Sensor - Black 3 Way
- Multi-Function Switch - Gray 20 Way
- Oxygen Sensor 1/1 Left Bank Up - Black 4 Way
- Oxygen Sensor 1/2 Left Bank Down - Black 4 Way
- Oxygen Sensor 2/1 Right Bank Up - Black 4 Way
- Oxygen Sensor 2/2 Right Bank Down - Black 4 Way
- Power Distribution Center
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Push-Button Starter Switch - Natural 6 Way
- Reverse Lock-Out Solenoid - White 2 Way
- Skip Shift Solenoid - White 2 Way
- Throttle Position Sensor - Black 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Schematic Diagrams
- Charts And Graphs
- Vehicle Theft Security
- Body Diagnostic Procedures
- Body Interior
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Body Control Module
- Chime Warning System
- Communication
- Door Ajar System
- Exterior Lighting System
- Relays Controlled By The BCM
- Heating & A/C System
- Instrument Cluster / Gauge Cluster
- Interior Lighting
- Tire Pressure Monitoring System (TPMS)
- Power Door Entry System
- Power Windows
- Electrically Heated Systems
- Vehicle Theft Security System
- Using The DRBIII®
- DRBIII® Error Messages
- DRBIII® Does Not Power Up (Blank Screen)
- Display Is Not Visible
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; ACCELEROMETER 2; INTERNAL 1; OUTPUT DRIVER 1; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: DRIVER SQUIB 2 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 2 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 2 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 2 SHORT TO GROUND
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH OPEN
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO BATTERY
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO GROUND
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO BATTERY
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: PASSENGER SQUIB 2 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 2 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 2 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 2 SHORT TO GROUND
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom List: CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH BCM
- Chime
- Communication
- Symptom: ACM MESSAGES NOT RECEIVED
- Symptom: AUDIO MESSAGES NOT RECEIVED
- Symptom: COUNTRY CODE NOT PROGRAMMED
- Symptom: INTERNAL BCM FAILURE
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom List: PCI BUS SHORTED TO BATTERY; PCI BUS SHORTED TO GROUND
- Symptom: PCI INTERNAL FAULT
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM BODY CONTROL MODULE
- Symptom: *NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE
- Symptom: *NO RESPONSE FROM HVAC
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM PCM (PCI BUS)
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY)
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM TIRE PRESSURE MONITOR MODULE
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Door Ajar
- Symptom: *DECKLID AJAR CIRCUIT OPEN
- Symptom: *DECKLID AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *DRIVER DOOR AJAR CIRCUIT OPEN
- Symptom: *DRIVER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *HOOD AJAR CIRCUIT OPEN
- Symptom: *HOOD AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *PASSENGER DOOR AJAR CIRCUIT OPEN
- Symptom: *PASSENGER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Electrically Heated Systems
- Exterior Lighting
- Symptom: LEFT FOG LAMP OUTPUT OPEN
- Symptom: LEFT FOG LAMP OUTPUT SHORTED
- Symptom: LEFT HIGH BEAM OUTPUT OPEN
- Symptom: LEFT HIGH BEAM OUTPUT SHORT
- Symptom: LOW BEAM RELAY COIL OUTPUT OPEN/SHORT TO GROUND
- Symptom: LOW BEAM RELAY COIL SHORT TO VOLTAGE
- Symptom: PARK LAMP OUTPUT SHORT
- Symptom: RIGHT FOG LAMP OUTPUT OPEN
- Symptom: RIGHT FOG LAMP OUTPUT SHORTED
- Symptom: RIGHT HIGH BEAM OUTPUT OPEN
- Symptom: RIGHT HIGH BEAM OUTPUT SHORT
- Heating & A/C
- Symptom List: A/C SWITCH FAULT (ACTIVE); CHECKSUM FAILURE (ACTIVE); DEFOG SWITCH FAULT (ACTIVE)
- Symptom List: A/C SWITCH FAULT (STORED); BACKLIGHT DIMMING RX FAILURE (STORED); BLEND OVERCURRENT (STORED); CHECKSUM FAILURE (STORED); DEFOG SWITCH FAULT (STORED); LOOPBACK TEST FAILURE (STORED); MODE 1 OVERCURRENT (STORED); MODE 2 OVERCURRENT (STORED); RECIRC OVERCURRENT (STORED); REFRIGERANT PRESS RX FAILURE (STORED); TX FAILURE (STORED); VIN RX FAILURE (STORED)
- Notes
- When Monitored and Set Condition:
- A/C Switch Fault (Stored)
- Backlight Dimming RX Failure (Stored)
- Blend OVERCURRENT (Stored)
- Checksum Failure (Stored)
- Defog Switch Fault (Stored)
- LOOPBACK Test Failure (Stored)
- Mode 1 OVERCURRENT (Stored)
- Mode 2 OVERCURRENT (Stored)
- RECIRC OVERCURRENT (Stored)
- Refrigerant Press RX Failure (Stored)
- TX Failure (Stored)
- VIN RX Failure (Stored)
- Possible Causes
- Diagnostic Procedure
- Symptom List: ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE; BLEND CIRCUIT SHORTED TO GROUND; BLEND CIRCUIT SHORTED TO IGN OR BATT; COMMON DRIVER SHORTED TO GROUND; COMMON DRIVER SHORTED TO IGN OR BATT; MODE 1 CIRCUIT SHORTED TO GROUND; MODE 1 CIRCUIT SHORTED TO IGN OR BATT; MODE 2 CIRCUIT SHORTED TO GROUND; MODE 2 CIRCUIT SHORTED TO IGN OR BATT; RECIRC CIRCUIT SHORTED TO GROUND; RECIRC CIRCUIT SHORTED TO IGN OR BATT; SHORT TOO COMPLEX
- Notes
- When Monitored and Set Condition:
- Act CKT Test Passed, OVERCURRENT DTCS Active
- Blend Circuit Shorted To Ground
- Blend Circuit Shorted To IGN Or Batt
- Common Driver Shorted To Ground
- Common Driver Shorted To IGN Or Batt
- Mode 1 Circuit Shorted To Ground
- Mode 1 Circuit Shorted To IGN Or Batt
- Mode 2 Circuit Shorted To Ground
- Mode 2 Circuit Shorted To IGN Or Batt
- RECIRC Circuit Shorted To Ground
- RECIRC Circuit Shorted To IGN Or Batt
- Short Too Complex
- Possible Causes
- Diagnostic Procedure
- Symptom: BACKLIGHT DIMMING RX FAILURE (ACTIVE)
- Symptom List: BLEND CALIBRATION FAULT; MODE 1 CALIBRATION FAULT; MODE 2 CALIBRATION FAULT; RECIRCULATION CALIBRATION FAULT
- Symptom List: BLEND OVERCURRENT (ACTIVE); MODE 1 OVERCURRENT (ACTIVE); MODE 2 OVERCURRENT (ACTIVE); RECIRC OVERCURRENT (ACTIVE)
- Symptom: DEFOG RELAY CONTROL CKT SHORTED TO BATT
- Symptom: LOOPBACK TEST FAILURE (ACTIVE)
- Symptom List: REFRIGERANT PRESSURE RX FAILURE (ACTIVE); VIN RX FAILURE (ACTIVE)
- Symptom: TX FAILURE (ACTIVE)
- Symptom: *A/C - HEATER CONTROL ILLUMINATION INOPERATIVE
- Symptom: *BLEND/MODE/RECIRC DOOR OPERATION IMPROPER
- Symptom: *BLOWER MOTOR INOPERATIVE
- Symptom: *BLOWER MOTOR SPEEDS INCORRECT
- Symptom: *EBL STATUS INDICATOR FLASHING
- Symptom: *HVAC SYSTEM TEST
- Ignition, Power, Accessory
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT OPEN
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT SHORT TO GROUND
- Symptom: BCM - IGNITION MUX SWITCH INPUT MISMATCH
- Symptom: BCM - IGNITION MUX SWITCH INPUT OPEN
- Symptom: BCM - IGNITION MUX SWITCH INPUT SHORT
- Symptom: BCM - IGNITION RUN 1 SHORT
- Symptom: BCM - IGNITION RUN 2 SHORT
- Symptom: BCM - IOD OUTPUT CIRCUIT SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT OPEN / SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT SHORT TO VOLTAGE
- Symptom: BCM - RUN/START HARDWIRE INPUT MISMATCH
- Symptom: HORN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: HORN RELAY COIL SHORT TO BATTERY
- Symptom: HORN SWITCH STUCK
- Symptom: *HORNS INOPERATIVE
- Instrument Cluster
- Symptom List: ABS LAMP CIRCUIT OPEN; ABS LAMP CIRCUIT SHORTED; AIRBAG LAMP CIRCUIT OPEN; AIRBAG LAMP CIRCUIT SHORTED
- Symptom: ABS MESSAGES NOT RECEIVED
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT OPEN / SHORTED TO VOLTAGE
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT SHORT TO GROUND
- Symptom: BCM - PWM DIMMING OUTPUT SHORT
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: ORC MESSAGES NOT RECEIVED
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *GAUGE CLUSTER DIAGNOSTIC TEST
- Symptom: *INSTRUMENT CLUSTER DIAGNOSTIC TEST
- Interior Lighting
- Power Door Locks/RKE
- Symptom: DECKLID RELEASE OUTPUT OPEN
- Symptom: DECKLID RELEASE OUTPUT SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH OPEN OR SHORT TO VOLTAGE
- Symptom: DRIVER CYLINDER UNLOCK SWITCH SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH STUCK
- Symptom: DRIVER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: DRIVER DOOR LOCK SWITCH STUCK
- Symptom: DRIVER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: DRIVER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: DRIVER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER DOOR LOCK SWITCH STUCK
- Symptom: PASSENGER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER/DRIVER DOOR UNLATCH RETURN SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT OPEN/SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT SHORT TO BATTERY
- Symptom: *ALL DOOR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR UNLATCH INOPERATIVE
- Symptom: *PASSENGER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *PASSENGER DOOR UNLATCH INOPERATIVE
- Symptom: *REMOTE KEYLESS ENTRY PROBLEM
- Power Windows
- Symptom: DRIVER WINDOW DOWN OUTPUT SHORT TO GROUND
- Symptom: DRIVER WINDOW HALL EFFECT FAILURE
- Symptom: DRIVER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: DRIVER WINDOW SWITCH SHORT TO GROUND
- Symptom: DRIVER WINDOW SWITCH STUCK DOWN
- Symptom: DRIVER WINDOW SWITCH STUCK UP
- Symptom: DRIVER WINDOW UP OUTPUT SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL SHORT TO BATTERY
- Symptom: PASSENGER WINDOW HALL EFFECT FAILURE
- Symptom: PASSENGER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: PASSENGER WINDOW SWITCH SHORT TO GROUND
- Symptom: PASSENGER WINDOW SWITCH STUCK DOWN
- Symptom: PASSENGER WINDOW SWITCH STUCK UP
- Symptom: PASSENGER WINDOW UP SHORT TO GROUND
- Symptom: *DRIVER WINDOW INOPERATIVE
- Symptom: *PASSENGER WINDOW INOPERATIVE
- Tire Pressure Monitoring
- Symptom: CRITICAL TIRE PRESSURE - BCM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM
- Symptom: TIRE PRESSURE LOW - BCM
- Symptom: TIRE PRESSURE MONITOR MODULE FAILURE - TPM
- Symptom: TPM DIAGNOSTIC - BCM
- Symptom: TPM MODULE INITIALIZED - BCM
- Symptom: *LO TIRE LCD MESSAGE FLASHING
- Vehicle Theft/Security
- Symptom: VTSS INDICATOR OUTPUT OPEN
- Symptom: VTSS INDICATOR OUTPUT SHORT
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *DECKLID DOES NOT TRIP VTSS
- Symptom: *DRIVER DOOR DOES NOT TRIP VTSS
- Symptom: *EXTERIOR LAMPS FAIL TO FLASH WHEN ALARM IS TRIPPED
- Symptom: *HOOD DOES NOT TRIP VTSS
- Symptom: *HORN FAILS TO SOUND WHEN ALARM IS TRIPPED
- Symptom: *PASSENGER DOOR DOES NOT TRIP VTSS
- Symptom: *VTSS LAMP ON STEADY DURING ARMING
- Symptom: *VTSS WILL NOT ARM
- Verification Tests
- Airbag
- Component Locations
- Connector PINOUTS
- A/C-Heater Control C1 - Black 10 Way
- A/C-Heater Control C2 - Black 16 Way
- Airbag Control Module C1 (Orc) - Yellow 32 Way
- Airbag Control Module C2 (Orc) - Yellow 32 Way
- Airbag On/Off Switch-Passenger - Yellow 6 Way
- Airbag Squib 1-Driver - Yellow/Black 2 Way
- Airbag Squib 2-Driver - Yellow/Gray 2 Way
- Airbag Squib-Passenger - Yellow 4 Way
- Ajar Switch-DECKLID - Black 3 Way
- Ajar Switch-Driver Door - Black 4 Way
- Ajar Switch-Hood - Natural 3 Way
- Ajar Switch-Passenger Door - Black 4 Way
- Blend Door Actuator - Gray 2 Way
- Blower Motor - Orange 2 Way
- Blower Motor Resistor Block - Black 4 Way
- Body Control Module C1 - Black 6 Way
- Body Control Module C2 - Black/Green 34 Way
- Body Control Module C3 - Black/White 34 Way
- Body Control Module C4 - Black/Gray 34 Way
- Brake Fluid Level Switch - Black 2 Way
- C200 - Black (Body Side)
- C200 - Black (Instrument Panel Side)
- C201 - Yellow (Body Side)
- C201 - Yellow (Instrument Panel Side)
- C202 - Natural (Driver Door Side)
- C202 - Natural (Instrument Panel Side)
- C203 - Natural (Instrument Panel Side)
- C203 - Natural (Passenger Door Side)
- C204 - LT. Gray (HVAC Jumper Side)
- C204 - LT. Gray (Instrument Panel Side)
- C206 - Red (Console Jumper Side)
- C206 - Red (Instrument Panel Side)
- C207 - Green (Instrument Panel Side)
- C207 - Natural (Passenger Door Side)
- C208 - Green (Instrument Panel Side)
- C208 - Natural (Driver Door Side)
- C303 - Black (Body Side)
- C303 - Black (DECKLID Jumper Side)
- CLOCKSPRING - White 8 Way
- Controller Antilock Brake - Black 24 Way
- Cylinder Unlock Switch-Driver - Black 2 Way
- Data Link Connector - Black 16 Way
- DECKLID Release Motor - Black 2 Way
- Door Latch Motor-Driver - 2 Way
- Door Latch Motor-Passenger - 2 Way
- Door Lock Switch-Driver - Black 3 Way
- Door Lock Switch-Passenger - Black 3 Way
- Exterior Door Handle Switch-Driver - Black 2 Way
- Exterior Door Handle Switch-Passenger - Black 2 Way
- Fog Lamp-Left - Black 2 Way
- Gauge Cluster C1 - White 3 Way
- Gauge Cluster C2 - Black 20 Way
- Hid Lamp-Left - Gray 2 Way
- High Beam Headlamp-Left - Black 2 Way
- Horn Switch - Black 1 Way
- Horn-High Note - Black 2 Way
- Horn-Low Note - Black 2 Way
- Ignition Switch - Black 5 Way
- Instrument Cluster C1 - Black 16 Way
- Instrument Cluster C2 - Black 20 Way
- Interior Door Handle Switch-Driver - Black 2 Way
- Interior Door Handle Switch-Passenger - Black 2 Way
- Marker Lamp-Left Front - DK. Gray 2 Way
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way
- Multi-Function Switch - Gray 20 Way
- Power Distribution Center
- Power Window Motor-Driver - Black 6 Way
- Power Window Motor-Passenger - Black 6 Way
- Power Window Switch-Driver - Gray 3 Way
- Power Window Switch-Passenger - Gray 3 Way
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Radio - Gray 22 Way
- RECIRCULATION Door Actuator - Gray 2 Way
- Remote Keyless Entry Module - Black 6 Way
- Seat Belt Switch-Driver - White 2 Way
- Seat Belt Switch-Passenger - White 2 Way
- Seat Belt TENSIONER-Driver - Yellow 2 Way
- Seat Belt TENSIONER-Passenger - Yellow 2 Way
- Speaker-Left Door - Black 2 Way
- Speaker-Left Instrument Panel - White 2 Way
- Speaker-Left Rear - White 3 Way
- Speaker-Rear Woofer - Gray 4 Way
- Speaker-Right Door - Black 2 Way
- Speaker-Right Instrument Panel - White 2 Way
- Speaker-Right Rear - White 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Window Down Relay-Passenger - Black 5 Way
- Window Up Relay-Passenger - Black 5 Way
- Schematic Diagrams
- Airbag System
- Audio System
- Chime System
- Communication
- Door Ajar System
- Electrically Heated Systems
- Exterior Lighting
- Heating & A/C System
- Ignition, Power, Accessory
- Instrument Cluster/Gauge Cluster
- Interior Lighting
- Power Door Locks/RKE
- Power Window System
- Tire Pressure Monitor Module (TPM)
- Vehicle Theft Security System
- Body Diagnostic Procedures
- Communication Devices
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Body Control Module
- Chime Warning System
- Communication
- Door Ajar System
- Exterior Lighting System
- Relays Controlled By The BCM
- Heating & A/C System
- Instrument Cluster / Gauge Cluster
- Interior Lighting
- Tire Pressure Monitoring System (TPMS)
- Power Door Entry System
- Power Windows
- Electrically Heated Systems
- Vehicle Theft Security System
- Using The DRBIII®
- DRBIII® Error Messages
- DRBIII® Does Not Power Up (Blank Screen)
- Display Is Not Visible
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; ACCELEROMETER 2; INTERNAL 1; OUTPUT DRIVER 1; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: DRIVER SQUIB 2 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 2 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 2 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 2 SHORT TO GROUND
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH OPEN
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO BATTERY
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO GROUND
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO BATTERY
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: PASSENGER SQUIB 2 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 2 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 2 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 2 SHORT TO GROUND
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom List: CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH BCM
- Chime
- Communication
- Symptom: ACM MESSAGES NOT RECEIVED
- Symptom: AUDIO MESSAGES NOT RECEIVED
- Symptom: COUNTRY CODE NOT PROGRAMMED
- Symptom: INTERNAL BCM FAILURE
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom List: PCI BUS SHORTED TO BATTERY; PCI BUS SHORTED TO GROUND
- Symptom: PCI INTERNAL FAULT
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM BODY CONTROL MODULE
- Symptom: *NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE
- Symptom: *NO RESPONSE FROM HVAC
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM PCM (PCI BUS)
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY)
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM TIRE PRESSURE MONITOR MODULE
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Door Ajar
- Symptom: *DECKLID AJAR CIRCUIT OPEN
- Symptom: *DECKLID AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *DRIVER DOOR AJAR CIRCUIT OPEN
- Symptom: *DRIVER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *HOOD AJAR CIRCUIT OPEN
- Symptom: *HOOD AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *PASSENGER DOOR AJAR CIRCUIT OPEN
- Symptom: *PASSENGER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Electrically Heated Systems
- Exterior Lighting
- Symptom: LEFT FOG LAMP OUTPUT OPEN
- Symptom: LEFT FOG LAMP OUTPUT SHORTED
- Symptom: LEFT HIGH BEAM OUTPUT OPEN
- Symptom: LEFT HIGH BEAM OUTPUT SHORT
- Symptom: LOW BEAM RELAY COIL OUTPUT OPEN/SHORT TO GROUND
- Symptom: LOW BEAM RELAY COIL SHORT TO VOLTAGE
- Symptom: PARK LAMP OUTPUT SHORT
- Symptom: RIGHT FOG LAMP OUTPUT OPEN
- Symptom: RIGHT FOG LAMP OUTPUT SHORTED
- Symptom: RIGHT HIGH BEAM OUTPUT OPEN
- Symptom: RIGHT HIGH BEAM OUTPUT SHORT
- Heating & A/C
- Symptom List: A/C SWITCH FAULT (ACTIVE); CHECKSUM FAILURE (ACTIVE); DEFOG SWITCH FAULT (ACTIVE)
- Symptom List: A/C SWITCH FAULT (STORED); BACKLIGHT DIMMING RX FAILURE (STORED); BLEND OVERCURRENT (STORED); CHECKSUM FAILURE (STORED); DEFOG SWITCH FAULT (STORED); LOOPBACK TEST FAILURE (STORED); MODE 1 OVERCURRENT (STORED); MODE 2 OVERCURRENT (STORED); RECIRC OVERCURRENT (STORED); REFRIGERANT PRESS RX FAILURE (STORED); TX FAILURE (STORED); VIN RX FAILURE (STORED)
- Notes
- When Monitored and Set Condition:
- A/C Switch Fault (Stored)
- Backlight Dimming RX Failure (Stored)
- Blend OVERCURRENT (Stored)
- Checksum Failure (Stored)
- Defog Switch Fault (Stored)
- LOOPBACK Test Failure (Stored)
- Mode 1 OVERCURRENT (Stored)
- Mode 2 OVERCURRENT (Stored)
- RECIRC OVERCURRENT (Stored)
- Refrigerant Press RX Failure (Stored)
- TX Failure (Stored)
- VIN RX Failure (Stored)
- Possible Causes
- Diagnostic Procedure
- Symptom List: ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE; BLEND CIRCUIT SHORTED TO GROUND; BLEND CIRCUIT SHORTED TO IGN OR BATT; COMMON DRIVER SHORTED TO GROUND; COMMON DRIVER SHORTED TO IGN OR BATT; MODE 1 CIRCUIT SHORTED TO GROUND; MODE 1 CIRCUIT SHORTED TO IGN OR BATT; MODE 2 CIRCUIT SHORTED TO GROUND; MODE 2 CIRCUIT SHORTED TO IGN OR BATT; RECIRC CIRCUIT SHORTED TO GROUND; RECIRC CIRCUIT SHORTED TO IGN OR BATT; SHORT TOO COMPLEX
- Notes
- When Monitored and Set Condition:
- Act CKT Test Passed, OVERCURRENT DTCS Active
- Blend Circuit Shorted To Ground
- Blend Circuit Shorted To IGN Or Batt
- Common Driver Shorted To Ground
- Common Driver Shorted To IGN Or Batt
- Mode 1 Circuit Shorted To Ground
- Mode 1 Circuit Shorted To IGN Or Batt
- Mode 2 Circuit Shorted To Ground
- Mode 2 Circuit Shorted To IGN Or Batt
- RECIRC Circuit Shorted To Ground
- RECIRC Circuit Shorted To IGN Or Batt
- Short Too Complex
- Possible Causes
- Diagnostic Procedure
- Symptom: BACKLIGHT DIMMING RX FAILURE (ACTIVE)
- Symptom List: BLEND CALIBRATION FAULT; MODE 1 CALIBRATION FAULT; MODE 2 CALIBRATION FAULT; RECIRCULATION CALIBRATION FAULT
- Symptom List: BLEND OVERCURRENT (ACTIVE); MODE 1 OVERCURRENT (ACTIVE); MODE 2 OVERCURRENT (ACTIVE); RECIRC OVERCURRENT (ACTIVE)
- Symptom: DEFOG RELAY CONTROL CKT SHORTED TO BATT
- Symptom: LOOPBACK TEST FAILURE (ACTIVE)
- Symptom List: REFRIGERANT PRESSURE RX FAILURE (ACTIVE); VIN RX FAILURE (ACTIVE)
- Symptom: TX FAILURE (ACTIVE)
- Symptom: *A/C - HEATER CONTROL ILLUMINATION INOPERATIVE
- Symptom: *BLEND/MODE/RECIRC DOOR OPERATION IMPROPER
- Symptom: *BLOWER MOTOR INOPERATIVE
- Symptom: *BLOWER MOTOR SPEEDS INCORRECT
- Symptom: *EBL STATUS INDICATOR FLASHING
- Symptom: *HVAC SYSTEM TEST
- Ignition, Power, Accessory
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT OPEN
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT SHORT TO GROUND
- Symptom: BCM - IGNITION MUX SWITCH INPUT MISMATCH
- Symptom: BCM - IGNITION MUX SWITCH INPUT OPEN
- Symptom: BCM - IGNITION MUX SWITCH INPUT SHORT
- Symptom: BCM - IGNITION RUN 1 SHORT
- Symptom: BCM - IGNITION RUN 2 SHORT
- Symptom: BCM - IOD OUTPUT CIRCUIT SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT OPEN / SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT SHORT TO VOLTAGE
- Symptom: BCM - RUN/START HARDWIRE INPUT MISMATCH
- Symptom: HORN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: HORN RELAY COIL SHORT TO BATTERY
- Symptom: HORN SWITCH STUCK
- Symptom: *HORNS INOPERATIVE
- Instrument Cluster
- Symptom List: ABS LAMP CIRCUIT OPEN; ABS LAMP CIRCUIT SHORTED; AIRBAG LAMP CIRCUIT OPEN; AIRBAG LAMP CIRCUIT SHORTED
- Symptom: ABS MESSAGES NOT RECEIVED
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT OPEN / SHORTED TO VOLTAGE
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT SHORT TO GROUND
- Symptom: BCM - PWM DIMMING OUTPUT SHORT
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: ORC MESSAGES NOT RECEIVED
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *GAUGE CLUSTER DIAGNOSTIC TEST
- Symptom: *INSTRUMENT CLUSTER DIAGNOSTIC TEST
- Interior Lighting
- Power Door Locks/RKE
- Symptom: DECKLID RELEASE OUTPUT OPEN
- Symptom: DECKLID RELEASE OUTPUT SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH OPEN OR SHORT TO VOLTAGE
- Symptom: DRIVER CYLINDER UNLOCK SWITCH SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH STUCK
- Symptom: DRIVER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: DRIVER DOOR LOCK SWITCH STUCK
- Symptom: DRIVER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: DRIVER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: DRIVER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER DOOR LOCK SWITCH STUCK
- Symptom: PASSENGER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER/DRIVER DOOR UNLATCH RETURN SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT OPEN/SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT SHORT TO BATTERY
- Symptom: *ALL DOOR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR UNLATCH INOPERATIVE
- Symptom: *PASSENGER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *PASSENGER DOOR UNLATCH INOPERATIVE
- Symptom: *REMOTE KEYLESS ENTRY PROBLEM
- Power Windows
- Symptom: DRIVER WINDOW DOWN OUTPUT SHORT TO GROUND
- Symptom: DRIVER WINDOW HALL EFFECT FAILURE
- Symptom: DRIVER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: DRIVER WINDOW SWITCH SHORT TO GROUND
- Symptom: DRIVER WINDOW SWITCH STUCK DOWN
- Symptom: DRIVER WINDOW SWITCH STUCK UP
- Symptom: DRIVER WINDOW UP OUTPUT SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL SHORT TO BATTERY
- Symptom: PASSENGER WINDOW HALL EFFECT FAILURE
- Symptom: PASSENGER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: PASSENGER WINDOW SWITCH SHORT TO GROUND
- Symptom: PASSENGER WINDOW SWITCH STUCK DOWN
- Symptom: PASSENGER WINDOW SWITCH STUCK UP
- Symptom: PASSENGER WINDOW UP SHORT TO GROUND
- Symptom: *DRIVER WINDOW INOPERATIVE
- Symptom: *PASSENGER WINDOW INOPERATIVE
- Tire Pressure Monitoring
- Symptom: CRITICAL TIRE PRESSURE - BCM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM
- Symptom: TIRE PRESSURE LOW - BCM
- Symptom: TIRE PRESSURE MONITOR MODULE FAILURE - TPM
- Symptom: TPM DIAGNOSTIC - BCM
- Symptom: TPM MODULE INITIALIZED - BCM
- Symptom: *LO TIRE LCD MESSAGE FLASHING
- Vehicle Theft/Security
- Symptom: VTSS INDICATOR OUTPUT OPEN
- Symptom: VTSS INDICATOR OUTPUT SHORT
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *DECKLID DOES NOT TRIP VTSS
- Symptom: *DRIVER DOOR DOES NOT TRIP VTSS
- Symptom: *EXTERIOR LAMPS FAIL TO FLASH WHEN ALARM IS TRIPPED
- Symptom: *HOOD DOES NOT TRIP VTSS
- Symptom: *HORN FAILS TO SOUND WHEN ALARM IS TRIPPED
- Symptom: *PASSENGER DOOR DOES NOT TRIP VTSS
- Symptom: *VTSS LAMP ON STEADY DURING ARMING
- Symptom: *VTSS WILL NOT ARM
- Verification Tests
- Airbag
- Component Locations
- Connector PINOUTS
- A/C-Heater Control C1 - Black 10 Way
- A/C-Heater Control C2 - Black 16 Way
- Airbag Control Module C1 (Orc) - Yellow 32 Way
- Airbag Control Module C2 (Orc) - Yellow 32 Way
- Airbag On/Off Switch-Passenger - Yellow 6 Way
- Airbag Squib 1-Driver - Yellow/Black 2 Way
- Airbag Squib 2-Driver - Yellow/Gray 2 Way
- Airbag Squib-Passenger - Yellow 4 Way
- Ajar Switch-DECKLID - Black 3 Way
- Ajar Switch-Driver Door - Black 4 Way
- Ajar Switch-Hood - Natural 3 Way
- Ajar Switch-Passenger Door - Black 4 Way
- Blend Door Actuator - Gray 2 Way
- Blower Motor - Orange 2 Way
- Blower Motor Resistor Block - Black 4 Way
- Body Control Module C1 - Black 6 Way
- Body Control Module C2 - Black/Green 34 Way
- Body Control Module C3 - Black/White 34 Way
- Body Control Module C4 - Black/Gray 34 Way
- Brake Fluid Level Switch - Black 2 Way
- C200 - Black (Body Side)
- C200 - Black (Instrument Panel Side)
- C201 - Yellow (Body Side)
- C201 - Yellow (Instrument Panel Side)
- C202 - Natural (Driver Door Side)
- C202 - Natural (Instrument Panel Side)
- C203 - Natural (Instrument Panel Side)
- C203 - Natural (Passenger Door Side)
- C204 - LT. Gray (HVAC Jumper Side)
- C204 - LT. Gray (Instrument Panel Side)
- C206 - Red (Console Jumper Side)
- C206 - Red (Instrument Panel Side)
- C207 - Green (Instrument Panel Side)
- C207 - Natural (Passenger Door Side)
- C208 - Green (Instrument Panel Side)
- C208 - Natural (Driver Door Side)
- C303 - Black (Body Side)
- C303 - Black (DECKLID Jumper Side)
- CLOCKSPRING - White 8 Way
- Controller Antilock Brake - Black 24 Way
- Cylinder Unlock Switch-Driver - Black 2 Way
- Data Link Connector - Black 16 Way
- DECKLID Release Motor - Black 2 Way
- Door Latch Motor-Driver - 2 Way
- Door Latch Motor-Passenger - 2 Way
- Door Lock Switch-Driver - Black 3 Way
- Door Lock Switch-Passenger - Black 3 Way
- Exterior Door Handle Switch-Driver - Black 2 Way
- Exterior Door Handle Switch-Passenger - Black 2 Way
- Fog Lamp-Left - Black 2 Way
- Gauge Cluster C1 - White 3 Way
- Gauge Cluster C2 - Black 20 Way
- Hid Lamp-Left - Gray 2 Way
- High Beam Headlamp-Left - Black 2 Way
- Horn Switch - Black 1 Way
- Horn-High Note - Black 2 Way
- Horn-Low Note - Black 2 Way
- Ignition Switch - Black 5 Way
- Instrument Cluster C1 - Black 16 Way
- Instrument Cluster C2 - Black 20 Way
- Interior Door Handle Switch-Driver - Black 2 Way
- Interior Door Handle Switch-Passenger - Black 2 Way
- Marker Lamp-Left Front - DK. Gray 2 Way
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way
- Multi-Function Switch - Gray 20 Way
- Power Distribution Center
- Power Window Motor-Driver - Black 6 Way
- Power Window Motor-Passenger - Black 6 Way
- Power Window Switch-Driver - Gray 3 Way
- Power Window Switch-Passenger - Gray 3 Way
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Radio - Gray 22 Way
- RECIRCULATION Door Actuator - Gray 2 Way
- Remote Keyless Entry Module - Black 6 Way
- Seat Belt Switch-Driver - White 2 Way
- Seat Belt Switch-Passenger - White 2 Way
- Seat Belt TENSIONER-Driver - Yellow 2 Way
- Seat Belt TENSIONER-Passenger - Yellow 2 Way
- Speaker-Left Door - Black 2 Way
- Speaker-Left Instrument Panel - White 2 Way
- Speaker-Left Rear - White 3 Way
- Speaker-Rear Woofer - Gray 4 Way
- Speaker-Right Door - Black 2 Way
- Speaker-Right Instrument Panel - White 2 Way
- Speaker-Right Rear - White 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Window Down Relay-Passenger - Black 5 Way
- Window Up Relay-Passenger - Black 5 Way
- Schematic Diagrams
- Airbag System
- Audio System
- Chime System
- Communication
- Door Ajar System
- Electrically Heated Systems
- Exterior Lighting
- Heating & A/C System
- Ignition, Power, Accessory
- Instrument Cluster/Gauge Cluster
- Interior Lighting
- Power Door Locks/RKE
- Power Window System
- Tire Pressure Monitor Module (TPM)
- Vehicle Theft Security System
- Electronic Control Modules
- Body Diagnostic Procedures
- Entertainment Systems
- Audio System (Service Information)
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Body Control Module
- Chime Warning System
- Communication
- Door Ajar System
- Exterior Lighting System
- Relays Controlled By The BCM
- Heating & A/C System
- Instrument Cluster / Gauge Cluster
- Interior Lighting
- Tire Pressure Monitoring System (TPMS)
- Power Door Entry System
- Power Windows
- Electrically Heated Systems
- Vehicle Theft Security System
- Using The DRBIII®
- DRBIII® Error Messages
- DRBIII® Does Not Power Up (Blank Screen)
- Display Is Not Visible
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; ACCELEROMETER 2; INTERNAL 1; OUTPUT DRIVER 1; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: DRIVER SQUIB 2 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 2 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 2 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 2 SHORT TO GROUND
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH OPEN
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO BATTERY
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO GROUND
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO BATTERY
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: PASSENGER SQUIB 2 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 2 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 2 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 2 SHORT TO GROUND
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom List: CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH BCM
- Chime
- Communication
- Symptom: ACM MESSAGES NOT RECEIVED
- Symptom: AUDIO MESSAGES NOT RECEIVED
- Symptom: COUNTRY CODE NOT PROGRAMMED
- Symptom: INTERNAL BCM FAILURE
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom List: PCI BUS SHORTED TO BATTERY; PCI BUS SHORTED TO GROUND
- Symptom: PCI INTERNAL FAULT
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM BODY CONTROL MODULE
- Symptom: *NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE
- Symptom: *NO RESPONSE FROM HVAC
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM PCM (PCI BUS)
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY)
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM TIRE PRESSURE MONITOR MODULE
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Door Ajar
- Symptom: *DECKLID AJAR CIRCUIT OPEN
- Symptom: *DECKLID AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *DRIVER DOOR AJAR CIRCUIT OPEN
- Symptom: *DRIVER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *HOOD AJAR CIRCUIT OPEN
- Symptom: *HOOD AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *PASSENGER DOOR AJAR CIRCUIT OPEN
- Symptom: *PASSENGER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Electrically Heated Systems
- Exterior Lighting
- Symptom: LEFT FOG LAMP OUTPUT OPEN
- Symptom: LEFT FOG LAMP OUTPUT SHORTED
- Symptom: LEFT HIGH BEAM OUTPUT OPEN
- Symptom: LEFT HIGH BEAM OUTPUT SHORT
- Symptom: LOW BEAM RELAY COIL OUTPUT OPEN/SHORT TO GROUND
- Symptom: LOW BEAM RELAY COIL SHORT TO VOLTAGE
- Symptom: PARK LAMP OUTPUT SHORT
- Symptom: RIGHT FOG LAMP OUTPUT OPEN
- Symptom: RIGHT FOG LAMP OUTPUT SHORTED
- Symptom: RIGHT HIGH BEAM OUTPUT OPEN
- Symptom: RIGHT HIGH BEAM OUTPUT SHORT
- Heating & A/C
- Symptom List: A/C SWITCH FAULT (ACTIVE); CHECKSUM FAILURE (ACTIVE); DEFOG SWITCH FAULT (ACTIVE)
- Symptom List: A/C SWITCH FAULT (STORED); BACKLIGHT DIMMING RX FAILURE (STORED); BLEND OVERCURRENT (STORED); CHECKSUM FAILURE (STORED); DEFOG SWITCH FAULT (STORED); LOOPBACK TEST FAILURE (STORED); MODE 1 OVERCURRENT (STORED); MODE 2 OVERCURRENT (STORED); RECIRC OVERCURRENT (STORED); REFRIGERANT PRESS RX FAILURE (STORED); TX FAILURE (STORED); VIN RX FAILURE (STORED)
- Notes
- When Monitored and Set Condition:
- A/C Switch Fault (Stored)
- Backlight Dimming RX Failure (Stored)
- Blend OVERCURRENT (Stored)
- Checksum Failure (Stored)
- Defog Switch Fault (Stored)
- LOOPBACK Test Failure (Stored)
- Mode 1 OVERCURRENT (Stored)
- Mode 2 OVERCURRENT (Stored)
- RECIRC OVERCURRENT (Stored)
- Refrigerant Press RX Failure (Stored)
- TX Failure (Stored)
- VIN RX Failure (Stored)
- Possible Causes
- Diagnostic Procedure
- Symptom List: ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE; BLEND CIRCUIT SHORTED TO GROUND; BLEND CIRCUIT SHORTED TO IGN OR BATT; COMMON DRIVER SHORTED TO GROUND; COMMON DRIVER SHORTED TO IGN OR BATT; MODE 1 CIRCUIT SHORTED TO GROUND; MODE 1 CIRCUIT SHORTED TO IGN OR BATT; MODE 2 CIRCUIT SHORTED TO GROUND; MODE 2 CIRCUIT SHORTED TO IGN OR BATT; RECIRC CIRCUIT SHORTED TO GROUND; RECIRC CIRCUIT SHORTED TO IGN OR BATT; SHORT TOO COMPLEX
- Notes
- When Monitored and Set Condition:
- Act CKT Test Passed, OVERCURRENT DTCS Active
- Blend Circuit Shorted To Ground
- Blend Circuit Shorted To IGN Or Batt
- Common Driver Shorted To Ground
- Common Driver Shorted To IGN Or Batt
- Mode 1 Circuit Shorted To Ground
- Mode 1 Circuit Shorted To IGN Or Batt
- Mode 2 Circuit Shorted To Ground
- Mode 2 Circuit Shorted To IGN Or Batt
- RECIRC Circuit Shorted To Ground
- RECIRC Circuit Shorted To IGN Or Batt
- Short Too Complex
- Possible Causes
- Diagnostic Procedure
- Symptom: BACKLIGHT DIMMING RX FAILURE (ACTIVE)
- Symptom List: BLEND CALIBRATION FAULT; MODE 1 CALIBRATION FAULT; MODE 2 CALIBRATION FAULT; RECIRCULATION CALIBRATION FAULT
- Symptom List: BLEND OVERCURRENT (ACTIVE); MODE 1 OVERCURRENT (ACTIVE); MODE 2 OVERCURRENT (ACTIVE); RECIRC OVERCURRENT (ACTIVE)
- Symptom: DEFOG RELAY CONTROL CKT SHORTED TO BATT
- Symptom: LOOPBACK TEST FAILURE (ACTIVE)
- Symptom List: REFRIGERANT PRESSURE RX FAILURE (ACTIVE); VIN RX FAILURE (ACTIVE)
- Symptom: TX FAILURE (ACTIVE)
- Symptom: *A/C - HEATER CONTROL ILLUMINATION INOPERATIVE
- Symptom: *BLEND/MODE/RECIRC DOOR OPERATION IMPROPER
- Symptom: *BLOWER MOTOR INOPERATIVE
- Symptom: *BLOWER MOTOR SPEEDS INCORRECT
- Symptom: *EBL STATUS INDICATOR FLASHING
- Symptom: *HVAC SYSTEM TEST
- Ignition, Power, Accessory
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT OPEN
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT SHORT TO GROUND
- Symptom: BCM - IGNITION MUX SWITCH INPUT MISMATCH
- Symptom: BCM - IGNITION MUX SWITCH INPUT OPEN
- Symptom: BCM - IGNITION MUX SWITCH INPUT SHORT
- Symptom: BCM - IGNITION RUN 1 SHORT
- Symptom: BCM - IGNITION RUN 2 SHORT
- Symptom: BCM - IOD OUTPUT CIRCUIT SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT OPEN / SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT SHORT TO VOLTAGE
- Symptom: BCM - RUN/START HARDWIRE INPUT MISMATCH
- Symptom: HORN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: HORN RELAY COIL SHORT TO BATTERY
- Symptom: HORN SWITCH STUCK
- Symptom: *HORNS INOPERATIVE
- Instrument Cluster
- Symptom List: ABS LAMP CIRCUIT OPEN; ABS LAMP CIRCUIT SHORTED; AIRBAG LAMP CIRCUIT OPEN; AIRBAG LAMP CIRCUIT SHORTED
- Symptom: ABS MESSAGES NOT RECEIVED
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT OPEN / SHORTED TO VOLTAGE
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT SHORT TO GROUND
- Symptom: BCM - PWM DIMMING OUTPUT SHORT
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: ORC MESSAGES NOT RECEIVED
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *GAUGE CLUSTER DIAGNOSTIC TEST
- Symptom: *INSTRUMENT CLUSTER DIAGNOSTIC TEST
- Interior Lighting
- Power Door Locks/RKE
- Symptom: DECKLID RELEASE OUTPUT OPEN
- Symptom: DECKLID RELEASE OUTPUT SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH OPEN OR SHORT TO VOLTAGE
- Symptom: DRIVER CYLINDER UNLOCK SWITCH SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH STUCK
- Symptom: DRIVER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: DRIVER DOOR LOCK SWITCH STUCK
- Symptom: DRIVER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: DRIVER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: DRIVER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER DOOR LOCK SWITCH STUCK
- Symptom: PASSENGER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER/DRIVER DOOR UNLATCH RETURN SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT OPEN/SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT SHORT TO BATTERY
- Symptom: *ALL DOOR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR UNLATCH INOPERATIVE
- Symptom: *PASSENGER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *PASSENGER DOOR UNLATCH INOPERATIVE
- Symptom: *REMOTE KEYLESS ENTRY PROBLEM
- Power Windows
- Symptom: DRIVER WINDOW DOWN OUTPUT SHORT TO GROUND
- Symptom: DRIVER WINDOW HALL EFFECT FAILURE
- Symptom: DRIVER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: DRIVER WINDOW SWITCH SHORT TO GROUND
- Symptom: DRIVER WINDOW SWITCH STUCK DOWN
- Symptom: DRIVER WINDOW SWITCH STUCK UP
- Symptom: DRIVER WINDOW UP OUTPUT SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL SHORT TO BATTERY
- Symptom: PASSENGER WINDOW HALL EFFECT FAILURE
- Symptom: PASSENGER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: PASSENGER WINDOW SWITCH SHORT TO GROUND
- Symptom: PASSENGER WINDOW SWITCH STUCK DOWN
- Symptom: PASSENGER WINDOW SWITCH STUCK UP
- Symptom: PASSENGER WINDOW UP SHORT TO GROUND
- Symptom: *DRIVER WINDOW INOPERATIVE
- Symptom: *PASSENGER WINDOW INOPERATIVE
- Tire Pressure Monitoring
- Symptom: CRITICAL TIRE PRESSURE - BCM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM
- Symptom: TIRE PRESSURE LOW - BCM
- Symptom: TIRE PRESSURE MONITOR MODULE FAILURE - TPM
- Symptom: TPM DIAGNOSTIC - BCM
- Symptom: TPM MODULE INITIALIZED - BCM
- Symptom: *LO TIRE LCD MESSAGE FLASHING
- Vehicle Theft/Security
- Symptom: VTSS INDICATOR OUTPUT OPEN
- Symptom: VTSS INDICATOR OUTPUT SHORT
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *DECKLID DOES NOT TRIP VTSS
- Symptom: *DRIVER DOOR DOES NOT TRIP VTSS
- Symptom: *EXTERIOR LAMPS FAIL TO FLASH WHEN ALARM IS TRIPPED
- Symptom: *HOOD DOES NOT TRIP VTSS
- Symptom: *HORN FAILS TO SOUND WHEN ALARM IS TRIPPED
- Symptom: *PASSENGER DOOR DOES NOT TRIP VTSS
- Symptom: *VTSS LAMP ON STEADY DURING ARMING
- Symptom: *VTSS WILL NOT ARM
- Verification Tests
- Airbag
- Component Locations
- Connector PINOUTS
- A/C-Heater Control C1 - Black 10 Way
- A/C-Heater Control C2 - Black 16 Way
- Airbag Control Module C1 (Orc) - Yellow 32 Way
- Airbag Control Module C2 (Orc) - Yellow 32 Way
- Airbag On/Off Switch-Passenger - Yellow 6 Way
- Airbag Squib 1-Driver - Yellow/Black 2 Way
- Airbag Squib 2-Driver - Yellow/Gray 2 Way
- Airbag Squib-Passenger - Yellow 4 Way
- Ajar Switch-DECKLID - Black 3 Way
- Ajar Switch-Driver Door - Black 4 Way
- Ajar Switch-Hood - Natural 3 Way
- Ajar Switch-Passenger Door - Black 4 Way
- Blend Door Actuator - Gray 2 Way
- Blower Motor - Orange 2 Way
- Blower Motor Resistor Block - Black 4 Way
- Body Control Module C1 - Black 6 Way
- Body Control Module C2 - Black/Green 34 Way
- Body Control Module C3 - Black/White 34 Way
- Body Control Module C4 - Black/Gray 34 Way
- Brake Fluid Level Switch - Black 2 Way
- C200 - Black (Body Side)
- C200 - Black (Instrument Panel Side)
- C201 - Yellow (Body Side)
- C201 - Yellow (Instrument Panel Side)
- C202 - Natural (Driver Door Side)
- C202 - Natural (Instrument Panel Side)
- C203 - Natural (Instrument Panel Side)
- C203 - Natural (Passenger Door Side)
- C204 - LT. Gray (HVAC Jumper Side)
- C204 - LT. Gray (Instrument Panel Side)
- C206 - Red (Console Jumper Side)
- C206 - Red (Instrument Panel Side)
- C207 - Green (Instrument Panel Side)
- C207 - Natural (Passenger Door Side)
- C208 - Green (Instrument Panel Side)
- C208 - Natural (Driver Door Side)
- C303 - Black (Body Side)
- C303 - Black (DECKLID Jumper Side)
- CLOCKSPRING - White 8 Way
- Controller Antilock Brake - Black 24 Way
- Cylinder Unlock Switch-Driver - Black 2 Way
- Data Link Connector - Black 16 Way
- DECKLID Release Motor - Black 2 Way
- Door Latch Motor-Driver - 2 Way
- Door Latch Motor-Passenger - 2 Way
- Door Lock Switch-Driver - Black 3 Way
- Door Lock Switch-Passenger - Black 3 Way
- Exterior Door Handle Switch-Driver - Black 2 Way
- Exterior Door Handle Switch-Passenger - Black 2 Way
- Fog Lamp-Left - Black 2 Way
- Gauge Cluster C1 - White 3 Way
- Gauge Cluster C2 - Black 20 Way
- Hid Lamp-Left - Gray 2 Way
- High Beam Headlamp-Left - Black 2 Way
- Horn Switch - Black 1 Way
- Horn-High Note - Black 2 Way
- Horn-Low Note - Black 2 Way
- Ignition Switch - Black 5 Way
- Instrument Cluster C1 - Black 16 Way
- Instrument Cluster C2 - Black 20 Way
- Interior Door Handle Switch-Driver - Black 2 Way
- Interior Door Handle Switch-Passenger - Black 2 Way
- Marker Lamp-Left Front - DK. Gray 2 Way
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way
- Multi-Function Switch - Gray 20 Way
- Power Distribution Center
- Power Window Motor-Driver - Black 6 Way
- Power Window Motor-Passenger - Black 6 Way
- Power Window Switch-Driver - Gray 3 Way
- Power Window Switch-Passenger - Gray 3 Way
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Radio - Gray 22 Way
- RECIRCULATION Door Actuator - Gray 2 Way
- Remote Keyless Entry Module - Black 6 Way
- Seat Belt Switch-Driver - White 2 Way
- Seat Belt Switch-Passenger - White 2 Way
- Seat Belt TENSIONER-Driver - Yellow 2 Way
- Seat Belt TENSIONER-Passenger - Yellow 2 Way
- Speaker-Left Door - Black 2 Way
- Speaker-Left Instrument Panel - White 2 Way
- Speaker-Left Rear - White 3 Way
- Speaker-Rear Woofer - Gray 4 Way
- Speaker-Right Door - Black 2 Way
- Speaker-Right Instrument Panel - White 2 Way
- Speaker-Right Rear - White 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Window Down Relay-Passenger - Black 5 Way
- Window Up Relay-Passenger - Black 5 Way
- Schematic Diagrams
- Airbag System
- Audio System
- Chime System
- Communication
- Door Ajar System
- Electrically Heated Systems
- Exterior Lighting
- Heating & A/C System
- Ignition, Power, Accessory
- Instrument Cluster/Gauge Cluster
- Interior Lighting
- Power Door Locks/RKE
- Power Window System
- Tire Pressure Monitor Module (TPM)
- Vehicle Theft Security System
- Exterior Lights
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Body Control Module
- Chime Warning System
- Communication
- Door Ajar System
- Exterior Lighting System
- Relays Controlled By The BCM
- Heating & A/C System
- Instrument Cluster / Gauge Cluster
- Interior Lighting
- Tire Pressure Monitoring System (TPMS)
- Power Door Entry System
- Power Windows
- Electrically Heated Systems
- Vehicle Theft Security System
- Using The DRBIII®
- DRBIII® Error Messages
- DRBIII® Does Not Power Up (Blank Screen)
- Display Is Not Visible
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; ACCELEROMETER 2; INTERNAL 1; OUTPUT DRIVER 1; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: DRIVER SQUIB 2 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 2 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 2 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 2 SHORT TO GROUND
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH OPEN
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO BATTERY
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO GROUND
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO BATTERY
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: PASSENGER SQUIB 2 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 2 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 2 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 2 SHORT TO GROUND
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom List: CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH BCM
- Chime
- Communication
- Symptom: ACM MESSAGES NOT RECEIVED
- Symptom: AUDIO MESSAGES NOT RECEIVED
- Symptom: COUNTRY CODE NOT PROGRAMMED
- Symptom: INTERNAL BCM FAILURE
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom List: PCI BUS SHORTED TO BATTERY; PCI BUS SHORTED TO GROUND
- Symptom: PCI INTERNAL FAULT
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM BODY CONTROL MODULE
- Symptom: *NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE
- Symptom: *NO RESPONSE FROM HVAC
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM PCM (PCI BUS)
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY)
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM TIRE PRESSURE MONITOR MODULE
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Door Ajar
- Symptom: *DECKLID AJAR CIRCUIT OPEN
- Symptom: *DECKLID AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *DRIVER DOOR AJAR CIRCUIT OPEN
- Symptom: *DRIVER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *HOOD AJAR CIRCUIT OPEN
- Symptom: *HOOD AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *PASSENGER DOOR AJAR CIRCUIT OPEN
- Symptom: *PASSENGER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Electrically Heated Systems
- Exterior Lighting
- Symptom: LEFT FOG LAMP OUTPUT OPEN
- Symptom: LEFT FOG LAMP OUTPUT SHORTED
- Symptom: LEFT HIGH BEAM OUTPUT OPEN
- Symptom: LEFT HIGH BEAM OUTPUT SHORT
- Symptom: LOW BEAM RELAY COIL OUTPUT OPEN/SHORT TO GROUND
- Symptom: LOW BEAM RELAY COIL SHORT TO VOLTAGE
- Symptom: PARK LAMP OUTPUT SHORT
- Symptom: RIGHT FOG LAMP OUTPUT OPEN
- Symptom: RIGHT FOG LAMP OUTPUT SHORTED
- Symptom: RIGHT HIGH BEAM OUTPUT OPEN
- Symptom: RIGHT HIGH BEAM OUTPUT SHORT
- Heating & A/C
- Symptom List: A/C SWITCH FAULT (ACTIVE); CHECKSUM FAILURE (ACTIVE); DEFOG SWITCH FAULT (ACTIVE)
- Symptom List: A/C SWITCH FAULT (STORED); BACKLIGHT DIMMING RX FAILURE (STORED); BLEND OVERCURRENT (STORED); CHECKSUM FAILURE (STORED); DEFOG SWITCH FAULT (STORED); LOOPBACK TEST FAILURE (STORED); MODE 1 OVERCURRENT (STORED); MODE 2 OVERCURRENT (STORED); RECIRC OVERCURRENT (STORED); REFRIGERANT PRESS RX FAILURE (STORED); TX FAILURE (STORED); VIN RX FAILURE (STORED)
- Notes
- When Monitored and Set Condition:
- A/C Switch Fault (Stored)
- Backlight Dimming RX Failure (Stored)
- Blend OVERCURRENT (Stored)
- Checksum Failure (Stored)
- Defog Switch Fault (Stored)
- LOOPBACK Test Failure (Stored)
- Mode 1 OVERCURRENT (Stored)
- Mode 2 OVERCURRENT (Stored)
- RECIRC OVERCURRENT (Stored)
- Refrigerant Press RX Failure (Stored)
- TX Failure (Stored)
- VIN RX Failure (Stored)
- Possible Causes
- Diagnostic Procedure
- Symptom List: ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE; BLEND CIRCUIT SHORTED TO GROUND; BLEND CIRCUIT SHORTED TO IGN OR BATT; COMMON DRIVER SHORTED TO GROUND; COMMON DRIVER SHORTED TO IGN OR BATT; MODE 1 CIRCUIT SHORTED TO GROUND; MODE 1 CIRCUIT SHORTED TO IGN OR BATT; MODE 2 CIRCUIT SHORTED TO GROUND; MODE 2 CIRCUIT SHORTED TO IGN OR BATT; RECIRC CIRCUIT SHORTED TO GROUND; RECIRC CIRCUIT SHORTED TO IGN OR BATT; SHORT TOO COMPLEX
- Notes
- When Monitored and Set Condition:
- Act CKT Test Passed, OVERCURRENT DTCS Active
- Blend Circuit Shorted To Ground
- Blend Circuit Shorted To IGN Or Batt
- Common Driver Shorted To Ground
- Common Driver Shorted To IGN Or Batt
- Mode 1 Circuit Shorted To Ground
- Mode 1 Circuit Shorted To IGN Or Batt
- Mode 2 Circuit Shorted To Ground
- Mode 2 Circuit Shorted To IGN Or Batt
- RECIRC Circuit Shorted To Ground
- RECIRC Circuit Shorted To IGN Or Batt
- Short Too Complex
- Possible Causes
- Diagnostic Procedure
- Symptom: BACKLIGHT DIMMING RX FAILURE (ACTIVE)
- Symptom List: BLEND CALIBRATION FAULT; MODE 1 CALIBRATION FAULT; MODE 2 CALIBRATION FAULT; RECIRCULATION CALIBRATION FAULT
- Symptom List: BLEND OVERCURRENT (ACTIVE); MODE 1 OVERCURRENT (ACTIVE); MODE 2 OVERCURRENT (ACTIVE); RECIRC OVERCURRENT (ACTIVE)
- Symptom: DEFOG RELAY CONTROL CKT SHORTED TO BATT
- Symptom: LOOPBACK TEST FAILURE (ACTIVE)
- Symptom List: REFRIGERANT PRESSURE RX FAILURE (ACTIVE); VIN RX FAILURE (ACTIVE)
- Symptom: TX FAILURE (ACTIVE)
- Symptom: *A/C - HEATER CONTROL ILLUMINATION INOPERATIVE
- Symptom: *BLEND/MODE/RECIRC DOOR OPERATION IMPROPER
- Symptom: *BLOWER MOTOR INOPERATIVE
- Symptom: *BLOWER MOTOR SPEEDS INCORRECT
- Symptom: *EBL STATUS INDICATOR FLASHING
- Symptom: *HVAC SYSTEM TEST
- Ignition, Power, Accessory
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT OPEN
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT SHORT TO GROUND
- Symptom: BCM - IGNITION MUX SWITCH INPUT MISMATCH
- Symptom: BCM - IGNITION MUX SWITCH INPUT OPEN
- Symptom: BCM - IGNITION MUX SWITCH INPUT SHORT
- Symptom: BCM - IGNITION RUN 1 SHORT
- Symptom: BCM - IGNITION RUN 2 SHORT
- Symptom: BCM - IOD OUTPUT CIRCUIT SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT OPEN / SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT SHORT TO VOLTAGE
- Symptom: BCM - RUN/START HARDWIRE INPUT MISMATCH
- Symptom: HORN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: HORN RELAY COIL SHORT TO BATTERY
- Symptom: HORN SWITCH STUCK
- Symptom: *HORNS INOPERATIVE
- Instrument Cluster
- Symptom List: ABS LAMP CIRCUIT OPEN; ABS LAMP CIRCUIT SHORTED; AIRBAG LAMP CIRCUIT OPEN; AIRBAG LAMP CIRCUIT SHORTED
- Symptom: ABS MESSAGES NOT RECEIVED
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT OPEN / SHORTED TO VOLTAGE
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT SHORT TO GROUND
- Symptom: BCM - PWM DIMMING OUTPUT SHORT
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: ORC MESSAGES NOT RECEIVED
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *GAUGE CLUSTER DIAGNOSTIC TEST
- Symptom: *INSTRUMENT CLUSTER DIAGNOSTIC TEST
- Interior Lighting
- Power Door Locks/RKE
- Symptom: DECKLID RELEASE OUTPUT OPEN
- Symptom: DECKLID RELEASE OUTPUT SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH OPEN OR SHORT TO VOLTAGE
- Symptom: DRIVER CYLINDER UNLOCK SWITCH SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH STUCK
- Symptom: DRIVER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: DRIVER DOOR LOCK SWITCH STUCK
- Symptom: DRIVER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: DRIVER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: DRIVER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER DOOR LOCK SWITCH STUCK
- Symptom: PASSENGER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER/DRIVER DOOR UNLATCH RETURN SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT OPEN/SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT SHORT TO BATTERY
- Symptom: *ALL DOOR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR UNLATCH INOPERATIVE
- Symptom: *PASSENGER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *PASSENGER DOOR UNLATCH INOPERATIVE
- Symptom: *REMOTE KEYLESS ENTRY PROBLEM
- Power Windows
- Symptom: DRIVER WINDOW DOWN OUTPUT SHORT TO GROUND
- Symptom: DRIVER WINDOW HALL EFFECT FAILURE
- Symptom: DRIVER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: DRIVER WINDOW SWITCH SHORT TO GROUND
- Symptom: DRIVER WINDOW SWITCH STUCK DOWN
- Symptom: DRIVER WINDOW SWITCH STUCK UP
- Symptom: DRIVER WINDOW UP OUTPUT SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL SHORT TO BATTERY
- Symptom: PASSENGER WINDOW HALL EFFECT FAILURE
- Symptom: PASSENGER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: PASSENGER WINDOW SWITCH SHORT TO GROUND
- Symptom: PASSENGER WINDOW SWITCH STUCK DOWN
- Symptom: PASSENGER WINDOW SWITCH STUCK UP
- Symptom: PASSENGER WINDOW UP SHORT TO GROUND
- Symptom: *DRIVER WINDOW INOPERATIVE
- Symptom: *PASSENGER WINDOW INOPERATIVE
- Tire Pressure Monitoring
- Symptom: CRITICAL TIRE PRESSURE - BCM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM
- Symptom: TIRE PRESSURE LOW - BCM
- Symptom: TIRE PRESSURE MONITOR MODULE FAILURE - TPM
- Symptom: TPM DIAGNOSTIC - BCM
- Symptom: TPM MODULE INITIALIZED - BCM
- Symptom: *LO TIRE LCD MESSAGE FLASHING
- Vehicle Theft/Security
- Symptom: VTSS INDICATOR OUTPUT OPEN
- Symptom: VTSS INDICATOR OUTPUT SHORT
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *DECKLID DOES NOT TRIP VTSS
- Symptom: *DRIVER DOOR DOES NOT TRIP VTSS
- Symptom: *EXTERIOR LAMPS FAIL TO FLASH WHEN ALARM IS TRIPPED
- Symptom: *HOOD DOES NOT TRIP VTSS
- Symptom: *HORN FAILS TO SOUND WHEN ALARM IS TRIPPED
- Symptom: *PASSENGER DOOR DOES NOT TRIP VTSS
- Symptom: *VTSS LAMP ON STEADY DURING ARMING
- Symptom: *VTSS WILL NOT ARM
- Verification Tests
- Airbag
- Component Locations
- Connector PINOUTS
- A/C-Heater Control C1 - Black 10 Way
- A/C-Heater Control C2 - Black 16 Way
- Airbag Control Module C1 (Orc) - Yellow 32 Way
- Airbag Control Module C2 (Orc) - Yellow 32 Way
- Airbag On/Off Switch-Passenger - Yellow 6 Way
- Airbag Squib 1-Driver - Yellow/Black 2 Way
- Airbag Squib 2-Driver - Yellow/Gray 2 Way
- Airbag Squib-Passenger - Yellow 4 Way
- Ajar Switch-DECKLID - Black 3 Way
- Ajar Switch-Driver Door - Black 4 Way
- Ajar Switch-Hood - Natural 3 Way
- Ajar Switch-Passenger Door - Black 4 Way
- Blend Door Actuator - Gray 2 Way
- Blower Motor - Orange 2 Way
- Blower Motor Resistor Block - Black 4 Way
- Body Control Module C1 - Black 6 Way
- Body Control Module C2 - Black/Green 34 Way
- Body Control Module C3 - Black/White 34 Way
- Body Control Module C4 - Black/Gray 34 Way
- Brake Fluid Level Switch - Black 2 Way
- C200 - Black (Body Side)
- C200 - Black (Instrument Panel Side)
- C201 - Yellow (Body Side)
- C201 - Yellow (Instrument Panel Side)
- C202 - Natural (Driver Door Side)
- C202 - Natural (Instrument Panel Side)
- C203 - Natural (Instrument Panel Side)
- C203 - Natural (Passenger Door Side)
- C204 - LT. Gray (HVAC Jumper Side)
- C204 - LT. Gray (Instrument Panel Side)
- C206 - Red (Console Jumper Side)
- C206 - Red (Instrument Panel Side)
- C207 - Green (Instrument Panel Side)
- C207 - Natural (Passenger Door Side)
- C208 - Green (Instrument Panel Side)
- C208 - Natural (Driver Door Side)
- C303 - Black (Body Side)
- C303 - Black (DECKLID Jumper Side)
- CLOCKSPRING - White 8 Way
- Controller Antilock Brake - Black 24 Way
- Cylinder Unlock Switch-Driver - Black 2 Way
- Data Link Connector - Black 16 Way
- DECKLID Release Motor - Black 2 Way
- Door Latch Motor-Driver - 2 Way
- Door Latch Motor-Passenger - 2 Way
- Door Lock Switch-Driver - Black 3 Way
- Door Lock Switch-Passenger - Black 3 Way
- Exterior Door Handle Switch-Driver - Black 2 Way
- Exterior Door Handle Switch-Passenger - Black 2 Way
- Fog Lamp-Left - Black 2 Way
- Gauge Cluster C1 - White 3 Way
- Gauge Cluster C2 - Black 20 Way
- Hid Lamp-Left - Gray 2 Way
- High Beam Headlamp-Left - Black 2 Way
- Horn Switch - Black 1 Way
- Horn-High Note - Black 2 Way
- Horn-Low Note - Black 2 Way
- Ignition Switch - Black 5 Way
- Instrument Cluster C1 - Black 16 Way
- Instrument Cluster C2 - Black 20 Way
- Interior Door Handle Switch-Driver - Black 2 Way
- Interior Door Handle Switch-Passenger - Black 2 Way
- Marker Lamp-Left Front - DK. Gray 2 Way
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way
- Multi-Function Switch - Gray 20 Way
- Power Distribution Center
- Power Window Motor-Driver - Black 6 Way
- Power Window Motor-Passenger - Black 6 Way
- Power Window Switch-Driver - Gray 3 Way
- Power Window Switch-Passenger - Gray 3 Way
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Radio - Gray 22 Way
- RECIRCULATION Door Actuator - Gray 2 Way
- Remote Keyless Entry Module - Black 6 Way
- Seat Belt Switch-Driver - White 2 Way
- Seat Belt Switch-Passenger - White 2 Way
- Seat Belt TENSIONER-Driver - Yellow 2 Way
- Seat Belt TENSIONER-Passenger - Yellow 2 Way
- Speaker-Left Door - Black 2 Way
- Speaker-Left Instrument Panel - White 2 Way
- Speaker-Left Rear - White 3 Way
- Speaker-Rear Woofer - Gray 4 Way
- Speaker-Right Door - Black 2 Way
- Speaker-Right Instrument Panel - White 2 Way
- Speaker-Right Rear - White 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Window Down Relay-Passenger - Black 5 Way
- Window Up Relay-Passenger - Black 5 Way
- Schematic Diagrams
- Airbag System
- Audio System
- Chime System
- Communication
- Door Ajar System
- Electrically Heated Systems
- Exterior Lighting
- Heating & A/C System
- Ignition, Power, Accessory
- Instrument Cluster/Gauge Cluster
- Interior Lighting
- Power Door Locks/RKE
- Power Window System
- Tire Pressure Monitor Module (TPM)
- Vehicle Theft Security System
- Lamp System & Lighting System - Exterior
- Lamps/Lighting - Exterior
- Backup Lamp
- Back Up Lamp Unit
- Brake Lamp Switch
- Center High Mounted Stop Lamp Unit
- Fog Lamp
- Fog Lamp Unit
- Front Side Marker Lamp
- Headlamp
- Headlamp Unit
- License Plate Lamp
- License Plate Lamp Unit
- Multi-Function Switch
- Rear Side Marker Lamp
- Tail Lamp
- Tail Lamp Unit
- Body Diagnostic Procedures
- Gauges & Instrument Panels
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Body Control Module
- Chime Warning System
- Communication
- Door Ajar System
- Exterior Lighting System
- Relays Controlled By The BCM
- Heating & A/C System
- Instrument Cluster / Gauge Cluster
- Interior Lighting
- Tire Pressure Monitoring System (TPMS)
- Power Door Entry System
- Power Windows
- Electrically Heated Systems
- Vehicle Theft Security System
- Using The DRBIII®
- DRBIII® Error Messages
- DRBIII® Does Not Power Up (Blank Screen)
- Display Is Not Visible
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; ACCELEROMETER 2; INTERNAL 1; OUTPUT DRIVER 1; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: DRIVER SQUIB 2 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 2 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 2 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 2 SHORT TO GROUND
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH OPEN
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO BATTERY
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO GROUND
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO BATTERY
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: PASSENGER SQUIB 2 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 2 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 2 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 2 SHORT TO GROUND
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom List: CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH BCM
- Chime
- Communication
- Symptom: ACM MESSAGES NOT RECEIVED
- Symptom: AUDIO MESSAGES NOT RECEIVED
- Symptom: COUNTRY CODE NOT PROGRAMMED
- Symptom: INTERNAL BCM FAILURE
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom List: PCI BUS SHORTED TO BATTERY; PCI BUS SHORTED TO GROUND
- Symptom: PCI INTERNAL FAULT
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM BODY CONTROL MODULE
- Symptom: *NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE
- Symptom: *NO RESPONSE FROM HVAC
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM PCM (PCI BUS)
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY)
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM TIRE PRESSURE MONITOR MODULE
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Door Ajar
- Symptom: *DECKLID AJAR CIRCUIT OPEN
- Symptom: *DECKLID AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *DRIVER DOOR AJAR CIRCUIT OPEN
- Symptom: *DRIVER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *HOOD AJAR CIRCUIT OPEN
- Symptom: *HOOD AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *PASSENGER DOOR AJAR CIRCUIT OPEN
- Symptom: *PASSENGER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Electrically Heated Systems
- Exterior Lighting
- Symptom: LEFT FOG LAMP OUTPUT OPEN
- Symptom: LEFT FOG LAMP OUTPUT SHORTED
- Symptom: LEFT HIGH BEAM OUTPUT OPEN
- Symptom: LEFT HIGH BEAM OUTPUT SHORT
- Symptom: LOW BEAM RELAY COIL OUTPUT OPEN/SHORT TO GROUND
- Symptom: LOW BEAM RELAY COIL SHORT TO VOLTAGE
- Symptom: PARK LAMP OUTPUT SHORT
- Symptom: RIGHT FOG LAMP OUTPUT OPEN
- Symptom: RIGHT FOG LAMP OUTPUT SHORTED
- Symptom: RIGHT HIGH BEAM OUTPUT OPEN
- Symptom: RIGHT HIGH BEAM OUTPUT SHORT
- Heating & A/C
- Symptom List: A/C SWITCH FAULT (ACTIVE); CHECKSUM FAILURE (ACTIVE); DEFOG SWITCH FAULT (ACTIVE)
- Symptom List: A/C SWITCH FAULT (STORED); BACKLIGHT DIMMING RX FAILURE (STORED); BLEND OVERCURRENT (STORED); CHECKSUM FAILURE (STORED); DEFOG SWITCH FAULT (STORED); LOOPBACK TEST FAILURE (STORED); MODE 1 OVERCURRENT (STORED); MODE 2 OVERCURRENT (STORED); RECIRC OVERCURRENT (STORED); REFRIGERANT PRESS RX FAILURE (STORED); TX FAILURE (STORED); VIN RX FAILURE (STORED)
- Notes
- When Monitored and Set Condition:
- A/C Switch Fault (Stored)
- Backlight Dimming RX Failure (Stored)
- Blend OVERCURRENT (Stored)
- Checksum Failure (Stored)
- Defog Switch Fault (Stored)
- LOOPBACK Test Failure (Stored)
- Mode 1 OVERCURRENT (Stored)
- Mode 2 OVERCURRENT (Stored)
- RECIRC OVERCURRENT (Stored)
- Refrigerant Press RX Failure (Stored)
- TX Failure (Stored)
- VIN RX Failure (Stored)
- Possible Causes
- Diagnostic Procedure
- Symptom List: ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE; BLEND CIRCUIT SHORTED TO GROUND; BLEND CIRCUIT SHORTED TO IGN OR BATT; COMMON DRIVER SHORTED TO GROUND; COMMON DRIVER SHORTED TO IGN OR BATT; MODE 1 CIRCUIT SHORTED TO GROUND; MODE 1 CIRCUIT SHORTED TO IGN OR BATT; MODE 2 CIRCUIT SHORTED TO GROUND; MODE 2 CIRCUIT SHORTED TO IGN OR BATT; RECIRC CIRCUIT SHORTED TO GROUND; RECIRC CIRCUIT SHORTED TO IGN OR BATT; SHORT TOO COMPLEX
- Notes
- When Monitored and Set Condition:
- Act CKT Test Passed, OVERCURRENT DTCS Active
- Blend Circuit Shorted To Ground
- Blend Circuit Shorted To IGN Or Batt
- Common Driver Shorted To Ground
- Common Driver Shorted To IGN Or Batt
- Mode 1 Circuit Shorted To Ground
- Mode 1 Circuit Shorted To IGN Or Batt
- Mode 2 Circuit Shorted To Ground
- Mode 2 Circuit Shorted To IGN Or Batt
- RECIRC Circuit Shorted To Ground
- RECIRC Circuit Shorted To IGN Or Batt
- Short Too Complex
- Possible Causes
- Diagnostic Procedure
- Symptom: BACKLIGHT DIMMING RX FAILURE (ACTIVE)
- Symptom List: BLEND CALIBRATION FAULT; MODE 1 CALIBRATION FAULT; MODE 2 CALIBRATION FAULT; RECIRCULATION CALIBRATION FAULT
- Symptom List: BLEND OVERCURRENT (ACTIVE); MODE 1 OVERCURRENT (ACTIVE); MODE 2 OVERCURRENT (ACTIVE); RECIRC OVERCURRENT (ACTIVE)
- Symptom: DEFOG RELAY CONTROL CKT SHORTED TO BATT
- Symptom: LOOPBACK TEST FAILURE (ACTIVE)
- Symptom List: REFRIGERANT PRESSURE RX FAILURE (ACTIVE); VIN RX FAILURE (ACTIVE)
- Symptom: TX FAILURE (ACTIVE)
- Symptom: *A/C - HEATER CONTROL ILLUMINATION INOPERATIVE
- Symptom: *BLEND/MODE/RECIRC DOOR OPERATION IMPROPER
- Symptom: *BLOWER MOTOR INOPERATIVE
- Symptom: *BLOWER MOTOR SPEEDS INCORRECT
- Symptom: *EBL STATUS INDICATOR FLASHING
- Symptom: *HVAC SYSTEM TEST
- Ignition, Power, Accessory
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT OPEN
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT SHORT TO GROUND
- Symptom: BCM - IGNITION MUX SWITCH INPUT MISMATCH
- Symptom: BCM - IGNITION MUX SWITCH INPUT OPEN
- Symptom: BCM - IGNITION MUX SWITCH INPUT SHORT
- Symptom: BCM - IGNITION RUN 1 SHORT
- Symptom: BCM - IGNITION RUN 2 SHORT
- Symptom: BCM - IOD OUTPUT CIRCUIT SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT OPEN / SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT SHORT TO VOLTAGE
- Symptom: BCM - RUN/START HARDWIRE INPUT MISMATCH
- Symptom: HORN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: HORN RELAY COIL SHORT TO BATTERY
- Symptom: HORN SWITCH STUCK
- Symptom: *HORNS INOPERATIVE
- Instrument Cluster
- Symptom List: ABS LAMP CIRCUIT OPEN; ABS LAMP CIRCUIT SHORTED; AIRBAG LAMP CIRCUIT OPEN; AIRBAG LAMP CIRCUIT SHORTED
- Symptom: ABS MESSAGES NOT RECEIVED
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT OPEN / SHORTED TO VOLTAGE
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT SHORT TO GROUND
- Symptom: BCM - PWM DIMMING OUTPUT SHORT
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: ORC MESSAGES NOT RECEIVED
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *GAUGE CLUSTER DIAGNOSTIC TEST
- Symptom: *INSTRUMENT CLUSTER DIAGNOSTIC TEST
- Interior Lighting
- Power Door Locks/RKE
- Symptom: DECKLID RELEASE OUTPUT OPEN
- Symptom: DECKLID RELEASE OUTPUT SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH OPEN OR SHORT TO VOLTAGE
- Symptom: DRIVER CYLINDER UNLOCK SWITCH SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH STUCK
- Symptom: DRIVER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: DRIVER DOOR LOCK SWITCH STUCK
- Symptom: DRIVER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: DRIVER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: DRIVER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER DOOR LOCK SWITCH STUCK
- Symptom: PASSENGER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER/DRIVER DOOR UNLATCH RETURN SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT OPEN/SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT SHORT TO BATTERY
- Symptom: *ALL DOOR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR UNLATCH INOPERATIVE
- Symptom: *PASSENGER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *PASSENGER DOOR UNLATCH INOPERATIVE
- Symptom: *REMOTE KEYLESS ENTRY PROBLEM
- Power Windows
- Symptom: DRIVER WINDOW DOWN OUTPUT SHORT TO GROUND
- Symptom: DRIVER WINDOW HALL EFFECT FAILURE
- Symptom: DRIVER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: DRIVER WINDOW SWITCH SHORT TO GROUND
- Symptom: DRIVER WINDOW SWITCH STUCK DOWN
- Symptom: DRIVER WINDOW SWITCH STUCK UP
- Symptom: DRIVER WINDOW UP OUTPUT SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL SHORT TO BATTERY
- Symptom: PASSENGER WINDOW HALL EFFECT FAILURE
- Symptom: PASSENGER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: PASSENGER WINDOW SWITCH SHORT TO GROUND
- Symptom: PASSENGER WINDOW SWITCH STUCK DOWN
- Symptom: PASSENGER WINDOW SWITCH STUCK UP
- Symptom: PASSENGER WINDOW UP SHORT TO GROUND
- Symptom: *DRIVER WINDOW INOPERATIVE
- Symptom: *PASSENGER WINDOW INOPERATIVE
- Tire Pressure Monitoring
- Symptom: CRITICAL TIRE PRESSURE - BCM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM
- Symptom: TIRE PRESSURE LOW - BCM
- Symptom: TIRE PRESSURE MONITOR MODULE FAILURE - TPM
- Symptom: TPM DIAGNOSTIC - BCM
- Symptom: TPM MODULE INITIALIZED - BCM
- Symptom: *LO TIRE LCD MESSAGE FLASHING
- Vehicle Theft/Security
- Symptom: VTSS INDICATOR OUTPUT OPEN
- Symptom: VTSS INDICATOR OUTPUT SHORT
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *DECKLID DOES NOT TRIP VTSS
- Symptom: *DRIVER DOOR DOES NOT TRIP VTSS
- Symptom: *EXTERIOR LAMPS FAIL TO FLASH WHEN ALARM IS TRIPPED
- Symptom: *HOOD DOES NOT TRIP VTSS
- Symptom: *HORN FAILS TO SOUND WHEN ALARM IS TRIPPED
- Symptom: *PASSENGER DOOR DOES NOT TRIP VTSS
- Symptom: *VTSS LAMP ON STEADY DURING ARMING
- Symptom: *VTSS WILL NOT ARM
- Verification Tests
- Airbag
- Component Locations
- Connector PINOUTS
- A/C-Heater Control C1 - Black 10 Way
- A/C-Heater Control C2 - Black 16 Way
- Airbag Control Module C1 (Orc) - Yellow 32 Way
- Airbag Control Module C2 (Orc) - Yellow 32 Way
- Airbag On/Off Switch-Passenger - Yellow 6 Way
- Airbag Squib 1-Driver - Yellow/Black 2 Way
- Airbag Squib 2-Driver - Yellow/Gray 2 Way
- Airbag Squib-Passenger - Yellow 4 Way
- Ajar Switch-DECKLID - Black 3 Way
- Ajar Switch-Driver Door - Black 4 Way
- Ajar Switch-Hood - Natural 3 Way
- Ajar Switch-Passenger Door - Black 4 Way
- Blend Door Actuator - Gray 2 Way
- Blower Motor - Orange 2 Way
- Blower Motor Resistor Block - Black 4 Way
- Body Control Module C1 - Black 6 Way
- Body Control Module C2 - Black/Green 34 Way
- Body Control Module C3 - Black/White 34 Way
- Body Control Module C4 - Black/Gray 34 Way
- Brake Fluid Level Switch - Black 2 Way
- C200 - Black (Body Side)
- C200 - Black (Instrument Panel Side)
- C201 - Yellow (Body Side)
- C201 - Yellow (Instrument Panel Side)
- C202 - Natural (Driver Door Side)
- C202 - Natural (Instrument Panel Side)
- C203 - Natural (Instrument Panel Side)
- C203 - Natural (Passenger Door Side)
- C204 - LT. Gray (HVAC Jumper Side)
- C204 - LT. Gray (Instrument Panel Side)
- C206 - Red (Console Jumper Side)
- C206 - Red (Instrument Panel Side)
- C207 - Green (Instrument Panel Side)
- C207 - Natural (Passenger Door Side)
- C208 - Green (Instrument Panel Side)
- C208 - Natural (Driver Door Side)
- C303 - Black (Body Side)
- C303 - Black (DECKLID Jumper Side)
- CLOCKSPRING - White 8 Way
- Controller Antilock Brake - Black 24 Way
- Cylinder Unlock Switch-Driver - Black 2 Way
- Data Link Connector - Black 16 Way
- DECKLID Release Motor - Black 2 Way
- Door Latch Motor-Driver - 2 Way
- Door Latch Motor-Passenger - 2 Way
- Door Lock Switch-Driver - Black 3 Way
- Door Lock Switch-Passenger - Black 3 Way
- Exterior Door Handle Switch-Driver - Black 2 Way
- Exterior Door Handle Switch-Passenger - Black 2 Way
- Fog Lamp-Left - Black 2 Way
- Gauge Cluster C1 - White 3 Way
- Gauge Cluster C2 - Black 20 Way
- Hid Lamp-Left - Gray 2 Way
- High Beam Headlamp-Left - Black 2 Way
- Horn Switch - Black 1 Way
- Horn-High Note - Black 2 Way
- Horn-Low Note - Black 2 Way
- Ignition Switch - Black 5 Way
- Instrument Cluster C1 - Black 16 Way
- Instrument Cluster C2 - Black 20 Way
- Interior Door Handle Switch-Driver - Black 2 Way
- Interior Door Handle Switch-Passenger - Black 2 Way
- Marker Lamp-Left Front - DK. Gray 2 Way
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way
- Multi-Function Switch - Gray 20 Way
- Power Distribution Center
- Power Window Motor-Driver - Black 6 Way
- Power Window Motor-Passenger - Black 6 Way
- Power Window Switch-Driver - Gray 3 Way
- Power Window Switch-Passenger - Gray 3 Way
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Radio - Gray 22 Way
- RECIRCULATION Door Actuator - Gray 2 Way
- Remote Keyless Entry Module - Black 6 Way
- Seat Belt Switch-Driver - White 2 Way
- Seat Belt Switch-Passenger - White 2 Way
- Seat Belt TENSIONER-Driver - Yellow 2 Way
- Seat Belt TENSIONER-Passenger - Yellow 2 Way
- Speaker-Left Door - Black 2 Way
- Speaker-Left Instrument Panel - White 2 Way
- Speaker-Left Rear - White 3 Way
- Speaker-Rear Woofer - Gray 4 Way
- Speaker-Right Door - Black 2 Way
- Speaker-Right Instrument Panel - White 2 Way
- Speaker-Right Rear - White 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Window Down Relay-Passenger - Black 5 Way
- Window Up Relay-Passenger - Black 5 Way
- Schematic Diagrams
- Airbag System
- Audio System
- Chime System
- Communication
- Door Ajar System
- Electrically Heated Systems
- Exterior Lighting
- Heating & A/C System
- Ignition, Power, Accessory
- Instrument Cluster/Gauge Cluster
- Interior Lighting
- Power Door Locks/RKE
- Power Window System
- Tire Pressure Monitor Module (TPM)
- Vehicle Theft Security System
- Instrument Cluster
- Interior/Exterior
- Body
- Warning
- Diagnosis And Testing
- Standard Procedure
- Standard Procedure - Plastic Body Panel Repair
- Notes
- Rigid Plastics:
- Semi-Rigid Plastics:
- Flexible Plastics:
- Repair Procedure:
- Adhesion Promoter/Surface Modifier:
- Safety Precaution And Warnings
- Rigid, Semi-Rigid, And Flexible Plastic Parts Types
- Panel Sectioning
- Panel Reinforcement
- Visual Inspection
- Panel Surface Preparation
- Patching Panels
- Panel Patch Fabrications
- Panel Patch Installation
- Patched Panel Surfacing
- Standard Procedure - Heat Staking
- Standard Procedure - Plastic Body Panel Repair
- Specifications
- Special Tools
- Convertible Top
- DECKLID
- Door - Front
- Exterior
- Hood
- Instrument Panel
- Interior
- Paint
- Seats
- Stationary Glass
- Weatherstrip/Seals
- Body Structure
- Body
- Body Diagnostic Procedures
- Headlights
- Lamp System & Lighting System - Exterior
- Lamps/Lighting - Exterior
- Backup Lamp
- Back Up Lamp Unit
- Brake Lamp Switch
- Center High Mounted Stop Lamp Unit
- Fog Lamp
- Fog Lamp Unit
- Front Side Marker Lamp
- Headlamp
- Headlamp Unit
- License Plate Lamp
- License Plate Lamp Unit
- Multi-Function Switch
- Rear Side Marker Lamp
- Tail Lamp
- Tail Lamp Unit
- Lamp System & Lighting System - Exterior
- Heated Glass/Defoggers
- Horns
- Infotainment
- Audio System (Service Information)
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Body Control Module
- Chime Warning System
- Communication
- Door Ajar System
- Exterior Lighting System
- Relays Controlled By The BCM
- Heating & A/C System
- Instrument Cluster / Gauge Cluster
- Interior Lighting
- Tire Pressure Monitoring System (TPMS)
- Power Door Entry System
- Power Windows
- Electrically Heated Systems
- Vehicle Theft Security System
- Using The DRBIII®
- DRBIII® Error Messages
- DRBIII® Does Not Power Up (Blank Screen)
- Display Is Not Visible
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; ACCELEROMETER 2; INTERNAL 1; OUTPUT DRIVER 1; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: DRIVER SQUIB 2 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 2 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 2 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 2 SHORT TO GROUND
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH OPEN
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO BATTERY
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO GROUND
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO BATTERY
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: PASSENGER SQUIB 2 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 2 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 2 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 2 SHORT TO GROUND
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom List: CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH BCM
- Chime
- Communication
- Symptom: ACM MESSAGES NOT RECEIVED
- Symptom: AUDIO MESSAGES NOT RECEIVED
- Symptom: COUNTRY CODE NOT PROGRAMMED
- Symptom: INTERNAL BCM FAILURE
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom List: PCI BUS SHORTED TO BATTERY; PCI BUS SHORTED TO GROUND
- Symptom: PCI INTERNAL FAULT
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM BODY CONTROL MODULE
- Symptom: *NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE
- Symptom: *NO RESPONSE FROM HVAC
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM PCM (PCI BUS)
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY)
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM TIRE PRESSURE MONITOR MODULE
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Door Ajar
- Symptom: *DECKLID AJAR CIRCUIT OPEN
- Symptom: *DECKLID AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *DRIVER DOOR AJAR CIRCUIT OPEN
- Symptom: *DRIVER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *HOOD AJAR CIRCUIT OPEN
- Symptom: *HOOD AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *PASSENGER DOOR AJAR CIRCUIT OPEN
- Symptom: *PASSENGER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Electrically Heated Systems
- Exterior Lighting
- Symptom: LEFT FOG LAMP OUTPUT OPEN
- Symptom: LEFT FOG LAMP OUTPUT SHORTED
- Symptom: LEFT HIGH BEAM OUTPUT OPEN
- Symptom: LEFT HIGH BEAM OUTPUT SHORT
- Symptom: LOW BEAM RELAY COIL OUTPUT OPEN/SHORT TO GROUND
- Symptom: LOW BEAM RELAY COIL SHORT TO VOLTAGE
- Symptom: PARK LAMP OUTPUT SHORT
- Symptom: RIGHT FOG LAMP OUTPUT OPEN
- Symptom: RIGHT FOG LAMP OUTPUT SHORTED
- Symptom: RIGHT HIGH BEAM OUTPUT OPEN
- Symptom: RIGHT HIGH BEAM OUTPUT SHORT
- Heating & A/C
- Symptom List: A/C SWITCH FAULT (ACTIVE); CHECKSUM FAILURE (ACTIVE); DEFOG SWITCH FAULT (ACTIVE)
- Symptom List: A/C SWITCH FAULT (STORED); BACKLIGHT DIMMING RX FAILURE (STORED); BLEND OVERCURRENT (STORED); CHECKSUM FAILURE (STORED); DEFOG SWITCH FAULT (STORED); LOOPBACK TEST FAILURE (STORED); MODE 1 OVERCURRENT (STORED); MODE 2 OVERCURRENT (STORED); RECIRC OVERCURRENT (STORED); REFRIGERANT PRESS RX FAILURE (STORED); TX FAILURE (STORED); VIN RX FAILURE (STORED)
- Notes
- When Monitored and Set Condition:
- A/C Switch Fault (Stored)
- Backlight Dimming RX Failure (Stored)
- Blend OVERCURRENT (Stored)
- Checksum Failure (Stored)
- Defog Switch Fault (Stored)
- LOOPBACK Test Failure (Stored)
- Mode 1 OVERCURRENT (Stored)
- Mode 2 OVERCURRENT (Stored)
- RECIRC OVERCURRENT (Stored)
- Refrigerant Press RX Failure (Stored)
- TX Failure (Stored)
- VIN RX Failure (Stored)
- Possible Causes
- Diagnostic Procedure
- Symptom List: ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE; BLEND CIRCUIT SHORTED TO GROUND; BLEND CIRCUIT SHORTED TO IGN OR BATT; COMMON DRIVER SHORTED TO GROUND; COMMON DRIVER SHORTED TO IGN OR BATT; MODE 1 CIRCUIT SHORTED TO GROUND; MODE 1 CIRCUIT SHORTED TO IGN OR BATT; MODE 2 CIRCUIT SHORTED TO GROUND; MODE 2 CIRCUIT SHORTED TO IGN OR BATT; RECIRC CIRCUIT SHORTED TO GROUND; RECIRC CIRCUIT SHORTED TO IGN OR BATT; SHORT TOO COMPLEX
- Notes
- When Monitored and Set Condition:
- Act CKT Test Passed, OVERCURRENT DTCS Active
- Blend Circuit Shorted To Ground
- Blend Circuit Shorted To IGN Or Batt
- Common Driver Shorted To Ground
- Common Driver Shorted To IGN Or Batt
- Mode 1 Circuit Shorted To Ground
- Mode 1 Circuit Shorted To IGN Or Batt
- Mode 2 Circuit Shorted To Ground
- Mode 2 Circuit Shorted To IGN Or Batt
- RECIRC Circuit Shorted To Ground
- RECIRC Circuit Shorted To IGN Or Batt
- Short Too Complex
- Possible Causes
- Diagnostic Procedure
- Symptom: BACKLIGHT DIMMING RX FAILURE (ACTIVE)
- Symptom List: BLEND CALIBRATION FAULT; MODE 1 CALIBRATION FAULT; MODE 2 CALIBRATION FAULT; RECIRCULATION CALIBRATION FAULT
- Symptom List: BLEND OVERCURRENT (ACTIVE); MODE 1 OVERCURRENT (ACTIVE); MODE 2 OVERCURRENT (ACTIVE); RECIRC OVERCURRENT (ACTIVE)
- Symptom: DEFOG RELAY CONTROL CKT SHORTED TO BATT
- Symptom: LOOPBACK TEST FAILURE (ACTIVE)
- Symptom List: REFRIGERANT PRESSURE RX FAILURE (ACTIVE); VIN RX FAILURE (ACTIVE)
- Symptom: TX FAILURE (ACTIVE)
- Symptom: *A/C - HEATER CONTROL ILLUMINATION INOPERATIVE
- Symptom: *BLEND/MODE/RECIRC DOOR OPERATION IMPROPER
- Symptom: *BLOWER MOTOR INOPERATIVE
- Symptom: *BLOWER MOTOR SPEEDS INCORRECT
- Symptom: *EBL STATUS INDICATOR FLASHING
- Symptom: *HVAC SYSTEM TEST
- Ignition, Power, Accessory
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT OPEN
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT SHORT TO GROUND
- Symptom: BCM - IGNITION MUX SWITCH INPUT MISMATCH
- Symptom: BCM - IGNITION MUX SWITCH INPUT OPEN
- Symptom: BCM - IGNITION MUX SWITCH INPUT SHORT
- Symptom: BCM - IGNITION RUN 1 SHORT
- Symptom: BCM - IGNITION RUN 2 SHORT
- Symptom: BCM - IOD OUTPUT CIRCUIT SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT OPEN / SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT SHORT TO VOLTAGE
- Symptom: BCM - RUN/START HARDWIRE INPUT MISMATCH
- Symptom: HORN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: HORN RELAY COIL SHORT TO BATTERY
- Symptom: HORN SWITCH STUCK
- Symptom: *HORNS INOPERATIVE
- Instrument Cluster
- Symptom List: ABS LAMP CIRCUIT OPEN; ABS LAMP CIRCUIT SHORTED; AIRBAG LAMP CIRCUIT OPEN; AIRBAG LAMP CIRCUIT SHORTED
- Symptom: ABS MESSAGES NOT RECEIVED
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT OPEN / SHORTED TO VOLTAGE
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT SHORT TO GROUND
- Symptom: BCM - PWM DIMMING OUTPUT SHORT
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: ORC MESSAGES NOT RECEIVED
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *GAUGE CLUSTER DIAGNOSTIC TEST
- Symptom: *INSTRUMENT CLUSTER DIAGNOSTIC TEST
- Interior Lighting
- Power Door Locks/RKE
- Symptom: DECKLID RELEASE OUTPUT OPEN
- Symptom: DECKLID RELEASE OUTPUT SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH OPEN OR SHORT TO VOLTAGE
- Symptom: DRIVER CYLINDER UNLOCK SWITCH SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH STUCK
- Symptom: DRIVER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: DRIVER DOOR LOCK SWITCH STUCK
- Symptom: DRIVER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: DRIVER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: DRIVER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER DOOR LOCK SWITCH STUCK
- Symptom: PASSENGER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER/DRIVER DOOR UNLATCH RETURN SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT OPEN/SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT SHORT TO BATTERY
- Symptom: *ALL DOOR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR UNLATCH INOPERATIVE
- Symptom: *PASSENGER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *PASSENGER DOOR UNLATCH INOPERATIVE
- Symptom: *REMOTE KEYLESS ENTRY PROBLEM
- Power Windows
- Symptom: DRIVER WINDOW DOWN OUTPUT SHORT TO GROUND
- Symptom: DRIVER WINDOW HALL EFFECT FAILURE
- Symptom: DRIVER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: DRIVER WINDOW SWITCH SHORT TO GROUND
- Symptom: DRIVER WINDOW SWITCH STUCK DOWN
- Symptom: DRIVER WINDOW SWITCH STUCK UP
- Symptom: DRIVER WINDOW UP OUTPUT SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL SHORT TO BATTERY
- Symptom: PASSENGER WINDOW HALL EFFECT FAILURE
- Symptom: PASSENGER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: PASSENGER WINDOW SWITCH SHORT TO GROUND
- Symptom: PASSENGER WINDOW SWITCH STUCK DOWN
- Symptom: PASSENGER WINDOW SWITCH STUCK UP
- Symptom: PASSENGER WINDOW UP SHORT TO GROUND
- Symptom: *DRIVER WINDOW INOPERATIVE
- Symptom: *PASSENGER WINDOW INOPERATIVE
- Tire Pressure Monitoring
- Symptom: CRITICAL TIRE PRESSURE - BCM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM
- Symptom: TIRE PRESSURE LOW - BCM
- Symptom: TIRE PRESSURE MONITOR MODULE FAILURE - TPM
- Symptom: TPM DIAGNOSTIC - BCM
- Symptom: TPM MODULE INITIALIZED - BCM
- Symptom: *LO TIRE LCD MESSAGE FLASHING
- Vehicle Theft/Security
- Symptom: VTSS INDICATOR OUTPUT OPEN
- Symptom: VTSS INDICATOR OUTPUT SHORT
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *DECKLID DOES NOT TRIP VTSS
- Symptom: *DRIVER DOOR DOES NOT TRIP VTSS
- Symptom: *EXTERIOR LAMPS FAIL TO FLASH WHEN ALARM IS TRIPPED
- Symptom: *HOOD DOES NOT TRIP VTSS
- Symptom: *HORN FAILS TO SOUND WHEN ALARM IS TRIPPED
- Symptom: *PASSENGER DOOR DOES NOT TRIP VTSS
- Symptom: *VTSS LAMP ON STEADY DURING ARMING
- Symptom: *VTSS WILL NOT ARM
- Verification Tests
- Airbag
- Component Locations
- Connector PINOUTS
- A/C-Heater Control C1 - Black 10 Way
- A/C-Heater Control C2 - Black 16 Way
- Airbag Control Module C1 (Orc) - Yellow 32 Way
- Airbag Control Module C2 (Orc) - Yellow 32 Way
- Airbag On/Off Switch-Passenger - Yellow 6 Way
- Airbag Squib 1-Driver - Yellow/Black 2 Way
- Airbag Squib 2-Driver - Yellow/Gray 2 Way
- Airbag Squib-Passenger - Yellow 4 Way
- Ajar Switch-DECKLID - Black 3 Way
- Ajar Switch-Driver Door - Black 4 Way
- Ajar Switch-Hood - Natural 3 Way
- Ajar Switch-Passenger Door - Black 4 Way
- Blend Door Actuator - Gray 2 Way
- Blower Motor - Orange 2 Way
- Blower Motor Resistor Block - Black 4 Way
- Body Control Module C1 - Black 6 Way
- Body Control Module C2 - Black/Green 34 Way
- Body Control Module C3 - Black/White 34 Way
- Body Control Module C4 - Black/Gray 34 Way
- Brake Fluid Level Switch - Black 2 Way
- C200 - Black (Body Side)
- C200 - Black (Instrument Panel Side)
- C201 - Yellow (Body Side)
- C201 - Yellow (Instrument Panel Side)
- C202 - Natural (Driver Door Side)
- C202 - Natural (Instrument Panel Side)
- C203 - Natural (Instrument Panel Side)
- C203 - Natural (Passenger Door Side)
- C204 - LT. Gray (HVAC Jumper Side)
- C204 - LT. Gray (Instrument Panel Side)
- C206 - Red (Console Jumper Side)
- C206 - Red (Instrument Panel Side)
- C207 - Green (Instrument Panel Side)
- C207 - Natural (Passenger Door Side)
- C208 - Green (Instrument Panel Side)
- C208 - Natural (Driver Door Side)
- C303 - Black (Body Side)
- C303 - Black (DECKLID Jumper Side)
- CLOCKSPRING - White 8 Way
- Controller Antilock Brake - Black 24 Way
- Cylinder Unlock Switch-Driver - Black 2 Way
- Data Link Connector - Black 16 Way
- DECKLID Release Motor - Black 2 Way
- Door Latch Motor-Driver - 2 Way
- Door Latch Motor-Passenger - 2 Way
- Door Lock Switch-Driver - Black 3 Way
- Door Lock Switch-Passenger - Black 3 Way
- Exterior Door Handle Switch-Driver - Black 2 Way
- Exterior Door Handle Switch-Passenger - Black 2 Way
- Fog Lamp-Left - Black 2 Way
- Gauge Cluster C1 - White 3 Way
- Gauge Cluster C2 - Black 20 Way
- Hid Lamp-Left - Gray 2 Way
- High Beam Headlamp-Left - Black 2 Way
- Horn Switch - Black 1 Way
- Horn-High Note - Black 2 Way
- Horn-Low Note - Black 2 Way
- Ignition Switch - Black 5 Way
- Instrument Cluster C1 - Black 16 Way
- Instrument Cluster C2 - Black 20 Way
- Interior Door Handle Switch-Driver - Black 2 Way
- Interior Door Handle Switch-Passenger - Black 2 Way
- Marker Lamp-Left Front - DK. Gray 2 Way
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way
- Multi-Function Switch - Gray 20 Way
- Power Distribution Center
- Power Window Motor-Driver - Black 6 Way
- Power Window Motor-Passenger - Black 6 Way
- Power Window Switch-Driver - Gray 3 Way
- Power Window Switch-Passenger - Gray 3 Way
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Radio - Gray 22 Way
- RECIRCULATION Door Actuator - Gray 2 Way
- Remote Keyless Entry Module - Black 6 Way
- Seat Belt Switch-Driver - White 2 Way
- Seat Belt Switch-Passenger - White 2 Way
- Seat Belt TENSIONER-Driver - Yellow 2 Way
- Seat Belt TENSIONER-Passenger - Yellow 2 Way
- Speaker-Left Door - Black 2 Way
- Speaker-Left Instrument Panel - White 2 Way
- Speaker-Left Rear - White 3 Way
- Speaker-Rear Woofer - Gray 4 Way
- Speaker-Right Door - Black 2 Way
- Speaker-Right Instrument Panel - White 2 Way
- Speaker-Right Rear - White 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Window Down Relay-Passenger - Black 5 Way
- Window Up Relay-Passenger - Black 5 Way
- Schematic Diagrams
- Airbag System
- Audio System
- Chime System
- Communication
- Door Ajar System
- Electrically Heated Systems
- Exterior Lighting
- Heating & A/C System
- Ignition, Power, Accessory
- Instrument Cluster/Gauge Cluster
- Interior Lighting
- Power Door Locks/RKE
- Power Window System
- Tire Pressure Monitor Module (TPM)
- Vehicle Theft Security System
- Interior/Exterior Trim
- Body
- Warning
- Diagnosis And Testing
- Standard Procedure
- Standard Procedure - Plastic Body Panel Repair
- Notes
- Rigid Plastics:
- Semi-Rigid Plastics:
- Flexible Plastics:
- Repair Procedure:
- Adhesion Promoter/Surface Modifier:
- Safety Precaution And Warnings
- Rigid, Semi-Rigid, And Flexible Plastic Parts Types
- Panel Sectioning
- Panel Reinforcement
- Visual Inspection
- Panel Surface Preparation
- Patching Panels
- Panel Patch Fabrications
- Panel Patch Installation
- Patched Panel Surfacing
- Standard Procedure - Heat Staking
- Standard Procedure - Plastic Body Panel Repair
- Specifications
- Special Tools
- Convertible Top
- DECKLID
- Door - Front
- Exterior
- Hood
- Instrument Panel
- Interior
- Paint
- Seats
- Stationary Glass
- Weatherstrip/Seals
- Body Structure
- Body
- Interior/Illumination Lights
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Body Control Module
- Chime Warning System
- Communication
- Door Ajar System
- Exterior Lighting System
- Relays Controlled By The BCM
- Heating & A/C System
- Instrument Cluster / Gauge Cluster
- Interior Lighting
- Tire Pressure Monitoring System (TPMS)
- Power Door Entry System
- Power Windows
- Electrically Heated Systems
- Vehicle Theft Security System
- Using The DRBIII®
- DRBIII® Error Messages
- DRBIII® Does Not Power Up (Blank Screen)
- Display Is Not Visible
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; ACCELEROMETER 2; INTERNAL 1; OUTPUT DRIVER 1; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: DRIVER SQUIB 2 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 2 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 2 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 2 SHORT TO GROUND
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH OPEN
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO BATTERY
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO GROUND
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO BATTERY
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: PASSENGER SQUIB 2 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 2 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 2 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 2 SHORT TO GROUND
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom List: CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH BCM
- Chime
- Communication
- Symptom: ACM MESSAGES NOT RECEIVED
- Symptom: AUDIO MESSAGES NOT RECEIVED
- Symptom: COUNTRY CODE NOT PROGRAMMED
- Symptom: INTERNAL BCM FAILURE
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom List: PCI BUS SHORTED TO BATTERY; PCI BUS SHORTED TO GROUND
- Symptom: PCI INTERNAL FAULT
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM BODY CONTROL MODULE
- Symptom: *NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE
- Symptom: *NO RESPONSE FROM HVAC
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM PCM (PCI BUS)
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY)
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM TIRE PRESSURE MONITOR MODULE
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Door Ajar
- Symptom: *DECKLID AJAR CIRCUIT OPEN
- Symptom: *DECKLID AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *DRIVER DOOR AJAR CIRCUIT OPEN
- Symptom: *DRIVER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *HOOD AJAR CIRCUIT OPEN
- Symptom: *HOOD AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *PASSENGER DOOR AJAR CIRCUIT OPEN
- Symptom: *PASSENGER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Electrically Heated Systems
- Exterior Lighting
- Symptom: LEFT FOG LAMP OUTPUT OPEN
- Symptom: LEFT FOG LAMP OUTPUT SHORTED
- Symptom: LEFT HIGH BEAM OUTPUT OPEN
- Symptom: LEFT HIGH BEAM OUTPUT SHORT
- Symptom: LOW BEAM RELAY COIL OUTPUT OPEN/SHORT TO GROUND
- Symptom: LOW BEAM RELAY COIL SHORT TO VOLTAGE
- Symptom: PARK LAMP OUTPUT SHORT
- Symptom: RIGHT FOG LAMP OUTPUT OPEN
- Symptom: RIGHT FOG LAMP OUTPUT SHORTED
- Symptom: RIGHT HIGH BEAM OUTPUT OPEN
- Symptom: RIGHT HIGH BEAM OUTPUT SHORT
- Heating & A/C
- Symptom List: A/C SWITCH FAULT (ACTIVE); CHECKSUM FAILURE (ACTIVE); DEFOG SWITCH FAULT (ACTIVE)
- Symptom List: A/C SWITCH FAULT (STORED); BACKLIGHT DIMMING RX FAILURE (STORED); BLEND OVERCURRENT (STORED); CHECKSUM FAILURE (STORED); DEFOG SWITCH FAULT (STORED); LOOPBACK TEST FAILURE (STORED); MODE 1 OVERCURRENT (STORED); MODE 2 OVERCURRENT (STORED); RECIRC OVERCURRENT (STORED); REFRIGERANT PRESS RX FAILURE (STORED); TX FAILURE (STORED); VIN RX FAILURE (STORED)
- Notes
- When Monitored and Set Condition:
- A/C Switch Fault (Stored)
- Backlight Dimming RX Failure (Stored)
- Blend OVERCURRENT (Stored)
- Checksum Failure (Stored)
- Defog Switch Fault (Stored)
- LOOPBACK Test Failure (Stored)
- Mode 1 OVERCURRENT (Stored)
- Mode 2 OVERCURRENT (Stored)
- RECIRC OVERCURRENT (Stored)
- Refrigerant Press RX Failure (Stored)
- TX Failure (Stored)
- VIN RX Failure (Stored)
- Possible Causes
- Diagnostic Procedure
- Symptom List: ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE; BLEND CIRCUIT SHORTED TO GROUND; BLEND CIRCUIT SHORTED TO IGN OR BATT; COMMON DRIVER SHORTED TO GROUND; COMMON DRIVER SHORTED TO IGN OR BATT; MODE 1 CIRCUIT SHORTED TO GROUND; MODE 1 CIRCUIT SHORTED TO IGN OR BATT; MODE 2 CIRCUIT SHORTED TO GROUND; MODE 2 CIRCUIT SHORTED TO IGN OR BATT; RECIRC CIRCUIT SHORTED TO GROUND; RECIRC CIRCUIT SHORTED TO IGN OR BATT; SHORT TOO COMPLEX
- Notes
- When Monitored and Set Condition:
- Act CKT Test Passed, OVERCURRENT DTCS Active
- Blend Circuit Shorted To Ground
- Blend Circuit Shorted To IGN Or Batt
- Common Driver Shorted To Ground
- Common Driver Shorted To IGN Or Batt
- Mode 1 Circuit Shorted To Ground
- Mode 1 Circuit Shorted To IGN Or Batt
- Mode 2 Circuit Shorted To Ground
- Mode 2 Circuit Shorted To IGN Or Batt
- RECIRC Circuit Shorted To Ground
- RECIRC Circuit Shorted To IGN Or Batt
- Short Too Complex
- Possible Causes
- Diagnostic Procedure
- Symptom: BACKLIGHT DIMMING RX FAILURE (ACTIVE)
- Symptom List: BLEND CALIBRATION FAULT; MODE 1 CALIBRATION FAULT; MODE 2 CALIBRATION FAULT; RECIRCULATION CALIBRATION FAULT
- Symptom List: BLEND OVERCURRENT (ACTIVE); MODE 1 OVERCURRENT (ACTIVE); MODE 2 OVERCURRENT (ACTIVE); RECIRC OVERCURRENT (ACTIVE)
- Symptom: DEFOG RELAY CONTROL CKT SHORTED TO BATT
- Symptom: LOOPBACK TEST FAILURE (ACTIVE)
- Symptom List: REFRIGERANT PRESSURE RX FAILURE (ACTIVE); VIN RX FAILURE (ACTIVE)
- Symptom: TX FAILURE (ACTIVE)
- Symptom: *A/C - HEATER CONTROL ILLUMINATION INOPERATIVE
- Symptom: *BLEND/MODE/RECIRC DOOR OPERATION IMPROPER
- Symptom: *BLOWER MOTOR INOPERATIVE
- Symptom: *BLOWER MOTOR SPEEDS INCORRECT
- Symptom: *EBL STATUS INDICATOR FLASHING
- Symptom: *HVAC SYSTEM TEST
- Ignition, Power, Accessory
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT OPEN
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT SHORT TO GROUND
- Symptom: BCM - IGNITION MUX SWITCH INPUT MISMATCH
- Symptom: BCM - IGNITION MUX SWITCH INPUT OPEN
- Symptom: BCM - IGNITION MUX SWITCH INPUT SHORT
- Symptom: BCM - IGNITION RUN 1 SHORT
- Symptom: BCM - IGNITION RUN 2 SHORT
- Symptom: BCM - IOD OUTPUT CIRCUIT SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT OPEN / SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT SHORT TO VOLTAGE
- Symptom: BCM - RUN/START HARDWIRE INPUT MISMATCH
- Symptom: HORN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: HORN RELAY COIL SHORT TO BATTERY
- Symptom: HORN SWITCH STUCK
- Symptom: *HORNS INOPERATIVE
- Instrument Cluster
- Symptom List: ABS LAMP CIRCUIT OPEN; ABS LAMP CIRCUIT SHORTED; AIRBAG LAMP CIRCUIT OPEN; AIRBAG LAMP CIRCUIT SHORTED
- Symptom: ABS MESSAGES NOT RECEIVED
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT OPEN / SHORTED TO VOLTAGE
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT SHORT TO GROUND
- Symptom: BCM - PWM DIMMING OUTPUT SHORT
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: ORC MESSAGES NOT RECEIVED
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *GAUGE CLUSTER DIAGNOSTIC TEST
- Symptom: *INSTRUMENT CLUSTER DIAGNOSTIC TEST
- Interior Lighting
- Power Door Locks/RKE
- Symptom: DECKLID RELEASE OUTPUT OPEN
- Symptom: DECKLID RELEASE OUTPUT SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH OPEN OR SHORT TO VOLTAGE
- Symptom: DRIVER CYLINDER UNLOCK SWITCH SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH STUCK
- Symptom: DRIVER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: DRIVER DOOR LOCK SWITCH STUCK
- Symptom: DRIVER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: DRIVER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: DRIVER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER DOOR LOCK SWITCH STUCK
- Symptom: PASSENGER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER/DRIVER DOOR UNLATCH RETURN SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT OPEN/SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT SHORT TO BATTERY
- Symptom: *ALL DOOR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR UNLATCH INOPERATIVE
- Symptom: *PASSENGER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *PASSENGER DOOR UNLATCH INOPERATIVE
- Symptom: *REMOTE KEYLESS ENTRY PROBLEM
- Power Windows
- Symptom: DRIVER WINDOW DOWN OUTPUT SHORT TO GROUND
- Symptom: DRIVER WINDOW HALL EFFECT FAILURE
- Symptom: DRIVER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: DRIVER WINDOW SWITCH SHORT TO GROUND
- Symptom: DRIVER WINDOW SWITCH STUCK DOWN
- Symptom: DRIVER WINDOW SWITCH STUCK UP
- Symptom: DRIVER WINDOW UP OUTPUT SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL SHORT TO BATTERY
- Symptom: PASSENGER WINDOW HALL EFFECT FAILURE
- Symptom: PASSENGER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: PASSENGER WINDOW SWITCH SHORT TO GROUND
- Symptom: PASSENGER WINDOW SWITCH STUCK DOWN
- Symptom: PASSENGER WINDOW SWITCH STUCK UP
- Symptom: PASSENGER WINDOW UP SHORT TO GROUND
- Symptom: *DRIVER WINDOW INOPERATIVE
- Symptom: *PASSENGER WINDOW INOPERATIVE
- Tire Pressure Monitoring
- Symptom: CRITICAL TIRE PRESSURE - BCM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM
- Symptom: TIRE PRESSURE LOW - BCM
- Symptom: TIRE PRESSURE MONITOR MODULE FAILURE - TPM
- Symptom: TPM DIAGNOSTIC - BCM
- Symptom: TPM MODULE INITIALIZED - BCM
- Symptom: *LO TIRE LCD MESSAGE FLASHING
- Vehicle Theft/Security
- Symptom: VTSS INDICATOR OUTPUT OPEN
- Symptom: VTSS INDICATOR OUTPUT SHORT
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *DECKLID DOES NOT TRIP VTSS
- Symptom: *DRIVER DOOR DOES NOT TRIP VTSS
- Symptom: *EXTERIOR LAMPS FAIL TO FLASH WHEN ALARM IS TRIPPED
- Symptom: *HOOD DOES NOT TRIP VTSS
- Symptom: *HORN FAILS TO SOUND WHEN ALARM IS TRIPPED
- Symptom: *PASSENGER DOOR DOES NOT TRIP VTSS
- Symptom: *VTSS LAMP ON STEADY DURING ARMING
- Symptom: *VTSS WILL NOT ARM
- Verification Tests
- Airbag
- Component Locations
- Connector PINOUTS
- A/C-Heater Control C1 - Black 10 Way
- A/C-Heater Control C2 - Black 16 Way
- Airbag Control Module C1 (Orc) - Yellow 32 Way
- Airbag Control Module C2 (Orc) - Yellow 32 Way
- Airbag On/Off Switch-Passenger - Yellow 6 Way
- Airbag Squib 1-Driver - Yellow/Black 2 Way
- Airbag Squib 2-Driver - Yellow/Gray 2 Way
- Airbag Squib-Passenger - Yellow 4 Way
- Ajar Switch-DECKLID - Black 3 Way
- Ajar Switch-Driver Door - Black 4 Way
- Ajar Switch-Hood - Natural 3 Way
- Ajar Switch-Passenger Door - Black 4 Way
- Blend Door Actuator - Gray 2 Way
- Blower Motor - Orange 2 Way
- Blower Motor Resistor Block - Black 4 Way
- Body Control Module C1 - Black 6 Way
- Body Control Module C2 - Black/Green 34 Way
- Body Control Module C3 - Black/White 34 Way
- Body Control Module C4 - Black/Gray 34 Way
- Brake Fluid Level Switch - Black 2 Way
- C200 - Black (Body Side)
- C200 - Black (Instrument Panel Side)
- C201 - Yellow (Body Side)
- C201 - Yellow (Instrument Panel Side)
- C202 - Natural (Driver Door Side)
- C202 - Natural (Instrument Panel Side)
- C203 - Natural (Instrument Panel Side)
- C203 - Natural (Passenger Door Side)
- C204 - LT. Gray (HVAC Jumper Side)
- C204 - LT. Gray (Instrument Panel Side)
- C206 - Red (Console Jumper Side)
- C206 - Red (Instrument Panel Side)
- C207 - Green (Instrument Panel Side)
- C207 - Natural (Passenger Door Side)
- C208 - Green (Instrument Panel Side)
- C208 - Natural (Driver Door Side)
- C303 - Black (Body Side)
- C303 - Black (DECKLID Jumper Side)
- CLOCKSPRING - White 8 Way
- Controller Antilock Brake - Black 24 Way
- Cylinder Unlock Switch-Driver - Black 2 Way
- Data Link Connector - Black 16 Way
- DECKLID Release Motor - Black 2 Way
- Door Latch Motor-Driver - 2 Way
- Door Latch Motor-Passenger - 2 Way
- Door Lock Switch-Driver - Black 3 Way
- Door Lock Switch-Passenger - Black 3 Way
- Exterior Door Handle Switch-Driver - Black 2 Way
- Exterior Door Handle Switch-Passenger - Black 2 Way
- Fog Lamp-Left - Black 2 Way
- Gauge Cluster C1 - White 3 Way
- Gauge Cluster C2 - Black 20 Way
- Hid Lamp-Left - Gray 2 Way
- High Beam Headlamp-Left - Black 2 Way
- Horn Switch - Black 1 Way
- Horn-High Note - Black 2 Way
- Horn-Low Note - Black 2 Way
- Ignition Switch - Black 5 Way
- Instrument Cluster C1 - Black 16 Way
- Instrument Cluster C2 - Black 20 Way
- Interior Door Handle Switch-Driver - Black 2 Way
- Interior Door Handle Switch-Passenger - Black 2 Way
- Marker Lamp-Left Front - DK. Gray 2 Way
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way
- Multi-Function Switch - Gray 20 Way
- Power Distribution Center
- Power Window Motor-Driver - Black 6 Way
- Power Window Motor-Passenger - Black 6 Way
- Power Window Switch-Driver - Gray 3 Way
- Power Window Switch-Passenger - Gray 3 Way
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Radio - Gray 22 Way
- RECIRCULATION Door Actuator - Gray 2 Way
- Remote Keyless Entry Module - Black 6 Way
- Seat Belt Switch-Driver - White 2 Way
- Seat Belt Switch-Passenger - White 2 Way
- Seat Belt TENSIONER-Driver - Yellow 2 Way
- Seat Belt TENSIONER-Passenger - Yellow 2 Way
- Speaker-Left Door - Black 2 Way
- Speaker-Left Instrument Panel - White 2 Way
- Speaker-Left Rear - White 3 Way
- Speaker-Rear Woofer - Gray 4 Way
- Speaker-Right Door - Black 2 Way
- Speaker-Right Instrument Panel - White 2 Way
- Speaker-Right Rear - White 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Window Down Relay-Passenger - Black 5 Way
- Window Up Relay-Passenger - Black 5 Way
- Schematic Diagrams
- Airbag System
- Audio System
- Chime System
- Communication
- Door Ajar System
- Electrically Heated Systems
- Exterior Lighting
- Heating & A/C System
- Ignition, Power, Accessory
- Instrument Cluster/Gauge Cluster
- Interior Lighting
- Power Door Locks/RKE
- Power Window System
- Tire Pressure Monitor Module (TPM)
- Vehicle Theft Security System
- Lamp System & Lighting System - Interior
- Body Diagnostic Procedures
- Power Mirrors
- Seats
- Interior/Exterior
- Body
- Warning
- Diagnosis And Testing
- Standard Procedure
- Standard Procedure - Plastic Body Panel Repair
- Notes
- Rigid Plastics:
- Semi-Rigid Plastics:
- Flexible Plastics:
- Repair Procedure:
- Adhesion Promoter/Surface Modifier:
- Safety Precaution And Warnings
- Rigid, Semi-Rigid, And Flexible Plastic Parts Types
- Panel Sectioning
- Panel Reinforcement
- Visual Inspection
- Panel Surface Preparation
- Patching Panels
- Panel Patch Fabrications
- Panel Patch Installation
- Patched Panel Surfacing
- Standard Procedure - Heat Staking
- Standard Procedure - Plastic Body Panel Repair
- Specifications
- Special Tools
- Convertible Top
- DECKLID
- Door - Front
- Exterior
- Hood
- Instrument Panel
- Interior
- Paint
- Seats
- Stationary Glass
- Weatherstrip/Seals
- Body Structure
- Body
- Interior/Exterior
- Warning Systems
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Body Control Module
- Chime Warning System
- Communication
- Door Ajar System
- Exterior Lighting System
- Relays Controlled By The BCM
- Heating & A/C System
- Instrument Cluster / Gauge Cluster
- Interior Lighting
- Tire Pressure Monitoring System (TPMS)
- Power Door Entry System
- Power Windows
- Electrically Heated Systems
- Vehicle Theft Security System
- Using The DRBIII®
- DRBIII® Error Messages
- DRBIII® Does Not Power Up (Blank Screen)
- Display Is Not Visible
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; ACCELEROMETER 2; INTERNAL 1; OUTPUT DRIVER 1; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: DRIVER SQUIB 2 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 2 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 2 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 2 SHORT TO GROUND
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH OPEN
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO BATTERY
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO GROUND
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO BATTERY
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: PASSENGER SQUIB 2 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 2 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 2 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 2 SHORT TO GROUND
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom List: CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH BCM
- Chime
- Communication
- Symptom: ACM MESSAGES NOT RECEIVED
- Symptom: AUDIO MESSAGES NOT RECEIVED
- Symptom: COUNTRY CODE NOT PROGRAMMED
- Symptom: INTERNAL BCM FAILURE
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom List: PCI BUS SHORTED TO BATTERY; PCI BUS SHORTED TO GROUND
- Symptom: PCI INTERNAL FAULT
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM BODY CONTROL MODULE
- Symptom: *NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE
- Symptom: *NO RESPONSE FROM HVAC
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM PCM (PCI BUS)
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY)
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM TIRE PRESSURE MONITOR MODULE
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Door Ajar
- Symptom: *DECKLID AJAR CIRCUIT OPEN
- Symptom: *DECKLID AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *DRIVER DOOR AJAR CIRCUIT OPEN
- Symptom: *DRIVER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *HOOD AJAR CIRCUIT OPEN
- Symptom: *HOOD AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *PASSENGER DOOR AJAR CIRCUIT OPEN
- Symptom: *PASSENGER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Electrically Heated Systems
- Exterior Lighting
- Symptom: LEFT FOG LAMP OUTPUT OPEN
- Symptom: LEFT FOG LAMP OUTPUT SHORTED
- Symptom: LEFT HIGH BEAM OUTPUT OPEN
- Symptom: LEFT HIGH BEAM OUTPUT SHORT
- Symptom: LOW BEAM RELAY COIL OUTPUT OPEN/SHORT TO GROUND
- Symptom: LOW BEAM RELAY COIL SHORT TO VOLTAGE
- Symptom: PARK LAMP OUTPUT SHORT
- Symptom: RIGHT FOG LAMP OUTPUT OPEN
- Symptom: RIGHT FOG LAMP OUTPUT SHORTED
- Symptom: RIGHT HIGH BEAM OUTPUT OPEN
- Symptom: RIGHT HIGH BEAM OUTPUT SHORT
- Heating & A/C
- Symptom List: A/C SWITCH FAULT (ACTIVE); CHECKSUM FAILURE (ACTIVE); DEFOG SWITCH FAULT (ACTIVE)
- Symptom List: A/C SWITCH FAULT (STORED); BACKLIGHT DIMMING RX FAILURE (STORED); BLEND OVERCURRENT (STORED); CHECKSUM FAILURE (STORED); DEFOG SWITCH FAULT (STORED); LOOPBACK TEST FAILURE (STORED); MODE 1 OVERCURRENT (STORED); MODE 2 OVERCURRENT (STORED); RECIRC OVERCURRENT (STORED); REFRIGERANT PRESS RX FAILURE (STORED); TX FAILURE (STORED); VIN RX FAILURE (STORED)
- Notes
- When Monitored and Set Condition:
- A/C Switch Fault (Stored)
- Backlight Dimming RX Failure (Stored)
- Blend OVERCURRENT (Stored)
- Checksum Failure (Stored)
- Defog Switch Fault (Stored)
- LOOPBACK Test Failure (Stored)
- Mode 1 OVERCURRENT (Stored)
- Mode 2 OVERCURRENT (Stored)
- RECIRC OVERCURRENT (Stored)
- Refrigerant Press RX Failure (Stored)
- TX Failure (Stored)
- VIN RX Failure (Stored)
- Possible Causes
- Diagnostic Procedure
- Symptom List: ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE; BLEND CIRCUIT SHORTED TO GROUND; BLEND CIRCUIT SHORTED TO IGN OR BATT; COMMON DRIVER SHORTED TO GROUND; COMMON DRIVER SHORTED TO IGN OR BATT; MODE 1 CIRCUIT SHORTED TO GROUND; MODE 1 CIRCUIT SHORTED TO IGN OR BATT; MODE 2 CIRCUIT SHORTED TO GROUND; MODE 2 CIRCUIT SHORTED TO IGN OR BATT; RECIRC CIRCUIT SHORTED TO GROUND; RECIRC CIRCUIT SHORTED TO IGN OR BATT; SHORT TOO COMPLEX
- Notes
- When Monitored and Set Condition:
- Act CKT Test Passed, OVERCURRENT DTCS Active
- Blend Circuit Shorted To Ground
- Blend Circuit Shorted To IGN Or Batt
- Common Driver Shorted To Ground
- Common Driver Shorted To IGN Or Batt
- Mode 1 Circuit Shorted To Ground
- Mode 1 Circuit Shorted To IGN Or Batt
- Mode 2 Circuit Shorted To Ground
- Mode 2 Circuit Shorted To IGN Or Batt
- RECIRC Circuit Shorted To Ground
- RECIRC Circuit Shorted To IGN Or Batt
- Short Too Complex
- Possible Causes
- Diagnostic Procedure
- Symptom: BACKLIGHT DIMMING RX FAILURE (ACTIVE)
- Symptom List: BLEND CALIBRATION FAULT; MODE 1 CALIBRATION FAULT; MODE 2 CALIBRATION FAULT; RECIRCULATION CALIBRATION FAULT
- Symptom List: BLEND OVERCURRENT (ACTIVE); MODE 1 OVERCURRENT (ACTIVE); MODE 2 OVERCURRENT (ACTIVE); RECIRC OVERCURRENT (ACTIVE)
- Symptom: DEFOG RELAY CONTROL CKT SHORTED TO BATT
- Symptom: LOOPBACK TEST FAILURE (ACTIVE)
- Symptom List: REFRIGERANT PRESSURE RX FAILURE (ACTIVE); VIN RX FAILURE (ACTIVE)
- Symptom: TX FAILURE (ACTIVE)
- Symptom: *A/C - HEATER CONTROL ILLUMINATION INOPERATIVE
- Symptom: *BLEND/MODE/RECIRC DOOR OPERATION IMPROPER
- Symptom: *BLOWER MOTOR INOPERATIVE
- Symptom: *BLOWER MOTOR SPEEDS INCORRECT
- Symptom: *EBL STATUS INDICATOR FLASHING
- Symptom: *HVAC SYSTEM TEST
- Ignition, Power, Accessory
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT OPEN
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT SHORT TO GROUND
- Symptom: BCM - IGNITION MUX SWITCH INPUT MISMATCH
- Symptom: BCM - IGNITION MUX SWITCH INPUT OPEN
- Symptom: BCM - IGNITION MUX SWITCH INPUT SHORT
- Symptom: BCM - IGNITION RUN 1 SHORT
- Symptom: BCM - IGNITION RUN 2 SHORT
- Symptom: BCM - IOD OUTPUT CIRCUIT SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT OPEN / SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT SHORT TO VOLTAGE
- Symptom: BCM - RUN/START HARDWIRE INPUT MISMATCH
- Symptom: HORN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: HORN RELAY COIL SHORT TO BATTERY
- Symptom: HORN SWITCH STUCK
- Symptom: *HORNS INOPERATIVE
- Instrument Cluster
- Symptom List: ABS LAMP CIRCUIT OPEN; ABS LAMP CIRCUIT SHORTED; AIRBAG LAMP CIRCUIT OPEN; AIRBAG LAMP CIRCUIT SHORTED
- Symptom: ABS MESSAGES NOT RECEIVED
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT OPEN / SHORTED TO VOLTAGE
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT SHORT TO GROUND
- Symptom: BCM - PWM DIMMING OUTPUT SHORT
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: ORC MESSAGES NOT RECEIVED
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *GAUGE CLUSTER DIAGNOSTIC TEST
- Symptom: *INSTRUMENT CLUSTER DIAGNOSTIC TEST
- Interior Lighting
- Power Door Locks/RKE
- Symptom: DECKLID RELEASE OUTPUT OPEN
- Symptom: DECKLID RELEASE OUTPUT SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH OPEN OR SHORT TO VOLTAGE
- Symptom: DRIVER CYLINDER UNLOCK SWITCH SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH STUCK
- Symptom: DRIVER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: DRIVER DOOR LOCK SWITCH STUCK
- Symptom: DRIVER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: DRIVER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: DRIVER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER DOOR LOCK SWITCH STUCK
- Symptom: PASSENGER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER/DRIVER DOOR UNLATCH RETURN SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT OPEN/SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT SHORT TO BATTERY
- Symptom: *ALL DOOR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR UNLATCH INOPERATIVE
- Symptom: *PASSENGER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *PASSENGER DOOR UNLATCH INOPERATIVE
- Symptom: *REMOTE KEYLESS ENTRY PROBLEM
- Power Windows
- Symptom: DRIVER WINDOW DOWN OUTPUT SHORT TO GROUND
- Symptom: DRIVER WINDOW HALL EFFECT FAILURE
- Symptom: DRIVER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: DRIVER WINDOW SWITCH SHORT TO GROUND
- Symptom: DRIVER WINDOW SWITCH STUCK DOWN
- Symptom: DRIVER WINDOW SWITCH STUCK UP
- Symptom: DRIVER WINDOW UP OUTPUT SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL SHORT TO BATTERY
- Symptom: PASSENGER WINDOW HALL EFFECT FAILURE
- Symptom: PASSENGER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: PASSENGER WINDOW SWITCH SHORT TO GROUND
- Symptom: PASSENGER WINDOW SWITCH STUCK DOWN
- Symptom: PASSENGER WINDOW SWITCH STUCK UP
- Symptom: PASSENGER WINDOW UP SHORT TO GROUND
- Symptom: *DRIVER WINDOW INOPERATIVE
- Symptom: *PASSENGER WINDOW INOPERATIVE
- Tire Pressure Monitoring
- Symptom: CRITICAL TIRE PRESSURE - BCM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM
- Symptom: TIRE PRESSURE LOW - BCM
- Symptom: TIRE PRESSURE MONITOR MODULE FAILURE - TPM
- Symptom: TPM DIAGNOSTIC - BCM
- Symptom: TPM MODULE INITIALIZED - BCM
- Symptom: *LO TIRE LCD MESSAGE FLASHING
- Vehicle Theft/Security
- Symptom: VTSS INDICATOR OUTPUT OPEN
- Symptom: VTSS INDICATOR OUTPUT SHORT
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *DECKLID DOES NOT TRIP VTSS
- Symptom: *DRIVER DOOR DOES NOT TRIP VTSS
- Symptom: *EXTERIOR LAMPS FAIL TO FLASH WHEN ALARM IS TRIPPED
- Symptom: *HOOD DOES NOT TRIP VTSS
- Symptom: *HORN FAILS TO SOUND WHEN ALARM IS TRIPPED
- Symptom: *PASSENGER DOOR DOES NOT TRIP VTSS
- Symptom: *VTSS LAMP ON STEADY DURING ARMING
- Symptom: *VTSS WILL NOT ARM
- Verification Tests
- Airbag
- Component Locations
- Connector PINOUTS
- A/C-Heater Control C1 - Black 10 Way
- A/C-Heater Control C2 - Black 16 Way
- Airbag Control Module C1 (Orc) - Yellow 32 Way
- Airbag Control Module C2 (Orc) - Yellow 32 Way
- Airbag On/Off Switch-Passenger - Yellow 6 Way
- Airbag Squib 1-Driver - Yellow/Black 2 Way
- Airbag Squib 2-Driver - Yellow/Gray 2 Way
- Airbag Squib-Passenger - Yellow 4 Way
- Ajar Switch-DECKLID - Black 3 Way
- Ajar Switch-Driver Door - Black 4 Way
- Ajar Switch-Hood - Natural 3 Way
- Ajar Switch-Passenger Door - Black 4 Way
- Blend Door Actuator - Gray 2 Way
- Blower Motor - Orange 2 Way
- Blower Motor Resistor Block - Black 4 Way
- Body Control Module C1 - Black 6 Way
- Body Control Module C2 - Black/Green 34 Way
- Body Control Module C3 - Black/White 34 Way
- Body Control Module C4 - Black/Gray 34 Way
- Brake Fluid Level Switch - Black 2 Way
- C200 - Black (Body Side)
- C200 - Black (Instrument Panel Side)
- C201 - Yellow (Body Side)
- C201 - Yellow (Instrument Panel Side)
- C202 - Natural (Driver Door Side)
- C202 - Natural (Instrument Panel Side)
- C203 - Natural (Instrument Panel Side)
- C203 - Natural (Passenger Door Side)
- C204 - LT. Gray (HVAC Jumper Side)
- C204 - LT. Gray (Instrument Panel Side)
- C206 - Red (Console Jumper Side)
- C206 - Red (Instrument Panel Side)
- C207 - Green (Instrument Panel Side)
- C207 - Natural (Passenger Door Side)
- C208 - Green (Instrument Panel Side)
- C208 - Natural (Driver Door Side)
- C303 - Black (Body Side)
- C303 - Black (DECKLID Jumper Side)
- CLOCKSPRING - White 8 Way
- Controller Antilock Brake - Black 24 Way
- Cylinder Unlock Switch-Driver - Black 2 Way
- Data Link Connector - Black 16 Way
- DECKLID Release Motor - Black 2 Way
- Door Latch Motor-Driver - 2 Way
- Door Latch Motor-Passenger - 2 Way
- Door Lock Switch-Driver - Black 3 Way
- Door Lock Switch-Passenger - Black 3 Way
- Exterior Door Handle Switch-Driver - Black 2 Way
- Exterior Door Handle Switch-Passenger - Black 2 Way
- Fog Lamp-Left - Black 2 Way
- Gauge Cluster C1 - White 3 Way
- Gauge Cluster C2 - Black 20 Way
- Hid Lamp-Left - Gray 2 Way
- High Beam Headlamp-Left - Black 2 Way
- Horn Switch - Black 1 Way
- Horn-High Note - Black 2 Way
- Horn-Low Note - Black 2 Way
- Ignition Switch - Black 5 Way
- Instrument Cluster C1 - Black 16 Way
- Instrument Cluster C2 - Black 20 Way
- Interior Door Handle Switch-Driver - Black 2 Way
- Interior Door Handle Switch-Passenger - Black 2 Way
- Marker Lamp-Left Front - DK. Gray 2 Way
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way
- Multi-Function Switch - Gray 20 Way
- Power Distribution Center
- Power Window Motor-Driver - Black 6 Way
- Power Window Motor-Passenger - Black 6 Way
- Power Window Switch-Driver - Gray 3 Way
- Power Window Switch-Passenger - Gray 3 Way
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Radio - Gray 22 Way
- RECIRCULATION Door Actuator - Gray 2 Way
- Remote Keyless Entry Module - Black 6 Way
- Seat Belt Switch-Driver - White 2 Way
- Seat Belt Switch-Passenger - White 2 Way
- Seat Belt TENSIONER-Driver - Yellow 2 Way
- Seat Belt TENSIONER-Passenger - Yellow 2 Way
- Speaker-Left Door - Black 2 Way
- Speaker-Left Instrument Panel - White 2 Way
- Speaker-Left Rear - White 3 Way
- Speaker-Rear Woofer - Gray 4 Way
- Speaker-Right Door - Black 2 Way
- Speaker-Right Instrument Panel - White 2 Way
- Speaker-Right Rear - White 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Window Down Relay-Passenger - Black 5 Way
- Window Up Relay-Passenger - Black 5 Way
- Schematic Diagrams
- Airbag System
- Audio System
- Chime System
- Communication
- Door Ajar System
- Electrically Heated Systems
- Exterior Lighting
- Heating & A/C System
- Ignition, Power, Accessory
- Instrument Cluster/Gauge Cluster
- Interior Lighting
- Power Door Locks/RKE
- Power Window System
- Tire Pressure Monitor Module (TPM)
- Vehicle Theft Security System
- Chime/Buzzer
- Chime/Buzzer
- Description
- Operation
- Airbag Warning
- Antilock Brake Warning
- Critical Coolant Temperature Warning
- Critical Oil Temperature Warning
- Deck Lid Ajar Reminder
- Dome Lamps On Reminder
- Door Ajar Warning
- Enhanced Seat Belt Reminder
- Fasten Seat Belt Reminder
- Headlamps Reminder
- Key In Ignition Reminder
- Low Fuel Reminder
- Park Brake/Low Brake Fluid Warning
- Service Engine Soon Warning
- Tire Pressure System Warning
- Under/Over Voltage Warning
- Warning Lamp Announcement
- Diagnosis And Testing
- Chime/Buzzer
- Body Diagnostic Procedures
- Window Motors & Regulators
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Body Control Module
- Chime Warning System
- Communication
- Door Ajar System
- Exterior Lighting System
- Relays Controlled By The BCM
- Heating & A/C System
- Instrument Cluster / Gauge Cluster
- Interior Lighting
- Tire Pressure Monitoring System (TPMS)
- Power Door Entry System
- Power Windows
- Electrically Heated Systems
- Vehicle Theft Security System
- Using The DRBIII®
- DRBIII® Error Messages
- DRBIII® Does Not Power Up (Blank Screen)
- Display Is Not Visible
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; ACCELEROMETER 2; INTERNAL 1; OUTPUT DRIVER 1; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: DRIVER SQUIB 2 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 2 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 2 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 2 SHORT TO GROUND
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH OPEN
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO BATTERY
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO GROUND
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO BATTERY
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: PASSENGER SQUIB 2 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 2 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 2 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 2 SHORT TO GROUND
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom List: CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH BCM
- Chime
- Communication
- Symptom: ACM MESSAGES NOT RECEIVED
- Symptom: AUDIO MESSAGES NOT RECEIVED
- Symptom: COUNTRY CODE NOT PROGRAMMED
- Symptom: INTERNAL BCM FAILURE
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom List: PCI BUS SHORTED TO BATTERY; PCI BUS SHORTED TO GROUND
- Symptom: PCI INTERNAL FAULT
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM BODY CONTROL MODULE
- Symptom: *NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE
- Symptom: *NO RESPONSE FROM HVAC
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM PCM (PCI BUS)
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY)
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM TIRE PRESSURE MONITOR MODULE
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Door Ajar
- Symptom: *DECKLID AJAR CIRCUIT OPEN
- Symptom: *DECKLID AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *DRIVER DOOR AJAR CIRCUIT OPEN
- Symptom: *DRIVER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *HOOD AJAR CIRCUIT OPEN
- Symptom: *HOOD AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *PASSENGER DOOR AJAR CIRCUIT OPEN
- Symptom: *PASSENGER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Electrically Heated Systems
- Exterior Lighting
- Symptom: LEFT FOG LAMP OUTPUT OPEN
- Symptom: LEFT FOG LAMP OUTPUT SHORTED
- Symptom: LEFT HIGH BEAM OUTPUT OPEN
- Symptom: LEFT HIGH BEAM OUTPUT SHORT
- Symptom: LOW BEAM RELAY COIL OUTPUT OPEN/SHORT TO GROUND
- Symptom: LOW BEAM RELAY COIL SHORT TO VOLTAGE
- Symptom: PARK LAMP OUTPUT SHORT
- Symptom: RIGHT FOG LAMP OUTPUT OPEN
- Symptom: RIGHT FOG LAMP OUTPUT SHORTED
- Symptom: RIGHT HIGH BEAM OUTPUT OPEN
- Symptom: RIGHT HIGH BEAM OUTPUT SHORT
- Heating & A/C
- Symptom List: A/C SWITCH FAULT (ACTIVE); CHECKSUM FAILURE (ACTIVE); DEFOG SWITCH FAULT (ACTIVE)
- Symptom List: A/C SWITCH FAULT (STORED); BACKLIGHT DIMMING RX FAILURE (STORED); BLEND OVERCURRENT (STORED); CHECKSUM FAILURE (STORED); DEFOG SWITCH FAULT (STORED); LOOPBACK TEST FAILURE (STORED); MODE 1 OVERCURRENT (STORED); MODE 2 OVERCURRENT (STORED); RECIRC OVERCURRENT (STORED); REFRIGERANT PRESS RX FAILURE (STORED); TX FAILURE (STORED); VIN RX FAILURE (STORED)
- Notes
- When Monitored and Set Condition:
- A/C Switch Fault (Stored)
- Backlight Dimming RX Failure (Stored)
- Blend OVERCURRENT (Stored)
- Checksum Failure (Stored)
- Defog Switch Fault (Stored)
- LOOPBACK Test Failure (Stored)
- Mode 1 OVERCURRENT (Stored)
- Mode 2 OVERCURRENT (Stored)
- RECIRC OVERCURRENT (Stored)
- Refrigerant Press RX Failure (Stored)
- TX Failure (Stored)
- VIN RX Failure (Stored)
- Possible Causes
- Diagnostic Procedure
- Symptom List: ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE; BLEND CIRCUIT SHORTED TO GROUND; BLEND CIRCUIT SHORTED TO IGN OR BATT; COMMON DRIVER SHORTED TO GROUND; COMMON DRIVER SHORTED TO IGN OR BATT; MODE 1 CIRCUIT SHORTED TO GROUND; MODE 1 CIRCUIT SHORTED TO IGN OR BATT; MODE 2 CIRCUIT SHORTED TO GROUND; MODE 2 CIRCUIT SHORTED TO IGN OR BATT; RECIRC CIRCUIT SHORTED TO GROUND; RECIRC CIRCUIT SHORTED TO IGN OR BATT; SHORT TOO COMPLEX
- Notes
- When Monitored and Set Condition:
- Act CKT Test Passed, OVERCURRENT DTCS Active
- Blend Circuit Shorted To Ground
- Blend Circuit Shorted To IGN Or Batt
- Common Driver Shorted To Ground
- Common Driver Shorted To IGN Or Batt
- Mode 1 Circuit Shorted To Ground
- Mode 1 Circuit Shorted To IGN Or Batt
- Mode 2 Circuit Shorted To Ground
- Mode 2 Circuit Shorted To IGN Or Batt
- RECIRC Circuit Shorted To Ground
- RECIRC Circuit Shorted To IGN Or Batt
- Short Too Complex
- Possible Causes
- Diagnostic Procedure
- Symptom: BACKLIGHT DIMMING RX FAILURE (ACTIVE)
- Symptom List: BLEND CALIBRATION FAULT; MODE 1 CALIBRATION FAULT; MODE 2 CALIBRATION FAULT; RECIRCULATION CALIBRATION FAULT
- Symptom List: BLEND OVERCURRENT (ACTIVE); MODE 1 OVERCURRENT (ACTIVE); MODE 2 OVERCURRENT (ACTIVE); RECIRC OVERCURRENT (ACTIVE)
- Symptom: DEFOG RELAY CONTROL CKT SHORTED TO BATT
- Symptom: LOOPBACK TEST FAILURE (ACTIVE)
- Symptom List: REFRIGERANT PRESSURE RX FAILURE (ACTIVE); VIN RX FAILURE (ACTIVE)
- Symptom: TX FAILURE (ACTIVE)
- Symptom: *A/C - HEATER CONTROL ILLUMINATION INOPERATIVE
- Symptom: *BLEND/MODE/RECIRC DOOR OPERATION IMPROPER
- Symptom: *BLOWER MOTOR INOPERATIVE
- Symptom: *BLOWER MOTOR SPEEDS INCORRECT
- Symptom: *EBL STATUS INDICATOR FLASHING
- Symptom: *HVAC SYSTEM TEST
- Ignition, Power, Accessory
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT OPEN
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT SHORT TO GROUND
- Symptom: BCM - IGNITION MUX SWITCH INPUT MISMATCH
- Symptom: BCM - IGNITION MUX SWITCH INPUT OPEN
- Symptom: BCM - IGNITION MUX SWITCH INPUT SHORT
- Symptom: BCM - IGNITION RUN 1 SHORT
- Symptom: BCM - IGNITION RUN 2 SHORT
- Symptom: BCM - IOD OUTPUT CIRCUIT SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT OPEN / SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT SHORT TO VOLTAGE
- Symptom: BCM - RUN/START HARDWIRE INPUT MISMATCH
- Symptom: HORN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: HORN RELAY COIL SHORT TO BATTERY
- Symptom: HORN SWITCH STUCK
- Symptom: *HORNS INOPERATIVE
- Instrument Cluster
- Symptom List: ABS LAMP CIRCUIT OPEN; ABS LAMP CIRCUIT SHORTED; AIRBAG LAMP CIRCUIT OPEN; AIRBAG LAMP CIRCUIT SHORTED
- Symptom: ABS MESSAGES NOT RECEIVED
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT OPEN / SHORTED TO VOLTAGE
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT SHORT TO GROUND
- Symptom: BCM - PWM DIMMING OUTPUT SHORT
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: ORC MESSAGES NOT RECEIVED
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *GAUGE CLUSTER DIAGNOSTIC TEST
- Symptom: *INSTRUMENT CLUSTER DIAGNOSTIC TEST
- Interior Lighting
- Power Door Locks/RKE
- Symptom: DECKLID RELEASE OUTPUT OPEN
- Symptom: DECKLID RELEASE OUTPUT SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH OPEN OR SHORT TO VOLTAGE
- Symptom: DRIVER CYLINDER UNLOCK SWITCH SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH STUCK
- Symptom: DRIVER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: DRIVER DOOR LOCK SWITCH STUCK
- Symptom: DRIVER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: DRIVER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: DRIVER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER DOOR LOCK SWITCH STUCK
- Symptom: PASSENGER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER/DRIVER DOOR UNLATCH RETURN SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT OPEN/SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT SHORT TO BATTERY
- Symptom: *ALL DOOR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR UNLATCH INOPERATIVE
- Symptom: *PASSENGER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *PASSENGER DOOR UNLATCH INOPERATIVE
- Symptom: *REMOTE KEYLESS ENTRY PROBLEM
- Power Windows
- Symptom: DRIVER WINDOW DOWN OUTPUT SHORT TO GROUND
- Symptom: DRIVER WINDOW HALL EFFECT FAILURE
- Symptom: DRIVER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: DRIVER WINDOW SWITCH SHORT TO GROUND
- Symptom: DRIVER WINDOW SWITCH STUCK DOWN
- Symptom: DRIVER WINDOW SWITCH STUCK UP
- Symptom: DRIVER WINDOW UP OUTPUT SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL SHORT TO BATTERY
- Symptom: PASSENGER WINDOW HALL EFFECT FAILURE
- Symptom: PASSENGER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: PASSENGER WINDOW SWITCH SHORT TO GROUND
- Symptom: PASSENGER WINDOW SWITCH STUCK DOWN
- Symptom: PASSENGER WINDOW SWITCH STUCK UP
- Symptom: PASSENGER WINDOW UP SHORT TO GROUND
- Symptom: *DRIVER WINDOW INOPERATIVE
- Symptom: *PASSENGER WINDOW INOPERATIVE
- Tire Pressure Monitoring
- Symptom: CRITICAL TIRE PRESSURE - BCM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM
- Symptom: TIRE PRESSURE LOW - BCM
- Symptom: TIRE PRESSURE MONITOR MODULE FAILURE - TPM
- Symptom: TPM DIAGNOSTIC - BCM
- Symptom: TPM MODULE INITIALIZED - BCM
- Symptom: *LO TIRE LCD MESSAGE FLASHING
- Vehicle Theft/Security
- Symptom: VTSS INDICATOR OUTPUT OPEN
- Symptom: VTSS INDICATOR OUTPUT SHORT
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *DECKLID DOES NOT TRIP VTSS
- Symptom: *DRIVER DOOR DOES NOT TRIP VTSS
- Symptom: *EXTERIOR LAMPS FAIL TO FLASH WHEN ALARM IS TRIPPED
- Symptom: *HOOD DOES NOT TRIP VTSS
- Symptom: *HORN FAILS TO SOUND WHEN ALARM IS TRIPPED
- Symptom: *PASSENGER DOOR DOES NOT TRIP VTSS
- Symptom: *VTSS LAMP ON STEADY DURING ARMING
- Symptom: *VTSS WILL NOT ARM
- Verification Tests
- Airbag
- Component Locations
- Connector PINOUTS
- A/C-Heater Control C1 - Black 10 Way
- A/C-Heater Control C2 - Black 16 Way
- Airbag Control Module C1 (Orc) - Yellow 32 Way
- Airbag Control Module C2 (Orc) - Yellow 32 Way
- Airbag On/Off Switch-Passenger - Yellow 6 Way
- Airbag Squib 1-Driver - Yellow/Black 2 Way
- Airbag Squib 2-Driver - Yellow/Gray 2 Way
- Airbag Squib-Passenger - Yellow 4 Way
- Ajar Switch-DECKLID - Black 3 Way
- Ajar Switch-Driver Door - Black 4 Way
- Ajar Switch-Hood - Natural 3 Way
- Ajar Switch-Passenger Door - Black 4 Way
- Blend Door Actuator - Gray 2 Way
- Blower Motor - Orange 2 Way
- Blower Motor Resistor Block - Black 4 Way
- Body Control Module C1 - Black 6 Way
- Body Control Module C2 - Black/Green 34 Way
- Body Control Module C3 - Black/White 34 Way
- Body Control Module C4 - Black/Gray 34 Way
- Brake Fluid Level Switch - Black 2 Way
- C200 - Black (Body Side)
- C200 - Black (Instrument Panel Side)
- C201 - Yellow (Body Side)
- C201 - Yellow (Instrument Panel Side)
- C202 - Natural (Driver Door Side)
- C202 - Natural (Instrument Panel Side)
- C203 - Natural (Instrument Panel Side)
- C203 - Natural (Passenger Door Side)
- C204 - LT. Gray (HVAC Jumper Side)
- C204 - LT. Gray (Instrument Panel Side)
- C206 - Red (Console Jumper Side)
- C206 - Red (Instrument Panel Side)
- C207 - Green (Instrument Panel Side)
- C207 - Natural (Passenger Door Side)
- C208 - Green (Instrument Panel Side)
- C208 - Natural (Driver Door Side)
- C303 - Black (Body Side)
- C303 - Black (DECKLID Jumper Side)
- CLOCKSPRING - White 8 Way
- Controller Antilock Brake - Black 24 Way
- Cylinder Unlock Switch-Driver - Black 2 Way
- Data Link Connector - Black 16 Way
- DECKLID Release Motor - Black 2 Way
- Door Latch Motor-Driver - 2 Way
- Door Latch Motor-Passenger - 2 Way
- Door Lock Switch-Driver - Black 3 Way
- Door Lock Switch-Passenger - Black 3 Way
- Exterior Door Handle Switch-Driver - Black 2 Way
- Exterior Door Handle Switch-Passenger - Black 2 Way
- Fog Lamp-Left - Black 2 Way
- Gauge Cluster C1 - White 3 Way
- Gauge Cluster C2 - Black 20 Way
- Hid Lamp-Left - Gray 2 Way
- High Beam Headlamp-Left - Black 2 Way
- Horn Switch - Black 1 Way
- Horn-High Note - Black 2 Way
- Horn-Low Note - Black 2 Way
- Ignition Switch - Black 5 Way
- Instrument Cluster C1 - Black 16 Way
- Instrument Cluster C2 - Black 20 Way
- Interior Door Handle Switch-Driver - Black 2 Way
- Interior Door Handle Switch-Passenger - Black 2 Way
- Marker Lamp-Left Front - DK. Gray 2 Way
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way
- Multi-Function Switch - Gray 20 Way
- Power Distribution Center
- Power Window Motor-Driver - Black 6 Way
- Power Window Motor-Passenger - Black 6 Way
- Power Window Switch-Driver - Gray 3 Way
- Power Window Switch-Passenger - Gray 3 Way
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Radio - Gray 22 Way
- RECIRCULATION Door Actuator - Gray 2 Way
- Remote Keyless Entry Module - Black 6 Way
- Seat Belt Switch-Driver - White 2 Way
- Seat Belt Switch-Passenger - White 2 Way
- Seat Belt TENSIONER-Driver - Yellow 2 Way
- Seat Belt TENSIONER-Passenger - Yellow 2 Way
- Speaker-Left Door - Black 2 Way
- Speaker-Left Instrument Panel - White 2 Way
- Speaker-Left Rear - White 3 Way
- Speaker-Rear Woofer - Gray 4 Way
- Speaker-Right Door - Black 2 Way
- Speaker-Right Instrument Panel - White 2 Way
- Speaker-Right Rear - White 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Window Down Relay-Passenger - Black 5 Way
- Window Up Relay-Passenger - Black 5 Way
- Schematic Diagrams
- Airbag System
- Audio System
- Chime System
- Communication
- Door Ajar System
- Electrically Heated Systems
- Exterior Lighting
- Heating & A/C System
- Ignition, Power, Accessory
- Instrument Cluster/Gauge Cluster
- Interior Lighting
- Power Door Locks/RKE
- Power Window System
- Tire Pressure Monitor Module (TPM)
- Vehicle Theft Security System
- Interior/Exterior
- Body
- Warning
- Diagnosis And Testing
- Standard Procedure
- Standard Procedure - Plastic Body Panel Repair
- Notes
- Rigid Plastics:
- Semi-Rigid Plastics:
- Flexible Plastics:
- Repair Procedure:
- Adhesion Promoter/Surface Modifier:
- Safety Precaution And Warnings
- Rigid, Semi-Rigid, And Flexible Plastic Parts Types
- Panel Sectioning
- Panel Reinforcement
- Visual Inspection
- Panel Surface Preparation
- Patching Panels
- Panel Patch Fabrications
- Panel Patch Installation
- Patched Panel Surfacing
- Standard Procedure - Heat Staking
- Standard Procedure - Plastic Body Panel Repair
- Specifications
- Special Tools
- Convertible Top
- DECKLID
- Door - Front
- Exterior
- Hood
- Instrument Panel
- Interior
- Paint
- Seats
- Stationary Glass
- Weatherstrip/Seals
- Body Structure
- Body
- Power Window System
- Body Diagnostic Procedures
- Wiper/Washer Systems
- Wiper System & Washer System (Service Information)
- Wipers/Washers
- Description
- Operation
- Diagnosis And Testing
- Diagnosis And Testing - Wipers/Washers
- Notes
- Motor Will Not Operate All Switch Positions
- Motor Operates Slowly At All Speeds
- Wipers Run At High Speed With Switch In Low Speed Position Or Wipers Run At Low Speed With Switch In High Speed Position.
- Wipers Will Operate Continuously With The Switch In The Intermittent Position - When Wiper Switch Is Turned Off, Wipers Stop Wherever They Are Without Returning To Park Position.
- Wipers Do Not Operate When Washer Motor Is Engaged (Pulse Wipe) Or Wipers Do Operate In Intermittent Position.
- Washer System Diagnosis
- Diagnosis And Testing - Wipers/Washers
- Washer Hoses / Tubes
- Washer Nozzle
- Washer Pump Motor
- Washer Reservoir
- Wiper Arms
- Wiper Blades
- Wiper Module
- Wiper Motor
- Wiper/Washer Switch
- Wipers/Washers
- Wiper System & Washer System (Service Information)
- Anti-Theft Systems
- Body & Frame
- Body, Cab Control Systems
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Body Control Module
- Chime Warning System
- Communication
- Door Ajar System
- Exterior Lighting System
- Relays Controlled By The BCM
- Heating & A/C System
- Instrument Cluster / Gauge Cluster
- Interior Lighting
- Tire Pressure Monitoring System (TPMS)
- Power Door Entry System
- Power Windows
- Electrically Heated Systems
- Vehicle Theft Security System
- Using The DRBIII®
- DRBIII® Error Messages
- DRBIII® Does Not Power Up (Blank Screen)
- Display Is Not Visible
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; ACCELEROMETER 2; INTERNAL 1; OUTPUT DRIVER 1; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: DRIVER SQUIB 2 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 2 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 2 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 2 SHORT TO GROUND
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH OPEN
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO BATTERY
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO GROUND
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO BATTERY
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: PASSENGER SQUIB 2 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 2 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 2 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 2 SHORT TO GROUND
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom List: CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH BCM
- Chime
- Communication
- Symptom: ACM MESSAGES NOT RECEIVED
- Symptom: AUDIO MESSAGES NOT RECEIVED
- Symptom: COUNTRY CODE NOT PROGRAMMED
- Symptom: INTERNAL BCM FAILURE
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom List: PCI BUS SHORTED TO BATTERY; PCI BUS SHORTED TO GROUND
- Symptom: PCI INTERNAL FAULT
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM BODY CONTROL MODULE
- Symptom: *NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE
- Symptom: *NO RESPONSE FROM HVAC
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM PCM (PCI BUS)
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY)
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM TIRE PRESSURE MONITOR MODULE
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Door Ajar
- Symptom: *DECKLID AJAR CIRCUIT OPEN
- Symptom: *DECKLID AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *DRIVER DOOR AJAR CIRCUIT OPEN
- Symptom: *DRIVER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *HOOD AJAR CIRCUIT OPEN
- Symptom: *HOOD AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *PASSENGER DOOR AJAR CIRCUIT OPEN
- Symptom: *PASSENGER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Electrically Heated Systems
- Exterior Lighting
- Symptom: LEFT FOG LAMP OUTPUT OPEN
- Symptom: LEFT FOG LAMP OUTPUT SHORTED
- Symptom: LEFT HIGH BEAM OUTPUT OPEN
- Symptom: LEFT HIGH BEAM OUTPUT SHORT
- Symptom: LOW BEAM RELAY COIL OUTPUT OPEN/SHORT TO GROUND
- Symptom: LOW BEAM RELAY COIL SHORT TO VOLTAGE
- Symptom: PARK LAMP OUTPUT SHORT
- Symptom: RIGHT FOG LAMP OUTPUT OPEN
- Symptom: RIGHT FOG LAMP OUTPUT SHORTED
- Symptom: RIGHT HIGH BEAM OUTPUT OPEN
- Symptom: RIGHT HIGH BEAM OUTPUT SHORT
- Heating & A/C
- Symptom List: A/C SWITCH FAULT (ACTIVE); CHECKSUM FAILURE (ACTIVE); DEFOG SWITCH FAULT (ACTIVE)
- Symptom List: A/C SWITCH FAULT (STORED); BACKLIGHT DIMMING RX FAILURE (STORED); BLEND OVERCURRENT (STORED); CHECKSUM FAILURE (STORED); DEFOG SWITCH FAULT (STORED); LOOPBACK TEST FAILURE (STORED); MODE 1 OVERCURRENT (STORED); MODE 2 OVERCURRENT (STORED); RECIRC OVERCURRENT (STORED); REFRIGERANT PRESS RX FAILURE (STORED); TX FAILURE (STORED); VIN RX FAILURE (STORED)
- Notes
- When Monitored and Set Condition:
- A/C Switch Fault (Stored)
- Backlight Dimming RX Failure (Stored)
- Blend OVERCURRENT (Stored)
- Checksum Failure (Stored)
- Defog Switch Fault (Stored)
- LOOPBACK Test Failure (Stored)
- Mode 1 OVERCURRENT (Stored)
- Mode 2 OVERCURRENT (Stored)
- RECIRC OVERCURRENT (Stored)
- Refrigerant Press RX Failure (Stored)
- TX Failure (Stored)
- VIN RX Failure (Stored)
- Possible Causes
- Diagnostic Procedure
- Symptom List: ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE; BLEND CIRCUIT SHORTED TO GROUND; BLEND CIRCUIT SHORTED TO IGN OR BATT; COMMON DRIVER SHORTED TO GROUND; COMMON DRIVER SHORTED TO IGN OR BATT; MODE 1 CIRCUIT SHORTED TO GROUND; MODE 1 CIRCUIT SHORTED TO IGN OR BATT; MODE 2 CIRCUIT SHORTED TO GROUND; MODE 2 CIRCUIT SHORTED TO IGN OR BATT; RECIRC CIRCUIT SHORTED TO GROUND; RECIRC CIRCUIT SHORTED TO IGN OR BATT; SHORT TOO COMPLEX
- Notes
- When Monitored and Set Condition:
- Act CKT Test Passed, OVERCURRENT DTCS Active
- Blend Circuit Shorted To Ground
- Blend Circuit Shorted To IGN Or Batt
- Common Driver Shorted To Ground
- Common Driver Shorted To IGN Or Batt
- Mode 1 Circuit Shorted To Ground
- Mode 1 Circuit Shorted To IGN Or Batt
- Mode 2 Circuit Shorted To Ground
- Mode 2 Circuit Shorted To IGN Or Batt
- RECIRC Circuit Shorted To Ground
- RECIRC Circuit Shorted To IGN Or Batt
- Short Too Complex
- Possible Causes
- Diagnostic Procedure
- Symptom: BACKLIGHT DIMMING RX FAILURE (ACTIVE)
- Symptom List: BLEND CALIBRATION FAULT; MODE 1 CALIBRATION FAULT; MODE 2 CALIBRATION FAULT; RECIRCULATION CALIBRATION FAULT
- Symptom List: BLEND OVERCURRENT (ACTIVE); MODE 1 OVERCURRENT (ACTIVE); MODE 2 OVERCURRENT (ACTIVE); RECIRC OVERCURRENT (ACTIVE)
- Symptom: DEFOG RELAY CONTROL CKT SHORTED TO BATT
- Symptom: LOOPBACK TEST FAILURE (ACTIVE)
- Symptom List: REFRIGERANT PRESSURE RX FAILURE (ACTIVE); VIN RX FAILURE (ACTIVE)
- Symptom: TX FAILURE (ACTIVE)
- Symptom: *A/C - HEATER CONTROL ILLUMINATION INOPERATIVE
- Symptom: *BLEND/MODE/RECIRC DOOR OPERATION IMPROPER
- Symptom: *BLOWER MOTOR INOPERATIVE
- Symptom: *BLOWER MOTOR SPEEDS INCORRECT
- Symptom: *EBL STATUS INDICATOR FLASHING
- Symptom: *HVAC SYSTEM TEST
- Ignition, Power, Accessory
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT OPEN
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT SHORT TO GROUND
- Symptom: BCM - IGNITION MUX SWITCH INPUT MISMATCH
- Symptom: BCM - IGNITION MUX SWITCH INPUT OPEN
- Symptom: BCM - IGNITION MUX SWITCH INPUT SHORT
- Symptom: BCM - IGNITION RUN 1 SHORT
- Symptom: BCM - IGNITION RUN 2 SHORT
- Symptom: BCM - IOD OUTPUT CIRCUIT SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT OPEN / SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT SHORT TO VOLTAGE
- Symptom: BCM - RUN/START HARDWIRE INPUT MISMATCH
- Symptom: HORN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: HORN RELAY COIL SHORT TO BATTERY
- Symptom: HORN SWITCH STUCK
- Symptom: *HORNS INOPERATIVE
- Instrument Cluster
- Symptom List: ABS LAMP CIRCUIT OPEN; ABS LAMP CIRCUIT SHORTED; AIRBAG LAMP CIRCUIT OPEN; AIRBAG LAMP CIRCUIT SHORTED
- Symptom: ABS MESSAGES NOT RECEIVED
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT OPEN / SHORTED TO VOLTAGE
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT SHORT TO GROUND
- Symptom: BCM - PWM DIMMING OUTPUT SHORT
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: ORC MESSAGES NOT RECEIVED
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *GAUGE CLUSTER DIAGNOSTIC TEST
- Symptom: *INSTRUMENT CLUSTER DIAGNOSTIC TEST
- Interior Lighting
- Power Door Locks/RKE
- Symptom: DECKLID RELEASE OUTPUT OPEN
- Symptom: DECKLID RELEASE OUTPUT SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH OPEN OR SHORT TO VOLTAGE
- Symptom: DRIVER CYLINDER UNLOCK SWITCH SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH STUCK
- Symptom: DRIVER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: DRIVER DOOR LOCK SWITCH STUCK
- Symptom: DRIVER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: DRIVER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: DRIVER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER DOOR LOCK SWITCH STUCK
- Symptom: PASSENGER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER/DRIVER DOOR UNLATCH RETURN SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT OPEN/SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT SHORT TO BATTERY
- Symptom: *ALL DOOR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR UNLATCH INOPERATIVE
- Symptom: *PASSENGER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *PASSENGER DOOR UNLATCH INOPERATIVE
- Symptom: *REMOTE KEYLESS ENTRY PROBLEM
- Power Windows
- Symptom: DRIVER WINDOW DOWN OUTPUT SHORT TO GROUND
- Symptom: DRIVER WINDOW HALL EFFECT FAILURE
- Symptom: DRIVER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: DRIVER WINDOW SWITCH SHORT TO GROUND
- Symptom: DRIVER WINDOW SWITCH STUCK DOWN
- Symptom: DRIVER WINDOW SWITCH STUCK UP
- Symptom: DRIVER WINDOW UP OUTPUT SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL SHORT TO BATTERY
- Symptom: PASSENGER WINDOW HALL EFFECT FAILURE
- Symptom: PASSENGER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: PASSENGER WINDOW SWITCH SHORT TO GROUND
- Symptom: PASSENGER WINDOW SWITCH STUCK DOWN
- Symptom: PASSENGER WINDOW SWITCH STUCK UP
- Symptom: PASSENGER WINDOW UP SHORT TO GROUND
- Symptom: *DRIVER WINDOW INOPERATIVE
- Symptom: *PASSENGER WINDOW INOPERATIVE
- Tire Pressure Monitoring
- Symptom: CRITICAL TIRE PRESSURE - BCM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM
- Symptom: TIRE PRESSURE LOW - BCM
- Symptom: TIRE PRESSURE MONITOR MODULE FAILURE - TPM
- Symptom: TPM DIAGNOSTIC - BCM
- Symptom: TPM MODULE INITIALIZED - BCM
- Symptom: *LO TIRE LCD MESSAGE FLASHING
- Vehicle Theft/Security
- Symptom: VTSS INDICATOR OUTPUT OPEN
- Symptom: VTSS INDICATOR OUTPUT SHORT
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *DECKLID DOES NOT TRIP VTSS
- Symptom: *DRIVER DOOR DOES NOT TRIP VTSS
- Symptom: *EXTERIOR LAMPS FAIL TO FLASH WHEN ALARM IS TRIPPED
- Symptom: *HOOD DOES NOT TRIP VTSS
- Symptom: *HORN FAILS TO SOUND WHEN ALARM IS TRIPPED
- Symptom: *PASSENGER DOOR DOES NOT TRIP VTSS
- Symptom: *VTSS LAMP ON STEADY DURING ARMING
- Symptom: *VTSS WILL NOT ARM
- Verification Tests
- Airbag
- Component Locations
- Connector PINOUTS
- A/C-Heater Control C1 - Black 10 Way
- A/C-Heater Control C2 - Black 16 Way
- Airbag Control Module C1 (Orc) - Yellow 32 Way
- Airbag Control Module C2 (Orc) - Yellow 32 Way
- Airbag On/Off Switch-Passenger - Yellow 6 Way
- Airbag Squib 1-Driver - Yellow/Black 2 Way
- Airbag Squib 2-Driver - Yellow/Gray 2 Way
- Airbag Squib-Passenger - Yellow 4 Way
- Ajar Switch-DECKLID - Black 3 Way
- Ajar Switch-Driver Door - Black 4 Way
- Ajar Switch-Hood - Natural 3 Way
- Ajar Switch-Passenger Door - Black 4 Way
- Blend Door Actuator - Gray 2 Way
- Blower Motor - Orange 2 Way
- Blower Motor Resistor Block - Black 4 Way
- Body Control Module C1 - Black 6 Way
- Body Control Module C2 - Black/Green 34 Way
- Body Control Module C3 - Black/White 34 Way
- Body Control Module C4 - Black/Gray 34 Way
- Brake Fluid Level Switch - Black 2 Way
- C200 - Black (Body Side)
- C200 - Black (Instrument Panel Side)
- C201 - Yellow (Body Side)
- C201 - Yellow (Instrument Panel Side)
- C202 - Natural (Driver Door Side)
- C202 - Natural (Instrument Panel Side)
- C203 - Natural (Instrument Panel Side)
- C203 - Natural (Passenger Door Side)
- C204 - LT. Gray (HVAC Jumper Side)
- C204 - LT. Gray (Instrument Panel Side)
- C206 - Red (Console Jumper Side)
- C206 - Red (Instrument Panel Side)
- C207 - Green (Instrument Panel Side)
- C207 - Natural (Passenger Door Side)
- C208 - Green (Instrument Panel Side)
- C208 - Natural (Driver Door Side)
- C303 - Black (Body Side)
- C303 - Black (DECKLID Jumper Side)
- CLOCKSPRING - White 8 Way
- Controller Antilock Brake - Black 24 Way
- Cylinder Unlock Switch-Driver - Black 2 Way
- Data Link Connector - Black 16 Way
- DECKLID Release Motor - Black 2 Way
- Door Latch Motor-Driver - 2 Way
- Door Latch Motor-Passenger - 2 Way
- Door Lock Switch-Driver - Black 3 Way
- Door Lock Switch-Passenger - Black 3 Way
- Exterior Door Handle Switch-Driver - Black 2 Way
- Exterior Door Handle Switch-Passenger - Black 2 Way
- Fog Lamp-Left - Black 2 Way
- Gauge Cluster C1 - White 3 Way
- Gauge Cluster C2 - Black 20 Way
- Hid Lamp-Left - Gray 2 Way
- High Beam Headlamp-Left - Black 2 Way
- Horn Switch - Black 1 Way
- Horn-High Note - Black 2 Way
- Horn-Low Note - Black 2 Way
- Ignition Switch - Black 5 Way
- Instrument Cluster C1 - Black 16 Way
- Instrument Cluster C2 - Black 20 Way
- Interior Door Handle Switch-Driver - Black 2 Way
- Interior Door Handle Switch-Passenger - Black 2 Way
- Marker Lamp-Left Front - DK. Gray 2 Way
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way
- Multi-Function Switch - Gray 20 Way
- Power Distribution Center
- Power Window Motor-Driver - Black 6 Way
- Power Window Motor-Passenger - Black 6 Way
- Power Window Switch-Driver - Gray 3 Way
- Power Window Switch-Passenger - Gray 3 Way
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Radio - Gray 22 Way
- RECIRCULATION Door Actuator - Gray 2 Way
- Remote Keyless Entry Module - Black 6 Way
- Seat Belt Switch-Driver - White 2 Way
- Seat Belt Switch-Passenger - White 2 Way
- Seat Belt TENSIONER-Driver - Yellow 2 Way
- Seat Belt TENSIONER-Passenger - Yellow 2 Way
- Speaker-Left Door - Black 2 Way
- Speaker-Left Instrument Panel - White 2 Way
- Speaker-Left Rear - White 3 Way
- Speaker-Rear Woofer - Gray 4 Way
- Speaker-Right Door - Black 2 Way
- Speaker-Right Instrument Panel - White 2 Way
- Speaker-Right Rear - White 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Window Down Relay-Passenger - Black 5 Way
- Window Up Relay-Passenger - Black 5 Way
- Schematic Diagrams
- Airbag System
- Audio System
- Chime System
- Communication
- Door Ajar System
- Electrically Heated Systems
- Exterior Lighting
- Heating & A/C System
- Ignition, Power, Accessory
- Instrument Cluster/Gauge Cluster
- Interior Lighting
- Power Door Locks/RKE
- Power Window System
- Tire Pressure Monitor Module (TPM)
- Vehicle Theft Security System
- Body Diagnostic Procedures
- Door Locks
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Body Control Module
- Chime Warning System
- Communication
- Door Ajar System
- Exterior Lighting System
- Relays Controlled By The BCM
- Heating & A/C System
- Instrument Cluster / Gauge Cluster
- Interior Lighting
- Tire Pressure Monitoring System (TPMS)
- Power Door Entry System
- Power Windows
- Electrically Heated Systems
- Vehicle Theft Security System
- Using The DRBIII®
- DRBIII® Error Messages
- DRBIII® Does Not Power Up (Blank Screen)
- Display Is Not Visible
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; ACCELEROMETER 2; INTERNAL 1; OUTPUT DRIVER 1; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: DRIVER SQUIB 2 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 2 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 2 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 2 SHORT TO GROUND
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH OPEN
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO BATTERY
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO GROUND
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO BATTERY
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: PASSENGER SQUIB 2 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 2 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 2 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 2 SHORT TO GROUND
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom List: CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH BCM
- Chime
- Communication
- Symptom: ACM MESSAGES NOT RECEIVED
- Symptom: AUDIO MESSAGES NOT RECEIVED
- Symptom: COUNTRY CODE NOT PROGRAMMED
- Symptom: INTERNAL BCM FAILURE
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom List: PCI BUS SHORTED TO BATTERY; PCI BUS SHORTED TO GROUND
- Symptom: PCI INTERNAL FAULT
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM BODY CONTROL MODULE
- Symptom: *NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE
- Symptom: *NO RESPONSE FROM HVAC
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM PCM (PCI BUS)
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY)
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM TIRE PRESSURE MONITOR MODULE
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Door Ajar
- Symptom: *DECKLID AJAR CIRCUIT OPEN
- Symptom: *DECKLID AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *DRIVER DOOR AJAR CIRCUIT OPEN
- Symptom: *DRIVER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *HOOD AJAR CIRCUIT OPEN
- Symptom: *HOOD AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *PASSENGER DOOR AJAR CIRCUIT OPEN
- Symptom: *PASSENGER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Electrically Heated Systems
- Exterior Lighting
- Symptom: LEFT FOG LAMP OUTPUT OPEN
- Symptom: LEFT FOG LAMP OUTPUT SHORTED
- Symptom: LEFT HIGH BEAM OUTPUT OPEN
- Symptom: LEFT HIGH BEAM OUTPUT SHORT
- Symptom: LOW BEAM RELAY COIL OUTPUT OPEN/SHORT TO GROUND
- Symptom: LOW BEAM RELAY COIL SHORT TO VOLTAGE
- Symptom: PARK LAMP OUTPUT SHORT
- Symptom: RIGHT FOG LAMP OUTPUT OPEN
- Symptom: RIGHT FOG LAMP OUTPUT SHORTED
- Symptom: RIGHT HIGH BEAM OUTPUT OPEN
- Symptom: RIGHT HIGH BEAM OUTPUT SHORT
- Heating & A/C
- Symptom List: A/C SWITCH FAULT (ACTIVE); CHECKSUM FAILURE (ACTIVE); DEFOG SWITCH FAULT (ACTIVE)
- Symptom List: A/C SWITCH FAULT (STORED); BACKLIGHT DIMMING RX FAILURE (STORED); BLEND OVERCURRENT (STORED); CHECKSUM FAILURE (STORED); DEFOG SWITCH FAULT (STORED); LOOPBACK TEST FAILURE (STORED); MODE 1 OVERCURRENT (STORED); MODE 2 OVERCURRENT (STORED); RECIRC OVERCURRENT (STORED); REFRIGERANT PRESS RX FAILURE (STORED); TX FAILURE (STORED); VIN RX FAILURE (STORED)
- Notes
- When Monitored and Set Condition:
- A/C Switch Fault (Stored)
- Backlight Dimming RX Failure (Stored)
- Blend OVERCURRENT (Stored)
- Checksum Failure (Stored)
- Defog Switch Fault (Stored)
- LOOPBACK Test Failure (Stored)
- Mode 1 OVERCURRENT (Stored)
- Mode 2 OVERCURRENT (Stored)
- RECIRC OVERCURRENT (Stored)
- Refrigerant Press RX Failure (Stored)
- TX Failure (Stored)
- VIN RX Failure (Stored)
- Possible Causes
- Diagnostic Procedure
- Symptom List: ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE; BLEND CIRCUIT SHORTED TO GROUND; BLEND CIRCUIT SHORTED TO IGN OR BATT; COMMON DRIVER SHORTED TO GROUND; COMMON DRIVER SHORTED TO IGN OR BATT; MODE 1 CIRCUIT SHORTED TO GROUND; MODE 1 CIRCUIT SHORTED TO IGN OR BATT; MODE 2 CIRCUIT SHORTED TO GROUND; MODE 2 CIRCUIT SHORTED TO IGN OR BATT; RECIRC CIRCUIT SHORTED TO GROUND; RECIRC CIRCUIT SHORTED TO IGN OR BATT; SHORT TOO COMPLEX
- Notes
- When Monitored and Set Condition:
- Act CKT Test Passed, OVERCURRENT DTCS Active
- Blend Circuit Shorted To Ground
- Blend Circuit Shorted To IGN Or Batt
- Common Driver Shorted To Ground
- Common Driver Shorted To IGN Or Batt
- Mode 1 Circuit Shorted To Ground
- Mode 1 Circuit Shorted To IGN Or Batt
- Mode 2 Circuit Shorted To Ground
- Mode 2 Circuit Shorted To IGN Or Batt
- RECIRC Circuit Shorted To Ground
- RECIRC Circuit Shorted To IGN Or Batt
- Short Too Complex
- Possible Causes
- Diagnostic Procedure
- Symptom: BACKLIGHT DIMMING RX FAILURE (ACTIVE)
- Symptom List: BLEND CALIBRATION FAULT; MODE 1 CALIBRATION FAULT; MODE 2 CALIBRATION FAULT; RECIRCULATION CALIBRATION FAULT
- Symptom List: BLEND OVERCURRENT (ACTIVE); MODE 1 OVERCURRENT (ACTIVE); MODE 2 OVERCURRENT (ACTIVE); RECIRC OVERCURRENT (ACTIVE)
- Symptom: DEFOG RELAY CONTROL CKT SHORTED TO BATT
- Symptom: LOOPBACK TEST FAILURE (ACTIVE)
- Symptom List: REFRIGERANT PRESSURE RX FAILURE (ACTIVE); VIN RX FAILURE (ACTIVE)
- Symptom: TX FAILURE (ACTIVE)
- Symptom: *A/C - HEATER CONTROL ILLUMINATION INOPERATIVE
- Symptom: *BLEND/MODE/RECIRC DOOR OPERATION IMPROPER
- Symptom: *BLOWER MOTOR INOPERATIVE
- Symptom: *BLOWER MOTOR SPEEDS INCORRECT
- Symptom: *EBL STATUS INDICATOR FLASHING
- Symptom: *HVAC SYSTEM TEST
- Ignition, Power, Accessory
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT OPEN
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT SHORT TO GROUND
- Symptom: BCM - IGNITION MUX SWITCH INPUT MISMATCH
- Symptom: BCM - IGNITION MUX SWITCH INPUT OPEN
- Symptom: BCM - IGNITION MUX SWITCH INPUT SHORT
- Symptom: BCM - IGNITION RUN 1 SHORT
- Symptom: BCM - IGNITION RUN 2 SHORT
- Symptom: BCM - IOD OUTPUT CIRCUIT SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT OPEN / SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT SHORT TO VOLTAGE
- Symptom: BCM - RUN/START HARDWIRE INPUT MISMATCH
- Symptom: HORN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: HORN RELAY COIL SHORT TO BATTERY
- Symptom: HORN SWITCH STUCK
- Symptom: *HORNS INOPERATIVE
- Instrument Cluster
- Symptom List: ABS LAMP CIRCUIT OPEN; ABS LAMP CIRCUIT SHORTED; AIRBAG LAMP CIRCUIT OPEN; AIRBAG LAMP CIRCUIT SHORTED
- Symptom: ABS MESSAGES NOT RECEIVED
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT OPEN / SHORTED TO VOLTAGE
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT SHORT TO GROUND
- Symptom: BCM - PWM DIMMING OUTPUT SHORT
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: ORC MESSAGES NOT RECEIVED
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *GAUGE CLUSTER DIAGNOSTIC TEST
- Symptom: *INSTRUMENT CLUSTER DIAGNOSTIC TEST
- Interior Lighting
- Power Door Locks/RKE
- Symptom: DECKLID RELEASE OUTPUT OPEN
- Symptom: DECKLID RELEASE OUTPUT SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH OPEN OR SHORT TO VOLTAGE
- Symptom: DRIVER CYLINDER UNLOCK SWITCH SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH STUCK
- Symptom: DRIVER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: DRIVER DOOR LOCK SWITCH STUCK
- Symptom: DRIVER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: DRIVER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: DRIVER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER DOOR LOCK SWITCH STUCK
- Symptom: PASSENGER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER/DRIVER DOOR UNLATCH RETURN SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT OPEN/SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT SHORT TO BATTERY
- Symptom: *ALL DOOR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR UNLATCH INOPERATIVE
- Symptom: *PASSENGER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *PASSENGER DOOR UNLATCH INOPERATIVE
- Symptom: *REMOTE KEYLESS ENTRY PROBLEM
- Power Windows
- Symptom: DRIVER WINDOW DOWN OUTPUT SHORT TO GROUND
- Symptom: DRIVER WINDOW HALL EFFECT FAILURE
- Symptom: DRIVER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: DRIVER WINDOW SWITCH SHORT TO GROUND
- Symptom: DRIVER WINDOW SWITCH STUCK DOWN
- Symptom: DRIVER WINDOW SWITCH STUCK UP
- Symptom: DRIVER WINDOW UP OUTPUT SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL SHORT TO BATTERY
- Symptom: PASSENGER WINDOW HALL EFFECT FAILURE
- Symptom: PASSENGER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: PASSENGER WINDOW SWITCH SHORT TO GROUND
- Symptom: PASSENGER WINDOW SWITCH STUCK DOWN
- Symptom: PASSENGER WINDOW SWITCH STUCK UP
- Symptom: PASSENGER WINDOW UP SHORT TO GROUND
- Symptom: *DRIVER WINDOW INOPERATIVE
- Symptom: *PASSENGER WINDOW INOPERATIVE
- Tire Pressure Monitoring
- Symptom: CRITICAL TIRE PRESSURE - BCM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM
- Symptom: TIRE PRESSURE LOW - BCM
- Symptom: TIRE PRESSURE MONITOR MODULE FAILURE - TPM
- Symptom: TPM DIAGNOSTIC - BCM
- Symptom: TPM MODULE INITIALIZED - BCM
- Symptom: *LO TIRE LCD MESSAGE FLASHING
- Vehicle Theft/Security
- Symptom: VTSS INDICATOR OUTPUT OPEN
- Symptom: VTSS INDICATOR OUTPUT SHORT
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *DECKLID DOES NOT TRIP VTSS
- Symptom: *DRIVER DOOR DOES NOT TRIP VTSS
- Symptom: *EXTERIOR LAMPS FAIL TO FLASH WHEN ALARM IS TRIPPED
- Symptom: *HOOD DOES NOT TRIP VTSS
- Symptom: *HORN FAILS TO SOUND WHEN ALARM IS TRIPPED
- Symptom: *PASSENGER DOOR DOES NOT TRIP VTSS
- Symptom: *VTSS LAMP ON STEADY DURING ARMING
- Symptom: *VTSS WILL NOT ARM
- Verification Tests
- Airbag
- Component Locations
- Connector PINOUTS
- A/C-Heater Control C1 - Black 10 Way
- A/C-Heater Control C2 - Black 16 Way
- Airbag Control Module C1 (Orc) - Yellow 32 Way
- Airbag Control Module C2 (Orc) - Yellow 32 Way
- Airbag On/Off Switch-Passenger - Yellow 6 Way
- Airbag Squib 1-Driver - Yellow/Black 2 Way
- Airbag Squib 2-Driver - Yellow/Gray 2 Way
- Airbag Squib-Passenger - Yellow 4 Way
- Ajar Switch-DECKLID - Black 3 Way
- Ajar Switch-Driver Door - Black 4 Way
- Ajar Switch-Hood - Natural 3 Way
- Ajar Switch-Passenger Door - Black 4 Way
- Blend Door Actuator - Gray 2 Way
- Blower Motor - Orange 2 Way
- Blower Motor Resistor Block - Black 4 Way
- Body Control Module C1 - Black 6 Way
- Body Control Module C2 - Black/Green 34 Way
- Body Control Module C3 - Black/White 34 Way
- Body Control Module C4 - Black/Gray 34 Way
- Brake Fluid Level Switch - Black 2 Way
- C200 - Black (Body Side)
- C200 - Black (Instrument Panel Side)
- C201 - Yellow (Body Side)
- C201 - Yellow (Instrument Panel Side)
- C202 - Natural (Driver Door Side)
- C202 - Natural (Instrument Panel Side)
- C203 - Natural (Instrument Panel Side)
- C203 - Natural (Passenger Door Side)
- C204 - LT. Gray (HVAC Jumper Side)
- C204 - LT. Gray (Instrument Panel Side)
- C206 - Red (Console Jumper Side)
- C206 - Red (Instrument Panel Side)
- C207 - Green (Instrument Panel Side)
- C207 - Natural (Passenger Door Side)
- C208 - Green (Instrument Panel Side)
- C208 - Natural (Driver Door Side)
- C303 - Black (Body Side)
- C303 - Black (DECKLID Jumper Side)
- CLOCKSPRING - White 8 Way
- Controller Antilock Brake - Black 24 Way
- Cylinder Unlock Switch-Driver - Black 2 Way
- Data Link Connector - Black 16 Way
- DECKLID Release Motor - Black 2 Way
- Door Latch Motor-Driver - 2 Way
- Door Latch Motor-Passenger - 2 Way
- Door Lock Switch-Driver - Black 3 Way
- Door Lock Switch-Passenger - Black 3 Way
- Exterior Door Handle Switch-Driver - Black 2 Way
- Exterior Door Handle Switch-Passenger - Black 2 Way
- Fog Lamp-Left - Black 2 Way
- Gauge Cluster C1 - White 3 Way
- Gauge Cluster C2 - Black 20 Way
- Hid Lamp-Left - Gray 2 Way
- High Beam Headlamp-Left - Black 2 Way
- Horn Switch - Black 1 Way
- Horn-High Note - Black 2 Way
- Horn-Low Note - Black 2 Way
- Ignition Switch - Black 5 Way
- Instrument Cluster C1 - Black 16 Way
- Instrument Cluster C2 - Black 20 Way
- Interior Door Handle Switch-Driver - Black 2 Way
- Interior Door Handle Switch-Passenger - Black 2 Way
- Marker Lamp-Left Front - DK. Gray 2 Way
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way
- Multi-Function Switch - Gray 20 Way
- Power Distribution Center
- Power Window Motor-Driver - Black 6 Way
- Power Window Motor-Passenger - Black 6 Way
- Power Window Switch-Driver - Gray 3 Way
- Power Window Switch-Passenger - Gray 3 Way
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Radio - Gray 22 Way
- RECIRCULATION Door Actuator - Gray 2 Way
- Remote Keyless Entry Module - Black 6 Way
- Seat Belt Switch-Driver - White 2 Way
- Seat Belt Switch-Passenger - White 2 Way
- Seat Belt TENSIONER-Driver - Yellow 2 Way
- Seat Belt TENSIONER-Passenger - Yellow 2 Way
- Speaker-Left Door - Black 2 Way
- Speaker-Left Instrument Panel - White 2 Way
- Speaker-Left Rear - White 3 Way
- Speaker-Rear Woofer - Gray 4 Way
- Speaker-Right Door - Black 2 Way
- Speaker-Right Instrument Panel - White 2 Way
- Speaker-Right Rear - White 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Window Down Relay-Passenger - Black 5 Way
- Window Up Relay-Passenger - Black 5 Way
- Schematic Diagrams
- Airbag System
- Audio System
- Chime System
- Communication
- Door Ajar System
- Electrically Heated Systems
- Exterior Lighting
- Heating & A/C System
- Ignition, Power, Accessory
- Instrument Cluster/Gauge Cluster
- Interior Lighting
- Power Door Locks/RKE
- Power Window System
- Tire Pressure Monitor Module (TPM)
- Vehicle Theft Security System
- Power Door Locks (Service Information)
- Power Locks
- Door Cylinder Unlock Switch
- Exterior Door Handle Switch
- Interior Door Handle Switch
- Power Lock Switch
- Remote Keyless Entry Module
- Remote Keyless Entry Transmitter
- Powertrain Diagnostic Procedures
- DTC Index
- Introduction
- Identification Of System
- System Description And Functional Operation
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Acronyms
- Diagnostic Information And Procedures
- Communication - Symptoms
- DRIVEABILITY - Gas - Symptoms
- Symptom: INTERMITTENT CONDITION
- Symptom: *BRAKE SWITCH SENSE STATUS DOES NOT CHANGE ON DRBIII®
- Symptom: *CANNOT SHIFT INTO 2ND AND 3RD GEARS
- Symptom: *CANNOT SHIFT INTO REVERSE
- Symptom: *CHECKING A/C SYSTEM OPERATION WITH NO DTCS
- Symptom: *CHECKING CHARGING SYSTEM OPERATION WITH NO DTCS
- Symptom: *CHECKING RADIATOR FAN OPERATION
- Symptom: *CHECKING THE PCM POWER AND GROUNDS
- DRIVEABILITY - Gas - Diagnostic Tests
- P0031-O2 Sensor 1/1 Heater Circuit Low; P0032-O2 Sensor 1/1 Heater Circuit High; P0051-O2 Sensor 2/1 Heater Circuit Low; P0052-O2 Sensor 2/1 Heater Circuit High
- P0071-Ambient/Battery Temp Sensor Performance
- P0107-Map Sensor Voltage Too Low
- P0108-Map Sensor Voltage Too High
- P0111-Intake Air Temp Performance
- P0112-Intake Air Temp Sensor Voltage Too Low
- P0113-Intake Air Temp Sensor Voltage Too High
- P0117-Engine Coolant Temp Sensor Voltage Too Low
- P0118-Engine Coolant Temp Sensor Voltage Too High
- P0121-TP Sensor Voltage Does Not Agree With Map
- P0122-Throttle Position Sensor #1 Voltage Too Low
- P0123-Throttle Position Sensor #1 Voltage Too High
- P0125-Closed Loop Temp Not Reached
- P0131-O2 Sensor 1/1 Circuit Voltage Too Low; P0137-O2 Sensor 1/2 Circuit Voltage Too Low; P0151-O2 Sensor 2/1 Circuit Voltage Too Low; P0157-O2 Sensor 2/2 Circuit Voltage Too Low
- P0132-O2 Sensor 1/1 Circuit Voltage Too High; P0138-O2 Sensor 1/2 Circuit Voltage Too High; P0152-O2 Sensor 2/1 Circuit Voltage Too High; P0158-O2 Sensor 2/2 Circuit Voltage Too High
- P0133-O2 Sensor 1/1 Slow Response; P0139-O2 Sensor 1/2 Slow Response; P0153-O2 Sensor 2/1 Slow Response; P0159-O2 Sensor 2/2 Slow Response
- P0135-O2 Sensor 1/1 Heater Failure; P0141-O2 Sensor 1/2 Heater Failure; P0155-O2 Sensor 2/1 Heater Failure; P0161-O2 Sensor 2/2 Heater Failure
- P0136-O2 Sensor 1/2 Heater Circuit Malfunction
- P0171-1/1 Fuel System Lean; P0174-2/1 Fuel System Lean
- P0172-1/1 Fuel System Rich; P0175-2/1 Fuel System Rich
- P0197-Engine Oil Temperature Sensor Voltage Too Low
- P0198-Engine Oil Temperature Sensor Voltage Too High
- P0201-Injector #1 Control Circuit; P0202-Injector #2 Control Circuit; P0203-Injector #3 Control Circuit; P0204-Injector #4 Control Circuit; P0205-Injector #5 Control Circuit; P0206-Injector #6 Control Circuit; P0207-Injector #7 Control Circuit; P0208-Injector #8 Control Circuit; P0209-Injector #9 Control Circuit; P0210-Injector #10 Control Circuit
- Notes
- When Monitored and Set Condition:
- P0201-Injector #1 Control Circuit
- P0202-Injector #2 Control Circuit
- P0203-Injector #3 Control Circuit
- P0204-Injector #4 Control Circuit
- P0205-Injector #5 Control Circuit
- P0206-Injector #6 Control Circuit
- P0207-Injector #7 Control Circuit
- P0208-Injector #8 Control Circuit
- P0209-Injector #9 Control Circuit
- P0210-Injector #10 Control Circuit
- Possible Causes
- Diagnostic Procedure
- P0300-Multiple Cylinder Mis-Fire; P0301-Cylinder #1 Misfire; P0302-Cylinder #2 Misfire; P0303-Cylinder #3 Misfire; P0304-Cylinder #4 Misfire; P0305-Cylinder #5 Misfire; P0306-Cylinder #6 Misfire; P0307-Cylinder #7 Misfire; P0308-Cylinder #8 Misfire; P0309-Cylinder #9 Misfire; P0310-Cylinder #10 Misfire
- P0320-No Crank Reference Signal At Pcm
- P0340-No Cam Reference Signal At Pcm
- P0351-Ignition Coil #1 Primary Circuit; P0352-Ignition Coil #2 Primary Circuit; P0353-Ignition Coil #3 Primary Circuit; P0354-Ignition Coil #4 Primary Circuit; P0355-Ignition Coil #5 Primary Circuit
- P0420-1/1 Catalytic Converter Efficiency; P0432-2/1 Catalytic Converter Efficiency
- P0441-EVAP Purge Flow Monitor
- P0442-EVAP Leak Monitor Medium (0.040) Leak Detected P0455-EVAP Leak Monitor Large Leak Detected
- P0443-EVAP Purge Solenoid Circuit
- P0460-Fuel Level Sending Unit No Change Over Miles
- P0462-Fuel Level Sending Unit Volts Too Low
- P0463-Fuel Level Sending Unit Volts Too High
- P0500-No Vehicle Speed Signal
- P0505-Idle Air Control Motor Circuits
- P0522-Oil Pressure Circuit Low
- P0523-Oil Pressure Circuit High
- P0601-Pcm Internal Controller Failure
- P0622-Generator Field Not Switching Properly
- P0645-A/C Clutch Relay Circuit
- P0801-Reverse Gear Lockout Circuit Open Or Shorted
- P1195-O2 Sensor 1/1 Slow During Catalyst Monitor P1196-O2 Sensor 2/1 Slow During Catalyst Monitor
- P1281-Engine Is Cold Too Long
- P1282-Fuel Pump/System Relay Control Circuit
- P1294-Target Idle Not Reached
- P1296-No 5-Volts To Map Sensor
- P1297-No Change In Map From Start To Run
- P1388-Auto Shutdown Relay Control Circuit
- P1389-No ASD Relay Output Voltage At Pcm
- P1391-Intermittent Loss Of CMP Or CKP
- P1398-Mis-Fire Adaptive Numerator At Limit
- P1486-EVAP Leak Monitor Pinched Hose Found
- P1492-Ambient/Battery Temperature Sensor Voltage Too High
- P1493-Ambient/Battery Temperature Sensor Voltage Too Low
- P1494-Leak Detection Pump Switch Or Mechanical Fault
- P1495-Leak Detection Pump Solenoid Circuit
- P1499-Hydraulic Fan Solenoid Circuit
- P1594-Charging System Voltage Too High
- P1598-A/C Pressure Sensor Voltage Too High
- P1599-A/C Pressure Sensor Voltage Too Low
- P1682-Charging System Voltage Too Low
- P1687-No Cluster Bus Message
- P1695-Bus Message From Body Control Module
- P1696-Pcm Failure EEPROM Write Denied
- P1719-Skip Shift Solenoid Circuit Open Or Shorted
- Starting - Symptoms
- Verification Tests
- Component Locations
- Control Modules And PDC
- Data Link Connector
- Sensors And Solenoids
- Battery Temp. Sensor Location
- Cam Position Sensor Location
- Crank Position Sensor Location
- MAP, ECT And Fuel Injector Locations
- IAT Sensor Location
- Engine Oil Pressure Sensor And Engine Oil Temp. Sensor Locations
- O2 Sensor Locations
- IAC Motor And TPS Locations
- Ignition Coil Locations
- Skip Shift Solenoid And Vehicle Speed Sensor Locations
- Fuel System
- Connector PINOUTS
- A/C Compressor Clutch - Black 2 Way
- A/C Low Pressure Switch - DK. Green 2 Way
- A/C Pressure Transducer - Black 4 Way
- Battery Temperature Sensor - 2 Way
- Brake Lamp Switch - Black 6 Way
- Camshaft Position Sensor - Gray 3 Way
- CLOCKSPRING - White 8 Way
- Clutch Interlock Switch - DK.Green 2 Way
- Crankshaft Position Sensor - Black 3 Way
- Data Link Connector - Black 16 Way
- Engine Coolant Temperature Sensor - Black 2 Way
- Engine Oil Pressure Sensor - Black 3 Way
- Engine Oil Temperature Sensor - Black 2 Way
- EVAP/Purge Solenoid - Black 2 Way
- Fuel Injector No. 1 - Black 2 Way
- Fuel Injector No. 2 - Black 2 Way
- Fuel Injector No. 3 - Black 2 Way
- Fuel Injector No. 4 - Black 2 Way
- Fuel Injector No. 5 - Black 2 Way
- Fuel Injector No. 6 - Black 2 Way
- Fuel Injector No. 7 - Black 2 Way
- Fuel Injector No. 8 - Black 2 Way
- Fuel Injector No. 9 - Black 2 Way
- Fuel Injector No. 10 - Black 2 Way
- Fuel Tank Module - Gray 4 Way
- Generator - Gray 2 Way
- Hydraulic Cooling Module - Black 3 Way
- Idle Air Control Motor - Black 4 Way
- Ignition Coil Pack-Left - Black 4 Way
- Ignition Coil Pack-Right - Black 3 Way
- Ignition Switch - Black 5 Way
- Intake Air Temperature Sensor - Black 2 Way
- Leak Detection Pump - Black 4 Way
- Manifold Absolute Pressure Sensor - Black 3 Way
- Multi-Function Switch - Gray 20 Way
- Oxygen Sensor 1/1 Left Bank Up - Black 4 Way
- Oxygen Sensor 1/2 Left Bank Down - Black 4 Way
- Oxygen Sensor 2/1 Right Bank Up - Black 4 Way
- Oxygen Sensor 2/2 Right Bank Down - Black 4 Way
- Power Distribution Center
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Push-Button Starter Switch - Natural 6 Way
- Reverse Lock-Out Solenoid - White 2 Way
- Skip Shift Solenoid - White 2 Way
- Throttle Position Sensor - Black 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Schematic Diagrams
- Charts And Graphs
- Vehicle Theft Security
- Body Diagnostic Procedures
- Exterior Body Panels
- Frame & Bumpers
- Interior/Exterior
- Body
- Warning
- Diagnosis And Testing
- Standard Procedure
- Standard Procedure - Plastic Body Panel Repair
- Notes
- Rigid Plastics:
- Semi-Rigid Plastics:
- Flexible Plastics:
- Repair Procedure:
- Adhesion Promoter/Surface Modifier:
- Safety Precaution And Warnings
- Rigid, Semi-Rigid, And Flexible Plastic Parts Types
- Panel Sectioning
- Panel Reinforcement
- Visual Inspection
- Panel Surface Preparation
- Patching Panels
- Panel Patch Fabrications
- Panel Patch Installation
- Patched Panel Surfacing
- Standard Procedure - Heat Staking
- Standard Procedure - Plastic Body Panel Repair
- Specifications
- Special Tools
- Convertible Top
- DECKLID
- Door - Front
- Exterior
- Hood
- Instrument Panel
- Interior
- Paint
- Seats
- Stationary Glass
- Weatherstrip/Seals
- Body Structure
- Body
- Exterior/Interior Trim
- Interior/Exterior
- Body
- Warning
- Diagnosis And Testing
- Standard Procedure
- Standard Procedure - Plastic Body Panel Repair
- Notes
- Rigid Plastics:
- Semi-Rigid Plastics:
- Flexible Plastics:
- Repair Procedure:
- Adhesion Promoter/Surface Modifier:
- Safety Precaution And Warnings
- Rigid, Semi-Rigid, And Flexible Plastic Parts Types
- Panel Sectioning
- Panel Reinforcement
- Visual Inspection
- Panel Surface Preparation
- Patching Panels
- Panel Patch Fabrications
- Panel Patch Installation
- Patched Panel Surfacing
- Standard Procedure - Heat Staking
- Standard Procedure - Plastic Body Panel Repair
- Specifications
- Special Tools
- Convertible Top
- DECKLID
- Door - Front
- Exterior
- Hood
- Instrument Panel
- Interior
- Paint
- Seats
- Stationary Glass
- Weatherstrip/Seals
- Body Structure
- Body
- Interior/Exterior
- Frames, Subframes & Crossmembers
- Power Mirrors
- Seats
- Interior/Exterior
- Body
- Warning
- Diagnosis And Testing
- Standard Procedure
- Standard Procedure - Plastic Body Panel Repair
- Notes
- Rigid Plastics:
- Semi-Rigid Plastics:
- Flexible Plastics:
- Repair Procedure:
- Adhesion Promoter/Surface Modifier:
- Safety Precaution And Warnings
- Rigid, Semi-Rigid, And Flexible Plastic Parts Types
- Panel Sectioning
- Panel Reinforcement
- Visual Inspection
- Panel Surface Preparation
- Patching Panels
- Panel Patch Fabrications
- Panel Patch Installation
- Patched Panel Surfacing
- Standard Procedure - Heat Staking
- Standard Procedure - Plastic Body Panel Repair
- Specifications
- Special Tools
- Convertible Top
- DECKLID
- Door - Front
- Exterior
- Hood
- Instrument Panel
- Interior
- Paint
- Seats
- Stationary Glass
- Weatherstrip/Seals
- Body Structure
- Body
- Interior/Exterior
- Sun Roof/T-Top/Convertible Top
- Interior/Exterior
- Body
- Warning
- Diagnosis And Testing
- Standard Procedure
- Standard Procedure - Plastic Body Panel Repair
- Notes
- Rigid Plastics:
- Semi-Rigid Plastics:
- Flexible Plastics:
- Repair Procedure:
- Adhesion Promoter/Surface Modifier:
- Safety Precaution And Warnings
- Rigid, Semi-Rigid, And Flexible Plastic Parts Types
- Panel Sectioning
- Panel Reinforcement
- Visual Inspection
- Panel Surface Preparation
- Patching Panels
- Panel Patch Fabrications
- Panel Patch Installation
- Patched Panel Surfacing
- Standard Procedure - Heat Staking
- Standard Procedure - Plastic Body Panel Repair
- Specifications
- Special Tools
- Convertible Top
- DECKLID
- Door - Front
- Exterior
- Hood
- Instrument Panel
- Interior
- Paint
- Seats
- Stationary Glass
- Weatherstrip/Seals
- Body Structure
- Body
- Interior/Exterior
- Windows
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Body Control Module
- Chime Warning System
- Communication
- Door Ajar System
- Exterior Lighting System
- Relays Controlled By The BCM
- Heating & A/C System
- Instrument Cluster / Gauge Cluster
- Interior Lighting
- Tire Pressure Monitoring System (TPMS)
- Power Door Entry System
- Power Windows
- Electrically Heated Systems
- Vehicle Theft Security System
- Using The DRBIII®
- DRBIII® Error Messages
- DRBIII® Does Not Power Up (Blank Screen)
- Display Is Not Visible
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; ACCELEROMETER 2; INTERNAL 1; OUTPUT DRIVER 1; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: DRIVER SQUIB 2 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 2 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 2 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 2 SHORT TO GROUND
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH OPEN
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO BATTERY
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO GROUND
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO BATTERY
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: PASSENGER SQUIB 2 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 2 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 2 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 2 SHORT TO GROUND
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom List: CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH BCM
- Chime
- Communication
- Symptom: ACM MESSAGES NOT RECEIVED
- Symptom: AUDIO MESSAGES NOT RECEIVED
- Symptom: COUNTRY CODE NOT PROGRAMMED
- Symptom: INTERNAL BCM FAILURE
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom List: PCI BUS SHORTED TO BATTERY; PCI BUS SHORTED TO GROUND
- Symptom: PCI INTERNAL FAULT
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM BODY CONTROL MODULE
- Symptom: *NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE
- Symptom: *NO RESPONSE FROM HVAC
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM PCM (PCI BUS)
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY)
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM TIRE PRESSURE MONITOR MODULE
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Door Ajar
- Symptom: *DECKLID AJAR CIRCUIT OPEN
- Symptom: *DECKLID AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *DRIVER DOOR AJAR CIRCUIT OPEN
- Symptom: *DRIVER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *HOOD AJAR CIRCUIT OPEN
- Symptom: *HOOD AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *PASSENGER DOOR AJAR CIRCUIT OPEN
- Symptom: *PASSENGER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Electrically Heated Systems
- Exterior Lighting
- Symptom: LEFT FOG LAMP OUTPUT OPEN
- Symptom: LEFT FOG LAMP OUTPUT SHORTED
- Symptom: LEFT HIGH BEAM OUTPUT OPEN
- Symptom: LEFT HIGH BEAM OUTPUT SHORT
- Symptom: LOW BEAM RELAY COIL OUTPUT OPEN/SHORT TO GROUND
- Symptom: LOW BEAM RELAY COIL SHORT TO VOLTAGE
- Symptom: PARK LAMP OUTPUT SHORT
- Symptom: RIGHT FOG LAMP OUTPUT OPEN
- Symptom: RIGHT FOG LAMP OUTPUT SHORTED
- Symptom: RIGHT HIGH BEAM OUTPUT OPEN
- Symptom: RIGHT HIGH BEAM OUTPUT SHORT
- Heating & A/C
- Symptom List: A/C SWITCH FAULT (ACTIVE); CHECKSUM FAILURE (ACTIVE); DEFOG SWITCH FAULT (ACTIVE)
- Symptom List: A/C SWITCH FAULT (STORED); BACKLIGHT DIMMING RX FAILURE (STORED); BLEND OVERCURRENT (STORED); CHECKSUM FAILURE (STORED); DEFOG SWITCH FAULT (STORED); LOOPBACK TEST FAILURE (STORED); MODE 1 OVERCURRENT (STORED); MODE 2 OVERCURRENT (STORED); RECIRC OVERCURRENT (STORED); REFRIGERANT PRESS RX FAILURE (STORED); TX FAILURE (STORED); VIN RX FAILURE (STORED)
- Notes
- When Monitored and Set Condition:
- A/C Switch Fault (Stored)
- Backlight Dimming RX Failure (Stored)
- Blend OVERCURRENT (Stored)
- Checksum Failure (Stored)
- Defog Switch Fault (Stored)
- LOOPBACK Test Failure (Stored)
- Mode 1 OVERCURRENT (Stored)
- Mode 2 OVERCURRENT (Stored)
- RECIRC OVERCURRENT (Stored)
- Refrigerant Press RX Failure (Stored)
- TX Failure (Stored)
- VIN RX Failure (Stored)
- Possible Causes
- Diagnostic Procedure
- Symptom List: ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE; BLEND CIRCUIT SHORTED TO GROUND; BLEND CIRCUIT SHORTED TO IGN OR BATT; COMMON DRIVER SHORTED TO GROUND; COMMON DRIVER SHORTED TO IGN OR BATT; MODE 1 CIRCUIT SHORTED TO GROUND; MODE 1 CIRCUIT SHORTED TO IGN OR BATT; MODE 2 CIRCUIT SHORTED TO GROUND; MODE 2 CIRCUIT SHORTED TO IGN OR BATT; RECIRC CIRCUIT SHORTED TO GROUND; RECIRC CIRCUIT SHORTED TO IGN OR BATT; SHORT TOO COMPLEX
- Notes
- When Monitored and Set Condition:
- Act CKT Test Passed, OVERCURRENT DTCS Active
- Blend Circuit Shorted To Ground
- Blend Circuit Shorted To IGN Or Batt
- Common Driver Shorted To Ground
- Common Driver Shorted To IGN Or Batt
- Mode 1 Circuit Shorted To Ground
- Mode 1 Circuit Shorted To IGN Or Batt
- Mode 2 Circuit Shorted To Ground
- Mode 2 Circuit Shorted To IGN Or Batt
- RECIRC Circuit Shorted To Ground
- RECIRC Circuit Shorted To IGN Or Batt
- Short Too Complex
- Possible Causes
- Diagnostic Procedure
- Symptom: BACKLIGHT DIMMING RX FAILURE (ACTIVE)
- Symptom List: BLEND CALIBRATION FAULT; MODE 1 CALIBRATION FAULT; MODE 2 CALIBRATION FAULT; RECIRCULATION CALIBRATION FAULT
- Symptom List: BLEND OVERCURRENT (ACTIVE); MODE 1 OVERCURRENT (ACTIVE); MODE 2 OVERCURRENT (ACTIVE); RECIRC OVERCURRENT (ACTIVE)
- Symptom: DEFOG RELAY CONTROL CKT SHORTED TO BATT
- Symptom: LOOPBACK TEST FAILURE (ACTIVE)
- Symptom List: REFRIGERANT PRESSURE RX FAILURE (ACTIVE); VIN RX FAILURE (ACTIVE)
- Symptom: TX FAILURE (ACTIVE)
- Symptom: *A/C - HEATER CONTROL ILLUMINATION INOPERATIVE
- Symptom: *BLEND/MODE/RECIRC DOOR OPERATION IMPROPER
- Symptom: *BLOWER MOTOR INOPERATIVE
- Symptom: *BLOWER MOTOR SPEEDS INCORRECT
- Symptom: *EBL STATUS INDICATOR FLASHING
- Symptom: *HVAC SYSTEM TEST
- Ignition, Power, Accessory
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT OPEN
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT SHORT TO GROUND
- Symptom: BCM - IGNITION MUX SWITCH INPUT MISMATCH
- Symptom: BCM - IGNITION MUX SWITCH INPUT OPEN
- Symptom: BCM - IGNITION MUX SWITCH INPUT SHORT
- Symptom: BCM - IGNITION RUN 1 SHORT
- Symptom: BCM - IGNITION RUN 2 SHORT
- Symptom: BCM - IOD OUTPUT CIRCUIT SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT OPEN / SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT SHORT TO VOLTAGE
- Symptom: BCM - RUN/START HARDWIRE INPUT MISMATCH
- Symptom: HORN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: HORN RELAY COIL SHORT TO BATTERY
- Symptom: HORN SWITCH STUCK
- Symptom: *HORNS INOPERATIVE
- Instrument Cluster
- Symptom List: ABS LAMP CIRCUIT OPEN; ABS LAMP CIRCUIT SHORTED; AIRBAG LAMP CIRCUIT OPEN; AIRBAG LAMP CIRCUIT SHORTED
- Symptom: ABS MESSAGES NOT RECEIVED
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT OPEN / SHORTED TO VOLTAGE
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT SHORT TO GROUND
- Symptom: BCM - PWM DIMMING OUTPUT SHORT
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: ORC MESSAGES NOT RECEIVED
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *GAUGE CLUSTER DIAGNOSTIC TEST
- Symptom: *INSTRUMENT CLUSTER DIAGNOSTIC TEST
- Interior Lighting
- Power Door Locks/RKE
- Symptom: DECKLID RELEASE OUTPUT OPEN
- Symptom: DECKLID RELEASE OUTPUT SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH OPEN OR SHORT TO VOLTAGE
- Symptom: DRIVER CYLINDER UNLOCK SWITCH SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH STUCK
- Symptom: DRIVER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: DRIVER DOOR LOCK SWITCH STUCK
- Symptom: DRIVER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: DRIVER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: DRIVER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER DOOR LOCK SWITCH STUCK
- Symptom: PASSENGER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER/DRIVER DOOR UNLATCH RETURN SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT OPEN/SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT SHORT TO BATTERY
- Symptom: *ALL DOOR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR UNLATCH INOPERATIVE
- Symptom: *PASSENGER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *PASSENGER DOOR UNLATCH INOPERATIVE
- Symptom: *REMOTE KEYLESS ENTRY PROBLEM
- Power Windows
- Symptom: DRIVER WINDOW DOWN OUTPUT SHORT TO GROUND
- Symptom: DRIVER WINDOW HALL EFFECT FAILURE
- Symptom: DRIVER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: DRIVER WINDOW SWITCH SHORT TO GROUND
- Symptom: DRIVER WINDOW SWITCH STUCK DOWN
- Symptom: DRIVER WINDOW SWITCH STUCK UP
- Symptom: DRIVER WINDOW UP OUTPUT SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL SHORT TO BATTERY
- Symptom: PASSENGER WINDOW HALL EFFECT FAILURE
- Symptom: PASSENGER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: PASSENGER WINDOW SWITCH SHORT TO GROUND
- Symptom: PASSENGER WINDOW SWITCH STUCK DOWN
- Symptom: PASSENGER WINDOW SWITCH STUCK UP
- Symptom: PASSENGER WINDOW UP SHORT TO GROUND
- Symptom: *DRIVER WINDOW INOPERATIVE
- Symptom: *PASSENGER WINDOW INOPERATIVE
- Tire Pressure Monitoring
- Symptom: CRITICAL TIRE PRESSURE - BCM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM
- Symptom: TIRE PRESSURE LOW - BCM
- Symptom: TIRE PRESSURE MONITOR MODULE FAILURE - TPM
- Symptom: TPM DIAGNOSTIC - BCM
- Symptom: TPM MODULE INITIALIZED - BCM
- Symptom: *LO TIRE LCD MESSAGE FLASHING
- Vehicle Theft/Security
- Symptom: VTSS INDICATOR OUTPUT OPEN
- Symptom: VTSS INDICATOR OUTPUT SHORT
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *DECKLID DOES NOT TRIP VTSS
- Symptom: *DRIVER DOOR DOES NOT TRIP VTSS
- Symptom: *EXTERIOR LAMPS FAIL TO FLASH WHEN ALARM IS TRIPPED
- Symptom: *HOOD DOES NOT TRIP VTSS
- Symptom: *HORN FAILS TO SOUND WHEN ALARM IS TRIPPED
- Symptom: *PASSENGER DOOR DOES NOT TRIP VTSS
- Symptom: *VTSS LAMP ON STEADY DURING ARMING
- Symptom: *VTSS WILL NOT ARM
- Verification Tests
- Airbag
- Component Locations
- Connector PINOUTS
- A/C-Heater Control C1 - Black 10 Way
- A/C-Heater Control C2 - Black 16 Way
- Airbag Control Module C1 (Orc) - Yellow 32 Way
- Airbag Control Module C2 (Orc) - Yellow 32 Way
- Airbag On/Off Switch-Passenger - Yellow 6 Way
- Airbag Squib 1-Driver - Yellow/Black 2 Way
- Airbag Squib 2-Driver - Yellow/Gray 2 Way
- Airbag Squib-Passenger - Yellow 4 Way
- Ajar Switch-DECKLID - Black 3 Way
- Ajar Switch-Driver Door - Black 4 Way
- Ajar Switch-Hood - Natural 3 Way
- Ajar Switch-Passenger Door - Black 4 Way
- Blend Door Actuator - Gray 2 Way
- Blower Motor - Orange 2 Way
- Blower Motor Resistor Block - Black 4 Way
- Body Control Module C1 - Black 6 Way
- Body Control Module C2 - Black/Green 34 Way
- Body Control Module C3 - Black/White 34 Way
- Body Control Module C4 - Black/Gray 34 Way
- Brake Fluid Level Switch - Black 2 Way
- C200 - Black (Body Side)
- C200 - Black (Instrument Panel Side)
- C201 - Yellow (Body Side)
- C201 - Yellow (Instrument Panel Side)
- C202 - Natural (Driver Door Side)
- C202 - Natural (Instrument Panel Side)
- C203 - Natural (Instrument Panel Side)
- C203 - Natural (Passenger Door Side)
- C204 - LT. Gray (HVAC Jumper Side)
- C204 - LT. Gray (Instrument Panel Side)
- C206 - Red (Console Jumper Side)
- C206 - Red (Instrument Panel Side)
- C207 - Green (Instrument Panel Side)
- C207 - Natural (Passenger Door Side)
- C208 - Green (Instrument Panel Side)
- C208 - Natural (Driver Door Side)
- C303 - Black (Body Side)
- C303 - Black (DECKLID Jumper Side)
- CLOCKSPRING - White 8 Way
- Controller Antilock Brake - Black 24 Way
- Cylinder Unlock Switch-Driver - Black 2 Way
- Data Link Connector - Black 16 Way
- DECKLID Release Motor - Black 2 Way
- Door Latch Motor-Driver - 2 Way
- Door Latch Motor-Passenger - 2 Way
- Door Lock Switch-Driver - Black 3 Way
- Door Lock Switch-Passenger - Black 3 Way
- Exterior Door Handle Switch-Driver - Black 2 Way
- Exterior Door Handle Switch-Passenger - Black 2 Way
- Fog Lamp-Left - Black 2 Way
- Gauge Cluster C1 - White 3 Way
- Gauge Cluster C2 - Black 20 Way
- Hid Lamp-Left - Gray 2 Way
- High Beam Headlamp-Left - Black 2 Way
- Horn Switch - Black 1 Way
- Horn-High Note - Black 2 Way
- Horn-Low Note - Black 2 Way
- Ignition Switch - Black 5 Way
- Instrument Cluster C1 - Black 16 Way
- Instrument Cluster C2 - Black 20 Way
- Interior Door Handle Switch-Driver - Black 2 Way
- Interior Door Handle Switch-Passenger - Black 2 Way
- Marker Lamp-Left Front - DK. Gray 2 Way
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way
- Multi-Function Switch - Gray 20 Way
- Power Distribution Center
- Power Window Motor-Driver - Black 6 Way
- Power Window Motor-Passenger - Black 6 Way
- Power Window Switch-Driver - Gray 3 Way
- Power Window Switch-Passenger - Gray 3 Way
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Radio - Gray 22 Way
- RECIRCULATION Door Actuator - Gray 2 Way
- Remote Keyless Entry Module - Black 6 Way
- Seat Belt Switch-Driver - White 2 Way
- Seat Belt Switch-Passenger - White 2 Way
- Seat Belt TENSIONER-Driver - Yellow 2 Way
- Seat Belt TENSIONER-Passenger - Yellow 2 Way
- Speaker-Left Door - Black 2 Way
- Speaker-Left Instrument Panel - White 2 Way
- Speaker-Left Rear - White 3 Way
- Speaker-Rear Woofer - Gray 4 Way
- Speaker-Right Door - Black 2 Way
- Speaker-Right Instrument Panel - White 2 Way
- Speaker-Right Rear - White 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Window Down Relay-Passenger - Black 5 Way
- Window Up Relay-Passenger - Black 5 Way
- Schematic Diagrams
- Airbag System
- Audio System
- Chime System
- Communication
- Door Ajar System
- Electrically Heated Systems
- Exterior Lighting
- Heating & A/C System
- Ignition, Power, Accessory
- Instrument Cluster/Gauge Cluster
- Interior Lighting
- Power Door Locks/RKE
- Power Window System
- Tire Pressure Monitor Module (TPM)
- Vehicle Theft Security System
- Interior/Exterior
- Body
- Warning
- Diagnosis And Testing
- Standard Procedure
- Standard Procedure - Plastic Body Panel Repair
- Notes
- Rigid Plastics:
- Semi-Rigid Plastics:
- Flexible Plastics:
- Repair Procedure:
- Adhesion Promoter/Surface Modifier:
- Safety Precaution And Warnings
- Rigid, Semi-Rigid, And Flexible Plastic Parts Types
- Panel Sectioning
- Panel Reinforcement
- Visual Inspection
- Panel Surface Preparation
- Patching Panels
- Panel Patch Fabrications
- Panel Patch Installation
- Patched Panel Surfacing
- Standard Procedure - Heat Staking
- Standard Procedure - Plastic Body Panel Repair
- Specifications
- Special Tools
- Convertible Top
- DECKLID
- Door - Front
- Exterior
- Hood
- Instrument Panel
- Interior
- Paint
- Seats
- Stationary Glass
- Weatherstrip/Seals
- Body Structure
- Body
- Power Window System
- Body Diagnostic Procedures
- Body, Cab Control Systems
- Brakes
- Anti-Lock Brakes
- Anti-Lock Brake System
- Chassis Diagnostic Procedures - Anti-Lock Brake System
- Introduction
- Identification Of System
- System Description And Functional Operation
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Brakes (Cab) - Symptoms
- Symptom: BUS SYSTEM COMMUNICATION
- Symptom: CAB INTERNAL FAILURE
- Symptom: CLUSTER LAMP FAILURE
- Symptom: INCORRECT TONE WHEEL FAILURE
- Symptom List: LEFT FRONT SENSOR CIRCUIT FAILURE; LEFT REAR SENSOR CIRCUIT FAILURE; RIGHT FRONT SENSOR CIRCUIT FAILURE; RIGHT REAR SENSOR CIRCUIT FAILURE
- Symptom List: LEFT FRONT WHEEL SPEED SIGNAL FAILURE; LEFT REAR WHEEL SPEED SIGNAL FAILURE; RIGHT FRONT WHEEL SPEED SIGNAL FAILURE; RIGHT REAR WHEEL SPEED SIGNAL FAILURE
- Symptom: PUMP CIRCUIT FAILURE
- Symptom: SYSTEM OVER VOLTAGE
- Symptom: SYSTEM UNDER VOLTAGE
- Symptom: VALVE POWER FEED FAILURE
- Symptom: *BRAKE LAMP SWITCH INOPERATIVE
- Communication - Symptoms
- Verification Tests
- Brakes (Cab) - Symptoms
- Component Locations
- Connector PINOUTS
- Abs Pump Motor (Connector Side) - 2 Way
- Brake Lamp Switch - Black 6 Way
- Controller Antilock Brake - Black 24 Way
- Data Link Connector - Black 16 Way
- Power Distribution Center
- Wheel Speed Sensor-Left Front - LT.Gray 2 Way
- Wheel Speed Sensor-Left Rear - Gray 2 Way
- Wheel Speed Sensor-Right Front - LT.Gray 2 Way
- Wheel Speed Sensor-Right Rear - Gray 2 Way
- Schematic Diagrams
- Mechanical - Hydraulic
- Mechanical Brake System - Base (Service Information)
- Brakes - Base
- Adjustable Pedals Switch
- Brake Fluid Level Switch
- Hydraulic/Mechanical
- Brake Lines
- Brake Pads/Shoes - Front/Rear
- Disc Brake Caliper - Front
- Disc Brake Caliper - Rear
- Fluid
- Master Cylinder
- Pedals - Adjustable
- Power Brake Booster
- Rotor
- Parking Brake
- Cable - Parking Brake
- Caliper - Parking Brake
- Lever - Parking Brake
- Pads/Shoes - Parking Brake
- Mechanical Brake System - Base (Service Information)
- Parking Brake System
- Mechanical Brake System - Base (Service Information)
- Brakes - Base
- Adjustable Pedals Switch
- Brake Fluid Level Switch
- Hydraulic/Mechanical
- Brake Lines
- Brake Pads/Shoes - Front/Rear
- Disc Brake Caliper - Front
- Disc Brake Caliper - Rear
- Fluid
- Master Cylinder
- Pedals - Adjustable
- Power Brake Booster
- Rotor
- Parking Brake
- Cable - Parking Brake
- Caliper - Parking Brake
- Lever - Parking Brake
- Pads/Shoes - Parking Brake
- Mechanical Brake System - Base (Service Information)
- Traction Control
- Anti-Lock Brake System
- Chassis Diagnostic Procedures - Anti-Lock Brake System
- Introduction
- Identification Of System
- System Description And Functional Operation
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Brakes (Cab) - Symptoms
- Symptom: BUS SYSTEM COMMUNICATION
- Symptom: CAB INTERNAL FAILURE
- Symptom: CLUSTER LAMP FAILURE
- Symptom: INCORRECT TONE WHEEL FAILURE
- Symptom List: LEFT FRONT SENSOR CIRCUIT FAILURE; LEFT REAR SENSOR CIRCUIT FAILURE; RIGHT FRONT SENSOR CIRCUIT FAILURE; RIGHT REAR SENSOR CIRCUIT FAILURE
- Symptom List: LEFT FRONT WHEEL SPEED SIGNAL FAILURE; LEFT REAR WHEEL SPEED SIGNAL FAILURE; RIGHT FRONT WHEEL SPEED SIGNAL FAILURE; RIGHT REAR WHEEL SPEED SIGNAL FAILURE
- Symptom: PUMP CIRCUIT FAILURE
- Symptom: SYSTEM OVER VOLTAGE
- Symptom: SYSTEM UNDER VOLTAGE
- Symptom: VALVE POWER FEED FAILURE
- Symptom: *BRAKE LAMP SWITCH INOPERATIVE
- Communication - Symptoms
- Verification Tests
- Brakes (Cab) - Symptoms
- Component Locations
- Connector PINOUTS
- Abs Pump Motor (Connector Side) - 2 Way
- Brake Lamp Switch - Black 6 Way
- Controller Antilock Brake - Black 24 Way
- Data Link Connector - Black 16 Way
- Power Distribution Center
- Wheel Speed Sensor-Left Front - LT.Gray 2 Way
- Wheel Speed Sensor-Left Rear - Gray 2 Way
- Wheel Speed Sensor-Right Front - LT.Gray 2 Way
- Wheel Speed Sensor-Right Rear - Gray 2 Way
- Schematic Diagrams
- Anti-Lock Brakes
- Drivelines & Axles
- Axle Shafts
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Electrical
- Body Electrical
- Connector End Views
- Connector Pin-Outs
- A/C Compressor Clutch Connector End View
- A/C Low Pressure Switch Connector End View
- A/C Pressure Transducer Connector End View
- A/C Heater Control Connector End View (C1)
- A/C Heater Control Connector End View (C2)
- Adjustable Pedals Motor Connector End View
- Adjustable Pedals Switch Connector End View
- Airbag Control Module (Occupant Restraint Control) Connector End View (C1)
- Airbag Control Module (Occupant Restraint Control) Connector End View (C2)
- Passenger Airbag On Off Switch Connector End View
- Driver Airbag Squib 1 Connector End View
- Driver Airbag Squib 2 Connector End View
- Passenger Airbag Squib Connector End View
- Decklid Ajar Switch Connector End View
- Driver Door Ajar Switch Connector End View
- Hood Ajar Switch Connector End View
- Passenger Door Ajar Switch Connector End View
- Amplifier Antenna Connector End View
- Backup Lamp Switch Connector End View
- Left Backup Lamp Connector End View
- Right Backup Lamp Connector End View
- Battery Temperature Sensor Connector End View
- Negative Battery Connector End View
- Positive Battery Connector End View
- Blend Door Actuator Connector End View
- Blower Motor Connector End View
- Blower Motor Resistor Block Connector End View
- Body Control Module Connector End View (C1)
- Body Control Module Connector End View (C2)
- Body Control Module Connector End View (C3)
- Body Control Module Connector End View (C4)
- Brake Fluid Level Switch Connector End View
- Brake Lamp Switch Connector End View
- Headlamp And Dash Side Inline Connector End View (C100)
- Instrument Panel Side Inline Connector End View (C100)
- Inline (Instrument Panel Side) Connector End View (C101)
- Inline (Headlamp And Dash Side) Connector End View (C101)
- Inline (Headlamp And Dash Side) Connector End View (C102)
- Body Side Inline Connector End View (C102)
- Inline (Headlamp And Dash Side) Connector End View (C103)
- Body Side Inline Connector End View (C103)
- Inline (Headlamp And Dash Side) Connector End View (C104)
- Engine Side Inline Connector End View (C104)
- Inline (Headlamp And Dash Side) Connector End View (C106)
- Inline (Left Headlamp Jumper Side) Connector End View (C106)
- Inline (Right Headlamp Jumper Side) Connector End View (C107)
- Inline (Headlamp And Dash Side) Connector End View (C107)
- Instrument Panel Side Inline Connector End View (C200)
- Body Side Inline Connector End View (C200)
- Body Side Inline Connector End View (C201)
- Instrument Panel Side Inline Connector End View (C201)
- Instrument Panel Side Inline Connector End View (C202)
- Driver Door Side Inline Connector End View (C202)
- Inline (Passenger Door Side) Connector End View (C203)
- Inline (Instrument Panel Side) Connector End View (C203)
- Inline (HVAC Jumper Side) Connector End View (C204)
- Inline (Instrument Panel Side) Connector End View (C204)
- Inline (Mirror Jumper Side) Connector End View (C205)
- Inline (Instrument Panel Side) Connector End View (C205)
- Inline (Instrument Panel Side) Connector End View (C206)
- Console Jumper Side Inline Connector End View (C206)
- Inline (Instrument Panel Side) Connector End View (C207)
- Inline (Passenger Door Side) Connector End View (C207)
- Driver Door Side Inline Connector End View (C208)
- Inline (Instrument Panel Side) Connector End View (C208)
- Transmission Side Inline Connector End View (C300)
- Body Side Inline Connector End View (C300)
- Body Side Inline Connector End View (C301)
- Inline (Left Tail Lamp Side) Connector End View (C301)
- Inline (Right Tail Lamp Side) Connector End View (C302)
- Body Side Inline Connector End View (C302)
- Decklid Jumper Side Inline Connector End View (C303)
- Body Side Inline Connector End View (C303)
- Camshaft Position Sensor Connector End View
- Center High Mounted Stop Lamp Connector End View
- Cigar Lighter Outlet Connector End View
- Clockspring Connector End View
- Clutch Interlock Switch Connector End View
- Antilock Brake Controller Connector End View
- Crankshaft Position Sensor Connector End View
- Driver Cylinder Unlock Switch Connector End View
- Data Link Connector, Connector End View
- Decklid Release Motor Connector End View
- Driver Door Latch Motor Connector End View
- Passenger Door Latch Motor Connector End View
- Driver Door Lock Switch Connector End View
- Passenger Door Lock Switch Connector End View
- Engine Coolant Temperature Sensor Connector End View
- Engine Oil Pressure Sensor Connector End View
- Engine Oil Temperature Sensor Connector End View
- EVAP Purge Solenoid Connector End View
- Driver Exterior Door Handle Switch Connector End View
- Passenger Exterior Door Handle Switch Connector End View
- Left Fog Lamp Connector End View
- Right Fog Lamp Connector End View
- Left Footwell Lamp Connector End View
- Right Footwell Lamp Connector End View
- Fuel Injector 1 Connector End View
- Fuel Injector 2 Connector End View
- Fuel Injector 3 Connector End View
- Fuel Injector 4 Connector End View
- Fuel Injector 5 Connector End View
- Fuel Injector 6 Connector End View
- Fuel Injector 7 Connector End View
- Fuel Injector 8 Connector End View
- Fuel Injector 9 Connector End View
- Fuel Injector 10 Connector End View
- Fuel Tank Module Connector End View
- Gauge Cluster Connector End View (C1)
- Gauge Cluster Connector End View (C2)
- Generator Connector End View
- Glove Box Lamp Connector End View
- Left HID Lamp Connector End View
- Right HID Lamp Connector End View
- Left High Beam Headlamp Connector End View
- Right High Beam Headlamp Connector End View
- Switch Horn Connector End View
- High Note Horn Connector End View
- Low Note Horn Connector End View
- Hydraulic Cooling Module Connector End View
- Idle Air Control Motor Connector End View
- Left Ignition Coil Pack Connector End View
- Right Ignition Coil Pack Connector End View
- Ignition Switch Connector End View
- Illuminated Rearview Mirror Connector End View
- Instrument Cluster Connector End View (C1)
- Instrument Cluster Connector End View (C2)
- Intake Air Temperature Sensor Connector End View
- Driver Interior Door Handle Switch Connector End View
- Passenger Interior Door Handle Switch Connector End View
- Key In Switch Halo Lamp Connector End View
- Knock Sensor 1 Connector End View
- Knock Sensor 2 Connector End View
- Leak Detection Pump Connector End View
- Left License Lamp Connector End View
- Right License Lamp Connector End View
- Manifold Absolute Pressure Sensor Connector End View
- Left Front Marker Lamp Connector End View
- Left Rear Marker Lamp Connector End View
- Right Front Marker Lamp Connector End View
- Right Rear Marker Lamp Connector End View
- Mode Door Defrost To Floor Actuator 1 Connector End View
- Mode Door Actuator 2 (Panel To Floor) Connector End View
- Multifunction Switch Connector End View
- Left Bank Up Oxygen Sensor 1/1 Connector End View
- Left Bank Down Oxygen Sensor 1/2 Connector End View
- Right Bank Up Oxygen Sensor 2/1 Connector End View
- Right Bank Down Oxygen Sensor 2/2 Connector End View
- Park Brake Switch Connector End View
- Left Park Turn Lamp Connector End View
- Right Park Turn Lamp Connector End View
- Power Amplifier Connector End View (C1)
- Power Amplifier Connector End View (C2)
- Power Distribution Center Eyelet Connector End View
- Power Mirror Switch Connector End View
- Driver Power Mirror Connector End View
- Passenger Power Mirror Connector End View
- Power Outlet Connector End View
- Driver Power Window Motor Connector End View
- Passenger Power Window Motor Connector End View
- Driver Power Window Switch Connector End View
- Passenger Power Window Switch Connector End View
- Powertrain Control Module Connector End View (C1)
- Powertrain Control Module Connector End View (C2)
- Powertrain Control Module Connector End View (C3)
- Push Button Starter Switch Connector End View
- Radio Connector End View
- Rear Window Defogger Feed Connector End View
- Rear Window Defogger Ground Connector End View
- Recirculation Door Actuator Connector End View
- Remote Keyless Entry Module Connector End View
- Left Remote Radio Provision Switch Connector End View
- Right Remote Radio Provision Switch Connector End View
- Reverse Lock Out Solenoid Connector End View
- Driver Seat Belt Switch Connector End View
- Passenger Seat Belt Switch Connector End View
- Driver Seat Belt Tensioner Connector End View
- Passenger Seat Belt Tensioner Connector End View
- Left Shutter Motor Connector End View
- Right Shutter Motor Connector End View
- Skip Shift Solenoid Connector End View
- Left Door Speaker Connector End View
- Left Instrument Panel Speaker Connector End View
- Left Rear Speaker Connector End View
- Rear Woofer Speaker Connector End View
- Right Door Speaker Connector End View
- Right Instrument Panel Speaker Connector End View
- Right Rear Speaker Connector End View
- Starter Motor Connector End View
- Starter Motor Battery Eyelet Connector End View
- Starter Motor Generator Connector End View
- Left Tail Lamp Connector End View
- Right Tail Lamp Connector End View
- Left Tail Stop Lamp Connector End View
- Right Tail Stop Lamp Connector End View
- Throttle Position Sensor Connector End View
- Tire Pressure Monitor Module Connector End View
- Left Rear Turn Signal Lamp Connector End View
- Right Rear Turn Signal Lamp Connector End View
- Vehicle Theft Security System LED Connector End View
- Washer Pump Motor Connector End View
- Left Front Wheel Speed Sensor Connector End View
- Left Rear Wheel Speed Sensor Connector End View
- Right Front Wheel Speed Sensor Connector End View
- Right Rear Wheel Speed Sensor Connector End View
- Passenger Window Down Relay Connector End View
- Passenger Window Up Relay Connector End View
- Wiper Control Module Connector End View
- Wiper Motor Connector End View
- Connector Pin-Outs
- Connector/Ground/Splice Location
- Power Distribution
- Connector End Views
- Charging Systems
- Component Locations
- Fuses & Circuit Breakers
- Gauges
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Body Control Module
- Chime Warning System
- Communication
- Door Ajar System
- Exterior Lighting System
- Relays Controlled By The BCM
- Heating & A/C System
- Instrument Cluster / Gauge Cluster
- Interior Lighting
- Tire Pressure Monitoring System (TPMS)
- Power Door Entry System
- Power Windows
- Electrically Heated Systems
- Vehicle Theft Security System
- Using The DRBIII®
- DRBIII® Error Messages
- DRBIII® Does Not Power Up (Blank Screen)
- Display Is Not Visible
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; ACCELEROMETER 2; INTERNAL 1; OUTPUT DRIVER 1; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: DRIVER SQUIB 2 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 2 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 2 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 2 SHORT TO GROUND
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH OPEN
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO BATTERY
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO GROUND
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO BATTERY
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: PASSENGER SQUIB 2 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 2 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 2 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 2 SHORT TO GROUND
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom List: CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH BCM
- Chime
- Communication
- Symptom: ACM MESSAGES NOT RECEIVED
- Symptom: AUDIO MESSAGES NOT RECEIVED
- Symptom: COUNTRY CODE NOT PROGRAMMED
- Symptom: INTERNAL BCM FAILURE
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom List: PCI BUS SHORTED TO BATTERY; PCI BUS SHORTED TO GROUND
- Symptom: PCI INTERNAL FAULT
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM BODY CONTROL MODULE
- Symptom: *NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE
- Symptom: *NO RESPONSE FROM HVAC
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM PCM (PCI BUS)
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY)
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM TIRE PRESSURE MONITOR MODULE
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Door Ajar
- Symptom: *DECKLID AJAR CIRCUIT OPEN
- Symptom: *DECKLID AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *DRIVER DOOR AJAR CIRCUIT OPEN
- Symptom: *DRIVER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *HOOD AJAR CIRCUIT OPEN
- Symptom: *HOOD AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *PASSENGER DOOR AJAR CIRCUIT OPEN
- Symptom: *PASSENGER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Electrically Heated Systems
- Exterior Lighting
- Symptom: LEFT FOG LAMP OUTPUT OPEN
- Symptom: LEFT FOG LAMP OUTPUT SHORTED
- Symptom: LEFT HIGH BEAM OUTPUT OPEN
- Symptom: LEFT HIGH BEAM OUTPUT SHORT
- Symptom: LOW BEAM RELAY COIL OUTPUT OPEN/SHORT TO GROUND
- Symptom: LOW BEAM RELAY COIL SHORT TO VOLTAGE
- Symptom: PARK LAMP OUTPUT SHORT
- Symptom: RIGHT FOG LAMP OUTPUT OPEN
- Symptom: RIGHT FOG LAMP OUTPUT SHORTED
- Symptom: RIGHT HIGH BEAM OUTPUT OPEN
- Symptom: RIGHT HIGH BEAM OUTPUT SHORT
- Heating & A/C
- Symptom List: A/C SWITCH FAULT (ACTIVE); CHECKSUM FAILURE (ACTIVE); DEFOG SWITCH FAULT (ACTIVE)
- Symptom List: A/C SWITCH FAULT (STORED); BACKLIGHT DIMMING RX FAILURE (STORED); BLEND OVERCURRENT (STORED); CHECKSUM FAILURE (STORED); DEFOG SWITCH FAULT (STORED); LOOPBACK TEST FAILURE (STORED); MODE 1 OVERCURRENT (STORED); MODE 2 OVERCURRENT (STORED); RECIRC OVERCURRENT (STORED); REFRIGERANT PRESS RX FAILURE (STORED); TX FAILURE (STORED); VIN RX FAILURE (STORED)
- Notes
- When Monitored and Set Condition:
- A/C Switch Fault (Stored)
- Backlight Dimming RX Failure (Stored)
- Blend OVERCURRENT (Stored)
- Checksum Failure (Stored)
- Defog Switch Fault (Stored)
- LOOPBACK Test Failure (Stored)
- Mode 1 OVERCURRENT (Stored)
- Mode 2 OVERCURRENT (Stored)
- RECIRC OVERCURRENT (Stored)
- Refrigerant Press RX Failure (Stored)
- TX Failure (Stored)
- VIN RX Failure (Stored)
- Possible Causes
- Diagnostic Procedure
- Symptom List: ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE; BLEND CIRCUIT SHORTED TO GROUND; BLEND CIRCUIT SHORTED TO IGN OR BATT; COMMON DRIVER SHORTED TO GROUND; COMMON DRIVER SHORTED TO IGN OR BATT; MODE 1 CIRCUIT SHORTED TO GROUND; MODE 1 CIRCUIT SHORTED TO IGN OR BATT; MODE 2 CIRCUIT SHORTED TO GROUND; MODE 2 CIRCUIT SHORTED TO IGN OR BATT; RECIRC CIRCUIT SHORTED TO GROUND; RECIRC CIRCUIT SHORTED TO IGN OR BATT; SHORT TOO COMPLEX
- Notes
- When Monitored and Set Condition:
- Act CKT Test Passed, OVERCURRENT DTCS Active
- Blend Circuit Shorted To Ground
- Blend Circuit Shorted To IGN Or Batt
- Common Driver Shorted To Ground
- Common Driver Shorted To IGN Or Batt
- Mode 1 Circuit Shorted To Ground
- Mode 1 Circuit Shorted To IGN Or Batt
- Mode 2 Circuit Shorted To Ground
- Mode 2 Circuit Shorted To IGN Or Batt
- RECIRC Circuit Shorted To Ground
- RECIRC Circuit Shorted To IGN Or Batt
- Short Too Complex
- Possible Causes
- Diagnostic Procedure
- Symptom: BACKLIGHT DIMMING RX FAILURE (ACTIVE)
- Symptom List: BLEND CALIBRATION FAULT; MODE 1 CALIBRATION FAULT; MODE 2 CALIBRATION FAULT; RECIRCULATION CALIBRATION FAULT
- Symptom List: BLEND OVERCURRENT (ACTIVE); MODE 1 OVERCURRENT (ACTIVE); MODE 2 OVERCURRENT (ACTIVE); RECIRC OVERCURRENT (ACTIVE)
- Symptom: DEFOG RELAY CONTROL CKT SHORTED TO BATT
- Symptom: LOOPBACK TEST FAILURE (ACTIVE)
- Symptom List: REFRIGERANT PRESSURE RX FAILURE (ACTIVE); VIN RX FAILURE (ACTIVE)
- Symptom: TX FAILURE (ACTIVE)
- Symptom: *A/C - HEATER CONTROL ILLUMINATION INOPERATIVE
- Symptom: *BLEND/MODE/RECIRC DOOR OPERATION IMPROPER
- Symptom: *BLOWER MOTOR INOPERATIVE
- Symptom: *BLOWER MOTOR SPEEDS INCORRECT
- Symptom: *EBL STATUS INDICATOR FLASHING
- Symptom: *HVAC SYSTEM TEST
- Ignition, Power, Accessory
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT OPEN
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT SHORT TO GROUND
- Symptom: BCM - IGNITION MUX SWITCH INPUT MISMATCH
- Symptom: BCM - IGNITION MUX SWITCH INPUT OPEN
- Symptom: BCM - IGNITION MUX SWITCH INPUT SHORT
- Symptom: BCM - IGNITION RUN 1 SHORT
- Symptom: BCM - IGNITION RUN 2 SHORT
- Symptom: BCM - IOD OUTPUT CIRCUIT SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT OPEN / SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT SHORT TO VOLTAGE
- Symptom: BCM - RUN/START HARDWIRE INPUT MISMATCH
- Symptom: HORN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: HORN RELAY COIL SHORT TO BATTERY
- Symptom: HORN SWITCH STUCK
- Symptom: *HORNS INOPERATIVE
- Instrument Cluster
- Symptom List: ABS LAMP CIRCUIT OPEN; ABS LAMP CIRCUIT SHORTED; AIRBAG LAMP CIRCUIT OPEN; AIRBAG LAMP CIRCUIT SHORTED
- Symptom: ABS MESSAGES NOT RECEIVED
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT OPEN / SHORTED TO VOLTAGE
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT SHORT TO GROUND
- Symptom: BCM - PWM DIMMING OUTPUT SHORT
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: ORC MESSAGES NOT RECEIVED
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *GAUGE CLUSTER DIAGNOSTIC TEST
- Symptom: *INSTRUMENT CLUSTER DIAGNOSTIC TEST
- Interior Lighting
- Power Door Locks/RKE
- Symptom: DECKLID RELEASE OUTPUT OPEN
- Symptom: DECKLID RELEASE OUTPUT SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH OPEN OR SHORT TO VOLTAGE
- Symptom: DRIVER CYLINDER UNLOCK SWITCH SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH STUCK
- Symptom: DRIVER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: DRIVER DOOR LOCK SWITCH STUCK
- Symptom: DRIVER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: DRIVER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: DRIVER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER DOOR LOCK SWITCH STUCK
- Symptom: PASSENGER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER/DRIVER DOOR UNLATCH RETURN SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT OPEN/SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT SHORT TO BATTERY
- Symptom: *ALL DOOR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR UNLATCH INOPERATIVE
- Symptom: *PASSENGER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *PASSENGER DOOR UNLATCH INOPERATIVE
- Symptom: *REMOTE KEYLESS ENTRY PROBLEM
- Power Windows
- Symptom: DRIVER WINDOW DOWN OUTPUT SHORT TO GROUND
- Symptom: DRIVER WINDOW HALL EFFECT FAILURE
- Symptom: DRIVER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: DRIVER WINDOW SWITCH SHORT TO GROUND
- Symptom: DRIVER WINDOW SWITCH STUCK DOWN
- Symptom: DRIVER WINDOW SWITCH STUCK UP
- Symptom: DRIVER WINDOW UP OUTPUT SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL SHORT TO BATTERY
- Symptom: PASSENGER WINDOW HALL EFFECT FAILURE
- Symptom: PASSENGER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: PASSENGER WINDOW SWITCH SHORT TO GROUND
- Symptom: PASSENGER WINDOW SWITCH STUCK DOWN
- Symptom: PASSENGER WINDOW SWITCH STUCK UP
- Symptom: PASSENGER WINDOW UP SHORT TO GROUND
- Symptom: *DRIVER WINDOW INOPERATIVE
- Symptom: *PASSENGER WINDOW INOPERATIVE
- Tire Pressure Monitoring
- Symptom: CRITICAL TIRE PRESSURE - BCM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM
- Symptom: TIRE PRESSURE LOW - BCM
- Symptom: TIRE PRESSURE MONITOR MODULE FAILURE - TPM
- Symptom: TPM DIAGNOSTIC - BCM
- Symptom: TPM MODULE INITIALIZED - BCM
- Symptom: *LO TIRE LCD MESSAGE FLASHING
- Vehicle Theft/Security
- Symptom: VTSS INDICATOR OUTPUT OPEN
- Symptom: VTSS INDICATOR OUTPUT SHORT
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *DECKLID DOES NOT TRIP VTSS
- Symptom: *DRIVER DOOR DOES NOT TRIP VTSS
- Symptom: *EXTERIOR LAMPS FAIL TO FLASH WHEN ALARM IS TRIPPED
- Symptom: *HOOD DOES NOT TRIP VTSS
- Symptom: *HORN FAILS TO SOUND WHEN ALARM IS TRIPPED
- Symptom: *PASSENGER DOOR DOES NOT TRIP VTSS
- Symptom: *VTSS LAMP ON STEADY DURING ARMING
- Symptom: *VTSS WILL NOT ARM
- Verification Tests
- Airbag
- Component Locations
- Connector PINOUTS
- A/C-Heater Control C1 - Black 10 Way
- A/C-Heater Control C2 - Black 16 Way
- Airbag Control Module C1 (Orc) - Yellow 32 Way
- Airbag Control Module C2 (Orc) - Yellow 32 Way
- Airbag On/Off Switch-Passenger - Yellow 6 Way
- Airbag Squib 1-Driver - Yellow/Black 2 Way
- Airbag Squib 2-Driver - Yellow/Gray 2 Way
- Airbag Squib-Passenger - Yellow 4 Way
- Ajar Switch-DECKLID - Black 3 Way
- Ajar Switch-Driver Door - Black 4 Way
- Ajar Switch-Hood - Natural 3 Way
- Ajar Switch-Passenger Door - Black 4 Way
- Blend Door Actuator - Gray 2 Way
- Blower Motor - Orange 2 Way
- Blower Motor Resistor Block - Black 4 Way
- Body Control Module C1 - Black 6 Way
- Body Control Module C2 - Black/Green 34 Way
- Body Control Module C3 - Black/White 34 Way
- Body Control Module C4 - Black/Gray 34 Way
- Brake Fluid Level Switch - Black 2 Way
- C200 - Black (Body Side)
- C200 - Black (Instrument Panel Side)
- C201 - Yellow (Body Side)
- C201 - Yellow (Instrument Panel Side)
- C202 - Natural (Driver Door Side)
- C202 - Natural (Instrument Panel Side)
- C203 - Natural (Instrument Panel Side)
- C203 - Natural (Passenger Door Side)
- C204 - LT. Gray (HVAC Jumper Side)
- C204 - LT. Gray (Instrument Panel Side)
- C206 - Red (Console Jumper Side)
- C206 - Red (Instrument Panel Side)
- C207 - Green (Instrument Panel Side)
- C207 - Natural (Passenger Door Side)
- C208 - Green (Instrument Panel Side)
- C208 - Natural (Driver Door Side)
- C303 - Black (Body Side)
- C303 - Black (DECKLID Jumper Side)
- CLOCKSPRING - White 8 Way
- Controller Antilock Brake - Black 24 Way
- Cylinder Unlock Switch-Driver - Black 2 Way
- Data Link Connector - Black 16 Way
- DECKLID Release Motor - Black 2 Way
- Door Latch Motor-Driver - 2 Way
- Door Latch Motor-Passenger - 2 Way
- Door Lock Switch-Driver - Black 3 Way
- Door Lock Switch-Passenger - Black 3 Way
- Exterior Door Handle Switch-Driver - Black 2 Way
- Exterior Door Handle Switch-Passenger - Black 2 Way
- Fog Lamp-Left - Black 2 Way
- Gauge Cluster C1 - White 3 Way
- Gauge Cluster C2 - Black 20 Way
- Hid Lamp-Left - Gray 2 Way
- High Beam Headlamp-Left - Black 2 Way
- Horn Switch - Black 1 Way
- Horn-High Note - Black 2 Way
- Horn-Low Note - Black 2 Way
- Ignition Switch - Black 5 Way
- Instrument Cluster C1 - Black 16 Way
- Instrument Cluster C2 - Black 20 Way
- Interior Door Handle Switch-Driver - Black 2 Way
- Interior Door Handle Switch-Passenger - Black 2 Way
- Marker Lamp-Left Front - DK. Gray 2 Way
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way
- Multi-Function Switch - Gray 20 Way
- Power Distribution Center
- Power Window Motor-Driver - Black 6 Way
- Power Window Motor-Passenger - Black 6 Way
- Power Window Switch-Driver - Gray 3 Way
- Power Window Switch-Passenger - Gray 3 Way
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Radio - Gray 22 Way
- RECIRCULATION Door Actuator - Gray 2 Way
- Remote Keyless Entry Module - Black 6 Way
- Seat Belt Switch-Driver - White 2 Way
- Seat Belt Switch-Passenger - White 2 Way
- Seat Belt TENSIONER-Driver - Yellow 2 Way
- Seat Belt TENSIONER-Passenger - Yellow 2 Way
- Speaker-Left Door - Black 2 Way
- Speaker-Left Instrument Panel - White 2 Way
- Speaker-Left Rear - White 3 Way
- Speaker-Rear Woofer - Gray 4 Way
- Speaker-Right Door - Black 2 Way
- Speaker-Right Instrument Panel - White 2 Way
- Speaker-Right Rear - White 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Window Down Relay-Passenger - Black 5 Way
- Window Up Relay-Passenger - Black 5 Way
- Schematic Diagrams
- Airbag System
- Audio System
- Chime System
- Communication
- Door Ajar System
- Electrically Heated Systems
- Exterior Lighting
- Heating & A/C System
- Ignition, Power, Accessory
- Instrument Cluster/Gauge Cluster
- Interior Lighting
- Power Door Locks/RKE
- Power Window System
- Tire Pressure Monitor Module (TPM)
- Vehicle Theft Security System
- Instrument Cluster
- Interior/Exterior
- Body
- Warning
- Diagnosis And Testing
- Standard Procedure
- Standard Procedure - Plastic Body Panel Repair
- Notes
- Rigid Plastics:
- Semi-Rigid Plastics:
- Flexible Plastics:
- Repair Procedure:
- Adhesion Promoter/Surface Modifier:
- Safety Precaution And Warnings
- Rigid, Semi-Rigid, And Flexible Plastic Parts Types
- Panel Sectioning
- Panel Reinforcement
- Visual Inspection
- Panel Surface Preparation
- Patching Panels
- Panel Patch Fabrications
- Panel Patch Installation
- Patched Panel Surfacing
- Standard Procedure - Heat Staking
- Standard Procedure - Plastic Body Panel Repair
- Specifications
- Special Tools
- Convertible Top
- DECKLID
- Door - Front
- Exterior
- Hood
- Instrument Panel
- Interior
- Paint
- Seats
- Stationary Glass
- Weatherstrip/Seals
- Body Structure
- Body
- Body Diagnostic Procedures
- Horns
- Motors, Switches, Relays
- Connector End Views
- Connector Pin-Outs
- A/C Compressor Clutch Connector End View
- A/C Low Pressure Switch Connector End View
- A/C Pressure Transducer Connector End View
- A/C Heater Control Connector End View (C1)
- A/C Heater Control Connector End View (C2)
- Adjustable Pedals Motor Connector End View
- Adjustable Pedals Switch Connector End View
- Airbag Control Module (Occupant Restraint Control) Connector End View (C1)
- Airbag Control Module (Occupant Restraint Control) Connector End View (C2)
- Passenger Airbag On Off Switch Connector End View
- Driver Airbag Squib 1 Connector End View
- Driver Airbag Squib 2 Connector End View
- Passenger Airbag Squib Connector End View
- Decklid Ajar Switch Connector End View
- Driver Door Ajar Switch Connector End View
- Hood Ajar Switch Connector End View
- Passenger Door Ajar Switch Connector End View
- Amplifier Antenna Connector End View
- Backup Lamp Switch Connector End View
- Left Backup Lamp Connector End View
- Right Backup Lamp Connector End View
- Battery Temperature Sensor Connector End View
- Negative Battery Connector End View
- Positive Battery Connector End View
- Blend Door Actuator Connector End View
- Blower Motor Connector End View
- Blower Motor Resistor Block Connector End View
- Body Control Module Connector End View (C1)
- Body Control Module Connector End View (C2)
- Body Control Module Connector End View (C3)
- Body Control Module Connector End View (C4)
- Brake Fluid Level Switch Connector End View
- Brake Lamp Switch Connector End View
- Headlamp And Dash Side Inline Connector End View (C100)
- Instrument Panel Side Inline Connector End View (C100)
- Inline (Instrument Panel Side) Connector End View (C101)
- Inline (Headlamp And Dash Side) Connector End View (C101)
- Inline (Headlamp And Dash Side) Connector End View (C102)
- Body Side Inline Connector End View (C102)
- Inline (Headlamp And Dash Side) Connector End View (C103)
- Body Side Inline Connector End View (C103)
- Inline (Headlamp And Dash Side) Connector End View (C104)
- Engine Side Inline Connector End View (C104)
- Inline (Headlamp And Dash Side) Connector End View (C106)
- Inline (Left Headlamp Jumper Side) Connector End View (C106)
- Inline (Right Headlamp Jumper Side) Connector End View (C107)
- Inline (Headlamp And Dash Side) Connector End View (C107)
- Instrument Panel Side Inline Connector End View (C200)
- Body Side Inline Connector End View (C200)
- Body Side Inline Connector End View (C201)
- Instrument Panel Side Inline Connector End View (C201)
- Instrument Panel Side Inline Connector End View (C202)
- Driver Door Side Inline Connector End View (C202)
- Inline (Passenger Door Side) Connector End View (C203)
- Inline (Instrument Panel Side) Connector End View (C203)
- Inline (HVAC Jumper Side) Connector End View (C204)
- Inline (Instrument Panel Side) Connector End View (C204)
- Inline (Mirror Jumper Side) Connector End View (C205)
- Inline (Instrument Panel Side) Connector End View (C205)
- Inline (Instrument Panel Side) Connector End View (C206)
- Console Jumper Side Inline Connector End View (C206)
- Inline (Instrument Panel Side) Connector End View (C207)
- Inline (Passenger Door Side) Connector End View (C207)
- Driver Door Side Inline Connector End View (C208)
- Inline (Instrument Panel Side) Connector End View (C208)
- Transmission Side Inline Connector End View (C300)
- Body Side Inline Connector End View (C300)
- Body Side Inline Connector End View (C301)
- Inline (Left Tail Lamp Side) Connector End View (C301)
- Inline (Right Tail Lamp Side) Connector End View (C302)
- Body Side Inline Connector End View (C302)
- Decklid Jumper Side Inline Connector End View (C303)
- Body Side Inline Connector End View (C303)
- Camshaft Position Sensor Connector End View
- Center High Mounted Stop Lamp Connector End View
- Cigar Lighter Outlet Connector End View
- Clockspring Connector End View
- Clutch Interlock Switch Connector End View
- Antilock Brake Controller Connector End View
- Crankshaft Position Sensor Connector End View
- Driver Cylinder Unlock Switch Connector End View
- Data Link Connector, Connector End View
- Decklid Release Motor Connector End View
- Driver Door Latch Motor Connector End View
- Passenger Door Latch Motor Connector End View
- Driver Door Lock Switch Connector End View
- Passenger Door Lock Switch Connector End View
- Engine Coolant Temperature Sensor Connector End View
- Engine Oil Pressure Sensor Connector End View
- Engine Oil Temperature Sensor Connector End View
- EVAP Purge Solenoid Connector End View
- Driver Exterior Door Handle Switch Connector End View
- Passenger Exterior Door Handle Switch Connector End View
- Left Fog Lamp Connector End View
- Right Fog Lamp Connector End View
- Left Footwell Lamp Connector End View
- Right Footwell Lamp Connector End View
- Fuel Injector 1 Connector End View
- Fuel Injector 2 Connector End View
- Fuel Injector 3 Connector End View
- Fuel Injector 4 Connector End View
- Fuel Injector 5 Connector End View
- Fuel Injector 6 Connector End View
- Fuel Injector 7 Connector End View
- Fuel Injector 8 Connector End View
- Fuel Injector 9 Connector End View
- Fuel Injector 10 Connector End View
- Fuel Tank Module Connector End View
- Gauge Cluster Connector End View (C1)
- Gauge Cluster Connector End View (C2)
- Generator Connector End View
- Glove Box Lamp Connector End View
- Left HID Lamp Connector End View
- Right HID Lamp Connector End View
- Left High Beam Headlamp Connector End View
- Right High Beam Headlamp Connector End View
- Switch Horn Connector End View
- High Note Horn Connector End View
- Low Note Horn Connector End View
- Hydraulic Cooling Module Connector End View
- Idle Air Control Motor Connector End View
- Left Ignition Coil Pack Connector End View
- Right Ignition Coil Pack Connector End View
- Ignition Switch Connector End View
- Illuminated Rearview Mirror Connector End View
- Instrument Cluster Connector End View (C1)
- Instrument Cluster Connector End View (C2)
- Intake Air Temperature Sensor Connector End View
- Driver Interior Door Handle Switch Connector End View
- Passenger Interior Door Handle Switch Connector End View
- Key In Switch Halo Lamp Connector End View
- Knock Sensor 1 Connector End View
- Knock Sensor 2 Connector End View
- Leak Detection Pump Connector End View
- Left License Lamp Connector End View
- Right License Lamp Connector End View
- Manifold Absolute Pressure Sensor Connector End View
- Left Front Marker Lamp Connector End View
- Left Rear Marker Lamp Connector End View
- Right Front Marker Lamp Connector End View
- Right Rear Marker Lamp Connector End View
- Mode Door Defrost To Floor Actuator 1 Connector End View
- Mode Door Actuator 2 (Panel To Floor) Connector End View
- Multifunction Switch Connector End View
- Left Bank Up Oxygen Sensor 1/1 Connector End View
- Left Bank Down Oxygen Sensor 1/2 Connector End View
- Right Bank Up Oxygen Sensor 2/1 Connector End View
- Right Bank Down Oxygen Sensor 2/2 Connector End View
- Park Brake Switch Connector End View
- Left Park Turn Lamp Connector End View
- Right Park Turn Lamp Connector End View
- Power Amplifier Connector End View (C1)
- Power Amplifier Connector End View (C2)
- Power Distribution Center Eyelet Connector End View
- Power Mirror Switch Connector End View
- Driver Power Mirror Connector End View
- Passenger Power Mirror Connector End View
- Power Outlet Connector End View
- Driver Power Window Motor Connector End View
- Passenger Power Window Motor Connector End View
- Driver Power Window Switch Connector End View
- Passenger Power Window Switch Connector End View
- Powertrain Control Module Connector End View (C1)
- Powertrain Control Module Connector End View (C2)
- Powertrain Control Module Connector End View (C3)
- Push Button Starter Switch Connector End View
- Radio Connector End View
- Rear Window Defogger Feed Connector End View
- Rear Window Defogger Ground Connector End View
- Recirculation Door Actuator Connector End View
- Remote Keyless Entry Module Connector End View
- Left Remote Radio Provision Switch Connector End View
- Right Remote Radio Provision Switch Connector End View
- Reverse Lock Out Solenoid Connector End View
- Driver Seat Belt Switch Connector End View
- Passenger Seat Belt Switch Connector End View
- Driver Seat Belt Tensioner Connector End View
- Passenger Seat Belt Tensioner Connector End View
- Left Shutter Motor Connector End View
- Right Shutter Motor Connector End View
- Skip Shift Solenoid Connector End View
- Left Door Speaker Connector End View
- Left Instrument Panel Speaker Connector End View
- Left Rear Speaker Connector End View
- Rear Woofer Speaker Connector End View
- Right Door Speaker Connector End View
- Right Instrument Panel Speaker Connector End View
- Right Rear Speaker Connector End View
- Starter Motor Connector End View
- Starter Motor Battery Eyelet Connector End View
- Starter Motor Generator Connector End View
- Left Tail Lamp Connector End View
- Right Tail Lamp Connector End View
- Left Tail Stop Lamp Connector End View
- Right Tail Stop Lamp Connector End View
- Throttle Position Sensor Connector End View
- Tire Pressure Monitor Module Connector End View
- Left Rear Turn Signal Lamp Connector End View
- Right Rear Turn Signal Lamp Connector End View
- Vehicle Theft Security System LED Connector End View
- Washer Pump Motor Connector End View
- Left Front Wheel Speed Sensor Connector End View
- Left Rear Wheel Speed Sensor Connector End View
- Right Front Wheel Speed Sensor Connector End View
- Right Rear Wheel Speed Sensor Connector End View
- Passenger Window Down Relay Connector End View
- Passenger Window Up Relay Connector End View
- Wiper Control Module Connector End View
- Wiper Motor Connector End View
- Connector Pin-Outs
- Connector/Ground/Splice Location
- Power Distribution
- Connector End Views
- Starter
- Powertrain Diagnostic Procedures
- DTC Index
- Introduction
- Identification Of System
- System Description And Functional Operation
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Acronyms
- Diagnostic Information And Procedures
- Communication - Symptoms
- DRIVEABILITY - Gas - Symptoms
- Symptom: INTERMITTENT CONDITION
- Symptom: *BRAKE SWITCH SENSE STATUS DOES NOT CHANGE ON DRBIII®
- Symptom: *CANNOT SHIFT INTO 2ND AND 3RD GEARS
- Symptom: *CANNOT SHIFT INTO REVERSE
- Symptom: *CHECKING A/C SYSTEM OPERATION WITH NO DTCS
- Symptom: *CHECKING CHARGING SYSTEM OPERATION WITH NO DTCS
- Symptom: *CHECKING RADIATOR FAN OPERATION
- Symptom: *CHECKING THE PCM POWER AND GROUNDS
- DRIVEABILITY - Gas - Diagnostic Tests
- P0031-O2 Sensor 1/1 Heater Circuit Low; P0032-O2 Sensor 1/1 Heater Circuit High; P0051-O2 Sensor 2/1 Heater Circuit Low; P0052-O2 Sensor 2/1 Heater Circuit High
- P0071-Ambient/Battery Temp Sensor Performance
- P0107-Map Sensor Voltage Too Low
- P0108-Map Sensor Voltage Too High
- P0111-Intake Air Temp Performance
- P0112-Intake Air Temp Sensor Voltage Too Low
- P0113-Intake Air Temp Sensor Voltage Too High
- P0117-Engine Coolant Temp Sensor Voltage Too Low
- P0118-Engine Coolant Temp Sensor Voltage Too High
- P0121-TP Sensor Voltage Does Not Agree With Map
- P0122-Throttle Position Sensor #1 Voltage Too Low
- P0123-Throttle Position Sensor #1 Voltage Too High
- P0125-Closed Loop Temp Not Reached
- P0131-O2 Sensor 1/1 Circuit Voltage Too Low; P0137-O2 Sensor 1/2 Circuit Voltage Too Low; P0151-O2 Sensor 2/1 Circuit Voltage Too Low; P0157-O2 Sensor 2/2 Circuit Voltage Too Low
- P0132-O2 Sensor 1/1 Circuit Voltage Too High; P0138-O2 Sensor 1/2 Circuit Voltage Too High; P0152-O2 Sensor 2/1 Circuit Voltage Too High; P0158-O2 Sensor 2/2 Circuit Voltage Too High
- P0133-O2 Sensor 1/1 Slow Response; P0139-O2 Sensor 1/2 Slow Response; P0153-O2 Sensor 2/1 Slow Response; P0159-O2 Sensor 2/2 Slow Response
- P0135-O2 Sensor 1/1 Heater Failure; P0141-O2 Sensor 1/2 Heater Failure; P0155-O2 Sensor 2/1 Heater Failure; P0161-O2 Sensor 2/2 Heater Failure
- P0136-O2 Sensor 1/2 Heater Circuit Malfunction
- P0171-1/1 Fuel System Lean; P0174-2/1 Fuel System Lean
- P0172-1/1 Fuel System Rich; P0175-2/1 Fuel System Rich
- P0197-Engine Oil Temperature Sensor Voltage Too Low
- P0198-Engine Oil Temperature Sensor Voltage Too High
- P0201-Injector #1 Control Circuit; P0202-Injector #2 Control Circuit; P0203-Injector #3 Control Circuit; P0204-Injector #4 Control Circuit; P0205-Injector #5 Control Circuit; P0206-Injector #6 Control Circuit; P0207-Injector #7 Control Circuit; P0208-Injector #8 Control Circuit; P0209-Injector #9 Control Circuit; P0210-Injector #10 Control Circuit
- Notes
- When Monitored and Set Condition:
- P0201-Injector #1 Control Circuit
- P0202-Injector #2 Control Circuit
- P0203-Injector #3 Control Circuit
- P0204-Injector #4 Control Circuit
- P0205-Injector #5 Control Circuit
- P0206-Injector #6 Control Circuit
- P0207-Injector #7 Control Circuit
- P0208-Injector #8 Control Circuit
- P0209-Injector #9 Control Circuit
- P0210-Injector #10 Control Circuit
- Possible Causes
- Diagnostic Procedure
- P0300-Multiple Cylinder Mis-Fire; P0301-Cylinder #1 Misfire; P0302-Cylinder #2 Misfire; P0303-Cylinder #3 Misfire; P0304-Cylinder #4 Misfire; P0305-Cylinder #5 Misfire; P0306-Cylinder #6 Misfire; P0307-Cylinder #7 Misfire; P0308-Cylinder #8 Misfire; P0309-Cylinder #9 Misfire; P0310-Cylinder #10 Misfire
- P0320-No Crank Reference Signal At Pcm
- P0340-No Cam Reference Signal At Pcm
- P0351-Ignition Coil #1 Primary Circuit; P0352-Ignition Coil #2 Primary Circuit; P0353-Ignition Coil #3 Primary Circuit; P0354-Ignition Coil #4 Primary Circuit; P0355-Ignition Coil #5 Primary Circuit
- P0420-1/1 Catalytic Converter Efficiency; P0432-2/1 Catalytic Converter Efficiency
- P0441-EVAP Purge Flow Monitor
- P0442-EVAP Leak Monitor Medium (0.040) Leak Detected P0455-EVAP Leak Monitor Large Leak Detected
- P0443-EVAP Purge Solenoid Circuit
- P0460-Fuel Level Sending Unit No Change Over Miles
- P0462-Fuel Level Sending Unit Volts Too Low
- P0463-Fuel Level Sending Unit Volts Too High
- P0500-No Vehicle Speed Signal
- P0505-Idle Air Control Motor Circuits
- P0522-Oil Pressure Circuit Low
- P0523-Oil Pressure Circuit High
- P0601-Pcm Internal Controller Failure
- P0622-Generator Field Not Switching Properly
- P0645-A/C Clutch Relay Circuit
- P0801-Reverse Gear Lockout Circuit Open Or Shorted
- P1195-O2 Sensor 1/1 Slow During Catalyst Monitor P1196-O2 Sensor 2/1 Slow During Catalyst Monitor
- P1281-Engine Is Cold Too Long
- P1282-Fuel Pump/System Relay Control Circuit
- P1294-Target Idle Not Reached
- P1296-No 5-Volts To Map Sensor
- P1297-No Change In Map From Start To Run
- P1388-Auto Shutdown Relay Control Circuit
- P1389-No ASD Relay Output Voltage At Pcm
- P1391-Intermittent Loss Of CMP Or CKP
- P1398-Mis-Fire Adaptive Numerator At Limit
- P1486-EVAP Leak Monitor Pinched Hose Found
- P1492-Ambient/Battery Temperature Sensor Voltage Too High
- P1493-Ambient/Battery Temperature Sensor Voltage Too Low
- P1494-Leak Detection Pump Switch Or Mechanical Fault
- P1495-Leak Detection Pump Solenoid Circuit
- P1499-Hydraulic Fan Solenoid Circuit
- P1594-Charging System Voltage Too High
- P1598-A/C Pressure Sensor Voltage Too High
- P1599-A/C Pressure Sensor Voltage Too Low
- P1682-Charging System Voltage Too Low
- P1687-No Cluster Bus Message
- P1695-Bus Message From Body Control Module
- P1696-Pcm Failure EEPROM Write Denied
- P1719-Skip Shift Solenoid Circuit Open Or Shorted
- Starting - Symptoms
- Verification Tests
- Component Locations
- Control Modules And PDC
- Data Link Connector
- Sensors And Solenoids
- Battery Temp. Sensor Location
- Cam Position Sensor Location
- Crank Position Sensor Location
- MAP, ECT And Fuel Injector Locations
- IAT Sensor Location
- Engine Oil Pressure Sensor And Engine Oil Temp. Sensor Locations
- O2 Sensor Locations
- IAC Motor And TPS Locations
- Ignition Coil Locations
- Skip Shift Solenoid And Vehicle Speed Sensor Locations
- Fuel System
- Connector PINOUTS
- A/C Compressor Clutch - Black 2 Way
- A/C Low Pressure Switch - DK. Green 2 Way
- A/C Pressure Transducer - Black 4 Way
- Battery Temperature Sensor - 2 Way
- Brake Lamp Switch - Black 6 Way
- Camshaft Position Sensor - Gray 3 Way
- CLOCKSPRING - White 8 Way
- Clutch Interlock Switch - DK.Green 2 Way
- Crankshaft Position Sensor - Black 3 Way
- Data Link Connector - Black 16 Way
- Engine Coolant Temperature Sensor - Black 2 Way
- Engine Oil Pressure Sensor - Black 3 Way
- Engine Oil Temperature Sensor - Black 2 Way
- EVAP/Purge Solenoid - Black 2 Way
- Fuel Injector No. 1 - Black 2 Way
- Fuel Injector No. 2 - Black 2 Way
- Fuel Injector No. 3 - Black 2 Way
- Fuel Injector No. 4 - Black 2 Way
- Fuel Injector No. 5 - Black 2 Way
- Fuel Injector No. 6 - Black 2 Way
- Fuel Injector No. 7 - Black 2 Way
- Fuel Injector No. 8 - Black 2 Way
- Fuel Injector No. 9 - Black 2 Way
- Fuel Injector No. 10 - Black 2 Way
- Fuel Tank Module - Gray 4 Way
- Generator - Gray 2 Way
- Hydraulic Cooling Module - Black 3 Way
- Idle Air Control Motor - Black 4 Way
- Ignition Coil Pack-Left - Black 4 Way
- Ignition Coil Pack-Right - Black 3 Way
- Ignition Switch - Black 5 Way
- Intake Air Temperature Sensor - Black 2 Way
- Leak Detection Pump - Black 4 Way
- Manifold Absolute Pressure Sensor - Black 3 Way
- Multi-Function Switch - Gray 20 Way
- Oxygen Sensor 1/1 Left Bank Up - Black 4 Way
- Oxygen Sensor 1/2 Left Bank Down - Black 4 Way
- Oxygen Sensor 2/1 Right Bank Up - Black 4 Way
- Oxygen Sensor 2/2 Right Bank Down - Black 4 Way
- Power Distribution Center
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Push-Button Starter Switch - Natural 6 Way
- Reverse Lock-Out Solenoid - White 2 Way
- Skip Shift Solenoid - White 2 Way
- Throttle Position Sensor - Black 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Schematic Diagrams
- Charts And Graphs
- Starting System
- Starting
- Starter Motor
- Starter Motor Relay
- Starter Solenoid
- Powertrain Diagnostic Procedures
- Wiring Diagrams
- Connector End Views
- Connector Pin-Outs
- A/C Compressor Clutch Connector End View
- A/C Low Pressure Switch Connector End View
- A/C Pressure Transducer Connector End View
- A/C Heater Control Connector End View (C1)
- A/C Heater Control Connector End View (C2)
- Adjustable Pedals Motor Connector End View
- Adjustable Pedals Switch Connector End View
- Airbag Control Module (Occupant Restraint Control) Connector End View (C1)
- Airbag Control Module (Occupant Restraint Control) Connector End View (C2)
- Passenger Airbag On Off Switch Connector End View
- Driver Airbag Squib 1 Connector End View
- Driver Airbag Squib 2 Connector End View
- Passenger Airbag Squib Connector End View
- Decklid Ajar Switch Connector End View
- Driver Door Ajar Switch Connector End View
- Hood Ajar Switch Connector End View
- Passenger Door Ajar Switch Connector End View
- Amplifier Antenna Connector End View
- Backup Lamp Switch Connector End View
- Left Backup Lamp Connector End View
- Right Backup Lamp Connector End View
- Battery Temperature Sensor Connector End View
- Negative Battery Connector End View
- Positive Battery Connector End View
- Blend Door Actuator Connector End View
- Blower Motor Connector End View
- Blower Motor Resistor Block Connector End View
- Body Control Module Connector End View (C1)
- Body Control Module Connector End View (C2)
- Body Control Module Connector End View (C3)
- Body Control Module Connector End View (C4)
- Brake Fluid Level Switch Connector End View
- Brake Lamp Switch Connector End View
- Headlamp And Dash Side Inline Connector End View (C100)
- Instrument Panel Side Inline Connector End View (C100)
- Inline (Instrument Panel Side) Connector End View (C101)
- Inline (Headlamp And Dash Side) Connector End View (C101)
- Inline (Headlamp And Dash Side) Connector End View (C102)
- Body Side Inline Connector End View (C102)
- Inline (Headlamp And Dash Side) Connector End View (C103)
- Body Side Inline Connector End View (C103)
- Inline (Headlamp And Dash Side) Connector End View (C104)
- Engine Side Inline Connector End View (C104)
- Inline (Headlamp And Dash Side) Connector End View (C106)
- Inline (Left Headlamp Jumper Side) Connector End View (C106)
- Inline (Right Headlamp Jumper Side) Connector End View (C107)
- Inline (Headlamp And Dash Side) Connector End View (C107)
- Instrument Panel Side Inline Connector End View (C200)
- Body Side Inline Connector End View (C200)
- Body Side Inline Connector End View (C201)
- Instrument Panel Side Inline Connector End View (C201)
- Instrument Panel Side Inline Connector End View (C202)
- Driver Door Side Inline Connector End View (C202)
- Inline (Passenger Door Side) Connector End View (C203)
- Inline (Instrument Panel Side) Connector End View (C203)
- Inline (HVAC Jumper Side) Connector End View (C204)
- Inline (Instrument Panel Side) Connector End View (C204)
- Inline (Mirror Jumper Side) Connector End View (C205)
- Inline (Instrument Panel Side) Connector End View (C205)
- Inline (Instrument Panel Side) Connector End View (C206)
- Console Jumper Side Inline Connector End View (C206)
- Inline (Instrument Panel Side) Connector End View (C207)
- Inline (Passenger Door Side) Connector End View (C207)
- Driver Door Side Inline Connector End View (C208)
- Inline (Instrument Panel Side) Connector End View (C208)
- Transmission Side Inline Connector End View (C300)
- Body Side Inline Connector End View (C300)
- Body Side Inline Connector End View (C301)
- Inline (Left Tail Lamp Side) Connector End View (C301)
- Inline (Right Tail Lamp Side) Connector End View (C302)
- Body Side Inline Connector End View (C302)
- Decklid Jumper Side Inline Connector End View (C303)
- Body Side Inline Connector End View (C303)
- Camshaft Position Sensor Connector End View
- Center High Mounted Stop Lamp Connector End View
- Cigar Lighter Outlet Connector End View
- Clockspring Connector End View
- Clutch Interlock Switch Connector End View
- Antilock Brake Controller Connector End View
- Crankshaft Position Sensor Connector End View
- Driver Cylinder Unlock Switch Connector End View
- Data Link Connector, Connector End View
- Decklid Release Motor Connector End View
- Driver Door Latch Motor Connector End View
- Passenger Door Latch Motor Connector End View
- Driver Door Lock Switch Connector End View
- Passenger Door Lock Switch Connector End View
- Engine Coolant Temperature Sensor Connector End View
- Engine Oil Pressure Sensor Connector End View
- Engine Oil Temperature Sensor Connector End View
- EVAP Purge Solenoid Connector End View
- Driver Exterior Door Handle Switch Connector End View
- Passenger Exterior Door Handle Switch Connector End View
- Left Fog Lamp Connector End View
- Right Fog Lamp Connector End View
- Left Footwell Lamp Connector End View
- Right Footwell Lamp Connector End View
- Fuel Injector 1 Connector End View
- Fuel Injector 2 Connector End View
- Fuel Injector 3 Connector End View
- Fuel Injector 4 Connector End View
- Fuel Injector 5 Connector End View
- Fuel Injector 6 Connector End View
- Fuel Injector 7 Connector End View
- Fuel Injector 8 Connector End View
- Fuel Injector 9 Connector End View
- Fuel Injector 10 Connector End View
- Fuel Tank Module Connector End View
- Gauge Cluster Connector End View (C1)
- Gauge Cluster Connector End View (C2)
- Generator Connector End View
- Glove Box Lamp Connector End View
- Left HID Lamp Connector End View
- Right HID Lamp Connector End View
- Left High Beam Headlamp Connector End View
- Right High Beam Headlamp Connector End View
- Switch Horn Connector End View
- High Note Horn Connector End View
- Low Note Horn Connector End View
- Hydraulic Cooling Module Connector End View
- Idle Air Control Motor Connector End View
- Left Ignition Coil Pack Connector End View
- Right Ignition Coil Pack Connector End View
- Ignition Switch Connector End View
- Illuminated Rearview Mirror Connector End View
- Instrument Cluster Connector End View (C1)
- Instrument Cluster Connector End View (C2)
- Intake Air Temperature Sensor Connector End View
- Driver Interior Door Handle Switch Connector End View
- Passenger Interior Door Handle Switch Connector End View
- Key In Switch Halo Lamp Connector End View
- Knock Sensor 1 Connector End View
- Knock Sensor 2 Connector End View
- Leak Detection Pump Connector End View
- Left License Lamp Connector End View
- Right License Lamp Connector End View
- Manifold Absolute Pressure Sensor Connector End View
- Left Front Marker Lamp Connector End View
- Left Rear Marker Lamp Connector End View
- Right Front Marker Lamp Connector End View
- Right Rear Marker Lamp Connector End View
- Mode Door Defrost To Floor Actuator 1 Connector End View
- Mode Door Actuator 2 (Panel To Floor) Connector End View
- Multifunction Switch Connector End View
- Left Bank Up Oxygen Sensor 1/1 Connector End View
- Left Bank Down Oxygen Sensor 1/2 Connector End View
- Right Bank Up Oxygen Sensor 2/1 Connector End View
- Right Bank Down Oxygen Sensor 2/2 Connector End View
- Park Brake Switch Connector End View
- Left Park Turn Lamp Connector End View
- Right Park Turn Lamp Connector End View
- Power Amplifier Connector End View (C1)
- Power Amplifier Connector End View (C2)
- Power Distribution Center Eyelet Connector End View
- Power Mirror Switch Connector End View
- Driver Power Mirror Connector End View
- Passenger Power Mirror Connector End View
- Power Outlet Connector End View
- Driver Power Window Motor Connector End View
- Passenger Power Window Motor Connector End View
- Driver Power Window Switch Connector End View
- Passenger Power Window Switch Connector End View
- Powertrain Control Module Connector End View (C1)
- Powertrain Control Module Connector End View (C2)
- Powertrain Control Module Connector End View (C3)
- Push Button Starter Switch Connector End View
- Radio Connector End View
- Rear Window Defogger Feed Connector End View
- Rear Window Defogger Ground Connector End View
- Recirculation Door Actuator Connector End View
- Remote Keyless Entry Module Connector End View
- Left Remote Radio Provision Switch Connector End View
- Right Remote Radio Provision Switch Connector End View
- Reverse Lock Out Solenoid Connector End View
- Driver Seat Belt Switch Connector End View
- Passenger Seat Belt Switch Connector End View
- Driver Seat Belt Tensioner Connector End View
- Passenger Seat Belt Tensioner Connector End View
- Left Shutter Motor Connector End View
- Right Shutter Motor Connector End View
- Skip Shift Solenoid Connector End View
- Left Door Speaker Connector End View
- Left Instrument Panel Speaker Connector End View
- Left Rear Speaker Connector End View
- Rear Woofer Speaker Connector End View
- Right Door Speaker Connector End View
- Right Instrument Panel Speaker Connector End View
- Right Rear Speaker Connector End View
- Starter Motor Connector End View
- Starter Motor Battery Eyelet Connector End View
- Starter Motor Generator Connector End View
- Left Tail Lamp Connector End View
- Right Tail Lamp Connector End View
- Left Tail Stop Lamp Connector End View
- Right Tail Stop Lamp Connector End View
- Throttle Position Sensor Connector End View
- Tire Pressure Monitor Module Connector End View
- Left Rear Turn Signal Lamp Connector End View
- Right Rear Turn Signal Lamp Connector End View
- Vehicle Theft Security System LED Connector End View
- Washer Pump Motor Connector End View
- Left Front Wheel Speed Sensor Connector End View
- Left Rear Wheel Speed Sensor Connector End View
- Right Front Wheel Speed Sensor Connector End View
- Right Rear Wheel Speed Sensor Connector End View
- Passenger Window Down Relay Connector End View
- Passenger Window Up Relay Connector End View
- Wiper Control Module Connector End View
- Wiper Motor Connector End View
- Connector Pin-Outs
- Using lemon2025'S System Wiring Diagrams
- Wiring Diagram Information
- Wiring Diagram Information
- Description
- Warning
- Diagnosis And Testing
- Standard Procedure
- Standard Procedure - Electrostatic Discharge (ESD) Sensitive Devices
- Standard Procedure - Testing Of Voltage Potential
- Standard Procedure - Testing For Continuity
- Standard Procedure - Testing For A Short To Ground
- Standard Procedure - Testing For A Short To Ground On Fuses Powering Several Loads
- Standard Procedure - Testing For A Voltage Drop
- Special Tools
- Connector
- Diode
- Terminal
- Wire
- Wiring Diagram Information
- Connector End Views
- Body Electrical
- Engine Mechanical
- Accessory Drive Belts
- Cooling System (Mechanical)
- Exhaust System (Service Information)
- Fuel System (Service Information)
- Fuel Delivery
- Fuel Injection
- Fuel Injection
- Accelerator Pedal
- Crankshaft Position Sensor
- Fuel Injectors
- Fuel Pump Relay
- Idle Air Control Motor
- Inlet Air Temperature Sensor
- Map Sensor
- O2 Sensor
- Throttle Body
- Throttle Cable
- Throttle Position Sensor
- Mechanical
- 8.3L Engine
- Description
- Diagnosis And Testing
- Engine Diagnosis - Introduction
- Engine Diagnosis - Performance
- Engine Diagnosis - Mechanical
- Diagnosis And Testing - Cylinder Compression Pressure Test
- Cylinder Combustion Pressure Leakage Test
- Cylinder Head Gasket Failure Diagnosis
- Diagnosis And Testing - Intake Manifold Leaks
- Hydraulic Tappet Noise Diagnosis
- Diagnosis And Testing - Engine Oil Leak Inspection
- Standard Procedure
- Removal & Installation
- Specifications
- Special Tools
- Air Cleaner Element
- Air Cleaner Housing
- Engine Mounts
- Intake Manifold
- Exhaust Manifold
- Cylinder Head(S)
- Cylinder Head Cover(S)
- Rocker Arms
- Valve Springs/Seals
- Intake/Exhaust - Valves/Seats/Guides
- Timing Chain Cover
- Timing Chain And Sprockets
- Lubrication
- Oil
- Oil Cooler & Lines
- Oil Pan
- Oil Pump
- Oil Pressure Sensor
- Oil Temperature Sensor
- Engine Block
- Hydraulic Tappets
- Camshaft
- Piston & Connecting Rod
- Piston Rings
- Connecting Rod Bearings
- Crankshaft Damper
- Crankshaft Oil Seal - Front
- Crankshaft Oil Seal And Retainer - Rear
- Crankshaft Main Bearings
- Crankshaft
- Crankshaft Pilot Bearing
- 8.3L Engine
- Starter
- Powertrain Diagnostic Procedures
- DTC Index
- Introduction
- Identification Of System
- System Description And Functional Operation
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Acronyms
- Diagnostic Information And Procedures
- Communication - Symptoms
- DRIVEABILITY - Gas - Symptoms
- Symptom: INTERMITTENT CONDITION
- Symptom: *BRAKE SWITCH SENSE STATUS DOES NOT CHANGE ON DRBIII®
- Symptom: *CANNOT SHIFT INTO 2ND AND 3RD GEARS
- Symptom: *CANNOT SHIFT INTO REVERSE
- Symptom: *CHECKING A/C SYSTEM OPERATION WITH NO DTCS
- Symptom: *CHECKING CHARGING SYSTEM OPERATION WITH NO DTCS
- Symptom: *CHECKING RADIATOR FAN OPERATION
- Symptom: *CHECKING THE PCM POWER AND GROUNDS
- DRIVEABILITY - Gas - Diagnostic Tests
- P0031-O2 Sensor 1/1 Heater Circuit Low; P0032-O2 Sensor 1/1 Heater Circuit High; P0051-O2 Sensor 2/1 Heater Circuit Low; P0052-O2 Sensor 2/1 Heater Circuit High
- P0071-Ambient/Battery Temp Sensor Performance
- P0107-Map Sensor Voltage Too Low
- P0108-Map Sensor Voltage Too High
- P0111-Intake Air Temp Performance
- P0112-Intake Air Temp Sensor Voltage Too Low
- P0113-Intake Air Temp Sensor Voltage Too High
- P0117-Engine Coolant Temp Sensor Voltage Too Low
- P0118-Engine Coolant Temp Sensor Voltage Too High
- P0121-TP Sensor Voltage Does Not Agree With Map
- P0122-Throttle Position Sensor #1 Voltage Too Low
- P0123-Throttle Position Sensor #1 Voltage Too High
- P0125-Closed Loop Temp Not Reached
- P0131-O2 Sensor 1/1 Circuit Voltage Too Low; P0137-O2 Sensor 1/2 Circuit Voltage Too Low; P0151-O2 Sensor 2/1 Circuit Voltage Too Low; P0157-O2 Sensor 2/2 Circuit Voltage Too Low
- P0132-O2 Sensor 1/1 Circuit Voltage Too High; P0138-O2 Sensor 1/2 Circuit Voltage Too High; P0152-O2 Sensor 2/1 Circuit Voltage Too High; P0158-O2 Sensor 2/2 Circuit Voltage Too High
- P0133-O2 Sensor 1/1 Slow Response; P0139-O2 Sensor 1/2 Slow Response; P0153-O2 Sensor 2/1 Slow Response; P0159-O2 Sensor 2/2 Slow Response
- P0135-O2 Sensor 1/1 Heater Failure; P0141-O2 Sensor 1/2 Heater Failure; P0155-O2 Sensor 2/1 Heater Failure; P0161-O2 Sensor 2/2 Heater Failure
- P0136-O2 Sensor 1/2 Heater Circuit Malfunction
- P0171-1/1 Fuel System Lean; P0174-2/1 Fuel System Lean
- P0172-1/1 Fuel System Rich; P0175-2/1 Fuel System Rich
- P0197-Engine Oil Temperature Sensor Voltage Too Low
- P0198-Engine Oil Temperature Sensor Voltage Too High
- P0201-Injector #1 Control Circuit; P0202-Injector #2 Control Circuit; P0203-Injector #3 Control Circuit; P0204-Injector #4 Control Circuit; P0205-Injector #5 Control Circuit; P0206-Injector #6 Control Circuit; P0207-Injector #7 Control Circuit; P0208-Injector #8 Control Circuit; P0209-Injector #9 Control Circuit; P0210-Injector #10 Control Circuit
- Notes
- When Monitored and Set Condition:
- P0201-Injector #1 Control Circuit
- P0202-Injector #2 Control Circuit
- P0203-Injector #3 Control Circuit
- P0204-Injector #4 Control Circuit
- P0205-Injector #5 Control Circuit
- P0206-Injector #6 Control Circuit
- P0207-Injector #7 Control Circuit
- P0208-Injector #8 Control Circuit
- P0209-Injector #9 Control Circuit
- P0210-Injector #10 Control Circuit
- Possible Causes
- Diagnostic Procedure
- P0300-Multiple Cylinder Mis-Fire; P0301-Cylinder #1 Misfire; P0302-Cylinder #2 Misfire; P0303-Cylinder #3 Misfire; P0304-Cylinder #4 Misfire; P0305-Cylinder #5 Misfire; P0306-Cylinder #6 Misfire; P0307-Cylinder #7 Misfire; P0308-Cylinder #8 Misfire; P0309-Cylinder #9 Misfire; P0310-Cylinder #10 Misfire
- P0320-No Crank Reference Signal At Pcm
- P0340-No Cam Reference Signal At Pcm
- P0351-Ignition Coil #1 Primary Circuit; P0352-Ignition Coil #2 Primary Circuit; P0353-Ignition Coil #3 Primary Circuit; P0354-Ignition Coil #4 Primary Circuit; P0355-Ignition Coil #5 Primary Circuit
- P0420-1/1 Catalytic Converter Efficiency; P0432-2/1 Catalytic Converter Efficiency
- P0441-EVAP Purge Flow Monitor
- P0442-EVAP Leak Monitor Medium (0.040) Leak Detected P0455-EVAP Leak Monitor Large Leak Detected
- P0443-EVAP Purge Solenoid Circuit
- P0460-Fuel Level Sending Unit No Change Over Miles
- P0462-Fuel Level Sending Unit Volts Too Low
- P0463-Fuel Level Sending Unit Volts Too High
- P0500-No Vehicle Speed Signal
- P0505-Idle Air Control Motor Circuits
- P0522-Oil Pressure Circuit Low
- P0523-Oil Pressure Circuit High
- P0601-Pcm Internal Controller Failure
- P0622-Generator Field Not Switching Properly
- P0645-A/C Clutch Relay Circuit
- P0801-Reverse Gear Lockout Circuit Open Or Shorted
- P1195-O2 Sensor 1/1 Slow During Catalyst Monitor P1196-O2 Sensor 2/1 Slow During Catalyst Monitor
- P1281-Engine Is Cold Too Long
- P1282-Fuel Pump/System Relay Control Circuit
- P1294-Target Idle Not Reached
- P1296-No 5-Volts To Map Sensor
- P1297-No Change In Map From Start To Run
- P1388-Auto Shutdown Relay Control Circuit
- P1389-No ASD Relay Output Voltage At Pcm
- P1391-Intermittent Loss Of CMP Or CKP
- P1398-Mis-Fire Adaptive Numerator At Limit
- P1486-EVAP Leak Monitor Pinched Hose Found
- P1492-Ambient/Battery Temperature Sensor Voltage Too High
- P1493-Ambient/Battery Temperature Sensor Voltage Too Low
- P1494-Leak Detection Pump Switch Or Mechanical Fault
- P1495-Leak Detection Pump Solenoid Circuit
- P1499-Hydraulic Fan Solenoid Circuit
- P1594-Charging System Voltage Too High
- P1598-A/C Pressure Sensor Voltage Too High
- P1599-A/C Pressure Sensor Voltage Too Low
- P1682-Charging System Voltage Too Low
- P1687-No Cluster Bus Message
- P1695-Bus Message From Body Control Module
- P1696-Pcm Failure EEPROM Write Denied
- P1719-Skip Shift Solenoid Circuit Open Or Shorted
- Starting - Symptoms
- Verification Tests
- Component Locations
- Control Modules And PDC
- Data Link Connector
- Sensors And Solenoids
- Battery Temp. Sensor Location
- Cam Position Sensor Location
- Crank Position Sensor Location
- MAP, ECT And Fuel Injector Locations
- IAT Sensor Location
- Engine Oil Pressure Sensor And Engine Oil Temp. Sensor Locations
- O2 Sensor Locations
- IAC Motor And TPS Locations
- Ignition Coil Locations
- Skip Shift Solenoid And Vehicle Speed Sensor Locations
- Fuel System
- Connector PINOUTS
- A/C Compressor Clutch - Black 2 Way
- A/C Low Pressure Switch - DK. Green 2 Way
- A/C Pressure Transducer - Black 4 Way
- Battery Temperature Sensor - 2 Way
- Brake Lamp Switch - Black 6 Way
- Camshaft Position Sensor - Gray 3 Way
- CLOCKSPRING - White 8 Way
- Clutch Interlock Switch - DK.Green 2 Way
- Crankshaft Position Sensor - Black 3 Way
- Data Link Connector - Black 16 Way
- Engine Coolant Temperature Sensor - Black 2 Way
- Engine Oil Pressure Sensor - Black 3 Way
- Engine Oil Temperature Sensor - Black 2 Way
- EVAP/Purge Solenoid - Black 2 Way
- Fuel Injector No. 1 - Black 2 Way
- Fuel Injector No. 2 - Black 2 Way
- Fuel Injector No. 3 - Black 2 Way
- Fuel Injector No. 4 - Black 2 Way
- Fuel Injector No. 5 - Black 2 Way
- Fuel Injector No. 6 - Black 2 Way
- Fuel Injector No. 7 - Black 2 Way
- Fuel Injector No. 8 - Black 2 Way
- Fuel Injector No. 9 - Black 2 Way
- Fuel Injector No. 10 - Black 2 Way
- Fuel Tank Module - Gray 4 Way
- Generator - Gray 2 Way
- Hydraulic Cooling Module - Black 3 Way
- Idle Air Control Motor - Black 4 Way
- Ignition Coil Pack-Left - Black 4 Way
- Ignition Coil Pack-Right - Black 3 Way
- Ignition Switch - Black 5 Way
- Intake Air Temperature Sensor - Black 2 Way
- Leak Detection Pump - Black 4 Way
- Manifold Absolute Pressure Sensor - Black 3 Way
- Multi-Function Switch - Gray 20 Way
- Oxygen Sensor 1/1 Left Bank Up - Black 4 Way
- Oxygen Sensor 1/2 Left Bank Down - Black 4 Way
- Oxygen Sensor 2/1 Right Bank Up - Black 4 Way
- Oxygen Sensor 2/2 Right Bank Down - Black 4 Way
- Power Distribution Center
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Push-Button Starter Switch - Natural 6 Way
- Reverse Lock-Out Solenoid - White 2 Way
- Skip Shift Solenoid - White 2 Way
- Throttle Position Sensor - Black 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Schematic Diagrams
- Charts And Graphs
- Starting System
- Starting
- Starter Motor
- Starter Motor Relay
- Starter Solenoid
- Powertrain Diagnostic Procedures
- Engine Performance
- Emissions
- Emission Applications
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Fuel Delivery
- Fuel System (Service Information)
- Fuel Delivery
- Fuel Injection
- Fuel Injection
- Accelerator Pedal
- Crankshaft Position Sensor
- Fuel Injectors
- Fuel Pump Relay
- Idle Air Control Motor
- Inlet Air Temperature Sensor
- Map Sensor
- O2 Sensor
- Throttle Body
- Throttle Cable
- Throttle Position Sensor
- Fuel System (Service Information)
- Ignition System
- Mode 6 - CHRYSLER
- Introduction
- 1996
- 1997-1998
- 1999
- 2000
- 2001
- 2002
- 2003-2004
- 2005
- 2006
- 2007
- 2007-09 Diesel Engines
- 2008
- 2008-10 Viper
- 2009-10 Pt Cruiser
- 2009 - All Vehicles With V6 Or V8 Engines
- 2009 Vehicles With The "World I4" 4 Cylinder Engine
- 2010 Vehicles
- 2011 Vehicles
- 2012 Vehicles
- System
- Emissions Control
- Emissions Control
- Evaporative Emissions
- On-Board Diagnostics
- Powertrain Diagnostic Procedures
- DTC Index
- Introduction
- Identification Of System
- System Description And Functional Operation
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Acronyms
- Diagnostic Information And Procedures
- Communication - Symptoms
- DRIVEABILITY - Gas - Symptoms
- Symptom: INTERMITTENT CONDITION
- Symptom: *BRAKE SWITCH SENSE STATUS DOES NOT CHANGE ON DRBIII®
- Symptom: *CANNOT SHIFT INTO 2ND AND 3RD GEARS
- Symptom: *CANNOT SHIFT INTO REVERSE
- Symptom: *CHECKING A/C SYSTEM OPERATION WITH NO DTCS
- Symptom: *CHECKING CHARGING SYSTEM OPERATION WITH NO DTCS
- Symptom: *CHECKING RADIATOR FAN OPERATION
- Symptom: *CHECKING THE PCM POWER AND GROUNDS
- DRIVEABILITY - Gas - Diagnostic Tests
- P0031-O2 Sensor 1/1 Heater Circuit Low; P0032-O2 Sensor 1/1 Heater Circuit High; P0051-O2 Sensor 2/1 Heater Circuit Low; P0052-O2 Sensor 2/1 Heater Circuit High
- P0071-Ambient/Battery Temp Sensor Performance
- P0107-Map Sensor Voltage Too Low
- P0108-Map Sensor Voltage Too High
- P0111-Intake Air Temp Performance
- P0112-Intake Air Temp Sensor Voltage Too Low
- P0113-Intake Air Temp Sensor Voltage Too High
- P0117-Engine Coolant Temp Sensor Voltage Too Low
- P0118-Engine Coolant Temp Sensor Voltage Too High
- P0121-TP Sensor Voltage Does Not Agree With Map
- P0122-Throttle Position Sensor #1 Voltage Too Low
- P0123-Throttle Position Sensor #1 Voltage Too High
- P0125-Closed Loop Temp Not Reached
- P0131-O2 Sensor 1/1 Circuit Voltage Too Low; P0137-O2 Sensor 1/2 Circuit Voltage Too Low; P0151-O2 Sensor 2/1 Circuit Voltage Too Low; P0157-O2 Sensor 2/2 Circuit Voltage Too Low
- P0132-O2 Sensor 1/1 Circuit Voltage Too High; P0138-O2 Sensor 1/2 Circuit Voltage Too High; P0152-O2 Sensor 2/1 Circuit Voltage Too High; P0158-O2 Sensor 2/2 Circuit Voltage Too High
- P0133-O2 Sensor 1/1 Slow Response; P0139-O2 Sensor 1/2 Slow Response; P0153-O2 Sensor 2/1 Slow Response; P0159-O2 Sensor 2/2 Slow Response
- P0135-O2 Sensor 1/1 Heater Failure; P0141-O2 Sensor 1/2 Heater Failure; P0155-O2 Sensor 2/1 Heater Failure; P0161-O2 Sensor 2/2 Heater Failure
- P0136-O2 Sensor 1/2 Heater Circuit Malfunction
- P0171-1/1 Fuel System Lean; P0174-2/1 Fuel System Lean
- P0172-1/1 Fuel System Rich; P0175-2/1 Fuel System Rich
- P0197-Engine Oil Temperature Sensor Voltage Too Low
- P0198-Engine Oil Temperature Sensor Voltage Too High
- P0201-Injector #1 Control Circuit; P0202-Injector #2 Control Circuit; P0203-Injector #3 Control Circuit; P0204-Injector #4 Control Circuit; P0205-Injector #5 Control Circuit; P0206-Injector #6 Control Circuit; P0207-Injector #7 Control Circuit; P0208-Injector #8 Control Circuit; P0209-Injector #9 Control Circuit; P0210-Injector #10 Control Circuit
- Notes
- When Monitored and Set Condition:
- P0201-Injector #1 Control Circuit
- P0202-Injector #2 Control Circuit
- P0203-Injector #3 Control Circuit
- P0204-Injector #4 Control Circuit
- P0205-Injector #5 Control Circuit
- P0206-Injector #6 Control Circuit
- P0207-Injector #7 Control Circuit
- P0208-Injector #8 Control Circuit
- P0209-Injector #9 Control Circuit
- P0210-Injector #10 Control Circuit
- Possible Causes
- Diagnostic Procedure
- P0300-Multiple Cylinder Mis-Fire; P0301-Cylinder #1 Misfire; P0302-Cylinder #2 Misfire; P0303-Cylinder #3 Misfire; P0304-Cylinder #4 Misfire; P0305-Cylinder #5 Misfire; P0306-Cylinder #6 Misfire; P0307-Cylinder #7 Misfire; P0308-Cylinder #8 Misfire; P0309-Cylinder #9 Misfire; P0310-Cylinder #10 Misfire
- P0320-No Crank Reference Signal At Pcm
- P0340-No Cam Reference Signal At Pcm
- P0351-Ignition Coil #1 Primary Circuit; P0352-Ignition Coil #2 Primary Circuit; P0353-Ignition Coil #3 Primary Circuit; P0354-Ignition Coil #4 Primary Circuit; P0355-Ignition Coil #5 Primary Circuit
- P0420-1/1 Catalytic Converter Efficiency; P0432-2/1 Catalytic Converter Efficiency
- P0441-EVAP Purge Flow Monitor
- P0442-EVAP Leak Monitor Medium (0.040) Leak Detected P0455-EVAP Leak Monitor Large Leak Detected
- P0443-EVAP Purge Solenoid Circuit
- P0460-Fuel Level Sending Unit No Change Over Miles
- P0462-Fuel Level Sending Unit Volts Too Low
- P0463-Fuel Level Sending Unit Volts Too High
- P0500-No Vehicle Speed Signal
- P0505-Idle Air Control Motor Circuits
- P0522-Oil Pressure Circuit Low
- P0523-Oil Pressure Circuit High
- P0601-Pcm Internal Controller Failure
- P0622-Generator Field Not Switching Properly
- P0645-A/C Clutch Relay Circuit
- P0801-Reverse Gear Lockout Circuit Open Or Shorted
- P1195-O2 Sensor 1/1 Slow During Catalyst Monitor P1196-O2 Sensor 2/1 Slow During Catalyst Monitor
- P1281-Engine Is Cold Too Long
- P1282-Fuel Pump/System Relay Control Circuit
- P1294-Target Idle Not Reached
- P1296-No 5-Volts To Map Sensor
- P1297-No Change In Map From Start To Run
- P1388-Auto Shutdown Relay Control Circuit
- P1389-No ASD Relay Output Voltage At Pcm
- P1391-Intermittent Loss Of CMP Or CKP
- P1398-Mis-Fire Adaptive Numerator At Limit
- P1486-EVAP Leak Monitor Pinched Hose Found
- P1492-Ambient/Battery Temperature Sensor Voltage Too High
- P1493-Ambient/Battery Temperature Sensor Voltage Too Low
- P1494-Leak Detection Pump Switch Or Mechanical Fault
- P1495-Leak Detection Pump Solenoid Circuit
- P1499-Hydraulic Fan Solenoid Circuit
- P1594-Charging System Voltage Too High
- P1598-A/C Pressure Sensor Voltage Too High
- P1599-A/C Pressure Sensor Voltage Too Low
- P1682-Charging System Voltage Too Low
- P1687-No Cluster Bus Message
- P1695-Bus Message From Body Control Module
- P1696-Pcm Failure EEPROM Write Denied
- P1719-Skip Shift Solenoid Circuit Open Or Shorted
- Starting - Symptoms
- Verification Tests
- Component Locations
- Control Modules And PDC
- Data Link Connector
- Sensors And Solenoids
- Battery Temp. Sensor Location
- Cam Position Sensor Location
- Crank Position Sensor Location
- MAP, ECT And Fuel Injector Locations
- IAT Sensor Location
- Engine Oil Pressure Sensor And Engine Oil Temp. Sensor Locations
- O2 Sensor Locations
- IAC Motor And TPS Locations
- Ignition Coil Locations
- Skip Shift Solenoid And Vehicle Speed Sensor Locations
- Fuel System
- Connector PINOUTS
- A/C Compressor Clutch - Black 2 Way
- A/C Low Pressure Switch - DK. Green 2 Way
- A/C Pressure Transducer - Black 4 Way
- Battery Temperature Sensor - 2 Way
- Brake Lamp Switch - Black 6 Way
- Camshaft Position Sensor - Gray 3 Way
- CLOCKSPRING - White 8 Way
- Clutch Interlock Switch - DK.Green 2 Way
- Crankshaft Position Sensor - Black 3 Way
- Data Link Connector - Black 16 Way
- Engine Coolant Temperature Sensor - Black 2 Way
- Engine Oil Pressure Sensor - Black 3 Way
- Engine Oil Temperature Sensor - Black 2 Way
- EVAP/Purge Solenoid - Black 2 Way
- Fuel Injector No. 1 - Black 2 Way
- Fuel Injector No. 2 - Black 2 Way
- Fuel Injector No. 3 - Black 2 Way
- Fuel Injector No. 4 - Black 2 Way
- Fuel Injector No. 5 - Black 2 Way
- Fuel Injector No. 6 - Black 2 Way
- Fuel Injector No. 7 - Black 2 Way
- Fuel Injector No. 8 - Black 2 Way
- Fuel Injector No. 9 - Black 2 Way
- Fuel Injector No. 10 - Black 2 Way
- Fuel Tank Module - Gray 4 Way
- Generator - Gray 2 Way
- Hydraulic Cooling Module - Black 3 Way
- Idle Air Control Motor - Black 4 Way
- Ignition Coil Pack-Left - Black 4 Way
- Ignition Coil Pack-Right - Black 3 Way
- Ignition Switch - Black 5 Way
- Intake Air Temperature Sensor - Black 2 Way
- Leak Detection Pump - Black 4 Way
- Manifold Absolute Pressure Sensor - Black 3 Way
- Multi-Function Switch - Gray 20 Way
- Oxygen Sensor 1/1 Left Bank Up - Black 4 Way
- Oxygen Sensor 1/2 Left Bank Down - Black 4 Way
- Oxygen Sensor 2/1 Right Bank Up - Black 4 Way
- Oxygen Sensor 2/2 Right Bank Down - Black 4 Way
- Power Distribution Center
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Push-Button Starter Switch - Natural 6 Way
- Reverse Lock-Out Solenoid - White 2 Way
- Skip Shift Solenoid - White 2 Way
- Throttle Position Sensor - Black 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Schematic Diagrams
- Charts And Graphs
- Emissions Control
- Testing & Diagnosis
- Emissions Control
- Emissions Control
- Evaporative Emissions
- On-Board Diagnostics
- Powertrain Diagnostic Procedures
- DTC Index
- Introduction
- Identification Of System
- System Description And Functional Operation
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Acronyms
- Diagnostic Information And Procedures
- Communication - Symptoms
- DRIVEABILITY - Gas - Symptoms
- Symptom: INTERMITTENT CONDITION
- Symptom: *BRAKE SWITCH SENSE STATUS DOES NOT CHANGE ON DRBIII®
- Symptom: *CANNOT SHIFT INTO 2ND AND 3RD GEARS
- Symptom: *CANNOT SHIFT INTO REVERSE
- Symptom: *CHECKING A/C SYSTEM OPERATION WITH NO DTCS
- Symptom: *CHECKING CHARGING SYSTEM OPERATION WITH NO DTCS
- Symptom: *CHECKING RADIATOR FAN OPERATION
- Symptom: *CHECKING THE PCM POWER AND GROUNDS
- DRIVEABILITY - Gas - Diagnostic Tests
- P0031-O2 Sensor 1/1 Heater Circuit Low; P0032-O2 Sensor 1/1 Heater Circuit High; P0051-O2 Sensor 2/1 Heater Circuit Low; P0052-O2 Sensor 2/1 Heater Circuit High
- P0071-Ambient/Battery Temp Sensor Performance
- P0107-Map Sensor Voltage Too Low
- P0108-Map Sensor Voltage Too High
- P0111-Intake Air Temp Performance
- P0112-Intake Air Temp Sensor Voltage Too Low
- P0113-Intake Air Temp Sensor Voltage Too High
- P0117-Engine Coolant Temp Sensor Voltage Too Low
- P0118-Engine Coolant Temp Sensor Voltage Too High
- P0121-TP Sensor Voltage Does Not Agree With Map
- P0122-Throttle Position Sensor #1 Voltage Too Low
- P0123-Throttle Position Sensor #1 Voltage Too High
- P0125-Closed Loop Temp Not Reached
- P0131-O2 Sensor 1/1 Circuit Voltage Too Low; P0137-O2 Sensor 1/2 Circuit Voltage Too Low; P0151-O2 Sensor 2/1 Circuit Voltage Too Low; P0157-O2 Sensor 2/2 Circuit Voltage Too Low
- P0132-O2 Sensor 1/1 Circuit Voltage Too High; P0138-O2 Sensor 1/2 Circuit Voltage Too High; P0152-O2 Sensor 2/1 Circuit Voltage Too High; P0158-O2 Sensor 2/2 Circuit Voltage Too High
- P0133-O2 Sensor 1/1 Slow Response; P0139-O2 Sensor 1/2 Slow Response; P0153-O2 Sensor 2/1 Slow Response; P0159-O2 Sensor 2/2 Slow Response
- P0135-O2 Sensor 1/1 Heater Failure; P0141-O2 Sensor 1/2 Heater Failure; P0155-O2 Sensor 2/1 Heater Failure; P0161-O2 Sensor 2/2 Heater Failure
- P0136-O2 Sensor 1/2 Heater Circuit Malfunction
- P0171-1/1 Fuel System Lean; P0174-2/1 Fuel System Lean
- P0172-1/1 Fuel System Rich; P0175-2/1 Fuel System Rich
- P0197-Engine Oil Temperature Sensor Voltage Too Low
- P0198-Engine Oil Temperature Sensor Voltage Too High
- P0201-Injector #1 Control Circuit; P0202-Injector #2 Control Circuit; P0203-Injector #3 Control Circuit; P0204-Injector #4 Control Circuit; P0205-Injector #5 Control Circuit; P0206-Injector #6 Control Circuit; P0207-Injector #7 Control Circuit; P0208-Injector #8 Control Circuit; P0209-Injector #9 Control Circuit; P0210-Injector #10 Control Circuit
- Notes
- When Monitored and Set Condition:
- P0201-Injector #1 Control Circuit
- P0202-Injector #2 Control Circuit
- P0203-Injector #3 Control Circuit
- P0204-Injector #4 Control Circuit
- P0205-Injector #5 Control Circuit
- P0206-Injector #6 Control Circuit
- P0207-Injector #7 Control Circuit
- P0208-Injector #8 Control Circuit
- P0209-Injector #9 Control Circuit
- P0210-Injector #10 Control Circuit
- Possible Causes
- Diagnostic Procedure
- P0300-Multiple Cylinder Mis-Fire; P0301-Cylinder #1 Misfire; P0302-Cylinder #2 Misfire; P0303-Cylinder #3 Misfire; P0304-Cylinder #4 Misfire; P0305-Cylinder #5 Misfire; P0306-Cylinder #6 Misfire; P0307-Cylinder #7 Misfire; P0308-Cylinder #8 Misfire; P0309-Cylinder #9 Misfire; P0310-Cylinder #10 Misfire
- P0320-No Crank Reference Signal At Pcm
- P0340-No Cam Reference Signal At Pcm
- P0351-Ignition Coil #1 Primary Circuit; P0352-Ignition Coil #2 Primary Circuit; P0353-Ignition Coil #3 Primary Circuit; P0354-Ignition Coil #4 Primary Circuit; P0355-Ignition Coil #5 Primary Circuit
- P0420-1/1 Catalytic Converter Efficiency; P0432-2/1 Catalytic Converter Efficiency
- P0441-EVAP Purge Flow Monitor
- P0442-EVAP Leak Monitor Medium (0.040) Leak Detected P0455-EVAP Leak Monitor Large Leak Detected
- P0443-EVAP Purge Solenoid Circuit
- P0460-Fuel Level Sending Unit No Change Over Miles
- P0462-Fuel Level Sending Unit Volts Too Low
- P0463-Fuel Level Sending Unit Volts Too High
- P0500-No Vehicle Speed Signal
- P0505-Idle Air Control Motor Circuits
- P0522-Oil Pressure Circuit Low
- P0523-Oil Pressure Circuit High
- P0601-Pcm Internal Controller Failure
- P0622-Generator Field Not Switching Properly
- P0645-A/C Clutch Relay Circuit
- P0801-Reverse Gear Lockout Circuit Open Or Shorted
- P1195-O2 Sensor 1/1 Slow During Catalyst Monitor P1196-O2 Sensor 2/1 Slow During Catalyst Monitor
- P1281-Engine Is Cold Too Long
- P1282-Fuel Pump/System Relay Control Circuit
- P1294-Target Idle Not Reached
- P1296-No 5-Volts To Map Sensor
- P1297-No Change In Map From Start To Run
- P1388-Auto Shutdown Relay Control Circuit
- P1389-No ASD Relay Output Voltage At Pcm
- P1391-Intermittent Loss Of CMP Or CKP
- P1398-Mis-Fire Adaptive Numerator At Limit
- P1486-EVAP Leak Monitor Pinched Hose Found
- P1492-Ambient/Battery Temperature Sensor Voltage Too High
- P1493-Ambient/Battery Temperature Sensor Voltage Too Low
- P1494-Leak Detection Pump Switch Or Mechanical Fault
- P1495-Leak Detection Pump Solenoid Circuit
- P1499-Hydraulic Fan Solenoid Circuit
- P1594-Charging System Voltage Too High
- P1598-A/C Pressure Sensor Voltage Too High
- P1599-A/C Pressure Sensor Voltage Too Low
- P1682-Charging System Voltage Too Low
- P1687-No Cluster Bus Message
- P1695-Bus Message From Body Control Module
- P1696-Pcm Failure EEPROM Write Denied
- P1719-Skip Shift Solenoid Circuit Open Or Shorted
- Starting - Symptoms
- Verification Tests
- Component Locations
- Control Modules And PDC
- Data Link Connector
- Sensors And Solenoids
- Battery Temp. Sensor Location
- Cam Position Sensor Location
- Crank Position Sensor Location
- MAP, ECT And Fuel Injector Locations
- IAT Sensor Location
- Engine Oil Pressure Sensor And Engine Oil Temp. Sensor Locations
- O2 Sensor Locations
- IAC Motor And TPS Locations
- Ignition Coil Locations
- Skip Shift Solenoid And Vehicle Speed Sensor Locations
- Fuel System
- Connector PINOUTS
- A/C Compressor Clutch - Black 2 Way
- A/C Low Pressure Switch - DK. Green 2 Way
- A/C Pressure Transducer - Black 4 Way
- Battery Temperature Sensor - 2 Way
- Brake Lamp Switch - Black 6 Way
- Camshaft Position Sensor - Gray 3 Way
- CLOCKSPRING - White 8 Way
- Clutch Interlock Switch - DK.Green 2 Way
- Crankshaft Position Sensor - Black 3 Way
- Data Link Connector - Black 16 Way
- Engine Coolant Temperature Sensor - Black 2 Way
- Engine Oil Pressure Sensor - Black 3 Way
- Engine Oil Temperature Sensor - Black 2 Way
- EVAP/Purge Solenoid - Black 2 Way
- Fuel Injector No. 1 - Black 2 Way
- Fuel Injector No. 2 - Black 2 Way
- Fuel Injector No. 3 - Black 2 Way
- Fuel Injector No. 4 - Black 2 Way
- Fuel Injector No. 5 - Black 2 Way
- Fuel Injector No. 6 - Black 2 Way
- Fuel Injector No. 7 - Black 2 Way
- Fuel Injector No. 8 - Black 2 Way
- Fuel Injector No. 9 - Black 2 Way
- Fuel Injector No. 10 - Black 2 Way
- Fuel Tank Module - Gray 4 Way
- Generator - Gray 2 Way
- Hydraulic Cooling Module - Black 3 Way
- Idle Air Control Motor - Black 4 Way
- Ignition Coil Pack-Left - Black 4 Way
- Ignition Coil Pack-Right - Black 3 Way
- Ignition Switch - Black 5 Way
- Intake Air Temperature Sensor - Black 2 Way
- Leak Detection Pump - Black 4 Way
- Manifold Absolute Pressure Sensor - Black 3 Way
- Multi-Function Switch - Gray 20 Way
- Oxygen Sensor 1/1 Left Bank Up - Black 4 Way
- Oxygen Sensor 1/2 Left Bank Down - Black 4 Way
- Oxygen Sensor 2/1 Right Bank Up - Black 4 Way
- Oxygen Sensor 2/2 Right Bank Down - Black 4 Way
- Power Distribution Center
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Push-Button Starter Switch - Natural 6 Way
- Reverse Lock-Out Solenoid - White 2 Way
- Skip Shift Solenoid - White 2 Way
- Throttle Position Sensor - Black 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Schematic Diagrams
- Charts And Graphs
- Emissions Control
- Tune-Up
- Emissions
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- OBD-II Drive Cycles
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- DTC Index
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Hoist/Jack
- Lubrication & Maintenance
- International Symbols
- Parts & Lubricant Recommendation
- Fluid Types
- Fluid Capacities
- Fluid Fill/Check Locations
- Lubrication Points
- Maintenance Schedules
- Hoisting
- Jump Starting
- Towing
- Vehicle Storage
- Standard Procedure
- Standard Procedure - Vehicle Preparation
- Standard Procedure - Engine Component Preparation
- Standard Procedure - Fuel System Preparation
- Standard Procedure - Brake System Preparation
- Standard Procedure - Rear Axle Preparation
- Standard Procedure - Wheels And Tires Preparation
- Standard Procedure - Interior Trim Preparation
- Standard Procedure - Body Preparation
- Standard Procedure - Returning Vehicle From Long Term Storage
- Standard Procedure
- Lubrication & Maintenance
- Identification
- Metric Conversions
- OEM General Information
- Lubrication & Maintenance
- International Symbols
- Parts & Lubricant Recommendation
- Fluid Types
- Fluid Capacities
- Fluid Fill/Check Locations
- Lubrication Points
- Maintenance Schedules
- Hoisting
- Jump Starting
- Towing
- Vehicle Storage
- Standard Procedure
- Standard Procedure - Vehicle Preparation
- Standard Procedure - Engine Component Preparation
- Standard Procedure - Fuel System Preparation
- Standard Procedure - Brake System Preparation
- Standard Procedure - Rear Axle Preparation
- Standard Procedure - Wheels And Tires Preparation
- Standard Procedure - Interior Trim Preparation
- Standard Procedure - Body Preparation
- Standard Procedure - Returning Vehicle From Long Term Storage
- Standard Procedure
- Vehicle Data
- Lubrication & Maintenance
- Reset Procedures
- ATEQ TPMS Reset Procedure
- BARTEC TPMS Reset Procedure (No COMS)
- Maintenance Reminder Light (Reset Procedures)
- Emissions Maintenance Reminder (EGR)
- Emissions Maintenance Reminder (EMR Mileage)
- Emissions Maintenance Reminder (MAINT REQD Or Check EGR)
- Emissions Maintenance Reminder (Sri)
- Engine Oil Replacement Reminder
- Maintenance Service Reminder (ASSYST Maintenance Computer)
- Maintenance Service Reminder (Perform Service)
- Maintenance Service Reminder (Service Reminder Indicator)
- Maintenance Service Reminder (Service Reminder Message)
- Tire Pressure Monitor System Reminder
- Tire Pressure Monitor Systems
- Restraints
- Specifications Index
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Towing
- Lubrication & Maintenance
- International Symbols
- Parts & Lubricant Recommendation
- Fluid Types
- Fluid Capacities
- Fluid Fill/Check Locations
- Lubrication Points
- Maintenance Schedules
- Hoisting
- Jump Starting
- Towing
- Vehicle Storage
- Standard Procedure
- Standard Procedure - Vehicle Preparation
- Standard Procedure - Engine Component Preparation
- Standard Procedure - Fuel System Preparation
- Standard Procedure - Brake System Preparation
- Standard Procedure - Rear Axle Preparation
- Standard Procedure - Wheels And Tires Preparation
- Standard Procedure - Interior Trim Preparation
- Standard Procedure - Body Preparation
- Standard Procedure - Returning Vehicle From Long Term Storage
- Standard Procedure
- Lubrication & Maintenance
- Traction Control Disable Procedures
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- HVAC Control Systems
- HVAC Systems (Service Information)
- Heating & Air Conditioning
- Controls
- Distribution
- Plumbing
- HVAC Systems (Service Information)
- HVAC Control Systems
- Maintenance
- Procedures
- Lubrication & Maintenance
- International Symbols
- Parts & Lubricant Recommendation
- Fluid Types
- Fluid Capacities
- Fluid Fill/Check Locations
- Lubrication Points
- Maintenance Schedules
- Hoisting
- Jump Starting
- Towing
- Vehicle Storage
- Standard Procedure
- Standard Procedure - Vehicle Preparation
- Standard Procedure - Engine Component Preparation
- Standard Procedure - Fuel System Preparation
- Standard Procedure - Brake System Preparation
- Standard Procedure - Rear Axle Preparation
- Standard Procedure - Wheels And Tires Preparation
- Standard Procedure - Interior Trim Preparation
- Standard Procedure - Body Preparation
- Standard Procedure - Returning Vehicle From Long Term Storage
- Standard Procedure
- Maintenance Reminder Light (Reset Procedures)
- Emissions Maintenance Reminder (EGR)
- Emissions Maintenance Reminder (EMR Mileage)
- Emissions Maintenance Reminder (MAINT REQD Or Check EGR)
- Emissions Maintenance Reminder (Sri)
- Engine Oil Replacement Reminder
- Maintenance Service Reminder (ASSYST Maintenance Computer)
- Maintenance Service Reminder (Perform Service)
- Maintenance Service Reminder (Service Reminder Indicator)
- Maintenance Service Reminder (Service Reminder Message)
- Tire Pressure Monitor System Reminder
- Lubrication & Maintenance
- Schedule
- Lubrication & Maintenance
- International Symbols
- Parts & Lubricant Recommendation
- Fluid Types
- Fluid Capacities
- Fluid Fill/Check Locations
- Lubrication Points
- Maintenance Schedules
- Hoisting
- Jump Starting
- Towing
- Vehicle Storage
- Standard Procedure
- Standard Procedure - Vehicle Preparation
- Standard Procedure - Engine Component Preparation
- Standard Procedure - Fuel System Preparation
- Standard Procedure - Brake System Preparation
- Standard Procedure - Rear Axle Preparation
- Standard Procedure - Wheels And Tires Preparation
- Standard Procedure - Interior Trim Preparation
- Standard Procedure - Body Preparation
- Standard Procedure - Returning Vehicle From Long Term Storage
- Standard Procedure
- Lubrication & Maintenance
- Procedures
- Restraints
- Air Bag, SRS
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Body Control Module
- Chime Warning System
- Communication
- Door Ajar System
- Exterior Lighting System
- Relays Controlled By The BCM
- Heating & A/C System
- Instrument Cluster / Gauge Cluster
- Interior Lighting
- Tire Pressure Monitoring System (TPMS)
- Power Door Entry System
- Power Windows
- Electrically Heated Systems
- Vehicle Theft Security System
- Using The DRBIII®
- DRBIII® Error Messages
- DRBIII® Does Not Power Up (Blank Screen)
- Display Is Not Visible
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; ACCELEROMETER 2; INTERNAL 1; OUTPUT DRIVER 1; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: DRIVER SQUIB 2 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 2 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 2 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 2 SHORT TO GROUND
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH OPEN
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO BATTERY
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO GROUND
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO BATTERY
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: PASSENGER SQUIB 2 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 2 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 2 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 2 SHORT TO GROUND
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom List: CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH BCM
- Chime
- Communication
- Symptom: ACM MESSAGES NOT RECEIVED
- Symptom: AUDIO MESSAGES NOT RECEIVED
- Symptom: COUNTRY CODE NOT PROGRAMMED
- Symptom: INTERNAL BCM FAILURE
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom List: PCI BUS SHORTED TO BATTERY; PCI BUS SHORTED TO GROUND
- Symptom: PCI INTERNAL FAULT
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM BODY CONTROL MODULE
- Symptom: *NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE
- Symptom: *NO RESPONSE FROM HVAC
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM PCM (PCI BUS)
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY)
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM TIRE PRESSURE MONITOR MODULE
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Door Ajar
- Symptom: *DECKLID AJAR CIRCUIT OPEN
- Symptom: *DECKLID AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *DRIVER DOOR AJAR CIRCUIT OPEN
- Symptom: *DRIVER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *HOOD AJAR CIRCUIT OPEN
- Symptom: *HOOD AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *PASSENGER DOOR AJAR CIRCUIT OPEN
- Symptom: *PASSENGER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Electrically Heated Systems
- Exterior Lighting
- Symptom: LEFT FOG LAMP OUTPUT OPEN
- Symptom: LEFT FOG LAMP OUTPUT SHORTED
- Symptom: LEFT HIGH BEAM OUTPUT OPEN
- Symptom: LEFT HIGH BEAM OUTPUT SHORT
- Symptom: LOW BEAM RELAY COIL OUTPUT OPEN/SHORT TO GROUND
- Symptom: LOW BEAM RELAY COIL SHORT TO VOLTAGE
- Symptom: PARK LAMP OUTPUT SHORT
- Symptom: RIGHT FOG LAMP OUTPUT OPEN
- Symptom: RIGHT FOG LAMP OUTPUT SHORTED
- Symptom: RIGHT HIGH BEAM OUTPUT OPEN
- Symptom: RIGHT HIGH BEAM OUTPUT SHORT
- Heating & A/C
- Symptom List: A/C SWITCH FAULT (ACTIVE); CHECKSUM FAILURE (ACTIVE); DEFOG SWITCH FAULT (ACTIVE)
- Symptom List: A/C SWITCH FAULT (STORED); BACKLIGHT DIMMING RX FAILURE (STORED); BLEND OVERCURRENT (STORED); CHECKSUM FAILURE (STORED); DEFOG SWITCH FAULT (STORED); LOOPBACK TEST FAILURE (STORED); MODE 1 OVERCURRENT (STORED); MODE 2 OVERCURRENT (STORED); RECIRC OVERCURRENT (STORED); REFRIGERANT PRESS RX FAILURE (STORED); TX FAILURE (STORED); VIN RX FAILURE (STORED)
- Notes
- When Monitored and Set Condition:
- A/C Switch Fault (Stored)
- Backlight Dimming RX Failure (Stored)
- Blend OVERCURRENT (Stored)
- Checksum Failure (Stored)
- Defog Switch Fault (Stored)
- LOOPBACK Test Failure (Stored)
- Mode 1 OVERCURRENT (Stored)
- Mode 2 OVERCURRENT (Stored)
- RECIRC OVERCURRENT (Stored)
- Refrigerant Press RX Failure (Stored)
- TX Failure (Stored)
- VIN RX Failure (Stored)
- Possible Causes
- Diagnostic Procedure
- Symptom List: ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE; BLEND CIRCUIT SHORTED TO GROUND; BLEND CIRCUIT SHORTED TO IGN OR BATT; COMMON DRIVER SHORTED TO GROUND; COMMON DRIVER SHORTED TO IGN OR BATT; MODE 1 CIRCUIT SHORTED TO GROUND; MODE 1 CIRCUIT SHORTED TO IGN OR BATT; MODE 2 CIRCUIT SHORTED TO GROUND; MODE 2 CIRCUIT SHORTED TO IGN OR BATT; RECIRC CIRCUIT SHORTED TO GROUND; RECIRC CIRCUIT SHORTED TO IGN OR BATT; SHORT TOO COMPLEX
- Notes
- When Monitored and Set Condition:
- Act CKT Test Passed, OVERCURRENT DTCS Active
- Blend Circuit Shorted To Ground
- Blend Circuit Shorted To IGN Or Batt
- Common Driver Shorted To Ground
- Common Driver Shorted To IGN Or Batt
- Mode 1 Circuit Shorted To Ground
- Mode 1 Circuit Shorted To IGN Or Batt
- Mode 2 Circuit Shorted To Ground
- Mode 2 Circuit Shorted To IGN Or Batt
- RECIRC Circuit Shorted To Ground
- RECIRC Circuit Shorted To IGN Or Batt
- Short Too Complex
- Possible Causes
- Diagnostic Procedure
- Symptom: BACKLIGHT DIMMING RX FAILURE (ACTIVE)
- Symptom List: BLEND CALIBRATION FAULT; MODE 1 CALIBRATION FAULT; MODE 2 CALIBRATION FAULT; RECIRCULATION CALIBRATION FAULT
- Symptom List: BLEND OVERCURRENT (ACTIVE); MODE 1 OVERCURRENT (ACTIVE); MODE 2 OVERCURRENT (ACTIVE); RECIRC OVERCURRENT (ACTIVE)
- Symptom: DEFOG RELAY CONTROL CKT SHORTED TO BATT
- Symptom: LOOPBACK TEST FAILURE (ACTIVE)
- Symptom List: REFRIGERANT PRESSURE RX FAILURE (ACTIVE); VIN RX FAILURE (ACTIVE)
- Symptom: TX FAILURE (ACTIVE)
- Symptom: *A/C - HEATER CONTROL ILLUMINATION INOPERATIVE
- Symptom: *BLEND/MODE/RECIRC DOOR OPERATION IMPROPER
- Symptom: *BLOWER MOTOR INOPERATIVE
- Symptom: *BLOWER MOTOR SPEEDS INCORRECT
- Symptom: *EBL STATUS INDICATOR FLASHING
- Symptom: *HVAC SYSTEM TEST
- Ignition, Power, Accessory
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT OPEN
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT SHORT TO GROUND
- Symptom: BCM - IGNITION MUX SWITCH INPUT MISMATCH
- Symptom: BCM - IGNITION MUX SWITCH INPUT OPEN
- Symptom: BCM - IGNITION MUX SWITCH INPUT SHORT
- Symptom: BCM - IGNITION RUN 1 SHORT
- Symptom: BCM - IGNITION RUN 2 SHORT
- Symptom: BCM - IOD OUTPUT CIRCUIT SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT OPEN / SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT SHORT TO VOLTAGE
- Symptom: BCM - RUN/START HARDWIRE INPUT MISMATCH
- Symptom: HORN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: HORN RELAY COIL SHORT TO BATTERY
- Symptom: HORN SWITCH STUCK
- Symptom: *HORNS INOPERATIVE
- Instrument Cluster
- Symptom List: ABS LAMP CIRCUIT OPEN; ABS LAMP CIRCUIT SHORTED; AIRBAG LAMP CIRCUIT OPEN; AIRBAG LAMP CIRCUIT SHORTED
- Symptom: ABS MESSAGES NOT RECEIVED
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT OPEN / SHORTED TO VOLTAGE
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT SHORT TO GROUND
- Symptom: BCM - PWM DIMMING OUTPUT SHORT
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: ORC MESSAGES NOT RECEIVED
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *GAUGE CLUSTER DIAGNOSTIC TEST
- Symptom: *INSTRUMENT CLUSTER DIAGNOSTIC TEST
- Interior Lighting
- Power Door Locks/RKE
- Symptom: DECKLID RELEASE OUTPUT OPEN
- Symptom: DECKLID RELEASE OUTPUT SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH OPEN OR SHORT TO VOLTAGE
- Symptom: DRIVER CYLINDER UNLOCK SWITCH SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH STUCK
- Symptom: DRIVER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: DRIVER DOOR LOCK SWITCH STUCK
- Symptom: DRIVER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: DRIVER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: DRIVER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER DOOR LOCK SWITCH STUCK
- Symptom: PASSENGER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER/DRIVER DOOR UNLATCH RETURN SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT OPEN/SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT SHORT TO BATTERY
- Symptom: *ALL DOOR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR UNLATCH INOPERATIVE
- Symptom: *PASSENGER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *PASSENGER DOOR UNLATCH INOPERATIVE
- Symptom: *REMOTE KEYLESS ENTRY PROBLEM
- Power Windows
- Symptom: DRIVER WINDOW DOWN OUTPUT SHORT TO GROUND
- Symptom: DRIVER WINDOW HALL EFFECT FAILURE
- Symptom: DRIVER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: DRIVER WINDOW SWITCH SHORT TO GROUND
- Symptom: DRIVER WINDOW SWITCH STUCK DOWN
- Symptom: DRIVER WINDOW SWITCH STUCK UP
- Symptom: DRIVER WINDOW UP OUTPUT SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL SHORT TO BATTERY
- Symptom: PASSENGER WINDOW HALL EFFECT FAILURE
- Symptom: PASSENGER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: PASSENGER WINDOW SWITCH SHORT TO GROUND
- Symptom: PASSENGER WINDOW SWITCH STUCK DOWN
- Symptom: PASSENGER WINDOW SWITCH STUCK UP
- Symptom: PASSENGER WINDOW UP SHORT TO GROUND
- Symptom: *DRIVER WINDOW INOPERATIVE
- Symptom: *PASSENGER WINDOW INOPERATIVE
- Tire Pressure Monitoring
- Symptom: CRITICAL TIRE PRESSURE - BCM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM
- Symptom: TIRE PRESSURE LOW - BCM
- Symptom: TIRE PRESSURE MONITOR MODULE FAILURE - TPM
- Symptom: TPM DIAGNOSTIC - BCM
- Symptom: TPM MODULE INITIALIZED - BCM
- Symptom: *LO TIRE LCD MESSAGE FLASHING
- Vehicle Theft/Security
- Symptom: VTSS INDICATOR OUTPUT OPEN
- Symptom: VTSS INDICATOR OUTPUT SHORT
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *DECKLID DOES NOT TRIP VTSS
- Symptom: *DRIVER DOOR DOES NOT TRIP VTSS
- Symptom: *EXTERIOR LAMPS FAIL TO FLASH WHEN ALARM IS TRIPPED
- Symptom: *HOOD DOES NOT TRIP VTSS
- Symptom: *HORN FAILS TO SOUND WHEN ALARM IS TRIPPED
- Symptom: *PASSENGER DOOR DOES NOT TRIP VTSS
- Symptom: *VTSS LAMP ON STEADY DURING ARMING
- Symptom: *VTSS WILL NOT ARM
- Verification Tests
- Airbag
- Component Locations
- Connector PINOUTS
- A/C-Heater Control C1 - Black 10 Way
- A/C-Heater Control C2 - Black 16 Way
- Airbag Control Module C1 (Orc) - Yellow 32 Way
- Airbag Control Module C2 (Orc) - Yellow 32 Way
- Airbag On/Off Switch-Passenger - Yellow 6 Way
- Airbag Squib 1-Driver - Yellow/Black 2 Way
- Airbag Squib 2-Driver - Yellow/Gray 2 Way
- Airbag Squib-Passenger - Yellow 4 Way
- Ajar Switch-DECKLID - Black 3 Way
- Ajar Switch-Driver Door - Black 4 Way
- Ajar Switch-Hood - Natural 3 Way
- Ajar Switch-Passenger Door - Black 4 Way
- Blend Door Actuator - Gray 2 Way
- Blower Motor - Orange 2 Way
- Blower Motor Resistor Block - Black 4 Way
- Body Control Module C1 - Black 6 Way
- Body Control Module C2 - Black/Green 34 Way
- Body Control Module C3 - Black/White 34 Way
- Body Control Module C4 - Black/Gray 34 Way
- Brake Fluid Level Switch - Black 2 Way
- C200 - Black (Body Side)
- C200 - Black (Instrument Panel Side)
- C201 - Yellow (Body Side)
- C201 - Yellow (Instrument Panel Side)
- C202 - Natural (Driver Door Side)
- C202 - Natural (Instrument Panel Side)
- C203 - Natural (Instrument Panel Side)
- C203 - Natural (Passenger Door Side)
- C204 - LT. Gray (HVAC Jumper Side)
- C204 - LT. Gray (Instrument Panel Side)
- C206 - Red (Console Jumper Side)
- C206 - Red (Instrument Panel Side)
- C207 - Green (Instrument Panel Side)
- C207 - Natural (Passenger Door Side)
- C208 - Green (Instrument Panel Side)
- C208 - Natural (Driver Door Side)
- C303 - Black (Body Side)
- C303 - Black (DECKLID Jumper Side)
- CLOCKSPRING - White 8 Way
- Controller Antilock Brake - Black 24 Way
- Cylinder Unlock Switch-Driver - Black 2 Way
- Data Link Connector - Black 16 Way
- DECKLID Release Motor - Black 2 Way
- Door Latch Motor-Driver - 2 Way
- Door Latch Motor-Passenger - 2 Way
- Door Lock Switch-Driver - Black 3 Way
- Door Lock Switch-Passenger - Black 3 Way
- Exterior Door Handle Switch-Driver - Black 2 Way
- Exterior Door Handle Switch-Passenger - Black 2 Way
- Fog Lamp-Left - Black 2 Way
- Gauge Cluster C1 - White 3 Way
- Gauge Cluster C2 - Black 20 Way
- Hid Lamp-Left - Gray 2 Way
- High Beam Headlamp-Left - Black 2 Way
- Horn Switch - Black 1 Way
- Horn-High Note - Black 2 Way
- Horn-Low Note - Black 2 Way
- Ignition Switch - Black 5 Way
- Instrument Cluster C1 - Black 16 Way
- Instrument Cluster C2 - Black 20 Way
- Interior Door Handle Switch-Driver - Black 2 Way
- Interior Door Handle Switch-Passenger - Black 2 Way
- Marker Lamp-Left Front - DK. Gray 2 Way
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way
- Multi-Function Switch - Gray 20 Way
- Power Distribution Center
- Power Window Motor-Driver - Black 6 Way
- Power Window Motor-Passenger - Black 6 Way
- Power Window Switch-Driver - Gray 3 Way
- Power Window Switch-Passenger - Gray 3 Way
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Radio - Gray 22 Way
- RECIRCULATION Door Actuator - Gray 2 Way
- Remote Keyless Entry Module - Black 6 Way
- Seat Belt Switch-Driver - White 2 Way
- Seat Belt Switch-Passenger - White 2 Way
- Seat Belt TENSIONER-Driver - Yellow 2 Way
- Seat Belt TENSIONER-Passenger - Yellow 2 Way
- Speaker-Left Door - Black 2 Way
- Speaker-Left Instrument Panel - White 2 Way
- Speaker-Left Rear - White 3 Way
- Speaker-Rear Woofer - Gray 4 Way
- Speaker-Right Door - Black 2 Way
- Speaker-Right Instrument Panel - White 2 Way
- Speaker-Right Rear - White 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Window Down Relay-Passenger - Black 5 Way
- Window Up Relay-Passenger - Black 5 Way
- Schematic Diagrams
- Airbag System
- Audio System
- Chime System
- Communication
- Door Ajar System
- Electrically Heated Systems
- Exterior Lighting
- Heating & A/C System
- Ignition, Power, Accessory
- Instrument Cluster/Gauge Cluster
- Interior Lighting
- Power Door Locks/RKE
- Power Window System
- Tire Pressure Monitor Module (TPM)
- Vehicle Theft Security System
- Restraints System (Service Information)
- Body Diagnostic Procedures
- Passive Restraints
- Restraints Control Systems
- Seat Belts
- Air Bag, SRS
- Steering
- Manual Steering
- Rack & Pinion Power Steering System
- Steering
- Column
- Gear
- Pump
- Rack & Pinion Power Steering System
- Rack & Pinion Power Steering System
- Steering
- Column
- Gear
- Pump
- Steering Column
- Rack & Pinion Power Steering System
- Steering
- Column
- Gear
- Pump
- Rack & Pinion Power Steering System
- Steering Gear
- Rack & Pinion Power Steering System
- Steering
- Column
- Gear
- Pump
- Rack & Pinion Power Steering System
- Steering Linkage
- Rack & Pinion Power Steering System
- Steering
- Column
- Gear
- Pump
- Rack & Pinion Power Steering System
- Manual Steering
- Suspension
- Front Suspension
- Suspension System
- Suspension
- Front Suspension
- Rear Suspension
- Wheel Alignment
- Suspension System
- Rear Suspension
- Suspension System
- Suspension
- Front Suspension
- Rear Suspension
- Wheel Alignment
- Suspension System
- Wheel Alignment
- Suspension System
- Suspension
- Front Suspension
- Rear Suspension
- Wheel Alignment
- Suspension System
- Wheels & Tire System
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Body Control Module
- Chime Warning System
- Communication
- Door Ajar System
- Exterior Lighting System
- Relays Controlled By The BCM
- Heating & A/C System
- Instrument Cluster / Gauge Cluster
- Interior Lighting
- Tire Pressure Monitoring System (TPMS)
- Power Door Entry System
- Power Windows
- Electrically Heated Systems
- Vehicle Theft Security System
- Using The DRBIII®
- DRBIII® Error Messages
- DRBIII® Does Not Power Up (Blank Screen)
- Display Is Not Visible
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; ACCELEROMETER 2; INTERNAL 1; OUTPUT DRIVER 1; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: DRIVER SQUIB 2 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 2 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 2 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 2 SHORT TO GROUND
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH OPEN
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO BATTERY
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO GROUND
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO BATTERY
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: PASSENGER SQUIB 2 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 2 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 2 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 2 SHORT TO GROUND
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom List: CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH BCM
- Chime
- Communication
- Symptom: ACM MESSAGES NOT RECEIVED
- Symptom: AUDIO MESSAGES NOT RECEIVED
- Symptom: COUNTRY CODE NOT PROGRAMMED
- Symptom: INTERNAL BCM FAILURE
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom List: PCI BUS SHORTED TO BATTERY; PCI BUS SHORTED TO GROUND
- Symptom: PCI INTERNAL FAULT
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM BODY CONTROL MODULE
- Symptom: *NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE
- Symptom: *NO RESPONSE FROM HVAC
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM PCM (PCI BUS)
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY)
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM TIRE PRESSURE MONITOR MODULE
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Door Ajar
- Symptom: *DECKLID AJAR CIRCUIT OPEN
- Symptom: *DECKLID AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *DRIVER DOOR AJAR CIRCUIT OPEN
- Symptom: *DRIVER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *HOOD AJAR CIRCUIT OPEN
- Symptom: *HOOD AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *PASSENGER DOOR AJAR CIRCUIT OPEN
- Symptom: *PASSENGER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Electrically Heated Systems
- Exterior Lighting
- Symptom: LEFT FOG LAMP OUTPUT OPEN
- Symptom: LEFT FOG LAMP OUTPUT SHORTED
- Symptom: LEFT HIGH BEAM OUTPUT OPEN
- Symptom: LEFT HIGH BEAM OUTPUT SHORT
- Symptom: LOW BEAM RELAY COIL OUTPUT OPEN/SHORT TO GROUND
- Symptom: LOW BEAM RELAY COIL SHORT TO VOLTAGE
- Symptom: PARK LAMP OUTPUT SHORT
- Symptom: RIGHT FOG LAMP OUTPUT OPEN
- Symptom: RIGHT FOG LAMP OUTPUT SHORTED
- Symptom: RIGHT HIGH BEAM OUTPUT OPEN
- Symptom: RIGHT HIGH BEAM OUTPUT SHORT
- Heating & A/C
- Symptom List: A/C SWITCH FAULT (ACTIVE); CHECKSUM FAILURE (ACTIVE); DEFOG SWITCH FAULT (ACTIVE)
- Symptom List: A/C SWITCH FAULT (STORED); BACKLIGHT DIMMING RX FAILURE (STORED); BLEND OVERCURRENT (STORED); CHECKSUM FAILURE (STORED); DEFOG SWITCH FAULT (STORED); LOOPBACK TEST FAILURE (STORED); MODE 1 OVERCURRENT (STORED); MODE 2 OVERCURRENT (STORED); RECIRC OVERCURRENT (STORED); REFRIGERANT PRESS RX FAILURE (STORED); TX FAILURE (STORED); VIN RX FAILURE (STORED)
- Notes
- When Monitored and Set Condition:
- A/C Switch Fault (Stored)
- Backlight Dimming RX Failure (Stored)
- Blend OVERCURRENT (Stored)
- Checksum Failure (Stored)
- Defog Switch Fault (Stored)
- LOOPBACK Test Failure (Stored)
- Mode 1 OVERCURRENT (Stored)
- Mode 2 OVERCURRENT (Stored)
- RECIRC OVERCURRENT (Stored)
- Refrigerant Press RX Failure (Stored)
- TX Failure (Stored)
- VIN RX Failure (Stored)
- Possible Causes
- Diagnostic Procedure
- Symptom List: ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE; BLEND CIRCUIT SHORTED TO GROUND; BLEND CIRCUIT SHORTED TO IGN OR BATT; COMMON DRIVER SHORTED TO GROUND; COMMON DRIVER SHORTED TO IGN OR BATT; MODE 1 CIRCUIT SHORTED TO GROUND; MODE 1 CIRCUIT SHORTED TO IGN OR BATT; MODE 2 CIRCUIT SHORTED TO GROUND; MODE 2 CIRCUIT SHORTED TO IGN OR BATT; RECIRC CIRCUIT SHORTED TO GROUND; RECIRC CIRCUIT SHORTED TO IGN OR BATT; SHORT TOO COMPLEX
- Notes
- When Monitored and Set Condition:
- Act CKT Test Passed, OVERCURRENT DTCS Active
- Blend Circuit Shorted To Ground
- Blend Circuit Shorted To IGN Or Batt
- Common Driver Shorted To Ground
- Common Driver Shorted To IGN Or Batt
- Mode 1 Circuit Shorted To Ground
- Mode 1 Circuit Shorted To IGN Or Batt
- Mode 2 Circuit Shorted To Ground
- Mode 2 Circuit Shorted To IGN Or Batt
- RECIRC Circuit Shorted To Ground
- RECIRC Circuit Shorted To IGN Or Batt
- Short Too Complex
- Possible Causes
- Diagnostic Procedure
- Symptom: BACKLIGHT DIMMING RX FAILURE (ACTIVE)
- Symptom List: BLEND CALIBRATION FAULT; MODE 1 CALIBRATION FAULT; MODE 2 CALIBRATION FAULT; RECIRCULATION CALIBRATION FAULT
- Symptom List: BLEND OVERCURRENT (ACTIVE); MODE 1 OVERCURRENT (ACTIVE); MODE 2 OVERCURRENT (ACTIVE); RECIRC OVERCURRENT (ACTIVE)
- Symptom: DEFOG RELAY CONTROL CKT SHORTED TO BATT
- Symptom: LOOPBACK TEST FAILURE (ACTIVE)
- Symptom List: REFRIGERANT PRESSURE RX FAILURE (ACTIVE); VIN RX FAILURE (ACTIVE)
- Symptom: TX FAILURE (ACTIVE)
- Symptom: *A/C - HEATER CONTROL ILLUMINATION INOPERATIVE
- Symptom: *BLEND/MODE/RECIRC DOOR OPERATION IMPROPER
- Symptom: *BLOWER MOTOR INOPERATIVE
- Symptom: *BLOWER MOTOR SPEEDS INCORRECT
- Symptom: *EBL STATUS INDICATOR FLASHING
- Symptom: *HVAC SYSTEM TEST
- Ignition, Power, Accessory
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT OPEN
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT SHORT TO GROUND
- Symptom: BCM - IGNITION MUX SWITCH INPUT MISMATCH
- Symptom: BCM - IGNITION MUX SWITCH INPUT OPEN
- Symptom: BCM - IGNITION MUX SWITCH INPUT SHORT
- Symptom: BCM - IGNITION RUN 1 SHORT
- Symptom: BCM - IGNITION RUN 2 SHORT
- Symptom: BCM - IOD OUTPUT CIRCUIT SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT OPEN / SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT SHORT TO VOLTAGE
- Symptom: BCM - RUN/START HARDWIRE INPUT MISMATCH
- Symptom: HORN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: HORN RELAY COIL SHORT TO BATTERY
- Symptom: HORN SWITCH STUCK
- Symptom: *HORNS INOPERATIVE
- Instrument Cluster
- Symptom List: ABS LAMP CIRCUIT OPEN; ABS LAMP CIRCUIT SHORTED; AIRBAG LAMP CIRCUIT OPEN; AIRBAG LAMP CIRCUIT SHORTED
- Symptom: ABS MESSAGES NOT RECEIVED
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT OPEN / SHORTED TO VOLTAGE
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT SHORT TO GROUND
- Symptom: BCM - PWM DIMMING OUTPUT SHORT
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: ORC MESSAGES NOT RECEIVED
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *GAUGE CLUSTER DIAGNOSTIC TEST
- Symptom: *INSTRUMENT CLUSTER DIAGNOSTIC TEST
- Interior Lighting
- Power Door Locks/RKE
- Symptom: DECKLID RELEASE OUTPUT OPEN
- Symptom: DECKLID RELEASE OUTPUT SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH OPEN OR SHORT TO VOLTAGE
- Symptom: DRIVER CYLINDER UNLOCK SWITCH SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH STUCK
- Symptom: DRIVER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: DRIVER DOOR LOCK SWITCH STUCK
- Symptom: DRIVER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: DRIVER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: DRIVER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER DOOR LOCK SWITCH STUCK
- Symptom: PASSENGER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER/DRIVER DOOR UNLATCH RETURN SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT OPEN/SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT SHORT TO BATTERY
- Symptom: *ALL DOOR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR UNLATCH INOPERATIVE
- Symptom: *PASSENGER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *PASSENGER DOOR UNLATCH INOPERATIVE
- Symptom: *REMOTE KEYLESS ENTRY PROBLEM
- Power Windows
- Symptom: DRIVER WINDOW DOWN OUTPUT SHORT TO GROUND
- Symptom: DRIVER WINDOW HALL EFFECT FAILURE
- Symptom: DRIVER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: DRIVER WINDOW SWITCH SHORT TO GROUND
- Symptom: DRIVER WINDOW SWITCH STUCK DOWN
- Symptom: DRIVER WINDOW SWITCH STUCK UP
- Symptom: DRIVER WINDOW UP OUTPUT SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL SHORT TO BATTERY
- Symptom: PASSENGER WINDOW HALL EFFECT FAILURE
- Symptom: PASSENGER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: PASSENGER WINDOW SWITCH SHORT TO GROUND
- Symptom: PASSENGER WINDOW SWITCH STUCK DOWN
- Symptom: PASSENGER WINDOW SWITCH STUCK UP
- Symptom: PASSENGER WINDOW UP SHORT TO GROUND
- Symptom: *DRIVER WINDOW INOPERATIVE
- Symptom: *PASSENGER WINDOW INOPERATIVE
- Tire Pressure Monitoring
- Symptom: CRITICAL TIRE PRESSURE - BCM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM
- Symptom: TIRE PRESSURE LOW - BCM
- Symptom: TIRE PRESSURE MONITOR MODULE FAILURE - TPM
- Symptom: TPM DIAGNOSTIC - BCM
- Symptom: TPM MODULE INITIALIZED - BCM
- Symptom: *LO TIRE LCD MESSAGE FLASHING
- Vehicle Theft/Security
- Symptom: VTSS INDICATOR OUTPUT OPEN
- Symptom: VTSS INDICATOR OUTPUT SHORT
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *DECKLID DOES NOT TRIP VTSS
- Symptom: *DRIVER DOOR DOES NOT TRIP VTSS
- Symptom: *EXTERIOR LAMPS FAIL TO FLASH WHEN ALARM IS TRIPPED
- Symptom: *HOOD DOES NOT TRIP VTSS
- Symptom: *HORN FAILS TO SOUND WHEN ALARM IS TRIPPED
- Symptom: *PASSENGER DOOR DOES NOT TRIP VTSS
- Symptom: *VTSS LAMP ON STEADY DURING ARMING
- Symptom: *VTSS WILL NOT ARM
- Verification Tests
- Airbag
- Component Locations
- Connector PINOUTS
- A/C-Heater Control C1 - Black 10 Way
- A/C-Heater Control C2 - Black 16 Way
- Airbag Control Module C1 (Orc) - Yellow 32 Way
- Airbag Control Module C2 (Orc) - Yellow 32 Way
- Airbag On/Off Switch-Passenger - Yellow 6 Way
- Airbag Squib 1-Driver - Yellow/Black 2 Way
- Airbag Squib 2-Driver - Yellow/Gray 2 Way
- Airbag Squib-Passenger - Yellow 4 Way
- Ajar Switch-DECKLID - Black 3 Way
- Ajar Switch-Driver Door - Black 4 Way
- Ajar Switch-Hood - Natural 3 Way
- Ajar Switch-Passenger Door - Black 4 Way
- Blend Door Actuator - Gray 2 Way
- Blower Motor - Orange 2 Way
- Blower Motor Resistor Block - Black 4 Way
- Body Control Module C1 - Black 6 Way
- Body Control Module C2 - Black/Green 34 Way
- Body Control Module C3 - Black/White 34 Way
- Body Control Module C4 - Black/Gray 34 Way
- Brake Fluid Level Switch - Black 2 Way
- C200 - Black (Body Side)
- C200 - Black (Instrument Panel Side)
- C201 - Yellow (Body Side)
- C201 - Yellow (Instrument Panel Side)
- C202 - Natural (Driver Door Side)
- C202 - Natural (Instrument Panel Side)
- C203 - Natural (Instrument Panel Side)
- C203 - Natural (Passenger Door Side)
- C204 - LT. Gray (HVAC Jumper Side)
- C204 - LT. Gray (Instrument Panel Side)
- C206 - Red (Console Jumper Side)
- C206 - Red (Instrument Panel Side)
- C207 - Green (Instrument Panel Side)
- C207 - Natural (Passenger Door Side)
- C208 - Green (Instrument Panel Side)
- C208 - Natural (Driver Door Side)
- C303 - Black (Body Side)
- C303 - Black (DECKLID Jumper Side)
- CLOCKSPRING - White 8 Way
- Controller Antilock Brake - Black 24 Way
- Cylinder Unlock Switch-Driver - Black 2 Way
- Data Link Connector - Black 16 Way
- DECKLID Release Motor - Black 2 Way
- Door Latch Motor-Driver - 2 Way
- Door Latch Motor-Passenger - 2 Way
- Door Lock Switch-Driver - Black 3 Way
- Door Lock Switch-Passenger - Black 3 Way
- Exterior Door Handle Switch-Driver - Black 2 Way
- Exterior Door Handle Switch-Passenger - Black 2 Way
- Fog Lamp-Left - Black 2 Way
- Gauge Cluster C1 - White 3 Way
- Gauge Cluster C2 - Black 20 Way
- Hid Lamp-Left - Gray 2 Way
- High Beam Headlamp-Left - Black 2 Way
- Horn Switch - Black 1 Way
- Horn-High Note - Black 2 Way
- Horn-Low Note - Black 2 Way
- Ignition Switch - Black 5 Way
- Instrument Cluster C1 - Black 16 Way
- Instrument Cluster C2 - Black 20 Way
- Interior Door Handle Switch-Driver - Black 2 Way
- Interior Door Handle Switch-Passenger - Black 2 Way
- Marker Lamp-Left Front - DK. Gray 2 Way
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way
- Multi-Function Switch - Gray 20 Way
- Power Distribution Center
- Power Window Motor-Driver - Black 6 Way
- Power Window Motor-Passenger - Black 6 Way
- Power Window Switch-Driver - Gray 3 Way
- Power Window Switch-Passenger - Gray 3 Way
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Radio - Gray 22 Way
- RECIRCULATION Door Actuator - Gray 2 Way
- Remote Keyless Entry Module - Black 6 Way
- Seat Belt Switch-Driver - White 2 Way
- Seat Belt Switch-Passenger - White 2 Way
- Seat Belt TENSIONER-Driver - Yellow 2 Way
- Seat Belt TENSIONER-Passenger - Yellow 2 Way
- Speaker-Left Door - Black 2 Way
- Speaker-Left Instrument Panel - White 2 Way
- Speaker-Left Rear - White 3 Way
- Speaker-Rear Woofer - Gray 4 Way
- Speaker-Right Door - Black 2 Way
- Speaker-Right Instrument Panel - White 2 Way
- Speaker-Right Rear - White 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Window Down Relay-Passenger - Black 5 Way
- Window Up Relay-Passenger - Black 5 Way
- Schematic Diagrams
- Airbag System
- Audio System
- Chime System
- Communication
- Door Ajar System
- Electrically Heated Systems
- Exterior Lighting
- Heating & A/C System
- Ignition, Power, Accessory
- Instrument Cluster/Gauge Cluster
- Interior Lighting
- Power Door Locks/RKE
- Power Window System
- Tire Pressure Monitor Module (TPM)
- Vehicle Theft Security System
- Tires & Wheels
- Body Diagnostic Procedures
- Front Suspension
- Transmission
- Clutch System (Service Information)
- T-56 Manual Transmission
- External Pages