Technical Service Bulletins
- A/C Compressor
- A/C System Additives (24-003-03)
- A/C System Leak Detection (24-009-02)
- R-134A Refrigerant Leak Detection (24-13-94)
- Manual A/C Inoperative:Body Control Module Locked Up (24-24-93)
- Climate Control Unit Whistling: Seam Resealing (24-10-93)
- ATC Sun Sensor Inoperative: Sensor Reposition (24-09-93)
- A/C Clutch Connectors Replacement: Inoperative A/C (24-07-93)
- A/C Refrigerant System Contamination:TXV Replacement (24-16-92)
- A/C Faulty Pressure Transducer: TRANSDCR Replacement (24-13-92)
- ATC Warm Air Discharge: Inspection/Operational Tips (24-14-92)
- Accessories Control Systems
- Accessory Drive Belts
- Air Bag, SRS
- Airbag On-Off Switches (08-37-99)
- Airbag/Clock Spring Service (08-010-01)
- Non-Deployed Airbag Handling Procedures (08-27-00)
- NHTSA Authorized Airbag Deactivation For Medical (08-32-97)
- Passenger Airbag Door Poor Fit/Warped (23-19-97)
- Service Manual Revisions - September, 1995 (26-07-95)
- Base Body Control Module Lock-Up (08-14-94 REV. A)
- Anti-Lock Brakes
- Anti-Theft Systems
- Internal Emergency Trunk Release (23-20-99)
- Body Mounted Door Weatherstrip Loose (23-08-97)
- Door Check Straps Noise/Travel Effort: Revised Strap (23-76-96)
- Door Glass Lift Plate Servicing - Information (23-11-95)
- Service Manual Revisions - February 1995 (26-01-95)
- Base Body Control Module Lock-Up (08-14-94 REV. A)
- Lock Cylinder Key Breakage (23-60-93)
- Rolling Door Locks: Service Manual Revision (08-13-93)
- Vehicle Wind Noise Point Inspection/Repair Procedure (23-15-93)
- DECKLID Torsion Bar Disengagement: RESECURING (23-38-92)
- Automatic Trans
- Automatic Transmission Fluid Usage ATF+4 (Type Ms9602) (21-014-07)
- Automatic Transmission Fluid Usage ATF+4 (Type 9602) (21-16-99)
- Reusable Automatic Transmission Oil Pan Gasket (21-05-99 REV. A)
- Running Changes To Transmission Range Sensor (21-04-99)
- 41TE & 42LE: Delayed Transaxle Engagement At Startup (21-07-98)
- Auxiliary Differential Vent (21-10-99)
- 41TE/42LE Service Information (21-18-96)
- 41TE/42LE Transaxle Shudder During An EMCC Shift (21-05-97)
- Shudder During Torque Converter Lockup - Code 38 (18-17-96 REV. B)
- Transmission Fluid AUXILLIARY Cooler Installation (21-17-96)
- Transmission Fluid Cooler Line Service (07-05-95)
- 41TE/42LE Trans Shifting While Speed Control Engaged (08-15-95 REV. A)
- 41TE/42LE Trans Poor Shift/Slips/Shudder - O/H Pkg. (21-06-95 REV. A)
- Improved Transmission Shift Quality - 41TE Or 42LE (18-27-94 REV. A)
- Front Hub Click/Clunk: New C/V Joint Kit (02-04-95)
- Transmission Buzz Or Rattle Noise (21-15-94)
- Carbon Buildup On Top Of Piston - Fuel INJ. Cleaner (09-21-93)
- Engine Coolant Recommendations (07-05-93)
- Floor Shifter Knob Button Sticking (21-30-93)
- Loose Floor Shifter Knob:New Set Screw (21-27-93)
- Whistling Noise At Idle (41TE/42LE A/T): Inspection (21-01-93)
- Auxiliary Emission Control Systems
- Axle Shafts
- Blowers, Superchargers & Turbochargers
- Body Interior
- Flash Programming Failure Recovery (18-32-98)
- Inoperative A/C System - A/C Pressure Transducer (24-14-94)
- Manual A/C Inoperative:Body Control Module Locked Up (24-24-93)
- Transaxle Quick Learn Procedure: Service Correction (21-02-93 REV. A)
- ATC Sun Sensor Inoperative: Sensor Reposition (24-09-93)
- A/C Clutch Connectors Replacement: Inoperative A/C (24-07-93)
- A/C Faulty Pressure Transducer: TRANSDCR Replacement (24-13-92)
- ATC Warm Air Discharge: Inspection/Operational Tips (24-14-92)
- Auto Temp Control: Supplemental Diagnostic Procedure (08-15-92)
- Brakes Control Systems
- Charging Systems
- Clutch
- Communication Devices
- Cooling Fan
- Cooling System (Mechanical)
- Low Or No Cabin Heat, Engine Cooling System Fill Procedure (07-02-00)
- Cooling Fan Noise - Cooling Fan Module Replacement (18-20-96)
- 3.3L/3.8L Lower Engine Oil Leaks: Suppl. Procedures (09-15-92)
- Oil Leak Diagnosis - Dye/Black Lite Test Info (09-17-94)
- Engine Coolant Recommendations (07-05-93)
- 3.3L & 3.5L Fuel Pressure Regulator Installation (14-16-93)
- Fuel Pump/Filter Diagnosis And Service (14-03-93)
- Cooling System Fill/Pressure Cap Application (07-04-92)
- Radiator Coolant Fill Supplemental Procedure (07-02-92)
- Cruise Control Systems
- Differentials & Drive Axles
- Front Hub Click/Clunk: New C/V Joint Kit (02-04-95)
- Service Manual Revisions - February 1995 (26-01-95)
- Service Manual Revision - Torque Specifications (02-17-94)
- Service Manual Revision - Torque Specifications (02-13-94)
- Carbon Buildup On Top Of Piston - Fuel INJ. Cleaner (09-21-93)
- Engine Coolant Recommendations (07-05-93)
- Driveshaft & Universal Joints
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Flash Programming Failure Recovery (18-32-98)
- Use Of Two Digit Calendar Year Codes In Computers (08-36-98)
- Service Manual Revisions - February 1995 (26-01-95)
- Engine Does Not Start Due To Pcm/BCM Swapping (08-02-95)
- Cold Weather No-Starts - New Pcm Spark Plugs & Oil (18-29-94)
- Diagnostic Manual Revision - Information Corrected (18-18-93)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Exterior Lights
- Headlamp Pattern Improvement - New Headlamp Design (08-33-95 REV. A)
- Base Body Control Module Lock-Up (08-14-94 REV. A)
- Moisture In Park/Turn Lamp - New Socket To Lamp Seal (08-59-94)
- Rear Assist Handle/Reading Lamp Service/Wire Routing (08-22-94)
- Moisture In Headlamp - Vent Tube Routing (08-38-93)
- Headlamp Aiming Procedure (08-08-93 REV. A)
- Electrical Failures:Front Frame Rail Grounding (08-10-93)
- Frames, Subframes & Crossmembers
- Front Suspension
- Vehicle Leads Or Pulls - Diagnostic Procedure & Fix (02-23-94)
- Power STERING Noise When Turning Steering Wheel (19-12-95)
- Squawk From Front Suspension In Cold Weather (02-11-95)
- Clunking Or Rattling Noise From Front Suspension (02-10-95)
- Front Hub Click/Clunk: New C/V Joint Kit (02-04-95)
- Rear Spring Rattle: New Coil Spring Sleeve (02-05-94)
- Rear Road Noise Improvement - Coil Spring Indexing (02-21-94)
- Service Manual Revision - Torque Specifications (02-17-94)
- Rear Suspension Squeak - New Rear Upper Strut Mounts (02-15-94)
- Tire Lead/Drift (22-03-93 REV. B)
- Fuel System
- Service Manual Revisions - February 1995 (26-01-95)
- Excess Fuel Tank Reserve - New Fuel Level Sensor (14-03-94)
- 3.3L Fuel System Rattle - Fuel Rail Replacement (14-14-94)
- 3.5L Fuel System Rattle: Fuel Rail ASSY Replacement (14-18-93)
- 3.5L Hard Start Long Crank Time Engine Miss (18-15-93)
- Stalls/Hesitation/Erratic Shifting: New Fuel Pump (14-08-93 REV. A)
- Hard Start/Long Crank Times: Fuel Pump Replacement (14-07-92)
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- Base Body Control Module Lock-Up (08-14-94 REV. A)
- Excess Fuel Tank Reserve - New Fuel Level Sensor (14-03-94)
- Ash Receiver Rattle: Insulation Installation (23-19-94)
- Electrical Failures:Front Frame Rail Grounding (08-10-93)
- Abs Amber Dash Lamp Flashes:New Ecu (Cab) ADAPTOR (05-01-93)
- Manual A/C Light Stays On: Programmer Operation (24-20-92)
- Fuel Level Gauge Operation: Diagnostic Indicators (08-17-92)
- Headlights
- Headlamp Pattern Improvement - New Headlamp Design (08-33-95 REV. A)
- Base Body Control Module Lock-Up (08-14-94 REV. A)
- Moisture In Park/Turn Lamp - New Socket To Lamp Seal (08-59-94)
- Rear Assist Handle/Reading Lamp Service/Wire Routing (08-22-94)
- Moisture In Headlamp - Vent Tube Routing (08-38-93)
- Headlamp Aiming Procedure (08-08-93 REV. A)
- Electrical Failures:Front Frame Rail Grounding (08-10-93)
- Horns
- HVAC Control Systems
- A/C Cooling Coil Odor (24-013-05)
- A/C System Additives (24-003-03)
- A/C System Leak Detection (24-009-02)
- Low Or No Cabin Heat, Engine Cooling System Fill Procedure (07-02-00)
- HVAC Housing Service - Revised Procedure/Labor Times (24-01-98)
- Air Conditioning Ducts Emit Odor (24-11-97)
- Evaporator Leaks - Cowl Plenum Screen (24-09-97)
- Water Ingestion Into Heater/Ac Housing - Cowl Screen (24-08-97)
- Cup Holder Improvements - Service Information (23-43-96)
- Intermittent A/C Or Poor A/C Performance (24-15-95)
- Service Manual Revisions - October, 1995 (26-08-95)
- Windshield Defrost Improvement (24-11-95)
- White Flakes From Instrument Panel Outlet (24-08-95)
- Water Ingestion Into Heater/A/C Housing (24-04-94 REV. A)
- Inoperative A/C System - A/C Pressure Transducer (24-14-94)
- R-134A Refrigerant Leak Detection (24-13-94)
- Body Diagnostics Procedures Manual Revision (08-46-94)
- A/C Evaporator Odor: Evaporator Cleaning (24-08-94)
- A/C Refrigerant Leaks At Compressor Hose Connections (24-29-93)
- Manual A/C Inoperative:Body Control Module Locked Up (24-24-93)
- Installation Of Heat Distribution Duct (24-22-93)
- R-134A Refrigerant Leak Detection (24-20-93)
- 3.5L A/C Compressor Noise: Diagnosis (24-18-93 REV. A)
- Heater/Ac Housing Water Ingestion (24-19-93)
- Climate Control Unit Whistling: Seam Resealing (24-10-93)
- ATC Sun Sensor Inoperative: Sensor Reposition (24-09-93)
- A/C Clutch Connectors Replacement: Inoperative A/C (24-07-93)
- Windshield Defrost Improvement Procedure (24-03-93 REV. A)
- Wind Noise In RECIRCULATION Mode:Revised RECIRC Door (24-01-93)
- Manual A/C Light Stays On: Programmer Operation (24-20-92)
- A/C Compressor Discharge Line Contact W/Exhaust (24-19-92)
- A/C Refrigerant System Contamination:TXV Replacement (24-16-92)
- LT/Rt Temp Differential: Instrument Panel Outlets (24-15-92)
- A/C Faulty Pressure Transducer: TRANSDCR Replacement (24-13-92)
- ATC Warm Air Discharge: Inspection/Operational Tips (24-14-92)
- Ignition Switch/Steering Lock
- Ignition System
- 3.5L Spark Plugs For Improved Cold Starting (18-18-95)
- Service Manual Revisions - February 1995 (26-01-95)
- Cold Weather No-Starts - New Pcm Spark Plugs & Oil (18-29-94)
- 3.5L Engine Buck Or Intermittent Miss (18-12-94)
- 3.3L & 3.5L Fuel Pressure Regulator Installation (14-16-93)
- 3.5L Eng Spark Plug Discoloration Explained (08-28-93)
- Engine Timing Belt TENSIONER Inspection (09-12-93)
- Fuel Pump/Filter Diagnosis And Service (14-03-93)
- Interior/Exterior Trim
- Passenger Airbag Door Poor Fit/Warped (23-19-97)
- Body Mounted Door Weatherstrip Loose (23-08-97)
- Chalky Residue On Black Plastic Body Components (23-03-97)
- Wind Noise Around Door: Sealer/Insulator Install.N (23-28-94)
- "B" Pillar Rattle: Insulation Installation (23-18-94)
- Lower Knee Bolster Panel To Door Panel Interference (23-53-93)
- License Plate Installation Information (23-20-93)
- Rusty C-Pillar Applique Attaching Screws: New Screws (23-32-92)
- Interior/Illumination Lights
- Headlamp Pattern Improvement - New Headlamp Design (08-33-95 REV. A)
- Base Body Control Module Lock-Up (08-14-94 REV. A)
- Moisture In Park/Turn Lamp - New Socket To Lamp Seal (08-59-94)
- Rear Assist Handle/Reading Lamp Service/Wire Routing (08-22-94)
- Moisture In Headlamp - Vent Tube Routing (08-38-93)
- Headlamp Aiming Procedure (08-08-93 REV. A)
- Electrical Failures:Front Frame Rail Grounding (08-10-93)
- Locking Hubs
- Lubrication System
- Service Manual Revisions - October, 1995 (26-08-95)
- 3.3L/3.8L Lower Engine Oil Leaks: Suppl. Procedures (09-15-92)
- Oil Leak Diagnosis - Dye/Black Lite Test Info (09-17-94)
- Carbon Buildup On Top Of Piston - Fuel INJ. Cleaner (09-21-93)
- Engine Coolant Recommendations (07-05-93)
- 3.3L & 3.5L Fuel Pressure Regulator Installation (14-16-93)
- Fuel Pump/Filter Diagnosis And Service (14-03-93)
- Manual Steering
- Manual Trans
- Mechanical
- Camshaft/Bearing Service (09-008-01)
- 3.5L Engine Valve Train Noise (09-01-96)
- Service Manual Revisions - October, 1995 (26-08-95)
- 3.3L/3.8L Lower Engine Oil Leaks: Suppl. Procedures (09-15-92)
- Oil Leak Diagnosis - Dye/Black Lite Test Info (09-17-94)
- Service Manual Correction - 3.5L Engine Camshaft Alignment (09-16-93)
- Engine Idle Piston Noise: New Coated Pistons (09-03-94)
- Carbon Buildup On Top Of Piston - Fuel INJ. Cleaner (09-21-93)
- 3.3L & 3.8L Idle Air Control Motor Whistle (14-09-93 REV. A)
- 3.3L & 3.5L Fuel Pressure Regulator Installation (14-16-93)
- Engine Timing Belt TENSIONER Inspection (09-12-93)
- Engine Mount Start-Up/Shut-Down Noise:Revised Mounts (09-05-93)
- Fuel Pump/Filter Diagnosis And Service (14-03-93)
- Mechanical - Hydraulic
- Brake Noise Information Guide (05-09-96)
- Service Manual Revisions - September, 1995 (26-07-95)
- Front Brake Disc (Rotor) Service (05-13-94)
- Service Manual Revisions - February 1995 (26-01-95)
- Rear Disc Brake Moan/Howl - New Brake Adapters (05-20-94)
- Service Manual Revision - Brake Disc (Rotor) Specification (05-12-94)
- Disc Brake Noise (05-20-93)
- Carbon Buildup On Top Of Piston - Fuel INJ. Cleaner (09-21-93)
- Engine Coolant Recommendations (07-05-93)
- Mirrors
- Paint & Coatings
- Passive Restraints
- Child Seat Tether Anchor Installation (23-35-99 REV.A)
- Power STERING Noise When Turning Steering Wheel (19-12-95)
- Front Hub Click/Clunk: New C/V Joint Kit (02-04-95)
- Rear Spring Rattle: New Coil Spring Sleeve (02-05-94)
- Rear Road Noise Improvement - Coil Spring Indexing (02-21-94)
- Rear Suspension Squeak - New Rear Upper Strut Mounts (02-15-94)
- Rear Suspension
- Vehicle Leads Or Pulls - Diagnostic Procedure & Fix (02-23-94)
- Power STERING Noise When Turning Steering Wheel (19-12-95)
- Squawk From Front Suspension In Cold Weather (02-11-95)
- Service Manual Revisions - September, 1995 (26-07-95)
- Clunking Or Rattling Noise From Front Suspension (02-10-95)
- Front Hub Click/Clunk: New C/V Joint Kit (02-04-95)
- Rear Spring Rattle: New Coil Spring Sleeve (02-05-94)
- Rear Road Noise Improvement - Coil Spring Indexing (02-21-94)
- Service Manual Revision - Torque Specifications (02-17-94)
- Rear Suspension Squeak - New Rear Upper Strut Mounts (02-15-94)
- Service Manual Revision - Rear Suspension Torque Specifications (02-07-92)
- Restraints Control Systems
- Seats
- Child Seat Tether Anchor Installation (23-35-99 REV.A)
- Front Seat Cushion Pan Replacement (23-046-00)
- "B" Pillar Rattle: Insulation Installation (23-18-94)
- Ash Receiver Rattle: Insulation Installation (23-19-94)
- BACKLITE Rattle: Resetting BACKLITE (23-15-94)
- Head Restraint Availability (23-51-93)
- "Clicking" Seat Track Rollers (23-36-93)
- Rear Window Squeak: Rear Window Molding Lubrication (23-18-93)
- Rolling Door Locks: Service Manual Revision (08-13-93)
- Electrical Failures:Front Frame Rail Grounding (08-10-93)
- Starter
- Steering Column
- Service Manual Revisions - December, 1995 (26-10-95)
- Power STERING Noise When Turning Steering Wheel (19-12-95)
- Steering Wheel Creak Noise (08-43-95)
- Front Hub Click/Clunk: New C/V Joint Kit (02-04-95)
- Rear Spring Rattle: New Coil Spring Sleeve (02-05-94)
- Rear Road Noise Improvement - Coil Spring Indexing (02-21-94)
- Rear Suspension Squeak - New Rear Upper Strut Mounts (02-15-94)
- Steering Gear
- Steering Linkage
- Loose Steering (19-003-00 REV. B)
- Service Torque For Inner Tie Rod To Steering Gear (19-08-99)
- Steering Gear Cold "Squawk" Noise (19-03-97 REV. A)
- Power STERING Noise When Turning Steering Wheel (19-12-95)
- Service Manual Revisions - October, 1995 (26-08-95)
- Service Manual Revisions - September, 1995 (26-07-95)
- Front Hub Click/Clunk: New C/V Joint Kit (02-04-95)
- Rear Spring Rattle: New Coil Spring Sleeve (02-05-94)
- Rear Road Noise Improvement - Coil Spring Indexing (02-21-94)
- Rear Suspension Squeak - New Rear Upper Strut Mounts (02-15-94)
- Service Manual Revision - Torque Specifications (02-13-94)
- Tire Lead/Drift (22-03-93 REV. B)
- Sun Roof/T-Top/Convertible Top
- System
- Flash Programming Failure Recovery (18-32-98)
- Use Of Two Digit Calendar Year Codes In Computers (08-36-98)
- 3.5L Spark Plugs For Improved Cold Starting (18-18-95)
- Service Manual Revisions - February 1995 (26-01-95)
- Engine Does Not Start Due To Pcm/BCM Swapping (08-02-95)
- Cold Weather No-Starts - New Pcm Spark Plugs & Oil (18-29-94)
- Excess Fuel Tank Reserve - New Fuel Level Sensor (14-03-94)
- 3.3L Fuel System Rattle - Fuel Rail Replacement (14-14-94)
- 3.5L Engine Buck Or Intermittent Miss (18-12-94)
- 3.5L Fuel System Rattle: Fuel Rail ASSY Replacement (14-18-93)
- 3.5L Hard Start Long Crank Time Engine Miss (18-15-93)
- Diagnostic Manual Revision - Information Corrected (18-18-93)
- 3.3L & 3.5L Fuel Pressure Regulator Installation (14-16-93)
- 3.5L Eng Spark Plug Discoloration Explained (08-28-93)
- Engine Timing Belt TENSIONER Inspection (09-12-93)
- Stalls/Hesitation/Erratic Shifting: New Fuel Pump (14-08-93 REV. A)
- Fuel Pump/Filter Diagnosis And Service (14-03-93)
- Normal Duty Cycle Purge Solenoid Noise: New Bracket (25-01-92)
- Hard Start/Long Crank Times: Fuel Pump Replacement (14-07-92)
- Transfer Case
- Transmission Control Systems
- Vacuum Pumps/Lines/Tanks/Water Trap
- Warning Systems
- Wheel Alignment
- Wheels & Tire System
- Vehicle Leads Or Pulls - Diagnostic Procedure & Fix (02-23-94)
- POLYCAST Wheel Center Falls Off (22-02-96)
- Service Manual Revision - Torque Specifications (02-13-94)
- Tire Lead/Drift (22-03-93 REV. B)
- Tire & Wheel RUNOUT (22-05-93)
- Front Wheels Road Noise: C-Pillar Foam Sealing (23-30-93)
- Tire Pressure Specifications (22-02-93)
- Window Motors & Regulators
- Body Mounted Door Weatherstrip Loose (23-08-97)
- Door Glass Lift Plate Servicing - Information (23-11-95)
- Ash Receiver Rattle: Insulation Installation (23-19-94)
- BACKLITE Rattle: Resetting BACKLITE (23-15-94)
- Weatherstrip Sticking (23-69-93)
- Rear Window Squeak: Rear Window Molding Lubrication (23-18-93)
- Rolling Door Locks: Service Manual Revision (08-13-93)
- Electrical Failures:Front Frame Rail Grounding (08-10-93)
- Scratched Mirror Glass: Precautions (23-08-93)
- DECKLID Torsion Bar Disengagement: RESECURING (23-38-92)
- Wiper/Washer Systems
- Windshield Washer Nozzle FREEZ-Up - New Check Valve (08-20-95 REV. A)
- Service Manual Revisions - February 1995 (26-01-95)
- Revised Windshield Wiper Arms (08-34-94)
- Windshield Washer Spray Pattern (08-48-93)
- Winter Windshield Wiper Blades (08-49-93)
- Service Manual Revision - Wiper Motor Diagnostics (08-19-93)
- Wiper Motor Service: Additional Drain Holes (08-11-93)
- Wiring Diagrams
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)