Technical Service Bulletins

A/C Compressor
- A/C Compressor Not Operational / Low FREON - Shaft Seal Leaks (06-4-9)
Accessories Control Systems
- No Crank With Diagnostic Trouble Code - DTC B1601 And/Or Pats Security Access Issues (04-23-4)
Accessory Drive Belts
- 2.3L/2.0L DURATEC - No Start/Possible Engine Damage - Install Special Service Tools Prior To Removing Crankshaft Pulley Bolt (06-21-4)
Air Bag, SRS
- RCM Fault Reporting Using DTCS And Bit-Mapped Parameter Identifiers (PIDS) - Service Tips (07-7-8)
Anti-Theft Systems
- Safety Recall 05S27 - Rear Door Latch Corrosion - Requests For Recall Service Action - Built On Or Before 1/26/2005 (16-0067)
- Keypad Diagnostics - Dealer Installed Accessory (06-15-8)
- Power Door Locks Cycling Or Self Locking (05-10-21)
- No Crank With Diagnostic Trouble Code - DTC B1601 And/Or Pats Security Access Issues (04-23-4)
Auxiliary Emission Control Systems
- Hard Start/Long Crank (06-8-14)
- Rattle - Pcm Bracket (05-12-2)
- General Pcm Programming Procedures (04-24-14)
- Mil On With DTC P2004 (04-21-18)
Body Electrical
- Service Wiring Harness Replacement Guidelines - Service Tips (06-17-8)
- Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)
Body Interior
- No Crank With Diagnostic Trouble Code - DTC B1601 And/Or Pats Security Access Issues (04-23-4)
Brakes Control Systems
- Increased Brake Pedal Efforts Required On Initial Stopping After Cold Start At High Altitude (06-18-5)
Charging Systems
- Stuck High Voltage Charge Cord Information Sheet (G0000127)
- Service Wiring Harness Replacement Guidelines - Service Tips (06-17-8)
Clutch
- Clutch Pedal Return Spring Noise And/Or Free Play (08-23-14)
- MTX-75 Premature Clutch Failure (06-24-10)
Cooling System (Mechanical)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
Cruise Control Systems
- Speed Control Diagnostics - W/O SCP (06-8-5)
Engine Control Systems
- Fuel Fill - Slow/Early Shut Off (07-8-1)
- 2.3L/2.0L DURATEC - No Start/Possible Engine Damage - Install Special Service Tools Prior To Removing Crankshaft Pulley Bolt (06-21-4)
- Hard Start/Long Crank (06-8-14)
- WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
- Rattle - Pcm Bracket (05-12-2)
- 2.0L/2.3L Engine With MTX-75 - Long Crank/Hard Start (05-9-16)
- General Pcm Programming Procedures (04-24-14)
- No Crank With Diagnostic Trouble Code - DTC B1601 And/Or Pats Security Access Issues (04-23-4)
- Mil On With DTC P2004 (04-21-18)
Entertainment Systems
- Audio / Navigation Service And Ordering Procedures (06-21-7)
- Cd Player With Mp3 Capability Pausing Or Skipping Between Tracks (06-17-4)
- Intermittent Cd Player Concerns - Audio Unit Programmable Module Installation (PMI) Requirements (05-6-9)
- Rear Window Defroster Grid/Integral Antenna Diagnosis And Repair - Terminal Tab Repair (04-24-5)
Exhaust
- Various Vehicles - Catalytic Converter Concern Analysis (22-7009)
Exterior Body Panels
- Fuel Fill - Slow/Early Shut Off (07-8-1)
- Luggage Compartment Lid Contacting Rear Bumper Cover (06-3-15)
- Water Leaks And/Or A/C Condensation Leaks At Front Floor Area (05-13-3)
- Luggage Compartment Lid Will Not Open/Re-Latches When Opening With Remote Transmitter Or Luggage Compartment Lid Release Switch (04-26-3)
- Weld Bonding Procedure (04-26-16)
Frames, Subframes & Crossmembers
- Drift/Pull Concern Due To Front SUBFRAME Misalignment (07-4-2)
- Luggage Compartment Lid Contacting Rear Bumper Cover (06-3-15)
- Water Leaks And/Or A/C Condensation Leaks At Front Floor Area (05-13-3)
- Weld Bonding Procedure (04-26-16)
Front Suspension
- Drift/Pull Concern Due To Front SUBFRAME Misalignment (07-4-2)
Fuel System
- Fuel Fill - Slow/Early Shut Off (07-8-1)
Fuses & Circuit Breakers
- Service Wiring Harness Replacement Guidelines - Service Tips (06-17-8)
- Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)
Heated Glass/Defoggers
- Rear Window Defroster Grid/Integral Antenna Diagnosis And Repair - Terminal Tab Repair (04-24-5)
HVAC Control Systems
- White Flakes Or Powder Coming From A/C Vents (11-9-6)
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
- A/C Compressor Not Operational / Low FREON - Shaft Seal Leaks (06-4-9)
- Water Leaks And/Or A/C Condensation Leaks At Front Floor Area (05-13-3)
Ignition Switch/Steering Lock
- Ignition Key Difficult Or Unable To Be Turned Or Removed - Key-In-Ignition Warning Chime Sounding With Key Removed (05-21-17)
Ignition System
- WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
Infotainment
- Audio / Navigation Service And Ordering Procedures (06-21-7)
- Rear Window Defroster Grid/Integral Antenna Diagnosis And Repair - Terminal Tab Repair (04-24-5)
Interior/Exterior Trim
- Center Console Arm Rest Pivot Loose (07-6-4)
- Interior Trim - Carpet Pulling From Under Left Or Right Front Scuff Plate Trim Panel (06-5-6)
- Squeaking Noise From 9 Spoke Wheel Covers (06-9-5)
- Luggage Compartment Lid Contacting Rear Bumper Cover (06-3-15)
- Water Leaks And/Or A/C Condensation Leaks At Front Floor Area (05-13-3)
- Interior Plastic Trim - Paint-To-Match And Repair - Interior Spray Paint And Adhesion Promoter Usage Instructions (05-9-3)
- Interior Trim - Carpet Pulling From Under Right Front Cowl Side Kick Panel (05-9-9)
Manual Steering
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
Manual Trans
- MTX-75 - Gearshift Cables Detaching At Transaxle (05-19-5)
- Difficult Or Unable To Shift Into 5TH Gear (05-8-1)
- Difficulty Changing Gears - Unable To Engage Gears (04-21-5)
Mechanical
- 2001-2019 Various Vehicles - 2.0L, 2.3L, And 2.5L 4-Cylinder Engine - Rear MAINSEAL Kit Tool Usage (SSM 47632)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Engine Vibration At Idle (11-3-24)
- 2.3L/2.0L DURATEC - No Start/Possible Engine Damage - Install Special Service Tools Prior To Removing Crankshaft Pulley Bolt (06-21-4)
Mechanical - Hydraulic
- Rear Brake Squeal (07-14-4)
- Increased Brake Pedal Efforts Required On Initial Stopping After Cold Start At High Altitude (06-18-5)
Mirrors
- Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
- Ford Interior Mirror Job Aid (G0000001)
Paint & Coatings
- Interior Plastic Trim - Paint-To-Match And Repair - Interior Spray Paint And Adhesion Promoter Usage Instructions (05-9-3)
- Paint - Iron Particle Removal - Industrial Fallout - Acid Rain Neutralization (99-12-10)
Passive Restraints
- Head Rests Rise While Driving (07-1-6)
- Safety Belt Web Stop Button Service (05-3-10)
Procedures
- 2001-2019 Various Vehicles - 2.0L, 2.3L, And 2.5L 4-Cylinder Engine - Rear MAINSEAL Kit Tool Usage (SSM 47632)
Restraints Control Systems
- RCM Fault Reporting Using DTCS And Bit-Mapped Parameter Identifiers (PIDS) - Service Tips (07-7-8)
Seats
- Head Rests Rise While Driving (07-1-6)
- Safety Belt Web Stop Button Service (05-3-10)
Starter
- Battery Service - Operation Of Battery Eye - Charging Service Tips (07-5-8)
- Battery Sliding In Battery Tray - Clunk Noise On Turns (06-8-8)
Steering Column
- Leather-Wrapped Steering Wheel - Leather Coming Loose (07-4-3)
Steering Control Systems
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
Steering Gear
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
Sun Roof/T-Top/Convertible Top
- Water Leaks And/Or A/C Condensation Leaks At Front Floor Area (05-13-3)
System
- Fuel Fill - Slow/Early Shut Off (07-8-1)
- 2.3L/2.0L DURATEC - No Start/Possible Engine Damage - Install Special Service Tools Prior To Removing Crankshaft Pulley Bolt (06-21-4)
- Hard Start/Long Crank (06-8-14)
- WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
- Rattle - Pcm Bracket (05-12-2)
- 2.0L/2.3L Engine With MTX-75 - Long Crank/Hard Start (05-9-16)
- General Pcm Programming Procedures (04-24-14)
- No Crank With Diagnostic Trouble Code - DTC B1601 And/Or Pats Security Access Issues (04-23-4)
- Mil On With DTC P2004 (04-21-18)
Towing
- Neutral Tow Capability - Service Kit Requirements (06-7-1)
Transmission Control Systems
- Rattle - Pcm Bracket (05-12-2)
Wheel Alignment
- Drift/Pull Concern Due To Front SUBFRAME Misalignment (07-4-2)
Wheels & Tire System
- Squeaking Noise From 9 Spoke Wheel Covers (06-9-5)
Wiper/Washer Systems
- Loss Of Intermittent Wiper Or Wiper Park Function (04-15-2)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Service Wiring Harness Replacement Guidelines - Service Tips (06-17-8)
- Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)