Technical Service Bulletins

A/C Compressor
- A/C Compressor Not Operational / Low FREON - Shaft Seal Leaks (06-4-9)
Accessory Drive Belts
- 2.3L/2.0L DURATEC - No Start/Possible Engine Damage - Install Special Service Tools Prior To Removing Crankshaft Pulley Bolt (06-21-4)
Air Bag, SRS
- RCM Fault Reporting Using DTCS And Bit-Mapped Parameter Identifiers (PIDS) - Service Tips (07-7-8)
Anti-Theft Systems
- Keypad Diagnostics - Dealer Installed Accessory (06-15-8)
Auxiliary Emission Control Systems
- 2.0L PZEV - Hesitation Or Surging While Driving With A/C On (06-18-4)
- Misfire DTCS P0316, P0300, P0301, P0302, P0303, And P0304 (06-18-1)
- 2.0L - DTC P1101 When Running KOEO Self Test (05-23-14)
- 2.0L - Minor Hesitation/Surge At Steady State Cruise 30 To 50 Mph (48 To 80 Km/H) (05-23-13)
Axle Shafts
- Half Shafts - Ratcheting/Clicking/Creaking Noise - Cold (07-18-6)
- Front Drive Intermediate Shaft Bearing Warble Type Noise On Acceleration (06-13-8)
Body Electrical
- Service Wiring Harness Replacement Guidelines - Service Tips (06-17-8)
- Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)
Brakes Control Systems
- Increased Brake Pedal Efforts Required On Initial Stopping After Cold Start At High Altitude (06-18-5)
Charging Systems
- Stuck High Voltage Charge Cord Information Sheet (G0000127)
- Service Wiring Harness Replacement Guidelines - Service Tips (06-17-8)
Clutch
- Clutch Pedal Return Spring Noise And/Or Free Play (08-23-14)
- MTX-75 Premature Clutch Failure (06-24-10)
- Transmission Fluid Leaks From Bell Housing Or Inability To Shift Into Gear Due To Clutch Slave Cylinder Leak (06-23-1)
Cooling System (Mechanical)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
Differentials & Drive Axles
- Half Shafts - Ratcheting/Clicking/Creaking Noise - Cold (07-18-6)
- Front Drive Intermediate Shaft Bearing Warble Type Noise On Acceleration (06-13-8)
Driveshaft & Universal Joints
- Half Shafts - Ratcheting/Clicking/Creaking Noise - Cold (07-18-6)
Engine Control Systems
- Fuel Fill - Slow/Early Shut Off (07-8-1)
- 2.3L/2.0L DURATEC - No Start/Possible Engine Damage - Install Special Service Tools Prior To Removing Crankshaft Pulley Bolt (06-21-4)
- 2.0L PZEV - Hesitation Or Surging While Driving With A/C On (06-18-4)
- Misfire DTCS P0316, P0300, P0301, P0302, P0303, And P0304 (06-18-1)
- 2.0L - DTC P1101 When Running KOEO Self Test (05-23-14)
- 2.0L - Minor Hesitation/Surge At Steady State Cruise 30 To 50 Mph (48 To 80 Km/H) (05-23-13)
- Hesitation And/Or Surge When A/C Compressor Cycles On/Off At Steady State Cruise (05-23-11)
- WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
Entertainment Systems
- Audio / Navigation Service And Ordering Procedures (06-21-7)
- Cd Player With Mp3 Capability Pausing Or Skipping Between Tracks (06-17-4)
Exhaust
- Various Vehicles - Catalytic Converter Concern Analysis (22-7009)
Exterior Body Panels
- Luggage Compartment Lid Solenoid Stuck Open (10-5-9)
- Fuel Fill - Slow/Early Shut Off (07-8-1)
- Water Leaks At Front And Rear Floor Area Or Coupe Rear Storage Area - Service Tips (07-1-11)
- Luggage Compartment Lid Contacting Rear Bumper Cover (06-3-15)
Frames, Subframes & Crossmembers
- Drift/Pull Concern Due To Front SUBFRAME Misalignment (07-4-2)
- Luggage Compartment Lid Contacting Rear Bumper Cover (06-3-15)
Front Suspension
- Drift/Pull Concern Due To Front SUBFRAME Misalignment (07-4-2)
Fuel System
- Fuel Fill - Slow/Early Shut Off (07-8-1)
Fuses & Circuit Breakers
- Service Wiring Harness Replacement Guidelines - Service Tips (06-17-8)
- Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)
HVAC Control Systems
- White Flakes Or Powder Coming From A/C Vents (11-9-6)
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
- A/C Compressor Not Operational / Low FREON - Shaft Seal Leaks (06-4-9)
Ignition System
- Misfire DTCS P0316, P0300, P0301, P0302, P0303, And P0304 (06-18-1)
- WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
Infotainment
- Audio / Navigation Service And Ordering Procedures (06-21-7)
Interior/Exterior Trim
- Center Console Arm Rest Pivot Loose (07-6-4)
- Water Leaks At Front And Rear Floor Area Or Coupe Rear Storage Area - Service Tips (07-1-11)
- Interior Trim - Carpet Pulling From Under Left Or Right Front Scuff Plate Trim Panel (06-5-6)
- Squeaking Noise From 9 Spoke Wheel Covers (06-9-5)
- Luggage Compartment Lid Contacting Rear Bumper Cover (06-3-15)
- Interior Plastic Trim - Paint-To-Match And Repair - Interior Spray Paint And Adhesion Promoter Usage Instructions (05-9-3)
Manual Steering
- Power Steering - Leak / Noisy (08-19-9)
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
Manual Trans
- Transmission Fluid Leaks From Bell Housing Or Inability To Shift Into Gear Due To Clutch Slave Cylinder Leak (06-23-1)
- MTX-75 - Gearshift Cables Detaching At Transaxle (05-19-5)
Mechanical
- 2001-2019 Various Vehicles - 2.0L, 2.3L, And 2.5L 4-Cylinder Engine - Rear MAINSEAL Kit Tool Usage (SSM 47632)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Engine Vibration At Idle (11-3-24)
- 2.3L/2.0L DURATEC - No Start/Possible Engine Damage - Install Special Service Tools Prior To Removing Crankshaft Pulley Bolt (06-21-4)
Mechanical - Hydraulic
- Rear Brake Squeal (07-14-4)
- Increased Brake Pedal Efforts Required On Initial Stopping After Cold Start At High Altitude (06-18-5)
Mirrors
- Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
- Ford Interior Mirror Job Aid (G0000001)
Paint & Coatings
- Interior Plastic Trim - Paint-To-Match And Repair - Interior Spray Paint And Adhesion Promoter Usage Instructions (05-9-3)
Parking Brake System
- Squeak Noise - Rear Of Vehicle Over Bumps (08-4-15)
Passive Restraints
- Head Rests Rise While Driving (07-1-6)
Procedures
- 2001-2019 Various Vehicles - 2.0L, 2.3L, And 2.5L 4-Cylinder Engine - Rear MAINSEAL Kit Tool Usage (SSM 47632)
Rear Suspension
- Focus Rear Shock "Chuckle" Noise Over Bumps (07-3-5)
Restraints Control Systems
- RCM Fault Reporting Using DTCS And Bit-Mapped Parameter Identifiers (PIDS) - Service Tips (07-7-8)
Seats
- Head Rests Rise While Driving (07-1-6)
Starter
- Battery Service - Operation Of Battery Eye - Charging Service Tips (07-5-8)
Steering Column
- Leather-Wrapped Steering Wheel - Leather Coming Loose (07-4-3)
Steering Control Systems
- Power Steering - Leak / Noisy (08-19-9)
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
Steering Gear
- Power Steering - Leak / Noisy (08-19-9)
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
System
- Fuel Fill - Slow/Early Shut Off (07-8-1)
- 2.3L/2.0L DURATEC - No Start/Possible Engine Damage - Install Special Service Tools Prior To Removing Crankshaft Pulley Bolt (06-21-4)
- 2.0L PZEV - Hesitation Or Surging While Driving With A/C On (06-18-4)
- Misfire DTCS P0316, P0300, P0301, P0302, P0303, And P0304 (06-18-1)
- 2.0L - DTC P1101 When Running KOEO Self Test (05-23-14)
- 2.0L - Minor Hesitation/Surge At Steady State Cruise 30 To 50 Mph (48 To 80 Km/H) (05-23-13)
- Hesitation And/Or Surge When A/C Compressor Cycles On/Off At Steady State Cruise (05-23-11)
- WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
Towing
- Neutral Tow Capability - Service Kit Requirements (06-7-1)
Wheel Alignment
- Drift/Pull Concern Due To Front SUBFRAME Misalignment (07-4-2)
Wheels & Tire System
- Squeaking Noise From 9 Spoke Wheel Covers (06-9-5)
Window Motors & Regulators
- Water Leaks At Front And Rear Floor Area Or Coupe Rear Storage Area - Service Tips (07-1-11)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Service Wiring Harness Replacement Guidelines - Service Tips (06-17-8)
- Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)