Technical Service Bulletins

Accessories Control Systems
- Various Vehicles - Module Reprogramming (G0000150)
- Audio Control Module (ACM) Displays Satellite Fault With Diagnostic Trouble Code (DTC) B1342 In Satellite Digital Audio Receiver System (SDARS) Module (11-3-3)
- Rattle/Buzz/Vibration - Transmission Cross-Member Exhaust Mount - Built Before 12/3/2007 (08-3-4)
- Discharged Batteries - Vehicles In Storage/Limited Usage (07-5-13)
Accessory Drive Belts
- Cold Start FEAD Hoot - Whistle Noise (09-9-7)
Air Bag, SRS
- Air Bag Warning Lamp On - DTC B2295 In Restraints Control Module (10-23-8)
Anti-Theft Systems
- Passive Anti Theft System(Pats) Key Programming (G0000156)
- Inoperative RKE Transmitter (Key Fob) - Discharged Key Fob Battery (08-12-9)
- Exterior Door Handle Not Flush In The Closed Position (07-16-7)
Automatic Trans
- 5R55S/5R55N/5R55W Transmissions - Shift Concerns, Loss Of 2ND, 3RD And 5TH Gear, Incorrect Ratio DTC'S - Procedure To Inspect And Repair Servo Pin Bore Wear (09-12-12)
- Shudder On ACCEL - Possible Wrong Trans CROSSMEMBER Assembly Installed (Excludes Gt 500) (08-23-4)
Auxiliary Emission Control Systems
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-7-4)
Axle Shafts
- Axle Whine (09-20-4)
Body Interior
- Various Vehicles - Module Reprogramming (G0000150)
- Audio Control Module (ACM) Displays Satellite Fault With Diagnostic Trouble Code (DTC) B1342 In Satellite Digital Audio Receiver System (SDARS) Module (11-3-3)
Charging Systems
- Stuck High Voltage Charge Cord Information Sheet (G0000127)
Clutch
- Clutch Pedal Very Low Engagement Effort 4.0L - Built From 8/20/2007 To 9/06/2007 (07-23-10)
Communication Devices
- Sync System Defaults To Or Stays In Privacy Mode, Multiple Vehicle Lines (10-2-8)
Cooling System (Mechanical)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
Differentials & Drive Axles
- Rear Drive Axle Vent - Oil Leak (12-5-8)
- Axle Whine (09-20-4)
Engine Control Systems
- Various Vehicles - Module Reprogramming (G0000150)
- Diagnostic Trouble Code (DTC) P1635 (19-7008)
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-7-4)
- Discharged Batteries - Vehicles In Storage/Limited Usage (07-5-13)
Entertainment Systems
- Audio Control Module (ACM) Displays Satellite Fault With Diagnostic Trouble Code (DTC) B1342 In Satellite Digital Audio Receiver System (SDARS) Module (11-3-3)
- Speaker Pop And/Or Radio Inoperative/Blank/Locked Up (09-20-10)
- Door Mounted Subwoofer - Static, Crackle, Pop Or Distorted Sound - Built Before 7/7/2008 (08-20-2)
- Satellite Digital Audio Receiver System (SDARS), May Not Seek All SIRIUS Satellite Radio Channels (08-5-1)
- Buzz/Rattle From Door Panel When Operating Audio System - Vehicles Built Before 8/2/2007 (07-17-6)
Exhaust
- Various Vehicles - Catalytic Converter Concern Analysis (22-7009)
- Rattle/Buzz/Vibration - Transmission Cross-Member Exhaust Mount - Built Before 12/3/2007 (08-3-4)
Exterior Body Panels
- Aluminum Panel Corrosion (17-0062)
- Luggage Compartment Lid Solenoid Stuck Open (10-5-9)
Exterior Lights
- Un-Commanded Perimeter Lighting (08-9-2)
Frames, Subframes & Crossmembers
- Aluminum Panel Corrosion (17-0062)
Front Suspension
- Grunt/Creak/Squeak/Chirp Noise From The Lower Control Arm Bushing Over Bumps - Built On Or Before 8/3/2009 (09-24-16)
Fuel System
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-7-4)
Gauges & Instrument Panels
- A-Pillar Rattle Noise (08-24-10)
- Rattle/Buzz/Vibration - Transmission Cross-Member Exhaust Mount - Built Before 12/3/2007 (08-3-4)
Headlights
- Un-Commanded Perimeter Lighting (08-9-2)
Ignition System
- 4.0L - Buzz Noise - Upper Engine (10-5-7)
- Spark Plug Removal Instructions - 4.6L 3V/5.4L 3V/6.8L 3V (08-7-6)
Interior/Exterior Trim
- Various Vehicles - Running Board Concern Analysis (G0000073)
- Convertible Top-Headliner Pulled Out From Number 1 Bow (13-8-12)
- Water Leak - Front Floor Area (08-26-7)
- A-Pillar Rattle Noise (08-24-10)
- Rattle/Buzz/Vibration - Transmission Cross-Member Exhaust Mount - Built Before 12/3/2007 (08-3-4)
- Buzz/Rattle From Door Panel When Operating Audio System - Vehicles Built Before 8/2/2007 (07-17-6)
Manual Trans
- 4.6L With Tr3650 Manual Transmission - Clash Or Raspy Feel - Shifting Into 2ND And/Or 3RD Gear (09-9-6)
- 4.6L Manual Transmission - Separator Plate Buzz - Built Before 4/5/2009 (09-18-16)
- Manual Transmission Shifter Boot Noise - Built Before 12/6/2007 (08-2-4)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-7-4)
- 4.0L - Buzz Noise - Upper Engine (10-5-7)
- 4.6L Manual Transmission - Separator Plate Buzz - Built Before 4/5/2009 (09-18-16)
- Cold Start FEAD Hoot - Whistle Noise (09-9-7)
- Spark Plug Removal Instructions - 4.6L 3V/5.4L 3V/6.8L 3V (08-7-6)
Mirrors
- Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
- Ford Interior Mirror Job Aid (G0000001)
Paint & Coatings
- Aluminum Panel Corrosion (17-0062)
Passive Restraints
- Rattle/Buzz/Vibration - Transmission Cross-Member Exhaust Mount - Built Before 12/3/2007 (08-3-4)
Restraints Control Systems
- Air Bag Warning Lamp On - DTC B2295 In Restraints Control Module (10-23-8)
Seats
- Rattle/Buzz/Vibration - Transmission Cross-Member Exhaust Mount - Built Before 12/3/2007 (08-3-4)
Starter
- Discharged Batteries - Vehicles In Storage/Limited Usage (07-5-13)
Steering Column
- Rattle/Buzz/Vibration - Transmission Cross-Member Exhaust Mount - Built Before 12/3/2007 (08-3-4)
Sun Roof/T-Top/Convertible Top
- Convertible Top-Headliner Pulled Out From Number 1 Bow (13-8-12)
- Convertible System Concerns (07-17-8)
System
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-7-4)
- 4.0L - Buzz Noise - Upper Engine (10-5-7)
- Spark Plug Removal Instructions - 4.6L 3V/5.4L 3V/6.8L 3V (08-7-6)
- Discharged Batteries - Vehicles In Storage/Limited Usage (07-5-13)
Transmission Control Systems
- 5R55S/5R55N/5R55W Transmissions - Shift Concerns, Loss Of 2ND, 3RD And 5TH Gear, Incorrect Ratio DTC'S - Procedure To Inspect And Repair Servo Pin Bore Wear (09-12-12)
Window Motors & Regulators
- Water Leak - Front Floor Area (08-26-7)
- Power Window Feature - Bounce Back Diagnostics (08-21-7)
- Convertible - Rear Quarter Glass - Torn/Separating Quarter Glass Division Bar (08-17-3)