Technical Service Bulletins

Accessories Control Systems
- Various Vehicles - Module Reprogramming (G0000150)
- Sync - Phone/USB Connectivity - Voice Recognition And Traffic - Directions And Information Messaging (12-9-6)
- Sync - Call Sound Quality/Background Noise Issues And/Or Voice Recognition Difficulties While Driving (10-8-4)
- Sync Software Update - Various Issues (09-7-9)
- Sync Functions Inoperative, DTC U3000-41,U0485, Or U0100, And/Or Battery Draw With Accessory Protocol Interface Module Connected (09-14-3)
- Sync With 911 Assist And Vehicle Health Report (VHR) Dealer Upgrade Software (09-5-4)
- Sync Software Programming Service Tips (08-21-2)
Accessory Drive Belts
- Cold Start Front End Accessory Drive (FEAD) Whine / Whistle Noise (09-1-1)
Anti-Theft Systems
- Passive Anti Theft System(Pats) Key Programming (G0000156)
- Intermittent No Crank/No Start - DTC P1260 - Transmission Shift Flare On Initial 2-3 Shift After A Re-Start (10-21-8)
- Rear Door Lock Inoperative - Built On Or Before 10/15/2009 (09-23-4)
Automatic Trans
- 4F27E Transmission - Symptoms Of Direct Clutch Failure - 2-3 Or 2-4 Upshift Flare - Lack Of 3RD And/Or 4TH Gear - DTCS P0733, P0734, P0751 And/Or P0972 (14-0002)
- Whine/Howl Or Groan Type Noise With Vehicle In Motion - Intermediate Shaft Bearing (13-4-24)
- Intermittent No Crank/No Start - DTC P1260 - Transmission Shift Flare On Initial 2-3 Shift After A Re-Start (10-21-8)
- Difficult To Remove Ignition Key From Ignition Cylinder - Built Before 5/31/2009 (09-12-14)
Auxiliary Emission Control Systems
- Rolling Idle When Stopped - No Diagnostic Trouble Code (DTC) (13-4-1)
- Rolling Idle And/Or Engine Surge Without Diagnostic Trouble Codes (DTC) Present (11-8-22)
- Intermittent No Crank/No Start - DTC P1260 - Transmission Shift Flare On Initial 2-3 Shift After A Re-Start (10-21-8)
- Malfunction Indicator Lamp (Mil) On With Diagnostic Trouble Codes (DTC) P1702, P0111, Or P0456 (09-8-4)
- Mil On With DTC P060A, P061B, P0600, P2107 And/Or U0300 (09-13-6)
- Malfunction Indicator Lamp (Mil) On With Diagnostic Trouble Code (DTC) - P0456 (09-3-5)
Axle Shafts
- Whine/Howl Or Groan Type Noise With Vehicle In Motion - Intermediate Shaft Bearing (13-4-24)
Body Interior
- Various Vehicles - Module Reprogramming (G0000150)
- Sync - Phone/USB Connectivity - Voice Recognition And Traffic - Directions And Information Messaging (12-9-6)
- Sync - Call Sound Quality/Background Noise Issues And/Or Voice Recognition Difficulties While Driving (10-8-4)
- Sync Software Update - Various Issues (09-7-9)
- Sync Functions Inoperative, DTC U3000-41,U0485, Or U0100, And/Or Battery Draw With Accessory Protocol Interface Module Connected (09-14-3)
- Sync With 911 Assist And Vehicle Health Report (VHR) Dealer Upgrade Software (09-5-4)
- Sync Software Programming Service Tips (08-21-2)
Charging Systems
- Stuck High Voltage Charge Cord Information Sheet (G0000127)
Clutch
- Squeak Noise When Applying And/Or Releasing Clutch Pedal (09-22-3)
Communication Devices
- Sync - Phone/USB Connectivity - Voice Recognition And Traffic - Directions And Information Messaging (12-9-6)
- Sync - Call Sound Quality/Background Noise Issues And/Or Voice Recognition Difficulties While Driving (10-8-4)
- Sync System Defaults To Or Stays In Privacy Mode, Multiple Vehicle Lines (10-2-8)
- Sync Software Update - Various Issues (09-7-9)
- Sync Functions Inoperative, DTC U3000-41,U0485, Or U0100, And/Or Battery Draw With Accessory Protocol Interface Module Connected (09-14-3)
- Call Sound Quality/Background Noise Issues And/Or Voice Recognition Difficulties While Driving (09-13-5)
- Sync With 911 Assist And Vehicle Health Report (VHR) Dealer Upgrade Software (09-5-4)
Cooling System (Mechanical)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
Differentials & Drive Axles
- Whine/Howl Or Groan Type Noise With Vehicle In Motion - Intermediate Shaft Bearing (13-4-24)
Engine Control Systems
- Various Vehicles - Module Reprogramming (G0000150)
- Diagnostic Trouble Code (DTC) P1635 (19-7008)
- Rolling Idle When Stopped - No Diagnostic Trouble Code (DTC) (13-4-1)
- Rolling Idle And/Or Engine Surge Without Diagnostic Trouble Codes (DTC) Present (11-8-22)
- Intermittent No Crank/No Start - DTC P1260 - Transmission Shift Flare On Initial 2-3 Shift After A Re-Start (10-21-8)
- Ticking Noise At Idle - Fuel Rail - Built On Or Before 12/23/2009 (10-9-3)
- Malfunction Indicator Lamp (Mil) On With Diagnostic Trouble Codes (DTC) P1702, P0111, Or P0456 (09-8-4)
- Mil On With DTC P060A, P061B, P0600, P2107 And/Or U0300 (09-13-6)
- Malfunction Indicator Lamp (Mil) On With Diagnostic Trouble Code (DTC) - P0456 (09-3-5)
Entertainment Systems
- Fm Radio Reception/Sound Quality Changes While Driving Or Satellite Radio Signal Bleed Through When Using Audio System In Aux Mode (10-13-3)
- Sync Software Update - Various Issues (09-7-9)
Exhaust
- Various Vehicles - Catalytic Converter Concern Analysis (22-7009)
Exterior Body Panels
- Luggage Compartment Lid Solenoid Stuck Open (10-5-9)
Front Suspension
- Click/Pop Noise From Front End While Turning Or Going Over Bumps (10-8-5)
Fuel System
- Ticking Noise At Idle - Fuel Rail - Built On Or Before 12/23/2009 (10-9-3)
HVAC Control Systems
- White Flakes Or Powder Coming From A/C Vents (11-9-6)
Ignition Switch/Steering Lock
- Ignition Key Binding In Ignition Cylinder When Turning To Start Position Only - Built On Or Before 8/3/2009 (09-19-15)
- Difficult To Remove Ignition Key From Ignition Cylinder - Built Before 5/31/2009 (09-12-14)
Interior/Exterior Trim
- Various Vehicles - Running Board Concern Analysis (G0000073)
- Carpet Pulled Out From Under The Door Scuff Trim Panels (10-15-8)
- Front Center Console Lid Contacting Driver Seat Back (10-2-12)
- Front Seat Cushion Trim Cover Detached (09-15-9)
Manual Steering
- Power Steering - Leak / Noisy (08-19-9)
Manual Trans
- Whine/Howl Or Groan Type Noise With Vehicle In Motion - Intermediate Shaft Bearing (13-4-24)
Mechanical
- 2001-2019 Various Vehicles - 2.0L, 2.3L, And 2.5L 4-Cylinder Engine - Rear MAINSEAL Kit Tool Usage (SSM 47632)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Engine Vibration At Idle (11-3-24)
- Ticking Noise At Idle - Fuel Rail - Built On Or Before 12/23/2009 (10-9-3)
- Cold Start Front End Accessory Drive (FEAD) Whine / Whistle Noise (09-1-1)
Mechanical - Hydraulic
- Rear Brake Drag Due To Parking Brake Adjustment (09-8-2)
Mirrors
- Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
- Ford Interior Mirror Job Aid (G0000001)
Paint & Coatings
- Paint Degradation/Road Abrasion (10-15-6)
Parking Brake System
- Squeak/Creak Noise While Driving Over Bumps - Park Brake Cable Contact With Routing Eyelets (10-24-6)
- Squeak/Creak Noise While Driving Over Bumps - Park Brake Cable Contact With Routing Eyelets (10-1-4)
- Rear Brake Drag Due To Parking Brake Adjustment (09-8-2)
- Parking Brake Lever Button Sticking / Binding (09-2-2)
Passive Restraints
- Front Center Console Lid Contacting Driver Seat Back (10-2-12)
- Front Seat Cushion Trim Cover Detached (09-15-9)
Procedures
- 2001-2019 Various Vehicles - 2.0L, 2.3L, And 2.5L 4-Cylinder Engine - Rear MAINSEAL Kit Tool Usage (SSM 47632)
Seats
- Front Center Console Lid Contacting Driver Seat Back (10-2-12)
- Front Seat Cushion Trim Cover Detached (09-15-9)
Starter
- Sync Functions Inoperative, DTC U3000-41,U0485, Or U0100, And/Or Battery Draw With Accessory Protocol Interface Module Connected (09-14-3)
Steering Column
- Leather Wrapped Steering Wheel - Leather Coming Loose (09-24-6)
Steering Control Systems
- Power Steering - Leak / Noisy (08-19-9)
Steering Gear
- Power Steering - Leak / Noisy (08-19-9)
Suspension Control Systems
- Click/Pop Noise From Front End While Turning Or Going Over Bumps (10-8-5)
System
- Rolling Idle When Stopped - No Diagnostic Trouble Code (DTC) (13-4-1)
- Rolling Idle And/Or Engine Surge Without Diagnostic Trouble Codes (DTC) Present (11-8-22)
- Intermittent No Crank/No Start - DTC P1260 - Transmission Shift Flare On Initial 2-3 Shift After A Re-Start (10-21-8)
- Ticking Noise At Idle - Fuel Rail - Built On Or Before 12/23/2009 (10-9-3)
- Malfunction Indicator Lamp (Mil) On With Diagnostic Trouble Codes (DTC) P1702, P0111, Or P0456 (09-8-4)
- Mil On With DTC P060A, P061B, P0600, P2107 And/Or U0300 (09-13-6)
- Malfunction Indicator Lamp (Mil) On With Diagnostic Trouble Code (DTC) - P0456 (09-3-5)
Transmission Control Systems
- 4F27E Transmission - Symptoms Of Direct Clutch Failure - 2-3 Or 2-4 Upshift Flare - Lack Of 3RD And/Or 4TH Gear - DTCS P0733, P0734, P0751 And/Or P0972 (14-0002)
- Intermittent No Crank/No Start - DTC P1260 - Transmission Shift Flare On Initial 2-3 Shift After A Re-Start (10-21-8)
- Difficult To Remove Ignition Key From Ignition Cylinder - Built Before 5/31/2009 (09-12-14)
Window Motors & Regulators
- Door Glass - Slow Close/Binds When Going Up/WINDNOISE Or Top Window Run Folded/Loose (09-22-9)