Technical Service Bulletins

Accessories Control Systems
- Various Vehicles - Module Reprogramming (G0000150)
- Audio Control Module (ACM) Displays Satellite Fault With Diagnostic Trouble Code (DTC) B1342 In Satellite Digital Audio Receiver System (SDARS) Module (11-3-3)
- Sync Software Programming Service Tips (08-21-2)
Accessory Drive Belts
- 4.0L Engine Belt Squeal Or Chirp Noise On Cold Startup (09-7-7)
Air Bag, SRS
- Air Bag Warning Lamp On - DTC B2295 In Restraints Control Module (10-23-8)
Anti-Theft Systems
- Passive Anti Theft System(Pats) Key Programming (G0000156)
Automatic Trans
- 5R55S/5R55N/5R55W Transmissions - Shift Concerns, Loss Of 2ND, 3RD And 5TH Gear, Incorrect Ratio DTC'S - Procedure To Inspect And Repair Servo Pin Bore Wear (09-12-12)
- Shudder On ACCEL - Possible Wrong Trans CROSSMEMBER Assembly Installed (Excludes Gt 500) (08-23-4)
Auxiliary Emission Control Systems
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-7-4)
- 4.0L / 5.4L / 6.8L - Calibration Update - Various Issues (11-1-3)
Axle Shafts
- Axle Whine (09-20-4)
Body Interior
- Various Vehicles - Module Reprogramming (G0000150)
- Audio Control Module (ACM) Displays Satellite Fault With Diagnostic Trouble Code (DTC) B1342 In Satellite Digital Audio Receiver System (SDARS) Module (11-3-3)
- Sync Software Programming Service Tips (08-21-2)
Charging Systems
- Stuck High Voltage Charge Cord Information Sheet (G0000127)
- 4.0L Engine Belt Squeal Or Chirp Noise On Cold Startup (09-7-7)
Communication Devices
- Sync System Defaults To Or Stays In Privacy Mode, Multiple Vehicle Lines (10-2-8)
Cooling System (Mechanical)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
Differentials & Drive Axles
- Rear Drive Axle Vent - Oil Leak (12-5-8)
- Axle Whine (09-20-4)
Engine Control Systems
- Various Vehicles - Module Reprogramming (G0000150)
- Diagnostic Trouble Code (DTC) P1635 (19-7008)
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-7-4)
- 4.0L / 5.4L / 6.8L - Calibration Update - Various Issues (11-1-3)
- 4.0L Mil On With DTC'S P030X, P0300, P0316, P0172, P0175 Or Misfire/Runs Rough - Engines Built 5/4/2008-5/14/2008 (10-7-1)
Entertainment Systems
- Audio Control Module (ACM) Displays Satellite Fault With Diagnostic Trouble Code (DTC) B1342 In Satellite Digital Audio Receiver System (SDARS) Module (11-3-3)
- Speaker Pop And/Or Radio Inoperative/Blank/Locked Up (09-20-10)
- Door Mounted Subwoofer - Static, Crackle, Pop Or Distorted Sound - Built Before 7/7/2008 (08-20-2)
Exhaust
- Various Vehicles - Catalytic Converter Concern Analysis (22-7009)
- 4.0L / 5.4L / 6.8L - Calibration Update - Various Issues (11-1-3)
Exterior Body Panels
- Aluminum Panel Corrosion (17-0062)
- Luggage Compartment Lid Solenoid Stuck Open (10-5-9)
Frames, Subframes & Crossmembers
- Aluminum Panel Corrosion (17-0062)
Front Suspension
- Grunt/Creak/Squeak/Chirp Noise From The Lower Control Arm Bushing Over Bumps - Built On Or Before 8/3/2009 (09-24-16)
Fuel System
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-7-4)
- 4.0L Mil On With DTC'S P030X, P0300, P0316, P0172, P0175 Or Misfire/Runs Rough - Engines Built 5/4/2008-5/14/2008 (10-7-1)
Gauges & Instrument Panels
- A-Pillar Rattle Noise (08-24-10)
HVAC Control Systems
- 2008-2019 Various Ford/LINCOLN/Mercury Vehicles - Inoperative Heating, Ventilation, And Air Conditioning (HVAC) Blower Motor (SSM 47797)
Ignition System
- 4.0L - Buzz Noise - Upper Engine (10-5-7)
Interior/Exterior Trim
- Various Vehicles - Running Board Concern Analysis (G0000073)
- Convertible Top-Headliner Pulled Out From Number 1 Bow (13-8-12)
- Water Leak - Front Floor Area (08-26-7)
- A-Pillar Rattle Noise (08-24-10)
Manual Trans
- 4.6L Manual Transmission - Separator Plate Buzz - Built Before 4/5/2009 (09-18-16)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-7-4)
- 4.0L - Buzz Noise - Upper Engine (10-5-7)
- 4.6L Manual Transmission - Separator Plate Buzz - Built Before 4/5/2009 (09-18-16)
- 4.0L Engine Belt Squeal Or Chirp Noise On Cold Startup (09-7-7)
Mirrors
- Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
- Ford Interior Mirror Job Aid (G0000001)
Paint & Coatings
- Aluminum Panel Corrosion (17-0062)
Restraints Control Systems
- Air Bag Warning Lamp On - DTC B2295 In Restraints Control Module (10-23-8)
Sun Roof/T-Top/Convertible Top
- Convertible Top-Headliner Pulled Out From Number 1 Bow (13-8-12)
System
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-7-4)
- 4.0L / 5.4L / 6.8L - Calibration Update - Various Issues (11-1-3)
- 4.0L Mil On With DTC'S P030X, P0300, P0316, P0172, P0175 Or Misfire/Runs Rough - Engines Built 5/4/2008-5/14/2008 (10-7-1)
- 4.0L - Buzz Noise - Upper Engine (10-5-7)
Transmission Control Systems
- 5R55S/5R55N/5R55W Transmissions - Shift Concerns, Loss Of 2ND, 3RD And 5TH Gear, Incorrect Ratio DTC'S - Procedure To Inspect And Repair Servo Pin Bore Wear (09-12-12)
Window Motors & Regulators
- Water Leak - Front Floor Area (08-26-7)
- Power Window Feature - Bounce Back Diagnostics (08-21-7)
- Convertible - Rear Quarter Glass - Torn/Separating Quarter Glass Division Bar (08-17-3)