Technical Service Bulletins

A/C Compressor
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Ac Blows Warm Or Poor Performance (PIT5099H)
- Ambient Temperature Display Not Reading Outside Temperature At Times Or A/C Compressor Inoperative Due To Low Ambient Temperature (PIT4211D)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
Accessories & Equipment
- Concerns Or Questions Regarding Installation Of Dealer Installed Accessories (PIT3099U)
- General Motors Dealership Critical Equipment Requirements And Recommendations (05-00-89-029F)
- Information On Module Harvesting (22-NA-205)
- Requesting A New Key Code For Customer With Lost Or Stolen Keys (12-00-89-002E)
- Information - Non-Gm Parts And Accessories (Aftermarket) (04-06-04-054D)
- New Labor Operation Codes for Dealer-Installed GM Accessories Replaced During Warranty Coverage Period (02-20-89-014)
Accessories Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Communication With ONSTAR Module After CANADIAN Cellular Upgrade (15-08-73-001A)
- Diagnostic Tip - Driver Information Center (DIC) Switch Buttons Are Inoperative (PIT4534G)
- Diagnostic Tips For I/M Flags Resetting After Ignition Cycled (PIP5627)
- Diagnostic Tip: Unable To Connect To ONSTAR Or Connects Failed To Voice (PIT5389F)
- Requirements For ONSTAR Over The Air Programming And Updates (PIC6107A)
- Power Lift-Gate Inoperative With Key Off (PIT4429F)
- Information On How To Prevent Inadvertent Vehicle Starting From Key Fob Or ONSTAR Mobile Application (17-NA-244)
- Red Led, No WIFI Operation, And/Or Limited ONSTAR® Module Functionality After ONSTAR Module Replacement For Another Condition (17-NA-215)
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- ONSTAR- Unwanted Or Phantom Phone Calls (PIC3278G)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Ambient Temperature Display Not Reading Outside Temperature At Times Or A/C Compressor Inoperative Due To Low Ambient Temperature (PIT4211D)
- Caller Id Unavailable After ONSTAR Upgrade (PIT5464)
- Unable To Receive Incoming ONSTAR Or HFC (Hands Free Calling) Calls (PIC6101)
- Diagnostic Tip: Unable To Connect Or Use Hands Free Calling Or No Data On The Call (Failed To Voice) (PIC4310L)
- Fuel Gauge Fluctuation In Park Or Neutral (PIT3046G)
- Diagnostic Tip: CANADIAN ONSTAR Subscriber Unable To Receive Turn-By-Turn Directions While Traveling In The United States (PIT5264C)
- Vehicle Software Enhancements (13-00-89-003)
- Passenger Presence System (PPS) May Command Seat Belt Reminder Chime And Passenger Airbag Indicator On When Electronic Devices Or Conductive Objects Are Placed On Front Passenger Seat, DTCS 5045 Or B0074 0F May Set In PPS Module (08-09-41-007I)
- Rear Window Defogger - Broken Heating Grid Detection Method (04-08-48-001D)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Power Liftgate Diagnosis and Repair Information (08-08-66-005B)
- Required Return Criteria of Complete Electrical Center (EC) and Body Control Module (BCM) with Integrated Electrical Center to Warranty Parts Center (WPC) (05-08-45-002E)
- Doors Unlock Automatically When Vehicle is Shifted into Park (Reprogram BCM) (07-08-64-014A)
- Diagnostic Tips/Recommendations on GM Accessory 2-Way Remote Start Transmitter When Transmitter Battery is Weak or Dead (09-08-52-004A)
- GM Accessories: 2-Way Advanced Remote Start Systems Part Information (09-00-89-025A)
- GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
- Power Liftgate "Liftgate Open" or "Rear Access Open" DIC Message Turn Off Delay, Liftgate Reverses While Closing (Reprogram Power Liftgate Module) (09-08-64-024)
Accessory Drive Belts
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
Air Bag, SRS
- Diagnostic Information For Supplemental Inflatable Restraint (Sir) System, Intermittent Air Bag Indicator/Lamp Illuminated With DTC(S) B0012, B0013, B0015, B0016, B0019, B0020, B0022, B0023, B0026, B0033, B0040, B0042 Or B0044 Set (Inspect And Replace Connector Position Assurance (CPA) Retainer) (08-09-41-002H)
- Information Regarding Servicing Components Located Near Sir Components (16-NA-055)
- Passenger Presence System (PPS) May Command Seat Belt Reminder Chime And Passenger Airbag Indicator On When Electronic Devices Or Conductive Objects Are Placed On Front Passenger Seat, DTCS 5045 Or B0074 0F May Set In PPS Module (08-09-41-007I)
- Airbag Light On, DTC B0071 and B0081 Set (Diagnose and Replace Right Front Seatbelt Buckle, If Necessary) (07-09-41-010D)
Anti-Lock Brakes
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- EBCM Wheel Speed Sensor Diagnostic Aid For Abs Message - Click Or Ratchet Noise - Service Traction Message - Service STABILITRAK Message - Service Steering Message (PIC5428G)
- Traction Control Light Flashes Under Hard Acceleration At Higher Road Speeds (16-NA-223)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Intermittent Abs Codes, No Communications, No Start And/Or Various Electrical Concerns (PIT4946A)
- Unable To Communicate With The EBCM DTC U0121 (PIT4056H)
- GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
Anti-Theft Systems
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (U.S. Only) (10-00-89-009F)
- Diagnostic Tip - Security Light On Intermittently / No Crank/No Start Or Start Stall / Keyless Access Vehicles May Display No Remote/Fob Detected / Poor Or No RKE Range / Service TPM DTC B3055, B3060, B3935, C0750, C0755, C0760, C0765, C0775 (PIC5650L)
- Requesting A New Key Code For Customer With Lost Or Stolen Keys (12-00-89-002E)
- Information On How To Prevent Inadvertent Vehicle Starting From Key Fob Or ONSTAR Mobile Application (17-NA-244)
- Information On Poor, Limited, Reduced Remote Keyless Entry (RKE) Or Remote Vehicle Start (RVS) Range (PI1018A)
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (CANADA Only) (10-00-89-010C)
- Information On Body Control Module (BCM) Grounds (07-08-47-004E)
- EI08028 - Intermittent, Inoperative Remote Keyless Entry (RKE) (Reprogram Key Fobs) (08-08-52-001G)
- Remote Keyless Entry Transmitter (RKE) Button Inoperative or Will Not Reprogram to Vehicle (10-08-52-003)
- Doors Unlock Automatically When Vehicle is Shifted into Park (Reprogram BCM) (07-08-64-014A)
- EI08397 - Remote Keyless Entry (RKE) Transmitter Inoperative (Engineering Information Closed) (08-08-52-005C)
- Key Code Information (99-00-89-011E)
- Information on Reprogramming Replacement Door Modules/Switches (08-08-64-013)
- Limited or Poor Transmitter Range When Using Remote Keyless Entry (RKE) and/or Remote Vehicle Start (RVS) (Add Shielding Foil Tape to Remote Control Door Lock Receiver Wire Harness) (08-08-52-003C)
Automatic Trans
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Ethylene Glycol In Transmission Fluid (08-07-30-035I)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Driveline Clunk Noise (99-04-20-002O)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Information On Automatic Transmission Oil Cooler Flush And Flow Test (17-NA-066)
- Diagnostic Tip On Avoiding Torque Converter Or Crankshaft Damage While Diagnosing Noise Concerns (PIP5640A)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- PQC Assembly Replacement Process - For Dealers Required To Contact PQC Prior To Replacing An Assembly (U.S. And CANADA Only) (99-07-30-020)
- Information On The Reuse Of Fasteners And The Proper Reading Of Torque Specifications (15-NA-069)
- Automatic Transmission Oil Cooler Flow Test Essential Tool J-45096 TRANSFLOW® (03-07-30-002B)
- Dealer Reimbursement Procedures For CAC Tier 1 And Tier 2 Empowerment Tools: Diagnostic Fee, Short Term Rental, And Up-Front Towing (U.S. Only) (15-00-89-003)
- Vibration Analysis Worksheet (03-00-91-001I)
- No Reverse, 3RD Or 5TH, Check Engine Light Illuminated, DTC P0776 (Replace 3-5 Reverse Clutch Plate (Waved) (09-07-30-012F)
- Console Mounted Shifter Control Binding Or Noisy (Clean Transmission Control Assembly) (09-07-30-002B)
- Fluid Leak At Transfer Case Left Hand Weep Hole Or Between Transfer Case To Transmission Interface (Replace Transfer Case Input Shaft Seal-Left Or Transfer Case O-Ring Seal) (09-04-21-004B)
- Warranty Administration- Change in Automatic Transmission Add Condition Documentation and Claim Submission (09-07-30-018A)
- Current Model Year Goodwrench Transmission Replacement Assembly Program (00-07-30-009D)
- GM Training - June 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-026)
- Transmission Fluid Leak Due to Transmission Converter Housing Seal (Inspect with Dye and Black Light, Replace Torque Converter Fluid Seal) (09-07-30-006)
- Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032E)
- Grinding and/or Growling Noise in Park on Incline (99-07-30-030F)
Auxiliary Emission Control Systems
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
Axle Shafts
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
Battery Management Systems
- Information On The Use Of Non Gm Approved Battery Chargers And Booster Packs (15-NA-030)
Body Electrical
- J-35616-64B Or El-35616-58 Terminal Test Probe Information/Repair (PIT5074R)
- Information For Electrical Ground Repair - Use New Replacement Fasteners With Conductive Finish (10-08-45-001F)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Information On Coax Repair Kit Availability (17-NA-346)
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- Low Beam Headlamp Bulb Diagnosis/Replacement (Inspect Bulb And Connector) (10-08-42-001E)
- Gm Wiring Repair Strategy Information (13-00-89-008A)
- SES Light And Misfire With Injector Codes (PIP4924D)
- Information On Body Control Module (BCM) Grounds (07-08-47-004E)
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
Body Interior
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Diagnostic Tip - Security Light On Intermittently / No Crank/No Start Or Start Stall / Keyless Access Vehicles May Display No Remote/Fob Detected / Poor Or No RKE Range / Service TPM DTC B3055, B3060, B3935, C0750, C0755, C0760, C0765, C0775 (PIC5650L)
- Diagnostic Tip - Driver Information Center (DIC) Switch Buttons Are Inoperative (PIT4534G)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Ambient Temperature Display Not Reading Outside Temperature At Times Or A/C Compressor Inoperative Due To Low Ambient Temperature (PIT4211D)
- Information On Body Control Module (BCM) Grounds (07-08-47-004E)
- Passenger Presence System (PPS) May Command Seat Belt Reminder Chime And Passenger Airbag Indicator On When Electronic Devices Or Conductive Objects Are Placed On Front Passenger Seat, DTCS 5045 Or B0074 0F May Set In PPS Module (08-09-41-007I)
- Rear Window Defogger - Broken Heating Grid Detection Method (04-08-48-001D)
- Unable to Reprogram Body Control Module (BCM), BCM Reprogramming Did Not Complete - Revised Reprogramming Instructions (09-08-47-001A)
- Required Return Criteria of Complete Electrical Center (EC) and Body Control Module (BCM) with Integrated Electrical Center to Warranty Parts Center (WPC) (05-08-45-002E)
- OnStar® Labor Operation Codes (05-08-46-005C)
Brakes Control Systems
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- EBCM Wheel Speed Sensor Diagnostic Aid For Abs Message - Click Or Ratchet Noise - Service Traction Message - Service STABILITRAK Message - Service Steering Message (PIC5428G)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Intermittent Abs Codes, No Communications, No Start And/Or Various Electrical Concerns (PIT4946A)
- Unable To Communicate With The EBCM DTC U0121 (PIT4056H)
- Vehicle Software Enhancements (13-00-89-003)
- GM Training - April 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-020)
Charging Systems
- Gm Wiring Repair Strategy Information (13-00-89-008A)
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
Collision/Avoidance
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Park Assist System Inoperative, Service Park Assist Message Displayed on Driver Information Center (DIC), DTC B1E3A and/or B0954, B0955, B0956, B0957, B0958, B0959, B0960, B0961 Set (Replace Appropriate Object Sensor or Repair Harness) (08-08-127-001B)
- EI09084 - Rear Parking Assist System Inoperative (Engineering Information Closed) (09-08-127-001B)
Communication Devices
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Information On Communication With ONSTAR Module After CANADIAN Cellular Upgrade (15-08-73-001A)
- Diagnostic Tip: Unable To Connect To ONSTAR Or Connects Failed To Voice (PIT5389F)
- Requirements For ONSTAR Over The Air Programming And Updates (PIC6107A)
- Diagnostic Tips: XM Audio Traffic And Travel Link Availability And Operation (PIT5353C)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- ONSTAR Will Not Power Up (PIC5491K)
- Questionnaire For BLUETOOTH Related Concerns (PIC5932B)
- Red Led, No WIFI Operation, And/Or Limited ONSTAR® Module Functionality After ONSTAR Module Replacement For Another Condition (17-NA-215)
- Normal Characteristic - ONSTAR Power Consumption (PIC4935F)
- Diagnostic Tip - ONSTAR Turn By Turn /TBT Feature Inoperative (PIC4801H)
- ONSTAR- Unwanted Or Phantom Phone Calls (PIC3278G)
- Programming And Activation Of Replacement ONSTAR Modules (VCIM) (PIC5588C)
- ONSTAR BLUETOOTH Option Availability (PIT4733K)
- ONSTAR BLUETOOTH Pairing Limit And Operational Characteristics (PIC5759B)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Off Route Message During ONSTAR Turn By Turn Operation (PIC5374D)
- Radio Does Not Mute Enough When ONSTAR® Turn-By Turn Navigation Directions Are Announced (Increase Volume Setting Or Request Soft Mute Feature Change Through ONSTAR® Customer Service) (10-08-46-001C)
- No Connect With Disabled Vehicle Or Dropped Calls With 1234567890 Min (PIC5050A)
- Information On Coax Repair Kit Availability (PI0572C)
- 118 Error When Attempting To Configure ONSTAR, Use TBT, Or Other Data Services After 15-08-44-001 Upgrade (PIT5484A)
- Behavior Of Non-Upgraded ONSTAR® Equipped Vehicles Operating In CANADA After Decommissioning Of 2G CDMA Cellular Networks (16-NA-025)
- ONSTAR® Voice Fallback Number Update (15-NA-079)
- Diagnostic Tip: BLUETOOTH Connectivity Issues After Software Update (PIT5468)
- Caller Id Unavailable After ONSTAR Upgrade (PIT5464)
- Turn By Turn Directions Not Displayed After CANADA Upgrade (PIT5465)
- Unable To Receive Incoming ONSTAR Or HFC (Hands Free Calling) Calls (PIC6101)
- Diagnostic Tip: Unable To Connect Or Use Hands Free Calling Or No Data On The Call (Failed To Voice) (PIC4310L)
- Diagnostic Tip: CANADIAN ONSTAR Subscriber Unable To Receive Turn-By-Turn Directions While Traveling In The United States (PIT5264C)
- UPFITTER Bulletin - Info - Radio Telephone/Mobile Radio (Transceiver) Installation And Troubleshooting Guidelines (UI 119)
- Information On Requests To Add ONSTAR BLUETOOTH Option (PIT4864F)
- ONSTAR Voice Recognition Operation Issues (PIC3011H)
- Information On Aftermarket Device Interference With ONSTAR® Diagnostic Services (08-08-46-004A)
- OnStar® Phone Number Concerns (Phone Number Incorrect/Assigned to Another Vehicle/Phone) That Occur During Diagnosis of OnStar® System (05-08-46-004C)
- Buzz Noise During Call When Using Bluetooth® (Replace Microphone and Bezel) (10-08-44-003B)
- Availability of OnStar® for Hearing Impaired (06-08-46-005B)
- Generation 8 OnStar® Modules Inoperative and Possible Battery Discharge Condition (Replace OnStar® VCIM) (09-08-46-004A)
- Audio Whine Noise from Radio Speakers When Using OnStar® (Install Noise Suppression Filter) (07-08-46-002D)
- GM Training - July 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-031)
- Information Required Before Contacting GM Technical Assistance or When Ordering Replacement OnStar® VCIM (09-08-46-003)
- OnStar® Labor Operation Codes (05-08-46-005C)
- Information on Verifying OnStar® System Function During Pre-Delivery Inspection (PDI) (06-08-46-006B)
- Voice Recognition System Will Not Recognize "Bluetooth" Command (08-08-44-024)
Cooling Fan
- Clicking/Chirping Noise Coming From Engine Cooling Fan Area (Remove Witness Marks on Shroud) (09-06-02-002A)
Cooling System (Mechanical)
- Information On Flushing Oil Contamination From Cooling System (25-NA-052)
- Information On Ethylene Glycol In Transmission Fluid (08-07-30-035I)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Intermittent MIL/Check Engine Light On, DTC P0128 Set (Reprogram ECM) (09-06-02-004A)
Differentials & Drive Axles
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- RDM Axle Ratios For AWD Vehicles For Vibration Diagnostics When Using The PICO Scope (17-NA-281)
Driveshaft & Universal Joints
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- RDM Axle Ratios For AWD Vehicles For Vibration Diagnostics When Using The PICO Scope (17-NA-281)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
Electronic Steering
- Grease Or Sealant Visible On Electronic Power Steering Gear - Should Not Be Interpreted As Leak (16-NA-109)
- GM Training - April 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-020)
Electronic Suspension
- GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
Engine Control Systems
- SES Light With A P2097 Or P2099 (PIP4964F)
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Module Damage From Incorrect AFIT Usage On Vehicles With Direct Fuel Injection (PIP5569B)
- Information On Sag Or Hesitation On Acceleration (PIP4112S)
- Diagnostic Aids For Gas Engine Misfire/Rough Running With DTC P0300-P0308 And/Or DTC P050D (PIP5628G)
- Diagnostic Tip For Malfunction Indicator Lamp (Mil) Illuminated - DTC P0442 And/Or P0455 Set (21-NA-124)
- Diagnostic Tips For Direct Injected Engines Hard Start Cold (PIP5180C)
- Information Assistance For HFV6 Re-Manufactured Engine Drivability Diagnosis Immediately Following Installation (PIP5528F)
- Information On Black Smoke, Rough Idle And Minimal Misfires On Cold Start (PIP5189C)
- Diagnostic Tips For I/M Flags Resetting After Ignition Cycled (PIP5627)
- SES Light With Fuel Trim And Or Oxygen Sensor Codes (PIP4925B)
- Malfunction Indicator Lamp (Mil) Check Engine Light On, DTC P182E (17-NA-084)
- DTC P0016 P0017 P0018 P0019 P0008 P0009 (PIP3423P)
- Cold Start Misfire And/Or Rough Idle - DTC P0300 May Be Set (PIP4959F)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Information On Remanufactured Engine Misfire Diagnosis After Installation (17-NA-307)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Information On Rough Idle, Crank No Start, Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves, Malfunction Indicator Light (Mil) Illuminated - DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308 Set (16-NA-383)
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- Procedure To Take Snapshot Data With A Tech 2 And Upload Data To A Computer Using TIS Software (07-07-30-010D)
- Malfunction Indicator Lamp (Mil) - Check Engine Light On, DTC P182E (PI0269B)
- Malfunction Indicator Lamp On - Check Engine Light, DTCS P0011, P0014, P0021, P0024, P0341, P0346, P0366 Or P0391 Set (Check Camshaft End Play And Perform Action As Outlined) (08-06-01-011K)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Floor Wet Under Carpet/Engine Continues To Run With Key Off/Possible No Crank/No Start/Communication Loss/Various Electrical Concerns (Seal Seam) (08-08-57-003F)
- Diagnostic Tip - Vehicle Start And Stalls After Theft Deterrent Module Replacement (PIT5028B)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Deceleration Misfire On All Cylinders 1400 Rpm To 1800 Rpm Diagnosis (PIP5264)
- SES Light And Misfire With Injector Codes (PIP4924D)
- Vehicle Software Enhancements (13-00-89-003)
- Information - Non-Gm Parts And Accessories (Aftermarket) (04-06-04-054D)
- Identifying Aftermarket Engine and Transmission Calibrations 2.0L, 2.2L, 2.4L, 2.8L, 2.9L, 3.0L, 3.1L, 3.2L, 3.4L, 3.5L, 3.6L, 3.8L, 3.9L, 4.2L, 4.3L, 4.4L, 4.6L, 4.8L, 5.0L, 5.3L, 5.7L, 6.0L, 6.2L, 7.0L, 7.4L, 8.1L Gas Powered Engines Only and 6T40/45 (MH8), 6T70/75 (MH2, MH4, MH6, MY9), 6L50 (MYB) 6L80 (MYC) or 6L90 (MYD) Automatic Transmission (08-06-04-033D)
- Intermittent MIL/Check Engine Light On, DTC P0128 Set (Reprogram ECM) (09-06-02-004A)
- Hesitation During Light Throttle, Launch or Slow Speed Right Turns, Jerky or Harsh Shifts, Tachometer Movement During Deceleration (Reprogram ECM) (09-06-04-019)
Entertainment Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Diagnostic Tips: XM Audio Traffic And Travel Link Availability And Operation (PIT5353C)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- Questionnaire For BLUETOOTH Related Concerns (PIC5932B)
- Programming And Activation Of Replacement ONSTAR Modules (VCIM) (PIC5588C)
- Information On Inappropriate Warranty Claims Submitted For Damaged Radios And Instrument Panel Clusters (IPCS) (08-08-44-015H)
- Audio Muting When Listening To Some SIRIUS XM Channels Due To Interference In Some Geographic Locations (16-NA-356)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- XM Band Not Receiving All Channels (Preview Mode) (PIC5088F)
- XM Weather, Traffic, Or Travel Link Displaying Dashes, No Data Or Updating Message At Startup (PIC4707E)
- Radio Does Not Mute Enough When ONSTAR® Turn-By Turn Navigation Directions Are Announced (Increase Volume Setting Or Request Soft Mute Feature Change Through ONSTAR® Customer Service) (10-08-46-001C)
- Information On Coax Repair Kit Availability (PI0572C)
- Return Or Reimbursement Of Customer Owned CDS, DVDS Or Navigation Discs (05-08-44-024E)
- Diagnostic Tip: Gm Accessory Replacement Rear Video Screen Compatibility (PIT5406)
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Information On Eliminating Noise In Audio System When Using Portable Playback Device (06-08-44-015C)
- Accessory Pal (Personal Audio Link) Or PDIM (Personal Device Interface Module) Charging Of IPOD (12-08-44-001)
- Information On Noise Sources From Navigation Radio - Cd/DVD Disc Accessing Noise From Radio Fan, For Cooling, Disc Accessing Noise For Navigation Operation Or NAV Traffic Information (06-08-44-034D)
- Intermittent Black or Blank Screen, Radio Reset, Map Screen Stops Updating or Freezes, Voice Recognition Inoperative, Dead Battery (Update Navigation Radio Calibration and/or Software) (09-08-44-002G)
- Information on Availability of Service Parts for GM Accessory DVD Headrest Systems (09-08-44-016)
- Rear DVD Screen Off After Ignition Key is Cycled (Nav and Non-Nav Radios) Operating Instructions (06-08-44-035C)
- Audio Whine Noise from Radio Speakers When Using OnStar® (Install Noise Suppression Filter) (07-08-46-002D)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- GM Training - April 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-020)
- DVD Will Not Eject or Play - GM Accessory Headrest DVD System (PIT4768A)
Exhaust
- SES Light With A P2097 Or P2099 (PIP4964F)
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- Normal Characteristic - Rusty Or Corroded Appearance On Exhaust Component (PIT4351F)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Information on Sulfur Odor from Exhaust (09-06-05-001)
Exterior Body Panels
- Underbody Component Corrosion (PI0281L)
- PAINTLESS Dent Repair Process (99-08-51-001F)
- Hem Flange Rust Repair (02-08-98-002H)
- Power Lift-Gate Inoperative With Key Off (PIT4429F)
- Clunk Or Pop Type Noise From Power Lift-Gate Assembly At Full Open Position (PIT5246E)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Non-Approval Of "Clipping" (Sectioning Of Two Vehicles) For Collision Repair (07-08-98-001B)
- Spare Tire Jack Storage Compartment Door Difficult To Latch Or Falls Open Due To Inability To Latch (PI0731B)
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Information On Hem Flange Sealer For Corrosion Protection (06-08-51-005C)
- Information On Body Control Module (BCM) Grounds (07-08-47-004E)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- Power Liftgate Diagnosis and Repair Information (08-08-66-005B)
- Squeeze Type Resistance Spot Welding/Equipment (03-08-98-002B)
- Sunroof and General Water Leak Diagnostic Guide (07-08-57-002G)
- EI09073 - Front and Rear Door Adjustment and/or Alignment for Water Leak, Windnoise, Clunk, Creak, Rattle, Rumble, Squeak, Binds, Excessive Effort to Close, Poor Fit, Misaligned (Engineering Information Closed) (09-08-64-010A)
Exterior Lights
- Exterior Lighting Components "Tinted Or Smoked" By An Outside Vendor (15-08-42-001A)
- Low Beam Headlamp Bulb Diagnosis/Replacement (Inspect Bulb And Connector) (10-08-42-001E)
- Headlamp, Tail Lamp, License Lamp Or Fog/Driving Lamp Damage (02-08-42-001J)
- Information On Body Control Module (BCM) Grounds (07-08-47-004E)
- Sunroof and General Water Leak Diagnostic Guide (07-08-57-002G)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
Frames, Subframes & Crossmembers
- Underbody Component Corrosion (PI0281L)
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Non-approval of "Clipping" (Sectioning of Two Vehicles) For Collision Repair (07-08-98-001A)
Front Suspension
- Information On Diagnosis And Replacement Of Shock Absorber And Strut Due To Fluid Leak (72-05-12)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Squawk Or Creak Type Noise From Front Of Vehicle (09-03-08-004E)
- Vibration Analysis Worksheet (03-00-91-001I)
- Clunk Or Thump Type Noise From Front Suspension (12-03-08-001)
Fuel System
- Top Tier™ Detergent Gasoline And Top Tier™ Diesel Fuel Information And Licensed Brands (05-06-04-022Q)
- Information On Clicking/Ticking Sound/Noise Heard During Cold Start (07-06-04-025L)
- Rough Idle Crank No Start Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves (PIP5029H)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Usage Of E85 Fuel In Gm Vehicles (05-06-04-035E)
- Information On Clicking/Ticking Sound/Noise Heard During Cold Start (07-06-04-025K)
- Fuel Gauge Does Not Go To Empty Or A Slosh Noise When Braking Or Accelerating After An Accident (PIT4712E)
- SES Light And Misfire With Injector Codes (PIP4924D)
- Fuel And Oil Additives - Facts And Myths - Maximizing Gasoline Fuel Economy (05-00-89-072F)
- Top Tier Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047L)
- Gm Fuel System Treatment Plus, Fuel Sending Unit Corrosion And Fuel System Deposits (05-00-89-078C)
- General Motors' Position Regarding Use of E 15 in Model Year 2007 and Newer Vehicles (10-06-04-015)
Fuses & Circuit Breakers
- J-35616-64B Or El-35616-58 Terminal Test Probe Information/Repair (PIT5074R)
- Intermittent Abs Codes, No Communications, No Start And/Or Various Electrical Concerns (PIT4946A)
- Gm Wiring Repair Strategy Information (13-00-89-008A)
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
Gauges & Instrument Panels
- Interior Cleaning - Instrument Panel (IP), Hard Or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability (06-00-89-029W)
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Diagnostic Tip - Driver Information Center (DIC) Switch Buttons Are Inoperative (PIT4534G)
- Verifying Odometer Accuracy (PIC3100G)
- Diagnostic Tips For I/M Flags Resetting After Ignition Cycled (PIP5627)
- IPC Odometer Programming Method Quick Reference Guide (07-08-49-020O)
- Information On Inappropriate Warranty Claims Submitted For Damaged Radios And Instrument Panel Clusters (IPCS) (08-08-44-015H)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- White Film/Residue On Vehicle Interior, Door Trim Panels And/Or Instrument Panel (IP) (PI0799A)
- Intermittent Abs Codes, No Communications, No Start And/Or Various Electrical Concerns (PIT4946A)
- Fuel Gauge Fluctuation In Park Or Neutral (PIT3046G)
- Hazard Button, HVAC Or Driver Information Center (DIC) Control Buttons May Stick When Depressed (Remove Excess Material On Instrument Panel Accessory Trim Plate) (09-08-49-004A)
- Hesitation During Light Throttle, Launch or Slow Speed Right Turns, Jerky or Harsh Shifts, Tachometer Movement During Deceleration (Reprogram ECM) (09-06-04-019)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Information On Speedometer Accuracy (08-08-49-011B)
General Servicing
- Information On Refrigerant (R1234YF) For A/C Service (12-01-37-001G)
- GM Training - April 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-020)
Headlights
- Exterior Lighting Components "Tinted Or Smoked" By An Outside Vendor (15-08-42-001A)
- Low Beam Headlamp Bulb Diagnosis/Replacement (Inspect Bulb And Connector) (10-08-42-001E)
- Headlamp, Tail Lamp, License Lamp Or Fog/Driving Lamp Damage (02-08-42-001J)
- Replacement of Headlamp Assemblies Under Warranty and Use of GM vs. Non-GM Headlamp Assemblies (08-08-42-005B)
Heated Glass/Defoggers
- Rear And Side Tempered Glass Spots (Quench Marks) (PI0754G)
- Repair Information For Reconnection Of Rear Window (Defroster) Contact Or Tab (03-08-48-006J)
Hoist/Jack
- Spare Tire Jack Storage Compartment Door Difficult To Latch Or Falls Open Due To Inability To Latch (PI0731B)
HVAC Control Systems
- Ac Blows Warm Or Poor Performance (PIT5099H)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Air Conditioning Odor (Install Evaporator Core Dryer Kit And Apply Cooling Coil Coating) (99-01-39-004I)
- HVAC Operation During Remote Start (PIT5061C)
- Diagnostic Tips For Odor Emanating From HVAC System (PI1440)
- Hazard Button, HVAC Or Driver Information Center (DIC) Control Buttons May Stick When Depressed (Remove Excess Material On Instrument Panel Accessory Trim Plate) (09-08-49-004A)
- Sun Reflection Off Chrome Trim Rings (Bezel) On Instrument Panel HVAC Air Outlets (Replace With Black Painted Trim Rings (Bezel)) (08-01-38-007C)
- Gear Oil Type Odor in Interior of Vehicle (Install Cabin Filter into HVAC Module) (10-01-37-002)
- HVAC Automatic Climate Control Defaults to Full Cold or Full Hot Despite Controls Being Set to Other Parameters, DTCs B0228, B0413, B0423, B0433, B3779 or B3782 Set (Reprogram HVAC Control Module) (08-01-39-009B)
- EI09086 - Automatic HVAC Inoperative, Automatic HVAC Control Replacement or Reprogramming (Engineering Information Closed) (09-01-39-004A)
- Information on Vehicles with HVAC Control Module A/C and Recirculation Indicators Flashing (09-01-38-004)
Identification
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Discontinuation of Printed GM VIN Cards (08-00-89-031B)
Ignition Switch/Steering Lock
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (U.S. Only) (10-00-89-009F)
- Diagnostic Tip - Security Light On Intermittently / No Crank/No Start Or Start Stall / Keyless Access Vehicles May Display No Remote/Fob Detected / Poor Or No RKE Range / Service TPM DTC B3055, B3060, B3935, C0750, C0755, C0760, C0765, C0775 (PIC5650L)
- Intermittently Key Will Not Rotate In Door Or Ignition Lock Cylinder (PI0091B)
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (CANADA Only) (10-00-89-010C)
- Diagnostic Tips/Recommendations on GM Accessory 2-Way Remote Start Transmitter When Transmitter Battery is Weak or Dead (09-08-52-004A)
- Key Code Information (99-00-89-011E)
Ignition System
- Information Assistance For HFV6 Re-Manufactured Engine Drivability Diagnosis Immediately Following Installation (PIP5528F)
Infotainment
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- ONSTAR Module 2G Sunset Information (23-NA-001)
- Questionnaire For BLUETOOTH Related Concerns (PIC5932B)
- Changing Turn-By-Turn Voice Response To Metric Or English Units (PIC5614B)
- Off Route Message During ONSTAR Turn By Turn Operation (PIC5374D)
- Radio Does Not Mute Enough When ONSTAR® Turn-By Turn Navigation Directions Are Announced (Increase Volume Setting Or Request Soft Mute Feature Change Through ONSTAR® Customer Service) (10-08-46-001C)
- Information On Coax Repair Kit Availability (PI0572C)
- Turn By Turn Directions Not Displayed After CANADA Upgrade (PIT5465)
- DVD Navigation Update Program, Navigation Disc Diagnostic Aid, AVN Software Update Discs And Ordering Information (06-08-44-012G)
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Information On Navigation Radio Not Displaying Accurate Vehicle Location After Radio Replacement, Power Loss Or Battery Replacement (08-08-44-023A)
- Information On Noise Sources From Navigation Radio - Cd/DVD Disc Accessing Noise From Radio Fan, For Cooling, Disc Accessing Noise For Navigation Operation Or NAV Traffic Information (06-08-44-034D)
- Intermittent Black or Blank Screen, Radio Reset, Map Screen Stops Updating or Freezes, Voice Recognition Inoperative, Dead Battery (Update Navigation Radio Calibration and/or Software) (09-08-44-002G)
- Park Assist System Inoperative, Service Park Assist Message Displayed on Driver Information Center (DIC), DTC B1E3A and/or B0954, B0955, B0956, B0957, B0958, B0959, B0960, B0961 Set (Replace Appropriate Object Sensor or Repair Harness) (08-08-127-001B)
- EI09084 - Rear Parking Assist System Inoperative (Engineering Information Closed) (09-08-127-001B)
- Information on OnStar® Destination Download Incomplete, Intermittent (Replace OnStar® (VCIM) Module) (08-08-46-003C)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- GM Training - April 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-020)
Interior/Exterior Trim
- Information On Proper Use Of Floor Mats (10-08-110-001L)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- White Film/Residue On Vehicle Interior, Door Trim Panels And/Or Instrument Panel (IP) (PI0799A)
- Headliner Wet, Water Leak From Front Or Rear Sunroof Glass Or Rear Compartment Carpet Wet (10-08-67-001C)
- Floor Wet Under Carpet/Engine Continues To Run With Key Off/Possible No Crank/No Start/Communication Loss/Various Electrical Concerns (Seal Seam) (08-08-57-003F)
- Information On Gm Accessory All-Weather Floor Mat Retention Hole Fit (08-08-110-017A)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- Sun Reflection Off Chrome Trim Rings (Bezel) On Instrument Panel HVAC Air Outlets (Replace With Black Painted Trim Rings (Bezel)) (08-01-38-007C)
- Separated, Broken Or Missing Floor Mat And Carpet Retainers (Replace Buttons And Retainers) (08-08-110-016C)
- 2nd and/or 3rd Row Seat Floor Mat Will Not Lay Flat (Adjust Floor Mat Retainer(s)) (07-08-110-001B)
- Front Side Door Trim Separates, Gap Between Armrest and Pull Cup (Install Tie Straps) (09-08-110-023)
- Proper Removal of Cargo Screen Retainers For Any Service Repairs Related to Quarter Lower Rear Trim Panel Removal (09-08-110-022)
- Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including Chevy Bowtie (Bulletin Cancelled) (06-08-111-004B)
- Information on Maintaining Exterior Weatherstrip Appearance (99-08-64-016C)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- Squeak, Creak or Chirp Noise from Left and/or Right Rear Quarter Panel (Install Squeak Reduction Tape to Left and Right Rear Quarter Panel Retaining Slots) (07-08-59-004)
Interior/Illumination Lights
- Dome Lamps Do Not Come On When The Door Is Open (PIT4248D)
- Information On Body Control Module (BCM) Grounds (07-08-47-004E)
Lubrication System
- Information On Flushing Oil Contamination From Cooling System (25-NA-052)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Engine Oil Consumption Guidelines (01-06-01-011Q)
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Information On Gasoline Engine Replacement Guidelines After Connecting Rod Or Crankshaft Main Bearing Damage - Replace Oil Cooler, Oil Cooler Lines, Oil Tank And Turbocharger (22-NA-074)
- Information For Engine Concerns Resulting From Lack Of Scheduled Maintenance, Improper Service Or Aftermarket Calibrations (16-NA-222)
- Information On New Torque Specification And Installation Procedure For ACDELCO Spin-On Oil Filters (22-NA-009)
- Engine Ticking Noise Or Oil Pressure Fluctuation On Cold Start (PIP5191C)
- Information Regarding Magnetic Drain Plugs (16-NA-117)
- Diagnostic Tips For Preventing Oil Leaks After Changing Oil And Filter (15-00-90-001)
- Fuel And Oil Additives - Facts And Myths - Maximizing Gasoline Fuel Economy (05-00-89-072F)
- Diagnostic Information On Internal Engine Noise Or Damage After Oil Filter Replacement (10-06-01-003C)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- Information on Revised Engine Oil and Oil Filter Replacement Procedure (09-06-01-007)
Manual Steering
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Power Steering Noise Or Fluid Leak From Power Steering Pump, Gear Or High Pressure Hose During Extreme Low Temperature Operation (Replace Power Steering Fluid) (12-02-32-002B)
- Diagnostic Tip - Replacing Power Steering Cooler (PIT5165C)
- Vibration Analysis Worksheet (03-00-91-001I)
- Whine or Moan Type Noise from Power Steering System During Low Speed Maneuvers (Perform Repair as Outlined Below) (10-02-32-002A)
- Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013B)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Power Steering Pump Whine or Moan Noise (Inspect Power Steering Lines for Contact) (09-02-32-003)
Manual Trans
- Information On Driveline Clunk Noise (99-04-20-002O)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- PQC Assembly Replacement Process - For Dealers Required To Contact PQC Prior To Replacing An Assembly (U.S. And CANADA Only) (99-07-30-020)
- Information On The Reuse Of Fasteners And The Proper Reading Of Torque Specifications (15-NA-069)
- Vibration Analysis Worksheet (03-00-91-001I)
Mechanical
- Engine Replacement After Severe Internal Engine Damage - Replace Intake Manifold (00-06-01-026R)
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Use Of Surface Conditioning Disks When Cleaning Gasket Sealing Surfaces And/Or Reused Parts (00-06-01-012N)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Engine Repair Tip For Installation Of Pistons (PI1394B)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Information On Engine Block Cracked At Head Bolt Hole Locations (23-NA-141)
- Information On Gasoline Engine Replacement Guidelines After Connecting Rod Or Crankshaft Main Bearing Damage - Replace Oil Cooler, Oil Cooler Lines, Oil Tank And Turbocharger (22-NA-074)
- Information For Engine Concerns Resulting From Lack Of Scheduled Maintenance, Improper Service Or Aftermarket Calibrations (16-NA-222)
- Diagnostic Tips For Knocking, Rattle, Squeak And/Or Squeal Type Noise From Engine - Engine Replacement Recommendations For HFV6 Gen 1 And Gen 2 (PIP5216G)
- Diagnostic Tip On Avoiding Torque Converter Or Crankshaft Damage While Diagnosing Noise Concerns (PIP5640A)
- Information For Repairing Engine Front Cover Oil Leak, Sealing Surface Preparation And Applying RTV Sealant (12-06-01-003D)
- Needle Bearings Found In The Oil Pan During An Oil Change (PIP5226D)
- Information Assistance For HFV6 Re-Manufactured Engine Drivability Diagnosis Immediately Following Installation (PIP5528F)
- Alleged Cylinders Out Of Round (PIP5163E)
- Engine Ticking Noise Or Oil Pressure Fluctuation On Cold Start (PIP5191C)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Information On Front Engine Mount Service Recommendation (PI1475)
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Information On Clicking/Ticking Sound/Noise Heard During Cold Start (07-06-04-025L)
- Rough Idle Crank No Start Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves (PIP5029H)
- Malfunction Indicator Lamp On - Check Engine Light, DTCS P0011, P0014, P0021, P0024, P0341, P0346, P0366 Or P0391 Set (Check Camshaft End Play And Perform Action As Outlined) (08-06-01-011K)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- PQC Assembly Replacement Process - For Dealers Required To Contact PQC Prior To Replacing An Assembly (U.S. And CANADA Only) (99-07-30-020)
- Information Regarding Magnetic Drain Plugs (16-NA-117)
- New Design Cylinder Heads (16-NA-085)
- New Design Cylinder Heads (PIP4936C)
- Information On The Reuse Of Fasteners And The Proper Reading Of Torque Specifications (15-NA-069)
- Information On High Feature V6 Timing Chain Kits And Chain Guide Replacements, DTCS P0008, P0009, P0016, P0017, P0018 And/Or P0019 (12-06-01-009F)
- Dealer Reimbursement Procedures For CAC Tier 1 And Tier 2 Empowerment Tools: Diagnostic Fee, Short Term Rental, And Up-Front Towing (U.S. Only) (15-00-89-003)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- Vibration Analysis Worksheet (03-00-91-001I)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
Mechanical - Hydraulic
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Brake Lathe Calibration Procedure (VSS20040074)
- Vibration Analysis Worksheet (03-00-91-001I)
- Information On Resurfacing Park Brake Portion Of Rear Brake Rotor (12-05-26-001)
- GM Training - April 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-020)
Memory Modules
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
Mirrors
- Power Foldaway Mirror Glass Shakes, Flutters At Normal Driving Speeds (16-NA-075)
- Information On Body Control Module (BCM) Grounds (07-08-47-004E)
- Mirror Glass Has Jerky Operation Or Stops During Mirror Travel (Follow Procedure Outlined Below) (10-08-64-003A)
- Information on Heated Electrochromatic Outside Rearview Mirror Performance (08-08-64-011A)
Paint & Coatings
- Information On Paint Stain Under Protective Shipping Film (05-08-51-001L)
- PAINTLESS Dent Repair Process (99-08-51-001F)
- Hem Flange Rust Repair (02-08-98-002H)
- Refinishing Aluminum And Chrome Wheels (99-08-51-007G)
- Application Of Anti-Corrosion Materials (01-08-51-003E)
- Information On Hem Flange Sealer For Corrosion Protection (06-08-51-005C)
- Pre-Painting/Cleaning Process For TPO Plastic Fascias (08-08-51-002A)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- Warranty Information-Fascia Refinish Labor Operations (10-08-62-003)
- Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) (43-17-01B)
Parking Brake System
- Information On Resurfacing Park Brake Portion Of Rear Brake Rotor (12-05-26-001)
Passive Restraints
- Seat Belt Extender Availability (99-09-40-005H)
- Information Regarding Servicing Components Located Near Sir Components (16-NA-055)
- Seat Belt Buckle Latching Issues And/Or Seat Belt Warning Lights Illuminated (09-09-40-001C)
- Safety Belt Locking Conditions (Normal Operating Characteristic) (05-09-40-002G)
- Seat Belt Latch Stop Button Available for Service (07-09-40-002A)
- Front Seatbelt Latch Plate Reversed, Front Seatbelt Twisted (Perform Repair to Untwist Seatbelt) (07-09-40-001A)
Procedures
- Vehicle Noise Diagnosis And TAC Requests For Assistance With Noise Related Complaints (PIP5358D)
- Website For AFIT, TPM, Gr8, MIT And PICO Scope Updates (PIP4723H)
- El-52800 - Diagnostic And Charge Battery Station (DCBS) - FAQS (23-NA-055)
Rear Suspension
- Information On Diagnosis And Replacement Of Shock Absorber And Strut Due To Fluid Leak (72-05-12)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Clunk Noise From Rear Suspension In Cold Weather (16-NA-101)
- Diagnosing Suspension And Rear End Sway (PIT5139C)
- Vibration Analysis Worksheet (03-00-91-001I)
Restraints Control Systems
- Information On Passenger Presence Sensing System (PPS Or PSS) Concerns With Custom Upholstery, Accessory Seat Heaters Or Other Comfort Enhancing Devices (06-08-50-009J)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- Diagnostic Information For Supplemental Inflatable Restraint (Sir) System, Intermittent Air Bag Indicator/Lamp Illuminated With DTC(S) B0012, B0013, B0015, B0016, B0019, B0020, B0022, B0023, B0026, B0033, B0040, B0042 Or B0044 Set (Inspect And Replace Connector Position Assurance (CPA) Retainer) (08-09-41-002H)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Information Regarding Servicing Components Located Near Sir Components (16-NA-055)
- Intermittent Abs Codes, No Communications, No Start And/Or Various Electrical Concerns (PIT4946A)
- Seat Belt Buckle Latching Issues And/Or Seat Belt Warning Lights Illuminated (09-09-40-001C)
- Vehicle Software Enhancements (13-00-89-003)
- Passenger Presence System (PPS) May Command Seat Belt Reminder Chime And Passenger Airbag Indicator On When Electronic Devices Or Conductive Objects Are Placed On Front Passenger Seat, DTCS 5045 Or B0074 0F May Set In PPS Module (08-09-41-007I)
- Airbag Light On, DTC B0071 and B0081 Set (Diagnose and Replace Right Front Seatbelt Buckle, If Necessary) (07-09-41-010D)
Seats
- Information On Seat Belt Lap Anchor Inspection (24-NA-147)
- Information On Passenger Presence Sensing System (PPS Or PSS) Concerns With Custom Upholstery, Accessory Seat Heaters Or Other Comfort Enhancing Devices (06-08-50-009J)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Seat Belt Extender Availability (99-09-40-005H)
- Second And/Or Third Row Bench Seat Center Belt Buckle Plastic Is Cracked (PIT4547G)
- Second Row Seat "Easy Entry" Function Inoperative, Seat Won't Travel In Fore/Aft Direction, Seat Doesn't Fold Flat (Follow Procedures Outlined Below) (11-08-50-001)
- Information On Driver Or Passenger Seat Head Restraint Concerns With Comfort, Custom Upholstery Or Other Comfort Enhancing Devices (10-08-50-003A)
- Manual Seat Adjuster Bumpy Or Jerky Operation, Binds, Sticks, Seat Won't Adjust (Revise Seat Adjuster Mounting, Burnish Seat Tracks) (10-08-50-005C)
- Front Driver Power Seat Inoperative, Driver Seat Will Not Move Forward or Backward (Replace Horizontal Motor Drive Cable) (07-08-50-013A)
- Minor Wrinkles/Creases, Discoloration, Cigarette Burns and Customer Induced Cuts and Stains on Front and Rear Driver and Passenger Seats with Leather, Vinyl or Cloth Seat Covers (04-08-50-006D)
- EI09060 - Engine No Crank/No Start Due to Discharged Battery/Parasitic Current Draw (Engineering Information Closed/Corrective Action Provided) (09-06-03-002G)
- Power Seat Feels Bumpy or Jerky When Moved Fore or Aft (Replace Lower Seat Track Assembly) (07-08-50-016C)
- Second Row Seat "Easy Entry" Function Inoperative (Replace Seat Recliner Stop Pin) (09-08-50-005)
Starter
- Cold Weather And Long Stand Time Battery Maintenance And Testing Tips (15-06-03-001F)
- Warranty Administration - Battery Testing And Warranty Replacement Requirements (North AMERICA Only) (03-06-03-004Z)
- Information On How To Prevent Inadvertent Vehicle Starting From Key Fob Or ONSTAR Mobile Application (17-NA-244)
- HVAC Operation During Remote Start (PIT5061C)
- Information On The Use Of Non Gm Approved Battery Chargers And Booster Packs (15-NA-030)
- Intermittent Abs Codes, No Communications, No Start And/Or Various Electrical Concerns (PIT4946A)
- ACDELCO® Replacement Battery Warranty Procedures (03-06-03-003D)
- Intermittent Battery Draw Dead Battery Or HVAC Odor (PIT5066A)
- EI09060 - Engine No Crank/No Start Due to Discharged Battery/Parasitic Current Draw (Engineering Information Closed/Corrective Action Provided) (09-06-03-002G)
- Intermittent Black or Blank Screen, Radio Reset, Map Screen Stops Updating or Freezes, Voice Recognition Inoperative, Dead Battery (Update Navigation Radio Calibration and/or Software) (09-08-44-002G)
- Battery Part Restriction Program Effective March 1st, 2008 (08-06-03-002C)
- Diagnostic Tips/Recommendations on GM Accessory 2-Way Remote Start Transmitter When Transmitter Battery is Weak or Dead (09-08-52-004A)
- Generation 8 OnStar® Modules Inoperative and Possible Battery Discharge Condition (Replace OnStar® VCIM) (09-08-46-004A)
- GM Accessories: 2-Way Advanced Remote Start Systems Part Information (09-00-89-025A)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- GM Dealer Visits: Proper Management of Batteries in Dealer Parts Stock / Vehicle Inventory (08-06-03-005)
- Battery Charging Tips (Includes Information References for HP2 Hybrid Truck [PHT] 42-volt System) (02-06-03-009C)
Steering Column
- Proper Wheel Installation And Wheel Torque Techniques (12-03-10-002A)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Squeak / Rattle Noise From Steering Column (Align Arrow On Rubber Grommet With Line On Dash Mat) (09-02-34-001B)
Steering Control Systems
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
Steering Gear
- Grease Or Sealant Visible On Electronic Power Steering Gear - Should Not Be Interpreted As Leak (16-NA-109)
- Power Steering Noise Or Fluid Leak From Power Steering Pump, Gear Or High Pressure Hose During Extreme Low Temperature Operation (Replace Power Steering Fluid) (12-02-32-002B)
- Change Power Steering Fluid To DEXRON®-VI When Replacing Steering Gear Assembly (PI0620A)
- Diagnostic Tips For Steering Gear Boot Stains, Perceived Fluid Leak From Power Steering Gear End Seals (12-02-32-004A)
- Hydraulic Power Steering System Leak - Required Diagnostic Actions (07-02-32-002M)
- Clunk or Knock Noise When Turning (Replace Steering Gear Bushing) (10-02-32-001A)
Sun Roof/T-Top/Convertible Top
- Rear And Side Tempered Glass Spots (Quench Marks) (PI0754G)
- Intermittent Sunroof Operation, Bind, Noise, Auto-Reverse, And/Or Water Leaks (PIC5260F)
- Headliner Wet, Water Leak From Front Or Rear Sunroof Glass Or Rear Compartment Carpet Wet (10-08-67-001C)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- Sunroof and General Water Leak Diagnostic Guide (07-08-57-002G)
- EI09119 - Sunroof Glass Water Leak, Wind Noise, Binding Condition, Not Flush With Roof Sheet Metal (Engineering Information) (09-08-67-010)
- Sunroof Rear Sunshade Binds or Will Not Move (Replace Right or Left Sunroof Sunshade Drive Cable Assembly) (09-08-67-009A)
- GM Training - GM Moveable Roof Systems Hands-On (#12040.30H) (U.S. Dealers) (This is not a Saturn STS Requirement) (08-00-89-027)
Suspension Control Systems
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Vehicle Software Enhancements (13-00-89-003)
- TPMS System Service and Re-Learning Sensor IDs (10-03-16-001)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
System
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Module Damage From Incorrect AFIT Usage On Vehicles With Direct Fuel Injection (PIP5569B)
- Information On Sag Or Hesitation On Acceleration (PIP4112S)
- Diagnostic Tips For Direct Injected Engines Hard Start Cold (PIP5180C)
- Diagnostic Tips For I/M Flags Resetting After Ignition Cycled (PIP5627)
- SES Light With Fuel Trim And Or Oxygen Sensor Codes (PIP4925B)
- Malfunction Indicator Lamp (Mil) Check Engine Light On, DTC P182E (17-NA-084)
- DTC P0016 P0017 P0018 P0019 P0008 P0009 (PIP3423P)
- Cold Start Misfire And/Or Rough Idle - DTC P0300 May Be Set (PIP4959F)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Information On Remanufactured Engine Misfire Diagnosis After Installation (17-NA-307)
- Information On Rough Idle, Crank No Start, Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves, Malfunction Indicator Light (Mil) Illuminated - DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308 Set (16-NA-383)
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- Procedure To Take Snapshot Data With A Tech 2 And Upload Data To A Computer Using TIS Software (07-07-30-010D)
- Malfunction Indicator Lamp (Mil) - Check Engine Light On, DTC P182E (PI0269B)
- Malfunction Indicator Lamp On - Check Engine Light, DTCS P0011, P0014, P0021, P0024, P0341, P0346, P0366 Or P0391 Set (Check Camshaft End Play And Perform Action As Outlined) (08-06-01-011K)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Usage Of E85 Fuel In Gm Vehicles (05-06-04-035E)
- Floor Wet Under Carpet/Engine Continues To Run With Key Off/Possible No Crank/No Start/Communication Loss/Various Electrical Concerns (Seal Seam) (08-08-57-003F)
- Diagnostic Tip - Vehicle Start And Stalls After Theft Deterrent Module Replacement (PIT5028B)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Deceleration Misfire On All Cylinders 1400 Rpm To 1800 Rpm Diagnosis (PIP5264)
- Information On Clicking/Ticking Sound/Noise Heard During Cold Start (07-06-04-025K)
- Vehicle Software Enhancements (13-00-89-003)
- EI09060 - Engine No Crank/No Start Due to Discharged Battery/Parasitic Current Draw (Engineering Information Closed/Corrective Action Provided) (09-06-03-002G)
- Identifying Aftermarket Engine and Transmission Calibrations 2.0L, 2.2L, 2.4L, 2.8L, 2.9L, 3.0L, 3.1L, 3.2L, 3.4L, 3.5L, 3.6L, 3.8L, 3.9L, 4.2L, 4.3L, 4.4L, 4.6L, 4.8L, 5.0L, 5.3L, 5.7L, 6.0L, 6.2L, 7.0L, 7.4L, 8.1L Gas Powered Engines Only and 6T40/45 (MH8), 6T70/75 (MH2, MH4, MH6, MY9), 6L50 (MYB) 6L80 (MYC) or 6L90 (MYD) Automatic Transmission (08-06-04-033D)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
Towing
- Supplemental Information On Trailer Towing And Recreational Vehicle Towing (Dinghy Towing) (07-00-89-021Q)
Transfer Case
- PQC Assembly Replacement Process - For Dealers Required To Contact PQC Prior To Replacing An Assembly (U.S. And CANADA Only) (99-07-30-020)
- Fluid Leak At Transfer Case Left Hand Weep Hole Or Between Transfer Case To Transmission Interface (Replace Transfer Case Input Shaft Seal-Left Or Transfer Case O-Ring Seal) (09-04-21-004B)
- Automatic Transmission Fluid Leak at Transfer Case Weep Hole (Replace Front Wheel Drive Intermediate (Inner) Shaft Seal) (08-04-21-002A)
Transmission Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Module Damage From Incorrect AFIT Usage On Vehicles With Direct Fuel Injection (PIP5569B)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- Procedure To Take Snapshot Data With A Tech 2 And Upload Data To A Computer Using TIS Software (07-07-30-010D)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Vehicle Software Enhancements (13-00-89-003)
- No Reverse, 3RD Or 5TH, Check Engine Light Illuminated, DTC P0776 (Replace 3-5 Reverse Clutch Plate (Waved) (09-07-30-012F)
- Identifying Aftermarket Engine and Transmission Calibrations 2.0L, 2.2L, 2.4L, 2.8L, 2.9L, 3.0L, 3.1L, 3.2L, 3.4L, 3.5L, 3.6L, 3.8L, 3.9L, 4.2L, 4.3L, 4.4L, 4.6L, 4.8L, 5.0L, 5.3L, 5.7L, 6.0L, 6.2L, 7.0L, 7.4L, 8.1L Gas Powered Engines Only and 6T40/45 (MH8), 6T70/75 (MH2, MH4, MH6, MY9), 6L50 (MYB) 6L80 (MYC) or 6L90 (MYD) Automatic Transmission (08-06-04-033D)
- Information on Automatic Transmission Service Fast Learn Adapts (SFL) Characteristics (08-07-30-039)
Wheel Alignment
- Refinishing Aluminum And Chrome Wheels (99-08-51-007G)
- Information On Slight Or Mild Tire Feathering And Recommended Practices (Normal Tire Wear Condition) (07-03-10-008E)
- Wheel Alignment Specifications, Requirements And Recommendations For Gm Vehicles (05-03-07-009H)
- Diagnosing Suspension And Rear End Sway (PIT5139C)
Wheels & Tire System
- Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean And Resurface Wheel Bead Seat) (08-03-10-006I)
- Guidelines When Changing Tire And Wheel Size (PIT3271P)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Vibration Shortly After Tires Are Mounted/Preventing Vibration From Wheel Slip (Tire Sliding On Wheel) (12-03-10-001E)
- Information On Proper Tire Pressure (00-00-90-002M)
- Information On Tire Radial Force Variation (RFV) (00-03-10-006P)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5338B)
- Information On Hunter Road Force Balancer (17-NA-170)
- Non-Design Intent Wheel Lock Nuts And Lug Nuts (17-NA-126)
- Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean And Resurface Wheel Bead Seat) (08-03-10-006H)
- Information On Slight Or Mild Tire Feathering And Recommended Practices (Normal Tire Wear Condition) (07-03-10-008E)
- Information On Tire/Wheel Characteristics (Vibration, Balance, Shake, Flat Spotting) Of Gm Original Equipment Tires (03-03-10-007J)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Spare Tire Jack Storage Compartment Door Difficult To Latch Or Falls Open Due To Inability To Latch (PI0731B)
- Use Of Nitrogen Gas In Tires (05-03-10-020F)
- Statement On Tire Sealant Included In Gm Inflator Kits (Supplied With New Vehicles Or As Gm Accessory) (09-03-10-013B)
- Proper Wheel Installation And Wheel Torque Techniques (12-03-10-002A)
- Dealership Service Consultant Procedure As Vehicle Comes Into Service Drive For Tire Pressure Monitor (TPM) System Message, Light And Customer Information (09-03-16-002B)
- Wheel Balancing Machine Finish Damage To Chrome Clad Or CHROMETECH® Wheels (09-03-10-016A)
- Gm Tire Warranty Program Goodwill Guidelines (U.S. Only) (08-03-10-012B)
- Guidelines for Using Labor Operations E0200, E0201, E0203, E0204 - Wheel Balance (72-05-03)
- TPMS System Service and Re-Learning Sensor IDs (10-03-16-001)
- 19 Inch Accessory Wheels Available Through GM Accessories (06-03-10-012D)
- Information on Proper Wheel Changing Procedures and Cautions (06-03-10-010A)
- Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (93-U-57)
- Tire Puncture Repair Procedures For All Cars and Light Duty Trucks (04-03-10-001F)
- TPM System Overview, Diagnosing Tire Pressure Monitor System (TPM) Concerns and TPM Frequently Asked Questions (FAQ) (07-03-16-004C)
- Information on Replacement Wheel Weights (09-03-10-017)
- Mounting, Balancing And Installation Of Accessory Wheels And Tires Available Through Gm Accessories (08-03-10-004A)
- Use of Chrome or Chrome Plated Steel Valve Caps on Aluminum Valve Stems (08-03-10-005A)
- EI07266 - Vehicle/Tire Vibration, P275/55R20, LT245/75R16, P265/70R17, P245/70R17, P285/45R22, LT265/75R17- Diagnostic Information to Reduce Vibration Concerns (07-03-10-013D)
- Performance Characteristics of Vehicles with Accessory Wheel/Tire Assemblies Installed as "Upsized" to Original Equipment (05-03-10-005D)
- Minimizing Damage to Tire Pressure Monitor (TPM) Sensors During Tire Mounting/Dismounting (08-03-10-007)
- Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
Window Motors & Regulators
- Information On Side Door Window Glass Chipping Caused By Hanging Vehicle Key Lock Box (06-08-64-001D)
- Repair Information For Reconnection Of Rear Window (Defroster) Contact Or Tab (03-08-48-006J)
- Front Or Rear Side Door Window Binds, Moves Slowly, Makes Rattle/Squeak Noise, Poor Fit/Misalignment Or Is Inoperative (PI0018B)
- Information On Body Control Module (BCM) Grounds (07-08-47-004E)
- Rear Window Defogger - Broken Heating Grid Detection Method (04-08-48-001D)
- Distortion in Outer Surface of Vehicle Glass (00-08-48-005D)
- Clear Stain or Film on Inside Perimeter of Windshield Glass (Clean/Polish Glass) (09-08-48-006)
- Marks/Stains on Windshield When Wet (Clean Windshield) (09-08-48-002A)
- Warranty Admin - Guidelines for Claiming C0034 - Windshield Replacement (72-05-04)
Wiper/Washer Systems
- Windshield Wiper Performance, Cleaning Instructions And Maintenance (06-08-43-003E)
Wiring Diagrams
- Warranty Administration - Revised Wiring Repair Labor Operations And Required Additional Information (10-00-89-005K)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- J-35616-64B Or El-35616-58 Terminal Test Probe Information/Repair (PIT5074R)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Information On Coax Repair Kit Availability (17-NA-346)
- Prior To Any Circuit Testing (PIP5094A)
- Information On Coax Repair Kit Availability (PI0572C)
- Intermittent Abs Codes, No Communications, No Start And/Or Various Electrical Concerns (PIT4946A)
- Gm Wiring Repair Strategy Information (13-00-89-008A)