Technical Service Bulletins
- A/C Compressor
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Ac Blows Warm Or Poor Performance (PIT5099H)
- Diagnostic Information to Accurately Diagnose A/C Low Pressure Switch Using Kent Moore Special Tool GE-47742 (04-01-38-010A)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
- Information on GM ACR2000 (J-43600) and New Refrigerant Recovery Recharging Equipment Standard SAE J2788 (07-01-38-004)
- New PAG Oil Released (02-01-39-004B)
- Diagnostic Information for Moan, Groan or Boom Noise at Idle, Vibration in Steering Wheel or Felt Through Floor When A/C Compressor Engages - Do Not Replace A/C Compressor (04-01-38-015)
- HVAC Not Cold Enough, A/C Compressor Does Not Engage (Repair Engine Compartment Wiring Harness Near Idler Arm) (04-01-38-013)
- Contaminated R-134a A/C Systems - Air Conditioning System Flushing Procedures and Universal In-Line A/C Filter Installation (83-12-21)
- Underhood Rattle Noise Heard On Acceleration (Check A/C System Performance and Compressor Operation) (03-01-38-019A)
- J-43600 ACR 2000 Essential Refrigerant Recovery/Recharge Equipment (99-01-38-006B)
- J 44551 A/C Suction Screen Kit Repair Recommendations And Procedures After Catastrophic Compressor Failures (01-01-39-003A)
- A/C Refrigerant System Sealer And A/C System Leak Detection Guidelines (03-01-38-001)
- Refrigerant Dye Added To A/C System At Assembly Plant (00-01-38-009B)
- Accessories & Equipment
- New Labor Operation Codes for Dealer-Installed GM Accessories Replaced During Warranty Coverage Period (02-20-89-014)
- Announcement of Price Increase for MDI (EL-47955) (08-00-89-018A)
- Processing GM Accessories - Initial Quality Issues (04-00-89-018C)
- Part and Accessory Replacement Policy (04-00-89-011)
- Accessories Control Systems
- Information On Communication With ONSTAR Module After CANADIAN Cellular Upgrade (15-08-73-001A)
- Diagnostic Tip: Unable To Connect To ONSTAR Or Connects Failed To Voice (PIT5389F)
- Requirements For ONSTAR Over The Air Programming And Updates (PIC6107A)
- ONSTAR- Unwanted Or Phantom Phone Calls (PIC3278G)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- Caller Id Unavailable After ONSTAR Upgrade (PIT5464)
- Diagnostic Tip: Unable To Connect Or Use Hands Free Calling Or No Data On The Call (Failed To Voice) (PIC4310L)
- Fuel Gauge Fluctuation In Park Or Neutral (PIT3046G)
- Diagnostic Tip: CANADIAN ONSTAR Subscriber Unable To Receive Turn-By-Turn Directions While Traveling In The United States (PIT5264C)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
- Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
- Programming OnStar(R) Module for Canadian French Voice Recognition (OnStar(R) Generation 5 or Generation 6) (02-08-46-010G)
- Rear Seat Audio (RSA) and/or Rear HVAC Inoperative (Replace RSA Module) (03-08-44-018C)
- Malfunction Indicator Lamp (MIL) On, Transmission Stuck in Second or Third Gear, Instrument Cluster Inoperative (Verify and Repair Source of Voltage Loss In Transmission Solenoid Power Supply Circuit) (01-07-30-002E)
- Intermittent Heated Seats Inoperative, DTC B3941 Set (Reprogram Driver Seat Module) (05-08-50-008)
- Memory Seat May Not Return to Requested Position (Reprogram Driver Seat Module) (04-08-50-016C)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- 2003, 2004, 2005 Silverado and Sierra, Tahoe, Yukon, Avalanche, Suburban, Yukon XL, Escalade, Escalade EXT and ESV, and HUMMER H2 Power Seat Will Not Retain Preset Memory Position (VSS20050521)
- Power Seat Switch Works In The Opposite Direction - Keywords An3 Driver Electrical Intermittent Memory Module Move Operation Recall Reverse RKE (PIT3598)
- Trailer Brakes Applied When Headlights/Park Lamps Are On, Brake Controller Illumination (Modify Brake Controller Wiring Harness) (02-05-22-004C)
- Enabling Memory Seat Feature via DIC If Feature Appears Inoperative (04-08-50-003)
- OnStar(R) Proactive Parts Shipment Process (02-08-46-013A)
- Information on Error Codes on Radio Display - Their Cause and Corrective Action (64-90-04A)
- Service Information for Front Heated Seat Inoperative/Cold (04-08-50-007)
- Diagnostic Information For Replacement Remote Keyless Entry (RKE) Transmitter Inoperative - Unable To Synchronize (03-08-52-005)
- HOMELINK Transceiver/Garage Door Opener Transmitter Test Kit (01-08-97-001B)
- Info - Changes In A/C Compressor On/Off Instrument Panel Display Symbol From 2003 To 2004 Model Year And Synchronizing The Driver And Passenger Set Temperatures (03-01-39-008)
- Radio Automatic Volume Control Feature Inoperative (Rewire Noise Cancellation Microphone) (03-08-44-004)
- Seat Heater And/Or Memory Power Seat Inoperative (Replace Memory Seat Control Module) (03-08-50-003)
- Service Air Suspension Message Diagnostic Trouble Code (DTC) C0711 And/Or Clicking Noise From Rear Of Vehicle With Ignition Off And/Or Electronic Controlled Air Suspension (ECAS) Compressor Cycles Too Frequently (Reprogram ECAS Control Module) (02-03-99-002)
- Diagnostic Information For No Audio Out Of Speakers On One Or More Channels (02-08-44-018)
- Info - Cycling Power Folding Exterior Mirror To Remain In Locked Position After Transport (02-08-64-022)
- Selecting Radio Source Using Steering Wheel Controls (02-08-44-017)
- Accessory Drive Belts
- Air Bag, SRS
- Anti-Lock Brakes
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
- Antilock Brake (ABS) Activation At Low Speeds (Clean Wheel Speed Sensor Mounting Surface) (03-05-25-007D)
- Anti-Theft Systems
- Information On Poor, Limited, Reduced Remote Keyless Entry (RKE) Or Remote Vehicle Start (RVS) Range (PI1018A)
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (CANADA Only) (10-00-89-010C)
- Key Code Information (99-00-89-011E)
- Remote Keyless Entry Operational Characteristics (99-08-52-005C)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Door Squeak/Rattle (Replace Door Trim Retainers) (05-08-64-025)
- Remote Keyless Entry (RKE) System Inoperative (03-08-52-001C)
- Diagnostic Information For Replacement Remote Keyless Entry (RKE) Transmitter Inoperative - Unable To Synchronize (03-08-52-005)
- Door Latch Freezing In Cold Temperatures (05-08-64-002B)
- Automatic Trans
- Information On Ethylene Glycol In Transmission Fluid (08-07-30-035I)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Driveline Clunk Noise (99-04-20-002O)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Prior To Any Circuit Testing (PIP5094A)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Automatic Transmission Oil Cooler Flow Test Essential Tool J-45096 TRANSFLOW® (03-07-30-002B)
- Information On 2-3 Upshift Or 3-2 Downshift Clunk Noise (01-07-30-042H)
- Vibration Analysis Worksheet (03-00-91-001I)
- Information On Normal Maintenance Or Warranty Service For 4T40, 4T45, 4T65, 4L60 Automatic Transmission Oil Pan Magnet Upgrade (08-07-30-040C)
- Release Of DEXRON®-VI Automatic Transmission Fluid (ATF) (04-07-30-037E)
- Warranty Administration- Change in Automatic Transmission Add Condition Documentation and Claim Submission (09-07-30-018A)
- Current Model Year Goodwrench Transmission Replacement Assembly Program (00-07-30-009D)
- GM Training - June 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-026)
- Diagnostic Tips for Automatic Transmission DTC P0756, Second, Third, Fourth Gear Start (01-07-30-036H)
- No Reverse, Second Gear or Fourth Gear (Replace Reaction Sun Shell with More Robust Heat Treated Parts) (00-07-30-022D)
- Diagnostic Information on Diagnostic Trouble Code (DTC) P0894 and P1870 (08-07-30-008B)
- Automatic Transmission/Transaxle Torque Converter Replacement (01-07-30-010C)
- Engagement Time of Electronically Controlled Transmissions in General Motors Vehicles (Garage Shifts, Park to Reverse, Neutral to Drive, Neutral to Reverse, Park to Drive, Delayed Engagement) (03-07-30-007E)
- Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
- Information Regarding Automatic Transmission Shift Lock Control Function (03-07-30-043A)
- Instructions To Be Followed To Aid in Obtaining Root Cause Analysis on Both OEM and Goodwrench(R) Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
- 4L60-E/4L65-E Automatic Transmission Diagnostic Information on Harsh 1-2 Upshift (01-07-30-030B)
- Transmission Fluid Leak Diagnosis (01-07-30-041B)
- Diagnosis of Cracked or Broken Transmission Case (02-07-30-024B)
- 1-2, 2-3, 3-4, 4-5 Shift and Torque Converter Clutch (TCC) Characteristics During Cold Weather Operation on 4L60-E, 4L80-E or Allison Transmissions (01-07-30-031A)
- 4L65-E, 4L60-E, 4L60 And 200-4R Automatic Transmission Oil Pump Spring First And Second Design Identification (04-07-30-006)
- 4L60-E A/T Oil Pump First & Second Design Identification (03-07-30-056)
- Driveline Clunk When Stopping (Reprogram Powertrain Control Module (Pcm)) (03-07-30-028)
- Most Frequently Asked Questions And Answers For J 45096 TRANSFLOW Transmission Oil Cooling System Flushing Machine (03-07-30-027)
- Transfer Case Bushing/Slip Yoke Leak, Transmission Downshifting, Loss Of Power, Vehicle Will Not Move (Replace Damaged Components/Install New Longer Style Propeller Shaft) (03-04-21-002)
- Automatic Transmission Oil Cooler Flushing And Flow Check Procedures (99-07-30-017A)
- Diagnostic Information For Intermittent Transmission Downshift, Slip, Busy/Cycling TCC Or Noisy Cooling Fan (99-07-30-016B)
- Automatic Transmission Serial Number & Site Code Locations (02-07-30-028)
- Auxiliary Emission Control Systems
- Catalytic Converter Break-In Information To Prevent DTCS P0420 And/Or P0430 (PIP3119P)
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- Possible Engine Oil Leak Due To PCV Freeze-Up (PIP3343F)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- I/M Readiness as Part of Emission Inspection and Maintenance Program for OBD II Vehicles (00-06-04-033B)
- New Add Time For Labor Operation L2300 - Converter, Oxidation Catalytic-Replace (02-00-89-006C)
- Oil Leak Under Extreme Cold Temperatures (-34°C (-30°F) or Colder) (Install Vented Oil Fill Cap) (05-06-01-014)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- SMU - Revised DTCS P0135, P0141, P0155 And P0161 (03-06-04-025)
- Vehicle Is Difficult To Fill With Fuel Or Filling Station Pump Shuts Off Before Tank Is Full (Inspect Fuel Tank Vent Tube Opening And Replace Fuel Tank) (03-06-04-019)
- ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
- Axle Shafts
- Body Electrical
- Information For Electrical Ground Repair - Use New Replacement Fasteners With Conductive Finish (10-08-45-001F)
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Updated Transfer Case Connector Service Kit Now Available For Transfer Case Speed Sensor Wire Harness Connector that Comes Loose Or Connector Retainer Clip Breaks (06-04-21-001)
- Instrument Panel (I/P), Body and General Wiring Harness Repair (06-08-45-004)
- Trailer Brakes Applied When GM Accessory Roof-Mounted Off-Road Spot Lamps are On (Modify Roof-Mounted Off-Road Spot Lamp Wiring Harness) (04-08-42-003)
- UPFITTER Bulletin - Modified Brake Controller Wiring Harness (UI 57)
- Body Interior
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- OnStar® Labor Operation Codes (05-08-46-005C)
- Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
- Rear Seat Audio (RSA) and/or Rear HVAC Inoperative (Replace RSA Module) (03-08-44-018C)
- Intermittent Heated Seats Inoperative, DTC B3941 Set (Reprogram Driver Seat Module) (05-08-50-008)
- Memory Seat May Not Return to Requested Position (Reprogram Driver Seat Module) (04-08-50-016C)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Trailer Brakes Applied When Headlights/Park Lamps Are On, Brake Controller Illumination (Modify Brake Controller Wiring Harness) (02-05-22-004C)
- OnStar(R) Proactive Parts Shipment Process (02-08-46-013A)
- Service Information for Front Heated Seat Inoperative/Cold (04-08-50-007)
- HOMELINK Transceiver/Garage Door Opener Transmitter Test Kit (01-08-97-001B)
- Radio Automatic Volume Control Feature Inoperative (Rewire Noise Cancellation Microphone) (03-08-44-004)
- Seat Heater And/Or Memory Power Seat Inoperative (Replace Memory Seat Control Module) (03-08-50-003)
- Service Air Suspension Message Diagnostic Trouble Code (DTC) C0711 And/Or Clicking Noise From Rear Of Vehicle With Ignition Off And/Or Electronic Controlled Air Suspension (ECAS) Compressor Cycles Too Frequently (Reprogram ECAS Control Module) (02-03-99-002)
- Diagnostic Information For No Audio Out Of Speakers On One Or More Channels (02-08-44-018)
- Info - Cycling Power Folding Exterior Mirror To Remain In Locked Position After Transport (02-08-64-022)
- Selecting Radio Source Using Steering Wheel Controls (02-08-44-017)
- Brakes Control Systems
- Charging Systems
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- Battery and Charging System Electrical Diagnostics (99-06-03-012)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Incorrect Amp Code On Generator (04-06-03-001)
- Communication Devices
- Information On Communication With ONSTAR Module After CANADIAN Cellular Upgrade (15-08-73-001A)
- Diagnostic Tip: Unable To Connect To ONSTAR Or Connects Failed To Voice (PIT5389F)
- Requirements For ONSTAR Over The Air Programming And Updates (PIC6107A)
- Diagnostic Tips: XM Audio Traffic And Travel Link Availability And Operation (PIT5353C)
- ONSTAR Will Not Power Up (PIC5491K)
- Normal Characteristic - ONSTAR Power Consumption (PIC4935F)
- Diagnostic Tip - ONSTAR Turn By Turn /TBT Feature Inoperative (PIC4801H)
- ONSTAR- Unwanted Or Phantom Phone Calls (PIC3278G)
- Programming And Activation Of Replacement ONSTAR Modules (VCIM) (PIC5588C)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- Unable Place An ONSTAR Call With Ignition In On Position After 15-08-44-001 CANADA Upgrade (PIT5485B)
- No Connect With Disabled Vehicle Or Dropped Calls With 1234567890 Min (PIC5050A)
- Behavior Of Non-Upgraded ONSTAR® Equipped Vehicles Operating In CANADA After Decommissioning Of 2G CDMA Cellular Networks (16-NA-025)
- Caller Id Unavailable After ONSTAR Upgrade (PIT5464)
- Unable To Receive Incoming ONSTAR Or HFC (Hands Free Calling) Calls (PIC6101)
- Diagnostic Tip: Unable To Connect Or Use Hands Free Calling Or No Data On The Call (Failed To Voice) (PIC4310L)
- Information On Upgrading Certain ONSTAR® Analog/Digital-Ready Systems To ONSTAR® Generation 6 Digital-Capable System (05-48-46-006G)
- Diagnostic Tip: CANADIAN ONSTAR Subscriber Unable To Receive Turn-By-Turn Directions While Traveling In The United States (PIT5264C)
- Information On Aftermarket Device Interference With ONSTAR® Diagnostic Services (08-08-46-004A)
- OnStar® Phone Number Concerns (Phone Number Incorrect/Assigned to Another Vehicle/Phone) That Occur During Diagnosis of OnStar® System (05-08-46-004C)
- GM Training - July 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-031)
- Information Required Before Contacting GM Technical Assistance or When Ordering Replacement OnStar® VCIM (09-08-46-003)
- OnStar® Labor Operation Codes (05-08-46-005C)
- Servicing Vehicles Upgraded To ONSTAR® Generation 6 Digital-Capable System (Follow Information Below) (09-08-46-001)
- Information on OnStar® Dual-Mode (Analog/Digital) Systems (06-08-46-008C)
- OnStar® Generation 5 or 6 (Digital) System Inoperative/Has No Power, LED Light Not On (Remove/Reinstall OnStar® Fuse and Replace VCIM or Follow SI Diagnostics) (05-08-46-001D)
- OnStar® System Inoperative, OnStar® System Status Light is Red, Radio Locked in Phone Mode or DTC B1000 (Update Early Release Generation 5 OnStar® System Software) (04-08-46-004B)
- Availability of GM OnStar® Vehicle Diagnostics and GM Goodwrench® Remote Diagnostic Services (06-08-46-002B)
- Cataloging of Electronic Service Center Parts (06-00-89-016A)
- Incorrect OnStar® Global Positioning System (GPS) Location Reported During OnStar® Call (02-08-46-006C)
- Information on OnStar® Dual-Mode (Analog/Digital) Systems (06-08-46-008A)
- Information On ONSTAR System - Possible Loss Of GPS Signal, Hands-Free Calling Minutes Expire Prematurely And/Or Inability To Add Hands-Free Calling Minutes (02-08-46-007D)
- Programming OnStar(R) Module for Canadian French Voice Recognition (OnStar(R) Generation 5 or Generation 6) (02-08-46-010G)
- Unable to Connect to OnStar(R) or OnStar(R) Personal Calling Inoperative (04-08-46-003B)
- Parts Restriction on Ordering OnStar(R) Generation 5 and 6 Vehicle Communication Interface Modules (VCIM) (03-08-46-004A)
- Programming of Replacement OnStar(R) Vehicle Communication and Interface Modules (VCIM) (01-08-46-002D)
- OnStar(R) System Cellular Antenna Replacement Parts Availability (00-08-46-002A)
- OnStar(R) Proactive Parts Shipment Process (02-08-46-013A)
- Radio Telephone/Mobile Radio (Transceiver) Installation and Troubleshooting Guidelines (04-08-46-002)
- Cooling Fan
- Cooling System (Mechanical)
- Information On Ethylene Glycol In Transmission Fluid (08-07-30-035I)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Aluminum Heater Core and/or Radiator Replacement (73-62-13A)
- DEX-COOL® Coolant - New Leak Detection Dye J 46366 - Replaces J 29545-6 (05-06-02-002B)
- Engine Coolant Recycling and Warranty Information (00-06-02-006D)
- Instructions for Using GE-47716 Vac-N-Fill Coolant Refill Tool (05-06-02-006)
- DEX-COOL(R) Engine Coolant Information (736214)
- Differentials & Drive Axles
- Axle Vent Hose Fluid Leak (PIP3454A)
- Revised Front Drive Axle Carrier Lubricant Information (05-00-90-010)
- Revised Front and Rear Drive Axle Fluid Capacities and Wheel Nut Torque Specification (05-00-90-004)
- Clunk, Bump or Squawk when Vehicle Comes to Complete Stop or Accelerating from Complete Stop (Replace Rear Drive Shaft Nickel-Plated Slip Yoke) (01-04-17-004B)
- Revised Wheel Drive Shaft Nut Torque Specification (04-04-95-001)
- Advance Service Info - Fluid Leak From Front Of Vehicle (Add TEFLON Tape To Front Axle Vent/Plug Threads) (03-04-19-003)
- Adm Msg - 2003 HUMMER H2 Information on Parts Availability for Locking Rear Differential (HUS20020017)
- Driveshaft & Universal Joints
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Advance Service Info - Fluid Leak From Front Of Vehicle (Add TEFLON Tape To Front Axle Vent/Plug Threads) (03-04-19-003)
- Driveline Clunk When Stopping (Reprogram Powertrain Control Module (Pcm)) (03-07-30-028)
- Electronic Suspension
- GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
- 2003-2005 HUMMER H2 Rear Air Suspension Relay (HUS20050038-02)
- New Suspension Position Calibration Procedure Added (05-03-99-001)
- New Air Suspension Pressurization Procedure (04-03-99-001)
- Electronically Controlled Air Suspension (ECAS) DTC C0660 Set In History with No Light or Message (03-03-99-001)
- Service Air Suspension Message Diagnostic Trouble Code (DTC) C0711 And/Or Clicking Noise From Rear Of Vehicle With Ignition Off And/Or Electronic Controlled Air Suspension (ECAS) Compressor Cycles Too Frequently (Reprogram ECAS Control Module) (02-03-99-002)
- Engine Control Systems
- Diagnostic Tip For Misfire, Chirp, Squeak, Squeal Or Tick Noise, Malfunction Indicator Lamp (Mil) Illuminated - DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307 And/Or P0308 Set (PIP4138R)
- Catalytic Converter Break-In Information To Prevent DTCS P0420 And/Or P0430 (PIP3119P)
- SES Light With Fuel Trim And Or Oxygen Sensor Codes (PIP4925B)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Prior To Any Circuit Testing (PIP5094A)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- DTC P0300 Setting After Engine Repairs (PIP5169)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Revised Inspection/Maintenance (I/M) Evaporative Emission (EVAP) System Set Procedure (05-06-04-021)
- Idle Instability, Low or Rough Idle with Electronic Throttle Control (Clean Throttle Body) (04-06-04-040)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- SMU - Revised DTC P0336 (03-06-04-033A)
- SMU - Revised DTC P2135 (03-06-04-062)
- UPFITTER Bulletin - PTO Vs Fast Idle (UI 64)
- SMU - Revised DTC P1125 (03-06-04-031)
- SMU - Revised DTCS P0135, P0141, P0155 And P0161 (03-06-04-025)
- ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
- Entertainment Systems
- Diagnostic Tips: XM Audio Traffic And Travel Link Availability And Operation (PIT5353C)
- Programming And Activation Of Replacement ONSTAR Modules (VCIM) (PIC5588C)
- Information On Inappropriate Warranty Claims Submitted For Damaged Radios And Instrument Panel Clusters (IPCS) (08-08-44-015H)
- XM Band Not Receiving All Channels (Preview Mode) (PIC5088F)
- Return Or Reimbursement Of Customer Owned CDS, DVDS Or Navigation Discs (05-08-44-024E)
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- Information on Refurbish Instead of Replace Out of Warranty Radios with Worn Graphics on Faceplate, Knobs or Buttons (08-08-44-026)
- Utilizing Tech 2® To Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) (04-08-44-005C)
- Cataloging of Electronic Service Center Parts (06-00-89-016A)
- Information on Rear Seat Headphone Foam Ear Pad Replacement if Worn or Damaged (05-08-44-005A)
- Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
- Rear Seat Audio (RSA) and/or Rear HVAC Inoperative (Replace RSA Module) (03-08-44-018C)
- XM Radio Labor Operation Codes (03-08-44-001A)
- Global Position Sensor (GPS) Performance Degradation (00-08-46-003B)
- Compact Disc (Cd) Or DVD Player Skipping, Inoperative, Sluggish And/Or Long Search Times (05-08-44-001)
- Information on Error Codes on Radio Display - Their Cause and Corrective Action (64-90-04A)
- Radio Noise Heard In One Or More Speakers (03-08-44-009)
- Radio Automatic Volume Control Feature Inoperative (Rewire Noise Cancellation Microphone) (03-08-44-004)
- Diagnostic Information For No Audio Out Of Speakers On One Or More Channels (02-08-44-018)
- Loss Of Radio Audio Signal (HUS20020015)
- Selecting Radio Source Using Steering Wheel Controls (02-08-44-017)
- No Audio Out Of Speakers At Times (Reprogram Radio And/Or Replace Amplifier) (02-08-44-020B)
- Exhaust
- Catalytic Converter Break-In Information To Prevent DTCS P0420 And/Or P0430 (PIP3119P)
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- Exhaust Popping/Snapping Noise When Vehicle is Hot, at Idle, or Immediately After Vehicle is Shut Off (Replace Muffler Heat Shield) (03-06-05-008D)
- L59, LR4, LM4, LM7, LQ4, LQ9, LS1, LS6 New Exhaust Manifold Bolts and Torque Specifications for GEN III Vortec(tm) Engine (06-06-01-026)
- New Add Time For Labor Operation L2300 - Converter, Oxidation Catalytic-Replace (02-00-89-006C)
- Exhaust/Muffler Heat Shield Rattle, Popping Noise Under Vehicle (Install Heat Shield Retaining Straps on Muffler) (02-06-05-005C)
- Exterior Body Panels
- Underbody Component Corrosion (PI0281L)
- Non-Approval Of "Clipping" (Sectioning Of Two Vehicles) For Collision Repair (07-08-98-001B)
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Information On Hem Flange Sealer For Corrosion Protection (06-08-51-005C)
- Squeeze Type Resistance Spot Welding/Equipment (03-08-98-002B)
- Information on Usage of 2008-2009 Hoods for 2003-2007 Vehicle Repairs Due to Temporary Part Unavailability - Modification Required (10-08-98-001)
- Metal Panel Bonding (02-08-98-001C)
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- Revised Endgate Adjustment Procedure (06-08-66-002)
- Addition of Fuel Tank Shield Replacement Procedure (05-08-61-009)
- Loose Chrome Fuel Filler Door Assembly (Install Tape Kit) (05-06-04-072)
- New Liftgate Strut Ball Stud Tightening Specification (05-08-66-004)
- Usage of E85 Fuels in GM Vehicles (05-06-04-035)
- 2003, 2004, 2005 HUMMER H2 Underbody Snap/Pop Noise (HUS20050048)
- Revised Inspection/Maintenance (I/M) Evaporative Emission (EVAP) System Set Procedure (05-06-04-021)
- Adm Msg - 2003,2004, 2005 HUMMER H2 Propane Odor in the Vehicle (HUS20040020)
- Additional Material and Source for Metal Panel Bonding Adhesives (04-08-98-001)
- 2003, 2004, 2005 HUMMER H2 Transit Damage (HUS20040016)
- Squeak or Rattle Noise from Rear Liftgate (Remove Material/Adjust Striker) (04-08-59-001)
- Wind Whistle/WINDRUSH (Seal Front Door Sheet Metal) (03-08-58-001)
- Vehicle Is Difficult To Fill With Fuel Or Filling Station Pump Shuts Off Before Tank Is Full (Inspect Fuel Tank Vent Tube Opening And Replace Fuel Tank) (03-06-04-019)
- Rattle, Pop, Clunk, Oil Canning Noise From Left Front Of Vehicle (Dimple/Distort Left Front Upper Inner Frame Rail Panel, Inspect Torque Specifications, Adjust Hood) (03-08-63-001)
- Replacement Of Air Inlet Grille Panel Or End Cap Retainers When Damaged (03-08-111-001)
- Lower Liftgate Molding Appears Wavy, Loose Or Falls Off (Replace Lower Liftgate Molding) (02-08-66-011)
- Expandable Acoustic Foam (Two Component Sound Dampener) Usage With Collision Damage Repairs (02-08-98-003)
- Exterior Lights
- Exterior Lighting Components "Tinted Or Smoked" By An Outside Vendor (15-08-42-001A)
- Headlamp, Tail Lamp, License Lamp Or Fog/Driving Lamp Damage (02-08-42-001J)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- Availability of Replacement Rear Tail Lamp Outboard Retainer Clips After Lamp Assembly Removal/Repositioning For Bulb Replacement or Service (04-08-42-009)
- Trailer Brakes Applied When GM Accessory Roof-Mounted Off-Road Spot Lamps are On (Modify Roof-Mounted Off-Road Spot Lamp Wiring Harness) (04-08-42-003)
- Headlight Aim Too High (Adjust Aim) (03-08-42-003)
- ADM MSG - 2003 Hummer H2 Roof Marker Lamp Retention - New Part Numbers (HUG20020036)
- Warranty Admin. - Dealer Installed Regular Production Accessories (02-00-89-012)
- Frames, Subframes & Crossmembers
- Underbody Component Corrosion (PI0281L)
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Non-approval of "Clipping" (Sectioning of Two Vehicles) For Collision Repair (07-08-98-001A)
- Lower Body Cladding Discolored (Chalky) (Apply Coating) (08-08-111-003)
- Information on Repair of Polypropylene Energy Absorbers (63-20-02)
- 2003, 2004, 2005 HUMMER H2 Underbody Snap/Pop Noise (HUS20050048)
- Undercoating Peeling Off Frame (Clean Frame And Reapply Coating) (03-08-61-001)
- Rattle, Pop, Clunk, Oil Canning Noise From Left Front Of Vehicle (Dimple/Distort Left Front Upper Inner Frame Rail Panel, Inspect Torque Specifications, Adjust Hood) (03-08-63-001)
- Expandable Acoustic Foam (Two Component Sound Dampener) Usage With Collision Damage Repairs (02-08-98-003)
- Front Suspension
- Information On Diagnosis And Replacement Of Shock Absorber And Strut Due To Fluid Leak (72-05-12)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Vibration Analysis Worksheet (03-00-91-001I)
- Snap/Popping Type Noise Coming from Front of Vehicle (Remove Bolt-In Front Crossmember and Add Washers) (03-08-61-002I)
- Revised Lower Control Arm Replacement (07-03-08-002)
- SMU - Revised Upper Control Arm Replacement (06-03-08-002)
- Recommended Idler Arm Grease Fitting Due to Limited Access (03-00-90-001B)
- Revised Air Spring Compressor Replacement (05-03-99-003)
- Revised Stabilizer Shaft Link Replacement Procedure and Fastener Tightening Specifications (05-03-08-006)
- New Air Suspension Pressurization Procedure (04-03-99-001)
- Fuel System
- Top Tier™ Detergent Gasoline And Top Tier™ Diesel Fuel Information And Licensed Brands (05-06-04-022Q)
- Rough Idle Crank No Start Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves (PIP5029H)
- Usage Of E85 Fuel In Gm Vehicles (05-06-04-035E)
- DTC P0300 Setting After Engine Repairs (PIP5169)
- Fuel And Oil Additives - Facts And Myths - Maximizing Gasoline Fuel Economy (05-00-89-072F)
- Top Tier Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047L)
- Gm Fuel System Treatment Plus, Fuel Sending Unit Corrosion And Fuel System Deposits (05-00-89-078C)
- Use of E85 Fuels in Vehicles Not Certified by GM as being FlexFuel Compatible / Aftermarket Conversion of Vehicles to Operate on E85 Fuels (06-06-04-035A)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Usage of E85 Fuels in GM Vehicles (05-06-04-035)
- Revised Inspection/Maintenance (I/M) Evaporative Emission (EVAP) System Set Procedure (05-06-04-021)
- Idle Instability, Low or Rough Idle with Electronic Throttle Control (Clean Throttle Body) (04-06-04-040)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- SMU - Revised DTC P2135 (03-06-04-062)
- SMU - Revised DTC P1125 (03-06-04-031)
- SMU - Revised DTCS P0135, P0141, P0155 And P0161 (03-06-04-025)
- ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
- Fuses & Circuit Breakers
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Service Alert: Concerns With Aftermarket Fuses in GM Vehicles (07-08-45-002)
- Information on Changes to the SI Table of Contents, Electrical Connectors, Terminal Testing/Repair, and the Importance of J-38125 Electrical Terminal Repair Kit Maintenance (06-08-45-001)
- Diagnostic Information For No Audio Out Of Speakers On One Or More Channels (02-08-44-018)
- Gauges & Instrument Panels
- Verifying Odometer Accuracy (PIC3100G)
- IPC Odometer Programming Method Quick Reference Guide (07-08-49-020O)
- Information On Inappropriate Warranty Claims Submitted For Damaged Radios And Instrument Panel Clusters (IPCS) (08-08-44-015H)
- Fuel Gauge Fluctuation In Park Or Neutral (PIT3046G)
- Information on Instrument Panel Cluster (IPC) Odometer and Engine Hour Meter Set Up at Dealership After IPC Replacement (07-08-49-015D)
- Utilizing Tech 2® To Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) (04-08-44-005C)
- Cataloging of Electronic Service Center Parts (06-00-89-016A)
- PRNDL Display Reduced Visibility For Approximately One Minute (02-08-72-004A)
- Noise Coming From Instrument Panel Cluster (Replace Instrument Panel Cluster (IPC)) (04-08-49-015A)
- Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
- Instrument Panel (I/P), Body and General Wiring Harness Repair (06-08-45-004)
- Malfunction Indicator Lamp (MIL) On, Transmission Stuck in Second or Third Gear, Instrument Cluster Inoperative (Verify and Repair Source of Voltage Loss In Transmission Solenoid Power Supply Circuit) (01-07-30-002E)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Console Compartment Door Will Not Stay Closed (Replace Console Compartment Door Latch Assembly) (02-08-49-010)
- General Servicing
- Headlights
- Exterior Lighting Components "Tinted Or Smoked" By An Outside Vendor (15-08-42-001A)
- Headlamp, Tail Lamp, License Lamp Or Fog/Driving Lamp Damage (02-08-42-001J)
- Replacement of Headlamp Assemblies Under Warranty and Use of GM vs. Non-GM Headlamp Assemblies (08-08-42-005B)
- Headlight Aim Too High (Adjust Aim) (03-08-42-003)
- Heated Glass/Defoggers
- Hoist/Jack
- HVAC Control Systems
- Ac Blows Warm Or Poor Performance (PIT5099H)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Air Conditioning Odor (Install Evaporator Core Dryer Kit And Apply Cooling Coil Coating) (99-01-39-004I)
- Diagnostic Tips For Odor Emanating From HVAC System (PI1440)
- Information On Aluminum Heater Core and/or Radiator Replacement (73-62-13A)
- Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
- 18 Digit "Snapshot/Charge Summary" Code No Longer Required For A/C Refrigerant System Repairs Submitted For Warranty Reimbursement (05-01-38-008B)
- Blower Motor Inoperative or May Not Shut Off in Extremely Low Ambient Temperature Conditions (Replace Blower Motor Control Module) (06-01-39-002C)
- HVAC Blower Motor Inoperative or Stays Running (Replace Blower Motor Control Module) (04-01-39-009C)
- Contaminated R134a Refrigerant Found on Market for Automotive Air-Conditioning Systems (06-01-39-007)
- Intermittent Heated Seats Inoperative, DTC B3941 Set (Reprogram Driver Seat Module) (05-08-50-008)
- 2003-2005 HUMMER H2 Sunroof Drain Hose (HUS20050035)
- HVAC Module External Seal Kit Now Available For Service Use (04-01-38-018)
- Diagnostic Information for Moan, Groan or Boom Noise at Idle, Vibration in Steering Wheel or Felt Through Floor When A/C Compressor Engages - Do Not Replace A/C Compressor (04-01-38-015)
- HVAC Not Cold Enough, A/C Compressor Does Not Engage (Repair Engine Compartment Wiring Harness Near Idler Arm) (04-01-38-013)
- Contaminated R-134a A/C Systems - Air Conditioning System Flushing Procedures and Universal In-Line A/C Filter Installation (83-12-21)
- J-43600 ACR 2000 Essential Refrigerant Recovery/Recharge Equipment (99-01-38-006B)
- Service Information for Front Heated Seat Inoperative/Cold (04-08-50-007)
- HVAC Control Knob Replacement (04-01-37-001)
- Passenger Compartment Air Filter - Aftermarket Dirt Dust HVAC Information Interior Part (PI01348)
- Insufficient HVAC System Cooling, Hissing Noise On Engine Shut Off (Inspect/Reposition Orifice Tube) (03-01-39-010)
- J 44551 A/C Suction Screen Kit Repair Recommendations And Procedures After Catastrophic Compressor Failures (01-01-39-003A)
- A/C Refrigerant System Sealer And A/C System Leak Detection Guidelines (03-01-38-001)
- Automatic Air Conditioning Control Operation (99-01-39-007B)
- Identification
- Ignition Switch/Steering Lock
- Ignition System
- Information on New Spark Plugs and Gapping (03-06-04-060B)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Infotainment
- DVD Navigation Update Program, Navigation Disc Diagnostic Aid, AVN Software Update Discs And Ordering Information (06-08-44-012G)
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Information On Navigation Radio Not Displaying Accurate Vehicle Location After Radio Replacement, Power Loss Or Battery Replacement (08-08-44-023A)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- Navigation Radio Diagnostic Tips (08-08-44-010F)
- Cataloging of Electronic Service Center Parts (06-00-89-016A)
- Incorrect OnStar® Global Positioning System (GPS) Location Reported During OnStar® Call (02-08-46-006C)
- Information On ONSTAR System - Possible Loss Of GPS Signal, Hands-Free Calling Minutes Expire Prematurely And/Or Inability To Add Hands-Free Calling Minutes (02-08-46-007D)
- Information on Obtaining Replacement Navigation Discs When Radios are Exchanged - Order Replacement Navigation Disc Through Navigation Disc Center (07-08-44-007)
- Unable to Connect to OnStar(R) or OnStar(R) Personal Calling Inoperative (04-08-46-003B)
- OnStar(R) System Cellular Antenna Replacement Parts Availability (00-08-46-002A)
- Global Position Sensor (GPS) Performance Degradation (00-08-46-003B)
- Interior/Exterior Trim
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Normal Characteristic - Passenger Compartment Air Filter (PIT3330G)
- Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including Chevy Bowtie (Bulletin Cancelled) (06-08-111-004B)
- Information on Maintaining Exterior Weatherstrip Appearance (99-08-64-016C)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- Lower Body Cladding Discolored (Chalky) (Apply Coating) (08-08-111-003)
- Stone Impingement/Corrosion in Weld Area of Tubular Assist Step (Install New Tubular Assist Step) (06-08-61-006)
- Loose Chrome Fuel Filler Door Assembly (Install Tape Kit) (05-06-04-072)
- Upper Windshield Molding Now Available - Molding Gaps to Roof (05-08-48-002A)
- Door Squeak/Rattle (Replace Door Trim Retainers) (05-08-64-025)
- 2003-2005 HUMMER H2 Door Panel Rattles (HUS20050047)
- 2003, 2004, 2005 HUMMER H2 Underbody Snap/Pop Noise (HUS20050048)
- 2003-2005 HUMMER H2 Door Panel Rattles (HUS20050046)
- 2003, 2004, 2005 HUMMER H2 "A" Pillar Reveal Molding Rattle (HUS20050037)
- 2003, 2004, 2005 HUMMER H2 Shifter Rattle (HUS20050040)
- Paint Peeling From Side Assist Step (Repaint Assist Step) (03-08-61-003A)
- 2003-2005 HUMMER H2 Upper Windshield Molding Replace (HUS20040024)
- Adm Msg - 2003,2004, 2005 HUMMER H2 Propane Odor in the Vehicle (HUS20040020)
- 2003, 2004 HUMMER H2 Roof Rack Cross Bar Rattles (HUS20040010)
- SMA Spare Tire Carrier May Rattle Over Rough Surfaces, T-Pin Lock Difficult To Remove (Install Revised Latch Isolator And Verify Installation Of Anti-Rotation Bolts In Hinge Bracket) (03-08-66-011)
- HOMELINK Transceiver/Garage Door Opener Transmitter Test Kit (01-08-97-001B)
- Rattle In Sunroof Area At Highway Speeds (03-08-67-003)
- Luggage Carrier Cross Rail Wind Rush Noise With Sunroof Open (Adjust Rail) (03-08-67-002)
- Replacement Of Air Inlet Grille Panel Or End Cap Retainers When Damaged (03-08-111-001)
- Console Compartment Door Will Not Stay Closed (Replace Console Compartment Door Latch Assembly) (02-08-49-010)
- Lower Liftgate Molding Appears Wavy, Loose Or Falls Off (Replace Lower Liftgate Molding) (02-08-66-011)
- ADM MSG - 2003 Hummer H2 Roof Marker Lamp Retention - New Part Numbers (HUG20020036)
- ADM MSG - 2003 Hummer H2 Windshield To A Pillar Moldings Loose Or Come Off (HUS20020013)
- Warranty Admin. - Dealer Installed Regular Production Accessories (02-00-89-012)
- Headliner Sag (Install Fastener) (02-08-110-003A)
- Lubrication System
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Information For Engine Concerns Resulting From Lack Of Scheduled Maintenance, Improper Service Or Aftermarket Calibrations (16-NA-222)
- Higher Than Expected Oil Consumption At 8600 GVW And Above (03-06-01-023C)
- Fuel And Oil Additives - Facts And Myths - Maximizing Gasoline Fuel Economy (05-00-89-072F)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- Oil Leak Under Extreme Cold Temperatures (-34°C (-30°F) or Colder) (Install Vented Oil Fill Cap) (05-06-01-014)
- Manual Steering
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Diagnosing Power Steering Concerns (05-02-32-008F)
- Vibration Analysis Worksheet (03-00-91-001I)
- Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013B)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Manual Trans
- Information On Driveline Clunk Noise (99-04-20-002O)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Vibration Analysis Worksheet (03-00-91-001I)
- Instructions To Be Followed To Aid in Obtaining Root Cause Analysis on Both OEM and Goodwrench(R) Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
- Mechanical
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Engine Repair Tip For Installation Of Pistons (PI1394B)
- Diagnostic Tip For Misfire, Chirp, Squeak, Squeal Or Tick Noise, Malfunction Indicator Lamp (Mil) Illuminated - DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307 And/Or P0308 Set (PIP4138R)
- Information For Engine Concerns Resulting From Lack Of Scheduled Maintenance, Improper Service Or Aftermarket Calibrations (16-NA-222)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- Possible Engine Oil Leak Due To PCV Freeze-Up (PIP3343F)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Rough Idle Crank No Start Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves (PIP5029H)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- Vibration Analysis Worksheet (03-00-91-001I)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- 5.3L, 5.7L, 6.0L, 6.2L, 7.0L - Engine Oil Leak at Rear Cover Assembly Area (Engine Block Porosity RTV Repair Procedure) (05-06-01-034L)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Service Information Update on Consolidating Use of GM Liquid Gasket/Engine Sealants and New Sealant Dispenser GE-48326 Essential Tool (05-06-01-010B)
- GM Performance Parts Engine Warranty Q & A (04-06-01-019A)
- Information on Revised Connecting Rod Bolt Torque for Small Block GEN III and GEN IV Vortec(tm) V8 Engines (07-06-01-002)
- Revised Mass Air Flow Core Return Requirements (06-06-04-057)
- Instructions To Be Followed To Aid in Obtaining Root Cause Analysis on Both OEM and Goodwrench(R) Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
- Oil Leak Under Extreme Cold Temperatures (-34°C (-30°F) or Colder) (Install Vented Oil Fill Cap) (05-06-01-014)
- Idle Instability, Low or Rough Idle with Electronic Throttle Control (Clean Throttle Body) (04-06-04-040)
- Needle Bearings Found In Oil Pan (Replace Rocker Arms) (02-06-01-029)
- Mechanical - Hydraulic
- Brake Pedal Moves Or Self Applies At Full Turns (PIT3665M)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Brake Lathe Calibration Procedure (VSS20040074)
- Vibration Analysis Worksheet (03-00-91-001I)
- Information On Resurfacing Park Brake Portion Of Rear Brake Rotor (12-05-26-001)
- Front Brake Squeal/Squeak Noise (Replace Front Brake Pads) (08-05-23-004)
- On-Car Brake Lathe Specifications and Maintenance Requirements (05-05-22-001)
- Memory Modules
- Mirrors
- Information On Curb Park Assist And Memory Related Issues On Outside Rearview Mirrors (07-08-64-022B)
- Outside Rearview Mirrors May Blow In At Highway Speeds or Power Folding Feature Appears Inoperative (Synchronize Mirrors) (03-08-64-010C)
- New Outside Rearview Mirrors Available (06-08-64-007)
- Outside Rearview Mirrors (HUS20050065)
- 2003-2005 HUMMER H2 Outside Rearview Mirror Head Vibrates (VSS20040161)
- Wind Whistle/WINDRUSH (Seal Front Door Sheet Metal) (03-08-58-001)
- Info - Cycling Power Folding Exterior Mirror To Remain In Locked Position After Transport (02-08-64-022)
- Paint & Coatings
- Refinishing Aluminum And Chrome Wheels (99-08-51-007G)
- Application Of Anti-Corrosion Materials (01-08-51-003E)
- Information On Hem Flange Sealer For Corrosion Protection (06-08-51-005C)
- Pre-Painting/Cleaning Process For TPO Plastic Fascias (08-08-51-002A)
- Warranty Information-Fascia Refinish Labor Operations (10-08-62-003)
- Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) (43-17-01B)
- Paint Peeling From Side Assist Step (Repaint Assist Step) (03-08-61-003A)
- Additional Material and Source for Metal Panel Bonding Adhesives (04-08-98-001)
- 2003, 2004, 2005 HUMMER H2 Transit Damage (HUS20040016)
- Parking Brake System
- Passive Restraints
- Power Takeoff
- Rear Suspension
- Information On Diagnosis And Replacement Of Shock Absorber And Strut Due To Fluid Leak (72-05-12)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Rear Air Suspension Compressor Service Part Change Information (PIT3137C)
- Vibration Analysis Worksheet (03-00-91-001I)
- Revised Air Spring Compressor Replacement (05-03-99-003)
- Revised Shock Absorber Bolt Tightening Specification (05-03-09-007)
- 2003-2005 HUMMER H2 Rear Air Suspension Relay (HUS20050038-02)
- 2003-2005 HUMMER H2 Rear Air Suspension Leak-Down (HUS20050036)
- Vehicle Sits Low Or The Suspension Sags Overnight (PIT3509)
- 2003, 2004, 2005 HUMMER H2 Rear Air Suspension (HUS2005034)
- 2003, 2004 HUMMER H2 Rear Air Suspension Compressor Service Part Change (HUS20040023)
- New Air Suspension Pressurization Procedure (04-03-99-001)
- Service Air Suspension Message Diagnostic Trouble Code (DTC) C0711 And/Or Clicking Noise From Rear Of Vehicle With Ignition Off And/Or Electronic Controlled Air Suspension (ECAS) Compressor Cycles Too Frequently (Reprogram ECAS Control Module) (02-03-99-002)
- Restraints Control Systems
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Prior To Any Circuit Testing (PIP5094A)
- Seat Belt Buckle Latching Issues And/Or Seat Belt Warning Lights Illuminated (09-09-40-001C)
- New SIR System Disabling and Enabling Procedure (05-09-41-010)
- Seats
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Seat Belt Extender Availability (99-09-40-005H)
- Information On Driver Or Passenger Seat Head Restraint Concerns With Comfort, Custom Upholstery Or Other Comfort Enhancing Devices (10-08-50-003A)
- Minor Wrinkles/Creases, Discoloration, Cigarette Burns and Customer Induced Cuts and Stains on Front and Rear Driver and Passenger Seats with Leather, Vinyl or Cloth Seat Covers (04-08-50-006D)
- Unwanted/Loose Seat Movement (Apply Adhesive and Install New Bolts in Seat Mounting Rails) (05-08-50-012A)
- Intermittent Heated Seats Inoperative, DTC B3941 Set (Reprogram Driver Seat Module) (05-08-50-008)
- Memory Seat May Not Return to Requested Position (Reprogram Driver Seat Module) (04-08-50-016C)
- 2003, 2004, 2005 Silverado and Sierra, Tahoe, Yukon, Avalanche, Suburban, Yukon XL, Escalade, Escalade EXT and ESV, and HUMMER H2 Power Seat Will Not Retain Preset Memory Position (VSS20050521)
- Power Seat Switch Works In The Opposite Direction - Keywords An3 Driver Electrical Intermittent Memory Module Move Operation Recall Reverse RKE (PIT3598)
- Enabling Memory Seat Feature via DIC If Feature Appears Inoperative (04-08-50-003)
- Service Information for Front Heated Seat Inoperative/Cold (04-08-50-007)
- Seat Heater And/Or Memory Power Seat Inoperative (Replace Memory Seat Control Module) (03-08-50-003)
- Starter
- Cold Weather And Long Stand Time Battery Maintenance And Testing Tips (15-06-03-001F)
- Warranty Administration - Battery Testing And Warranty Replacement Requirements (North AMERICA Only) (03-06-03-004Z)
- ACDELCO® Replacement Battery Warranty Procedures (03-06-03-003D)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- GM Dealer Visits: Proper Management of Batteries in Dealer Parts Stock / Vehicle Inventory (08-06-03-005)
- Battery and Charging System Electrical Diagnostics (99-06-03-012)
- Battery Charging Tips (Includes Information References for HP2 Hybrid Truck [PHT] 42-volt System) (02-06-03-009C)
- Automatic Dual Zone HVAC Battery Draw (02-01-39-007B)
- Starter Cranks After Key Is Released (Normal Condition) (03-06-03-001D)
- Intermittent No Crank, No Start (03-06-03-006A)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Battery Specification Label (04-06-03-016)
- Battery Parasitic Drain (02-06-03-010A)
- Steering Column
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Clunking Noise Under Hood and Can Be Felt in Steering Wheel and/or Steering Column (Replace Upper Intermediate Steering Shaft [I-Shaft] Assembly) (00-02-35-003N)
- SMU - Revised Steering Wheel Replacement Procedure (03-02-35-006)
- Selecting Radio Source Using Steering Wheel Controls (02-08-44-017)
- Steering Control Systems
- Steering Gear
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- 2003, 2004, 2005 HUMMER H2 Sun Roof Motors (HUS20050050)
- 2003-2005 HUMMER H2 Sunroof Drain Hose (HUS20050035)
- Water Leak From Sunroof Area (Replace Drain Hoses) (03-08-57-002)
- Rattle In Sunroof Area At Highway Speeds (03-08-67-003)
- Luggage Carrier Cross Rail Wind Rush Noise With Sunroof Open (Adjust Rail) (03-08-67-002)
- Suspension Control Systems
- Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
- Revised Air Spring Compressor Replacement (05-03-99-003)
- 2003-2005 HUMMER H2 Rear Air Suspension Relay (HUS20050038-02)
- New Suspension Position Calibration Procedure Added (05-03-99-001)
- 2003-2005 HUMMER H2 Rear Air Suspension Leak-Down (HUS20050036)
- Vehicle Sits Low Or The Suspension Sags Overnight (PIT3509)
- 2003, 2004, 2005 HUMMER H2 Rear Air Suspension (HUS2005034)
- New Air Suspension Pressurization Procedure (04-03-99-001)
- Electronically Controlled Air Suspension (ECAS) DTC C0660 Set In History with No Light or Message (03-03-99-001)
- Service Air Suspension Message Diagnostic Trouble Code (DTC) C0711 And/Or Clicking Noise From Rear Of Vehicle With Ignition Off And/Or Electronic Controlled Air Suspension (ECAS) Compressor Cycles Too Frequently (Reprogram ECAS Control Module) (02-03-99-002)
- System
- Diagnostic Tip For Misfire, Chirp, Squeak, Squeal Or Tick Noise, Malfunction Indicator Lamp (Mil) Illuminated - DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307 And/Or P0308 Set (PIP4138R)
- SES Light With Fuel Trim And Or Oxygen Sensor Codes (PIP4925B)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Prior To Any Circuit Testing (PIP5094A)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Usage Of E85 Fuel In Gm Vehicles (05-06-04-035E)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Diagnostic Trouble Codes (DTCs) Required On Repair Orders (06-00-89-050B)
- Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
- Normal Characteristics of Malfunction Indicator Lamp (MIL) During On-Board Diagnostic (OBD) Inspection/Maintenance (I/M) Testing (06-06-04-037)
- Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Oil Leak Under Extreme Cold Temperatures (-34°C (-30°F) or Colder) (Install Vented Oil Fill Cap) (05-06-01-014)
- Revised Inspection/Maintenance (I/M) Evaporative Emission (EVAP) System Set Procedure (05-06-04-021)
- Idle Instability, Low or Rough Idle with Electronic Throttle Control (Clean Throttle Body) (04-06-04-040)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- SMU - Revised DTC P0336 (03-06-04-033A)
- SMU - Revised DTC P2135 (03-06-04-062)
- UPFITTER Bulletin - PTO Vs Fast Idle (UI 64)
- SMU - Revised DTC P1125 (03-06-04-031)
- SMU - Revised DTCS P0135, P0141, P0155 And P0161 (03-06-04-025)
- ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
- Towing
- Recreational (Dinghy) Towing (00-00-89-008F)
- Trailer Brakes Applied When Headlights/Park Lamps Are On, Brake Controller Illumination (Modify Brake Controller Wiring Harness) (02-05-22-004C)
- Trailer Brakes Applied When GM Accessory Roof-Mounted Off-Road Spot Lamps are On (Modify Roof-Mounted Off-Road Spot Lamp Wiring Harness) (04-08-42-003)
- Shift Stabilization And Tow/Haul Mode Feature For Hydra-MATIC 4L60-E/4L65-E And 4L80-E/4L85-E Transmissions (99-07-30-022A)
- Transfer Case
- Driveline Characteristics For All-Wheel Drive (AWD) and Four-Wheel Drive (4WD) Systems (01-04-18-001F)
- Instructions To Be Followed To Aid in Obtaining Root Cause Analysis on Both OEM and Goodwrench(R) Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
- Updated Transfer Case Connector Service Kit Now Available For Transfer Case Speed Sensor Wire Harness Connector that Comes Loose Or Connector Retainer Clip Breaks (06-04-21-001)
- Transfer Case Bushing/Slip Yoke Leak, Transmission Downshifting, Loss Of Power, Vehicle Will Not Move (Replace Damaged Components/Install New Longer Style Propeller Shaft) (03-04-21-002)
- Transmission Control Systems
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Prior To Any Circuit Testing (PIP5094A)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Information On 2-3 Upshift Or 3-2 Downshift Clunk Noise (01-07-30-042H)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- Diagnostic Information on Diagnostic Trouble Code (DTC) P0894 and P1870 (08-07-30-008A)
- Automatic Transmission Shift Lock Control Actuator Available for Service Use (05-07-129-001B)
- Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
- Information Regarding Automatic Transmission Shift Lock Control Function (03-07-30-043A)
- Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
- Malfunction Indicator Lamp (MIL) On, Transmission Stuck in Second or Third Gear, Instrument Cluster Inoperative (Verify and Repair Source of Voltage Loss In Transmission Solenoid Power Supply Circuit) (01-07-30-002E)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- 2003, 2004, 2005 HUMMER H2 Shifter Rattle (HUS20050040)
- 1-2, 2-3, 3-4, 4-5 Shift and Torque Converter Clutch (TCC) Characteristics During Cold Weather Operation on 4L60-E, 4L80-E or Allison Transmissions (01-07-30-031A)
- Driveline Clunk When Stopping (Reprogram Powertrain Control Module (Pcm)) (03-07-30-028)
- Shift Stabilization And Tow/Haul Mode Feature For Hydra-MATIC 4L60-E/4L65-E And 4L80-E/4L85-E Transmissions (99-07-30-022A)
- ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
- Diagnostic Information For Intermittent Transmission Downshift, Slip, Busy/Cycling TCC Or Noisy Cooling Fan (99-07-30-016B)
- Wheel Alignment
- Refinishing Aluminum And Chrome Wheels (99-08-51-007G)
- Wheel Alignment Specifications, Requirements And Recommendations For Gm Vehicles (05-03-07-009H)
- Missing Alignment Dowel Pin (PI02003D)
- Revised Front Caster and Camber Adjustment Procedure (02-03-07-002A)
- New Alignment Procedure For Labor Operation Numbers E2020 and E2000 (04-03-07-002A)
- SMU - Revised Front Caster And Camber Adjustment Procedure (02-03-07-002)
- Wheels & Tire System
- Guidelines When Changing Tire And Wheel Size (PIT3271P)
- Vibration Shortly After Tires Are Mounted/Preventing Vibration From Wheel Slip (Tire Sliding On Wheel) (12-03-10-001E)
- Information On Proper Tire Pressure (00-00-90-002M)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5338B)
- Information On Hunter Road Force Balancer (17-NA-170)
- Non-Design Intent Wheel Lock Nuts And Lug Nuts (17-NA-126)
- Information On Tire/Wheel Characteristics (Vibration, Balance, Shake, Flat Spotting) Of Gm Original Equipment Tires (03-03-10-007J)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Use Of Nitrogen Gas In Tires (05-03-10-020F)
- Statement On Tire Sealant Included In Gm Inflator Kits (Supplied With New Vehicles Or As Gm Accessory) (09-03-10-013B)
- Wheel Balancing Machine Finish Damage To Chrome Clad Or CHROMETECH® Wheels (09-03-10-016A)
- General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015B)
- Guidelines for Using Labor Operations E0200, E0201, E0203, E0204 - Wheel Balance (72-05-03)
- Information on Proper Wheel Changing Procedures and Cautions (06-03-10-010A)
- Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (93-U-57)
- Tire Puncture Repair Procedures For All Cars and Light Duty Trucks (04-03-10-001F)
- Information on Replacement Wheel Weights (09-03-10-017)
- Mounting, Balancing And Installation Of Accessory Wheels And Tires Available Through Gm Accessories (08-03-10-004A)
- Use of Chrome or Chrome Plated Steel Valve Caps on Aluminum Valve Stems (08-03-10-005A)
- Minimizing Damage to Tire Pressure Monitor (TPM) Sensors During Tire Mounting/Dismounting (08-03-10-007)
- Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
- Driveline Characteristics For All-Wheel Drive (AWD) and Four-Wheel Drive (4WD) Systems (01-04-18-001F)
- Pitting and Brake Dust on Chrome Wheels (04-03-10-012B)
- Spare Tire Carrier Hinge Lubrication (08-03-10-001)
- Proper Use of OEM Service Wheel Weights, Marring and/or Damage Due to Use of Non-OEM and/or Incorrect Wheel Weight Installation (06-03-10-004)
- Use Recommended Tire Mounting Lubricant To Prevent Tires From Slipping on Chrome Wheels (T-93-93)
- Revised Front and Rear Drive Axle Fluid Capacities and Wheel Nut Torque Specification (05-00-90-004)
- SMA Spare Tire Carrier May Rattle Over Rough Surfaces, T-Pin Lock Difficult To Remove (Install Revised Latch Isolator And Verify Installation Of Anti-Rotation Bolts In Hinge Bracket) (03-08-66-011)
- Recommended Wheel Nut/Bolt Torque Specifications (02-03-10-008)
- Wheel Balance Weight Usage (99-03-10-009A)
- Window Motors & Regulators
- Information On Side Door Window Glass Chipping Caused By Hanging Vehicle Key Lock Box (06-08-64-001D)
- Repair Information For Reconnection Of Rear Window (Defroster) Contact Or Tab (03-08-48-006J)
- Distortion in Outer Surface of Vehicle Glass (00-08-48-005D)
- Marks/Stains on Windshield When Wet (Clean Windshield) (09-08-48-002A)
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- Upper Windshield Molding Now Available - Molding Gaps to Roof (05-08-48-002A)
- 2003-2005 HUMMER H2 Upper Windshield Molding Replace (HUS20040024)
- Guidelines To Prevent Cracks In Replacement Windshields (03-08-48-004)
- Squeak Noise When Window Is Raised (Adjust Window) (03-08-64-008)
- Wiper/Washer Systems
- Windshield Wiper Performance, Cleaning Instructions And Maintenance (06-08-43-003E)
- Separate Serviceability for Rear Wiper Module and Motor (05-08-43-008)
- Availability of Windshield Wiper Motor Cover/Module From GMSPO (05-08-43-007)
- 2003, 2004, 2005 HUMMER H2 Windshield Wiper Pulse Function (HUS20050031)
- Replacement of Windshield Wiper Inserts (04-08-43-003)
- Rear Window Washer Spray Nozzle Drips And/Or Extended Pump Run Time For Washer To Spray (Install Rear Window Washer Check Valve) (02-08-43-004)
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Prior To Any Circuit Testing (PIP5094A)
- Information on Changes to the SI Table of Contents, Electrical Connectors, Terminal Testing/Repair, and the Importance of J-38125 Electrical Terminal Repair Kit Maintenance (06-08-45-001)
- Trailer Brakes Applied When Headlights/Park Lamps Are On, Brake Controller Illumination (Modify Brake Controller Wiring Harness) (02-05-22-004C)
- UPFITTER Bulletin - Modified Brake Controller Wiring Harness (UI 57)