ESC (Electronic Stability Control) System
- Components (1)
- Description of ESC
- ESC Operation Mode
- EBD (Electronic Brake-Force Distribution) Operation
- ESC Circuit Diagram (1)
- ESC Circuit Diagram (2)
- ESC Circuit Diagram (3)
- ESC Connector Input/Output
- Failure Diagnosis
- Scan Tool Check
- Standard Flow of Diagnostic Troubleshooting
- Problem Symptoms Table
- Notes
- ABS Does Not Operate
- ABS Does Not Operate (Intermittently)
- Communication with Scan-Tool is not possible. (Communication with any system is not possible)
- Communication with Scan Tool is not possible. (Communication with ABS only is not possible)
- When Ignition Key Is Turned ON (engine OFF), The ABS Warning Lamp Does Not Light Up
- Even After The Engine Is Started, The ABS Warning Lamp Remains ON
- Bleeding of Brake System
- Diagnostic Trouble Codes (DTC)
- Notes
- DTC C1101: Battery Voltage High
- DTC C1102: Battery Voltage Low
- DTC C1200: Wheel Speed Sensor Front-LH Open/Short
- DTC C1201: Wheel Speed Sensor Front-LH Range/Performance/Intermittent
- DTC C1202: Wheel Speed Sensor Front-LH Invalid/no Signal
- DTC C1203: Wheel Speed Sensor Front-RH Open/Short
- DTC C1204: Wheel Speed Sensor Front-RH Range/Performance/Intermittent
- DTC C1205: Wheel Speed Sensor Front-RH Invalid/no Signal
- DTC C1206: Wheel Speed Sensor Rear-LH Open/Short
- DTC C1207: Wheel Speed Sensor Rear-LH Range/Performance/Intermittent
- DTC C1208: Wheel Speed Sensor Rear-LH Invalid/no Signal
- DTC C1209: Wheel Speed Sensor Rear-RH Open/Short
- DTC C1210: Wheel Speed Sensor Rear-RH Range/Performance/Intermittent
- DTC C1211: Wheel Speed Sensor Rear-RH Invalid/no Signal
- DTC C1235: Primary Pressure Sensor-Electrical
- DTC C1237: Primary Pressure Sensor-Signal
- DTC C1260: Steering Angle Sensor Circuit-Signal
- DTC C1261: Steering Angle Sensor Not Calibrated
- DTC C1274: Longitudinal G Sensor-Electrical
- DTC C1275: Longitudinal G Sensor-Range/Performance
- DTC C1282: Yaw Rate & Lateral G Sensor-Electrical
- DTC C1283: Yaw Rate & Lateral G Sensor-Signal
- DTC C1353: Pressure sensor (Wh1) - electrical
- DTC C1354: Pressure sensor (Wh1) - Other
- DTC C1355: Pressure sensor (Wh2) - electrical
- DTC C1356: Pressure sensor (Wh2) - Other
- DTC C1357: SCC or DBF deceleration plausibility error
- DTC C1358: AVH not available due to EPB in Emergency Release
- DTC C1359: SCC Control Unit Error
- DTC C1503: TCS/ESC (ESP) Switch error
- DTC C1513: Brake switch error
- Component Location
- General Description
- DTC Description
- DTC Detecting Condition
- Diagnostic Circuit Diagram
- Monitor Scantool Data
- Terminal and Connector Inspection
- Signal Circuit Inspection (In case of brake-pedal released)
- Signal Circuit Inspection (In case of brake-pedal pressed)
- Component Inspection
- Verification of Vehicle Repair
- DTC C1604: ECU Hardware Error
- DTC C1605: CAN Hardware error
- DTC C1611: CAN Time-out ECM
- DTC C1612: CAN Time-out TCM
- DTC C1613: CAN signal error ECM (Check ECM)
- DTC C1616: CAN Communication Bus Off
- DTC C1623: CAN Time-out Steering Angle Sensor
- DTC C1626: Implausible Control
- DTC C1638: CAN time-out SCC
- DTC C1648: CAN signal error ECM for SCC (Check ECM)
- DTC C1649: CAN time-out ECM for SCC
- DTC C1650: CAN signal error SCC
- DTC C1651: CAN time out EPB
- DTC C1652: CAN signal error EPB
- DTC C1653: CAN time-out Cluster for SCC
- DTC C1654: CAN time-out Cluster for EPB
- DTC C1655: CAN signal error TCU for EPB
- DTC C1702: Variant Coding Error
- DTC C2112: Valve Relay Error
- DTC C2227: Excessive Temperature Of Brake Disc
- DTC C2228: CAN Signal error TCM for SCC
- DTC C2312: Front-LH Valve error (Outlet Valve)
- DTC C2308: Front-LH Valve error (Inlet Valve)
- DTC C2316: Front-RH Valve error (Inlet Valve)
- DTC C2320: Front-RH Valve error (Outlet Valve)
- DTC C2324: Rear-LH Valve error (Inlet Valve)
- DTC C2328: Rear-LH Valve error (Outlet Valve)
- DTC C2332: Rear-RH Valve error (Inlet Valve)
- DTC C2336: Rear-RH Valve error (Outlet Valve)
- DTC C2366: TC Valve Primary (USV1) Error
- DTC C2370: TC Valve Secondary (USV2) Error
- DTC C2372: Electronic Shuttle Valve Primary (HSV1) Error
- DTC C2374: Electronic Shuttle Valve Secondary (HSV2) Error
- DTC C2380: ABS/TCS/ESP valve error
- DTC C2402: Motor Failure
- ESC Control Unit
- Front Wheel Speed Sensor
- Rear Wheel Speed Sensor
- Yaw-rate and Lateral G Sensor
- ESC OFF Switch
- Steering Angle Sensor