Technical Service Bulletins
- A/C Compressor
- New Sae J2788 Refrigerant Recovery Standard (IB07-12-S004)
- Contaminated R134A Refrigerant Found On Market For Automotive Air-Conditioning Systems (IB06-12-S001)
- Replacement Of The Receiver Drier During Air Conditioning Repair And Service (IB00-12-S002)
- R-12 To R-134A A/C System Conversion/Retrofit Procedures (Supersedes Sb00-12-S002) (SB00-12-S004)
- A/C FREON Blends Warning (SB92-12-003)
- A/C FREON Recovery Caution (SB91-12-002)
- A/C Diagnosis Chart (SB91-12-001)
- A/C Compressor Updated Wiring Diagram (SB90-04-007)
- Accessories Control Systems
- Aerodynamic Devices
- Air Bag, SRS
- Anti-Theft Systems
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Misfire DTC'S And Catalytic Converter Damage Due To Installation Of Alarm Systems (IB04-03-S001)
- CURTIS Key Code Cutter And Application Listing (SB03-14-S001)
- Rear Seat HOLDDOWN Hook Warm - Cover (SB89-11-007)
- Automatic Trans
- Automatic Transmission Flushing Procedure (IB02-05-S004)
- LOCTITE/PERMATEX Cross-Reference Chart (SB99-14-S001)
- Propylene Glycol Based Engine Coolant (SB96-14-L002)
- Propylene Glycol-Based Engine Coolant Warning (SB94-14-005)
- DEXRON-IIE A/T And Power Steering Fluid (SB93-14-003)
- A/C FREON Blends Warning (SB92-12-003)
- 2.6L Eng 4L30E Trans Hum - New Oil Cooler Bypass VLV (SB91-05-001)
- 2.6L Eng Aw30/80LE/ Trans Noise Under Load (SB91-05-001)
- Speedo Bounce/Noise - Modify Speedo Cable Length (SB89-04-005)
- A/T Shifting Characteristics (SB89-05-006)
- Torque CONV. Cycling - Proper Operation/Repair Info (SB89-05-006)
- Auxiliary Emission Control Systems
- Specified Major Emission-Control Components Defect Warranty Coverage Enhancement (WB07-L004)
- Reprogramming Of Powertrain Control Modules (Pcm) (IB03-14-S002)
- Air Regulator Specifications/Testing (SB90-03-003)
- Catalytic Converter/Exhaust Pipe Rattling Noise -Fix (SB90-03-001)
- 4ZE1 Eng Power Transistor Testing (SB89-03-001)
- 4ZE1 Eng C/C Throttle Valve Switch Adjust/TPS Test (SB89-02-002)
- Axle Shafts
- Locking Front Hubs Special Tool Identification (SB93-07-003)
- Manual Locking Hub Overhaul Kit Availability Info (SB90-07-004)
- MUA5C Trans Droning Noise - Driveline Angle (SB90-05-005)
- Front Hub Reassembly - Workshop Manual Correction (SB88-07-001)
- Conversion From Auto To Manual Locking Hub Info (SB85-06-002)
- Blowers, Superchargers & Turbochargers
- Charging Systems
- Clutch
- Communication Devices
- Cooling System (Mechanical)
- Engine Crankshaft Front Oil Seal Retainer Leakage (SB96-01-L006)
- Propylene Glycol Based Engine Coolant (SB96-14-L002)
- Propylene Glycol-Based Engine Coolant Warning (SB94-14-005)
- Oil Leak - Rear Oil Seal Diagnosis/Repair (SB92-01-002)
- 2.6L Eng Fuel Leak - Fuel INJ O-Ring Replacement (SB89-02-003)
- 2.3/2.6L Eng Water Pump Repair Kits (SB89-01-009)
- 2.6L Eng Coolant Loss - New Radiator Overflow Tank (SB89-01-003)
- 2.6L Eng Filling Cooling System (SB89-01-007)
- 2.6L Eng Flywheel Bolt Installation Info (SB89-01-004)
- Recommended Sealants (SB89-14-002)
- Camshaft Front Oil Seal Leak - Inspect Seal Seating (SB86-01-004)
- Gasoline/Alcohol Fuel Blend Caution/Guidelines (SB84-02-002)
- Cruise Control Systems
- Inspection Of All Related Wiring Harness Connections When Diagnosing Miscellaneous DTC'S, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative Air Conditioning Systems, Service Engine Soon Lamps Illuminated, 4WD Lamp Illuminated, Instrument Panel Gauges Inoperative, Cruise Inoperative (IB05-04-S005)
- Cruise Control INOP - Cruise Switch Repair Kit (SB91-04-009)
- Cruise Control Inoperative - Switch Repair Kit (SB91-04-009)
- Cruise Control Stalk R & R (SB89-04-004)
- 4ZE1 Eng Cruise Control Cable Adjustment (SB89-02-001)
- Revised Cruise Control Troubleshooting (SB88-04-001)
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Engine Control Systems
- Specified Major Emission-Control Components Defect Warranty Coverage Enhancement (WB07-L004)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Reprogramming Of Powertrain Control Modules (Pcm) (IB03-14-S002)
- Pcm Reprogramming (IB00-S002)
- Air Regulator Specifications/Testing (SB90-03-003)
- 4ZE1 Eng Power Transistor Testing (SB89-03-001)
- 4ZE1 Eng C/C Throttle Valve Switch Adjust/TPS Test (SB89-02-002)
- Entertainment Systems
- Exhaust
- Misfire DTC'S And Catalytic Converter Damage Due To Installation Of Alarm Systems (IB04-03-S001)
- Adjustment Of J-45735 Exhaust BACKPRESSURE Gauge (IB03-14-S001)
- 2.3L/2.6L Engine Exhaust Manifold Stud Nut Removal (SB97-01-L004)
- Catalytic Converter/Exhaust Pipe Rattling Noise -Fix (SB90-03-001)
- 2.3/2.6L Eng Exhaust Pipe/Gasket/Nut Replacing Info (SB88-03-004)
- 2.3L Eng Exhaust Pipe/Gasket Replacement - REPL Nuts (SB88-03-004)
- Exterior Body Panels
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- Low Voltage Display On IP Gauge, Lights Dim At Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights At Idle, Low Generator Output (IB07-04-S003)
- Inspection Of All Related Wiring Harness Connections When Diagnosing Miscellaneous DTC'S, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative Air Conditioning Systems, Service Engine Soon Lamps Illuminated, 4WD Lamp Illuminated, Instrument Panel Gauges Inoperative, Cruise Inoperative (IB05-04-S005)
- Radio Clock Display Resets With Key Off - #6 Fuse (SB90-04-002)
- Speedo Bounce/Noise - Modify Speedo Cable Length (SB89-04-005)
- Speedometer/Odometer Replacement Labels (SB89-04-002)
- Inst Panel Noise - Speedo/Throttle Cables Contacting (SB88-04-005)
- Headlights
- Heated Glass/Defoggers
- HVAC Control Systems
- New Sae J2788 Refrigerant Recovery Standard (IB07-12-S004)
- Inspection Of All Related Wiring Harness Connections When Diagnosing Miscellaneous DTC'S, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative Air Conditioning Systems, Service Engine Soon Lamps Illuminated, 4WD Lamp Illuminated, Instrument Panel Gauges Inoperative, Cruise Inoperative (IB05-04-S005)
- A/C Refrigerant System Sealer And A/C System Leak Detecting Guidelines (IB04-12-S001)
- Replacement Of The Receiver Drier During Air Conditioning Repair And Service (IB00-12-S002)
- R-12 To R-134A A/C System Conversion/Retrofit Procedures (Supersedes Sb00-12-S002) (SB00-12-S004)
- HVAC System Deodorizing Treatment (SB99-12-S002)
- HVAC System Deodorizing Treatment (SB98-12-L001)
- A/C FREON Blends Warning (SB92-12-003)
- A/C FREON Recovery Caution (SB91-12-002)
- A/C Diagnosis Chart (SB91-12-001)
- A/C Compressor Updated Wiring Diagram (SB90-04-007)
- Fuel/Brake Line Leakage - New Lines/Clips (SB89-12-001)
- Receiver Drier Replacement During Air Conditioning Repair & Service (IB00-12-S002)
- Identification
- Ignition Switch/Steering Lock
- Ignition System
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- 2.3L Eng Oil In Distributor - Worn Distributor Seal (SB91-04-007)
- 2.6L Eng Fuel Leak - Fuel INJ O-Ring Replacement (SB89-02-003)
- 4ZE1 Eng Power Transistor Testing (SB89-03-001)
- 1.9L Eng Distributor Cap Boot (SB86-04-008)
- Gasoline/Alcohol Fuel Blend Caution/Guidelines (SB84-02-002)
- Interior/Exterior Trim
- Interior/Illumination Lights
- Locking Hubs
- Lubrication System
- Engine Oil Usage Testing And Reporting (SB07-01-S001)
- Precaution In Installing An ISUZU Oil Filter (IB00-01-S001)
- Engine Crankshaft Front Oil Seal Retainer Leakage (SB96-01-L006)
- Propylene Glycol Based Engine Coolant (SB96-14-L002)
- Propylene Glycol-Based Engine Coolant Warning (SB94-14-005)
- A/C FREON Blends Warning (SB92-12-003)
- Oil Leak - Rear Oil Seal Diagnosis/Repair (SB92-01-002)
- 2.6L Eng Fuel Leak - Fuel INJ O-Ring Replacement (SB89-02-003)
- Oil Drain Plug Washer Replacement Requirements (SB89-01-011)
- 4ZE1 Eng Revised Engine Oil Capacity (SB89-01-010)
- 2.6L Eng Flywheel Bolt Installation Info (SB89-01-004)
- Recommended Sealants (SB89-14-002)
- Turbocharger Operation/Service Precautions (SB87-14-002)
- Camshaft Front Oil Seal Leak - Inspect Seal Seating (SB86-01-004)
- Gasoline/Alcohol Fuel Blend Caution/Guidelines (SB84-02-002)
- Manual Steering
- Manual Trans
- Mechanical
- Use Of Surface Conditioning Disks (IB05-01-S002)
- Adjustment Of J-45735 Exhaust BACKPRESSURE Gauge (IB03-14-S001)
- LOCTITE/PERMATEX Cross-Reference Chart (SB99-14-S001)
- Use Of Surface Conditioning Discs (IB00-14-S001)
- Precaution In Installing An ISUZU Oil Filter (IB00-01-S001)
- 4ZD1/4ZE1 Engine Exhaust Valve Leaking (IB00-S004)
- 2.3L/2.6L Engine Exhaust Manifold Stud Nut Removal (SB97-01-L004)
- Engine Crankshaft Front Oil Seal Retainer Leakage (SB96-01-L006)
- Oil Leak - Rear Oil Seal Diagnosis/Repair (SB92-01-002)
- 2.3/2.6L Eng Oil Leak Rear Seal - Rear Oil Seal Tool (SB92-01-001)
- 2.6L Eng Fuel Leak - Fuel INJ O-Ring Replacement (SB89-02-003)
- Crankshaft Bearing Selection Specifications (SB89-01-008)
- 2.6L Eng Flywheel Bolt Installation Info (SB89-01-004)
- Recommended Sealants (SB89-14-002)
- 2.2L Turbo Eng Failed - Short Block REPL/Repair Info (SB88-01-003)
- Camshaft Front Oil Seal Leak - Inspect Seal Seating (SB86-01-004)
- Gasoline/Alcohol Fuel Blend Caution/Guidelines (SB84-02-002)
- Mechanical - Hydraulic
- Disc Brake Squeal (IB00-09-S001)
- Propylene Glycol Based Engine Coolant (SB96-14-L002)
- Propylene Glycol-Based Engine Coolant Warning (SB94-14-005)
- A/C FREON Blends Warning (SB92-12-003)
- Rear Brake Groaning - Rear Disc Brake Pad Kit (SB89-09-003)
- Rear Disc Brake Pad Replacement - Caliper Tool (SB88-09-002)
- Loose Rear Disc Brake Caliper Guide Pin - Repair Kit (SB88-09-001)
- Mirrors
- Paint & Coatings
- Passive Restraints
- Procedures
- Rear Suspension
- Restraints Control Systems
- Schedule
- Seats
- Starter
- Low Voltage Display On IP Gauge, Lights Dim At Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights At Idle, Low Generator Output (IB07-04-S003)
- CALIFORNIA Consent Order On Settlement Of Lawsuit On Batteries (Proposition 65) (IB00-14-S004)
- 2.6L Eng Fuel Leak - Fuel INJ O-Ring Replacement (SB89-02-003)
- Battery Testing/Charging (SB88-04-003)
- Gasoline/Alcohol Fuel Blend Caution/Guidelines (SB84-02-002)
- CALIFORNIA Consent Order-Lawsuit Settlement On Batteries (Proposition 65) (IB00-14-S004)
- Steering Column
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- System
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Inspection Of All Related Wiring Harness Connections When Diagnosing Miscellaneous DTC'S, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative Air Conditioning Systems, Service Engine Soon Lamps Illuminated, 4WD Lamp Illuminated, Instrument Panel Gauges Inoperative, Cruise Inoperative (IB05-04-S005)
- Reprogramming Of Powertrain Control Modules (Pcm) (IB03-14-S002)
- LOCTITE/PERMATEX Cross-Reference Chart (SB99-14-S001)
- Engine Crankshaft Front Oil Seal Retainer Leakage (SB96-01-L006)
- Oil Leak - Rear Oil Seal Diagnosis/Repair (SB92-01-002)
- 2.3L Eng Oil In Distributor - Worn Distributor Seal (SB91-04-007)
- 2.3/2.6/2.8L Eng Hard Start - Fuel Pump Diagnostics (SB90-02-002)
- 2.6/2.8L Eng Replacement Fuel Pump/Bracket Kits (SB90-02-003)
- Air Regulator Specifications/Testing (SB90-03-003)
- Catalytic Converter/Exhaust Pipe Rattling Noise -Fix (SB90-03-001)
- 2.6L Eng Fuel Leak - Fuel INJ O-Ring Replacement (SB89-02-003)
- 4ZE1 Eng Power Transistor Testing (SB89-03-001)
- 4ZE1 Eng C/C Throttle Valve Switch Adjust/TPS Test (SB89-02-002)
- 2.6L Eng Flywheel Bolt Installation Info (SB89-01-004)
- Recommended Sealants (SB89-14-002)
- 1.8/2.2/2.3L Diesel Eng Lacks Power - Fouled Screen (SB87-02-001)
- Camshaft Front Oil Seal Leak - Inspect Seal Seating (SB86-01-004)
- 1.9L Eng Distributor Cap Boot (SB86-04-008)
- Gasoline/Alcohol Fuel Blend Caution/Guidelines (SB84-02-002)
- Transfer Case
- Inspection Of All Related Wiring Harness Connections When Diagnosing Miscellaneous DTC'S, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative Air Conditioning Systems, Service Engine Soon Lamps Illuminated, 4WD Lamp Illuminated, Instrument Panel Gauges Inoperative, Cruise Inoperative (IB05-04-S005)
- Driveline Sound In Four Wheel Drive Operation (IB01-05-S001)
- Trans Bearing Removal Tool - Proper Use/Application (SB91-05-008)
- MUA5C Trans Droning Noise - Driveline Angle (SB90-05-005)
- Transmission Control Systems
- Wheel Hubs
- Wheels & Tire System
- Information On Proper Tire Pressure (IB06-08-S003)
- Use Of The HAWEKA Flange Plate Adapter For Tire Balancers (IB01-14-S005)
- Driveline Sound In Four Wheel Drive Operation (IB01-05-S001)
- 3/4 Inch (19MM) Wheel Lug Torque Stick (SB99-14-S008)
- Radial Tire Sidewall Indentations - Information (SB94-08-001)
- Locking Front Hubs Special Tool Identification (SB93-07-003)
- YOKOHAMA Tires Availability (SB93-08-001)
- Manual Locking Hub Overhaul Kit Availability Info (SB90-07-004)
- Front Hub Reassembly - Workshop Manual Correction (SB88-07-001)
- Conversion From Auto To Manual Locking Hub Info (SB85-06-002)
- Window Motors & Regulators
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)