Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups
Common Specs & Procedures
DTC Index
Electrical Component Locations
Fluids
Technical Bulletins
Tire Fitment
Wiring Diagrams- System Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Body Computer
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Electronic Suspension
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Top/Sunroof
- Power Windows
- Radio
- Shift Interlocks
- Starting/Charging
- Supplemental Restraints
- Transmission
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- System Wiring Diagrams
- Accessories & Equipment
- Anti-Theft Systems
- Communication Devices
- Cruise Control Systems
- Description
- Operation
- Component Locations
- Programming
- Adjustments
- Self-Diagnostic System
- Diagnostic Tests
- Removal & Installation
- Wiring Diagrams
- Gauges & Instrument Panels
- Heated Glass/Defoggers
- Power Seats
- Steering Column Switches
- Power-Assisted Steering System
- Service Precaution
- Diagnosis
- General Description
- Power Steering System Test
- Fluid Level
- Bleeding The Power Steering System
- Bleeding Procedure
- Flushing The Power Steering System
- Steering Wheel Free Play Inspection
- Front End Alignment Inspection and Adjustment
- Main Data and Specifications
- Special Tools
- Power Steering Unit
- Power Steering Pump
- Transfer Gear Assembly
- Supplemental Restraint System Steering Wheel & Column
- Inflator Module
- Steering Wheel
- Combination Switch
- Lock Cylinder
- Steering Column
- Supplemental Restraint System Steering Wheel & Column and Associated Parts
- Steering Column Switches
- Power-Assisted Steering System
- Window Motors & Regulators
- Wiper/Washer Systems
- Body & Frame
- Door Locks
- Power Seats
- Sun Roof/T-Top/Convertible Top
- Power Windows
- Brakes
- Anti-Lock Brakes
- Description
- Operation
- Component Locations
- Bleeding Brake System
- Trouble Shooting
- Self-Diagnostic System
- Diagnostic Trouble Code Definitions
- Diagnostic Tests
- Notes
- DTC 13: 2WD Controller In 4WD Vehicle; DTC 24: Open Or Shorted 4X4 Input Signal
- DTC 14: CPU Error
- DTC 15: Low Or High Ignition Voltage
- DTC 17: Excessive Dump Time
- DTC 18: Excessive Isolation Time
- DTC 21: "G" Sensor Output Failure
- DTC 22: Brake Switch Failure
- DTC 32: Pump Motor Failure
- DTC 35: EHCU Valve Relay Failure
- DTCS 41, 42, 43, 44, 45 Or 46: ISOLATION/DUMP SOLENOID VALVE FAILURE
- DTC 51: Left Front Wheel Speed Sensor Open Or Shorted
- DTC 52: Right Front Wheel Speed Sensor Open Or Shorted
- DTC 53: Rear Wheel Speed Sensor Open Or Shorted
- DTC 61: Left Front Missing Sensor Signal
- DTC 62: Right Front Missing Sensor Signal
- DTC 63: Rear Wheel Speed Sensor Missing
- DTC 64: Simultaneous Drop-Out Of Front Speed Sensor Signals
- DTC 65: Abnormal Wheel Speed Sensor Signal Input
- System Tests
- Notes
- Test A-1: Abs Works Frequently But Vehicle Does Not Decelerate
- Test Ta-1: Abs Works Frequently But Vehicle Does Not Decelerate
- Test A-2: Uneven Braking Occurs While Abs Is Operating
- Test Ta-2: Uneven Braking Occurs While Abs Is Operating
- Test A-3/Ta-3: Wheels Lock During Braking
- Test A-4: Brake Pedal Feel Is Abnormal
- Test A-5/Ta-5: Braking Sound From Hydraulic Unit (Brakes Released)
- Test B-1: Abs Warning Light Does Not Illuminate (Key On/Engine Off)
- Component Tests
- Removal & Installation
- Torque Specifications
- Pin Voltage Tests
- Wiring Diagrams
- Mechanical - Hydraulic
- Disc & Drum
- Description & Operation
- Bleeding Brake System
- Adjustments & Inspections
- Trouble Shooting
- Removal & Installation
- Notes
- Brake Pedal
- Brake Pipe
- Front Brake Caliper
- Front Brake Pads
- Front Brake Rotor
- Front Caliper Brake Hose
- Front Hub & Disc (4WD Model)
- Front Hub & Disc (RWD Model)
- Hydraulic Brake Exterior Components
- Master Cylinder
- Parking Brake Lever & Front Cable
- Parking Brake Rear Cable (4WD Model)
- Parking Brake Rear Cable (RWD Model)
- Proportioning & Bypass Valve
- Rear Axle Brake Hose
- Rear Brake Caliper
- Rear Brake Pads
- Rear Brake Rotor
- Rear Drum Brake Shoes
- Stoplight Switch
- Vacuum Booster
- Wheel Cylinders
- Overhaul
- Torque Specifications
- Disc Brake Specifications
- Drum Brake Specifications
- Disc & Drum
- Traction Control
- Anti-Lock
- Description
- Operation
- Component Locations
- Bleeding Brake System
- Trouble Shooting
- Self-Diagnostic System
- Diagnostic Trouble Code Definitions
- Diagnostic Tests
- Notes
- DTC 13: 2WD Controller In 4WD Vehicle; DTC 24: Open Or Shorted 4X4 Input Signal
- DTC 14: CPU Error
- DTC 15: Low Or High Ignition Voltage
- DTC 17: Excessive Dump Time
- DTC 18: Excessive Isolation Time
- DTC 21: "G" Sensor Output Failure
- DTC 22: Brake Switch Failure
- DTC 32: Pump Motor Failure
- DTC 35: EHCU Valve Relay Failure
- DTCS 41, 42, 43, 44, 45 Or 46: ISOLATION/DUMP SOLENOID VALVE FAILURE
- DTC 51: Left Front Wheel Speed Sensor Open Or Shorted
- DTC 52: Right Front Wheel Speed Sensor Open Or Shorted
- DTC 53: Rear Wheel Speed Sensor Open Or Shorted
- DTC 61: Left Front Missing Sensor Signal
- DTC 62: Right Front Missing Sensor Signal
- DTC 63: Rear Wheel Speed Sensor Missing
- DTC 64: Simultaneous Drop-Out Of Front Speed Sensor Signals
- DTC 65: Abnormal Wheel Speed Sensor Signal Input
- System Tests
- Notes
- Test A-1: Abs Works Frequently But Vehicle Does Not Decelerate
- Test Ta-1: Abs Works Frequently But Vehicle Does Not Decelerate
- Test A-2: Uneven Braking Occurs While Abs Is Operating
- Test Ta-2: Uneven Braking Occurs While Abs Is Operating
- Test A-3/Ta-3: Wheels Lock During Braking
- Test A-4: Brake Pedal Feel Is Abnormal
- Test A-5/Ta-5: Braking Sound From Hydraulic Unit (Brakes Released)
- Test B-1: Abs Warning Light Does Not Illuminate (Key On/Engine Off)
- Component Tests
- Removal & Installation
- Torque Specifications
- Pin Voltage Tests
- Wiring Diagrams
- Anti-Lock
- Anti-Lock Brakes
- Drivelines & Axles
- Differentials & Drive Axles
- Differential (Rear)
- Service Precaution
- General Description
- Diagnosis
- Axle Housing
- Axle Shaft, Oil Seal and Bearing
- Pinion Oil Seal
- Differential Assembly
- Differential Case Assembly
- Limited Slip Differential Assembly
- Main Data and Specifications
- Special Tools
- Differential (Rear)
- Driveshaft & Universal Joints
- Drive Shaft System
- Service Precaution
- General Description
- Diagnosis
- Front Hub and Disc (2WD Model)
- Front Hub and Disc (4WD Model)
- Front Drive Shaft Joint
- Front Axle Drive Shaft
- Shift On The Fly System
- Propeller Shaft
- Front Propeller Shaft
- Rear Propeller Shaft
- Drive Shaft System
- Differentials & Drive Axles
- Electrical
- Charging Systems
- Component Locations
- Fuses & Circuit Breakers
- Gauges
- Starters
- Wiring Diagrams
- System Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Body Computer
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Electronic Suspension
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Top/Sunroof
- Power Windows
- Radio
- Shift Interlocks
- Starting/Charging
- Supplemental Restraints
- Transmission
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- System Wiring Diagrams
- Engine Mechanical
- Auxiliary Emission Control Systems
- Emission Control System Visual Inspection Procedures - General Information
- * Please Read This First *
- Emission Control Labels
- Emission Control Visual Inspection
- Notes
- Positive Crankcase Ventilation (PCV)
- Thermostatic Air Cleaner (TAC)
- Fuel Evaporative System (EVAP)
- Catalytic Converters
- Fill Pipe RESTRICTOR (Fr)
- Exhaust Gas RECIRCULATION (EGR) System
- Spark Controls (SPK)
- Air Injection System (AIS)
- Oxygen Sensor (O2)
- Computerized Engine Controls (CEC)
- Early Fuel Evaporation (EFE)
- Emission Maintenance Reminder Light (EMR) (If Equipped)
- Malfunction Indicator Light (Mil)
- Emission Control System Visual Inspection Procedures - General Information
- Cooling System (Mechanical)
- Exhaust (Y22SE 2.2L)
- Fuel System
- Lubrication System
- Mechanical
- Air Induction System (Y22SE 2.2L)
- Engine (Y22SE 2.2L)
- Service Precaution
- General Description
- Engine Diagnosis
- Cylinder Head Cover
- Exhaust Manifold
- Crankshaft Pulley
- Intake Manifold
- Cylinder Head Assembly
- Timing Belt
- Camshaft
- Engine Assembly
- Cylinder Head
- Valve Spring, Valve, Valve Guide
- Crankshaft
- Piston and Connecting Rod
- Cylinder Block
- Balance Unit Assembly
- Main Data and Specifications
- Engine Main Specifications
- Torque Specifications
- Camshaft Bracket, Timing Gear Camshaft Side, Cylinder Head
- Timing Gear Crankshaft (Center Bolt), Timing Belt Cover Front, Timing Belt Cover Rear, Timing Belt Tensioner, Camshaft Angle Sensor
- Crankshaft Main Bearing, Oil Pan Support, Oil Pan, Balance Unit Assembly, Conrad Cap, Oil Pump, Oil Strainer
- Spark Plug, Throttle Body, EGR Valve Adaptor Assembly, Bypass Housing Assembly, Thermostat Assembly, Inlet Manifold Assembly, Exhaust Manifold Assembly, Heat Shield, Ignition Cable Cover
- Engine Mount
- Special Tools
- Starters
- Timing Belt Replacement - 2.2L - DOHC
- Auxiliary Emission Control Systems
- Engine Performance
- Engine Controls - On-Vehicle Adjustments
- Application
- Emissions
- EGR Function Testing - ISUZU
- Emission Applications - Gas
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Fuel Delivery
- Ignition System (Y22SE 2.2L)
- Mode 6 - 1996-2007 ISUZU
- Engine Controls - Pin Voltage Charts
- Remove, Overhaul & Install
- Engine Controls - Removal, Overhaul & Installation
- Introduction
- Engine Sensors & Switches
- Emissions Systems
- Fuel System
- Torque Specifications
- Engine Controls - Removal, Overhaul & Installation
- Sensor Range Charts
- Specifications
- System
- Engine Controls - Basic Diagnostic Procedures
- Introduction
- Preliminary Inspection & Adjustments
- No Start Diagnosis
- Fuel System
- Ignition Checks
- Idle Speed & Ignition Timing
- Summary
- Engine Controls - Self-Diagnostics - 2.2L
- Introduction
- Self-Diagnostic System
- Notes
- On-Board Diagnostics
- Comprehensive Component Monitor Diagnostic Operation
- System Status & Drive Cycle For Satisfying Federal Inspection/Maintenance (I/M 240) Regulations
- Common OBD-II Terms
- Diagnostic Executive
- Preliminary Check
- Data Link Connector Location
- Retrieving Diagnostic Trouble Codes
- Clearing Diagnostic Trouble Codes
- Verifying Vehicle Repair
- Serial Data Communications
- On-Board Diagnostic II System Check
- Miscellaneous Tests
- Multiple Powertrain Control Module Information Sensor Diagnostic Trouble Codes Set
- Malfunction Indicator Lights
- Powertrain Control Module
- Summary
- Diagnostic Trouble Code Definitions
- Diagnostic Tests
- Notes
- DTC P0106: Manifold Absolute Pressure Sensor - Circuit/Range Performance Fault
- DTC P0107: Manifold Absolute Pressure Sensor - Low Input
- DTC P0108: Manifold Absolute Pressure Sensor - High Input
- DTC P0112: Intake Air Temperature Sensor - Low Input Voltage
- DTC P0113: Intake Air Temperature Circuit - High Input Voltage
- DTC P0117: Engine Coolant Temperature Sensor - Low Voltage
- DTC P0118: Engine Coolant Temperature Sensor - High Input Voltage
- DTC P0121: Throttle Position Sensor - Circuit Range/Performance
- DTC P0122: Throttle Position Sensor - Circuit Low Input
- DTC P0123: Throttle Position Sensor - Circuit High Input
- DTC P0125: Insufficient Temperature For Closed Loop Fuel Control
- DTC P0128: Thermostat Insufficient Temperature For Stable Operation
- DTC P0131: Bank 1 Heated Oxygen Sensor-1 Circuit - Low Voltage
- DTC P0132: Bank 1 Heated Oxygen Sensor-1 Circuit - High Voltage
- DTC P0133: Bank 1 Heated Oxygen Sensor-1 - Slow Response
- DTC P0134: Bank 1 Heated Oxygen Sensor-1 - No Activity Detected
- DTC P0135: Bank 1 Heated Oxygen Sensor-1 - Heater Circuit Malfunction
- DTC P0137: Bank 1 Heated Oxygen Sensor-2 Circuit - Low Voltage
- DTC P0138: Bank 1 Heated Oxygen Sensor-2 Circuit - High Voltage
- DTC P0140: Bank 1 Heated Oxygen Sensor-2 - No Activity Detected
- DTC P0141: Bank 1 Heated Oxygen Sensor-2 - Heater Circuit Malfunction
- DTC P0171: Fuel Trim System Lean
- DTC P0172: Fuel Trim System Rich
- DTC P0201: Cylinder No. 1 Injector Circuit Malfunction, DTC P0202: Cylinder No. 2 Injector Circuit Malfunction, DTC P0203: Cylinder No. 3 Injector Circuit Malfunction Or DTC P0204: Cylinder No. 4 Injector Circuit Malfunction
- DTC P0300: Random/Multiple Cylinder Misfire Detected
- DTC P0301: Random/Multiple Cylinder No. 1 Misfire Detected, DTC P0302: Random/Multiple Cylinder No. 2 Misfire Detected, DTC P0303: Random/Multiple Cylinder No. 3 Misfire Detected Or DTC P0304: Random/Multiple Cylinder No. 4 Misfire Detected
- DTC P0325: Knock Sensor - Circuit Malfunction
- DTC P0327: Knock Sensor Circuit - Low Input
- DTC P0336: Crankshaft Position Sensor Circuit - Range/Performance
- DTC P0337: Crankshaft Position Sensor Circuit - Low Input
- DTC P0341: Camshaft Position Sensor Circuit - Range/Performance Malfunction
- DTC P0342: Camshaft Position Sensor Circuit - Low Input
- DTC P0351: Ignition Coil "A" Primary/Secondary Circuit Malfunction, Or DTC P0352: Ignition Coil "B" Primary/Secondary Circuit Malfunction
- DTC P0401: Exhaust Gas RECIRCULATION System - Insufficient Flow
- DTC P0402: Exhaust Gas RECIRCULATION System - Excessive Flow Detected
- DTC P0404: Exhaust Gas RECIRCULATION System - Range/Performance Malfunction
- DTC P0405: Exhaust Gas RECIRCULATION System - Circuit Low Input
- DTC P0406: Exhaust Gas RECIRCULATION System - Circuit High Input
- DTC P0420: Catalytic CONVERTOR System Efficiency Below Threshold
- DTC P0440: Evaporative Emission Control System Malfunction
- DTC P0442: Evaporative Emission Control System - Small Leak Detected
- DTC P0443: Evaporative Emission Control System - Purge Control Valve Circuit Malfunction
- DTC P0446: Evaporative Emission Control System - Vent Control Circuit Malfunction
- DTC P0449: Evaporative Emission Control System - Vent Valve/Solenoid Circuit Malfunction
- DTC P0456: Evaporative Emission Control System - Very Small Leak Detected
- DTC P0461: Fuel Level Sensor Circuit - Range Performance Malfunction
- DTC P0462: Fuel Level Sensor Circuit - Low Input
- DTC P0463: Fuel Level Sensor Circuit - High Input
- DTC P0464: Fuel Level Sensor Circuit - Noisy Signal
- DTC P0480: Cooling Fan 1 Control Circuit Malfunction
- DTC P0481: Cooling Fan 2 Control Malfunction
- DTC P0502: Vehicle Speed Sensor Circuit - Low Input
- DTC P0506: Idle Control System - Rpm Lower Than Expected
- DTC P0507: Idle Control System - Rpm Higher Than Expected
- DTC P0532: A/C Refrigerant Pressure Sensor Circuit - Low Input
- DTC P0533: A/C Refrigerant Pressure Sensor Circuit High
- DTC P0562: System Voltage Low
- DTC P0563: System Voltage High
- DTC P0601: Powertrain Control Module Memory Check Sum Error
- DTC P1106: Map Sensor Circuit - Intermittent High Voltage
- DTC P1107: Map Sensor Circuit - Intermittent Low Voltage
- DTC P1111: Intake Air Temperature Sensor Circuit - Intermittent High Voltage
- DTC P1112: Intake Air Temperature Sensor Circuit - Intermittent Low Voltage
- DTC P1114: Engine Coolant Temperature Sensor Circuit - Intermittent Low Voltage
- DTC P1115: Engine Coolant Temperature Sensor Circuit - Intermittent High Voltage
- DTC P1121: Throttle Position Sensor Circuit - Intermittent High Voltage
- DTC P1122: Throttle Position Sensor Circuit - Intermittent Low Voltage
- DTC P1133: Bank 1 Heated Oxygen Sensor-1 - Insufficient Switching
- DTC P1134: Bank 1 Heated Oxygen Sensor-1 - Transition Time Ratio
- DTC P1171: Fuel System Lean During Acceleration
- DTC P1336: Crankshaft Position Sensor System - Variation Not Learned
- DTC P1380: Anti-Lock Brake System - Rough Road System Fault
- DTC P1381: Anti-Lock Brake System - Rough Road Class 2 Serial Data Fault
- DTC P1404: Exhaust Gas RECIRCULATION Closed Valve
- DTC P1441: Evaporative Emissions System - Flow During Non-Purge
- DTC P1546: A/C Compressor Clutch Output Circuit Malfunction
- DTC P1625: Powertrain Control Module Unexpected Result
- DTC P1627: Powertrain Control Module A/D Conversion Malfunction
- DTC P1635: 5-Volt Reference Voltage Circuit Malfunction
- Engine Controls - System & Component Testing
- Introduction
- Computerized Engine Controls
- Emission Systems & Sub-Systems
- Engine Sensors & Switches
- Fuel System
- Notes
- Electronic Throttle Control System
- Fuel Delivery
- Fuel Pressure Test
- Fuel Pressure Regulator
- Fuel Injection
- Fuel Injector Balance Test
- Fuel Injector Coil Test
- Fuel System Pressure Release
- Fuel Tank Leak Check
- Idle Air Control System Check (Rodeo & Rodeo Sport 2.2L)
- Idle Air Control Valve (Axiom & Trooper)
- Ignition Systems
- Miscellaneous Powertrain Control Module Controls
- A/C Clutch Control (Axiom & Trooper)
- A/C Clutch Control (Rodeo & Rodeo Sport 2.2L)
- A/C Clutch Relay
- A/C Clutch Circuit Diagnosis
- Brake Light Switch (Rodeo & Rodeo Sport 2.2L)
- Brake Light Switch (Axiom, Passport, Rodeo 3.2L & Rodeo Sport 3.2L)
- Brake Light Switch (Trooper)
- Brake Light Switch With Cruise Control
- Malfunction Indicator Light Does Not Illuminate Or Remains Illuminated
- Misfire Monitor Diagnosis
- Modules & Relays
- Component Locations
- Engine Controls - Trouble Shooting - No Codes
- Engine Speed Control System (Y22SE 2.2L)
- Engine Controls - Basic Diagnostic Procedures
- Testing & Diagnosis
- Engine Controls - Basic Diagnostic Procedures
- Introduction
- Preliminary Inspection & Adjustments
- No Start Diagnosis
- Fuel System
- Ignition Checks
- Idle Speed & Ignition Timing
- Summary
- Engine Controls - Self-Diagnostics - 2.2L
- Introduction
- Self-Diagnostic System
- Notes
- On-Board Diagnostics
- Comprehensive Component Monitor Diagnostic Operation
- System Status & Drive Cycle For Satisfying Federal Inspection/Maintenance (I/M 240) Regulations
- Common OBD-II Terms
- Diagnostic Executive
- Preliminary Check
- Data Link Connector Location
- Retrieving Diagnostic Trouble Codes
- Clearing Diagnostic Trouble Codes
- Verifying Vehicle Repair
- Serial Data Communications
- On-Board Diagnostic II System Check
- Miscellaneous Tests
- Multiple Powertrain Control Module Information Sensor Diagnostic Trouble Codes Set
- Malfunction Indicator Lights
- Powertrain Control Module
- Summary
- Diagnostic Trouble Code Definitions
- Diagnostic Tests
- Notes
- DTC P0106: Manifold Absolute Pressure Sensor - Circuit/Range Performance Fault
- DTC P0107: Manifold Absolute Pressure Sensor - Low Input
- DTC P0108: Manifold Absolute Pressure Sensor - High Input
- DTC P0112: Intake Air Temperature Sensor - Low Input Voltage
- DTC P0113: Intake Air Temperature Circuit - High Input Voltage
- DTC P0117: Engine Coolant Temperature Sensor - Low Voltage
- DTC P0118: Engine Coolant Temperature Sensor - High Input Voltage
- DTC P0121: Throttle Position Sensor - Circuit Range/Performance
- DTC P0122: Throttle Position Sensor - Circuit Low Input
- DTC P0123: Throttle Position Sensor - Circuit High Input
- DTC P0125: Insufficient Temperature For Closed Loop Fuel Control
- DTC P0128: Thermostat Insufficient Temperature For Stable Operation
- DTC P0131: Bank 1 Heated Oxygen Sensor-1 Circuit - Low Voltage
- DTC P0132: Bank 1 Heated Oxygen Sensor-1 Circuit - High Voltage
- DTC P0133: Bank 1 Heated Oxygen Sensor-1 - Slow Response
- DTC P0134: Bank 1 Heated Oxygen Sensor-1 - No Activity Detected
- DTC P0135: Bank 1 Heated Oxygen Sensor-1 - Heater Circuit Malfunction
- DTC P0137: Bank 1 Heated Oxygen Sensor-2 Circuit - Low Voltage
- DTC P0138: Bank 1 Heated Oxygen Sensor-2 Circuit - High Voltage
- DTC P0140: Bank 1 Heated Oxygen Sensor-2 - No Activity Detected
- DTC P0141: Bank 1 Heated Oxygen Sensor-2 - Heater Circuit Malfunction
- DTC P0171: Fuel Trim System Lean
- DTC P0172: Fuel Trim System Rich
- DTC P0201: Cylinder No. 1 Injector Circuit Malfunction, DTC P0202: Cylinder No. 2 Injector Circuit Malfunction, DTC P0203: Cylinder No. 3 Injector Circuit Malfunction Or DTC P0204: Cylinder No. 4 Injector Circuit Malfunction
- DTC P0300: Random/Multiple Cylinder Misfire Detected
- DTC P0301: Random/Multiple Cylinder No. 1 Misfire Detected, DTC P0302: Random/Multiple Cylinder No. 2 Misfire Detected, DTC P0303: Random/Multiple Cylinder No. 3 Misfire Detected Or DTC P0304: Random/Multiple Cylinder No. 4 Misfire Detected
- DTC P0325: Knock Sensor - Circuit Malfunction
- DTC P0327: Knock Sensor Circuit - Low Input
- DTC P0336: Crankshaft Position Sensor Circuit - Range/Performance
- DTC P0337: Crankshaft Position Sensor Circuit - Low Input
- DTC P0341: Camshaft Position Sensor Circuit - Range/Performance Malfunction
- DTC P0342: Camshaft Position Sensor Circuit - Low Input
- DTC P0351: Ignition Coil "A" Primary/Secondary Circuit Malfunction, Or DTC P0352: Ignition Coil "B" Primary/Secondary Circuit Malfunction
- DTC P0401: Exhaust Gas RECIRCULATION System - Insufficient Flow
- DTC P0402: Exhaust Gas RECIRCULATION System - Excessive Flow Detected
- DTC P0404: Exhaust Gas RECIRCULATION System - Range/Performance Malfunction
- DTC P0405: Exhaust Gas RECIRCULATION System - Circuit Low Input
- DTC P0406: Exhaust Gas RECIRCULATION System - Circuit High Input
- DTC P0420: Catalytic CONVERTOR System Efficiency Below Threshold
- DTC P0440: Evaporative Emission Control System Malfunction
- DTC P0442: Evaporative Emission Control System - Small Leak Detected
- DTC P0443: Evaporative Emission Control System - Purge Control Valve Circuit Malfunction
- DTC P0446: Evaporative Emission Control System - Vent Control Circuit Malfunction
- DTC P0449: Evaporative Emission Control System - Vent Valve/Solenoid Circuit Malfunction
- DTC P0456: Evaporative Emission Control System - Very Small Leak Detected
- DTC P0461: Fuel Level Sensor Circuit - Range Performance Malfunction
- DTC P0462: Fuel Level Sensor Circuit - Low Input
- DTC P0463: Fuel Level Sensor Circuit - High Input
- DTC P0464: Fuel Level Sensor Circuit - Noisy Signal
- DTC P0480: Cooling Fan 1 Control Circuit Malfunction
- DTC P0481: Cooling Fan 2 Control Malfunction
- DTC P0502: Vehicle Speed Sensor Circuit - Low Input
- DTC P0506: Idle Control System - Rpm Lower Than Expected
- DTC P0507: Idle Control System - Rpm Higher Than Expected
- DTC P0532: A/C Refrigerant Pressure Sensor Circuit - Low Input
- DTC P0533: A/C Refrigerant Pressure Sensor Circuit High
- DTC P0562: System Voltage Low
- DTC P0563: System Voltage High
- DTC P0601: Powertrain Control Module Memory Check Sum Error
- DTC P1106: Map Sensor Circuit - Intermittent High Voltage
- DTC P1107: Map Sensor Circuit - Intermittent Low Voltage
- DTC P1111: Intake Air Temperature Sensor Circuit - Intermittent High Voltage
- DTC P1112: Intake Air Temperature Sensor Circuit - Intermittent Low Voltage
- DTC P1114: Engine Coolant Temperature Sensor Circuit - Intermittent Low Voltage
- DTC P1115: Engine Coolant Temperature Sensor Circuit - Intermittent High Voltage
- DTC P1121: Throttle Position Sensor Circuit - Intermittent High Voltage
- DTC P1122: Throttle Position Sensor Circuit - Intermittent Low Voltage
- DTC P1133: Bank 1 Heated Oxygen Sensor-1 - Insufficient Switching
- DTC P1134: Bank 1 Heated Oxygen Sensor-1 - Transition Time Ratio
- DTC P1171: Fuel System Lean During Acceleration
- DTC P1336: Crankshaft Position Sensor System - Variation Not Learned
- DTC P1380: Anti-Lock Brake System - Rough Road System Fault
- DTC P1381: Anti-Lock Brake System - Rough Road Class 2 Serial Data Fault
- DTC P1404: Exhaust Gas RECIRCULATION Closed Valve
- DTC P1441: Evaporative Emissions System - Flow During Non-Purge
- DTC P1546: A/C Compressor Clutch Output Circuit Malfunction
- DTC P1625: Powertrain Control Module Unexpected Result
- DTC P1627: Powertrain Control Module A/D Conversion Malfunction
- DTC P1635: 5-Volt Reference Voltage Circuit Malfunction
- Engine Controls - System & Component Testing
- Introduction
- Computerized Engine Controls
- Emission Systems & Sub-Systems
- Engine Sensors & Switches
- Fuel System
- Notes
- Electronic Throttle Control System
- Fuel Delivery
- Fuel Pressure Test
- Fuel Pressure Regulator
- Fuel Injection
- Fuel Injector Balance Test
- Fuel Injector Coil Test
- Fuel System Pressure Release
- Fuel Tank Leak Check
- Idle Air Control System Check (Rodeo & Rodeo Sport 2.2L)
- Idle Air Control Valve (Axiom & Trooper)
- Ignition Systems
- Miscellaneous Powertrain Control Module Controls
- A/C Clutch Control (Axiom & Trooper)
- A/C Clutch Control (Rodeo & Rodeo Sport 2.2L)
- A/C Clutch Relay
- A/C Clutch Circuit Diagnosis
- Brake Light Switch (Rodeo & Rodeo Sport 2.2L)
- Brake Light Switch (Axiom, Passport, Rodeo 3.2L & Rodeo Sport 3.2L)
- Brake Light Switch (Trooper)
- Brake Light Switch With Cruise Control
- Malfunction Indicator Light Does Not Illuminate Or Remains Illuminated
- Misfire Monitor Diagnosis
- Modules & Relays
- Component Locations
- Engine Controls - Trouble Shooting - No Codes
- Engine Speed Control System (Y22SE 2.2L)
- Engine Controls - Basic Diagnostic Procedures
- Theory and Operation
- Engine Controls - Theory & Operation
- Introduction
- Computerized Engine Controls
- Notes
- Powertrain Control Module
- Input Devices
- Notes
- 58X Reference PCM Input
- A/C Request - A/C On
- Bank 1 & Bank 2 Heated Oxygen Sensors No. 1
- Bank 1 & Bank 2 Heated Oxygen Sensors No. 2
- Battery Voltage
- Camshaft Position Sensor
- Crankshaft Position Sensor
- EGR Pintle Position Sensor
- Engine Coolant Temperature Sensor
- Fuel Vapor Pressure Sensor
- Fuel Level Sensor
- Intake Air Temperature Sensor
- Knock Sensor
- Manifold Absolute Pressure Sensor
- Mass Airflow Sensor
- Park/Neutral Switch - A/T (Mode Switch) & Inhibitor Switch - M/T
- Power Steering Pressure Switch
- Transmission Fluid Temperature Sensor
- Throttle Position Sensor
- Vehicle Speed Sensor
- Output Signals
- Notes
- CHECK ENGINE Light or Malfunction Indicator Light
- Cooling Fan Relays
- Distributorless Ignition System
- Evaporative Canister Purge Control
- Exhaust Gas Recirculation Valve
- Electronic Spark Advance
- Electronic Spark Timing
- Fuel Disable Mode - Engine Speed
- Deceleration Mode
- Clear Flood Mode
- Acceleration Mode
- Fuel Injectors
- Fuel Pressure Regulator
- Fuel Pump
- Fuel Pump Relay
- Idle Air Control Valve
- Fuel System
- Ignition System
- Emission Systems
- Self-Diagnostic System
- Engine Controls - Theory & Operation
- Tune-Up
- Vacuum Diagrams
- Engine Performance - Wiring Diagrams
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- Computer Relearn Procedures - Import
- Introduction
- ACURA
- AUDI
- BMW
- HONDA
- HYUNDAI
- INFINITI
- ISUZU
- Jaguar
- KIA
- Land Rover
- LEXUS
- MAZDA
- MERCEDES-BENZ
- Notes
- Synchronization Of Power Windows
- Activating Steering Angle Sensor
- Synchronization Of Sliding/Tilt-Up Roof
- Easy Entry/Exit Function
- Control Module Version Coding
- Enabling Code Function For Radio
- Notes
- Audio 5 & 10 Models Or Sound 10, 20 & 30 Models (CLK, E & SLK Class)
- Becker 2000 (CL, S & SL Class)
- Becker Mexico, Grand Prix, Europa & Avus Models (SL Class)
- Radio With Navigation Control Module (CL, S & SL Class)
- Radio With 4-Digit Fixed Code (CL, S & SL Class)
- Radio & Radio With Navigation Control Module With 5-Digit Fixed Code (CL, S & SL Class)
- Radio (ML Class)
- Programming Supplemental Restraint System Control Module
- MITSUBISHI
- NISSAN
- PORSCHE
- SAAB
- SUBARU
- SUZUKI
- TOYOTA
- Service Precautions (PRIUS)
- Immobilizer Programming (Except PRIUS)
- Additional Master Key Registration (Except PRIUS)
- Additional Sub-Key Registration (Except PRIUS)
- Erasure Of Transponder Key Code (Except PRIUS)
- Immobilizer Component Replacement Programming Procedures (PRIUS)
- Notes
- Programming When Replacing Transponder Key Electronic Control Unit
- Programming When Replacing Hybrid Vehicle Control Electronic Control Unit
- Programming When Replacing Transponder Key Electronic Control Unit & Hybrid Vehicle Control Electronic Control Unit
- Programming If All Ignition Keys Are Lost
- Ignition Key Registration
- Additional Master Key Registration
- Additional Sub-Key Registration
- Erasure Of Transponder Key Code
- Power Sliding Door REINITIALIZATION Procedure (Sienna)
- Sun Roof Initialization (CAMRY & CELICA)
- VOLKSWAGEN
- VOLVO
- OBD-II Drive Cycles
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- DTC Index
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Identification
- Metric Conversions
- OEM General Information
- How To Use The Engine Performance Section
- Maintenance Reminder Light (Reset Procedures)
- Restraints
- Air Bag And Supplemental Restraint System (SRS) Component Inspection & Replacement Tables
- Air Bag Deactivation Procedures
- Specifications Index
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Traction Control Disable Procedures
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- General Servicing
- HVAC Control Systems
- HVAC Systems
- Service Precaution
- Heating and Ventilation System
- General Description
- Wiring Diagram
- Diagnosis
- Heating Cycle Diagnosis
- Fan Control Lever (Fan Switch) Diagnosis
- Chart "A" Blower Motor Does Not Run
- Chart "B" Blower Motor Does Not Run At Low Position
- Chart "C" Blower Motor Does Not Run At Medium Low Position
- Chart "D" Blower Motor Does Not Run At Medium High Position
- Chart "E" Blower Motor Does Not Run At High Position
- Chart "F" Blower Motor Does Not Stop In The "OFF" Position
- Individual Inspection
- Heater Unit
- Heater Core and / or Mode Door
- Heater Mode Control Link Unit
- Heater Temperature Control Link Unit
- Blower Assembly
- Blower Link Unit and/or Mode Door
- Blower Motor
- Rear Heater Duct, Defroster Nozzle and Ventilation Duct
- Control Lever Assembly and / or Control Cable
- Control Panel Illumination Bulb
- Resistor
- Air Conditioning System
- General Description
- Air Conditioning Refrigerant Cycle Construction
- Evaporation
- Compression
- Condensation
- Expansion
- Compressor
- Magnetic Clutch
- Condenser
- Receiver / Drier
- Dual Pressure Switch (V6, M/T)
- Triple Pressure Switch (V6, A/T)
- Pressure Sensor (L4, X22SE)
- Expansion Valve
- Evaporator
- Electronic Thermostat
- Refrigerant Line
- Air Conditioning Parts
- Wiring Diagram
- General Description
- Diagnosis
- Individual Inspection
- Fan Control Knob (Fan Switch) and Air+ Conditioning (A/C) Switch
- Heater (X-1), Thermostat (X-8), Condenser Fan (X-11) and Compressor (X-2) Relay
- Pressure Switch
- Triple Pressure Switch (V6, A/T)
- Condenser Fan
- General Repair Procedure
- Leak Check
- Inspection of refrigerant leak
- Inspection flow of refrigerant leak
- Inspection Steps
- High Pressure Side
- Low Pressure Side
- Major Checking Points of Refrigerant Leak
- Leak at Refrigerant Line Connections
- Leaks In The Hose
- Compressor Leaks
- Recovery, Recycling, Evacuation and Charging of HFC-134a
- Refrigerant Recovery
- Refrigerant Recycling
- Evacuation of The Refrigerant System
- Charging The Refrigerant System
- Checking The A/C System
- Compressor Assembly
- Condenser Assembly
- Condenser Fan Motor
- Receiver / Drier
- Pressure Switch
- Evaporator Assembly
- Electronic Thermostat, Evaporator Core and/or Expansion Valve
- Refrigerant Line
- Main Data and Specifications
- Compressor
- General Description
- Magnetic Clutch Assembly (DKV-14G Type)
- Compressor Oil
- Special Tools
- HVAC Systems
- Maintenance
- Restraints
- Air Bag, SRS
- Air Bag Restraint Systems
- Description & Operation
- Component Locations
- System Operation Check
- Air Bag Safety Precautions
- Adjustments
- Disabling & Activating Air Bag System
- Disposal Procedures
- Post-Collision Inspection
- Removal & Installation
- Diagnostics
- Diagnostic Tests
- SRS Diagnostic System Check
- SDM Integrity Check
- Air Bag Warning Light Comes On Steady
- Air Bag Warning Light Does Not Come On Steady
- DTC 15: Passenger Deployment Loop Resistance High
- DTC 16: Passenger Deployment Loop Resistance Low
- DTC 17: Passenger Deployment Loop Open
- DTC 18: Passenger Deployment Loop Short To Ground
- DTC 19: Passenger Deployment Loop Short To Voltage
- DTC 21: Driver Deployment Loop Resistance High
- DTC 22: Driver Deployment Loop Resistance Low
- DTC 24: Driver Deployment Loop Short To Ground
- DTC 25: Driver Deployment Loop Short To Voltage
- DTC 26: Driver Deployment Loop Open
- DTC 51 & 53: Deployment Event Commanded/Deployment Event Commanded With Deployment Loop Fault Or Energy Reserves Out Of Range
- DTC 61: Warning Light Circuit Failure
- DTC 71: Internal SDM Fault
- Torque Specifications
- Wiring Diagrams
- Air Bag Restraint Systems
- Air Bag, SRS
- Steering
- Manual Steering
- Power-Assisted Steering System
- Service Precaution
- Diagnosis
- General Description
- Power Steering System Test
- Fluid Level
- Bleeding The Power Steering System
- Bleeding Procedure
- Flushing The Power Steering System
- Steering Wheel Free Play Inspection
- Front End Alignment Inspection and Adjustment
- Main Data and Specifications
- Special Tools
- Power Steering Unit
- Power Steering Pump
- Transfer Gear Assembly
- Supplemental Restraint System Steering Wheel & Column
- Inflator Module
- Steering Wheel
- Combination Switch
- Lock Cylinder
- Steering Column
- Supplemental Restraint System Steering Wheel & Column and Associated Parts
- Power-Assisted Steering System
- Power Steering
- Power-Assisted Steering System
- Service Precaution
- Diagnosis
- General Description
- Power Steering System Test
- Fluid Level
- Bleeding The Power Steering System
- Bleeding Procedure
- Flushing The Power Steering System
- Steering Wheel Free Play Inspection
- Front End Alignment Inspection and Adjustment
- Main Data and Specifications
- Special Tools
- Power Steering Unit
- Power Steering Pump
- Transfer Gear Assembly
- Supplemental Restraint System Steering Wheel & Column
- Inflator Module
- Steering Wheel
- Combination Switch
- Lock Cylinder
- Steering Column
- Supplemental Restraint System Steering Wheel & Column and Associated Parts
- Power-Assisted Steering System
- Steering Column
- Power-Assisted Steering System
- Service Precaution
- Diagnosis
- General Description
- Power Steering System Test
- Fluid Level
- Bleeding The Power Steering System
- Bleeding Procedure
- Flushing The Power Steering System
- Steering Wheel Free Play Inspection
- Front End Alignment Inspection and Adjustment
- Main Data and Specifications
- Special Tools
- Power Steering Unit
- Power Steering Pump
- Transfer Gear Assembly
- Supplemental Restraint System Steering Wheel & Column
- Inflator Module
- Steering Wheel
- Combination Switch
- Lock Cylinder
- Steering Column
- Supplemental Restraint System Steering Wheel & Column and Associated Parts
- Power-Assisted Steering System
- Steering Gear
- Power-Assisted Steering System
- Service Precaution
- Diagnosis
- General Description
- Power Steering System Test
- Fluid Level
- Bleeding The Power Steering System
- Bleeding Procedure
- Flushing The Power Steering System
- Steering Wheel Free Play Inspection
- Front End Alignment Inspection and Adjustment
- Main Data and Specifications
- Special Tools
- Power Steering Unit
- Power Steering Pump
- Transfer Gear Assembly
- Supplemental Restraint System Steering Wheel & Column
- Inflator Module
- Steering Wheel
- Combination Switch
- Lock Cylinder
- Steering Column
- Supplemental Restraint System Steering Wheel & Column and Associated Parts
- Power-Assisted Steering System
- Steering Linkage
- Power-Assisted Steering System
- Service Precaution
- Diagnosis
- General Description
- Power Steering System Test
- Fluid Level
- Bleeding The Power Steering System
- Bleeding Procedure
- Flushing The Power Steering System
- Steering Wheel Free Play Inspection
- Front End Alignment Inspection and Adjustment
- Main Data and Specifications
- Special Tools
- Power Steering Unit
- Power Steering Pump
- Transfer Gear Assembly
- Supplemental Restraint System Steering Wheel & Column
- Inflator Module
- Steering Wheel
- Combination Switch
- Lock Cylinder
- Steering Column
- Supplemental Restraint System Steering Wheel & Column and Associated Parts
- Power-Assisted Steering System
- Manual Steering
- Suspension
- Electronic Suspension
- Intelligent Suspension System
- Service Precaution
- General Description
- General Diagnosis
- DTC 2 Actuator Coil Over Current
- DTC 3 Actuator Coil/Position Sensor Open Circuit or Short
- DTC 4 G-Sensor Open Circuit or Short
- DTC 5 Vehicle Speed Sensor Open Circuit or Short
- DTC 6 Stop Lamp Switch Open Circuit or Short
- DTC 7 Engine Speed Signal Open Circuit or Short
- DTC 9 Control Unit Abnormality
- Control Unit
- Front Actuator
- Rear Shock Absorber
- Intelligent Suspension System
- Front Suspension
- Rear Suspension
- Wheel Alignment
- Wheels & Tire System
- Electronic Suspension
- Transmission
- Automatic Trans
- Automatic Transmission (4L30-E)
- Service Precaution
- Construction
- Range Reference Chart
- Normal Operation of 2001 4L30-E Transmission
- Diagnosis
- Driver Information
- General Diagnosis Procedure
- Preliminary Inspection Chart
- Checking Transmission Fluid Level and Condition
- Test Driving
- Mechanical/Hydraulic Diagnosis Check Trans Indicator Chart
- Mechanical/Hydraulic Diagnosis Symptoms Index
- Perform Preliminary Inspection First!
- Chart 1: No Engine Start In Neutral Or Park
- Chart 2: No Forward Gears In Any Range/No Reverse
- Chart 3: No Engine Brake In Any Range
- Chart 4: Poor Shifting In All Gears (All Harsh Or All Soft)
- Chart 5a: Delays In Drive and Reverse
- Chart 5b: Delays In Reverse Only
- Chart 6: Diagnostic Trouble Code (DTC) P0730
- Chart 7: Harsh 1-2 Shift
- Chart 8: Harsh 3-4 Shift
- Chart 9a: 3-2 Downshift Complaint
- Chart 9b: Harsh Shift When Shifting Into "D" Or Accelerating From Stop
- Chart 9c: Coastdown Harsh Shift Or Clunk At 3-2 Downshift
- Chart 10: Intermittent 4TH To 2ND Gear Downshift At Steady Speed
- Chart 11: Engine Flare At Shifting During Turning Only (Usually With Warm Engine)
- Chart 12: Engine Flare During 1-2 Or 2-3 Shift
- Chart 13: Shudder Only During Torque Converter Clutch (TCC) Applying
- Chart 14: Possible Causes of Transmission Noise
- Chart 15a: Possible Causes of Low Line Pressure
- Chart 15b: Possible Causes of High Line Pressure
- Chart 16: Possible Causes of Transmission Fluid Leaks
- Stall Test
- Line Pressure Test
- Shift Speed Chart (V6)
- Lockup Speed Chart
- Shift Speed Chart (HEC)
- Changing Transmission Fluid
- Selector Lever
- Select Cable
- Shift Lock Cable
- Mode Switch
- Transmission Assembly
- Solenoid (Main Case Valve Body)
- Solenoid (Adapter Case Valve Body)
- Valve Body Assembly (Main Case)
- Valve Body Assembly (Adapter Case)
- Powertrain Control Module (PCM) (V6)
- Powertrain Control Module (PCM) (HEC)
- Speed Sensor (Extension Assembly)
- Transmission Oil Temperature Sensor (Main Case) (V6)
- Transmission Oil Temperature Sensor (Adapter Case) (HEC)
- Front Oil Seal (Converter Housing)
- Rear Oil Seal (Extension Assembly)
- Transmission (4L30-E)
- Converter Housing and Oil Pump Assembly
- Oil Pump
- Main Case Valve Body
- Adapter Case Valve Body
- Third Clutch and Sprag Unit
- Third Clutch
- Sprag Unit
- Second Clutch
- 3-4 Accumulator Piston
- Reverse Clutch Piston and Center Support
- Overrun Clutch and Turbine Shaft
- Main Data and Specifications
- Special Tools
- 4L30-E Parts List
- Servicing - A/T
- Transmission Control System (4L30-E) (HEC 2.2L)
- Service Precaution
- General Description
- Notes
- Electronic Control Diagram
- Powertrain Control Module (PCM)
- Control System Diagram
- Shift Control
- Band Apply Control
- Torque Converter Clutch Control
- Line Pressure Control
- On-Board Diagnostic System
- Fail-Safe Mechanism
- Torque Management Control
- ATF Warning Control
- Reverse Lock Out Control
- Downhill Control
- Uphill Control
- Shift Mode Control
- Gear Shift Control
- Winter Drive Mode
- Backup Mode
- Transmission Range Switch
- Functions of Input / Output Components
- Diagnosis
- Electronic Diagnosis
- Check Trans Indicator
- Diagnostic Check
- "Check Trans" Check
- Tech 2 OBD II Connection
- OBD II Diagnostic Management System
- 16 - Terminal Data Link Connector (DLC)
- Malfunction Indicator Lamp (MIL)
- DTC Types
- Clear DTC
- DTC Check
- PCM Precaution
- Information On PCM
- Intermittent Conditions
- Transmission and PCM Identification
- Isuzu Rodeo
- Diagnostic Trouble Code (DTC) Identification
- DTC P0218: Transmission Fluid Over Temperature
- DTC P0560: System Voltage Malfunction
- DTC P0705: Transmission Range Switch (Mode Switch) Illegal Position
- DTC P0706: Transmission Range Switch (Mode Switch) Performance
- DTC P0711: Transmission Fluid Temperature (TFT) Sensor Performance
- DTC P0712: Transmission Fluid Temperature (TFT) Sensor Circuit Low Input
- DTC P0713: Transmission Fluid Temperature (TFT) Sensor Circuit High Input
- DTC P0719: Brake Switch Circuit Low (Stuck On)
- DTC P0722: Automatic Transmission Output Shaft Speed Sensor (OSS) Low Input
- DTC P0723: Automatic Transmission Output Shaft Speed Sensor (OSS) Intermittent
- DTC P0724: Brake Switch Circuit High (Stuck Off)
- DTC P0730: Gear Error Without Input Speed
- DTC P0742: Torque Converter Clutch (TCC) System Stuck On
- DTC P0748: Pressure Control Solenoid (PCS) (Force Motor) Circuit Electrical
- DTC P0751: Shift Solenoid A Performance Without Input Speed Or Stuck Off
- DTC P0753: Shift Solenoid A Electrical
- DTC P0756: Shift Solenoid B Performance Without Input Speed Or Stuck Off
- DTC P0758: Shift Solenoid B Electrical
- DTC P1790: ROM Transmission Side Bad Check Sum
- DTC P1792: EEPROM Transmission Side Bad Check Sum
- DTC P1835: Kickdown Switch Always On
- DTC P1850: Brake Band Apply Solenoid Malfunction
- DTC P1860: TCC Solenoid Electrical
- DTC P1870: Transmission Component Slipping (TCC Stuck Off)
- Circuit Diagram
- Parts Location
- Harness Connector Faces
- Automatic Transmission (4L30-E)
- Transfer Case
- Driveline Control System
- Service Precaution
- Shift On The Fly System
- Shift On The Fly Electrical Equipment
- 4WD Control Unit
- Shift On The Fly Controller
- Transfer Case
- Service Precaution
- General Description
- Transfer Rear Oil Seal
- Transfer Case Assembly
- Transfer Control Unit
- Transfer Disassembly
- Main Data and Specifications
- Transfer Case Control System
- Transfer Controller
- Notes
- Removal
- Installation
- Function of Switch and Indicator Lamp
- 2H to 4H Retrial
- Parts Location
- Circuit Diagram
- Connector List
- Diagnosis
- Diagnosis From Symptom
- Check 4WD Lighting Up
- Cannot shift from 2WD to 4H or 4L. When shifting from 2H to other position, the indicator (4WD, 4Lo, Check 4WD) does not respond.
- Even after correction step 1-1(Before determining a trouble (Non-trouble mode)), the 4WD indicator still blinks at 2Hz and clicking sound of relay continues.
- Even after the correction step 1-2(Before determining a trouble (Non-trouble mode)), the 4WD indicator still blinks at 2Hz when shifting with clicking sound of relay from 2H to 4H.
- After operation, indicator of target position blinks for 1.5 sec. at 2Hz, return to 2H condition (4WD indicator going out)
- Transfer cannot shift to a position other than 4H. When shifting from 4H to other position, indicator (4WD, 4Lo, Check 4WD) does not respond (Only 4WD keeps lighting).
- Even after the correction step 2-1(Before determining a trouble (Non-trouble mode)), the 4WD indicator still blinks at 2Hz when shifting from 4H to 2H.
- Though the indicator responds when shifting from 4H to 2H (or other position), it returns to 4H.
- From 4H to 4L; Even after the correction step 3-3(Before determining a trouble (Non-trouble mode)), 4Lo indicator blinks at 4Hz
- From 4L to 4H: After the correction step 4-3(Before determining a trouble (Non-trouble mode)), 4Lo indicator blinks at 4H.
- Transfer Case Overhaul
- Driveline Control System
- Automatic Trans
- External Pages