Technical Service Bulletins

A/C Compressor
- Air Conditioning (A/C) Inoperative (JLRTB02109NAS1)
- R-12 Refrigerant - Jaguar Approved (SECTION ADM, NO. 6-46)
- Refrigerant R-12 Phase Out Information (SECTION 06, NO. 27)
- A/C Rotary Flaps Sticking: Diagnostics/Repair (SECTION 82, NO. 26)
- FREON Recovery/Recycling Equipment - Requirement (SECTION TOL, NO. 35)
Accessories Control Systems
- Portable Diagnostic Unit Software - Issue PDU 1031 (SECTION PDU, NO. 9)
- Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
- Battery Test Procedure (SECTION 86, NO. 75)
- Jaguar Diagnostic System - Pod 7/Upgrade Kit (SECTION TOL, NO. 22)
- JDS Software - Software Application Information (SECTION JDS, NO. 50)
- Jaguar Diagnostic System - Printout Reading Info (SECTION JDS, NO. 46)
- Jaguar Diagnostic System - Flexible ADAPTOR Probe (SECTION TOL, NO. 14)
- Jaguar Diagnostic System - Flexible Probe ADAPTOR (SECTION JDS, NO. 44)
- Jaguar Diagnostic Systems - ACCESORY ADAPTORS (SECTION JDS, NO. 42)
Anti-Theft Systems
- Sunroof Limit Switch Inoperative:Diagnosis Procedure (SECTION 86, NO. 106)
- Battery Test Procedure (SECTION 86, NO. 75)
- Water Leaks Into Trunk - Revised Trunk Lock Finisher (SECTION 76, NO. 57)
- Operation Of Radio Security System (SECTION 86, NO. 3)
- Antitheft Radio Code - Information (SECTION ELE, J86/43)
Automatic Trans
- Coolant Specification Change - Coolant D542 (Yellow) (SECTION 26, NO. 17)
- Engine Stall: Trans Fluid Level Low-Check Procedure (SECTION 18, NO. 31)
- Cooling System Antifreeze Leaks: Add Bar's Leaks (SECTION 26, NO. 7)
- Special Tool Introduction - Information/Chart (SECTION TOL, NO. 23)
- Use Of Gasohol (SECTION ENG, J83/36)
- Borg WARNER Trans Removal/Replacement - Precautions (SECTION A/T, J83/31)
Auxiliary Emission Control Systems
- Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
- PDU Software Release 1000 Error - Revised Procedure (SECTION JDS, NO. PDU)
- Jaguar Diagnostic System - Pod 7/Upgrade Kit (SECTION TOL, NO. 22)
- JDS Software - Software Application Information (SECTION JDS, NO. 50)
- Jaguar Diagnostic System - Printout Reading Info (SECTION JDS, NO. 46)
- Jaguar Diagnostic System - Flexible ADAPTOR Probe (SECTION TOL, NO. 14)
- Jaguar Diagnostic System - Flexible Probe ADAPTOR (SECTION JDS, NO. 44)
- Jaguar Diagnostic Systems - ACCESORY ADAPTORS (SECTION JDS, NO. 42)
- 1987 New Model Changes (SECTION GEN, J86/44)
- 4.2L Eng Hot Start Problems - Modification Kit (SECTION ENG, J83/32)
- Pick-Up Module Failure - Test/Replacement Procedure (SECTION ENG, J83/14)
Axle Shafts
- Rear Hub Master Spacer/Bearing Tool Availability (SECTION 64, NO. 11)
- Front Hub End Float: New Specs/Adjustment Procedures (SECTION 57, NO. 15)
Body Interior
- Changes To Calibration And As-Built Package V61 Or Greater. (SSM47397)
- Portable Diagnostic Unit Software - Issue PDU 1031 (SECTION PDU, NO. 9)
- Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
- A/C Ecu & Water Temp SW:Matched Pairs-Identification (SECTION 82, NO. 28)
- A/C Rotary Flaps Sticking: Diagnostics/Repair (SECTION 82, NO. 26)
- Jaguar Diagnostic System - Pod 7/Upgrade Kit (SECTION TOL, NO. 22)
- JDS Software - Software Application Information (SECTION JDS, NO. 50)
- Electronic Component Damage - Welding Precautions (SECTION 86, NO. 58)
- Jaguar Diagnostic System - Printout Reading Info (SECTION JDS, NO. 46)
- Jaguar Diagnostic System - Flexible ADAPTOR Probe (SECTION TOL, NO. 14)
- Jaguar Diagnostic System - Flexible Probe ADAPTOR (SECTION JDS, NO. 44)
- Jaguar Diagnostic Systems - ACCESORY ADAPTORS (SECTION JDS, NO. 42)
Brakes Control Systems
- Changes To Calibration And As-Built Package V61 Or Greater. (SSM47397)
- Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
- Power Hydraulic Diagnostic Component Kit (SECTION TOL, NO. 24)
- Jaguar Diagnostic System - Pod 7/Upgrade Kit (SECTION TOL, NO. 22)
- JDS Software - Software Application Information (SECTION JDS, NO. 50)
- Jaguar Diagnostic System - Printout Reading Info (SECTION JDS, NO. 46)
- Jaguar Diagnostic System - Flexible ADAPTOR Probe (SECTION TOL, NO. 14)
- Jaguar Diagnostic System - Flexible Probe ADAPTOR (SECTION JDS, NO. 44)
- Jaguar Diagnostic Systems - ACCESORY ADAPTORS (SECTION JDS, NO. 42)
Communication Devices
- Aftermarket Wheels Adversely Affect Vehicle Handling (WRKSHP ADM., NO. 6)
Cooling System (Mechanical)
- 'Coolant Level LOW' Message Displayed On The Instrument Panel Cluster (IPC) (JLRTB02027NAS3)
- 'Coolant Level LOW' Message Displayed On The Instrument Panel Cluster (IPC) (JLRTB02027NAS2)
- Coolant Specification Change - Coolant D542 (Yellow) (SECTION 26, NO. 17)
- CYL Head Rear Cover-Coolant/Oil Leaks: New Gasket (SECTION 12, NO. 32)
- Cooling System Antifreeze Leaks: Add Bar's Leaks (SECTION 26, NO. 7)
- Cooling System Leak - Add Sealant W/Antifreeze (SECTION 26, NO. 5)
- Rear Main Oil Seal Replacement Shortcut Caution (SECTION 12, NO. 24)
- 4.2L Eng Front Oil Seal - REPL Procedure Revision (SECTION ENG, J84/35)
Cruise Control Systems
- Cruise Control Set Speed Varies: FREEPLAY Inspection (SECTION 19, NO. 18)
Differentials & Drive Axles
- Coolant Specification Change - Coolant D542 (Yellow) (SECTION 26, NO. 17)
- Diff Noise At Various Speeds: Sound Insulation Pads (SECTION 51, NO. 2)
- Cooling System Antifreeze Leaks: Add Bar's Leaks (SECTION 26, NO. 7)
- Special Tool Introduction - Information/Chart (SECTION TOL, NO. 23)
- Rear Axle Oil Contamination : Wrong Lubricant (MAILGRAM P.U. #11-01)
- Use Of Gasohol (SECTION ENG, J83/36)
Electronic Suspension
- Power Hydraulic Diagnostic Component Kit (SECTION TOL, NO. 24)
Engine Control Systems
- Changes To Calibration And As-Built Package V61 Or Greater. (SSM47397)
- Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
- PDU Software Release 1000 Error - Revised Procedure (SECTION JDS, NO. PDU)
- Jaguar Diagnostic System - Pod 7/Upgrade Kit (SECTION TOL, NO. 22)
- JDS Software - Software Application Information (SECTION JDS, NO. 50)
- Jaguar Diagnostic System - Printout Reading Info (SECTION JDS, NO. 46)
- Jaguar Diagnostic System - Flexible ADAPTOR Probe (SECTION TOL, NO. 14)
- Jaguar Diagnostic System - Flexible Probe ADAPTOR (SECTION JDS, NO. 44)
- Jaguar Diagnostic Systems - ACCESORY ADAPTORS (SECTION JDS, NO. 42)
- Pick-Up Module Failure - Test/Replacement Procedure (SECTION ENG, J83/14)
Entertainment Systems
- Antenna Mast Seizure/Failure - Clean Or Replace (SECTION 86, NO. 93)
- Radio Failure/Water Entry - Condensation Shield (SECTION 86, NO. 85)
- Radio Reception Poor - Am & Fm Operation (SECTION 86, NO. 87)
- Radio Interference - Jaguar Diagnostic System Guide (SECTION 86, NO. 50)
- Operation Of Radio Security System (SECTION 86, NO. 3)
- Antitheft Radio Code - Information (SECTION ELE, J86/43)
- Equipment Supplied W/Car (SECTION GEN, J86/32)
Exterior Body Panels
- Fuel Filler APERATURE Drain Blocked:Strainer Install (SECTION 19, NO. 21)
- Water Leaks Into Trunk - Revised Trunk Lock Finisher (SECTION 76, NO. 57)
Exterior Lights
- Bulb Failure Warning: Manual Diagnosis Procedure (SECTION 86, NO. 110)
- Battery Test Procedure (SECTION 86, NO. 75)
- Audible Warning Lights On - Retrofit Instructions (SECTION 86, NO. 54)
Front Suspension
- Power Hydraulic Diagnostic Component Kit (SECTION TOL, NO. 24)
- Coil SPRNG COMPRSSOR Anchor Pin Loose - New Kit (SECTION TOL, NO. 17)
Fuel System
- Throttle Valve Clearance Adjustment Guidelines (SECTION 19, NO. 23)
Fuses & Circuit Breakers
- Portable Diagnostic Unit Software - Issue PDU 1031 (SECTION PDU, NO. 9)
- Bulb Failure Warning: Manual Diagnosis Procedure (SECTION 86, NO. 110)
- Battery Test Procedure (SECTION 86, NO. 75)
- Electronic Component Damage - Welding Precautions (SECTION 86, NO. 58)
Gauges & Instrument Panels
- 'Coolant Level LOW' Message Displayed On The Instrument Panel Cluster (IPC) (JLRTB02027NAS3)
- 'Coolant Level LOW' Message Displayed On The Instrument Panel Cluster (IPC) (JLRTB02027NAS2)
- Wood Veneer Panels Repair Kit (SECTION 76, NO. 59)
- Battery Test Procedure (SECTION 86, NO. 75)
- Audible Warning Lights On - Retrofit Instructions (SECTION 86, NO. 54)
Headlights
- Bulb Failure Warning: Manual Diagnosis Procedure (SECTION 86, NO. 110)
- Battery Test Procedure (SECTION 86, NO. 75)
- Audible Warning Lights On - Retrofit Instructions (SECTION 86, NO. 54)
HVAC Control Systems
- R-12 Refrigerant - Jaguar Approved (SECTION ADM, NO. 6-46)
- Refrigerant R-12 Phase Out Information (SECTION 06, NO. 27)
- A/C Rotary Flaps Sticking: Diagnostics/Repair (SECTION 82, NO. 26)
- A/C Blower Motor Noise - Replacement Part Numbers (SECTION 82, NO. 25)
- A/C Compressor Noise/Leak - Diagnosis/Repair (SECTION 82, NO. 24)
- FREON Recovery/Recycling Equipment - Requirement (SECTION TOL, NO. 35)
Identification
- Replacement Of Identification Labels (SECTION 06, NO. 39)
- VIN & Certification Labels/Plate Replacement (WRKSHP ADM., NO. 19)
Ignition System
- Idle Misfire - Oscilloscope Spark Plug Diagnosis (SECTION 18, NO. 20)
- Systems Checks Before EFI EPITEST (SECTION EFI, J86/36)
- Pick-Up Module Failure - Test/Replacement Procedure (SECTION ENG, J83/14)
Interior/Exterior Trim
- Approved Cleaning Products By AUTOGLYM (JAGA100-001)
- Wood Veneer Repair Program (A-01)
- Jaguar Approved Cleaners - Parts Numbers (SECTION ADM, NO. 1-75)
- Wood Veneer Panels Repair Kit (SECTION 76, NO. 59)
- Wood Veneer Panel Repair - Kit (SECTION TOL, NO. 34)
- Equipment Supplied W/Car (SECTION GEN, J86/32)
Interior/Illumination Lights
- Bulb Failure Warning: Manual Diagnosis Procedure (SECTION 86, NO. 110)
- Battery Test Procedure (SECTION 86, NO. 75)
- Audible Warning Lights On - Retrofit Instructions (SECTION 86, NO. 54)
Lubrication System
- Coolant Specification Change - Coolant D542 (Yellow) (SECTION 26, NO. 17)
- Oil Filter ASSY: Replace W/Sandwich Plate Removed (SECTION 12, NO. 37)
- CYL Head Rear Cover-Coolant/Oil Leaks: New Gasket (SECTION 12, NO. 32)
- Cooling System Antifreeze Leaks: Add Bar's Leaks (SECTION 26, NO. 7)
- Rear Main Oil Seal Replacement Shortcut Caution (SECTION 12, NO. 24)
- 4.2L Eng Front Oil Seal - REPL Procedure Revision (SECTION ENG, J84/35)
- Use Of Gasohol (SECTION ENG, J83/36)
Manual Steering
- Pas-Lack Of Power Assistance: Repair Procedure (SECTION 57, NO. 14)
- Steering Rack MOUNTNG Bushings Replacement Tool (SECTION 57, NO. 8)
- Power Steering Rack Reconditioned By OEM Available (SECTION 57, NO. 6)
Manual Trans
- Rear Axle Oil Contamination : Wrong Lubricant (MAILGRAM P.U. #11-01)
Mechanical
- Jaguar Approved Cleaners - Parts Numbers (SECTION ADM, NO. 1-75)
- CYL Head Rear Cover-Coolant/Oil Leaks: New Gasket (SECTION 12, NO. 32)
- Rear Main Oil Seal Replacement Shortcut Caution (SECTION 12, NO. 24)
- 4.2L Eng Front Oil Seal - REPL Procedure Revision (SECTION ENG, J84/35)
- 4.2L Eng Tappet Noise - Valve Guide Retainer Plate (SECTION ENG, J82/44)
Mechanical - Hydraulic
- Coolant Specification Change - Coolant D542 (Yellow) (SECTION 26, NO. 17)
- Brake Fluid Replacement Intervals (SECTION 70, NO. 20)
- Cooling System Antifreeze Leaks: Add Bar's Leaks (SECTION 26, NO. 7)
- Power Hydraulic Diagnostic Component Kit (SECTION TOL, NO. 24)
- Use Of Gasohol (SECTION ENG, J83/36)
Memory Modules
- Battery Test Procedure (SECTION 86, NO. 75)
Paint & Coatings
- Exterior Paint Issues Reporting Aid (XJ501-023)
- Jaguar Approved Cleaners - Parts Numbers (SECTION ADM, NO. 1-75)
- Repairing Paint Damage With MEGUIAR'S Products (SECTION 76, NO. 52)
- DUPONT Color Mix Codes : Cob Color Paint Formulation (SECTION 76, NO. 1)
- 1987 New Model Changes (SECTION GEN, J86/44)
- Paint Technology Change : Paint Codes (SECTION BDY, J86/41)
- Equipment Supplied W/Car (SECTION GEN, J86/32)
Parking Brake System
- Parking Brake Does Not Release (JTB00044)
Procedures
- Lower Than Actual Compression Figures Using The K00825-0/JLR-4425 COMPRESSIOR Tester Kit (SSM75380)
- Use Of Non Approved Jaguar Land Rover Anti Bacterial Fogging Agents (SSM75126)
Rear Suspension
- Power Hydraulic Diagnostic Component Kit (SECTION TOL, NO. 24)
- Coil SPRNG COMPRSSOR Anchor Pin Loose - New Kit (SECTION TOL, NO. 17)
Restraints Control Systems
- Changes To Calibration And As-Built Package V61 Or Greater. (SSM47397)
- Jaguar Diagnostic System - Pod 7/Upgrade Kit (SECTION TOL, NO. 22)
- JDS Software - Software Application Information (SECTION JDS, NO. 50)
- Jaguar Diagnostic System - Printout Reading Info (SECTION JDS, NO. 46)
- Jaguar Diagnostic System - Flexible ADAPTOR Probe (SECTION TOL, NO. 14)
- Jaguar Diagnostic System - Flexible Probe ADAPTOR (SECTION JDS, NO. 44)
- Jaguar Diagnostic Systems - ACCESORY ADAPTORS (SECTION JDS, NO. 42)
Schedule
- Coolant Specification Change - Coolant D542 (Yellow) (SECTION 26, NO. 17)
Seats
- Approved Cleaning Products By AUTOGLYM (JAGA100-001)
- Front Seat Belts Rattle - Repair Procedure (SECTION 76, NO. 92)
- Passive Belt Disconnection Not Permissible (WRKSHP ADM., NO. 5)
- 1987 New Model Changes (SECTION GEN, J86/44)
Starter
- Battery Update : New Battery Type (SECTION ELE, MEMO 10/90)
Steering Control Systems
- Jaguar Diagnostic System - Pod 7/Upgrade Kit (SECTION TOL, NO. 22)
- JDS Software - Software Application Information (SECTION JDS, NO. 50)
- Jaguar Diagnostic System - Printout Reading Info (SECTION JDS, NO. 46)
- Jaguar Diagnostic System - Flexible ADAPTOR Probe (SECTION TOL, NO. 14)
- Jaguar Diagnostic System - Flexible Probe ADAPTOR (SECTION JDS, NO. 44)
- Jaguar Diagnostic Systems - ACCESORY ADAPTORS (SECTION JDS, NO. 42)
Steering Gear
- Pas-Lack Of Power Assistance: Repair Procedure (SECTION 57, NO. 14)
- Steering Rack MOUNTNG Bushings Replacement Tool (SECTION 57, NO. 8)
- Power Steering Rack Reconditioned By OEM Available (SECTION 57, NO. 6)
Steering Linkage
- Rear Hub Master Spacer/Bearing Tool Availability (SECTION 64, NO. 11)
- Front Hub End Float: New Specs/Adjustment Procedures (SECTION 57, NO. 15)
Sun Roof/T-Top/Convertible Top
- Sunroof Limit Switch Inoperative:Diagnosis Procedure (SECTION 86, NO. 106)
Suspension Control Systems
- Power Hydraulic Diagnostic Component Kit (SECTION TOL, NO. 24)
- Jaguar Diagnostic System - Pod 7/Upgrade Kit (SECTION TOL, NO. 22)
- JDS Software - Software Application Information (SECTION JDS, NO. 50)
- Jaguar Diagnostic System - Printout Reading Info (SECTION JDS, NO. 46)
- Jaguar Diagnostic System - Flexible ADAPTOR Probe (SECTION TOL, NO. 14)
- Jaguar Diagnostic System - Flexible Probe ADAPTOR (SECTION JDS, NO. 44)
- Jaguar Diagnostic Systems - ACCESORY ADAPTORS (SECTION JDS, NO. 42)
System
- Changes To Calibration And As-Built Package V61 Or Greater. (SSM47397)
- Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
- PDU Software Release 1000 Error - Revised Procedure (SECTION JDS, NO. PDU)
- Throttle Valve Clearance Adjustment Guidelines (SECTION 19, NO. 23)
- CYL Head Rear Cover-Coolant/Oil Leaks: New Gasket (SECTION 12, NO. 32)
- Idle Misfire - Oscilloscope Spark Plug Diagnosis (SECTION 18, NO. 20)
- Rear Main Oil Seal Replacement Shortcut Caution (SECTION 12, NO. 24)
- Jaguar Diagnostic System - Pod 7/Upgrade Kit (SECTION TOL, NO. 22)
- JDS Software - Software Application Information (SECTION JDS, NO. 50)
- Jaguar Diagnostic System - Printout Reading Info (SECTION JDS, NO. 46)
- Jaguar Diagnostic System - Flexible ADAPTOR Probe (SECTION TOL, NO. 14)
- Jaguar Diagnostic System - Flexible Probe ADAPTOR (SECTION JDS, NO. 44)
- Jaguar Diagnostic Systems - ACCESORY ADAPTORS (SECTION JDS, NO. 42)
- 1987 New Model Changes (SECTION GEN, J86/44)
- Systems Checks Before EFI EPITEST (SECTION EFI, J86/36)
- 4.2L Eng Front Oil Seal - REPL Procedure Revision (SECTION ENG, J84/35)
- 4.2L Eng Hot Start Problems - Modification Kit (SECTION ENG, J83/32)
- Pick-Up Module Failure - Test/Replacement Procedure (SECTION ENG, J83/14)
Transfer Case
- Rear Axle Oil Contamination : Wrong Lubricant (MAILGRAM P.U. #11-01)
Transmission Control Systems
- Changes To Calibration And As-Built Package V61 Or Greater. (SSM47397)
- Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
- Jaguar Diagnostic System - Pod 7/Upgrade Kit (SECTION TOL, NO. 22)
- JDS Software - Software Application Information (SECTION JDS, NO. 50)
- Jaguar Diagnostic System - Printout Reading Info (SECTION JDS, NO. 46)
- Jaguar Diagnostic System - Flexible ADAPTOR Probe (SECTION TOL, NO. 14)
- Jaguar Diagnostic System - Flexible Probe ADAPTOR (SECTION JDS, NO. 44)
- Jaguar Diagnostic Systems - ACCESORY ADAPTORS (SECTION JDS, NO. 42)
Wheel Hubs
- Rear Hub Master Spacer/Bearing Tool Availability (SECTION 64, NO. 11)
- Front Hub End Float: New Specs/Adjustment Procedures (SECTION 57, NO. 15)
Wheels & Tire System
- PIRELLI P5 Discontinued - Replace With P4000 (SECTION 04, NO. 21)
- Rear Hub Master Spacer/Bearing Tool Availability (SECTION 64, NO. 11)
- Front Hub End Float: New Specs/Adjustment Procedures (SECTION 57, NO. 15)
- Tire Pressure Correction For Maximum Ride Comfort (SECTION 04, NO. 4)
- Aftermarket Wheels Adversely Affect Vehicle Handling (WRKSHP ADM., NO. 6)
- Equipment Supplied W/Car (SECTION GEN, J86/32)
Window Motors & Regulators
- Windshield Damage Diagnostic Aid (JAGA501-001)
- Sunroof Limit Switch Inoperative:Diagnosis Procedure (SECTION 86, NO. 106)
- Special Tool Introduction - Information/Chart (SECTION TOL, NO. 23)
Wiper/Washer Systems
- Removing Transit Wiper Protection At PDI (XJ501-024)
- Windshield Wiper Smearing -Use Jaguar Cleaning Paste (SECTION 84, NO. 11)
- Windshield Wiper Streaking/Smearing: New Arm & Blade (SECTION 84, NO. 9)
- New 7 Liter Washer Fluid Reservoir Installation (SECTION 84, NO. 8)
- Windshield Cleaning/Windshield Wiper Info (SECTION 84, NO. 1)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Portable Diagnostic Unit Software - Issue PDU 1031 (SECTION PDU, NO. 9)
- Battery Test Procedure (SECTION 86, NO. 75)
- Electronic Component Damage - Welding Precautions (SECTION 86, NO. 58)