Technical Service Bulletins
- A/C Compressor
- Air Conditioning (A/C) Inoperative (JLRTB02109NAS1)
- Leak Detection System - Ultraviolet Dye (SECTION 82, NO. 52)
- R-134A Retrofit Kits (SECTION 82, NO. 39 REV.)
- R-12 Refrigerant - Jaguar Approved (SECTION ADM, NO. 6-46)
- New PAG A/C Oil For NIPPONDENSO Compressor - Info (SECTION 82, NO. 43)
- R134A A/C System Connections: Revised Torque Specs (SECTION 82, NO. 35)
- R134A System "O" Ring Specification: Service Info (SECTION 82, NO. 34)
- R134A A/C System: Butyl 'O' Ring Seals Recommended (SECTION 82, NO. 33)
- A/C Compressor Seal Remove/Replace Tool Availability (SECTION 01, NO. 48)
- Refrigerant R-12 Phase Out Information (SECTION 06, NO. 27)
- A/C Rotary Flaps Sticking: Diagnostics/Repair (SECTION 82, NO. 26)
- Accessories Control Systems
- Accessory Drive Belts
- Air Bag, SRS
- Anti-Lock Brakes
- Anti-Theft Systems
- Automatic Trans
- Coolant Specification Change - Coolant D542 (Yellow) (SECTION 26, NO. 17)
- ZF 4HP 24 E9 Automatic Transmission Shift Quality (SECTION 44, NO. 27)
- A/T Gear Selector Locks In Park - Repair Procedure (SECTION 86, NO. 146)
- ZF A/T Internal Damage Due To High Rpm In "P" Or "N" (SECTION 44, NO. 26)
- ZF A/T Noise In Reverse Gear When Cold - Procedure (SECTION 44, NO. 25)
- A/T Defaults To "Limp Mode" In Wet Weather-Procedure (SECTION 04, NO. 18)
- Engine Stalls When Engaged In "R" Or "D" - Procedure (SECTION 44, NO. 23)
- A/T Shift Quality, Harsh - Install Modified TCM (SECTION 44, NO. 21)
- Engine Stall: Trans Fluid Level Low-Check Procedure (SECTION 18, NO. 31)
- Cooling System Antifreeze Leaks: Add Bar's Leaks (SECTION 26, NO. 7)
- Auxiliary Emission Control Systems
- New PDU Software - JTP 626/4 (SECTION PDU, NO. 12)
- New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
- Service Action S458 - Air Pump Clutch Operation (SECTION 17, NO. 9 REV.)
- Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
- Check Engine Light On, DTC 12 - Changeover Relay (SECTION 18, NO. 36)
- Momentary Engine Power Loss Or Stalling - Diagnosis (SECTION 18, NO. 38)
- PDU Software Release 1000 Error - Revised Procedure (SECTION JDS, NO. PDU)
- Multiple Procedural Updates (SECTION 04, NO. 12)
- "Check Engine" On/DTC 12 - New EFI Relay & Leads (SECTION 18, NO. 33)
- Air INJ Pump Operation After Eng Start:Revised CTL (SECTION 18, NO. 34)
- Diagnostic Trouble Code 44: O2 Sensor Splash Shield (SECTION 18, NO. 30)
- Pin Checking/Gauge Tool Availability (SECTION 01, NO. 52)
- Software Issue DBC 4070: Faults Diagnosis (SECTION JDS, NO. 62)
- Axle Shafts
- Body Interior
- Changes To Calibration And As-Built Package V61 Or Greater. (SSM47397)
- New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
- Portable Diagnostic Unit Software - Issue PDU 1031 (SECTION PDU, NO. 9)
- Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
- A/T Defaults To "Limp Mode" In Wet Weather - Repair (SECTION 44, NO. 24)
- Pin Checking/Gauge Tool Availability (SECTION 01, NO. 52)
- Software Issue DBC 4070: Faults Diagnosis (SECTION JDS, NO. 62)
- A/C Ecu & Water Temp SW:Matched Pairs-Identification (SECTION 82, NO. 28)
- A/C Rotary Flaps Sticking: Diagnostics/Repair (SECTION 82, NO. 26)
- Brakes Control Systems
- Charging Systems
- Communication Devices
- Component Locations
- Cooling System (Mechanical)
- 'Coolant Level LOW' Message Displayed On The Instrument Panel Cluster (IPC) (JLRTB02027NAS3)
- 'Coolant Level LOW' Message Displayed On The Instrument Panel Cluster (IPC) (JLRTB02027NAS2)
- Coolant Specification Change - Coolant D542 (Yellow) (SECTION 26, NO. 17)
- 4.0L(AJ6 & AJ16) Fuel Injectors - Identification (SECTION 18, NO. 46)
- Cooling Fans Not Working Properly - Control Module (SECTION 86, NO. 140)
- 4.0L Oil Pump Sealer Specification (SECTION 12, NO. 49)
- Erosion Of Head Gasket Surface -Use Filler Material (SECTION 12, NO. 48)
- Coolant Header Tank Cap Seal Leak: Lubricate Seal (SECTION 26, NO. 11)
- CYL Heads/Gaskets: Added Cooling Holes (4.0L AJ6) (SECTION 12, NO. 45)
- Revised Water Pump: New Center Gasket (4.0L AJ6) (SECTION 26, NO. 10)
- Coolant Header Tank Cap Seal Leak-Lubricate Seal (SECTION 26, NO. 12)
- Revised Water Pump W/New Center Gasket ASSY (SECTION 26, NO. 9)
- Coolant System Pressure Test ADAPTOR Usage (SECTION 01, NO. 54)
- CYL Head Rear Cover-Coolant/Oil Leaks: New Gasket (SECTION 12, NO. 32)
- CYL Head Gasket-Coolant Seepage: Add Bar's Leaks (SECTION 12, NO. 30)
- Cooling System Antifreeze Leaks: Add Bar's Leaks (SECTION 26, NO. 7)
- Cruise Control Systems
- Differentials & Drive Axles
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Changes To Calibration And As-Built Package V61 Or Greater. (SSM47397)
- Background Download Icon 'Software Update Should Be PERFORMED' (SSM46877)
- Removal Of Seized Oxygen (O2) Sensors (JAGA309-001)
- Final PDU Software - JTP 626/7 And JTP 627/10 (SECTION 1, NO. 125)
- New PDU Software - JTP 626/7 And JTP 627/8 (SECTION 1, NO. 110)
- New PDU Software - JTP 626/4 (SECTION PDU, NO. 12)
- New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
- Special Tool JD 208 - Fuel Pressure Testing (SECTION 19, NO. 39)
- Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
- Check Engine Light On, DTC 12 - Changeover Relay (SECTION 18, NO. 36)
- Momentary Engine Power Loss Or Stalling - Diagnosis (SECTION 18, NO. 38)
- PDU Software Release 1000 Error - Revised Procedure (SECTION JDS, NO. PDU)
- Multiple Procedural Updates (SECTION 04, NO. 12)
- "Check Engine" On/DTC 12 - New EFI Relay & Leads (SECTION 18, NO. 33)
- Air INJ Pump Operation After Eng Start:Revised CTL (SECTION 18, NO. 34)
- Diagnostic Trouble Code 44: O2 Sensor Splash Shield (SECTION 18, NO. 30)
- Pin Checking/Gauge Tool Availability (SECTION 01, NO. 52)
- Software Issue DBC 4070: Faults Diagnosis (SECTION JDS, NO. 62)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- General Servicing
- Headlights
- HVAC Control Systems
- Leak Detection System - Ultraviolet Dye (SECTION 82, NO. 52)
- R-134A Retrofit Kits (SECTION 82, NO. 39 REV.)
- A/C System Servicing - Preventing Entry Of Moisture (SECTION 82, NO. 50)
- R-12 Refrigerant - Jaguar Approved (SECTION ADM, NO. 6-46)
- Climate Control System - Pressure Switch Location (SECTION 82, NO. 45)
- New PAG A/C Oil For NIPPONDENSO Compressor - Info (SECTION 82, NO. 43)
- Multiple Procedural Updates (SECTION 04, NO. 12)
- A/C System Inoperative: Diagnostic Procedure (SECTION 82, NO. 37)
- A/C Vacuum Reservoir: New Location (SECTION 82, NO. 36)
- R134A A/C System Connections: Revised Torque Specs (SECTION 82, NO. 35)
- R134A System "O" Ring Specification: Service Info (SECTION 82, NO. 34)
- R134A A/C System: Butyl 'O' Ring Seals Recommended (SECTION 82, NO. 33)
- A/C Compressor Seal Remove/Replace Tool Availability (SECTION 01, NO. 48)
- Noisy A/C Blower Motors: Revised Motor (SECTION 82, NO. 31)
- Refrigerant R-12 Phase Out Information (SECTION 06, NO. 27)
- A/C Rotary Flaps Sticking: Diagnostics/Repair (SECTION 82, NO. 26)
- Identification
- Ignition System
- Infotainment
- Interior/Exterior Trim
- Interior/Illumination Lights
- Locking Hubs
- Lubrication System
- Coolant Specification Change - Coolant D542 (Yellow) (SECTION 26, NO. 17)
- 4.0L(AJ6 & AJ16) Fuel Injectors - Identification (SECTION 18, NO. 46)
- 4.0L Oil Pump Sealer Specification (SECTION 12, NO. 49)
- Erosion Of Head Gasket Surface -Use Filler Material (SECTION 12, NO. 48)
- CYL Heads/Gaskets: Added Cooling Holes (4.0L AJ6) (SECTION 12, NO. 45)
- Revised Water Pump: New Center Gasket (4.0L AJ6) (SECTION 26, NO. 10)
- Revised Water Pump W/New Center Gasket ASSY (SECTION 26, NO. 9)
- CYL Head Rear Cover-Coolant/Oil Leaks: New Gasket (SECTION 12, NO. 32)
- CYL Head Gasket-Coolant Seepage: Add Bar's Leaks (SECTION 12, NO. 30)
- Cooling System Antifreeze Leaks: Add Bar's Leaks (SECTION 26, NO. 7)
- Manual Steering
- Mechanical
- Upper Chain Guide Bolts - Apply Locking Compound (SECTION 12, NO. 64)
- Cylinder Head Bolts - Reuse Twice - Conditions (SECTION 12, NO. 62)
- Main Bearing Cap Bolts - Reuse Twice - Conditions (SECTION 12, NO. 63)
- Jaguar Approved Cleaners - Parts Numbers (SECTION ADM, NO. 1-75)
- Rattle After Start/Upper Timing Chain/New TENSIONER (SECTION 12, NO. 61)
- 4.0L(AJ6 & AJ16) Fuel Injectors - Identification (SECTION 18, NO. 46)
- Poor Running In Wet Or Hot Weather - Air Cleaner (SECTION 19, NO. 31)
- Oil Leak From Generator Bracket Bolts - Use LOCTITE (SECTION 12, NO. 50)
- AJ6 Engines - Torque Specifications For Drain Plug (SECTION 12, NO. 52)
- 4.0L Oil Pump Sealer Specification (SECTION 12, NO. 49)
- Erosion Of Head Gasket Surface -Use Filler Material (SECTION 12, NO. 48)
- CYL Heads/Gaskets: Added Cooling Holes (4.0L AJ6) (SECTION 12, NO. 45)
- Size Graded CRAKSHAFT Bearings Intro: 4.0L/6.0L/V12 (SECTION 12, NO. 44)
- Revised Water Pump: New Center Gasket (4.0L AJ6) (SECTION 26, NO. 10)
- Revised Water Pump W/New Center Gasket ASSY (SECTION 26, NO. 9)
- Inconsistent Idle Speed Settings: Idle Air Valve Adj (SECTION JDS, NO. 64)
- CYL Head Rear Cover-Coolant/Oil Leaks: New Gasket (SECTION 12, NO. 32)
- CYL Head Gasket-Coolant Seepage: Add Bar's Leaks (SECTION 12, NO. 30)
- Mechanical - Hydraulic
- Memory Modules
- Mirrors
- Overdrive Unit
- Paint & Coatings
- Parking Brake System
- Passive Restraints
- Procedures
- Rear Suspension
- Restraints Control Systems
- Schedule
- Seats
- Starter
- Steering Column
- Steering Column Switches
- Steering Control Systems
- Steering Gear
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- System
- Changes To Calibration And As-Built Package V61 Or Greater. (SSM47397)
- Background Download Icon 'Software Update Should Be PERFORMED' (SSM46877)
- Final PDU Software - JTP 626/7 And JTP 627/10 (SECTION 1, NO. 125)
- Spark Plug "Blow-By Stain"/Corona Stain - Spark Plug Function Not Affected - Replacement Unnecessary (SECTION 18, NO. 55)
- New PDU Software - JTP 626/7 And JTP 627/8 (SECTION 1, NO. 110)
- New PDU Software - JTP 626/4 (SECTION PDU, NO. 12)
- New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
- Service Action S458 - Air Pump Clutch Operation (SECTION 17, NO. 9 REV.)
- Special Tool JD 208 - Fuel Pressure Testing (SECTION 19, NO. 39)
- Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
- 4.0L(AJ6 & AJ16) Fuel Injectors - Identification (SECTION 18, NO. 46)
- Poor Running In Wet Or Hot Weather - Air Cleaner (SECTION 19, NO. 31)
- Check Engine Light On, DTC 12 - Changeover Relay (SECTION 18, NO. 36)
- 4.0L Oil Pump Sealer Specification (SECTION 12, NO. 49)
- Erosion Of Head Gasket Surface -Use Filler Material (SECTION 12, NO. 48)
- Momentary Engine Power Loss Or Stalling - Diagnosis (SECTION 18, NO. 38)
- PDU Software Release 1000 Error - Revised Procedure (SECTION JDS, NO. PDU)
- Multiple Procedural Updates (SECTION 04, NO. 12)
- CYL Heads/Gaskets: Added Cooling Holes (4.0L AJ6) (SECTION 12, NO. 45)
- Throttle Valve Clearance Adjustment Guidelines (SECTION 19, NO. 23)
- "Check Engine" On/DTC 12 - New EFI Relay & Leads (SECTION 18, NO. 33)
- Air INJ Pump Operation After Eng Start:Revised CTL (SECTION 18, NO. 34)
- Diagnostic Trouble Code 44: O2 Sensor Splash Shield (SECTION 18, NO. 30)
- Revised Water Pump: New Center Gasket (4.0L AJ6) (SECTION 26, NO. 10)
- Pin Checking/Gauge Tool Availability (SECTION 01, NO. 52)
- Software Issue DBC 4070: Faults Diagnosis (SECTION JDS, NO. 62)
- Distributor Body/Rotor Arm: Set Position Using Tool (SECTION 18, NO. 25)
- Revised Water Pump W/New Center Gasket ASSY (SECTION 26, NO. 9)
- Distributor Setting Gauge Tool Availability (SECTION 01, NO. 49)
- Inconsistent Idle Speed Settings: Idle Air Valve Adj (SECTION JDS, NO. 64)
- CYL Head Rear Cover-Coolant/Oil Leaks: New Gasket (SECTION 12, NO. 32)
- CYL Head Gasket-Coolant Seepage: Add Bar's Leaks (SECTION 12, NO. 30)
- Transmission Control Systems
- Vacuum Pumps/Lines/Tanks/Water Trap
- Warning Systems
- Wheel Hubs
- Wheels & Tire System
- Window Motors & Regulators
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)