Technical Service Bulletins

A/C Compressor
- Air Conditioning (A/C) Inoperative (JLRTB02109NAS1)
- Leak Detection System - Ultraviolet Dye (SECTION 14, NO. 14)
- R-134A Refrigerant - Jaguar Approved (SECTION ADM, NO. 6-50)
Accessories & Equipment
- PDU Download Capture/Print Out - Additional R.O.T. (01-23)
Accessories Control Systems
- SDD 152.05 Diagnostic Trouble Codes (DTC) Not Shown In Some Modules (SSM73807)
- JTP 759/13 WDS Software (SECTION 1, NO. 130)
- JTP 759/10 WDS Software (SECTION 1, NO. 126)
- Final PDU Software - JTP 626/7 And JTP 627/10 (SECTION 1, NO. 125)
- JTP 759/9 WDS Software (SECTION 1, NO. 124)
- JTP 759/8 WDS Software (SECTION 1, NO. 123)
- JTP 759/6 WDS Software (SECTION 1, NO. 122)
- JTP 759/5 WDS Software (SECTION 1, NO. 121)
- JTP 759/4 WDS Software (SECTION 1, NO. 120)
- New PDU Software - JTP 626/7 And JTP 627/8 (SECTION 1, NO. 110)
- New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
- Portable Diagnostic Unit Software - Issue PDU 1031 (SECTION PDU, NO. 9)
Air Bag, SRS
- SRS Airbag - Deactivation Switch - Installation (SECTION 15, NO. 51)
- SRS Airbag - Deactivation - Install Shunt (SECTION 15, NO. 46)
- SRS Airbag Mil Illumination -DTC 32- Loose Connector (SECTION 15, NO. 36)
- Passenger Airbag Warning Label - Owner Letter (SECTION ADM, NO. 6-51)
- Airbag Door - Adjusting Clearances (SECTION 19.5, NO. 01)
- Airbag Door & Fascia Noise - Repair Procedure (SECTION 19.5, NO. 02)
Anti-Lock Brakes
- Brake Pedal Switch - Parts Inventory Simplified (SECTION 12, NO. 10)
- Traction Control Cable - Check Cable Position (SECTION 19.6, NO. 03)
Anti-Theft Systems
- Security System - Inclination & Intrusion Sensors (SECTION 86, NO. 154)
- Airbag Door - Adjusting Clearances (SECTION 19.5, NO. 01)
- Airbag Door & Fascia Noise - Repair Procedure (SECTION 19.5, NO. 02)
- Security System - Handset Transmitter - Manual Prog. (SECTION 86, NO. 160)
Automatic Trans
- Coolant Specification Change - Coolant D542 (Yellow) (SECTION 26, NO. 17)
- Coolant Specification Change - Coolant D542 (Yellow) (SECTION 4.1, NO. 02)
- Sliding Roof - Drive Cables - Water-Resist Grease (SECTION 13, NO. 30)
- Loss Of 4TH Gear, Slipping In 4TH Gear, Busy (77-71-77)
- ZF 4HP 24 E Transmission Diagnosis - Using PDU To Verify Fluid Is At Operating Temperature (08.1-02)
- Automatic Transmission-Pressure Testing Gauge JD 204 (SECTION 08.2, NO. 02)
- ZF 4 Hp 24 E Transmission - Diagnostic Flowcharts (08.1-03)
- Fluid Leak At BELLHOUSING - ZF 4HP 24 E Auto Trans (SECTION 08.1, NO. 05)
- ZF 4 Hp 24 E Transmission - Diagnostic Flowcharts (SECTION 08.1, NO. 03)
Auxiliary Emission Control Systems
- JTP 759/13 WDS Software (SECTION 1, NO. 130)
- Recall R493 - AJ16 EGR System - Replace Proms And EGR Valve (SECTION 05.1, NO. 26)
- New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
- Evaporative Loss System Check - Clarified Procedure (SECTION 5.1, NO. 29)
- Evaporative Loss System Check - Clarified Procedure (05.1-29)
- Replacement Air Injection Pump - Upgrade Fuse Rating (SECTION 5.1, NO. 30)
- Service Action S659 - 4.0/6.0L Eng Mil DTC P0300 (SECTION 05.1 NO. 08)
- Service Action S672 - DTC P0441 - Mil Illumination (SECTION 05.1, NO. 22)
- Insufficient Air Flow - Air Pump (AIRP) - Diagnosis (SECTION 5.1, NO. 27)
- Heated Oxygen Sensor Torque Specification - Revised (SECTION 18, NO. 45)
- Enhanced Evaporative System Vehicles - Leak Check (SECTION ADM, NO. 1-76)
- Idle Speed Adj. Procedure - AJ16 Engines - Deposits (05.1-23 REV.)
- EGR Valve Harness - Reroute - Service Action S666 (SECTION 86, NO. 173)
- Poor Hot Start - Tank Pressure Control Valve - Check (SECTION 05.1, NO. 16REV)
- Poor Hot Start-Tank Pressure Control Valve Operation (SECTION 5.1, NO. 16)
- Service Action S669 - Engine Harness Contacts EGR (SECTION 86, NO. 175)
- Valve Timing Changes - AJ16 Engine (SECTION 03.1, NO. 05)
Axle Shafts
- Drive Shaft FASTENTER - Revised Torque Spec. (SECTION 09, NO. 02)
- Vehicle Vibration Diagnosis (SECTION 47, NO. 6)
Blowers, Superchargers & Turbochargers
- Oil Level - Supercharger - Maintenance Check (SECTION 12, NO. 59)
Body Electrical
- Electrical Guides - Revisions To 1995 And 1996 My Editions (15-42)
Body Interior
- SDD 152.05 Diagnostic Trouble Codes (DTC) Not Shown In Some Modules (SSM73807)
- New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
- Sliding Roof Control Module (SCRM) - R & I Procedure (SECTION 13, NO. 34)
- Portable Diagnostic Unit Software - Issue PDU 1031 (SECTION PDU, NO. 9)
Brakes Control Systems
- JTP 759/13 WDS Software (SECTION 1, NO. 130)
- JTP 759/10 WDS Software (SECTION 1, NO. 126)
- Final PDU Software - JTP 626/7 And JTP 627/10 (SECTION 1, NO. 125)
- JTP 759/9 WDS Software (SECTION 1, NO. 124)
- JTP 759/8 WDS Software (SECTION 1, NO. 123)
- JTP 759/6 WDS Software (SECTION 1, NO. 122)
- JTP 759/5 WDS Software (SECTION 1, NO. 121)
- JTP 759/4 WDS Software (SECTION 1, NO. 120)
- New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
Charging Systems
- Low Maintenance Battery - Recommended Practices (SECTION 15, NO. 44)
Communication Devices
- Inadvertent Radio Antenna Operation (SECTION 86, NO. 168)
Cooling Fan
- Cooling System Fan Fuse Failure - Single Switch (SECTION 82, NO. 48)
Cooling System (Mechanical)
- 'Coolant Level LOW' Message Displayed On The Instrument Panel Cluster (IPC) (JLRTB02027NAS3)
- 'Coolant Level LOW' Message Displayed On The Instrument Panel Cluster (IPC) (JLRTB02027NAS2)
- Coolant Specification Change - Coolant D542 (Yellow) (04.1-02)
- Coolant Specification Change - Coolant D542 (Yellow) (SECTION 26, NO. 17)
- Coolant Specification Change - Coolant D542 (Yellow) (SECTION 4.1, NO. 02)
- DTC'S P1176, P1177, P1178, P1179 - Adaptive Fuel SYS (SECTION 5.1, N0. 31)
- Cooling System Fan Fuse Failure - Single Switch (SECTION 82, NO. 48)
- Cooling System Fan Fuse Failure - Pressure Switch (SECTION 86, NO. 171)
Cruise Control Systems
- Brake Pedal Switch - Parts Inventory Simplified (SECTION 12, NO. 10)
Differentials & Drive Axles
- Coolant Specification Change - Coolant D542 (Yellow) (SECTION 26, NO. 17)
- Coolant Specification Change - Coolant D542 (Yellow) (SECTION 4.1, NO. 02)
- Sliding Roof - Drive Cables - Water-Resist Grease (SECTION 13, NO. 30)
- Drive Shaft FASTENTER - Revised Torque Spec. (SECTION 09, NO. 02)
- Vehicle Vibration Diagnosis (SECTION 47, NO. 6)
Driveshaft & Universal Joints
- Drive Shaft FASTENTER - Revised Torque Spec. (SECTION 09, NO. 02)
- Vehicle Vibration Diagnosis (SECTION 47, NO. 6)
Electronic Steering
- Power Assisted Steering - Diagnosis (SECTION 10, NO. 07)
Electronic Suspension
- Power Assisted Steering - Diagnosis (SECTION 10, NO. 07)
Engine Control Systems
- Symptom Driven Diagnostics (SDD) Displays Update Icon And Reduced Functionality If Not Updated (SSM74982)
- SDD 152.05 Diagnostic Trouble Codes (DTC) Not Shown In Some Modules (SSM73807)
- Removal Of Seized Oxygen (O2) Sensors (JAGA309-001)
- JTP 759/13 WDS Software (SECTION 1, NO. 130)
- Recall R493 - AJ16 EGR System - Replace Proms And EGR Valve (SECTION 05.1, NO. 26)
- Service Action S676 - Momentary Engine Hesitation/Instability (SECTION 05.1, NO. 25)
- JTP 759/10 WDS Software (SECTION 1, NO. 126)
- Final PDU Software - JTP 626/7 And JTP 627/10 (SECTION 1, NO. 125)
- JTP 759/9 WDS Software (SECTION 1, NO. 124)
- JTP 759/8 WDS Software (SECTION 1, NO. 123)
- JTP 759/6 WDS Software (SECTION 1, NO. 122)
- JTP 759/5 WDS Software (SECTION 1, NO. 121)
- Rough Idle/Drivability - Diagnosis To Follow Prior To Replacing MAF (SECTION 05.1, NO. 36)
- JTP 759/4 WDS Software (SECTION 1, NO. 120)
- New PDU Software - JTP 626/7 And JTP 627/8 (SECTION 1, NO. 110)
- New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
- Service Action S659 - 4.0/6.0L Eng Mil DTC P0300 (SECTION 05.1 NO. 08)
- Service Action S672 - DTC P0441 - Mil Illumination (SECTION 05.1, NO. 22)
- Heated Oxygen Sensor Torque Specification - Revised (SECTION 18, NO. 45)
- Idle Speed Adj. Procedure - AJ16 Engines - Deposits (05.1-23 REV.)
- Damaged Wiring Harness - Misfire/No Start (SECTION 86, NO. 174)
- Poor Hot Start-Tank Pressure Control Valve Operation (SECTION 5.1, NO. 16)
- Special Tool JD 208 - Fuel Pressure Testing (SECTION 19, NO. 39)
- Valve Timing Changes - AJ16 Engine (SECTION 03.1, NO. 05)
Entertainment Systems
- Poor Antenna Mast Operation - Cleaning - Replacing (SECTION 15, NO. 45)
- Poor Sound Quality - Tape Head Cleaning (SECTION 15, NO. 43)
- Radio & Cd AUTOCHANGER Compatibility -Jag Units Only (SECTION 15, NO. 41)
- Cd Changer - Transit Screws - Storage Location (SECTION 15, NO. 40)
- Inadvertent Radio Antenna Operation (SECTION 86, NO. 168)
- Interior & Fascia Panel Lighting Malfunctions (SECTION 86, NO. 169)
Exhaust
- Removal Of Seized Oxygen (O2) Sensors (JAGA309-001)
Exterior Body Panels
- Partly Detached Mounting - Front UNDERTRAY To Bumper (SECTION 13, NO. 41)
- Rear Lip Corrosion - Replacing Damaged Section (SECTION 13, NO. 38)
- Hood Panel Vibration - New Modification Procedure (SECTION 76, NO. 119)
- VIN Stamping In Trunk - Revised Location (SECTION 76, NO. 116)
Exterior Lights
- Steering Column Cassette - Replacement Procedure (SECTION 10, NO. 15)
- Brake Pedal Switch - Parts Inventory Simplified (SECTION 12, NO. 10)
- Front Fog Lamps - Accumulation Of Condensation (SECTION 15, NO. 39)
Frames, Subframes & Crossmembers
- Partly Detached Mounting - Front UNDERTRAY To Bumper (SECTION 13, NO. 41)
- Rear Lip Corrosion - Replacing Damaged Section (SECTION 13, NO. 38)
Front Suspension
- Multimedia Training Software Update Version 2.0 (SECTION 6, NO. 62)
- Power Assisted Steering - Diagnosis (SECTION 10, NO. 07)
- Lower Wishbone - Fulcrum Bolt - Revised Torque Spec. (SECTION 11, NO. 07)
- Shock Absorber Mounting - Knocking Front Suspension (SECTION 19.7, NO. 03)
Fuel System
- Rough Idle/Drivability - Diagnosis To Follow Prior To Replacing MAF (SECTION 05.1, NO. 36)
- Evaporative Loss System Check - Clarified Procedure (05.1-29)
- DTCS P1176, P1177, P1178, P1179 - Adaptive Fuelling System - Diagnostic Procedure (05.1-31)
- Poor Hot Start - Tank Pressure Control Valve - Check Operation (05.1-16)
- Idle Speed Adj. Procedure - AJ16 Engines - Deposits (05.1-23 REV.)
- Poor Hot Start-Tank Pressure Control Valve Operation (SECTION 5.1, NO. 16)
- Intermittent High Idle - New Throttle Return Spring (SECTION 19, NO. 37)
- Special Tool JD 208 - Fuel Pressure Testing (SECTION 19, NO. 39)
Fuses & Circuit Breakers
- Replacement Air Injection Pump - Upgrade Fuse Rating (SECTION 5.1, NO. 30)
- Replacement Air Injection Pump - Upgrade Fuse Rating (SECTION 05.1 NO. 30)
- Service Action S669-Engine Harness Contacts EGR Pipe (SECTION 05.1, NO. 20)
- EGR Valve Harness - Reroute - Service Action S666 (SECTION 86, NO. 173)
- Cooling System Fan Fuse Failure - Single Switch (SECTION 82, NO. 48)
- Cooling System Fan Fuse Failure - Pressure Switch (SECTION 86, NO. 171)
- Interior & Fascia Panel Lighting Malfunctions (SECTION 86, NO. 169)
- Portable Diagnostic Unit Software - Issue PDU 1031 (SECTION PDU, NO. 9)
- Fuses - Ratings/Circuits - Refer To FUSEBOX Label (SECTION 86, NO. 165)
Gauges & Instrument Panels
- 'Coolant Level LOW' Message Displayed On The Instrument Panel Cluster (IPC) (JLRTB02027NAS3)
- 'Coolant Level LOW' Message Displayed On The Instrument Panel Cluster (IPC) (JLRTB02027NAS2)
- Inaccurate Fuel Level Reading - Improved Sender Unit (SECTION 05.1, NO. 34)
- AJ16 Engine - Incorrect Fuel Gauge Reading-Diagnosis (SECTION 05.1, NO. 13)
- Interior & Fascia Panel Lighting Malfunctions (SECTION 86, NO. 169)
General Servicing
- Leak Detection System - Ultraviolet Dye (SECTION 14, NO. 14)
Headlights
- Steering Column Cassette - Replacement Procedure (SECTION 10, NO. 15)
- Front Fog Lamps - Accumulation Of Condensation (SECTION 15, NO. 39)
HVAC Control Systems
- Leak Detection System - Ultraviolet Dye (SECTION 14, NO. 14)
- Poor Heater Performance - Coolant Specification Change - Replace Coolant With Heater Core (14-13)
- Poor Heater Performance - Replace Coolant & Heater (SECTION 14, NO. 13)
- A/C Odor - Apply Odor Control Treatment (SECTION 82, NO. 49)
- A/C System Servicing -Prevent Moisture Contamination (SECTION 14, NO. 12)
- R-134A Refrigerant - Jaguar Approved (SECTION ADM, NO. 6-50)
Identification
- VIN Stamping In Trunk - Revised Location (SECTION 76, NO. 116)
Ignition System
- Rough Idle/Drivability - Diagnosis To Follow Prior To Replacing MAF (SECTION 05.1, NO. 36)
- Spark Plug "Blow-By Stain"/Corona Stain - Spark Plug Function Not Affected - Replacement Unnecessary (SECTION 05.1, NO. 35)
- Spark Plugs - AJ16 Engine - Change Of Specification (SECTION 05.1, NO. 07)
Infotainment
- Inadvertent Radio Antenna Operation (SECTION 86, NO. 168)
Interior/Exterior Trim
- Approved Cleaning Products By AUTOGLYM (JAGA100-001)
- Uneven Operation Of Windows Or Sliding Roof (SECTION 13, NO. 42)
- Partly Detached Mounting - Front UNDERTRAY To Bumper (SECTION 13, NO. 41)
- Squeaking Interior Trim - KRYTOX Fluid Available (SECTION 19.1, NO. 04)
- Wood Veneer Repair Program (A-01)
- Damaged CUPHOLDER - Replace Mechanism Only (SECTION 13, NO. 33)
- Interior Trim Cleaning - Products & Procedures (SECTION 01, NO. 18)
- Jaguar Approved Cleaners - Parts Numbers (SECTION ADM, NO. 1-75)
- Interior Trim/Convertible Top Cleaning - Procedures (SECTION 13, NO. 27)
Interior/Illumination Lights
- Steering Column Cassette - Replacement Procedure (SECTION 10, NO. 15)
- Front Fog Lamps - Accumulation Of Condensation (SECTION 15, NO. 39)
- Interior & Fascia Panel Lighting Malfunctions (SECTION 86, NO. 169)
Locking Hubs
- Power Assisted Steering - Diagnosis (SECTION 10, NO. 07)
Lubrication System
- Coolant Specification Change - Coolant D542 (Yellow) (SECTION 26, NO. 17)
- Coolant Specification Change - Coolant D542 (Yellow) (SECTION 4.1, NO. 02)
- Sliding Roof - Drive Cables - Water-Resist Grease (SECTION 13, NO. 30)
- Oil Level - Supercharger - Maintenance Check (SECTION 12, NO. 59)
- Engine Oil - Viscosity/Temperature Ranges - Revision (SECTION 12, NO. 58)
Manual Steering
- Power Assisted Steering Pumps - Reconditioned Avail. (SECTION 10, NO. 14)
- Leaking Pinion Shaft Oil Seal (SECTION 10, NO. 13)
- Steering Rack - Leak At Transfer Pipe Union Nut (SECTION 10, NO. 11)
- Power Assisted Steering - Diagnosis (SECTION 10, NO. 07)
- Power Steering System - Rev. Hose Clips On Reservoir (SECTION 10, NO. 09)
- Pas Pump - Drive Dog Tool - Replacement Procedure (SECTION 57, NO. 21)
- New Special Tools - Power Steering (SECTION 1, NO. 60)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Rough Idle/Drivability - Diagnosis To Follow Prior To Replacing MAF (SECTION 05.1, NO. 36)
- Cylinder Head Bolts - Reuse Twice - Conditions (03.1-13)
- Cylinder Head Bolts - Reuse Twice - Conditions (SECTION 3.1, NO. 13)
- Intermittent Poor Idle - Carbon Deposits On Valves (03.1-10)
- Jaguar Approved Cleaners - Parts Numbers (SECTION ADM, NO. 1-75)
- Rattle After Start/Upper Timing Chain/New TENSIONER (SECTION 12, NO. 61)
- Camshaft Cover Oil Leaks - AJ16 Engine - Bolt Torque (SECTION 12, NO. 60)
- Oil Level - Supercharger - Maintenance Check (SECTION 12, NO. 59)
- Engine Oil - Viscosity/Temperature Ranges - Revision (SECTION 12, NO. 58)
- New Special Tool - Camshaft Timing (SECTION 1, NO. 61)
Mechanical - Hydraulic
- Brake Disc Vibration - Diagnosis - General Information (SECTION 12, NO. 09)
- Brake Pedal Switch - Parts Inventory Simplified (SECTION 12, NO. 10)
- Coolant Specification Change - Coolant D542 (Yellow) (SECTION 26, NO. 17)
- Coolant Specification Change - Coolant D542 (Yellow) (SECTION 4.1, NO. 02)
- Sliding Roof - Drive Cables - Water-Resist Grease (SECTION 13, NO. 30)
- Clicking Noise Form Front Of Vehicle - Brake Shield (SECTION 19.7, NO. 04)
- Rear Brake Caliper Retaining Bolts - New Design (SECTION 70, NO. 26)
- Front Suspension Rattle - Brake Disc Shield (SECTION 11, NO. 04)
- New Brake Fluid Specification - Super Dot 4 (SECTION 70, NO. 24)
Mirrors
- Uneven Operation Of Windows Or Sliding Roof (SECTION 13, NO. 42)
- Front Seat Memory - Potentiometer - Adjust/Replace (SECTION 15, NO. 50)
- Detached Rear View Mirror Mount - Repair Procedure (SECTION 13, NO. 37)
- Rolling Code Garage Door Opener - Avail For Retrofit (SECTION 15, NO. 48)
Paint & Coatings
- Exterior Paint Issues Reporting Aid (XJ501-023)
- Glass Bonding - Procedures & Materials (SECTION 13, NO. 35)
- Rear Lip Corrosion - Replacing Damaged Section (SECTION 13, NO. 38)
- List Of Approved Products - KENT Industries Products (SECTION 01, NO. 15)
- Jaguar Approved Cleaners - Parts Numbers (SECTION ADM, NO. 1-75)
- Hood Panel Vibration - New Modification Procedure (SECTION 76, NO. 119)
- Approval For 'TEROSON' Products (13-24)
- Paint Colors - Codes - DU PONT Stock Numbers (SECTION 76, NO. 112)
Parking Brake System
- Parking Brake Does Not Release (JTB00044)
- Rattle - Rear Of Vehicle Underbody (SECTION 19.7, NO. 05)
Passive Restraints
- Power Assisted Steering - Diagnosis (SECTION 10, NO. 07)
Procedures
- Lower Than Actual Compression Figures Using The K00825-0/JLR-4425 COMPRESSIOR Tester Kit (SSM75380)
- Use Of Non Approved Jaguar Land Rover Anti Bacterial Fogging Agents (SSM75126)
- Symptom Driven Diagnostics (SDD) Displays Update Icon And Reduced Functionality If Not Updated (SSM74982)
- Symptom Driven Diagnostics (SDD) Displays Update Icon And Reduced Functionality If Not Updated (SSM74881)
- SDD Software Update Icon Is Displayed And When Trying To Update 'No Update AVAILABLE' Is Displayed (SSM74805)
- Unable To Log Into SDD And Pathfinder (SSM74324)
- Unable To Update Approved Diagnostic Software Due To Lack Of Available Storage Space (SSM73696)
- Notice - Essential Maintenance For Calibration And As-Built Servers (SSM74002)
- Unable To Login To Pathfinder (SSM73894)
- Unable To Login To Symptom Driven Diagnostics (SDD) And Pathfinder (SSM73894)
- SDD 152.05 Diagnostic Trouble Codes (DTC) Not Shown In Some Modules (SSM73807)
Rear Suspension
- Knocking Noise - Rear SUBFRAME Bushing - Modification Procedure (11-09)
- Power Assisted Steering - Diagnosis (SECTION 10, NO. 07)
- Lower Wishbone - Fulcrum Bolt - Revised Torque Spec. (SECTION 11, NO. 07)
- Shock Absorber Mounting - Knocking Front Suspension (SECTION 19.7, NO. 03)
Restraints Control Systems
- JTP 759/13 WDS Software (SECTION 1, NO. 130)
- New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
Schedule
- Coolant Specification Change - Coolant D542 (Yellow) (SECTION 26, NO. 17)
- Coolant Specification Change - Coolant D542 (Yellow) (SECTION 4.1, NO. 02)
- Oil Level - Supercharger - Maintenance Check (SECTION 12, NO. 59)
Seats
- Approved Cleaning Products By AUTOGLYM (JAGA100-001)
- Uneven Operation Of Windows Or Sliding Roof (SECTION 13, NO. 42)
- Front Seat Memory - Potentiometer - Adjust/Replace (SECTION 15, NO. 50)
- Installation Of Child Seat Tether Mounting Eyes (SECTION 13, NO. 40)
- Rolling Code Garage Door Opener - Avail For Retrofit (SECTION 15, NO. 48)
- Anti-SQUEEK Materials - Parts Info Tables (SECTION 19.1, NO. 03)
Starter
- Low Maintenance Battery - Recommended Practices (SECTION 15, NO. 44)
- Intermittent No Crank - Starter Cable Loose (SECTION 15, NO. 38)
Steering Column
- Steering Column Cassette - Replacement Procedure (SECTION 10, NO. 15)
- Steering Column Tilt Motor - Seized Motor - Repair (SECTION 10, NO. 10 REV.)
- Steering Column Tilt Motor Seized - Replace (SECTION 10, NO. 12)
- Power Assisted Steering - Diagnosis (SECTION 10, NO. 07)
- ZF 4 Hp 24 E Transmission - Diagnostic Flowcharts (08.1-03)
Steering Column Switches
- Brake Pedal Switch - Parts Inventory Simplified (SECTION 12, NO. 10)
Steering Control Systems
- JTP 759/13 WDS Software (SECTION 1, NO. 130)
- New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
Steering Gear
- Leaking Pinion Shaft Oil Seal (SECTION 10, NO. 13)
- Steering Rack - Leak At Transfer Pipe Union Nut (SECTION 10, NO. 11)
- Power Assisted Steering - Diagnosis (SECTION 10, NO. 07)
- Power Steering System - Rev. Hose Clips On Reservoir (SECTION 10, NO. 09)
Steering Linkage
- Corrosion Prevention - Wheels & Hub (SECTION 11, NO. 10)
- Power Assisted Steering - Diagnosis (SECTION 10, NO. 07)
- Vehicle Vibration Diagnosis (SECTION 47, NO. 6)
- Alignment Specifications Table (SECTION 60, NO. 5)
- Front Suspension - Vehicle Pulls - Check Pull Index (SECTION 60, NO. 6)
Sun Roof/T-Top/Convertible Top
- Uneven Operation Of Windows Or Sliding Roof (SECTION 13, NO. 42)
- Sliding Roof - Diagnosis & Repair (SECTION 13, NO. 39)
- Sliding Roof Control Module (SCRM) - R & I Procedure (SECTION 13, NO. 34)
- Anti-SQUEEK Materials - Parts Info Tables (SECTION 19.1, NO. 03)
Suspension Control Systems
- JTP 759/13 WDS Software (SECTION 1, NO. 130)
- New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
System
- SDD 152.05 Diagnostic Trouble Codes (DTC) Not Shown In Some Modules (SSM73807)
- JTP 759/13 WDS Software (SECTION 1, NO. 130)
- Recall R493 - AJ16 EGR System - Replace Proms And EGR Valve (SECTION 05.1, NO. 26)
- Service Action S676 - Momentary Engine Hesitation/Instability (SECTION 05.1, NO. 25)
- JTP 759/10 WDS Software (SECTION 1, NO. 126)
- Final PDU Software - JTP 626/7 And JTP 627/10 (SECTION 1, NO. 125)
- JTP 759/9 WDS Software (SECTION 1, NO. 124)
- JTP 759/8 WDS Software (SECTION 1, NO. 123)
- JTP 759/6 WDS Software (SECTION 1, NO. 122)
- JTP 759/5 WDS Software (SECTION 1, NO. 121)
- Rough Idle/Drivability - Diagnosis To Follow Prior To Replacing MAF (SECTION 05.1, NO. 36)
- Spark Plug "Blow-By Stain"/Corona Stain - Spark Plug Function Not Affected - Replacement Unnecessary (SECTION 05.1, NO. 35)
- JTP 759/4 WDS Software (SECTION 1, NO. 120)
- New PDU Software - JTP 626/7 And JTP 627/8 (SECTION 1, NO. 110)
- New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
- Evaporative Loss System Check - Clarified Procedure (SECTION 5.1, NO. 29)
- Coolant Specification Change - Coolant D542 (Yellow) (SECTION 4.1, NO. 02)
- Replacement Air Injection Pump - Upgrade Fuse Rating (SECTION 5.1, NO. 30)
- Service Action S659 - 4.0/6.0L Eng Mil DTC P0300 (SECTION 05.1 NO. 08)
- Service Action S672 - DTC P0441 - Mil Illumination (SECTION 05.1, NO. 22)
- Insufficient Air Flow - Air Pump (AIRP) - Diagnosis (SECTION 5.1, NO. 27)
- DTC'S P1176, P1177, P1178, P1179 - Adaptive Fuel SYS (SECTION 5.1, N0. 31)
- DTCS P1176, P1177, P1178, P1179 - Adaptive Fuelling System - Diagnostic Procedure (05.1-31)
- Intermittent Poor Idle - Carbon Deposits On Valves (03.1-10)
- Heated Oxygen Sensor Torque Specification - Revised (SECTION 18, NO. 45)
- Insufficient Air Flow - Air Pump (AIRP) - Diagnosis (05.1-27)
- Enhanced Evaporative System Vehicles - Leak Check (SECTION ADM, NO. 1-76)
- Idle Speed Adj. Procedure - AJ16 Engines - Deposits (05.1-23 REV.)
- Damaged Wiring Harness - Misfire/No Start (SECTION 86, NO. 174)
- EGR Valve Harness - Reroute - Service Action S666 (SECTION 86, NO. 173)
- Poor Hot Start - Tank Pressure Control Valve - Check (SECTION 05.1, NO. 16REV)
- Poor Hot Start-Tank Pressure Control Valve Operation (SECTION 5.1, NO. 16)
- Service Action S669 - Engine Harness Contacts EGR (SECTION 86, NO. 175)
- Intermittent High Idle - New Throttle Return Spring (SECTION 19, NO. 37)
- Special Tool JD 208 - Fuel Pressure Testing (SECTION 19, NO. 39)
- Valve Timing Changes - AJ16 Engine (SECTION 03.1, NO. 05)
- Spark Plugs - AJ16 Engine - Change Of Specification (SECTION 05.1, NO. 07)
Transmission Control Systems
- JTP 759/13 WDS Software (SECTION 1, NO. 130)
- JTP 759/10 WDS Software (SECTION 1, NO. 126)
- Final PDU Software - JTP 626/7 And JTP 627/10 (SECTION 1, NO. 125)
- JTP 759/9 WDS Software (SECTION 1, NO. 124)
- JTP 759/8 WDS Software (SECTION 1, NO. 123)
- JTP 759/6 WDS Software (SECTION 1, NO. 122)
- JTP 759/5 WDS Software (SECTION 1, NO. 121)
- JTP 759/4 WDS Software (SECTION 1, NO. 120)
- New PDU Software - JTP 626/7 And JTP 627/8 (SECTION 1, NO. 110)
- New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
- Loss Of 4TH Gear, Slipping In 4TH Gear, Busy (77-71-77)
- ZF 4HP 24 E Transmission Diagnosis - Using PDU To Verify Fluid Is At Operating Temperature (08.1-02)
- ZF 4 Hp 24 E Transmission - Diagnostic Flowcharts (SECTION 08.1, NO. 03)
Vacuum Pumps/Lines/Tanks/Water Trap
- Brake Pedal Switch - Parts Inventory Simplified (SECTION 12, NO. 10)
Warning Systems
- Brake Pedal Switch - Parts Inventory Simplified (SECTION 12, NO. 10)
Wheels & Tire System
- Corrosion Prevention - Wheels & Hub (SECTION 11, NO. 10)
- Vibration Diagnosis - Wheel & Tire Balance (SECTION 11, NO. 08)
- PIRELLI Tires - Technical Service (SECTION 01, NO. 14)
- Clicking Noise Form Front Of Vehicle - Brake Shield (SECTION 19.7, NO. 04)
- Vehicle Vibration Diagnosis (SECTION 47, NO. 6)
Window Motors & Regulators
- Windshield Damage Diagnostic Aid (JAGA501-001)
- Uneven Operation Of Windows Or Sliding Roof (SECTION 13, NO. 42)
- Front Seat Memory - Potentiometer - Adjust/Replace (SECTION 15, NO. 50)
- Sliding Roof - Diagnosis & Repair (SECTION 13, NO. 39)
- Rolling Code Garage Door Opener - Avail For Retrofit (SECTION 15, NO. 48)
- Anti-SQUEEK Materials - Parts Info Tables (SECTION 19.1, NO. 03)
Wiper/Washer Systems
- Removing Transit Wiper Protection At PDI (XJ501-024)
- Windshield Wiper Streaking/Juddering - Repair Policy (SECTION 15, NO. 49)
- Windshield Wiper Blade/Washer Fluid Mix/Maintenance (SECTION 15, NO. 19)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Brake Pedal Switch - Parts Inventory Simplified (SECTION 12, NO. 10)
- Service Action S669-Engine Harness Contacts EGR Pipe (SECTION 05.1, NO. 20)
- Damaged Wiring Harness - Misfire/No Start (SECTION 86, NO. 174)
- EGR Valve Harness - Reroute - Service Action S666 (SECTION 86, NO. 173)
- Interior & Fascia Panel Lighting Malfunctions (SECTION 86, NO. 169)
- Portable Diagnostic Unit Software - Issue PDU 1031 (SECTION PDU, NO. 9)