Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups
Common Specs & Procedures
DTC Index
Electrical Component Locations
Fluids
Technical Bulletins
Tire Fitment
Wiring Diagrams- System Wiring Diagrams
- Using lemon2025'S Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Body Control Modules
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Memory Systems
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Top/Sunroof
- Power Windows
- Radio
- Shift Interlock
- Starting/Charging
- Supplemental Restraints
- Transmission
- Trunk, Tailgate, Fuel Door
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- System Wiring Diagrams
- Accessories & Equipment
- Anti-Theft Systems
- Anti-Theft Systems
- Power Door Locks & Remote Keyless Entry Systems
- Body Interior
- Body Control Modules
- Description
- Operation
- Component Locations
- Programming
- Service Precautions
- Self-Diagnostic System
- System Tests
- Notes
- Chime
- Communications
- Battery IOD Disconnect At Body Control Module (BCM)
- Body Control Module (BCM) EEPROM Checksum Failure
- Body Control Module (BCM) Flash Checksum Failure
- Driver's Door Module (DDM) Message Not Received
- Mechanical Instrument Cluster (MIC) Message Not Received At Body Control Module (BCM)
- No PCI Messages From CD Changer
- Powertrain Control Module (PCM) Message Not Received At Body Control Module (BCM)
- Passenger's Door Module (PDM) Message Not Received At Body Control Module (BCM)
- Bus +/- Signals Open From Memory/Heated Seat Module (MHSM)
- Bus +/- Signals Open From Automatic Zone Control (AZC) Module
- Bus +/- Signal Open From Body Control Module (BCM)
- Bus +/- Signals Open From Driver's Door Module (DDM)
- Bus +/- Signals Open From Electronic Vehicle Information Center (EVIC)
- Bus +/- Signals Open From Mechanical Instrument Cluster (MIC)
- Bus +/- Signals Open From Passenger's Door Module (PDM)
- Bus +/- Signals Open From Sentry Key Immobilizer Module (SKIM)
- No Response From Air Bag Control Module (ACM)
- No Response From Controller Anti-Lock Brake (CAB)
- No Response From Powertrain Control Module (PCI Bus)
- No Response From Radio
- No Response From Transmission Control Module (TCM)
- PCI Bus Communication Failure
- Unable To Communicate With Driver's Door Module (DDM) &/Or Passenger's Door Module (PDM) Using Scan Tool
- Electrically Heated Systems
- Notes
- Driver's Seat Heat Output Open/Short To Voltage
- Driver's Seat Heat Output Short To Ground
- Driver's Thermistor Out Of Range High
- Driver's Thermistor Out Of Range Low
- Passenger's Seat Heat Output Open/Short To Voltage
- Passenger's Seat Heat Output Short To Ground
- Passenger's Thermistor Out Of Range High
- Passenger's Thermistor Out Of Range Low
- Driver's/Passenger's Seat Back Heater Inoperative
- Driver's/Passenger's Seat Bolster Heater Inoperative
- Driver's/Passenger's Seat Cushion Heater Inoperative
- Rear Defogger Relay Shorted High
- Rear Defogger Relay Open
- Rear Window Defogger Grid Inoperative
- Rear Defogger Switch Indicator Inoperative (Rear Window Defogger Operates)
- Exterior Lighting
- Foglight Relay Ckt Shorted Hi
- Foglight Relay Ckt Shorted Lo/Open
- Hazard Relay Ckt Shorted Hi
- Headlight Sw Open Ckt
- Headlight Sw Short To Ground
- High Beam Relay Ckt Shorted Hi
- Low Beam Relay Ckt Shorted Hi
- Low Beam Relay Ckt Shorted Lo/Open
- Park Light Relay Ckt Shorted Hi
- Park Light Relay Ckt Shorted Lo/Open
- Auto Headlights Will Not Turn Off, Or Auto Headlights Will Not Turn On
- Flash To Pass Inoperative
- Foglights Will Not Turn Off
- Foglights Will Not Turn On
- High Beam Head Lights Will Not Turn Off
- High Beam Head Lights Will Not Turn On
- Low Beam Headlights Will Not Turn Off
- Low Beam Headlights Will Not Turn On
- Parking Lights Will Not Turn Off
- Parking Lights Will Not Turn On
- Instrument Cluster
- ABS Light Circuit Short
- ABS Light Open
- ABS Message Not Received By MIC
- ACM Message Not Received By MIC
- Air Bag Lamp Driver Failure
- Air Bag Lamp Open
- BCM Messages Not Received By MIC
- Brake Light Circuit Short
- Brake Light Open
- JTEC Message Not Received By MIC
- SKIM Message Not Received By MIC
- Air Bag Indicator Not Operating Properly
- All Gauges Inoperative
- All Indicators Inoperative
- Brake Indicator Not Operating Properly
- Check Engine Indicator Not Operating Properly
- Check Gauges Indicator Not Operating Properly
- Cluster Illumination Failure
- Cruise Indicator Not Operating Properly
- Fuel Gauge Not Operating Properly
- High Beam Indicator Not Operating Properly
- Low Fuel Indicator Not Operating Properly
- O/D OFF Indicator Not Operating Properly
- Oil Pressure Gauge Not Operating Properly
- Seat Belt Indicator Not Operating Properly
- Sentry Key Immobilizer System (SKIS) Indicator Not Operating Properly
- Speedometer Not Operating Properly
- Tachometer Not Operating Properly
- Temperature Gauge Not Operating Properly
- Trans Over Temp Indicator Not Operating Properly
- Voltmeter Inoperative
- Interior Lighting
- Dim Sw Short To Ground
- Dim Sw Open Ckt
- Light Fade Failure Short To Battery
- Load Shed Failure Short To Battery
- Panel Light Driver Failure
- All Courtesy Lights Inoperative
- Ashtray Light Inoperative
- Courtesy Lights Inoperative (Except Front Doors)
- Courtesy Lights Inoperative From Dome Light Switch Only
- Courtesy Lights Inoperative From Driver's Front Door Only
- Courtesy Lights Inoperative From Left Rear Door Only
- Courtesy Lights Inoperative From Liftgate
- Courtesy Lights Inoperative From Liftgate Flip-Up Glass Only
- Courtesy Lights Inoperative From Passenger Front Door Only
- Courtesy Lights Inoperative From Right Rear Door Only
- Courtesy Lights On At All Times (Except Both Front Door Courtesy Lights If Equipped)
- Driver's Door Courtesy Light Inoperative
- Glove Box Light Inoperative
- Heated Seat Switch Illumination Light Inoperative
- A/C Control Illumination Lights Inoperative
- Liftgate Courtesy Light Disable Feature Inoperative
- Overhead, Rear & Liftgate Courtesy Lights Inoperative
- Passenger Door Courtesy Light Inoperative
- PRNDL/T-Case Illumination Lights Inoperative
- Radio Illumination Lights Inoperative
- Reading & Vanity Lights Inoperative
- Memory Seat
- Front Riser Out Of Range High
- Front Riser Out Of Range Low
- Horizontal Sensor Out Of Range High
- Horizontal Sensor Out Of Range Low
- Rear Riser Out Of Range High
- Rear Riser Out Of Range Low
- Recline Sensor Out Of Range High
- Recline Sensor Out Of Range Low
- Driver Seat Front Riser Movement Inoperative
- Driver Seat Horizontal Movement Inoperative
- Driver Seat Rear Riser Movement Inoperative
- Driver Seat Recliner Movement Inoperative
- Overhead Console
- Notes
- Ambient Temperature Sensor Ckt Open
- Ambient Temperature Sensor Ckt Short To Ground
- Bus Messages Missing
- Coolant Level Switch Circuit Open
- EVIC Internal Failure
- EVIC Mileage & Distance Functions
- EVIC Self Test
- Incorrect Ambient Temperature Reading
- Low Coolant Indicator On All The Time
- Low Washer Fluid Indicator On All The Time
- Power Door Lock/Remote Keyless Entry (RKE)
- All Doors (Except Driver's) Door Fail To Lock/Unlock
- All Doors (Except Driver's) Door Fails To Lock
- All Doors (Except Driver's) Door Fails To Unlock
- All Locks Inoperative From Driver's Door Module
- All Locks Inoperative From Passenger's Door Module
- Automatic Door Locks Inoperative
- Doors Lock With Key In Ignition & Front Door Open
- Driver Door Fails To Lock
- Driver's Door Fails To Lock/Unlock
- Driver Door Fails To Unlock
- Driver's Rear Door Fails To Lock/Unlock
- Liftgate Lock Fails To Lock/Unlock
- Passenger Door Fails To Lock/Unlock
- Passenger Rear Door Fails To Lock/Unlock
- RKE Transmitter Inoperative
- Power Mirror
- Power Top
- Power Window
- Driver Rear Window Inoperative From Both Switches
- Driver's Rear Window Inoperative From DDM (Driver's Front Door Switch)
- Driver's Rear Window Inoperative From Rear Switch
- Driver's Window Inoperative
- Passenger's Rear Window Inoperative From Both Switches
- Passenger's Rear Window Inoperative From DDM (Driver's Front Door Switch)
- Passenger's Rear Window Inoperative From Rear Switch
- Passenger's Window Inoperative From Both Switches
- Passenger's Window Inoperative From DDM (Driver's Front Door Switch)
- Passenger's Window Inoperative From PDM
- Vehicle Theft Security System
- Antenna Failure, COP Failure, EEPROM Failure, Internal Faults, RAM Failure, Serial Link Failure or, Stack Overflow Failure
- PCM Status Failure ,Rolling Code Failure, or Serial Link External Fault
- Transponder Cyclic Redundancy Check (CRC) Failure, Transponder Communication Failure, Transponder ID Mismatch, or Transponder Response Mismatch
- VIN Mismatch
- Horn Relay Ckt Shorted Hi
- Alarm Trips Without Cause
- Driver's Door Key Fails To Disarm VTSS
- Hazard Lights Fail To Flash With Alarm Tripped
- Headlights Fail To Flash With Alarm Tripped
- Horn Fails To Sound With Alarm Tripped
- Theft Alarm Will Not Arm
- VTSS Does Not Trip From Driver's Front Door
- VTSS Does Not Trip From Hood (If Equipped)
- VTSS Does Not Trip From Left Rear Door
- VTSS Does Not Trip From Liftgate
- VTSS Does Not Trip From Liftgate Flip-Up Glass Only
- VTSS Does Not Trip From Passenger Front Door
- VTSS Does Not Trip From Right Rear Door
- VTSS Indicator Inoperative
- Windshield Wiper/Washer System
- Washer Fluid Sensor Failure
- Wiper On/Off Relay Shorted High
- Wiper On/Off Relay Shorted Low/Open Circuit
- Wiper Park Failure
- Wiper Switch Mux Ckt Open
- Wiper Switch Mux Ckt Short To Ground
- Rear Washer, Runs All The Time With Ignition On
- Rear Washer Inoperative
- Rear Wiper Not Working At All
- Rear Wiper Operates Constantly With Ignition On
- Rear Wiper Not Working In Delay Position
- Rear Wiper Not Working In On Position
- Rear Wipers Move To Park Position With Switch In On Or Delay Position
- Washer Inoperative
- Washer Runs All The Time With Ignition On
- Wiper Not Working In Low Speed
- Wiper Erratic Operation In Intermittent Speeds
- Wiper Inoperative With Wash Function
- Wiper Not Working At All
- Wiper Not Working In High Speed
- One Or More Wiper Intermittent Speeds Inoperative
- Wiper Operates Constantly With Ignition On
- Verification Tests
- Removal & Installation
- Wiring Diagrams
- Body Control Modules
- Communication Devices
- Body Control Modules
- Description
- Operation
- Component Locations
- Programming
- Service Precautions
- Self-Diagnostic System
- System Tests
- Notes
- Chime
- Communications
- Battery IOD Disconnect At Body Control Module (BCM)
- Body Control Module (BCM) EEPROM Checksum Failure
- Body Control Module (BCM) Flash Checksum Failure
- Driver's Door Module (DDM) Message Not Received
- Mechanical Instrument Cluster (MIC) Message Not Received At Body Control Module (BCM)
- No PCI Messages From CD Changer
- Powertrain Control Module (PCM) Message Not Received At Body Control Module (BCM)
- Passenger's Door Module (PDM) Message Not Received At Body Control Module (BCM)
- Bus +/- Signals Open From Memory/Heated Seat Module (MHSM)
- Bus +/- Signals Open From Automatic Zone Control (AZC) Module
- Bus +/- Signal Open From Body Control Module (BCM)
- Bus +/- Signals Open From Driver's Door Module (DDM)
- Bus +/- Signals Open From Electronic Vehicle Information Center (EVIC)
- Bus +/- Signals Open From Mechanical Instrument Cluster (MIC)
- Bus +/- Signals Open From Passenger's Door Module (PDM)
- Bus +/- Signals Open From Sentry Key Immobilizer Module (SKIM)
- No Response From Air Bag Control Module (ACM)
- No Response From Controller Anti-Lock Brake (CAB)
- No Response From Powertrain Control Module (PCI Bus)
- No Response From Radio
- No Response From Transmission Control Module (TCM)
- PCI Bus Communication Failure
- Unable To Communicate With Driver's Door Module (DDM) &/Or Passenger's Door Module (PDM) Using Scan Tool
- Electrically Heated Systems
- Notes
- Driver's Seat Heat Output Open/Short To Voltage
- Driver's Seat Heat Output Short To Ground
- Driver's Thermistor Out Of Range High
- Driver's Thermistor Out Of Range Low
- Passenger's Seat Heat Output Open/Short To Voltage
- Passenger's Seat Heat Output Short To Ground
- Passenger's Thermistor Out Of Range High
- Passenger's Thermistor Out Of Range Low
- Driver's/Passenger's Seat Back Heater Inoperative
- Driver's/Passenger's Seat Bolster Heater Inoperative
- Driver's/Passenger's Seat Cushion Heater Inoperative
- Rear Defogger Relay Shorted High
- Rear Defogger Relay Open
- Rear Window Defogger Grid Inoperative
- Rear Defogger Switch Indicator Inoperative (Rear Window Defogger Operates)
- Exterior Lighting
- Foglight Relay Ckt Shorted Hi
- Foglight Relay Ckt Shorted Lo/Open
- Hazard Relay Ckt Shorted Hi
- Headlight Sw Open Ckt
- Headlight Sw Short To Ground
- High Beam Relay Ckt Shorted Hi
- Low Beam Relay Ckt Shorted Hi
- Low Beam Relay Ckt Shorted Lo/Open
- Park Light Relay Ckt Shorted Hi
- Park Light Relay Ckt Shorted Lo/Open
- Auto Headlights Will Not Turn Off, Or Auto Headlights Will Not Turn On
- Flash To Pass Inoperative
- Foglights Will Not Turn Off
- Foglights Will Not Turn On
- High Beam Head Lights Will Not Turn Off
- High Beam Head Lights Will Not Turn On
- Low Beam Headlights Will Not Turn Off
- Low Beam Headlights Will Not Turn On
- Parking Lights Will Not Turn Off
- Parking Lights Will Not Turn On
- Instrument Cluster
- ABS Light Circuit Short
- ABS Light Open
- ABS Message Not Received By MIC
- ACM Message Not Received By MIC
- Air Bag Lamp Driver Failure
- Air Bag Lamp Open
- BCM Messages Not Received By MIC
- Brake Light Circuit Short
- Brake Light Open
- JTEC Message Not Received By MIC
- SKIM Message Not Received By MIC
- Air Bag Indicator Not Operating Properly
- All Gauges Inoperative
- All Indicators Inoperative
- Brake Indicator Not Operating Properly
- Check Engine Indicator Not Operating Properly
- Check Gauges Indicator Not Operating Properly
- Cluster Illumination Failure
- Cruise Indicator Not Operating Properly
- Fuel Gauge Not Operating Properly
- High Beam Indicator Not Operating Properly
- Low Fuel Indicator Not Operating Properly
- O/D OFF Indicator Not Operating Properly
- Oil Pressure Gauge Not Operating Properly
- Seat Belt Indicator Not Operating Properly
- Sentry Key Immobilizer System (SKIS) Indicator Not Operating Properly
- Speedometer Not Operating Properly
- Tachometer Not Operating Properly
- Temperature Gauge Not Operating Properly
- Trans Over Temp Indicator Not Operating Properly
- Voltmeter Inoperative
- Interior Lighting
- Dim Sw Short To Ground
- Dim Sw Open Ckt
- Light Fade Failure Short To Battery
- Load Shed Failure Short To Battery
- Panel Light Driver Failure
- All Courtesy Lights Inoperative
- Ashtray Light Inoperative
- Courtesy Lights Inoperative (Except Front Doors)
- Courtesy Lights Inoperative From Dome Light Switch Only
- Courtesy Lights Inoperative From Driver's Front Door Only
- Courtesy Lights Inoperative From Left Rear Door Only
- Courtesy Lights Inoperative From Liftgate
- Courtesy Lights Inoperative From Liftgate Flip-Up Glass Only
- Courtesy Lights Inoperative From Passenger Front Door Only
- Courtesy Lights Inoperative From Right Rear Door Only
- Courtesy Lights On At All Times (Except Both Front Door Courtesy Lights If Equipped)
- Driver's Door Courtesy Light Inoperative
- Glove Box Light Inoperative
- Heated Seat Switch Illumination Light Inoperative
- A/C Control Illumination Lights Inoperative
- Liftgate Courtesy Light Disable Feature Inoperative
- Overhead, Rear & Liftgate Courtesy Lights Inoperative
- Passenger Door Courtesy Light Inoperative
- PRNDL/T-Case Illumination Lights Inoperative
- Radio Illumination Lights Inoperative
- Reading & Vanity Lights Inoperative
- Memory Seat
- Front Riser Out Of Range High
- Front Riser Out Of Range Low
- Horizontal Sensor Out Of Range High
- Horizontal Sensor Out Of Range Low
- Rear Riser Out Of Range High
- Rear Riser Out Of Range Low
- Recline Sensor Out Of Range High
- Recline Sensor Out Of Range Low
- Driver Seat Front Riser Movement Inoperative
- Driver Seat Horizontal Movement Inoperative
- Driver Seat Rear Riser Movement Inoperative
- Driver Seat Recliner Movement Inoperative
- Overhead Console
- Notes
- Ambient Temperature Sensor Ckt Open
- Ambient Temperature Sensor Ckt Short To Ground
- Bus Messages Missing
- Coolant Level Switch Circuit Open
- EVIC Internal Failure
- EVIC Mileage & Distance Functions
- EVIC Self Test
- Incorrect Ambient Temperature Reading
- Low Coolant Indicator On All The Time
- Low Washer Fluid Indicator On All The Time
- Power Door Lock/Remote Keyless Entry (RKE)
- All Doors (Except Driver's) Door Fail To Lock/Unlock
- All Doors (Except Driver's) Door Fails To Lock
- All Doors (Except Driver's) Door Fails To Unlock
- All Locks Inoperative From Driver's Door Module
- All Locks Inoperative From Passenger's Door Module
- Automatic Door Locks Inoperative
- Doors Lock With Key In Ignition & Front Door Open
- Driver Door Fails To Lock
- Driver's Door Fails To Lock/Unlock
- Driver Door Fails To Unlock
- Driver's Rear Door Fails To Lock/Unlock
- Liftgate Lock Fails To Lock/Unlock
- Passenger Door Fails To Lock/Unlock
- Passenger Rear Door Fails To Lock/Unlock
- RKE Transmitter Inoperative
- Power Mirror
- Power Top
- Power Window
- Driver Rear Window Inoperative From Both Switches
- Driver's Rear Window Inoperative From DDM (Driver's Front Door Switch)
- Driver's Rear Window Inoperative From Rear Switch
- Driver's Window Inoperative
- Passenger's Rear Window Inoperative From Both Switches
- Passenger's Rear Window Inoperative From DDM (Driver's Front Door Switch)
- Passenger's Rear Window Inoperative From Rear Switch
- Passenger's Window Inoperative From Both Switches
- Passenger's Window Inoperative From DDM (Driver's Front Door Switch)
- Passenger's Window Inoperative From PDM
- Vehicle Theft Security System
- Antenna Failure, COP Failure, EEPROM Failure, Internal Faults, RAM Failure, Serial Link Failure or, Stack Overflow Failure
- PCM Status Failure ,Rolling Code Failure, or Serial Link External Fault
- Transponder Cyclic Redundancy Check (CRC) Failure, Transponder Communication Failure, Transponder ID Mismatch, or Transponder Response Mismatch
- VIN Mismatch
- Horn Relay Ckt Shorted Hi
- Alarm Trips Without Cause
- Driver's Door Key Fails To Disarm VTSS
- Hazard Lights Fail To Flash With Alarm Tripped
- Headlights Fail To Flash With Alarm Tripped
- Horn Fails To Sound With Alarm Tripped
- Theft Alarm Will Not Arm
- VTSS Does Not Trip From Driver's Front Door
- VTSS Does Not Trip From Hood (If Equipped)
- VTSS Does Not Trip From Left Rear Door
- VTSS Does Not Trip From Liftgate
- VTSS Does Not Trip From Liftgate Flip-Up Glass Only
- VTSS Does Not Trip From Passenger Front Door
- VTSS Does Not Trip From Right Rear Door
- VTSS Indicator Inoperative
- Windshield Wiper/Washer System
- Washer Fluid Sensor Failure
- Wiper On/Off Relay Shorted High
- Wiper On/Off Relay Shorted Low/Open Circuit
- Wiper Park Failure
- Wiper Switch Mux Ckt Open
- Wiper Switch Mux Ckt Short To Ground
- Rear Washer, Runs All The Time With Ignition On
- Rear Washer Inoperative
- Rear Wiper Not Working At All
- Rear Wiper Operates Constantly With Ignition On
- Rear Wiper Not Working In Delay Position
- Rear Wiper Not Working In On Position
- Rear Wipers Move To Park Position With Switch In On Or Delay Position
- Washer Inoperative
- Washer Runs All The Time With Ignition On
- Wiper Not Working In Low Speed
- Wiper Erratic Operation In Intermittent Speeds
- Wiper Inoperative With Wash Function
- Wiper Not Working At All
- Wiper Not Working In High Speed
- One Or More Wiper Intermittent Speeds Inoperative
- Wiper Operates Constantly With Ignition On
- Verification Tests
- Removal & Installation
- Wiring Diagrams
- Body Control Modules
- Cruise Control Systems
- Exterior Lights
- Gauges & Instrument Panels
- Headlights
- Heated Glass/Defoggers
- Interior/Illumination Lights
- Power Mirrors
- Seats
- Power Seat System
- Description
- Operation
- Trouble Shooting
- System Tests
- Component Tests
- Removal & Installation
- Wiring Diagrams
- Power Seat System
- Steering Column Switches
- Warning Systems
- Window Motors & Regulators
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Anti-Theft Systems
- Body & Frame
- Body, Cab Control Systems
- Body Control Modules
- Description
- Operation
- Component Locations
- Programming
- Service Precautions
- Self-Diagnostic System
- System Tests
- Notes
- Chime
- Communications
- Battery IOD Disconnect At Body Control Module (BCM)
- Body Control Module (BCM) EEPROM Checksum Failure
- Body Control Module (BCM) Flash Checksum Failure
- Driver's Door Module (DDM) Message Not Received
- Mechanical Instrument Cluster (MIC) Message Not Received At Body Control Module (BCM)
- No PCI Messages From CD Changer
- Powertrain Control Module (PCM) Message Not Received At Body Control Module (BCM)
- Passenger's Door Module (PDM) Message Not Received At Body Control Module (BCM)
- Bus +/- Signals Open From Memory/Heated Seat Module (MHSM)
- Bus +/- Signals Open From Automatic Zone Control (AZC) Module
- Bus +/- Signal Open From Body Control Module (BCM)
- Bus +/- Signals Open From Driver's Door Module (DDM)
- Bus +/- Signals Open From Electronic Vehicle Information Center (EVIC)
- Bus +/- Signals Open From Mechanical Instrument Cluster (MIC)
- Bus +/- Signals Open From Passenger's Door Module (PDM)
- Bus +/- Signals Open From Sentry Key Immobilizer Module (SKIM)
- No Response From Air Bag Control Module (ACM)
- No Response From Controller Anti-Lock Brake (CAB)
- No Response From Powertrain Control Module (PCI Bus)
- No Response From Radio
- No Response From Transmission Control Module (TCM)
- PCI Bus Communication Failure
- Unable To Communicate With Driver's Door Module (DDM) &/Or Passenger's Door Module (PDM) Using Scan Tool
- Electrically Heated Systems
- Notes
- Driver's Seat Heat Output Open/Short To Voltage
- Driver's Seat Heat Output Short To Ground
- Driver's Thermistor Out Of Range High
- Driver's Thermistor Out Of Range Low
- Passenger's Seat Heat Output Open/Short To Voltage
- Passenger's Seat Heat Output Short To Ground
- Passenger's Thermistor Out Of Range High
- Passenger's Thermistor Out Of Range Low
- Driver's/Passenger's Seat Back Heater Inoperative
- Driver's/Passenger's Seat Bolster Heater Inoperative
- Driver's/Passenger's Seat Cushion Heater Inoperative
- Rear Defogger Relay Shorted High
- Rear Defogger Relay Open
- Rear Window Defogger Grid Inoperative
- Rear Defogger Switch Indicator Inoperative (Rear Window Defogger Operates)
- Exterior Lighting
- Foglight Relay Ckt Shorted Hi
- Foglight Relay Ckt Shorted Lo/Open
- Hazard Relay Ckt Shorted Hi
- Headlight Sw Open Ckt
- Headlight Sw Short To Ground
- High Beam Relay Ckt Shorted Hi
- Low Beam Relay Ckt Shorted Hi
- Low Beam Relay Ckt Shorted Lo/Open
- Park Light Relay Ckt Shorted Hi
- Park Light Relay Ckt Shorted Lo/Open
- Auto Headlights Will Not Turn Off, Or Auto Headlights Will Not Turn On
- Flash To Pass Inoperative
- Foglights Will Not Turn Off
- Foglights Will Not Turn On
- High Beam Head Lights Will Not Turn Off
- High Beam Head Lights Will Not Turn On
- Low Beam Headlights Will Not Turn Off
- Low Beam Headlights Will Not Turn On
- Parking Lights Will Not Turn Off
- Parking Lights Will Not Turn On
- Instrument Cluster
- ABS Light Circuit Short
- ABS Light Open
- ABS Message Not Received By MIC
- ACM Message Not Received By MIC
- Air Bag Lamp Driver Failure
- Air Bag Lamp Open
- BCM Messages Not Received By MIC
- Brake Light Circuit Short
- Brake Light Open
- JTEC Message Not Received By MIC
- SKIM Message Not Received By MIC
- Air Bag Indicator Not Operating Properly
- All Gauges Inoperative
- All Indicators Inoperative
- Brake Indicator Not Operating Properly
- Check Engine Indicator Not Operating Properly
- Check Gauges Indicator Not Operating Properly
- Cluster Illumination Failure
- Cruise Indicator Not Operating Properly
- Fuel Gauge Not Operating Properly
- High Beam Indicator Not Operating Properly
- Low Fuel Indicator Not Operating Properly
- O/D OFF Indicator Not Operating Properly
- Oil Pressure Gauge Not Operating Properly
- Seat Belt Indicator Not Operating Properly
- Sentry Key Immobilizer System (SKIS) Indicator Not Operating Properly
- Speedometer Not Operating Properly
- Tachometer Not Operating Properly
- Temperature Gauge Not Operating Properly
- Trans Over Temp Indicator Not Operating Properly
- Voltmeter Inoperative
- Interior Lighting
- Dim Sw Short To Ground
- Dim Sw Open Ckt
- Light Fade Failure Short To Battery
- Load Shed Failure Short To Battery
- Panel Light Driver Failure
- All Courtesy Lights Inoperative
- Ashtray Light Inoperative
- Courtesy Lights Inoperative (Except Front Doors)
- Courtesy Lights Inoperative From Dome Light Switch Only
- Courtesy Lights Inoperative From Driver's Front Door Only
- Courtesy Lights Inoperative From Left Rear Door Only
- Courtesy Lights Inoperative From Liftgate
- Courtesy Lights Inoperative From Liftgate Flip-Up Glass Only
- Courtesy Lights Inoperative From Passenger Front Door Only
- Courtesy Lights Inoperative From Right Rear Door Only
- Courtesy Lights On At All Times (Except Both Front Door Courtesy Lights If Equipped)
- Driver's Door Courtesy Light Inoperative
- Glove Box Light Inoperative
- Heated Seat Switch Illumination Light Inoperative
- A/C Control Illumination Lights Inoperative
- Liftgate Courtesy Light Disable Feature Inoperative
- Overhead, Rear & Liftgate Courtesy Lights Inoperative
- Passenger Door Courtesy Light Inoperative
- PRNDL/T-Case Illumination Lights Inoperative
- Radio Illumination Lights Inoperative
- Reading & Vanity Lights Inoperative
- Memory Seat
- Front Riser Out Of Range High
- Front Riser Out Of Range Low
- Horizontal Sensor Out Of Range High
- Horizontal Sensor Out Of Range Low
- Rear Riser Out Of Range High
- Rear Riser Out Of Range Low
- Recline Sensor Out Of Range High
- Recline Sensor Out Of Range Low
- Driver Seat Front Riser Movement Inoperative
- Driver Seat Horizontal Movement Inoperative
- Driver Seat Rear Riser Movement Inoperative
- Driver Seat Recliner Movement Inoperative
- Overhead Console
- Notes
- Ambient Temperature Sensor Ckt Open
- Ambient Temperature Sensor Ckt Short To Ground
- Bus Messages Missing
- Coolant Level Switch Circuit Open
- EVIC Internal Failure
- EVIC Mileage & Distance Functions
- EVIC Self Test
- Incorrect Ambient Temperature Reading
- Low Coolant Indicator On All The Time
- Low Washer Fluid Indicator On All The Time
- Power Door Lock/Remote Keyless Entry (RKE)
- All Doors (Except Driver's) Door Fail To Lock/Unlock
- All Doors (Except Driver's) Door Fails To Lock
- All Doors (Except Driver's) Door Fails To Unlock
- All Locks Inoperative From Driver's Door Module
- All Locks Inoperative From Passenger's Door Module
- Automatic Door Locks Inoperative
- Doors Lock With Key In Ignition & Front Door Open
- Driver Door Fails To Lock
- Driver's Door Fails To Lock/Unlock
- Driver Door Fails To Unlock
- Driver's Rear Door Fails To Lock/Unlock
- Liftgate Lock Fails To Lock/Unlock
- Passenger Door Fails To Lock/Unlock
- Passenger Rear Door Fails To Lock/Unlock
- RKE Transmitter Inoperative
- Power Mirror
- Power Top
- Power Window
- Driver Rear Window Inoperative From Both Switches
- Driver's Rear Window Inoperative From DDM (Driver's Front Door Switch)
- Driver's Rear Window Inoperative From Rear Switch
- Driver's Window Inoperative
- Passenger's Rear Window Inoperative From Both Switches
- Passenger's Rear Window Inoperative From DDM (Driver's Front Door Switch)
- Passenger's Rear Window Inoperative From Rear Switch
- Passenger's Window Inoperative From Both Switches
- Passenger's Window Inoperative From DDM (Driver's Front Door Switch)
- Passenger's Window Inoperative From PDM
- Vehicle Theft Security System
- Antenna Failure, COP Failure, EEPROM Failure, Internal Faults, RAM Failure, Serial Link Failure or, Stack Overflow Failure
- PCM Status Failure ,Rolling Code Failure, or Serial Link External Fault
- Transponder Cyclic Redundancy Check (CRC) Failure, Transponder Communication Failure, Transponder ID Mismatch, or Transponder Response Mismatch
- VIN Mismatch
- Horn Relay Ckt Shorted Hi
- Alarm Trips Without Cause
- Driver's Door Key Fails To Disarm VTSS
- Hazard Lights Fail To Flash With Alarm Tripped
- Headlights Fail To Flash With Alarm Tripped
- Horn Fails To Sound With Alarm Tripped
- Theft Alarm Will Not Arm
- VTSS Does Not Trip From Driver's Front Door
- VTSS Does Not Trip From Hood (If Equipped)
- VTSS Does Not Trip From Left Rear Door
- VTSS Does Not Trip From Liftgate
- VTSS Does Not Trip From Liftgate Flip-Up Glass Only
- VTSS Does Not Trip From Passenger Front Door
- VTSS Does Not Trip From Right Rear Door
- VTSS Indicator Inoperative
- Windshield Wiper/Washer System
- Washer Fluid Sensor Failure
- Wiper On/Off Relay Shorted High
- Wiper On/Off Relay Shorted Low/Open Circuit
- Wiper Park Failure
- Wiper Switch Mux Ckt Open
- Wiper Switch Mux Ckt Short To Ground
- Rear Washer, Runs All The Time With Ignition On
- Rear Washer Inoperative
- Rear Wiper Not Working At All
- Rear Wiper Operates Constantly With Ignition On
- Rear Wiper Not Working In Delay Position
- Rear Wiper Not Working In On Position
- Rear Wipers Move To Park Position With Switch In On Or Delay Position
- Washer Inoperative
- Washer Runs All The Time With Ignition On
- Wiper Not Working In Low Speed
- Wiper Erratic Operation In Intermittent Speeds
- Wiper Inoperative With Wash Function
- Wiper Not Working At All
- Wiper Not Working In High Speed
- One Or More Wiper Intermittent Speeds Inoperative
- Wiper Operates Constantly With Ignition On
- Verification Tests
- Removal & Installation
- Wiring Diagrams
- Body Control Modules
- Door Locks
- Anti-Theft Systems
- Power Door Locks & Remote Keyless Entry Systems
- Power Mirrors
- Seats
- Power Seat System
- Description
- Operation
- Trouble Shooting
- System Tests
- Component Tests
- Removal & Installation
- Wiring Diagrams
- Power Seat System
- Sun Roof/T-Top/Convertible Top
- Power Windows
- Body, Cab Control Systems
- Brakes
- Anti-Lock Brakes
- Anti-Lock Brake System - TEVES Mark 20
- Description
- Operation
- Bleeding Brake System
- Diagnosis & Testing
- Connector Identification
- Diagnostic Tests
- Notes
- Test A1: Brake Fluid Level Switch Circuit (2000)
- Test A2: Brake Fluid Level Switch Circuit (2001)
- Test B1: Cab Power Feed Circuit (2000)
- Test B2: Cab Power Feed Circuit (2001)
- Test C: Cluster Fault
- Test D: Controller Failure
- Test E: "G" Switch Not Processable
- Test F1: Left Front Sensor Circuit Failure (2000)
- Test F2: Left Front Sensor Circuit Failure (2001)
- Test G1: Left Front Sensor Signal Failure (2000)
- Test G2: Left Front Sensor Signal Failure (2001)
- Test H1: Left Rear Sensor Circuit Failure (2000)
- Test H2: Left Rear Sensor Circuit Failure (2001)
- Test I1: Left Rear Sensor Signal Failure (2000)
- Test I2: Left Rear Sensor Signal Failure (2001)
- Test J1: PCI Bus Communication (2000)
- Test J2: PCI Bus Communication (2001)
- Test K1: Pump Motor Not Working Properly (2000)
- Test K2: Pump Motor Not Working Properly (2001)
- Test L1: Right Front Sensor Circuit Failure (2000)
- Test L2: Right Front Sensor Circuit Failure (2001)
- Test M1: Right Front Sensor Signal Failure (2000)
- Test M2: Right Front Sensor Signal Failure (2001)
- Test N1: Right Rear Sensor Circuit Failure (2000)
- Test N2: Right Rear Sensor Circuit Failure (2001)
- Test O1: Right Rear Sensor Signal Failure (2000)
- Test O2: Right Rear Sensor Signal Failure (2001)
- Test P1: System OVERVOLTAGE (2000)
- Test P2: System OVERVOLTAGE (2001)
- Test Q1: System UNDERVOLTAGE (2000)
- Test Q2: System UNDERVOLTAGE (2001)
- Test R: No Response From Cab Controller (2000)
- Abs Verification Test
- Removal & Installation
- Adjustments
- Torque Specifications
- Wiring Diagrams
- Anti-Lock Brake System - Wiring Diagrams
- Anti-Lock Brake System - TEVES Mark 20
- Mechanical - Hydraulic
- Parking Brake System
- Traction Control
- Anti-Lock Brake System - TEVES Mark 20
- Description
- Operation
- Bleeding Brake System
- Diagnosis & Testing
- Connector Identification
- Diagnostic Tests
- Notes
- Test A1: Brake Fluid Level Switch Circuit (2000)
- Test A2: Brake Fluid Level Switch Circuit (2001)
- Test B1: Cab Power Feed Circuit (2000)
- Test B2: Cab Power Feed Circuit (2001)
- Test C: Cluster Fault
- Test D: Controller Failure
- Test E: "G" Switch Not Processable
- Test F1: Left Front Sensor Circuit Failure (2000)
- Test F2: Left Front Sensor Circuit Failure (2001)
- Test G1: Left Front Sensor Signal Failure (2000)
- Test G2: Left Front Sensor Signal Failure (2001)
- Test H1: Left Rear Sensor Circuit Failure (2000)
- Test H2: Left Rear Sensor Circuit Failure (2001)
- Test I1: Left Rear Sensor Signal Failure (2000)
- Test I2: Left Rear Sensor Signal Failure (2001)
- Test J1: PCI Bus Communication (2000)
- Test J2: PCI Bus Communication (2001)
- Test K1: Pump Motor Not Working Properly (2000)
- Test K2: Pump Motor Not Working Properly (2001)
- Test L1: Right Front Sensor Circuit Failure (2000)
- Test L2: Right Front Sensor Circuit Failure (2001)
- Test M1: Right Front Sensor Signal Failure (2000)
- Test M2: Right Front Sensor Signal Failure (2001)
- Test N1: Right Rear Sensor Circuit Failure (2000)
- Test N2: Right Rear Sensor Circuit Failure (2001)
- Test O1: Right Rear Sensor Signal Failure (2000)
- Test O2: Right Rear Sensor Signal Failure (2001)
- Test P1: System OVERVOLTAGE (2000)
- Test P2: System OVERVOLTAGE (2001)
- Test Q1: System UNDERVOLTAGE (2000)
- Test Q2: System UNDERVOLTAGE (2001)
- Test R: No Response From Cab Controller (2000)
- Abs Verification Test
- Removal & Installation
- Adjustments
- Torque Specifications
- Wiring Diagrams
- Anti-Lock Brake System - Wiring Diagrams
- Anti-Lock Brake System - TEVES Mark 20
- Anti-Lock Brakes
- Drivelines & Axles
- Front Axle Shafts
- Differentials & Drive Axles
- Differentials - TRAC-LOK
- Drive Axle - 7 1/8" & 7 1/3" & 7 9/16" & 7 4/5" & 8 1/4" & 8 1/2 & 8 9/10" Ring Gears
- Front Axle Shafts
- Driveshaft & Universal Joints
- Wheel Hubs
- Electrical
- Charging Systems
- Charging System - Generators & Regulators
- Identification
- Description
- Operation
- Adjustments
- Trouble Shooting
- On-Vehicle Testing
- Self-Diagnostic System
- Diagnostic Tests
- System Tests
- Verification Tests
- Bench Testing
- Torque Specifications
- Wiring Diagrams
- Charging System - Generators & Regulators
- Component Locations
- Fuses & Circuit Breakers
- Gauges
- Starter
- Starting System
- Description
- Adjustments
- Trouble Shooting
- On-Vehicle Testing
- Bench Testing
- Removal & Installation
- Overhaul
- Starter Specifications
- Torque Specifications
- Wiring Diagrams
- Starting System
- Wiring Diagrams
- System Wiring Diagrams
- Using lemon2025'S Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Body Control Modules
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Memory Systems
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Top/Sunroof
- Power Windows
- Radio
- Shift Interlock
- Starting/Charging
- Supplemental Restraints
- Transmission
- Trunk, Tailgate, Fuel Door
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- System Wiring Diagrams
- Charging Systems
- Engine Mechanical
- Accessory Drive Belts
- Auxiliary Emission Control Systems
- Emission Control System Visual Inspection Procedures - General Information
- * Please Read This First *
- Emission Control Labels
- Emission Control Visual Inspection
- Notes
- Positive Crankcase Ventilation (PCV)
- Thermostatic Air Cleaner (TAC)
- Fuel Evaporative System (EVAP)
- Catalytic Converters
- Fill Pipe RESTRICTOR (Fr)
- Exhaust Gas RECIRCULATION (EGR) System
- Spark Controls (SPK)
- Air Injection System (AIS)
- Oxygen Sensor (O2)
- Computerized Engine Controls (CEC)
- Early Fuel Evaporation (EFE)
- Emission Maintenance Reminder Light (EMR) (If Equipped)
- Malfunction Indicator Light (Mil)
- Emission Control System Visual Inspection Procedures - General Information
- Cooling Fan
- Cooling System (Mechanical)
- Mechanical
- 4.0L Engine
- Engine Identification
- Adjustments
- Trouble Shooting
- Removal & Installation
- Overhaul
- Engine Oiling
- Torque Specifications
- Engine Specifications
- General Specifications
- Crankshaft, Main Bearings & Connecting Rod Bearings Specifications
- Connecting Rods Specifications
- Pistons, Piston Pins & Piston Rings Specifications
- Cylinder Head Specifications
- Camshaft Specifications
- Valve Lifters Specifications
- Cylinder Block Specifications
- Engine Valves & Valve Springs Specifications
- 4.0L Engine
- Starter
- Starting System
- Description
- Adjustments
- Trouble Shooting
- On-Vehicle Testing
- Bench Testing
- Removal & Installation
- Overhaul
- Starter Specifications
- Torque Specifications
- Wiring Diagrams
- Starting System
- Engine Performance
- Engine Controls - On-Vehicle Adjustments
- Application
- Emissions
- Emission Applications
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Mode 6 - CHRYSLER
- Introduction
- 1996
- 1997-1998
- 1999
- 2000
- 2001
- 2002
- 2003-2004
- 2005
- 2006
- 2007
- 2007-09 Diesel Engines
- 2008
- 2008-10 Viper
- 2009-10 Pt Cruiser
- 2009 - All Vehicles With V6 Or V8 Engines
- 2009 Vehicles With The "World I4" 4 Cylinder Engine
- 2010 Vehicles
- 2011 Vehicles
- 2012 Vehicles
- Remove, Overhaul & Install
- Engine Controls - Removal, Overhaul & Installation
- Introduction
- Computerized Engine Controls
- Engine Sensors & Switches
- Battery Temperature Sensor
- Brake Switch
- Camshaft Position (CMP) Sensor
- Crankshaft Position (CKP) Sensor
- Downstream Heated Oxygen Sensor
- Engine Coolant Temperature Sensor
- Fuel Level Sensor
- Intake Air Temperature (IAT) Sensor
- Manifold Absolute Pressure (Map) Sensor
- Oil Pressure Sensor
- Output Shaft Speed (OSS) Sensor
- Park/Neutral (P/N) Switch
- Power Steering Pressure (PSP) Switch
- Throttle Position (TP) Sensor
- Transmission Governor Pressure Sensor
- Transmission Overdrive Switch
- Transmission Speed Sensor
- Transmission Temperature Sensor
- Upstream Oxygen Sensor
- Motors, Relays & Solenoids
- Ignition System
- Fuel Systems
- Torque Specifications
- Engine Controls - Removal, Overhaul & Installation
- Specifications
- System
- Engine Controls - Basic Diagnostic Procedures
- Engine Controls - Self-Diagnostics
- Introduction
- Self-Diagnostic System
- Fuel System Pressure Release
- Powertrain Control Module Location
- Programming
- Scan Tool Error Messages
- Summary
- Diagnostic Trouble Code Definitions
- Diagnostic Tests
- Notes
- DTC P0107: Map Sensor Voltage Too Low
- DTC P0108: Map Sensor Voltage Too High
- DTC P0112: Intake Air Temp Sensor Voltage Low
- DTC P0113: Intake Air Temperature Sensor Voltage High
- DTC P0117: ECT Sensor Voltage Too Low
- DTC P0118: ECT Sensor Voltage Too High
- DTC P0121: TPS Voltage Does Not Agree With Map
- DTC P0122: Throttle Position Sensor Voltage Low
- DTC P0123: Throttle Position Sensor Voltage High
- DTC P0125: Closed Loop Temp Not Reached DTC P1281: Engine Is Cold Too Long
- DTC P0130: 1/1 O2 Sensor Heater Circuit Malfunction (With CALIF. Emissions)
- DTC P0131: 1/1 O2 Sensor Shorted To Ground
- DTC P0132: 1/1 O2 Sensor Shorted To Voltage
- DTC P0133: 1/1 O2 Sensor Slow Response
- DTC P0135: 1/1 O2 Sensor Heater Failure
- DTC P0136: 1/2 O2 Sensor Heater Circuit Malfunction (With CALIF. Emissions)
- DTC P0137: 1/2 O2 Sensor Shorted To Ground
- DTC P0138: 1/2 O2 Sensor Shorted To Voltage
- DTC P0139: 1/2 O2 Sensor Slow Response
- DTC P0141: 1/2 O2 Sensor Heater Failure
- DTC P0151: 2/1 O2 Sensor Shorted To Ground (With CALIF. Emissions)
- DTC P0152: 2/1 O2 Sensor Shorted To Voltage (With CALIF. Emissions)
- DTC P0153: 2/1 O2 Sensor Slow Response (With CALIF. Emissions)
- DTC P0155: 2/1 O2 Sensor Heater Failure (With CALIF. Emissions)
- DTC P0157: 2/2 O2 Sensor Shorted To Ground (With CALIF. Emissions)
- DTC P0158: 2/2 O2 Sensor Shorted To Voltage (With CALIF. Emissions)
- DTC P0159: 2/2 O2 Sensor Slow Response (With CALIF. Emissions)
- DTC P0161: 2/2 O2 Sensor Heater Malfunction (With CALIF. Emissions)
- DTC P0171: 1/1 Fuel System Lean DTC P0174: 2/1 Fuel System Lean (With CALIF. Emissions)
- DTC P0172: 1/1 Fuel System Rich DTC P0175: 2/1 Fuel System Rich (With CALIF. Emissions)
- DTC P0201: Injector #1 Control Circuit
- DTC P0202: Injector #2 Control Circuit
- DTC P0203: Injector #3 Control Circuit
- DTC P0204: Injector #4 Control Circuit
- DTC P0205: Injector #5 Control Circuit (4.0L)
- DTC P0206: Injector #6 Control Circuit
- DTC P0207: Injector #7 Control Circuit (4.7L)
- DTC P0208: Injector #8 Control Circuit (4.7L)
- DTC P0300: Multiple Cylinder Misfire
- DTC P0301-P0308: Cylinder Misfire
- DTC P0320: No Crank Reference Signal At Pcm
- DTC P0340: No Cam Signal At Pcm
- DTC P0351: Ignition Coil #1 Primary Circuit (4.0L)
- DTC P0351: Ignition Coil #1 Primary Circuit (4.7L)
- DTC P0352: Ignition Coil #2 Primary Circuit (4.0L)
- DTC P0352: Ignition Coil #2 Primary Circuit (4.7L)
- DTC P0353: Ignition Coil #3 Primary Circuit (4.0L)
- DTC P0353: Ignition Coil #3 Primary Circuit (4.7L)
- DTC P0354: Ignition Coil #4 Primary Circuit (4.7L)
- DTC P0355: Ignition Coil #5 Primary Circuit (4.7L)
- DTC P0356: Ignition Coil #6 Primary Circuit (4.7L)
- DTC P0357: Ignition Coil #7 Primary Circuit (4.7L)
- DTC P0358: Ignition Coil #8 Primary Circuit (4.7L)
- DTC P0420: 1/1 Catalytic Converter Efficiency
- DTC P0432: 2/1 Catalytic Converter Efficiency (With CALIF. Emissions)
- DTC P0441: EVAP Purge Flow Monitor Failure
- DTC P0442: EVAP Leak Monitor Medium (.040") Leak Detected DTC P0455: EVAP Leak Monitor Large Leak Detected
- DTC P0443: EVAP Purge Solenoid Circuit
- DTC P0460: Fuel Level Unit No Change Over Miles
- DTC P0461: Fuel Level Unit No Change Over Time
- DTC P0462: Fuel Level Sending Unit Volts Too Low
- DTC P0463: Fuel Level Sending Unit Volts Too High
- DTC P0500: No Vehicle Speed Sensor Signal
- DTC P0505: Idle Air Control Motor Circuits
- DTC P0522: Oil Pressure Sensor Volts Low
- DTC P0523: Oil Pressure Sensor Volts High
- DTC P0600: Pcm Failure SPI Communications
- DTC P0601: Internal Controller Failure
- DTC P0645: A/C Clutch Relay Circuit
- DTC P0700: EATX Controller DTC Present
- DTC P1195: Slow 1/1 O2S During Catalyst Monitor
- DTC P1196: Slow 2/1 O2S During Catalyst Monitor (With CALIF. Emissions)
- DTC P1282: Fuel Pump Relay Control Circuit
- DTC P1294: Target Idle Not Reached
- DTC P1296: No 5 Volts To Map Sensor
- DTC P1297: No Change In Map From Start To Run
- DTC P1388: Auto Shutdown Relay Control Circuit
- DTC P1389: No ASD Relay Output Voltage At Pcm
- DTC P1391: Intermittent Loss Of CMP Or CKP
- DTC P1398: Misfire Adaptive Numerator At Limit
- DTC P1486: EVAP Leak Monitor Pinched Hose Found
- DTC P1491: Radiator Fan Control Relay Circuit
- DTC P1492: Ambient/Bat Temperature Sensor Voltage Too High
- DTC P1493: Ambient/Bat Temperature Sensor Voltage Too Low
- DTC P1494: Leak Detection Pump SW Or Mechanical Fault
- DTC P1495: Leak Detection Pump Solenoid Circuit
- DTC P1685: Invalid Skim Key
- DTC P1686: No Skim Bus Message Received
- DTC P1687: No Cluster Bus Message
- DTC P1696: Pcm Failure EEPROM Write Denied
- DTC P1698: No Bus Message From Trans Control Module
- DTC P1899: P/N Switch Stuck In Park Or In Gear (4.0L A/T)
- Verification Tests
- Engine Controls - System & Component Testing
- Introduction
- Programming
- Computerized Engine Controls
- Engine Sensors & Switches
- Camshaft Position Sensor
- Checking Brake Switch
- Checking Engine Coolant Temperature Sensor Calibration
- Checking Intake Air Temperature Sensor
- Checking Map Sensor Calibration
- Checking Oxygen Sensor Heater
- Checking Oxygen Sensor Switching
- Checking Park/Neutral Position Switch (A/T)
- Checking Throttle Position Sensor Calibration
- Crankshaft Position Sensor
- Leak Detection Pump Switch
- Power Steering Switch (2.5L)
- Vehicle Speed Sensor
- Motors, Relays & Solenoids
- Fuel Systems
- Idle Control Systems
- Ignition Systems
- Emission Systems & Sub-Systems
- Miscellaneous Controls
- Verification Tests
- Engine Controls - Tests W/O Codes
- O2 Sensor Location & Identification
- Testing & Diagnosis
- Engine Controls - Basic Diagnostic Procedures
- Engine Controls - Self-Diagnostics
- Introduction
- Self-Diagnostic System
- Fuel System Pressure Release
- Powertrain Control Module Location
- Programming
- Scan Tool Error Messages
- Summary
- Diagnostic Trouble Code Definitions
- Diagnostic Tests
- Notes
- DTC P0107: Map Sensor Voltage Too Low
- DTC P0108: Map Sensor Voltage Too High
- DTC P0112: Intake Air Temp Sensor Voltage Low
- DTC P0113: Intake Air Temperature Sensor Voltage High
- DTC P0117: ECT Sensor Voltage Too Low
- DTC P0118: ECT Sensor Voltage Too High
- DTC P0121: TPS Voltage Does Not Agree With Map
- DTC P0122: Throttle Position Sensor Voltage Low
- DTC P0123: Throttle Position Sensor Voltage High
- DTC P0125: Closed Loop Temp Not Reached DTC P1281: Engine Is Cold Too Long
- DTC P0130: 1/1 O2 Sensor Heater Circuit Malfunction (With CALIF. Emissions)
- DTC P0131: 1/1 O2 Sensor Shorted To Ground
- DTC P0132: 1/1 O2 Sensor Shorted To Voltage
- DTC P0133: 1/1 O2 Sensor Slow Response
- DTC P0135: 1/1 O2 Sensor Heater Failure
- DTC P0136: 1/2 O2 Sensor Heater Circuit Malfunction (With CALIF. Emissions)
- DTC P0137: 1/2 O2 Sensor Shorted To Ground
- DTC P0138: 1/2 O2 Sensor Shorted To Voltage
- DTC P0139: 1/2 O2 Sensor Slow Response
- DTC P0141: 1/2 O2 Sensor Heater Failure
- DTC P0151: 2/1 O2 Sensor Shorted To Ground (With CALIF. Emissions)
- DTC P0152: 2/1 O2 Sensor Shorted To Voltage (With CALIF. Emissions)
- DTC P0153: 2/1 O2 Sensor Slow Response (With CALIF. Emissions)
- DTC P0155: 2/1 O2 Sensor Heater Failure (With CALIF. Emissions)
- DTC P0157: 2/2 O2 Sensor Shorted To Ground (With CALIF. Emissions)
- DTC P0158: 2/2 O2 Sensor Shorted To Voltage (With CALIF. Emissions)
- DTC P0159: 2/2 O2 Sensor Slow Response (With CALIF. Emissions)
- DTC P0161: 2/2 O2 Sensor Heater Malfunction (With CALIF. Emissions)
- DTC P0171: 1/1 Fuel System Lean DTC P0174: 2/1 Fuel System Lean (With CALIF. Emissions)
- DTC P0172: 1/1 Fuel System Rich DTC P0175: 2/1 Fuel System Rich (With CALIF. Emissions)
- DTC P0201: Injector #1 Control Circuit
- DTC P0202: Injector #2 Control Circuit
- DTC P0203: Injector #3 Control Circuit
- DTC P0204: Injector #4 Control Circuit
- DTC P0205: Injector #5 Control Circuit (4.0L)
- DTC P0206: Injector #6 Control Circuit
- DTC P0207: Injector #7 Control Circuit (4.7L)
- DTC P0208: Injector #8 Control Circuit (4.7L)
- DTC P0300: Multiple Cylinder Misfire
- DTC P0301-P0308: Cylinder Misfire
- DTC P0320: No Crank Reference Signal At Pcm
- DTC P0340: No Cam Signal At Pcm
- DTC P0351: Ignition Coil #1 Primary Circuit (4.0L)
- DTC P0351: Ignition Coil #1 Primary Circuit (4.7L)
- DTC P0352: Ignition Coil #2 Primary Circuit (4.0L)
- DTC P0352: Ignition Coil #2 Primary Circuit (4.7L)
- DTC P0353: Ignition Coil #3 Primary Circuit (4.0L)
- DTC P0353: Ignition Coil #3 Primary Circuit (4.7L)
- DTC P0354: Ignition Coil #4 Primary Circuit (4.7L)
- DTC P0355: Ignition Coil #5 Primary Circuit (4.7L)
- DTC P0356: Ignition Coil #6 Primary Circuit (4.7L)
- DTC P0357: Ignition Coil #7 Primary Circuit (4.7L)
- DTC P0358: Ignition Coil #8 Primary Circuit (4.7L)
- DTC P0420: 1/1 Catalytic Converter Efficiency
- DTC P0432: 2/1 Catalytic Converter Efficiency (With CALIF. Emissions)
- DTC P0441: EVAP Purge Flow Monitor Failure
- DTC P0442: EVAP Leak Monitor Medium (.040") Leak Detected DTC P0455: EVAP Leak Monitor Large Leak Detected
- DTC P0443: EVAP Purge Solenoid Circuit
- DTC P0460: Fuel Level Unit No Change Over Miles
- DTC P0461: Fuel Level Unit No Change Over Time
- DTC P0462: Fuel Level Sending Unit Volts Too Low
- DTC P0463: Fuel Level Sending Unit Volts Too High
- DTC P0500: No Vehicle Speed Sensor Signal
- DTC P0505: Idle Air Control Motor Circuits
- DTC P0522: Oil Pressure Sensor Volts Low
- DTC P0523: Oil Pressure Sensor Volts High
- DTC P0600: Pcm Failure SPI Communications
- DTC P0601: Internal Controller Failure
- DTC P0645: A/C Clutch Relay Circuit
- DTC P0700: EATX Controller DTC Present
- DTC P1195: Slow 1/1 O2S During Catalyst Monitor
- DTC P1196: Slow 2/1 O2S During Catalyst Monitor (With CALIF. Emissions)
- DTC P1282: Fuel Pump Relay Control Circuit
- DTC P1294: Target Idle Not Reached
- DTC P1296: No 5 Volts To Map Sensor
- DTC P1297: No Change In Map From Start To Run
- DTC P1388: Auto Shutdown Relay Control Circuit
- DTC P1389: No ASD Relay Output Voltage At Pcm
- DTC P1391: Intermittent Loss Of CMP Or CKP
- DTC P1398: Misfire Adaptive Numerator At Limit
- DTC P1486: EVAP Leak Monitor Pinched Hose Found
- DTC P1491: Radiator Fan Control Relay Circuit
- DTC P1492: Ambient/Bat Temperature Sensor Voltage Too High
- DTC P1493: Ambient/Bat Temperature Sensor Voltage Too Low
- DTC P1494: Leak Detection Pump SW Or Mechanical Fault
- DTC P1495: Leak Detection Pump Solenoid Circuit
- DTC P1685: Invalid Skim Key
- DTC P1686: No Skim Bus Message Received
- DTC P1687: No Cluster Bus Message
- DTC P1696: Pcm Failure EEPROM Write Denied
- DTC P1698: No Bus Message From Trans Control Module
- DTC P1899: P/N Switch Stuck In Park Or In Gear (4.0L A/T)
- Verification Tests
- Engine Controls - System & Component Testing
- Introduction
- Programming
- Computerized Engine Controls
- Engine Sensors & Switches
- Camshaft Position Sensor
- Checking Brake Switch
- Checking Engine Coolant Temperature Sensor Calibration
- Checking Intake Air Temperature Sensor
- Checking Map Sensor Calibration
- Checking Oxygen Sensor Heater
- Checking Oxygen Sensor Switching
- Checking Park/Neutral Position Switch (A/T)
- Checking Throttle Position Sensor Calibration
- Crankshaft Position Sensor
- Leak Detection Pump Switch
- Power Steering Switch (2.5L)
- Vehicle Speed Sensor
- Motors, Relays & Solenoids
- Fuel Systems
- Idle Control Systems
- Ignition Systems
- Emission Systems & Sub-Systems
- Miscellaneous Controls
- Verification Tests
- Engine Controls - Tests W/O Codes
- O2 Sensor Location & Identification
- Theory and Operation
- Engine Controls - Theory & Operation
- Introduction
- Computerized Engine Controls
- Powertrain Control Module (Pcm)
- Pcm Inputs
- Pcm Outputs
- Input Signals
- Notes
- Auto Shutdown (ASD) Relay
- Battery Voltage
- Brake Switch
- Camshaft Position Sensor (2.5L)
- Camshaft Position Sensor (4.0L)
- Camshaft Position Sensor (4.7L)
- Crankshaft Position (CKP) Sensor
- 5-Volt Supply
- Fuel Level Sensor
- Engine Coolant Temperature (ECT) Sensor
- Extended Idle Switch
- Oxygen (O2) Sensor
- Ignition Circuit Sense
- Intake Air Temperature (IAT) Sensor
- Manifold Absolute Pressure (MAP) Sensor
- Oil Pressure Sensor
- Power Steering Pressure Switch (PSPS)
- Throttle Position (TP) Sensor
- Vehicle Speed Sensor (VSS)
- Output Signals
- Notes
- A/C Compressor Clutch Relay
- Automatic Shutdown (ASD) Relay
- Cruise Control Servo
- Evaporative (EVAP) Emission System
- Fuel Injectors
- Fuel Pump Relay
- Generator Field
- Generator Light
- Idle Air Control (IAC) Motor
- Ignition Coil
- Injection Timing
- Malfunction Indicator Light (MIL)
- Radiator Cooling Fan Relay
- Serial Communication Interface (SCI) Transmit
- Upshift Indicator Light (M/T)
- Fuel System
- Ignition System
- Hall Effect System
- Notes
- Engine Coolant Temperature (ECT) Sensor
- Crankshaft Position (CKP) Sensor
- Distributor (Cherokee & Wrangler)
- Ignition Coil (Cherokee & Wrangler)
- Ignition Coils (Grand Cherokee)
- Intake Air Temperature (IAT) Sensor
- Manifold Absolute Pressure (MAP) Sensor
- Powertrain Control Module (PCM)
- Throttle Position (TP) Sensor
- Hall Effect System
- Emission Systems & Sub-Systems
- Self-Diagnostic System
- Miscellaneous Controls
- Engine Controls - Theory & Operation
- Vacuum Diagrams
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- Computer Relearn Procedures
- OBD-II Drive Cycles
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- DTC Index
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Identification
- Metric Conversions
- OEM General Information
- Diagnostic Trouble Code Definitions - General Information
- How To Use The Engine Performance Section
- Maintenance Reminder Light (Reset Procedures)
- Air Bag Restraints & SRS Components - Inspection & Replacement Tables
- Specifications Index
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Traction Control Disable Procedures
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- General Servicing
- Cabin Air Filter
- HVAC System - Compressor Applications & Body Designations
- HVAC System - Compressor Refrigerant Oil Checking
- Refrigerant Oils
- Servicing Precautions
- Checking Compressor Oil
- DELPHI-Thermal (HARRISON) Hd6/Ht6/HU6 & Hd6/Hr-6HE 6-CYL., V5 5-CYL. & V7 7-CYL.
- Ford FS-10 10-Cylinder
- Ford SC90V Variable Scroll
- Ford SC115 Fixed Scroll
- NIPPONDENSO 10-Cylinder
- NIPPONDENSO 10S15/10S17/10S20
- NIPPONDENSO 10PA17/10PA17C 10-CYL.
- SANDEN Scroll
- SANDEN MSC90-C Scroll
- SANDEN SD-7H15 7-Cylinder
- SANDEN TRS-90 & Tr-105 Scroll
- ZEXEL Rotary Vane
- HVAC System - Compressor Servicing
- DELPHI-Thermal (HARRISON) Hd6/Ht6/HU6 & Hd6/Hr-6HE 6-CYL., V5 5-CYL. & V7 7-CYL.
- Ford FS-10 10-Cylinder
- Ford SC90V Scroll
- Ford SC115 Scroll
- NIPPONDENSO 10-Cylinder
- NIPPONDENSO 10S15/10S17/10S20
- NIPPONDENSO 10PA17/10PA17C 10-Cylinder
- SANDEN Scroll
- SANDEN MSC90-C Scroll
- SANDEN SD-7H15 7-Cylinder
- SANDEN TRS-90 Scroll
- SANDEN TRS-105 Scroll
- ZEXEL Rotary Vane
- HVAC System - General Servicing Procedures
- USING R-134a REFRIGERANT
- System Service Valves
- Service Equipment
- Manifold Gauge Set
- Pressure-Temperature Relationship
- Pressure Gauge Readings
- Orifice Tube Replacement
- Refrigerant Recovery/Recycling
- Flushing A/C System
- Evacuating A/C System
- Charging A/C System
- Leak Testing
- HVAC System - Refrigerant Oil & Refrigerant Specifications
- HVAC Control Systems
- Heater Systems - Wiring
- HVAC System - Automatic
- Specifications
- Description
- Operation
- Programming
- Symptom Tests
- Self-Diagnostics
- Diagnostic Tests
- Identifying AZC System Problems
- Ambient Air Temp. Failure
- Blower Switch Open
- Blower Switch Shorted
- Cal Checksum Failure
- Country Code Failure
- Defective I/R Sensor
- Driver Blend Door Not Responding
- Driver Blend Door Range Too Large
- Driver Blend Door Range Too Small
- Engine Coolant Response Failure
- Engine Rpm Failure
- Mode Door Motor Not Responding
- Mode Door Range Too Large
- Mode Door Range Too Small
- Mode Select Switch Open
- Mode Select Switch Shorted
- Passenger Blend Door Motor Not Responding
- Passenger Blend Door Range Too Large
- Passenger Blend Door Range Too Small
- Recirculated Air Door Motor Not Responding
- Recirculated Air Door Range Too Large
- Recirculated Air Door Range Too Small
- Vehicle Speed Sensor Failure
- Vehicle VIN Number Failure
- Vacuum Fluorescent (VF) Dimming Failure
- System Tests
- Component Tests
- Removal & Installation
- Torque Specifications
- Wiring Diagrams
- HVAC System - Automatic - Wiring
- HVAC System - Manual
- Specifications
- Description
- Operation
- Trouble Shooting
- System Tests
- Component Tests
- Removal & Installation
- Notes
- Accumulator
- A/C-Heater Unit
- Blend-Air Door
- Blend-Air Door Motor
- Blower Motor
- Blower Motor Resistor
- Compressor
- Condenser
- Control Panel
- Evaporator
- Heater Core
- Heat/Defrost Door
- Heat/Defrost Door Actuator
- High Pressure Cut-Out Switch
- Instrument Panel
- Panel/Defrost Door
- Panel/Defrost Door Actuator
- RECIRCULATION Air Door
- RECIRCULATION Air Door Actuator
- Vacuum Reservoir
- Torque Specifications
- Vacuum Hose Diagram(S)
- Wiring Diagrams
- HVAC System - Manual - Wiring
- General Servicing
- Maintenance
- Restraints
- Air Bag, SRS
- Air Bag Restraint Systems
- Description & Operation
- Component Locations
- Servicing
- System Operation Check
- Air Bag Safety Precautions
- Adjustments
- Disabling & Activating Air Bag System
- Disposal Procedures
- Post-Collision Inspection
- Removal & Installation
- Diagnostics
- Diagnostic Tests
- Test 1A: Identifying System Problems
- Test 1B: Repairing Stored Codes
- Test 2A: Cluster Message Mismatch (Active Code)
- Test 3A: Driver Squib Circuit Open (Active Code)
- Test 4A: Driver Squib Circuit Shorted (Active Code)
- Test 5A: Driver Squib Circuit Shorted To Battery (Active Code)
- Test 6A: Driver Squib Circuit Shorted To Ground (Active Code)
- Test 7A: Loss Of Ignition Run Only (Active Code)
- Test 8A: Loss Of Ignition Run-Start (Active Code)
- Test 8B: Loss Of Ignition Run-Start (Stored Code)
- Test 9A: No PCI Transmission (Stored Code)
- Test 10A: No Cluster Messages (Active Code)
- Test 11A: Passenger Squib Circuit Open (Active Code)
- Test 12A: Passenger Squib Circuit Shorted (Active Code)
- Test 13A: Passenger Squib Circuit Shorted To Battery (Active Code)
- Test 14A: Passenger Squib Circuit Shorted To Ground (Active Code)
- Test 15A: Warning Lamp Open (Active Code)
- Test VER-1A: Air Bag Verification Test
- Test VER-2A: Body Verification Test
- Vehicle Communications
- Torque Specifications
- Wiring Diagrams
- Supplemental Inflatable Restraint System Deactivation Procedures
- Special Care During Mechanical Repairs
- DAIMLERCHRYSLER
- Ford Motor Co.
- System Operation Check
- Service Precautions
- Disabling & Activating Air Bag System
- Notes
- Disabling System (Continental & Town Car)
- Activating System (Continental & Town Car)
- Disabling System (Contour, Mustang, Mystique & Ranger)
- Activating System (Contour, Mustang, Mystique & Ranger)
- Disabling System (Cougar)
- Activating System (Cougar)
- Disabling System (Crown Victoria & Grand Marquis)
- Activating System (Crown Victoria & Grand Marquis)
- Disabling System (Econoline)
- Activating System (Econoline)
- Disabling System (Escort)
- Activating System (Escort)
- Disabling System (Excursion & F250/350 Super Duty)
- Activating System (Excursion & F250/350 Super Duty)
- Disabling System (Expedition & Navigator)
- Activating System (Expedition & Navigator)
- Disabling System (Explorer & Mountaineer)
- Activating System (Explorer & Mountaineer)
- Disabling System (Focus)
- Activating System (Focus)
- Disabling System (F150 & F250 Light Duty)
- Activating System (F150 & F250 Light Duty)
- Disabling System (LS)
- Activating System (LS)
- Disabling System (Sable & Taurus)
- Activating System (Sable & Taurus)
- Disabling System (Villager)
- Activating System (Villager)
- Disabling System (Windstar)
- Activating System (Windstar)
- Air Bag Simulator
- Driver Air Bag Module
- Notes
- Removal & Installation (Continental, Contour, Cougar, Escort, Escort Coupe, Focus, LS, Mustang, Mystique, Ranger & Town Car)
- Removal & Installation (Crown Victoria & Grand Marquis)
- Removal & Installation (Econoline, Excursion, Explorer, F150, F250 Light Duty, F250/350 Super Duty, Expedition, Mountaineer & Navigator)
- Passenger Air Bag Module
- Torque Specifications
- General Motors
- Notes
- System Operation Check
- Service Precautions
- Disabling & Activating Air Bag System
- Notes
- Disabling System (Alero, Grand Am & Malibu)
- Activating System (Alero, Grand Am & Malibu)
- Disabling System (Astro & Safari)
- Activating System (Astro & Safari)
- Disabling System (Bonneville, LeSabre & Park Avenue)
- Activating System (Bonneville, LeSabre & Park Avenue)
- Disabling System (Blazer, Bravada, Envoy, Jimmy, Sonoma & S10)
- Activating System (Blazer, Bravada, Envoy, Jimmy, Sonoma & S10)
- Disabling System ("C" & "K" Pickup, & Escalade)
- Activating System ("C" & "K" Pickup, & Escalade)
- Disabling System (Camaro & Firebird)
- Activating System (Camaro & Firebird)
- Disabling System (Catera)
- Activating System (Catera)
- Disabling System (Cavalier & Sunfire)
- Activating System (Cavalier & Sunfire)
- Disabling System (Century, Grand Prix, Intrigue & Regal)
- Activating System (Century, Grand Prix, Intrigue & Regal)
- Disabling System (Corvette)
- Activating System (Corvette)
- Disabling System (DeVille & Seville)
- Activating System (DeVille & Seville)
- Disabling System (Eldorado)
- Activating System (Eldorado)
- Disabling System (Express, Van & Savana)
- Activating System (Express, Van & Savana)
- Disabling System (Impala & Monte Carlo)
- Activating System (Impala & Monte Carlo)
- Disabling System (Lumina)
- Activating System (Lumina)
- Disabling System (Metro & Firefly (Canadian))
- Activating System (Metro & Firefly (Canadian))
- Disabling System (Montana, Silhouette & Venture)
- Activating System (Montana, Silhouette & Venture)
- Disabling System (Prizm)
- Activating System (Prizm)
- Disabling System (Saturn "L" Series)
- Activating System (Saturn "L" Series)
- Disabling System (Saturn "S" Series)
- Activating System (Saturn "S" Series)
- Disabling System (Sierra, Silverado, Suburban, Tahoe & Yukon)
- Activating System (Sierra, Silverado, Suburban, Tahoe & Yukon)
- Disabling System (Tracker)
- Activating System (Tracker)
- Jeep
- Air Bag Restraint Systems
- Air Bag, SRS
- Steering
- Manual Steering
- Steering System - Power Recirculating Ball
- Description & Operation
- Testing
- Lubrication
- Adjustments
- Removal & Installation
- Overhaul
- Torque Specifications
- Steering System - Power Recirculating Ball
- Power Steering
- Steering System - Power Recirculating Ball
- Description & Operation
- Testing
- Lubrication
- Adjustments
- Removal & Installation
- Overhaul
- Torque Specifications
- Steering System - Power Recirculating Ball
- Steering Wheel & Steering Column
- Manual Steering
- Suspension
- Front Suspension
- Description
- Adjustments & Inspection
- Removal & Installation
- Torque Specifications
- Rear Suspension
- Wheel Alignment Specifications & Adjustment Procedures
- Front Suspension
- Transmission
- Automatic Trans
- Automatic Transmission (RFE Series Transmissions) (Service Information)
- Automatic Transmission Diagnosis - 42RE & 44RE & 46RE & 47RE
- Application
- Model Identification
- Description & Operation
- Trouble Shooting
- Diagnosis & Testing
- Diagnostic Tests
- Notes
- DTC P0711: Trans Temp Sensor, No Temp Rise After Start
- DTC P0712: Trans Temp Sensor Voltage Too Low
- DTC P0713: Trans Temp Sensor Voltage Too High
- DTC P0720: Low Output Speed Sensor Rpm Above 15 Mph
- DTC P0740: TORQ CONV CLU, No Rpm Drop At Lockup
- DTC P0743: Torque CONV Clutch Solenoid/Trans Relay CKT
- DTC P0748: Governor Pressure Sol Control/Trans Relay Circuits
- DTC P0751: Od Off Switch Pressed (Lo) More Than 5 Min
- DTC P0753: Trans 3-4 Shift Solenoid/Trans Relay Circuits
- DTC P0783: 3-4 Shift Sol, No Rpm Drop @ 3-4 Shift
- DTC P1740: TCC Or Od Solenoid Performance
- DTC P1756: Gov Press Not Equal To Target @ 15-20 Psi
- DTC P1756: Gov Press Not Equal To Target @ 35-40 Psi
- DTC P1757: Gov Pres Above 3 Psi In Gear With 0 Mph
- DTC P1762: Gov Press Sen Offset Volts Too Low Or High
- DTC P1763: Governor Pressure Sensor Volts Too High
- DTC P1764: Governor Pressure Sensor Volts Too Low
- DTC P1765: Trans 12-Volt Supply Relay CNTRL Circuit
- DTC P1899: P/N Switch Stuck In Park Or In Gear
- Transmission Verification Test
- Verification Test VER-5A (Diesel)
- Verification Test VER-5A (Gasoline)
- Removal & Installation
- Wiring Diagrams
- Overhaul - 42RE & 44RE Automatic Transmission
- Application
- Identification
- Description & Operation
- Lubrication
- On-Vehicle Service
- Trouble Shooting
- Notes
- Symptom Diagnosis
- Notes
- Buzzing Noise
- Delayed Engagement From Neutral To Drive Or Reverse
- Drags Or Locks Up
- Growling, Grating Or Scraping Noise
- Harsh Engagement From Neutral To Drive Or Reverse
- No Drive Range In Any Position (Reverse Is Okay)
- No Kickdown Or Normal Downshift
- No Low Gear (Moves In 2nd & 3rd Gears Only)
- No Reverse
- Shifts Delayed Or Erratic
- Slips In All Forward Gears
- Slips In Low & Drive But Not In 1st Gear
- Slips In Reverse Only
- Harsh 1-2, 2-3, 3-4 Or 3-2 Shifts
- Torque Converter Locks Up In 2nd &/Or 3rd Gear
- Vehicle Moves In Neutral
- Vehicle Moves In 2nd Or 3rd Gear & Abruptly Downshifts To Low
- Vehicle Will Not Move In Any Gear
- Will Not Upshift From Low Gear
- No Start In Park Or Neutral
- 1st & Reverse Gears Only
- Noise Related To Engine Speed
- Overdrive Unit Symptom Diagnosis
- Delayed 3-4 Upshift
- No Reverse Or Slips In Reverse
- No 3-4 Upshift
- No 4-3 Downshift
- No 4-3 Downshift With Overdrive Switch In OFF Position
- Noisy Operation In 4th Gear Only
- Slips In 4th Gear
- 3-4 Upshift Occurs Immediately After Completing 2-3 Upshift
- Clunk Noise From Driveline On Closed Throttle 4-3 Downshift
- Performance Tests
- Road Test
- Hydraulic Pressure Tests
- Notes
- Test Preparation
- Pressure Test With Transmission In "1" (Low Gear)
- Pressure Test With Transmission In "2" (2nd Gear)
- Pressure Test With Transmission In "D" (Drive Gear)
- Pressure Test With Transmission In "R" (Reverse Gear)
- Pressure Test With Transmission In Overdrive (4th Gear)
- Transmission Governor Pressure
- Hydraulic Pressure Test Results
- Hydraulic Pressure Adjustments
- Torque Converter
- Clutch & Servo Air Pressure Test
- Removal & Installation
- Transmission Disassembly
- Transmission Component Disassembly & Reassembly
- Transmission Reassembly
- Overdrive Unit
- Torque Specifications
- Transmission Specifications
- Removal & Installation - Automatic Transmission
- Shift Interlock Systems
- Automatic Transmission Hydraulic Diagrams - 42RE & 44RE & 46RE & 47RE
- Overhaul - NV247 Transfer Case
- Automatic Trans
- External Pages