Technical Service Bulletins

A/C Compressor
- A/C System Additives (24-003-03)
- A/C System Leak Detection (24-009-02)
Accessories Control Systems
- Scan Tool Support Before And After Collision Repair (31-002-16)
- Co-Pilot Support And Correct Cable Usage (18-029-05)
Accessory Drive Belts
- 2.4L Engine - Chirp-Like Sound From Accessory Drive Belt (07-003-05)
Air Bag, SRS
- Replacement Seat Covers And Seat Cover Repairs (31-004-11)
- Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
- Safety Systems - Vehicle Modifications/Repair (08-027-04)
Anti-Theft Systems
- Powertrain Control Module Initialization (08-030-06 REV.A)
Automatic Trans
- Mil Illumination - DTC P1776 Solenoid Switch Valve Latched In LR Position (21-008-04 REV. A)
- Automatic Transmission Diagnostic Tear Down Procedure (21-021-08)
- Automatic Transmission Fluid Usage ATF+4 (Type Ms9602) (21-014-07)
- Transmission Delayed Engagement (21-007-04)
- Automatic Transmission Diagnostic TEARDOWN Procedure (21-009-03)
- New Fasteners To Prevent Possible 42RLE Transmission Fluid WEEPAGE (21-007-03)
Auxiliary Emission Control Systems
- Evaporative Systems Service (25-001-04)
- Flash Programming Failure Recovery (18-32-98)
Body Interior
- Scan Tool Support Before And After Collision Repair (31-002-16)
- Flash Programming Failure Recovery (18-32-98)
Brakes Control Systems
- Safety Systems - Vehicle Modifications/Repair (08-027-04)
Clutch
- Clutch Slipping (06-002-03)
Communication Devices
- Radio Communication Equipment Installation Recommendations (08-024-05)
Cooling System (Mechanical)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
Differentials & Drive Axles
- A Self-Sustaining Vibration (Shimmy) Of The Vehicle And Steering Wheel While Driving At Speeds Typically Above 50 Mph (80 KMH) (19-002-12)
Engine Control Systems
- Powertrain Control Module Initialization (08-030-06 REV.A)
- Co-Pilot Support And Correct Cable Usage (18-029-05)
- Powertrain Control Module Initialization (08-015-05)
- Safety Systems - Vehicle Modifications/Repair (08-027-04)
- New Spark Plug For 2.4L Engine (08-034-03)
- 4.0L Multiple Cylinder Misfire (09-003-03)
- Flash Programming Failure Recovery (18-32-98)
Entertainment Systems
- Buzz Or Rattle-Like Sound From Sound Bar Radio Speaker Housing And/Or Harness (08-040-05)
Exterior Body Panels
- Scan Tool Support Before And After Collision Repair (31-002-16)
- Do Not Apply Corrosion Protection On Sheet Molding Compound (SMC) Plastic Panels (31-005-12)
- Blending CLEARCOAT During The Refinish Process (31-002-13)
- OVERSPRAY Removal (31-001-13)
- Welded Sheet Metal Repairs And Replacements (31-007-12)
- Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
- Repair Parts Used For Structural Repairs (31-002-11)
- Use Of Heat To Straighten Damaged Components (31-001-11)
- Creak-Like Sound From Right Rear Wheel Well Area (23-029-03)
Exterior Lights
- Exterior Lamp Condensation And Fogging (08-091-14)
Frames, Subframes & Crossmembers
- Repair Parts Used For Structural Repairs (31-002-11)
- Creak-Like Sound From Right Rear Wheel Well Area (23-029-03)
Front Suspension
- Shock Strut Weeping Condition Identification (02-001-15)
- Special Offset Ball Joint - Allows Adjustment To Caster And Camber Angles (02-006-04)
Headlights
- Exterior Lamp Condensation And Fogging (08-091-14)
HVAC Control Systems
- A/C Cooling Coil Odor (24-013-05)
- A/C System Additives (24-003-03)
- A/C System Leak Detection (24-009-02)
Identification
- Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
Ignition System
- New Spark Plug For 2.4L Engine (08-034-03)
Interior/Exterior Trim
- Replacement Seat Covers And Seat Cover Repairs (31-004-11)
- Tomb Raider Aluminum Wheel Center Cap Medallion Looses Adhesion To Cap (22-005-03)
Manual Steering
- Power Steering Fluid Usage (19-007-01)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Irregular Engine Snapping Sound (09-007-04)
- 4.0L Multiple Cylinder Misfire (09-003-03)
Paint & Coatings
- Do Not Apply Corrosion Protection On Sheet Molding Compound (SMC) Plastic Panels (31-005-12)
- Blending CLEARCOAT During The Refinish Process (31-002-13)
- OVERSPRAY Removal (31-001-13)
- Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
Passive Restraints
- Safety Systems - Vehicle Modifications/Repair (08-027-04)
Rear Suspension
- Shock Strut Weeping Condition Identification (02-001-15)
Restraints Control Systems
- Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
Seats
- Replacement Seat Covers And Seat Cover Repairs (31-004-11)
Steering Column
- Steering Wheel Not Centered (02-002-15)
- Steering Shimmy (19-003-06)
Steering Control Systems
- A Self-Sustaining Vibration (Shimmy) Of The Vehicle And Steering Wheel While Driving At Speeds Typically Above 50 Mph (80 KMH) (19-002-12)
Steering Linkage
- A Self-Sustaining Vibration (Shimmy) Of The Vehicle And Steering Wheel While Driving At Speeds Typically Above 50 Mph (80 KMH) (19-002-12)
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
Sun Roof/T-Top/Convertible Top
- Soft Top - Seam Sealer Tape Repair (23-008-05)
- Soft Top Zipper Cleaner And Lubricant - For Difficult To Operate Window Zippers (23-025-01)
System
- Co-Pilot Support And Correct Cable Usage (18-029-05)
- New Spark Plug For 2.4L Engine (08-034-03)
- 4.0L Multiple Cylinder Misfire (09-003-03)
- Flash Programming Failure Recovery (18-32-98)
Transfer Case
- Spark Knock Or Powertrain Rattle-Like Sound From Transfer Case Shifter Area (21-010-05)
- NV-241 Transfer Case Fluid Seepage From Area Of Rear Output Shaft Retainer (21-003-04)
Transmission Control Systems
- Co-Pilot Support And Correct Cable Usage (18-029-05)
- MIL ILLUMINATION FOR DTC's P0750, P0755, P0760, P0765, P0846, P0871 OR P0841 (21-009-05)
- Transmission Delayed Engagement (21-007-04)
- Transmission Harsh 4-3 Downshift (21-006-03 REV. A)
- Flash Programming Failure Recovery (18-32-98)
Wheel Alignment
- Steering Wheel Not Centered (02-002-15)
- Vehicle Pulls Or Leads Right Or Left (02-003-15)
- Special Offset Ball Joint - Allows Adjustment To Caster And Camber Angles (02-006-04)
Wheel Hubs
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
Wheels & Tire System
- Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
- Steering Wheel Vibration Diagnostic Procedure (22-001-14 REV. A)
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
- Reconditioned Wheel Usage (31-005-11)
- Tomb Raider Aluminum Wheel Center Cap Medallion Looses Adhesion To Cap (22-005-03)
- Chrome Wheel Care (22-01-99)
Window Motors & Regulators
- Rear Window Lift Glass Seal/Carrier Replacement (23-022-04)
- Soft Top Zipper Cleaner And Lubricant - For Difficult To Operate Window Zippers (23-025-01)
Wiper/Washer Systems
- Windshield Wiper Blade/Element Maintenance (23-037-15)