Automatic Transmission Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- General Description
- Functional Operation
- Diagnostic Trouble Codes
- Using The DRBIII®
- DRBIII® Error Messages
- Transmission Simulator (Miller Tool # 8333) And Electronic Transmission Adapter Kit (Miller Tool #8333-1A)
- Disclaimers, Safety, And Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Communication
- Transmission - 42RLE
- P0122-Throttle Position Sensor/Apps Low
- P0123-Throttle Position Sensor/Apps High
- P0124- Throttle Position Sensor/Apps Intermittent
- P0218-High Temperature Operation Activated
- P0562-Low Battery Voltage
- P0604-Internal TCM
- P0605-Internal TCM
- P0613-Internal TCM
- P0706-Check Shifter Signal
- P0711-Transmission Temperature Sensor Performance
- P0712-Transmission Temperature Sensor Low
- P0713-Transmission Temperature Sensor High
- P0714-Transmission Temperature Sensor Intermittent
- P0715-Input Speed Sensor Error
- P0720-Output Speed Sensor Error
- P0725-Engine Speed Sensor Circuit
- P0731-Gear Ratio Error In 1ST
- P0732-Gear Ratio Error In 2ND
- P0733-Gear Ratio Error In 3RD
- P0734-Gear Ratio Error In 4TH
- P0736-Gear Ratio Error In Reverse
- P0740-Torque Converter Clutch Control Circuit
- P0750-LR Solenoid Circuit
- P0755-2/4 Solenoid Circuit
- P0760-Od Solenoid Circuit
- P0765-UD Solenoid Circuit
- P0841-LR Pressure Switch Sense Circuit
- P0845-2/4 Hydraulic Pressure Test Failure
- P0846-2/4 Pressure Switch Sense Circuit
- P0870-Od Hydraulic Pressure Test Failure
- P0871-Od Pressure Switch Sense Circuit
- P0884-Power Up At Speed
- P0888-Relay Output Always Off
- P0890-Switched Battery
- P0891-Transmission Relay Always On
- P0897-Worn Out/Burnt Transaxle Fluid
- P0944-Loss Of Prime
- P0992- 2-4/Od Hydraulic Pressure Test Failure
- P1652-Serial Communication Link Malfunction
- P1684-Battery Was Disconnected
- P1687-No Communication With The Mic
- P1694-Bus Communication With Engine Module
- P1775-Solenoid Switch Valve Latched In TCC Position
- P1776-Solenoid Switch Valve Latched In LR Position
- P1790-Fault Immediately After Shift
- P1793-TRD Link Communication Error
- P1794-Speed Sensor Ground Error
- P1797-Manual Shift Overheat
- Symptom: *BACKUP LAMPS COME ON WHILE SHIFTER IS NOT IN REVERSE POSITION
- Symptom: *BACKUP LAMPS INOPERATIVE
- Symptom: *CHECKING PARK/NEUTRAL SWITCH OPERATION
- Symptom: *INCORRECT TRANSMISSION FLUID LEVEL
- Symptom: *NO SPEEDOMETER OPERATION
- Symptom: *TRANSMISSION NOISY WITH NO DTC'S PRESENT
- Symptom: *TRANSMISSION SHIFTS EARLY WITH NO DTC'S
- Symptom: *TRANSMISSION SIMULATOR 8333 WILL NOT POWER UP
- Verification Tests
- Component Locations
- Connector PINOUTS
- Crankshaft Position Sensor (2.4/4.0L A/T) - Black 3 Way
- Data Link Connector - Black 16 Way
- Input Speed Sensor - 2 Way
- Output Speed Sensor - 2 Way
- Overdrive Off Switch - 4 Way
- Transmission Control Relay (In PDC)
- Powertrain Control Module C1 - Black 32 Way
- Powertrain Control Module C2 - White 32 Way
- Powertrain Control Module C3 - Gray 32 Way
- Throttle Position Sensor (2.4L) - White/Blue 3 Way
- Throttle Position Sensor (4.0L) - 3 Way
- Transfer Case Switch (Except Off-Road Package) - Black 2 Way
- Transfer Case Switch (Off-Road Package) - Black 2 Way
- Transmission Control Module - 60 Way
- Transmission Range Sensor - 10 Way
- Transmission Solenoid/Pressure Switch Assembly - 10 Way
- Schematic Diagrams
- Charts And Graphs