EUROPE - Diesel Engine

This vehicle is equipped with an automatic oil change indicator system. The oil change indicator system will remind you that it is time to take your vehicle in for scheduled servicing. Based on engine operation conditions, the oil change indicator message will illuminate. This means that service is required for your vehicle. Operating conditions such as frequent short-trips, trailer tow, extremely hot or cold ambient temperatures will influence when the "Oil Change Required" message is displayed.

Engine Oil Filter Replacement

Residual oil in the housing may spill from the housing when the new filter is installed if the residual oil is not either removed from the housing or enough time has not elapsed to allow the oil to drain back into the engine. When servicing the oil filter on this engine, carefully remove the filter and use a suction gun to remove any residual oil left in the housing or wait about 30 minutes for the oil to drain back into the engine.

NOTE:

Under no circumstances should oil change intervals exceed 12, 500 miles (20 000 km) or 12 months, whichever comes first.

NOTE:

Flush and replace the engine coolant at 120 months or 150, 000 miles (240, 000 km) whichever comes first.

Oil Change Indicator - RESET

Unless reset, this message continues to display each time you turn the ignition switch to the ON/RUN position. To turn off the message temporarily, press and release the Menu button. To reset the oil change indicator system (after performing the scheduled maintenance) perform the following procedure:
- Turn the ignition switch to the "ON" position (Do not start the engine).
- Fully depress the accelerator pedal slowly three times within 10 seconds.
- Turn the ignition switch to the "LOCK" position.
  NOTE:
  If the indicator message illuminates when you start the vehicle, the oil change indicator system did not reset. If necessary repeat this procedure.

At Each Stop for Fuel

Check the engine oil level about 5 minutes after a fully warmed engine is shut off. Checking the oil level while the vehicle is on level ground will improve the accuracy of the oil level reading. Add oil only when the level is at or below the ADD or MIN mark.
Check the windshield washer solvent and add if required.

Once a Month

Check tire pressure and look for unusual wear or damage. Rotate tires at the first sign of irregular wear, even if it occurs before the oil indicator system turns on.
Inspect the battery and clean and tighten the terminals as required.
Check the fluid levels of the coolant reservoir, and brake master cylinder; add as needed.
Check all lights and other electrical items for correct operation.

At Each Oil Change

Change the engine oil filter.
Inspect the brake hoses and lines.
Inspect the CV/Universal joints.
Inspect for the presence of water in the fuel filter/water separator unit.
Completely fill the AdBlue Fluid tank.

Demanding Vehicle Use

Restore additive level for AdBlue® Diesel emissions (UREA) (if equipped), when the lamp is illuminated or the message on the instrument panel.

At Every Second Oil Change

Replace fuel filter.

MAINTENANCE CHART

Miles or time passed (whichever comes first):

12, 500

25, 000

37, 500

50, 000

62, 500

75, 000

87, 500

100, 000

112, 500

125, 000

137, 500

150, 000

Or Months:

108

120

132

144

Kilometers:

20, 000

40, 000

60, 000

80, 000

100, 000

120, 000

140, 000

160, 000

180, 000

200, 000

220, 000

240, 000

Change engine oil and oil filter.

⁽¹⁾

Check and, if necessary, top up fluid levels. ⁽³⁾

Rotate tires

If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary.

Inspect the brake linings, replace if necessary.

Inspect exhaust system.

Inspect CV Joints

Visually inspect condition of: exterior bodywork, underbody protection, pipes and hoses (exhaust - fuel system - brakes), rubber elements (boots, sleeves, bushings, etc.)

Inspect the front suspension, tie rod ends and boot seals, replace if necessary.

Change brake fluid every 24 months if using DOT 4 brake fluid. ⁽²⁾

Inspect the front and rear axle fluid, change if using your vehicle for police, taxi, fleet, off road or frequent trailer towing.

Replace the fuel filter.

Fuel filter replacement interval shall be at every second oil change

Adjust parking brake on vehicles equipped with four-wheel disc brakes.

Replace engine air cleaner filter.

Replace air conditioning/cabin air filter

Replace accessory drive belt(s).

Flush and replace the engine coolant at 10 years or 150, 000 miles (240, 000 km) whichever comes first.

Inspect or change the transfer case fluid if using your vehicle for any of the following: police, taxi, fleet, or frequent trailer towing.

Change the transfer case fluid

⁽¹⁾	The actual interval for changing engine oil and replacing the engine oil filter depends on the vehicle usage conditions, and is signaled by the warning light or message in the instrument panel. In all cases, never exceed 1 year/20, 000 km.

⁽²⁾	The brake fluid change interval is time based only, mileage intervals do not apply.

⁽³⁾	Consumption of additive AdBlue® (UREA) depends on the condition of use of the vehicle and is indicated by LED and/or message on the instrument panel.