Technical Service Bulletins

A/C Compressor
- Compressor Diagnosis Tool (SST040 REV1)
- R1234YF Oil And Dye Injectors (SST044 REV 2)
- Servicing R1234YF A/C Systems Using The MAHLE ACX1299 (SST054 REV3)
Accessories & Equipment
- UVO Voice Assist - Navigation Local Search (PS662)
- Valet Alert Feature On KIA Access App (PS615)
- Introduction To Pin Tension Gauge (SST062)
Accessories Control Systems
- KIA Vehicle Inspection & Delivery (KVID) Program (SST055 REV 5)
- USB Multi-Box Guidelines (PS634 REV 1)
- Service Action: Power Window Switch Assembly Replacement (SA354) (SA354)
- Use Of Aftermarket USB Charging Cables In USB/12V Ports (PS443 REV 1)
Air Bag, SRS
- Side Airbag (SAB) Inspection And Replacement For DTC(S) B1380/B1384 (BOD324)
- Airbag And SEATBELT System Parts Replacement Precautions (GEN100)
Anti-Theft Systems
- Customer Satisfaction: Theft Deterrent Ignition Cylinder Protector & Decal Installation (Cs2311) (CS2311 REV 3)
- Customer Satisfaction: Anti-Theft S/W Logic Upgrade & Decal Installation (Cs2303) (CS2303 REV 4)
- Customer Satisfaction: KIA Genuine Remote Start Control Module Upgrade For Anti-Theft Logic Compatibility (Cs2310) (CS2310)
- Partial Repair - Trunk Latch (BOD208)
- Remote Start Valet Mode (PS586)
Automatic Trans
- Transmission Fluid Application Guide (TRA046 REV 5)
- Remanufactured Engines And TRANSMISISONS Are Not Shipped With Engine Oil Or Transmission Fluid (PS740)
- KIA Vehicle Inspection & Delivery (KVID) Program (SST055 REV 5)
- Shift Lock Release Operation (PS657)
Auxiliary Emission Control Systems
- "Web Based" KDS IUMPR Data Collection (SST064 REV 1)
- Data Collection: Extract CALIFORNIA Emissions Data From Ecu (Dc19) (ENG197 REV 1)
Auxiliary Power Unit
- Wireless Charging System Diagnosis (PS716 REV 3)
Axle Shafts
- Driveshaft Serviceability (TRA047 REV 2)
Body Electrical
- Use Of Aftermarket USB Charging Cables In USB/12V Ports (PS443 REV 1)
Body Interior
- Customer Satisfaction: Theft Deterrent Ignition Cylinder Protector & Decal Installation (Cs2311) (CS2311 REV 3)
- Software (S/W) Upgrade Instruction Using KDS (SST081)
- Use Of Aftermarket USB Charging Cables In USB/12V Ports (PS443 REV 1)
Charging Systems
- Use Of Aftermarket USB Charging Cables In USB/12V Ports (PS443 REV 1)
Clutch
- 7-Speed DCT Judder Inspection And Dual Clutch Assembly Replacement (TRA083 REV 1)
Collision/Avoidance
- Front Camera/Radar Blockage DTC Information - C2A2397, C2A2497, C2A2597, C2A2697 (PS763)
- BSD/BCW Troubleshooting & Angle Measurement (SST060 REV 1)
- Front Radar Sensor Mounting Inspection (PS704) (PS704)
- MFC, Concerns For Disabled Operation (PS663)
Communication Devices
- Service Action: KIA Connect Modem Reset (SA611) (ELE378)
- BLUETOOTH Memory And Voice Recognition Concern With AVN 5.0/W (PS703)
- UVO Link Activation/UVO App Compatibility (PS607 REV 2)
- USB Multi-Box Guidelines (PS634 REV 1)
- KIA Access With UVO Link (Embedded Telematics) (PS575 REV 2)
- UVO Play (D. Audio 2.0) With Android Auto & Apple CARPLAY (PS570)
- Volume Settings In UVO Link (PS574)
Cooling System (Mechanical)
- MAHLE ACX1299 Program Enhancement (SST063)
Differentials & Drive Axles
- Wheel Bearing Assembly Removal (PS650)
- Driveshaft Serviceability (TRA047 REV 2)
Electronic Steering
- Partial Repair Of C-MDPS Motor, Ecu, Worm Gear And/Or Steering Column Housing (CHA084 REV 7)
Engine Control Systems
- Software (S/W) Upgrade Instruction Using KDS (SST081)
- KIA Vehicle Inspection & Delivery (KVID) Program (SST055 REV 5)
- Service Action: 2.4L GDI Engine Start Logic Improvement (SA369) (SA369)
Entertainment Systems
- Factory Reset Through Dealer Mode (PS689 REV 3)
- UVO Link Activation/UVO App Compatibility (PS607 REV 2)
- Identifying Embedded Modem Head Units (PS666)
- Identifying Head Unit Software Version For Direct Exchange (ELE091 REV 5)
- Steering Wheel Mode Button Functions (PS594)
- Touchscreen Display Inoperative (PS595)
- KIA Access With UVO Link (Embedded Telematics) (PS575 REV 2)
- Navigation Voice Prompts Via BLUETOOTH (PS591)
- Apple CARPLAY Updates And BLUETOOTH Concerns With IOS 12.X Versions (PS585)
- UVO Play (D. Audio 2.0) With Android Auto & Apple CARPLAY (PS570)
- Volume Settings In UVO Link (PS574)
Exterior Lights
- Information For Headlamp Condensation And Moisture (BOD055 REV 1)
Fuel System
- Fuel Pump Filter Inspection/Replacement (FUE061 REV 1)
- Special Service Information & Specifications For GDI High Pressure Fuel System (ENG083 REV 1)
Gauges & Instrument Panels
- Steering Wheel Mode Button Functions (PS594)
General Servicing
- MAHLE ACX1299 Service Portal Overview (SST065)
Headlights
- Information For Headlamp Condensation And Moisture (BOD055 REV 1)
HVAC Control Systems
- Compressor Diagnosis Tool (SST040 REV1)
- Air Conditioning Inoperative Due To Leak (PS700)
- Servicing R1234YF A/C Systems Using The MAHLE ACX1299 (SST054 REV3)
- MAHLE ACX1299 Service Portal Overview (SST065)
Identification
- Customer Satisfaction: Theft Deterrent Ignition Cylinder Protector & Decal Installation (Cs2311) (CS2311 REV 3)
- Load Carrying Capacity Label Requirements And Instruction To Comply With FMVSS110 (KT2008053001)
Infotainment
- Navigation System - Server-Based Routing (PS728)
- Head Unit Software Update - MAPCARE (ELE208 REV 1)
- UVO Link Activation/UVO App Compatibility (PS607 REV 2)
- UVO Voice Assist - Navigation Local Search (PS662)
- Modem Status - Activation State PRERDR - Basic (2) (PS660)
- Identifying Head Unit Software Version For Direct Exchange (ELE091 REV 5)
- Touchscreen Display Inoperative (PS595)
- Navigation Voice Prompts Via BLUETOOTH (PS591)
- Navigation Map Upgrade - Customer Retail (GEN051REV7)
Interior/Exterior Trim
- Sport Visor Installation (PS636)
Lubrication System
- Excessive Oil Consumption Nu/Gamma/Theta/Kappa Engines (ENG222 REV 8)
Manual Steering
- Replacement Of MOBIS C-MDPS Small Bearing (CHA111)
Manual Trans
- Transmission Fluid Application Guide (TRA046 REV 5)
Mechanical
- Excessive Oil Consumption Nu/Gamma/Theta/Kappa Engines (ENG222 REV 8)
- Diagnostic Aid: Cylinder Bore Marking(S) (ENG248)
- Engine Replacement Instructions For DTC P1326 (Pi1805Y/Z) (PI1805Y/Z)
- Engine Component Re-Use Guidelines (PS539 REV 1)
- Engine Replacement Practices Reminder (ENG190 REV 1)
- Low Oil Pressure At Idle After Gamma 1.6L GDI Short Block Engine Replacement (PS739)
- Remanufactured Engines And TRANSMISISONS Are Not Shipped With Engine Oil Or Transmission Fluid (PS740)
- Technician Web Portal (Twp) Changes (PS683)
Mechanical - Hydraulic
- Long Term Storage Brake Rotor Light Rust Removal Practices (PS756)
- Aftermarket Brake Fluid Not Advised For Brake Fluid Air Bleeding Procedures (PS706)
- Brake Fluid - Supersession To Dot 4 (PS691)
- Brake Caliper Leak Inspection (PS675)
Memory Modules
- Maintenance Reminder Feature (ENG219 REV 1)
Passive Restraints
- Airbag And SEATBELT System Parts Replacement Precautions (GEN100)
Procedures
- Long Term Storage Brake Rotor Light Rust Removal Practices (PS756)
- Improved Air Bleeding Tool (SST079)
- Maintenance Reminder Feature (ENG219 REV 1)
- BCT Dial Gauge Battery Replacement (PS711)
- Aftermarket Brake Fluid Not Advised For Brake Fluid Air Bleeding Procedures (PS706)
- Electronic Control Unit REFLASH Best Practices (PS688)
- MAHLE ACX1299 Service Portal Overview (SST065)
Schedule
- Maintenance Reminder Feature (ENG219 REV 1)
Seats
- Airbag And SEATBELT System Parts Replacement Precautions (GEN100)
Starter
- Service Action: KIA Connect Modem Reset (SA611) (ELE378)
- Customer Satisfaction: KIA Genuine Remote Start Control Module Upgrade For Anti-Theft Logic Compatibility (Cs2310) (CS2310)
- KIA Smart Battery Tester (B2Q) And Warranty Policy (SST070)
- KIA Smart Battery Tester Application Download And Initial Login (PS565 REV 4)
- No Crank/No Start & DTC Due To Aftermarket Accessories On Ignition Switch (PS718)
- AGM Battery Charging Procedure (SST066)
- KIA Smart Battery Tester V1.8 Replacement (SST061)
- Remote Start Valet Mode (PS586)
Steering Column
- Oily Substance Dripping From MDPS Column (PS343 REV 1)
Steering Control Systems
- Partial Repair Of C-MDPS Motor, Ecu, Worm Gear And/Or Steering Column Housing (CHA084 REV 7)
Suspension Control Systems
- TPMS Low Tire Pressure Indicator Lamp On (PS633)
System
- Special Service Information & Specifications For GDI High Pressure Fuel System (ENG083 REV 1)
Towing
- Recreational Towing Requirements (GEN018REV1)
Towing Systems
- Recreational Towing Requirements (GEN018REV1)
Transmission Control Systems
- IVT Software Logic Improvement And/Or IVT Replacement (TRA102 REV 1)
- 7-Speed Dual Clutch Transmission (DCT) Anti-Judder Logic Improvement (TRA098)
- 7-Speed DCT Judder Inspection And Dual Clutch Assembly Replacement (TRA083 REV 1)
Wheel Hubs
- Bearing Clearance Tester (BCT) Procedures (SST067 REV 2)
- Wheel Bearing Assembly Removal (PS650)
- Wheel Hub Bearing Noise Diagnosis (PS631)
Wheels & Tire System
- Bearing Clearance Tester (BCT) Procedures (SST067 REV 2)
- Tire Removal/Installation With TPMS Valve And Partial Part Replacement (PS072 REV 2)
- TPMS Low Tire Pressure Indicator Lamp On (PS633)
Window Motors & Regulators
- Sport Visor Installation (PS636)
- Service Action: Power Window Switch Assembly Replacement (SA354) (SA354)
Wiper/Washer Systems
- Windshield Wiper Blade Service Guide (23-BD-008H)
- Correct Procedure For Raising Windshield Wipers (PS299 REV 4)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Use Of Aftermarket USB Charging Cables In USB/12V Ports (PS443 REV 1)