Data List/Active Test
- DATA LIST
HINT:
While the intelligent tester is connected to the DLC3 with the ignition switch turned to the ON position, the ABS, TRAC and VSC data list can be displayed. Follow the prompts on the tester screen to access the "DATA LIST".
DATA LISTTester Display Measurement Item/Range Normal Condition Diagnostic Note HB MOT RELAY HB motor relay / ON or OFF ON: During pump motor operation
OFF: No pump motor operation- SOL RELAY Solenoid relay / ON or OFF ON: Solenoid relay ON
OFF: Solenoid relay OFF- IDLE SW Main idle switch / ON or OFF ON: Accelerator pedal released
OFF: Accelerator pedal depressed- STOP LIGHT SW Stop light switch / ON or OFF ON: Brake pedal depressed
OFF: Brake pedal released- PKB SW Parking brake switch / ON or OFF ON: Parking brake applied
OFF: Parking brake released- RESERVOIR SW Brake fluid level warning switch / ON or OFF ON: Switch ON
OFF: Switch OFF- AIR BLD SUPPORT Air bleed availability / SUPPORT or NOT SUP SUPPORT: Support ON
NOT SUP: Support OFF- ABS OPERT FR ABS operation (FR) / BEFORE or OPERATE BEFORE: No ABS operation (FR)
OPERATE: During ABS operation (FR)- ABS OPERT FL ABS operation (FL) / BEFORE or OPERATE BEFORE: No ABS operation (FL)
OPERATE: During ABS operation (FL)- ABS OPERT RR ABS operation (RR) / BEFORE or OPERATE BEFORE: No ABS operation (RR)
OPERATE: During ABS operation (RR)- ABS OPERT RL ABS operation (RL) / BEFORE or OPERATE BEFORE: No ABS operation (RL)
OPERATE: During ABS operation (RL)- WHEEL SPD FR FR wheel speed sensor reading / min.: 0 mph (0 km/h), max.: 202 mph (326 km/h) Actual wheel speed Similar speed as indicated on speedometer WHEEL SPD FL FL wheel speed sensor reading / min.: 0 mph (0 km/h), max.: 202 mph (326 km/h) Actual wheel speed Similar speed as indicated on speedometer WHEEL SPD RR RR wheel speed sensor reading / min.: 0 mph (0 km/h), max.: 202 mph (326 km/h) Actual wheel speed Similar speed as indicated on speedometer WHEEL SPD RL RL wheel speed sensor reading / min.: 0 mph (0 km/h), max.: 202 mph (326 km/h) Actual wheel speed Similar speed as indicated on speedometer DECELERAT SEN Acceleration sensor 1 reading / min.: -1.869 G, max.: 1.869 G Approximately 0 +- 0.13 G while stationary Reading changes when vehicle is bounced DECELERAT SEN2 Acceleration sensor 2 reading / min.: -1.869 G, max.: 1.869 G Approximately 0 +- 0.13 G while stationary Reading changes when vehicle is bounced IG VOLTAGE ECU IG power supply voltage / TOO LOW / NORMAL / TOO HIGH TOO LOW: 9.5 V or less
NORMAL: 9.5 V to 14.0 V
TOO HIGH: 14.0 V or more- SFRR ABS solenoid (SFRR) / ON or OFF ON: Operates - SFRH ABS solenoid (SFRH) / ON or OFF ON: Operates - SFLR ABS solenoid (SFLR) / ON or OFF ON: Operates - SFLH ABS solenoid (SFLH) / ON or OFF ON: Operates - SRRR (SRR) ABS solenoid (SRRR) / ON or OFF ON: Operates - SRRH (SRH) ABS solenoid (SRRH) / ON or OFF ON: Operates - SRLR ABS solenoid (SRLR) / ON or OFF ON: Operates - SRLH ABS solenoid (SRLH) / ON or OFF ON: Operates - SRCF (SA1) TRAC solenoid (SMCF) / ON or OFF - - SRCR (SA2) TRAC solenoid (SREA) / ON or OFF - - SRMF (SMCF, SA3) TRAC solenoid (SREC) / ON or OFF - - SRMR (SMCR, STR) TRAC solenoid (STR) / ON or OFF - - ENGINE SPD Engine speed / min.: 0 rpm, max.: 6000 rpm Actual engine speed - VEHICLE SPD Vehicle speed reading / min.: 0 mph (0 km/h), max.: 202 mph (326 km/h) Actual vehicle speed - YAW RATE Yaw rate sensor / min.: -128 deg/s, max.: 127 deg/s min.:-128 deg/s
max.: 127 deg/s- YAW ZERO VALUE Memorized zero value / min.: -128 deg/s, max.: 127 deg/s min.: -128 deg/s
max.: 127 deg/s- STEERING ANG Steering angle sensor / min.: -1152 deg/s, max.: 1150.875 deg/s Left turn: Increase
Right turn: Decrease- MAS CYL PRS 1 Master cylinder pressure sensor 1 reading / min.: 0 V, max.: 5 V When brake pedal is released: 0.3 to 0.9 V Reading increases when brake pedal is depressed ACC PRESS SENS Accumulator pressure sensor / min.: 0 V, max.: 5 V 3.58 to 5 V If the value is constant regardless of pump operation, accumulator pressure sensor malfunction is suspected. WHEEL DIR FR FR wheel direction / FORWARD or BACK BACK: Back, FORWARD: Forward - WHEEL DIR FL FL wheel direction / FORWARD or BACK BACK: Back, FORWARD: Forward - WHEEL DIR RR RR wheel direction / FORWARD or BACK BACK: Back, FORWARD: Forward - WHEEL DIR RL RL wheel direction / FORWARD or BACK BACK: Back, FORWARD: Forward - SPD SEN FR FR speed sensor open detection / OPN DET or NORMAL OPN DET: Momentary interruption
NORMAL: Normal- SPD SEN FL FL speed sensor open detection / OPN DET or NORMAL OPN DET: Momentary interruption
NORMAL: Normal- SPD SEN RR RR speed sensor open detection / OPN DET or NORMAL OPN DET: Momentary interruption
NORMAL: Normal- SPD SEN RL RL speed sensor open detection / OPN DET or NORMAL OPN DET: Momentary interruption
NORMAL: Normal- ACCELERATOR % The difference of a present accelerator/ min.: 0 %, max.: 128 % - - TORQUE Real output torque / min.: -1024 Nm, max.: 1016 Nm - - TEST MODE Test mode operation / NORMAL or TEST NORMAL: Normal mode
TEST: During test mode- #CODES Number of DTC recorded / min.: 0, max.: 255 - - THROTTLE Throttle position sensor / min.: 0, max.: 125 - - PRESS LOW Low hydraulic brake booster pressure switch / ON, OFF ON: Low pressure
OFF: Normal- PRESS HIGH High hydraulic brake booster pressure switch / ON, OFF ON: High pressure
OFF: Normal- VSC/TRC OFF SW VSC / TRAC OFF switch / ON or OFF ON: Switch ON
OFF: Switch OFF- - ACTIVE TEST
HINT:
Performing the ACTIVE TEST using the intelligent tester allows the relay, actuator, etc. to operate without removing any parts. Performing the ACTIVE TEST as the first step of troubleshooting is one of the methods to shorten labor time.
It is possible to display the DATA LIST during the ACTIVE TEST.
- Connect the intelligent tester to the DLC3.
- Turn the ignition switch to the ON position.
- According to the display on the tester, perform the "ACTIVE TEST".
HINT:
The ignition switch must be turned to the ON position to proceed to the ACTIVE TEST using the intelligent tester.
DATA LISTTester Display Test Part Control Range Diagnostic Note SFRR Turns ABS solenoid (SFRR) Solenoid ON / OFF Operation sound of solenoid (clicking sound) can be heard SFRH Turns ABS solenoid (SFRH) Solenoid ON / OFF Operation sound of solenoid (clicking sound) can be heard SFLR Turns ABS solenoid (SFLR) Solenoid ON / OFF Operation sound of solenoid (clicking sound) can be heard SFLH Turns ABS solenoid (SFLH) Solenoid ON / OFF Operation sound of solenoid (clicking sound) can be heard SRRR Turns ABS solenoid (SRRR) Solenoid ON / OFF Operation sound of solenoid (clicking sound) can be heard SRRH Turns ABS solenoid (SRRH) Solenoid ON / OFF Operation sound of solenoid (clicking sound) can be heard SRLR Turns ABS solenoid (SRLR) Solenoid ON / OFF Operation sound of solenoid (clicking sound) can be heard SRLH Turns ABS solenoid (SRLH) Solenoid ON / OFF Operation sound of solenoid (clicking sound) can be heard SRCF(SA1) Turns TRAC solenoid (SRCF (SA1)) Solenoid ON / OFF Operation sound of solenoid (clicking sound) can be heard SRCR (SA2) Turns TRAC solenoid (SRCR (SA2)) Solenoid ON / OFF Operation sound of solenoid (clicking sound) can be heard SRMF (SMCF, SA3) Turns TRAC solenoid (SRMF (SMCF, SA3)) Solenoid ON / OFF Operation sound of solenoid (clicking sound) can be heard SRMR (SMCR, STR) Turns TRAC solenoid (SRMR (SMCR, STR)) Solenoid ON / OFF Operation sound of solenoid (clicking sound) can be heard SFRR & SFRH Turns ABS solenoid (SFRR and SFRH) Solenoid ON / OFF Operation sound of solenoid (clicking sound) can be heard SFLR & SFLH Turns ABS solenoid (SFLR and SFLH) Solenoid ON / OFF Operation sound of solenoid (clicking sound) can be heard SRH & SRR Turns ABS solenoid (SRH and SRR) Solenoid ON / OFF Operation sound of solenoid (clicking sound) can be heard SRLR & SRLH Turns ABS solenoid (SRLR and SRLH) Solenoid ON / OFF Operation sound of solenoid (clicking sound) can be heard SFRH & SFLH Turns ABS solenoid (SFRH and SFLH) Solenoid ON / OFF Operation sound of solenoid (clicking sound) can be heard SRCF 8; SRCR Turns TRAC solenoid (SRCF and SRCR) Solenoid ON / OFF Operation sound of solenoid (clicking sound) can be heard SRMF & SRMR Turns TRAC solenoid (SRMF and SRMR) Solenoid ON / OFF Operation sound of solenoid (clicking sound) can be heard ABS WARN LIGHT Turns ABS warning light Warning light ON / OFF Observe combination meter VSC WARN LIGHT Turns VSC TRAC warning light Warning light ON / OFF Observe combination meter VSC / TRC OFF IND Turns VSC OFF indicator light Indicator light ON / OFF Observe combination meter SLIP INDI LIGHT Turns SLIP indicator light Indicator light ON / OFF Observe combination meter BRAKE WRN LIGHT Turns BRAKE warning light Warning light ON / OFF Observe combination meter VSC / BR WARN BUZ Turns skid control buzzer Buzzer ON / OFF Buzzer can be heard H/B MOT RELAY Turns H/B motor relay Relay ON / OFF Operation sound of motor can be heard STP LIGHT RELAY Turns stop light operation relay Relay ON / OFF Observe rear combination light (Does not come on for 5 sec. or more) TRAC MOT RELAY Turns TRAC motor relay Relay ON / OFF Operation sound of motor can be heard SOL RELAY Turns SOL relay Relay ON / OFF Operation sound of motor can be heard