Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups
Common Specs & Procedures
DTC Index- A/C-Heater Systems (Automatic) DTCS
- Anti-Lock Brakes DTCS
- Anti-Theft Systems DTCS (Passive)
- AUTOLAMP Systems DTCS
- Automatic Transmission Electronic Controls Diagnosis DTCS
- Electric Cooling Fans DTCS
- Instrument Panels - Analog
- Power Door Locks DTC
- Power Mirrors DTCS
- Power Seats DTCS
- Power Windows DTCS
- Remote Keyless Entry Systems DTCS
- Self-Diagnostics DTCS
- Steering Column Switches DTCS
Electrical Component Locations
Fluids
Technical Bulletins
Tire Fitment
Wiring Diagrams- System Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Electronic Power Steering
- Electronic Suspension
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Memory Systems
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Top/Sunroof
- Power Windows
- Radio
- Shift Interlocks
- Starting/Charging
- Supplemental Restraints
- Transmission
- Trunk, Tailgate, Fuel Door
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- System Wiring Diagrams
- Accessories & Equipment
- Anti-Theft Systems
- Anti-Theft Systems - Active
- Description
- Operation
- Self-Diagnostic System
- System Tests
- Notes
- Test A: No Communication With SCIL Module
- Test B: Anti-Theft Indicator Light Is Always On
- Test C: Anti-Theft Indicator Light Will Not Come On
- Test D: Alarm System Will Not Arm Or Disarm Using Remote Keyless Entry Transmitter Or Keyless Entry Keypad
- Test E: Alarm System Will Not Arm Using Door Lock Switch
- Test F: Alarm System Will Not Disarm Using Door Lock Switch
- Test G: Alarm System Does Not Operate Properly
- Removal & Installation
- Wiring Diagrams
- Anti-Theft Systems - Passive
- Description
- Operation
- Programming
- Self-Diagnostic System
- DTC Tests
- Notes
- DTC C1446: Brake Switch Circuit Failure
- DTC B1246: Panel Dim Potentiometer Switch Circuit Failure
- DTC B1312: Headlight Input Circuit Short To Battery
- DTC B1334: Luggage Compartment Door Ajar Circuit Short To Ground
- DTC B1342: Ecu Defective
- DTC B1353: Ignition Key-In Circuit Open
- DTC B1360: Ignition Run/Acc Circuit Open
- DTC B1364: Ignition Start Circuit Open
- DTC B1446: Wiper Park Sensor Circuit Failure
- DTC B1485: Brake Pedal Input Short To Battery
- DTC B1490: Door Handle Right Front Short To Ground
- DTC B1498: Luggage Compartment Door Punch Out Sensor Shorted To Ground
- DTC B1509: Flash-To-Pass Switch Circuit Short To Battery
- DTC B1522: Hood Switch Circuit Short To Ground
- DTC B1562: Door Lock Cylinder Circuit Short To Ground
- DTC B1566: Door Ajar Circuit Short To Ground
- DTC B1600: Pats Ignition Key Transponder Signal Not Received
- DTC B1601: Pats Received Incorrect Ignition Key Code From Ignition Key Transponder
- DTC B1676: Battery Voltage Out Of Range
- DTC B1682: Pats Is Disabled
- DTC B1687: Dome Light Input Circuit Short To Battery
- DTC B1689: AUTOLAMP Delay Circuit Failure
- DTC B1796: Headlight Low Beam Circuit Short To Battery
- DTC B1875: Turn Signal/Hazard Switch Signal Circuit Failure
- DTC B1980: Bulb Outage Condition Detected
- DTC B2328: Steering Column Reach Feedback Potentiometer Circuit Failure
- DTC B2332: Steering Column Tilt Feedback Potentiometer Circuit Failure
- DTC B2351: Steering Column Switch Signal Circuit Failure
- DTC U1027: SCP Invalid Or Missing Data For Engine Rpm
- DTC U1041: SCP Invalid Or Missing Data For Vehicle Speed
- DTC U1057: SCP Invalid Or Missing Data For Vehicle Configuration
- DTC U1059: SCP Invalid Or Missing Data For Transmission PRNDL
- DTC U1123: SCP Invalid Or Missing Data For Odometer
- DTC U1147: SCP Invalid Or Missing Data For Vehicle Security
- DTC U1180 & DTC U1181: SCP Invalid Or Missing Data For Memory Features
- DTC U1197: SCP Invalid Or Missing Data For Door Locks
- DTC U1198: SCP Invalid Or Missing Data For External Access Doors
- DTC U1199: SCP Invalid Or Missing Data For External Access Doors
- DTC U1211: SCP Invalid Or Missing Data For Restraints
- DTC U1222: SCP Invalid Or Missing Data For Interior Lights
- System Testing
- Removal & Installation
- Wiring Diagrams
- Keyless Entry System - Remote
- Description
- Operation
- Programming
- Trouble Shooting
- Component Testing
- System Testing
- Diagnostic Trouble Code Testing
- Diagnostic Testing
- Notes
- Test A: No Communication With Driver's Door Module
- Test B: No Communication With Steering Column/Ignition/
- Test C: Doors Do Not Lock/Unlock Using Keypad
- Test D: Locks Do Not Operate From Remote Transmitter
- Test E: AUTOLOCK Does Not Operate Properly
- Test F: Smart Lock Feature Does Not Operate Properly
- Test G: Panic Alarm Does Not Operate From Remote Transmitter
- Test H: Illuminated Entry Does Not Operate Using Keypad
- Test J: Illuminated Entry Does Not Operate Using Remote
- Removal & Installation
- Wiring Diagrams
- Passive Anti-Theft System Job Aid
- Power Door Locks & Trunk Release
- Description & Operation
- Trouble Shooting
- Component Tests
- System Tests
- Diagnostic Tests
- Symptom Tests
- Notes
- Test A: No Communication With Driver's Door Module
- Test B: No Communication With Steering Column/Ignition/Lighting Module
- Test C: All Door Locks Inoperative
- Test D: Driver's Door Lock Inoperative
- Test E: Passenger's Door Lock Inoperative
- TEST F: All DOOR LOCKS OPERATE FROM ONE SWITCH ONLY
- Test G: Trunk Lid Does Not Lock
- Test H: Trunk Lid Does Not Unlock
- Test J: Trunk Lid Opens With Vehicle In Motion
- Test K: Fuel Filler Door Remote Release Inoperative
- Removal & Installation
- Wiring Diagrams
- Anti-Theft Systems - Active
- Communication Devices
- Module Communications Network
- Description & Operation
- Repairing Bus Wiring
- Communication Network Diagnostics
- Testing
- Notes
- Test A: Anti-Lock Brake System (Abs) Module Does Not Respond To NGS Tester
- Test B: Cellular Phone Module (CPM) Does Not Respond To NGS Tester
- Test C: Driver's Door Module (DDM) Does Not Respond To NGS Tester
- Test D: Driver's Seat Module (DSM) Does Not Respond To NGS Tester
- Test E: Electronic Automatic Temperature Control (EATC) Module Does Not Respond To NGS Tester
- Test F: Hybrid Electronic Cluster (HEC) Does Not Respond To NGS Tester
- Test G: Message Center Module (MCM) Does Not Respond To NGS Tester
- Test H: Passenger's Seat Module (PSM) Does Not Respond To NGS Tester
- Test J: Powertrain Control Module (Pcm) Does Not Respond To NGS Tester
- Test K: Steering Column/Ignition/Lighting Control (SCIL) Module Does Not Respond To NGS Tester
- Test L: Variable Load Control Module (VLCM) Does Not Respond To NGS Tester
- Test M: No Module/Network Communication - Bus Link
- Test N: No Module/Network Communication
- Wiring Diagrams
- Module Communications Network
- Cruise Control Systems
- Description & Operation
- Adjustments
- Trouble Shooting
- Self-Diagnostic System
- System Testing
- Notes
- Test A: Flash Code 1 - No Dynamic Pull At Speed Control Servo/Actuator
- Test B: Flash Code 1 - Speed Control Is Inoperative
- Test C: Flash Code 2 - Brake Pedal Position (BPP) Switch Circuit Failure
- Test D: Flash Code 3 - DEACTIVATOR Switch Circuit Failure
- Test E: Flash Code 4 - Vehicle Speed Sensor (VSS) Circuit Failure
- Test F: Speed Control Inoperative - No Flash Codes
- Test G: Coast Switch Is Inoperative
- Test H: Set/ACCEL Switch Is Inoperative
- Test J: Resume Switch Is Inoperative
- Test K: Speed Control Indicator Does Not Turn Off
- Test M: Set Speed Fluctuates
- Removal & Installation
- Wiring Diagrams
- Exterior Lights
- AUTOLAMP Systems
- Description
- System Operation
- Adjustments
- Trouble Shooting
- Self-Diagnostics
- Symptom Tests
- Diagnostic Trouble Code Tests
- Test A: Ecu Defective
- Test B: Wiper Park Sensor Circuit Failure
- Test C: Flash-To-Pass Switch Circuit Short To Battery
- Test D: Battery Voltage Out Of Range
- Test E: AUTOLAMP Delay Circuit Failure
- Test F: Bulb Outage Condition Detected
- Test G: Headlight Input Circuit Short To Battery
- Test H: No Communication With Steering Column/Ignition/Lighting (SCIL) Module
- Test I: Stoplights Inoperative
- Test J: Turn Signal Lights/Hazard Flasher Lights Inoperative
- Removal & Installation
- Wiring Diagrams
- AUTOLAMP Systems
- Gauges & Instrument Panels
- Instrument Panels - Analog
- Description & Operation
- Self-Diagnostic System
- Diagnostic Testing
- Symptom Testing
- No Communication With Hybrid Electronic Instrument Cluster (HEIC)
- No Communication With Steering Column/Ignition/Lighting (SCIL) Control Module
- Fuel Level Reads Inaccurately
- Engine Coolant Temperature Reads Inaccurately
- Low Oil Pressure Warning Never/Always On
- Speedometer Reads Inaccurately
- Cruise Control Indicator Never/Always On
- Tachometer Not Reflecting Correct Engine Speed
- Brake Warning Never/Always On
- Charge System Warning Never/Always On
- Transmission Range Indicator Never/Always On
- Left Turn Indicator Inoperative
- Right Turn Indicator Inoperative
- High Beam Indicator Inoperative
- High Beam Indicator Always On
- Removal & Installation
- Wiring Diagrams
- Instrument Panels - Analog
- Heated Glass/Defoggers
- Power Memory Mirrors
- Connector Identification
- System Testing
- DTC Tests
- DTC B1342: Ecu Defective
- DTC B1529: Memory Set Switch Circuit Short To Battery
- DTC B1539: Mirror Driver's Switch Assembly Circuit Failure
- DTC B2312: Passenger Mirror Horizontal Feedback Potentiometer Circuit Failure
- DTC B2316: Passenger Mirror Vertical Feedback Potentiometer Circuit Failure
- DTC B2320: Driver's Mirror Horizontal Feedback Potentiometer Circuit Failure
- DTC B2324: Driver's Mirror Vertical Feedback Potentiometer Circuit Failure
- DTC U1181: SCP Invalid Or Missing Data For Personalization Features
- Diagnostic Tests
- Test A: Mirror/Seat Potentiometer Circuit Failure
- Test B: Mirror Potentiometer Circuit Failure (DTC B2312, B2316, B2320 & B2324)
- Test C: SCP Invalid Or Missing Data From DDM (U1180 & U1194)
- Test D: No Communication With Driver's Door Module (DDM)
- Test E: No Communication With Driver's Seat Module (DSM)
- Test F: Both Mirrors Inoperative
- Test G: Passenger Mirror Inoperative
- Test H: Driver's Mirror Inoperative
- Test J: Driver's Mirror Vertical Control Inoperative
- Test K: Driver's Mirror Horizontal Control Inoperative
- Test L: Passenger Mirror Vertical Control Inoperative
- Test M: Passenger Mirror Horizontal Control Inoperative
- Test N: Automatic Dimming Function Inoperative
- Test P: Heated Mirrors Inoperative
- Test Q: Memory Mirrors Inoperative
- Description
- Operation
- Trouble Shooting
- Component Tests
- Removal & Installation
- Wiring Diagrams
- Power Seats
- Connector Identification
- System Testing
- Diagnostic Testing
- DTC B1248: Passenger Seat Auto-Glide Rearward Switch Open
- DTC B1342 (DSM): Ecu Defective (Driver Seat Module)
- DTC B1342 (PSM): Ecu Defective (Passenger Seat Module)
- DTC B1360: Ignition Switch Run/Acc Circuit Open
- DTC B1565: Door Ajar Signal Short To Voltage
- DTC B1676: Battery Voltage Out Of Range
- DTC B1950: Driver Seat Rear Up/Down Feedback Circuit
- DTC B1954: Driver Seat Front Up/Down Feedback Circuit
- DTC B1958: Driver Seat Recline Fwd/BWD Feedback Circuit
- DTC B1962 (DSM): Driver Seat Horizontal Fwd/BWD Feedback
- DTC B1962 (PSM): Passenger Seat Horizontal Fwd/BWD Feedback
- DTC B1986: Driver Seat Auto-Glide Rearward Switch Circuit
- Symptom Testing
- Notes
- Test A: Seat Back Auto-Glide Forward Switch Circuit Short
- Test B: Seat Recline Forward/Rearward Circuit Short To
- Test C: Seat Front Up/Down Circuit Short To Voltage
- Test D: Seat Forward/Rearward Circuit Short To Voltage
- Test E: Seat Rear Up/Down Circuit Short To Voltage
- Test F: Driver Seat Potentiometer Feed Or Return Circuit
- Test G: No Communication With Driver Seat Module
- Test H: No Communication With Passenger Seat Module
- Test J: No Communication With SCIL Module
- Test K: Driver Seat Completely Inoperative
- Test L: Passenger Seat Completely Inoperative
- Test M: Driver Seat Horizontal Adjustment Inoperative
- Test N: Passenger Seat Horizontal Adjustment Inoperative
- Test P: Driver Seat Vertical Adjustment Inoperative
- Test Q: Passenger Seat Vertical Adjustment Inoperative
- Test R: Driver Seat Recline Adjustment Inoperative
- Test S: Passenger Seat Recline Adjustment Inoperative
- Test T: Memory Seat Does Not Work Properly
- Test U: Easy Entry/Exit Does Not Work Properly
- Test V: Driver Seat AUTOGLIDE Does Not Work Properly
- Test W: Passenger Seat AUTOGLIDE Does Not Work Properly
- Test X: Heated Seat Inoperative
- Test Y: Both Heated Seats Inoperative
- Test Z: Heated Seat Cushion Inoperative
- Test Aa: Lumbar Seat Inoperative
- Test Ab: Wiper Park Sensor Circuit Failure
- Test Ac: Battery Voltage Out Of Range For SCIL Module
- Description & Operation
- Component Locations
- Trouble Shooting
- Removal & Installation
- Wiring Diagrams
- Steering Column Switches
- Description
- Trouble Shooting
- Component Testing
- System Testing
- Diagnostic Trouble Code Testing
- DTC B1446: Wiper Park Sensor Circuit Failure
- DTC B1509: Flash-To-Pass Switch Circuit Short To Battery
- DTC B1875: Turn Signal/Hazard Switch Signal Circuit Failure
- DTC B2328: Steering Column Reach Feedback Potentiometer
- DTC B2332: Steering Column Tilt Feedback Potentiometer
- DTC B2351: Steering Column Switch Signal Circuit Failure
- Diagnostic Testing
- Test A: Ignition Switch Power Supply Failure
- Test B: No Communication With SCIL Module
- Test C: Ignition Key-In Circuit Open
- Test D: Ignition Run/Acc Circuit Open
- Test E: Ignition Start Circuit Open
- Test F: Turn Signal Lights/Hazard Flasher Lights Inoperative
- Test G: Flash-To-Pass Feature Inoperative
- Test H: Steering Column Potentiometer Circuit Failure
- Test J: Steering Column Tilt Adjustment Inoperative
- Test K: Steering Column Telescope Adjustment Inoperative
- Test L: Steering Column Tilt And Telescope Adjustments
- Removal & Installation
- Torque Specifications
- Wiring Diagrams
- Window Motors & Regulators
- Power Windows
- Description & Operation
- Trouble Shooting
- Component Testing
- Self-Diagnostic System
- Diagnostic Testing
- System Testing
- Test A: No Communication With DDM
- Test B: No Communication With SCIL Module
- Test C: All Power Windows Are Inoperative
- Test D: Single Power Window Is Inoperative
- Test E: One-Touch Down Feature Is Inoperative
- Test F: Power Window Switch Does Not Illuminate
- Test G: Delayed Accessory Will Not Turn Off
- Test H: Delayed Accessory Feature Does Not Operate Properly
- Test J: Window Is Stuck Or Binding
- Removal & Installation
- Wiring Diagrams
- Power Windows
- Wiper/Washer Systems
- Description & Operation
- Adjustments
- Trouble Shooting
- Component Testing
- Symptom Testing
- Notes
- Test A: Washer Pump Inoperative
- Test B: Wipers Inoperative
- Test C: Low Speed Wipers Inoperative
- Test D: High Speed Wipers Inoperative
- Test E: Intermittent Wipers Inoperative
- Test F: Wipers Do Not Park Properly
- Test G: Wipers Run Continuously
- Test H: Wipers Inoperative In Mist Position
- Test J: Headlights Inoperative When Wipers Are On
- Removal & Installation
- Wiring Diagrams
- Anti-Theft Systems
- Body & Frame
- Door Locks
- Anti-Theft Systems - Active
- Description
- Operation
- Self-Diagnostic System
- System Tests
- Notes
- Test A: No Communication With SCIL Module
- Test B: Anti-Theft Indicator Light Is Always On
- Test C: Anti-Theft Indicator Light Will Not Come On
- Test D: Alarm System Will Not Arm Or Disarm Using Remote Keyless Entry Transmitter Or Keyless Entry Keypad
- Test E: Alarm System Will Not Arm Using Door Lock Switch
- Test F: Alarm System Will Not Disarm Using Door Lock Switch
- Test G: Alarm System Does Not Operate Properly
- Removal & Installation
- Wiring Diagrams
- Anti-Theft Systems - Passive
- Description
- Operation
- Programming
- Self-Diagnostic System
- DTC Tests
- Notes
- DTC C1446: Brake Switch Circuit Failure
- DTC B1246: Panel Dim Potentiometer Switch Circuit Failure
- DTC B1312: Headlight Input Circuit Short To Battery
- DTC B1334: Luggage Compartment Door Ajar Circuit Short To Ground
- DTC B1342: Ecu Defective
- DTC B1353: Ignition Key-In Circuit Open
- DTC B1360: Ignition Run/Acc Circuit Open
- DTC B1364: Ignition Start Circuit Open
- DTC B1446: Wiper Park Sensor Circuit Failure
- DTC B1485: Brake Pedal Input Short To Battery
- DTC B1490: Door Handle Right Front Short To Ground
- DTC B1498: Luggage Compartment Door Punch Out Sensor Shorted To Ground
- DTC B1509: Flash-To-Pass Switch Circuit Short To Battery
- DTC B1522: Hood Switch Circuit Short To Ground
- DTC B1562: Door Lock Cylinder Circuit Short To Ground
- DTC B1566: Door Ajar Circuit Short To Ground
- DTC B1600: Pats Ignition Key Transponder Signal Not Received
- DTC B1601: Pats Received Incorrect Ignition Key Code From Ignition Key Transponder
- DTC B1676: Battery Voltage Out Of Range
- DTC B1682: Pats Is Disabled
- DTC B1687: Dome Light Input Circuit Short To Battery
- DTC B1689: AUTOLAMP Delay Circuit Failure
- DTC B1796: Headlight Low Beam Circuit Short To Battery
- DTC B1875: Turn Signal/Hazard Switch Signal Circuit Failure
- DTC B1980: Bulb Outage Condition Detected
- DTC B2328: Steering Column Reach Feedback Potentiometer Circuit Failure
- DTC B2332: Steering Column Tilt Feedback Potentiometer Circuit Failure
- DTC B2351: Steering Column Switch Signal Circuit Failure
- DTC U1027: SCP Invalid Or Missing Data For Engine Rpm
- DTC U1041: SCP Invalid Or Missing Data For Vehicle Speed
- DTC U1057: SCP Invalid Or Missing Data For Vehicle Configuration
- DTC U1059: SCP Invalid Or Missing Data For Transmission PRNDL
- DTC U1123: SCP Invalid Or Missing Data For Odometer
- DTC U1147: SCP Invalid Or Missing Data For Vehicle Security
- DTC U1180 & DTC U1181: SCP Invalid Or Missing Data For Memory Features
- DTC U1197: SCP Invalid Or Missing Data For Door Locks
- DTC U1198: SCP Invalid Or Missing Data For External Access Doors
- DTC U1199: SCP Invalid Or Missing Data For External Access Doors
- DTC U1211: SCP Invalid Or Missing Data For Restraints
- DTC U1222: SCP Invalid Or Missing Data For Interior Lights
- System Testing
- Removal & Installation
- Wiring Diagrams
- Keyless Entry System - Remote
- Description
- Operation
- Programming
- Trouble Shooting
- Component Testing
- System Testing
- Diagnostic Trouble Code Testing
- Diagnostic Testing
- Notes
- Test A: No Communication With Driver's Door Module
- Test B: No Communication With Steering Column/Ignition/
- Test C: Doors Do Not Lock/Unlock Using Keypad
- Test D: Locks Do Not Operate From Remote Transmitter
- Test E: AUTOLOCK Does Not Operate Properly
- Test F: Smart Lock Feature Does Not Operate Properly
- Test G: Panic Alarm Does Not Operate From Remote Transmitter
- Test H: Illuminated Entry Does Not Operate Using Keypad
- Test J: Illuminated Entry Does Not Operate Using Remote
- Removal & Installation
- Wiring Diagrams
- Passive Anti-Theft System Job Aid
- Power Door Locks & Trunk Release
- Description & Operation
- Trouble Shooting
- Component Tests
- System Tests
- Diagnostic Tests
- Symptom Tests
- Notes
- Test A: No Communication With Driver's Door Module
- Test B: No Communication With Steering Column/Ignition/Lighting Module
- Test C: All Door Locks Inoperative
- Test D: Driver's Door Lock Inoperative
- Test E: Passenger's Door Lock Inoperative
- TEST F: All DOOR LOCKS OPERATE FROM ONE SWITCH ONLY
- Test G: Trunk Lid Does Not Lock
- Test H: Trunk Lid Does Not Unlock
- Test J: Trunk Lid Opens With Vehicle In Motion
- Test K: Fuel Filler Door Remote Release Inoperative
- Removal & Installation
- Wiring Diagrams
- Anti-Theft Systems - Active
- Power Memory Mirrors
- Connector Identification
- System Testing
- DTC Tests
- DTC B1342: Ecu Defective
- DTC B1529: Memory Set Switch Circuit Short To Battery
- DTC B1539: Mirror Driver's Switch Assembly Circuit Failure
- DTC B2312: Passenger Mirror Horizontal Feedback Potentiometer Circuit Failure
- DTC B2316: Passenger Mirror Vertical Feedback Potentiometer Circuit Failure
- DTC B2320: Driver's Mirror Horizontal Feedback Potentiometer Circuit Failure
- DTC B2324: Driver's Mirror Vertical Feedback Potentiometer Circuit Failure
- DTC U1181: SCP Invalid Or Missing Data For Personalization Features
- Diagnostic Tests
- Test A: Mirror/Seat Potentiometer Circuit Failure
- Test B: Mirror Potentiometer Circuit Failure (DTC B2312, B2316, B2320 & B2324)
- Test C: SCP Invalid Or Missing Data From DDM (U1180 & U1194)
- Test D: No Communication With Driver's Door Module (DDM)
- Test E: No Communication With Driver's Seat Module (DSM)
- Test F: Both Mirrors Inoperative
- Test G: Passenger Mirror Inoperative
- Test H: Driver's Mirror Inoperative
- Test J: Driver's Mirror Vertical Control Inoperative
- Test K: Driver's Mirror Horizontal Control Inoperative
- Test L: Passenger Mirror Vertical Control Inoperative
- Test M: Passenger Mirror Horizontal Control Inoperative
- Test N: Automatic Dimming Function Inoperative
- Test P: Heated Mirrors Inoperative
- Test Q: Memory Mirrors Inoperative
- Description
- Operation
- Trouble Shooting
- Component Tests
- Removal & Installation
- Wiring Diagrams
- Power Seats
- Connector Identification
- System Testing
- Diagnostic Testing
- DTC B1248: Passenger Seat Auto-Glide Rearward Switch Open
- DTC B1342 (DSM): Ecu Defective (Driver Seat Module)
- DTC B1342 (PSM): Ecu Defective (Passenger Seat Module)
- DTC B1360: Ignition Switch Run/Acc Circuit Open
- DTC B1565: Door Ajar Signal Short To Voltage
- DTC B1676: Battery Voltage Out Of Range
- DTC B1950: Driver Seat Rear Up/Down Feedback Circuit
- DTC B1954: Driver Seat Front Up/Down Feedback Circuit
- DTC B1958: Driver Seat Recline Fwd/BWD Feedback Circuit
- DTC B1962 (DSM): Driver Seat Horizontal Fwd/BWD Feedback
- DTC B1962 (PSM): Passenger Seat Horizontal Fwd/BWD Feedback
- DTC B1986: Driver Seat Auto-Glide Rearward Switch Circuit
- Symptom Testing
- Notes
- Test A: Seat Back Auto-Glide Forward Switch Circuit Short
- Test B: Seat Recline Forward/Rearward Circuit Short To
- Test C: Seat Front Up/Down Circuit Short To Voltage
- Test D: Seat Forward/Rearward Circuit Short To Voltage
- Test E: Seat Rear Up/Down Circuit Short To Voltage
- Test F: Driver Seat Potentiometer Feed Or Return Circuit
- Test G: No Communication With Driver Seat Module
- Test H: No Communication With Passenger Seat Module
- Test J: No Communication With SCIL Module
- Test K: Driver Seat Completely Inoperative
- Test L: Passenger Seat Completely Inoperative
- Test M: Driver Seat Horizontal Adjustment Inoperative
- Test N: Passenger Seat Horizontal Adjustment Inoperative
- Test P: Driver Seat Vertical Adjustment Inoperative
- Test Q: Passenger Seat Vertical Adjustment Inoperative
- Test R: Driver Seat Recline Adjustment Inoperative
- Test S: Passenger Seat Recline Adjustment Inoperative
- Test T: Memory Seat Does Not Work Properly
- Test U: Easy Entry/Exit Does Not Work Properly
- Test V: Driver Seat AUTOGLIDE Does Not Work Properly
- Test W: Passenger Seat AUTOGLIDE Does Not Work Properly
- Test X: Heated Seat Inoperative
- Test Y: Both Heated Seats Inoperative
- Test Z: Heated Seat Cushion Inoperative
- Test Aa: Lumbar Seat Inoperative
- Test Ab: Wiper Park Sensor Circuit Failure
- Test Ac: Battery Voltage Out Of Range For SCIL Module
- Description & Operation
- Component Locations
- Trouble Shooting
- Removal & Installation
- Wiring Diagrams
- Sun Roof/T-Top/Convertible Top
- Power Moon Roofs
- Description
- Operation
- Adjustments
- Trouble Shooting
- Component Testing
- System Testing
- Diagnostic Tests
- Test A: Excessive Wind Noise
- Test B: Moon Roof Leaks
- Test C: Moon Roof Noisy During Operation
- Test D: Moon Roof Inoperative
- Test E: No Operation In Vent Position
- Test F: Moon Roof Does Not Stop Flush In Any Position
- Test G: Express Open Feature Inoperative
- Test H: Moon Roof Will Not Slide Closed Or Pop Up
- Test J: Moon Roof Will Not Slide Open Or Closed From Vent Position
- Removal & Installation
- Wiring Diagrams
- Power Moon Roofs
- Power Windows
- Description & Operation
- Trouble Shooting
- Component Testing
- Self-Diagnostic System
- Diagnostic Testing
- System Testing
- Test A: No Communication With DDM
- Test B: No Communication With SCIL Module
- Test C: All Power Windows Are Inoperative
- Test D: Single Power Window Is Inoperative
- Test E: One-Touch Down Feature Is Inoperative
- Test F: Power Window Switch Does Not Illuminate
- Test G: Delayed Accessory Will Not Turn Off
- Test H: Delayed Accessory Feature Does Not Operate Properly
- Test J: Window Is Stuck Or Binding
- Removal & Installation
- Wiring Diagrams
- Door Locks
- Brakes
- Anti-Lock Brakes
- Anti-Lock Brake System
- Description
- Operation
- Component Locations
- Bleeding Brake System
- Diagnosis & Testing
- Diagnostic Tests
- DTC C1095: Abs Hydraulic Pump Motor Failure
- DTC C1145: Right Front Wheel Speed Sensor Input Circuit Failure
- DTC C1155: Left Front Wheel Speed Sensor Input Circuit Failure
- DTC C1165: Right Rear Wheel Speed Sensor Input Circuit Failure
- DTC C1175: Left Rear Wheel Speed Sensor Input Circuit Failure
- DTC C1233: Left Front, C1234: Right Front, C1235: Right Rear Or C1236: Left Rear Wheel Speed Sensor Input Missing
- DTC B1485: Brake Pedal Input Circuit Short To Battery
- DTC B1676: Battery Voltage Out Of Range
- Symptom Tests
- Test A: No Communication With Abs Control Module
- Test B: No Communication With Hybrid Electronic Instrument Cluster (HEIC)
- Test C: Spongy Brake Pedal With No Warning Light Operation
- Test D: Poor Vehicle Tracking During Abs Function
- Test E: Traction Control Inoperative (Warning Indicator Normal)
- Test F: Abs Indicator Does Not Self-Check
- Test G: Abs Warning Light & Traction Control Indicator Always On
- Test H: Traction Control Cannot Be Disabled
- Removal & Installation
- Torque Specifications
- Wiring Diagrams
- Anti-Lock Brake System
- Mechanical - Hydraulic
- Disc Brakes & Drum Brakes
- Description & Operation
- Bleeding Brake System
- Adjustments
- Removal & Installation
- Overhaul
- Disc Brake Specifications
- Drum Brake Specifications
- Torque Specifications
- Disc Brakes & Drum Brakes
- Traction Control
- Anti-Lock Brake System
- Description
- Operation
- Component Locations
- Bleeding Brake System
- Diagnosis & Testing
- Diagnostic Tests
- DTC C1095: Abs Hydraulic Pump Motor Failure
- DTC C1145: Right Front Wheel Speed Sensor Input Circuit Failure
- DTC C1155: Left Front Wheel Speed Sensor Input Circuit Failure
- DTC C1165: Right Rear Wheel Speed Sensor Input Circuit Failure
- DTC C1175: Left Rear Wheel Speed Sensor Input Circuit Failure
- DTC C1233: Left Front, C1234: Right Front, C1235: Right Rear Or C1236: Left Rear Wheel Speed Sensor Input Missing
- DTC B1485: Brake Pedal Input Circuit Short To Battery
- DTC B1676: Battery Voltage Out Of Range
- Symptom Tests
- Test A: No Communication With Abs Control Module
- Test B: No Communication With Hybrid Electronic Instrument Cluster (HEIC)
- Test C: Spongy Brake Pedal With No Warning Light Operation
- Test D: Poor Vehicle Tracking During Abs Function
- Test E: Traction Control Inoperative (Warning Indicator Normal)
- Test F: Abs Indicator Does Not Self-Check
- Test G: Abs Warning Light & Traction Control Indicator Always On
- Test H: Traction Control Cannot Be Disabled
- Removal & Installation
- Torque Specifications
- Wiring Diagrams
- Anti-Lock Brake System
- Anti-Lock Brakes
- Drivelines & Axles
- Axle Shafts
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Electrical
- Charging Systems
- Component Locations
- Fuses & Circuit Breakers
- Gauges
- Instrument Panels - Analog
- Description & Operation
- Self-Diagnostic System
- Diagnostic Testing
- Symptom Testing
- No Communication With Hybrid Electronic Instrument Cluster (HEIC)
- No Communication With Steering Column/Ignition/Lighting (SCIL) Control Module
- Fuel Level Reads Inaccurately
- Engine Coolant Temperature Reads Inaccurately
- Low Oil Pressure Warning Never/Always On
- Speedometer Reads Inaccurately
- Cruise Control Indicator Never/Always On
- Tachometer Not Reflecting Correct Engine Speed
- Brake Warning Never/Always On
- Charge System Warning Never/Always On
- Transmission Range Indicator Never/Always On
- Left Turn Indicator Inoperative
- Right Turn Indicator Inoperative
- High Beam Indicator Inoperative
- High Beam Indicator Always On
- Removal & Installation
- Wiring Diagrams
- Instrument Panels - Analog
- Starter
- Wiring Diagrams
- System Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Electronic Power Steering
- Electronic Suspension
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Memory Systems
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Top/Sunroof
- Power Windows
- Radio
- Shift Interlocks
- Starting/Charging
- Supplemental Restraints
- Transmission
- Trunk, Tailgate, Fuel Door
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- System Wiring Diagrams
- Engine Mechanical
- Accessory Drive Belts
- Engine Cooling System Specifications & Drive Belt Routing
- Bleeding
- Belt Adjustment
- Notes
- Drive Belt TENSIONER Wear Indicator Location (Escort)
- Drive Belt TENSIONER Wear Indicator Location (3.0L V6 VIN "U")
- Drive Belt TENSIONER Wear Indicator Location (3.0L V6 VIN "S")
- Drive Belt TENSIONER Wear Indicator Location (3.4L V8 SHO)
- Drive Belt TENSIONER Wear Indicator Location (3.8L V6)
- Drive Belt TENSIONER Wear Indicator Location (4.6L V8)
- Drive Belt Routing
- Drive Belt Routing (Escort 2.0L 4-CYL. VIN "P")
- Drive Belt Routing (Escort, ZX2 2.0L VIN 3)
- Drive Belt Routing (Contour, Cougar & Mystique - 2.0L 4-CYL. VIN 3)
- Drive Belt Routing (2.5L - Contour & Mystique)
- Drive Belt Routing (2.5L - Cougar)
- Drive Belt Routing (2.5L)
- Drive Belt Routing (3.0L V6 VIN "S")
- Drive Belt Routing (3.0L V6 VIN "U")
- Drive Belt Routing (3.4L V8 SHO)
- Drive Belt Routing (3.8L V6)
- Drive Belt Routing (4.6L V8 VIN "V")
- Drive Belt Routing (4.6L V8 VIN "X")
- Specifications
- Engine Cooling System Specifications & Drive Belt Routing
- Auxiliary Emission Control Systems
- Emission Control System Visual Inspection Procedures - General Information
- * Please Read This First *
- Emission Control Labels
- Emission Control Visual Inspection
- Notes
- Positive Crankcase Ventilation (PCV)
- Thermostatic Air Cleaner (TAC)
- Fuel Evaporative System (EVAP)
- Catalytic Converters
- Fill Pipe RESTRICTOR (Fr)
- Exhaust Gas RECIRCULATION (EGR) System
- Spark Controls (SPK)
- Air Injection System (AIS)
- Oxygen Sensor (O2)
- Computerized Engine Controls (CEC)
- Early Fuel Evaporation (EFE)
- Emission Maintenance Reminder Light (EMR) (If Equipped)
- Malfunction Indicator Light (Mil)
- Emission Control System Visual Inspection Procedures - General Information
- Electric Cooling Fan - EEC-V
- Cooling System (Mechanical)
- Engine Cooling System Specifications & Drive Belt Routing
- Bleeding
- Belt Adjustment
- Notes
- Drive Belt TENSIONER Wear Indicator Location (Escort)
- Drive Belt TENSIONER Wear Indicator Location (3.0L V6 VIN "U")
- Drive Belt TENSIONER Wear Indicator Location (3.0L V6 VIN "S")
- Drive Belt TENSIONER Wear Indicator Location (3.4L V8 SHO)
- Drive Belt TENSIONER Wear Indicator Location (3.8L V6)
- Drive Belt TENSIONER Wear Indicator Location (4.6L V8)
- Drive Belt Routing
- Drive Belt Routing (Escort 2.0L 4-CYL. VIN "P")
- Drive Belt Routing (Escort, ZX2 2.0L VIN 3)
- Drive Belt Routing (Contour, Cougar & Mystique - 2.0L 4-CYL. VIN 3)
- Drive Belt Routing (2.5L - Contour & Mystique)
- Drive Belt Routing (2.5L - Cougar)
- Drive Belt Routing (2.5L)
- Drive Belt Routing (3.0L V6 VIN "S")
- Drive Belt Routing (3.0L V6 VIN "U")
- Drive Belt Routing (3.4L V8 SHO)
- Drive Belt Routing (3.8L V6)
- Drive Belt Routing (4.6L V8 VIN "V")
- Drive Belt Routing (4.6L V8 VIN "X")
- Specifications
- Engine Cooling System Specifications & Drive Belt Routing
- Mechanical
- Engine - 4.6L V8 - VIN [V]
- Engine Identification
- Adjustments
- Trouble Shooting
- Removal & Installation
- Overhaul
- Engine Oiling
- Torque Specifications
- Engine Specifications
- General Specifications
- Crankshaft, Main Bearings & Connecting Rod Bearings Specifications
- Connecting Rods Specifications
- Engine Valves & Valve Springs Specifications
- Pistons, Piston Pins & Piston Rings Specifications
- Valve Lash Adjuster Specifications
- Cylinder Head Specifications
- Camshaft Specifications
- Cylinder Block Specifications
- Engine - 4.6L V8 - VIN [V]
- Starter
- Accessory Drive Belts
- Engine Performance
- Engine Controls - Adjustments 4.6L
- Application
- Emissions
- EGR Function Testing - Ford - Cars
- Emission Applications
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Mode 6 - 1998 Ford - Except Diesel
- Engine Controls - Pin Voltage Charts 4.6L
- Remove, Overhaul & Install
- Engine Controls - Remove/Install/Overhaul 4.6L
- Sensor Range Charts
- Specifications
- System
- Engine Controls - Basic Testing 4.6L
- Engine Controls - System/Component Tests 4.6L
- Engine Controls - Tests W/Codes 4.6L
- Introduction
- Self-Diagnostic System
- Quick Test
- Additional System Functions
- Notes
- Parameter Identification (PID)
- On-Board System Readiness (OSR) Test Mode
- Freeze Frame Data Mode
- Output Test Mode
- Failure Mode Effects Management (FMEM)
- Hardware Limited Operational Strategy (HLOS)
- Drive Cycles
- OBD-II Drive Cycle Description
- Vehicle Preparation For OBD-II Or Monitor Repair Verification Drive Cycle
- OBD-II Drive Cycle
- Comprehensive Component Monitor Repair Verification Drive Cycle
- EGR Monitor Repair Verification Drive Cycle
- EVAP Running Loss System Repair Verification Drive Cycle
- Catalyst Monitor Repair Verification Drive Cycle
- Fuel Monitor Or HO2S Monitor Repair Verification Drive Cycle
- Misfire Monitor Repair Verification Drive Cycle
- Secondary Air Monitor Repair Verification Drive Cycle
- Summary
- Diagnostic Trouble Code (DTC) Reference Chart
- Circuit Tests
- Notes
- How To Use Circuit Tests
- Circuit Test A - No Start/Vehicle Will Not Start
- Circuit Test B - EEC-V Power Relay
- Circuit Test C - Reference Voltage
- Circuit Test DA - Temperature Sensor Test (IAT & ECT)
- Circuit Test Db - Engine Fuel Temperature (Eft) Sensor
- Circuit Test Dc - Mass Airflow (MAF) Sensor
- Circuit Test Dd - Fuel Rail Pressure (FRP) Sensor
- Circuit Test Dg - Knock Sensor (KS)
- Circuit Test DH - Throttle Position (TP) Sensor
- Circuit Test DL - Cylinder Head Temperature (CHT) Sensor
- Circuit Test DP - Vehicle Speed Sensor (VSS)
- Circuit Test Dr - Camshaft Position (CMP) Sensor
- Circuit Test DS - Air Conditioning Pressure (ACP) Sensor
- Circuit Test FB - Power Take Off (PTO)
- Circuit Test FD - Brake Pedal Position (BPP) Switch
- Circuit Test Ff - Power Steering Pressure (PSP) Switch
- Circuit Test FG - Octane Adjust
- Circuit Test H - Fuel Control
- Circuit Test HC - Gasoline Fuel Delivery System
- Circuit Test Hd - Misfire Detection Monitor
- Circuit Test He - EGR System
- Circuit Test Hf - Catalyst Efficiency Monitor & Exhaust Systems
- Circuit Test Hg - PCV System
- Circuit Test HK - Variable Cam Timing (VCT)
- Circuit Test HM - Secondary Air Injection (Air) System
- Circuit Test HU - Air Intake System
- Circuit Test HW - Evaporative Emission Purge Flow System
- Circuit Test HX - Evaporative Emission (EVAP) Monitor & System
- Circuit Test JB - Secondary Ignition
- Circuit Test JD - Crankshaft Position (CKP) Sensor
- Circuit Test JF - Integrated Ignition Coil On Plug Failure
- Circuit Test JH - Tachometer Output Failure
- Circuit Test Kb - Fuel Pump Driver Module (FPDM)
- Circuit Test KE - Idle Air Control (IAC) Valve
- Circuit Test MB - Output Test Mode Not Functioning
- Circuit Test NB - Malfunction Indicator Light (Mil)
- Circuit Test NC - Ignition Diagnostic Monitor (IDM)
- Circuit Test ND - Engine Rpm/Vehicle Speed Limiter
- Circuit Test QA - Unable To Activate Self-Test/SCP Communication Error DTC Not Listed
- Circuit Test QB - Diagnostic Trouble Code P0603 Or P1605
- Circuit Test QC - OBD-II Monitor Testing Not Complete; Diagnostic Trouble Code P1000
- Circuit Test QD - Diagnostic Trouble Code P1260
- Circuit Test Tb - Transmission Control Switch (TCS)/ Transmission Control Indicator Lamp (TCIL)
- Circuit Test XB - Variable Load Control Module (VLCM)
- Circuit Test Z - Intermittent
- Engine Controls - Tests W/O Codes 4.6L
- Introduction
- Symptoms
- Notes
- Symptom Diagnosis
- No Crank
- Hard Start/Long Crank
- No Start/Normal Crank
- Slow Return To Idle
- High Idle (Diesels/Runs On)
- Low Idle (Stalls On Deceleration)
- Rough Idle, Stalls, Misses, Hesitation Or Surge
- Backfires
- Loss Of Power
- Spark Knock
- Poor Fuel Economy
- Emissions Compliance
- Warning Indicator Lights
- Improper Automatic Transmission Shift
- Tachometer, Speedometer Or Fuel Gauge Inoperative
- High Oil Consumption
- Electric Cooling Fan Does Not Run At Low/& Or High Speed
- Electric Cooling Fan Always On
- Exhaust Smoke
- Fuel Smell
- Engine Noise
- Climate Control (Lack Of Cooling)
- Climate Control (A/C Always On)
- A/C Does Not Go Off During Wot
- BRAKELIGHTS Always On Or Off
- Sulfur Smell
- Fuel Pump Always On
- INTERMITTENTS
- Testing & Diagnosis
- Engine Controls - Basic Testing 4.6L
- Engine Controls - System/Component Tests 4.6L
- Engine Controls - Tests W/Codes 4.6L
- Introduction
- Self-Diagnostic System
- Quick Test
- Additional System Functions
- Notes
- Parameter Identification (PID)
- On-Board System Readiness (OSR) Test Mode
- Freeze Frame Data Mode
- Output Test Mode
- Failure Mode Effects Management (FMEM)
- Hardware Limited Operational Strategy (HLOS)
- Drive Cycles
- OBD-II Drive Cycle Description
- Vehicle Preparation For OBD-II Or Monitor Repair Verification Drive Cycle
- OBD-II Drive Cycle
- Comprehensive Component Monitor Repair Verification Drive Cycle
- EGR Monitor Repair Verification Drive Cycle
- EVAP Running Loss System Repair Verification Drive Cycle
- Catalyst Monitor Repair Verification Drive Cycle
- Fuel Monitor Or HO2S Monitor Repair Verification Drive Cycle
- Misfire Monitor Repair Verification Drive Cycle
- Secondary Air Monitor Repair Verification Drive Cycle
- Summary
- Diagnostic Trouble Code (DTC) Reference Chart
- Circuit Tests
- Notes
- How To Use Circuit Tests
- Circuit Test A - No Start/Vehicle Will Not Start
- Circuit Test B - EEC-V Power Relay
- Circuit Test C - Reference Voltage
- Circuit Test DA - Temperature Sensor Test (IAT & ECT)
- Circuit Test Db - Engine Fuel Temperature (Eft) Sensor
- Circuit Test Dc - Mass Airflow (MAF) Sensor
- Circuit Test Dd - Fuel Rail Pressure (FRP) Sensor
- Circuit Test Dg - Knock Sensor (KS)
- Circuit Test DH - Throttle Position (TP) Sensor
- Circuit Test DL - Cylinder Head Temperature (CHT) Sensor
- Circuit Test DP - Vehicle Speed Sensor (VSS)
- Circuit Test Dr - Camshaft Position (CMP) Sensor
- Circuit Test DS - Air Conditioning Pressure (ACP) Sensor
- Circuit Test FB - Power Take Off (PTO)
- Circuit Test FD - Brake Pedal Position (BPP) Switch
- Circuit Test Ff - Power Steering Pressure (PSP) Switch
- Circuit Test FG - Octane Adjust
- Circuit Test H - Fuel Control
- Circuit Test HC - Gasoline Fuel Delivery System
- Circuit Test Hd - Misfire Detection Monitor
- Circuit Test He - EGR System
- Circuit Test Hf - Catalyst Efficiency Monitor & Exhaust Systems
- Circuit Test Hg - PCV System
- Circuit Test HK - Variable Cam Timing (VCT)
- Circuit Test HM - Secondary Air Injection (Air) System
- Circuit Test HU - Air Intake System
- Circuit Test HW - Evaporative Emission Purge Flow System
- Circuit Test HX - Evaporative Emission (EVAP) Monitor & System
- Circuit Test JB - Secondary Ignition
- Circuit Test JD - Crankshaft Position (CKP) Sensor
- Circuit Test JF - Integrated Ignition Coil On Plug Failure
- Circuit Test JH - Tachometer Output Failure
- Circuit Test Kb - Fuel Pump Driver Module (FPDM)
- Circuit Test KE - Idle Air Control (IAC) Valve
- Circuit Test MB - Output Test Mode Not Functioning
- Circuit Test NB - Malfunction Indicator Light (Mil)
- Circuit Test NC - Ignition Diagnostic Monitor (IDM)
- Circuit Test ND - Engine Rpm/Vehicle Speed Limiter
- Circuit Test QA - Unable To Activate Self-Test/SCP Communication Error DTC Not Listed
- Circuit Test QB - Diagnostic Trouble Code P0603 Or P1605
- Circuit Test QC - OBD-II Monitor Testing Not Complete; Diagnostic Trouble Code P1000
- Circuit Test QD - Diagnostic Trouble Code P1260
- Circuit Test Tb - Transmission Control Switch (TCS)/ Transmission Control Indicator Lamp (TCIL)
- Circuit Test XB - Variable Load Control Module (VLCM)
- Circuit Test Z - Intermittent
- Engine Controls - Tests W/O Codes 4.6L
- Introduction
- Symptoms
- Notes
- Symptom Diagnosis
- No Crank
- Hard Start/Long Crank
- No Start/Normal Crank
- Slow Return To Idle
- High Idle (Diesels/Runs On)
- Low Idle (Stalls On Deceleration)
- Rough Idle, Stalls, Misses, Hesitation Or Surge
- Backfires
- Loss Of Power
- Spark Knock
- Poor Fuel Economy
- Emissions Compliance
- Warning Indicator Lights
- Improper Automatic Transmission Shift
- Tachometer, Speedometer Or Fuel Gauge Inoperative
- High Oil Consumption
- Electric Cooling Fan Does Not Run At Low/& Or High Speed
- Electric Cooling Fan Always On
- Exhaust Smoke
- Fuel Smell
- Engine Noise
- Climate Control (Lack Of Cooling)
- Climate Control (A/C Always On)
- A/C Does Not Go Off During Wot
- BRAKELIGHTS Always On Or Off
- Sulfur Smell
- Fuel Pump Always On
- INTERMITTENTS
- Theory and Operation
- Engine Controls - Theory & Operation 4.6L
- Introduction
- Computerized Engine Controls
- Powertrain Control Module (Pcm)
- Fuel Pump Driver Module (FPDM)
- Variable Load Control Module (VLCM)
- Input Devices
- Notes
- A/C Cycling Switch (ACCS)
- A/C Pressure Sensor
- A/C High Pressure Switch
- Brake Pedal Position (BPP) Switch
- Camshaft Position (CMP) Sensor
- Clutch Pedal Position (CPP) Switch
- Coolant Temperature Sensor
- Crankshaft Position (CKP) Sensor
- Cylinder Head Temperature (CHT) Sensor
- Differential Pressure Feedback EGR (DPFE) Sensor
- Engine Coolant Temperature (ECT) Sensor
- Engine Fuel Temperature (EFT) Sensor
- Fuel Pump Monitor (Models Without Fuel Pump Driver Module)
- Fuel Pump Monitor (Models With Fuel Pump Driver Module)
- Fuel Rail Pressure (FRP) Sensor
- Heated Oxygen Sensor (HO2S)
- Intake Air Temperature (IAT) Sensor
- Mass Airflow (MAF) Sensor
- Octane Adjust Shorting Bar
- Park/Neutral Position (PNP) Switch
- Power Steering Pressure (PSP) Sensor
- Power Steering Pressure (PSP) Switch
- Power Take-Off (PTO) Switch
- Throttle Position (TP) Sensor
- Transmission Control Switch (TCS)
- Transmission Fluid Temperature (TFT) Sensor
- Vehicle Speed Sensor (VSS)
- Output Signals
- Fuel System (Gasoline)
- Ignition System
- Emission Systems
- Self-Diagnostic System
- Engine Controls - Theory & Operation 4.6L
- Vacuum Diagrams
- Wiring Diagrams
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- Computer Relearn Procedures
- OBD-II Drive Cycles
- 1996-99 Gasoline Models (Except Villager)
- 1996 Villager
- 1997-99 Villager
- 2000-04 Gasoline Models
- 2005-09 Gasoline Models
- 2010-12 Gasoline Models (Except Fiesta)
- 2011-12 Fiesta
- 2003-07 6.0L Diesel
- 2008-10 6.4L Diesel
- 2011-12 6.7L Diesel
- 1996-03 7.3L Diesel
- 2005-09 Hybrid
- 2005-12 Escape Hybrid
- 2011-12 Fusion Hybrid
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- DTC Index
- A/C-Heater Systems (Automatic) DTCS
- Anti-Lock Brakes DTCS
- Anti-Theft Systems DTCS (Passive)
- AUTOLAMP Systems DTCS
- Automatic Transmission Electronic Controls Diagnosis DTCS
- Electric Cooling Fans DTCS
- Instrument Panels - Analog
- Power Door Locks DTC
- Power Mirrors DTCS
- Power Seats DTCS
- Power Windows DTCS
- Remote Keyless Entry Systems DTCS
- Self-Diagnostics DTCS
- Steering Column Switches DTCS
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Identification
- Metric Conversions
- OEM General Information
- How To Use The Engine Performance Section
- Maintenance Reminder Light (Reset Procedures)
- A/C Filter Service Reminder
- Engine Oil Replacement Reminder
- Notes
- Engine Oil Replacement Reminder Reset - Procedure 01
- Engine Oil Replacement Reminder Reset - Procedure 02
- Engine Oil Replacement Reminder Reset - Procedure 03
- Engine Oil Replacement Reminder Reset - Procedure 04
- Engine Oil Replacement Reminder Reset - Procedure 05
- Engine Oil Replacement Reminder Reset - Procedure 06
- Engine Oil Replacement Reminder Reset - Procedure 07
- Engine Oil Replacement Reminder Reset - Procedure 08
- Engine Oil Replacement Reminder Reset - Procedure 09
- Engine Oil Replacement Reminder Reset - Procedure 10
- Engine Oil Replacement Reminder Reset - Procedure 11
- Engine Oil Replacement Reminder Reset - Procedure 12
- Engine Oil Replacement Reminder Reset - Procedure 13
- Engine Oil Replacement Reminder Reset - Procedure 14
- Engine Oil Replacement Reminder Reset - Procedure 15
- Engine Oil Replacement Reminder Reset - Procedure 16
- Engine Oil Replacement Reminder Reset - Procedure 17
- Engine Oil Replacement Reminder Reset - Procedure 18
- Engine Oil Replacement Reminder Reset - Procedure 19
- Engine Oil Replacement Reminder Reset - Procedure 20
- Engine Oil Replacement Reminder Reset - Procedure 21
- Engine Oil Replacement Reminder Reset - Procedure 22
- Engine Oil Replacement Reminder Reset - Procedure 23
- Engine Oil Replacement Reminder Reset - Procedure 24
- Engine Oil Replacement Reminder Reset - Procedure 25
- Engine Oil Replacement Reminder Reset - Procedure 26
- Engine Oil Replacement Reminder Reset - Procedure 27
- Engine Oil Replacement Reminder Reset - Procedure 28
- Maintenance Service Reminder (Overhead Warning Lights)
- Maintenance Service Reminder (Sri)
- Maintenance Service Reminder (VMM)
- Tire Pressure Monitor System Reminder
- Notes
- Tire Pressure Sensor Types
- TPMS Reminder Reset - Procedure 01
- TPMS Reminder Reset - Procedure 02
- TPMS Reminder Reset - Procedure 03
- TPMS Reminder Reset - Procedure 04
- TPMS Reminder Reset - Procedure 05
- TPMS Reminder Reset - Procedure 07
- TPMS Reminder Reset - Procedure 08
- TPMS Reminder Reset - Procedure 09
- TPMS Reminder Reset - Procedure 10
- Restraints
- Supplemental Inflatable Restraint System Deactivation Procedures
- Special Care During Mechanical Repairs
- CHRYSLER Corp.
- Ford Motor Co.
- Notes
- System Operation Check
- Service Precautions
- Disabling & Activating Air Bag System
- Notes
- Disabling System (Continental, Crown Victoria, Grand Marquis & Town Car)
- Activating System
- Disabling System (Contour, Mystique & Windstar)
- Disabling System (Escort, Escort Coupe, "F" Series Pickups & Tracer)
- Disabling System ("E" Series Vans With One Battery)
- Disabling System ("E" Series Vans With Dual Batteries)
- Disabling System (Explorer, Expedition, Mountaineer, Navigator & Ranger)
- Disabling System (Mark VIII, Mustang, Sable & Taurus)
- Disabling System (Villager)
- Driver-Side Air Bag Module
- Removal & Installation (Expedition, Explorer, "E" Series Vans, "F" Series Pickups, Mountaineer, Navigator & Ranger)
- Removal & Installation (Continental, Crown Victoria, Grand Marquis, Mark VIII, Mustang, Sable, Taurus & Town Car)
- Removal & Installation (Contour & Mystique)
- Removal & Installation (Escort, Escort Coupe & Tracer)
- Removal & Installation (Windstar)
- Passenger-Side Air Bag Module
- Removal & Installation (Continental, Crown Victoria, Grand Marquis & Town Car)
- Removal & Installation (Contour & Mystique)
- Removal & Installation ("E" Series Vans)
- Removal & Installation (Expedition, "F" Series Pickups & Navigator)
- Removal & Installation (Explorer & Mountaineer)
- Removal & Installation (Escort, Escort Coupe & Tracer)
- Removal & Installation (Mark VIII)
- Removal & Installation (Mustang & Ranger)
- Removal & Installation (Sable & Taurus)
- Removal & Installation (Windstar)
- Torque Specifications
- General Motors
- Notes
- System Operation Check
- Service Precautions
- Disabling & Activating Air Bag System
- Notes
- Disabling & Activating System (Corvette)
- Disabling & Activating System (Catera)
- Disabling & Activating System (Concours, DeVille, Eldorado & Seville)
- Disabling & Activating System (Cutlass & Malibu)
- Disabling & Activating System (Grand Prix)
- Disabling & Activating System (Lumina & Monte Carlo)
- Disabling & Activating System (Metro, Firefly (Canadian) & Tracker)
- Disabling & Activating System (Prizm)
- Disabling & Activating System (Saturn)
- Disabling & Activating System (Silhouette, Trans Sport & Venture)
- Disabling & Activating System (All Other Models)
- Jeep
- Supplemental Inflatable Restraint System Deactivation Procedures
- Specifications Index
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Traction Control Disable Procedures
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- General Servicing
- A/C System Specifications
- HVAC System General Servicing
- Refrigerant Oil & Refrigerant Capacity Specifications
- USING R-134a REFRIGERANT
- System Service Valves
- Service Equipment
- Manifold Gauge Set
- Pressure-Temperature Relationship
- Pressure Gauge Readings
- Orifice Tube Replacement
- Refrigerant Recovery/Recycling
- Flushing A/C System
- Evacuating A/C System
- Charging A/C System
- Leak Testing
- HVAC System - Compressor Servicing
- HVAC System Compressor Refrigerant Oil Checking
- HVAC Control Systems
- A/C-Heater System
- A/C System Specifications
- Description
- Operation
- Trouble Shooting
- Self-Diagnostics
- Entering Self-Diagnostics
- Exiting Self-Diagnostics
- Symptom Diagnosis
- Notes
- No Communication With EATC Module
- EATC System Inoperative, Intermittent Or Improper Operation
- Improper/Erratic Direction Of Airflow From Outlets
- Insufficient, Erratic Or No Heat
- A/C Does Not Operate/Does Not Operate Properly
- Insufficient A/C Cooling
- Engine Cooling Fan Does Not Operate When A/C Is On
- Blower Motor Does Not Run
- Blower Motor Runs Continuously In High Speed
- Blower Motor Does Not Operate At Some Settings
- Temperature Set Point Does Not Repeat After Turning Ignition Off
- Temperature Display Will Not Switch Between °F & °C
- DTC B1249 Test: Blend Door Failure
- DTC B1251 Test: In-Car Temperature Sensor Open
- DTC B1253 Test: In-Car Temperature Sensor Short
- DTC B1255 Test: Ambient Temperature Sensor Open
- DTC B1257 Test: Ambient Temperature Sensor Short
- DTC B1261 Test: SUNLOAD Sensor Short
- Test A: No Communication With EATC Module
- Test B: EATC System Inoperative, Intermittent Or Improper Operation
- Test C: Improper Or Erratic Direction Of Airflow From Outlets
- Test D: Insufficient, Erratic Or No Heat
- Test E: A/C Does Not Operate Or Does Not Operate Properly
- Test F: Insufficient A/C Cooling
- Test G: Blower Motor Does Not Run
- Test H: Blower Motor Runs Continuously In High Speed
- Test J: Blower Motor Does Not Operate In Some Settings
- Test K: Temperature Set Point Does Not Repeat After Turning Ignition Off
- Test L: Temperature Display Will Not Switch Between FAHRENHEIT & CELSIUS
- Testing
- Removal & Installation
- Notes
- A/C Manifold & Tube Assembly
- Accumulator-Drier
- Blower Motor Assembly
- Blower Speed Controller (BSC)
- Compressor
- Condenser
- Electronic Automatic Temperature Control (EATC) Module
- Evaporator/Heater Housing & Cores
- Fixed Orifice Tube
- Instrument Panel
- Ambient Temperature Sensor
- In-Car Temperature Sensor
- SUNLOAD Sensor
- Temperature Blend Door Actuator
- Vacuum Reservoir Tank
- Heater Door Vacuum Actuator
- Defrost Door Vacuum Actuator
- Air Inlet Duct Door Vacuum Actuator
- Torque Specifications
- Vacuum Hose Diagram(S)
- Wiring Diagram
- A/C-Heater System
- General Servicing
- Maintenance
- Procedures
- Maintenance Information
- Model Identification
- Maintenance Service Information
- Service Point Locations
- Lubrication Specifications
- Fluid Capacities
- Wheel & Tire Specifications
- Battery Specifications
- Cautions & Warnings
- Supplemental Restraint System (Air Bag System)
- Air Conditioning Servicing
- Air Suspension System
- Anti-Lock Brake System
- Replacing Blown Fuses
- Brake Pad Wear Indicator
- Catalytic Converter
- Electrostatic Discharge Sensitive (ESD) Parts
- Fuel Pump Shutoff Switch
- Fuel System Service
- Halogen Bulbs
- Methanol Gasoline
- Radiator Cap
- Radiator Fan
- Spark Plugs
- Warranty Information
- Fuses & Circuit Breakers (Interior)
- Maintenance Reminder Light (Reset Procedures)
- A/C Filter Service Reminder
- Engine Oil Replacement Reminder
- Notes
- Engine Oil Replacement Reminder Reset - Procedure 01
- Engine Oil Replacement Reminder Reset - Procedure 02
- Engine Oil Replacement Reminder Reset - Procedure 03
- Engine Oil Replacement Reminder Reset - Procedure 04
- Engine Oil Replacement Reminder Reset - Procedure 05
- Engine Oil Replacement Reminder Reset - Procedure 06
- Engine Oil Replacement Reminder Reset - Procedure 07
- Engine Oil Replacement Reminder Reset - Procedure 08
- Engine Oil Replacement Reminder Reset - Procedure 09
- Engine Oil Replacement Reminder Reset - Procedure 10
- Engine Oil Replacement Reminder Reset - Procedure 11
- Engine Oil Replacement Reminder Reset - Procedure 12
- Engine Oil Replacement Reminder Reset - Procedure 13
- Engine Oil Replacement Reminder Reset - Procedure 14
- Engine Oil Replacement Reminder Reset - Procedure 15
- Engine Oil Replacement Reminder Reset - Procedure 16
- Engine Oil Replacement Reminder Reset - Procedure 17
- Engine Oil Replacement Reminder Reset - Procedure 18
- Engine Oil Replacement Reminder Reset - Procedure 19
- Engine Oil Replacement Reminder Reset - Procedure 20
- Engine Oil Replacement Reminder Reset - Procedure 21
- Engine Oil Replacement Reminder Reset - Procedure 22
- Engine Oil Replacement Reminder Reset - Procedure 23
- Engine Oil Replacement Reminder Reset - Procedure 24
- Engine Oil Replacement Reminder Reset - Procedure 25
- Engine Oil Replacement Reminder Reset - Procedure 26
- Engine Oil Replacement Reminder Reset - Procedure 27
- Engine Oil Replacement Reminder Reset - Procedure 28
- Maintenance Service Reminder (Overhead Warning Lights)
- Maintenance Service Reminder (Sri)
- Maintenance Service Reminder (VMM)
- Tire Pressure Monitor System Reminder
- Notes
- Tire Pressure Sensor Types
- TPMS Reminder Reset - Procedure 01
- TPMS Reminder Reset - Procedure 02
- TPMS Reminder Reset - Procedure 03
- TPMS Reminder Reset - Procedure 04
- TPMS Reminder Reset - Procedure 05
- TPMS Reminder Reset - Procedure 07
- TPMS Reminder Reset - Procedure 08
- TPMS Reminder Reset - Procedure 09
- TPMS Reminder Reset - Procedure 10
- Maintenance Information
- Procedures
- Restraints
- Air Bag, SRS
- Air Bag Restraint System
- Description & Operation
- Servicing
- Disabling & Activating Air Bag System
- Post-Collision Inspection
- Adjustments
- Disposal Procedures
- Removal & Installation
- Diagnosis & Testing
- Diagnostic Tests
- Notes
- Test A: No Air Bag Warning Light
- Test B: Air Bag Warning Light On Continuously
- Test C: Low Battery Voltage (LFC 12)
- Test D: Air Bag Circuit Shorted To Ground (LFC 13)
- Test E: Front Impact Sensor Shorted To Ground (LFC 14)
- Test F: SAFING Sensor Not Mounted Properly (LFC 21)
- Test G: SAFING Sensor Output Circuit Shorted To Battery Voltage (LFC 22)
- Test H: SAFING Sensor Input Feed/Return Circuit Open (LFC 23)
- Test I: SAFING Sensor Output Feed/Return Circuit Open (LFC 24)
- Test J: High Resistance Or Open In Driver-Side Air Bag Circuit (LFC 32)
- Test K: High Resistance Or Open In Passenger-Side Air Bag Circuit (LFC 33)
- Test L: Low Resistance Or Short In Driver Side Air Bag Circuit (LFC 34)
- Test M: Low Resistance Or Short In Passenger-Side Air Bag Circuit (LFC 35)
- Test N: Open In Right Front Impact Sensor Circuit (LFC 41)
- Test O: Open Left Front Impact Sensor Circuit (LFC 42)
- Test P: Right Impact Sensor Not Mounted Properly (LFC 44)
- Test Q: Left Impact Sensor Not Mounted Properly (LFC 45)
- Test T: Diagnostic Monitor Internal Thermal Fuse Open (LFC 51)
- Test R: Back-Up Power Supply Fault (LFC 52)
- Test S: Impact Sensor Circuits Resistance To Ground Or Diagnostic Monitor Internal Fault (LFC 53)
- Test T: Rapid Continuous Flashing Of Air Bag Warning Light
- Wire Repair
- Torque Specifications
- Wiring Diagrams
- Supplemental Inflatable Restraint System -- Air Bag/SRS Component Inspection & Replacement Tables
- Air Bag Restraint System
- Restraints Control Systems
- Seat Belts
- Air Bag, SRS
- Steering
- Electronic Steering
- Description & Operation
- Component Locations
- Trouble Shooting
- Self-Diagnostics
- Symptom Charts
- Diagnostic Tests
- System Tests
- Component Tests
- Lubrication
- Adjustments
- Removal & Installation
- Overhaul
- Power Steering Specifications
- Torque Specifications
- Wiring Diagrams
- Steering Column
- Electronic Steering
- Suspension
- Electronic Suspension
- Electronic Air
- Description
- Operation
- Repair Precautions
- Adjustments
- Trouble Shooting
- Diagnosis & Testing
- Symptom Tests
- Diagnostic Tests
- Notes
- DTC 18: Control Module Detects Low Battery Voltage
- DTC 19: Control Module Detects High Battery Voltage
- DTC 25: Height Sensor Supply Not 5 Volts
- DTC 29: Two Door Cycles Not Detected During Self Test
- DTC 35: EVO Actuator Problem
- DTC 45: Steering Wheel Rotation Not Detected
- DTC 50: Left Front Height Sensor Out Of Range
- DTC 55: Right Front Height Sensor Out Of Range
- DTC 60: Left Rear Height Sensor Out Of Range
- DTC 70: Vent Solenoid
- DTC 75: Compressor Relay Control Circuit
- DTC: 80, 85, 90 Or 95: Air Spring Solenoid Valves
- DTC 98: Compressor Run Time Exceeded
- DTC 99: Unable To Detect Raising Or Lowering Of One Or More Corners
- Removal & Installation
- Notes
- Air Spring Fill Procedure
- Air Spring Venting Procedure
- Air Spring Solenoid
- Air Spring
- Air Lines
- Height Sensor
- Control Module
- Compressor Relay
- Air Compressor Assembly
- Air Drier
- Upper Control Arm
- Lower Control Arm
- Ball Joints
- Stabilizer Bar, Link & Bushing
- Knuckle/Hub Assembly (Rear)
- Spindle Assembly (Front)
- Shock Replacement
- Wheel Bearings
- Torque Specifications
- Wiring Diagrams
- Electronic Air
- Wheel Alignment Specifications & Procedures
- Electronic Suspension
- Transmission
- Automatic Trans
- Automatic Transmission Removal & Installation
- Automatic Transmission Servicing
- Application
- Identification
- Lubrication
- Service Intervals
- Checking Fluid Level
- Recommended Fluids
- Fluid Capacities
- Draining & Refilling
- Notes
- AX4N & AX4S (Continental, Sable, Taurus & Windstar)
- CD4E (Contour, Cougar & Mystique)
- E4OD & 4R100 (Expedition, Navigator, Pickup & Van)
- F4E III /F4E Type "F" (Escort & Tracer)
- 4F20E (Villager)
- 4R44E & 5R55E (Explorer, Mountaineer & Ranger)
- 4R70W & 4R100 (Expedition, Crown Victoria, Grand Marquis, Mark VIII, Mountaineer, Mustang, Navigator, Pickup, Town Car & Van)
- Adjustments
- Notes
- Band
- Shift Cable/Linkage
- Shift Indicator Cable
- Transmission Range (Tr) Sensor/Switch
- AX4N & AX4S (Continental, Sable, Taurus & Windstar)
- CD4E & E4OD (Contour, Cougar, Expedition, Mystique, Pickup & Van)
- F4E III (Escort & Tracer)
- 4F20E (Villager)
- 4R44E & 5R55E (Aerostar & Ranger)
- 4R70W (Crown Victoria, Cougar, Expedition, Explorer, Grand Marquis, Mark VIII, Mountaineer, Mustang, Pickup, Town Car & Van)
- 4R100 (Expedition, Navigator, Pickup & Van)
- Torque Specifications
- Diagnosis - 4R70W Automatic Transmission
- Description & Operation
- Notes
- Input Sensors
- Notes
- Air Conditioning Clutch (ACC)
- Brake On/Off (BOO) Switch
- Electronic Ignition (EI)
- Engine Coolant Temperature (ECT) Sensor
- Mass Airflow (MAF) Sensor
- Transmission Range (TR) Sensor
- Output Shaft Speed (OSS) Sensor
- Programmable Speedometer/Odometer Module (PSOM)
- Throttle Position (TP) Sensor
- Transmission Control Switch (TCS)
- Transmission Fluid Temperature (TFT) Sensor
- Vehicle Speed Sensor (VSS)
- Output Devices
- Trouble Shooting
- Self-Diagnostic System
- Diagnostic Procedure
- Diagnostic Trouble Codes (DTC)
- Retrieving Codes
- Reading Codes
- Clearing Codes
- Quick Test
- Output State Control (OSC) Modes
- Additional System Functions
- Symptom Diagnosis
- Harsh Reverse Only Engagement
- Harsh Forward Only Engagement
- Some Or All Shifts Missing
- Some Or All Shifts Early Or Late
- Erratic Or Hunting Shifts
- Soft Or Slipping Shifts
- Harsh Shifts
- No Manual 1st Or 2nd Gear
- No 1st Gear
- No 1-2, 2-3 Or 3-4 Upshift (Automatic)
- No TCC Engagement
- TCC Always Engaged
- TCC Cycling Or Shuddering
- Poor Vehicle Performance Only
- Incorrect Gear Ratio In "D", "2" Or "1" Positions
- Engine Will Not Crank
- Transmission Drive Cycle Test
- Pinpoint Tests: 1997 Models
- Pinpoint Tests: 1998 Models
- Notes
- How To Use Circuit Tests & Pinpoint Tests
- Test A: Shift Solenoid & TCC Solenoid Electrical Circuit
- Test B: TFT Sensor Circuit
- Test D: Transmission Range (Tr) Sensor
- Test E: EPC Solenoid
- Test F: Output Shaft Speed (OSS) Sensor
- Test H: Solenoid Mechanical Failure
- Test Tb: Transmission Control Switch (TCS), Transmission Control Indicator Lamp (TCIL)
- Test TG: 4WD Low Range Switch
- Wiring Diagrams
- Description & Operation
- Overhaul - 4R70W Automatic Transmission
- Application
- Identification
- Description
- Lubrication & Adjustments
- On-Vehicle Service
- Trouble Shooting
- Notes
- Symptom Diagnosis
- No Forward Engagement
- No Reverse Engagement
- Harsh Reverse Engagement
- Harsh Forward Engagement
- Delayed/Soft Reverse Engagement
- Delayed/Soft Forward Engagement
- Some Or All Shifts Missing
- Early/Late Shift Speeds
- Erratic/Hunting Shifting
- Soft/Slipping Shift Feel
- Harsh Shift Feel
- No 1st Gear In Drive, Engages In Higher Gear
- No Manual Low Gear
- No Manual 2nd Gear
- No 1-2 Automatic Shift
- No 2-3 Automatic Shift
- No 3-4 Automatic Shift
- No 4-3 Automatic Downshift
- No 3-2 Automatic Downshift
- No 2-1 Automatic Downshift
- No Torque Converter Clutch Application
- Torque Converter Clutch Always Applied
- Torque Converter Clutch Cycling/Shudder/Chatter
- Miscellaneous Faults
- Clutch & Band Application Chart
- Testing
- Torque Converter
- Removal & Installation
- Transmission Disassembly
- Component Disassembly & Reassembly
- Transmission Reassembly
- Transmission Specifications
- Torque Specifications
- Shift Interlock Systems
- Description & Operation
- Trouble Shooting
- Diagnosis & Testing
- Removal & Installation
- Gearshift Lever Assembly
- Removal & Installation (Aspire)
- Removal & Installation (Continental & Town Car)
- Removal & Installation (Contour & Mystique)
- Removal & Installation (Cougar, Mustang & Thunderbird)
- Removal & Installation (Escort & Tracer)
- Removal & Installation (Mark VIII)
- Removal & Installation (Probe)
- Removal & Installation (Sable & Taurus)
- Removal & Installation (Light Duty Trucks & Vans)
- Shift Interlock Actuator
- Shift Interlock Cable
- Steering Column/Ignition/Lighting Control (SCIL) Module
- Gearshift Lever Assembly
- Torque Specifications
- Wiring Diagrams
- Automatic Transmission - Hydraulic Diagrams - 4R70W
- Automatic Trans
- External Pages