Technical Service Bulletins

A/C Compressor
- Climate Control - A/C Service Tech Tips (02-20-8)
Accessories Control Systems
- "CANADA Only" - Map Zoom - Navigation System Will Not Zoom Closer Than A 16 Mile Scale (32 Km) (05-16-8)
- Climate Controlled Seats Turning Off Shortly After Initialization - DTC'S B2729, B2730, B2731 (04-4-2)
Accessory Drive Belts
- 3.9L Accessory Drive Belt Snap Noise In Freezing Temperatures (08-16-5)
Air Bag, SRS
- RCM Fault Reporting Using DTCS And Bit-Mapped Parameter Identifiers (PIDS) - Service Tips (07-7-8)
Anti-Lock Brakes
- Diagnostic Trouble Code - DTC C1145 And/Or C1155 Stored In Anti-Lock Brake System (Abs) Module (04-22-13)
Anti-Theft Systems
- Keypad Diagnostics - Dealer Installed Accessory (06-15-8)
- Remote Keyless Entry (RKE) - Service Tips (03-18-1)
Automatic Trans
- 5R55S/5R55N/5R55W Transmissions - Shift Concerns, Loss Of 2ND, 3RD And 5TH Gear, Incorrect Ratio DTC'S - Procedure To Inspect And Repair Servo Pin Bore Wear (09-12-12)
- 3.0L With 5R55S - Harsh 2-3 Upshifts 20-50 Mph (32-80 Km/H) Or Harsh Coasting Downshifts 10-15 Mph (16-24 Km/H) (05-19-6)
- 5R55S - Illuminated Transmission Control Indicator Light And DTC P1744 (04-12-3)
- 5R55S - Harsh Shifts (03-15-8)
- New Transmission Cooler Flusher - Service Tips (03-14-8)
- 5R55N, 5R55S, 5R55W - New Rotunda Tool For Checking Fluid Level & Filling (02-20-3)
Auxiliary Emission Control Systems
- Wrench Light On With Both DTC P2106 And P2135 - Vehicles Built 11/29/2004 And Prior (05-9-15)
- Rough Idle Or Mil Lamp On (05-6-5)
- MAF Diagnostic Service Tip - Vehicles Equipped With EGR System Module (ESM) (05-3-1)
- General Pcm Programming Procedures (04-24-14)
- Malfunction Indicator Lamp (Mil) Illuminated - System Lean Diagnostic Trouble Codes - DTC'S - Service Tips (04-17-4)
- Mil With DTC'S P0442, P0455, P0456, P0457, P1442 Or Check Fuel Cap Lamp With DTC P0457 (03-9-8)
Body Electrical
- Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)
Body Interior
- "CANADA Only" - Map Zoom - Navigation System Will Not Zoom Closer Than A 16 Mile Scale (32 Km) (05-16-8)
- Climate Controlled Seats Turning Off Shortly After Initialization - DTC'S B2729, B2730, B2731 (04-4-2)
Brakes Control Systems
- Diagnostic Trouble Code - DTC C1145 And/Or C1155 Stored In Anti-Lock Brake System (Abs) Module (04-22-13)
Charging Systems
- Stuck High Voltage Charge Cord Information Sheet (G0000127)
Collision/Avoidance
- Parking Aid System Inoperative - DTC C1983 (06-25-13)
Cooling System (Mechanical)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
- Cooling System - MOTORCRAFT Premium Gold Engine Coolant - Service Tips (02-3-4)
Engine Control Systems
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-8-1)
- 3.0L - Vacuum Leakage Noise And Mil On With Lean Codes (08-12-4)
- WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
- Wrench Light On With Both DTC P2106 And P2135 - Vehicles Built 11/29/2004 And Prior (05-9-15)
- 3.0L - Stumble And/Or Inductive Backfire (05-9-7)
- Rough Idle Or Mil Lamp On (05-6-5)
- General Pcm Programming Procedures (04-24-14)
- Malfunction Indicator Lamp (Mil) Illuminated - System Lean Diagnostic Trouble Codes - DTC'S - Service Tips (04-17-4)
- Mil With DTC'S P0442, P0455, P0456, P0457, P1442 Or Check Fuel Cap Lamp With DTC P0457 (03-9-8)
Entertainment Systems
- Rear Window Defroster Grid/Integral Antenna Diagnosis And Repair - Terminal Tab Repair (04-24-5)
- Am Radio Interference - Vehicles Produced Prior To 12/01/2003 (04-1-7)
- CDX6 Radio Damaged During Service Shipping - Correct Shipment Procedures (02-25-2)
Exhaust
- Various Vehicles - Catalytic Converter Concern Analysis (22-7009)
Exterior Body Panels
- Aluminum Panel Corrosion (17-0062)
- Mil With DTC'S P0442, P0455, P0456, P0457, P1442 Or Check Fuel Cap Lamp With DTC P0457 (03-9-8)
- Plastic Bumper/Fascia Parts - Preparation Procedures - Service Tips (03-10-1)
Exterior Lights
- Moisture In Reverse Lamp (04-15-7)
- Inadvertent Disabling Of Brake Shift Interlock (99-13-9)
Frames, Subframes & Crossmembers
- Aluminum Panel Corrosion (17-0062)
- Plastic Bumper/Fascia Parts - Preparation Procedures - Service Tips (03-10-1)
Fuel System
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-8-1)
- 3.0L - Vacuum Leakage Noise And Mil On With Lean Codes (08-12-4)
- Mil With DTC'S P0442, P0455, P0456, P0457, P1442 Or Check Fuel Cap Lamp With DTC P0457 (03-9-8)
Fuses & Circuit Breakers
- Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)
Heated Glass/Defoggers
- Rear Window Defroster Grid/Integral Antenna Diagnosis And Repair - Terminal Tab Repair (04-24-5)
HVAC Control Systems
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
- Climate Control - A/C Service Tech Tips (02-20-8)
Ignition System
- WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
Infotainment
- "CANADA Only" - Map Zoom - Navigation System Will Not Zoom Closer Than A 16 Mile Scale (32 Km) (05-16-8)
- Rear Window Defroster Grid/Integral Antenna Diagnosis And Repair - Terminal Tab Repair (04-24-5)
Interior/Exterior Trim
- Ash Tray Door Will Not Latch Closed (03-22-7)
- Headliner Falling/Unattached In Rear (03-17-2)
Lubrication System
- Engine Oil Level Indicator Markings - Reports Of Low Oil Level (03-8-3)
Manual Steering
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
- Steering Gear Squeak When Turning The Steering Wheel During Low Speed Parking Maneuvers (06-5-16)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-8-1)
- 3.9L Accessory Drive Belt Snap Noise In Freezing Temperatures (08-16-5)
- 3.0L - Vacuum Leakage Noise And Mil On With Lean Codes (08-12-4)
- Identifying The Correct Replacement Head Gasket For Certain Remanufactured Engines - Service Tip (06-18-16)
- Engine Oil Level Indicator Markings - Reports Of Low Oil Level (03-8-3)
- Engine - Straightedge Procedure For Checking Cylinder Head & Block Flatness (02-21-13)
Mirrors
- Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
- Ford Interior Mirror Job Aid (G0000001)
- Exterior Mirror Glass And Motor Replacement (98-9-14)
Paint & Coatings
- Aluminum Panel Corrosion (17-0062)
- Plastic Bumper/Fascia Parts - Preparation Procedures - Service Tips (03-10-1)
- Body - Paint - No CLEARCOAT Blending - Collision Manual Change (03-3-7)
- Approved Paint Materials For Warranty Repairs (02-16-7)
- Paint - New Polishing Products - Service Procedures (02-16-3)
Passive Restraints
- Safety Belt Retraction Speed (05-16-11)
- Safety Belt Web Stop Button Service (05-3-10)
Restraints Control Systems
- RCM Fault Reporting Using DTCS And Bit-Mapped Parameter Identifiers (PIDS) - Service Tips (07-7-8)
Seats
- Safety Belt Retraction Speed (05-16-11)
- Safety Belt Web Stop Button Service (05-3-10)
- Climate Controlled Seats Turning Off Shortly After Initialization - DTC'S B2729, B2730, B2731 (04-4-2)
Starter
- Battery Service - Operation Of Battery Eye - Charging Service Tips (07-5-8)
- Battery Drain Diagnosis - Service Tips (05-22-9)
Steering Column
- Leather-Wrapped Steering Wheel - Leather Coming Loose (07-4-3)
Steering Control Systems
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
- Steering Gear Squeak When Turning The Steering Wheel During Low Speed Parking Maneuvers (06-5-16)
Steering Gear
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
- Steering Gear Squeak When Turning The Steering Wheel During Low Speed Parking Maneuvers (06-5-16)
System
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-8-1)
- 3.0L - Vacuum Leakage Noise And Mil On With Lean Codes (08-12-4)
- WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
- Wrench Light On With Both DTC P2106 And P2135 - Vehicles Built 11/29/2004 And Prior (05-9-15)
- 3.0L - Stumble And/Or Inductive Backfire (05-9-7)
- Rough Idle Or Mil Lamp On (05-6-5)
- MAF Diagnostic Service Tip - Vehicles Equipped With EGR System Module (ESM) (05-3-1)
- General Pcm Programming Procedures (04-24-14)
- Malfunction Indicator Lamp (Mil) Illuminated - System Lean Diagnostic Trouble Codes - DTC'S - Service Tips (04-17-4)
- Mil With DTC'S P0442, P0455, P0456, P0457, P1442 Or Check Fuel Cap Lamp With DTC P0457 (03-9-8)
Transmission Control Systems
- 5R55S/5R55N/5R55W Transmissions - Shift Concerns, Loss Of 2ND, 3RD And 5TH Gear, Incorrect Ratio DTC'S - Procedure To Inspect And Repair Servo Pin Bore Wear (09-12-12)
- 3.0L With 5R55S - Harsh 2-3 Upshifts 20-50 Mph (32-80 Km/H) Or Harsh Coasting Downshifts 10-15 Mph (16-24 Km/H) (05-19-6)
- 5R55S - Illuminated Transmission Control Indicator Light And DTC P1744 (04-12-3)
- 5R55S - Harsh Shifts (03-15-8)
- Inadvertent Disabling Of Brake Shift Interlock (99-13-9)
Warning Systems
- Parking Aid System Inoperative - DTC C1983 (05-26-12)
Wiper/Washer Systems
- Am Radio Interference - Vehicles Produced Prior To 12/01/2003 (04-1-7)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)