Technical Service Bulletins

A/C Compressor
- Chirp Noise From FEAD Area When A/C Compressor Engages (05-20-9)
- Climate Control - A/C Service Tech Tips (02-20-8)
Accessories Control Systems
- "CANADA Only" - Map Zoom - Navigation System Will Not Zoom Closer Than A 16 Mile Scale (32 Km) (05-16-8)
Accessory Drive Belts
- Chirp Noise From FEAD Area When A/C Compressor Engages (05-20-9)
Air Bag, SRS
- RCM Fault Reporting Using DTCS And Bit-Mapped Parameter Identifiers (PIDS) - Service Tips (07-7-8)
- DTC B1342 - Restraint Control Module - Diagnostic Service Tip (04-25-15)
Anti-Theft Systems
- Keypad Diagnostics - Dealer Installed Accessory (06-15-8)
- Door Locks Inoperative - Fuse 2.30 Opening Intermittently (05-6-7)
- Remote Keyless Entry (RKE) - Service Tips (03-18-1)
Automatic Trans
- 4R70W - New Service Part - Number 5 Needle Bearing And Race Kit (03-26-1)
Auxiliary Emission Control Systems
- Mil On And DTC P0460 In Memory (05-11-3)
- MAF Diagnostic Service Tip - Vehicles Equipped With EGR System Module (ESM) (05-3-1)
- General Pcm Programming Procedures (04-24-14)
- Malfunction Indicator Lamp (Mil) Illuminated - System Lean Diagnostic Trouble Codes - DTC'S - Service Tips (04-17-4)
- Diagnostic Trouble Code DTC P0442 (04-15-15)
- Mil With DTC'S P0442, P0455, P0456, P0457, P1442 Or Check Fuel Cap Lamp With DTC P0457 (03-9-8)
Axle Shafts
- Axle - Rear Axle Shaft And/Or Axle Bearing Premature Wear (03-5-5)
Body Electrical
- Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)
Body Interior
- "CANADA Only" - Map Zoom - Navigation System Will Not Zoom Closer Than A 16 Mile Scale (32 Km) (05-16-8)
Charging Systems
- Stuck High Voltage Charge Cord Information Sheet (G0000127)
- Charging System - DTC P1246 - Battery Warning Lamp Illuminated (03-24-4)
Collision/Avoidance
- Parking Aid System Inoperative - DTC C1983 (06-25-13)
Cooling Fan
- Engine Cooling Fan Inoperative - DTC P0480 (03-19-1)
Cooling System (Mechanical)
- All Chain Driven Water Pumps (TT003-13)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
- Engine Cooling Fan Inoperative - DTC P0480 (03-19-1)
- Body - Radiator Alignment Pin Ground Clearance (03-14-11)
- Cooling System - MOTORCRAFT Premium Gold Engine Coolant - Service Tips (02-3-4)
Cruise Control Systems
- Speed Control Diagnostic Tips - SCP (06-8-4)
Differentials & Drive Axles
- Axle - Rear Axle Shaft And/Or Axle Bearing Premature Wear (03-5-5)
Engine Control Systems
- WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
- Mil On And DTC P0460 In Memory (05-11-3)
- General Pcm Programming Procedures (04-24-14)
- Malfunction Indicator Lamp (Mil) Illuminated - System Lean Diagnostic Trouble Codes - DTC'S - Service Tips (04-17-4)
- Diagnostic Trouble Code DTC P0442 (04-15-15)
- Charging System - DTC P1246 - Battery Warning Lamp Illuminated (03-24-4)
- Mil With DTC'S P0442, P0455, P0456, P0457, P1442 Or Check Fuel Cap Lamp With DTC P0457 (03-9-8)
- Engine Cooling Fan Inoperative - DTC P0480 (03-19-1)
- Engine Vibration At Idle &/Or Low Speeds - Cold Engine (03-12-4)
- 3.0L/3.8L/4.6L - Fuel Pressure Relief Valve (SCHRADER Valve) Discontinued (02-8-4)
Entertainment Systems
- Rear Window Defroster Grid/Integral Antenna Diagnosis And Repair - Terminal Tab Repair (04-24-5)
- Radio - Poor Am Range Reception (03-7-6)
Exhaust
- Various Vehicles - Catalytic Converter Concern Analysis (22-7009)
- Engine Knock During Initial Cold Start (04-2-1)
- Engine Vibration At Idle &/Or Low Speeds - Cold Engine (03-12-4)
Exterior Body Panels
- Aluminum Panel Corrosion (17-0062)
- Mil With DTC'S P0442, P0455, P0456, P0457, P1442 Or Check Fuel Cap Lamp With DTC P0457 (03-9-8)
- Plastic Bumper/Fascia Parts - Preparation Procedures - Service Tips (03-10-1)
- Body - Collision Repair Updates (02-17-11)
Exterior Lights
- Inadvertent Disabling Of Brake Shift Interlock (99-13-9)
Frames, Subframes & Crossmembers
- Aluminum Panel Corrosion (17-0062)
- Plastic Bumper/Fascia Parts - Preparation Procedures - Service Tips (03-10-1)
- Body - Collision Repair Updates (02-17-11)
Front Suspension
- Squeak Or Rubbing Noise From Front Suspension - Front Spring Insulator Revised (04-15-5)
Fuel System
- Mil With DTC'S P0442, P0455, P0456, P0457, P1442 Or Check Fuel Cap Lamp With DTC P0457 (03-9-8)
- 3.0L/3.8L/4.6L - Fuel Pressure Relief Valve (SCHRADER Valve) Discontinued (02-8-4)
Fuses & Circuit Breakers
- Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)
- Door Locks Inoperative - Fuse 2.30 Opening Intermittently (05-6-7)
Heated Glass/Defoggers
- Rear Window Defroster Grid/Integral Antenna Diagnosis And Repair - Terminal Tab Repair (04-24-5)
HVAC Control Systems
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
- Erratic Climate Control Blower Motor Operation During Braking, Turning Or Acceleration (04-14-11)
- Climate Control - Register Vent Rattle With A/C Blower On (04-7-6)
- Fluttering/Hooting From Climate Control System RECIRC/Fresh Air Mode Door (03-23-4)
- Whistle From Climate Control - Blower Fan At Max Speed & Heat At Max (03-1-6)
- Climate Control - A/C Service Tech Tips (02-20-8)
Ignition System
- 4.6L 2V, 5.4L 2V, Or 6.8L 2V - Spark Plug Thread Repair Procedure - Not Covered Under New Vehicle Limited Warranty (07-21-2)
- WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
Infotainment
- "CANADA Only" - Map Zoom - Navigation System Will Not Zoom Closer Than A 16 Mile Scale (32 Km) (05-16-8)
- Rear Window Defroster Grid/Integral Antenna Diagnosis And Repair - Terminal Tab Repair (04-24-5)
- Radio - Poor Am Range Reception (03-7-6)
Interior/Exterior Trim
- Body - Trim - Carpet Pulling Out Of Trim (04-1-4)
Lubrication System
- Engine Oil Level Indicator Markings - Reports Of Low Oil Level (03-8-3)
Manual Steering
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- 4.6L 2V, 5.4L 2V, Or 6.8L 2V - Spark Plug Thread Repair Procedure - Not Covered Under New Vehicle Limited Warranty (07-21-2)
- Identifying The Correct Replacement Head Gasket For Certain Remanufactured Engines - Service Tip (06-18-16)
- Chirp Noise From FEAD Area When A/C Compressor Engages (05-20-9)
- Engine Knock During Initial Cold Start (04-2-1)
- Engine - Romeo Built 4.6L 2V - Tick Noise From Engine (03-25-6)
- Engine Vibration At Idle &/Or Low Speeds - Cold Engine (03-12-4)
- Engine Oil Level Indicator Markings - Reports Of Low Oil Level (03-8-3)
- Engine - Straightedge Procedure For Checking Cylinder Head & Block Flatness (02-21-13)
- New Gasket Remover/Cleaner Service Tips For Aluminum Heads & Blocks (02-11-4)
Mirrors
- Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
- Ford Interior Mirror Job Aid (G0000001)
- Exterior Mirror Glass And Motor Replacement (98-9-14)
Paint & Coatings
- Aluminum Panel Corrosion (17-0062)
- Plastic Bumper/Fascia Parts - Preparation Procedures - Service Tips (03-10-1)
- Approved Paint Materials For Warranty Repairs (02-16-7)
- Paint - New Polishing Products - Service Procedures (02-16-3)
Passive Restraints
- Driver Or Passenger Power Seat Binding - Grinding Or Clicking Noise During Power Seat Operation (05-21-12)
- Safety Belt Retraction Speed (05-16-11)
- Safety Belt Web Stop Button Service (05-3-10)
Restraints Control Systems
- RCM Fault Reporting Using DTCS And Bit-Mapped Parameter Identifiers (PIDS) - Service Tips (07-7-8)
- DTC B1342 - Restraint Control Module - Diagnostic Service Tip (04-25-15)
Seats
- Driver Or Passenger Power Seat Binding - Grinding Or Clicking Noise During Power Seat Operation (05-21-12)
- Safety Belt Retraction Speed (05-16-11)
- Safety Belt Web Stop Button Service (05-3-10)
Starter
- Battery Service - Operation Of Battery Eye - Charging Service Tips (07-5-8)
Steering Column
- Leather-Wrapped Steering Wheel - Leather Coming Loose (07-4-3)
Steering Control Systems
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
Steering Gear
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
System
- 4.6L 2V, 5.4L 2V, Or 6.8L 2V - Spark Plug Thread Repair Procedure - Not Covered Under New Vehicle Limited Warranty (07-21-2)
- WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
- Mil On And DTC P0460 In Memory (05-11-3)
- MAF Diagnostic Service Tip - Vehicles Equipped With EGR System Module (ESM) (05-3-1)
- General Pcm Programming Procedures (04-24-14)
- Malfunction Indicator Lamp (Mil) Illuminated - System Lean Diagnostic Trouble Codes - DTC'S - Service Tips (04-17-4)
- Diagnostic Trouble Code DTC P0442 (04-15-15)
- Charging System - DTC P1246 - Battery Warning Lamp Illuminated (03-24-4)
- Mil With DTC'S P0442, P0455, P0456, P0457, P1442 Or Check Fuel Cap Lamp With DTC P0457 (03-9-8)
- Engine Cooling Fan Inoperative - DTC P0480 (03-19-1)
- Engine Vibration At Idle &/Or Low Speeds - Cold Engine (03-12-4)
- 3.0L/3.8L/4.6L - Fuel Pressure Relief Valve (SCHRADER Valve) Discontinued (02-8-4)
Transmission Control Systems
- Inadvertent Disabling Of Brake Shift Interlock (99-13-9)
Warning Systems
- Parking Aid System Inoperative - DTC C1983 (05-26-12)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)
- Erratic Climate Control Blower Motor Operation During Braking, Turning Or Acceleration (04-14-11)