Technical Service Bulletins

Accessories Control Systems
- "CANADA Only" - Map Zoom - Navigation System Will Not Zoom Closer Than A 16 Mile Scale (32 Km) (05-16-8)
- Climate Controlled Seats Turning Off Shortly After Initialization - DTC'S B2729, B2730, B2731 (04-4-2)
Accessory Drive Belts
- 3.9L Accessory Drive Belt Snap Noise In Freezing Temperatures (08-16-5)
Air Bag, SRS
- RCM Fault Reporting Using DTCS And Bit-Mapped Parameter Identifiers (PIDS) - Service Tips (07-7-8)
Anti-Lock Brakes
- Diagnostic Trouble Code - DTC C1145 And/Or C1155 Stored In Anti-Lock Brake System (Abs) Module (04-22-13)
Anti-Theft Systems
- Keypad Diagnostics - Dealer Installed Accessory (06-15-8)
- Remote Keyless Entry (RKE) - Service Tips (03-18-1)
Automatic Trans
- 5R55S/5R55N/5R55W Transmissions - Shift Concerns, Loss Of 2ND, 3RD And 5TH Gear, Incorrect Ratio DTC'S - Procedure To Inspect And Repair Servo Pin Bore Wear (09-12-12)
- Delayed Or Harsh Reverse Engagements - 5R55S Transmission - Vehicles Built Prior To 09/23/2004 (05-6-12)
- 3.0L With 5R55S - Harsh 2-3 Upshifts 20-50 Mph (32-80 Km/H) Or Harsh Coasting Downshifts 10-15 Mph (16-24 Km/H) (05-19-6)
Auxiliary Emission Control Systems
- Wrench Light On With Both DTC P2106 And P2135 - Vehicles Built 11/29/2004 And Prior (05-9-15)
- Rough Idle Or Mil Lamp On (05-6-5)
- MAF Diagnostic Service Tip - Vehicles Equipped With EGR System Module (ESM) (05-3-1)
- General Pcm Programming Procedures (04-24-14)
- Malfunction Indicator Lamp (Mil) Illuminated - System Lean Diagnostic Trouble Codes - DTC'S - Service Tips (04-17-4)
Body Electrical
- Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)
Body Interior
- "CANADA Only" - Map Zoom - Navigation System Will Not Zoom Closer Than A 16 Mile Scale (32 Km) (05-16-8)
- Climate Controlled Seats Turning Off Shortly After Initialization - DTC'S B2729, B2730, B2731 (04-4-2)
Brakes Control Systems
- Diagnostic Trouble Code - DTC C1145 And/Or C1155 Stored In Anti-Lock Brake System (Abs) Module (04-22-13)
Charging Systems
- Stuck High Voltage Charge Cord Information Sheet (G0000127)
Collision/Avoidance
- Parking Aid System Inoperative - DTC C1983 (06-25-13)
Cooling System (Mechanical)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
Engine Control Systems
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-8-1)
- 3.0L - Vacuum Leakage Noise And Mil On With Lean Codes (08-12-4)
- WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
- Wrench Light On With Both DTC P2106 And P2135 - Vehicles Built 11/29/2004 And Prior (05-9-15)
- 3.0L - Stumble And/Or Inductive Backfire (05-9-7)
- Rough Idle Or Mil Lamp On (05-6-5)
- General Pcm Programming Procedures (04-24-14)
- Malfunction Indicator Lamp (Mil) Illuminated - System Lean Diagnostic Trouble Codes - DTC'S - Service Tips (04-17-4)
Entertainment Systems
- Rear Window Defroster Grid/Integral Antenna Diagnosis And Repair - Terminal Tab Repair (04-24-5)
- Am Radio Interference - Vehicles Produced Prior To 12/01/2003 (04-1-7)
Exhaust
- Various Vehicles - Catalytic Converter Concern Analysis (22-7009)
Exterior Body Panels
- Aluminum Panel Corrosion (17-0062)
Exterior Lights
- Moisture In Reverse Lamp (04-15-7)
Frames, Subframes & Crossmembers
- Aluminum Panel Corrosion (17-0062)
Fuel System
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-8-1)
- 3.0L - Vacuum Leakage Noise And Mil On With Lean Codes (08-12-4)
Fuses & Circuit Breakers
- Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)
Heated Glass/Defoggers
- Rear Window Defroster Grid/Integral Antenna Diagnosis And Repair - Terminal Tab Repair (04-24-5)
HVAC Control Systems
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
Ignition System
- WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
Infotainment
- "CANADA Only" - Map Zoom - Navigation System Will Not Zoom Closer Than A 16 Mile Scale (32 Km) (05-16-8)
- Rear Window Defroster Grid/Integral Antenna Diagnosis And Repair - Terminal Tab Repair (04-24-5)
Interior/Exterior Trim
- Interior Plastic Trim - Paint-To-Match And Repair - Interior Spray Paint And Adhesion Promoter Usage Instructions (05-9-3)
- Headliner Falling/Unattached In Rear (03-17-2)
Manual Steering
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
- Steering Gear Squeak When Turning The Steering Wheel During Low Speed Parking Maneuvers (06-5-16)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-8-1)
- 3.9L Accessory Drive Belt Snap Noise In Freezing Temperatures (08-16-5)
- 3.0L - Vacuum Leakage Noise And Mil On With Lean Codes (08-12-4)
- Identifying The Correct Replacement Head Gasket For Certain Remanufactured Engines - Service Tip (06-18-16)
Mirrors
- Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
- Ford Interior Mirror Job Aid (G0000001)
- Exterior Mirror Glass And Motor Replacement (98-9-14)
Paint & Coatings
- Aluminum Panel Corrosion (17-0062)
- Interior Plastic Trim - Paint-To-Match And Repair - Interior Spray Paint And Adhesion Promoter Usage Instructions (05-9-3)
- Paint - Iron Particle Removal - Industrial Fallout - Acid Rain Neutralization (99-12-10)
Passive Restraints
- Safety Belt Retraction Speed (05-16-11)
- Safety Belt Web Stop Button Service (05-3-10)
Restraints Control Systems
- RCM Fault Reporting Using DTCS And Bit-Mapped Parameter Identifiers (PIDS) - Service Tips (07-7-8)
Seats
- Safety Belt Retraction Speed (05-16-11)
- Safety Belt Web Stop Button Service (05-3-10)
- Climate Controlled Seats Turning Off Shortly After Initialization - DTC'S B2729, B2730, B2731 (04-4-2)
Starter
- Battery Service - Operation Of Battery Eye - Charging Service Tips (07-5-8)
- Battery Drain Diagnosis - Service Tips (05-22-9)
Steering Column
- Leather-Wrapped Steering Wheel - Leather Coming Loose (07-4-3)
Steering Control Systems
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
- Steering Gear Squeak When Turning The Steering Wheel During Low Speed Parking Maneuvers (06-5-16)
Steering Gear
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
- Steering Gear Squeak When Turning The Steering Wheel During Low Speed Parking Maneuvers (06-5-16)
System
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-8-1)
- 3.0L - Vacuum Leakage Noise And Mil On With Lean Codes (08-12-4)
- WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
- Wrench Light On With Both DTC P2106 And P2135 - Vehicles Built 11/29/2004 And Prior (05-9-15)
- 3.0L - Stumble And/Or Inductive Backfire (05-9-7)
- Rough Idle Or Mil Lamp On (05-6-5)
- MAF Diagnostic Service Tip - Vehicles Equipped With EGR System Module (ESM) (05-3-1)
- General Pcm Programming Procedures (04-24-14)
- Malfunction Indicator Lamp (Mil) Illuminated - System Lean Diagnostic Trouble Codes - DTC'S - Service Tips (04-17-4)
Transmission Control Systems
- 5R55S/5R55N/5R55W Transmissions - Shift Concerns, Loss Of 2ND, 3RD And 5TH Gear, Incorrect Ratio DTC'S - Procedure To Inspect And Repair Servo Pin Bore Wear (09-12-12)
- 3.0L With 5R55S - Harsh 2-3 Upshifts 20-50 Mph (32-80 Km/H) Or Harsh Coasting Downshifts 10-15 Mph (16-24 Km/H) (05-19-6)
- 5R55S - Harsh 2-3 Upshift (04-13-2)
Warning Systems
- Parking Aid System Inoperative - DTC C1983 (05-26-12)
Wiper/Washer Systems
- Am Radio Interference - Vehicles Produced Prior To 12/01/2003 (04-1-7)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)