Technical Service Bulletins
- Accessories Control Systems
- Climate Control Seat Heat Function Inoperative - Vehicles Built Prior To 3/24/2005 (07-16-8)
- Rear Wiper Inoperative - Possible Battery Drain (07-10-13)
- Discharged Batteries - Vehicles In Storage/Limited Usage (07-5-13)
- Battery Drain - Vehicles Built Prior To 3/24/2006 (06-8-13)
- "CANADA Only" - Map Zoom - Navigation System Will Not Zoom Closer Than A 16 Mile Scale (32 Km) (05-16-8)
- Deployable Running Boards Diagnostic Jumper Harness (05-13-12)
- "Check Park Assist" Displayed In Message Center (05-9-12)
- Diagnostic Trouble Code - DTC C1983 - Inoperative Parking Aid System (05-4-1)
- Air Bag, SRS
- Anti-Theft Systems
- Automatic Trans
- 4WD - Grinding/Clicking/Ratcheting Noise From Front Wheel Area (24-2188)
- Torque-On-Demand (Tod) Transfer Case - Grinding/Clicking/Ratcheting Noise From Front Wheel Area (20-2307)
- Hard Start, Low Power At 3500 Rpm, Mil On P0340, P0344, P0172, P0175 And Expedition Only - Idles Too Fast Cold (06-13-9)
- Floor Mounted Shifter Stuck In Park (06-2-3)
- 6HP26 6-Speed Automatic Transmission - Service Tips (04-19-12)
- Auxiliary Emission Control Systems
- Hard Start, Low Power At 3500 Rpm, Mil On P0340, P0344, P0172, P0175 And Expedition Only - Idles Too Fast Cold (06-13-9)
- Mil On With DTC P0351-P0358 - Lack Of Upshift (05-23-1)
- Wrench Light On With Both DTC P2106 And P2135 - Vehicles Built 11/29/2004 And Prior (05-9-15)
- Mil On With DTC P061B And P2106 After Cold Start And Rapid Transmission Gear (05-6-3)
- General Pcm Programming Procedures (04-24-14)
- Axle Shafts
- Body Electrical
- Body Interior
- Climate Control Seat Heat Function Inoperative - Vehicles Built Prior To 3/24/2005 (07-16-8)
- "CANADA Only" - Map Zoom - Navigation System Will Not Zoom Closer Than A 16 Mile Scale (32 Km) (05-16-8)
- Deployable Running Boards Diagnostic Jumper Harness (05-13-12)
- "Check Park Assist" Displayed In Message Center (05-9-12)
- Diagnostic Trouble Code - DTC C1983 - Inoperative Parking Aid System (05-4-1)
- Brakes Control Systems
- Charging Systems
- Collision/Avoidance
- Cooling System (Mechanical)
- Cruise Control Systems
- Differentials & Drive Axles
- 4 Wheel Drive/All Wheel Drive - With Control TRAC - Shudder On Acceleration/Deceleration Or Binding On Slow Turns (08-21-11)
- Unitized Seal Diagnosis - Leak / Grease Oil Separation - Axle Bearing Seal 8.8 Ifs, 8.8 IRS, And 9.75 IRS Axles (08-19-3)
- Rear Axle Noise Repair (05-6-18)
- Clunk/Grind/Thump Noise From Rear Of Vehicle When Transmission Is Shifted (05-16-1)
- Engine Control Systems
- 5.4L 3V - Intermittent Rattle Noise While Driving/Rough Idle When Engine Is At Operating Temperature (14-0114)
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-8-1)
- 5.4L 3V With P030X And/Or P0316 Accompanied By Spark Knock (08-25-4)
- Discharged Batteries - Vehicles In Storage/Limited Usage (07-5-13)
- DTC P0340/P0344/P0345/P0349 - 4.6L 3V And 5.4L 3V (06-2-9)
- Hard Start, Low Power At 3500 Rpm, Mil On P0340, P0344, P0172, P0175 And Expedition Only - Idles Too Fast Cold (06-13-9)
- Mil On With DTC P0351-P0358 - Lack Of Upshift (05-23-1)
- WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
- Wrench Light On With Both DTC P2106 And P2135 - Vehicles Built 11/29/2004 And Prior (05-9-15)
- 5.4L 3-Valve - Hard Start/Long Crank, Rough Idle, Engine Idle Misfire - Mil - DTCS P0300 Through P0308, P0171, P0172, P0174, P0175, P0316, P2195, P2196, P2197, P2198 (05-13-4)
- Mil On With DTC P061B And P2106 After Cold Start And Rapid Transmission Gear (05-6-3)
- General Pcm Programming Procedures (04-24-14)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- Headlights
- Heated Glass/Defoggers
- HVAC Control Systems
- White Flakes Or Powder Coming From A/C Vents (11-9-6)
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
- Hoot Or Whistle Noise From Rear A/C System (06-10-4)
- Insufficient A/C Cooling (06-10-3)
- A/C Condensation Leaking Onto The Passenger Front Floor (05-20-7)
- Water Leak Into Passenger Compartment Floor And/Or Rattle Noise From Dash (05-8-7)
- Ignition System
- Infotainment
- Interior/Exterior Trim
- Paint Bubbles Around Liftgate Trim (07-2-9)
- Lower Door Cladding Rubbing On Front Fender (06-14-18)
- Deployable Running Board Squeal/Squeak Noise When Deploying Or Stowing (05-22-15)
- Deployable Running Boards Diagnostic Jumper Harness (05-13-12)
- Interior Plastic Trim - Paint-To-Match And Repair - Interior Spray Paint And Adhesion Promoter Usage Instructions (05-9-3)
- Water Leak Into Passenger Compartment Floor And/Or Rattle Noise From Dash (05-8-7)
- Manual Steering
- Mechanical
- 3V Cam Phaser (G0000009)
- 5.4L 3V - Intermittent Rattle Noise While Driving/Rough Idle When Engine Is At Operating Temperature (14-0114)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-8-1)
- Spark Plug Removal Instructions - 4.6L 3V/5.4L 3V/6.8L 3V (08-7-6)
- Ticking And / Or Knocking Noise / Startup Rattle From Engine - 4.6L / 5.4L 3V (06-4-7)
- Mechanical - Hydraulic
- Mirrors
- Paint & Coatings
- Passive Restraints
- Rear Suspension
- Restraints Control Systems
- Seats
- Climate Control Seat Heat Function Inoperative - Vehicles Built Prior To 3/24/2005 (07-16-8)
- DTC B272-C/D For The Dual Climate Control Seat Module (06-13-6)
- Drivers Front Power Seat Will Not Move Forward Or Rearward (05-9-4)
- Safety Belt Retraction Speed (05-16-11)
- Inability To Disable The Supplemental Safety Belt Warning Chime (BELTMINDER) (05-9-17)
- Starter
- Rear Wiper Inoperative - Possible Battery Drain (07-10-13)
- Battery Service - Operation Of Battery Eye - Charging Service Tips (07-5-8)
- Discharged Batteries - Vehicles In Storage/Limited Usage (07-5-13)
- No Crank / Starter Terminal Fatigue (06-19-14)
- Battery Drain - Vehicles Built Prior To 3/24/2006 (06-8-13)
- Steering Column
- Steering Control Systems
- Steering Gear
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- System
- 5.4L 3V - Intermittent Rattle Noise While Driving/Rough Idle When Engine Is At Operating Temperature (14-0114)
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-8-1)
- 5.4L 3V With P030X And/Or P0316 Accompanied By Spark Knock (08-25-4)
- Spark Plug Removal Instructions - 4.6L 3V/5.4L 3V/6.8L 3V (08-7-6)
- Discharged Batteries - Vehicles In Storage/Limited Usage (07-5-13)
- DTC P0340/P0344/P0345/P0349 - 4.6L 3V And 5.4L 3V (06-2-9)
- No Crank / Starter Terminal Fatigue (06-19-14)
- Hard Start, Low Power At 3500 Rpm, Mil On P0340, P0344, P0172, P0175 And Expedition Only - Idles Too Fast Cold (06-13-9)
- Mil On With DTC P0351-P0358 - Lack Of Upshift (05-23-1)
- WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
- Wrench Light On With Both DTC P2106 And P2135 - Vehicles Built 11/29/2004 And Prior (05-9-15)
- 5.4L 3-Valve - Hard Start/Long Crank, Rough Idle, Engine Idle Misfire - Mil - DTCS P0300 Through P0308, P0171, P0172, P0174, P0175, P0316, P2195, P2196, P2197, P2198 (05-13-4)
- 5.4L 3V - Mil On, Misfire DTCS, Spark Knock (05-10-15)
- Mil On With DTC P061B And P2106 After Cold Start And Rapid Transmission Gear (05-6-3)
- General Pcm Programming Procedures (04-24-14)
- Transfer Case
- Transmission Control Systems
- Warning Systems
- Wheels & Tire System
- 4WD - Grinding/Clicking/Ratcheting Noise From Front Wheel Area (24-2188)
- Vibration Diagnostics - Steering Wheel Nibble - Tire Wheel RUNOUT And Balance (08-24-2)
- 4 Wheel Drive/All Wheel Drive - With Control TRAC - Shudder On Acceleration/Deceleration Or Binding On Slow Turns (08-21-11)
- Low Tire Indicator On - TPMS System Sensor Wake Up (06-3-7)
- Steering Wheel Nibble At 65 Mph (105 Km/H) Or Higher (05-7-2)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)