Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups
Common Specs & Procedures
DTC Index
Electrical Component Locations
Fluids
Technical Bulletins
Tire Fitment
Wiring Diagrams- OEM Connector End Views (2.5L)
- Connector End Views
- TP Sensor Connector End View (Protege 1.5L & 626)
- Joint Box JB02, JB-03, JB-04 Connector End View
- EVAP System Leak Detection Pump Connector End View (MPV)
- A/C Amplifier And Climate Control Unit Connector End View
- PCM Connector End View
- Ignition Coil Connector End View (Miata & Protege)
- ABS/TCS HU/CM Connector End View
- Left Rear HO2S Connector End View
- Heated Seat Relay Connector End View (Millenia)
- Left Front HO2S Sensor Connector End View
- Generator Connector End View
- ABS H/U Connector End View
- Transmission Range Switch Connector End View (LJ4A-EL)
- Solenoid Valve Connector End View
- Magnetic Clutch Connector End View
- Instrument Cluster Connector End View (Blue 18-pin)
- Condenser Fan Relay No. 1 Connector End View
- Fuel Gauge Sender Unit Connector End View
- Clockspring Connector End View
- IAT Sensor Connector End View
- Throttle Position (TP) Sensor Connector End View
- Relay (Five Terminal Type A Connector) Connector End View
- Side Air Bag Sensor Connector End View
- IAT Sensor Connector End View (Protege 2.0L)
- HO2S Connector End View (Protege)
- Power Window Switch Connector End View
- Engine Coolant Temperature (ECT) Sensor Connector End View
- SAS Control Module Connector End View
- Instrument Cluster Harness Connector End View
- Sunroof Motor Connector End View
- Door Lock Switch Connector End View
- Power Window Subswitch Connector End View
- CMP Sensor Connector End View
- Right Rear HO2S Sensor Connector End View
- Seat Back Warmer Connector End View
- TCS OFF Switch Connector End View
- Relay (Four Terminal Type D Connector) Connector End View
- MAF Sensor Connector End View
- Fuel Pump Relay Connector End View (626)
- Power Window Connector End View
- Left Front HO2S Connector End View
- Multifunction Switch Connector End View (Millenia)
- Sunroof Switch Connector End View
- Relay (Five Terminal Type B Connector) Connector End View
- Right Rear HO2S Connector End View
- EVAP System Leak Detection Pump Connector End View -- MPV
- Rear Tilt Motor Connector End View
- Relay (Four Terminal Type C Connector) Connector End View
- Trunk Lid Opener Relay Connector End View
- Fuel Tank Pressure Sensor Connector End View
- Fuel Pump Relay Connector End View (Miata)
- Right Front HO2S Connector End View
- PCM Connector End View (Millenia 2.5L)
- Climate Control Unit Connector End View
- TCM Component Connector End View (1995 Millenia, MX-3, MX-6 & 626)
- Hazard Switch Connector End View (MPV)
- Lumbar Support Motor Connector End View
- CMP Sensor Connector End View (MPV)
- Recliner Motor Connector End View
- Relay (Eight Terminal Connector) Connector End View
- Brake Switch And Noise Filter Connector End View
- Main Relay Connector End View (Except MPV & 626)
- ABS HU/CM Connector & SST Connector End View
- PCM Connector End View (Millenia S 2.3L)
- Power MOS FET Connector End View
- Right Front HO2S Sensor Connector End View
- Transmission Range Switch Connector End View (GF4A-EL)
- Variable Resonance Induction System (VRIS) Solenoid Valve No. 1 Connector End View
- Seat Cushion Warmer Connector End View
- CKP Sensor Connector End View (Protege & Protege5)
- Front Tilt Motor Connector End View
- Key Interlock Resistor Connector End View
- Idle Air Control Valve Connector End View
- Shift Lock Solenoid Connector End View
- Key Interlock Solenoid Connector End View
- Cooling Fan Relay No. 1 & Condenser Fan Relay No. 2 Connector End View
- Starter And Starter Relay Connector End View
- Knock Sensor Connector End View
- Hazard Switch Connector End View (Millenia)
- Intermittent Relay Connector End View (Millenia)
- Fuel Injector Wiring Harness Connector End View (Millenia)
- Slide Motor Connector End View
- Fuel Pump Relay Connector End View (Mazda6 & MPV)
- Seat Warmer Switch Connector End View
- Power Steering Pressure Switch Connector End View
- Keyless Control Module Connector End View
- CPU Connector End View (Millenia)
- Main/Fuel Pump Relay Connector End View
- Door Lock Timer Unit Connector End View
- Relay (Four Terminal Type A Connector) Connector End View
- Fuel Tank Unit 4-Pin Harness Connector End View
- Power Seat Control Switch Connector & Motor Connector End View (Millenia)
- EGR Boost Sensor Connector End View
- Ignition Switch Connector End View (Millenia, MX-5 Miata & 626)
- Variable Resonance Induction System (VRIS) Solenoid Valve No. 2 Connector End View
- Cruise Control Module Connector End View (MPV & Protege - 1.8L)
- Washer Motor Connector End View
- PRC Solenoid Valve Connector End View
- EGR Valve Connector End View (Protege)
- Lumbar Support Switch Connector End View
- CKP Sensor Connector End View
- Output Speed Sensor Connector End View
- Driver's & Passenger's Side Heated Seat Switch Connector End View (MIllenia)
- TP Sensor Connector End View (Millenia & MPV)
- Throttle Position Sensor Connector End View
- Fuel Pump Resistor & Relay Connector End View (Millenia 2.3L)
- Information Display Connector End View
- Main Switch Connector End View
- Left Rear HO2S Sensor Connector End View
- HO2S Connector End View (Millenia 2.5L)
- Brake Switch Connector End View
- Flasher Unit Connector End View (Millenia, MPV, MX-5 Miata, Protege)
- EGR Boost Sensor 3-Pin Connector End View
- Transaxle Harness Connector End View
- Relay (Four Terminal Type B Connector) Connector End View
- EGR Valve Position Sensor Connector End View
- Wiper Motor Connector End View (Millenia, MX-5 Miata & Protege)
- ECT Sensor Connector End View (Protege)
- Connector End Views
- OEM Wiring Diagram
- General Information
- Ground Point (Kl)
- Ground Point (KJ)
- Electrical Wiring Schematic
- Engine-Related System
- Charging System (Kl)/Starting System (Kl)
- Charging System (KJ)/Starting System (KJ)
- Engine Control System (Kl)/EC-At Control System (Kl)/Ignition System (Kl)
- Engine Control System (KJ)/Ignition System (KJ)
- Fuel Control System (Kl)
- Fuel Control System (KJ)
- Cooling Fan System (KJ)
- Instrument Cluster
- Information Display
- Windshield Wiper And Washer
- Daytime Running Light (DRL)/Headlight)
- Front Fog Light
- Front Side Marker Light/License Plate Light/Parking Light/Taillight
- Turn And Hazard Warning Light
- Back-Up Light/Brake Light/High-Mount Brake Light
- Horn
- Condenser Fan System
- Heater And Air Conditioner
- EC-At Control System (KJ)
- Key Interlock System/Shift-Lock System
- Cigarette Lighter/Rear Window Defroster
- Illumination Light
- Courtesy Light/Interior Light/Map Light/Rear Personal Light/Trunk Compartment Light/Vanity Mirror Illumination
- CPU/Theft-Deterrent System
- Keyless Control System
- AUDI System (Without BOSE System)
- AUDI System (With BOSE System)
- Power Window System
- Power Door Lock System
- Heated Outside Mirror/Power Outside Mirror
- Sliding Sunroof
- Auto-Tilt Steering Column
- Antilock Brake System (Kl)/Traction Control System (Kl)
- Antilock Brake System (KJ)/Traction Control System (KJ)
- Power Seat
- Seat Warmer
- Cruise Control System
- Air Bag System Service Cautions/Service Warnings
- Air Bag System
- Accessory Socket/Fuel-Filler Lid Opener/Trunk Lid Opener
- Data Link Connector
- Common Connector List
- Parts Index
- System Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Body Computer
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Electronic Power Steering
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Top/Sunroof
- Power Windows
- Radio
- Shift Interlocks
- Starting/Charging
- Supplemental Restraints
- Transmission
- Trunk, Tailgate, Fuel Door
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- OEM Connector End Views (2.5L)
- Accessories & Equipment
- Anti-Theft Systems
- Door Locks & Anti-Theft System
- Description & Operation
- Component Locations
- Servicing
- Programming
- Component Tests
- Removal & Installation
- Wiring Diagrams
- Door Locks & Anti-Theft System
- Communication Devices
- Cruise Control Systems
- Gauges & Instrument Panels
- Heated Glass/Defoggers
- Power Mirrors
- Description & Operation
- Symptom Tests
- Removal & Installation
- Wiring Diagrams
- Power Seats
- Description & Operation
- Component Tests
- Removal & Installation
- Notes
- Front Seat Removal/Installation
- Front Seat Disassembly/Assembly
- Rear Seat Removal/Installation
- Rear Seat Disassembly/Assembly
- Front Tilt Motor Inspection
- Rear Tilt Motor Inspection
- Recliner Motor Inspection
- Slide Motor Inspection
- Lumbar Support Motor Inspection
- Lumbar Support Switch Removal/Installation
- Lumbar Support Switch Inspection
- Power Seat Switch Inspection
- Seat Back Warmer Inspection
- Seat Cushion Warmer Inspection
- Seat Warmer Switch Removal/Installation
- Seat Warmer Switch Inspection
- Seat Warmer Relay Removal/Installation
- Wiring Diagrams
- Steering Column Switches
- Window Motors & Regulators
- Power Windows
- Wiper/Washer Systems
- Anti-Theft Systems
- Body & Frame
- Door Locks & Anti-Theft System
- Description & Operation
- Component Locations
- Servicing
- Programming
- Component Tests
- Removal & Installation
- Wiring Diagrams
- Power Mirrors
- Description & Operation
- Symptom Tests
- Removal & Installation
- Wiring Diagrams
- Power Seats
- Description & Operation
- Component Tests
- Removal & Installation
- Notes
- Front Seat Removal/Installation
- Front Seat Disassembly/Assembly
- Rear Seat Removal/Installation
- Rear Seat Disassembly/Assembly
- Front Tilt Motor Inspection
- Rear Tilt Motor Inspection
- Recliner Motor Inspection
- Slide Motor Inspection
- Lumbar Support Motor Inspection
- Lumbar Support Switch Removal/Installation
- Lumbar Support Switch Inspection
- Power Seat Switch Inspection
- Seat Back Warmer Inspection
- Seat Cushion Warmer Inspection
- Seat Warmer Switch Removal/Installation
- Seat Warmer Switch Inspection
- Seat Warmer Relay Removal/Installation
- Wiring Diagrams
- Sun Roof/T-Top/Convertible Top
- Power Sun Roofs
- Sliding Sunroof Location Index
- Glass Panel Adjustment
- Sunroof Unit Removal/Installation
- Sunroof Unit Disassembly/Assembly
- Sunroof Motor Inspection
- Sunroof Switch Inspection
- Headliner Removal/Installation
- A-Pillar Trim Removal/Installation
- B-Pillar Upper Trim Removal/Installation
- B-Pillar Lower Trim Removal/Installation
- C-Pillar Trim Removal/Installation
- Wiring Diagrams
- Power Sun Roofs
- Power Windows
- Door Locks & Anti-Theft System
- Brakes
- Anti-Lock Brakes
- Antilock Brake System
- On-Board Diagnostic (Abs)
- Abs System Diagram
- Abs On-Board Diagnosis
- DTC C1145 (11), C1155 (12), C1165 (13) & C1175 (14): Abs Wheel Speed Sensor
- DTC C1148 (41), C1158 (42), C1168 (43), C1178 (44), C1233 (46), C1234 (45), C1235 (47) & C1236 (48): Abs Wheel Speed Sensor/Sensor Rotor
- DTC C1194 (24), C1198 (25), C1210 (22), C1214 (23), C1242 (28), C1246 (26), C1250 (29) & C1254 (27): Pressure Reduction Valve & Pressure Retention Valve
- DTC C1140 (30): Abs HU/Cm (Pump)
- DTC C1510 (32), C1511 (33), C1512 (34) & C1513 (35): Solenoid Valve, Abs Motor Or Wheel Speed Sensor/Sensor Rotor
- DTC C1186 (51) & C1266 (52): Fail-Safe Relay
- DTC C1095 (54) & C1096 (53): Motor Relay, Abs Motor
- DTC B1342 (61): Abs/TCS HU/Cm (With TCS) Or Abs HU/Cm (Without TCS) (Cm)
- DTC B1318 (63): Abs/TCS HU/Cm (With TCS) Or Abs HU/Cm (Without TCS) Power Supply
- DTC C1117 (17): Engine Control System, Engine Speed Signal Line
- DTC C1118 (82): Engine Control System, Torque Reduction Request Signal Line
- DTC C1119 (83): Torque Reduction Inhibit Signal Line
- DTC P1248 (84): High Air Charging Pressure Zone Signal Line
- DTC U2021 (87): Engine Coolant Temperature Is 0°C (32°F) Or Less
- Symptom Troubleshooting [Abs]
- Abs System Diagram
- Foreword
- Precaution
- Symptom Troubleshooting
- No.1 Abs Warning Light Stays On (Without TCS)
- No.2 Abs Warning Light Does Not Illuminate (Without TCS)
- No.3 Brake System Warning Light Stays On (Without TCS)
- No.4 Brake System Warning Light Does Not Illuminate (Without TCS)
- No.5 Brake System Malfunction (Without TCS)
- No.2 Abs Warning Light Does Not Illuminate (With TCS)
- No.3 Brake System Warning Light Stays On (With TCS)
- No.4 Brake System Warning Light Does Not Illuminate (With TCS)
- No.5 Abs Warning Light, Brake System Warning Light, TCS Indicator Light And TCS Off Light Do Not Illuminate (With TCS)
- No.6 TCS Indicator Light Does Not Illuminate (With TCS)
- No.7 TCS Off Light Does Not Illuminate (With TCS)
- No.8 TCS Indicator Light Stays On (With TCS)
- No.9 TCS Off Light Stays On (With TCS)
- No.10 TCS Operates Frequently (With TCS)
- No.11 TCS Does Not Operate Correctly (With TCS)
- No.12 Brake And TCS System Malfunction (With TCS)
- Traction Control System
- Mechanical - Hydraulic
- Disc
- Description & Operation
- Bleeding Brake System
- Adjustments
- Component Tests
- Removal & Installation
- Overhaul
- Torque Specifications
- Disc Brake Specifications
- Disc
- Traction Control
- Antilock Brake System
- On-Board Diagnostic (Abs)
- Abs System Diagram
- Abs On-Board Diagnosis
- DTC C1145 (11), C1155 (12), C1165 (13) & C1175 (14): Abs Wheel Speed Sensor
- DTC C1148 (41), C1158 (42), C1168 (43), C1178 (44), C1233 (46), C1234 (45), C1235 (47) & C1236 (48): Abs Wheel Speed Sensor/Sensor Rotor
- DTC C1194 (24), C1198 (25), C1210 (22), C1214 (23), C1242 (28), C1246 (26), C1250 (29) & C1254 (27): Pressure Reduction Valve & Pressure Retention Valve
- DTC C1140 (30): Abs HU/Cm (Pump)
- DTC C1510 (32), C1511 (33), C1512 (34) & C1513 (35): Solenoid Valve, Abs Motor Or Wheel Speed Sensor/Sensor Rotor
- DTC C1186 (51) & C1266 (52): Fail-Safe Relay
- DTC C1095 (54) & C1096 (53): Motor Relay, Abs Motor
- DTC B1342 (61): Abs/TCS HU/Cm (With TCS) Or Abs HU/Cm (Without TCS) (Cm)
- DTC B1318 (63): Abs/TCS HU/Cm (With TCS) Or Abs HU/Cm (Without TCS) Power Supply
- DTC C1117 (17): Engine Control System, Engine Speed Signal Line
- DTC C1118 (82): Engine Control System, Torque Reduction Request Signal Line
- DTC C1119 (83): Torque Reduction Inhibit Signal Line
- DTC P1248 (84): High Air Charging Pressure Zone Signal Line
- DTC U2021 (87): Engine Coolant Temperature Is 0°C (32°F) Or Less
- Symptom Troubleshooting [Abs]
- Abs System Diagram
- Foreword
- Precaution
- Symptom Troubleshooting
- No.1 Abs Warning Light Stays On (Without TCS)
- No.2 Abs Warning Light Does Not Illuminate (Without TCS)
- No.3 Brake System Warning Light Stays On (Without TCS)
- No.4 Brake System Warning Light Does Not Illuminate (Without TCS)
- No.5 Brake System Malfunction (Without TCS)
- No.2 Abs Warning Light Does Not Illuminate (With TCS)
- No.3 Brake System Warning Light Stays On (With TCS)
- No.4 Brake System Warning Light Does Not Illuminate (With TCS)
- No.5 Abs Warning Light, Brake System Warning Light, TCS Indicator Light And TCS Off Light Do Not Illuminate (With TCS)
- No.6 TCS Indicator Light Does Not Illuminate (With TCS)
- No.7 TCS Off Light Does Not Illuminate (With TCS)
- No.8 TCS Indicator Light Stays On (With TCS)
- No.9 TCS Off Light Stays On (With TCS)
- No.10 TCS Operates Frequently (With TCS)
- No.11 TCS Does Not Operate Correctly (With TCS)
- No.12 Brake And TCS System Malfunction (With TCS)
- Traction Control System
- Anti-Lock Brakes
- Drivelines & Axles
- Electrical
- Body Electrical
- OEM Connector End Views (2.5L)
- Connector End Views
- TP Sensor Connector End View (Protege 1.5L & 626)
- Joint Box JB02, JB-03, JB-04 Connector End View
- EVAP System Leak Detection Pump Connector End View (MPV)
- A/C Amplifier And Climate Control Unit Connector End View
- PCM Connector End View
- Ignition Coil Connector End View (Miata & Protege)
- ABS/TCS HU/CM Connector End View
- Left Rear HO2S Connector End View
- Heated Seat Relay Connector End View (Millenia)
- Left Front HO2S Sensor Connector End View
- Generator Connector End View
- ABS H/U Connector End View
- Transmission Range Switch Connector End View (LJ4A-EL)
- Solenoid Valve Connector End View
- Magnetic Clutch Connector End View
- Instrument Cluster Connector End View (Blue 18-pin)
- Condenser Fan Relay No. 1 Connector End View
- Fuel Gauge Sender Unit Connector End View
- Clockspring Connector End View
- IAT Sensor Connector End View
- Throttle Position (TP) Sensor Connector End View
- Relay (Five Terminal Type A Connector) Connector End View
- Side Air Bag Sensor Connector End View
- IAT Sensor Connector End View (Protege 2.0L)
- HO2S Connector End View (Protege)
- Power Window Switch Connector End View
- Engine Coolant Temperature (ECT) Sensor Connector End View
- SAS Control Module Connector End View
- Instrument Cluster Harness Connector End View
- Sunroof Motor Connector End View
- Door Lock Switch Connector End View
- Power Window Subswitch Connector End View
- CMP Sensor Connector End View
- Right Rear HO2S Sensor Connector End View
- Seat Back Warmer Connector End View
- TCS OFF Switch Connector End View
- Relay (Four Terminal Type D Connector) Connector End View
- MAF Sensor Connector End View
- Fuel Pump Relay Connector End View (626)
- Power Window Connector End View
- Left Front HO2S Connector End View
- Multifunction Switch Connector End View (Millenia)
- Sunroof Switch Connector End View
- Relay (Five Terminal Type B Connector) Connector End View
- Right Rear HO2S Connector End View
- EVAP System Leak Detection Pump Connector End View -- MPV
- Rear Tilt Motor Connector End View
- Relay (Four Terminal Type C Connector) Connector End View
- Trunk Lid Opener Relay Connector End View
- Fuel Tank Pressure Sensor Connector End View
- Fuel Pump Relay Connector End View (Miata)
- Right Front HO2S Connector End View
- PCM Connector End View (Millenia 2.5L)
- Climate Control Unit Connector End View
- TCM Component Connector End View (1995 Millenia, MX-3, MX-6 & 626)
- Hazard Switch Connector End View (MPV)
- Lumbar Support Motor Connector End View
- CMP Sensor Connector End View (MPV)
- Recliner Motor Connector End View
- Relay (Eight Terminal Connector) Connector End View
- Brake Switch And Noise Filter Connector End View
- Main Relay Connector End View (Except MPV & 626)
- ABS HU/CM Connector & SST Connector End View
- PCM Connector End View (Millenia S 2.3L)
- Power MOS FET Connector End View
- Right Front HO2S Sensor Connector End View
- Transmission Range Switch Connector End View (GF4A-EL)
- Variable Resonance Induction System (VRIS) Solenoid Valve No. 1 Connector End View
- Seat Cushion Warmer Connector End View
- CKP Sensor Connector End View (Protege & Protege5)
- Front Tilt Motor Connector End View
- Key Interlock Resistor Connector End View
- Idle Air Control Valve Connector End View
- Shift Lock Solenoid Connector End View
- Key Interlock Solenoid Connector End View
- Cooling Fan Relay No. 1 & Condenser Fan Relay No. 2 Connector End View
- Starter And Starter Relay Connector End View
- Knock Sensor Connector End View
- Hazard Switch Connector End View (Millenia)
- Intermittent Relay Connector End View (Millenia)
- Fuel Injector Wiring Harness Connector End View (Millenia)
- Slide Motor Connector End View
- Fuel Pump Relay Connector End View (Mazda6 & MPV)
- Seat Warmer Switch Connector End View
- Power Steering Pressure Switch Connector End View
- Keyless Control Module Connector End View
- CPU Connector End View (Millenia)
- Main/Fuel Pump Relay Connector End View
- Door Lock Timer Unit Connector End View
- Relay (Four Terminal Type A Connector) Connector End View
- Fuel Tank Unit 4-Pin Harness Connector End View
- Power Seat Control Switch Connector & Motor Connector End View (Millenia)
- EGR Boost Sensor Connector End View
- Ignition Switch Connector End View (Millenia, MX-5 Miata & 626)
- Variable Resonance Induction System (VRIS) Solenoid Valve No. 2 Connector End View
- Cruise Control Module Connector End View (MPV & Protege - 1.8L)
- Washer Motor Connector End View
- PRC Solenoid Valve Connector End View
- EGR Valve Connector End View (Protege)
- Lumbar Support Switch Connector End View
- CKP Sensor Connector End View
- Output Speed Sensor Connector End View
- Driver's & Passenger's Side Heated Seat Switch Connector End View (MIllenia)
- TP Sensor Connector End View (Millenia & MPV)
- Throttle Position Sensor Connector End View
- Fuel Pump Resistor & Relay Connector End View (Millenia 2.3L)
- Information Display Connector End View
- Main Switch Connector End View
- Left Rear HO2S Sensor Connector End View
- HO2S Connector End View (Millenia 2.5L)
- Brake Switch Connector End View
- Flasher Unit Connector End View (Millenia, MPV, MX-5 Miata, Protege)
- EGR Boost Sensor 3-Pin Connector End View
- Transaxle Harness Connector End View
- Relay (Four Terminal Type B Connector) Connector End View
- EGR Valve Position Sensor Connector End View
- Wiper Motor Connector End View (Millenia, MX-5 Miata & Protege)
- ECT Sensor Connector End View (Protege)
- Connector End Views
- OEM Connector End Views (2.5L)
- Charging Systems
- Component Locations
- Fuses & Circuit Breakers
- Gauges
- Motors, Switches, Relays
- OEM Connector End Views (2.5L)
- Connector End Views
- TP Sensor Connector End View (Protege 1.5L & 626)
- Joint Box JB02, JB-03, JB-04 Connector End View
- EVAP System Leak Detection Pump Connector End View (MPV)
- A/C Amplifier And Climate Control Unit Connector End View
- PCM Connector End View
- Ignition Coil Connector End View (Miata & Protege)
- ABS/TCS HU/CM Connector End View
- Left Rear HO2S Connector End View
- Heated Seat Relay Connector End View (Millenia)
- Left Front HO2S Sensor Connector End View
- Generator Connector End View
- ABS H/U Connector End View
- Transmission Range Switch Connector End View (LJ4A-EL)
- Solenoid Valve Connector End View
- Magnetic Clutch Connector End View
- Instrument Cluster Connector End View (Blue 18-pin)
- Condenser Fan Relay No. 1 Connector End View
- Fuel Gauge Sender Unit Connector End View
- Clockspring Connector End View
- IAT Sensor Connector End View
- Throttle Position (TP) Sensor Connector End View
- Relay (Five Terminal Type A Connector) Connector End View
- Side Air Bag Sensor Connector End View
- IAT Sensor Connector End View (Protege 2.0L)
- HO2S Connector End View (Protege)
- Power Window Switch Connector End View
- Engine Coolant Temperature (ECT) Sensor Connector End View
- SAS Control Module Connector End View
- Instrument Cluster Harness Connector End View
- Sunroof Motor Connector End View
- Door Lock Switch Connector End View
- Power Window Subswitch Connector End View
- CMP Sensor Connector End View
- Right Rear HO2S Sensor Connector End View
- Seat Back Warmer Connector End View
- TCS OFF Switch Connector End View
- Relay (Four Terminal Type D Connector) Connector End View
- MAF Sensor Connector End View
- Fuel Pump Relay Connector End View (626)
- Power Window Connector End View
- Left Front HO2S Connector End View
- Multifunction Switch Connector End View (Millenia)
- Sunroof Switch Connector End View
- Relay (Five Terminal Type B Connector) Connector End View
- Right Rear HO2S Connector End View
- EVAP System Leak Detection Pump Connector End View -- MPV
- Rear Tilt Motor Connector End View
- Relay (Four Terminal Type C Connector) Connector End View
- Trunk Lid Opener Relay Connector End View
- Fuel Tank Pressure Sensor Connector End View
- Fuel Pump Relay Connector End View (Miata)
- Right Front HO2S Connector End View
- PCM Connector End View (Millenia 2.5L)
- Climate Control Unit Connector End View
- TCM Component Connector End View (1995 Millenia, MX-3, MX-6 & 626)
- Hazard Switch Connector End View (MPV)
- Lumbar Support Motor Connector End View
- CMP Sensor Connector End View (MPV)
- Recliner Motor Connector End View
- Relay (Eight Terminal Connector) Connector End View
- Brake Switch And Noise Filter Connector End View
- Main Relay Connector End View (Except MPV & 626)
- ABS HU/CM Connector & SST Connector End View
- PCM Connector End View (Millenia S 2.3L)
- Power MOS FET Connector End View
- Right Front HO2S Sensor Connector End View
- Transmission Range Switch Connector End View (GF4A-EL)
- Variable Resonance Induction System (VRIS) Solenoid Valve No. 1 Connector End View
- Seat Cushion Warmer Connector End View
- CKP Sensor Connector End View (Protege & Protege5)
- Front Tilt Motor Connector End View
- Key Interlock Resistor Connector End View
- Idle Air Control Valve Connector End View
- Shift Lock Solenoid Connector End View
- Key Interlock Solenoid Connector End View
- Cooling Fan Relay No. 1 & Condenser Fan Relay No. 2 Connector End View
- Starter And Starter Relay Connector End View
- Knock Sensor Connector End View
- Hazard Switch Connector End View (Millenia)
- Intermittent Relay Connector End View (Millenia)
- Fuel Injector Wiring Harness Connector End View (Millenia)
- Slide Motor Connector End View
- Fuel Pump Relay Connector End View (Mazda6 & MPV)
- Seat Warmer Switch Connector End View
- Power Steering Pressure Switch Connector End View
- Keyless Control Module Connector End View
- CPU Connector End View (Millenia)
- Main/Fuel Pump Relay Connector End View
- Door Lock Timer Unit Connector End View
- Relay (Four Terminal Type A Connector) Connector End View
- Fuel Tank Unit 4-Pin Harness Connector End View
- Power Seat Control Switch Connector & Motor Connector End View (Millenia)
- EGR Boost Sensor Connector End View
- Ignition Switch Connector End View (Millenia, MX-5 Miata & 626)
- Variable Resonance Induction System (VRIS) Solenoid Valve No. 2 Connector End View
- Cruise Control Module Connector End View (MPV & Protege - 1.8L)
- Washer Motor Connector End View
- PRC Solenoid Valve Connector End View
- EGR Valve Connector End View (Protege)
- Lumbar Support Switch Connector End View
- CKP Sensor Connector End View
- Output Speed Sensor Connector End View
- Driver's & Passenger's Side Heated Seat Switch Connector End View (MIllenia)
- TP Sensor Connector End View (Millenia & MPV)
- Throttle Position Sensor Connector End View
- Fuel Pump Resistor & Relay Connector End View (Millenia 2.3L)
- Information Display Connector End View
- Main Switch Connector End View
- Left Rear HO2S Sensor Connector End View
- HO2S Connector End View (Millenia 2.5L)
- Brake Switch Connector End View
- Flasher Unit Connector End View (Millenia, MPV, MX-5 Miata, Protege)
- EGR Boost Sensor 3-Pin Connector End View
- Transaxle Harness Connector End View
- Relay (Four Terminal Type B Connector) Connector End View
- EGR Valve Position Sensor Connector End View
- Wiper Motor Connector End View (Millenia, MX-5 Miata & Protege)
- ECT Sensor Connector End View (Protege)
- Connector End Views
- OEM Connector End Views (2.5L)
- Starter
- Wiring Diagrams
- OEM Connector End Views (2.5L)
- Connector End Views
- TP Sensor Connector End View (Protege 1.5L & 626)
- Joint Box JB02, JB-03, JB-04 Connector End View
- EVAP System Leak Detection Pump Connector End View (MPV)
- A/C Amplifier And Climate Control Unit Connector End View
- PCM Connector End View
- Ignition Coil Connector End View (Miata & Protege)
- ABS/TCS HU/CM Connector End View
- Left Rear HO2S Connector End View
- Heated Seat Relay Connector End View (Millenia)
- Left Front HO2S Sensor Connector End View
- Generator Connector End View
- ABS H/U Connector End View
- Transmission Range Switch Connector End View (LJ4A-EL)
- Solenoid Valve Connector End View
- Magnetic Clutch Connector End View
- Instrument Cluster Connector End View (Blue 18-pin)
- Condenser Fan Relay No. 1 Connector End View
- Fuel Gauge Sender Unit Connector End View
- Clockspring Connector End View
- IAT Sensor Connector End View
- Throttle Position (TP) Sensor Connector End View
- Relay (Five Terminal Type A Connector) Connector End View
- Side Air Bag Sensor Connector End View
- IAT Sensor Connector End View (Protege 2.0L)
- HO2S Connector End View (Protege)
- Power Window Switch Connector End View
- Engine Coolant Temperature (ECT) Sensor Connector End View
- SAS Control Module Connector End View
- Instrument Cluster Harness Connector End View
- Sunroof Motor Connector End View
- Door Lock Switch Connector End View
- Power Window Subswitch Connector End View
- CMP Sensor Connector End View
- Right Rear HO2S Sensor Connector End View
- Seat Back Warmer Connector End View
- TCS OFF Switch Connector End View
- Relay (Four Terminal Type D Connector) Connector End View
- MAF Sensor Connector End View
- Fuel Pump Relay Connector End View (626)
- Power Window Connector End View
- Left Front HO2S Connector End View
- Multifunction Switch Connector End View (Millenia)
- Sunroof Switch Connector End View
- Relay (Five Terminal Type B Connector) Connector End View
- Right Rear HO2S Connector End View
- EVAP System Leak Detection Pump Connector End View -- MPV
- Rear Tilt Motor Connector End View
- Relay (Four Terminal Type C Connector) Connector End View
- Trunk Lid Opener Relay Connector End View
- Fuel Tank Pressure Sensor Connector End View
- Fuel Pump Relay Connector End View (Miata)
- Right Front HO2S Connector End View
- PCM Connector End View (Millenia 2.5L)
- Climate Control Unit Connector End View
- TCM Component Connector End View (1995 Millenia, MX-3, MX-6 & 626)
- Hazard Switch Connector End View (MPV)
- Lumbar Support Motor Connector End View
- CMP Sensor Connector End View (MPV)
- Recliner Motor Connector End View
- Relay (Eight Terminal Connector) Connector End View
- Brake Switch And Noise Filter Connector End View
- Main Relay Connector End View (Except MPV & 626)
- ABS HU/CM Connector & SST Connector End View
- PCM Connector End View (Millenia S 2.3L)
- Power MOS FET Connector End View
- Right Front HO2S Sensor Connector End View
- Transmission Range Switch Connector End View (GF4A-EL)
- Variable Resonance Induction System (VRIS) Solenoid Valve No. 1 Connector End View
- Seat Cushion Warmer Connector End View
- CKP Sensor Connector End View (Protege & Protege5)
- Front Tilt Motor Connector End View
- Key Interlock Resistor Connector End View
- Idle Air Control Valve Connector End View
- Shift Lock Solenoid Connector End View
- Key Interlock Solenoid Connector End View
- Cooling Fan Relay No. 1 & Condenser Fan Relay No. 2 Connector End View
- Starter And Starter Relay Connector End View
- Knock Sensor Connector End View
- Hazard Switch Connector End View (Millenia)
- Intermittent Relay Connector End View (Millenia)
- Fuel Injector Wiring Harness Connector End View (Millenia)
- Slide Motor Connector End View
- Fuel Pump Relay Connector End View (Mazda6 & MPV)
- Seat Warmer Switch Connector End View
- Power Steering Pressure Switch Connector End View
- Keyless Control Module Connector End View
- CPU Connector End View (Millenia)
- Main/Fuel Pump Relay Connector End View
- Door Lock Timer Unit Connector End View
- Relay (Four Terminal Type A Connector) Connector End View
- Fuel Tank Unit 4-Pin Harness Connector End View
- Power Seat Control Switch Connector & Motor Connector End View (Millenia)
- EGR Boost Sensor Connector End View
- Ignition Switch Connector End View (Millenia, MX-5 Miata & 626)
- Variable Resonance Induction System (VRIS) Solenoid Valve No. 2 Connector End View
- Cruise Control Module Connector End View (MPV & Protege - 1.8L)
- Washer Motor Connector End View
- PRC Solenoid Valve Connector End View
- EGR Valve Connector End View (Protege)
- Lumbar Support Switch Connector End View
- CKP Sensor Connector End View
- Output Speed Sensor Connector End View
- Driver's & Passenger's Side Heated Seat Switch Connector End View (MIllenia)
- TP Sensor Connector End View (Millenia & MPV)
- Throttle Position Sensor Connector End View
- Fuel Pump Resistor & Relay Connector End View (Millenia 2.3L)
- Information Display Connector End View
- Main Switch Connector End View
- Left Rear HO2S Sensor Connector End View
- HO2S Connector End View (Millenia 2.5L)
- Brake Switch Connector End View
- Flasher Unit Connector End View (Millenia, MPV, MX-5 Miata, Protege)
- EGR Boost Sensor 3-Pin Connector End View
- Transaxle Harness Connector End View
- Relay (Four Terminal Type B Connector) Connector End View
- EGR Valve Position Sensor Connector End View
- Wiper Motor Connector End View (Millenia, MX-5 Miata & Protege)
- ECT Sensor Connector End View (Protege)
- Connector End Views
- OEM Wiring Diagram
- General Information
- Ground Point (Kl)
- Ground Point (KJ)
- Electrical Wiring Schematic
- Engine-Related System
- Charging System (Kl)/Starting System (Kl)
- Charging System (KJ)/Starting System (KJ)
- Engine Control System (Kl)/EC-At Control System (Kl)/Ignition System (Kl)
- Engine Control System (KJ)/Ignition System (KJ)
- Fuel Control System (Kl)
- Fuel Control System (KJ)
- Cooling Fan System (KJ)
- Instrument Cluster
- Information Display
- Windshield Wiper And Washer
- Daytime Running Light (DRL)/Headlight)
- Front Fog Light
- Front Side Marker Light/License Plate Light/Parking Light/Taillight
- Turn And Hazard Warning Light
- Back-Up Light/Brake Light/High-Mount Brake Light
- Horn
- Condenser Fan System
- Heater And Air Conditioner
- EC-At Control System (KJ)
- Key Interlock System/Shift-Lock System
- Cigarette Lighter/Rear Window Defroster
- Illumination Light
- Courtesy Light/Interior Light/Map Light/Rear Personal Light/Trunk Compartment Light/Vanity Mirror Illumination
- CPU/Theft-Deterrent System
- Keyless Control System
- AUDI System (Without BOSE System)
- AUDI System (With BOSE System)
- Power Window System
- Power Door Lock System
- Heated Outside Mirror/Power Outside Mirror
- Sliding Sunroof
- Auto-Tilt Steering Column
- Antilock Brake System (Kl)/Traction Control System (Kl)
- Antilock Brake System (KJ)/Traction Control System (KJ)
- Power Seat
- Seat Warmer
- Cruise Control System
- Air Bag System Service Cautions/Service Warnings
- Air Bag System
- Accessory Socket/Fuel-Filler Lid Opener/Trunk Lid Opener
- Data Link Connector
- Common Connector List
- Parts Index
- System Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Body Computer
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Electronic Power Steering
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Top/Sunroof
- Power Windows
- Radio
- Shift Interlocks
- Starting/Charging
- Supplemental Restraints
- Transmission
- Trunk, Tailgate, Fuel Door
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- OEM Connector End Views (2.5L)
- Body Electrical
- Engine Mechanical
- Accessory Drive Belts
- Engine Mechanical - 2.5L
- Mechanical Location Index
- Drive Belt Inspection
- Drive Belt Adjustment
- Before Repair Procedure
- After Repair Procedure
- Fuel Line Pressure Inspection
- Compression Inspection
- Timing Belt Removal/Installation
- Cylinder Head Gasket Replacement
- Hydraulic Lash Adjuster (HLA) Removal/Installation
- Hydraulic Lash Adjuster (HLA) Troubleshooting Guide
- Front Oil Seal Replacement
- Rear Oil Seal Replacement
- Engine Removal/Installation
- Procedure
- Notes
- Removing Engine - Step 1
- Removing Engine - Step 2
- Removing Engine - Step 3
- Notes
- No. 1 Engine Mount Stay Removal Note
- No. 1 Engine Mount Bracket Removal Note
- Engine Mount Member Removal Note
- No. 4 Engine Mount Bracket Removal Note
- No. 3 Engine Mount Sub Bracket Removal Note
- Engine And Transaxle Removal Note
- Engine And Transaxle Installation Note
- No. 3 Engine Mount Sub Bracket Installation Note
- No. 4 Engine Mount Bracket Installation Note
- Engine Mount Member Installation Note
- No. 1 Engine Mount Bracket Installation Note
- No. 1 Engine Mount Stay Installation Note
- Procedure
- Engine Tune-Up
- Torque Specifications
- Engine Mechanical - 2.5L
- Auxiliary Emission Control Systems
- Emission Control System Visual Inspection Procedures - General Information
- * Please Read This First *
- Emission Control Labels
- Emission Control Visual Inspection
- Notes
- Positive Crankcase Ventilation (PCV)
- Thermostatic Air Cleaner (TAC)
- Fuel Evaporative System (EVAP)
- Catalytic Converters
- Fill Pipe RESTRICTOR (Fr)
- Exhaust Gas RECIRCULATION (EGR) System
- Spark Controls (SPK)
- Air Injection System (AIS)
- Oxygen Sensor (O2)
- Computerized Engine Controls (CEC)
- Early Fuel Evaporation (EFE)
- Emission Maintenance Reminder Light (EMR) (If Equipped)
- Malfunction Indicator Light (Mil)
- Emission Control System Visual Inspection Procedures - General Information
- Electric Cooling Fans
- Cooling System (Mechanical)
- Engine Cooling [2.5L]
- Cooling System Location Index
- Cooling System Service Warnings
- Engine Coolant Level Inspection
- Engine Coolant Leakage Inspection
- Engine Coolant Protection
- Engine Coolant Replacement
- Radiator Cap Inspection
- Radiator Removal/Installation
- Thermostat Removal/Installation
- Thermostat Inspection
- Water Pump Removal/Installation
- Specifications & Drive Belt Routing
- Engine Cooling [2.5L]
- Engine Exhaust System - 2.5L
- Lubrication System
- Mechanical
- Engine - Intake-Air System - 2.5L
- Vacuum Hose Routing Diagram [Kl]
- Intake-Air System Removal/Installation [Kl]
- Intake Manifold Component Disassembly/Assembly [Kl]
- Idle Air Control (IAC) Valve Removal/Installation [Kl]
- Idle Air Control (IAC) Valve Inspection [Kl]
- VRIS Check Valve (One-Way) Inspection [Kl]
- VRIS Shutter Valve Actuator Inspection [Kl]
- VRIS Solenoid Valve Inspection [Kl]
- Engine Mechanical - 2.5L
- Mechanical Location Index
- Drive Belt Inspection
- Drive Belt Adjustment
- Before Repair Procedure
- After Repair Procedure
- Fuel Line Pressure Inspection
- Compression Inspection
- Timing Belt Removal/Installation
- Cylinder Head Gasket Replacement
- Hydraulic Lash Adjuster (HLA) Removal/Installation
- Hydraulic Lash Adjuster (HLA) Troubleshooting Guide
- Front Oil Seal Replacement
- Rear Oil Seal Replacement
- Engine Removal/Installation
- Procedure
- Notes
- Removing Engine - Step 1
- Removing Engine - Step 2
- Removing Engine - Step 3
- Notes
- No. 1 Engine Mount Stay Removal Note
- No. 1 Engine Mount Bracket Removal Note
- Engine Mount Member Removal Note
- No. 4 Engine Mount Bracket Removal Note
- No. 3 Engine Mount Sub Bracket Removal Note
- Engine And Transaxle Removal Note
- Engine And Transaxle Installation Note
- No. 3 Engine Mount Sub Bracket Installation Note
- No. 4 Engine Mount Bracket Installation Note
- Engine Mount Member Installation Note
- No. 1 Engine Mount Bracket Installation Note
- No. 1 Engine Mount Stay Installation Note
- Procedure
- Engine Tune-Up
- Torque Specifications
- Engine Mechanical - Overhaul - 2.5L
- Engine Stand Mounting
- Disassembly/Assembly
- Preparation
- Auxiliary Parts
- Timing Belt
- Cylinder Head
- Notes
- Camshaft Pulley Disassembly Note
- Camshaft Disassembly Note
- HLA Disassembly Note
- Cylinder Head Disassembly Note
- Valve Keeper Disassembly Note
- Valve Seal Disassembly Note
- Valve Seal Assembly Note
- Valve Spring Assembly Note
- Valve Keeper Assembly Note
- Cylinder Head Gasket Assembly Note
- Cylinder Head Assembly Note
- Camshaft Assembly Note
- Camshaft Pulley Assembly Note
- Cylinder Head Cover Assembly Note
- Cylinder Block (External Parts)
- Notes
- Backing Plate, Drive Plate, Adapter Disassembly Note
- Knock Sensor Disassembly Note
- Oil Pan Disassembly Note
- Front Oil Seal Disassembly Note
- Front Oil Seal Assembly Note
- Oil Pump Assembly Note
- Oil Baffle Assembly Note
- Oil Strainer Assembly Note
- Oil Pan Assembly Note
- Knock Sensor Assembly Note
- Backing Plate, Drive Plate, Adapter
- Cylinder Block (Internal Parts)
- Notes
- Connecting Rod Cap Disassembly Note
- Piston & Connecting Rod Assembly Disassembly Note
- Piston Ring Disassembly Note
- Piston Pin Disassembly Note
- Lower Cylinder Block Disassembly Note
- Lower Cylinder Block Assembly Note
- Oil Clearance Inspection Assembly Note
- Connecting Rod Assembly Note
- Piston Ring Assembly Note
- Piston & Connecting Rod Assembly Note
- Connecting Rod Cap Assembly Note
- Inspection/Repair
- Engine Stand Dismounting
- Torque Specifications
- Lubrication - Engine Mechanical - 2.5L
- Engine - Intake-Air System - 2.5L
- Starter
- Timing Belt Replacement - 2.5L
- Accessory Drive Belts
- Engine Performance
- Engine Controls - On-Vehicle Adjustments
- Application
- Introduction
- Introduction
- Notes
- Vehicle Identification Number Description (Except B-Series Truck & Tribute)
- Vehicle Identification Number Description (B-Series Truck & Tribute)
- Notes
- World Manufacturer Identifier - Position 1
- Gross Vehicle Weight Rating (GVWR) & Restraint Type Code - Position 2
- Line, Series & Body Type Code - Position 3
- Engine Code - Position 4
- Computer-Generated Check Digit - Position 5
- Model Year Code - Position 6
- Assembly Plant Code - Position 7
- Production Sequence Number - Position 8
- Model/Year VIN Code Applications
- Engine Code Location
- Introduction
- Introduction
- Emissions
- EGR Function Testing - MAZDA
- Emission Applications
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Mode 6 - 1999-2023 MAZDA
- Pin Voltage Charts
- Engine Controls - Pin Voltage/PID Value Charts
- Introduction
- Test Procedures
- Pin Voltage & PID Value Charts
- Pin Voltage & PID Value Chart Index
- Wire Color Identification
- Pin Voltage Charts
- PID Value Charts
- Notes
- Generic PCM PID Value Chart (B3000 & B4000)
- PCM PID Input Value Chart (B3000 A/T)
- PCM PID Input Value Chart (B3000 M/T)
- PCM PID Input Value Chart (B4000 A/T)
- PCM PID Input Value Chart (B4000 M/T)
- PCM PID Value Chart (Miata)
- PCM PID Value Chart (Millenia 2.3L)
- PCM PID Value Chart (Millenia 2.5L)
- PCM PID Value Chart (MPV)
- PCM PID Value Chart (Protege & Protege5)
- PCM PID Value Chart (626 2.0L)
- PCM PID Value Chart (626 2.5L)
- Pin/PID Charts
- Engine Controls - Pin Voltage/PID Value Charts
- Remove, Overhaul & Install
- Engine Controls - Removal, Overhaul & Installation
- Introduction
- Air Induction Systems
- Supercharger
- Computerized Engine Controls
- Engine Sensors & Switches
- Cooling System
- Ignition System
- Fuel System
- Notes
- Fuel System Pressure Release
- Fuel Filter Location
- Fuel Filter Replacement
- Fuel Line Connectors (B2300, B3000, B4000, MPV & Tribute)
- Plastic Fuel Line Coupler (MPV, Protege & Protege5)
- Fuel Line Connectors (MIATA, MILLENIA, MPV, Protege, Protege5 & 626)
- Fuel System Priming
- Fuel Pump
- Fuel Pressure Regulator
- Fuel Rails & Injectors
- Emission Systems & Sub-Systems
- Variable Valve Timing System
- Torque Specifications
- Engine Controls - Removal, Overhaul & Installation
- Sensor Range Charts
- Specifications
- Engine Controls - Service & Adjustment Specifications
- Introduction
- Capacities
- Quick-Service
- Mechanical Checks
- Ignition System
- Ignition Coil
- Crankshaft Position Sensor
- High Tension Wire Resistance
- Spark Plugs
- Firing Order & Ignition Coils
- Notes
- Firing Order & Coil Pack (Tribute 2.0L)
- Firing Order & Coil Pack (B2300)
- Firing Order & Coil Pack (B3000 & B4000)
- Firing Order & Ignition Coils (Millenia 2.3L)
- Firing Order & Distributor Rotation (Millenia 2.5L)
- Firing Order (MPV & Tribute 3.0L Engine)
- Firing Order & Coil Pack (626 2.0L)
- Firing Order & Coil Pack (626 2.5L)
- Firing Order & Coil Pack(Miata 1.8L, Protege & Protege5 2.0L)
- Ignition Timing
- Spark Plug Wire Routing
- Fuel System
- Firing Order & Cylinder Identification
- Engine Controls - Service & Adjustment Specifications
- System
- Engine Controls - Basic Diagnostic Procedures
- Introduction
- Preliminary Inspection & Adjustments
- Fuel System
- Preliminary Checks
- Fuel Pressure Release
- Fuel Pressure (Except B2300, B3000, B4000 & Tribute)
- Fuel Pressure Hold Inspection
- Fuel Line Pressure Inspection
- Fuel Pump Inspection
- Fuel Pump Hold Pressure Inspection
- Fuel Pump Maximum Pressure Inspection
- Fuel Pump Relay Inspection (Miata)
- Fuel Pump Resistor & Relay (Millenia 2.3L)
- Fuel Pump Relay Inspection (Millenia 2.5L, Protege, Protege5 & 626)
- Fuel Pump Relay Inspection (MPV)
- Fuel Pressure Regulator Inspection
- Injector Fuel Leakage Inspection
- Fuel Pressure (B2300, B3000, B4000 & Tribute)
- Ignition Checks
- Notes
- Except B2300, B3000, B4000 & Tribute
- Spark Check
- Camshaft Position Sensor (Miata)
- Camshaft Position Sensor (Millenia 2.3L)
- Camshaft Position Sensor (Millenia 2.5L)
- Camshaft Position Sensor (MPV)
- Camshaft Position Sensor (Protege & Protege5)
- Camshaft Position Sensor (626 2.0L)
- Camshaft Position Sensor (626 2.5L)
- Crankshaft Position Sensor Resistance (Except Miata)
- Crankshaft Position Sensor Air Gap (Except MPV)
- Ignition Coil Operation Inspection (Miata, Protege & Protege5)
- Ignition Coil Resistance (Miata, Protege & Protege5)
- Ignition Coil Resistance (Millenia 2.3L)
- Ignition Coil Resistance (Millenia 2.5L)
- Ignition Coil Resistance (MPV)
- Ignition Coil Resistance (626)
- Ignition Control Module (Millenia)
- B2300, B3000, B4000 & Tribute
- Idle Speed & Ignition Timing
- Summary
- Engine Controls - Removal, Overhaul & Installation
- Introduction
- Air Induction Systems
- Supercharger
- Computerized Engine Controls
- Engine Sensors & Switches
- Cooling System
- Ignition System
- Fuel System
- Notes
- Fuel System Pressure Release
- Fuel Filter Location
- Fuel Filter Replacement
- Fuel Line Connectors (B2300, B3000, B4000, MPV & Tribute)
- Plastic Fuel Line Coupler (MPV, Protege & Protege5)
- Fuel Line Connectors (MIATA, MILLENIA, MPV, Protege, Protege5 & 626)
- Fuel System Priming
- Fuel Pump
- Fuel Pressure Regulator
- Fuel Rails & Injectors
- Emission Systems & Sub-Systems
- Variable Valve Timing System
- Torque Specifications
- Engine Controls - Self-Diagnostics - 2.5L
- Introduction
- Self-Diagnostic System
- Test Equipment
- Summary
- Diagnostic Trouble Code Definitions
- Diagnostic Tests
- Notes
- DTC P0100: MAF Circuit Malfunction
- DTC P0110: IAT Circuit Malfunction
- DTC P0115: Engine Coolant Temperature (ECT) Circuit Malfunction
- DTC P0120: Throttle Position (TP) Circuit Malfunction
- DTC P0125: Insufficient Coolant Temperature For Closed Loop Fuel Control
- DTC P0130 & 150: Front Right & Left Ho2S Circuit Malfunction
- DTC P0134, P0140, P0154 & P0160: Right, Left, Front & Rear Ho2S Circuit, No Activity Detected
- DTC P0135: Right Front Ho2S Heater Circuit Malfunction
- DTC P0138: Right Rear Ho2S Circuit High Input
- DTC P0141: Right Rear Ho2S Heater Circuit Malfunction
- DTC P0155: Left Front Ho2S Heater Circuit Malfunction
- DTC P0158: Left Rear Ho2S Circuit High Input
- DTC P0161: Left Rear Ho2S Heater Circuit Malfunction
- DTC P0170 & P0173: Right & Left Bank Fuel Trim System Malfunction
- DTC P0300: Random Misfire Detected
- DTC P0301, P0302, P0303, P0304, P0305 & P0306: Misfire Detection
- DTC P0325: Knock Sensor Circuit Malfunction
- DTC P0335: CKP Sensor Circuit Malfunction
- DTC P0400: EGR System Malfunction
- DTC P0404: EGR Circuit, Range/Performance Problem
- DTC P0421 & DTC P0431: Right & Left Warm-Up Catalyst System Efficiency Below Threshold
- DTC P0442: EVAP Control System, Small Leak Detected
- DTC P0450: Fuel Tank Pressure Sensor Circuit Malfunction
- DTC P0451: Fuel Tank Pressure Sensor, Performance Problem
- DTC P0455: EVAP Control System, Excessive Leak Or Blockage Detected
- DTC P0464: Fuel Gauge Sending Unit Circuit, Slosh Check
- DTC P0480: Condenser Fan Relay No. 1 Circuit Malfunction
- DTC P0481 & P0482: Cooling Fan Relay & Condenser Fan Relay No. 2 Circuit Malfunction
- DTC P0505: Idle Air Control System Malfunction
- DTC P0550: Power Steering Pressure Switch Circuit Malfunction
- DTC P0703: Brake Switch Input Malfunction
- DTC P1170 & P1173: Right & Left Front Ho2S, No Inversion
- DTC P1195: BARO Circuit Malfunction
- DTC P1196: Starter Signal Circuit Malfunction
- DTC P1250: PRC Solenoid Valve Circuit Malfunction
- DTC P1345: CMP Sensor Circuit Malfunction
- DTC P1402: EGR Valve Position Sensor Circuit Malfunction
- DTC P1450: EVAP Emission Control System Malfunction (Excessive Vacuum)
- DTC P1455: Fuel Gauge Sender Unit Circuit Malfunction
- DTC P1521: Variable Resonance Induction System (VRIS) Solenoid Valve No. 1 Circuit Malfunction
- DTC P1522: Variable Resonance Induction System (VRIS) Solenoid Valve No. 2 Circuit Malfunction
- DTC P1609: Pcm Internal Malfunction
- DTC P1627: Powertrain Control Module (Pcm) - Anti-Lock Brake System (Abs)/Traction Control System (TCS)/Line Communication Error
- DTC P1794: PCM +BB Voltage Low
- Engine Controls - System & Component Testing
- Introduction
- Air Induction Systems
- Computerized Engine Controls
- Engine Sensors & Switches
- BRAKELIGHT Switch
- Camshaft Position Sensor
- Closed Throttle Position Switch
- Clutch Switch (M/T)
- Crankshaft Position Sensor
- EGR Boost Sensor
- Engine Coolant Temperature Sensor
- Fuel Tank Pressure Sensor
- Heated Oxygen Sensor
- Intake Air Temperature Sensor
- Knock Sensor
- Manifold Absolute Pressure Sensor
- Mass Airflow Sensor
- Neutral Switch (M/T)
- Power Steering Pressure Switch
- Throttle Position Sensor
- Transmission Range Switch
- Vehicle Speed Sensor
- Relays & Solenoids
- Fuel Pump Relay
- Fuel Pump Resistor & Relay (Speed)
- Main Relay
- Solenoids
- Air By-Pass Valve (ABV) Vent Solenoid Valve (Millenia 2.3L)
- By-Pass Air Solenoid Valve (Millenia 2.3L)
- Charge Air Cooler By-Pass Solenoid Valve (Millenia 2.3L)
- EGR Boost Sensor Solenoid
- EGR Vent Solenoid Valve (Millenia)
- EGR Vacuum Solenoid Valve (Millenia)
- Manifold Absolute Pressure Sensor Solenoid Valve (Millenia 2.3L)
- Pressure Regulator Control (PRC) Solenoid Valve
- Purge Control Solenoid
- VICS Solenoid - Protege & Protege5
- VRIS Solenoid - Millenia 2.5L & 626 2.5L
- VTCS Solenoid - Miata 1.8L & 626 2.0L
- Fuel System
- Idle Control System
- Ignition System
- Emission Systems & Sub-Systems
- Evaporative System Leak Inspection Using Leak Tester
- Exhaust Gas RECIRCULATION System
- Fuel-Filler Cap Inspection
- Fuel Evaporative System (Except MPV)
- Notes
- System Inspection
- System Leak Inspection - Using Vacuum Pump
- Charcoal Canister (Except Millenia)
- Charcoal Canister (Millenia)
- Canister Drain Cut Valve (CDCV) - Airflow Inspection
- Canister Drain Cut Valve (CDCV) - Circuit Inspection
- Catch Tank (Miata, Protege, Protege5 & 626)
- Evaporative Gas (Two-Way) Check Valve - Millenia, Protege, Protege5 & 626
- Fuel-Filler Cap Inspection
- Fuel Shut-Off/Rollover Valves (Miata)
- Fuel Shut-Off Valve (Millenia)
- Fuel Shut-Off/Rollover Valves (Protege & Protege5)
- Fuel Shut-Off Valve (626)
- One-Way Check Valve (Millenia)
- Purge Solenoid Valve - Airflow Inspection
- Purge Solenoid Valve - Circuit Inspection
- Rollover Valve (Millenia)
- Rollover Valve (626)
- Fuel Evaporative System (MPV)
- Positive Crankcase Ventilation
- Warm Up Three-Way Catalytic Converter
- Vacuum Pump
- Variable Valve Timing System
- Miscellaneous Controls
- Engine Controls - Trouble Shooting - No Codes
- Introduction
- Symptom Diagnosis
- Notes
- Abnormal Engine Noise
- A/C Does Not Turn Off During Wide Open Throttle
- A/C Is Always On Or Compressor Runs Continuously
- Constant Voltage
- Cranks Normally But Will Not Start
- Emissions Failure
- Engine Runs Rough, Misses, Hesitates, Stumbles, Surges Or Stalls During Acceleration Or Cruise, Or Engine Bucks Or Jerks During Acceleration, Cruise Or Deceleration
- Engine Stalls At Idle Or Just After Starting
- Engine Vibration
- Excessive Oil Consumption
- Exhaust Smoke
- Exhaust Sulphur (Rotten Egg) Smell
- Fast Idle Or Run-On
- Fuel Odor In Engine Compartment
- Hard To Start (Long Cranking, Erratic Cranking Or Erratic Starting)
- Knocking Or Pinging During Acceleration Or Cruise
- Lack Or Loss Of Power During Acceleration Or Cruise
- Low Idle Or Engine Stalls During Deceleration
- Poor Fuel Economy
- Rough Or Unstable Idle
- Slow Return To Idle
- Will Not Crank
- INTERMITTENTS
- Engine Controls - Basic Diagnostic Procedures
- Testing & Diagnosis
- Engine Controls - Basic Diagnostic Procedures
- Introduction
- Preliminary Inspection & Adjustments
- Fuel System
- Preliminary Checks
- Fuel Pressure Release
- Fuel Pressure (Except B2300, B3000, B4000 & Tribute)
- Fuel Pressure Hold Inspection
- Fuel Line Pressure Inspection
- Fuel Pump Inspection
- Fuel Pump Hold Pressure Inspection
- Fuel Pump Maximum Pressure Inspection
- Fuel Pump Relay Inspection (Miata)
- Fuel Pump Resistor & Relay (Millenia 2.3L)
- Fuel Pump Relay Inspection (Millenia 2.5L, Protege, Protege5 & 626)
- Fuel Pump Relay Inspection (MPV)
- Fuel Pressure Regulator Inspection
- Injector Fuel Leakage Inspection
- Fuel Pressure (B2300, B3000, B4000 & Tribute)
- Ignition Checks
- Notes
- Except B2300, B3000, B4000 & Tribute
- Spark Check
- Camshaft Position Sensor (Miata)
- Camshaft Position Sensor (Millenia 2.3L)
- Camshaft Position Sensor (Millenia 2.5L)
- Camshaft Position Sensor (MPV)
- Camshaft Position Sensor (Protege & Protege5)
- Camshaft Position Sensor (626 2.0L)
- Camshaft Position Sensor (626 2.5L)
- Crankshaft Position Sensor Resistance (Except Miata)
- Crankshaft Position Sensor Air Gap (Except MPV)
- Ignition Coil Operation Inspection (Miata, Protege & Protege5)
- Ignition Coil Resistance (Miata, Protege & Protege5)
- Ignition Coil Resistance (Millenia 2.3L)
- Ignition Coil Resistance (Millenia 2.5L)
- Ignition Coil Resistance (MPV)
- Ignition Coil Resistance (626)
- Ignition Control Module (Millenia)
- B2300, B3000, B4000 & Tribute
- Idle Speed & Ignition Timing
- Summary
- Engine Controls - Removal, Overhaul & Installation
- Introduction
- Air Induction Systems
- Supercharger
- Computerized Engine Controls
- Engine Sensors & Switches
- Cooling System
- Ignition System
- Fuel System
- Notes
- Fuel System Pressure Release
- Fuel Filter Location
- Fuel Filter Replacement
- Fuel Line Connectors (B2300, B3000, B4000, MPV & Tribute)
- Plastic Fuel Line Coupler (MPV, Protege & Protege5)
- Fuel Line Connectors (MIATA, MILLENIA, MPV, Protege, Protege5 & 626)
- Fuel System Priming
- Fuel Pump
- Fuel Pressure Regulator
- Fuel Rails & Injectors
- Emission Systems & Sub-Systems
- Variable Valve Timing System
- Torque Specifications
- Engine Controls - Self-Diagnostics - 2.5L
- Introduction
- Self-Diagnostic System
- Test Equipment
- Summary
- Diagnostic Trouble Code Definitions
- Diagnostic Tests
- Notes
- DTC P0100: MAF Circuit Malfunction
- DTC P0110: IAT Circuit Malfunction
- DTC P0115: Engine Coolant Temperature (ECT) Circuit Malfunction
- DTC P0120: Throttle Position (TP) Circuit Malfunction
- DTC P0125: Insufficient Coolant Temperature For Closed Loop Fuel Control
- DTC P0130 & 150: Front Right & Left Ho2S Circuit Malfunction
- DTC P0134, P0140, P0154 & P0160: Right, Left, Front & Rear Ho2S Circuit, No Activity Detected
- DTC P0135: Right Front Ho2S Heater Circuit Malfunction
- DTC P0138: Right Rear Ho2S Circuit High Input
- DTC P0141: Right Rear Ho2S Heater Circuit Malfunction
- DTC P0155: Left Front Ho2S Heater Circuit Malfunction
- DTC P0158: Left Rear Ho2S Circuit High Input
- DTC P0161: Left Rear Ho2S Heater Circuit Malfunction
- DTC P0170 & P0173: Right & Left Bank Fuel Trim System Malfunction
- DTC P0300: Random Misfire Detected
- DTC P0301, P0302, P0303, P0304, P0305 & P0306: Misfire Detection
- DTC P0325: Knock Sensor Circuit Malfunction
- DTC P0335: CKP Sensor Circuit Malfunction
- DTC P0400: EGR System Malfunction
- DTC P0404: EGR Circuit, Range/Performance Problem
- DTC P0421 & DTC P0431: Right & Left Warm-Up Catalyst System Efficiency Below Threshold
- DTC P0442: EVAP Control System, Small Leak Detected
- DTC P0450: Fuel Tank Pressure Sensor Circuit Malfunction
- DTC P0451: Fuel Tank Pressure Sensor, Performance Problem
- DTC P0455: EVAP Control System, Excessive Leak Or Blockage Detected
- DTC P0464: Fuel Gauge Sending Unit Circuit, Slosh Check
- DTC P0480: Condenser Fan Relay No. 1 Circuit Malfunction
- DTC P0481 & P0482: Cooling Fan Relay & Condenser Fan Relay No. 2 Circuit Malfunction
- DTC P0505: Idle Air Control System Malfunction
- DTC P0550: Power Steering Pressure Switch Circuit Malfunction
- DTC P0703: Brake Switch Input Malfunction
- DTC P1170 & P1173: Right & Left Front Ho2S, No Inversion
- DTC P1195: BARO Circuit Malfunction
- DTC P1196: Starter Signal Circuit Malfunction
- DTC P1250: PRC Solenoid Valve Circuit Malfunction
- DTC P1345: CMP Sensor Circuit Malfunction
- DTC P1402: EGR Valve Position Sensor Circuit Malfunction
- DTC P1450: EVAP Emission Control System Malfunction (Excessive Vacuum)
- DTC P1455: Fuel Gauge Sender Unit Circuit Malfunction
- DTC P1521: Variable Resonance Induction System (VRIS) Solenoid Valve No. 1 Circuit Malfunction
- DTC P1522: Variable Resonance Induction System (VRIS) Solenoid Valve No. 2 Circuit Malfunction
- DTC P1609: Pcm Internal Malfunction
- DTC P1627: Powertrain Control Module (Pcm) - Anti-Lock Brake System (Abs)/Traction Control System (TCS)/Line Communication Error
- DTC P1794: PCM +BB Voltage Low
- Engine Controls - System & Component Testing
- Introduction
- Air Induction Systems
- Computerized Engine Controls
- Engine Sensors & Switches
- BRAKELIGHT Switch
- Camshaft Position Sensor
- Closed Throttle Position Switch
- Clutch Switch (M/T)
- Crankshaft Position Sensor
- EGR Boost Sensor
- Engine Coolant Temperature Sensor
- Fuel Tank Pressure Sensor
- Heated Oxygen Sensor
- Intake Air Temperature Sensor
- Knock Sensor
- Manifold Absolute Pressure Sensor
- Mass Airflow Sensor
- Neutral Switch (M/T)
- Power Steering Pressure Switch
- Throttle Position Sensor
- Transmission Range Switch
- Vehicle Speed Sensor
- Relays & Solenoids
- Fuel Pump Relay
- Fuel Pump Resistor & Relay (Speed)
- Main Relay
- Solenoids
- Air By-Pass Valve (ABV) Vent Solenoid Valve (Millenia 2.3L)
- By-Pass Air Solenoid Valve (Millenia 2.3L)
- Charge Air Cooler By-Pass Solenoid Valve (Millenia 2.3L)
- EGR Boost Sensor Solenoid
- EGR Vent Solenoid Valve (Millenia)
- EGR Vacuum Solenoid Valve (Millenia)
- Manifold Absolute Pressure Sensor Solenoid Valve (Millenia 2.3L)
- Pressure Regulator Control (PRC) Solenoid Valve
- Purge Control Solenoid
- VICS Solenoid - Protege & Protege5
- VRIS Solenoid - Millenia 2.5L & 626 2.5L
- VTCS Solenoid - Miata 1.8L & 626 2.0L
- Fuel System
- Idle Control System
- Ignition System
- Emission Systems & Sub-Systems
- Evaporative System Leak Inspection Using Leak Tester
- Exhaust Gas RECIRCULATION System
- Fuel-Filler Cap Inspection
- Fuel Evaporative System (Except MPV)
- Notes
- System Inspection
- System Leak Inspection - Using Vacuum Pump
- Charcoal Canister (Except Millenia)
- Charcoal Canister (Millenia)
- Canister Drain Cut Valve (CDCV) - Airflow Inspection
- Canister Drain Cut Valve (CDCV) - Circuit Inspection
- Catch Tank (Miata, Protege, Protege5 & 626)
- Evaporative Gas (Two-Way) Check Valve - Millenia, Protege, Protege5 & 626
- Fuel-Filler Cap Inspection
- Fuel Shut-Off/Rollover Valves (Miata)
- Fuel Shut-Off Valve (Millenia)
- Fuel Shut-Off/Rollover Valves (Protege & Protege5)
- Fuel Shut-Off Valve (626)
- One-Way Check Valve (Millenia)
- Purge Solenoid Valve - Airflow Inspection
- Purge Solenoid Valve - Circuit Inspection
- Rollover Valve (Millenia)
- Rollover Valve (626)
- Fuel Evaporative System (MPV)
- Positive Crankcase Ventilation
- Warm Up Three-Way Catalytic Converter
- Vacuum Pump
- Variable Valve Timing System
- Miscellaneous Controls
- Engine Controls - Trouble Shooting - No Codes
- Introduction
- Symptom Diagnosis
- Notes
- Abnormal Engine Noise
- A/C Does Not Turn Off During Wide Open Throttle
- A/C Is Always On Or Compressor Runs Continuously
- Constant Voltage
- Cranks Normally But Will Not Start
- Emissions Failure
- Engine Runs Rough, Misses, Hesitates, Stumbles, Surges Or Stalls During Acceleration Or Cruise, Or Engine Bucks Or Jerks During Acceleration, Cruise Or Deceleration
- Engine Stalls At Idle Or Just After Starting
- Engine Vibration
- Excessive Oil Consumption
- Exhaust Smoke
- Exhaust Sulphur (Rotten Egg) Smell
- Fast Idle Or Run-On
- Fuel Odor In Engine Compartment
- Hard To Start (Long Cranking, Erratic Cranking Or Erratic Starting)
- Knocking Or Pinging During Acceleration Or Cruise
- Lack Or Loss Of Power During Acceleration Or Cruise
- Low Idle Or Engine Stalls During Deceleration
- Poor Fuel Economy
- Rough Or Unstable Idle
- Slow Return To Idle
- Will Not Crank
- INTERMITTENTS
- Engine Controls - Basic Diagnostic Procedures
- Theory and Operation
- Engine Controls - Theory & Operation
- Introduction
- Air Induction System
- Computerized Engine Controls
- Notes
- Powertrain Control Module
- Input Devices
- Notes
- A/C Amplifier
- A/C Pressure Switch
- A/C Switch
- Brake Switch
- Camshaft Position Sensor
- Closed Throttle Position Switch (Millenia 2.3L)
- Clutch Pedal Position Switch (M/T)
- Crankshaft Position Sensor
- Cylinder Head Temperature Sensor (B2300 & Tribute 2.0L)
- Differential Pressure Feedback EGR Sensor
- EGR Boost Sensor
- EGR Position Sensor
- Engine Coolant Temperature Sensor
- Fuel Tank Pressure Sensor
- Heated Oxygen Sensor
- Intake Air Temperature Sensor
- Knock Sensor
- Main Relay
- Mass Airflow Sensor
- Manifold Absolute Pressure Sensor (B2300 & Millenia 2.3L)
- Neutral Switch
- Power Steering Pressure Switch
- Throttle Position Sensor
- Transmission Fluid Temperature Sensor
- Transmission Range Sensor
- Vehicle Speed Sensor
- Output Signals
- Fuel System
- Ignition Systems
- Emission Systems
- Self-Diagnostic System
- Miscellaneous Controls
- Engine Controls - Theory & Operation
- Vacuum Diagrams
- Wiring Diagrams
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- Computer Relearn Procedures - Import
- Introduction
- ACURA
- AUDI
- BMW
- HONDA
- HYUNDAI
- INFINITI
- ISUZU
- Jaguar
- KIA
- Land Rover
- LEXUS
- MAZDA
- MERCEDES-BENZ
- Notes
- Synchronization Of Power Windows
- Activating Steering Angle Sensor
- Synchronization Of Sliding/Tilt-Up Roof
- Easy Entry/Exit Function
- Control Module Version Coding
- Enabling Code Function For Radio
- Notes
- Audio 5 & 10 Models Or Sound 10, 20 & 30 Models (CLK, E & SLK Class)
- Becker 2000 (CL, S & SL Class)
- Becker Mexico, Grand Prix, Europa & Avus Models (SL Class)
- Radio With Navigation Control Module (CL, S & SL Class)
- Radio With 4-Digit Fixed Code (CL, S & SL Class)
- Radio & Radio With Navigation Control Module With 5-Digit Fixed Code (CL, S & SL Class)
- Radio (ML Class)
- Programming Supplemental Restraint System Control Module
- MITSUBISHI
- NISSAN
- PORSCHE
- SAAB
- SUBARU
- SUZUKI
- TOYOTA
- Service Precautions (PRIUS)
- Immobilizer Programming (Except PRIUS)
- Additional Master Key Registration (Except PRIUS)
- Additional Sub-Key Registration (Except PRIUS)
- Erasure Of Transponder Key Code (Except PRIUS)
- Immobilizer Component Replacement Programming Procedures (PRIUS)
- Notes
- Programming When Replacing Transponder Key Electronic Control Unit
- Programming When Replacing Hybrid Vehicle Control Electronic Control Unit
- Programming When Replacing Transponder Key Electronic Control Unit & Hybrid Vehicle Control Electronic Control Unit
- Programming If All Ignition Keys Are Lost
- Ignition Key Registration
- Additional Master Key Registration
- Additional Sub-Key Registration
- Erasure Of Transponder Key Code
- Power Sliding Door REINITIALIZATION Procedure (Sienna)
- Sun Roof Initialization (CAMRY & CELICA)
- VOLKSWAGEN
- VOLVO
- OBD-II Drive Cycles
- * Please Read This First *
- Drive Cycles
- Notes
- 1996: 626, MX-6
- 1996: B2300, B3000, B4000
- 1996: MILLENIA, MPV, MX-5 MIATA, Protege & 1997: 626 (2.0L M/T, 2.5L), MX-6 (2.0L M/T, 2.5L), MILLENIA, MPV, MX-5 MIATA, Protege & 1998: MILLENIA, MPV, Protege & 1999-2000: MILLENIA, MX-5 MIATA
- 1997: 626 (2.0L A/T), MX-6 (2.0L A/T)
- 1997: B2300, B4000
- Preparation
- Drive Mode
- Comprehensive Component Monitor Repair Verification Drive Mode
- EGR Monitor Repair Verification Drive Mode
- Catalyst Monitor Repair Verification Drive Mode
- Fuel Monitor, Oxygen Sensor Monitor or Oxygen Sensor Heater Monitor Repair Verification Drive Mode
- Misfire Monitor Repair Verification Drive Mode
- 1998: 626, B2500, B3000, B4000
- OBD-II Drive Cycle Description
- Vehicle Preparation For OBD-II Or Monitor Repair Verification Drive Cycle
- OBD-II Drive Cycle
- Comprehensive Component Monitor Repair Verification Drive Cycle
- EGR Monitor Repair Verification Drive Cycle
- EVAP Running Loss System Repair Verification Drive Cycle
- Catalyst Monitor Repair Verification Drive Cycle
- Fuel Monitor Or HO2S Monitor Repair Verification Drive Cycle
- Misfire Monitor Repair Verification Drive Cycle
- Secondary Air Monitor Repair Verification Drive Cycle
- 1999-2000: 626
- 1999: B2500, B3000, B4000
- 1999: Protege
- 2000: B2500, B3000, B4000
- 2000: MPV
- 2000: Protege
- 2001-02: 626
- 2001: B2300, B2500, B3000, B4000, Tribute
- 2001: MILLENIA
- 2001: MPV
- 2001: MX-5 MIATA
- 2001: Protege
- 2002-09: B2300, B3000, B4000 & 2002-06: Tribute
- 2002: MILLENIA
- 2002-03: MPV
- 2002-03: MX-5 MIATA
- 2002-03: Protege, Protege5
- 2003: MAZDA6
- 2004-06: MAZDA3 & 2006: MAZDA5 & 2007-09: MAZDA3 (W/O Turbo)
- 2004-05: MAZDA6
- Notes
- Mode 1 (Pcm Adaptive Memory Produce Drive Mode)
- Mode 2 (EGR System Repair Verification Drive Mode)
- Mode 3: 2004 (H02S Heater, H02S & TWC Repair Verification Drive Mode) (3.0L Cal: AJ57EM060AJV5010 (M/T), AJ58EM060AJVN010 (A/T) Only)
- Mode 3: 2004 (H02S Heater, H02S & TWC Repair Verification Drive Mode) (2.3L & 3.0L Cal: Except For AJ57EM060AJV5010 (M/T), AJ58EM060AJVN010 (A/T)): 2005 All Engines
- Mode 6 (EVAP System Repair Verification Drive Mode)
- Single Drive Mode (Pcm Adaptive Memory Produce, EGR System, H02S Heater, H02S, TWC & EVAP System Repair Verification Drive Mode) (3.0L Cal: AJ57EM060AJV5010 (M/T), AJ58EM060AJVN010 (A/T) Only)
- Single Drive Mode (Pcm Adaptive Memory Produce, EGR System, H02S Heater, H02S, TWC & EVAP System Repair Verification Drive Mode) (2.3L & 3.0L Cal: Except For AJ57EM060AJV5010 (M/T), AJ58EM060AJVN010 (A/T))
- 2004: MPV
- Notes
- Mode 1 (PCM Adaptive Memory Produce Drive Mode)
- Mode 2 (EGR System Repair Verification Drive Mode)
- Mode 3 (HO2S heater, HO2S, and TWC Repair Verification Drive Mode)
- Mode 6 (EVAP System Repair Verification Drive Mode)
- Single Drive (PCM Adaptive Memory Produce, EGR System Repair Verification, HO2S heater, HO2S TWC, and EVAP System Verification Drive Mode)
- 2004: MX-5 MIATA
- Notes
- Mode 1 (Pcm Adaptive Memory Production Drive Mode)
- Mode 2 (EGR System Repair Verification Drive Mode)
- Mode 3 (Ho2S Heater, Ho2S, & TWC Repair Verification Drive Mode)
- Mode 4 (EVAP System Repair Verification Drive Mode)
- Single Drive Mode (Pcm Adaptive Memory Production, EGR System Repair Verification, Ho2S Heater, Ho2S, TWC, & EVAP System Verification Drive Mode)
- 2004: RX-8
- 2005-06: MPV
- Notes
- Mode 1 (PCM Adaptive Memory Produce Drive Mode)
- Mode 2 (EGR System Repair Verification Drive Mode) With rear HO2S model
- Mode 3 (HO2S heater, HO2S, and TWC Repair Verification Drive Mode)
- H02S Heater, H02S, and EGR System Repair Verification Drive Mode Without rear HO2S model
- Mode 6 (EVAP System Repair Verification Drive Mode)
- Single Drive Mode (PCM Adaptive Memory Produce, EGR System Repair verification, HO2S heater, HO2S, TWC, and EVAP System Verification Drive Mode)
- 2005: MX-5 MIATA
- Notes
- Mode 1 (PCM Adaptive Memory Production Drive Mode)
- Mode 2 (EGR System Repair Verification Drive Mode)
- Mode 3 (HO2S heater, HO2S, and TWC Repair Verification Drive Mode)
- Mode 4 (EVAP System Repair Verification Drive Mode)
- Single Drive Mode (PCM Adaptive Memory Production, EGR System Repair Verification, HO2S heater, HO2S, TWC, and EVAP System Verification Drive Mode)
- 2005-08: RX-8
- 2006-08: MAZDA6
- Notes
- PCM Adaptive Memory Production Drive Mode
- EGR System Repair Verification Drive Mode
- HO2S heater, HO2S, and TWC Repair Verification Drive Mode
- EVAP System Repair Verification Drive Mode (4 Cylinder W/O Turbo & V6)
- EVAP System Repair Verification Drive Mode (4 Cylinder W/Turbo)
- PCM Adaptive Memory Production, EGR, HO2S heater, HO2S, TWC, and EVAP System Repair Verification Drive Mode (4 Cylinder W/O Turbo)
- PCM Adaptive Memory Production, EGR, HO2S heater, HO2S, TWC, and EVAP System Repair Verification Drive Mode (4 Cylinder W/Turbo)
- Single Drive Mode (PCM Adaptive Memory Produce, EGR System, HO2S heater, HO2S, TWC, and EVAP System Repair Verification Drive Mode) (V6)
- 2006-08: MX-5 MIATA
- 2007-09: MAZDA3 (W/Turbo)
- 2007: MAZDA5
- 2007-08: CX-7
- 2007-10: CX-9
- 2008-09: MAZDA5
- 2008-09: Tribute
- 2009-10: MAZDA6 (4 Cylinder)
- 2009-10: MAZDA6 (V6)
- 2009: CX-7
- 2009: MX-5 MIATA
- 2009-11: RX-8
- 2010-13: MAZDA3 (W/Turbo)
- 2010: MAZDA5
- 2010-12: CX-7 (W/Turbo)
- 2010-12: CX-7 (W/O Turbo)
- 2010-13: MX-5 MIATA
- 2010-11: Tribute
- 2011-13: CX-9
- 2010-13: MAZDA3 (W/O Turbo)
- 2012-13: MAZDA5
- 2011-13: MAZDA6 (4 Cylinder)
- 2011-13: MAZDA6 (V6)
- 2012-13: MAZDA2
- 2013: CX-5
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- DTC Index
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Identification
- Metric Conversions
- OEM General Information
- How To Use The Engine Performance Section
- Restraints
- Air Bag And Supplemental Restraint System (SRS) Component Inspection & Replacement Tables
- Air Bag Deactivation Procedures
- Specifications Index
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Traction Control Disable Procedures
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- A/C Compressor
- HVAC System - Automatic A/C-Heater Systems
- Air Conditioner System On-Board Diagnostic (OBD)
- DTC 2: Malfunction In Solar Radiation Sensor System
- DTC 6, 7: Malfunction In Passenger Compartment Temperature Sensor System
- DTC 10, 11: Malfunction In Evaporator Temperature Sensor System
- DTC 12, 13: Malfunction In Ambient Temperature Sensor System
- DTC 14, 15: Malfunction In Water Temperature Sensor System
- DTC 18, 19, 58: Malfunction In Air Mix Actuator System
- DTC 21, 22, 59: Malfunction In Airflow Mode Actuator System
- Troubleshooting Index
- No. 1 On-Board Diagnostic Function Does Not Work
- No. 2 Blower Motor Does Not Operate/Blower Motor Does Not Operate Properly
- No. 3 Air Intake Actuator Does Not Operate
- No. 4 Electrical Load Idle-Up Does Not Operate
- No. 5 Information Display And Switch Lights Do Not Dim Or Illuminate
- No. 6 Any Or All Switch Lights Of The Climate Control Unit Do Not Illuminate
- No. 7 Information Display Indicators Do Not Illuminate Entirely Or Normally
- No. 8 Set Temperature Indicator Does Not Change Ambient Temperature Indicator
- No. 9 Always Starts When Specified Temperature Is Set
- No. 10 Magnetic Clutch, Condenser Fan, And A/C Compressor Idle-Up Do Not Operate
- No. 11 Magnetic Clutch And Condenser Fan Do Not Operate
- No. 12 Magnetic Clutch Does Not Operate
- No. 13 Condenser Fan Does Not Operate
- No. 14 Condenser Fan Does Not Operate At Low Speed
- No. 15 Condenser Fan Does Not Operate At High Speed
- No. 16 Control System Inoperative
- No. 17 Air From Vents Not Cold Enough
- No. 18 Vane Noise Occurs
- Refrigerant System Service Warnings
- Refrigerant System Service Cautions
- Refrigerant System General Procedures
- Refrigerant System Performance Test
- Refrigerant Pressure Check
- Refrigerant Charging
- Basic System Location Index
- Blower Unit Removal/Installation
- Blower Unit Disassembly/Assembly
- Heater Unit Removal/Installation
- Heater Unit Disassembly/Assembly
- Heater Core Inspection
- Cooling Unit Removal/Installation
- Cooling Unit Disassembly/Assembly
- Evaporator Inspection
- Air Filter Removal/Installation
- Air Filter Inspection
- Rear Heat Duct Removal/Installation
- A/C Compressor Removal/Installation
- Receiver/Drier Removal/Installation
- Condenser Removal/Installation
- Condenser Inspection
- Refrigerant Lines Removal/Installation
- Control System Location Index
- Magnetic Clutch Inspection
- Magnetic Clutch Adjustment
- Magnetic Clutch Disassembly/Assembly
- Condenser Fan Inspection
- Condenser Fan Removal/Installation
- Air Intake Actuator Removal/Installation
- Air Intake Actuator Inspection
- Air Mix Actuator Removal/Installation
- Air Mix Actuator Inspection
- Airflow Mode Actuator Removal/Installation
- Airflow Mode Actuator Inspection
- Blower Motor Inspection
- Blower Motor Removal/Installation
- Ambient Temperature Sensor Inspection
- Ambient Temperature Sensor Removal/Installation
- Solar Radiation Sensor Removal/Installation
- Solar Radiation Sensor Inspection
- Evaporator Temperature Sensor Inspection
- Evaporator Temperature Sensor Removal/Installation
- Passenger Compartment Temperature Sensor Removal/Installation
- Passenger Compartment Temperature Sensor Inspection
- Refrigerant Pressure Switch Inspection
- Refrigerant Pressure Switch Removal/Installation
- Thermal Protector Removal/Installation
- Pressure Relief Valve Removal/Installation
- Climate Control Component Removal/Installation
- Climate Control Component Disassembly/Assembly
- Climate Control Unit Inspection
- A/C Amplifier Inspection
- Power Mos FET Inspection
- Power Mos FET Removal/Installation
- Relay Inspection
- HVAC Technical Data
- HVAC SST
- Torque Specifications
- Wiring Diagrams
- Specifications
- HVAC System - Automatic A/C-Heater Systems
- General Servicing
- Cabin Air Filter
- HVAC System - Automatic A/C-Heater Systems
- Air Conditioner System On-Board Diagnostic (OBD)
- DTC 2: Malfunction In Solar Radiation Sensor System
- DTC 6, 7: Malfunction In Passenger Compartment Temperature Sensor System
- DTC 10, 11: Malfunction In Evaporator Temperature Sensor System
- DTC 12, 13: Malfunction In Ambient Temperature Sensor System
- DTC 14, 15: Malfunction In Water Temperature Sensor System
- DTC 18, 19, 58: Malfunction In Air Mix Actuator System
- DTC 21, 22, 59: Malfunction In Airflow Mode Actuator System
- Troubleshooting Index
- No. 1 On-Board Diagnostic Function Does Not Work
- No. 2 Blower Motor Does Not Operate/Blower Motor Does Not Operate Properly
- No. 3 Air Intake Actuator Does Not Operate
- No. 4 Electrical Load Idle-Up Does Not Operate
- No. 5 Information Display And Switch Lights Do Not Dim Or Illuminate
- No. 6 Any Or All Switch Lights Of The Climate Control Unit Do Not Illuminate
- No. 7 Information Display Indicators Do Not Illuminate Entirely Or Normally
- No. 8 Set Temperature Indicator Does Not Change Ambient Temperature Indicator
- No. 9 Always Starts When Specified Temperature Is Set
- No. 10 Magnetic Clutch, Condenser Fan, And A/C Compressor Idle-Up Do Not Operate
- No. 11 Magnetic Clutch And Condenser Fan Do Not Operate
- No. 12 Magnetic Clutch Does Not Operate
- No. 13 Condenser Fan Does Not Operate
- No. 14 Condenser Fan Does Not Operate At Low Speed
- No. 15 Condenser Fan Does Not Operate At High Speed
- No. 16 Control System Inoperative
- No. 17 Air From Vents Not Cold Enough
- No. 18 Vane Noise Occurs
- Refrigerant System Service Warnings
- Refrigerant System Service Cautions
- Refrigerant System General Procedures
- Refrigerant System Performance Test
- Refrigerant Pressure Check
- Refrigerant Charging
- Basic System Location Index
- Blower Unit Removal/Installation
- Blower Unit Disassembly/Assembly
- Heater Unit Removal/Installation
- Heater Unit Disassembly/Assembly
- Heater Core Inspection
- Cooling Unit Removal/Installation
- Cooling Unit Disassembly/Assembly
- Evaporator Inspection
- Air Filter Removal/Installation
- Air Filter Inspection
- Rear Heat Duct Removal/Installation
- A/C Compressor Removal/Installation
- Receiver/Drier Removal/Installation
- Condenser Removal/Installation
- Condenser Inspection
- Refrigerant Lines Removal/Installation
- Control System Location Index
- Magnetic Clutch Inspection
- Magnetic Clutch Adjustment
- Magnetic Clutch Disassembly/Assembly
- Condenser Fan Inspection
- Condenser Fan Removal/Installation
- Air Intake Actuator Removal/Installation
- Air Intake Actuator Inspection
- Air Mix Actuator Removal/Installation
- Air Mix Actuator Inspection
- Airflow Mode Actuator Removal/Installation
- Airflow Mode Actuator Inspection
- Blower Motor Inspection
- Blower Motor Removal/Installation
- Ambient Temperature Sensor Inspection
- Ambient Temperature Sensor Removal/Installation
- Solar Radiation Sensor Removal/Installation
- Solar Radiation Sensor Inspection
- Evaporator Temperature Sensor Inspection
- Evaporator Temperature Sensor Removal/Installation
- Passenger Compartment Temperature Sensor Removal/Installation
- Passenger Compartment Temperature Sensor Inspection
- Refrigerant Pressure Switch Inspection
- Refrigerant Pressure Switch Removal/Installation
- Thermal Protector Removal/Installation
- Pressure Relief Valve Removal/Installation
- Climate Control Component Removal/Installation
- Climate Control Component Disassembly/Assembly
- Climate Control Unit Inspection
- A/C Amplifier Inspection
- Power Mos FET Inspection
- Power Mos FET Removal/Installation
- Relay Inspection
- HVAC Technical Data
- HVAC SST
- Torque Specifications
- Wiring Diagrams
- Specifications
- HVAC Control Systems
- HVAC System - Automatic A/C-Heater Systems
- Air Conditioner System On-Board Diagnostic (OBD)
- DTC 2: Malfunction In Solar Radiation Sensor System
- DTC 6, 7: Malfunction In Passenger Compartment Temperature Sensor System
- DTC 10, 11: Malfunction In Evaporator Temperature Sensor System
- DTC 12, 13: Malfunction In Ambient Temperature Sensor System
- DTC 14, 15: Malfunction In Water Temperature Sensor System
- DTC 18, 19, 58: Malfunction In Air Mix Actuator System
- DTC 21, 22, 59: Malfunction In Airflow Mode Actuator System
- Troubleshooting Index
- No. 1 On-Board Diagnostic Function Does Not Work
- No. 2 Blower Motor Does Not Operate/Blower Motor Does Not Operate Properly
- No. 3 Air Intake Actuator Does Not Operate
- No. 4 Electrical Load Idle-Up Does Not Operate
- No. 5 Information Display And Switch Lights Do Not Dim Or Illuminate
- No. 6 Any Or All Switch Lights Of The Climate Control Unit Do Not Illuminate
- No. 7 Information Display Indicators Do Not Illuminate Entirely Or Normally
- No. 8 Set Temperature Indicator Does Not Change Ambient Temperature Indicator
- No. 9 Always Starts When Specified Temperature Is Set
- No. 10 Magnetic Clutch, Condenser Fan, And A/C Compressor Idle-Up Do Not Operate
- No. 11 Magnetic Clutch And Condenser Fan Do Not Operate
- No. 12 Magnetic Clutch Does Not Operate
- No. 13 Condenser Fan Does Not Operate
- No. 14 Condenser Fan Does Not Operate At Low Speed
- No. 15 Condenser Fan Does Not Operate At High Speed
- No. 16 Control System Inoperative
- No. 17 Air From Vents Not Cold Enough
- No. 18 Vane Noise Occurs
- Refrigerant System Service Warnings
- Refrigerant System Service Cautions
- Refrigerant System General Procedures
- Refrigerant System Performance Test
- Refrigerant Pressure Check
- Refrigerant Charging
- Basic System Location Index
- Blower Unit Removal/Installation
- Blower Unit Disassembly/Assembly
- Heater Unit Removal/Installation
- Heater Unit Disassembly/Assembly
- Heater Core Inspection
- Cooling Unit Removal/Installation
- Cooling Unit Disassembly/Assembly
- Evaporator Inspection
- Air Filter Removal/Installation
- Air Filter Inspection
- Rear Heat Duct Removal/Installation
- A/C Compressor Removal/Installation
- Receiver/Drier Removal/Installation
- Condenser Removal/Installation
- Condenser Inspection
- Refrigerant Lines Removal/Installation
- Control System Location Index
- Magnetic Clutch Inspection
- Magnetic Clutch Adjustment
- Magnetic Clutch Disassembly/Assembly
- Condenser Fan Inspection
- Condenser Fan Removal/Installation
- Air Intake Actuator Removal/Installation
- Air Intake Actuator Inspection
- Air Mix Actuator Removal/Installation
- Air Mix Actuator Inspection
- Airflow Mode Actuator Removal/Installation
- Airflow Mode Actuator Inspection
- Blower Motor Inspection
- Blower Motor Removal/Installation
- Ambient Temperature Sensor Inspection
- Ambient Temperature Sensor Removal/Installation
- Solar Radiation Sensor Removal/Installation
- Solar Radiation Sensor Inspection
- Evaporator Temperature Sensor Inspection
- Evaporator Temperature Sensor Removal/Installation
- Passenger Compartment Temperature Sensor Removal/Installation
- Passenger Compartment Temperature Sensor Inspection
- Refrigerant Pressure Switch Inspection
- Refrigerant Pressure Switch Removal/Installation
- Thermal Protector Removal/Installation
- Pressure Relief Valve Removal/Installation
- Climate Control Component Removal/Installation
- Climate Control Component Disassembly/Assembly
- Climate Control Unit Inspection
- A/C Amplifier Inspection
- Power Mos FET Inspection
- Power Mos FET Removal/Installation
- Relay Inspection
- HVAC Technical Data
- HVAC SST
- Torque Specifications
- Wiring Diagrams
- Specifications
- HVAC System - Automatic A/C-Heater Systems
- A/C Compressor
- Restraints
- Air Bag, SRS
- Air Bag System
- Description & Operation
- Component Locations
- System Operation Check
- Air Bag Safety Precautions
- Adjustments
- Disabling & Activating Air Bag System
- Disposal Procedures
- Post-Collision Inspection
- Removal & Installation
- Diagnostics
- Diagnostic Tests
- Test A: Air Bag Warning Light Does Not Illuminate After Ignition Is Turned On
- Test B: Air Bag Warning Light Stays On Constant After Ignition Is Turned On
- DTC 1: SAS Control Module Poor Connection
- DTC 2: SAS Control Module Internal Malfunction
- DTC 3: Power Supply Of SAS Control Module
- DTC 6: Driver-Side Air Bag Module Circuit
- DTC 7: Passenger-Side Air Bag Module Circuit
- DTC 22: Left Side Air Bag Sensor Internal Circuit
- DTC 25: Left Side Air Bag Sensor Communication Error
- DTC 26: Left Side Air Bag Module Circuit
- DTC 32: Right Side Air Bag Sensor Internal Circuit
- DTC 35: Right Side Air Bag Sensor Communication Error
- DTC 37: Right Side Air Bag Module Circuit
- DTC 91: Air Bag Warning Light Circuit
- Wire Repair
- Torque Specifications
- Wiring Diagrams
- Air Bag System
- Air Bag, SRS
- Steering
- Manual Steering
- Power Rack & Pinion
- Description
- Lubrication
- Adjustments
- System Tests
- Removal & Installation
- Overhaul
- Steering Gear
- Power Steering Pump
- Notes
- Exploded View Of Power Steering Pump (Protege 1.8L Engine)
- Exploded View Of Power Steering Pump (Protege 1.6L Engine)
- Exploded View Of Power Steering Pump (Millenia 2.5L Engine; 626 2.5L Engine Is Similar)
- Exploded View Of Power Steering Pump (Millenia 2.3L Engine)
- Exploded View Of Power Steering Pump (626 2.0L Engine)
- Exploded View Of Power Steering Pump (MPV)
- Torque Specifications
- Power Rack & Pinion
- Power Steering
- Power Rack & Pinion
- Description
- Lubrication
- Adjustments
- System Tests
- Removal & Installation
- Overhaul
- Steering Gear
- Power Steering Pump
- Notes
- Exploded View Of Power Steering Pump (Protege 1.8L Engine)
- Exploded View Of Power Steering Pump (Protege 1.6L Engine)
- Exploded View Of Power Steering Pump (Millenia 2.5L Engine; 626 2.5L Engine Is Similar)
- Exploded View Of Power Steering Pump (Millenia 2.3L Engine)
- Exploded View Of Power Steering Pump (626 2.0L Engine)
- Exploded View Of Power Steering Pump (MPV)
- Torque Specifications
- Power Rack & Pinion
- Steering Column
- Manual Steering
- Suspension
- Front Suspension
- Front Suspension Location Index
- Front Shock Absorber And Coil Spring
- Front Lower Arm
- Removal/Installation
- Notes
- Engine Mount Member Removal Note
- Tie-Rod End Ball Joint Removal Note
- Lower Ball Joint Removal Note
- Dust Boot (Lower Ball Joint) Removal Note
- Lower Arm Removal Note
- Lower Arm Bushing (Front) Removal Note
- Lower Ball Joint Installation Note
- Dust Boot (Lower Ball Joint) Installation Note
- Lower Arm Bushing (Front) Installation Note
- Lower Arm Bushing (Rear) Installation Note
- Front Lower Arm Inspection
- Removal/Installation
- Upper Lateral Link
- Front Upper Leading Link
- Front Stabilizer
- Front CROSSMEMBER
- Torque Specifications
- Rear Suspension
- Rear Suspension
- Hub Spindle Assembly
- Rear Suspension Location Index
- Rear Shock Absorber & Spring
- Rear Shock Absorber & Coil Spring Removal/Installation
- Rear Package Front Trim Removal/Installation (Canada)
- Rear Package Front Trim Removal/Installation (Except Canada)
- C-Pillar Trim Removal/Installation
- Tire House Trim Removal/Installation
- Rear Personal Light Removal/Installation
- Rear Seat Removal/Installation
- Rear Scuff Plate Removal/Installation
- Rear Shock Absorber
- Rear Lateral Links
- Lower Lateral Link, Upper Lateral Link & Rear Lower Lateral Link Removal/Installation
- Notes
- Upper Lateral Link Ball Joint Removal Note
- Nut, Cam Plate, & Adjusting Cam Bolt Removal Note
- Dust Boot (Lower Lateral Link) Removal Note
- Lower Lateral Link Bushing Removal Note
- Damper Bushing Removal Note
- Dust Boot (Upper Lateral Link) Removal Note
- Dust Boot (Lower Lateral Link) Installation Note
- Dust Boot (Upper Lateral Link) Installation Note
- Dust Boot (Rear Lower Lateral Link) Installation Note
- Lower Lateral Link Bushing Installation Note
- Damper Bushing Installation Note
- Nut, Cam Plate & Adjusting Cam Bolt Installation Note
- Lower Lateral Link, Upper Lateral Link & Rear Lower Lateral Link Removal/Installation
- Lower Lateral Link, Upper Lateral Link & Rear Lower Lateral Link Inspection
- Rear Trailing Links
- Lower Trailing Link & Upper Trailing Link Removal/Installation
- Notes
- Lower Trailing Link Ball Joint Removal Note
- Dust Boot (Lower Trailing Link) Removal Note
- Upper Trailing Link Ball Joint Removal Note
- Dust Boot (Upper Trailing Link) Removal Note
- Dust Boot (Lower Trailing Link) Installation Note
- Dust Boot (Upper Trailing Link) Installation Note
- Lower Trailing Link & Upper Trailing Link Inspection
- Lower Trailing Link & Upper Trailing Link Removal/Installation
- Rear Stabilizer
- Stabilizer Control Link (Front/Rear)
- Rear CROSSMEMBER
- Wheel Bearing
- Torque Specifications
- Suspension Technical Data
- Service Tools
- Rear Suspension
- Specifications & Procedures - Wheel Alignment
- Front Suspension
- Transmission
- Automatic Trans
- Automatic Transaxle - Overhaul [GF4A-El]
- Application
- Identification
- Description & Operation
- Lubrication
- On-Vehicle Service
- Trouble Shooting
- Transaxle Disassembly
- Component Disassembly & Reassembly
- Torque Converter
- Oil Pump
- Accumulators
- Forward, Coasting & Reverse Clutches
- Small Sun Gear & One-Way Clutch No. 1
- One-Way Clutch No. 2 & Planetary Carrier
- 3-4 Clutch
- Low-Reverse Brake
- 2-4 Brake Band Servo
- 2-4 Brake Band
- Differential Assembly
- Output Gear
- Idler Gear Assembly
- Bearing Cover Assembly
- Valve Body Assembly
- Transaxle Reassembly
- Torque Specifications
- Transaxle Specifications
- Automatic Transmission - Diagnosis - GF4A-El
- Application
- Identification
- Description & Operation
- Component Locations
- Trouble Shooting
- Preliminary Inspection
- Symptom Diagnosis
- Notes
- Vehicle Does Not Move In "D", "S", "L" Or "R"
- Vehicles Moves In "P" Or "N"
- Excessive Creep
- No Creep
- Poor Acceleration
- Transaxle Will Not Shift
- No Shift To 4th Gear
- Abnormal Shift
- Frequent Shifting
- Shift Speeds Too High Or Too Low
- No Torque Converter Clutch
- No Kickdown
- Transaxle Shift Flare
- Shudder During TCC Lockup
- Excessive Gear Engagement Shock
- Excessive Gear Shift Shock
- Excessive TCC Shift Shock
- Noise At Idle When Vehicle Stopped
- No Engine Braking In HOLD Mode
- Transaxle Overheats
- Engine Stalls During Shift To "D", "S", "L" &/Or "R"
- Surges While Cruising
- Lack Of Power
- Poor Fuel Economy
- Clutch & Band Application
- Shift Solenoid Application Diagnosis
- Performance Tests
- Self-Diagnostic System
- Diagnostic Tests
- DTC P0500: Vehicle Speed Sensor Circuit Fault
- DTC P0705: Transaxle Range Switch Circuit Shorted To Power
- DTC P0706: Transaxle Range Switch Circuit Open
- DTC P0710: Transaxle Fluid Temperature Sensor Circuit Shorted To Ground Or Open
- DTC P0711: Transaxle Fluid Temperature Sensor Circuit Fault (Stuck)
- DTC P0715: Input/Turbine Speed Sensor Circuit Fault
- DTC P0731: Incorrect 1ST Gear Ratio
- DTC P0732: Incorrect 2ND Gear Ratio
- DTC P0733: Incorrect 3RD Gear Ratio
- DTC P0734: Incorrect 4TH Gear Ratio
- DTC P0740: Torque Converter Clutch System Fault
- DTC P0745: Pressure Control Solenoid Fault
- DTC P0750: Shift Solenoid "A" Fault
- DTC P0755: Shift Solenoid "B" Fault
- DTC P0760: Shift Solenoid "C" Fault
- DTC P1743: Torque Converter Clutch Control Solenoid Circuit Fault
- DTC P1765: 3-2 Timing Solenoid Circuit Fault
- Component Tests
- Connector Identification
- Pin Voltage Tests
- Wiring Diagrams
- Hydraulic Diagrams - GF4A-El
- Servicing - A/T
- Shift Interlock Systems
- Automatic Transaxle - Overhaul [GF4A-El]
- Hydraulic Diagrams - GF4A-El
- Automatic Trans
- External Pages