Technical Service Bulletins

Accessories & Equipment
- All Models - WDS Ms-Can 5-Meter Cable (ST-003/04)
- Special Service Tool Shipment - June 2006 (ST-003/06)
- Availability Of Non-Required Tools - April 2007 (ST-003/07)
- Special Tool Shipment - February 2006 (ST-001/06)
- All Models - WDS Ms-Can 16-Pin Cable Shipment (ST001/03)
Accessories Control Systems
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
- Precautions For Module Reprogramming (01-030/08)
Accessory Drive Belts
- Diagnostic Procedure For Engine Noise Repair (01-053/09)
Air Bag, SRS
- Standard Deployment/Two-Step Deployment For Air Bag System (MT-003/18)
- Non Genuine Accessories Affect On Air Bag Operation (CAT. T, NO. 023/96)
Anti-Lock Brakes
- Clunk/Bang/Buzz Noise During First Forward Movement After Sitting (04-009/06)
Anti-Theft Systems
- Keyless Entry Remote Transmitter (Key Fob) Battery Replacement Caution (09-041/10)
- Retractable Type Keyless Transmitter Does Not Work (09-003/10)
- Advanced Keyless System Inoperative (09-028/06)
- Doors Cannot Be Locked/Unlocked Using Transmitter - Battery Is OK (09-035/06)
- Security Access Procedure Change For Coded Access Pats And Advanced Keyless System - Service Tip (09-003/06)
Automatic Trans
- Automatic Transmission/Transaxle Cooler And Lines Flushing Procedure (05-012/10)
- Correct Application For ATF M-V (Type M5), MERCON®V, MERCON®LV, And JWS3309 (T-IV) Automatic Transmission Fluids (05-005/08)
- Diagnostic Procedure For Engine Noise Repair (01-053/09)
Auxiliary Emission Control Systems
- Multi-Model - Determining Evaporative System Leak Location For DTCS P0441/P0442/P0455/P0456 (01-023/10)
- Mode 06 Monitor Test Value Of Oxygen Sensor Output - Improper Readings (01-037/07)
- Ids / PDS Update For MAZDA Modular Diagnostic System (M-MDS) (01-014/06)
Axle Shafts
- Clunk Noise From Drive Shaft (03-002/10)
- Special Service Tool Shipment - June 2007 (ST-004/07)
Body Electrical
- "Ten" Terminal On 17-Pin Diagnostic Connector (5809)
Body Interior
- As-Built Data Search On Ms3 (00-001/10)
Brakes Control Systems
- Clunk/Bang/Buzz Noise During First Forward Movement After Sitting (04-009/06)
- As-Built Data Search On Ms3 (00-001/10)
- Precautions For Module Reprogramming (01-030/08)
- Abs/DSC Active Command On M-MDS - False DTC C1096 - Service Tip (04-008/06)
Charging Systems
- Special Service Tool Shipment - October 2011 (ST-002/11)
- Battery Test Procedure Requirements Using The Gr8-1291 (01-054-10)
- Diagnostic Procedure For Engine Noise Repair (01-053/09)
Clutch
- Manual Transmission - Clutch Hard To Disengage (05-010/07)
- Squeaking Noise From Clutch Pedal When Depressed (05-002/06)
Cooling System (Mechanical)
- Water Pump Coolant Leak (01-022/19)
- Pre-Mixed Long-Life "Fl22" Engine Coolant (01-033/07)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Mode 6 Thermostat Monitor Below Lower Test Limit (01-023/08)
- Reconditioned Anti-Freeze (CAT. E, NO. 002/96)
Differentials & Drive Axles
- Whining Noise From Rear Differential (03-004/14)
- Differential Oil Level - Service Tip (03-003/06)
Engine Control Systems
- Multi-Model - Determining Evaporative System Leak Location For DTCS P0441/P0442/P0455/P0456 (01-023/10)
- Oxygen/Air Fuel Ratio Sensor Removal Caution (01-051/09)
- As-Built Data Search On Ms3 (00-001/10)
- Mil Illuminated - P0455 Set (01-040/09)
- MAZDA Special Program (MSP13) - Mil Illumination With DTC P0455 (01-041/09)
- Unstable Idling/Engine Stalls Just After Stopping (01-007/09)
- Mil Illumination - DTC P0441 (01-003/09)
- "Ten" Terminal On 17-Pin Diagnostic Connector (5809)
- Generic OBDII Application For Ids (5670)
- No COMMS Recovery Procedure For Blanked Modules (5878)
- Precautions For Module Reprogramming (01-030/08)
- Ids / PDS Update For MAZDA Modular Diagnostic System (M-MDS) (01-014/06)
Entertainment Systems
- SIRIUSXM Satellite Radio Registration Transfer After Unit Replacement (09-030/13)
- Rattle Noise From Audio System When Driving (09-038/09)
- SIRIUS Satellite Radio Activation (09-025/06)
- Popping Noise From Radio When Passing Over Bumps (09-011/07)
- Am Radio - Poor Reception (09-010/07)
Exhaust
- Sulfur Smell From Exhaust System (CAT. 01, NO. 029/02)
- Replacing Engine Check Intake And Exhaust Debris (6757)
Exterior Body Panels
- Service Bumper Specification Change (09-022/09)
Exterior Lights
- Condensation/Fog In Front And Rear Combination Lamps (Headlamp And TAILLAMP Assemblies) (09-049/14)
- Condensation/Fog In Front And Rear Combination Lights (09-057/10)
- Water Drops Trapped Under High Mount Stop Light Lens (09-004/09)
Frames, Subframes & Crossmembers
- Service Bumper Specification Change (09-022/09)
- Front License Plate Bracket - Installation Instructions - Service Tip (09-011/06)
Fuel System
- Sulfur Smell From Exhaust System (CAT. 01, NO. 029/02)
- Special Service Tool Shipment - October 2011 (ST-002/11)
- Unstable Idling/Engine Stalls Just After Stopping (01-007/09)
- Mil Illumination - DTC P0441 (01-003/09)
- Replacing Engine Check Intake And Exhaust Debris (6757)
- Fuel System Servicing Procedure Precaution (01-042/07)
- CALIFORNIA Reformulated Gasoline (Effect On Vehicle Performance And Fuel Economy) (CAT. F, NO. 014/96)
Gauges & Instrument Panels
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
- Elimination Of Odometer Write For MAZDA Modular Diagnostic System (M-MDS) (01-031/10)
- Odometer Data Configuration (09-034/06)
Headlights
- Condensation/Fog In Front And Rear Combination Lamps (Headlamp And TAILLAMP Assemblies) (09-049/14)
- Headlight Plastic Lens Maintenance Caution (09-035/09)
- Condensation/Fog In Front And Rear Combination Lights (09-057/10)
HVAC Control Systems
- Air Conditioning Musty/Mildew Odor (07-006/07)
- Poor Blower Performance / Wet Passenger Floor (5768)
- Abnormal Heater Performance At Idle (07-001/06)
- Use Of A/C Tracer Dye (U-008/97)
Identification
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
Ignition Switch/Steering Lock
- Establishment Of Ignition Key Knob Base (09-019/12)
Ignition System
- Engine Misfire Diagnostic Procedures - Service Tip (01-002/06)
- Spark Plug Installation / Removal Caution (01-036/06)
Infotainment
- Short Antenna (5710)
Interior/Exterior Trim
- Proper Usage Of Driver's Floor Mat (09-027/14)
- Exterior Trim Heat Damage (MT-038/16)
- Headlight Plastic Lens Maintenance Caution (09-035/09)
- Dashboard Upper Surface Poor Appearance (09-038/12)
- Water Accumulation In FOOTWELL/Plugged Soft Top Drains (09-046/10)
- Front Windshield Protector - Cowl Removal Service Tip (7370)
- Establishment Of Service Felt Under Floor Mat (09-012/09)
- Squeaking Noise Around Rear Center Console Lid (09-040/08)
- Center Console Side Wall Removal Caution - Service Tip (09-007/07)
- Gap Appears In Hard Plastic Door Trim Panels (09-006/07)
- Center Console Lid Will Not Stay Closed (09-033/06)
Lubrication System
- High Engine Oil Consumption (MT-012/15)
- Correct Oil Filter Wrenches For LF And L3 Engines (5728)
Manual Trans
- Diagnostic Procedure For Engine Noise Repair (01-053/09)
Mechanical
- High Engine Oil Consumption (MT-012/15)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Special Service Tool Shipment - October 2011 (ST-002/11)
- Variable Valve Timing (VVT) Noise When Starting Engine (01-043/07)
- Diagnostic Procedure For Engine Noise Repair (01-053/09)
- Service Points For Engine Replacement Due To Engine Noise (01-042/09)
- Engine Compartment Shroud Panel Poor Appearance (09-034/09)
- Correct Oil Filter Wrenches For LF And L3 Engines (5728)
- Special Service Tool Shipment - June 2007 (ST-004/07)
- Front Crankshaft Bolt Service Warning (01-040/07)
Mechanical - Hydraulic
- Brake Noise, Judder And Dragging Diagnosis And Servicing (04-007/11)
- On-Car Brake Lathe (ST-001/11)
- Discontinuation Of Front Disc Plate Fixing Screws (04-001/13)
- Front Brake Creaking At Low Speeds (04-001/09)
- Front Brake Creaking At Low Speeds (04-004/07)
Paint & Coatings
- MAZDA Paint Program (MPP02) - Paint OVERSPRAY On Exterior Surfaces (09-017/06)
Passive Restraints
- Seat Belt Slow To Retract (08-001/11)
- 2006 MIATA / 2007-2011 MX5 - Seat Belt Slow To Retract (7526)
- Squeak And/Or Rattle Noise From Front Seat Belt Buckle (08-003/09)
Procedures
- MAZDA Guidelines For Factory Scheduled Maintenance (00-004/12)
- Carb Regulation (CALIFORNIA Only) - Mandatory Tire Pressure Check (MT-015/10)
Restraints Control Systems
- Passenger Airbag Deactivation (Pad) Indicator Light Illumination (08-003/11)
- As-Built Data Search On Ms3 (00-001/10)
Schedule
- MAZDA Guidelines For Factory Scheduled Maintenance (00-004/12)
Seats
- Squeaking Noise From Seat Back Due To Frame And Seat Back Pad Contact (09-069/09)
- Squeaking Noise From Seat Back Due To Frame And Spring Contact (09-064/09)
- Squeaking Noise From Under Driver Seat Lifter Link (09-065/09)
- Clunk Noise From Seat When Braking (09-060/09)
- Squeaking Noise From Leather Seats (09-062/09)
Starter
- 12 Volt Battery Test Procedure Requirements For Warranty (Using The COA-8000PM) (01-054/10)
- Battery Maintenance (01-029/06)
- All Models - Use Gr8 Battery Charger When Reprogramming Modules (MT-014/17)
- Battery Test Procedure Requirements Using The Gr8-1291 (01-054-10)
- Special Service Equipment Distribution - November 2010 (ST-002/10)
- JIS/BCI Standard To CCA Conversion Chart (01-010/10)
- JIS/BCI Standard To CCA Conversion Chart (00-003/09)
- Battery Charging Cautions (CAT. 01, NO. 012/99)
Steering Column
- Body Vibration Or Steering Wheel Shimmy (CAT. 02, NO. 001/03)
Steering Control Systems
- Precautions For Module Reprogramming (01-030/08)
Sun Roof/T-Top/Convertible Top
- Water Accumulation In FOOTWELL/Plugged Soft Top Drains (09-046/10)
- Header Weatherstrip - Butyl Adhesive Issues (09-001/06)
- Interference Between Soft Top And BELTLINE Molding (09-018/06)
- Water Leak Above Side Windows (09-036/06)
- Water Leak At Front Of Convertible Top (09-013/06)
Suspension Control Systems
- Precautions For Module Reprogramming (01-030/08)
System
- Multi-Model - Determining Evaporative System Leak Location For DTCS P0441/P0442/P0455/P0456 (01-023/10)
- Oxygen/Air Fuel Ratio Sensor Removal Caution (01-051/09)
- Mass Air Flow (MAF) Sensor Inspection Procedure (01-009/12)
- Mil Illuminated - P0455 Set (01-040/09)
- MAZDA Special Program (MSP13) - Mil Illumination With DTC P0455 (01-041/09)
- Mil Illumination - DTC P0441 (01-003/09)
- "Ten" Terminal On 17-Pin Diagnostic Connector (5809)
- Generic OBDII Application For Ids (5670)
- No COMMS Recovery Procedure For Blanked Modules (5878)
- Mt - Mil On - P0507 Set (01-036/08)
- Revised Workshop Manual Diagnostic Procedure For P0441 (01-029/08)
- Fuel System Servicing Procedure Precaution (01-042/07)
- Engine Misfire Diagnostic Procedures - Service Tip (01-002/06)
- Mil Comes On With DTC P2407 (LDP Sensor Erratic) (01-037/06)
- Mil On With DTC P0106 (01-044/06)
- Update Warnings On Ids (Laptop Pc) And PFM (PDS File Manager) For MAZDA Modular Diagnostic System (M-MDS) (01-028/06)
Transmission Control Systems
- As-Built Data Search On Ms3 (00-001/10)
- Precautions For Module Reprogramming (01-030/08)
Wheel Hubs
- Discontinuation Of Front Disc Plate Fixing Screws (04-001/13)
Wheels & Tire System
- Carb Regulation (CALIFORNIA Only) - Mandatory Tire Pressure Check (MT-015/10)
- Body Vibration Or Steering Wheel Shimmy (MT-012/18)
- Service Caution For TPMS (02-007/09)
- Body Vibration Or Steering Wheel Shimmy (CAT. 02, NO. 001/03)
- MAZDA Wheel Lock Installation - Service Tip (02-001/06)
Window Motors & Regulators
- Diagnostic Tips For Windshield Flaws/Scratches/Cracks Caused By External Factors (09-002/10)
- Header Weatherstrip - Butyl Adhesive Issues (09-001/06)
Wiper/Washer Systems
- Multi-Model - Wiper Rubber Insert Replacement (09-009/10)
- Windshield Wiper Blade Maintenance And Cleaning (09-006/06)