Technical Service Bulletins

Accessories Control Systems
- Fuel Gauge Erratic/Inaccurate And/Or Mil On With DTC P0463, B1202, B2627, B2879, And/Or P2068 (06-17-2)
- Intermittent Instrument Cluster Operation - Including Gauges Sweep/Reset - Multiple Warning Lights Illuminated And/Or Reverse Lights Stay On - Vehicles Built Before 2/17/2006 (06-6-2)
Aerodynamic Devices
- Paint Degradation To Body Side (05-26-8)
Air Bag, SRS
- RCM Fault Reporting Using DTCS And Bit-Mapped Parameter Identifiers (PIDS) - Service Tips (07-7-8)
- Air Bag Light On With DTC B2290 - Difficult To Duplicate (06-20-2)
Anti-Lock Brakes
- Traction Control Lamp On - No DTCS Present, Or DTC P1889 In Differential Electronic Module (DEM) (08-4-11)
Anti-Theft Systems
- Keypad Diagnostics - Dealer Installed Accessory (06-15-8)
Automatic Trans
- AISIN Transmission Harsh Shifting - No DTC Mileage Above 20,000 Miles (32,200 Km) (08-24-1)
- Transmission Shifter Binding/High Effort - Bezel Replacement (07-1-8)
- Continuously Variable Transaxle (CVT) Noise Diagnosis (06-11-4)
- Harsh/Erratic/Slow Downshifts Or Tip-In Hesitation - 6 Speed Automatic Transaxle - Vehicles Built Before 10/17/2005 (05-24-5)
Auxiliary Emission Control Systems
- Idle Rpm Fluctuation With Or Without DTCS - P0505, P0506 And/Or P061B (11-8-5)
- Mil On - DTCS P0106, P0109, P2111, P2112, And Or P2072 (08-9-7)
- Wrench Light On - No DTCS And/Or U0401 (07-2-2)
- Long Cranking Time Or No Start On Initial Start Attempt - Vehicles Built On Or Before 6/6/2006 (06-20-7)
- Mil On With DTC P0460 (06-18-6)
- Long Cranking Time Or No Start On Initial Start Attempt (06-12-7)
- 3.0L - Engine Oil Leak From Dipstick - Heated PCV Service Kit (05-25-12)
Body Electrical
- Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)
Body Interior
- Fuel Gauge Erratic/Inaccurate And/Or Mil On With DTC P0463, B1202, B2627, B2879, And/Or P2068 (06-17-2)
Brakes Control Systems
- Traction Control Lamp On - No DTCS Present, Or DTC P1889 In Differential Electronic Module (DEM) (08-4-11)
Charging Systems
- Stuck High Voltage Charge Cord Information Sheet (G0000127)
Collision/Avoidance
- Parking Aid Speaker Inoperative - DTCS C1742 And C1743 (06-20-5)
Cooling System (Mechanical)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
Engine Control Systems
- Idle Rpm Fluctuation With Or Without DTCS - P0505, P0506 And/Or P061B (11-8-5)
- Mil On - DTCS P0106, P0109, P2111, P2112, And Or P2072 (08-9-7)
- Fuel Filler Cap Binding, Fuel Cap Light / Warning Message And/Or DTC P0457 (07-6-6)
- Slow Fuel Fill/Premature Shut Off (07-11-15)
- Mil On With DTC P0191 - Fuel Rail Pressure Sensor Circuit Performance (07-4-7)
- Wrench Light On - No DTCS And/Or U0401 (07-2-2)
- Long Cranking Time Or No Start On Initial Start Attempt - Vehicles Built On Or Before 6/6/2006 (06-20-7)
- Mil On With DTC P0460 (06-18-6)
- Long Cranking Time Or No Start On Initial Start Attempt (06-12-7)
- DTC P2107 And/Or P2110 - Long Crank Times - Vehicles Built Before 12/14/2005 (05-26-17)
- WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
- Engine Rpm Fluctuation At Highway Cruising Speeds (05-17-5)
Entertainment Systems
- Pioneer Navigation Radio - Seek Function Inoperative - Service Tip (06-25-3)
- Audio / Navigation Service And Ordering Procedures (06-21-7)
- Am Radio Static When Driving (05-18-16)
Exhaust
- Various Vehicles - Catalytic Converter Concern Analysis (22-7009)
- Exhaust System Rattle/Buzz While Driving (06-21-5)
Exterior Body Panels
- Fuel Filler Cap Binding, Fuel Cap Light / Warning Message And/Or DTC P0457 (07-6-6)
- Slow Fuel Fill/Premature Shut Off (07-11-15)
- Water Trapped In Doors (06-25-4)
- Paint Degradation To Body Side (05-26-8)
Exterior Lights
- Intermittent Instrument Cluster Operation - Including Gauges Sweep/Reset - Multiple Warning Lights Illuminated And/Or Reverse Lights Stay On - Vehicles Built Before 2/17/2006 (06-6-2)
Front Suspension
- Noise From Front While Turning Steering Wheel (08-4-20)
Fuel System
- Idle Rpm Fluctuation With Or Without DTCS - P0505, P0506 And/Or P061B (11-8-5)
- Fuel Filler Cap Binding, Fuel Cap Light / Warning Message And/Or DTC P0457 (07-6-6)
- Slow Fuel Fill/Premature Shut Off (07-11-15)
- Mil On With DTC P0191 - Fuel Rail Pressure Sensor Circuit Performance (07-4-7)
- Mil On With DTC P0460 (06-18-6)
Fuses & Circuit Breakers
- Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)
Gauges & Instrument Panels
- Fuel Gauge Erratic/Inaccurate And/Or Mil On With DTC P0463, B1202, B2627, B2879, And/Or P2068 (06-17-2)
- Intermittent Instrument Cluster Operation - Including Gauges Sweep/Reset - Multiple Warning Lights Illuminated And/Or Reverse Lights Stay On - Vehicles Built Before 2/17/2006 (06-6-2)
HVAC Control Systems
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
- Noise In Right Front Of Passenger Compartment/Air Inlet Door Actuator Inoperative/Blower Motor Fan Noise (06-6-10)
Ignition System
- WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
Infotainment
- Audio / Navigation Service And Ordering Procedures (06-21-7)
- Navigation System Routing Issue In MICHIGAN (06-3-2)
Interior/Exterior Trim
- Roof Ditch Molding Loose Or Noisy (07-6-12)
- Instrument Panel Storage Compartment Lid - Bubbles (05-26-9)
- Interior Plastic Trim - Paint-To-Match And Repair - Interior Spray Paint And Adhesion Promoter Usage Instructions (05-9-3)
Lubrication System
- 3.0L - Engine Oil Leak From Dipstick - Heated PCV Service Kit (05-25-12)
Manual Steering
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
- Squeak - Steering Column / Rack (06-23-3)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Idle Rpm Fluctuation With Or Without DTCS - P0505, P0506 And/Or P061B (11-8-5)
- Camshaft Tick Noise - 3.0L 4V Engine Only With Exhaust Camshaft Driven Water Pumps (08-3-10)
- 3.0L - Engine Oil Leak From Dipstick - Heated PCV Service Kit (05-25-12)
Mechanical - Hydraulic
- Rear Brake Drag, Noise, Dust, And/Or Premature Pad Wear (07-5-9)
Mirrors
- Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
- Ford Interior Mirror Job Aid (G0000001)
Paint & Coatings
- Paint Degradation To Body Side (05-26-8)
- Interior Plastic Trim - Paint-To-Match And Repair - Interior Spray Paint And Adhesion Promoter Usage Instructions (05-9-3)
Passive Restraints
- Inoperative Heated Seat(S) - Built Before 12/14/2007 (09-4-8)
- Seat Headrest Raises While Driving (06-8-6)
Rear Suspension
- Suspension - Rear Tire Inner Edge Wear (10-2-13)
- 2005-2006 Five Hundred/MONTEGO - Noise From Rear Suspension - Cold Only (06-5-12)
Restraints Control Systems
- RCM Fault Reporting Using DTCS And Bit-Mapped Parameter Identifiers (PIDS) - Service Tips (07-7-8)
- Air Bag Light On With DTC B2290 - Difficult To Duplicate (06-20-2)
Seats
- Inoperative Heated Seat(S) - Built Before 12/14/2007 (09-4-8)
- Seat Headrest Raises While Driving (06-8-6)
- Heated Seats Inoperative (06-2-11)
Starter
- Battery Service - Operation Of Battery Eye - Charging Service Tips (07-5-8)
Steering Column
- Leather-Wrapped Steering Wheel - Leather Coming Loose (07-4-3)
- Squeak - Steering Column / Rack (06-23-3)
Steering Control Systems
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
- Squeak - Steering Column / Rack (06-23-3)
Steering Gear
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
- Squeak - Steering Column / Rack (06-23-3)
Sun Roof/T-Top/Convertible Top
- Roof Ditch Molding Loose Or Noisy (07-6-12)
Suspension Control Systems
- Noise From Front While Turning Steering Wheel (08-4-20)
System
- Idle Rpm Fluctuation With Or Without DTCS - P0505, P0506 And/Or P061B (11-8-5)
- Mil On - DTCS P0106, P0109, P2111, P2112, And Or P2072 (08-9-7)
- Fuel Filler Cap Binding, Fuel Cap Light / Warning Message And/Or DTC P0457 (07-6-6)
- Slow Fuel Fill/Premature Shut Off (07-11-15)
- Mil On With DTC P0191 - Fuel Rail Pressure Sensor Circuit Performance (07-4-7)
- Wrench Light On - No DTCS And/Or U0401 (07-2-2)
- Long Cranking Time Or No Start On Initial Start Attempt - Vehicles Built On Or Before 6/6/2006 (06-20-7)
- Mil On With DTC P0460 (06-18-6)
- Long Cranking Time Or No Start On Initial Start Attempt (06-12-7)
- DTC P2107 And/Or P2110 - Long Crank Times - Vehicles Built Before 12/14/2005 (05-26-17)
- 3.0L - Engine Oil Leak From Dipstick - Heated PCV Service Kit (05-25-12)
- WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
- Engine Rpm Fluctuation At Highway Cruising Speeds (05-17-5)
Transmission Control Systems
- AISIN Transmission Harsh Shifting - No DTC Mileage Above 20,000 Miles (32,200 Km) (08-24-1)
- Wrench Light On - No DTCS And/Or U0401 (07-2-2)
- Transmission Shifter Binding/High Effort - Bezel Replacement (07-1-8)
- Harsh/Erratic/Slow Downshifts Or Tip-In Hesitation - 6 Speed Automatic Transaxle - Vehicles Built Before 10/17/2005 (05-24-5)
- Engine Rpm Fluctuation At Highway Cruising Speeds (05-17-5)
Wheel Alignment
- Suspension - Rear Tire Inner Edge Wear (10-2-13)
Wheels & Tire System
- Suspension - Rear Tire Inner Edge Wear (10-2-13)
Window Motors & Regulators
- 2005-2006 Freestyle/Five Hundred/MONTEGO - Intermittent Bounce-Back Of The Driver's Window During One Touch Up Operation (06-8-12)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)