Continuous Monitor (Wiggle) Test
The Self-Test Output (STO) will be activated each time a fault is detected. If the STO is activated long enough during the wiggle tests a service code will be stored. A fault is indicated by a deflection of 10.5 volts or greater on VOM. STAR tester LED turns off.
- KEY ON/ENGINE OFF Test: With SELF-TEST deactivated, turn ignition on to enter into wiggle mode.
- ENGINE RUNNING Test: Activate SELF-TEST and perform ENGINE RUNNING SELF-TEST. After service code output has finished, do not turn engine off or deactivate SELF-TEST. About 2 minutes after code 11 has been displayed, wiggle mode will start. The system will remain in wiggle mode until SELF-TEST is deactivated or engine is turned off.
NOTE:
An alternate method of entering CONTINUOUS MONITOR (WIGGLE) TEST with engine running is to start ENGINE RUNNING SELF-
TEST, exit, and re-enter ENGINE RUNNING SELF-TEST
without turning engine off.
- Observe VOM while moving, wiggling, and tapping the system harness (in short sections), connectors, and sensors. If an intermittent condition is created, the monitor will indicate this by storing a service code. Carefully inspect harness and associated connectors of affected circuits.
- If an intermittent condition is not created, carefully disconnect sensor from harness. Remove terminals from connector and visually inspect terminals at both ends for corrosion, bad crimps, improperly seated terminals, etc.
- Reconnect harness after inspection. Disconnect processor from harness as carefully as possible. Remove and inspect terminals associated with sensor being checked.
- If an intermittent condition cannot be created, reconnect connector and erase the CONTINUOUS SELF-TEST service codes. To erase service codes, activate KEY ON/ENGINE OFF SELF-TEST .
- Remove jumper from Self-Test Input terminal as soon as first service code appears. Repeat SELF-TEST with jumper to verify that service codes have been erased. QUICK TEST is complete.
CONTINUOUS SELF-TEST
| Continuous Memory | Test |
|---|---|
| 14 | CIRCUIT TEST OO |
| 18 | CIRCUIT TEST LL |
| 21 | CIRCUIT TEST G Step 9) |
| 22 | CIRCUIT TEST H Step 14) |
| 41 | CIRCUIT TEST Q Step 15) |
| 42 | CIRCUIT TEST Q Step 15) |
| 51 | CIRCUIT TEST G Step 10) |
| 53 | CIRCUIT TEST J Step 11) |
| 54 | CIRCUIT TEST D Step 9) |
| 56 | CIRCUIT TEST K Step 11) |
| 61 | CIRCUIT TEST G Step 10) |
| 63 | CIRCUIT TEST J Step 15) |
| 64 | CIRCUIT TEST D Step 9) |
| 66 | CIRCUIT TEST K Step 11) |