Technical Service Bulletins
- A/C Compressor
- Accessories & Equipment
- Tool Rental Program (SI M04 05 17)
- Integrated Measurement Interface Box - IMIB R2 V6 (M07 01 16)
- Test Kit For Electrical Contacts (M04 01 13)
- Crimping Pliers For Wire End Ferrules (M04 13 12)
- Mini Output Shaft Adapter Kit For Use With Hydraulic Wheel Bearing And Output Shaft Tool (M04 06 12)
- Workshop Efficiency Mobile Toolbox (M04 11 12)
- Cable Set For Test Box (M04 04 12)
- Mini Special Tool Storage Cabinet (M04 02 12)
- ISTA Does Not Automatically Id The Vehicle (M07 06 10)
- Diagnosis Feedback Using ISTA (M07 05 06)
- ISTA Pc Client (M07 03 10)
- ISTA FASTA Data Not Available (M07 04 10)
- Integrated Measurement Interface Box - IMIB (M07 03 09)
- ISTA Test Plan Priority Error (M07 02 10)
- Integrated Measurement Interface Box - IMIB (M04 16 09)
- Activating ISTA In Offline Mode When ISIS Is Not Available (M07 02 09)
- Dis V57 Release Notes (M07 01 09)
- New Programming And Coding System: ISTA/P (M09 01 07)
- Dis V55 Release Notes (M07 07 08)
- Dis V54 Release Notes (M07 04 08)
- Dis V52 Release Notes (M07 11 07)
- Dis V52 Changes Based On Diagnosis Feedback (December 2007 Release) (M07 12 07)
- Importance Of Using The Most Current Diagnostic/Programming Software (M07 08 07)
- Dis V51 Corrections Based On Diagnosis Feedback (September 2007 Release) (M07 03 07)
- CARTOOL Part Number Search (M04 08 07)
- Release Notes PROGMAN V22.1 And V22.1.1 And V22.1.2 (M09 05 06)
- Release Notes PROGMAN V22.0 And V22.0.1 (M09 04 06)
- Accessories Control Systems
- Key Remote Bar Codes (M61 01 03)
- Enabling Code Information (M09 02 11)
- Closed-Circuit Current Monitoring (M61 07 07)
- ISTA Fault Code "S0001" Entries Still Present After Quick Delete (M07 01 10)
- ICOM Extension Cable (M04 11 09)
- Dis V57 Release Notes (M07 01 09)
- Navigation System Operating Software (SI M84 04 03)
- Dis V52 Release Notes (M07 11 07)
- Run Test Modules To Completion (M07 10 07)
- Importance Of Using The Most Current Diagnostic/Programming Software (M07 08 07)
- Brake Lights On With Ignition Off (M63 200 05)
- Replacement Of Instrument Cluster Fails Coding (M09 07 06)
- Battery Discharge With Key Inserted In Ignition Lock (M61 200 04)
- No Daytime Running Lights Available In CKM (M09 03 06)
- Vehicle Memory (M09 01 02)
- Clock Inaccurate (M62 01 05)
- Rear Defogger Relay Clicks After Several Minutes Of Operation (M64 01 05)
- Battery Draw Since The IPOD Is Installed (SI M65 200 05)
- Available Software For DISPLUS/Gt1/SSS (SI M00 02 04)
- Conversion USA - CANADA (M62 01 04)
- R50 (Cooper), R53 (Cooper S) With Navigation System (Option 609): Board Monitor Start-Up Delay, Not Temperature Related (SI M65 200 04)
- R50, R53; Speedometer Needle Vibrates (M62 200 04)
- Modified Vehicles (Installation Of Non-Approved Accessories) (M01 08 03)
- Convenience Open Feature (M61 02 02)
- Fuel Gauge Reading Incorrectly (M16 02 01 (805))
- Accessory Drive Belts
- Aerodynamic Devices
- Air Bag, SRS
- Airbag Warning Light Is On: MRS FC 02, 03, 05, 06 (SI M72 01 03)
- Not Possible To Delete Faults In The MRS5K Using Quick Delete (SI M65 03 09)
- Seat Occupancy Adapter Cable (OC3) - ITOOLS (M04 09 08)
- Airbag Warning Lamp For OC3 Seat Mat Fault (SI M65 03 06)
- Airbag Warning Lamp For OC3 Seat Mat Fault (SI M72 01 06)
- Recycling Or Disposal Of Airbags And SEATBELT PRETENSIONERS (M01 05 05)
- Passenger Airbag Status Lamp (SI M72 01 05)
- Deactivation/Reactivation Of Airbags (SI M72 02 03)
- Anti-Lock Brakes
- Anti-Theft Systems
- Key Remote Bar Codes (M61 01 03)
- Remote Control And Comfort Access/Passive Go Is Inoperative (SI M66 01 12)
- Door Lock Striker Adapter For Adjusting Side Windows (M04 08 08)
- Door Wrench Adaptation (M04 05 08)
- BOWDEN Cable Inside Door Comes Loose (M51 05 06)
- Disabling Double Lock (M61 06 02)
- Convenience Open Feature (M61 02 02)
- Automatic Trans
- Mini Operating Fluids (SI M00 02 02)
- Mini CVT Replacement Parts Warranty Extension: Additional 12 Months With Up To 50,000 Accumulated Miles (M01 05 14)
- Mini CVT Transmission Repair & Replacement Information (M24 01 03)
- CVT - Howling Noise From The Transmission (M24 02 06)
- Engine, Transmission, Or Clutch Related Complaints (M11 02 06)
- Automatic Transmission (CVT) Tools (M04 01 06)
- HAZET Square Drive Set (M04 03 03)
- CVT Input Shaft Radial Oil Seal Leaking (M24 01 04)
- CVT Input Shaft Seal Tools (M04 04 04)
- Selector Shaft Seal Tools (M04 06 04)
- Square Drive Torque Wrench (M04 04 03)
- Service Action 6 - Flush And Replace CVT Transmission Oil On Mini Cooper (M24 01 02)
- Assorted Special Tools (M04 04 02)
- Auxiliary Emission Control Systems
- Crankcase Ventilation System Diagnosis And Measurement (M11 07 08)
- VACUTEC Leak Finder (M04 01 14)
- State Inspection And Emission (I/M) Test Fails Due To An Invalid VIN Number (M12 02 13)
- Enabling Code Information (M09 02 11)
- Service Engine Soon Lamp Illuminated: FC 130 Oxygen Sensor (M12 06 07)
- ISTA Fault Code "S0001" Entries Still Present After Quick Delete (M07 01 10)
- ICOM Extension Cable (M04 11 09)
- Special DME And EGS Programming - Shipping Procedure (M12 03 04)
- Run Test Modules To Completion (M07 10 07)
- TEILECLEARING (Enhanced Technical Support) For DME (M12 09 07)
- Importance Of Using The Most Current Diagnostic/Programming Software (M07 08 07)
- Evaporative System Test ADAPTOR (M04 06 07)
- Testing Evaporative System For Leaks (M16 01 07)
- Ems2K/Ms5150 Reprogramming Helpful Hints (M12 200 03)
- Ems2K - FC P0128; Coolant Thermostat (M12 03 06)
- Evaporative System Tester (M04 05 06)
- Incorrect DME Programming (M12 08 05)
- Setting OBD Readiness Code Prior To State Inspection (M12 02 04)
- DRIVEABILITY Complaints - DME Programming (M12 02 03)
- Test Cables (M04 02 02)
- Axle Shafts
- Battery Management Systems
- Body Electrical
- Body Interior
- Key Remote Bar Codes (M61 01 03)
- Enabling Code Information (M09 02 11)
- ISTA Fault Code "S0001" Entries Still Present After Quick Delete (M07 01 10)
- ICOM Extension Cable (M04 11 09)
- Dis V57 Release Notes (M07 01 09)
- Navigation System Operating Software (SI M84 04 03)
- Dis V52 Release Notes (M07 11 07)
- Run Test Modules To Completion (M07 10 07)
- Importance Of Using The Most Current Diagnostic/Programming Software (M07 08 07)
- Brake Lights On With Ignition Off (M63 200 05)
- No Daytime Running Lights Available In CKM (M09 03 06)
- Vehicle Memory (M09 01 02)
- Rear Defogger Relay Clicks After Several Minutes Of Operation (M64 01 05)
- Available Software For DISPLUS/Gt1/SSS (SI M00 02 04)
- R50 (Cooper), R53 (Cooper S) With Navigation System (Option 609): Board Monitor Start-Up Delay, Not Temperature Related (SI M65 200 04)
- Convenience Open Feature (M61 02 02)
- Brakes Control Systems
- Enabling Code Information (M09 02 11)
- Magnetic Test Card For Wheel Speed Sensors (M04 01 12)
- ISTA Fault Code "S0001" Entries Still Present After Quick Delete (M07 01 10)
- ICOM Extension Cable (M04 11 09)
- Run Test Modules To Completion (M07 10 07)
- Importance Of Using The Most Current Diagnostic/Programming Software (M07 08 07)
- Illuminated Dynamic Stability Control (DSC) Light (M34 201 03)
- Charging Systems
- Electrical Contact Release Kit (M04 03 06)
- Closed-Circuit Current Monitoring (M61 07 07)
- DEUTRONIC Battery Chargers (M04 10 09)
- V & H MULTICHARGER 750 (M04 09 09)
- Wiring Harness Repairs (M61 02 07)
- Various Complaints Caused By Damaged Engine Harness (M12 05 05)
- Assorted Special Tools (M04 04 02)
- Mini Special Tools (M04 01 02)
- Clutch
- Communication Devices
- Cooling Fan
- Cooling System (Mechanical)
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Engine Control Systems
- W10 Engine: Ems2K - Comprehensive Component OBD Readiness Monitor Not Completed (SI M12 08 17)
- High-Pressure Direct Injection Fuel System Repairs (M13 02 15)
- Mini Operating Fluids (SI M00 02 02)
- Crankcase Ventilation System Diagnosis And Measurement (M11 07 08)
- Key Reader Error: Fuel System Additive On Service Check Sheet (M00 08 14)
- Remote Control And Comfort Access/Passive Go Is Inoperative (SI M66 01 12)
- VACUTEC Leak Finder (M04 01 14)
- State Inspection And Emission (I/M) Test Fails Due To An Invalid VIN Number (M12 02 13)
- Top Tier Detergent Gasoline In Mini Vehicles (M13 02 06)
- Enabling Code Information (M09 02 11)
- ISTA Does Not Automatically Id The Vehicle (M07 06 10)
- Service Engine Soon Lamp Illuminated: FC 130 Oxygen Sensor (M12 06 07)
- ISTA Fault Code "S0001" Entries Still Present After Quick Delete (M07 01 10)
- ICOM Extension Cable (M04 11 09)
- Fuel Line Plugs (M04 04 09)
- R50/R52 CVT; Engine Speed Flaring On Deceleration (M24 01 09)
- Special DME And EGS Programming - Shipping Procedure (M12 03 04)
- Fuel Injection And Induction System Cleaning Tool Hose Replacement (M04 17 07)
- Fuel Injection And Induction System Cleaning (M04 07 07)
- Run Test Modules To Completion (M07 10 07)
- TEILECLEARING (Enhanced Technical Support) For DME (M12 09 07)
- Importance Of Using The Most Current Diagnostic/Programming Software (M07 08 07)
- Evaporative System Test ADAPTOR (M04 06 07)
- Testing Evaporative System For Leaks (M16 01 07)
- Ems2K FC 2096 - Post-Cat Oxygen Sensor Lean Mixture (M12 01 06)
- Ems2K/Ms5150 Reprogramming Helpful Hints (M12 200 03)
- Hose Guide Tool (M04 06 06)
- Alcohol Detection Procedure (M13 04 06)
- Ems2K - FC P0128; Coolant Thermostat (M12 03 06)
- Fuel Pump Failure After Refueling With Ethanol Fuel Blend (M13 03 06)
- EDK Throttle Faults On W10/W11 Engines - Diagnostic Procedure (M12 04 02)
- Incorrect DME Programming (M12 08 05)
- DME (Ems2000 Or Ms5150) Fault Code P0128 - Coolant Thermostat (M12 201 05)
- Battery Draw Since The IPOD Is Installed (SI M65 200 05)
- Powertrain DRIVEABILITY Complaints (M12 202 04)
- Power Steering Pump Cooling Fan Activation (M32 01 04)
- DRIVEABILITY Complaints - DME Programming (M12 02 03)
- 2002 New Vehicle Preparation And Maintenance Requirements (SI M00 01 02)
- Test Cables (M04 02 02)
- Entertainment Systems
- Navigation System Has Missing Or Incorrect Road Map Data (SI M65 06 10)
- BLUETOOTH: IPHONE Is Not Displayed In The List Of Paired Devices (SI M84 02 12)
- SIRIUSXM Satellite Radio: How It Works (SI M65 04 12)
- USB Audio Interface (M65 01 09)
- Entertainment And Communication Systems Are Inoperative Intermittently (M65 02 11)
- Champ2 - Navigation System Road Map Move (M65 01 11)
- Real Time Traffic Information (SI M65 07 10)
- Power Port Release Tool (M04 02 10)
- Audio Complaints Relating To Audio Cd/Audio DVD Drive (SI M65 11 08)
- Dis V52 Release Notes (M07 11 07)
- Rattling Noise From Loudspeaker / Door Panel (M51 02 06)
- Battery Draw Since The IPOD Is Installed (SI M65 200 05)
- Mp3 Player Will Not Work On Vehicles With An In-Dash Cassette Radio (SI M65 04 03)
- "Reg Off" Displayed On NG C53 Cassette Radio (M65 02 03)
- Speed Dependent Volume Function Is Not Adjustable (M65 01 03)
- Business Cd53 Radio Has Distortion When In Am Band (SI M65 03 02)
- Alpine I Bus Cd Changer Installation Kit P/N 82 11 0 147 417 (M65 01 02)
- Exhaust
- Exterior Body Panels
- Tool For Setting Hood Into Service Position (M04 03 13)
- Hand-Held Riveting Tool (M04 02 09)
- Door Wrench Adaptation (M04 05 08)
- Tailgate Is Difficult To Open And/Or Close (M41 01 07)
- Corrosion On Door Seal Flange (M41 02 06)
- Hose Guide Tool (M04 06 06)
- Solutions Overview For Noise Complaints (SI M00 04 06)
- Rattling Or Squeaking Noises Heard From The Door/Window (M51 07 05)
- Paint Damaged Under Hood (M41 200 03)
- Rattles From Rear Hatch (M41 01 02)
- Body Squeaks And Rattles Troubleshooting Guide (M51 05 02)
- Hood Grille Is Loose Or Rattles (M51 04 02)
- Exterior Lights
- Light Bulb Replacement - Incandescent And Halogen Light Bulbs (M63 01 11)
- Automatic Headlights: Adjusting Sensitivity (M63 01 08)
- Headlamp Moisture: Fault Diagnostics (M63 03 09)
- Brake Lights On With Ignition Off (M63 200 05)
- Brake Lights Stay On All The Time (M63 202 05)
- No Daytime Running Lights Available In CKM (M09 03 06)
- Modified Headlight Adjustment Tool (M04 03 05)
- Auxiliary Driving Light Installation Kit P/N 63 12 0 144 132 (M63 01 02)
- Mini Special Tools (M04 01 02)
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- Fuel Tank Siphon Kit - Gasoline (SI M04 03 18)
- High-Pressure Direct Injection Fuel System Repairs (M13 02 15)
- Mini Operating Fluids (SI M00 02 02)
- Key Reader Error: Fuel System Additive On Service Check Sheet (M00 08 14)
- VACUTEC Leak Finder (M04 01 14)
- Top Tier Detergent Gasoline In Mini Vehicles (M13 02 06)
- Fuel Level Sensor Repair Procedure (M16 01 09)
- Alcohol Fuel Blends In Mini Vehicles (M13 01 06)
- Mini Fuel System Cleaner Plus (M13 05 06)
- Fuel Injection And Induction System Cleaning (M13 01 07)
- Fuel Composition Tester (M04 05 11)
- Testing Fuel Composition (M13 05 10)
- Hose Pinch Pliers (M04 04 11)
- Fuel Line Plugs (M04 04 09)
- Fuel Injection And Induction System Cleaning Tool Hose Replacement (M04 17 07)
- Fuel Injection And Induction System Cleaning (M04 07 07)
- Evaporative System Test ADAPTOR (M04 06 07)
- Testing Evaporative System For Leaks (M16 01 07)
- Testing Induction Systems Using The VACUTEC® Smoke Machine (M11 04 07)
- Ems2K FC 2096 - Post-Cat Oxygen Sensor Lean Mixture (M12 01 06)
- Hose Guide Tool (M04 06 06)
- Alcohol Detection Procedure (M13 04 06)
- Fuel Pump Failure After Refueling With Ethanol Fuel Blend (M13 03 06)
- EDK Throttle Faults On W10/W11 Engines - Diagnostic Procedure (M12 04 02)
- Acceleration Pedal Feels "NOTCHY" At Times (M35 01 02)
- 2002 New Vehicle Preparation And Maintenance Requirements (SI M00 01 02)
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- Fuel Level Sensor Repair Procedure (M16 01 09)
- Replacement Of Instrument Cluster Fails Coding (M09 07 06)
- Instrument Panel Noise (M51 08 05)
- Clock Inaccurate (M62 01 05)
- Conversion USA - CANADA (M62 01 04)
- R50, R53; Speedometer Needle Vibrates (M62 200 04)
- Body Squeaks And Rattles Troubleshooting Guide (M51 05 02)
- Fuel Gauge Reading Incorrectly (M16 02 01 (805))
- Hazardous Waste Material
- Headlights
- Light Bulb Replacement - Incandescent And Halogen Light Bulbs (M63 01 11)
- Automatic Headlights: Adjusting Sensitivity (M63 01 08)
- Headlamp Moisture: Fault Diagnostics (M63 03 09)
- No Daytime Running Lights Available In CKM (M09 03 06)
- Modified Headlight Adjustment Tool (M04 03 05)
- Auxiliary Driving Light Installation Kit P/N 63 12 0 144 132 (M63 01 02)
- Mini Special Tools (M04 01 02)
- Heated Glass/Defoggers
- HVAC Control Systems
- Mini Operating Fluids (SI M00 02 02)
- Noise From RECIRCULATION Motors (M64 04 08)
- J-48943 A/C Service Unit (M04 19 09)
- A/C O-Ring Tool (M04 15 09)
- Brake Lights Stay On All The Time (M63 202 05)
- IHKA Intermittently Doesn't Switch On (M64 202 04)
- Air Conditioning System Musty Odor (M64 01 06)
- Air Conditioning Doesn't Cool (M64 02 05)
- A/C Does Not Blow Cold Air (M64 02 04)
- Poor Performance/Noise From The Air Conditioning System (M64 200 03)
- Identification
- Ignition Switch/Steering Lock
- Ignition System
- Infotainment
- Navigation System Has Missing Or Incorrect Road Map Data (SI M65 06 10)
- Antenna Test Cables (M04 04 16)
- Entertainment And Communication Systems Are Inoperative Intermittently (M65 02 11)
- Champ2 - Navigation System Road Map Move (M65 01 11)
- Real Time Traffic Information (SI M65 07 10)
- Navigation System Operating Software (SI M84 04 03)
- R50 (Cooper), R53 (Cooper S) With Navigation System (Option 609): Board Monitor Start-Up Delay, Not Temperature Related (SI M65 200 04)
- MK3: Start-Up Delay At Temperatures Below 37 Degrees F (SI M84 03 03)
- Interior/Exterior Trim
- Mini Vehicles - Leather Care (SI M00 03 19)
- Rear License Plate Bracket: Seized Screws (M51 04 13)
- Floor Mat Awl (M04 12 07)
- Installation Roller (M04 08 06)
- Instrument Panel Noise (M51 08 05)
- Creaking Noise When Driving From Heating And Air Conditioning Housing Area (M51 07 06)
- Solutions Overview For Noise Complaints (SI M00 04 06)
- Rattling Noise From Loudspeaker / Door Panel (M51 02 06)
- Rear Cup Holder Bezel Is Loose (M51 15 05)
- Cracked Outside A-Pillar Trim (M51 06 05)
- Glove Box Difficult To Latch Or Open (M51 200 04)
- Glove Box Does Not Open (M51 201 04)
- Outside A-Pillar Trim Torn Off (M51 202 04)
- Service Action To Check Engine Compartment Shielding Fasteners (M51 03 02)
- Dimples In Roof Panel - Cars Without Sunroof (M41 01 03)
- Body Squeaks And Rattles Troubleshooting Guide (M51 05 02)
- Windshield Cover Comes Loose (M51 01 02)
- Hood Grille Is Loose Or Rattles (M51 04 02)
- Interior/Illumination Lights
- Lubrication System
- Engine Oil Pressure Diagnosis Hints (SI M11 02 23)
- External Engine Oil Leaks And Repairs (SI M01 05 21)
- Engine Replacement And Engine Repairs (M11 04 15)
- Engine Oil Consumption (M11 02 13)
- CPO (Mini Next) Inspection Guidelines: Engines Requiring A Technical Puma Case (M11 03 13)
- Engine Oil Is Below The Minimum Level (M01 05 15)
- Mini Operating Fluids (SI M00 02 02)
- Crankcase Ventilation System Diagnosis And Measurement (M11 07 08)
- Mini Maintenance Program: Annual Low-Mileage Engine Oil Changes (M01 02 03)
- Engine Oil Residue Found Near Oil Filler Cap (M11 05 14)
- Oil Seepage From The Filter Housing Area (M11 01 06)
- Various Complaints Caused By Damaged Engine Harness (M12 05 05)
- Replacement Oil Filters (M00 06 02)
- Mini Special Tools (M04 01 02)
- Manual Steering
- Mini Operating Fluids (SI M00 02 02)
- Replacement Of Steering Gear Due To Accident Damage (M32 04 05)
- Electro-Hydraulic Power-Assist Steering Pump (EHPS) And Cooling Fan: Limited Warranty Extension To 13 Years/150,000 Miles (M01 01 13)
- Various Complaints Caused By Damaged Engine Harness (M12 05 05)
- Power Steering Pump Noise (M32 200 04)
- Power Steering Pump Cooling Fan Activation (M32 01 04)
- Manual Trans
- Mini Operating Fluids (SI M00 02 02)
- Mini With Manual Transmission - "Stiff" Diagonal Gearshift (M23 03 08)
- Extractor For Rotary Shaft Seal - GS5 And GS6 Transmissions (M04 07 09)
- Replacement Of Output Shaft Seal - Manual 5-Speed (M23 04 08)
- Transmission Shifting Cables Frozen (M25 200 04)
- Engine, Transmission, Or Clutch Related Complaints (M11 02 06)
- HAZET Square Drive Set (M04 03 03)
- Hydraulic Clutch Control Repair And Bleeding Procedures (M21 02 05)
- Mini Special Tools (M04 02 05)
- Square Drive Torque Wrench (M04 04 03)
- Assorted Special Tools (M04 04 02)
- Mechanical
- Engine Replacement And Engine Repairs (M11 04 15)
- Crankshaft Seal And Bed Plate Liquid Sealer (M11 11 16)
- Engine Oil Consumption (M11 02 13)
- CPO (Mini Next) Inspection Guidelines: Engines Requiring A Technical Puma Case (M11 03 13)
- Engine Oil Is Below The Minimum Level (M01 05 15)
- Mini Operating Fluids (SI M00 02 02)
- Crankcase Ventilation System Diagnosis And Measurement (M11 07 08)
- Mini Maintenance Program: Annual Low-Mileage Engine Oil Changes (M01 02 03)
- Valve Guide To Valve Stem Wear Specification (M11 06 14)
- Engine Oil Residue Found Near Oil Filler Cap (M11 05 14)
- VACUTEC Leak Finder (M04 01 14)
- Engine Cross-Member And Supports (M04 10 11)
- New Engine Support Part Numbers (M04 03 09)
- Fuel Injection And Induction System Cleaning Tool Hose Replacement (M04 17 07)
- Fuel Injection And Induction System Cleaning (M04 07 07)
- Testing Induction Systems Using The VACUTEC® Smoke Machine (M11 04 07)
- Ems2K FC 2096 - Post-Cat Oxygen Sensor Lean Mixture (M12 01 06)
- Engine, Transmission, Or Clutch Related Complaints (M11 02 06)
- HAZET Square Drive Set (M04 03 03)
- Oil Seepage From The Filter Housing Area (M11 01 06)
- Various Complaints Caused By Damaged Engine Harness (M12 05 05)
- New Mini Tools (M04 02 04)
- Special Tools (M04 06 03)
- Square Drive Torque Wrench (M04 04 03)
- Assorted Special Tools (M04 04 02)
- Replacement Oil Filters (M00 06 02)
- 2002 New Vehicle Preparation And Maintenance Requirements (SI M00 01 02)
- Mini Special Tools (M04 01 02)
- Mechanical - Hydraulic
- Vibration When Braking: Diagnosing And Repairing (M34 02 15)
- Brake Pad Maintenance Services: Brake Disc Resurfacing Guidelines (SI M34 04 16)
- On-Car Brake Lathe (SI M34 05 16)
- Mini Operating Fluids (SI M00 02 02)
- Brake Disc And Brake Pad Service And Reference Information (M34 01 14)
- Brake Rotor Minimum Thickness (M34 01 10)
- Brake Rotor Puller (M04 13 09)
- Sticking Rear Brake Calipers (M34 02 05)
- Mini Special Tools (M04 01 02)
- Memory Modules
- Mirrors
- Paint & Coatings
- Parking Brake System
- Passive Restraints
- Airbag Warning Light Is On: MRS FC 02, 03, 05, 06 (SI M72 01 03)
- Seat Occupancy Adapter Cable (OC3) - ITOOLS (M04 09 08)
- Seat Heaters Too Hot Or Too Cold (M61 01 04)
- Front Seat Backrest Difficult To Recline (M52 02 06)
- Solutions Overview For Noise Complaints (SI M00 04 06)
- Recycling Or Disposal Of Airbags And SEATBELT PRETENSIONERS (M01 05 05)
- Rattles From Rear Seat Backrest (M52 01 03)
- Squeaks From Seat Cushion Frame (M52 05 02)
- Troubleshooting Noises From Front Seat Backrest (M52 04 02)
- Front Seat Backrest Inoperative (M52 01 02)
- Retrofit Of Front Seat Backrest Operating Levers (M52 03 02)
- Seat Lever Tool (M04 05 02)
- Procedures
- Mini Dealer Self-Authorized (DSA) Goodwill And The Elite Shop Programs (SI M01 06 03)
- Battery Maintenance Requirements: Battery Care (SI M61 01 02)
- Mini Engine Oil (SI M11 01 21)
- Mini Alternate Transportation Measures (ATM): Amp And Rental Vehicles (SIM 01 02 21)
- The New Mini Dealer Retail Audit Approach (SI M00 02 21)
- What's New In ISPI Next 20.2 (SI M05 01 20)
- Mini Warranty Simplification Program (WSP) Diagnosis Work Time Flat Rate Concept (SI M01 04 20)
- Mini Warranty Simplification Program (WSP) Standard Variable Diagnosis Work Time (SI M01 01 20)
- QCI Claim Payment And Process Change (SI M01 01 08)
- Mini MOTORER Obsession (Reboot): Non-Repair Customer Goodwill Initiative (SI M01 09 14)
- BMW Group Technical Support And New TSARA Hotline (TRI M00 02 19)
- TIS 2.0 Launches On December 13TH (SI M10 01 18)
- IRAP Control Unit Recovery (SI M09 01 18)
- Mini Engine: Oil Repair Order Invoicing Procedure (SI M01 04 15)
- Mini Recall/Service Action Repairs Alternative Mobility Solutions (AMS) (SI M01 01 17)
- Tool Rental Program (SI M04 05 17)
- IRAP Next (SI M09 01 16)
- CPO (Mini Next) Inspection Guidelines: Engines Requiring A Technical Puma Case (M11 03 13)
- 60-Day Bundling Of Maintenance Services For MOTORER Satisfaction (M01 06 13)
- Mini Maintenance Program: Annual Low-Mileage Engine Oil Changes (M01 02 03)
- Key Reader Error: Fuel System Additive On Service Check Sheet (M00 08 14)
- New Enrollment Procedure For Mini Maintenance Plan Upgrade To 4/50 (M01 09 03)
- Rear Suspension
- Restraints Control Systems
- Enabling Code Information (M09 02 11)
- Airbag Warning Light Is On: MRS FC 02, 03, 05, 06 (SI M72 01 03)
- ISTA Fault Code "S0001" Entries Still Present After Quick Delete (M07 01 10)
- ICOM Extension Cable (M04 11 09)
- Not Possible To Delete Faults In The MRS5K Using Quick Delete (SI M65 03 09)
- Seat Occupancy Adapter Cable (OC3) - ITOOLS (M04 09 08)
- Run Test Modules To Completion (M07 10 07)
- Importance Of Using The Most Current Diagnostic/Programming Software (M07 08 07)
- Airbag Warning Lamp For OC3 Seat Mat Fault (SI M65 03 06)
- Airbag Warning Lamp For OC3 Seat Mat Fault (SI M72 01 06)
- Passenger Airbag Status Lamp (SI M72 01 05)
- Deactivation/Reactivation Of Airbags (SI M72 02 03)
- Schedule
- CPO (Mini Next) Inspection Guidelines: Engines Requiring A Technical Puma Case (M11 03 13)
- 60-Day Bundling Of Maintenance Services For MOTORER Satisfaction (M01 06 13)
- Mini Maintenance Program: Annual Low-Mileage Engine Oil Changes (M01 02 03)
- New Enrollment Procedure For Mini Maintenance Plan Upgrade To 4/50 (M01 09 03)
- Seats
- Required Hardware Replacements During Seat Service/Repair (SI M52 02 19)
- Mini Vehicles - Leather Care (SI M00 03 19)
- Seat Occupancy Adapter Cable (OC3) - ITOOLS (M04 09 08)
- Seat Heaters Too Hot Or Too Cold (M61 01 04)
- Front Seat Backrest Difficult To Recline (M52 02 06)
- Solutions Overview For Noise Complaints (SI M00 04 06)
- Recycling Or Disposal Of Airbags And SEATBELT PRETENSIONERS (M01 05 05)
- Rattles From Rear Seat Backrest (M52 01 03)
- Squeaks From Seat Cushion Frame (M52 05 02)
- Troubleshooting Noises From Front Seat Backrest (M52 04 02)
- Front Seat Backrest Inoperative (M52 01 02)
- Retrofit Of Front Seat Backrest Operating Levers (M52 03 02)
- Seat Lever Tool (M04 05 02)
- Starter
- Battery Maintenance Requirements: Battery Care (SI M61 01 02)
- Approved Battery Charger/Power Supplies (M04 08 09)
- Transport Mode Switching Device: TMSD (M04 11 14)
- Remote Control And Comfort Access/Passive Go Is Inoperative (SI M66 01 12)
- EXIDE Replacement Batteries (M01 09 13)
- Updated Battery Registration Procedure (M61 03 12)
- Closed-Circuit Current Monitoring (M61 07 07)
- DEUTRONIC Battery Chargers (M04 10 09)
- V & H MULTICHARGER 750 (M04 09 09)
- Vehicle Battery Charging Voltage (M04 07 06)
- Battery Discharge With Key Inserted In Ignition Lock (M61 200 04)
- Correct Routing Of Battery Vent Tube (M61 03 02)
- Battery Draw Since The IPOD Is Installed (SI M65 200 05)
- Steering Column
- Steering Control Systems
- Mini Operating Fluids (SI M00 02 02)
- Electro-Hydraulic Power-Assist Steering Pump (EHPS) And Cooling Fan: Limited Warranty Extension To 13 Years/150,000 Miles (M01 01 13)
- Enabling Code Information (M09 02 11)
- ISTA Fault Code "S0001" Entries Still Present After Quick Delete (M07 01 10)
- ICOM Extension Cable (M04 11 09)
- Run Test Modules To Completion (M07 10 07)
- Importance Of Using The Most Current Diagnostic/Programming Software (M07 08 07)
- Various Complaints Caused By Damaged Engine Harness (M12 05 05)
- Illuminated Dynamic Stability Control (DSC) Light (M34 201 03)
- Power Steering Pump Noise (M32 200 04)
- Steering Gear
- Steering Linkage
- Required Hardware Replacement During Wheel Alignments (SI M32 01 18)
- New Installation Of Right-Hand Drive Steering Spindle In Left-Hand Drive Vehicle Is No Longer Required (M32 02 14)
- Replacement Of Steering Gear Due To Accident Damage (M32 04 05)
- Wheel Alignment Data (M32 01 08)
- New Mini Tools (M04 02 04)
- Sun Roof/T-Top/Convertible Top
- Mini Operating Fluids (SI M00 02 02)
- Test Plans For Panoramic Roof (M54 01 11)
- Various Noises From The Convertible Top (M54 01 10)
- Dis V52 Release Notes (M07 11 07)
- Solutions Overview For Noise Complaints (SI M00 04 06)
- Sunroof Cassette Screw Tool (M04 01 04)
- Squeaking Noise When Operating Sunroof (M54 01 04)
- Dimples In Roof Panel - Cars Without Sunroof (M41 01 03)
- Troubleshooting Sunroof Squeaks And Rattles (M54 01 02)
- Convenience Open Feature (M61 02 02)
- Suspension Control Systems
- Enabling Code Information (M09 02 11)
- ISTA Fault Code "S0001" Entries Still Present After Quick Delete (M07 01 10)
- ICOM Extension Cable (M04 11 09)
- Wheel Alignment Data (M32 01 08)
- Run Test Modules To Completion (M07 10 07)
- Importance Of Using The Most Current Diagnostic/Programming Software (M07 08 07)
- Illuminated Dynamic Stability Control (DSC) Light (M34 201 03)
- Tire Pressure Monitoring Systems (TPMS) (M36 02 05)
- System
- High-Pressure Direct Injection Fuel System Repairs (M13 02 15)
- Mini Operating Fluids (SI M00 02 02)
- Crankcase Ventilation System Diagnosis And Measurement (M11 07 08)
- Key Reader Error: Fuel System Additive On Service Check Sheet (M00 08 14)
- Remote Control And Comfort Access/Passive Go Is Inoperative (SI M66 01 12)
- VACUTEC Leak Finder (M04 01 14)
- State Inspection And Emission (I/M) Test Fails Due To An Invalid VIN Number (M12 02 13)
- Top Tier Detergent Gasoline In Mini Vehicles (M13 02 06)
- Enabling Code Information (M09 02 11)
- Service Engine Soon Lamp Illuminated: FC 130 Oxygen Sensor (M12 06 07)
- Spark Plug Application (M12 01 02)
- ISTA Fault Code "S0001" Entries Still Present After Quick Delete (M07 01 10)
- ICOM Extension Cable (M04 11 09)
- Fuel Line Plugs (M04 04 09)
- R50/R52 CVT; Engine Speed Flaring On Deceleration (M24 01 09)
- Special DME And EGS Programming - Shipping Procedure (M12 03 04)
- Fuel Injection And Induction System Cleaning Tool Hose Replacement (M04 17 07)
- Fuel Injection And Induction System Cleaning (M04 07 07)
- Run Test Modules To Completion (M07 10 07)
- TEILECLEARING (Enhanced Technical Support) For DME (M12 09 07)
- Importance Of Using The Most Current Diagnostic/Programming Software (M07 08 07)
- Evaporative System Test ADAPTOR (M04 06 07)
- Testing Evaporative System For Leaks (M16 01 07)
- Testing Induction Systems Using The VACUTEC® Smoke Machine (M11 04 07)
- Ems2K FC 2096 - Post-Cat Oxygen Sensor Lean Mixture (M12 01 06)
- Ems2K/Ms5150 Reprogramming Helpful Hints (M12 200 03)
- Hose Guide Tool (M04 06 06)
- Alcohol Detection Procedure (M13 04 06)
- Ems2K - FC P0128; Coolant Thermostat (M12 03 06)
- Evaporative System Tester (M04 05 06)
- Fuel Pump Failure After Refueling With Ethanol Fuel Blend (M13 03 06)
- EDK Throttle Faults On W10/W11 Engines - Diagnostic Procedure (M12 04 02)
- Incorrect DME Programming (M12 08 05)
- DME (Ems2000 Or Ms5150) Fault Code P0128 - Coolant Thermostat (M12 201 05)
- Battery Draw Since The IPOD Is Installed (SI M65 200 05)
- Setting OBD Readiness Code Prior To State Inspection (M12 02 04)
- Powertrain DRIVEABILITY Complaints (M12 202 04)
- DRIVEABILITY Complaints - DME Programming (M12 02 03)
- Acceleration Pedal Feels "NOTCHY" At Times (M35 01 02)
- 2002 New Vehicle Preparation And Maintenance Requirements (SI M00 01 02)
- Test Cables (M04 02 02)
- Transfer Case
- Transmission Control Systems
- Enabling Code Information (M09 02 11)
- ISTA Fault Code "S0001" Entries Still Present After Quick Delete (M07 01 10)
- ICOM Extension Cable (M04 11 09)
- R50/R52 CVT; Engine Speed Flaring On Deceleration (M24 01 09)
- Run Test Modules To Completion (M07 10 07)
- Importance Of Using The Most Current Diagnostic/Programming Software (M07 08 07)
- Wheel Alignment
- Wheels & Tire System
- Tire Valve Torque Wrench (SI M04 04 18)
- Stripped Locking Wheel Bolts (M04 05 16)
- New Installation Of Right-Hand Drive Steering Spindle In Left-Hand Drive Vehicle Is No Longer Required (M32 02 14)
- New Wheel Balancing Adapter Kit (M04 02 14)
- Mini Tire Center Target Satisfaction Program (M01 01 04)
- Adjusting Tire Pressures (M36 02 10)
- Hunter GSP97BMW Wheel Balancer - Features And Operator Training (M36 01 04)
- Nitrogen Inflated Tires (M36 01 06)
- Tire Pressure Monitoring Systems (TPMS) (M36 02 05)
- Window Motors & Regulators
- Wire Pull Handle With Suction Cup For Windshield Removal (M04 09 12)
- Cracked Or Damaged Windshield (M51 01 09)
- Door Lock Striker Adapter For Adjusting Side Windows (M04 08 08)
- Mini Glass Repair (M02 03 06)
- Slow Power Window Operation (M51 08 06)
- Solutions Overview For Noise Complaints (SI M00 04 06)
- Rattling Or Squeaking Noises Heard From The Door/Window (M51 07 05)
- Cracked Outside A-Pillar Trim (M51 06 05)
- Windshield Water Ingress (M51 13 05)
- Windshield Exhibits Stress Cracks After Replacement Of Windshield (M51 201 03)
- Windows Do Not Drop When Opening Door (M61 03 03)
- Body Squeaks And Rattles Troubleshooting Guide (M51 05 02)
- Convenience Open Feature (M61 02 02)
- Windshield Cover Comes Loose (M51 01 02)
- Assorted Special Tools (M04 04 02)
- Wiper/Washer Systems
- Wiring Diagrams
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)