Section 2764 (Engine - Repair - F01/F02)
WARNING: This page does not describe the selected car, but rather 15 other vehicles, including the 2015 BMW Alpina B7L, 2015 BMW Alpina B7, 2014 BMW Alpina B7L, 2014 BMW Alpina B7, and 2013 BMW Alpina. However, it is still accessible from the selected car via links, so may be relevant.
- 1100 Engine, General
- 00 Danger of poisoning if oil is ingested/absorbed through the skin
- Engine identification
- 1100... Overview of consumable (Electronic Parts Catalogue)
- 1100 Removing and installing/replacing acoustic cover (N63)
- 1100050 Removing and installing/replacing engine (N63)
- 00 Risk of injury if oil comes into contact with eyes and skin
- 00 Safety information for working on vehicles with automatic engine start-stop function (MSA)
- 00 Safety instructions for handling oil
- 1100670 Securing engine in installation position (N63)
- 1100... Service - engine oil (N63)
- 1112 Cylinder Head And Cylinder Head Cover
- 1112729 Checking cylinder head for watertightness (N63)
- 1112719 Grinding cylinder head sealing surface (N63)
- 1112105 Removing and installing left cylinder head (N63)
- 1112106 Removing and installing right cylinder head (N63)
- 1112005 Removing and installing/sealing left cylinder head cover (N63)
- 1112006 Removing and installing/sealing right cylinder head cover (N63)
- 1112112 Replacing both cylinder head gaskets (N63)
- 1113 Oil Sump
- 1114 Housing Cover
- 1114110 Removing and installing lower timing case cover (N63)
- 1114080 Removing and installing timing case cover, top left (N63)
- 1114085 Removing and installing timing case cover, top right (N63)
- 1114250 Removing and installing/sealing rear coolant end cover (N63)
- 1114151 Replacing crankshaft radial seal on transmission side (N63)
- 1114141 Replacing radial shaft seal in lower timing case cover (N63)
- 1121 Crankshaft With Bearing
- 1122 Flywheel
- 1123 Vibration Damper
- 1124 Connecting Rod With Bearing
- 1125 Piston With Rings And Pin
- 1128 V-Ribbed Belt W.Tens./Deflect
- 1131 Camshaft
- 1131573 Adjusting camshaft timing on left side (N63)
- 1131574 Adjusting camshaft timing on right side (N63)
- 1131070 Checking camshaft timing on left side (N63)
- 1131071 Checking camshaft timing on right side (N63)
- 1131038 Removing and installing/renewing right exhaust camshaft (N63)
- 1133054 Removing and installing/renewing rocker arms on right side (N63)
- 1133052 Removing and installing/replacing all rocker arms on left side (N63)
- 1131036 Removing and installing/replacing left exhaust camshaft (N63)
- 1131032 Removing and installing/replacing left inlet camshaft (N63)
- 1131034 Removing and installing/replacing right inlet camshaft (N63)
- 1131094 Removing hydraulic chain tensioner for timing chains on left side (N63)
- 1131095 Removing hydraulic chain tensioner for timing chains on right side (N63)
- 1131052 Replacing both timing chains (N63)
- 1133 Rocker Arm With Bearing Mount
- 1134 Valves With Springs
- 1136 Variable Camshaft Timing
- 1131573 Adjusting camshaft timing on left side (N63)
- 1131574 Adjusting camshaft timing on right side (N63)
- 1131070 Checking camshaft timing on left side (N63)
- 1131071 Checking camshaft timing on right side (N63)
- 1136720 Removing and installing/renewing both solenoid valves on right side (N63)
- 1136047 Removing and installing/renewing inlet and exhaust adjustment units on left side (N63)
- 1136715 Removing and installing/replacing both solenoid valves on left side (N63)
- 1136048 Removing and installing/replacing inlet and exhaust adjustment units on right side (N63)
- 1140 Oil Supply
- 1141 Oil Pump With Filter And Drive
- 1142 Oil Filter And Lines
- 1151 Water Pump With Drive
- 1153 Thermostat And Connections
- 1161 Intake Manifold
- 1161730 Check BMW diagnosis system for excess pressure and vacuum (N63)
- Notes
- Necessary preliminary work
- Pressure measurement
- Vacuum pressure measurement
- Calibration for vacuum pressure measurement
- Connections on EPPC
- Vacuum activation, cylinders 1-4
- Vacuum activation, cylinders 5-8
- Exhaust turbocharger, cylinders 1-4
- Exhaust turbocharger, cylinders 5-8
- Check wastegate valve with vacuum
- 1161065 Removing and installing/replacing left intake plenum (N63)
- 1161068 Removing and installing/replacing right intake plenum (N63)
- 1161730 Check BMW diagnosis system for excess pressure and vacuum (N63)
- 1165 Supercharger With Control
- 1165 Connection diagram, vacuum activation (N63)
- 1165714 Removing and installing/renewing electric changeover valve on exhaust turbocharger, right (N63)
- 1165185 Removing and installing/renewing heat shield at bottom (N63)
- 1165180 Removing and installing/renewing heat shield at top (N63)
- 1165712 Removing and installing/replacing electric changeover valve on exhaust turbocharger, left (N63)
- 1165030 Removing and installing/replacing exhaust turbocharger, left, cylinders 5-8 (N63)
- 1165025 Removing and installing/replacing exhaust turbocharger, right, cylinders 1-4 (N63)
- 1161065 Removing and installing/replacing left intake plenum (N63)
- 1165010 Removing and installing/replacing pressure accumulator (N63)
- 1161068 Removing and installing/replacing right intake plenum (N63)
- 1166 Vacuum Pump
- 1174 El.Valve For EXH. Gas RECIRCULATION
- 1178 Emission Control, Oxygen Sensor