Section 3509 (Engine - Repair)
WARNING: This page is about a different car, the 2013 BMW X5 M, 2012 BMW X5 M, 2011 BMW X5 M, and 2010 BMW X5 M. However, it is still accessible from the selected car via links, so may be relevant.
- Engine, General
- 31 10 001 Completely removing and installing front axle with engine and transmission (N63/S63 E70/E71)
- 00 Danger of poisoning if oil is ingested/absorbed through the skin
- 11 00 000 Differences among basic engine versions (N63 / S63)
- Engine identification
- 11 00... Overview of consumables (Electronic Parts Catalogue)
- 11 00 598 Removing and installing engine on front axle E70 E71 (N63/S63)
- 00 Risk of injury if oil comes into contact with eyes and skin
- 00 Safety information for working on vehicles with automatic engine start-stop function (MSA)
- 00 Safety instructions for handling oil
- 11 00 670 Securing engine in installation position (S63)
- 11 00... Service - engine oil (S63)
- Cylinder Head And Cylinder Head Cover
- 11 12 729 Checking cylinder head for water leaks (S63)
- 11 12 105 Removing and installing left cylinder head (S63)
- 11 12 106 Removing and installing right cylinder head (S63)
- 11 12 005 Removing and installing/sealing left cylinder head cover (S63)
- 11 12 006 Removing and installing/sealing right cylinder head cover (S63)
- Oil Sump
- Housing Cover
- 11 14 110 Removing and installing lower timing case cover (S63)
- 11 14 080 Removing and installing timing case cover, top left (S63)
- 11 14 085 Removing and installing timing case cover, top right (S63)
- 11 14 250 Removing and installing/sealing rear coolant end cover (N63)
- 11 14 151 Replacing crankshaft radial seal on transmission side (S63)
- 11 14 141 Replacing radial shaft seal in lower timing case cover (S63)
- Crankshaft With Bearing
- Flywheel
- Vibration Damper
- Piston With Rings And Pin
- V-Ribbed Belt With Tension/Deflection Element
- Camshaft
- 11 31 573 Adjusting camshaft timing on left side (S63)
- 11 31 574 Adjusting camshaft timing on right side (S63)
- 11 31 070 Checking camshaft timing on left side (S63)
- 11 31 071 Checking camshaft timing on right side (S63)
- 11 31 032 Remove and install/replace left intake camshaft (S63)
- 11 31 038 Removing and installing/renewing right exhaust camshaft (S63)
- 11 33 052 Removing and installing/replacing all rocker arms on left side (S63)
- 11 31 036 Removing and installing/replacing left exhaust camshaft (S63)
- 11 31 034 Removing and installing/replacing right inlet camshaft (S63)
- 11 33 054 Removing and installing/replacing rocker arms on right side (S63)
- 11 31 094 Removing hydraulic chain tensioner for timing chains on left side (S63)
- 11 31 095 Removing hydraulic chain tensioner for timing chains on right side (S63)
- 11 31 052 Replacing both timing chains (S63)
- Rocker Arm With Bearing Mount
- Valves With Springs
- Variable Camshaft Timing
- 11 31 573 Adjusting camshaft timing on left side (S63)
- 11 31 574 Adjusting camshaft timing on right side (S63)
- 11 31 070 Checking camshaft timing on left side (S63)
- 11 31 071 Checking camshaft timing on right side (S63)
- 11 36 715 Removing and installing/replacing both solenoid valves on left side (S63)
- 11 36 720 Removing and installing/replacing both solenoid valves on right side (S63)
- 11 36 047 Removing and installing/replacing inlet and exhaust adjustment units on left side (S63)
- 11 36 048 Removing and installing/replacing inlet and exhaust adjustment units on right side (S63)
- Oil Pump With Filter And Drive
- Oil Filter And Lines
- Water Pump With Drive
- Thermostat And Connections
- Intake Manifold
- Supercharger With Control
- 11 65 Connection diagram, vacuum activation (S63)
- 11 65 714 Removing and installing/renewing electric changeover valve on exhaust turbocharger, right (S63)
- 11 65 025 Removing and installing/renewing exhaust turbocharger, right, cylinders 1-4 (S63)
- 11 65 185 Removing and installing/renewing heat shield at bottom (S63)
- 11 65 712 Removing and installing/replacing electric changeover valve on exhaust turbocharger, left (S63)
- 11 65 030 Removing and installing/replacing exhaust turbocharger, left, cylinders 5-8 (S63)
- 11 65 180 Removing and installing/replacing heat shield at top (S63)
- 11 61 065 Removing and installing/replacing left intake plenum (S63)
- 11 65 010 Removing and installing/replacing pressure accumulator (S63)
- 11 61 068 Removing and installing/replacing right intake plenum (S63)
- Vacuum Pump
- Exhaust Valve For Exhaust Gas RECIRCULATION
- Emission Control, Oxygen Sensor