Idle Speed & Ignition Timing
NOTE:
If engine is equipped with a dual diaphragm distributor, vehicle will not have an ignition timing adjustment connector.
- Ensure vehicle is at operating temperature, all accessories are off and transmission is in Park or Neutral. Vehicle front wheels must be in straight-ahead position and curb idle speed set to specification. If vehicle is equipped with a dual diaphragm distributor, go to next step. If vehicle is equipped with an ignition timing adjustment connector, go to step 3).
- Disconnect vacuum hose farthest from distributor. Plug vacuum hose. Check basic ignition timing. Connect vacuum hose to distributor. Check actual ignition timing. Refer to the IGNITION TIMING table.
- Ground ignition timing adjustment connector. Refer to IGNITION TIMING ADJUSTMENT CONNECTOR LOCATION
table. Check basic ignition timing. Disconnect ground wire on ignition timing adjustment connector. Check actual ignition timing. Refer to the IGNITION TIMING
table.IGNITION TIMING (Degrees BTDC @ RPM)
Application (1) Basic (2)(3) Actual 1.5L Precis Federal 5 @ 650-850 N/A California 3 @ 650-850 N/A Mirage 5 @ 650-850 15 @ 650-850 1.6L Mirage 5 @ 650-850 8 @ 650-850 2.0L Galant & Pickup 5 @ 600-800 (4) 10 @ 600-800 2.4L Van/Wagon 5 @ 650-850 8 @ 650-850 2.6L Starion 10 @ 750-950 15 @ 750-950 Montero & Pickup 7 @ 750-950 12 @ 750-950 3.0L Montero & Sigma 5 @ 600-800 15 @ 600-800 (1) With ignition timing adjustment connector grounded or vacuum hose (farthest from dist.) disconnected. (2) With ignition timing adjustment connector ungrounded or vacuum hose (farthest from dist.) connected. Ignition timing may fluctuate. (3) If altitude is more than 2300 ft. above sea level, actual timing may be advanced. (4) Actual ignition timing on Galant Dual Overhead Camshaft (DOHC) engine is 12 degrees. IGNITION TIMING ADJUSTMENT CONNECTOR LOCATION (1)Application (2) Wire Color Location Starion Red/Yellow Right front of engine compartment Galant White/Yellow Left rear of engine compartment Mirage Yellow/Red Middle of firewall Montero White/Yellow Left rear of engine compartment Sigma Black/Blue Front of left shock tower Van/Wagon Silver Rear center of engine compartment (1) Remove waterproof female connector (if equipped) for access to wire. (2) This wire in connector is grounded for basic timing adjustment.